Text preview for : XDDV 170 Revision.pdf part of Aiwa XD-DV170 DVD/CD Player - mech. DV32BF (pag. 50+20)
Back to : DVD-170-Sim-Rev.part1.rar | Home
XD-DV170 EZ(S), K(S),
LH(S)
SIMPLE-2
SERVICE MANUAL
DVD PLAYER BASIC DVD/CD MECHANISM : DV32BF This Service Manual is the "Revision Publishing" and replaces "Simple Manual" (S/M Code No. 09-00A-350-7T3).
A par t of contents is adequate. Re-issuing is under r equest.
RE
S/M Code No. 09-00A-350-7R3
VI
DA TA
SIO
N
PROTECTION OF EYES FROM LASER BEAM DURING SERVICING
This set employs laser. Therefore, be sure to follow carefully the instructions below when servicing.
CAUTION
WARNING! ATTENTION
ADVARSEL!
This Compact Disc player is classified as a CLASS 1 LASER product. The CLASS 1 LASER PRODUCT label is located on the rear exterior.
VAROITUS!
CLASS 1 KLASSE 1 LUOKAN 1 KLASS 1 LASER PRODUCT LASER PRODUKT LASER LAITE LASER APPARAT
VARNING!
(SF-HD3AV/HD3AVC)
Precaution to replace Optical block
Body or clothes electrostatic potential could ruin laser diode in the optical block. Be sure ground body and workbench, and use care the clothes do not touch the diode.
Solder short land for DVD laser diode Solder short land for CD laser diode
1) After the connection, remove solder shown in the figures below.
-2-
SPECIFICATIONS
100-240 V AC, 50/60 Hz 12 W 950 g (2.09 lbs) 230 x 65 x 180 mm (w x h x d) (91/8 x 25/8 x 71/8 in.) Signal format NTSC/PAL NTSC Supported discs DVD 12 cm (single-sided single-layer, singlesided double-layer, double-sided doublelayer) 8 cm (single-sided single-layer, singlesided double-layer, double-sided doublelayer) Compact discs (CD-DA, video CD) 12 cm and 8 cm discs Video output Video composit output 1 Vp-p (75 ohms, sync negative) RCA jacks S2 video output Y output: 1 Vp-p (75 ohms, sync negative) C output: 0.286 Vp-p Audio output DOWN MIXING AUDIO OUT connector 140 mV RMS (1 kHz, -20 dB) RCA jacks (L/R) Fiber optical connector (IEC 958) Audio output characteristics Frequency range: CD/VCD: 20 Hz to 20 kHz DVD: 4 Hz to 22 kHz (48 kHz sampling) 4 Hz to 44 kHz (96 kHz sampling) Wow and flutter: unmeasurable Operating conditions 5 C to 35 C (41 F to 95 F) Power supply Power consumption Weight External dimensions Manufactured under license from Dolby Laboratories. Dolby , Pro Logic and the double-D symbol are trademarks of Dolby Laboratories. Confidential unpublished works. 1992-1997 Dolby Laboratories. All rights reserved. Manufactured under license from Digital Theatre Systems, Ino. US Pat. No. 5,451,942 and other worldwide patents issued and pending. DTS and DTS Digital Surround are trademarks of Digital Theatre Systems, Inc. 1996 Digital Theatre systems, Ino. All rights reserved.
· Design and specifications are subject to change without notice.
-3-
ACCESSORIES LIST
REF. NO 1 1 1 2 3 3 3 4 5 5 KANRI DESCRIPTION NO. 8A-AV6-911-010 IB,LH (ESP) -DV170 8A-AV6-906-010 IB,K (E) -DV170 8A-AV6-907-010 IB,EZ (9L) -DV170 8A-AV6-620-010 RC UNIT,RC-AVL01 87-B30-415-010 AC ADAPTOR,AC-D1003ENC 87-050-076-010 87-AV1-641-010 87-050-052-010 87-A91-017-010 87-099-726-010 AC CORD SET ASSY,E ADAPTOR,RGB-RCA YKS11-0027 CORD,PIN 1.5M Y/W/R 3P PLUG,CONVERSION JT-0476 PLUG,ADPTR CONV(K) PART NO.
! ! ! !
-4-
ELECTRICAL MAIN PARTS LIST -1/4
REF. NO IC 87-A21-032-080 87-A20-925-040 87-A20-905-040 87-A21-764-040 87-A20-080-040 87-017-027-040 8A-ZA7-804-010 87-A21-697-040 8A-ZA7-803-010 8A-ZA7-802-040 87-A21-309-040 8A-ZA7-800-010 87-017-917-080 8A-ZA7-801-040 88-KT1-608-010 87-A21-245-010 8A-ZA7-602-040 8Z-AV2-628-010 87-A20-185-040 87-001-551-080 8A-AV6-632-010 8A-AV6-605-030 87-A20-957-040 87-A21-755-040 8Z-AV2-630-010 87-A21-617-010 87-A20-689-080 87-A21-613-040 87-A21-362-040 87-017-585-080 87-A21-103-040 87-A21-754-010 87-A20-582-010 87-017-453-080 87-017-750-080 TRANSISTOR 87-A30-382-040 89-110-372-080 89-211-323-080 89-333-265-040 87-A30-516-040 87-026-210-080 89-341-165-080 89-115-864-080 87-026-227-080 87-026-342-080 89-342-132-080 87-026-211-080 89-324-123-080 DIODE 87-017-779-080 87-017-990-080 87-A40-797-040 87-001-166-080 87-001-165-080 MAIN C.B C0002 C0003 C0005 C0006 C0007 87-016-669-080 87-010-831-080 87-A11-976-080 87-A12-416-080 87-016-669-080 C-CAP,S C-CAP,U C-CAP,E C-CAP,E C-CAP,S 0.1-25 K B 0.1-16 Z F 470-16 M 10.5L MV 100U-25 M 7.7L UD 0.1-25 K B C-DIODE,1SS355 C-DIODE,U2FWJ44N C-DIODE,SBE001 C-DIODE,1SS301 C-DIODE,1SS300 C-FET,FTS1002 C-TR,2SA1037K(R) C-TR,2SB1132R C-TR,2SC3326A C-FET,3LN01C-TB C-TR,DTC144EK C-TR,2SC4116GR C-TR,2SA1586Y C-TR,DTA114EK C-TR,DTC144EU C-TR,2SC4213B C-TR,DTA144EK C-TR,2SC2412KS C0122 C0123 C0124 C0125 C0126 C0127 C0128 C0129 C0130 C0201 C0202 C0203 C0205 C0206 C0208 C0209 C0211 C0217 C0218 C0219 C0220 C0221 C0222 C0224 C0225 C0226 C0227 C0228 C0229 C0231 87-012-172-080 87-012-172-080 87-012-172-080 87-012-172-080 87-012-286-080 87-012-286-080 87-012-286-080 87-012-286-080 87-012-286-080 87-010-831-080 87-A11-031-080 87-010-831-080 87-010-831-080 87-A11-031-080 87-016-430-080 87-016-427-080 87-010-831-080 87-010-831-080 87-010-831-080 87-A12-344-080 87-012-274-080 87-012-274-080 87-010-831-080 87-012-277-080 87-012-274-080 87-012-274-080 87-012-274-080 87-012-274-080 87-012-274-080 87-012-274-080 C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,E C-CAP,U C-CAP,U C-CAP,E C-CAP,E C-CAP,E C-CAP,U C-CAP,U C-CAP,U C-CAP,E C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U 10P-50 D CH 10P-50 D CH 10P-50 D CH 10P-50 D CH 0.01-25 K B 0.01-25 K B 0.01-25 K B 0.01-25 K B 0.01-25 K B 0.1-16 Z F 100-16 M WX 0.1-16 Z F 0.1-16 Z F 100-16 M WX 100-6.3 M 5.5L WX 47-6.3 M 5.5L WX 0.1-16 Z F 0.1-16 Z F 0.1-16 Z F 100-6.3 VC PX 1000P-50 1000P-50 0.1-16 Z 1800P-50 1000P-50 1000P-50 1000P-50 1000P-50 1000P-50 1000P-50 K K F K K K K K K K B B B GRM B B B B B B C-IC,S-8520B28MC C-IC,BA05FP C-IC,BA033FP C-IC,BA00ASFP C-IC,TC74HC14AF C-IC,TC7W08F C-IC,LC87F72C8A C-IC,TC7SHU04F C-IC,LC78660W C-IC,LC324265AT-25DV C-IC,HD74LV74A C-IC,LA9702W-MPB C-IC,BU4066BCF C-IC,LA6556L-TE-L C-IC,LC75854W IC,RPM6938-V4 C-IC,HN58X2416FPI C-IC,HD6412350F20 C-IC,PST600DMT C-IC,TC7S08F IC,P-ROMAAV-6(VER.029) C-IC,UT611024LC-12 C-IC,SN74LV245APW C-IC,SN74LV541APW C-IC,L64021D C-IC,HY57V161610DTC-8 C-IC,PCM1723 C-IC,SN74LV04APW C-IC,NJM2100M(TE2) C-IC,NJM4580E C-IC,MM1454XFBE C-IC,MC44722AVFU IC,GP1F31TJ C-IC,NJM2267M C-IC,MM1041XM PART NO. KANRI NO. DESCRIPTION REF. NO C0008 C0009 C0010 C0012 C0015 C0016 C0017 C0018 C0019 C0020 C0021 C0022 C0023 C0024 C0026 C0027 C0028 C0029 C0100 C0101 C0102 C0103 C0104 C0105 C0106 C0107 C0108 C0109 C0110 C0111 C0112 C0113 C0114 C0115 C0116 C0117 C0118 C0119 C0120 C0121 PART NO. KANRI NO. C-CAP,E C-CAP,S C-CAP,U C-CAP,S C-CAP,S C-CAP,U C-CAP,E C-CAP,U C-CAP,E C-CAP,S C-CAP,U C-CAP,E C-CAP,U C-CAP,E C-CAP,U C-CAP,E C-CAP,U C-CAP,E C-CAP,U C-CAP,E C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,E C-CAP,U C-CAP,E C-CAP,U C-CAP,U C-CAP,U C-CAP,E C-CAP,E C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U DESCRIPTION 100U-25 M 7.7L UD 0.1-25 K B 0.01-25 K B 1-16 K B 1-16 K B 0.1-16 470-16 0.1-16 470-16 1-16 K 0.1-16 470-16 0.1-16 470-16 0.1-16 Z M Z M B Z M Z M Z F 10.5L MV F 10.5L MV F 10.5L MV F 10.5L MV F
87-A12-416-080 87-016-669-080 87-012-286-080 87-A11-282-080 87-A11-282-080 87-010-831-080 87-A11-976-080 87-010-831-080 87-A11-976-080 87-A11-282-080 87-010-831-080 87-A11-976-080 87-010-831-080 87-A11-976-080 87-010-831-080 87-A11-976-080 87-010-831-080 87-A11-976-080 87-012-274-080 87-016-428-080 87-010-831-080 87-010-831-080 87-012-180-080 87-012-180-080 87-010-831-080 87-016-428-080 87-010-831-080 87-016-428-080 87-010-831-080 87-012-195-080 87-010-831-080 87-010-848-080 87-010-848-080 87-010-831-080 87-012-172-080 87-012-172-080 87-012-172-080 87-012-172-080 87-012-172-080 87-012-172-080
470-16 M 10.5L MV 0.1-16 Z F 470-16 M 10.5L MV 1000P-50 K B 47-16 M 5.5L WX 0.1-16 0.1-16 22P-50 22P-50 0.1-16 Z Z J J Z F F CH CH F
47-16 M 5.5L WX 0.1-16 Z F 47-16 M 5.5L WX 0.1-16 Z F 100P-50 J CH 0.1-16 Z F 10-16 M 5.5L MV 10-16 M 5.5L MV 0.1-16 Z F 10P-50 D CH 10P-50 10P-50 10P-50 10P-50 10P-50 D D D D D CH CH CH CH CH
-5-
ELECTRICAL MAIN PARTS LIST -2/4
REF. NO C0232 C0233 C0234 C0235 C0236 C0237 C0238 C0239 C0240 C0241 C0242 C0243 C0244 C0245 C0246 C0247 C0248 C0249 C0250 C0251 C0252 C0253 C0254 C0255 C0256 C0257 C0259 C0260 C0261 C0300 C0301 C0302 C0303 C0304 C0305 C0307 C0308 C0311 C0312 C0313 C0314 C0315 C0316 C0317 C0318 C0319 C0320 C0321 C0322 C0323 C0324 C0330 C0332 C0333 C0334 C0335 C0336 C0337 C0338 C0339 C0340 C0341 C0342 C0343 C0344 C0345 C0346 C0347 C0348 C0349 KANRI NO. 87-012-274-080 C-CAP,U 87-010-831-080 C-CAP,U 87-010-831-080 C-CAP,U 87-012-174-080 C-CAP,U 87-012-174-080 C-CAP,U 87-010-831-080 87-010-829-080 87-010-829-080 87-010-831-080 87-010-831-080 87-012-286-080 87-012-197-080 87-010-831-080 87-010-831-080 87-010-831-080 87-010-831-080 87-010-831-080 87-010-831-080 87-010-831-080 87-010-831-080 87-010-831-080 87-010-831-080 87-010-831-080 87-010-831-080 87-012-282-080 87-016-427-080 87-016-427-080 87-012-286-080 87-012-286-080 87-016-427-080 87-016-427-080 87-010-831-080 87-010-831-080 87-012-274-080 87-016-428-080 87-012-274-080 87-016-428-080 87-010-831-080 87-012-271-080 87-012-271-080 87-012-271-080 87-012-271-080 87-012-271-080 87-012-282-080 87-012-271-080 87-012-196-080 87-A11-031-080 87-010-831-080 87-012-196-080 87-010-831-080 87-012-197-080 87-012-184-080 87-012-197-080 87-012-184-080 87-012-191-080 87-012-199-080 87-012-197-080 87-012-188-080 87-012-174-080 87-012-195-080 87-016-428-080 87-012-193-080 87-012-180-080 87-012-270-080 87-012-195-080 87-012-197-080 87-012-196-080 87-012-165-080 87-010-831-080 87-010-843-080 C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,E C-CAP,E C-CAP,U C-CAP,U C-CAP,E C-CAP,E C-CAP,U C-CAP,U C-CAP,U C-CAP,E C-CAP,U C-CAP,E C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,E C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,E C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,E PART NO. DESCRIPTION 1000P-50 0.1-16 Z 0.1-16 Z 12P-50 J 12P-50 J 0.1-16 Z 0.047-16 0.047-16 0.1-16 Z 0.1-16 Z K B F F CH CH F Z F Z F F F REF. NO C0350 C0351 C0352 C0353 C0354 C0355 C0356 C0357 C0358 C0359 C0400 C0401 C0402 C0403 C0404 C0405 C0406 C0407 C0408 C0409 C0410 C0424 C0425 C0426 C0427 C0601 C0602 C0604 C0605 C0608 C0609 C0612 C0613 C0614 C0615 C0617 C0619 C0620 C0623 C0624 C0625 C0626 C0627 C0628 C0630 C0632 C0634 C0639 C0640 C0641 C0642 C0643 C0702 C0703 C0704 C0705 C0706 C0707 C0708 C0709 C0710 C0711 C0712 C0713 C0714 C0715 C0716 C0717 C0718 C0719 KANRI NO. 87-010-831-080 C-CAP,U 87-010-831-080 C-CAP,U 87-016-427-080 C-CAP,E 87-016-427-080 C-CAP,E 87-012-164-080 C-CAP,U 87-A11-031-080 87-012-176-080 87-010-831-080 87-012-274-080 87-012-274-080 87-010-831-080 87-016-427-080 87-010-831-080 87-010-831-080 87-A11-968-080 87-010-831-080 87-010-831-080 87-012-199-080 87-012-199-080 87-012-199-080 87-012-199-080 87-010-848-080 87-010-831-080 87-010-831-080 87-010-848-080 87-012-286-080 87-012-286-080 87-012-286-080 87-012-286-080 87-016-428-080 87-012-286-080 87-012-286-080 87-012-286-080 87-012-172-080 87-016-428-080 87-012-172-080 87-012-286-080 87-012-286-080 87-012-286-080 87-012-286-080 87-010-848-080 87-012-286-080 87-012-286-080 87-012-286-080 87-010-848-080 87-010-848-080 87-012-286-080 87-010-848-080 87-012-286-080 87-012-286-080 87-012-286-080 87-010-197-080 87-016-428-080 87-A11-031-080 87-012-286-080 87-012-286-080 87-012-286-080 87-012-278-080 87-012-286-080 87-012-286-080 87-016-428-080 87-012-286-080 87-012-286-080 87-012-286-080 87-012-286-080 87-012-286-080 87-012-286-080 87-012-286-080 87-012-286-080 87-012-286-080 C-CAP,E C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,E C-CAP,U C-CAP,U C-CAP,E C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,E C-CAP,U C-CAP,U C-CAP,E C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,E C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,E C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,E C-CAP,U C-CAP,U C-CAP,U C-CAP,E C-CAP,E C-CAP,U C-CAP,E C-CAP,U C-CAP,U C-CAP,U C-CAP,S C-CAP,E C-CAP,E C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,E C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U PART NO. DESCRIPTION 0.1-16 Z F 0.1-16 Z F 47-6.3 M 5.5L WX 47-6.3 M 5.5L WX 2P-50 C CH 100-16 M 15P-50 J 0.1-16 Z 1000P-50 1000P-50 0.1-16 47-6.3 0.1-16 0.1-16 220-16 Z M Z Z M WX CH F K B K B F 5.5L WX F F UR
0.01-25 K B 150P-50 J CH 0.1-16 Z F 0.1-16 Z F 0.1-16 Z F 0.1-16 0.1-16 0.1-16 0.1-16 0.1-16 Z Z Z Z Z F F F F F F F F F K B
0.1-16 Z F 0.1-16 Z F 220P-50 J CH 220P-50 J CH 220P-50 J CH 220P-50 J CH 10-16 M 5.5L MV 0.1-16 Z F 0.1-16 Z F 10-16 M 5.5L MV 0.01-25 0.01-25 0.01-25 0.01-25 47-16 M K B K B K B K B 5.5L WX
0.1-16 Z 0.1-16 Z 0.1-16 Z 0.1-16 Z 4700P-50
47-6.3 M 5.5L WX 47-6.3 M 5.5L WX 0.01-25 K B 0.01-25 K B 47-6.3 M 5.5L WX 47-6.3 M 5.5L WX 0.1-16 Z F 0.1-16 Z F 1000P-50 K B 47-16 M 5.5L WX 1000P-50 K B 47-16 M 5.5L WX 0.1-16 Z F 560P-50 K B 560P-50 K B 560P-50 K B 560P-50 K B 560P-50 K B 4700P-50 K B 560P-50 K B 120P-50 J CH 100-16 M WX 0.1-16 Z F 120P-50 J CH 0.1-16 Z F 150P-50 J CH 33P-50 J CH 150P-50 J CH 33P-50 J CH 68P-50 J CH 220P-50 J CH 150P-50 J CH 47P-50 J CH 12P-50 J CH 100P-50 J CH 47-16 M 5.5L WX 82P-50 J CH 22P-50 J CH 470P-50 K B 100P-50 J CH 150P-50 J CH 120P-50 J CH 3P-50 C CH 0.1-16 Z F 1-50 M 5.5L MV
0.01-25 K B 0.01-25 K B 0.01-25 K B 10P-50 D CH 47-16 M 5.5L WX 10P-50 D CH 0.01-25 K B 0.01-25 K B 0.01-25 K B 0.01-25 K B 10-16 M 0.01-25 0.01-25 0.01-25 10-16 M 10-16 M 0.01-25 10-16 M 0.01-25 0.01-25 5.5L MV K B K B K B 5.5L MV 5.5L MV K B 5.5L MV K B K B
0.01-25 K B 0.01-25 K B C2012 47-16 M 5.5L WX 100-16 M WX 0.01-25 K B 0.01-25 K B 0.01-25 K B 2200P-50 K B 0.01-25 K B 0.01-25 K B 47-16 M 0.01-25 0.01-25 0.01-25 0.01-25 0.01-25 0.01-25 0.01-25 0.01-25 0.01-25 5.5L WX K B K B K B K B K K K K K B B B B B
-6-
ELECTRICAL MAIN PARTS LIST -3/4
REF. NO C0720 C0721 C0722 C0723 C0724 C0725 C0726 C0731 C0732 C0733 C0734 C0735 C0736 C0737 C0738 C0741 C0744 C0745 C0759 C0760 C0771 C0772 C0773 C0774 C0775 C0776 C0777 C0778 C0779 C0780 C0781 C0782 C0783 C0784 C0785 C0786 C0787 C0788 C0789 C0790 C0791 C0792 C0793 C0794 C0795 C0800 C0801 C0802 C0803 C0804 C0806 C0810 C0811 C0812 C0817 C0818 C0819 C0820 C0834 C0835 C0836 C0837 C0838 C0839 C0844 C0950 C0951 C0952 C0953 C0954 KANRI NO. 87-012-286-080 C-CAP,U 87-012-286-080 C-CAP,U 87-012-286-080 C-CAP,U 87-012-286-080 C-CAP,U 87-012-286-080 C-CAP,U 87-012-170-080 87-012-196-080 87-010-848-080 87-012-286-080 87-012-196-080 87-012-170-080 87-012-286-080 87-010-848-080 87-010-848-080 87-012-196-080 87-010-831-080 87-010-831-080 87-010-831-080 87-010-848-080 87-010-848-080 87-012-278-080 87-012-278-080 87-012-279-080 87-012-279-080 87-012-267-080 87-012-267-080 87-010-458-080 87-010-458-080 87-A11-974-080 87-A11-974-080 87-012-186-080 87-012-186-080 87-010-848-080 87-010-831-080 87-010-831-080 87-010-848-080 87-010-831-080 87-010-831-080 87-010-848-080 87-010-848-080 87-012-195-080 87-016-428-080 87-012-286-080 87-012-286-080 87-A11-974-080 87-012-286-080 87-016-428-080 87-016-428-080 87-010-831-080 87-010-831-080 87-010-831-080 87-012-286-080 87-016-428-080 87-012-286-080 87-010-848-080 87-012-286-080 87-012-186-080 87-012-182-080 87-012-184-080 87-012-174-080 87-012-178-080 87-012-184-080 87-012-174-080 87-012-178-080 87-012-168-080 87-012-286-080 87-010-848-080 87-010-846-080 87-A11-974-080 87-A11-031-080 C-CAP,U C-CAP,U C-CAP,E C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,E C-CAP,E C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,E C-CAP,E C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,E C-CAP,E C-CAP,E C-CAP,E C-CAP,U C-CAP,U C-CAP,E C-CAP,U C-CAP,U C-CAP,E C-CAP,U C-CAP,U C-CAP,E C-CAP,E C-CAP,U C-CAP,E C-CAP,U C-CAP,U C-CAP,E C-CAP,U C-CAP,E C-CAP,E C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,E C-CAP,U C-CAP,E C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,U C-CAP,E C-CAP,E C-CAP,E C-CAP,E PART NO. DESCRIPTION 0.01-25 0.01-25 0.01-25 0.01-25 0.01-25 8P-50 D 120P-50 10-16 M 0.01-25 120P-50 8P-50 D 0.01-25 10-16 M 10-16 M 120P-50 K K K K K B B B B B REF. NO C0955 C0956 C0957 C0958 C0959 C0960 C0961 CN0100 CN0300 CN0402 CN0600 CN0601 CNA0402 CNA0601 CNA0601 FB0001 FB0002 FB0003 FB0005 FB0006 FB0007 FB0008 FB0201 FB0731 FB0737 FB0739 FFC0001 J0001 J0606 J0950 J0951 L0003 L0004 L0005 L0006 L0100 L0201 L0202 L0203 L0300 L0301 L0302 L0400 L0600 L0601 L0602 L0603 L0700 L0701 L0702 L0704 L0705 L0800 L0801 L0802 L0803 L0805 L0806 L0810 L0811 L0950 R0005 R0006 R0012 R0013 R0020 R0021 S0950 X0100 X0200 KANRI NO. 87-012-286-080 C-CAP,U 87-010-846-080 C-CAP,E 87-A11-974-080 C-CAP,E 87-A11-031-080 C-CAP,E 87-012-286-080 C-CAP,U 87-012-286-080 87-010-831-080 87-A61-476-080 87-A61-459-080 87-A61-337-080 87-009-984-080 87-A60-777-010 8A-ZGD-607-010 8A-AV6-617-010 8A-AV6-618-010 87-A91-720-080 87-A91-720-080 87-A91-720-080 87-A91-720-080 87-A91-720-080 87-A91-720-080 87-A91-720-080 87-A91-720-080 87-A91-480-080 87-A91-480-080 87-A91-480-080 8A-AV6-607-010 87-A61-165-010 87-A61-145-010 87-A60-127-010 87-A61-473-010 87-A50-545-080 84-HD1-620-080 87-A50-395-080 87-A50-395-080 87-A50-667-080 87-A50-395-080 87-A91-720-080 87-A50-668-080 87-A50-395-080 87-005-811-080 87-005-811-080 87-A50-667-080 87-A50-667-080 87-A50-667-080 87-A50-667-080 87-A50-667-080 87-A50-667-080 87-A50-667-080 87-A50-668-080 87-A50-668-080 87-005-815-080 87-A50-668-080 87-005-815-080 87-005-811-080 87-005-817-080 87-005-816-080 87-005-816-080 87-005-816-080 87-005-816-080 87-005-815-080 87-022-247-080 87-022-284-080 87-022-284-080 87-022-285-080 87-022-241-080 87-022-223-080 87-A90-166-010 87-A70-284-080 87-A70-283-080 PART NO. DESCRIPTION 0.01-25 K B 4.7-35 M 5.5L MV 22-16 M 5.5L MV 100-16 M WX 0.01-25 K B
CH J CH 5.5L MV K B J CH CH K B 5.5L MV 5.5L MV J CH
C-CAP,U 0.01-25 K B C-CAP,U 0.1-16 Z F C-CONN,10P V WHT BM10B-SRSS-TB C-CONN,33P H XF2H-3315-1 C-CONN,9P V WHT PH-SM3-TB C-CONN,2P V WHT ZR CONN,14P B TMC-D(P) CONN ASSY,9P PH CONN ASSY,2P V WHT LID (CHINA) CONN ASSY,2P V WHT LID U (CHIN C-F-BEAD, C-F-BEAD, C-F-BEAD, C-F-BEAD, C-F-BEAD, C-F-BEAD, C-F-BEAD, C-F-BEAD, C-F-BEAD, C-F-BEAD, FBMJ3216HS800-T FBMJ3216HS800-T FBMJ3216HS800-T FBMJ3216HS800-T FBMJ3216HS800-T FBMJ3216HS800-T FBMJ3216HS800-T FBMJ3216HS800-T BK1608 HS121 BK1608 HS121
0.1-16 Z F 0.1-16 Z F 0.1-16 Z F 10-16 M 5.5L MV 10-16 M 5.5L MV 2200P-50 K B 2200P-50 K B 2700P-50 K B GRM 2700P-50 K B GRM 270P-50 K B GRM 270P-50 K B GRM 2.2-50 M MV 2.2-50 M MV 22-16 M 5.5L MV 22-16 M 5.5L MV 39P-50 J CH 39P-50 J CH 10-16 M 5.5L MV 0.1-16 Z F 0.1-16 Z F 10-16 M 5.5L MV 0.1-16 Z F 0.1-16 Z F 10-16 M 5.5L MV 10-16 M 5.5L MV 100P-50 47-16 M 0.01-25 0.01-25 22-16 M J CH 5.5L WX K B K B 5.5L MV
C-F-BEAD, BK1608 HS121 FLEX-PWB,33P RF JACK,DC 4.75 BLK 10.5 C-SOCKET,IC 2-44P IC179-44600 JACK,Y/CYKF51-5503 JACK,PIN 3P WHT YKC21-5816 C-COIL,47UH-D124C C-COIL, 22UH M D75C C-COIL,100UHD73C-636CY C-COIL,100UHD73C-636CY C-COIL, 1.0UH K FLC32 C-COIL,100UHD73C-636CY C-F-BEAD, FBMJ3216HS800-T C-COIL, 2.2UH K FLC32 C-COIL,100UHD73C-636CY C-COIL, C-COIL, C-COIL, C-COIL, C-COIL, C-COIL, C-COIL, C-COIL, C-COIL, C-COIL, C-COIL, C-COIL, C-COIL, C-COIL, C-COIL, C-COIL, C-COIL, C-COIL, C-COIL, C-COIL, C-COIL, C-RES,U C-RES,U C-RES,U C-RES,U 10UH FLC32 10UH FLC32 1.0UH K FLC32 1.0UH K FLC32 1.0UH K FLC32 1.0UH 1.0UH 1.0UH 1.0UH 2.2UH K K K K K FLC32 FLC32 FLC32 FLC32 FLC32
0.01-25 K B 47-16 M 5.5L WX 47-16 M 5.5L WX 0.1-16 Z F 0.1-16 Z F 0.1-16 Z F 0.01-25 K B 47-16 M 5.5L WX 0.01-25 K B 10-16 M 5.5L MV 0.01-25 K B 39P-50 J CH 27P-50 J CH 33P-50 J CH 12P-50 J CH 18P-50 J CH 33P-50 J CH 12P-50 J CH 18P-50 J CH 6P-50 D CH 0.01-25 K B 10-16 M 5.5L MV 4.7-35 M 5.5L MV 22-16 M 5.5L MV 100-16 M WX
2.2UH K FLC32 22UH J FLC32 2.2UH K FLC32 22UH J FLC32 10UH FLC32 33UH 27UH 27UH 27UH 27UH J J J J J FLC32 FLC32 FLC32 FLC32 FLC32
22UH J FLC32 22K-1/16W F 68K-1/16W F 68K-1/16W F 82K-1/16W F
C-RES,U 12K-1/16W F C-RES,U 2.2K-1/16W F SW,SL SLD-12-500H C-VIB,XTAL 10MHZ HC-49/U03C C-VIB,XTAL 16.9344MHZ HC-49/U0
-7-
ELECTRICAL MAIN PARTS LIST -4/4
REF. NO X0600 X0700 FRONT C.B C0500 C0501 C0502 C0503 C0504 C0505 C0506 CN0500 L0500 LCD0500 LED0500 LED0501 S0500 S0501 S0502 S0503 S0504 S0505 S0506 S0507 S0508 S0509 S0510 S0511 S0512 S0513 S0514 S0515 87-010-831-080 87-010-831-080 87-012-272-080 87-010-831-080 87-010-498-080 87-010-831-080 87-010-498-080 87-A60-769-010 87-005-184-080 8A-AV6-608-010 87-A40-943-010 87-A40-943-010 87-A90-164-080 87-A90-164-080 87-A90-164-080 87-A90-164-080 87-A90-164-080 87-A90-164-080 87-A90-164-080 87-A90-164-080 87-A90-164-080 87-A90-164-080 87-A90-164-080 87-A90-164-080 87-A90-164-080 87-A90-164-080 87-A90-164-080 87-A90-164-080 C-CAP,U 0.1-16 Z F C-CAP,U 0.1-16 Z F C-CAP,U 680P-50 K B GRM C-CAP,U 0.1-16 Z F CAP,E 10-16 M 5L SRE C-CAP,U 0.1-16 Z F CAP,E 10-16 M 5L SRE CONN,14P B TMC-D(X) COIL,1UH K EL0606 LCD,AAV-6 LED,SEL6810ALF62 ORG LED,SEL6810ALF62 ORG SW,TACT SKQNAB(N) SW,TACT SKQNAB(N) SW,TACT SKQNAB(N) SW,TACT SW,TACT SW,TACT SW,TACT SW,TACT SW,TACT SW,TACT SW,TACT SW,TACT SW,TACT SKQNAB(N) SKQNAB(N) SKQNAB(N) SKQNAB(N) SKQNAB(N) SKQNAB(N) SKQNAB(N) SKQNAB(N) SKQNAB(N) SKQNAB(N) KANRI DESCRIPTION NO. 87-A70-194-080 C-VIB,XTAL 20MHZ HC-49/U03C 87-A70-195-080 C-VIB,XTAL 27MHZ HC-49/U03C PART NO. REF. NO PART NO. KANRI NO. DESCRIPTION
SW,TACT SKQNAB(N) SW,TACT SKQNAB(N) SW,TACT SKQNAB(N)
· Regarding connectors, they are not stocked as they are not the initial order items. The connectors are available after they are supplied from connector manufacturers upon the order is received.
CHIP RESISTOR PART CODE
Chip Resistor Part Coding
8 8
A
Resistor Code Value of resistor Chip resistor
Dimensions (mm)
Figure
Wattage 1/16W 1/16W 1/10W 1/8W
Type 1005 1608 2125 3216
Tolerance 5% 5% 5% 5%
Symbol CJ CJ CJ CJ
Form
L W
L 1.0
t
W 0.5 0.8 1.25 1.6
t 0.35 0.45 0.45 0.55
:A Resistor Code : A
104 108 118 128
1.6 2 3.2
-8-
TRANSISTOR ILLUSTRATION
8 C D
7
6
5
B E
E B C 2SB1132
G S
1
2
3
4
2SA1037 2SA1586 2SC2412 2SC3326 2SC4116 2SC4213 DTA114EK DTA144EK DTC144EK DTC144EU
3LN01C
FTS1002
-9-
BLOCK DIAGRAM
(TE2)
IC606 P-ROM AAV6 (VER.17B): LH (E): K,EZ ROM IC608 UT611024LC-12 DRAM
-10-
SCHEMATIC DIAGRAM - 1 (MAIN C.B -1/9)
DC10V
VSS
-11-
SCHEMATIC DIAGRAM - 2 (MAIN C.B -2/9)
-12-
SCHEMATIC DIAGRAM - 3 (MAIN C.B -3/9)
-13-
SCHEMATIC DIAGRAM - 4 (MAIN C.B -4/9)
NOT USED
3T BOOST SW
LASER DIODE CURRENT SUPPLY FOR DVD
DEFECT INHIBIT SW
NOT USED
H
Q304 LASER DIODE CURRENT SUPPLY FOR CD
FE DEFECT ENABLE/ DISABLE CTL DEFECT INHIBIT SW
DEFECT INHIBIT SW FE DEFECT ENABLE/ DISABLE CTL
FE DEFECT ENABLE/ DISABLE CTL
SWITCH
SWITCH
-14-
SCHEMATIC DIAGRAM - 5 (MAIN C.B -5/9)
-15-
SCHEMATIC DIAGRAM - 6 (MAIN C.B -6/9)
AND GATE
R614 47k R616 : 22k : 39k R621 10k
: 33k : 10k
POWER ON INVERTOR
NC NC NC
C643 0.01
R662 47k
P-ROM AAV-6(VER.029)
UT611024LC-12
-16-
SCHEMATIC DIAGRAM - 7 (MAIN C.B -7/9)
D-RAM
D-RAM
(TE2)
TP715
AUDIO DAC ZERO MUTE
AUDIO MUTE
AUDIO DAC ZERO MUTE
AUDIO MUTE
-17-
SCHEMATIC DIAGRAM - 8 (MAIN C.B -8/9)
2SA1037K(R)
VFU
-18-
SCHEMATIC DIAGRAM - 9 (MAIN C.B -9/9)
S950 NTSC H: NTSC L: PAL PAL
CHROMA SIGNAL S2 DC VOLTAGE SUPER IMPOSE
CHROMA SIGNAL S2 DC VOLTAGE SUPER IMPOSE
-19-
WIRING - 1 (MAIN C.B) -Top View
32 31 30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 A
This wiring diagram show a 4-layer boards. The , , a ~ z, a ~ c marks show the connections between the usual double-face patterns and the patterns on the internal layers that cannot be seen. The patterns with marks are connected to +B patterns. The patterns with marks are connected to GND patterns. The patterns with a ~ z, a ~ c marks are connected to each alphabetical jumper patterns.
B
C
D
E
F
G
H
I
J
K
L
M
N
O
R616
R614 R621
P
Q
R
S
T
U
-20-
WIRING - 2 (MAIN C.B) -Bottom View1 A 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32
B
TO FE PROGRAM WRITING IIG
C
S950
S950 PAL NTSC
D
E
F
G
1 14 3 5 7 12 10 8
H
I
J
K
L
M
N
O
P
Q
R
S
DC10V
T
U
-21-
SCHEMATIC DIAGRAM - 10 (FRONT C.B)
LED DRIVE
IC500 POWER SUPPLY SW
-22-
WIRING - 3 (FRONT C.B)
1 A 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32
B
C
D
E
F
G
H
I
J
K
L
1 2
5 6
9 10
13 14
M
N
O
P
Q
R
S
T
U
-23-
SCHEMATIC DIAGRAM - 11 (DVD MECHANISM SECTION)
-24-
WIRING - 4 (DVD MECHANISM SECTION)
15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 A
PICK-UP
B
C
D
E
CON1 1
F
FFC1 TO MAIN C.B CN300
G
33
H
I
J
DECK C. B
M1 SPINDLE MOTOR CNA402 9 TO MAIN C.B CN402 7 5 3 1 BLK BLK BLK BLK BLK BLK BLK BLK RED 9 7 5 3 1 SW1 SW1 LIMIT SWITCH RED BLK WHT
SENSOR C. B
PS1 M1 RED BLK WHT
K
L
M
N
PS1 PHOTO INTERRUPTER
O
P
Q
CON2 9 7 5 3 1 M2 M2 SLED MOTOR
R
S
T
U
-25-
LCD DISPLAY
-26-
IC BLOCK DIAGRAM - 1/4
IC, BA00ASFP
IC, SN74LV541APW
-27-
IC BLOCK DIAGRAM - 2/4
IC, NJM2267M
V+ 7
IC, MM1454XFBE
VIN2 8
6.2dB Amp
CLAMP
75 DRIVER 750
5 VOUT2 6 VSAG2
2.2k 2.07k
VIN1 1
CLAMP
6.2dB Amp
75 DRIVER 750
4 VOUT1
3 VSAG1 2.07k 2.2k
2 GND
IC, LC75854W
COM1 COM2 COM3 COM4 S39 S38 S37 S36 S35 S34 S33 S32 S31 S30 S29 S28 S27 S26 S25 S24 S23 S22 S21 S20 S19 S18 S17 S16 S15 S14 S13 S12
40
41
42
43
39 38 37 36 35 34 33 32 31 30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 SEGMENT DRIVER & LATCH 11 10 9 8 7 6 5 4 3 2 1 S11 S10 S9 S8 S7 S6 S5 S4/P4 S3/P3 S2/P2 S1/P1
TEST 55
COMMON DRIVER SHIFT REGISTER
OSC 60
CLOCK GENERATOR
CONTROL REGISTER
DO DI CL CE
61 64 63 62
CCB INTERFACE
KEY BUFFER
VDD 56 VDD1 57 VDET VDD2 58 VSS 59 KEY SCAN
54
KI5
53
KI4
52
KI3
51
KI2
50
KI1
49
KS6
48
KS5
47
KS4
46
KS3
45
S41/KS2
44
S40/KS1
IC, NJM2100M
IC, NJM4580E
A OUT 1
A OUTPUT 1 A INTPUT 2 A +INTPUT 3 V 4 A B 6 B INTPUT 8 V+
8 V+ 7 B OUT A B 6 B IN 5 B +IN
A IN 2
7 B OUTPUT
A +IN 3
5 B +INTPUT
V 4
-28-
IC BLOCK DIAGRAM - 3/4
IC, LA6556L-TE-L
REV 2 VCC2 3 LLD- 4 VLD+ 5 VO4+ 6 VO4- 7 VO3- 8 VO3+ 9
INPUT
FWD 1
36 S-GND MUTE2 MUTE1 35 MUTE2 34 MUTE1 33 VIN4 22k 11k 32 VIN431 VIN4+ 30 VREF-IN VIN1/VREF-SW 29 VIN1(VREF)-SW 28 VREF-OUT(CH1)
LEVEL SHIFT
LEVEL SHIFT
OUTPUT CONTROL
FR FR
FR FR
LEVEL SHIFT
VO2+ 10 VO2- 11 VO1+ 12 VO1- 13 VCC1 14
27 REG-OUT 26 REG-IN 22k 25 VIN3+ 24 VIN323 VIN3
LEVEL SHIFT
11k
22k 11k VIN1 15 VIN1-A 16 VIN1+A 17 VIN1-B 18 AMP-B VIN1(VREF)-SW L:AMP-A H:AMP-B 22k 11k AMP-A L H 22 VIN2+ 21 VIN220 VIN2 19 VIN1+B
IC, MM1041XM
IC, TC74HC14AF
2 VCC IN 3 6dB GND 4 OUT 1
-29-
IC BLOCK DIAGRAM - 4/4
IC, PCM1723
Internal System Clock
Data ROM
Counter N Phase Detector & Loop Filter VCO
OSC
Counter M
24 XTO
1 XTI
5 MCKO 27 MHz
2 SCKO 256 fs / 384 fs
IC, S-8520B28MC
VIN 5
OSC
REFERENCE POWER SUPPLY 3 VOUT
EXT 4
PWM CONTROL CIRCUIT
ON/OFF 2 VSS 1 ON/OFF
IC, SN74LV245APW
-30-
IC DESCRIPTION - 1/7 (MC44722AVFU) -1/1
Pin No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 ~32 33 34 35 36 37 Pin Name CVBS/CB
________________
I/O O O
Description Analog composite video signal or Cb signal output current drive (positive) Analog composite video signal or Cb signal output current drive (negative) Power supply for CVBS/Cb DAC circuit
CVBS/CB CVBS/CBVDD Y
___
O O O O O I I O I/O I I I I I I I I/O I/O I/O I/O
Analog luminance signal output current drive (positive) Analog luminance signal output current drive (negative) Power supply for Y DAC circuit Analog signal output or Cr signal output drive (positive) Analog signal output or Cr signal output drive (negative) Power supply for C/Cr DAC circuit Ground for DAC circuit Reference current for the 3 DACs Power supply for DAC current Reference full scale voltage for the 3 DACs 12C chip address select (0 : 42(hex)/43(hex), 1 : IC(hex)/1D(hex) TEST pin (Ground) If SPI mode, serial data output/If 12C mode, connect to ground Serial data input, open drain output. If SPI mode, serial data input. Serial clock Connect to ground. If SPI mode, this pin is chip select. Ground for digital circuit 27 MHz clock input Power supply for digital circuit Reset signal (active Low) NTSC/PAL select. This pin active only reset time (NTSC: Low, PAL: High) 8-bit multiplexed Y/Cr/Cb 4:2:2 data (ITU-Rec656) input (DVIA), or multiplexed Y data (ITURec656/601) input in 16-bit input mode (DVIA7: MSB)
Y YVDD C/CR
_________
C/CR CVDD DAVSS TBIAS DAVDD VREF CHIPA TEST SO SDA/SI SCL/SCK SEL DVSS CLOCK DVDD RESET PAL/NTSC DVIA7 ~ 0 VMUTE C/FSYNC/VBI F/VSYNC HSYNC A/B SEL
Video mute on reset (0: normal, 1: mute), or test data input Csync/frame sync output or external VBI information input Frame sync or vertical sync input/output Horizontal sync input/output Switch control for 8-bit X2 multiplexed Y/Cr/Cb 4:2:2 data (ITU-Rec656) input (DVIA) or (DVIB), or test data I/O
38 ~ 41 42 43 44 ~ 47 48
DVIB7 ~ 4 DVSS DVDD DVIB3 ~ 0 TP
I/O I/O I/O
8-bit multiplexed 4:2:2 data (ITU-Rec656/601) input (2), or multiplexed Cr/Cb data (ITURec656/601) input in 16-bit input mode (MSB DVIB 8), or test data I/O Ground for digital curcuit Power supply for digital circuit 8-bit multiplexed 4:2:2 data (ITU-Rec656/601) input (DVIB), or multiplexed Cr/Cb data (ITURec656/601) input in 16-bit input mode (LSB DVIB), or test data I/O for test (should be ground)
-31-
IC DESCRIPTION -2/7 (L64021D) -1/3
Pin No. 1 2~5 6 7 ~ 10 11 12 ~ 19 20 21 22, 23 24 25 26 27 28 29 30 31, 32 33 34 ~ 39 40 41 42 43 ~ 45 46 47 ~ 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 Pin Name VSS SBD_7 ~ 4 VDD SBD_3 ~ 0 VSS CH_DATA_0 ~ 7 VSS ____ TOS NC _______ ERROR VDD _______ AVALID ________ VVALID DCK _____ VREQ _____ AREQ NC VSS A_8 ~ 3 VDD NC VDD A_2 ~ 0 VSS D_7 ~ 0 VSS SYSCLK ______ RESET ______ DREQ _____ INTR BUSMODE VDD ____ RDY ______ READ ______ WRITE _____ WAIT/WTN VSS NC ___ CS VS HS I/O I I/O I I/O I I I I I I I I I I O O -- I I I -- I I I I/O I I I O O I I O I I I/O I -- I I I Ground. SDRAM data bus 7 ~ 4. Power (3.3V). SDRAM data bus 3 ~ 0. Ground. Channel data bus 0 ~ 7. Ground. Top of sector. Not connected. Error. Power (3.3V). Audio data valid. Video data valid. Data clock. Video transfer request. Audio transfer request. Not connected. Ground. Address 8 ~ 3. Power (3.3V). Not connected. Power (3.3V). Address 2 ~ 0. Ground. Host data bus 7 ~ 0. Ground. System clock. Reset. DMA transfer request. Interrupt. Busmode. Power (3.3V). Ready. Read indicator. Write indicator. Wait. Ground. Not connected. Chip select. Vertical synchronization. Horizontal synchronization. Description
-32-
IC DESCRIPTION - 2/7 (L64021D) -2/3
Pin No. 71 72 73, 74 75 76-78 79 80 81 82 ~ 84 85 86 87 88 ~ 91 92 93 94 95 96 97 98 99 100 101 102 103 104 105 106 107 108, 109 110 111 112 113, 114 115 116 117 118 119, 120 121 122 Pin Name VDD OSD_ACTIVE PD_0, 1 VSS PD_2-4 VDD NC VSS PD_5 ~ 7 VSS BLANK CREF EXT_OSD_0 ~ 3 NC VDD ACLK_441 ACLK_48 ACLK_32 VSS CD_BCLK CD_LRCLK CD_ACLK CD_ASDATA SPDIF_IN A_ACLK VDD BCLK LRCLK ASDATA NC VSS SPDIF_OUT AUDIO_SYNC TM1, TM0 ZTEST SCAN_TE _____ PREQ VDD SBD_15, 14 NC SBD_13 I/O I O O I O I -- I O I O O I O I I I I I I I I I I O I O O O O I O O I I I O I I/O -- I/O Power (3.3V). On screen display active. Pixel data output bus 0, 1. Ground. Pixel data output bus 2-4. Power (3.3V). Not connected. Ground. Pixel data output bus 5 ~ 7. Ground. Blank (composite). Chroma reference for pixel data. External OSD palette selection bus 0 ~ 3. Not connected. Power (3.3V). Audio input clock for 44.1kHz*N. Audio input clock for 48kHz*N. Audio input clock for 32kHz*N. Ground. CD-Serial DAC bit clock. CD-Left right clock. CD-External audio clock. CD-Audio serial data line. Sony/Philips data interface-input. Output audio clock. Power (3.3V). Serial DAC bit clock. Serial DAC left right clock. Audio serial data line. Not connected. Ground. Sony/Philips data interface output. Audio sync strobe. Test mode 1, 0. Test mode pin. Scan test mode pin. PCM FIFO request. Power (3.3V). SDRAM data bus 15, 14. Not connected. SDRAM data bus 13. Description
-33-
IC DESCRIPTION - 2/7 (L64021D) -3/3
Pin No. 123 124 ~ 126 127 128, 129 130 131 132 ~ 134 135 136 ~ 138 139 140 ~ 142 143 144 145, 146 147 148 149 150 151 152 153 154 155 166 157 158 159 160 Pin Name VSS SBD_12 ~ 10 VDD SBD_9, 8 SCLK VSS SBA_9 ~ 7 VDD SBA_6 ~ 4 VSS SBA_3 ~ 1 VDD SBA_0 SBA_10, 11 VSS _____ SCS1 ____ SCS _____ SRAS VDD _____ SCAS ____ SWE SDQM VSS PLLVDD NC PLLVSS VDD NC I/O I I/O I I/O I/O I O I O I O I O O I O O O I O O O I I -- I I -- Ground. SDRAM data bus 12 ~ 10. Power (3.3V). SDRAM data bus 9, 8. SDRAM 81MHz clock. Ground. SDRAM address bus 9 ~ 7. Power (3.3V). SDRAM address bus 6 ~ 4. Ground. SDRAM address bus 3 ~ 1. Power (3.3V). SDRAM address bus 0. SDRAM address bus 10, 11. Ground. Chip select for second DRAM. Chip select for SDRAM. SDRAM row address strobe. Power (3.3V). SDRAM column address strobe. SDRAM write enable. SDRAM control pin. Ground. Power-phase locked loop for SDRAM. Not connected. Phase locked-loop ground pin. Power (3.3V). Not connected. Description
-34-
IC DESCRIPTION - 3/7 (HD6412350F20) -1/3
Pin No. 1 2 3, 4 5 6~9 10 11 ~ 18 19 20 ~ 27 28 29 30 31 32 33, 34 35, 36 37 38 39 40 ~ 43 44 45 ~ 52 53 54 ~ 57 58 59 60 61 62 63 64 65 66 67, 68 69 70 71 72 73 74 75 Pin Name
________________
I/O -- O I I O I O I O I O -- I I -- I O I/O I I/O I I/O I I/O I O O I I O O I O I O I O O O I O Not used.
Description
CS1ROM
________________
CS0ROM VSS VCC A0 ~ 3 VSS A4 ~ 11 VSS A12 ~ 19 VSS A20 CODEC_ERR
____________________
Chip select output terminal for ROM. GND. Power input terminal. EVER 5 V. Address bus output terminal. GND. Address bus output terminal. GND. Address bus output terminal. GND. Not used. Not used. Interrupt signal for AV DECODER IC. Interrupt signal from LOADER. Not used. GND. EEPROM serial clock output. EEPROM serial data I/O. Power input terminal. EVER 5 V. Data bus input/output terminal. GND. Data bus input/output terminal. GND. Data bus input/output terminal. Power input terminal. EVER 5 V. Data output terminal for FL DRIVER IC serial communication control. Data output terminal for LOADER serial communication control. Data input terminal for FL DRIVER IC serial communication control. Data input terminal for LOADER serial communication control. Clock output terminal for FL DRIVER IC serial communication control. Clock output terminal for LOADER serial communication control. GND. Chip select output terminal for AV DECODER IC. GND. Chip select output terminal for SRAM. MPEG decoder data request. Reset for Front Board. FL DRIVER IC chip select output terminal. System reset signal output terminal. Remote control signal input terminal. I2C clock output terminal for EEPROM, video encoder IC.
INT_VDEC
_______________
HD_INT P67, 66 VSS SCL SDA VCC D0 ~ 3 VSS D4 ~ 11 VSS D12 ~ 15 VCC TXD0 TXD1 RXD0 RXD1 SCK0 SCK1 VSS
__________________
CS VDEC VSS
________
CS5 DREQ1 RESET FR CS_FR
________________
SYSRST REMOCON USCL
-35-
IC DESCRIPTION - 3/7 (HD6412350F20) -2/3
Pin No. 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97, 98 99, 100 101 102 103 104 105 106 107 108 109 110 111 112 113 114 115 116 117 118 Pin Name USDA UML UMC UMD
__________________
I/O I/O O O O O I I I I I I I -- I -- O O O O -- O -- I O -- I I -- I I I I -- -- O I I -- -- -- -- Not used. (pull up) Not used. Not used. (pull up) Not used. (pull up) GND. Power input terminal. EVER 5 V.
2
Description I C data input/output terminal for EEPROM, video encoder IC. Data enable signal output terminal for AUDIO DAC IC control. Clock for AUDIO DAC IC control. Data output terminal for AUDIO DAC IC control. Watch dog timer overflow signal output terminal. Micro processor reset input terminal. Fixed is to "H".
WDTOVF
______________
RESET NMI
___________
STBY VCC XTAL EXTAL VSS fO VCC
______
Crystal oscilator input terminal. 20 MHz.
Not used. (System clock output for external device.) Power input terminal. EVER 5 V. Not used. (Address strobe.) Lead signal output terminal for bus control. "H" write signal output terminal for bus control. "L" write signal output terminal for bus control. Bus request output terminal. Not used. (Bus request acknowlege.) Reset signal output terminal for LOADER. Not used. GND. Q SURROUND IC control terminal. ON = H OFF = L. Not used. Power supply input terminal for A/D. EVER 5V. Reference voltage input terminal for A/D. EVER 5V. Not used. NTSC: L, PAL: H (for DVD output) DVD REGION CODE, 1: 0 ~ 1 V, 2: 1 ~ 2 V, 3: 2 ~ 3 V, 4: 3 ~ 4 V, 5: 4 ~ 5 V. Karaoke echo volume control 0 ~ 5 V. NTSC/PAL serect (for VIDEO CD) (Not used). Not used. Not used. Voltage output for S2 terminal. S1 = 5V S2 = 2.5 V Normally = 0 V. GND.
AS
______
RD
__________
HWR
__________
LWR
____________
WAIT PFO HRST YS SCK, YS SI VSS Q_SURROUND TEST MUTE AVCC VREF V-DET _____ NTSC/PAL REGION ECOHVOL SW C2PO EMPH SV2 AVSS VSS AK4527CS RGB/YC ____ YS912 CBS CS-KARAOKE
-36-
IC DESCRIPTION - 3/7 (HD6412350F20) -3/3
Pin No. 119 120 121 122 123, 124 125 126 127 128 Pin Name AMUTE POWER ON A MUTE AC-3 ___ YS917 CS MD0, 1 MD2 PG0 LID RDY HIF I/O O O -- -- I I -- I I Description Audio signal (analog audio) output mute control terminal ON = H OFF = L. Power supply control terminal ON = H OFF = L. Not used. Not used, Operation mode control Fixed to L. Operation mode control Fixed to H. Not used. (VMUTE control) OPEN/CLOSE sensor Front END µcom RDY
-37-
IC DESCRIPTION - 4/7 (LC87F72C8A)-1/2
Pin No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 ~ 42 43 ~ 50 51 52 53 54 55 Pin Name SUBRXD SUBSCK LEDD1 LEDCSB LEDCLK RDY_HIF PWM RESET XT1/AN10 XT2/AN11 GND CLOCK CLOCK +5V TESTKEY BUSYB FBUSYB HEXKEY P84/AN4 OPEN_SW CLOSE_SW LSW HIRQB INT_SUBSCK FGO WRQ S0/PA0 FEL_CSBI FEL_CSBO ZWR ZRD S5/PA5 WAITB S7/PA7 DB0 ~ 7 AB0 ~ 7 +5V GND S24/PD0 DEFINHB TOPEN I/O I I O O O O O I I I/O -- I O -- O I I O O O O I I I I I O O O O O O I I/O I/O O -- -- O O I Description DATA input terminal for LOADER serial communication control. Clock input terminal for LOADER serial communication control. Detection of LEDD1. Detection of LEDCSB. Detection of LEDCLK. LOADER READY signal output terminal. Detection of PWM. Reset signal input terminal. Input for 32.768kHz crystal oscillation. AD input port: AN10. (Connected to power supply) Out put for crystal oscillation. AD input port: AN11. (Not Connected) GND. In put for 10MHz crystal oscillation. Out put for 10MHz crystal oscillation. Power supply 5V. TESTKEY output pin. DSP command dispose busy signal input pin. DSP command receiver busy signal input pin. Detection of HEXKEY. Detection of P84/AN4. Detection of OPEN SW. Detection of CLOSE SW pin. LIMIT SW input pin. Interrupt signal input pin. Clock input terminal for LOADER serial communication control. SENSER input. Subcode Q read ready monitor input. LCD display segment output. (Not Connected) Chip select signal output pin. Chip select signal output pin. Write signal output pin. Read signal output pin. FECONT control output pin. Wait signal input pin. Detection of S7/PA7. Data 0 ~ 7. Address 0 ~ 7. Power supply 5V. GND. Detection of S24/PD0. DEFINHB control output. RF general-purpose port output pin 0.
-38-
IC DESCRIPTION - 4/7 (LC87F72C8A)-2/2
Pin No. 56 57 58 59 60 61 ~ 65 66-68 69 ~ 72 73 74, 75 76 77 ~ 79 80 ~ 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98, 99 100 Pin Name CURRENT RW_DISC DUAL DECRESB EVARESOB AB8-12 S37-39/PE5 ~ 7 CONT1-4 S44/PF4 OUT 1, 2 HD_INT V3-1/PL6 ~ 4 COM0-3/PL0 ~ 3 TRY_FWD TRY_REV GND +5V DMUTE F_DIO F_CLK F_DIOI DPD_TEB RFSCT XQBH EQSCT CD3T PP_TEB LDON1, 2 SUBTXD I/O I O O O O O O O O O O O O O O -- -- O O O O O O O O O O O O Description RF general-purpose port output pin 2. RW DISC control output pin. DUAL control output pin. Decoder reset output pin. System reset output pin. Address 8-12. Detection of S37-39/PE5 ~ 7. CONT1-4 output pin. Detection of S44/PF4. Detection of OUT 1, 2. Interropt signal for AV DECODER IC/TEST PIN. Detection of V3-1/PL6 ~ 4. Detection of COM0-3/PL0 ~ 3. TRY control output. TRY control output. GND. Power supply pin (+). MUTE output pin. F_DIO output pin. F_CLK output pin. F_DIOI output pin. DPD_TEB output. RFSCT control output. XQBH out put. (Not Connected) EQSCT output. CD3T control output. PP TEB output. LDON 1, 2 output. DATA output terminal for LOADER serial communication control.
-39-
IC DESCRIPTION - 5/7 (LC78660W)-1/4
Pin No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 Pin Name RFPI TEST0 DVDD2 DVSS AD5/BH AD4/PH/TE AD3 AD2 AD1/JV AD0/RREC RF_PH RF_BH TE FE TEST0 EFMINP TEST1 EFMINN SLCLPF0 SLCLPF1 SLC01 SLC02 AVDD1 ADSS VREF SLCBIAS TESBIAS HFLBIAS OFSET BCA BOOT3T RFVCA TBAL FBAL SGC SLSO SPDO TDO FDO DVSS DVDD0 I/O I I/O -- -- I I I I I I I I I I I I I I -- -- -- -- -- -- O O O O O O O O O O O O O O O -- -- RF input port pin. (Pull down) Tracking margin signal I/O pin. A/D D/A internai logic power supply. [Digital 5V] Digital GND. Servo A/D input pin. (AD5: Assistant input 5) Servo A/D input pin. (AD4: Assistant input 4) Servo A/D input pin. (AD3: Assistant input 3) Servo A/D input pin. (AD2: Assistant input 2) Servo A/D input pin. (AD1: Assistant input 1) Servo A/D input pin. (AD0: Assistant input 0) Servo A/D input pin. (RF_PH: RF peak hold signal) Servo A/D input pin. (RF_BH: RF bottom hold signal) Servo A/D input pin. (TE: Tracking error signal) Servo A/D input pin. (FE: Focus error signal) Test input pin 0. (L Fixed) EFM/EFM+input pin. Test input pin 1. (L Fixed) EFM-input pin. SLC LPF pin. SLC LPF pin. SLC control pin. SLC control pin. A/D D/A SLC power supply. [Analog 5V] Analog GND. Servo D/A standerd voltage. Servo D/A output pin. (SLCBIAS: SLC standerd voltage signal) Servo D/A output pin. (TESBIAS: TES standerd voltage signal) Servo D/A output pin. (HFLBIAS: HFL standerd voltage signal) Servo D/A output pin. (OFSET: Assistant signal) Servo D/A output pin. (BCA: Assistant signal) Servo D/A output pin. (BOOT3T: Assistant signal) Servo D/A output pin. (RFVCA: Assistant signal) Servo D/A output pin. (TBAL: Tracking balance control signal) Servo D/A output pin. (FBAL: Focus balance control signal) Servo D/A output pin. (SGC: Assistant signal) Servo D/A output pin. (SLSO: Thread control signal) Servo D/A output pin. (SPDO: Spindle control signal) Servo D/A output pin. (TDO: Tracking control signal) Servo D/A output pin. (FDO: Focus control signal) Digital GND. Internal logic power supply. [Digital 3.3V] Description
-40-
IC DESCRIPTION - 5/7 (LC78660W)-2/4
Pin No. 42 43 44 45 ~ 48 49 50 51 52 53 54 55 56 57 58 59 60 61 ~ 68 69 ~ 81 82 83 84 85 86 87 88 89 90, 91 92 93 94 95 96 97 98 99 100 101 102 103 104 105 Pin Name FG EVENT HFLIO PP0 ~ 3 WRQ HFBUSYB HBUSYB DVDD3 DVSS HWAITB HIRQB DVDRESB RESB HRDB HWRB HCSB HDAT0 ~ 7 HADR0 ~ 12 DVDD3 DVSS PW/FSEQ SBCK SBSY SFSY FSX EFLG PP4, 5 X16MOUT X16MIN TEST2 DVDCKOUT DVDCKIN TEST3 DVDD0 DVSS VPDO VRPFR VCOC AVSS AVDD3 DVSS I/O I I I/O I/O O O O -- -- O O I I I I I I/O I -- -- O I O O O O I/O O I I O I I -- -- -- -- -- -- -- -- FG counter input pin. EVENT counter input pin. (Pull down) Mirror detest signal I/O pins. General-purpose port 0 ~ 3. (Pull down) Subcode Q read ready monitor pin. DSP command dispose busy signal output pin. DSP command receiver busy signal output pin. I/O power supply. [Digital 5V] Digital GND. Wait signal output pin. Interrupt signal output pin. Decoder reset input pin. System reset input pin. Read signal input pin. Write signal input pin. Chip select signal input pin. Data0 ~ 7. Address0 ~ 12. I/O power supply. [Digital 5V] Digital GND. Subcode [P, Q, R, S, T, U, V and W] data output pin. Subcode data readout shift clock input pin. (Connected to GND) Subcode block synchronization signal output pin. (No connected) Subcode frame synchronization signal output pin. CD1 frame synchronization signal. Error correction C1, C2 correction conditions monitor pins. General-purpose port4, 5. (Pull down) Internal 16MHz output pin. (No connected) External 16MHz input pin. Test input pin2. (L Fixed) Internal DVD clock output pin. External DVD clock input pin. (Pull down) Test input pin3. (L Fixed) Internal logic power supply. [Digital 3.3V] Digital GND. SYSTEM PLL filter connection pin. SYSTEM PLL VCO oscillator range adjustment pin. SYSTEM PLL filter connection pin. Analog GND. SYSTEM VCO power supply. [Analog 3.3V] Digital GND. Description
-41-
IC DESCRIPTION - 5/7 (LC78660W)-3/4
Pin No. 106 107 108 109, 110 111 112 113 114 115 116 117 118 ~ 125 126 127 128 129 130 131 132 133 134 135 136 137 138 139 140 141 142 ~ 144 145 146 147 148 149 150 151 152, 153 154 155 156 157 Pin Name XIN XOUT DVDD6 PP6, 7 AVREQIO AVACKOI AVDACK AVSCTB AVERRB DVSS DVDD4 AVD0 ~ 7 C2F ROMXA ROMCK LRSY EMPH DOUT DVDD4 DVSS EFMOUT LEFM PCK DVDD4 DVSS VCOCTL PPDO FPDO LF1 ~ 3 PCN PISET FISET CDFR DVDFR AVDD2 AVSS2 JVCPI, JVCPC JVAO JVAIN JVRVO AVDD4 I/O I O -- I/O I/O I/O O O O -- -- O O O O O O O -- -- O O O -- -- -- -- -- -- -- -- -- -- -- -- -- -- O -- -- -- Oscillator circuit input pin. Oscillator circuit outpit pin. Oscillator circuit power supply. [Digital 3.3V] General-purpose port6, 7. (Pull down) AV data demand flag I/O pins. AV data read strobe output pin. AV data read (Clock/Enable) output pins. AV output sector synchronization output pin. AV data reliable flag output pin. Digital GND. I/O power supply. [Digital 3.3V or 5V] AV data0 ~ 7. C2 flag output pin. CD data output pin. CD data output shift lock output pin. CD data output L/R clock output pin. Deemphasis monitor pin. Audio EIAJ data output pin. I/O power supply. [Digital 3.3V or 5V] Digital GND. EFM 2 value signal output pin. Output pin for the signal picked out from EFM binary signal with PCK. EFM playback shift clock output pin. Inner logic power supply. [Digital 3.3V] Digital GND. VCO filter connection pin. Phase comparison filter connection pin. Frequency comparison filter connection pin. Filter connection pin1 ~ 3. Voltage monitor pin. (Phase comparison charge pomp PCH control voltage) Current setting pin for the constant-current phase comparison charge pump. Current setting pin for the constant-current frequency comparison charg pump. EFM playback VCO oscillator range setting pin. [For CD] (Pull down) EFM playback VCO oscillator range setting pin. [For DVD] (Pull down) EFM PLL JV power supply. [Analog 5V] Analog GND. JV control pin. EFM playback PLL clock jitter output pin. JV control pin. (Pull down) JV control pin. (No connected) SYSTEM PLL power supply. [Analog 3.3V] Description
-42-
IC DESCRIPTION - 5/7 (LC78660W)-4/4
Pin No. 158 159 ~ 166 167 168 169 ~ 176 177 ~ 184 185 186 187 188 ~ 191 192 193 194 195 196 197 198 199 200 ~ 204 205 206 207 208 Pin Name AVSS MD15 ~ 8 DVDD5 DVSS MD7 ~ 0 MA0 ~ 7 DVDD5 DVSS MA8 MA9-12 MRAS0B MRAS1B MCASUB MCASLB MOEB MWEB DVSS DVDD0 RFP0 ~ 4 DBFECTO DEFECTTI DVSS DVDD1 I/O -- I/O -- -- I/O O -- -- O O O O O O O O -- -- O O I -- -- Analog GND. DRAM data15 ~ 8. I/O power supply. [Digital 5V] Digital GND. DRAM data7 ~ 0. DRAM address0 ~ 7. I/O power supply. [Digital 5V] Digital GND. DRAM address8. DRAM address9 ~ 12. (No connected) RAS output pin0. RAS output pin1. (No connected) CAS output pin. (Upper Byte) CAS output pin. (Lower Byte) OE output pin. WE output pin. Digital GND. Inner logic power supply. [Digital 3.3V] RF general-purpose port output pin0 ~ 4. Defect signal output pin. Defect signal input pin. Digital GND. I/O power supply. [Digital 5V] Description
-43-
IC DESCRIPTION - 6/7(LA9702W)-1/2
Pin No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 Pin Name RFM RFP PD1 PD2 PD3 PD4 PD5 PD6 PD7 PD8 PD9 VCC LDD1 LDS1 LDD2 LDS2 GND SGC FBAL TEBL VGA BST FOST TOST BCATH REFI 2.5V OUT RRBC FE TE THC WO ISET WOI WOO TEO TEN CP BHI RFON I/O I I I I I I I I I I I -- O I O I -- I I I I I I I I I O O O O -- O -- I O -- -- -- -- O RF signal - input. (Pull down) RF signal + input. Pickup signal input. Pickup signal input. Pickup signal input. Pickup signal input. Pickup signal input. Pickup signal input. Pickup signal input. Pickup signal input. Pickup signal input. Power supply. (Servo signal system) APC1 output. APC1 monitor voltage input. APC2 output. APC2 monitor voltage input. Ground. (Servo signal system) Servo gain control terminal. (RREC, FE, TE) Focus balance adjustment terminal. Tracking balance adjustment terminal. RF gain adjustment terminal. Equalizer boost adjustment terminal. Focus offset adjustment terminal. Tracking offset adjustment terminal. BCA threshold adjustment terminal. Reference voltage setting terminal. Reference voltage output for servo signal. Reflection output. Focus error output. Tracking error output. External capacitor for setting TE hold time constant is connected to this terminal. Warble output terminal. External resistor for setting BPF center frequency is connected to this terminal. (Pull down) Push-pull signal input. Push-pull signal output. TE gain setting terminal for 3 beam. TE gain setting terminal for 3 beam. External resistor and capacitor for setting charge pump gain, are connected to this terminal. External resistor for setting bottom hold detection constant, is connected to this terminal. (Pull down) RF - output. Description
-44-
IC DESCRIPTION - 6/7 (LA9702W)-2/2
Pin No. 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 Pin Name RFOP BH PHI PH BCA DEF DEFC TC GND LPC CPOF EQO2 TH EQL2 VCC EQO4 XHTR BQL4 XQBH EQO3 EQSCT EQI3 DPD/TEB RFO2 RFO1 VCC EQI1 TE/PP EQO1 LDON2 EQI2 LDON1 EQO2 GND EQL1 RFSCT EQO1 CAO PREF OAN I/O O O -- O O O -- -- -- -- I -- I I -- O I I I O I I I O O -- I I O I I I O -- I I O O -- I RF + output. RF bottom detection output. External resistor for setting peak hold detection constant, is connected to this terminal. (Pull down). RF peak detection output. BCA output. Defect output. (H: Defect detection) External resistor for defect detection is connected to this terminal. External resistor for setting defect detection constant is connected to this terminal. Ground. (DPD system) External capacitor for RF DC servo is connected to this terminal. Charge pump OFF terminal. (H: OFF) RF equalizer setting terminal. Tracking hold. (H: Hold) RF equalizer setting terminal. Power supply. (DPD system) RF equalizer setting terminal. Tracking bottom detection band switch. (L: High band) RF equalizer setting terminal. Bottom detection constant switch. (L: High speed) RF equalizer setting terminal. Equalizer switcher. (H: 77-pin selection, L: 52-pin selection) RF equalizer setting terminal. DPD 3-beam tracking switcher. (H: DPD) RF output. RF output. Power supply. (RF system) RF equalizer setting terminal. 3-beam push-pull tracking switcher. (L: 3-beam) RF equalizer setting terminal. APC2 laser ON terminal. (H: ON) RF equalizer setting terminal. APC1 laser ON terminal. (H: ON) RF equalizer setting terminal. Ground. (RF system) RF equalizer setting terminal. RF input switcher. (H: RF different input, PP error) RF equalizer setting terminal. Customer amplifier output. Reference voltage output. (for pick) Customer amplifier input. Description
-45-
IC DESCRIPTION - 7/7 (HN58X2416FPI) -1/1
Pin No. 1~3 4 5 6 7 8 Pin Name NC VSS SDA SCL WP VCC I/O -- -- I/O I I -- Not used. Ground Serial data input/output Serial clock input Write protect Power supply Description
-46-
MECHANICAL EXPLODED VIEW 1/1
1
PWB
15 2 16 SH,LCD 11 10 3 4 9 14 PWB 20 a
5
C a C C 6 12 7 19 COVER,PICK UP 8 SHLD-CASE, BTTM 13
21
A
A 17
B B 18 18
-47-
MECHANICAL MAIN PARTS LIST 1/1
REF. NO 1 2 3 4 4 5 6 7 8 9 10 11 12 13 14 15 16 16 17 17 17 18 19 20 21 PART NO. 8A-AV6-007-010 8A-AV6-005-110 8A-AV6-001-010 8A-AV6-216-010 8A-AV6-205-010 87-036-389-010 87-063-164-010 8A-AV6-006-010 8A-AV6-003-010 8A-AV6-008-010 8A-AV6-009-010 8A-AV6-608-010 8A-AV6-010-010 8A-AV6-012-010 8A-AV6-202-010 8A-AV6-201-010 8A-AV6-002-010 8A-AV6-013-010 8A-AV6-020-010 8A-AV6-018-110 8A-AV6-019-110 8A-AV6-215-010 87-A91-554-010 87-HC4-014-010 8A-AV6-299-010 KANRI NO. DESCRIPTION
WINDOW,LID LID,DISK CABI,TOP SPR-T,LID 2 SPR-T,LID SW,PUSH 1-1-1 R8120125 OIL-DMPR, WINDOW,LCD CABI,FRONT BADGE,AIWA 25 SIL KEY,POWER LCD,AAV-6 KEY,PLAY KEY,ENTER LENS,LCD HLDR,LCD CABI,CNTR CABI,CNTR W/SW CABI,BTTM LH CABI,BTTM K CABI,BTTM EZ FOOT,19-1.5 COVER,2-44P IC179-44600 COVER, OPT MECHA,DVDTEMP S-SCREW,MECH 880 TAPPING SCREW, BVT2+3-15 VFT2+2.6-12 W/O SLOT
A 8A-ZG1-201-010 B 87-067-581-010 C 87-B10-307-010
-48-
COLOR NAME TABLE
COLOR NAME TABLE
Basic color symbol Color Basic color symbol Color Basic color symbol Color B Black C Cream D Orange G Green H Gray L Blue LT Transparent Blue N Gold P Pink R Red S Silver ST Titan Silver T Brown V Violet W White WT Transparent White Y Yellow YT Transparent Yellow LM Metallic Blue LL Light Blue GT Transparent Green LD Dark Blue DT Transparent Orange GM Metallic Green YM Metallic Yellow DM Metallic Orange PT Transparent Pink LA Aqua Blue GL Light Green
-49-
211, IKENOHATA 1CHOME, TAITO-KU, TOKYO 110-8710, JAPAN TEL:03 (3827) 3111
920074 Printed in Singapore