Text preview for : 42DPC85_schemdiag.pdf part of Toshiba 42DPC85 3 files, 86 pages, service manual for Toshiba plasma monitor model # 42DPC85.
Back to : 42DPC85_schemdiag.part1.r | Home
SCHEMATIC DIAGRAM
MODEL : 42DPC85
WARNING : BEFORE SERVICING THIS CHASSIS, READ THE "SERVICE SAFETY PRECAUTIONS" ON THE MANUAL FOR THIS MODEL. CAUTION : The international hazard symbols " " in the schematic diagram and the parts list designate components which have special characteristics important for safety and should be replaced only with types identical to those in the original circuit or specified in the parts list. The mounting position of replacements is to be identical with originals. Before replacing any of these components, read carefully the SERVICE SAFETY PRECAUTIONS on the MANUAL for this model. Do not degrade the safety of the receiver through improper servicing.
NOTE: 1. RESISTOR
Resistance is shown in ohm [K = 1.000, M = 1.000.000]. All resistors are 1/6W and 5% tolerance carbon resistor, unless otherwise noted as the following marks. 1/2R = Metal or Metal oxide of 1/2 watt 1/2S = Carbon compsistion of 1/2 watt 1RF = Fuse resistor of 1 watt 10W = Cement of 10 watt K = ±10% G = ±2% F = ±1% 2. CAPACITOR Unless otherwise noted in schematic, all capacitor values less than 1 are expressed in ?F, and the values more than 1 in pF. All capacitors are ceramic 50V, unless otherwise noted as the following marks. Electolytic capacitor Mylar capacitor 3. The parts indicated with " * " have special characteristics, and should be replaced with identical parts only. 4. Voltages read with DIGITAL MULTI-METER from point indicated to chassing ground, using a color bar signal with all controls at normal, line voltage 220 volts. 5. Waveforms are taken receiving color bar signal with enough sensitivity. 6. Voltage reading shown are nominal values and may vary ±20% except H.V.
SCHEMATIC DIAGRAM STRUCTURE:
CONNECTOR [SHEET-1/4] ........ 1/47 AV-TERMINAL [SHEET-2/4] ........ 2/47 A-OUT [SHEET-3/4] ........ 3/47 EXPANDER FOR PDP [SHEET-4/4] ........ 4/47 FRONT-AV ........................................................................................................................................................... 5/47 IR LED ................................................................................................................................................................ 6/47 KEY ..................................................................................................................................................................... 7/47 LOWB .................................................................................................................................................................. 8/47 SIGNAL ANALOG IN [SHEET-200] ........ 9/47 D IN A [SHEET-300] ...... 10/47 D IN B [SHEET-301] ...... 11/47 HDMI (Link, I2C) [SHEET-302] ...... 12/47 HDMI Rx#2 (Video/Audio) [SHEET-303] ...... 13/47 HDMI Rx#3 (PWR,Audio) [SHEET-304] ...... 14/47 HDMI AUDIO PLL [SHEET-305] ...... 15/47 HDMI AUDIO DAC [SHEET-306] ...... 16/47 HDMI AUDIO OUT [SHEET-307] ...... 17/47 HDMI CONTROLLER [SHEET-308] ...... 18/47 EEPROM1 [SHEET-309] ...... 19/47 EEPROM2 [SHEET-310] ...... 20/47 MICRO I/O [SHEET-400] ...... 21/47 OCM MEMORY I/F [SHEET-401] ...... 22/47 FLASH MEMORY [SHEET-402] ...... 23/47 SYNC SEPA [SHEET-403] ...... 24/47 E2P OTHER [SHEET-404] ...... 25/47 STD-BY MICOR [SHEET-405] ...... 26/47 CORTEZ REG 1 [SHEET-406] ...... 27/47 CORTEZ REG 2 [SHEET-407] ...... 28/47 CORTEZ REG 3 [SHEET-408] ...... 29/47 BOOT CONFIG [SHEET-409] ...... 30/47 SERVICE CONNECTOR [SHEET-410] ...... 31/47 I2C Switch [SHEET-411] ...... 32/47 STBY MICRO for DVD internal [SHEET-412] ...... 33/47 DVD 10pin connector [SHEET-413] ...... 34/47 I2C Level shift [SHEET-414] ...... 35/47 AUDIO [SHEET-600] ...... 36/47 AUDIO MSP [SHEET-601] ...... 37/47 CORTEZ 1 [SHEET-700] ...... 38/47 CORTEZ 2 [SHEET-701] ...... 39/47 DDR I/F [SHEET-702] ...... 40/47 DDR SDRAM [SHEET-703] ...... 41/47 DDR TERMINATION [SHEET-704] ...... 42/47 DCDC CONV. [SHEET-802] ...... 43/47 LVDS OUT [SHEET-900] ...... 44/47 LVDS OUT(SHARP LCD) [SHEET-901] ...... 45/47 Power Connector and Dimming [SHEET-902] ...... 46/47 LVDS Power and Others [SHEET-903] ...... 47/47
AV/AOUT
CIRCUIT BLOCK DIAGRAM
AV
SIGNAL
IC700:FLI8532(Cortez) VBI Data Processor OSD
QV16
MONI-OUT
MM1508 (+6dB)
M_OUT
V
Video Decoder DCDi MADi Scaling
S1 V1 Analog Front End
V1/YC1
S2 V2 MUX
V2/YC2
BEP
LVDS
PANEL (VGA) 2nd Channel Process
V3
V3
FRONT-AV
Y/Pb/Pr
CS1 CS2 Digital Input A
Y/Pb/Pr
IR I/F
Microprocessor
GPIO ADC
HDMI_1 HDMI_2
IC300 HDMI RCV 4:2:2(16bit)
Digital Input B
IR-LED
RV60 OPEN RV58 OPEN RV57 OPEN
RV59 OPEN
3P
PJ21A
3 2 1
9V1 GND 5V-2
PLUG_2mm_3P\B3B-PH-K-S
DE99 MTZJ6.2B
50 49 48
A1 GND
2-D3
PB_CS2 GND
SV1(PB_CS2)
47 46
GND
2-C3
PB_CS1 GND
C1(PB_CS1) GND
45 44
2-A4
SC_E1 GND RV41 SHORT
B1(SC_E1) GND
43 42 41 40 39
AN(RET)
SV2 GND
2-A4
V_E1 GND
A2(V_E1) GND
38 37
2-C3
Y_CS1 GND
B2(Y_CS1)
36 35 34 33
GND C2 GND BN(RET) RV42 SHORT
32 31 30
SV3 GND
2-C3
PR_CS1 GND
A3(PR_CS1)
29 28
GND
2-D3
Y_CS2 GND
B3(Y_CS2)
27 26
GND
1-C6
V_E3 GND RV43 SHORT
C3(V_E3)
25 24 23
GND CN(RET)
2-B3
V_E2 GND
SV4(V_E2) GND
22 21
2-D3
PR_CS2 GND
A4(PR_CS2)
20 19 18 17
GND B4 GND
2-A4
SY_E1 GND RV44 SHORT
C4(SY_E1)
16 15 14 13 12 11 10
GND SNV(RET)
NC(V_DGT) GND OPT3(NC) V_EPG(to Seine) GND GND
50P-FFC
9
2-D7
MOUT
MONI-OUT
8 7 6 5 4
EPG_SW
PJ22A
OPT8 OPT9 MONI_SW S_SW_E1
2-A4
S_SW_E1
3 2
POD_STOP_FAN
4-B1 4-A1
SDA1 SCL1
SDA1
9637S-50ATL\FFC/FPC 0.5mm50P SOCKET
TO SIGNAL BOARD
1 50 49 48 47 46 45 44
SCL1
S_SW_E2 S_SW_E3 NC(SHORT_LNB) NC(LR_LNB) CS_S_SW
NC(STOP_FAN)
2-C7 2-C7
SW_DVI2 SW_DVI1
SW_DVI2
43 42 41
SW_DVI1 ATXD_cortez H_PC
7 6
TUNER GND(2mm)
40
GND
1-B7 1-B7
V_PC TUNER GND(2mm)
39
7P
UART_SW
5
R_SC4-IN L_SC4-IN GND
1-B3
RV55 OPEN
R_E3
PDP_CONT_EN
38
4-A2 PDP_CONT_EN
4 3 2
L_E3 GND
PDP_CONT_EN
PDP_MUTE
37
4-A2 PDP_MUTE
PDP_MUTE
36
V_E3 GND
RV56 OPEN
V_E3 LV209 TEM2034AD
ARXD_cortez
35
BS_TV_MUTE
FRONT-AV(E3)
1
GND
34
3-B1
PV25A
EXT_MUTE
EXT_MUTE
33
3-A1
MUTE
2-C7 R_HDMI 2-C7 L_HDMI
MUTE
32
B7B-PH-K-S
NC
R_HDMI
31 30
L_HDMI
GND
GND
29 28 27
R_BS(NC) L_BS(NC)
GND
GND R_TV(NC)
26 25 24
L_TV(NC)
GND
5
GND W_APRO
23 22
3-A1 1-C7,1-E7,3-A2,3-A2,3-A2 3-A2 3-A2 1-C7,1-E7,3-A2,3-A2,3-A2
GND_AUDIO R_OUT L_OUT GND_AUDIO
R_APRO
GND_AUDIO R_OUT L_OUT GND_AUDIO
R_APRO
4 3 2 1
GND R_AUDIO L_AUDIO GND
21
3-A1
L_APRO GND
2-E7
R_MONITOR
R_MONITOR L_MONITOR
L_APRO
20 19 18
GND R_MONITOR
5P FRONT-AV
2-B7
2-E7
L_MONITOR
L_MONITOR
GND
P602A
GND R_SC4-IN
17 16
GND
9V1
26V
1-C6
5V3 5V1
R_SC4-IN
1-C6
R_SC4-IN
GND_AUDIO
ACDETECT
L_SC4-IN
15
B5B-PH-K-S
L_SC4-IN GND
2-A3 2-A3
L_SC4-IN
GND R_SC3-IN
14 13
GND
R_SC3-IN L_SC3-IN
R_SC3-IN
U121
NV03
NV02
NV01
L_SC3-IN
OTHER PARTS
12
L_SC3-IN
PWB PD****-1
SOLDEREX9025
SOLDER9025SE
SOLDER9025SE
12
11
10
P804B
P803B
GND
2-B3
GND
9
8
7
6
5
4
3
2
1
11
6 GND
GND
R_SC2-IN
10
W-B 12P_2.5mm_1.5A_Beige
6P_2.5mm_1.5A_Beige
2 26V
1 26V
R_SC2-IN
NC
R_SC2-IN
5V-3
5V-3
9V-1
5V-1
GND
GND
GND
GND
L_SC2-IN
9
32V(NC)
2-B3
L_SC2-IN GND
2-D7 2-D7
L_SC2-IN
9V-2(NC)
NV06
NV05
NV04
12P
ACDETECT
GND R_SC1-IN
8
4 SOUND GND
3 SOUND GND
50P-FFC
5 POD_STOP_FAN(NC)
6P
GND
7
THINNER4520
R_SC1-IN L_SC1-IN GND
R_SC1-IN
FLUX CF330VH
FLUX CF330VH
L_SC1-IN
6 5 4 3
L_SC1-IN GND
PJ60A
SIF(NC)
NV09
NV08
NV07
GND
GND
SOLDER9025SE
SOLDER9025SE
SOLDEREX9025
9637S-50ATL\FFC/FPC 0.5mm50P SOCKET
2 1
SYS_SW2(NC) SYS_SW1(NC)
NV11
NV10
THINNER4520
FLUX CF330VH
42DPC85 AV/AOUT CONNECTOR [SHEET-1/4] (1/47)
TO LOWB BOARD
PV01 JACK 1S6P SMK C Y
LV200 TEM2034AD
SY_E1 S
CV38 1000 RV330 1/8W75
GND
RV370 1/8W75
DV08 OPEN
SC_E1
RV331 100
1-B2 1-B2
GND V_E1 GND 5V3
RV333 OPEN LV201 TEM2034AD
EXT-1
V
RV340 1/8W75
1-D7,2-D7,4-A2
L_SC3-IN
RC01
L_SC3-IN R_SC3-IN GND
1-B7
RV334 OPEN
S_SW_E1
L
100
R_SC3-IN
RC02
1-B7
CC01 B1000p
CC02 B1000p
LV202 TEM2034AD
R
100
V_E2 V
RV40 1/8W75
GND
L_SC2-IN
RC03
EXT-2
L_SC2-IN R_SC2-IN GND
1-B8 1-B8
L
100
R_SC2-IN
RC04
CC03 B1000p
CC04 B1000p
R
100
9V1
PV02 JACK 7P
DV01 OPEN
1-D7
LV203 TEM2034AD
D672 MA8056-L
R6636 100K
R6627 100K
1/8W75
C6602 B16V2.2
EXT-4
CB Y
L2
R265 1/8W75
DV03 OPEN
LV204 TEM2034AD
Y2
X2
15
2
GND PB_CS1 GND Y_CS1
GND R_HDMI1
Y0
VDD
16
R6622 100
R6625 100K
1-B3 1-B2
R6660 100K
DV02 OPEN
R6635 100K
CR
L1
R266
GND PR_CS1
Q6600 CD4052BNSR
C6600 B16V1.0u
R6626 100K
C6607 B16V2.2
R6634 100
R6628 100K R6658 100K
R6633 100 R6623 100
Y-OUT X1
14 3
Q6603 RN1404
R6639 47k
R6638 47k
C6605 16V4.7u
R6629 2.2k
SW_DVI1
1-B5
1
L3
C6603 B16V2.2
C6606 B16V2.2
R264
1/8W75
LV205 TEM2034AD
C6615 B16V2.2 C6604 B16V2.2
RC11 100
Y1
X0
12
5
HDMI-1 EXT-4
L4
R
CC14 B1000p
Y3
X-OUT
13
R6657 100 R6624 100
R6620 100
C6601 B16V2.2 Q6604 RN1404
SW_DVI2
1-B5
4
R_E4
RC06 100 RC05 100
R6659 C6616 B16V2.2 100
INH X3
11 9 10 6
R1
R
R2
CC05 B1000p CC06 B1000p L_E4
VEE
A
GND
VSS B
8
L
GND
R4
7
L_HDMI
HDMI-1
CC15 B1000p
RC12 100
R_HDMI L_HDMI1 GND
L
L_HDMI R_HDMI GND
1-B6 1-B6
PV03 JACK 7P
DV04 OPEN
L_SC1-IN
LV206 TEM2034AD
L_SC1-IN R_SC1-IN GND
1-B8 1-B8
R_SC1-IN
R_HDMI1
L_HDMI1
R_HDMI
L_HDMI
L_SC1-IN
R_E5
L_E5
R_E4
L_E4
GND
GND
GND
GND
1-B4 1-B2
R_SC1-IN
CR
L1
R288
1/8W75
DV05 OPEN
GND PR_CS2
LV208 TEM2034AD
GND
GND
EXT-5
CB Y
L2
R287
1/8W75
DV06 OPEN
GND PB_CS2 GND Y_CS2
LV207 TEM2034AD
L3
R286
1/8W75
NC EXT-5
L4
R
RC08 100
R1
LV43 COLTRF4100CG R_E5 CC07 B1000p L_E5 GRV76 OPEN QV16 MM1508XNRE
IN1(L)
5V3
5V3
1-D7,2-A3,4-A2
R
R2
RC07 100
CC08 B1000p
GND
L
1
CV68 50V1uF 1.35
+
NC
R4
RV76 75
CV72 16V470
+
L
OUT
GND
2
Vcc
3
CV76 V_MON GND 25V0.1
+
CV74 16V100
LC01 TEM2121M
L_MONI R_MONI
R6614 1k
4
5
6
MOUT
MOUT GND
1-B4
L_MONITOR
L_MONITOR R_MONITOR A_MUTE
1-B7 1-B7
LC02 TEM2121M
L_MONI CC11 1000p
R_MONI
R6615 1k Q651 RN2404(TE85L,F)
R_MONITOR
R
CC12 1000p
R6616 100k
R6617 100k
(0.5mm)
RV376 LV284 ACM32251022 SHORT
R658 47k GND Q653 2SC3326-B(TE85,F) Q652 2SC3326-B(TE85,F) R657 47k
C656 50V10
R659 10k A_MUTE
3-B2
MONITOR OUT
L V
DV07 OPEN
+
R656 OPEN
GND GND V_MON
RV377 SHORT
PV05 JACK PIN 3P SMK
GND
42DPC85 AV/AOUT AV-TERMINAL [SHEET-2/4] (2/47)
Q670 Q670A
TA8246AHQ HEAT SINK SCREW BITTB 3x10 ECO
L/R
Q670B
MUTE TC
FILTER
OUT(L)
OUT(R)
MUTE
IN (L)
IN(R)
GND
GND
VCC
NC
NC
1
1 R674 OPEN C660 50V4.7
+
2
C670 50V10
3
4
C671 50V10
5
6
7
8
9
10
11
12
M
C666 OPEN
+
26V
D671 D670 KDS160-RTK/P KDS160-RTK/P KDS160-RTK/P KDS160-RTK/P R6604 C673 16V47u
26V
1-E7
B50V0.01
35V1000
1-B7
L_APRO GND
+
L_APRO
C661 50V4.7
R671 4.7k R675 OPEN C667 OPEN R677 OPEN
M
C678 B50V0.1 R678 1/8W 2.2
C679 B50V0.1 R679 1/8W 2.2
M
R673 1.8k
D675
GND
C664 OPEN
C680
C684
R672 1.8k
C662 B680p
R676 OPEN
M
+
C674 B16V1.0u
1-B7 R_APRO
D674
R_APRO
1k
R670 4.7k
+
GND_AUDIO
GND_AUDIO
VCC_GND
+
D607
MA8330-M
C663 B680p
GND_AUDIO
GND_AUDIO C681 35V2200
C665 OPEN Q672 2SC3326-B(TE85,F)
L_OUT
+
L_OUT
1-C7 1-C7
C682 35V2200
R_OUT
+
R_OUT
R681 47K D676 KDS160-RTK/P C691 B16V0.22 R680 47K
GND_AUDIO
GND_AUDIO Q671 2SC3326-B(TE85,F)
1-B6
MUTE
C669
B1000p
R664 100K
+
C675 OPEN C692 B16V0.22
D680 KETSU Q673 R685 2.2k D678 KDS160-RTK/P C690 6.3V1000
+
2SA1162-Y R686 1k R684 100k R683 10k
1-D7
5V1
5V1
A_MUTE
A_MUTE
2-E7
C677 B16V1.0u C685 10V1u
R692 22k Q660 2SC4081-Q
R691 10k
1-D7
ACDETECT
ACDETECT
R690 47k
Q661 2SC4081-Q
R6605 10k
Q665 RN2404(TE85L,F)
1-B6
EXT_MUTE
EXT_MUTE
R6603 22k
Q664 2SC4081-Q
R6606 100K
42DPC85 AV/AOUT A-OUT [SHEET-3/4] (3/47)
1-D7,2-A3,2-D7
5V3
QB517 OPEN
CS0
SO SCL
CS1
SDA
CS2
D0
VDD
13
RB577 OPEN
4
14
SDA1
RB576 OPEN
3
15
SCL1
RB575 OPEN
2
16
1
CB512 OPEN
D1
D7
D2
D6
D3
D5
8
GND
D4
9
10
7
11
6
12
RB578 OPEN
5
PDP_CONT_EN
1-B5 1-B5
SCL1 SDA1
SCL1 PDP_MUTE SDA1
PDP_CONT_EN PDP_MUTE
1-B6 1-B6
42DPC85 AV/AOUT EXPANDER FOR PDP [SHEET-4/4] (4/47)
CV122 100p DV121 KETSU
DV122 KETSU
7P
PV25B
3PJACK
LV121
PV60
ACM32251022
RV132 OPEN
B7B-PH-K-S 1 2 GND_V_E3 V_E3 GND L_E3 R_E3 TUNER GND(2mm) TUNER GND(2mm)
V E3 L R
L
RC09 100
RV123 75
RV133
OPEN 3
L_E3
4
AV-Terminal
M
GR605 SHORT
CC13 B1000p RC10 100
R_E3
5 6
R 7
GR604 KETSU CC10 B1000p
CY650 B50V0.01
D653 KETSU
D652 KETSU
4P
P601
4
R_SPK
3 2 1
L_AMP R_AMP
L_SPK
R_GND R_SPK L_SPK L_GND
(2mm) (2mm) (2mm) (2mm)
R/L_SPK
4P_2.5mm_1.5A_Beige
R695 1/8W1k R694 1/8W1k R693 1/8W1k
HP
P661
EARPHONE J D3.5
5P
P602B
R688 1/8W1k R689 1/8W1k R687 1/8W1k C606 B1000p C605 B1000p
5 4 3 2 1
NC R_GND R_AMP L_AMP L_GND
B5B-PH-K-S
(2mm) (2mm) (2mm) (2mm)
TN-AV
42DPC85 FRONT-AV (5/47)
RB18 OPEN
RB15 470
QB07 2SC2712Y
DB01 SCL-003URC3FXGHJ
1
DB01A LED HOLDER
ROKUGA KAISEN TAIKI(LED_GREEN) GND ROKUGA_YOYAKU JUZOU(LED_RED) 5V1 GND RMT_IN 3.3V RMT_FGND
POWER (RED)
2 3 4 5 6 7
CB04 25V0.1 + CB05 7L10V220u
8 9 10
+ CB38 25V0.1 CB01 7L10V220u
11
PJ41C B11B-PH-K-S
RB24 CHIP_JP
RB22 OPEN
RB09 47
4
GPIUE281RK
GP1UE281RK0F
DB23 1SS355-TE17
RB08 47
Vout Vcc GND 5
1 2
DB22
KB01
3
+
1SS355-TE17
CB03 25V0.1
CB02 7L10V220u
DB20 UDZS TE-17 5.6B
42DPC85 IR LED (6/47)
(GUIDE)
SA08 OPEN
RA76 OPEN RA77 10k
VIDEO/ENTER
SA06 SWITCH PUSH 1C1P
MENU
SA05 SWITCH PUSH 1C1P
PJ 8pin
RA71 68k RA78 CHIP_JP RA72 22k RA73 10k
VOL-DOWN
SA04 SWITCH PUSH 1C1P
VOL-UP
SA03 SWITCH PUSH 1C1P
DOWN
SA02 SWITCH PUSH 1C1P
UP
SA01 SWITCH PUSH 1C1P
POWER
SA07 SWITCH PUSH 1C1P
RA79 RA74 CHIP_JP
CHIP_JP
8 7 6 5 4 3
KEY_FGND ADC_IN2 GND
PJ 4pin
ADC_IN1
2 1
PJ42 S8B-PH-K-S
POWER_KEY NC
OTHER PARTS U123
PWB PD****-3
42DPC85 KEY (7/47)
QE70
ON/OFF
MPD6S011S
N.C. N.C. VIN VIN VIN
VOUT
VOUT
VOUT
VAR1
1
LE70
2
3
4
5
6
7
8
9
10
11
13
14
15
16
VAR2
GND
GND
GND
GND
PJ62A
LE71
TLN3499AA/AH RE74 1k
CE70 + CE71
TLN3481AA/AH
+ +
CE72
4400mA
GJ70
6.3V1000u
DE72
B5P-VH
1
RE70 180k OPEN
3.3VD_a 3.3VD_b GND 6VD GND
3300mA
2 3
35V470u
35V1000u
MTZJ4.3C
DE71 1SS133 RE73 1k
4 5
QE30
ON/OFF
MPD6S011S
N.C. N.C. VIN VIN VIN
TO DB
VOUT VOUT VOUT VAR1 VAR2 GND GND GND GND
PJ63A 5P_2.5mm_1.5A
QE10 LE10
1
LE30
2
3
4
5
6
7
8
9
10
11
13
14
15
16
LE31
1 2 3
32V GND 20V 20V NC(LNB)
QE10A
SI-3090CA
RE10
TRF4220AZ
5
QE10B
M 1
IN
OUT ON /OFF
3 4
18G
TLN3499AA/AH RE34 1k
CE30 + CE31
TLN3481AA/AH
+ +
DE32 CE32
+ CE10
GND
+
CE12
35V470u 35V1000u GJ10 SHORT RE30 150k 6.3V1000u
MTZJ4.3C DE31 1SS133 RE33 1k
4 5
16V47
CE11
M0.47
2.2kG
RE11
1
2
16V47
QE11 RN1206
QE15
OPEN
5
M
IN
OUT
3 4
+ CE15
GND
ON /OFF
+
CE17
OPEN
1
CE16
2
OPEN RE27 1/2R1k
QE25 2SA1020-Y
OPEN
QE71 RN2004
GJ11 SHORT
QE60
RE28 1/2R3.3k
RE15
+
CE25
35V47 RE29 10k
DE74 1SS133 GJ12 OPEN
SW OUT
RE01 RE04
1.8k
SI-8050SS QE60B
1
QE26 2SC1815-Y
15k 2.2k
RE26 47k
GND
V IN
QE60A FIN
S.S.
Vos
1 P807A W-B 12P_2.5mm_1.5A_Beige
M
2
3
4
5
M CE64 LE60
QE61 RN1206
QE65 LE62 RE03
QE04 2SC1815-Y
15k
RE65 CE67
RE17 10k
GJ60 SHORT
CE63 LE61
M0.1
M0.1
TLN3499AA/AH
SI-3050C
QE01 2SC1815-Y
RE02
TRF4220AZ
FMB-G14L
TLN3540AH
62G
20V(NC) 20V(NC) GND GND 12V 12V TO POWER 12V 12V GND
1
DE60
5
DE62 MTZJ7.5B
M
IN
OUT
3 4
2.2kG
RE66
16V47
47k
+
RE16 47k
1.2KF
RE61
2 3 4 5
GJ61 OPEN
CE60 +
RE60 240F
CE61
+
GND
CE66
ON /OFF
+
CE62
+
1
2
P822 OPEN
DE61 1SS133
35V470u
16V1200
10V1000
M0.47
1
RE20
FAN_VCC GND STOP_FAN
OPEN
CE65
2 3
RE63
6 7 8 9
16V47
QE66 RN1206 QE86 OPEN
DE89
1k
DE20
OPEN P821 OPEN
OPEN FE20 F630mAL 250V
1
RE14
FAN_VCC GND STOP_FAN TO FAN
GND 10 GND 11 GND 12
RE87 OPEN DE88 OPEN
DE87
OPEN
2 3
+
CE86
CE87
+
DE14
OPEN
OPEN
OPEN P820 3P_2.5mm_1.5A_Beige
OPEN
QE85 2SC2655-Y P803A W-B 12P_2.5mm_1.5A_Beige
DE05 RE07
1
ERB12-01 3.9k
FAN_VCC GND STOP_FAN
2 3
1 2
23713473(Not Green)
TO SIGNAL
GND 5V-1 32V 9V-1 9V-2 GND GND 5V-3 5V-3 ACDETECT GND NC
DE04 DE08 DE85
RE85 1/2R2.2k DE86 1SS133
DE10
1SS133
P819 3P_2.5mm_1.5A_Beige
3 4 5 6 7
+
CE85
1
RE05 CE05 +
FAN_VCC GND STOP_FAN
PJ80A
W-B PHD 16P PLUG TOP
16V47 3.9k
2 3
POWER_SIG
1
2
STOP_FAN POWER_TV
MTZJ11A
RE86
50V100
RE06
10k
47k
DE06
NC(POWER_LCD)
P809A W-B 11P_2.5mm_1.5A_Beige
3
4
1SS133 P818
DE07
ACDETECT GND 5V1 GND GND
5
6
POWER_DB GND
RE12 4.7k RE13 1k DE02 AK04
CE03 M
MTZJ3.3A
3P_2.5mm_S_SMK
32V GND 5V-1 POWER POWER_SIG ACDETECT TO POWER PROTECT SOUND GND SOUND GND
8 9 10 11 12
M0.1
ERB12-01
1 2 3 4 5 6 7 8 9
1
RE08
FAN_VCC GND STOP_FAN TO POD FAN
7
8
TO AV
CE08 +
4.7k 50V100
RE09
2 3
9
10
12V GND
RN1206 QE03 DE01 AK04
47k
DE09
1SS133
11
12
RE18 15k QE02 2SC1815-Y
MTZJ3.3A
13
14
NC(12VLCD) NC(12VLCD)
1
NC(12VLCD)
15 16 DE03 RE19 47k MTZJ3.6A
26V 26V SOUND GND SOUND GND PODFAN_STOP GND
2 3 4 5 6
26V 10 26V 11
P804A 6P_2.5mm_1.5A_Beige
42DPC85 LOWB (8/47)
42DPC85 SIGNAL ANALOG IN (9/47)
42DPC85 SIGNAL D IN A (10/47)
42DPC85 SIGNAL D IN B (11/47)
42DPC85 SIGNAL HDMI (Link,I2C) (12/47)
42DPC85 SIGNAL HDMI Rx#2 (Video/Audio) (13/47)
42DPC85 SIGNAL HDMI Rx#3 (PWR,Audio) (14/47)
42DPC85 SIGNAL HDMI AUDIO PLL (15/47)
42DPC85 SIGNAL HDMI AUDIO DAC (16/47)
42DPC85 SIGNAL HDMI AUDIO OUT (17/47)
42DPC85 SIGNAL HDMI CONTROLLER (18/47)
42DPC85 SIGNAL EEPROM1 (19/47)
42DPC85 SIGNAL EEPROM2 (20/47)
Note: For GATE of IC705 During, POD STANDBY mode of GATE_BTXD line, it keeping at SW1.8V mode. Normally, when power is ON, POWER_DB line (L:ON) is shut-off whichever pin No.1 or 2 of IC 707 is OFF.
42DPC85 SIGNAL MICRO I/O (21/47)
42DPC85 SIGNAL OCM MEMORY I/F (22/47)
42DPC85 SIGNAL FLASH MEMORY (23/47)
42DPC85 SIGNAL SYNC SEPA (24/47)
42DPC85 SIGNAL E2P OTHER (25/47)
Note:
Normally, I2C Bus Lines (SDA_STBY, SCL_STBY), these are connected to Cortez line. When I2C Bus Lines are POD STBY mode, these are connected to DB line.
42DPC85 SIGNAL STD-BY MICRO (26/47)
42DPC85 SIGNAL CORTEZ REG 1 (27/47)
42DPC85 SIGNAL CORTEZ REG 2 (28/47)
42DPC85 SIGNAL CORTEZ REG 3 (29/47)
42DPC85 SIGNAL BOOT CONFIG (30/47)
42DPC85 SIGNAL SERVICE CONNECTOR (31/47)
Note: I2C Bus lines switching for Stand-by Micom. SW1.8V to H (normally): Connect to Cortez SW1.8V to L (POD STBY mode): Connect to DB]
42DPC85 SIGNAL I2C Switch (32/47)
42DPC85 SIGNAL STBY MICRO for DVD internal (33/47)
42DPC85 SIGNAL DVD 10pin connector (34/47)
42DPC85 SIGNAL I2C Level shift (35/47)
42DPC85 SIGNAL AUDIO (36/47)
42DPC85 SIGNAL AUDIO MSP (37/47)
42DPC85 SIGNAL CORTEZ 1 (38/47)
42DPC85 SIGNAL CORTEZ 2 (39/47)
42DPC85 SIGNAL DDR I/F (40/47)
42DPC85 SIGNAL DDR SDRAM (41/47)
42DPC85 SIGNAL DDR TERMINATION (42/47)
42DPC85 SIGNAL DCDC CONV. (43/47)
42DPC85 SIGNAL LVDS OUT (44/47)
R/L U/D L L L H H L L L
Normal Indication Flip Vertical Flip Horizontal Half Turn
42DPC85 SIGNAL LVDS OUT(SHARP LCD) (45/47)
42DPC85 SIGNAL Power Connector and Dimming (46/47)
42DPC85 SIGNAL LVDS Power and Others (47/47)