Text preview for : Sony-SAVE522_525 actsub.pdf part of Sony SAVE522, SAVE525 active subwoofer
Back to : Sony-SAVE522_525 actsub.p | Home
SA-VE522/VE525/WMS525/ SS-MS525/V521
SERVICE MANUAL
Ver.1.0 2001.2
US Model Canadian Model AEP Model UK Model E Model Australian Model
· SA-WMS525 and SS-MS525 is the micro satellite system in SA-VE522/VE525. · SS-V521 is SS-MS525 which can be purchased alone.
SA-WMS525
SS-MS525 SS-V521
SPECIFICATION
SS-MS525 (front,center, and rear speakers) SS-V521
Speaker system Speaker units Enclosure type Rated impedance Power handling capacity Maximum input power: Sensitivity level Frequency range Dimensions (w/h/d) Full range x 2, magnetically shielded 5 cm (2 in.), balance drive type Bassreflex 8 ohms 120 watts 87 dB (1 W, 1 m) 120 Hz - 20,000 Hz When attached speaker grille: Approx. 89 x 144 x 130 mm (3 5/ 8 x 5 3/ 4 x 5 1/ 8 in.) When attached supplied speaker stand: Approx. 89 x 128 x 143 mm (3 5/ 8 x 5 1/ 8 x 5 3/ 4 in.) (pointed upwards) Approx. 89 x 122 x 143 mm (3 5/ 8 x 4 7/ 8 x 5 3/ 4 in.) (pointed downwards) When attached speaker grille: Approx. 750 g (1 lb 10 oz) When attached supplied speaker stand: Approx. 850 g (1 lb 14 oz) Outputs LINE OUT (output pin jack) SPEAKER OUT (output terminals) General Power requirements USA and Canada: Europe and Australia: E: Power consumptions Dimensions (w/h/d) 120 V AC, 60 Hz 220 - 230 V AC, 50/60 Hz 110-120V/220-240V AC, 50/60Hz 90 W 1 W (standby mode) Approx. 230 x 392 x 464 mm (9 1/ 8 x 15 1/ 2 x 18 3/ 8 in.), including front grille Approx. 13.2 kg (29 lb 2 oz)
Mass
Supplied accessories
SA-VE525 Foot pads (16) Center speaker stand (1) Screw (for the center speaker stand) (1) Washer (for the center speaker stand) (1) Audio connecting cord (1) Speaker connecting cords, 10 m (32 ft 9 3/ 4 in.) (2) Speaker connecting cords, 3.5 m (11 ft 6 in.) (3) Speaker connecting cords, 2.5 m (8 ft 2 1/ 2 in.) (2) SA-VE522 Foot pads (8) Audio connecting cord (1) Speaker connecting cords, 3.5 m (11 ft 6 in.) (2) Speaker connecting cords, 2.5 m (8 ft 2 1/ 2 in.) (2) SS-V521 Foot pads (4) Speaker connecting cords, 10m (32 ft 9 3/ 4 in.) (1) Design and specifications are subject to change without notice.
Mass
SA-WMS525 (subwoofer)
Active subwoofer, magnetically shielded Speaker unit Woofer: 20 cm (8 in.), cone type Enclosure type Advanced SAW type Reproduction frequency range 26 Hz - 250 Hz Amplifier section Rated Power Output 120 W (8 ohms 20 Hz - 20 kHz, THD 0.8%) Inputs LINE IN (input pin jack) SPEAKER IN (input terminals) Speaker system
ACTIVE SUBWOOFER
9-873-807-11
2001B0900-1 © 2001. 2
Sony Corporation
Audio Entertainment Group General Engineering Dept.
1
SA-VE522/VE525/WM525/SS-MS525/V521
SAFETY CHECK-OUT
(US model)
After correcting the original service problem, perform the following safety checks before releasing the set to the customer: Check the antenna terminals, metal trim, "metallized" knobs, screws, and all other exposed metal parts for AC leakage. Check leakage as described below.
TABLE OF CONTENTS 1. GENERAL .......................................................................... 3 2. DIAGRAMS
2-1. Circuit Boards Location ........................................................ 3 2-2. Schematic Diagram ............................................................... 4 2-3. Printed Wiring Board ............................................................ 5
LEAKAGE
The AC leakage from any exposed metal part to earth ground and from all exposed metal parts to any exposed metal part having a return to chassis, must not exceed 0.5 mA (500 microamperes). Leakage current can be measured by any one of three methods. 1. A commercial leakage tester, such as the Simpson 229 or RCA WT-540A. Follow the manufacturers' instructions to use these instruments. A battery-operated AC milliammeter. The Data Precision 245 digital multimeter is suitable for this job. Measuring the voltage drop across a resistor by means of a VOM or battery-operated AC voltmeter. The "limit" indication is 0.75 V, so analog meters must have an accurate low-voltage scale. The Simpson 250 and Sanwa SH-63Trd are examples of a passive VOM that is suitable. Nearly all battery operated digital multimeters that have a 2V AC range are suitable. (See Fig. A)
3. EXPLODED VIEW
3-1. Front Panel Section ............................................................... 6 3-2. Rear Panel Section ................................................................ 6 3-3. SS-V521 Section, SS-MS525 Section .................................. 7
4. ELECTRICAL PARTS LIST ......................................... 8
2.
3.
To Exposed Metal Parts on Set
0.15µF
1.5k
AC voltmeter (0.75V)
Earth Ground
Fig. A. Using an AC voltmeter to check AC leakage.
SAFETY-RELATED COMPONENT WARNING!! COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.
ATTENTION AU COMPOSANT AYANT RAPPORT À LA SÉCURITÉ! LES COMPOSANTS IDENTIFÉS PAR UNE MARQUE 0 SUR LES DIAGRAMMES SCHÉMATIQUES ET LA LISTE DES PIÈCES SONT CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT. NE REMPLACER CES COMPOSANTS QUE PAR DES PIÈSES SONY DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL OU DANS LES SUPPÉMENTS PUBLIÉS PAR SONY.
2
SECTION 1 GENERAL
· Location of controls Front view (a part)
SA-VE522/VE525/WM525/SS-MS525/V521 SECTION 2 DIAGRAMS
THIS NOTE IS COMMON FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS. (In addition to this, the necessary note is printed in each block.) For printed wiring boards.
Note: · X : parts extracted from the component side. · Y : parts extracted from the conductor side. · b : Pattern from the side which enables seeing.
For schematic diagrams.
Note: · All capacitors are in µF unless otherwise noted. pF: µµF 50 WV or less are not indicated except for electrolytics and tantalums. · All resistors are in and 1/4 W or less unless otherwise specified. · C : panel designation. Note: The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. Note: Les composants identifiés par une marque 0 sont critiques pour la sécurité. Ne les remplacer que par une piéce por tant le numéro spécifié.
1
2
3
4
1 POWER button 2 ON/STANDBY indicator 3 LEVEL dial 4 MODE dial
· : B+ Line. · : B Line. · Voltages are dc with respect to ground under no-signal conditions. no mark : Power on : Impossible to measure · Voltages are taken with a VOM (Input impedance 10M). Voltage variations may be noted due to normal preduction tolerances. · Signal path. K : AUDIO · Abbreviation CND : Canadian model SP : Singapore model MX : Mexican model
2-1. Circuit Boards Location
POWER board AUTO POWER board
LED board MAIN board
POWER SWITCH board
CONTROLboard
3
3
SA-VE522/VE525/WM525/SS-MS525/V521
2-3. SCHEMATIC DIAGRAM
4
4
2-2. PRINTED WIRING BOARD · See page 3 for Circuit Boards Location.
SA-VE522/VE525/WM525/SS-MS525/V521
MAIN BOARD
There are a few cases that the part isn't mounted in model is printed on diagram.
J101 IN LINE
CONTROL BOARD
OUT TM101
· Semiconductor Location
L
Ref. No. D101 D102 D103 D104 D303 D304 D305 D306 D501 D502 D503 D505 D506 D507 D701 D702 D703 D704 IC101 IC102 IC104
Location B-5 B-5 B-6 B-6 B-4 B-4 C-4 E-4 E-4 E-4 E-4 E-4 D-4 D-4 C-5 C-5 C-5 C-5 A-6 A-5 C-4
Ref. No. Q101 Q301 Q302 Q303 Q304 Q305 Q306 Q307 Q308 Q309 Q310 Q311 Q501 Q502 Q701 Q702 Q703 Q704 Q705
Location A-5 B-4 A-4 A-4 A-5 A-5 B-4 B-5 D-4 D-4 C-4 D-4 D-4 D-4 C-6 C-5 D-6 D-4 D-4
SP
SPEAKER
R
11 (11)
1-680-785-
OUT
IN
S701 AUTO POWER SAVE
POWER BOARD
AUTO POWER BOARD
SP AC IN
11 (11)
1-680-786SP SP
LED BOARD
POWER SW BOARD
11 (11) 11 (11)
1-680-7881-680-7871-680-784-
11 (11)
EXCEPT SP 1-680-789-
11 (11)
5
5
SA-VE522/VE525/WM525/SS-MS525/V521 SECTION 3 EXPLODED VIEWS
NOTE: · -XX and -X mean standardized parts, so they may have some difference from the original one. · Color Indication of Appearance Parts Example: KNOB, BALANCE (WHITE) . . . (RED) Parts Color Cabinet's Color · Items marked "*" are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. · The mechanical parts with no reference number in the exploded views are not supplied. · Accessories and packing materials are given in the last of the electrical parts list. · Abbreviation CND : Canadian model SP : Singapore model MX : Mexican model The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. Les composants identifiés par une marque 0 sont critiques pour la sécurité. Ne les remplacer que par une piéce portant le numéro spécifié.
3-2. REAR PANEL SECTION
#5
56
not supplied
54
#5
#3
#5
#5
#5 #5 #4
3-1. FRONT PANEL SECTION
T601 #5 not supplied
55
#5 #5 not supplied #5
SP901
53 60
#1
#4 #3
T501
#1
5 4 2
Supplied with RV201 and S201
6
57
8
#5
58
#5
3
#2
7 9
52
#2
not supplied
59
1
52
3
10
51
Ref. No. 51 52 53 54 55 56 56 56 56 57
Part No. A-4412-638-A 4-981-864-01 1-680-789-11 1-680-786-11 3-905-609-01 4-232-739-11 4-232-739-21 4-232-739-31 4-232-739-41 1-777-071-21
Description CABINET ASSY, SPEAKER FOOT AUTO POWER BOARD POWER BOARD SCREW(TRANSISTOR) PANEL, REAR (US,MX) PANEL, REAR (AEP,UK) PANEL, REAR (CND) PANEL, REAR (SP) CORD,POWER (AEP,UK,SP)
Remark
Ref. No. 1 2 3 4 5
Part No. X-4953-330-1 X-4953-555-1 3-703-564-21 4-227-298-01 4-999-482-31
Description FRAMEASSY, GRILLE PANELASSY, FRONT SCREW,TAPPING SHEET KNOB(VOL)
Remark
Ref. No. 6 7 8 9 10 SP901
Part No. 4-231-866-01 1-680-787-11 4-973-938-51 1-680-788-11 1-680-785-11
Description PACKING POWER SWITCH BOARD KNOB(A), PUSH LED BOARD CONTROL BOARD
Remark
Ref. No. 57 * 58 59 * 60 0 T501 0 T501 0 T501 0 T601 0 T601 0 T601
Part No. 1-783-820-11 3-703-244-00 A-4476-543-A 3-703-044-26 1-435-999-11 1-437-219-11 1-437-246-11 1-435-993-11 1-435-994-11 1-435-995-11
Description Remark CORD,POWER (US,CND,MX) BUSHING (2104), CORD MAINMOUNTED PC BOARD LABEL, CAUTION (US,CND,MX) TRANSFORMER, POWER (US,CND,MX) TRANSFORMER, POWER (SP) TRANSFORMER, POWER (AEP,UK) TRANSFORMER, POWER (US,CND,MX) TRANSFORMER, POWER (AEP,UK) TRANSFORMER, POWER (SP)
1-529-296-11 SPEAKER (20CM)
6
6
SA-VE522/VE525/WM525/SS-MS525/V521
3-3. SS-V521, SS-MS525 SECTION
SP
105 104
106
104
102
104
103 102 101
SP
Ref. No. 101 102 103 104 105
Part No. X-4953-331-1 4-231-872-01 4-231-867-01 4-986-971-11 X-4953-556-1
Description FRAME ASSY, GRILLE SCREW, ORNAMENTAL PANEL, FRONT SCREW (3.5) CABINET ASSY
Remark
Ref. No. 106 SP
Part No. Description 1-694-516-21 TERMINAL, SPEAKER 1-529-977-11 SPEAKER (5CM)
Remark
7
SA-VE522/VE525/WM525/SS-MS525/V521 SECTION 4 AUTO POWER CONTROL ELECTRICAL PARTS LIST
NOTE: Ref. No. Part No. Description · Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. · -XX, -X mean standardized parts, so they may have some difference from the original one. · Items marked "*" are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. · CAPACITORS: uF: µF · RESISTORS All resistors are in ohms. METAL: metal-film resistor METAL OXIDE: Metal Oxide-film resistor F: nonflammable Ref. No. Part No. Description Remarks Ref. No. COILS uH: µH · SEMICONDUCTORS In each case, u: µ, for example: uA...: µA... , uPA... , µPA... , uPB... , µPB... , uPC... , µPC... , uPD..., µPD... · Abbreviation CND : Canadian model SP : Singapore model MX : Mexican model · Part No. Description Remarks
When indicating parts by reference number, please include the board name.
The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. Les composants identifiés par une marque 0 sont critiques pour la sécurité. Ne les remplacer que par une piéce portant le numéro spécifié.
Remarks
Ref. No. R602
Part No.
Description 3.3K 5%
Remarks 1/4W
1-680-789-11 AUTO POWER BOARD ****************** 1-533-217HOLDER, FUSE < CAPACITOR > 0 C2 0 C3 0 C4 0 C5 C601 C602 C603 C604 C605 C606 1-113-925-11 CERAMIC 1-113-925-11 CERAMIC 1-113-925-11 CERAMIC 1-113-924-11 CERAMIC 1-104-666-11 ELECT 1-104-666-11 1-126-964-11 1-126-964-11 1-126-964-11 1-126-964-11 ELECT ELECT ELECT ELECT ELECT < CONNECTOR > CN601 CN602 * CN604 * CN605 1-564-505-11 1-564-505-11 1-564-104-00 1-564-507-11 PLUG, CONNECTOR 2P PLUG, CONNECTOR 2P PIN, CONNECTOR (B3P-VH) 3P PLUG, CONNECTOR 4P < DIODE > D601 D602 D603 D604 D605 D606 D607 D608 8-719-974-59 8-719-974-59 8-719-974-59 8-719-974-59 8-719-921-88 DIODE DIODE DIODE DIODE DIODE 1SR139-100 1SR139-100 1SR139-100 1SR139-100 MTZJ-13B 20.00% 250V 20.00% 250V (CND,AEP,UK,US,MX) 0.01uF 20.00% 250V (SP) 0.0047uF 20.00%250V 220uF 20.00% 25V 220uF 10uF 10uF 10uF 10uF 20.00% 20.00% 20.00% 20.00% 20.00% 25V 50V 50V 50V 50V 0.01uF 0.01uF
1-247-843-11 CARBON < RELAY >
RY601 RY602
1-755-276-11 RELAY, POWER (CND,AEP,UK,US,MX) 1-755-276-11 RELAY, POWER (SP) < SWITCH >
0 S601
1-771-474-11 SWITCH, POWER (VOLTAGE SELECTOR)(SP,MX) ************************************************************** 1-680-785-11 CONTROL BOARD *************** < CAPACITOR > C201 C202 C203 C204 C205 C206 C207 C208 C209 C210 C211 C212 C213 C214 1-136-165-00 1-136-169-00 1-136-169-00 1-136-169-00 1-136-169-00 1-136-169-00 1-136-169-00 1-136-169-00 1-136-169-00 1-136-169-00 1-126-964-11 1-126-964-11 1-136-165-00 1-136-165-00 MYLAR MYLAR MYLAR MYLAR MYLAR MYLAR MYLAR MYLAR MYLAR MYLAR ELECT ELECT MYLAR MYLAR < CONNECTOR > 0.1uF 0.22uF 0.22uF 0.22uF 0.22uF 0.22uF 0.22uF 0.22uF 0.22uF 0.22uF 10uF 10uF 0.1uF 0.1uF 5.00% 5.00% 5.00% 5.00% 5.00% 5.00% 5.00% 5.00% 5.00% 5.00% 20.00% 20.00% 5.00% 5.00% 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V
8-719-921-88 DIODE MTZJ-13B 8-719-911-19 DIODE 1SS119-25 (CND,AEP,UK,US,MX) 8-719-911-19 DIODE 1SS119-25 (SP)
* CN201
1-564-508-11 PLUG, CONNECTOR 5P < DIODE >
0 F601 0 F601 0 F601 0 F602
1-532-744-11 1-532-463-11 1-532-215-00 1-532-259-00
FUSE 2.5A/125V (US,CND,MX) FUSE 1A/250V (AEP,UK) FUSE TIME-LAG T800mAL/250V (SP) FUSE TIME-LAG T1.6AL/250V (SP) < TRANSISTOR >
D201 D202
8-719-991-33 DIODE 1SS133T-77 8-719-991-33 DIODE 1SS133T-77 < IC >
Q601 Q602
8-729-119-78 TRANSISTOR 2SC2785-HFE 8-729-173-38 TRANSISTOR 2SA733-K < RESISTOR >
IC201 IC202 IC203 IC204
8-759-145-58 8-759-145-58 8-759-145-58 8-759-145-58
IC IC IC IC
BA4558 BA4558 BA4558 BA4558
< RESISTOR > R201 R202 1-247-831-91 CARBON 1-247-855-91 CARBON 1K 10K 5% 5% 1/4W 1/4W
R601
1-247-843-11 CARBON
3.3K
5%
1/4W
8
SA-VE522/VE525/WM525/SS-MS525/V521 CONTROL
Ref. No. R203 R204 R205 R206 R207 R208 R209 R210 R211 R212 R213 R214 R215 R216 R217 R218 R219 R220 R221 Part No. Description 3.3K 56K 10K 6.8K 47K 10K 10K 15K 2.2K 100 10K 3.9K 3.9K 10K 10K 10K 8.2K 8.2K 100 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% Remarks 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W * * * * CN101 CN301 CN302 CN501 CN502 CN701 S201 1-771-632-11 SWITCH, ROTARY ********************************************************************* A-4476-543-A MAIN MOUNTED BOARD, COMPLETE ****************************** < CAPACITOR > C101 C102 C103 C104 C105 C106 C107 C108 C109 C110 C111 C116 C117 C118 C301 C303 C304 C305 0 C306 0 C307 C308 C309 C310 C311 C312 C313 C314 C315 C316 C317 1-162-286-31 1-162-286-31 1-162-286-31 1-162-286-21 1-126-964-11 1-162-215-31 1-162-215-31 1-136-163-00 1-136-164-00 1-136-174-00 1-136-163-00 1-136-153-00 1-136-153-00 1-126-964-11 1-136-153-00 1-126-964-11 1-162-282-31 1-102-121-00 1-101-804-00 1-101-810-00 1-126-934-11 1-128-560-11 1-128-560-11 1-130-313-11 1-136-165-00 1-130-471-00 1-136-161-00 1-126-934-11 1-126-964-11 1-126-948-11 CERAMIC CERAMIC CERAMIC CERAMIC ELECT CERAMIC CERAMIC MYLAR MYLAR MYLAR MYLAR FILM FILM ELECT FILM ELECT CERAMIC CERAMIC CERAMIC CERAMIC ELECT ELECT ELECT FILM MYLAR MYLAR MYLAR ELECT ELECT ELECT 220PF 220PF 220PF 220PF 10uF 47PF 47PF 0.068uF 0.082uF 0.56uF 0.068uF 0.01uF 0.01uF 10uF 0.01uF 10uF 100PF 2200PF 10PF 100PF 220uF 22uF 22uF 0.047uF 0.1uF 0.001uF 0.047uF 220uF 10uF 100uF 10% 10% 10% 10.00% 20.00% 5% 5% 5.00% 5.00% 5.00% 5.00% 5% 5% 20.00% 5% 20.00% 10% 10% 5% 5% 20.00% 20.00% 20.00% 5.00% 5.00% 5% 5.00% 20.00% 20.00% 20.00% 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 500V 500V 10V 100V 100V 100V 50V 50V 50V 10V 50V 35V D101 D102 D103 D104 D303 D304 D305 D306 D501 D502 D503 D504 D505 D506 D507 D701 D702 D703 D704 8-719-991-33 8-719-991-33 8-719-991-33 8-719-991-33 8-719-991-33 8-719-991-33 8-719-991-33 8-719-991-33 8-719-302-37 8-719-974-59 8-719-974-59 8-719-974-59 8-719-974-59 8-719-921-88 8-719-921-88 8-719-991-33 8-719-991-33 8-719-991-33 8-719-991-33 1-564-508-11 1-564-243-11 1-565-792-11 1-564-687-11 1-564-507-11 PLUG, CONNECTOR 5P PIN, CONNECTOR 6P PIN, CONNECTOR 2P PIN, CONNECTOR 3P PLUG, CONNECTOR 4P Ref. No. C501 C502 C503 C504 C505 C506 C507 C508 C509 C510 C511 C512 C513 C514 C515 C516 C701 Part No. 1-130-955-00 1-130-955-00 1-135-782-11 1-135-782-11 1-104-666-11 1-104-666-11 1-126-964-11 1-126-964-11 1-104-664-11 1-104-664-11 1-164-159-21 1-164-159-21 1-126-964-11 1-126-964-11 1-164-159-21 Description FILM FILM ELECT CHIP ELECT CHIP ELECT ELECT ELECT ELECT ELECT ELECT CERAMIC CERAMIC ELECT ELECT CERAMIC 0.01uF 0.01uF 10000uF 10000uF 220uF 220uF 10uF 10uF 47uF 47uF 0.1uF 0.1uF 10uF 10uF 0.1uF 0.1uF 330uF 5% 5% 20% 20% 20.00% 20.00% 20.00% 20.00% 20.00% 20.00% 1-247-843-11 CARBON 1-247-873-91 CARBON 1-247-855-91 CARBON 1-247-851-91 1-247-871-91 1-247-855-91 1-247-855-91 1-247-859-91 1-247-839-91 1-247-807-31 1-247-855-91 1-247-845-91 1-247-845-91 1-247-855-91 1-247-855-91 1-247-855-91 1-247-853-91 1-247-853-91 CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON
MAIN
Remarks 100V 100V 80V 80V 25V 25V 50V 50V 25V 25V
50V 50V 20.00% 50V 20.00% 50V 50V 50V 20.00% 16V
1-164-159-21 CERAMIC 1-104-661-91 ELECT < CONNECTOR >
1-247-807-31 CARBON
< VARIABLE RESISTOR > RV201 1-225-826-11 RES, VAR, CARBON 20K < SWITCH >
1-564-506-11 PLUG, CONNECTOR 3P < DIODE > DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE < IC > 1SS133T-77 1SS133T-77 1SS133T-77 1SS133T-77 1SS133T-77 1SS133T-77 1SS133T-77 1SS133T-77 RBV-602 1SR139-100 1SR139-100 1SR139-100 1SR139-100 MTZJ-13B MTZJ-13B 1SS133T-77 1SS133T-77 1SS133T-77 1SS133T-77
IC101 IC102 IC104 IC301 IC701
8-759-145-58 8-759-145-58 8-759-145-58 8-759-145-58 8-759-145-58
IC IC IC IC IC
BA4558 BA4558 BA4558 BA4558 BA4558
< JACK > J101 1-785-795-11 JACK, PIN 2P < TRANSISTOR > Q101 Q301 Q302 8-729-178-55 TRANSISTOR 2SC2785-E 8-729-117-41 TRANSISTOR 2SA1174-P 8-729-117-41 TRANSISTOR 2SA1174-P
9
SA-VE522/VE525/WM525/SS-MS525/V521 MAIN
Ref. No. Q303 Q304 Q305 Q306 Q307 Q308 Q309 Q310 Q311 Q501 Q502 Q701 Q702 Q703 Q704 Q705 Part No. Description Remarks Ref. No. 0 R309 0 R310 R311 R312 0 R313 0 R314 R315 R316 0 R317 0 R318 0 R319 R320 R321 R322 R323 R324 R325 R326 R327 R328 R329 R330 R331 R332 R333 R335 R336 R337 R338 R339 R340 R341 0 R501 0 R502 R503 R504 R701 R702 R703 R704 R705 R706 R707 R708 R709 R710 R711 Part No. 1-247-813-91 1-249-408-91 1-247-855-91 1-247-863-91 1-249-407-11 1-249-401-11 1-247-873-91 1-247-835-91 1-249-393-11 1-249-393-11 1-249-393-11 1-217-156-00 1-215-868-00 1-247-855-91 1-247-827-91 1-247-831-91 1-247-831-91 1-247-831-91 1-247-855-91 1-247-857-91 1-247-839-91 1-215-868-00 1-247-831-91 1-247-859-91 1-247-837-91 1-247-863-91 1-247-857-91 1-247-873-91 1-247-879-91 1-247-879-91 1-247-863-91 1-215-868-00 1-249-393-11 1-249-393-11 1-247-839-91 1-247-839-91 1-247-879-91 1-247-831-91 1-247-857-91 1-247-855-91 1-247-855-91 1-247-879-91 1-247-903-00 1-247-831-91 1-247-839-91 Description CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON METAL METAL OXIDE CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON METAL OXIDE CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON METAL OXIDE CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON 180 180 10K 22K 150 47 56K 1.5K 10 10 10 0.22 680 10K 680 1K 1K 1K 10K 12K 2.2K 680 1K 15K 1.8K 22K 12K 56K 100K 100K 22K 680 10 10 2.2K 2.2K 100K 1K 12K 10K 10K 100K 1M 1K 2.2K 2.2K 10K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 10% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% Remarks 1/4W F 1/4W F 1/4W 1/4W 1/4W F 1/4W F 1/4W 1/4W 1/4W F 1/4W F 1/4W F 5W 1W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1W 1/4W F 1/4W F 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 8-729-117-41 TRANSISTOR 2SA1174-P 8-729-119-78 TRANSISTOR 2SC2785-HFE 8-729-119-78 8-729-214-51 8-729-270-51 8-729-119-78 8-729-178-41 8-729-119-78 8-729-029-86 1-800-937-11 1-800-938-11 8-729-029-86 8-729-119-77 8-729-029-86 8-729-029-40 8-729-029-40 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR < RESISTOR > R101 R102 R103 R104 R105 R106 R107 R108 R109 R110 R111 R112 R113 R114 R115 R116 R117 R118 R119 R120 R121 R122 R123 R124 R125 R126 R136 R137 R138 R139 R140 R141 R301 R302 R303 R304 R305 R306 R307 R308 1-260-107-11 1-260-107-11 1-247-871-91 1-247-871-91 1-247-855-91 1-247-855-91 1-247-855-91 1-247-855-91 1-247-839-91 1-247-839-91 1-247-855-91 1-247-831-91 1-247-831-91 1-247-879-91 1-247-879-91 1-247-855-91 1-247-843-11 1-247-855-91 1-247-837-91 1-247-839-91 1-247-869-81 1-247-831-91 1-247-867-81 1-247-845-91 1-247-845-91 1-247-807-31 1-247-859-91 1-247-863-91 1-247-867-81 1-247-839-91 1-247-839-91 1-247-887-00 1-247-855-91 1-247-855-91 1-247-855-91 1-247-863-91 1-247-873-91 1-247-819-81 1-247-859-91 1-249-408-91 CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON 4.7K 4.7K 47K 47K 10K 10K 10K 10K 2.2K 2.2K 10K 1K 1K 100K 100K 10K 3.3K 10K 1.8K 2.2K 39K 1K 33K 3.9K 3.9K 100 15K 22K 33K 2.2K 2.2K 220K 10K 10K 10K 22K 56K 330 15K 180 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/2W 1/2W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 2SC2785-HFE 2SA1145-O 2SC2705-O 2SC2785-HFE 2SC2784-P 2SC2785-HFE DTC124ESA 2SC2003 2SA954 DTC124ESA 2SA1175-FEK DTC124ESA DTA124ESA DTA124ESA
1-247-839-91 CARBON 1-247-855-91 CARBON < RELAY >
RY301
1-515-920-11 RELAY (24V) < SWITCH >
S701
1-571-588-21 SWITCH, SLIDE < TERMINAL >
TM101 1-537-737-11 TERMINAL BOARD *********************************************************************
The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified.
Les composants identifiés par une marque 0 sont critiques pour la sécurité. Ne les remplacer que par une piéce portant le numéro spécifié.
10
SA-VE522/VE525/WM525/SS-MS525/V521 LED
Ref. No. Part No. Description Remarks Ref. No. Part No.
POWER
Description
POWER SWITCH
Remarks
1-680-788-11 LED BOARD ********* < CONNECTOR > CN801 1-564-506-11 PLUG, CONNECTOR 3P < DIODE > D801 8-719-028-30 DIODE SPR-39MVWF
ACCESSORIES & PACKING MATERIALS ******************************* 1-569-008-21 ADAPTOR, CONVERSION 2P (SA-VE522/VE525)(SP) 1-769-329-21 CORD, CONNECTION (SA-VE522/VE525)(PIN-PIN) 1-770-019-12 ADAPTOR CONVERSION PLUG 3P (UK) 1-790-503-11 CORD, SPEAKER (10m)(SA-VE525) 1-790-503-11 CORD, SPEAKER (10m)(SS-V521) 1-790-503-21 1-790-503-31 3-701-443-21 4-233-674-11 CORD, SPEAKER (2.5m)(SA-VE522/VE525) CORD, SPEAKER (3.5m)(SA-VE522/VE525) WASHER, 5 DIA. (SA-VE522/VE525) MANUAL, INSTRUCTION (SA-VE522/VE525)(CND,UK,US) (ENGLISH,FRENCH) 4-233-674-21 MANUAL, INSTRUCTION (SA-VE522/VE525)(AEP)(ENGLISH,FRENCH, GERMAN,ITALIAN) 4-233-674-31 MANUAL, INSTRUCTION (SA-VE522/VE525)(AEP)(DUTCH,SPANISH, SWEDISH,POLISH) 4-233-674-41 MANUAL, INSTRUCTION (SA-VE522/VE525)(AEP)(PORTUGUESE, DANISH,FINNISH,RUSSIAN) 4-233-674-51 MANUAL, INSTRUCTION (SA-VE522/VE525)(MX,SP)(ENGLISH, FRENCH,SPANISH,CHINESE) 4-972-322-01 FOOT (Y)(SA-VE522/VE525) 4-972-322-01 FOOT (Y)(SS-V521) 4-233-678-11 MANUAL, INSTRUCTION (SS-V521)(US,CND)(ENGLISH,FRENCH) 4-233-678-21 MANUAL, INSTRUCTION (SS-V521)(AEP)(ENGLISH,FRENCH, GERMAN,ITALIAN) 4-233-678-31 MANUAL, INSTRUCTION (SS-V521)(AEP)(DUTCH,SPANISH, SWEDISH,POLISH) 4-233-678-41 MANUAL, INSTRUCTION (SS-V521)(AEP)(PORTUGUESE, DANISH,FINNISH,RUSSIAN) 4-233-678-51 MANUAL, INSTRUCTION (SS-V521)(E)(ENGLISH,FRENCH, SPANISH,CHINESE) X-4953-333-1 STAND ASSY (SA-VE522/VE525) ************************************************************** ********** HARDWARE LIST ********** #1 #2 #3 #4 #5 7-685-664-79 7-685-646-79 7-685-662-79 7-685-660-19 7-685-647-79 SCREW +P 4X20 TYPE1 SCREW +BVTP 3X8 TYPE2 N-S SCREW +BVTP 4X14 TYPE2 N-S SCREW +BVTP 4X10 TYPE2 N-S SCREW +P 3X10 TYPE2 NON-SLIT
********************************************************************* 1-680-786-11 POWER BOARD ************* < CAPACITOR > C401 1-104-664-11 ELECT < CONNECTOR > * CN401 1-564-243-11 PIN, CONNECTOR 6P < TRANSISTOR > Q401 Q402 Q403 Q404 8-729-141-30 8-729-119-76 8-749-010-25 8-749-010-26 TRANSISTOR 2SC3623A-LK TRANSISTOR 2SA1175-HFE IC MN2488-OPY-M IC MP1620-OPY-M < RESISTOR > R401 1-247-871-91 CARBON 47K 5% 1/4W R402 1-247-839-91 CARBON 2.2K 5% 1/4W 0 R403 1-249-414-11 CARBON 560 5% 1/4W F 0 R404 1-249-408-11 CARBON 180 5% 1/4W F 0 R405 1-249-408-11 CARBON 180 5% 1/4W F 0 R406 1-217-151-00 METAL 0.22 10% 2W 0 R407 1-217-151-00 METAL 0.22 10% 2W ********************************************************************* 1-680-787-11 POWER SWITCH BOARD ******************* < CAPACITOR > 0 C1 1-113-924-11 CERAMIC < CONNECTOR > * CN1 1-695-044-11 PIN, CONNECTOR 2P < SWITCH > S1 1-554-920-61 SWITCH, PUSH (AC POWER)(1 KEY) ********************************************************************* MISCELLANEOUS ************* SPEAKER (20CM) TRANSFORMER, POWER (US,CND,MX) TRANSFORMER, POWER (SP) TRANSFORMER, POWER (AEP,UK) TRANSFORMER, POWER (US,CND,MX) 0.0047uF 20.00% 250V 47uF 20.00% 25V
SP901 0 T501 0 T501 0 T501 0 T601
1-529-296-11 1-435-999-11 1-437-219-11 1-437-246-11 1-435-993-11
0 T601 1-435-994-11 TRANSFORMER, POWER (AEP,UK) 0 T601 1-435-995-11 TRANSFORMER, POWER (SP) **************************************************************
The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. Les composants identifiés par une marque 0 sont critiques pour la sécurité. Ne les remplacer que par une piéce portant le numéro spécifié.
11
SA-VE522/VE525/WM525/SS-MS525/V521
Ref. No. Part No. Description REVISION HISTORY
Remarks
Ref. No.
Part No.
Description
Remarks
Clicking the version allows you to jump to the revised page. Also, clicking the version at the upper right on the revised page allows you to jump to the next revised page. Ver. 1.0 Date 2001.01 New Description of Revision
12