Text preview for : onkyo DPC-5.3.pdf part of onkyo dpc-5.3 onkyo dpc-5.3 service manual
Back to : onkyo DPC-5.3.part1.rar | Home
DPC-5.3
Ref. No. 3736
SERVICE MANUAL
Sep, 2002
DVD CHANGER MODEL DPC-5.3
DISC SKIP
Black model BUDD 120V AC, 60Hz
RC-503DV
SAFETY-RELATED COMPONENT WARNING!!
COMPONENTS IDENTIFIED BY MARK ON THE SCHEMATIC DIAGRAM AND IN THE PARTS LIST ARE CRITICAL FOR RISK OF FIRE AND ELECTRIC SHOCK. REPLACE THESE COMPONENTS WITH ONKYO PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL. MAKE LEAKAGE-CURRENT OR RESISTANCE MEASUREMENTS TO DETERMINE THAT EXPOSED PARTS ARE ACCEPTABLY INSULATED FROM THE SUPPLY CIRCUIT BEFORE RETURNING THE APPLIANCE TO THE CUSTOMER.
www.denom.com
DPC-5.3 SPECIFICATIONS
DVD Changer
Power supply Power consumption Weight External dimensions Signal system Frequency range (digital audio) Signal-to-noise ratio (digital audio) Audio dynamic range (digital audio) Harmonic distortion (digital audio) Wow and flutter Operating conditions AC 120 V, 60 Hz 20 W 15.0 lbs 17 1/8" x 5 1/16" x 16 15/16" (W/H/D) NTSC 48 kHz sampling 4 Hz to 22 kHz 96 kHz sampling 4 Hz to 42 kHz More than 98 dB More than 95 dB Less than 0.008 % Below measurable level Temperature: 5 C to 35 C (41 F to 95 F) Operation status: Horizontal
Outputs
Video output S-video output Component video output Audio output (digital output Optical) Audio output (digital output Coaxial) Audio output (analog output) 1.0 V (p-p), 75 ohm, negative sync., pin jack x 1 (Y) 1.0V (p-p), 75 ohm, negative sync. (C) 0.286 V (p-p), 75 ohm Mini DIN 4-pin x 1 , (Y) 1.0 V (p-p), 75 ohm, negative sync., pin jack x 1 (PB)/(PR) 0.7 V (p-p), 75 ohm pin jack x 2 Optical connecter x 1 0.5 V (p-p), 75 ohm , pin jack x 1 2.0 V (rms), 320 ohm, pin jack (L, R) x 2
Specifications and features are subject to change without notice.
www.denom.com
DPC-5.3 SERVICE PROCEDURE
PRECAUTIONS
1. Ground for the work-desk. Place a conductive sheet such as a sheet of copper (with impedance lower than 10M ohm) on the work-desk and place the set on the conductive sheet so that the chassis. 2. Grounding for the test equipments and tools. Test equipments and toolings should be grounded in order that their ground level is the same the ground of the power source. 3. Grounding for the human body. Be sure to put on a wrist-strap for grounding whose other end is grounded. Be particularly careful when the workers wear synthetic fiber clothes, or air is dry. 4. Select a soldering iron that permits no leakage and have the tip of the iron well-grounded. 5. Do not check the laser diode terminals with the probe of a circuit tester or oscilloscope. 1. Replacing the fuses
This symbol located near the fuse indicates that the fuse used is show operating type, For continued protection against fire hazard, replace with same type fuse , For fuse rating, refer to the marking adjust to the symbol. Ce symbole indique que le fusible utilise est e lent. Pour une protection permanente, n'utiliser que des fusibles de meme type. Ce demier est indique la qu le present symbol est apposre. REF.NO. F1 PART NO. SR-5, T 2A DESCRIPTION 250VCA T 2.0A
2. Safety-check out
(Only U.S.A. model) After correcting the original service problem perform the following safety check before releasing the set to the customer Connect the insulating-resistance tester between the plug of power supply cord and terminal GND on the back panel. Specifications: More than 10M ohm at 500V
LASER CAUTION
The lightning flash with arrowhead symbol, within an equilateral triangle, is intended to alert the user to the presence of uninsulated "dangerous voltage" within the product's enclosure that may be of sufficient magnitude to constitute a risk of electric shock to persons. The exclamation point within an equilateral triangle is intended to alert the user to the presence of important operating and maintenance (servicing) instruction in the literature accompanying the appliance.
WARNING : TO REDUCE THE RISK OF FIRE OR ELECTRIC SHOCK, DO NOT EXPOSE THIS APPLIANCE TO RAIN OR MOISTURE. DANGEROUS HIGH VOLTAGES ARE PRESENT INSIDE THE ENCLOSURE. DO NOT OPEN THE CABINET. REFER SERVICING TO QUALIFIED PERSONNEL ONLY. TO PREVENT ELECTRIC SHOCK, MATCH WIDE BLADE OF PLUG TO WIDE SLOT, FULLY INSERT.
CAUTION :
ATTENTION : POUR EVITER LES CHOCS ELECTRIQUE, INTRODUIRE LA LAME LA PLUS LARGE DA LA FICHE DANS LA BORNE CORRESPONDANTE DA LA PRISE ET POUSSER JUSQU' AU FOND.
Initialization of setup
1. Press the "CD PLAY" and "DISC 3" key to the same timing on the front panel. You will see that the program is updated by watching the version in the FL tube. 2. Push the power switch.
www.denom.com
DP-C5.3
A B C
S1 S2 S2 S2 46 S1 S2 S6 S3 44
1
D
E
F
G
H
EXPLODED VIEW-1
CHASSIS 1
S1
2
40
2
41 S1 S2 42 43 S3 50 49 S2 51 56 39 S6 54 51 S2
3
S2 52 23
47 48
55 S2 58
53 60 S2 22 7 24 10 6 9 5 11 S4 12 13 25 S2 S2 29 28 23
38 30 S2 36
4
S5
8 S4 4
27 24 25 S2 S2 26 24 25 S2 21 S2 23
23
16 2 3 S4 20 19 S2 1 14 17 18 15 S5
5
www.denom.com
DPC-5.3
A B
280
C
CLAMPER DVD ASS'Y Part No. 55542660
D
EXPLODED VIEW-2
DVD Mechanism
1
50 140 240 160 150 120 130 100 110 150 160
BASE ASS'Y - CDM5G Part No.55542650
160 150
90
2
170
150
160 150 160 70 80 280 420 310 430 300 * 2 320 480 440 60 280 * 2
3
200 240 210 220 240 230 270 * 2 460
*4
290 450
*4
470
4
190
Assy Part No. 55542660
260 70 250 5000 500 300 530
490 510 550
300
520 540
*2
5
300 560
300
300
300
www.denom.com
DPC-5.3
A B C D E
BLOCK DIAGRAM -5
POWER SUPPLY UNIT 1
HOT > SW1 F1 FL OUTPUT RECTIFIER & SMOOTHING CIRCUIT
AC INPUT
NUT >
LINE FILTER
RECTIFIER & SMOOTHING CIRCUIT
SNUBBER CIRCUIT
-27V OUTPUT RECTIFIER & SMOOTHING CIRCUIT
R2 -9V OUTPUT RECTIFIER & SMOOTHING CIRCUIT
2
R3
+12V OUTPUT RECTIFIER & SMOOTHING CIRCUIT
+9V OUTPUT RECTIFIER & SMOOTHING CIRCUIT
. DRIVER CIRCUIT . VOLTAGE CONTROLLER CIRCUIT . OVER CURRENT PROTECTOR CIRCUIT
+5.5V OUTPUT RECTIFIER & SMOOTHING CIRCUIT
+5V OUTPUT RECTIFIER & SMOOTHING CIRCUIT
3
+3.5V OUTPUT RECTIFIER & SMOOTHING CIRCUIT
+2.5V OUTPUT RECTIFIER & SMOOTHING CIRCUIT
VOLTAGE DETECTOR CIRCUIT
PC1
4
www.denom.com
DPC-5.3
A B C D E
BLOCK DIAGRAM -4
DVD MECHANISM & OUTPUT CIRCUIT 1
AUDIO/VIDEO JACK
MECHANISM CONTROL PC BOARD
2
Main circuit PC board
AUDIO/VIDEO JACK
3
PICK UP
Flat cable
4
www.denom.com
DPC-5.3
A B C D E
BLOCK DIAGRAM -3 DISPLAY SECTION
1
From Power supply unit
2
To Main PC board
3
Key matrix
4
www.denom.com
DPC-5.3
A B C D E
BLOCK DIAGRAM -2
MAIN CIRCUIT BOARD
IC61
1
IC-CONV WN8728 D/A IC-OPEAMP BA4560F
To OUT
CP25:04PIN CP25:06PIN
POWER SUPPLY UNIT
To OUT
CN27:SPDIF
2
IC-LOGIC 74HC74 FLIF/FLOP CMOS IC-LOGIC 74HC86 GATE HCMOS
To Mechanism control
IC- VIDEOPROC STI5519 MPEG VIDEO DECODER
INVERTER HCT IC-LOGIC M74HCU04M1R
To OUT
CP25:08PIN CP25:10PIN CP25:12PIN CP25:14PIN CP25:16PIN CP25:18PIN
3
To Pick up
IC41
IC MEMFLASH M29W800A T901N1
TR SWITCH CIRCUIT P SCAN ON/OFF
IC31
To Display
IC-DRAM HY57V651620BTC-8 125M 64M(1M x 16 x 4)
4
www.denom.com
DPC-5.3
A B C D E F G H
BLOCK DIAGRAM-1
OVER ALL 1
2
3
4
5
www.denom.com
DV-CP500
A B C D
SCHEMATIC DIAGRAM
Main circuit PC board-1 1
L501 FCM2012H-102T04 100N-03
R504 100R-03 R501 20P-03 C506 20P-03 R502 56R-03 R503 C501 1M-03
C505 470/6.3
C504
100R-03
D3V3
C503 22P-03
X501 X-TAL
GND
+3.3VM
47K-03 R413
R415 FCM2012H-102T04
F_ADDR17
ADD IC41 IC-M29F400T-90N1 A15 A16 48 A14 BYTE 47 A13 VSS 46 A12 DQ15 45 A11 DQ7 44 A10 DQ14 43 A9 DQ6 42 A8 DQ13 41 NC DQ5 40 NC DQ12 39 WE DQ4 38 RP VCC 37 NC DQ11 36 NC DQ3 35 RY/BY DQ10 34 A18 DQ2 33 A17 DQ9 32 A7 DQ1 31 A6 DQ8 30 A5 DQ0 29 A4 QE 28 A3 VSS 27 A2 CE 26 A1 A0 25
2
F_ADDR16 F_ADDR15 F-ADDR14 F_ADDR13 F_ADDR12 F_ADDR11 F_ADDR10 F_ADDR09 F_ADDR20 F_RESET R411 DR-03 R412 DR-03 F_ADDR19 F_ADDR18 F_ADDR08 F_ADDR07 F_ADDR06 F_ADDR05 F_ADDR04 F_ADDR03 F_ADDR02 F_ADDR01
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24
+5V6S
100N-03 R245 1K8-03 1K8-03 R247 C228 IC22 IC-M24C02 1 E0 VDD 8 2 E1 3 E2 4 VSS WC 7 R248 47R-03 R249 47R-03 10R-03
SCL 6 SDA 5
3
GND
4
CP21 FPC-19P Pickup to Main PCB
NC D_GND SECTOR_START DATA_VALID DATA BIT_CLOCK D_GND RESET DXX_INTERRUPT SCL SDA D_GND DRIVE_GND +3V3D +5VD D_GND A_GND DISC_M_POWER TRACK_M_POWER 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19
From Display circuit PC board (To Connection PCB)
R246
C406 100/10
5
www.denom.com
To Mechanism control PCB (P406)
Down load Jig
C502 22P-03
5 Main circuit PC board-2
4
3
2
1 A B
SCHEMATIC DIAGRAM
www.denom.com
NC NC NC NC To Output PCB (CP01) To Power supply unit (CN2) To Output terminal PCB (CN01)
C
Video signal out
DPC-5.3
D
DPC-5.3
A B C D E
+3V3 R219 0R-03
100N-03 C207
F
DAC_LAT125 DAC_SCKDSD DAC_SDIOEM MCLK_IN BCK_IN DATA_IN LRC_IN
G
+3V3 +5VD
L601 FCM2012H_102T04 DAC_CSBIWL
H
SCHEMATIC DIAGRAM-1
L602 FCM2012H_102T04
+5VA
JTAG TEST CONNECTION
R220 0R-03
R222 10K-03 R223 10K-03 R224 10K-03
10P-03 C613 10P-03
47K-03
4K7-03
R612 4K7-03
R605
R225
47R-03 47R-03 47R-03 47R-03
100N-03
C504
13 12 11 10 9 GND 8
R502 56R-03
C505 470/6.3
C608 100/10
1
C506 20P-03 20P-03
1 100R-03 R504 100R-03 R501
C501
VCC 14
D3V3
R61L 47K-03
2 3 4 5 6 7
R228
C605 10P-03 GND
C62L 2N7-03
+5VD
R227
6 DGND 7 DVDD 8 VOUTR 9 AGND 10 AVDD
CSBIWL 15 VREFP 14 VREFN 13 VMID 12 VOUTL 11
33R-03 R602 33R-03 R601
OUT 2
1
DTC323TK(S) 330R-03 -9V 820K-03 R606
100P-03 C67R
Q602 DTC114YKA
R229
10K-03 R414 R406 R405
1M-03 R503
47R-03
10K-03 R230
R67L 100R-03 R65R
R66R 100K-03
1SS355(SMD)
10K-03
10R-03
47/16
C65L
R231 0R-03
DOWN LOAD JIG
15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
AGND
330P-03
47/16 C66R
9K1-03
R64R
GND
C607 560P-03
C63R
10/16 C606
A_MUTE
C502 22P-03
C503 22P-03
C32R 2N7-03
X501 X-TAL
5
R63R 3K9-03 OUT
Q61R
R61R
AGND
47K-03
7
330R-03 +9V
DTC323TK(S)
6
8
C65R 47/16
GND
GND
FPC-ST_15P CP22
R67R
+3V3
+3.3VM
+2V5
47R-03 10K-03 10K-03 R237 10R-03 R234 R236
R415 FCM2012H-102T04
10K-03
R404 R403 R402 R401
F_DATA00 F_DATA01 F_DATA02 F_DATA03
47R-03 47R-03 47R-03 47R-03
AGND
CN25 CN_2.5_12P
1 2 3 4 5 6 7 8 9 10 11 12 +9V A_GND -9V +12V_SCART +5V6S +3V5D D_GND +2V5D +5VD +9V_MOTOR M_GND NC
R235
47K-03
C406 100/10
1 3 5 7 1 3 5 7 1 3 5 7 1 3 5 7
2 RA41 47R 4 6 8 2 RA42 47R 4 6 8 2 RA43 47R 4 6 8 2 RA44 47R 4 6 8
+2V5
100N-03 C212
F_RESET
R232
+3V3
C210
47R-03 R238
R147 10R-03
C133 100N-03
+3V3D -9V
C134 100N-03
4K7-03
10K-03
R413
10K-03
4K7-03
+3V3
R233
R215
10N-03
100N-03
1 2 3 4
1RD 1D 1CP 1SD 1Q 1Q GND
C209
F_ADDR17
C211
1K-03 R218
VCC 14 2RD 13 2D 12 2CP 11 2SD 10 2Q 9 2Q 8
2 3 4 5 6 7 GND
F_DATA(00:15)
100N-03
470P-03
C206
1K-03
C213
C205
R214
1N-03
48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 28 27 26 25
100N-03
IC41 M29F400T-90N1
F_ADDR16 F_ADDR15 F-ADDR14 F_ADDR13 F_ADDR12 F_ADDR11 F_ADDR10 F_ADDR09 F_ADDR20 F_RESET R411 DR-03 R412 DR-03 F_ADDR19 F_ADDR18 F_ADDR08 F_ADDR07 F_ADDR06 F_ADDR05 F_ADDR04 F_ADDR03 F_ADDR02 F_ADDR01
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 A15 A14 A13 A12 A11 A10 A9 A8 NC NC WE RP NC NC RY/BY A18 A17 A7 A6 A5 A4 A3 A2 A1 A16 BYTE VSS DQ15 DQ7 DQ14 DQ6 DQ13 DQ5 DQ12 DQ4 VCC DQ11 DQ3 DQ10 DQ2 DQ9 DQ1 DQ8 DQ0 QE VSS CE A0
11 10 9 8
C405
F_DATA15 F_DATA07 F_DATA14 F_DATA06 F_DATA13 F_DATA05 F_DATA12 F_DATA04 F_DATA11 F_DATA03 F_DATA10 F_DATA02 F_DATA09 F_DATA01 F_DATA08 F_DATA00
156
155
154
153
152
151
150
149
148
147
146
145
144
143
142
141
140
139
138
137
136
135
134
133
132
131
130
129
128
127
126
125
124
123
122
121
120
119
118
116
113
112
109
108
106
117
115
114
111
110
107
105
F_DATA12 F_DATA13 F_DATA14 F_DATA15
100N-03 C208
5 6 7
CPU_DATA(3)
CPU_DATA(13)
CPU_DATA(12)
CPU_DATA(11)
CPU_DATA(10)
CPU_CE(0)
CPU_CE(1)
CPU_CE(2)
CPU_CE(3)
CPU_WAIT
CPU_BE(1)
CPU_BE(0)
CPU_DATA(9)
CPU_DATA(8)
VDD_PLL
CPU_RW
CPU_PROCLK
CPU_CAS1
CPU_CAS0
CPU_RAS1
VDD2_5
RESET
IRQ(0)
IRQ(1)
IRQ(2)
CPU_DATA(7)
CPU_DATA(6)
CPU_DATA(5)
CPU_DATA(4)
CUP_DATA(2)
CPU_DATA(1)
CPU_DATA(0)
VDD3_3
TRST
TDO
ADC_PCMCLK
ADC_DATA
PIX_CLK
VDD2_5
VSS
TCK
CPU_OE
VSS_PLL
VDD3_3
VSS
PWM0
PWM1
PWM2
VSS
TDI
TMS
VSS
Q201 KTC3875(S) GND
Q202 KTC3875(S)
100/10 C21P
ADD
F_DATA08 F_DATA09 F_DATA10 F_DATA11
12
+9V
0R-03 R21P
L210 KIA7805API FCM2012H-102T04 IC1P
+5VA (VIDEO_AUDIO)
F_DATA04 F_DATA05 F_DATA06 F_DATA07
R216
R217
GND
100/10
IC14 74AHC74 1
IC15 74AHC86 VCC 14 13
+12V_SCART +5V5S +3V5D +2V5D +5VD +9V_MOTOR
W4
0R_03 0R_03 CP25 FPC_ST_23P(6216)
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23
1N-03 C404
+3V3
+2V5
V_SYNC H_SYNC
W3
2
157 CPU_DATA(14) 158 CPU_DATA(15)
100N-03
ADC_LRCLK ADC_SCLK SMI_DATA(15)
104 103 102 101 100 99 98 97 96 95 94 93 92 91 90 89 88 87 86 85
R310 R311 R312 R313
GND SDATA(00:15) 1 3 5 7 1 3 5 7 1 3 5 7 1 3 5 7 2 RA37 47R 4 6 8 2 RA36 47R 4 6 8 2 RA35 47R 4 6 8 2 RA34 47R 4 6 8 SDATA15 SDATA14 SDATA13 SDATA12 SDATA11 SDATA10 SDATA09 SDATA08 SDATA07 SDATA06 SDATA05 SDATA04 SDATA03 SDATA02 SDATA01 SDATA00 SDATA(00:15) 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27
159 VDD3_3
C214
AUDIO_R AUDIO_L CVBS C_OUT Y_OUT R_OUT(Cr) G_OUT(Y) B_OUT(Cb) +5VD PRO_SCAN AGND
DIAGNOSTICS
161 CPU_ADR(1) 162 CPU_ADR(2) 163 CPU_ADR(3)
INTERFACE FLASH MEMORY CPU MEMORY PROGRAMABLE
GENERATOR CLOCK PLL
SYSTEM SERVICE
GND
CONTROLLER AND
160 VSS
SMI_DATA(14) SMI_DATA(13)
IC31 SDRAM_4Mx16
VCC DQ0 VCCQ DQ1 DQ2 VSSQ DQ3 DQ4 VCCQ DQ5 DQ6 VSSQ DQ7 VCC LDQM WE CAS RAS CS BA0 BA1 A10 A0 A1 A2 A3 VCC VSS DQ15 VSSQ DQ14 DQ13 VCCQ DQ12 DQ11 VSSQ DQ10 DQ9 VCCQ DQ8 VSS NC UDQM CLK CKE NC A11 A9 A8 A7 A6 A5 A4 VSS 54 53 52 51 50 49 48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 28 SDATA15 SDATA14 SDATA13 SDATA12 SDATA11 SDATA10 SDATA09 SDATA08 TXD RXD
KARAOKE MODULE
SMI_DATA(12) SMI_DATA(11) SMI_DATA(10) VSS SMI_CLKOUT VDD2_5 SMI_DATA(9) SMI_DATA(8) SMI_DATA(7) SMI_DATA(6) SMI_DATA(5)
SDATA00 SDATA01 SDATA02 SDATA03 SDATA04 SDATA05 SDATA06 SDATA07
R411 R412 R413 ATMEL 16M 0 ohm NC 4K7 ST 16M NC 0 ohm
164 CPU_ADR(4) 165 CPU_ADR(5) F_ADDR(01:21) 166 CPU_ADR(6) RA45 F_ADDR01 F_ADDR02 F_ADDR03 F_ADDR04 1 3 5 7 RA46 47R 2 4 6 8 47R
C215 100N-03
167 CPU_ADR(7) 168 CPU_ADR(8) 169 CPU_ADR(9) 170 CPU_ADR(10)
R207 R208
47R_03 47R_03
1. DGND 2. SPDIF 3. AGND 4. AUDIO_R 5. AGND 6. AUDIO_L 7. AGND 8. CVBS 9. AGND 10. C_OUT 11. AGND 12. Y_OUT 13. AGND 14. R_OUT(Cr) 15. AGND 16. G_OUT(Y) 17. AGND 18. B_OUT(Cb) 19. +5VD 20. NC 21. PRO_SCAN_ON_OFF
+5V6S
172 VSS 173 CPU_ADR(11) 174 CPU_ADR(12) 175 CPU_ADR(13) 176 CPU_ADR((14)
100N-03
R245 1K8-03 1K8-03 R247
RA47
10R-03
47R 2 4 6 8
C228 IC22 IC-M24C02 1 E0 VDD 8 2 E1 3 E2 4 VSS WC 7
R246
F_ADDR09 F_ADDR10 F_ADDR11 F_ADDR12
1 3 5 7 RA48 47R
SMI_DATA(2) SMI_DATA(1) SMI_DATA(0) VSS SMI_CLKIN
0R-03 SADDR(00:13) R314
100N-03 100/10 C311 C312
0R-03
R248 47R-03 R249 47R-03
SCL 6 SDA 5
F_ADDR13 F_ADDR14 F_ADDR15 F_ADDR16
1 3 5 7
2 4 6 8
177 CPU_ADR(15) 178 CPU_ADR(16) 179 CPU_ADR(17) 180 CPU_ADR(18) 181 CPU_ADR(19) 182 CPU_ADR(20) 183 CPU_ADR(21)
C216 100N-03
84 83 82 81 80 79 78 77 76 75 74 73 72 71 70 69 68 67 66 65 64 63 GND 1 3 5 7 1 3 5 7 1 3 5 7 R302 R301 100R-03 100R-03 +2V5 +3V3 R309 R308 R307 R306 R305 R304 R303 100R-03 100R-03 100R-03 100R-03 100R-03 100R-03 100R-03
J301
L301
SMI_DATA(3)
0R-03
IC21
+3V3
SMI_DATA(4)
4K7-03 4K7-03 4K7-03 4K7-03
F_ADDR05 F_ADDR06 F_ADDR07 F_ADDR08
1 3 5 7
2 4 6 8
171 VDD2_5
R315
47K(SMD)
SADDR12 SADDR13 SADDR10 SADDR00 SADDR01 SADDR02 SADDR03
SADR11 SADDR09 SADDR08 SADDR07 SADDR06 SADDR05 SADDR04
CN27 CP_2.0_ST_02P 1 2 1.SPDIF 2.D_GND
F_ADDR17 F_ADDR18 F_ADDR19 F_ADDR20
GND
R407 R408 R409 R410
47R-03 47R-03 47R-03 47R-03
4KB SRAM DATA-CACHE 2KB
SDRAM MEMORY
VDD3_3 SMI_DQMU SMI_DQML
GND SADDR(00:13)
STI5519 ST20 CPU
INTERFACE SHARED MEMORY 2KB CACHE INSTRUCTION
SMI_WE SMI_CAS SMI_RAS SMI_CS(1) SMI_CS(0) SMI_ADR(13) SMI_ADR(12) SMI_ADR(11) SMI_ADR(10)
184 VDD3_3 185 VSS 186 PIO0(0) T_STROBE 187 PIO0(1) MOD_SW 188 PIO0(2) 189 PIO0(3) 190 PIO0(4) 191 PIO0(5) 192 PIO0(6) 193 PIO0(7) 194 PIO1(0) 195 PIO1(1) 196 PIO1(2) SLIDER_SENSOR_OPEN/VLOSE SLIDER_IN (DRAWER_CCW_CTRL) SDA SCL SLIDER_OUT (DRAWER_CW_CTRL) TXD(JIG)
PCM_LRCIN_OUT PCM_DATA_OUT PCM_BCK_OUT PCM_MCLK_OUT SASSR13 SADDR12 +2V5D
10R-03 R126
3
R239 R240
47R-03 47R-03
+3V3D
10R-03
1N-03
C123
3-PWM Outputs
SMI_ADR(1) SMI_ADR(2)
47K-03
47K-03
47K-03
SMI_ADR(3) VSS
R124 2R2-03
1N-03
R122
R121
R120
R119
C120
47R-03
C217 100N-03
197 PIO1(3) GND 198 VDD2_5 199 VSS 200 PIO1(4) 201 PIO1(5) TRIGIN TRIGOUT
2-UARTS
VDD2_5 SMI_ADR(9)
R123 2R2-03
2 RA31 SADDR07 4 47R SADDR06 6 SADDR05 8 SADDR04
47K-03
12C Controller
F_RESET
C119 1N-03
100/16
1N-03 10R-03
R117
100/16
R241
C117
R118 2R2-03
2 RA32 SADDR02 4 47R SADDR03 SADDR09 6 SADDR08 8
C121
SMI_ADR(0)
1N-03
2 RA33 SADDR11 4 47R SADDR10 6 SADDR00 8 SADDR01
100/16
100/16
C124
C122
R125
+2V5A
+5VA
VDD3 60
SRN 59
CLK 58
RAM2 56
RAM5 53
GND 52
VDD3 49
VO0 48
SPR0/VO2 46
SPR3/VO5 43
GND 57
RAM3 55
RAM4 54
GND 51
GND 50
SPR1/VO3 45
SPR2/VO4 44
GND 42
VO1 47
1N-03
100N-03 C118 VDD3 40
R242 R243 75R-03 75R-03 R244
FRONT_TXD1
PAL/NTSC/SECAM ENCODER
PCM OUT
10-BIT DAC 10-BIT DAC 10-BIT DAC
SMI_ADR(6) SMI_ADR(5) SMI_ADR(4) SPDIF_OUT (LRCIN) DAC_LRCLK (MCLK) DAC_PCMCLK
60 59 58 57 SPDIF 56 PCM_LR$CIN 55 PCM_MCLK 54 53 47R-03 R619
C620 10P-03 10P-03
202 TRIGGER_IN 203 TRIGGER_OUT 204 PIO2(0) 205 PIO2(1) 206 PIO2(2) 207 PIO2(3) 208 PIO2(4) VIDEO_MUTE FRONT_RXD AUDIO_MUTE DAC_LATI2S_OUT DAC_SCKDSD_OUT
PIO2(5) DAC_SDIOEM_IN/OUT PIO2(6) DAC_MUTEB_IN/OUT PIO3(0) PRO_SCAN_ON/OFF PIO2(7) DAC_CSBIWL_OUT
C125
61 VDD2 L604 BEAD 120 ohm PM0026STB PM0026DATA PM0026CLK R127 R128 R129 100R-03 62 CSB 100R-03 100R-03 C128 47P-03 C127 47P-03 C126 47P-03 R130 47K-03 65 RAM1 66 RAM0 67 CKPOL 68 VIA9 63 SDTA 64 SCLK R131 47K-03 R132 100R-03
1N-03
6-CHANNEL
SPR5/VO7 38 SPR6/VO8 37 GND 36 SPR7/VO9 35 CLMP 34 AGND 33
C114
INTERFACE FRONT-END
SPR4/VO6 39 2R2-03 R116 1K(SMD)
Q15R KTN2907A
R18R
AUDIO DECODER
DAC_PCMOUT2 DAC_PCMOUT1
C621
R618 100R-03
100(SMD) R19R R20R 75(SMD) 100N-03 C112 C111 1N-03
360R-03 R115
10 PIO3(4) IR(REMOTECONT)
69 VIA8
52 DAC_PCMOUT0 (DATA) 13 PIO3(7) DVD_RESET
70 VIA7 71 VIA6 72 VIA5 73 VIA4 74 VIA3 75 VIA2 PCM_DATA_OUT R617 PCM_BCK_OUT R616 47R-03 47R-03
C618 10P-03 10P-03 C619
51 DAC_SCLK (BCK)
FSADJ 30 VREF 29 AVDD2 28 DAO_R 27 AGND 26 DAO_B 25 AVDD2 24 DAO_Y 23 AGND 22 VDD2 21
17 TEST2 18 TEST1 19 TEST0 15 DOS1 16 DOS0 20 VDD3
100(SMD) R19B R20B 75(SMD) R18G 1K(SMD)
22 NRSS_OUT
35 V_REF_YC
28 V_REF_RG
36 I_REF_YC
VDD_PCM
29 I_REF_RG
23 VDD_RGB
30 VDD_YCC
24 VSS_RGB
31 VSS_YCC
20 B_WCLK
19 B_SYNC
34 CV_OUT
17 B_BCLK
18 B_FLAG
37 VDD2_5
VDD3_3
39 PIO4(0)
40 PIO4(1)
16 B_DATA
14 DVV2_5
11 PIO3(5)
12 PIO3(6)
26 G_OUT
PIO3(1)
27 R_OUT
33 C_OUT
VSS_PCM
C110 1N-03
32 Y_OUT
PIO(2)
PIO(3)
25 B_out
21 B_V4
38 VSS
VDD3_3]
PIO4(2)
PIO4(3)
PIO4(4)
PIO4(5)
PIO4(6)
PIO4(7)
VSS
+3V3
+2V5 L201 0R-03
100(SMD) R19C R20G 75(SMD) C109 1N-03
47R-03
47R-03
47R-03
47R-03
47R-03
47R-03
47R-03
47R-03
10N-03 C617
100N-03
100N-03
C615
18K-03
L101 10N-03 C204 C102 C101 100/10
18K-03
100N-03 C105
100N-03
C616
C201
100/10
C202
470/6.3
3K6-05 0.5%
C203
R113
2U2H L202
100/10
R101
10N-03 100/10 C104 C103 L102 2U2H
R102
2U2H
HSYNC
R134
100R-03 79 NHS
VDD3
GND
10 GND
11 GND
VIB8
VIB4
VIB9
VIB7
VIB6
VIB5
VIB3
12 VIB2
13 VIB1
14 VIB0
2U2H
C129 1N-03
R103
R106
R108
R109
R104
R105
R107
R17R
R13R
2K2-03
R14R
FCM2012H-102T04 AGND
GND
36K-03
L205
R11B +9VM
10R-03
5K6-03
NC D_GND SECTOR_START DATA_VALID DATA BIT_CLOCK D_GND RESET DXX_INTERRUPT SCL SDA D_GND DRIVE_GND +3V3D +5VD D_GND A_GND DISC_M_POWER TRACK_M_POWER
1 2 3 4 5 (EXT_DATA) 6 (EXT_BCLK) 7 8 (3V3_R) 9 (IRQ2) 10 11 12 13 14 15 16 0R-03 R250 17 18 19
300R-03
300R-03
300R-03
R110
GND
C108 1N-03
1
CP21 FPC-19P From Pickup to Main PCB
80 VDD3
2 3
C113 100N-03
VR11
0.5% 1K4-05
R10C
R10Y
R10G
R10R
R10B
R10S
R201 R202 R203 R204
100R-03 100R-03 100R-03 100R-03
+2.5VA
GND
2
C107 1N-03
R112
200
1
2
3
4
5
6
7
8
9
3
IC13 1
R114
+2V5
78 NVS
82R-03
4
76 VIA1 77 VIA0 VSYNC R138 100R-03
L603
Q15G KTN2907A
VSS
15 VSS
41
42
43
44
45
46
47
48
49
50
1
2
3
4
5
6
7
8
9
Q15B KTN2907A
IC PM0026A
VG 32 AVDD2 31
R18B
1K(SMD)
C116
47R-03
RXD(JIG)
SMI_ADR(7)
61
VDD3 41
38-Bit Programable I/O
SMI_ADR(8)
62
C115
TL431
G
+5VA
C130 100/16 300R-03 300R-03 300R-03
10K-03
R251
R253 100R-03
100N-03 68P-03 68P-03 C226 C227 C225
PM0026STB PM0026DATA PM0026CLK AGND
R11S R11C R11Y
10R-03 10R-03 10R-03 13K7-03-1% Q12R Q11R KTN2222 KTN2222
R15R 680(SMD)
IC12 IC-MM1568
+3V3D 10K-03 R22R R23R
10/16 C10R 5K6-03
13K7-03-1% R24R C11R 10/16
R12R
C131
R252 100R-03
10N-03
1 10N-03 C12C 100N-03 C12S 100N-03 C12Y 2 3 4 5 6 7 8 C106 22/16 9
VCC1 CIN LPF MUTE1 VIN LPF SELECT YIN LPF BIAS GND1 NC
VCC2 34 C 33 6dB GND2 32 CVBS 31 6dB 30 GND2 29 6dB Y 28 27 GND2 26 25 6dB CY 24 GND2 23 6dB Cb 22 21 GND2 20 C13R 100/16 C14R 22/16 75R-03 R25R C13B 100/16 C14B 22/16 75R-03 R25B C13G 100/16 C14G 22/16 75R-03 R25G 13Y 100/16 C14Y 22/16 75R-03 R25Y 100N-03 C13C C13S 100/16 C14S 22/16 75R-03 R25S 75R-03 R25C
10K-03 R29C
FCM2012H-102T04 L203 +3V3 L204 47/16 C224
47/16 C222
+5VD
R11R R11G
10R-03 10R-03
47/16 C223
FCM2012H-102T04
10K-03 R29S
CVBS
Q10R DTC114YKA
36K-03
From Display circuit PC board (to connection PCB)
10K-03
10K-03
R259
CN21 CN-2.0-05P 1 RESET_MAIN 2 FRONT_TXD 3 FRONT_RXD 4 OPTION_NC 5 +5V6S 0R-03 R254
+5V6S R256 47R-03 R257 47R-03
0R-03 R260
R16R
Q13R KTN2907A
Q14R DTC114YKA
10K-03 R29Y
+3V3D
R15G 680(SMD)
R258
R111
4K7-03
13K7-03-1% 13K7-03-1% 10K-03 R23G
10/16 C10G 5K6-03
10 GND1 11 NC 100N-03 C11G 10/16 C12C C12B 1/50 C12R 1/50 12 CY 13 CLP 14 Cb LPF 13.5MHz
10K-03 R29C
+3V3D
R609
3K3-03 PROG_H R613 47R-03 DAC_CSBIWL_OUT DTA114TS Q101 DTC114YS Q102 DAC_SDIDEM_IN/OUT DAC_SCKSD_OUT DAC_LATI3S_OUT +5VD Q10G DTC114YKA
Q11G Q12G KTN2222 KTN2222
R24G
10K-03 R29B
R22G
R12G
5K6-03
R13G
2K2-03
+5V6S
C233 100P-03
36K-03
R14G
CN26 CP-2.0-AN-12P R261 R262 R263 R264 R265 R266 R267 R268 47K-03 47K-03 47K-03 47K-03 47K-03 47K-03 47K-03 47K-03 2R2-1/2W +12V_MOTOR R277 +5VD R269 R270 R271 R272 R273 R274 R275 R276 47R-03 47R-03 47R-03 47R-03 47R-03 47R-03 47R-03 47R-03 1 2 3 4 5 6 7 8 9 10 11 12 ROU-MOROU-MO+ ROU-SEN DISC-SEN CLOSE-SEN OPEN-SEN ID-MOID-MO+ +12V MOTOR M GND +5VD M GND
R17G
LPF 13.5MHz 15 MUTE2 16 Cr
R611 R610 R608
47R-03 47R-03 47R-03
36K-03
5
13K7-03-1%
R15B
13K7-03-1% R607 47R-03
4K7(S) R136
AUDIO_MUTE
10K-03 R22B
R23B
10/16 C10B
Q11B Q12B KTN2222 KTN2222
680(SMD)
R24B
R16G
Q13G KTN2907A
Q14G DTC114YKA
Cr 19 LPF 13.5MHz 6dB 17 GND2 18
10K-03 R29R
10/16 C11B AGND
5K6-03
R12B
5K6-03
36K-03
100N(SMD)
R135 R206 10K-03 47R-03
10N-03
D101
C132
R14B
R16B
+3V3D
36K-03
Q13B KYN2907A
R205
PRO_SCAN_ON_OFF
C229
Q103 KTC3875(S)
GND AGND
www.denom.com
R137
Q14B DTC114YKA
1K(SMD)
2K2-03
Q10B CTC114YKA
R13B
100R-03
1SS355(SMD)
R17B
+9VA
C61R 47/16
R62R 4K7-03
BA4560 IC62-B
D601
C
Y
CY
Cb
Cr
D602
5 ZERO
MODE 16
R63L 3K9-03
Q61L
330/6.3 C614
1N414B
IC51 74HCU04
L501 FCM2012H-102T04
R226
FPC_ST_15P CP23 1: TRIGOUT 1 2 2: TRIGIN 3 4 3: GND(Option) 5 4: TMS 6 7 5: GND 8 6: TCK 9 10 7: GND 11 12 8: TDI 13 9: GND 14 15 10: TDO 11: +5VD 12: TDX(JIG) 13: RXD(JIG) 14: JTAG_RST/ 15: TRST
47K-03
10/50 C603 C604 560P-03
47/16 C601 C602 560P-03
R615
C612 10P-03 C611 10P-03 C610 10P-03
R64L 9K1-03 330P-03 C63L
IC61 WM8728(SSOP) 1 LRCIN
R221
LAT125 20 SCKSD 19 SDIDEM 18 MUTEB 17
47R-03
R614
R66L 100K-03
3 BCKIN 4 MCLK
C609
3
Q601 DTA114YKA
C61L 47/16
R62L 4K7-03
IC62-A BA4560
C67L
C66L
100P-03
2 DIN
47/16
100R-03 R65L 0R-03 R604
AUDIO_R
AUDIO_L
MAIN CIRCUIT PC BOARD
470R-03 R605
A
B
C
D
SCHEMATIC DIAGRAM-2
1
OUTPUT TERMINAL PC BOARD
From Main PCB
2
3
4
RS-232C TERMINAL
5
www.denom.com
DPC-5.3
E F G H
S-VIDEO OUT
VIDEO OUT
RI IN/OUT JACJ PC BOARD
VIDEO COMPONENT OUT
1K
1K NC NC NC
NC
100R
FILTER CIRCUIT
100R
www.denom.com
DPC-5.3
A B C D E F G H
SCHEMATIC DIAGRAM-2
1
OUTPUT TERMINAL PC BOARD
VIDEO OUT S-VIDEO OUT
From Main PCB
RI IN/OUT JACJ PC BOARD
VIDEO COMPONENT OUT
2
1K
1K NC NC NC
NC
3
4
RS-232C TERMINAL
5
www.denom.com
100R
FILTER CIRCUIT
100R
DPC-5.3
E F G H
From Power supply unit
FL Tube FL91
www.denom.com
A
B
C
D
SCHEMATIC DIAGRAM
DISPLAY CIRCUIT PC BOARD
1
2
To OUTPUT TERMINAL PC BOARD
3
STANDBY LED PC BOARD
To Front
To Standby LED
4
5
www.denom.com
DPC-5.3
A B C D E F G H
SCHEMATIC DIAGRAM
DISPLAY CIRCUIT PC BOARD
From Power supply unit
1
2
To OUTPUT TERMINAL PC BOARD
FL Tube FL91
3
STANDBY LED PC BOARD
To Front
To Standby LED
4
5
www.denom.com
DPC-5.3
A B C D E
SCHEMATIC DIAGRAM 5
POWER SUPPLY UNIT 1
R40 2.2 D7 1N5819 C7 10V470 R5 1K
R6 10 SW1 F1 250V2A AC POWER TNR1 10471K R1 1M 1/4W C1 104 C2 104 C23 102 C3 200V100 C22 101 LF1 D1-D4 1N4007 NT1 10D-9 T1 EER2828 R41 3.3 D8 UF4003 C8 50V100 R2 2W47K C4 630V472 R39 20MH 2.2 D9 UF4003 C9 50V100 R8 1K ZD1 3.3V
1 2 3 4 5
GND +FL -27 -FL +5.65 CN1
R7 4.7K
2
D10 SR206 R9 C10 C19 1KV101 R3 330K 1KV102 4.7 C11 L3
4.7uH C12 I
U3 KA7809 R15 18K R10 680 O 1 2 3
D5 UF4007
25V470 25V470
G
C13 50V22
+B GND -12V +12V RST +2.5 GND +2.5
NOTE 1. Resistor values are indicated in ohms unless otherwise specified ( K = 1.000 M = 1.000.000 )
U1 KA1L0365R 1 D6 FB VCC 1N4148 22 R4
D11 SR204
L2 4.7uH
D13 SR1A0
4 5 6 7
C14 10V1000
C16 10V470
2. Capacitor values are indicated in
R13 2.2K
R18 1K
8 9 +5 10 11 +9 GND NC CN2
3
microfarades or picofarades ( :microfarades :pocofarades)
D12 SR204
L1 4.7uH R22 100 PC1/A
12
CAUTION Safety precaution to be followed during servicing 1) Since those parts marked with are critical parts for safety. use only the one described in the parts list. 2) Before returning the set to the customer make apprppriate laekage current or resistance measurements to determine the exposed parts are prpperly insulated from the supply circuit.
C21 152Y1 PC18 817 ZD3 9.1V C5 333 C6 50V22 C17 10V1000 U2 431 R21 1K
R14 1.5KF D14 1N4007
C15 50V1
R16 150 R17 820
C18 10V470
R19 330
R20 330
4
www.denom.com
DPC-5.3
A B C D E
SCHEMATIC DIAGRAM 4
MECHANISM SECTION 1
2
3
4
CAROUSEL MOTOR PC BOARD
www.denom.com
DPC-5.3
PC BOARD CONNECTION DIAGRAM
CN2
CN1
RI IN/OUT JACK PC BOARD
RS-232C TERMINAL
FFC
CN25 CP25 CN01 CP01
OUTPUT TERMINAL PC BOARD
POWER SUPPLY UNIT
MAIN CIRCUIT PC BOARD
CP21 CN27
AC120V 60Hz
FFC
P406
CN21
CP22
CN26
MECHANISM CONTROL PC BOARD
P003
CN3
CP94 B10 CP95 To Roulette motor
P0
Roulette motor PC board
27
TR
STANDBY LED CN96
A
VE
R
SE
M
EC
H
A
.
CN91
DISPLAY CIRCUIT PC BOARD
CN92 CN93
STANDBY LED PC BOARD OPEN/CLOSE SWITCH PC BOARD
CP93
CP96
OPEN/CLOSE
www.denom.com
DPC-5.3
A B C D
PRINTED CIRCUIT BOARD VIEW 1 MAIN CIRCUIT PC BOARD
1
2
3
4
5
Bottom pattern and Bottom component
www.denom.com
DPC-5.3
A B C D
PRINTED CIRCUIT BOARD VIEW 1
MAIN CIRCUIT PC BOARD 1
2
3
4
5
Top pattern and Top component
www.denom.com
A
B
C
D
PRINTED CIRCUIT BOARD FROM SOLDERING SIDE VIEW 2
1
Display circuit PC board
2
PLAY/PAUSE S907 STOP S905
FF S903
FR S901
CN93
S927 DISC5
S924 DISC4
DISC3
DISC2
DISC1
S921
S917
S915
DISC SKIP S911
J902
C
3
4
S907
S905
S915 S927 S924 S921 S917
5
www.denom.com
DPC-5.3
E F G H
C909
J903
+
C907
C906
+
+
J904
RM91
S913
J920
+
C901
Component side
CN92
FL91
IC91
S913
Soldering side
www.denom.com
CN96
CN91
CN96
CN91
J901
CN92
FL91
DPC-5.3
A B C D E F G H
PRINTED CIRCUIT BOARD FROM SOLDERING SIDE VIEW 2
1
Display circuit PC board
C909
J902
J903
+
C907
C906
PLAY/PAUSE S907
STOP S905
+
+
J904
CN93
S927 DISC5
S924 DISC4
DISC3
DISC2
DISC1
S921
S917
S915
DISC SKIP S911
RM91
S913
J920
+
C901
Component side
3
CN92
4
FL91
S907
S905
S915 S927 S924 S921 S917
IC91
S913
Soldering side
5
www.denom.com
CN96
CN91
CN96
CN91
2
FF S903
FR S901
J901
CN92
FL91
DPC-5.3
A B C D E F G H
PRINTED CIRCUIT BOARD FROM SOLDERING SIDE VIEW 3
1
Output terminal PC board
JK83
JK82
JK81
IC85
9
8
7
6
C802
D711
5
4
3
2
1
+
CP01
2
Component side
3
9
8
7
6
5
4
3
2
1
4
Soldering side
5
www.denom.com
CN01
A
B
C
D
PRINTED CIRCUIT BOARD FROM SOLDERING SIDE VIEW 3
1
Output terminal PC board
9
8
7
6
5
4
3
2
1
2
Com
3
9
8
7
6
5
4
3
2
1
4
So
5
www.denom.com
DPC-5.3
E F G H
JK83
JK82
JK81
IC85
C802
D711
+
CP01
Component side
Soldering side
www.denom.com
CN01
A
B
C
D
PRINTED CIRCUIT BOARD VIEW FROM SOLDERING SIDE 4
Roulette motor PC board 1
D-PHOTO RP1574/GP1S58V D-PHOTO GP2S28 WCL 060-05 UL24
P1004
P1003
Component side view
2
Mechanism control PC board
3
JW21 JW6 JW17 JW13 JW3 R001 JW7
4
5
www.denom.com
DPC-5.3
E F G H
Ri IN/OUT Jack PC board
Component side view
C002
JW18 IC001 L001
C003
JW14
JW20
D001
JW10
C001
R003 R004
JW15
C005
R002
D002 IC002 JW8 C004
-
Component side view
Soldering side view
JW22
www.denom.com
DPC-5.3
A B C D E F G H
PRINTED CIRCUIT BOARD VIEW FROM SOLDERING SIDE 4
Roulette motor PC board 1
D-PHOTO RP1574/GP1S58V D-PHOTO GP2S28 WCL 060-05 UL24
P1004
Ri IN/OUT Jack PC board
P1003
Component side view
2
Component side view
Mechanism control PC board
C002 JW18 IC001 C003 L001
3
JW21 JW6 JW17 JW13 JW3 R001 JW7 R002
Component side view
JW14 JW22
JW20
D001
JW10
C001
R003 R004
JW15
C005
D002 IC002 JW8 C004
-
4
5
Soldering side view
www.denom.com
DPC-5.3
A B C D
PRINTED CIRCUIT BOARD FROM SOLDERING SIDE VIEW 5
1
Standby LED PC board Connection PC board
CP94
CP96
S931
D905
2
Component side
CP95
3
Soldering side
Soldering side
Inlet terminal PC board OPEN/CLOSE Switch PC board 4
CP93
OPEN/CLOSE
S930
Soldering side Soldering side
5
www.denom.com
DPC-5.3 FW DOWNLOAD
Confirm the firmware "CD PLAY" button and "DISC 3" button on the front panel should be pressed at the same time. --------- Factory EEPROM reset. Wattching the version of firmware in the FL tube. When the name of the binaly file you wantto downloding is "dvcp5111.bin", you may type "ttcmake dpc5.3fw1" in thr DOS prompt. Adifferent bin file requires a new data. 1. "TTCMAKE.EXE" file is downloaded to its own personal computer. (C-Drive) Fig. 1 2. "dvcp5111.bin" file is downloaded to its own personal computer. TTCMAKE.EXE : application file (The same drive as 1.)
dvcp5111.bin : Binaly file
Space
3. Call the "ttcmake dvcp5111" in the DOS prompt. 4. Call the file name of "dpc5.3" holder, and "ttcmake dvcp5111" . Fig. 2
5. Created the "ENTRISE. TTC" Fig. 3 6. File created by 5. is copied to CD-R. Caution: File format should be "ISO9660"
dps5.3
dps5.3
Fig. 1
C: >cd.. C: cd dpc5.3 C: dpc5.3>ttcmake dvcp5111
cd dpc5.3 dpc5.3
Fig. 2
Fig. 3
www.denom.com
DPC-5.3
DISASSEMBLY PROCEDURE
Replacement of DVD mechanism
The laser diode in the optical pickup block so sensitive to static electricity, surge current and etc.. That the components are liable to be broken down or its reliability remarkable deteriorated. During repair, carefully take the following precautions. Do not touch the optical pickup object lens with the hands. 1. Remove the top cover with six screws. 2. Remove the tray. 3. Remove the roulette assembly. 4. Remove the roulette. (Roulette is removed as written below.) 5. Solder the LD output lands on the DVD optical pickup. Please perform right photo to reference. 6. Replace the pickup mechanism assembly etc. . After unsolder the laser diodes output lands.
Short Land
Remove the roulette
1. Pull out the tray. 2. Stops in the position (cut deeply). 3. Remove in the direction of arrow. 4. Reassembly is performed by 3 to 1.
Roulette
Cut deep
www.denom.com
DPC-5.3 PACKING VIEW
100 150
80
240
RC-503DV
250 220 120
60 110 50 130 210
170 105
205 230
D
-5 PC
.3
side
r Rea
www.denom.com
PRINTED CIRCUIT BOARD PARTS LIST MAIN CIRCUIT PC BOARD CIRCUIT NO. PART NO. C13B 20269020 C13G 20269020 C13R 20269020 C13S 20269020 C13Y 20269020 CC21 55532610 CC25 55238420 CN21 55182960 CN25 55182970 CN26 55123450 CN27 55541130 CP21 55124680 CP22 55125910 CP25 55124620 D602 70436540 FING 55178960 GND1 55135980 IC13 15069010 IC1P 55491690 R277 55232770 VR11 55307870 X501 55128980 J301 10328750 L101 55188040 L102 55188040 L201 10328750 L202 55188040 L203 55126670 L204 55126670 L205 55126670 L210 55126670 L601 55126670 L602 55126670 L603 55188040 Q101 55133190 Q12B 55388740 Q12G 55388740 Q12R 55388740 Q14B 55133180 Q14G 55133180 Q14R 55133180 Q15B 55137830 Q15G 55137830 Q15R 55137830 W003 10328750 W004 10328750 C101 20268940 C103 20268940 C106 20251930 C10B 15002130 C10G 15002130 C10R 15002130 C115 20269020 C117 20269020 C11B 15002130 C11G 15002130 C11R 15002130 C122 20269020 C124 20269020 C12B 20268840 C12R 20268840 C130 20269020 C14B 20251930 C14G 20251930 C14R 20251930 C14S 20251930 C14Y 20251930 C201 20268940 C203 20268620 C210 20268940 C21P 20268940 C222 20267830 C223 20267830 C224 20267830 C311 20268940 C406 20268940 C505 20268620 C601 20267830 C603 20268880 Pkg 30 30 30 30 30 NR NR NR NR NR NR 16 NR 56 NR NR NR NR 91 91 91 91 91 50 50 50 50 50 50 91 92 92 92 92 92 92 92 92 92 92 91 91 30 30 30 30 30 30 30 30 30 30 30 30 30 30 30 30 30 30 30 30 30 30 30 30 30 30 30 30 30 30 30 30 30 Unit PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE DESCRIPTION CE 100U0F +20% 16.0V 85C CE 100U0F +20% 16.0V 85C CE 100U0F +20% 16.0V 85C CE 100U0F +20% 16.0V 85C CE 100U0F +20% 16.0V 85C FFC-JUMPER 19X 1.25MM 220MM FOLD FFC-JUMPER 23X 1.25MM 100MM WIRECONASY UNIQUE 5P 130MM UL1007 PVC DISCRETE 26 1 WIRECONASY UNIQUE 12P 150MM UL1007 PVC DISCRETE 26 1 CONNECTOR 2.0MM 12 MA R NAT LW2003P12 0 0 SOCKET AS DL 2.0MM BLUE 2P 270MM UL1533 SHIELD 26 1 CONNECTOR 1.25MM 19 FE R WH GF120-19S-LS 2794 A6 CONNECTOR 1.0MM 15 FE ST BK 00-6232-015-006-800 0 0 CONNECTOR 1.25MM 23 FE ST WH GF120-23S-TS 2794 A6 D-SLP 1N4148 100.0V 150E-3A SPRING PLATE LUG TERMINAL GND IC-REGSPECKT TL431 IC-REGPOSFXD KIA7805AP NORMAL RMF 2R2 OHM +5% 500MI0W PR 200R0 OHM +30% 100MI0W FILQZ 27M0 HZ +15 PPM 50.0 OHM FUNDAMENTAL 16P5 F RMGCFMIC 0 OHM +0% 62MI5W LF-SMD 2U2H +10% LF-SMD 2U2H +10% RMGCFMIC 0 OHM +0% 62MI5W LF-SMD 2U2H +10% FBEAD SURFACE MT 1000OHM FCM2012H-102T04 FBEAD SURFACE MT 1000OHM FCM2012H-102T04 FBEAD SURFACE MT 1000OHM FCM2012H-102T04 FBEAD SURFACE MT 1000OHM FCM2012H-102T04 FBEAD SURFACE MT 1000OHM FCM2012H-102T04 FBEAD SURFACE MT 1000OHM FCM2012H-102T04 LF-SMD 2U2H +10% TR-SSD DTA114YKA P 10K0 OHM 47K0 OHM TR-SLPSWA KTN2222AS P 40V -600MI0A TR-SLPSWA KTN2222AS P 40V -600MI0A TR-SLPSWA KTN2222AS P 40V -600MI0A TR-SSD DTC114YKA N 10K0 OHM 47K0 OHM TR-SSD DTC114YKA N 10K0 OHM 47K0 OHM TR-SSD DTC114YKA N 10K0 OHM 47K0 OHM TR-SLPSWA KTN2907AS N 50V -600MI0A TR-SLPSWA KTN2907AS N 50V -600MI0A TR-SLPSWA KTN2907AS N 50V -600MI0A RMGCFMIC 0 OHM +0% 62MI5W RMGCFMIC 0 OHM +0% 62MI5W ELECT. CAPCITOR 100U0F +20% 10.0V 85C ELECT. CAPCITOR 100U0F +20% 10.0V 85C ELECT. CAPCITOR 22U0F +20% 16.0V 85C ELECT. CAPCITOR 10U0F +20% 16.0V 85C ELECT. CAPCITOR 10U0F +20% 16.0V 85C ELECT. CAPCITOR 10U0F +20% 16.0V 85C ELECT. CAPCITOR 100U0F +20% 16.0V 85C ELECT. CAPCITOR 100U0F +20% 16.0V 85C ELECT. CAPCITOR 10U0F +20% 16.0V 85C ELECT. CAPCITOR 10U0F +20% 16.0V 85C ELECT. CAPCITOR 10U0F +20% 16.0V 85C ELECT. CAPCITOR 100U0F +20% 16.0V 85C ELECT. CAPCITOR 100U0F +20% 16.0V 85C ELECT. CAPCITOR 1U0F +20% 50.0V 85C ELECT. CAPCITOR 1U0F +20% 50.0V 85C ELECT. CAPCITOR 100U0F +20% 16.0V 85C ELECT. CAPCITOR 22U0F +20% 16.0V 85C ELECT. CAPCITOR 22U0F +20% 16.0V 85C ELECT. CAPCITOR 22U0F +20% 16.0V 85C ELECT. CAPCITOR 22U0F +20% 16.0V 85C ELECT. CAPCITOR 22U0F +20% 16.0V 85C ELECT. CAPCITOR 100U0F +20% 10.0V 85C ELECT. CAPCITOR 470U0F +20% 6.3V 85C ELECT. CAPCITOR 100U0F +20% 10.0V 85C ELECT. CAPCITOR 100U0F +20% 10.0V 85C ELECT. CAPCITOR 47U0F +20% 16.0V 85C ELECT. CAPCITOR 47U0F +20% 16.0V 85C ELECT. CAPCITOR 47U0F +20% 16.0V 85C ELECT. CAPCITOR 100U0F +20% 10.0V 85C ELECT. CAPCITOR 100U0F +20% 10.0V 85C ELECT. CAPCITOR 470U0F +20% 6.3V 85C ELECT. CAPCITOR 47U0F +20% 16.0V 85C ELECT. CAPCITOR 10U0F +20% 50.0V 85C
www.denom.com
C606 C608 C614 C617 C61L C61R C65L C65R C66L C66R D101 D601 IC11 IC12 IC14 IC15 IC21 IC22 IC31 IC41 IC51 IC61 IC62 L301 L501 L604 Q102 Q103 Q10B Q10G Q10R Q11B Q11G Q11R Q13B Q13G Q13R Q201 Q202 Q601 Q602 Q61L Q61R
15002130 20268940 20269110 20268940 20267830 20267830 20267830 20267830 20267830 20267830 20496510 20496510 55388940 55389040 20997870 15178670 55130350 20940740 55156290 55136720 55133310 55291470 55128990 10328750 55126670 55126710 55133180 20970460 55133180 55133180 55133180 55388740 55388740 55388740 55137830 55137830 55137830 20970460 20970460 55133190 55133180 55039430 55039430
30 30 30 30 30 30 30 30 30 30 85 85 MS CP CQ CQ IC 65 MS MS KV IP CQ 91 50 50 92 92 92 92 92 92 92 92 92 92 92 92 92 92 92 91 91
PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE
ELECT. CAPCITOR 10U0F +20% 16.0V 85C ELECT. CAPCITOR 100U0F +20% 10.0V 85C ELECT. CAPCITOR 330U0F +20% 6.3V 85C ELECT. CAPCITOR 100U0F +20% 10.0V 85C ELECT. CAPCITOR 47U0F +20% 16.0V 85C ELECT. CAPCITOR 47U0F +20% 16.0V 85C ELECT. CAPCITOR 47U0F +20% 16.0V 85C ELECT. CAPCITOR 47U0F +20% 16.0V 85C ELECT. CAPCITOR 47U0F +20% 16.0V 85C ELECT. CAPCITOR 47U0F +20% 16.0V 85C D-SLP 1SS355 35.0V 225MI0A D-SLP 1SS355 35.0V 225MI0A IC-VIDEOPROC PM0026A LQFP80 PIONEER VIDEO PROCESSOR IC-VIDEOPROC MM1568AJBE SSOP34A MITSUMI AMPLIFIER&DRIVER IC-SPECFUNC MC74HC74AD DUAL-D FLIP FLOP IC-LOGIC 74HC86 GATE HCMOS IC-VIDEOPROC STI5519 MPEG VIDEO DECODER IC-EEPROM M24C02WMN6 IC-DRAM 100M0 HZ 8N0 64M(1M*16*4) HY57V651620BTC-8 125M IC-MEMFLASH M29W800AT90N1 IC-LOGIC M74HCU04M1R INVERTER HCT IC-CONV WM8728 D/A IC-OPERAMP BA4560F DUAL OP RMGCFMIC 0 OHM +0% 62MI5W FBEAD SURFACE MT 1000OHM FCM2012H-102T04 FBEAD SURFACE MT 120OHM FCM2012C-121T06 TR-SSD DTC114YKA N 10K0 OHM 47K0 OHM TR-SLPSWA KTC3875Y N 50V 150MI0A TR-SSD DTC114YKA N 10K0 OHM 47K0 OHM TR-SSD DTC114YKA N 10K0 OHM 47K0 OHM TR-SSD DTC114YKA N 10K0 OHM 47K0 OHM TR-SLPSWA KTN2222AS P 40V -600MI0A TR-SLPSWA KTN2222AS P 40V -600MI0A TR-SLPSWA KTN2222AS P 40V -600MI0A TR-SLPSWA KTN2907AS N 50V -600MI0A TR-SLPSWA KTN2907AS N 50V -600MI0A TR-SLPSWA KTN2907AS N 50V -600MI0A TR-SLPSWA KTC3875Y N 50V 150MI0A TR-SLPSWA KTC3875Y N 50V 150MI0A TR-SSD DTA114YKA P 10K0 OHM 47K0 OHM TR-SSD DTC114YKA N 10K0 OHM 47K0 OHM TR-SSD DTC323TK N 2K2 OHM TR-SSD DTC323TK N 2K2 OHM
PRINTED CIRCUIT BOARD PARTS LIST DISPLAY CIRCUIT PC BOARD CIRCUIT NO. PART NO. C901 20342060 C903 20288040 C904 20288040 C905 20288040 C906 20252050 C907 20268620 C908 20288040 C909 20268840 C911 20288040 C917 20288040 CN91 55255440 CN92 55182990 CN93 55199600 CN94 55123320 CN95 55123320 CN96 55199610 D904 70436540 D906 55177870 D917 20496510 FING 55178960 FL91 55390980 IC91 55443360 IC92 55191090 L901 14039360 L902 10328750 L903 20538660 L904 20538660 L905 10328750 L909 55126670 L912 55126670 L913 55126670 L914 55126670 L917 80440510 L918 80440510 Pkg 30 91 91 91 30 41 91 30 91 91 NR NR NR NR 16 88 85 NR MS NR 91 91 91 91 91 50 50 50 50 91 91 Unit PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE DESCRIPTION ELECT. CAPACITOR 47U0F +20% 16.0V 85C CCCFMIC 100N0F +80% -20% 16.0V Y5V CCCFMIC 100N0F +80% -20% 16.0V Y5V CCCFMIC 100N0F +80% -20% 16.0V Y5V ELECT. CAPACITOR 100U0F +20% 6.3V 85C ELECT. CAPACITOR 470U0F +20% 6.3V 85C CCCFMIC 100N0F +80% -20% 16.0V Y5V ELECT. CAPACITOR 1U0F +20% 50.0V 85C CCCFMIC 100N0F +80% -20% 16.0V Y5V CCCFMIC 100N0F +80% -20% 16.0V Y5V SOCKET AS UNIQUE 5P 380MM UL2791 SHIELD 28 SOCKET AS UNIQUE 5P 220MM UL1007 PVC DISCRETE 26 1 SOCKET AS UNIQUE 2P 40MM UL1007 RIBBON 26 1 CONNECTOR 2.0MM 5 MA ST NAT LW2002P05 0 0 CONNECTOR 2.0MM 5 MA ST NAT LW2002P05 0 0 SOCKET AS UNIQUE 4P 70MM UL1007 RIBBON 26 1 D-SLP 1N4148 100.0V 150E-3A D-SR SCHOTTKY RB501V-40 40.0V 100MI0A D-SLP 1SS355 35.0V 225MI0A SPRING PLATE SPRING GND C5212 0.2T AVR520 DISPLAY HNV-12SM24 IC-MICROCONT CXP82532-310Q DV-CP500 IC-REGNEGFXD KIA7045P LOW VOLTAGE DROP LF-SMD 22U0H +10% RMGCFMIC 0 OHM +0% 62MI5W RMGCFMIC 4R7 OHM +5% 62MI5W RMGCFMIC 4R7 OHM +5% 62MI5W RMGCFMIC 0 OHM +0% 62MI5W FBEAD SURFAELECT. CAPACITOR MT 1000OHM FCM2012H-102T04 FBEAD SURFAELECT. CAPACITOR MT 1000OHM FCM2012H-102T04 FBEAD SURFAELECT. CAPACITOR MT 1000OHM FCM2012H-102T04 FBEAD SURFAELECT. CAPACITOR MT 1000OHM FCM2012H-102T04 RMGCFMIN 0 OHM +0% 100MI0W RMGCFMIN 0 OHM +0% 100MI0W
DISP DISP DISP DISP DISP DISP DISP DISP DISP DISP DISP DISP DISP DISP DISP DISP DISP DISP DISP DISP DISP DISP DISP DISP DISP DISP DISP DISP DISP DISP DISP DISP DISP DISP
www.denom.com
DISP DISP DISP DISP DISP DISP DISP DISP DISP DISP DISP DISP DISP
RM91 S901 S903 S905 S907 S911 S913 S915 S917 S921 S924 S927 X901
55156010 55145270 55145270 55145270 55145270 55145270 55145270 55145270 55145270 55145270 55145270 55145270 55126140
NR KX KX KX KX KX KX KX KX KX KX KX NR
PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE
IC-REMOTE NJL63H380A REELECT. CAPACITOR IVER 38KHZ SWITACT VERTICAL TACTILE F/B 50MI0A 12.0V 500MI0OHM 1T 1P SWITACT VERTICAL TACTILE F/B 50MI0A 12.0V 500MI0OHM 1T 1P SWITACT VERTICAL TACTILE F/B 50MI0A 12.0V 500MI0OHM 1T 1P SWITACT VERTICAL TACTILE F/B 50MI0A 12.0V 500MI0OHM 1T 1P SWITACT VERTICAL TACTILE F/B 50MI0A 12.0V 500MI0OHM 1T 1P SWITACT VERTICAL TACTILE F/B 50MI0A 12.0V 500MI0OHM 1T 1P SWITACT VERTICAL TACTILE F/B 50MI0A 12.0V 500MI0OHM 1T 1P SWITACT VERTICAL TACTILE F/B 50MI0A 12.0V 500MI0OHM 1T 1P SWITACT VERTICAL TACTILE F/B 50MI0A 12.0V 500MI0OHM 1T 1P SWITACT VERTICAL TACTILE F/B 50MI0A 12.0V 500MI0OHM 1T 1P SWITACT VERTICAL TACTILE F/B 50MI0A 12.0V 500MI0OHM 1T 1P RESONATOR 10M0 HZ 25.0 OHM 0F
INLT INLT INLT
INLET TERMINAL PC BOARD (INCLUDED DISPLAY PCB) CIRCUIT NO. PART NO. Pkg Unit DESCRIPTION DCN1 55384200 NR PCE SOCKET AS UNIQUE 3P 630MM UL2547 26 MCN1 55548930 NR PCE SOCKET AS DL 3.96MM 2P 500MM UL1617 MCN2 55222010 PCE SOCKET MAINS INLET A/C INLET 7014-NGP
OPEN/CLOSE SWITCH PC BOARD (INCLUDED DISPLAY PCB) CIRCUIT NO. PART NO. Pkg Unit DESCRIPTION OPN/CL CP93 55090070 PCE CONNECTOR 2.0MM 2 MA ST NAT LW2002P0200T 0 0 OPN/CL S930 55145270 KX PCE SWITACT VERTICAL TACTILE F/B 50MI0A 12.0V 500MI0OHM 1T 1P STANDBY SWITCH PC BOARD (INCLUDED DISPLAY PCB) CIRCUIT NO. PART NO. Pkg Unit DESCRIPTION CP96 55123310 PCE CONNECTOR 2.0MM 4 MA ST NAT LW2002P04 0 0 D905 55125510 NR PCE D-LEM LTL-1CHE RD RND 3.0 DIFU 5.6CD Q901 55133180 92 PCE TR-SSD DTC114YKA N 10K0 OHM 47K0 OHM S931 55145270 KX PCE SWITACT VERTICAL TACTILE F/B 50MI0A 12.0V 500MI0OHM 1T 1P PRINTED CIRCUIT BOARD PARTS LIST OUTPUT TERMINAL PC BOARD CIRCUIT NO. PART NO. C701 20268840 C702 20268840 C703 20268840 C705 20252050 C706 20268840 C707 20268840 C802 20267830 CN01 55124620 CN71 67472300 CP01 55090070 D711 70436540 D801 20496510 D802 20496510 FCN1 55171520 FCN2 55177410 GND1 55135980 GND2 55135980 IC71 55197900 IC85 55164740 JK81 55270580 JK82 55266550 JK83 55266570 JK84 55266540 L801 55126710 L802 55126710 L803 55126710 Q801 20970460 Q802 20970480 Q87L 55039430 Q87R 55039430 Pkg 30 30 30 30 30 30 30 NR 16 85 85 NR NR CQ NR Unit PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE DESCRIPTION ELECT. CAPACITOR 1U0F +20% 50.0V 85C ELECT. CAPACITOR 1U0F +20% 50.0V 85C ELECT. CAPACITOR 1U0F +20% 50.0V 85C ELECT. CAPACITOR 100U0F +20% 6.3V 85C ELECT. CAPACITOR 1U0F +20% 50.0V 85C ELECT. CAPACITOR 1U0F +20% 50.0V 85C ELECT. CAPACITOR 47U0F +20% 16.0V 85C CONNECTOR 1.25MM 23 FE ST WH GF120-23S-TS 2794 A6 CONNECTOR -SPE 87204-6063 SUB D FE 2.77MM 9 -- 1630 A1 CONNECTOR 2.0MM 2 MA ST NAT LW2002P0200T 0 0 D-SLP 1N4148 100.0V 150E-3A D-SLP 1SS355 35.0V 225MI0A D-SLP 1SS355 35.0V 225MI0A CONNECTOR 2.0MM 5 MA ST NAT MOLEX 35336-0510 0 0 CONNECTOR 2.0MM 3 MA ST NAT MOLEX 35336-0310 0 0 LUG GND LUG GND IC-SPECFUNC UPD4721 DRIVERS/REELECT D-LEM GP1F32T RD RND CL JACK 1P W/GND RCA-139PJ JACK 2P WR W/GND CAP RCA-235P JACK DIN SCKT MIX SOCKET RCA & S-VIDEO RCA-138JP1S JACK PHONO SCKT RCA 3P RUG W/GND CAP RCA-328P FBEAD SURFAELECT. CAPACITOR MT 120OHM FCM2012C-121T06 FBEAD SURFAELECT. CAPACITOR MT 120OHM FCM2012C-121T06 FBEAD SURFAELECT. CAPACITOR MT 120OHM FCM2012C-121T06 TR-SLPSWA KTC3875Y N 50V 150MI0A TR-SLPSWA KTA1504Y P -50V -150MI0A TR-SSD DTC323TK N 2K2 OHM TR-SSD DTC323TK N 2K2 OHM
STBY STBY STBY STBY
50 50 50 92 92 92 92
PRINTED CIRCUIT BOARD PARTS LIST DIGITAL FILTER CIRCUIT NO. DCP1 DG91 DP91 FCP1 DD01 IC01 IC1L IC1R C04L C04R PC BOARD PART NO. 55090080 55190890 55207930 55206580 20496510 55164460 55164460 55164460 20267830 20267830 Pkg KV 85 CQ CQ CQ 30 30 Unit PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE DESCRIPTION CONNECTOR 2.0MM 3 MA ST NAT LW2002P03 0 0 CON PHONO SCKT REMOTEIH 2 PINS PHOTCOUP PC-17T1 CONNECTOR 2.0MM 5 MA R NAT BD'BD SOCKET MOLEX 35237-0510 0 0 D-SLP 1SS355 35.0V 225MI0A IC-OPERAMP NJM4556AM DUAL OP IC-OPERAMP NJM4556AM DUAL OP IC-OPERAMP NJM4556AM DUAL OP ELECT. CAPACITOR 47U0F +20% 16.0V 85C ELECT. CAPACITOR 47U0F +20% 16.0V 85C
www.denom.com
C05L C05R DC01
20267830 20267830 20267830
30 30 30
PCE PCE PCE
ELECT. CAPACITOR 47U0F +20% 16.0V 85C ELECT. CAPACITOR 47U0F +20% 16.0V 85C ELECT. CAPACITOR 47U0F +20% 16.0V 85C
www.denom.com
NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 36 39 40 41 42 43 44 46 47 48 49 50 51 52 53 54 55 56 58 60 S1 S2 S3 S4 S5 S6
PARTS No 55384980 55382960 55223420 55204210 55186710 55259110 55184600 55204250 55184650 55448310 55244670 55221140 55164930 55382610 55204260 55244680 55145270 55448310 55448310 55178960 55236110 55201610 55174550 55125120 55141370 5518662A 55190770 55405550 55190690 55448320 67472300 55383140 55174610 55371600 55186680 55186600 5518667A 55190680 55516410 55514090 55448290 55190160 55186640 55332110 55202510 55222010 55448310 55222020 55448330 SR-5, T2A 838130068 838130088 238440088 55127120 55127180 838430108
DPC-5.3 EX-VIEW PARTS LIST PARTS NAME PLATE BADGE DVD DOOR TRAY WINDOW DISPLAY LOGO BADGE INTEGRA FACET STANDBY COVER POWER BUTTON SHAFT POWER SWITCH POWER BUTTON STANDBY BUTTON POWER/STANDBY SWITCH PC BOARD ASSY (INCLUDE DISP. BUTTON CD PLAY SHIELD COVER SENSOR HOLDER FL PANEL FRONT BUTTON OPEN/CLOSE DPC5.2 BUTTON 9KEY TACT SWITCH VERTICAL OPEN/CLOSE SWITCH PC BOARD ASSY (INCLUDE DISP. PCB) DISPLAY PC BOARD ASSY SPRING GND C5212 0.2T CABINET CHASSIS FRONT RUBBER SPACER 14.5*14.5*22 SHIELD GASKET 12 X 8 X 20 FOOT FOOT RUBBER CABINET CHASSIS MAIN FELT 38X120X0.3T BK SHIELD COVER SHIELD COVER DOWN LOAD OUTPUT TERMINAL PC BOARD ASSY D SUB CONNECTOR REAR PANEL BRACKET MECHA RIGHT MECHANISM ASSY CDM5G(TVM503R-1) BRACKET FRAME MECHA R COVER TOP BRACKET FRAME MECHA L SHIELD COVER CONNECT BOARD SHIELD PLATE MPEG SHIELD COVER PROTECT MAIN PC BOARD ASSY BRACKET GROUND BRACKET MAIN PCB POWER SUPPLY UNIT SHIELD COVER POWER SUPPLY UNIT INLET TERMINAL INLET TERMINAL PC BOARD BRACKET INLET RI IN/OUT JACK PC BOARD FUSE, 250VCA T 2.0A SCREW 3TTB+6B SCREW 3TTB+8B SCREW 4TTB+8BC(BC) SCREW 3MM 8MM WITH WASHER SCREW 3MM 8MM SCREW 3TTB+8B(BC)
www.denom.com
DPC-5.3 EX-VIEW P
NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 36 39 40 41 42 43 44 46 47 48 49 50 51 52 53 54 55 56 58 PARTS No 55384980 55382960 55223420 55204210 55186710 55259110 55184600 55204250 55184650 55448310 55244670 55221140 55164930 55382610 55204260 55244680 55145270 55448310 55448310 55178960 55236110 55201610 55174550 55125120 55141370 5518662A 55190770 55405550 55190690 55448320 67472300 55383140 55174610 55371600 55186680 55186600 5518667A 55190680 55516410 55514090 55448290 55190160 55186640 55332110 55202510 55222010 55448310 55222020 55448330
www.denom.com
PACKING VIEW PARTS LIST
NO. 50 60 70 100 105 110 120 130 150 170 205 210 220 230 240 250 PART NO. 55383370 55184410 55184420 55176530 55547410 55383400 55231700 55188250 55170650 20194780 29110148 55208740 2010389 5544550A 55445530 3010054 Unit PCE PCE PCE PCE PCE PCE PCE PCE PCE PCE M PCE PCE PCE PCE PCE DESCRIPTION CARTON BOX DPC5.3 INTEGRA ENDCAP CUSHION RIGHT ENDCAP CUSHION LEFT AUDIO CONNECTION CABLE POWER CORD INSTRUCTION MANUAL POLY BAG FOAM SHEET WARRANTY CARD POLY BAG 260MM X 410MM CABLE-TIE THE FITMOS PLASTIC PP TAPE CUSHION -- 80.0MM X 35.0MM 0 0 RI CABLE AC PRI LABEL POS DPC-5.3(B) REMOTE CONTROLLER RC-503DV BATTERY 1.5V AAA 1.15 AH
www.denom.com
Pos 0010 0020 0030 0040 0050 0060 0070
Tocom# 55448270 55448280 55448290 55448310 55448320 55448330 55371600
SName ASSY MECH BOM DPC-5.3 OEM ASSY BOM PKG DPC-5.3 ASSY EMBD IMA MAIN BD DPC-5.3 ASSY EMBD IMA FRONT BD DPC-5.3 ASSY EMBD IMA OUT BD DPC-5.3 ASSY EMBD IMA DIGI/FILTER BD DPC-5.3 ASSY MSA ASY CDM5G(TVM503R-1)
Step ENGPAWW ENGPAWW ENGCAWW ENGCAWW ENGCAWW ENGCAWW ENGPAWW
www.denom.com
DPC-5.3
Integra Division of ONKYO CORPORATION Sales & Product Planning Div. : 2-1, Nisshin-cho, Neyagawa-shi, OSAKA 572-8540, JAPAN Tel: 072-831-8111 Fax: 072-833-5222 http://www.onkyo.co.jp/ Integra Division of ONKYO U.S.A. CORPORATION 18 Park Way, Upper Saddle River, N.J. 07458, U.S.A. Tel: 201-785-2600 Fax: 201-785-2650 E-mail: [email protected] http://www.integrahometheater.com
PN 0Mxxxx D01xx Printed in Japan
www.denom.com