Text preview for : service manual IC F3gt-gs.pdf part of ICOM F3GS GT this is service manual for IC F3GS or F3GT
Back to : service manual IC F3gt-gs | Home
SERVICE MANUAL
VHF FM TRANSCEIVERS
INTRODUCTION
This service manual describes the latest service information for the IC-F3GT and IC-F3GS at the time of publication. To upgrade quality, all electrical or mechanical parts and internal circuits are subject to change without notice or obligation.
DANGER
NEVER connect the transceiver to an AC outlet or to a DC power supply that uses more than 16 V. Such a connection could cause a fire hazard and/or electric shock. DO NOT expose the transceiver to rain, snow or any liquids. DO NOT reverse the polarities of the power supply when connecting the transceiver. DO NOT apply an RF signal of more than 20 dBm (100mW) to the antenna connector. This could damage the transceiver's front end.
ORDERING PARTS
Be sure to include the following four points when ordering replacement parts: 1. 2. 3. 4. 10-digit order numbers Component part number and name Equipment model name and unit name Quantity required
0910051872 PCB B-5386B 8810009510 Screw BT M2 x 6 ZK IC-F3GT IC-F3GS MAIN UNIT 1 pieces Chassis 10 pieces
IC-F3GT
IC-F3GS
Addresses are provided on the inside back cover for your convenience.
REPAIR NOTES
Make sure a problem is internal before disassembling the transceiver. DO NOT open the transceiver until the transceiver is disconnected from its power source. DO NOT force any of the variable components. Turn them slowly and smoothly. DO NOT short any circuits or electronic parts. An insulated turning tool MUST be used for all adjustments. DO NOT keep power ON for a long time when the transceiver is defective. DO NOT transmit power into a signal generator or a sweep generator. ALWAYS connect a 40 dB to 50 dB attenuator between the transceiver and a deviation meter or spectrum analyzer when using such test equipment. 8. READ the instructions of test equipment thoroughly before connecting equipment to the transceiver. 1. 2. 3. 4. 5. 6. 7.
TABLE OF CONTENTS
SECTION SECTION SECTION 1 2 3
3-1 3-2
SPECIFICATIONS INSIDE VIEWS DISASSEMBLY AND OPTION INSTRUCTIONS
DISASSEMBLY INSTRUCTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3 - 1 OPTIONAL UNIT INSTALLATIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3 - 2
SECTION
4
4-1 4-2 4-3 4-4 4-5
CIRCUIT DESCRIPTION
RECEIVER CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4 - 1 TRANSMITTER CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4 - 2 PLL CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4 - 3 POWER SUPPLY CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4 - 3 CPU PORT CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4 - 4
SECTION
5
5-1 5-2 5-3
ADJUSTMENT PROCEDURES
PREPARATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5 - 1 PLL ADJUSTMENT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5 - 4 SOFTWARE ADJUSTMENT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5 - 5
SECTION SECTION SECTION SECTION SECTION SECTION
6 7 8 9
PARTS LIST MECHANICAL PARTS AND DISASSEMBLY SEMI-CONDUCTOR INFORMATION BOARD LAYOUTS
10 BLOCK DIAGRAM 11 VOLTAGE DIAGRAM
SECTION 1
` GENERAL
· Frequency coverage · Type of emission · Number of channels · Power supply requirement · Current drain (approx.)
SPECIFICATIONS
: 136.000150.000 MHz : 16K0F3E (W-type), 8K50F3E (N-type) : 32 ch (16 channels × 2 banks: 2-BANK version), 16 ch (16 channel version) : 7.2 V DC (negative ground; supplied battery pack) : Transmit Receive at High (5.0 W) at Low (1.0 W) rated audio stand-by 1.6 A 700 mA 250 mA 70 mA
· Frequency stability · Usable temperature range · Dimensions (projections not included) · Weight (with ant., BP-209)
: ±0.0005 % : 30°C to +60°C; 22°F to +140°F : 54(W) × 132(H) × 35(D) mm; 2 5/32(W) × 5 3/16(H) × 1 3/8(D) in. : 370 g; 13.1 oz.
` TRANSMITTER
· RF output power (at 7.2 V DC) (with supplied battery pack) · Modulation system · Maximum frequency deviation · Spurious emissions · Adjacent channel power · Transmitter audio distortion · Limitting charact of modulator · Ext. microphone connector : 5 W / 1 W (High / Low) : Variable reactance frequency modulation : ±5.0 kHz (W-type), ±2.5 kHz (N-type) : 73 dBc typical : 60 dB typical : Less than 3% at 1 kHz, 40% deviation : 70100% of max. deviation : 3-conductor 2.5(d) mm (1/10")/2.2 k
` RECEIVER
· Receive system · Intermediate frequencies · Sensitivity · Squelch sensitivity · Adjacent channel selectivity · Spurious response rejection · Intermodulation rejection ratio · Hum and noise · Audio output power (at 7.4 V DC) · Ext. speaker connector : Double conversion superheterodyne system : 1st 2nd 31.05 MHz 450 kHz
: 0.25 µV at 12 dB SINAD (typical) : 0.25 µV at threshold (typical) : 65 dB (typical) : 70 dB (typical) : 70 dB (typical) : 40 dB (typical) : 500 mW typical at 5% distortion with an 8 load : 3-conductor 3.5(d) mm (1/8")/8
Specifications are measured in accordance with EIA/TIA-603.
All stated specifications are subject to change without notice or obligation.
1-1
SECTION 2
· MAIN UNIT
INSIDE VIEWS
TOP VIEW
Antenna swtching circuit (D1, D2, D8: MA77) Power amplifier (Q1: 2SK2974)
BOTTOM VIEW
Low-pass filter circuit
RF amplifier (Q12: 3SK293) 1st mixer (Q13: 3SK239A)
(
APC IC3A: NJM2902V Q37: DTA144EU
)
FM IF IC (IC2: TA31136FN(D)) IF amplifier (Q14: 2SC4215 O) Mic amplifier circuit PLL IC (IC1: µPD3140GS)
(
Crystal filter FI1: FL-311 [NARROW] FL-312 [WIDE] PLL reference oscillator (X1: CR-664 15.3 MHz) VCO circuit
)
D/A converter (IC10: M62363FP-560C) TX/RX switch (D3, D4: MA77) EEPROM (IC7: HN58X2432TI)
CPU (IC8: HD64738747H)
2-1
SECTION 3
DISASSEMBLY AND OPTION INSTRUCTIONS
3-1 DISASSEMBLY INSTRUCTION
· REMOVING THE CHASSIS PANEL
1 2 3 4 Unscrew 1 nut A, and remove 1 knob B. Unscrew 2 screws C. Take off the chassis in the direction of the arrow. Unplug J6 to separate front panel and chassis.
C (nickel,2mm) x 2 Chassis
B
J6 (Speaker connector)
A
Front panel
· REMOVING THE MAIN UNIT
1 2 3 4 Remove the searing rubber. Unsolder 3 points D, and unscrew 1 nut E. Unscrew 4 screws F and 5 screws G (silver, 2mm) to separate the chassis and the MAIN unit. Take off the MAIN unit in the direction of the arrow.
F (black,2mm) x 2 G (silver,2mm) x 6 Shield cover F D D G
MAIN unit
D
E Sealing rubber Chassis
Guide holes
3-1
3-2 OPTIONAL UNIT INSTALLATIONS
1 2 3 4 Remove the option cover. Remove the bottom protective paper of spoge. Connect one of UT-96, UT-105, UT-109, UT-110, UT-111, and UT-108 optional unit J5. Replace the option cover to the chassis-hole.
Option cover
Option unit
SPONGE Parts name : 1556 sponge Order No. : 8930013545
J5
3-2
SECTION 4
CIRCUIT DESCRIPTION
The signals from the RF circuit are mixed at the 1st mixer (Q13) with a 1st LO signal coming from the VCO circuit to produce a 31.05 MHz 1st IF signal. The 1st IF signal is applied to a pair of crystal filters (FI1) to suppress out-of-band signals. The filtered 1st IF signal is applied to the IF amplifier (Q14), then applied to the 2nd mixer circuit (IC2, pin 16).
4-1 RECEIVER CIRCUITS
4-1-1 ANTENNA SWITCHING CIRCUIT
Received signals are passed through the low-pass filter (L1, L2, C1C5, C8). The filtered signals are applied to the /4 type antenna switching circuit (D2, D8). The antenna switching circuit functions as a low-pass filter while receiving. However, its impedance becomes very high while D2 and D8 are turned ON. Thus transmit signals are blocked from entering the receiver circuits. The antenna switching circuit employs a /4 type diode switching system. The passed signals are then applied to the RF amplifier circuit.
4-1-4 2ND IF AND DEMODULATOR CIRCUITS
The 2nd mixer circuit converts the 1st IF signal into a 2nd IF signal. A double conversion superheterodyne system (which converts receive signals twice) improves the image rejection ratio and obtains stable receiver gain. The 1st IF signal from the IF amplifier is applied to the 2nd mixer section of the FM IF IC (IC2, pin 16), and is mixed with the 2nd LO signal to be converted into a 450 kHz 2nd IF signal. The FM IF IC contains the 2nd mixer, limiter amplifier, quadrature detector and active filter circuits. A 2nd LO signal (30.6 MHz) is produced at the PLL circuit by doubling it's reference frequency. The 2nd IF signal from the 2nd mixer (IC2, pin 3) passes through a ceramic filter (FI2) to remove unwanted heterodyned frequencies. It is then amplified at the limiter amplifier (IC2, pin 5) and applied to the quadrature detector (IC2, pins 10, 11) to demodulate the 2nd IF signal into AF signals.
4-1-2 RF CIRCUIT
The RF circuit amplifies signals within the range of frequency coverage and filters out-of-band signals. The signals from the antenna switching circuit are amplified at the RF amplifier (Q12) after passing through the tunable bandpass filter (L16, L17, D9, D10, C78C80, C86, C93, C277). The amplified signals are applied to the 1st mixer circuit (Q13) after out-of-band signals are suppressed at the tunable bandpass filter (D11, D12, L18, L19, C91, C92, C94, C96C98). Varactor diodes are employed at the bandpass filters that track the filters and are controlled by the CPU (IC8) via the expander IC (IC10) using T1T4 signals. These diodes tune the centre frequency of an RF passband for wide bandwidth receiving and good image response rejection.
4-1-3 1ST MIXER AND 1ST IF CIRCUITS
The 1st mixer circuit converts the received signal into a fixed frequency of the 1st IF signal with a PLL output frequency. By changing the PLL frequency, only the desired frequency will pass through a crystal filter at the next stage of the 1st mixer.
· 2nd IF and demodulator circuits
2nd IF filter 450 kHz C122 R87 R88 8 R86 C121 7 Noise detector Limiter amp. RSSI 5 Noise comp. Mixer X1 15.3 MHz FI2 3 2 17 PLL IC IC1 ×2 16
Active filter "SQLIN" signal from the D/A convertor (IC10, pin 23) FM detector 9 AF signal "DET" R83 C112 C113
IC2 TA31136F
10 C116 11 R82 R5 X3 R84 12 13 16 1st IF from the IF amplifier (Q14) "NOIS" signal to the CPU pin 19 "SD" signal to the CPU pin 98
4-1
4-1-5 AF CIRCUIT
AF signals from the FM IF IC (IC2, pin 9) are applied to the mute switch (IC4, pin 1) via the AF filter circuit (IC3b, pins 6, 7). The output signals from pin 11 are applied to the AF power amplifier (IC5, pin 4) after being passed through the [VOL] control (R143). The applied AF signals are amplified at the AF power amplifier circuit (IC5, pin 4) to obtain the specified audio level. The amplified AF signals, output from pin 10, are applied to the internal speaker (SP1) as the "SP" signal via the [SP] jack when no plug is connected to the jack.
The AF signals from the microphone are applied to the microphone amplifier circuit (IC3c, pin 10). The amplified AF signals are passed through the low-pass filter circuit (IC3d, pins 13, 14) via the mute switch (IC4, pins 4, 3). The filtered AF signals are applied to the modulator circuit after being passed through the mute switch (IC4, pins 9, 8).
4-2-2 MODULATION CIRCUIT
The modulation circuit modulates the VCO oscillating signal (RF signal) using the microphone audio signal. The audio signals change the reactance of a diode (D6) to modulate an oscillated signal at the VCO circuit (Q7, Q8). The oscillated signal is amplified at the buffer-amplifiers (Q4, Q6), then applied to the T/R switching circuit (D3, D4).
4-1-6 SQUELCH CIRCUIT
A squelch circuit cuts out AF signals when no RF signals are received. By detecting noise components in the AF signals, the squelch switches the AF mute switch. A portion of the AF signals from the FM IF IC (IC2, pin 9) are applied to the active filter section (IC2, pin 8) where noise components are amplified and detected with an internal noise detector. The active filter section amplifies noise components. The filtered signals are rectified at the noise detector section and converted into "NOIS" (pulse type) signals at the noise comparator section. The "NOIS" signal is applied to the CPU (IC8, pin 19). The CPU detects the receiving signal strength from the number of the pulses, and outputs an "RMUT" signal from pin 49. This signal controls the mute switch (IC4) to cut the AF signal line.
4-2-3 DRIVE/POWER AMPLIFIER CIRCUITS
The signal from the VCO circuit passes through the T/R switching circuit (D3) and is amplified at the buffer (Q3), drive (Q2) and power amplifier (Q1) to obtain 5 W of RF power (at 7.2 V DC). The amplified signal passes through the antenna switching circuit (D1), and low-pass filter and is then applied to the antenna connector. The bias current of the drive (Q2) and the power amplifier (Q1) is controlled by the APC circuit.
4-2-5 APC CIRCUIT
The APC circuit (IC3a, Q37) protects the drive and the power amplifiers from excessive current drive, and selects HIGH or LOW output power. The signal output from the power detector circuit (D32, D33) is applied to the differential amplifier (IC3a, pin 2), and the "T4" signal from the expander (IC10, pin 11), controlled by the CPU (IC8), is applied to the other input for reference.
4-2 TRANSMITTER CIRCUITS
4-2-1 MICROPHONE AMPLIFIER CIRCUIT
The microphone amplifier circuit amplifies audio signals with +6 dB/octave pre-emphasis characteristics from the microphone to a level needed for the modulation circuit.
· APC circuit
VCC
RF signal from PLL
Q2 Driver amp.
Q1 Power amp.
L4, C278, C287 LPF D33 D32 to antenna
S5 Q37 T4 + APC control circuit IC3a
TXC
Power detector circuit (D32, D33)
4-2
When the driving current is increased, input voltage of the differential amplifier (pin 2) will be increased. In such cases, the differential amplifier output voltage (pin 1) is decreased to reduce the driving current.
4-4 POWER SUPPLY CIRCUITS
VOLTAGE LINE
LINE HV VCC DESCRIPTION The voltage from the attached battery pack. The same voltage as the HV line (battery voltage) which is controlled by the power swtich ([VOL] control). Common 5 V converted from the VCC line by the reference regulator circuit (IC6). The output voltage is applied to the CPU (IC8), the 5 V regulator circuit (Q18, Q19) and reset circuit (IC11). 5 V for transmitter circuits regulated by the T5 regulator circuit (Q22). 5 V for receiver circuits regulated by the R5 regulator circuit (Q21). Common 5 V converted from the VCC line by the S5 regulator circuit (Q18, Q19). The same voltage as the 5V line for the optional HM-46L, EM-71 or HS-51 through a resistor (R132).
4-3 PLL CIRCUIT
A PLL circuit provides stable oscillation of the transmit frequency and receive 1st LO frequency. The PLL output compares the phase of the divided VCO frequency to the reference frequency. The PLL output frequency is controlled by the divided ratio (N-data) of a programmable divider. The PLL circuit contains the VCO circuit (Q7, Q8). The oscillated signal is amplified at the buffer-amplifiers (Q6, Q5) and then applied to the PLL IC (IC1, pin 2). The PLL IC contains a prescaler, programmable counter, programmable divider and phase detector, etc. The entered signal is divided at the prescaler and programmable counter section by the N-data ratio from the CPU. The divided signal is detected on phase at the phase detector using the reference frequency. If the oscillated signal drifts, its phase changes from that of the reference frequency, causing a lock voltage change to compensate for the drift in the oscillated frequency. A portion of the VCO signal is amplified at the buffer-amplifier (Q4) and is then applied to the receive 1st mixer (Q13) or transmit buffer-amplifier circuit (Q3) via the T/R switching diode (D3, D4).
5V
T5 R5 S5
OPT
· PLL circuit
VCO circuit Q7, Q8 Buffer Q6
"DEV" signal from the D/A convertor (IC10, pin 22) when transmitting
Buffer Q4
D3
to transmitter circuit to 1st mixer circuit
D4 Loop filter Buffer Q5
8 30.6 MHz signal to the FM IF IC 17
Phase detector ×2
Programmable counter
Prescaler
2 3 4 5 PLST SCK SO
Programmable divider 16 X1 15.3 MHz
Shift register
4-3
4-5 PORT ALLOCATIONS
4-5-1 CPU (IC8)
Pin number 1 9 11 12 Port name VIN RESET CSIFT SCK Description Input port for battely voltage detection. Input port for RESET signal. Outputs reference oscillator for the CPU control signal. Outputs clock signal to the PLL IC (IC1), EEPROM (IC7), etc. · Outputs strobe signals to the expander IC (IC10, pin 6). · Input port for the initial version signal. Input port for the cloning signal. Outputs the cloning signal. Outputs strobe signals to the PLL IC (IC1, pin 3). Input for for noise signals (pulse type). Outputs BUSY detection. Low: The channel is busy. Input port for the optional unit detection signal from J5. Output ports for key matrix. Low: When the key is pushed. · Outputs RX mute control signal. · Input port for the RX mute signal from optional units. · Output TX mute control signal. · Input port for the TX mute signal from optional units. Outputs low-pass filter cut-off frequency control signal when DTCS is activated. Outputs S5 regulator control signal. Low: While power is ON. Outputs R5 regulator control signal. Low: While receiving. Outputs T5 regulator control signal. Low: While transmitting. Outputs APC circuit control signal. High: While transmitting. Outputs control signal for the regulator circuit of AF power amplifier. High: When squelch is open, etc. Outputs LCD backlight control signal. High: Lights ON. Outputs EEPROM (IC7, pin 6) clock signal. I/O port for data signals from/to EEPROM (IC7, pin 5) 96 97 98 99 100 BDET REM0 SD LVIN TEMP 91 94 95 DTMF CTCIN PTT0 63 UNLK
CPU (IC8)continued
Pin number Port name Description Input port for unlock signal. High: PLL is unlocked. Low: PLL is locked. Output port for: Beep audio while receiving. 2/5-tone signals while transmitting. Outputs DTMF tone signal while transmitting. CTCSS/DTCS signals input port for decording. Input port for the [PTT] switch. High: While [PTT] switch is pushed. Input port for the battery's type detection. Input port for the remote-control signal from external MIC (HM-75). Input port for the RSSI detection. Input port for the PLL lock voltage. Input port for the transceiver's internal temperature detection.
90
MTONE
15
DAST
16 17 18 19 21 3638 4447
CLIN CLOUT PLST NOIS BUSY OPV3 OPV1 KR3 KR0 RMUT
49
4-5-2 OUTPUT EXPANDER IC (IC10)
Pin number 2, 3, 10, 11 6 Port name T1T4 DAST Description Output tunable bandpass filter control signals. Input port for strobe signal from the CPU (IC8, pin 15). Input port for clock signal from the CPU (IC8, pin 12).
50
MMUT
51
DUSE
52 53 54 55
S5C R5C T5C TXC
7
SCK
56
AFON
57 58 59
LIGT ESCK ESDA
4-4
SECTION 5 ADJUSTMENT PROCEDURES
5-1 PREPARATION
When you adjust the contents on page 5-5 or 5-6, SOFTWARE ADJUSTMENT, the optional CS-F3G ADJ ADJUSTMENT SOFTWARE (Rev. 1.0 or later), OPC-478 CLONING CABLE and a JIG CABLE (see illustration at page 5-2) are required.
s REQUIRED TEST EQUIPMENT
EQUIPMENT DC power supply GRADE AND RANGE Output voltage Current capacity Measuring range Frequency range Impedance SWR : 7.2 V DC : 5 A or more : : : : 110 W 120500 MHz 50 Less than 1.2 : 1 EQUIPMENT Audio generator Attenuator Standard signal generator (SSG) DC voltmeter Oscilloscope GRADE AND RANGE Frequency range Output level Power attenuation Capacity Frequency range Output level Input impedance Frequency range Measuring range Measuring range : 3003000 Hz : 1500 mV : 40 or 50 dB : 10 W or more : 120500 MHz : 0.1 µV32 mV (127 to 17 dBm) : 50 k/V DC or better : DC20 MHz : 0.0120 V : 10 mV10 V
RF power meter (terminated type)
Frequency counter
Frequency range : 0.1500 MHz Frequency accuracy : ±1 ppm or better Sensitivity : 100 mV or better Frequency range Measuring range Input impedance : DC500 MHz : 0 to ±5 kHz
FM deviation meter Digital multimeter
: 10 M/V DC or better AC millivoltmeter
s SYSTEM REQUIREMENTS
· IBM PC compatible computer with an RS -232C serial port (38400 bps or faster). · Microsoft Windows 95 or Windows 98 · Intel i486DX processor or faster (Pentium 100 MHz or faster recommended) · At least 16 MB RAM and 10 MB of hard disk space · 640×480 pixel display (800×600 pixel display recommended)
s STARTING SOFTWARE ADJUSTMENT
q Connect IC-F3GT/GS and PC with the optional OPC-478 and the JIG cable. w Boot up Windows, and turn the transceiver power ON. e Click the program group `CS-F3G ADJ' in the `Programs' folder of the [Start] menu, then CS-F3G ADJ's window is appeared. r Click `Connect' on the CS-F3G's window, then appears IC-F3GT/GS's up-to-date condition. t Set or modify adjustment data as desired.
s ADJUSTMENT SOFTWARE INSTALLATION
NOTE: Before using the program, make a backup copy of the original disk. After making a backup copy, keep the original disk in a safe place. q Boot up Windows. - Quit all applications when Windows is running. w Insert the backup disk1 into the appropriate floppy drive. e Select `Run' from the [Start] menu. r Type the setup program name using the full path name, then push the [Enter] key. (A:\ setup) t Follow the prompts. y Program group `CS-F3G ADJ' appears in the `Programs' folder of the [Start] menu. IBM is a registered trademark of International Bussiness Machines Corporation in the U.S.A. and other countries. Microsoft and Windows are registered trademarks of Microsoft Corporation in the U.S.A. and other countries. Screen shots produced with permission from Microsoft Corporation. All other products or brands are registered trademarks or trademarks of their respective holders.
5-1
· ADJUSTMENT SOFTWARE'S SCREEN DISPLAY EXAMPLE
2 CS-F3G ADJ Rev.1.0 File Option COM 1: OPEN 1 [A / D] 3 4 VIN LVIN SD BDET : 189 : BDh : : : 98 : 62h : 0 : 00h : 14 : 0Eh : 7 . 41V 30 . 35'C 1 . 92V 0 . 00V 0 . 27V 5 . 00V TEMPS : 186 : BAh : Connect Reload (F5) [D / A] BPF T1 : BPF T2 : BPF T3 : T4/POW : REF : DTCS BL: Dev : SQL Lev: Disp para TCXO
REMOT :
: 255 : FFh :
114 96 101 99 102 140 103 120
: 72h : 60h : 65h : 63h : 66h : 8Ch : 67h : 78h
: : : : : : : :
2 . 24V 1 . 88V 1 . 98V 1 . 94V 2 . 00V 54 . 90% 2 . 02V 47 . 06%
13
5 6 7 8 9 10
CH No. : Power (Hi) : Power (LO) :
38 150 50
(RX Freq
= 160.500, TX Freq = <
) RF Power :
High
[############] [####]
DTCS BAL : 140 [ # # # # # # # # # # # ] MOD : 117 [ # # # # # # # # # ] SQL : 120 [ # # # # # # # # # ] BPF ALL : [ Enter] to Start BPF BPF BPF BPF T1 : 70 T2 : 104 T3 : 112 T4 : 88 TXF : [#####] [###############] [################] [##########] to Start [ Enter ] [ Enter ] [ Enter ] [ Enter ] to to to to Sweep Sweep Sweep Sweep
11
12 14
[ Enter]
NOTE: The above values for settings are example only.
Each transceiver has its own specific values for each setting.
1 2 3 4 5 6 7
: Transceiver's connection state : Reload adjustment data : Connected DC voltage : PLL lock voltage : Operating channel select : RF output power : DTCS wave form
8 : FM deviation 9 : Squelch level 10 : Receive sensitivity (automatically) 11 : Receive sensitivity (manually) 12 : Reference frequency 13 : Receive sensitivity measurement 14 : Adjustment items
· JIG CABLE
( + SP) ( SPE) ( GND) 3-conductor 3.5(d) mm plug
to IC-F3GT/GS [SP] jack
JIG cable ( + CLONE)
OPC-478
5-2
· CONNECTION Standard signal generator to the antenna connector 0.1 µV to 32 mV (127 dBm to 17 dBm)
to [MIC]
Audio generator
CAUTION:
DO NOT transmit while SSG is connected to the antenna connector.
to an RS-232C port Personal computer
FM deviation meter
Attenuator 40 dB or 50 dB RF power meter 0.110 W/50
OPC-478
DB9 female plug
Frequency counter
(incl. level converter circuit)
Speaker (8 )
to [SP]
SINAD meter
JIG cable
· DC POWER CABLE CONNECTIONS SOFTWARE ADJUSTMENT + DC POWER SUPPLY + DC POWER SUPPLY Soldering DC cable here PLL ADJUSTMENT
Top view
5-3
5-2 PLL ADJUSTMENT
MEASUREMENT ADJUSTMENT PLL LOCK VOLTAGE ADJUSTMENT CONDITIONS UNIT 1 · Operating frequency: 146.000 MHz · Receiving 2 · Transmitting LOCATION 2.0 V 1.52.5 V MAIN Connect a digital multi meter to check point LV. VALUE UNIT ADJUST MAIN L11 Verify ADJUSTMENT
· MAIN unit
RF power meter
L11
PLL lock voltage adjustment
LV
PLL lock voltage check point
Bottom view
5-4
5-3 SOFTWARE ADJUSTMENT
Select an operation using [] / [] keys, then set specified value using [] / [] keys on the connected computer keyboard. ADJUSTMENT REFERENCE FREQUENCY [TXF] ADJUSTMENT CONDITION MEASUREMENT UNIT LOCATION VALUE 146.00000 MHz
1 · Operating frequency: 146.000 MHz Top Loosely couple a frequnecy · High/Low switch : Low panel counter to the antenna connec· Connect the RF power meter or 50 tor. dummy load to the antenna connector. · Transmitting 2 · Transmitting 1 · Operating frequency: 146.000 MHz · High/Low switch : Low · Transmitting 2 · High/Low switch · Transmitting : High Top Connect an RF power meter to panel the antenna connector.
146.00146 MHz 1.0 W
OUTPUT POWER [POWER(LO)] [POWER(HI)] FM DEVIATION [MOD]
5.0 W
1 · Operating frequency: 146.000 MHz Top Connect an FM deviation meter ±4.2 kHz (W-type) · High/Low switch : Low panel to the antenna connector ±2.1 kHz (N-type) · Connect the audio generator to the through the attenuator. [MIC] jack and set as: 1.0 kHz/150 mVrms · Set the FM deviation meter as: HPF : OFF LPF : 20 kHz De-emphasis : OFF Detector : (PP)/2 · Transmitting 1 · Operating frequency: 160.000 MHz · High/Low switch : Low · No audio applied to the [MIC] jack. · DTCS code : 007 · Transmitting Top Connect an FM deviation meter panel with an oscilloscope to the antenna connector through an attenuator.
Set to flat wave form
DTCS WAVE FORM [DTCS BAL]
5-5
SOFTWARE ADJUSTMENT continued
Select an operation using [] / [] keys, then set specified value using [] / [] keys on the connected computer keyboard. ADJUSTMENT RX SENSITIVITY [BPF T1] [BPF T4] ADJUSTMENT CONDITION MEASUREMENT UNIT LOCATION VALUE
1 · Operating frequency: 146.000 MHz Top Connect a SINAD meter with an Minimum distortion · Connect a standard signal generator to panel 8 load to the [SP] jack. level the antenna connector and set as: Frequency : 146.000 MHz Level : 3.2 µV* (97 dBm) Modulation : 1 kHz Deviation : ±3.5 kHz (W-type) ±1.75 kHz (N-type) · Receiving
CONVENIENT: The BPF T1BPF T4 can be adjusted automatically.
q-1: Set the cursol to "BPF ALL" on the adjustment program and then push [ENTER] key. q-2: The connected PC tunes BPF T1BPF T4 to peak levels. or w-1: Set the cursol to one of BPF T1, T2, T3, or T4 as desired. w-2: Push [ENTER] key to start tuning. w-3: Repeat w-1 and w-2 to perform additional BPF tuning. SQUELCH LEVEL [SQL] 1 · Operating frequency: 146.000 MHz Top Connect a SINAD meter with an · Connect a standard signal generator to panel 8 load to the [SP] jack. the antenna connector and set as: Frequency : 146.000 MHz Level : OFF Modulation : 1 kHz Deviation : ±3.5 kHz (W-type) ±1.75 kHz (N-type) · Receiving 2 · Receiving 12 dB SINAD
At the point where the audio signals just appears.
*The output level of the standard signal generator (SSG) is indicated as the SSG's open circuit.
5-6
SECTION 6 PARTS LIST
[MAIN UNIT]
REF NO.
IC1 IC2 IC3 IC4 IC5 IC6 IC7 IC8 IC10 IC11 IC12
[MAIN UNIT]
DESCRIPTION
S.IC S.IC S.IC S.IC S.IC S.IC S.IC S.IC S.IC S.IC S.IC µPD3140GS-E1 (DS8) TA31136FN (D,EL) NJM2902V-TE1 BU4066BCFV-E1 TA7368F (TP1) TK11250BMCL HN58X2432TI HD6473877H (Z-TAT) M62363FP-650C S-80942ANMP-DD6-T2 NJM2904V-TE1
ORDER NO.
1130007610 1110003490 1110003780 1130008090 1110001810 1180001740 1130009680 1140003750 1190000350 1130009110 1110003800
REF NO.
L1 L2 L4 L5 L6 L7 L8 L9 L10 L11 L12 L13 L14 L15 L16 L17 L18 L19 L20 L21 L22 L24 L25 L26 L28 L29 L31 L32 L33 L34
ORDER NO.
6200008580 6200008500 6200008280 6200008510 6200007730 6200009180 6200009180 6200009180 6200009180 6200004850 6200003710 6200001980 6200009150 6200008280 6200007750 6200007750 6200007750 6200007750 6200004770 6200005540 6200009170 6200008280 6200003090 6200001980 6200003590 6200009150 6200009180 6200008490 6200008330 6200001980 6200004920 S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL
DESCRIPTION
0.30-1.4-6TL 32N 0.30-1.3-6TL 28N 0.30-1.7-7TL 50N 0.30-0.9-4TR 10.5N LQN21A 39NJ04 ELJRE R10J-F3 ELJRE R10J-F3 ELJRE R10J-F3 ELJRE R10J-F3 MC152-E558CN-100024 NL 252018T-2R7J NL 252018T-1R0J ELJRE 82NJ-F3 0.30-1.7-7TL 50N LQN21A 56NJ04 LQN21A 56NJ04 LQN21A 56NJ04 LQN21A 56NJ04 ELJNC R56J-F ELJNC R47K-F ELJRE 47NJ-F2 0.30-1.7-7TL 50N NL 322522T-2R7J-3 NL 252018T-1R0J EXCCL3225U1 ELJRE 82NJ-F3 ELJRE R10J-F3 0.30-0.9-3TR 7.5N 0.45-1.4-4TL 15N NL 252018T-1R0J MLF1608A 2R2K-T
Q1 Q2 Q3 Q4 Q5 Q6 Q7 Q8 Q10 Q11 Q12 Q13 Q14 Q15 Q16 Q17 Q18 Q19 Q20 Q21 Q22 Q25 Q31 Q32 Q33 Q34 Q35 Q36 Q37 Q38
1560001050 1560001020 1530003230 1530002600 1530002600 1530002600 1530003230 1530003230 1530002690 1590001190 1580000730 1580000720 1530002600 1520000460 1590001190 1590002530 1520000460 1590001190 1590000720 1510000920 1510000920 1530002690 1590000660 1590000430 1590000430 1560000810 1530002690 1530002690 1590000720 1590000430
S.FET S.FET S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.FET S.FET S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.FET S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR
2SK2974 2SK2973 (MTS101P) 2SC5085-Y (TE85R) 2SC4215-O (TE85R) 2SC4215-O (TE85R) 2SC4215-O (TE85R) 2SC5085-Y (TE85R) 2SC5085-Y (TE85R) 2SC4116-GR (TE85R) XP6501-(TX) .AB 3SK293 (TE85L) 3SK239AXRTL 2SC4215-O (TE85R) 2SB1132 T100 R XP6501-(TX) .AB UN911H (TX) 2SB1132 T100 R XP6501-(TX) .AB DTA144EUA T106 2SA1577 T107 Q 2SA1577 T107 Q 2SC4116-GR (TE85R) DTC144TU T107 DTC144EUA T106 DTC144EUA T106 2SK1069-4-TL 2SC4116-GR (TE85R) 2SC4116-GR (TE85R) DTA144EUA T106 DTC144EUA T106
[Wide] [Narrow]
D1 D2 D3 D4 D5 D6 D7 D8 D9 D10 D11 D12 D13 D14 D26 D27 D28 D29 D32 D33
1790000620 1790000620 1790000620 1790000620 1750000710 1790001260 1720000660 1790000620 1720000370 1720000370 1720000370 1720000370 1750000710 1790000620 1160000070 1790001670 1790000620 1730002260 1790001670 1790001670
S.DIODE S.DIODE S.DIODE S.DIODE S.VARICAP S.DIODE S.VARICAP S.DIODE S.VARICAP S.VARICAP S.VARICAP S.VARICAP S.VARICAP S.DIODE S.DIODE S.DIODE S.DIODE S.ZENER S.DIODE S.DIODE
MA77 (TX) MA77 (TX) MA77 (TX) MA77 (TX) HVC350BTRF MA2S077-(TX) 1SV288 (TPH2) MA77 (TX) HVU350TRF HVU350TRF HVU350TRF HVU350TRF HVC350BTRF MA77 (TX) DAN202K T146 RB706F-40T106 MA77 (TX) MA8030-H (TX) RB706F-40T106 RB706F-40T106
R1 R2 R3 R5 R7 R9 R10 R11 R12 R13 R14 R15 R16 R17 R18 R19 R20 R21 R22 R23 R25 R26 R27 R28 R29 R30 R31 R32 R33 R34 R35 R41 R44 [Narrow] [Wide] [Narrow] [Wide] R45 R48 R49 R50 R51 R52 R53 R54 R57
FI1 FI2
2010002430 2010002440 2020001080 2020001490
S.XTAL S.XTAL S.CERAMIC S.CERAMIC
FL-311 (31.05 MHz) FL-312 (31.05 MHz) SFPC450G-TC01 SFPC450E-TC01
X1 X2 X3
6050010880 S.XTAL CR-664 (15.3 MHz) 6050010870 S.XTAL CR-663 (9.200 MHz) 6070000210 S.DISCRIMINATOR CDBCA450CX24
7030003670 7030003480 7030003480 7030003240 7030003320 7030003560 7030003310 7030003450 7030003500 7030003260 7030003520 7030003320 7030004050 7030003440 7030003630 7030003320 7030003660 7030003320 7030003660 7030003320 7030005040 7030005040 7030003400 7030003320 7030005120 7030003520 7030003440 7030003410 7030003480 7030003200 7030003420 7030003320 7030003560 7030003590 7030003320 7030003560 7030003640 7030003760 7030003680 7030003680 7030003560 7030003710 7030003680
S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR
ERJ3GEYJ 823 V (82 k) ERJ3GEYJ 222 V (2.2 k) ERJ3GEYJ 222 V (2.2 k) ERJ3GEYJ 220 V (22 ) ERJ3GEYJ 101 V (100 ) ERJ3GEYJ 103 V (10 k) ERJ3GEYJ 820 V (82 ) ERJ3GEYJ 122 V (1.2 k) ERJ3GEYJ 332 V (3.3 k) ERJ3GEYJ 330 V (33 ) ERJ3GEYJ 472 V (4.7 k) ERJ3GEYJ 101 V (100 ) ERJ3GEYJ 1R0 V (1 ) ERJ3GEYJ 102 V (1 k) ERJ3GEYJ 393 V (39 k) ERJ3GEYJ 101 V (100 ) ERJ3GEYJ 683 V (68 k) ERJ3GEYJ 101 V (100 ) ERJ3GEYJ 683 V (68 k) ERJ3GEYJ 101 V (100 ) ERJ2GEJ 472 X (4.7 k) ERJ2GEJ 472 X (4.7 k) ERJ3GEYJ 471 V (470 ) ERJ3GEYJ 101 V (100 ) ERJ2GEJ 102 X (1 k) ERJ3GEYJ 472 V (4.7 k) ERJ3GEYJ 102 V (1 k) ERJ3GEYJ 561 V (560 ) ERJ3GEYJ 222 V (2.2 k) ERJ3GEYJ 100 V (10 ) ERJ3GEYJ 681 V (680 ) ERJ3GEYJ 101 V (100 ) ERJ3GEYJ 103 V (10 k) [Narrow] ERJ3GEYJ 183 V (18 k) [Wide] ERJ3GEYJ 101 V (100 ) ERJ3GEYJ 103 V (10 k) ERJ3GEYJ 473 V (47 k) ERJ3GEYJ 474 V (470 k) ERJ3GEYJ 104 V (100 k) ERJ3GEYJ 104 V (100 k) ERJ3GEYJ 103 V (10 k) ERJ3GEYJ 184 V (180 k) ERJ3GEYJ 104 V (100 k)
S.=Surface mount
6-1
[MAIN UNIT]
REF NO.
R58 R59 R61 R62 R63 R64 R65 R66 R67 R68 R69 R70 R72 R75 R77 R79 R80 R81 R82 R83 R84 R85 R86 R87 R88 R89 R90 R93 R94 R95 R96 R97 R98 R99 R100 R101 R102 R103 R104 R105 R107 R108 R109 R112 R113 R114 R115 R116 R117 R120 R121 R122 R123 R125 R126 R127 R128 R130 R131 R132 R134 R135 R136 R137 R139 R140 R141 R142 R143 R144 R145 R146 R147 R148 R150
[MAIN UNIT]
DESCRIPTION
S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR VARIABLE S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR ERJ3GEYJ 104 V (100 k) ERJ3GEYJ 471 V (470 ) ERJ3GEYJ 470 V (47 ) ERJ3GEYJ 104 V (100 k) ERJ3GEYJ 104 V (100 k) ERJ3GEYJ 104 V (100 k) ERJ3GEYJ 104 V (100 k) ERJ3GEYJ 104 V (100 k) ERJ3GEYJ 104 V (100 k) ERJ3GEYJ 472 V (4.7 k) ERJ3GEYJ 101 V (100 ) ERJ3GEYJ 104 V (100 k) ERJ3GEYJ 103 V (10 k) ERJ3GEYJ 121 V (120 ) ERJ3GEYJ 101 V (100 ) ERJ3GEYJ 561 V (560 ) [Narrow] ERJ3GEYJ 122 V (1.2 k) [Wide] ERJ3GEYJ 104 V (100 k) ERJ3GEYJ 152 V (1.5 k) ERJ3GEYJ 222 V (2.2 k) [Wide] ERJ3GEYJ 392 V (3.9 k) [Narrow] ERJ3GEYJ 471 V (470 ) ERJ3GEYJ 391 V (390 ) ERJ3GEYJ 152 V (1.5 k) ERJ3GEYJ 473 V (47 k) [Narrow] ERJ3GEYJ 104 V (100 k) [Wide] ERJ3GEYJ 471 V (470 ) [Wide] ERJ3GEYJ 222 V (2.2 k) [Narrow] ERJ3GEYJ 333 V (33 k) [Narrow] ERJ3GEYJ 393 V (39 k) [Wide] ERJ3GEYJ 122 V (1.2 k) ERJ3GEYJ 684 V (680 k) ERJ3GEYJ 273 V (27 k) ERJ3GEYJ 105 V (1 M) ERJ3GEYJ 105 V (1 M) ERJ3GEYJ 473 V (47 k) ERJ3GEYJ 224 V (220 k) ERJ3GEYJ 184 V (180 k) ERJ3GEYJ 123 V (12 k) ERJ3GEYJ 182 V (1.8 k) ERJ3GEYJ 105 V (1 M) ERJ3GEYJ 100 V (10 ) ERJ3GEYJ 123 V (12 k) ERJ3GEYJ 104 V (100 k) ERJ3GEYJ 391 V (390 ) [Wide] ERJ3GEYJ 471 V (470 ) [Narrow] ERJ3GEYJ 154 V (150 k) ERJ3GEYJ 154 V (150 k) ERJ3GEYJ 103 V (10 k) ERJ3GEYJ 105 V (1 M) ERJ3GEYJ 683 V (68 k) ERJ3GEYJ 223 V (22 k) [Wide] ERJ3GEYJ 333 V (33 k) [Narrow] ERJ3GEYJ 124 V (120 k) ERJ3GEYJ 102 V (1 k) ERJ3GEYJ 152 V (1.5 k) ERJ3GEYJ 683 V (68 k) ERJ3GEYJ 102 V (1 k) ERJ3GEYJ 272 V (2.7 k) ERJ3GEYJ 332 V (3.3 k) ERJ3GEYJ 273 V (27 k) ERJ3GEYJ 103 V (10 k) ERJ3GEYJ 330 V (33 ) ERJ3GEYJ 100 V (10 ) ERJ3GEYJ 104 V (100 k) ERJ3GEYJ 471 V (470 ) ERJ3GEYJ 471 V (470 ) ERJ3GEYJ 222 V (2.2 k) ERJ3GEYJ 103 V (10 k) ERJ3GEYJ 101 V (100 ) ERJ3GEYJ 101 V (100 ) ERJ3GEYJ 472 V (4.7 k) ERJ3GEYJ 104 V (100 k) ERJ3GEYJ 472 V (4.7 k) ERJ3GEYJ 101 V (100 ) TP76N00N-15F-10KA-2251 ERJ3GEYJ 223 V (22 k) ERJ3GEYJ 105 V (1 M) ERJ3GEYJ 123 V (12 k) ERJ3GEYJ 123 V (12 k) ERJ3GEYJ 104 V (100 k) ERJ3GEYJ 471 V (470 )
ORDER NO.
7030003680 7030003400 7030003280 7030003680 7030003680 7030003680 7030003680 7030003680 7030003680 7030003520 7030003320 7030003680 7030003560 7030003330 7030003320 7030003410 7030003450 7030003680 7030003460 7030003480 7030003510 7030003400 7030003390 7030003460 7030003640 7030003680 7030003400 7030003480 7030003620 7030003630 7030003450 7030003780 7030003610 7030003800 7030003800 7030003640 7030003720 7030003710 7030003570 7030003470 7030003800 7030003200 7030003570 7030003680 7030003390 7030003400 7030003700 7030003700 7030003560 7030003800 7030003660 7030003600 7030003620 7030003690 7030003440 7030003460 7030003660 7030003440 7030003490 7030003500 7030003610 7030003560 7030003260 7030003200 7030003680 7030003400 7030003400 7030003480 7030003560 7030003320 7030003320 7030003520 7030003680 7030003520 7030003320 7210003060 7030003600 7030003800 7030003570 7030003570 7030003680 7030003400
REF NO.
R151 R152 R153 R154 R155 R159 R160 R161 R162 R163 R164 R165 R168 R169 R170 R171 R174 R175 R176 R177 R178 R181 R182 R184 R185 R186 R187 R190 R191 R192 R193 R194 R195 R196 R197 R198 R199 R200 R201 R202 R203 R204 R205 R206 R207 R208 R209 R210 R211 R212 R213 R215 R216 R218 R219 R220 R221 R222 R223 R224 R225 R226 R227 R228 R229 R230 R231 R232 R234 R235 R236 R237 R238 R239 R240
ORDER NO.
7030003640 7030003760 7030003760 7030003760 7030003320 7030003680 7030003340 7030003600 7030003600 7030003480 7030003680 S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR
DESCRIPTION
ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ 473 474 474 474 101 104 151 223 223 222 104 V V V V V V V V V V V
(47 k) (470 k) (470 k) (470 k) (100 ) (100 k) (150 ) (22 k) (22 k) (2.2 k) (100 k) [F3GT] only 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 k) [F3GS] only 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 k) 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 k) [Narrow] 7030003570 S.RESISTOR ERJ3GEYJ 123 V (12 k) [Wide] 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 k) 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 k) 7030003580 S.RESISTOR ERJ3GEYJ 153 V (15 k) 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 k) 7030003510 S.RESISTOR ERJ3GEYJ 392 V (3.9 k) 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 k) 7030003510 S.RESISTOR ERJ3GEYJ 392 V (3.9 k) 7030005870 S.RESISTOR RR0816R-104-D (100 k) 7510001280 S.THERMISTOR NTCCM20124AG473J-T 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 k) 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 k) 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 k) 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 k) 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 k) 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 k) 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 k) 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 k) 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 k) 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 k) 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 k) 7030003650 S.RESISTOR ERJ3GEYJ 563 V (56 k) 7030003590 S.RESISTOR ERJ3GEYJ 183 V (18 k) 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 k) [Wide] 7030004050 S.RESISTOR ERJ3GEYJ 1R0 V (1 ) [Narrow] 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 k) [Wide] 7030004050 S.RESISTOR ERJ3GEYJ 1R0 V (1 ) [Narrow] 7030003780 S.RESISTOR ERJ3GEYJ 684 V (680 k) [Narrow] only 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 k) 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 k) 7030003500 S.RESISTOR ERJ3GEYJ 332 V (3.3 k) 7030003460 S.RESISTOR ERJ3GEYJ 152 V (1.5 k) 7030003760 S.RESISTOR ERJ3GEYJ 474 V (470 k) [Wide] only 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 k) 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 k) 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 k) 7030003510 S.RESISTOR ERJ3GEYJ 392 V (3.9 k) 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 k) 7030003660 S.RESISTOR ERJ3GEYJ 683 V (68 k) 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 ) 7030005870 S.RESISTOR RR0816R-104-D (100 k) 7030005870 S.RESISTOR RR0816R-104-D (100 k) 7030003690 S.RESISTOR ERJ3GEYJ 124 V (120 k) 7030003690 S.RESISTOR ERJ3GEYJ 124 V (120 k) 7030003730 S.RESISTOR ERJ3GEYJ 274 V (270 k) 7030003740 S.RESISTOR ERJ3GEYJ 334 V (330 k) 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 k) 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 k) 7030003610 S.RESISTOR ERJ3GEYJ 273 V (27 k) 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 k) 7410000950 S.ARRAY EXB-V8V 102JV 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 k) 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 k) 7030003710 S.RESISTOR ERJ3GEYJ 184 V (180 k) 7030003650 S.RESISTOR ERJ3GEYJ 563 V (56 k) 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 k) 7410000950 S.ARRAY EXB-V8V 102JV 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 k) 7030003780 S.RESISTOR ERJ3GEYJ 684 V (680 k) 7410000950 S.ARRAY EXB-V8V 102JV 7410000950 S.ARRAY EXB-V8V 102JV 7410000950 S.ARRAY EXB-V8V 102JV 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 k) 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 k)
S.=Surface mount
6-2
[MAIN UNIT]
REF NO.
R241 R242 R243 R244 R245 R246 R249 R251 R252 R253 R255 R257 R258 R260 R261 R262 R264 R265 R266 R267
[MAIN UNIT]
DESCRIPTION
S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ 105 V (1 M) 105 V (1 M) 105 V (1 M) 104 V (100 k) 104 V (100 k) 104 V (100 k) 473 V (47 k) 334 V (330 k) 104 V (100 k) 471 V (470 ) 560 V (56 ) 1R0 V (1 ) 333 V (33 k) 103 V (10 k) 103 V (10 k) 182 V (1.8 k) [Narrow] 1R0 V (1 ) [Wide] 683 V (68 k) [Wide] 154 V (150 k) [Narrow] 104 V (100 k) 153 V (15 k) 473 V (47 k) [Narrow] 104 V (100 k) [Wide]
ORDER NO.
7030003800 7030003800 7030003800 7030003680 7030003680 7030003680 7030003640 7030003740 7030003680 7030003400 7030003290 7030004050 7030003620 7030003560 7030003560 7030003470 7030004050 7030003660 7030003700 7030003680 7030003580 7030003640 7030003680
REF NO.
C70 C71 C72 C73 C75 C76 C78 C79 C80 C81 C82 C83 C84 C85 C86 C87 C88 C89 C90 C91 C92 C93 C94 C95 C96 C97 C98 C99 C100 C101 C102 C104 C105 C106 C107 C108 C109 C110 C111 C112 C113 C114 C115 C116 C117 C118 C119 C120 C121 C122 C123 C124 C125 C126 C128 C129 C131 C132 C133 C134 C135 C136 C137 C138 C139 C140 C144 C145 C146 C147 C148 C149 C150 C151 C152 C153 C154 C155
ORDER NO.
4030006900 4030011600 4550006150 4030011600 4030011600 4030006990 4030007010 4030009920 4030009530 4030007130 4030006860 4030009510 4030006860 4030007160 4030009920 4030006900 4030006860 4030006860 4030006860 4030009920 4030007130 4030006860 4030009510 4030006860 4030007160 4030009920 4030009920 4030006860 4030007080 4030007100 4030007030 4030006860 4030006900 4030007090 4030007100 4030006860 4030006900 4030006860 4030007000 4030009350 4030006900 4030006860 4030006860 4030008900 4030006900 4030007120 4030007140 4030006860 4030006900 4030008680 4030011600 4030007170 4030007170 4030006860 4030006900 4030006870 4030008470 4030008680 4550006680 4030006900 4030008770 4030011600 4030007170 4030007160 4030008770 4030008890 4030008900 4030006860 4030011600 4030011600 4030006860 4510004630 4030006860 4030008630 4030006900 4030011600 4550006200 4030007090 4030008920 4510006940 4550006200 4510004630 S.CERAMIC S.CERAMIC S.TANTALUM S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.TANTALUM S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.ELECTROLYTIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.TANTALUM S.CERAMIC S.CERAMIC S.ELECTROLYTIC S.TANTALUM S.ELECTROLYTIC
DESCRIPTION
C1608 JB 1E 103K-T-A C1608 JB 1C 104KT-N ECST1CY105R C1608 JB 1C 104KT-N C1608 JB 1C 104KT-N C1608 CH 1H 080D-T-A C1608 CH 1H 100D-T-A C1608 CH 1H 050B-T-A C1608 CH 1H 030B-T-A C1608 CH 1H 101J-T-A C1608 JB 1H 102K-T-A C1608 CH 1H 010B-T-A C1608 JB 1H 102K-T-A C1608 CH 1H 181J-T-A C1608 CH 1H 050B-T-A C1608 JB 1E 103K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 CH 1H 050B-T-A C1608 CH 1H 101J-T-A C1608 JB 1H 102K-T-A C1608 CH 1H 010B-T-A C1608 JB 1H 102K-T-A C1608 CH 1H 181J-T-A C1608 CH 1H 050B-T-A C1608 CH 1H 050B-T-A C1608 JB 1H 102K-T-A C1608 CH 1H 390J-T-A C1608 CH 1H 560J-T-A C1608 CH 1H 150J-T-A C1608 JB 1H 102K-T-A C1608 JB 1E 103K-T-A C1608 CH 1H 470J-T-A C1608 CH 1H 560J-T-A C1608 JB 1H 102K-T-A C1608 JB 1E 103K-T-A C1608 JB 1H 102K-T-A C1608 CH 1H 090D-T-A C1608 CH 1H 3R5B-T-A C1608 JB 1E 103K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1C 333K-T-A C1608 JB 1E 103K-T-A C1608 CH 1H 820J-T-A C1608 CH 1H 121J-T-A C1608 JB 1H 102K-T-A C1608 JB 1E 103K-T-A C2012 JF 1C 105Z-T-A C1608 JB 1C 104KT-N C1608 CH 1H 221J-T-A C1608 CH 1H 221J-T-A C1608 JB 1H 102K-T-A C1608 JB 1E 103K-T-A C1608 JB 1H 222K-T-A C1608 JB 1H 272K-T-A C2012 JF 1C 105Z-T-A ECST0JY156R C1608 JB 1E 103K-T-A C1608 JB 1H 562K-T-A C1608 JB 1C 104KT-N C1608 CH 1H 221J-T-A C1608 CH 1H 181J-T-A C1608 JB 1H 562K-T-A C1608 JB 1C 273K-T-A C1608 JB 1C 333K-T-A C1608 JB 1H 102K-T-A C1608 JB 1C 104KT-N C1608 JB 1C 104KT-N C1608 JB 1H 102K-T-A ECEV1CA100SR C1608 JB 1H 102K-T-A C1608 JF 1C 104Z-T-A C1608 JB 1E 103K-T-A C1608 JB 1C 104KT-N ECST0JY106R C1608 CH 1H 470J-T-A C1608 JB 1C 473K-T-A EEVFC0J101P ECST0JY106R ECEV1CA100SR
C1 C2 C3 C4 C5 C8 C10 C13 C14 C15 C17 C18 C19 C20 C21 C22 C23 C24 C25 C26 C27 C28 C29 C30 C31 C32 C33 C34 C35 C36 C37 C38 C39 C41 C42 C44 C45 C46 C47 C48 C49 C50 C51 C52 C53 C54 C55 C56 C60 C61 C62 C63 C64 C65 C66 C67 C69
4030007030 4030011770 4030008560 4030007000 4030007040 4030006860 4030006860 4030006860 4030006860 4030007120 4030006860 4030006860 4030006860 4030006860 4550006540 4030007060 4030006860 4030006860 4030011770 4030006860 4030007040 4030007020 4030006860 4030007050 4030009920 4030006860 4030006860 4030009500 4030013850 4030013850 4030014020 4030014030 4030006860 4030016800 4030006860 4030013850 4030014440 4030006860 4030011600 4550006170 4550006590 4550006200 4030007090 4030007050 4030007040 4030006860 4030006900 4030006900 4030006860 4030007020 4030007000 4030007100 4030009910 4030009520 4030007040 4030007010 4030007070
S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.TANTALUM S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.TANTALUM S.TANTALUM S.TANTALUM S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC
C1608 CH 1H 150J-T-A C1608 CH 1H 060B-T-A C1608 CH 1H 300J-T-A C1608 CH 1H 090D-T-A C1608 CH 1H 180J-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 CH 1H 820J-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A ECST1CY475R C1608 CH 1H 270J-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 CH 1H 060B-T-A C1608 JB 1H 102K-T-A C1608 CH 1H 180J-T-A C1608 CH 1H 120J-T-A C1608 JB 1H 102K-T-A C1608 CH 1H 220J-T-A C1608 CH 1H 050B-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 CH 1H 0R5B-T-A ECUE1E102KBQ ECUE1E102KBQ ECUE1H020BCQ ECUE1H2R5BCQ C1608 JB 1H 102K-T-A ECUE1H300JCQ C1608 JB 1H 102K-T-A ECUE1E102KBQ ECUE1H820JCQ C1608 JB 1H 102K-T-A C1608 JB 1C 104KT-N ECST1AY225R ECST1CY684R ECST0JY106R C1608 CH 1H 470J-T-A C1608 CH 1H 220J-T-A C1608 CH 1H 180J-T-A C1608 JB 1H 102K-T-A C1608 JB 1E 103K-T-A C1608 JB 1E 103K-T-A C1608 JB 1H 102K-T-A C1608 CH 1H 120J-T-A C1608 CH 1H 090D-T-A C1608 CH 1H 560J-T-A C1608 CH 1H 040B-T-A C1608 CH 1H 020B-T-A C1608 CH 1H 180J-T-A C1608 CH 1H 100D-T-A C1608 CH 1H 330J-T-A
[Wide] [Narrow]
[Narrow] [Wide]
[Narrow] [Wide]
[F3GS] [F3GT]
S.=Surface mount
6-3
[MAIN UNIT]
REF NO.
C156 C158 C159 C160 C161 C162 C163 C164 C165 C166 C167 C168 C169 C171 C173 C174 C179 C193 C194 C195 C196 C197 C198 C199 C200 C201 C202 C204 C205 C209 C211 C212 C213 C214 C215 C216 C217 C218 C219 C221 C222 C223 C224 C225 C227 C228 C229 C230 C231 C232 C233 C234 C235 C236 C243 C244 C245 C248 C249 C250 C251 C252 C277 C278 C280 C281 C282 C283 C285 C286 C287 C288 C289 C290 C293 C294 C295 C296 C297 C298
[MAIN UNIT]
DESCRIPTION
S.CERAMIC S.TANTALUM S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.ELECTROLYTIC S.ELECTROLYTIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.TANTALUM S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.TANTALUM S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.TANTALUM S.CERAMIC S.CERAMIC S.CERAMIC S.TANTALUM C1608 JB 1C 104KT-N ECST0JY106R C1608 JB 1H 471K-T-A C1608 JB 1E 103K-T-A C1608 JB 1E 103K-T-A C1608 JB 1E 103K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 CH 1H 470J-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1C 104KT-N ECEV1CA470SP ECEV0JA220SR C1608 JB 1E 103K-T-A C1608 CH 1H 080D-T-A C1608 CH 1H 150J-T-A C1608 CH 1H 560J-T-A C1608 JB 1H 471K-T-A C1608 JB 1C 104KT-N ECST1AY225R C1608 JB 1C 104KT-N C1608 JB 1C 333K-T-A C1608 JB 1C 104KT-N C1608 JB 1E 103K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1C 104KT-N C1608 JB 1C 104KT-N C1608 JB 1E 103K-T-A ECST1AY225R C1608 JB 1C 333K-T-A C1608 JB 1C 104KT-N C1608 JB 1C 104KT-N C1608 JB 1C 104KT-N ECUE1E102KBQ C1608 JB 1H 822K-T-A C1608 JB 1C 393K-T-A C1608 JB 1C 104KT-N C1608 JB 1E 103K-T-A C1608 JB 1E 103K-T-A C1608 JB 1H 472K-T-A C1608 JB 1H 682K-T-A C1608 JB 1C 104KT-N C1608 JB 1H 821K-T-A C1608 JB 1H 102K-T-A C1608 JB 1C 223K-T-A C1608 JF 1C 104Z-T-A C1608 JF 1C 104Z-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1C 104KT-N C1608 JB 1E 103K-T-A C1608 JB 1H 102K-T-A C1608 JB 1E 103K-T-A C1608 JB 1E 103K-T-A C1608 JB 1E 103K-T-A C1608 JB 1E 103K-T-A C1608 JB 1E 103K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 CH 1H 020B-T-A C1608 CH 1H 1R5B-T-A C1608 CH 1H 200J-T-A C1608 CH 1H 470J-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 CH 1H 470J-T-A C1608 JB 1H 222K-T-A C1608 CH 1H 200J-T-A C1608 JB 1H 102K-T-A C1608 CH 1H 470J-T-A C1608 CH 1H 150J-T-A C1608 JB 1C 104KT-N TEMSVB2 0J 336M8L C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A ECST1CY475R
ORDER NO.
4030011600 4550006200 4030006850 4030006900 4030006900 4030006900 4030006860 4030006860 4030006860 4030006860 4030007090 4030006860 4030006860 4030011600 4510004640 4510005430 4030006900 4030006990 4030007030 4030007100 4030006850 4030011600 4550006170 4030011600 4030008900 4030011600 4030006900 4030006860 4030006860 4030011600 4030011600 4030006900 4550006170 4030008900 4030011600 4030011600 4030011600 4030013850 4030009630 4030008910 4030011600 4030006900 4030006900 4030006880 4030009880 4030011600 4030009490 4030006860 4030008880 4030008630 4030008630 4030006860 4030006860 4030011600 4030006900 4030006860 4030006900 4030006900 4030006900 4030006900 4030006900 4030006860 4030006860 4030009520 4030009540 4030009990 4030007090 4030006860 4030006860 4030006860 4030007090 4030006870 4030009990 4030006860 4030007090 4030007030 4030011600 4550006110 4030006860 4030006860 4030006860 4550006540
REF NO.
C299 C300 C301 C302 C303 C304
ORDER NO.
4030011340 4030006860 4030006860 4030011600 4030006860 4030008920 S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC
DESCRIPTION
C1608 C1608 C1608 C1608 C1608 C1608 CH 1H 471J-T-A JB 1H 102K-T-A JB 1H 102K-T-A JB 1C 104KT-N JB 1H 102K-T-A JB 1C 473K-T-A
J2 J3 J5 J6
6450001680 6450001690 6510018430 6510021900
CONNECTOR CONNECTOR S.CONNECTOR S.CONNECTOR
HSJ1122-010010 HSJ1456-01-220 AXN330C038P BM02B-ASRS-TF
DS1 DS2 DS3
5030001800 LCD 5010000160 S.LED 5010000160 S.LED
LM-7045B LNJ310M6URA LNJ310M6URA
MC1
7700002160 MICROPHON
KUC3523-040245
S1 S2 S3
2230000900 S.SWITCH 2230000900 S.SWITCH 2230000900 S.SWITCH
JPM1990-2013R JPM1990-2013R JPM1990-2013R
SP1
2510001060 SPEAKER
K036NA500-47
W5 W7 W8
8900009640 CABLE 7030003860 S.JUMPER 7030003860 S.JUMPER
OPC-963 ERJ3GE JPW V ERJ3GE JPW V
EP1 EP2
0910051872 PCB B 5386B 8930051310 LCD CONTACT SRCN-2251-SP-N-W
[Narrow] [Wide]
[Wide] [Narrow]
S.=Surface mount
6-4
SECTION 7
[CHASSIS PARTS]
REF. NO. ODER NO. MP1 MP2 MP3 MP4 MP5 MP7 MP8 MP9 MP10 MP12 MP13 MP14 MP15 MP18 MP20 MP21 MP22 MP23 MP24 MP25 MP26 MP27 MP31 MP32 MP33 MP36 MP37 MP38 MP39 MP40 MP41 8210016750 8210016740 8930050890 8010017990 8210016570 8930050870 8310047580 8930051350 8210016550 8610010780 8930050820 8930050790 8930050590 8930050840 8930050850 8930050880 8930042350 8930051300 8930051290 8830001340 8930050900 8930036751 8950005260 8830001250 8810009510 8810009560 8810000100 8930051330 8930050800 8950005240 8860001210 8930051750 8510012900
MECHANICAL PARTS AND DISASSEMBLY
[MAIN UNIT]
DESCRIPTION QTY. [F3GT] [F3GS] 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 8 7 4 1 1 1 1 1 1 REF. NO. ODER NO. SP1 EP2 MP1 MP2 MP3 MP4 MP5 DESCRIPTION QTY. 1 1 1 1 1 1 1 2510001060 Speaker K036NA500-47 8930051310 LCD contact SRCN-2251-SP-N-W 8510011111 8510011101 8930050810 8210016580 8410002230 1922 VCO case-1 1922 VCO cover-1 2251 LCD holder 2251 reflector 2078 PA heatsink
2251-T front panel 2251-S front panel 2251 terminal holder 2251 chassis 2251 rear panel 2251 release button 2251 window plate 2251 jack rubber 2251 jack panel Knob N-276 2251 main seal 2251 10key 2251 6key 2251 minus terminal 2251 plus terminal 2251 spring holder 1922 mic sheet 2251 mic sponge 2251 opt sheet 1903 hex nut 2251 window sheet Spring Ant connector-102 Ant connector-101 Screw BT M2 x 4 NI-ZU Screw BT M2 x 6 ZK Screw M2 x 4 ZK 2251 contact rubber 2251 jack cap 2251 contact spring 2251 ANT rug Sponge 2251 shield plate
[F3GT] [F3GS]
[ACCESSORIES]
REF. NO. ODER NO. EP1 EP2 MP1 MP2 DESCRIPTION QTY. 1 1 1 1 1 3310002330 Antenna FA-SC25V 3310002320 Antenna FA-SC55V 0800005400 Battery BC-209 8930042040 1922 Belt clip 8930051290 2251 OPT sheet
EP1
Screw abbreviations
A, B0, BT: Self-tapping PH: Pan head FH: Flat head BiH: Bind head SUS: Stainless NI: Nickel ZK: Black
EP2
MP1
MP2
7-1
MP33 (C)
MP39 (C) MP32 (C)
MP26 (C)
MP32 (C) MP23 (C) MP3 (C) MP2 (C) MP5 (C) MP12 (C) MP31 (C) MP14 (C) MP5 (M) MP31 (C) MP15 (C) MP4 (C) MP25 (C)
MP36 (C) MP38 (C) MP8 (C) MP9 (C) MP31 (C) MP41 (C) MP37 (C) MP40 (C)
MP2 (M) MP18 (C) MP32 (C) MP1 (M)
MP22 (C) MP32 (C)
MP33 (C)
MP10 (C) MP27 (C) SP1 (M)
MP31 (C)
IC-F3GS parts
MP31 (C)
MP1 (C)
MP4 (M) EP2 (M) DS1 (M) MP3 (M) MP31 (C) MP21 (C) MP20 (C)
MAIN unit
MP24 (C) MP7 (C) MP13 (C) MP13 (C) MP1 (C)
UNIT abbreviation (C): CHASSIS PARTS, (M): MAIN UNIT
7-2
SECTION 8
· TRANSISTOR AND FET'S
2SA1577 Q (Symbol: HQ)
B C E E
SEMI-CONDUCTOR INFORMATION
2SC4215 O (Symbol: QO)
B C E C E
2SC4116 GR (Symbol: LG)
B
2SC5085 Y (Symbol: MCY)
B C
2SK1069 4 (Symbol: FJ4)
S G D
2SK2973 (Symbol: K1)
G S D S
2SK2974 (Symbol: K2974)
D
3SK239 A (Symbol: XR)
D S G2
3SK293 (Symbol: UF)
D G2
DTA144 EU (Symbol: 16)
B C
G (top view)
S
G1
S
G1
E
DTC144 EU (Symbol: 26)
B C E
DTC144 TU (Symbol: 06)
B C E
UN911 H (Symbol: 6P)
B C E
XP6501 AB (Symbol: 5N)
E1 E2 B2 C1 B1 C2
· DIODES
1SV288 (Symbol: TJ)
pink A1 A C A2 C
DAN202K (Symbol: N)
HVC350B (Symbol: BO)
HVU350 (Symbol: 4)
MA2S077 (Symbol: S)
MA77 (Symbol: 4B)
MA8030 H (Symbol: 3^0)
RB706F-40 (Symbol: 3J)
A
C
8-1
SECTION 9
MAIN UNIT
· TOP VIEW
BOARD LAYOUTS
R134
Q19
C113
C294
R89
C156
Q20
C112
C63
R83
C159
C64 C55 R45
L13
C56 R90
C160
R135 R88 C20 C122
C54
C21
Q10
R244
DS2
C293 R35 C290
R82 C116
C119
C120 R86
IC6
X3
Q18
C51 C303 R253 C300 C111 R81 R80 R79
L26
C121 R87 C118 C19
C282 R142 C14
R34
Q14
R84
C117 C24
L7
C22
C280
R151
R255
Q34
R185 C233 R186 C234
R208
C49
R264 R175 C211 C295 R249
C15
R12
R11
R10
DS1
C46 R257 R31 R30
R14 C286
C25 C124
C23
R15
C26
C50
R169 R125 R44
C243
Q11
C131
C301
R16
C17 R251 C179 C75
C13
R7 R9 C217 R105 C134
R5
D3
Q37
R176
C251 R162 C10 R163 R161 C252
R109
R93
D33
R177 C133
C212
R168
C215
R108
R210
R17 R97
R54
W7
R3
D32
C148 R98
D4
IC4
C128
R112
C136 C137
R114 C135
R107 C214 R113
R116
C213
R115 R117
IC3
R52 C92 R64 C93 R222 R62
C205 C5
R53 C73
D1 L15
C52
R170
D12
D11
C96
R65 C84 R57
D2
C2
C4
Q1 L32
R2
R13
Q3 Q2
L6
L5
L28
C289
C115
R85
IC1
IC2
C283
MC1
R155
DS3 Q25
R67
R66
C90
C95
L22 D8
R1 C78
D27
D10
R205
J6
C85
D9
L18 Q31
R61
C81
R204
R174 C299
9-1
C1
· BOTTOM VIEW
C281
L4 L31 S1
C285
R143
C278
C3
C287
C158
C204 C76 R96 C18 R160 C126 C125 R95
C288
L24
C79 C80 C82 R58 R154
L1 L2
C8
C173
L16
C83
L17 D29
C277 C86 R252 R63
C155
C298
R258 R100 R159
R94 R178 R99
C138
FI2
MP5
C88 R104 C87 C91 R187 R59 R70 R75 C104 C105 C89
Q12
C129
C174
Q13
C110
Q22
C94 C98 C109 R262 C162 C114 R72
R261
Q21
R260 R141
L20
L19
C102 C108 C107 C29 L8 R19 R18 C27 C99 R77 L29
FI1
C106
C97
R139 C161 C67
J2
C101 C165 C168 R132 L21 C100 R68 C166 C167
L25
C66
S3
C65
J3
Q6 Q4
C28 R69 C39
C36
C31 C33 R22 L10 C34 R28 R23 R21 R27 C229
R20
C53
Q5
L9
X1
L34
Q7
C38 C37 D13
C32
C30
R25
C169
C35
R26
C163 R144
R209 C235
D5
C62 L14
Q8
C44 D6 C41
D28 Q32 L11
C45 R29
C153
R128 C164 C152
C70
R49
C42
C48
R184
R41
C61 C60
C69
D7
R48 R51 R50
C72
C71
L12
C218
R33 C47 R32
W8 R150 C244
C123
C219
R227
R152
C236
C171 C151 R127
C150
D26
R123
C228 R207 C227
R202 R203
R153
S2
IC5
C149 R126 C146 R148
C140 R224 R121 R122 R145 R120 C139 C250
IC10
Q35
R223 R267 R234
Q15
Q16
C216
R221
C145
Q36
C248
L33
Q38
R231
R230
R229
R225 R228
R190
C221
R191
IC7
R219
R218
IC11
X2
C195 R146
C201
R237
C232 R181 R215 R216 C231 C193 C194 R101 R103 D14 R102 R147
R220
C225 R246 R245
R192
R182
C245 C202
C222
IC12 Q33
C249
IC8
R239
R240 R212
R236 R238
C296 C297 R201 R206 R200 C200 R213 R211 R197
C198
R226 C154
C230 C196 C197 C144 R193 R194 R195 R196 R164 R131 Q17 R130 C147 R266 R165
R199
R198
R232
C199 R241 R242 R235 R140
1
16
R265
C132
R243
C304
C302
9-2
C223
1
C224 R171
R137 C209
J5
J5 to the OPTIONAL unit
30
R136
15
SCK SI SO CIRQ CCS REM AFOUT DISCIN RXMUTE BEEPOUT AFONOP MICMUTE VCC 5V GND
PTTIN PTTOUT MICOUT MICIN AUX BUSY MOWN SIGOUT OPT1 OPT2 OPT3 GND OPV3 OPV2 OPV1
SECTION 10
J5 AXN330C038
BlLOCK DIAGRAM
OPTION UNIT
2TONE or 5TONE
REF
IC1: UPD3140GS PLL IC
VCO Q7: 2SC5085 Y Q8: 2SC5085 Y Q6: 2SC4215 O LOOP FIL BUFF
Q4: 2SC4215 O BUFF
D3: MA77 D4: MA77 TX/RX SW
Q3: 2SC5085 Y BUFF
Q2: 2SK2973 PRE DRIVE
Q1: 2SK2974 PWR AMP LPF
D1: MA77 D2: MA77 D8: MA77 ANT SW LPF
ANT
FRQCON
X1: CR-664 (15.3 MHz) Q5: 2SC4215 O BUFF DEV TXC APC PWR DET IC3A: NJM2902V Q37: DTA144EU D32: RB706F-40 D33: RB706F-40
MIC, AF, PTT, MMUT RMUT, AFONOP SIGOUT
PTT CONT Q10: 2SC4116 GR PTT MIC VCC (30.6MHz) IC2: TA31136FN(D) AF REG DET IF DET IC Q17: UN911H BUFF BPF
DBAL
Q34: 2SK1069 4 BUFF
Q14: 2SC4215 O IF AMP
FI1 FL-311: [Narrow] FL-312: [Wide] (31.05MHz) BPF Q13: 3SK239A
D11: HVU350 D12: HVU350 BPF
Q12: 3SK293 RF AMP
D9: HVU350 D10:HVU350 BPF
Q15: 2SB1132 R Q16: XP6501 AB D26: DAN202K
IC5: TA7368F AF AMP SP SQL BPF T3, T4 T1, T2 FI2 SFPC450G: [Narrow] SEPC450E: [Wide] (450kHz) SD NOIS IC10: M62363FP-650C T4 D/A IC10: M62363FP-650C D/A VR OPT EXT.MIC S5 MIC JACK IC3B: NJM2902V AF OUT SP CLONE Q31: DTC144TU D27: RB706F-40 BUFF IC3C: NJM2902V SP JACK PRE ENPHA MIC AMP LPF T5 IC4: BU4066BCFV HPF ANALOG SWR5 IC3D: NJM2902V Q22: 2SA1577 Q REG T5 T5C R5 Q21: 2SA1577 Q REG R5 R5C RESET X2: CR-663 (9.2 MHz) 5V CPU5 Q18: 2SB1132 R Q19: XP6501 AB REG S5 Q20: DTA144EU S5 CONT IC6: TK11250BM +5 CPU S5C
VCC
CPU5 IC11: S-80942ANMP-DD6
IC12: NJM2904V LPF
CPU
IC8: HD64738747H
LCD
Q35: 2SC4116 GR CTCSS DTCS LPF
VCC CTCSS TONE MMUT POWER SW BATT RMUT Q36: 2SC4116 GR DTMF BUFF MTONE
BDET EEPROM GND IC7: HN58X2432TI
KEY MATRIX
COMMON LINE RX LINE TX LINE
10 - 1
SECTION 11
VOLTAGE DIAGRAM
AFOUT DISCIN VCC T5 R5 S5 5V R5 S5 LVIN AFOUT DISCIN VCC T5 R5 S5 5V R5 S5 LVIN
J5 16 15 17 14 18 13 19 12 20 11 21 10 22 9 23 8 24 7 25 6 26 5 27 4 28 3 29 2 30 1 SCK OPV1 SI OPV2 SO OPV3 CIRQ GND CCS OPT3 REM OPT2 AFOUT OPT1 DISCIN SIGOUT RXMUTE MOWN BEEPOUT BUSY AFONOP AUX MICMUTE MICIN VCC MICOUT 5V PTTOUT GND PTTIN
BUSY
R5 S5
R5 S5
VCC
VCC R97 220 k R44 10 k [Narrow] 18 k [Wide] 7 C217 0.1 C124 0.01 C126 0.0027 R94 1M 5 R257 1 1 2 3 4 5 6 7 I/O O/I O/I I/O CONT.B CONT.C VEE VDD CONT.A CONT.D I/O O/I O/I I/O 14 13 12 11 10 9 8 R169 10 k [Narrow] 12 k [Wide] C212 R98 0.01 180 k C213 R107 150 k 2.2 C214 R113 0.033 68 k R168 10 k R170 10 k R159 100 k R114 33 k [Narrow] 22 k [Wide] 13 14 12 R112 1M C128 1 R115 120 k 1.94 V C135 180 P C137 0.033 [Narrow] 0.027 [Wide] R117 1.5 k R99 12 k 1.94 V R120 68 k D26 DAN202K
VCC
to Optional unit
RMUTE
CPU5 R131 470 R266 15 k TX: 3.69 V RX: 5.01 V C304 0.047 C132 0.0056
IC3C NJM2902V
10 8 9 R105 470 [Narrow] 390 [Wide] C134 220 P
R177 1k C125 0.0022 6
R95 1M
Q15 2SB1132 R
TX: 0 V TX: 0 V RX: 4.62 V RX: 3.96 V
VOLMIN 7.23 V
6
5
4
Q16 XP6501
R 2
MMUTE PTT
D
TX: 4.84 V RX: 0 V
Q17 UN911H
C147 C154 R130 0.1 10 100
C209 0.1
C C133 0.1 R137 100 R104 100 k
R176 3.9 k R108 150 k R109 10 k VOLIN VOLOUT AFOUT
R93 27 k
IC3B NJM2902V
R96 47 k C286 0.0022
IC4 BU4066BCFV
C131 0.01
IC3D NJM2902V
R116 1k
R178 3.9 k
1
2
3
C136 0.0056
MICIN
BEEPOUT R171 47 k
AFON
TONE R125 27 k
MMUT R5C
RMUT
CPU5 VCC 5V T5 R5 S5
C148 0.01
C215 0.1
TX: 5.0 V RX: 0.01 V
AFONOP
C223 C224 0.01 0.01
MIC VOLIN VOLOUT AFOUT MICOUT
R100 C129 1.8 k 15 VOLIN VOLOUT AFOUT TONE CTCSS SIGOUT VOLOUT AFOUT
R145 C139 R121 1k 1 M 0.1
C140 0.1 TX: RX:
TX: 0 V RX: 4.99 V
SP1
W5 OPC-963 2 1 SPEAKER
J6 1 2 SP
C164 0.001 BDET 5.06 V CPU5 VCC 5V R5 S5 VOUT GND VIN TX: 4.97 V RX: 0.03 V TX: 0 V RX: 5.01 V 4 5 6 R135 10 k T1 T2 T3 T4 DAST SCK SO
R265 100 k
Q18 2SB1132 R
CPU5 VCC 5V 5.02 V R150 470 1 2 3 4 5 6 7 8 9 10 11 12
5.01 V VCC CPU5
R182 NTCCM20124AG473JCT
C302 0.1
IC10 M62363FP-650C
VIN1 VOUT1 VOUT2 VIN2 VDD LD CLK DI VIN3 VOUT3 VOUT4 VIN4 VIN8 VOUT8 VOUT7 VIN7 GND RESET VDAREF DO VIN6 VOUT6 VOUT5 VIN5 24 23 22 21 20 19 18 17 16 15 14 13
C123 0.001
L33 1.0 µH R103 12 k R146 12 k R147 12 k D14 MA77 C144 0.001 C196 470 P C195 56 P C193 8P R101 1M R102 10 C194 15 P R215 100 k C231 0.1 R181 100 k
CTCIN REMO R148 100 k C197 0.1 C232 0.1 TEMPS LVIN SD REMO BDET PTT CTCIN CPU5 CPU5 DTMF MTONE CPU5 CONT R196 100 k C199 1 KS4 COM4 COM3 COM2 COM1 26 27 28 29 30 31 32 33 34 35 36 37 38 39 P10/TMOW VSS V3 V2 V1 VCC PA3/COM4 PA2/COM3 PA1/COM2 PA0/COM1 P50/WKP0/SEG1 P51/WKP1/SEG2 P52/WKP2/SEG3 P 3/WKP3/SEG4 PB0/AN0 AVSS TEST X2 X1 VSS OSC1 OSC2 RES NMI P20/IRQ4/ADTRG P21/SCK1 P22/SI1 P23/SO1 P24/SCK3 P25/RXD P26/TXD P27/IRQ0 P17/IRQ3/TMIF P16/IRQ2 P15/IRQ1 P14 P13/TMIG P12/TMOFH P11/TMOFL P81/AN1 P82/AN2 P83/AN3 P84/AN4 P85/AN5 P86/AN6 P87/AN7 AVREF VTREF TONED TONEM AVCC PE3/SEG52/CL1 /S G /C 1 2 3 4 5 6 7 XIN 8 XOUT RESET 9 10 CSIFT 11 12 SCK 13 SI 14 SO 15 DAST 16 CLIN CLOUT 17 18 PLST 19 NOIS 20 CIRQ BUSY 21 22 CCS 23 OPT1 24 OPT2 25 OPT3 VIN 100 99 98 97 96 95 94 93 92 91 90 89 88 87
MC1 MIC MIC R144 22 K S3 C163 0.001 VOLIN VOLOUT AFOUT MIC SP
Q22 2SA1577 Q
CPU5 VCC 5V T5 R5 S5
6
5
4
5.01 V
0.12 V
N. BYPASS GND CONT
R260 10 k
Q21 2SA1577 Q
R261 10 k
Q19 XP6501 AB
IC6 TK11250BM
T5
IC11 S-80942ANMP-DD6
1 OUT 2 VDD 3 VSS CD NC 5 4
R216 100 k X2 CR-663
PTT SWITCH
TX: 0.85 V RX: 5.01 V
R141 4.7 k
TX: 5.01 V RX: 0.86 V
R139 4.7 k
1
2
3
Q20 DTA144 EU
4.44 V
3 2 1
BDET
MTONE
VCC C282 0.001 A (VR)