Text preview for : SERVICE MANUAL AVR 1803.pdf part of Denon AVR1803 Service Manual for DENON 1803
Back to : SERVICE MANUAL AVR 1803.p | Home
For U.S.A., Canada, Europe, U.K., Asia, China, Hong Kong, Taiwan R.O.C. & Korea model
Hi-Fi Component
SERVICE MANUAL
MODEL
AVR-1803/883
AV SURROUND RECEIVER
Some illustrations using in this service manual are slightly different from the actual set.
16-11, YUSHIMA 3-CHOME, BUNKYOU-KU, TOKYO 113-0034 JAPAN Telephone: 03 (3837) 5321
X0154 NC 0210
AVR-1803/883
SAFETY PRECAUTIONS
The following check should be performed for the continued protection of the customer and service technician.
LEAKAGE CURRENT CHECK
Before returning the unit to the customer, make sure you make either (1) a leakage current check or (2) a line to chassis resistance check. If the leakage current exceeds 0.5 milliamps, or if the resistance from chassis to either side of the power cord is less than 460 kohms, the unit is defective.
SPECIFICATIONS
Audio section
· Power amplifier
80W+80W (8 ohms, 20Hz~20kHz with 0.08% T.H.D.) 110W+110W (6 ohms, 1kHz with 0.7% T.H.D.) (U.S.A., Canada, Europe, U.K. Models) 130W+130W (6 ohms, EIAJ *) (Asia Model) Center: 80W (8 ohms, 20Hz~20kHz with 0.08% T.H.D.) 110W (6 ohms, 1kHz with 0.7% T.H.D.) (U.S.A., Canada, Europe, U.K. Models) 130W (6 ohms, EIAJ *) (Asia Model) Surround: 80W+80W (8 ohms, 20Hz~20kHz with 0.08% T.H.D.) 110W+110W (6 ohms, 1kHz with 0.7% T.H.D.) (U.S.A., Canada, Europe, U.K. Models) 130W+130W (6 ohms, EIAJ *) (Asia Model) Surround Back: 80 W (8 ohms , 20 Hz ~ 20 kHz with 0.08% T.H.D.) 110 W (6 ohms , 1 kHz with 0.7% T.H.D.) 130W (6 ohms, EIAJ *) (Asia Model) Dynamic power: 100 W x 2 ch (8 ohms) 145 W x 2 ch (4 ohms) 170 W x 2 ch (2 ohms) Output terminals: Front, Center, Surround: 6 ~ 16 ohms Surround Back: A or B 6 ~ 16 ohms A+B 12 ~ 16 ohms Input sensitivity / input impedance: 200 mV / 47 kohms Frequency response: 10 Hz ~ 100 kHz: +1, -3 dB (DIRECT mode) S/N: 100 dB (IHF-A weighted) (DIRECT mode) Rated output: Front:
· Phone equalizer (PHONE input REC OUT)
Input sensitivity: RIAA deviation: Signal to noise ratio: Rated output / Maximum output: Distortion factor: 2.5 mV ±1 dB (20 Hz to 20 kHz) 74 dB (A weighting, with 5 mV input) 150 mV / 7 V 0.03% (1 kHz, 3 V)
Video section
· Standard video jacks
Input / output level and impedance: Frequency response: 1 Vp-p, 75 ohms 5 Hz ~ 10 MHz +1, -3 dB Y (brightness) signal 1 Vp-p, 75 ohms C (color) signal 0.286 Vp-p, 75 ohms 5 Hz ~ 10 MHz +1, -3 dB Y (brightness) signal 1 Vp-p, 75 ohms PB/CB (blue) signal 0.7 Vp-p, 75 ohms PR/CR (red) signal 0.7Vp-p, 75 ohms 5 Hz ~ 27 MHz +1, -3 dB
· S -video jacks
Input / output level and impedance: Frequency response:
· Color component video jacks
Input / output level and impedance:
Frequency response:
* EIAJ: It is the standard which JEITA (Japan Electronics & Information Technology Industries Association) enacted.
2
AVR-1803/883
Tuner section
Receiving Range: U.S.A. & Canada Models: Europe & U.K. Models: Asia Model: Usable Sensitivity: 50 dB Quieting Sensitivity: S/N (IHF-A): Total Harmonic Distortion (at 1 kHz): [FM] (note: µV at 75 ohms, 0 dBf=1 x 10-15 W) 87.50 MHz ~ 107.90 MHz 87.50 MHz ~ 108.00 MHz 87.50 MHz ~ 107.90 MHz (0.2 MHz steps) 87.50 MHz ~ 108.00 MHz (0.05 MHz steps) 1.0 µV (11.2 dBf) MONO 1.6 µV (15.3 dBf) STEREO 23 µV (38.5 dBf) MONO 80 dB (IHF-A weighted) STEREO 75 dB (IHF-A weighted) MONO 0.15% (1kHz) STEREO 0.3% (1kHz) [AM] 520 kHz ~ 1710 kHz 522 kHz ~ 1611 kHz 520 kHz ~ 1710 kHz (10 kHz steps) 522 kHz ~ 1611 kHz (9 kHz steps) 18 µV
General
Power supply: AC 120 V, 60 Hz (U.S.A. & Canada Models) AC 230 V, 50 Hz (Europe & U.K. Models) AC 115/230 V, 50/60 Hz (Asia Model) 4.5 A (U.S.A. & Canada Models) 260 W (Europe, U.K. & Asia Models) 1 W Max. (Standby) 434 (W) x 171 (H) x 417 (D) mm (17-3/32" x 6-47/64" x 16-27/64") 11.7 kg (25 lbs 6 oz)
Power consumption:
Maximum external dimensions: Mass:
Remote control unit
Batteries: External dimensions: Mass:
RC-916 (U.S.A. & Canada Models) RC-917 (Europe, U.K. & Asia Models)
R6P/AA Type (tow batteries) 55 (W) x 225 (H) x 34.5 (D) mm (2-11/64" x 8-55/64" x 1-9/64") 165 g (Approx. 5.8 oz) (including batteries)
* For purposes of improvement, specifications and design are subject to change without notice.
3
AVR-1803/883
DISASSEMBLY
(Follow the procedure below in the reverse order when reassembling) Top Cover
1. Top Cover
Remove 6 screws 1 and 3 screws 2 , then detach the Top Cover to the arrow direction.
1
2
1
2. Front Panel
(1) Remove 4 screws 3 and 3 screws 4 . (2) Disconnect 4 connectors coming from the Front Panel side. (3) Disconnect the connector coming from the Trans., and detach the Front Panel to the arrow direction. Connector
4 4
Front Panel
4
3
Connector
3. Rear Panel
(1) Take off the AC cord 5 . (2) Remove screws 6 . (44 pieces for U.S.A & Canada models) (41 pieces for Europe model) (43 pieces for Asia model) (3) Detach the Rear Panel to the arrow direction.
5
Rear Panel
6
6
6
4
AVR-1803/883
LEVEL DIAGRAMS
1
FRONT/CENTER/SURROUND
2
3
4
5
6
7
8
A
B
C
D
E
5
AVR-1803/883
1
SUB WOOFER
2
3
4
5
6
7
8
A
B
C
D
E
6
AVR-1803/883
BLOCK DIAGRAM
1 2 3 4 5 6 7 8
A
B
C
D
E
7
AVR-1803/883
ADJUSTMENT
Tuner Section
CONNECTION DIAGRAM OF MEASURING INSTRUMENTS FM
T402 T403 R471 IC402 75ohm VR402 Digital Voltmeter TUNER B'D FM SSG STEREO MODULATOR
FM ALIGNMENT
Step Alignment Item Center Adjustment Distortion Tuning Frequency Setting 98.1MHz (98.0MHz) 98.1MHz (98.0MHz) 98.1MHz (98.0MHz) Type Frequency Input Input Level 60dBµ Output Modulation Coupling Type Connect to Adjustment Points T402 T403 Adjust to ± 50mV Minimum Distortion
1 2 3 4
FM SSG 98.1MHz FM SSG 98.1MHz
Signal Level
FM SSG 98.1MHz
Mono Antenna 1kHz 100% Terminal Mono Antenna 60dBµ 1kHz 100% Terminal Repeat Steps 1 and 2 Antenna 20dBµ OFF Terminal
Digital R471 Voltmeter Distortion Output Meter Terminal (L) Light "TUNED" on FL Display
VR402
20 +14 dB -10
AM
T402 T403 R471 IC402
VR401
TUNER B'D
AM ALIGNMENT
Step 1 Alignment Item Signal Level Frequency 999 (1000) kHz Input AM SSG Type Output Connect to Adjustment Adjust to Light "TUNED" on VR401 FL Display Points Remarks SSG OUTPUT 74dBµ (EMF)
8
AVR-1803/883
Audio Section
Idling Current
Required measurement equipment : DC Voltmeter
Preparation
(1) Avoid direct blow from an air conditioner or an electric fan, and adjust the unit at normal room tempereture 15 °C ~ 30 °C (59 °F ~ 86 °F). (2) Presetting POWER (Power sourse switch) SPEAKER (Speaker terminal) OFF No load (Do not connect speaker, dummy resistor, etc.)
Adjustment
(1) Remove top cover and set VR101, VR102, VR103, VR104, VR105 on Amp. Unit, VR106 on SURR.-BACK ch Amp. Unit at full counterclockwise ( ) position.
(2) Connect DC Voltmeter to test points (FRONT-Lch: TP104, FRONT-Rch: TP105, CENTER ch: TP103, SURROUND-Lch: TP101, SURROUND-Rch: TP102, SURROUND-BACK ch: CP106). (3) Connect power cord to AC Line, and turn power switch "ON". (4) Presetting. MASTER VOLUME : "---" counterclockwise ( MODE : 6CH STEREO FUNCTION : CD min.)
(5) Within 2 minutes after the power on, turn VR101 clockwise ( DC.
) to adjust the TEST POINT voltage to 1.5 mV ±0.5 mV
(6) After 10 minutes from the preset above, turn VR101 to set the voltage to 2.5 mV ±0.5 mV DC. (7) Adjust the Variable Resistors of other channels in the same way.
F Lch
VR104 TR104
S Lch S Back ch
VR101,TP101 VR106 CP106
C ch
VR103,TP103
VR102 S Rch TP102 VR105 TP105
DC Voltmeter
F Rch
9
AVR-1803/883
SEMICONDUCTORS
IC's
CXP740096 (IC201)
PC6 PC7 PA0 PA1 PA2 PA3 PA4 PA5 PA6 PA7 NC VDD VSS PK1/TX PK2/TEX PI1/RMC PI2/NMI PI3/TO0/ADJ PI4/INT1/CS1 PI5/SCK1 100 99 98 97 96 95 94 93 92 91 90 89 88 87 86 85 84 83 82 81
PC5 PC4 PC3 PC2 PC1 PC0 PB7/SI2 PB6/SO2 PB5/SCK2 PB4/TO2 PB3 PB2 PB1 PB0 PJ7 PJ6 PJ5 PJ4 PJ3 PJ2 PJ1 PJ0 PD7 PD6 PD5 PD4 PD3 PD2 PD1 PD0
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30
TOP VIEW
80 79 78 77 76 75 74 73 72 71 70 69 68 67 66 65 64 63 62 61 60 59 58 57 56 55 54 53 52 51
PI6/SO1 PI7/SI1 PE0/INT0 PE1/INT2 PE2/PWM0 PE3/PWM1 PE4 PE5 PE6 PE7 PG0/TxD PG1/RxD PG2/EC0 PG3/EC1 PG4/EC2 PG5/INT3 PG6/INT4 PG7/CINT AN0 AN1 AN2 AN3 PF0/AN4 PF1/AN5 PF2/AN6 PF3/AN7 AVDD AVREF AVSS PF4/AN8
CXP740096 Terminal Function
Pin No. Pin Name I/O Function
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23
9274 STB 9274 73 9164 CLK 9274 73 9164 DAT FRONT MUTE 9273 CE ERR MUTE ERR MUTE OFF 89057 AUDIO 89057 EMPHA SW SUM M32 SDIN 89057 SDIN EPROM RESET 89057 RESET M32 CS M32 SDOUT 89057 CE 89057 1837 SDOUT 89057 1837 SCLK 1837 RESET 9164 CE SW MUTE RELAY SPK B
O O O O O O O I I O I I O O O O O O O O O O O
TC9274 CONTROL TC9274/TC9273/TC9164 CONTROL TC9274/TC9273/TC9164 CONTROL FRONT MUTE TC9273 CONTROL ERR MUTE ERR MUTE OFF LC89057 CONTROL LC89057 CONTROL SW SUMMING CONTROL DATA INPUT FROM MELODY32 DATA INPUT FROM LC89057 EPROM RESET LC89057 RESET MELODY32 CS MELODY32 CONTROL DATA LC89057 CE CONTROL DATA CONTROL CLOCK CODEC RESET TC9164 CONTROL SW MUTE SURROUND BACK RELAY
PH7 PH6 PH5 PH4 PH3 PH2 PH1 PH0 PK7/TO1 RST VSS XTAL EXTAL PK6/CS0 PK5/SI0 PK4/SO0 PK3/SCK0 PF7/AN11 PF6/AN10 PF5/AN9
31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50
10
AVR-1803/883
Pin No.
Pin Name
I/O
Function
24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76
RELAY SPK A RELAY SURR RELAY CNT RELAY H/P FUNC UP H/P DETECT FUNC DOWN NC CNT MUTE FRONT MUTE SURR MUTE NC NC NC FL DRV RESET RELAY POWER RESET GND XTAL EXTAL FL DRV CE FL DRV DATA FL DRV/2090 CLK 2090 DATA VOL DOWN VOL UP SEL DOWN SEL UP AVSS VREF AVDD NC GND STEP OPT SET OPT GND KEY IN3 KEY IN2 KEY IN1 9K/10K STEP PROTECT 89057 INT M32 SCLK 1837 CE M32 RESET NC STBY LED NC NC NC NC SURR BACK MUTE KIC9459 CE
O O O O I I I O O O O O I I O O O O I I I I I I I I I I I I O O O O O O
FRONT RELAY SURROUND RELAY CENTER RELAY H/P RELAY ENCODER INPUT(FUNCTION) H/P DETECT ENCODER INPUT(FUNCTION) CENTER MUTE FRONT MUTE SURROUND MUTE
LC75721NE RESET POWER RELAY RESET
LC75721NE CE LC75721NE DATA CONTROL CLOCK BU2090F DATA ENCODER INPUT(VOLUME) ENCODER INPUT(VOLUME) ENCODER INPUT(SELECT) ENCODER INPUT(SELECT)
AREA SELECT MODEL SELECT KEY INPUT KEY INPUT KEY INPUT TUNER STEP SELECT PROTECTION LC89057 INTERUPT MELODY32 CLOCK CODEC CE MELODY32 RESET STANDBY LED
SURROUND BACK MUTE KIC9459 CONTROL
11
AVR-1803/883
Pin No.
Pin Name
I/O
Function
77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100
PWR DOWN RDS CLK RDS DATA NC 9184 CE M32 INTREQ MULTI MUTE MULTI SB RLY REMOCON GND GND VSS VDD NC TC9482 CE PLL DATA PLL CLK PLL DT IN TU MUTE STEREO TUNED PLL CE 2090 CLK VIDEO 2090 DATA VIDEO
I O O O I/O O O I O O O O O I I O O O
POWER DOWN DETECT TDA7330 CONTROL CLOCK TDA7330 CONTROL DATA TC9184 CONTROL MELODY32 CONTROL MULTI MUTE MULTI/SURROUND BACK :SELECTION RELAY REMOTE CONTROL SIGNAL INPUT
VDD BACK UP TC9482 CONTROL PLL CONTROL PLL CONTROL PLL CONTROL TUNER MUTE STEREO DETECT TUNED DETECT PLL CONTROL BU2090 CONTROL(VIDEO) BU2090 CONTROL(VIDEO)
M29W800AT (IC805)
A15 A14 A13 A12 A11 A10 A9 A8 NC NC W RP NC NC RB A18 A17 A7 A6 A5 A4 A3 A2 A1 1 48 A16 BYTE VSS DQ15A-1 DQ7 DQ14 DQ6 DQ13 DQ5 DQ12 DQ4 VCC DQ11 DQ3 DQ10 DQ2 DQ9 DQ1 DQ8 DQ0 G VSS E A0
PIN DESCRIPTION
VCC
Symbol
A0-A18 Address Inputs 15 DQ0-DQ14 DQ0-DQ7 DQ8-DQ14 DQ15A-1 E G W RP RB BYTE VCC VSS NC DU
Pin Name
Data Input/Outputs, Command Inputs Data Input/Outputs Data Input/Output or Address Input Chip Enable Output Enable Write Enable Reset/Block Temporary Unprotect Ready/Busy Output Byte/Word Organization Supply Voltage Ground No Connected Internally Don't Use as Internally Connected
19 A0-A18
W E G RP M29W800AT
DQ15A-1 BYTE RB
12 M29W800T 37 13 M29W800T 36
24
25
Vss
IS61LV6416 (IC806)
A15 A14 A13 A12 A11 CE I/O0 I/O1 I/O2 I/O3 Vcc GND I/O4 I/O5 I/O6 I/O7 WE A10 A9 A8 A7 NC 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 28 27 26 25 24 23 A0 A1 A2 OE UB LB I/O15 I/O14 I/O13 I/O12 GND Vcc I/O11 I/O10 I/O9 I/O8 NC A3 A4 A5 A6 NC
A0-A15
DECODER
64K x 16 MEMORY ARRAY
PIN DESCRIPTION
Symbol
A0-A15 I/O0-I/O15 CE
Pin Name
Address inputs Data Inputs/Outputs Chip Enable Input Output Enable Input Write Enable Input Lower-byte Control (I/O0-I/O7) Upper-byte Control (I/O8-I/O15) No Connection Power Ground
VCC GND I/O0-I/O7 Lower Byte I/O8-I/O15 Upper Byte CE OE WE UB LB I/O DATA CIRCUIT COLUMN I/O
OE WE LB UB NC VCC GND
CONTROL CIRCUIT
12
AVR-1803/883
MELODY32 (IC804)
144 1
109 108
TOP VIEW
36 37 72
73
MELODY32 Terminal Function
Pin No. Pin Name Pin No. Pin Name Pin No. Pin Name Pin No. Pin Name Pin No. Pin Name Pin No. Pin Name
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24
D14 D15 HAD0 HAD1 GND HAD2 HAD3 HAD4 HAD5 HAD6 HAD7 HAD8 VDDEXT HAD9 HAD10 GND HAD11 HAD12 VDDINT HAD13 HAD14 HAD15 HA16 HACK_P
25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48
VDDEXT HACK HCMS HCIOMS GND HALE HRD HWR GND PF0 PF1 PF2 PF3 PF4 PF5 VDDEXT PF6 PF7 TMR0 TMR1 TMR2 DT2 TCLK2 TFS2
49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72
DR2 RCLK2 RFS2 RXD TXD GND GND DT0 TCLK0 VDDINT TF50 DR0 RCLK0 RFS0 VDDEXT DT1 TCLK1 TFS1 DR1 RCLK1 RFS1 BMODE0 BMODE1 BYPASS
73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96
RESET TDO TDI TMS GND TCK TRST GND EMU VDDINT OPMODE A0 A1 A2 A3 A4 A5 VDDEXT A6 A7 A8 GND A9 A10
97 98 99 100 101 102 103 104 105 106 107 108 109 110 111 112 113 114 115 116 117 118 119 120
A11 A12 A13 VDDEXT A14 A15 A16 A17 GND A18 A19 A20 A21 BGH BG BR BMS IOMS MS0 MS1 MS2 VDDEXT MS3 ACK
121 122 123 124 125 126 127 128 129 130 131 132 133 134 135 136 137 138 139 140 141 142 143 144
WR RD D0 D1 D2 D3 VDDINT D4 GND CLKOUT VDDEXT CLKIN XTAL GND D5 D6 D7 D8 D9 D10 D11 D12 VDDEXT D13
13
AVR-1803/883
DSDATA4
DSDATA3
DSDATA2
ASDATA
ALRCLK
ODVDD
ABCLK
DGND
52
51
50
49
48
47
46
45
44
43
42
41
DGND
40 39 DVDD 38 DBCLK 37 DLRCLK 36 M/S 35 AGND 34 OUTR4 33 NC 32 OUTL4 31 NC 30 AGND 29 AVDD 28 OUTR3 27 NC 26
COUT
DVDD 1 CLATCH 2 CIN 3 PD/RST 4 AGND 5 NC 6 OUTL1 7 NC 8 OUTR1 9 AGND 10 AVDD 11 NC 12 OUTL2 13
14 15 16 17 18 19 20 21 22 23 24 25
TOP VIEW
MCLK
CCLK
AD1837 (IC808)
ADCRN
ADCRP
ADCLN
AVDD
NC
ADCLP
AGND
OUTR2
AGND
FILTD
FILTR
NC
DSDATA1
DVDD DVDD ODVDD DLRCLK DBCLK DSDATA1 DSDATA2 DSDATA3 DSDATA4
ALRCLK ABCLK ASDATA CCLK CLATCH CIN COUT
CONTROL PORT SERIAL DATA I/O PORT VOLUME VOLUME VOLUME VOLUME
CLOCK DIGITAL FILTER DIGITAL FILTER DIGITAL FILTER DIGITAL FILTER - DAC - DAC - DAC - DAC VREF OUTL1 OUTR1 OUTL2 OUTR2 OUTL3 OUTR3 OUTL4 OUTR4 FILTD FILTR
ADCLP ADCLN
- ADC
DIGITAL FILTER
VOLUME VOLUME VOLUME
ADCRP ADCRN
- ADC
DIGITAL FILTER
VOLUME
AD1837
AD1837 Terminal Function
Pin No. 1,39 2 33 4 5,10,16,24,30,35 6,12,25,31 7,13,26,32 8,14,27,33 9,15,28,34 11,19,29 17 18 20 21 22 23 36 37 38 40,52 41-44 45 46 47 48 49 50 51 Pin Name DVDD CLATCH CIN PD/RST AGND NC OUTLx NC OUTRx AVDD FILTD FILTR ADCLN ADCLP ADCRN ADCRP M/S DLRCLK DBCLK DGND DSDATAx ABCLK ALRCLK MCLK ADVDD ASDATA COUT CCLK Input/ Output I I I
DGND DGND AGND AGND AGND AGND
O O
I I I I I I/O I/O I I/O I/O I O O I
Digital Power Supply. Connect to digital 5V supply. Latch Input for Control Data Serial Control Input Power-Down/Reset Analog Ground Not connected DACx Left Channel Output Not connected DACx Right Channel Output Analog Power Supply. Connect to analog 5V supply. Filter Capacitor Connection. Recommend 10µF/100nF. Reference Filter Capacitor Connection. Recommended 10µF/100nF. ADC Left Channel Negative Input ADC Left Channel Positive Input ADC Right Channel Negative Input ADC Right Channel Positive Input ADC Master/Slave Select DAC LR Clock DAC Bit Clock Digital Ground DACx Input Data (Left and Right Supply) ADC Bit Clock ADC LR Clock Master Clock Input Digital Output Driver Power Supply ADC Serial Data Output Output for Control Data Control Clock Input for Control Data
OUTL3
MCLK PD/RST M/S AVDD AVDD
Description
14
AVR-1803/883
LC89057W (IC807)
RXOUT 1 RX0 RX1 RX2 RX3 RX4 RX5/VI RX6/UI 2 3 4 5 8 9 10
C bit, U bit
36 RERR Input Selector
DO DI CE CL XMODE DGND DVDD TMCK/PIO0 TBCK/PIO1 TLRCK/PIO2 TDATA/PIO3 TXO/PIOEN 37 38 39 40 41 42 43 44 45 46 47 48 24 23 22 21 20 19 18 17 16 15 14 13 SDIN SLRCK SBCK RDATA RLRCK DVDD DGND RBCK RMCK AGND AVDD LPF
Demodulation & Lock Detect
Data Selector
21 RDATA
24 SDIN PLL Clock Selector Modulation or Parallel Port I/N 16 17 20 22 23 RMCK RBCK RLRCK SBCK SLRCK
LPF 13 TMCK/PIO0 TBCK/PIO1 TLRCK/PIO2 TDATA/PIO3 44 45 46 47
TXO/PIOEN 48 29 XIN 28 XOUT 27 XMCK 34 CKST
LC89057W Terminal Function
Pin No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 Pin Name RXOUT RX0 RX1 RX2 RX3 DGND DVDD RX4 RX5/VI RX6/UI DVDD DGND LPF AVDD AGND RMCK RBCK DGND DVDD RLRCK RDATA SBCK SLRCK SDIN DGND DVDD XMCK I/O O I5 I I5 I5 -- -- I5 I5 I5 -- -- O -- -- O O/I -- -- O/I O O O I5 -- -- O Function Input bi-phase select data output terminal TTL compatible digital data input terminal Coaxial compatible amp built-in digital data input terminal TTL compatible digital data input terminal TTL compatible digital data input terminal Digital GND Digital power TTL compatible digital data input terminal TTL compatible digital data/Validity flag input terminal for modulation TTL compatible digital data/User data input terminal for modulation Digital power for PLL Digital GND for PLL PLL loop filter connecting terminal Analog power for PLL Analog GND for PLL RMCK clock output terminal (256fs, 512fs, XIN, VCO) RBCK clock in/output terminal (64fs) Digital GND Digital power RLRCK clock in/output terminal (fs) Serial audio data output terminal SBCK clock output terminal (32fs, 64fs, 128fs) SLRCK clock output terminal (fs/2, fs, 2fs) Serial audio data input terminal Digital GND Digital power Osc. amp output terminal
RXOUT 1 RX0 2 RX1 3 RX2 4 RX3 5 DGND 6 DVDD 7 RX4 8 RX5/VI 9 RX6/UI 10 DVDD 11 DGND 12
36 35 34 33 32 31 30 29 28 27 26 25
Microcontroller I/F
37 DO
RERR INT CKST AUDIO/VO EMPHA/UO DGND DVDD XIN XOUT XMCK DVDD DGND
EMPHA/UO 32
AUDIO/VO 33
INT CL CE DI 35 40 39 38
XMODE 41
TOP VIEW
15
AVR-1803/883
Pin No. 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48
Pin Name XOUT XIN DVDD DGND EMPHA/UO AUDIO/VO CKST INT RERR DO DI CE CL XMODE DGND DVDD TMCK/PIO0 TBCK/PIO1 TLRCK/PIO2 TDATA/PIO3 TXO/PIOEN
I/O O I -- -- I/O I/O I/O I/O O O I5 I5 I5 I5 -- -- I/O I/O I/O I/O O/I
Function X'tal osc. connecting output terminal X'tal osc. connection, external clock input terminal (24.576MHz or 12.288MHz) Digital power Digital GND Emphasis information/U-data output/Chip address setting terminal Non-PCM detect/V-flag output/ Chip address setting terminal Clock switch transition period output/Demodulation master or slave function switching terminal Interrupt output for µcom (Interrupt factor selectable)/Modulation or general I/O switching terminal PLL lock error, data error flag output µcom I/F, read out data output terminal (3-state) µcom I/F, write data input terminal µcom I/F, chip enable input terminal µcom I/F, clock input terminal System reset input terminal Digital GND Digital power 256fs system clock input for modulation/General I/O in/output terminal 64fs bit clock input for modulation/General I/O in/output terminal fs clock input for modulation/General I/O in/output terminal Serial audio data input for modulation/General I/O in/output terminal Modulation data output/ General I/O enable input terminal
* For latch-up countermeasure, perform each power supply ON/OFF in the same timing.
LC72131 (IC401)
LA1266 (IC402)
AM-IF FM-IF
1 2
FM-IN
3 5 6 7
Vcc
1
XIN 1 20 XOUT
24
20
18
11
13
10
IF BUFFER
IF BUFFER
FM - IF
Q.D.
POST AMP
12
CE 2
19 Vss
9
DI 3
18 AOUT
AM-IN 21
RF
MIX
AM-IF
DET
15
CL 4
17 AIN
REG OSC
OSC BUFFER
NARROW S-METER
AGC
S-METER
LED DRIVER
8
DO 5
16 PD
GND
BO1 6
15 VDD
12
13
22
23
24
4
14
19
17
16
BO2 7
14 FMIN
LA3401 (IC403)
13 AMIN
22
VOL REG
BO3 8
21
20
19
18
17
16
15
14
13
12
BO4 9
12 IO2
OSC
PHASE COMPARATOR VCO STOP
PILOT DET
LAMP DRIVER
IO1 10
11 IFIN
SYMMETRICAL REOCTANCE CIRCUIT
TRIGGER
FF
FF
FF 38kHz
FF 38kHz 90°
FF 19kHz 90°
STEREO SWITCH
DECODER Ro MUTING FM AM CHANGE Rc Rb Rb
MUTING CONTROL FM AM CHANGE OVER
MUTING OUTPUT
Rc
Vcc ON MUTING
1
2
3
4
5
6
7
8
9
10
11
16
AVR-1803/883
LC75721E (IC301)
G7 G8 G9 G10 G11 AA8/G12 AA7/G13 AA6/G14 AA5/G15 AA4/G16 AA3 AA2 AA1 AM35 AM34 AM33
MM74LCX244 (IC809~811) LC75721E Terminal Function
Symbol VDD VSS VFL
AM 17 AM 18 AM 19 AM 20 AM 21 AM 22 AM 23 AM 24 AM 25 AM 26 AM 27 AM 28 AM 29 AM 30 AM 31 AM 32
TOP VIEW
OE I0 O4 I1 O5 I2 O6 I3 O7 1 2 3 4 5 6 7 8 9 10 20 19 18 17 I4 16 15 14 13 12 11 O1 I5 O2 I6 O3 I7 VCC OE2 O0
Function Power terminal +5V Power terminal GND Power terminal FL drive Serial data transfer terminal DI: Data CL: Clock CE: Chip enable External CR connecting terminal System reset terminal Anode output terminal
48
DI CL CE RES VDD OSCI OSCO Vss TEST VFL G1 G2 G3 G4 G5 G6
33 32
49
DI CL CE OSCI OSCO RES AM1~AM35 AA1~AA3 AA4/G16 AA5/G15 AA6/G14 AA7/G13 AA8/G12 G1~G11 TEST
GND
64 1 16
AM 1 AM 2 AM 3 AM 4 AM 5 AM 6 AM 7 AM 8 AM 9 AM 10 AM 11 AM 12 AM 13 AM 14 AM 15 AM 16
17
Anode/Grid output terminal
Grid output terminal LSI test terminal
74LCX74 (IC821)
CD1 1 D1 2 CP1 3 SD1 4 Q1 5 Q1 6 GND 7
D2 CP2 CD2 Q2 SD2 Q2 CP1 D1 SD1 CD1
BU2090F (IC302, 602)
VSS 1 2 3 4 5 6 7 8 9
12-bit SHIFT REGISTER 12-bit STRAGEREGISTER
O TP TB F R(O E D A ) U U U FE P N R IN
14 VCC 13 CD2 12 D2 11 CP2 10 SD2 9 Q2 8 Q2
Pin Descriptions
Pin Names D1, D2 CP1, CP2 CD1, CD2 SD1, SD2 Q1, Q1, Q2, Q2 Description Data Inputs Clock Pulse Inputs Direct Clear Inputs Direct Set Inputs Outputs
CONTROL CIRCUIT
18 VDD 17 OE 16 Q11 15 Q10 14 Q9 13 Q8 12 Q7 11 Q6 10 Q5
DATA CLOCK LCK Q0 Q1 Q2 Q3 Q4
Q1 Q1
TDA7330BD (IC202)
TOP VIEW
MUXIN 1 VREF 2 COMP 3 FILOUT 4 GND 5 T1 6 T3 7 T4
8 20 POR 19 TM 18 FSEL 17 T2 16 VCC 15 ARI 14 QUAL 13 RDDA 12 RDCL 11 T57
MM74LCX02 (IC813)
NJM2068MD BA4510F
A OUTPUT 1 A INPUT 2 A+INPUT 3 V
4 8 V 7 B OUTPUT 6 B INPUT 5 B +INPUT
1Y 1 1A 2 1B 3 2Y 4 2A 5 2B 6 GND 7
14 Vcc 13 4Y 12 4B 11 4A 10 3Y 9 3B 8 3A
OSCOUT 9 OSCIN 10
SN74LV00APW (IC814)
1A 1 1B 2 1Y 3 2A 4 2B 5 2Y 6 GND 7 14 Vcc 13 4B 12 4A 11 4Y 10 3B 9 8 3A 3Y
74HCU04 (IC803)
1A 1Y 2A 2Y 3A 3Y GND 1 2 3 4 5 6 7 14 13 12 11 10 9 8 Vcc 6A 6Y 5A 5Y 4A 4Y
KIA78R05PI (IC663)
Vin 1
2 Vo
Specific IC
4 Vadj
1
4 23
3
GND
17
AVR-1803/883
BA7625 (IC605D) BA7626 (IC652, 653, 601, 603 603D, 604D, 651, 654)
A
Monitor OUT GND IN5 GND IN4 CTL E IN3 CTL D 1 2 3 4 5 6 7 8
6dB LOGIC 6dB LOGIC
TC9184AP (IC552)
CK DATA
8 9
GND
VDD
B L L H H H D L L H H H D L L H H H
E * * * L H E * * * L H E * * * L H
MONITOR OUT IN 1
Ladder resister
16 15 14 13 12 11 10 9
IN1 CTL A V OUT1 Vcc IN2 CTL B V OUT2 CTL C
L H L H H C L H L H H C L H L H H
1
16
7
10
13 bit latch circuit
STB
Vss
BASS+
2
Analog switch
Analog switch
IN 2 IN 3 IN 4 IN 5 V OUT 1 IN 2 IN 3 IN 4 IN 5 V OUT 2 IN 1 IN 3 IN 4 IN 5
Level shift
Ladder resister
15
BASS+
BASSCOM TREBLE-
3
20 bit Shift register circuit
14 13
BASSCOM TREBLE-
4
13 bit latch circuit
Ladder resister
Analog switch
Analog switch
5
Ladder resister
12
Note 1:
* mark means that feasible for either H or L. Each input terminal is provided with sink chip clamp (BA7625). Each input terminal takes 20kohm at the end (BA7626).
TREBLE+
6
Code detect circuit
11
TREBLE+
Note 2:
KIA7806AP (IC602) KIA7805AP (IC104, 103, 822) KIA7815AP (IC101) KIA7812AP (IC271)
FRONT VIEW
KIA7915PI (IC102)
RC1117S25T (IC824) RC1117S33ST (IC823)
FRONT VIEW
MM74HCT244 (IC812)
FRONT VIEW
3
IN OUT ADJ/GND
VOUT
2
2 1
Input GND Output
GND Input Output
1G 1A0 2Y0 1A1 2Y1 1A2 2Y2 1A3 2Y3 GND
1 2 3 4 5 6 7 8 9 10
20 19 18 17 16 15 14 13 12 11
VCC 2G 1Y 0 2A0 1Y1 2A1 1Y2 2A2 1Y3 2A3
OPTICAL
INPUT GP1FA502RZ (IC801~803) OUTPUT GP1FA502TZ(IC817)
IC PROTECTOR
ICP-N15 (IC105)
FRONT VIEW
VCC VOUT GND LED DRIVE IC VCC Vin GND
Vcc GND Vout
Vin Vcc GND
IR SENSOR
NJL64H380A(RMC301)
TOP VIEW
VCC
22kohm
POSISTOR
P43T7D330BW16
FRONT VIEW
Head Amp Amp Limitter
B.P.F PD
ABLC
Comparator
Detector
VOUT
GND
Vout GND Vcc
18
AVR-1803/883
TRANSISTORS
DTA114ES DTC114TS DTC114YS DTC144ES DTA114EK DTA114YK DTA144EK DTC114EK DTC114YK DTC144EK
B E E C B TOP VIEW
DTA Series
C R1 B R2
DTC Series
C R1 B R2 E R1 R2 10kohm / 10kohm / 47kohm / 47kohm / R1 E R2
FRONT VIEW
C
DTA114EK DTA114ES DTA114YK DTA144EK
10kohm / 10kohm / 10kohm / 47kohm /
DTC114EK 10kohm / 10kohm / DTC114TS 10kohm / DTC114YK 10kohm / 47kohm / DTC114YS 10kohm / 47kohm / DTC144EK 47kohm / 47kohm / DTC144ES 47kohm / 47kohm /
2SC1740S 2SC3199Y KSA916Y KSA992F KSC1845F KTA1266Y KTA1268BL KTC2874B KTC3198Y KTC3200BL
2SC2412K KTC3880S
2SK117
2SD947F
2SD3290Y 2SB1560Y
FRONT VIEW
B E
TOP VIEW
C
FRONT VIEW
E C B
D G S
E (Emitter) C (Collector) B (Base)
E (Emitter) C (Collector) B (Base)
DIODES (LED included)
MTZJ3.3B MTZJ5.1B MTZJ6.8B MTZJ7.5A MTZJ8.2B MTZJ11B MTZJ18B MTZJ20B 1N4007 1SS133 KDS160
TOP VIEW
HL-50RDRF4T
TOP VIEW
KBPC604
TOP VIEW
19
AVR-1803/883
FL DISPLAY
16-st-42GNK (FL301)
1 58
G1
S9
PRO LOGIC DIGITAL CH
DIGITAL ANALOG
TUNED RDS
STEREO AUTO
REC MULTI
PHONO VCR
CD TUNER AUX DVD / -1 -2 -3 V.AUX MD /
VDP TV TAPE -1
/ DBS -2
S1 S6 S7 S5 S4 S2 S3
S14 S38 S13
S10 S15 S11 S12
F1
F2 G2~G16
S1 S6 S2 S7 S3 S8 S4 S9 S5 S10
TUNED STEREO REC PHONO AUTO MULTI VCR RDS
G16
G15
G13
G12
G10
CD TUNER AUX DVD / VDP TV / DBS -1 -2 -3 V.AUX MD / TAPE -1 -2 PRO LOGIC DIGITAL
DIGITAL ANALOG
G9
G7
G6 G5 G4
G3
G2
G1
S11 S12 S13 S14 S15 S16 S17 S18 S19 S20 S21 S22 S23 S24 S25 S26 S27 S28 S29 S30 S31 S32 S33 S34 S35
CH
G14
G11
G8
Pin Assignment
PIN NO. CONNECTION PIN NO. CONNECTION PIN NO. CONNECTION
1 F1 21 S19 41 G16
2 F1 22 S20 42 G15
3 S1 23 S21 43 G14
4 S2 24 S22 44 G13
5 S3 25 S23 45 G12
7 S5 27 S24 S25 46 47 G11 G10
6 S4 26
8 9 10 11 12 13 14 15 16 17 S6 S7 S8 S9 S10 S11 S12 S13 S14 S15 28 29 30 31 32 33 34 35 36 37 S26 S27 S28 S29 S30 S31 S32 S33 S34 S35 48 49 50 51 52 53 54 55 56 57 G9 G8 G7 G6 G5 G4 G3 G2 G1 F2
18 19 20 S16 S17 S18 38 39 40 S36 S37 S38 58 F2
F1, F2 : Filament G1~G16 : Grid S1~S38 : Anode
Anode & Grid Assignment
S1 S2 S3 S4 S5 S6 S7 S8 S9 G1 S1 S2 S3 S4 S5 S6 S7 S9 G2~G16 S1 S2 S3 S4 S5 S6 S7 S8 S9 S10 S11 S12 S13 S14 S15 S16 S17 S18 S10 S11 S12 S13 S14 S15 S16 DIGITAL S17 PRO LOGIC S18 G1 S10 S11 S12 S13 S14 S15 G2~G16 S19 S20 S21 S22 S23 S24 S25 S26 S27 G1 G2~G16 S19 S20 S21 S22 S23 S24 S25 S26 S27 G1 S28 S29 S30 S31 S32 S33 S34 S35 G2~G16 S28 S29 S30 S31 S32 S33 S34 S35
G1 S36 S37 S38
G2
G3
G4
G5
G6
G7
G8
G9
G10 G11
G12
G13
G14
G15
G16
S38
/ TV -2 -1 DBS
VDP /(DVD) DVD AUX TAPE /(MD) MD V.AUX
TUNER CD -2 -1 -3
PHONO REC MULTI VCR
STEREO TUNED AUTO RDS CH
20
AVR-1803/883
PRINTED WIRING BOARDS
1 2 3 4 5 6 7 8
MAIN P .W.B. UNIT (for U.S.A., Canada, Europe, U.K., Australia, China & Korea models)
A
B
C
D
E
COMPONENT SIDE
21
AVR-1803/883
1
2
3
4
5
6
7
8
A
B
C
D
E
FOIL SIDE
22
AVR-1803/883
1
2
3
4
5
6
7
8
MAIN P .W.B. UNIT (for Asia, Hong Kong & Taiwan R.O.C. models)
A
B
C
D
E
COMPONENT SIDE
23
AVR-1803/883
1
2
3
4
5
6
7
8
A
B
C
D
E
FOIL SIDE
24
AVR-1803/883
1
CPU P .W.B. UNIT
2
3
4
5
6
7
8
A
B
C
D
E
COMPONENT SIDE
25
AVR-1803/883
1
2
3
4
5
6
7
8
A
B
C
D
E
FOIL SIDE
26
AVR-1803/883
1
CNT P .W.B. UNIT
2
3
4
5
6
7
8
A
B
C
D
E
COMPONENT SIDE
27
AVR-1803/883
1
2
3
4
5
6
7
8
A
B
C
D
E
FOIL SIDE
28
AVR-1803/883
1
INPUT-PREAMP P .W.B. UNIT
2
3
4
5
6
7
8
A
B
C
D
E
COMPONENT SIDE
29
AVR-1803/883
1
2
3
4
5
6
7
8
A
B
C
D
E
FOIL SIDE
30
AVR-1803/883
1
DSP P .W.B. UNIT
2
3
4
5
6
7
8
A
B
COMPONENT SIDE
C
D
E
FOIL SIDE
31
AVR-1803/883
1
2
3
4
VOL-SEL P .W.B. UNIT
A
B
COMPONENT SIDE
C
D
E
32
AVR-1803/883
NOTE FOR PARTS LIST
l Part indicated with the mark "
" are not always in stock and possibly to take a long period of time for supplying, or in some case supplying of part may be refused. l When ordering of part, clearly indicate "1" and "I" (i) to avoid mis-supplying. l Ordering part without stating its part number can not be supplied. l Part indicated with the mark " " is not illustrated in the exploded view. l Not including Carbon Film ±5%, 1/4W Type in the P.W.Board parts list. (Refer to the Schematic Diagram for those parts.) WARNING: Parts marked with this symbol have critical characteristics. Use ONLY replacement parts recommended by the manufacturer.
l Resistors Ex.: RN 14K 2E 182 G FR Type Shape Power Resist- Allowable Others and perance error formance
t t t t
l Capacitors Ex.: CE 04W 1H 2R2 M BP Type Shape Dielectric Capacity Allowable Others and per- strength error formance
t t t t
RD : Carbon RC : Composition RS : Metal oxide film RW : Winding RN : Metal film RK : Metal mixture Resistance 1 8 2
s s
2B 2E 2H 3A 3D 3F 3H
: 1/8W : 1/4W : 1/2W : 1W : 2W : 3W : 5W
F G J K M
: ±1% : ±2% : ±5% : ±10% : ±20%
P : Pulse-resistant type NL : Low noise type NB : Non-burning type FR : Fuse-resistor F : Lead wire forming
CE : Aluminum foil electrolytic CA : Aluminum solid electrolytic CS : Tantalum electrolytic CQ : Film CK : Ceramic CC : Ceramic CP : Oil CM : Mica CF : Metallized CH : Metallized
0J : 6.3V 1A : 10V 1C : 16V 1E : 25V 1V : 35V 1H 2A 2B 2C 2D 2E 2H 2J : 50V : 100V : 125V : 160V : 200V : 250V : 500V : 630V
F : ±1% G : ±2% J : ±5% K : ±10% M : ±20% Z : +80% 20% P : +100% 0% C : ±0.25pF D : ±0.5pF = : Others
HS : High stability type BP : Non-polar type HR : Ripple-resistant type DL : For change and discharge HF : For assuring high requency U : UL part C : CSA part W : UL-CSA type F : Lead wire forming
1800 ohm = 1.8 kohm Indicates number of zeros after effective number. 2-digit effective number.
· Units: ohm 1
s
R
2
s
1.2 ohm 1-digit effective number. 2-digit effective number, decimal point indicated by R.
· Units: ohm
Capacity (electrolyte only) 2 2 2 2200µF s s Indicates number of zeros after effective number. 2-digit effective number. · Units: µF. 2
s
R
2
s
2.2µF 1-digit effective number. 2-digit effective number, decimal point indicated by R.
· Units: µF. Capacity (except electrolyte) 2 2 2 2200pF=0.0022µF s s (More than 2) Indicates number of zeros after effective number. 2-digit effective number. · Units: pF. 2
s
2
s
1
220pF (0 or 1) Indicates number of zeros after effective number. 2-digit effective number.
· Units: pF. · When the dielectric strength is indicated in AC, "AC" is included after the dieelectric strength value.
33
AVR-1803/883
PARTS LIST OF P.W.B. UNIT ASS'Y
MAIN P.W.B. ASS'Y
Ref. No. IC101 IC102 IC103 IC104 IC105 Q104C Q104FL Q104FR Q104SL Q104SR Q111 Q112 Q113 Q114 Q115 Q116 Q117 Q151 Q171 Q171A Q171B Q171C Q172 Q173 Q174 Q175 Q176 Q177 Q178 Q179 Q180 Q181 D101 D102 D103 D104 D105 D121 D122 D123 D124 D125 D126 D131A D131B D132 D133 D134 D135 Part No. Part Name Remarks SEMICONDUCTORS GROUP 963 0057 903 IC KIA7815AP 960 0179 905 IC KIA7915 960 0159 501 IC KIA7805API 963 0057 709 IC KIA7805AP 960 0195 808 IC protector ICP-N15 960 0196 506 Transistor KSC1845F 960 0196 506 Transistor KSC1845F 960 0196 506 Transistor KSC1845F 960 0196 506 Transistor KSC1845F 960 0196 506 Transistor KSC1845F 960 0196 904 Transistor DTC114YS (NPN) 960 0196 904 Transistor DTC114YS (NPN) 960 0196 904 Transistor DTC114YS (NPN) 960 0196 904 Transistor DTC114YS (NPN) 960 0196 904 Transistor DTC114YS (NPN) 960 0196 409 Transistor 2SC1740SR 960 0196 904 Transistor DTC114YS (NPN) 960 0196 409 Transistor 2SC1740SR 960 0005 202 Transistor KTC3198Y 960 0196 302 Transistor KTA1268BL 960 0196 302 Transistor KTA1268BL 960 0196 302 Transistor KTA1268BL 960 0005 202 Transistor KTC3198Y 960 0005 202 Transistor KTC3198Y 960 0005 202 Transistor KTC3198Y 960 0005 202 Transistor KTC3198Y 960 0005 202 Transistor KTC3198Y 960 0005 202 Transistor KTC3198Y 960 0005 105 Transistor KTA1266Y 960 0189 005 Transistor KSA916Y 960 0196 302 Transistor KTA1268BL 960 0196 302 Transistor KTA1268BL 963 0096 508 Diode 1N4148 963 0096 508 Diode 1N4148 963 0096 508 Diode 1N4148 963 0096 508 Diode 1N4148 963 0096 508 Diode 1N4148 963 0096 508 Diode 1N4148 963 0096 508 Diode 1N4148 963 0096 508 Diode 1N4148 963 0096 508 Diode 1N4148 963 0096 508 Diode 1N4148 963 0096 508 Diode 1N4148 960 0197 107 Diode KBPC604 960 0197 107 Diode KBPC604 963 0096 508 Diode 1N4148 963 0046 202 Zener diode MTZJ18B 963 0046 202 Zener diode MTZJ18B 963 0096 508 Diode 1N4148
Note: The symbols in the column "Remarks" indicate the following destinations. E3: U.S.A. model, Canada model E1: Asia model EU: U.S.A. model (AVR-883) E1C: China model E2: Europe model E1H: Hong Kong model EK: U.K. model E1T: Taiwan R.O.C. model E1K: Korea model
Ref. No. D136 D137 D138 D141 D142 D143 D144 D145 D146 D148 D149 D150 D151 D152 D153 D154 D157 D158 D159 D160 ZD310 ZD311
Part No.
Part Name
Remarks
963 0058 504 Zener diode MTZJ11B 963 0096 508 Diode 1N4148 963 0058 407 Diode IN4007 963 0058 407 Diode IN4007 963 0058 407 Diode IN4007 963 0058 407 Diode IN4007 963 0058 407 Diode IN4007 963 0058 407 Diode IN4007 963 0058 407 Diode IN4007 963 0096 508 Diode 1N4148 963 0058 407 Diode IN4007 963 0058 407 Diode IN4007 963 0096 508 Diode 1N4148 963 0058 407 Diode IN4007 963 0058 407 Diode IN4007 960 0095 908 Zener diode MTZJ8.2B 960 0014 905 Zener diode MTZJ20B 963 0096 508 Diode 1N4148 963 0096 508 Diode 1N4148 963 0096 508 Diode 1N4148 960 0095 607 Zener diode MTZJ5.6B 960 0095 607 Zener diode MTZJ5.6B
RESISTORS GROUP R104C R104FL R104FR R104SL R104SR R105C R105FL R105FR R105SL R105SR R106C R106FL R106FR R106SL R106SR R107C R107FL R107FR R107SL R107SR R108C R108FL R108FR R108SL R108SR R109C R109FL 963 9005 451 Metal oxide 5.6 kohm 1W 963 9005 451 Metal oxide 5.6 kohm 1W 963 9005 451 Metal oxide 5.6 kohm 1W 963 9005 451 Metal oxide 5.6 kohm 1W 963 9005 451 Metal oxide 5.6 kohm 1W 963 9005 451 Metal oxide 5.6 kohm 1W 963 9005 451 Metal oxide 5.6 kohm 1W 963 9005 451 Metal oxide 5.6 kohm 1W 963 9005 451 Metal oxide 5.6 kohm 1W 963 9005 451 Metal oxide 5.6 kohm 1W 963 9003 068 Metal film 4.7 ohm 1/4W (NB) 963 9003 068 Metal film 4.7 ohm 1/4W (NB) 963 9003 068 Metal film 4.7 ohm 1/4W (NB) 963 9003 068 Metal film 4.7 ohm 1/4W (NB) 963 9003 068 Metal film 4.7 ohm 1/4W (NB) 963 9003 068 Metal film 4.7 ohm 1/4W (NB) 963 9003 068 Metal film 4.7 ohm 1/4W (NB) 963 9003 068 Metal film 4.7 ohm 1/4W (NB) 963 9003 068 Metal film 4.7 ohm 1/4W (NB) 963 9003 068 Metal film 4.7 ohm 1/4W (NB) 963 9005 477 Metal oxide 0.22 ohm 1W 963 9005 477 Metal oxide 0.22 ohm 1W 963 9005 477 Metal oxide 0.22 ohm 1W 963 9005 477 Metal oxide 0.22 ohm 1W 963 9005 477 Metal oxide 0.22 ohm 1W 963 9005 477 Metal oxide 0.22 ohm 1W 963 9005 477 Metal oxide 0.22 ohm 1W
34
AVR-1803/883
Ref. No. R109FR R109SL R109SR R110C R110FL R110FR R110SL R110SR R111C R111FL R111FR R111SL R111SR R118C R118FL R118FR R118SL R118SR R119C R119FL R119FR R119SL R119SR R135 R136 R141 R142 R148 R149 R151 R154 R179 R181 R184 R185 R903H R904H VR101 VR102 VR103 VR104 VR105
Part No.
Part Name
Remarks
Ref. No. C102FL C102FR C102SL C102SR C103C C103FL C103FR C103SL C103SR C104C C104FL C104FR C104SL C104SR C105C C105FL C105FR C105SL C105SR C107C C107FL C107FR C107SL C107SR C131 C132 C133 C134 C135 C136
Part No.
Part Name
Remarks
963 9005 477 Metal oxide 0.22 ohm 1W 963 9005 477 Metal oxide 0.22 ohm 1W 963 9005 477 Metal oxide 0.22 ohm 1W 963 9005 477 Metal oxide 0.22 ohm 1W 963 9005 477 Metal oxide 0.22 ohm 1W 963 9005 477 Metal oxide 0.22 ohm 1W 963 9005 477 Metal oxide 0.22 ohm 1W 963 9005 477 Metal oxide 0.22 ohm 1W 963 9005 477 Metal oxide 0.22 ohm 1W 963 9005 477 Metal oxide 0.22 ohm 1W 963 9005 477 Metal oxide 0.22 ohm 1W 963 9005 477 Metal oxide 0.22 ohm 1W 963 9005 477 Metal oxide 0.22 ohm 1W 963 9005 480 Metal oxide 10 ohm 1W 963 9005 480 Metal oxide 10 ohm 1W 963 9005 480 Metal oxide 10 ohm 1W 963 9005 480 Metal oxide 10 ohm 1W 963 9005 480 Metal oxide 10 ohm 1W 963 9005 480 Metal oxide 10 ohm 1W 963 9005 480 Metal oxide 10 ohm 1W 963 9005 480 Metal oxide 10 ohm 1W 963 9005 480 Metal oxide 10 ohm 1W 963 9005 480 Metal oxide 10 ohm 1W 963 0045 203 Winding 0.1 ohm 5W 963 0045 203 Winding 0.1 ohm 5W 244 2043 982 Metal oxide 0.22 ohm 1W 244 2043 982 Metal oxide 0.22 ohm 1W 244 2043 982 Metal oxide 0.22 ohm 1W 244 2043 982 Metal oxide 0.22 ohm 1W 963 9003 343 Metal film 68ohm 1/4W 963 0043 108 Metal film 2.2 Mohm 1/2W 963 9003 055 Metal film 47 kohm 1/4W (NB) 963 9003 068 Metal film 4.7 ohm 1/4W (NB) 963 9005 480 Metal oxide 10 ohm 1W 963 9005 655 Metal film 22 ohm 1/4W 960 9009 270 Metal film 470ohm 2W 960 9009 270 Metal film 470ohm 2W 960 0091 601 Semi fixed resistor 1 kohm 960 0091 601 Semi fixed resistor 1 kohm 960 0091 601 Semi fixed resistor 1 kohm 960 0091 601 Semi fixed resistor 1 kohm 960 0091 601 Semi fixed resistor 1 kohm for E3,EU
963 9005 778 Electrolytic 10uF/50V 963 9005 778 Electrolytic 10uF/50V 963 9005 778 Electrolytic 10uF/50V 963 9005 778 Electrolytic 10uF/50V 963 9003 084 Ceramic 100pF/500V 963 9003 084 Ceramic 100pF/500V 963 9003 084 Ceramic 100pF/500V 963 9003 084 Ceramic 100pF/500V 963 9003 084 Ceramic 100pF/500V 963 9003 084 Ceramic 100pF/500V 963 9003 084 Ceramic 100pF/500V 963 9003 084 Ceramic 100pF/500V 963 9003 084 Ceramic 100pF/500V 963 9003 084 Ceramic 100pF/500V 960 9003 108 Ceramic 0.022uF/25V 960 9003 108 Ceramic 0.022uF/25V 960 9003 108 Ceramic 0.022uF/25V 960 9003 108 Ceramic 0.022uF/25V 960 9003 108 Ceramic 0.022uF/25V 963 9003 097 Mylar film 0.1uF/250V 963 9003 097 Mylar film 0.1uF/250V 963 9003 097 Mylar film 0.1uF/250V 963 9003 097 Mylar film 0.1uF/250V 963 9003 097 Mylar film 0.1uF/250V 963 9003 097 Mylar film 0.1uF/250V 963 9003 097 Mylar film 0.1uF/250V 963 9003 097 Mylar film 0.1uF/250V 963 9003 097 Mylar film 0.1uF/250V 963 9003 097 Mylar film 0.1uF/250V 963 9006 094 Electrolytic 12000uF/63V 963 9006 094 Electrolytic 12000uF/63V 963 9005 749 Electrolytic 1uF/50V 963 0021 900 Mylar film 0.047uF/100V 963 0021 900 Mylar film 0.047uF/100V 963 0021 900 Mylar film 0.047uF/100V 960 9007 201 Electrolytic 3300uF/10V 963 9003 123 Electrolytic 1000uF/35V 963 9005 749 Electrolytic 1uF/50V 963 9005 749 Electrolytic 1uF/50V 963 0021 900 Mylar film 0.047uF/100V 963 0021 900 Mylar film 0.047uF/100V 963 0021 900 Mylar film 0.047uF/100V 963 0021 104 Electrolytic 6800uF/16V 963 9005 309 Electrolytic 47uF/10V 963 9004 559 Ceramic 0.1uF/50V 963 9005 749 Electrolytic 1uF/50V 963 9003 136 Electrolytic 1000uF/25V 963 9005 749 Electrolytic 1uF/50V 963 9005 752 Electrolytic 10uF/35V 963 9005 312 Electrolytic 100uF/10V 963 9004 559 Ceramic 0.1uF/50V 963 9004 559 Ceramic 0.1uF/50V
C137 C138 C141 C142 C143 C144 C145 C146 C148 C150 C151 C152 C153 C154 C155 C157 C158 C159 C161 C171 C171A C171B
CAPACITORS GROUP C101C C101FL C101FR C101SL C101SR C102C 963 9005 888 Electrolytic 47uF/50V 963 9005 888 Electrolytic 47uF/50V 963 9005 888 Electrolytic 47uF/50V 963 9005 888 Electrolytic 47uF/50V 963 9005 888 Electrolytic 47uF/50V 963 9005 778 Electrolytic 10uF/50V
35
AVR-1803/883
Ref. No. C171C C172 C173 C174 C175 C176 C177 C178 C181 C182 C191 C192 C193 C194 C195 C197 C198C C198FL C198SL C198SR C199FL C199FR C331 C332 C901H C902H C903H C904H
Part No.
Part Name
Remarks
Ref. No. CN391 CN392 CN393 CN502V CN901 CN931A CP101 CP102
Part No.
Part Name
Remarks
Q'ty 1 1 1 1 1
963 9004 559 Ceramic 0.1uF/50V 963 9005 833 Electrolytic 220uF/6.3V 963 9005 833 Electrolytic 220uF/6.3V 963 9005 752 Electrolytic 10uF/35V 963 9005 914 Electrolytic 4.7uF/50V 963 9005 749 Electrolytic 1uF/50V 963 9005 749 Electrolytic 1uF/50V 963 9003 149 Electrolytic 330uF/63V 960 0177 208 Ceramic 4700pF/250V(AC) 963 9006 120 Electrolytic 10uF/100V 963 9006 007 Ceramic 2200pF/16V 963 9006 007 Ceramic 2200pF/16V 963 9006 007 Ceramic 2200pF/16V 963 9006 007 Ceramic 2200pF/16V 963 9006 007 Ceramic 2200pF/16V 963 9006 007 Ceramic 2200pF/16V 963 0024 703 Mylar film 0.01uF/100V 963 0024 703 Mylar film 0.01uF/100V 963 0024 703 Mylar film 0.01uF/100V 963 0024 703 Mylar film 0.01uF/100V 963 0024 703 Mylar film 0.01uF/100V 963 0024 703 Mylar film 0.01uF/100V 963 9004 546 Ceramic 0.01uF/16V 963 9004 546 Ceramic 0.01uF/16V for E2,EK for E2,EK for E2,EK for E2,EK for E2,EK for E2,EK for E2,EK for E2,EK for E2,EK for E2,EK for E2,EK for E2,EK
OTHER PARTS GROUP 963 0060 602 7P connector base 963 0106 207 4P wire 963 0050 104 4P connector base 963 0106 304 8P wire 963 0106 401 3P wire 960 0059 707 2P connector cord 960 0118 908 AC cord connector base 960 0123 304 2P connector base 960 0128 901 3P connector base 960 0128 804 6P connector base 960 0123 207 3P connector base 963 0086 903 5P connector base (TUC-P) 963 0087 009 6P connector base (TUC-P) 963 0086 903 5P connector base (TUC-P) 963 0086 806 9P connector base (TUC-P) 963 0086 903 5P connector base (TUC-P) 963 0087 106 20P connector base (TUC-P) 963 0085 807 7P connector base (TUC-P) 963 0085 807 7P connector base (TUC-P) 963 0048 909 3P connector base 960 0123 304 2P connector base 960 0123 207 3P connector base 960 0188 705 Fuse 8A 963 0104 704 Fuse 2.5A 960 0005 804 Fuse clip 960 0005 804 Fuse clip 960 0188 705 Fuse 8A 963 0104 801 Fuse 3.15A 960 0005 804 Fuse clip 960 0005 804 Fuse clip 960 9006 600 Terminal 960 9006 600 Terminal 960 0188 608 4P speaker terminal 963 0074 009 8P speaker terminal 960 0194 809 2P speaker terminal 960 0187 803 AC outlet(2P) 963 0095 402 Head phone jack (D6.5) 963 0049 005 Inductor 0.5uH 963 0049 005 Inductor 0.5uH 963 0049 005 Inductor 0.5uH 963 0049 005 Inductor 0.5uH 963 0049 005 Inductor 0.5uH 960 0181 702 Relay (G5PA-28 24V) 960 0181 702 Relay (G5PA-28 24V) 960 0181 702 Relay (G5PA-28 24V) for E3,EU for E3,EU for E2,EK,E1K for E3,EU for E2,EK,E1K for E2,EK,ASIA for E2,EK,ASIA
1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
CP103 CP104 CP106 CP501 CP502 CP503 CP504 CP505 CP553 CP703 CP704 CP901 CP931 CP992 F101
963 9004 533 Ceramic 0.001uF/50V 963 9004 533 Ceramic 0.001uF/50V 963 9005 749 Electrolytic 1uF/50V 960 9003 108 Ceramic 0.022uF/25V
F101 F101A F101B F102 F102 F102A F102B GND101 GND102 JK101 JK102 JK103 JK104 JK901 L101C L101FL L101FR L101SL L101SR RLY101 RLY102 RLY103
36
AVR-1803/883
CPU P.W.B. ASS'Y
Ref. No. RLY104 RLY105 RLY106 SW391 SW393 SW901 SW901A TP101 TP102 TP103 TP104 TP105 VEC303 Part No. Part Name Remarks Q'ty 1 1 1 1 1 for E3,EU for E2,EK,ASIA 1 1 1 1 1 1 1 1 1 1 for E2,EK,E1C,E1K for E2,EK,E1K for E1C for E3,EU for E2,EK,EA for E1C,E1K for E1,E1H,E1T 1 1 1 1 1 1 1 3 Q201 Q202 Q203 Q204 Q207 Q208 Q209 Q210 Q216 Q217 Q218 Q221 Q300 Q301 Q302 Q303 Q304 Q305 Q306 Q307 D201 D202 D204 D205 D206 D207 D209 D213 D214 269 0054 901 Transistor DTC144EK 963 0045 902 Transistor 2SC2412KT 269 0055 900 Transistor DTA144EK 963 0024 208 Transistor DTC114YK 960 0196 807 Transistor 2SK117Y 960 0196 807 Transistor 2SK117Y 269 0093 904 Transistor DTA144ES 269 0040 902 Transistor DTC144ES 269 0046 906 Transistor DTA114ES 963 0102 803 Transistor 2SA933S 963 0102 803 Transistor 2SA933S 269 0083 901 Transistor DTA114EK 269 0055 900 Transistor DTA144EK 269 0055 900 Transistor DTA144EK 269 0054 901 Transistor DTC144EK 269 0054 901 Transistor DTC144EK 269 0054 901 Transistor DTC144EK 269 0055 900 Transistor DTA144EK 269 0082 902 Transistor DTC114EK 963 0024 208 Transistor DTC114YK 963 0096 508 Diode 1N4148 963 0058 407 Diode IN4007 960 0197 000 Diode KDS160 960 0197 000 Diode KDS160 960 0197 000 Diode KDS160 960 0197 000 Diode KDS160 960 0197 000 Diode KDS160 963 0096 508 Diode 1N4148 963 0058 407 Diode IN4007 for E2,EK RMC301 960 0181 100 IC NJL64H380A IC301 IC302 IC603 IC803 960 0180 004 IC LC75721E 963 0074 504 IC BU2090F 960 0174 502 IC NJM2068DD 269 0186 002 IC GP1FA502RZ Ref. No. IC201 IC202 IC203 963 0045 708 Tact switch 963 0045 708 Tact switch 960 0176 209 Push switch 963 0098 807 Push switch 960 0161 405 3P connector base 960 0161 405 3P connector base 960 0161 405 3P connector base 960 0161 405 3P connector base 960 0161 405 3P connector base 963 0095 208 Encoder SW Heat sink Heat sink IC204 IC205 IC206 IC207 IC208 IC209 IC210 Part No. Part Name Remarks 960 0181 702 Relay (G5PA-28 24V) 963 0071 303 Relay (RSB24S 24V) 960 0181 605 Relay (G5PA-1-8 12V) SEMICONDUCTORS GROUP 963 0102 201 IC CXP740096-161Q 963 0057 602 IC TDA7330BD 960 0080 201 IC KIC9164AN 963 0043 603 IC KIC9482F 960 0174 502 IC NJM2068DD 960 0174 502 IC NJM2068DD 960 0174 502 IC NJM2068DD 960 0174 502 IC NJM2068DD 960 0174 502 IC NJM2068DD 960 0174 502 IC NJM2068DD for E2,EK
963 0068 400 Capacitor cover 963 0060 000 Fuse label(2.5A) 963 0090 504 Fuse label(3.15A) 963 0094 924 Mini trans 963 0094 937 Mini trans 963 0094 911 Mini trans 963 0094 940 Mini trans 963 0018 007 Screw (2S 3×8 ZNY/BH)
37
AVR-1803/883
Ref. No. D302 D303 D304 D305 D306 D307 ZD201 ZD301 ZD302 ZD303 ZD304 ZD305 LED301 LED302 LED303 LED304 LED305 LED306 LED307 LED308 LED309
Part No.
Part Name
Remarks
Ref. No. R220 R220SW R221SW R222SW R223 R223SW R224 R224SW R225 R229 R230 R237 R239C R239FL R239FR R239SL R239SR R239SW R240C R240FL R240FR R240SL R240SR R240SW R241C R241FL R241FR R241SL R241SR R241SW R242C R242FL R242FR R242SL R242SR R242SW R244C R244FL R244FR R244SL R244SR R244SW R245C R245FL R245FR R245SL R245SR R245SW R246C R246SL R246SR R246SW
Part No.
Part Name
Remarks
963 0096 508 Diode 1N4148 963 0096 508 Diode 1N4148 963 0096 508 Diode 1N4148 960 0197 000 Diode KDS160 960 0197 000 Diode KDS160 960 0197 000 Diode KDS160 963 0047 502 Zener diode MTZJ3.3B 960 0095 801 Zener diode MTZJ6.8B 960 0095 607 Zener diode MTZJ5.6B 960 0095 607 Zener diode MTZJ5.6B 960 0095 607 Zener diode MTZJ5.6B 960 0095 607 Zener diode MTZJ5.6B 960 0197 204 LED PI5-RD/HL50RDRF4T 960 0197 204 LED PI5-RD/HL50RDRF4T 960 0197 204 LED PI5-RD/HL50RDRF4T 960 0197 204 LED PI5-RD/HL50RDRF4T 960 0197 204 LED PI5-RD/HL50RDRF4T 960 0197 204 LED PI5-RD/HL50RDRF4T 960 0197 204 LED PI5-RD/HL50RDRF4T 960 0197 204 LED PI5-RD/HL50RDRF4T 960 0197 204 LED PI5-RD/HL50RDRF4T
963 9004 070 Carbon chip 10 kohm 1/16W 963 9004 070 Carbon chip 10 kohm 1/16W 963 9005 707 Carbon chip 3.6 kohm 1/16W 960 9009 775 Carbon chip 9.1 kohm 1/16W 963 9004 070 Carbon chip 10 kohm 1/16W for E2,EK 963 9003 385 Carbon chip 100 ohm 1/16W 963 9004 070 Carbon chip 10 kohm 1/16W for E2,EK 963 9004 083 Carbon chip 100 kohm 1/16W 963 9004 245 Carbon chip 2.2 Mohm 1/16W for E2,EK 244 2051 961 Metal film 100 ohm 1W 244 2051 961 Metal film 100 ohm 1W 963 9003 398 Carbon chip 1 kohm 1/16W 963 9004 083 Carbon chip 100 kohm 1/16W 963 9004 083 Carbon chip 100 kohm 1/16W 963 9004 083 Carbon chip 100 kohm 1/16W 963 9004 083 Carbon chip 100 kohm 1/16W 963 9004 083 Carbon chip 100 kohm 1/16W 963 9004 083 Carbon chip 100 kohm 1/16W 963 9003 385 Carbon chip 100 ohm 1/16W 963 9003 385 Carbon chip 100 ohm 1/16W 963 9003 385 Carbon chip 100 ohm 1/16W 963 9003 385 Carbon chip 100 ohm 1/16W 963 9003 385 Carbon chip 100 ohm 1/16W 963 9003 385 Carbon chip 100 ohm 1/16W 963 9004 083 Carbon chip 100 kohm 1/16W 963 9004 083 Carbon chip 100 kohm 1/16W 963 9004 083 Carbon chip 100 kohm 1/16W 963 9004 083 Carbon chip 100 kohm 1/16W 963 9004 083 Carbon chip 100 kohm 1/16W 963 9004 083 Carbon chip 100 kohm 1/16W 963 9004 478 Carbon chip 7.5 kohm 1/16W 963 9004 478 Carbon chip 7.5 kohm 1/16W 963 9004 478 Carbon chip 7.5 kohm 1/16W 963 9004 478 Carbon chip 7.5 kohm 1/16W 963 9004 478 Carbon chip 7.5 kohm 1/16W 963 9004 449 Carbon chip 6.8 kohm 1/16W 963 9005 671 Carbon chip 1.3 kohm 1/16W 963 9005 671 Carbon chip 1.3 kohm 1/16W 963 9005 671 Carbon chip 1.3 kohm 1/16W 963 9005 671 Carbon chip 1.3 kohm 1/16W 963 9005 671 Carbon chip 1.3 kohm 1/16W 963 9004 407 Carbon chip 620 ohm 1/16W 963 9004 083 Carbon chip 100 kohm 1/16W 963 9004 083 Carbon chip 100 kohm 1/16W 963 9004 083 Carbon chip 100 kohm 1/16W 963 9004 083 Carbon chip 100 kohm 1/16W 963 9004 083 Carbon chip 100 kohm 1/16W 963 9004 083 Carbon chip 100 kohm 1/16W 963 9004 083 Carbon chip 100 kohm 1/16W 963 9004 083 Carbon chip 100 kohm 1/16W 963 9004 083 Carbon chip 100 kohm 1/16W 963 9004 083 Carbon chip 100 kohm 1/16W
RESISTORS GROUP R201V R202 R202V R204 R205 R206 R208 R209 R210FL R210FR R211 R212 R213FR R214FL R214FR R215FL R215FR R216 R216FL R216FR R217 R217FL R217FR R218 R218 R219 963 9003 398 Carbon chip 1 kohm 1/16W 963 9003 398 Carbon chip 1 kohm 1/16W 963 9003 398 Carbon chip 1 kohm 1/16W 963 9004 342 Carbon chip 4.7 kohm 1/16W 963 9004 070 Carbon chip 10 kohm 1/16W 963 9004 232 Carbon chip 220 kohm 1/16W 963 9004 070 Carbon chip 10 kohm 1/16W 963 9004 083 Carbon chip 100 kohm 1/16W 963 9004 313 Carbon chip 4.3 kohm 1/16W 963 9004 313 Carbon chip 4.3 kohm 1/16W 963 9004 070 Carbon chip 10 kohm 1/16W 963 9003 398 Carbon chip 1 kohm 1/16W 963 9004 151 Carbon chip 15 kohm 1/16W 963 9004 151 Carbon chip 15 kohm 1/16W 963 9004 151 Carbon chip 15 kohm 1/16W 963 9003 385 Carbon chip 100 ohm 1/16W 963 9003 385 Carbon chip 100 ohm 1/16W 963 9004 070 Carbon chip 10 kohm 1/16W for E3,EU,E2,EK 963 9004 083 Carbon chip 100 kohm 1/16W 963 9004 083 Carbon chip 100 kohm 1/16W 963 9004 151 Carbon chip 15 kohm 1/16W for E3,EU,ASIA 963 9004 410 Carbon chip 6.2 kohm 1/16W 963 9004 410 Carbon chip 6.2 kohm 1/16W 963 9004 177 Carbon chip 18 kohm 1/16W for E2,EK 963 9004 070 Carbon chip 10 kohm 1/16W for ASIA 963 9004 070 Carbon chip 10 kohm 1/16W
38
AVR-1803/883
Ref. No. R247C R247SL R247SR R247SW R250 R251 R252 R253 R255 R261 R262 R263 R264 R265 R266 R267 R268 R269 R270 R271 R301B R302A R302B R303B R304A R310 R336 R337 R338 R339 R340 R341 R342 R343 R344 R344 R345 R346 R347 R348 R349 R349FL R350 R350FL R351 R351FL R352 R352FL R353 R353FL R354FL
Part No.
Part Name
Remarks
Ref. No. R355 R355FL R356 R356FL R357FL R358FL R359FL R360FL R361 R361FL R362FL R363FL R364FL R365FL R366FL R367FL R368FL R369FL R370FL R371FL R372FL R373FL R374FL R375FL R376FL R377FL R378FL R379FL R380FL R381FL R382FL R383FL R384FL R385FL R386FL R387FL R388FL R389FL R390FL R391FL R392FL R393FL R394FL R395FL R396FL R397FL R398FL R399FL R400FL R401FL R402FL
Part No.
Part Name
Remarks
963 9004 339 Carbon chip 470 ohm 1/16W 963 9004 339 Carbon chip 470 ohm 1/16W 963 9004 339 Carbon chip 470 ohm 1/16W 963 9004 339 Carbon chip 470 ohm 1/16W 963 9004 368 Carbon chip 470 kohm 1/16W 963 9004 368 Carbon chip 470 kohm 1/16W 963 9004 847 Carbon chip 3.3 kohm 1/16W 963 9003 398 Carbon chip 1 kohm 1/16W 963 9004 368 Carbon chip 470 kohm 1/16W 963 9004 122 Carbon chip 12 kohm 1/16W 963 9004 070 Carbon chip 10 kohm 1/16W 963 9004 122 Carbon chip 12 kohm 1/16W 963 9004 122 Carbon chip 12 kohm 1/16W 963 9004 339 Carbon chip 470 ohm 1/16W 963 9004 339 Carbon chip 470 ohm 1/16W 963 9004 339 Carbon chip 470 ohm 1/16W 963 9004 339 Carbon chip 470 ohm 1/16W 963 9004 339 Carbon chip 470 ohm 1/16W 963 9004 339 Carbon chip 470 ohm 1/16W 963 9004 339 Carbon chip 470 ohm 1/16W 963 9004 119 Carbon chip 1.2 kohm 1/16W 963 9006 052 Carbon chip 1.5 kohm 1/16W 963 9006 052 Carbon chip 1.5 kohm 1/16W 960 9009 717 Carbon chip 1.8 kohm 1/16W 963 9005 040 Carbon chip 2.4 kohm 1/16W 963 9004 436 Carbon chip 680 ohm 1/16W 963 9004 465 Carbon chip 75 ohm 1/16W 963 9004 355 Carbon chip 47 kohm 1/16W 963 9004 339 Carbon chip 470 ohm 1/16W 963 9004 465 Carbon chip 75 ohm 1/16W 963 9004 436 Carbon chip 680 ohm 1/16W 963 9004 436 Carbon chip 680 ohm 1/16W 963 9004 436 Carbon chip 680 ohm 1/16W 963 9004 436 Carbon chip 680 ohm 1/16W 963 9004 070 Carbon chip 10 kohm 1/16W 963 9004 465 Carbon chip 75 ohm 1/16W 963 9004 436 Carbon chip 680 ohm 1/16W 963 9004 436 Carbon chip 680 ohm 1/16W 963 9004 436 Carbon chip 680 ohm 1/16W 963 9004 436 Carbon chip 680 ohm 1/16W 963 9004 339 Carbon chip 470 ohm 1/16W 963 9004 397 Carbon chip 56 kohm 1/16W 963 9004 245 Carbon chip 2.2 Mohm 1/16W 963 9004 397 Carbon chip 56 kohm 1/16W 963 9004 245 Carbon chip 2.2 Mohm 1/16W 963 9004 397 Carbon chip 56 kohm 1/16W 963 9004 070 Carbon chip 10 kohm 1/16W 963 9004 397 Carbon chip 56 kohm 1/16W 963 9003 398 Carbon chip 1 kohm 1/16W 963 9004 397 Carbon chip 56 kohm 1/16W 963 9004 397 Carbon chip 56 kohm 1/16W
963 9004 847 Carbon chip 3.3 kohm 1/16W 963 9004 397 Carbon chip 56 kohm 1/16W 963 9003 398 Carbon chip 1 kohm 1/16W 963 9004 397 Carbon chip 56 kohm 1/16W 963 9004 397 Carbon chip 56 kohm 1/16W 963 9004 397 Carbon chip 56 kohm 1/16W 963 9004 397 Carbon chip 56 kohm 1/16W 963 9004 397 Carbon chip 56 kohm 1/16W 963 9004 070 Carbon chip 10 kohm 1/16W 963 9004 397 Carbon chip 56 kohm 1/16W 963 9004 397 Carbon chip 56 kohm 1/16W 963 9004 397 Carbon chip 56 kohm 1/16W 963 9004 397 Carbon chip 56 kohm 1/16W 963 9004 397 Carbon chip 56 kohm 1/16W 963 9004 397 Carbon chip 56 kohm 1/16W 963 9004 397 Carbon chip 56 kohm 1/16W 963 9004 397 Carbon chip 56 kohm 1/16W 963 9004 397 Carbon chip 56 kohm 1/16W 963 9004 397 Carbon chip 56 kohm 1/16W 963 9004 397 Carbon chip 56 kohm 1/16W 963 9004 397 Carbon chip 56 kohm 1/16W 963 9004 397 Carbon chip 56 kohm 1/16W 963 9004 397 Carbon chip 56 kohm 1/16W 963 9004 397 Carbon chip 56 kohm 1/16W 963 9004 397 Carbon chip 56 kohm 1/16W 963 9004 397 Carbon chip 56 kohm 1/16W 963 9004 397 Carbon chip 56 kohm 1/16W 963 9004 397 Carbon chip 56 kohm 1/16W 963 9004 397 Carbon chip 56 kohm 1/16W 963 9004 397 Carbon chip 56 kohm 1/16W 963 9004 397 Carbon chip 56 kohm 1/16W 963 9004 397 Carbon chip 56 kohm 1/16W 963 9004 397 Carbon chip 56 kohm 1/16W 963 9004 397 Carbon chip 56 kohm 1/16W 963 9004 397 Carbon chip 56 kohm 1/16W 963 9004 397 Carbon chip 56 kohm 1/16W 963 9004 397 Carbon chip 56 kohm 1/16W 963 9004 397 Carbon chip 56 kohm 1/16W 963 9004 397 Carbon chip 56 kohm 1/16W 963 9004 397 Carbon chip 56 kohm 1/16W 963 9004 397 Carbon chip 56 kohm 1/16W 963 9004 397 Carbon chip 56 kohm 1/16W 963 9004 397 Carbon chip 56 kohm 1/16W 963 9004 397 Carbon chip 56 kohm 1/16W 963 9004 397 Carbon chip 56 kohm 1/16W 963 9004 397 Carbon chip 56 kohm 1/16W 963 9004 397 Carbon chip 56 kohm 1/16W 963 9004 397 Carbon chip 56 kohm 1/16W 963 9004 397 Carbon chip 56 kohm 1/16W 963 9004 397 Carbon chip 56 kohm 1/16W 963 9004 397 Carbon chip 56 kohm 1/16W
39
AVR-1803/883
Ref. No. R407 R601BL R601BR R602BL R602BR R603BL R603BR R604BL R604BR R605BL R605BR
Part No.
Part Name
Remarks
Ref. No. C227 C228 C229 C230 C230C C231 C231C C231FL C231FR C231SL C231SR C231SW C232 C232C C232FL C232FR C232SL C232SR C232SW C233 C234 C235SW C238 C239 C240 C241 C242 C243 C244 C245 C246 C247 C248 C249 C250 C301 C3010 C302 C3020 C303 C303O C304 C305 C306 C307 C308 C309 C310 C312 C314 C315
Part No.
Part Name
Remarks
963 9004 342 Carbon chip 4.7 kohm 1/16W 963 9003 385 Carbon chip 100 ohm 1/16W 963 9003 385 Carbon chip 100 ohm 1/16W 963 9006 065 Carbon chip 200 kohm 1/16W 963 9006 065 Carbon chip 200 kohm 1/16W 963 9006 065 Carbon chip 200 kohm 1/16W 963 9006 065 Carbon chip 200 kohm 1/16W 963 9003 385 Carbon chip 100 ohm 1/16W 963 9003 385 Carbon chip 100 ohm 1/16W 963 9004 083 Carbon chip 100 kohm 1/16W 963 9004 083 Carbon chip 100 kohm 1/16W
963 9005 765 Electrolytic 10uF/35V 963 9004 575 Ceramic chip 100pF/50V 963 9004 575 Ceramic chip 100pF/50V 963 9004 575 Ceramic chip 100pF/50V 963 9005 914 Electrolytic 4.7uF/50V 963 9004 575 Ceramic chip 100pF/50V 963 9005 914 Electrolytic 4.7uF/50V 963 9005 765 Electrolytic 10uF/35V 963 9005 765 Electrolytic 10uF/35V 963 9005 914 Electrolytic 4.7uF/50V 963 9005 914 Electrolytic 4.7uF/50V 963 9005 914 Electrolytic 4.7uF/50V 963 9004 575 Ceramic chip 100pF/50V 963 9004 669 Ceramic chip 56pF/50V 963 9004 669 Ceramic chip 56pF/50V 963 9004 669 Ceramic chip 56pF/50V 963 9004 630 Ceramic chip 39pF/50V 963 9004 630 Ceramic chip 39pF/50V 963 9004 669 Ceramic chip 56pF/50V 963 9004 575 Ceramic chip 100pF/50V 963 9004 575 Ceramic chip 100pF/50V 963 9004 575 Ceramic chip 100pF/50V 963 9005 927 Electrolytic 0.1uF/50V 963 9004 753 Ceramic chip 0.047uF/50V 963 9005 749 Electrolytic 1uF/50V 963 9005 765 Electrolytic 10uF/35V 963 9004 685 Ceramic chip 1000pF/50V 963 9004 753 Ceramic chip 0.047uF/50V 963 9004 753 Ceramic chip 0.047uF/50V 963 9004 575 Ceramic chip 100pF/50V 963 9005 765 Electrolytic 10uF/35V 963 9004 575 Ceramic chip 100pF/50V 963 9004 685 Ceramic chip 1000pF/50V 963 9004 737 Ceramic chip 0.022uF/25V 963 9004 575 Ceramic chip 100pF/50V 963 9004 698 Ceramic chip 0.01uF/50V 963 9005 309 Electrolytic 47uF/10V 963 9004 698 Ceramic chip 0.01uF/50V 963 9004 559 Ceramic 0.1uF/50V 963 9004 698 Ceramic chip 0.01uF/50V 963 9004 591 Ceramic chip 22pF/50V 963 9004 698 Ceramic chip 0.01uF/50V 963 9004 685 Ceramic chip 1000pF/50V 963 9004 575 Ceramic chip 100pF/50V 963 9004 575 Ceramic chip 100pF/50V 963 9005 406 Ceramic chip 30pF/50V 963 9004 737 Ceramic chip 0.022uF/25V 963 9004 562 Ceramic 0.047uF/50V 963 9004 753 Ceramic chip 0.047uF/50V 963 0021 900 Mylar film 0.047uF/100V 963 9005 749 Electrolytic 1uF/50V
CAPACITORS GROUP BC201 C202 C203 C204 C205 C206 C207 C208 C209 C210 C211 C211SW C212 C212SW C213 C213FL C213FR C214 C215 C216 C217 C218 C218FL C218FR C219 C219FL C219FR C219SW C220 C221 C221FL C221FR C222SW C223SL C223SR C225 C226 963 0061 504 Electrolytic 8200uF/5.5V 963 9004 698 Ceramic chip 0.01uF/50V 963 9004 698 Ceramic chip 0.01uF/50V 963 9005 914 Electrolytic 4.7uF/50V 963 9004 562 Ceramic 0.047uF/50V 963 9005 309 Electrolytic 47uF/10V 963 9004 546 Ceramic 0.01uF/16V 963 9004 805 Ceramic 270pF/50V 963 9005 765 Electrolytic 10uF/35V 963 9004 698 Ceramic chip 0.01uF/50V 963 9004 614 Ceramic chip 27pF/50V 963 9004 575 Ceramic chip 100pF/50V 963 9004 614 Ceramic chip 27pF/50V 963 9004 643 Ceramic chip 47pF/50V 963 9004 753 Ceramic chip 0.047uF/50V 963 9004 575 Ceramic chip 100pF/50V 963 9004 575 Ceramic chip 100pF/50V 963 9004 753 Ceramic chip 0.047uF/50V 963 9004 753 Ceramic chip 0.047uF/50V 963 9004 753 Ceramic chip 0.047uF/50V 963 9004 753 Ceramic chip 0.047uF/50V 963 9004 753 Ceramic chip 0.047uF/50V 963 9004 627 Ceramic chip 33pF/50V 963 9004 627 Ceramic chip 33pF/50V 963 9004 753 Ceramic chip 0.047uF/50V 963 9005 765 Electrolytic 10uF/35V 963 9005 765 Electrolytic 10uF/35V 963 9005 765 Electrolytic 10uF/35V 963 9005 765 Electrolytic 10uF/35V 960 9009 911 Electrolytic 100uF/10V 963 9005 914 Electrolytic 4.7uF/50V 963 9005 914 Electrolytic 4.7uF/50V 963 9005 914 Electrolytic 4.7uF/50V 963 9005 914 Electrolytic 4.7uF/50V 963 9005 914 Electrolytic 4.7uF/50V 963 9004 753 Ceramic chip 0.047uF/50V 963 9004 753 Ceramic chip 0.047uF/50V for E2,EK for E2,EK for E2,EK for E2,EK for E2,EK for E2,EK for E2,EK
40
AVR-1803/883
Ref. No. C316 C317 C318 C319 C320 C321 C322 C323 C324 C325 C326 C327 C328 C329 C330 C601BL C601BR C602BL C602BR C603BL C603BR
Part No.
Part Name
Remarks
Ref. No. J324 J325 J340 J342 J343 JACK301 JACK301 L301 L3010 L302 SW301A SW301C SW302A SW302B SW302C SW303A SW303B SW303C SW304A SW304B SW304C SW305A SW305B SW305C SW306A SW306C SW307A SW307C SW308A SW308C SW309A SW309C VEC301 VEC302 X201 X202
Part No.
Part Name
Remarks
Q'ty 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
963 9005 778 Electrolytic 10uF/50V 963 9005 862 Electrolytic 47uF/16V 963 0021 900 Mylar film 0.047uF/100V 963 9005 862 Electrolytic 47uF/16V 963 9005 749 Electrolytic 1uF/50V 963 0021 900 Mylar film 0.047uF/100V 963 9005 309 Electrolytic 47uF/10V 963 9004 766 Mylar film 0.1uF/100V 963 9005 914 Electrolytic 4.7uF/50V 963 9004 575 Ceramic chip 100pF/50V 963 9005 914 Electrolytic 4.7uF/50V 963 9005 914 Electrolytic 4.7uF/50V 963 9004 753 Ceramic chip 0.047uF/50V 963 9006 133 Electrolytic 4.7uF/16V 963 9006 133 Electrolytic 4.7uF/16V 963 9005 914 Electrolytic 4.7uF/50V 963 9005 914 Electrolytic 4.7uF/50V 963 9004 698 Ceramic chip 0.01uF/50V 963 9004 698 Ceramic chip 0.01uF/50V 963 9005 765 Electrolytic 10uF/35V 963 9005 765 Electrolytic 10uF/35V 963 0095 305 Tact switch 963 0045 708 Tact switch 963 0095 305 Tact switch 963 0095 305 Tact switch 963 0045 708 Tact switch 963 0095 305 Tact switch 963 0095 305 Tact switch 963 0045 708 Tact switch 963 0095 305 Tact switch 963 0095 305 Tact switch 963 0045 708 Tact switch 963 0095 305 Tact switch 963 0045 708 Tact switch 963 0045 708 Tact switch 963 0095 305 Tact switch 963 0045 708 Tact switch 963 0095 305 Tact switch 963 0045 708 Tact switch 963 0095 305 Tact switch 963 0045 708 Tact switch 963 0095 305 Tact switch 963 0045 708 Tact switch 963 0102 007 Encoder SW 963 0102 007 Encoder SW 960 0181 003 Resonator CST12.0MTW-TF01 963 0099 505 Crystl 4.332MHz 960 0260 005 Wire clamp 960 0184 408 FLT holder 960 0180 509 FLT (16-ST-42GNK) for E2,EK 960 0010 307 Inductor 10uH 960 0215 908 Inductor 4.7uH 960 0128 008 Inductor 100uH 963 0084 206 3P pin jack 963 0102 104 1P S terminal 963 9003 369 Carbon chip 0 ohm 1/8W 963 9003 369 Carbon chip 0 ohm 1/8W 963 9003 369 Carbon chip 0 ohm 1/8W 963 9003 369 Carbon chip 0 ohm 1/8W 963 9003 369 Carbon chip 0 ohm 1/8W
OTHER PARTS GROUP CB201 CB202 CN303 CN502 CN604 CN605 CN606 CN609 CP201 CP301 CP303 CP391 CP401 CP551 CP552 CP601 CP602 CP603 CP701 CP702 CP801 CP802 CP803 CP901 GP303 963 0053 800 Beads inductor 963 0053 800 Beads inductor 963 0102 502 22P FFC connector base 960 0252 107 4P connector base (TUC-P) 963 0106 508 6P wire 963 0106 605 3P wire 963 0106 702 5P wire 963 0048 909 3P connector base 963 0087 805 11P connector base (TUC-P) 963 0102 405 22P FFC connector base 963 0049 102 3P connector base 963 0106 809 7P wire 963 0087 407 16P connector base (TUC-P) 963 0087 504 19P connector base (TUC-P) 963 0087 504 19P connector base (TUC-P) 963 0087 504 19P connector base (TUC-P) 963 0086 903 5P connector base (TUC-P) 963 0087 009 6P connector base (TUC-P) 963 0087 902 17P connector base (TUC-P) 963 0087 805 11P connector base (TUC-P) 963 0087 407 16P connector base (TUC-P) 963 0087 504 19P connector base (TUC-P) 963 0087 601 8P connector base (TUC-P) 963 0060 806 11P connector base 1P contact Ass'y
Q'ty 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
1 2 1 1
41
AVR-1803/883
CNT P.W.B. ASS'Y
Ref. No. IC201RM IC401 IC402 IC403 IC551 IC552 IC603D IC604D IC605D IC651 IC652 IC653 IC654 IC663 Q201RM Q401 Q402 Q403 Q404 Q405 Q406 Q407 Q408 Q409 Q551 Q551SW Q552 Q552SW Q553 Q553T Q554 Q555 Q556 Q557C Q558C Q601D Q602D Q603D Q607 Q608 Q609 Q610 Q611 Q612 Part No. Part Name Remarks Ref. No. Q651 Q652 Q653 963 0043 700 IC LC72131 963 0043 904 IC LA1266 963 0044 000 IC LA3401 960 0174 502 IC NJM2068DD 963 0043 506 IC TC9184AP D403 963 0083 304 IC BA7626 963 0083 304 IC BA7626 960 0175 200 IC BA7625 963 0083 304 IC BA7626 963 0083 304 IC BA7626 963 0083 304 IC BA7626 963 0083 304 IC BA7626 963 0057 806 IC KIA78R05PI 269 0093 904 Transistor DTA144ES 960 0189 102 Transistor KTC3880S-O 269 0083 901 Transistor DTA114EK 269 0083 901 Transistor DTA114EK 269 0083 901 Transistor DTA114EK 960 0196 603 Transistor KTC2874B 960 0196 603 Transistor KTC2874B 963 0024 208 Transistor DTC114YK 269 0083 901 Transistor DTA114EK 960 0189 102 Transistor KTC3880S-O 960 0196 700 Transistor KTC3200BL 960 0196 603 Transistor KTC2874B 960 0196 302 Transistor KTA1268BL 960 0196 603 Transistor KTC2874B 269 0083 901 Transistor DTA114EK 960 0196 904 Transistor DTC114YS (NPN) 269 0046 906 Transistor DTA114ES 269 0046 906 Transistor DTA114ES 269 0083 901 Transistor DTA114EK 960 0217 003 Transistor 2SA1037KT 963 0024 208 Transistor DTC114YK 960 0005 105 Transistor KTA1266Y 960 0005 105 Transistor KTA1266Y 960 0005 105 Transistor KTA1266Y 963 0102 900 Transistor DTC114TK 963 0102 900 Transistor DTC114TK 963 0102 900 Transistor DTC114TK 963 0102 900 Transistor DTC114TK 963 0102 900 Transistor DTC114TK 963 0102 900 Transistor DTC114TK ZD401 960 0095 500 Zener diode MTZJ5.1B D901 D902 960 0197 000 Diode KDS160 960 0197 000 Diode KDS160 D601D D602D D651 D652 D653 D654 D655 D656 D657 D658 D659S 960 0197 000 Diode KDS160 960 0197 000 Diode KDS160 960 0197 000 Diode KDS160 960 0197 000 Diode KDS160 960 0197 000 Diode KDS160 960 0197 000 Diode KDS160 960 0197 000 Diode KDS160 960 0197 000 Diode KDS160 963 0058 407 Diode IN4007 963 0058 407 Diode IN4007 963 0096 508 Diode 1N4148 for E2,EK D551 D551T D552 D553 D554 D555 D556 D557 D558 D559 D560 D561 D562 D563 D564 D565 D566 D567 D568C D569C D570C 963 0096 508 Diode 1N4148 963 0096 508 Diode 1N4148 963 0096 508 Diode 1N4148 963 0096 508 Diode 1N4148 963 0096 508 Diode 1N4148 963 0096 508 Diode 1N4148 963 0096 508 Diode 1N4148 963 0096 508 Diode 1N4148 963 0096 508 Diode 1N4148 963 0096 508 Diode 1N4148 963 0096 508 Diode 1N4148 963 0096 508 Diode 1N4148 963 0058 407 Diode IN4007 963 0058 407 Diode IN4007 963 0096 508 Diode 1N4148 960 0095 500 Zener diode MTZJ5.1B 963 0096 508 Diode 1N4148 963 0096 508 Diode 1N4148 963 0096 508 Diode 1N4148 963 0096 508 Diode 1N4148 963 0096 508 Diode 1N4148 D404 D405 D406 960 0197 000 Diode KDS160 963 0096 508 Diode 1N4148 963 0096 508 Diode 1N4148 963 0096 508 Diode 1N4148 Q654 Q655 Q656 D201RM Part No. Part Name Remarks SEMICONDUCTORS GROUP 960 0174 104 IC CXA1511M 960 0005 105 Transistor KTA1266Y 960 0005 105 Transistor KTA1266Y 960 0005 105 Transistor KTA1266Y 960 0005 105 Transistor KTA1266Y 960 0005 105 Transistor KTA1266Y 960 0005 105 Transistor KTA1266Y 960 0095 704 Zener diode MTZJ6.2B
42
AVR-1803/883
Ref. No. R201RM R202RM R203RM R204RM R205RM R206RM R401 R403 R404 R405 R406 R407 R407 R408 R408 R409 R411 R412 R413 R414 R415 R416 R417 R418 R420 R426