Text preview for : CTX 310 - 320 Rev.pdf part of AIWA CT-X310 car audio (18 pag) mod. X320, X325, X4100, X4150, X410, X420.
Back to : 310 .part1.rar | Home
CT-X420 YU(ST) CT-X410 YU(ST) CT-X4150YL(ST) CT-X4100YL(ST) CT-X325 YVJ(ST) CT-X320 YZ(ST),YVJ(ST) CT-X310 YZ(ST)
SERVICE MANUAL
STEREO CAR CASSETTE RECEIVER BASIC TAPE MECHANISM : CDS-363AG1-A This Service Manual is the "Revision Publishing" and replaces "Simple Manual" CT-X420 YU(ST)/X410 YU(ST)(S/M Code No.09-003-339-2T1), CT-X310 YZ(ST)/X325 YVJ(ST)/X320 YZ(ST),YVJ(ST)/X4100 YL(ST)/X4150 YL(ST) (S/M Code No.09-003-339-1T2).
RE
S/M Code No. 09-003-339-2R1
DA TA
VI
SIO
N
SPECIFICATIONS
RADIO SECTION (FM)
Frequency Range: 87.5 MHz108 MHz (100-kHz steps) 87.5 MHz108 MHz [Except YV] 65 MHz74 MHz [YV] (50-kHz steps) 12.7 dBf 17.2 dBf 80 dB 30 Hz-15,000 Hz 63 dB 35 dB at 1 kHz 70 dB 3 dB
TAPE SECTION
Tape Speed: S/N Ratio: Frequency Response: Stereo Separation: FF/REW Time: 4.8 cm/sec. (17/8 ips) 50 dB 40 Hz14,000 Hz 40 dB 190 sec. (C-60)
AUDIO SECTION
Max. Power Output: 40 W x 4 channels
Usable Sensitivity: 50 dB Quieting Sensitivity: IF Rejection: Frequency Response: S/N Ratio: Stereo Separation: Alternate Channel Selectivity: Capture Ratio:
CD/MD IN input
Input sensitivity (load impedance) CD/MD IN: 300 mV (10 k)
GENERAL
14.4 V (11 to 16 V allowable), DC, negative ground Load Impedance: 4 Tone Control: Bass ± 10 dB at 100 Hz Treble ± 10 dB at 10 kHz Preamp Output Voltage (load impedance): 2.2 V (10 k) Installation size: 182(W) x 53(H) x 155(D) mm (71/4(W) x 21/8(H) x 61/8(D) inches) Power-Supply Voltage:
(AM(MW)) [YU]
Frequency Range: 530 kHz1,710 kHz (10-kHz steps) 531 kHz1,602 kHz (9-kHz steps) 30 µV (30 dB)
Usable Sensitivity:
(MW) [YZ, YV]
Frequency Range: 531 kHz1,620 kHz (9-kHz steps) 530 kHz1,710 kHz (10-kHz steps) 30 µV (30 dB)
· Design and specifications are subject to change without notice.
Usable Sensitivity:
(LW) [YZ, YV]
Frequency Range: Usable Sensitivity: 144 kHz288 kHz (1-kHz/9-kHz steps) 30 µV (30 dB)
ACCESSORIES LIST
REF. NO 1 1 1 1 1 2 2 2 2 3 4 5 6 7 8
PART NO.
KANRI NO. IB,YL(3L) IB,YU(3L) IB,YU(3L) IB,YV(ER) IB,YZ(9L)
DESCRIPTION 4100,4150 410 420 320 320
REF. NO 9 10 11 12 13
PART NO.
KANRI NO.
DESCRIPTION
8A-KTG-903-010 8A-KTG-902-010 8A-KTG-901-010 8A-KTG-906-010 8A-KTG-905-010 8A-KTG-904-010 8A-KTG-907-010 8A-KT5-902-010 8A-KT3-902-010 86-KT1-237-010 8Z-KT1-231-010 8Z-KT1-625-010 8Z-KT1-030-010 8Z-KT1-232-010 87-B10-141-010
8Z-KT1-251-010 88-KT1-247-010 88-KT1-250-010 8A-KTG-951-010 8Z-KTG-951-010
S-SCREW,5*6 TH+ TAPPING ST S-SCREW,HEXAGON S-SCREW,THIN HEAD+2.6-4 BLK SPKR,13CM ASSY SPKR,16CM ASSY UT1+5-15 W/O SLOT W,5.2-10-0.5 W-SPR,5.3-8.5-1.5
TYPE A B C D E F G H MODEL NAME CT-X420 CT-X410 CT-X310 CT-X325 CT-X320 CT-X320 CT-X4100 CT-X4150 SUFFIX YU YU YZ YV YZ YV YL YL
IB,INST,SP (3L,P)-A IB,INST,SP (ER)-A IB,INST,YU,YL (3L,P) IB,INST,YZ (9L)-A HLDR,REAR MTG HLDR,HALF -T CONN ASSY,16P SOC016 CASE,DFP -T KEY,REMOVE -T NUT,5 TYPE-2
14 87-B10-143-010 15 87-B10-144-010 16 87-B10-145-010
2
ELECTRICAL MAIN PARTS LIST
REF. NO IC
PART NO.
KANRI NO.
DESCRIPTION
REF. NO C304 C305 C306 C307 C308 C309 C310 C311 C312 C313 C314 C315 C316 C401 C402 C403 C404 C405 C406 C407 C408 C409 C410 C411 C412 C413 C414 C415 C416 C417 C418 C419 C420 C421 C422 C424 C425 C426 C451 C452 C501 C502 C503 C504 C505 C506 C507 C508 C601 C602 C603 C604 C605 C607 C608 C609 C610 C611 C612 C701 C702 C703 C705 C706 C707 C708 C709 C710 C711 C712
PART NO.
KANRI NO.
DESCRIPTION
8Z-KT1-622-010 8Z-KTG-622-010 87-A21-539-030 87-A21-191-010 87-A21-441-010 TRANSISTOR 89-423-953-010 87-A30-468-040 87-026-576-080 87-A30-470-040 87-A30-471-040 8Z-KTH-626-080 8Z-KTH-627-080 87-A30-476-010 87-A30-487-080 87-A30-295-010 87-A30-473-080 87-A30-475-080 8Z-KTH-623-080 87-A30-467-040 87-A30-469-040 87-A30-472-040 DIODE 87-020-465-080 87-A40-798-010 87-001-783-080 87-017-932-080 87-070-334-080 87-A40-337-080 87-A40-523-080 87-A40-830-040 87-020-585-080 87-A40-819-040 MAIN C.B ANT101 C101 C102 C103 C104 C105 C106 C109 C110 C111 C112 C119 C120 C121 C122 C123 C124 C201 C203 C204 C205 C208 C211 C213 C214 C215 C301 C302 C303 8Z-KT1-614-010 87-018-119-080 87-018-134-080 87-010-380-010 87-010-380-010 87-018-134-080 87-018-134-080 87-018-134-080 87-018-134-080 87-010-402-080 87-018-205-080 87-010-194-080 87-010-194-080 87-018-134-080 87-018-134-080 87-010-380-010 87-018-209-080 87-018-209-080 87-018-132-010 87-018-205-080 87-010-263-010 87-010-112-010 87-010-378-010 87-010-380-010 87-018-134-080 87-018-209-080 87-018-131-080 87-018-131-080 87-010-378-010
C-IC,LC75374E IC,TA8259H C-IC,TC9323F IC,KIA6225S C-IC,TC9297FB
87-010-378-010 87-010-263-010 87-010-263-010 87-012-365-080 87-012-365-080 87-010-401-010 87-010-401-010 87-010-263-010 87-010-401-010 87-010-401-010 87-010-380-010 87-A11-128-080 87-A11-128-080 87-010-380-010 87-010-196-080 87-010-401-010 87-010-401-010 87-010-401-010 87-010-401-010 87-010-184-080 87-010-184-080 87-010-198-080 87-010-198-080 87-010-378-010 87-010-378-010 87-A11-177-080 87-A11-177-080 87-A11-177-080 87-A11-177-080 87-010-378-010 87-010-378-010 87-010-401-010 87-010-401-010 87-010-401-010 87-010-401-010 87-010-378-010 87-010-196-080 87-010-196-080 87-010-401-010 87-010-401-010 87-010-378-010 87-010-378-010 87-010-378-010 87-010-378-010 87-010-175-080 87-010-175-080 87-010-175-080 87-010-175-080 87-016-083-080 87-016-083-080 87-016-083-080 87-016-083-080 87-018-209-080 87-A11-179-010 8Z-KT1-633-090 87-010-180-080 87-010-180-080 87-010-180-080 87-010-180-080 87-010-380-010 87-010-248-010 87-010-198-080 87-010-314-080 87-010-197-080 87-010-315-080 87-010-314-080 87-016-526-080 87-010-401-010 87-010-404-010 87-012-349-080
CAP, ELECT 10-16SME CAP, ELECT 100-10V CAP, ELECT 100-10V C-CAP,S 0.027-25VBK C-CAP,S 0.027-25VBK CAP, CAP, CAP, CAP, CAP, ELECT ELECT ELECT ELECT ELECT 1-50V 1-50V 100-10V 1-50V 1-50V
TR,2SD2395FY C-TR,KRC102S-RTK C-TR,DTC343TK C-TR,KTC3875SY-RTK C-TR,KTA1504SY-RTK TR,KTC3203Y TR,KTA1273Y TR,KTA1046Y TR,KRC111M-AT TR,KRA226M TR,KRC102M-AT TR,KRA104M-AT TR,KTA1267Y C-TR,KRA111S-RTK C-TR,KRC111S-RTK C-TR,KRA226S-RTK
CAP,E 47-16 SME CAP, CER 4700P CAP, CER 4700P CAP,E 47-16 SME CHIP CAPACITOR,0.1-25 CAP, CAP, CAP, CAP, CHIP CHIP CAP, CAP, CAP, CAP, ELECT 1-50V ELECT 1-50V ELECT 1-50V ELECT 1-50V CAPACITOR 3300P(K) CAPACITOR 3300P(K) CHIP 0.022 CHIP 0.022 ELECT 10-16SME ELECT 10-16SME
DIODE,1SS133 (110MA) DIODE,1N5402GW(3A/200V) DIODE,1N4002 ZENER,MTZJ6.2B ZENER,MTZJ10B ZENER,MTZJ 6.8B ZENER,MTZJ9.1B DIODE,KDS226-RTK CHIP-ZENER,02CZ6.2Y C-ZENER,STZ6.8T
C-CAP,S 0.15-16 K B C-CAP,S 0.15-16 K B C-CAP,S 0.15-16 K B C-CAP,S 0.15-16 K B CAP, ELECT 10-16SME CAP, CAP, CAP, CAP, CAP, CAP, CHIP CHIP CAP, CAP, ELECT ELECT ELECT ELECT ELECT 10-16SME 1-50V 1-50V 1-50V 1-50V
ELECT 10-16SME CAPACITOR,0.1-25 CAPACITOR,0.1-25 ELECT 1-50V ELECT 1-50V
ANT,AW-002 CAP, CER 100P-50V CAPACITOR,TC-U 0.01-16 CAP,E 47-16 SME CAP,E 47-16 SME CAPACITOR,TC-U 0.01-16 CAPACITOR,TC-U 0.01-16 CAPACITOR,TC-U 0.01-16 CAPACITOR,TC-U 0.01-16 CAP, ELECT 2.2-50V CAP, CERA-SOL 0.022 CAP, CHIP 0.047 CAP, CHIP 0.047 CAPACITOR,TC-U 0.01-16 CAPACITOR,TC-U 0.01-16 CAP,E 47-16 SME CAP, CER 0.1-50V CAP, CER 0.1-50V CAP CER CYL SS 2200P CAP, CERA-SOL 0.022 CAP, ELECT 100-10V CAP,ELECT 100-16V CAP, ELECT 10-16SME CAP,E 47-16 SME CAPACITOR,TC-U 0.01-16 CAP, CAP, CAP, CAP, CER 0.1-50V CER 1000P-50V CER 1000P-50V ELECT 10-16SME
CAP, ELECT 10-16SME CAP, ELECT 10-16SME CAP, ELECT 10-16SME CAP, ELECT 10-16SME CAP 560P CAP 560P CAP 560P CAP 560P C-CAP,S 0.15-16 RK C-CAP,S 0.15-16 RK C-CAP,S 0.15-16 RK C-CAP,S 0.15-16 RK CAP, CER 0.1-50V CAP,E 10-16-105 D5*L11 KMF CAP,E 3300U-16 PW C-CER C-CER C-CER C-CER CAP,E 1500P 1500P 1500P 1500P 47-16 SME
CAP, ELECT 100-10V CAP, CHIP 0.022 C-CAP,S 22P-50V CAP, CHIP 0.01 DM C-CAP,S 27P-50 CH C-CAP,S 22P-50V C-CAP,S 0.47-16 BK CAP, ELECT 1-50V CONDENSER 4.7-50 C-CAP,S 1000P-50 CH
3
REF. NO C713 C714 C715 C716 C717 C801 C802 C803 C804 C805 CN201 CN301 CN302 CN801 CNA201 CNA202 CNA301 CNA302 D806 F201 J501 J501 L101 L102 L201 L451 L701 L702 L801 S751 TUN101 TUN101 TUN101 X701
KANRI DESCRIPTION NO. 87-016-526-080 C-CAP,S 0.47-16 BK 87-016-526-080 C-CAP,S 0.47-16 BK 87-016-669-080 C-CAP,S 0.1-25 K B 87-016-669-080 C-CAP,S 0.1-25 K B 87-010-248-010 CAP, ELECT 100-10V 87-018-134-080 87-018-209-080 87-018-209-080 87-012-349-080 87-012-349-080 8Z-KT1-624-010 87-009-031-010 87-099-408-010 88-KTA-603-010 8A-KT1-631-010 8A-KT1-632-010 8Z-KTG-651-010 8Z-KTG-652-010 87-027-262-010 8Z-KC1-621-010 87-A61-225-010 87-A61-224-010 87-003-143-080 8Z-KT1-619-010 8Z-KT1-615-010 87-003-143-080 87-003-149-080 87-003-097-080 87-003-149-080 87-A91-152-010 8A-KC8-620-010 8A-KC8-621-010 8A-KTG-607-010 87-A70-175-010 CAPACITOR,TC-U 0.01-16 CAP, CER 0.1-50V CAP, CER 0.1-50V C-CAP,S 1000P-50 CH C-CAP,S 1000P-50 CH CONN,16P SOC017 CONNECTOR, 3P CONN,8P EH V WHT CONN,15P CAM-B68 CONN ASSY,8P ISO-BLACK-A CONN ASSY,8P ISO-WHITE-A CONN ASSY,3P HEAD CONN ASSY,8P MOTOR LEDE,TLR-124(RED) FUSE,15A 32V JACK,PIN 2P XR-401 JACK,PIN 4P XR-401 COIL 4.7 UH COIL,68MH K7-D FLTR,AMORPHOUS -CHOKE COIL 4.7 UH COIL,47UH COIL,1UH COIL,47UH SW,SL 1-1-2 SSSS212-11-A TU UNIT, TU UNIT, TU UNIT, VIB,XTAL FAE347-A11 FAE347-A12 FAE347-P10 4.5MHZ AT-49
PART NO.
REF. NO FRONT C.B C901 C902 CN901 D907 D908 D909 D910 D911 D912 LCD901 LCD901 PL901 PL902 S901 S902 S903 S904 S905 S906 S907 S908 S909 S910 S911 S912 S913 S915 S916 VR101 W901 AUX C.B J901
PART NO.
KANRI NO.
DESCRIPTION
87-012-358-080 87-010-197-080 88-KTA-602-010 87-017-827-070 87-017-827-070 87-017-827-070 87-A40-813-040 87-A40-813-040 87-A40-813-040 8A-KTG-612-010 8A-KTG-610-010 8A-KT7-655-010 8A-KT7-655-010 87-036-251-080 87-036-251-080 87-036-251-080 87-036-251-080 87-A90-001-080 87-036-251-080 87-036-251-080 87-036-251-080 87-036-251-080 87-036-251-080 87-A90-001-080 87-A90-001-080 87-036-251-080 87-A90-001-080 87-A90-001-080 87-A91-597-010 8A-KT9-611-010
C-CAP,S 0.47-10 F Z CAP, CHIP 0.01 DM CONN,15P CAM-B67 C-LED,SEC 1201C RED C-LED,SEC 1201C RED C-LED,SEC 1201C RED C-LED,SEC1E01C BLUE C-LED,SEC1E01C BLUE C-LED,SEC1E01C BLUE LCD,AKT-16-17 AUX LCD,AKT-16-17 LAMP,9V-50MA LAMP,9V-50MA SW,T CT 6X3.5 160 SW,T CT 6X3.5 160 SW,T CT 6X3.5 160 SW,T CT 6X3.5 160 C-SW,TACT SKQMAL SW,T CT 6X3.5 160 SW,T CT 6X3.5 160 SW,T CT 6X3.5 160 SW,T CT 6X3.5 160 SW,T CT 6X3.5 160 C-SW,TACT SKQMAL C-SW,TACT SKQMAL SW,T CT 6X3.5 160 C-SW,TACT SKQMAL C-SW,TACT SKQMAL SW,RTRY SIM-026MT F-CABLE,3P 50MM
87-A61-229-010
TYPE A B C D E F G H
JACK,3.5 BLK ST W/SW
SUFFIX YU YU YZ YV YZ YV YL YL
MODEL NAME CT-X420 CT-X410 CT-X310 CT-X325 CT-X320 CT-X320 CT-X4100 CT-X4150
CHIP RESISTOR PART CODE
Chip Resistor Part Coding
8 8
A
Resistor Code Value of resistor Chip resistor
Dimensions (mm)
Figure
Wattage 1/16W 1/16W 1/10W 1/8W
Type 1005 1608 2125 3216
Tolerance 5% 5% 5% 5%
Symbol CJ CJ CJ CJ
Form
L W
L 1.0
t
W 0.5 0.8 1.25 1.6
t 0.35 0.45 0.45 0.55
:A Resistor Code : A
104 108 118 128
1.6 2 3.2
4
TRANSISTOR ILLUSTRATION
IC BLOCK DIAGRAM-1
IC, TC9297FB
C
B E ECB KTC3203 ECB KRA104M KRA226M KRC102M KRC111M KTA1267 KTA1273 BCE 2SD2395 KTA1046 DTC343TK KRA111S KRA226S KRC102S KRC111S KTA1504 KTC3875
IC, LC75374E
5
6
SCHEMATIC DIAGRAM-1
M1
MTZJ9.1B
YZ/YV ONLY
7
8
WIRING-1
1 2 3 4 5 6 7 8 9 10 11 12 13
DIFFERENCE TABLE
14
[This table listes the different components marked with asterisks (*) in the MAIN CB]
Ref No. C214 C501 C502 C505 C506 CN201 CNA201 CNA202 D751 D754 D757 J501-2 Q212 R111 R217 R218 A A A A A A B C C D D E E F F G H
A
[YV,YZ]
B C C D D D D D D D D E E F F F
G
H
B
A A
B C C C C E E E E F F F F F
G
H
C
[YU,YL]
D
TYPE A B C D E F G H
MODEL NAME CT-X420 CT-X410 CT-X310 CT-X325 CT-X320 CT-X320 CT-X4100 CT-X4150
SUFFIX YU YU YZ YV YZ YV YL YL
E
F
G
1 80 5 75 70
H
20 24 25
10 15
65 64
60 55 30 35 45 40 41 50
I
J
9
10
SCHEMATIC DIAGRAM-2
LAMPE+B
5.4/0.9 5.4/0.9 5.4/0.9 5.4/0.9 0/0.9 0/0.9 0/0.9 0/0.9
5.4 2.1/0 0 2.7 5.4 5.4
VDD
11
12
WIRING-2
1 2 3 4 5 6 7
A
B
6
5
4
3
2
1 A A
1
2
3
4
5
6
C
B B
C C
D
D D
E E
E
F F
F
G G
35 40
30 25 20
45
H H
55 60 5 10
G
I
I
J J
H
K K
L L
I
2 3 1
M M
N N
J
13
IC BLOCK DIAGRAM-2
IC, KIA6225S
IC, TA8259H
14
IC DESCRIPTION IC, TC9323F
Pin No. 1~4 5 6 7 8 9 10 11 12 Pin Name N.C
_______
I/O O O O O O O O Not connected. MS signal output Not connected. Standby muting output Muting output to power amp Loudness output
Description
APS N.C S-MUTE
______________
P-MUTE LOUD LOCAL MONO 20dB MUTE
Local/DX switching output. LOCAL: "H", DX: "L" MONO/STEREO switching output. MONO: "H", STEREO: "L" -20dB muting output. This function is enabled when the -20dB muting jumper is selected.
13 14 15 16
AGC CUT/IF REQ RADIO TAPE CD
O O O O
Outputs "H" during searching of frequency. This is an IF count control signal or used to shut off the AGC circuit. RADIO output TAPE output CD output Band switching outputs
17
BAND 1
O FM MW LW FM (L)
BAND1 H L L H
BAND2 L L H H
18
BAND 2
O
19 ~ 21 22 23 24 ~ 33 34 ~ 37 38 ~ 45 46 47 48 49 50 51 52 53 54 55 56
N.C RE1 RE2 N.C K0 ~ K3 T0 ~ T7 TAPE CD PANEL POWER PHONE MUTE LEVEL METER DIR FF/REW E-VOL DATA E-VOL CK E-VOL CE
I I I O I I I O I I I
Not connected Rotary encoder input 1 Rotary encoder input 2 Not connected Key matrix inputs Diode matrix outputs TAPE input CD input. "H" CD input enables the CD key. Detects detachable panel (0.2-0.5 s chattering time is provided). Panel provided: "H", Panel not provided: "L" Power output The telephone signal automatically applies muting. The signal level is converted to a digital signal. This meter signal moves the LCD level bar according to the level. TAPE running direction indicator input TAPE FF/REW indicator input
O
Pins to control the LC75374E electronic VR.
15
Pin No. 57
Pin Name V-REF
I/O I Reference voltage pin
Description
This function is enabled when the ACC input is "L" and PANEL input is "L". "H" 58 LED FLASH O causes flashing for 0.1 s and "L" causes 0.9 s flashing. This output is disabled when the LED FLASH jumper is "H". 59 60 61 62 63 64 65 66 67 68 69 70, 71 72 73 74 75 76 77 78 79 80 DATA CLK CE BEEP T-MUTE REMO-IN INTR 2 TEST HOLD SD-IN IF-IN DO1, DO2 GND FMIN AMIN VDD
_____________
I/O O O O O I I I I I I O I I O I GND For the connection of a crystal oscillator Buzzer output Tuner muting output Interrupt of remote control signal Not used. Test mode control input Monitors that the power is turned on with ignition switched on. SD signal input IF signal input DO outputs GND FM/AM local oscillator signal input VDD terminal Reset input For communications with LCD driver and key input IC TC9297F.
RESET XOUT XIN VXT GND
16
LCD DISPLAY
Parts No. 8A-KTG-610-010 [Except for CT-X320YV] Parts No. 8A-KTG-610-010 [CT-X320YV]
17
18
MECHANICAL EXPLODED VIEW 1/1
42 7 10 11 CSD-363AG1-A 1314 B 17
9 8 12 6 4 15 19 18 20 21 C C 24 C 40 30 A FRONT C.B 29 B 27 LCD901 26 A D C AUX C.B 28 B CHAS,SIDE R-T 334 33 31 32 B 38 SH,PWB C B 39 MAIN C.B 35 CHAS,FRONT S C 45 36 37 CHAS,SIDE L-T B B HT-SINK C C E F C 44(A,B,G,H only) C 43 25 5 16 41 C
C
44 (C.D.E.F only)
2 1 3 5 22
23
46
19
20
MECHANICAL MAIN PARTS LIST 1/1
REF. NO 1 2 3 3 3 3 3 3 3 4 4 5 5 6 7 8 8 9 10 11 12 13 14 15 16 17 18 19 20 20 21 21 22 22 23
KANRI DESCRIPTION NO. 8A-KTF-020-010 KNOB,RTRY NON RUBBER 8A-KT5-021-010 RING,RTRY A 8A-KTG-017-010 WINDOW,LCD X310 8A-KTG-010-010 WINDOW,LCD X320 8A-KTG-016-010 WINDOW,LCD X325 8A-KTG-005-010 8A-KTG-006-010 8A-KTG-007-010 8A-KTG-002-010 8A-KT4-011-010 8A-KTF-004-010 8A-KT4-010-010 8A-KTF-005-010 8A-KTG-001-010 8A-KTF-013-010 8A-KT5-012-010 8A-KT4-005-010 8A-KT5-210-010 8A-KTF-010-010 8Z-KTA-226-010 8A-KTG-003-010 8A-KTF-205-010 8A-KTF-012-010 8A-KTF-011-010 87-KTE-205-010 8A-KTG-004-010 8A-KTF-015-010 8Z-KTA-223-010 8A-KT5-013-010 8A-KT4-007-010 8A-KT5-014-010 8A-KT4-009-010 8A-KT5-016-010 8A-KTG-015-010 8A-KT5-015-010 WINDOW,LCD X410 WINDOW,LCD X4100 WINDOW,LCD X4150 WINDOW,LCD X420 WINDOW,L 4 WINDOW,L F WINDOW,R 4 WINDOW,R F CABI,FRONT G BTN,FNC F BTN,PWR BTN,PWR 4 HLDR,BTN MU BTN,EJECT F SPR-C,EJECT BTN,UP/DN G LENS,ENCO F BTN,REW F BTN,FF F SPR-C,EJ/FF/REW BTN,P.SET G BTN,DETACH SPR-C,RELEASE -T10 BTN,DISP BTN,SEL 4 BTN,A/M BTN,PS 4 BTN,INFO BTN,INFO G BTN,LO
PART NO.
REF. NO 24 25 26 27 28 29 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 44 45 46 A B C D E
KANRI NO. 8A-KT5-211-010 HLDR,BTN 8A-KTF-206-010 LENS,R F 8A-KTG-201-010 HLDR,LCD 8A-KTG-203-010 LENS,LCD 8A-KTG-202-010 CASE,LCD 8Z-KT1-239-0100 8Z-KTG-209-010 8A-KTF-002-010 8A-KTF-003-010 8Z-KT1-231-010 8Z-KTA-203-010 8Z-KTA-221-010 8A-KTF-014-010 8Z-KT1-244-010 8Z-KT1-023-110 8Z-KTA-204-110 8Z-KTA-222-010 8A-KT5-204-010 8A-KTF-202-010 8Z-KT1-211-010 8Z-KT4-201-010 8Z-KT5-201-010 8A-KT5-219-010 8A-KTF-201-010 8Z-KT1-212-010 8Z-KT1-253-010 88-KT1-250-010 87-251-073-410 87-432-903-010 87-251-097-410
PART NO.
DESCRIPTION DISP G G G
CAP,LAMP BLU B CAP,LAMP ORN CABI,REAR F CABI,TRIM F HLDR,HALF -T LEVER,DFP LOCK -T10 SPR-C,DETACH LOCK-T10 CABI,BASE F SPR-T,DOOR Z DOOR,CASS LEVER,DEF HOOK -T10 SPR-T,DETACH LOCK-T10 HLDR,TR HLDR,DECK F COVER, TOP -T COVER, CD BLIND -T COVER, ISO BLIND -T HLDR,ISO-WIRE 5 HLDR,IC F COVER, BOTTOM -T S-SCREW,PT 2*8 BH+ BLK S-SCREW,THIN HEAD+2.6-4 BLK SCREW,U+2.6-6 WASHER,WTE 2.6 U+3-12 UT2+3.0-10.0 W/O SLOT (BH TAP)
F 87-B10-259-010
TYPE A B C D E F G H
MODEL NAME CT-X420 CT-X410 CT-X310 CT-X325 CT-X320 CT-X320 CT-X4100 CT-X4150
SUFFIX YU YU YZ YV YZ YV YL YL
COLOR NAME TABLE
Basic color symbol Color Basic color symbol Color Basic color symbol Color B Black C Cream D Orange G Green H Gray L Blue LT Transparent Blue N Gold P Pink R Red S Silver ST Titan Silver T Brown V Violet W White WT Transparent White Y Yellow YT Transparent Yellow LM Metallic Blue LL Light Blue GT Transparent Green LD Dark Blue DT Transparent Orange
21
MECHANISM EXPLODED VIEW 1/1
8 A 9 7 11
C D A 24 12 13 14 25
5
6
15 26 B E B 17 10 F F 18 19 20 A 29 21 30 31 A 1 73 I 22 23 33 34 32 H G 28 C 27 E E 25 16
4
3 2
35 40 39 38 N 41 42 68 67 69 66 65 64 63 72 62 5 C 61 C 57 57 58 M 60 M M 59 51 50 52 49 A I 71 54 53 70 55 56 45 I 48 47 46 M M 44 73 43 L J J 37 K 36
22
MECHANISM MAIN PARTS LIST 1/1
REF. NO 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 39 40 42 42 44 45
KANRI DESCRIPTION NO. S1-013-810-100 HOLDER CASS(X) SX-003-610-190 EJECT CAM LOCK ASSY S1-003-220-070 TAPE HOOKER S1-013-810-020 HANGER CASS(X) S1-003-640-070 EJECT CAM LOCK SPG S1-003-640-230 S1-003-610-180 S1-036-350-070 S1-003-670-570 S1-036-330-420 S1-003-630-320 S1-003-610-150 S1-003-640-100 S1-003-640-110 S1-036-370-040 S1-013-820-053 S1-013-810-060 S1-003-820-180 S1-036-320-060 SX-036-310-020 S1-003-640-060 SX-036-310-040 S1-003-640-170 S1-003-610-510 S1-003-640-010 S1-003-610-530 S1-003-610-290 S1-003-640-020 S1-003-610-230 S1-036-330-110 S1-003-640-080 SX-036-360-020 S1-036-350-030 SX-036-360-030 SX-036-360-050 S1-036-340-030 S1-036-370-010 S1-036-370-050 S1-003-620-030 S1-036-340-050 S1-003-610-070 S1-036-310-030 S1-036-340-060 S1-036-370-020 S1-005-820-215 CENTER PLATE SPG(B) PLATE CENTER RETURN LINK MOTOR MOTOR PULLEY(MBC) ROLLER FF(A) PLATE SPG SUPPORT ADJUSTER ARM SPG(A) ADJUSTER ARM SPG(B) HEAD ADJUSTER ARM BLUE ADJUSTER SHIM(X) GUIDE TAPE LINK ADJUSTER(B) HEAD PLATE ASSY PLATE SPG HEAD FR CONVRT ARM ASSY(A) SW SELECT ARM SPG LEVER FF(AT) LEVER SPG FF/REW LEVER REW(AT) ARM LOCK(A) LEVER SPG LOCK LEVER CHANG(B) ROLLER PROGRAM ARM SPG PROGRAM LEVER BRACKET ASSY SELECTOR LINK(B) TU GEAR ARM ASSY PINCH ARM ASSY(F) PINCH ARM SPG(F) SW,MUTE SW POWER GEAR REDUCTION(B) LEVER SPG EJECT LEVER EJECT CAM EJECT CAM SPG EJECT SW,SLLLLLIDE IDLE PULLEY(A)
PART NO.
REF. NO 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 70 71 72 73 A B C D E F G H I J
KANRI DESCRIPTION NO. S1-036-360-100 FLYWHEEL ASSY(F) CPL S1-036-360-110 FLYWHEEL ASSY(R) CPL S1-003-650-040 BELT MAIN S1-003-610-260 ARM FR(B) S1-036-320-030 GEAR PULLEY S1-036-350-010 SX-036-360-040 S1-036-340-040 SX-036-320-050 SX-036-360-060 S1-013-840-010 SX-036-360-010 S1-003-620-140 S1-003-640-150 S1-003-620-100 S1-003-630-180 S1-003-640-030 S1-003-820-140 S1-003-840-140 S1-003-620-070 S1-003-620-040 S1-003-620-010 S1-003-620-090 S1-036-330-070 S2-171-200-501 S2-103-200-25C S1-003-650-240 S2-101-200-40C S1-013-850-020 S2-103-200-70C S2-171-250-601 S2-133-200-40C S2-181-200-30D S2-181-600-32E BELT SUB PINCH ARM ASSY(R) PINCH ARM(R) REEL SPINDLE ASSY DETECTOR CAM ASSY(V) BACK REEL GEAR DASH GEAR TENSION SPG BASE ASSY DETECTR SPG SELECTOR
PART NO.
COLLER(SELECTOR GEAR) GEAR LOCK ARM SPG GEAR LOCK ARM RATCHET SPG RATCHET GEAR REDUCTION(A) GEAR IDLE ARM SENSOR ROLLER HP(A) E-RING 2 SCREW,M2-2.5 PSW(REEL)B 1.5-3.2-0.25 SCREW,M2-4 SCREW,M2-5 SCREW,M2-7 E-RING 2.5 SCREW,S-TYPE M2-4 PSW-S 1.2-3.0-0.25 LMW-S 1.6-3.2-0.35 SCREW,S-TYPE M1.7-4 SCREW,B-TYPE M2-3 SCREW,S-TYPE M1.7-6
K S2-133-170-40C M S2-138-200-30C N S2-133-170-60C
23
211, IKENOHATA 1CHOME, TAITO-KU, TOKYO 110-8710, JAPAN TEL:03 (3827) 3111
931196 Printed in Singapore