Text preview for : CTFRV 735 Rev.pdf part of AIWA CT-FR707 car audio (26 pag) - mech. CDS-801AW1 - mod. FR710, FRV715, FX730M, FX930M, FRV735M, FR730M, FR930M.
Back to : 735.part1.rar | Home
CT-FR930M CT-FR730M CT-FRV735M CT-FR707 CT-FR710 CT-FRV715 CT-FX930M CT-FX730M
YZ YZ YZ YZ YZ YZ YU YH YU YH
SERVICE MANUAL
STEREO CAR CASSETTE RECEIVER BASIC TAPE MECHANISM : CDS-801AW1
This Service Manual is the "Revision Publishing" and replaces "Simple Manual" (S/M Code No. 09-003-342-9T1).
RE
S/M Code No. 09-003-342-9R1
VI
DA TA
SIO
N
SPECIFICATIONS
RADIO SECTION (FM)
Frequency Range [YZ]: Frequency Range [YH,YU]: 87.5 MHz108 MHz (50-kHz steps) 87.5 MHz-108 MHz (50-kHz steps) 87.5 MHz108 MHz (100-kHz steps) 12.7 dBf 17.2 dBf 80 dB 30 Hz-15,000 Hz 63 dB 35 dB at 1 kHz 70 dB 3 dB
TAPE SECTION
Tape Speed: S/N Ratio (normal): S/N Ratio (metal): [CT-FR930M,FX930M] Frequency Response: Stereo Separation: FF/REW Time: 4.8 cm/sec. (17/8 ips) 50 dB DOLBY-NR OFF 54 dB DOLBY-NR ON 64 dB 40 Hz14,000 Hz (normal) 40 Hz16,000 Hz (metal) 40 dB 95 sec. (C-60)
Usable Sensitivity: 50 dB Quieting Sensitivity: IF Rejection: Frequency Response: S/N Ratio: Stereo Separation: Alternate Channel Selectivity: Capture Ratio:
AUDIO SECTION
Max. Power Output: 45 W x 4 channels
AUX IN INPUT
Input Sensitivity (Load impedance) AUX IN: 300 mV (10 k)
(MW) [YZ]
Frequency Range: Usable Sensitivity: 531 kHz1,602 kHz (9-kHz steps) 30 µV (30 dB)
GENERAL
Power-Supply Voltage: 14.4 V (11 to 16 V allowable), DC, negative ground Load Impedance: 4 Tone Control: Bass ±10 dB at 100 Hz Treble ±10 dB at 10 kHz Preamp Output Voltage (load impedance): 2.2 V (10 k) [YZ] 4.0 V (10 k) [YU,YH] Installation size: 182(W) x 53(H) x 155(D) mm (71/4(W) x 21/8(H) x 61/8(D) inches)
(AM(MW)) [YH, YU]
Frequency Range: 530 kHz1,710 kHz (10-kHz steps) 531 kHz1,620 kHz (9-kHz steps) 30 µV (30 dB)
Usable Sensitivity:
(LW) [YZ]
Frequency Range: Usable Sensitivity: 144 kHz288 kHz (1-kHz/9-kHz steps) 30 µV (30 dB)
Steering-wheel-mounted remote control unit
Dimensions: approx. 67(W) x 26(H) x 27(D) mm (23/4(W) x 11/16(H) x 11/8 (D) inches) (excluding holder, battery) approx. 38 g (1.33 oz.) (including holder, battery)
· ·
·
Design and specifications are subject to change without notice. Dolby noise reduction manufactured under license from Dolby Laboratories Licensing Corporation. "DOLBY", and the double-D symbol are trademarks of Dolby Laboratories Licensing Corporation.
ACCESSORIES LIST
REF. NO 1 1 1 1 1 1 2 2 2 3 4 5 6 7 8 9 10 11 12 13
KANRI DESCRIPTION NO. 8A-KT1-901-010 IB,YZ(9L) FR930M 8A-KT3-901-010 IB,YZ(9L) FR730M,FRV735M 8A-KT3-901-010 IB,YZ(9L) FR730M,FRV735M 8A-KT5-901-010 IB,YU(3L) 930M 8A-KT5-907-010 IB,YH(E CK CH A) 930M 8A-KT7-901-010 8A-KT3-902-010 8A-KT5-902-010 8A-KT5-908-010 R8-AZR-190-040 8Z-KT1-625-010 86-KT1-237-010 87-B10-141-010 87-B10-143-010 87-B10-144-010 88-KT1-247-010 8Z-KT1-231-010 8Z-KT1-232-010 8Z-KT1-251-010 8Z-KT1-030-010 IB,YU(3L) 730M IB,INST,YZ (9L)-A IB,INST,YU,YL (3L,P) IB,INST,YH,Y (E CK CH A)-A AZR-1 RCKCGNF CONN ASSY,16P SOC016 HLDR,REAR MTG NUT,5 TYPE-2 UT1+5-15 W/O SLOT W,5.2-10-0.5 S-SCREW,HEXAGON HLDR,HALF -T KEY,REMOVE -T S-SCREW,5*6 TH+ TAPPING ST CASE,DFP -T
PART NO.
REF. NO 14 15 16 17 18
KANRI DESCRIPTION NO. 88-KT1-250-010 S-SCREW,THIN HEAD+2.6-4 BLK 87-B10-145-010 W-SPR,5.3-8.5-1.5 88-KC4-255-010 S-SCREW,HEX-SOC+3-3.5 BLK 88-KC4-257-010 KEY,HEXAGON WRENCH 88-KC4-057-010 BELT, HRC HLDR,BELT HRC
PART NO.
19 88-KC4-053-010
TYPE
MODEL NAME SUFFIX
A B C D E F G H I J
CT-FR930M CT-FR730M CT-FRV735M CT-FR707 CT-FR710 CT-FRV715 CT-FX930M CT-FX930M CT-FX730M CT-FX730M
YZ YZ YZ YZ YZ YZ YU YH YU YH
2
ELECTRICAL MAIN PARTS LIST
REF. NO IC
PART NO.
KANRI NO.
DESCRIPTION
REF. NO C112 C112 C113 C114 C115 C116 C117 C118 C119 C120 C301 C302 C401 C402 C501 C502 C503 C504 C505 C506 C507 C508 C509 C510 C511 C512 C513 C514 C515 C516 C517 C518 C519 C520 C521 C522 C523 C524 C525 C526 C527 C528 C529 C530 C531 C601 C602 C603 C604 C605 C606 C607 C608 C609 C610 C611 C612 C613 C614 C615 C616 C617 C618 C619 C620 C621 C622 C623 C624 C625
PART NO.
KANRI NO.
DESCRIPTION
87-A20-233-010 87-002-394-010 87-A21-538-010 8Z-KT1-622-010 87-A21-562-010 87-A21-531-030 87-A21-594-030 87-A21-530-030 87-002-689-080 87-A21-532-030 88-KT1-608-010 87-A90-951-010 88-KT1-607-080 87-001-611-080 TRANSISTOR 87-A30-468-040 87-A30-470-040 87-A30-471-040 87-A30-469-040 87-A30-295-010 87-A30-472-040 87-026-576-080 87-A30-467-040 8Z-KTH-627-080 87-A30-476-010 87-A30-063-080 8Z-KTH-626-080 87-A30-483-040 89-423-953-010 DIODE 87-020-465-080 87-A40-350-080 87-A40-504-040 87-017-932-080 87-A40-829-040 87-A40-830-040 87-001-783-080 87-A40-250-080 87-A40-819-040 87-020-590-080 87-027-262-010 87-020-585-080 87-020-583-080 87-A40-337-080 87-070-022-010 87-070-334-080 87-A40-869-080 87-017-931-080 87-A40-523-080 87-A40-814-080 MAIN C.B C101 C102 C103 C104 C105 C106 C107 C108 C109 C110 C111 C111 87-010-322-080 87-010-197-080 87-010-322-080 87-010-186-080 87-010-490-040 87-010-198-080 87-010-553-040 87-010-196-080 87-010-553-040 87-010-194-080 87-010-213-080 87-010-198-080
C-IC,HA12192F IC,LB1641 IC,KIA2025P C-IC,LC75374E IC,LA4743B C-IC,UPD178006A-XXX C-IC,UPD178016AGC-559-3B9 C-IC,UPD178018A-XXX IC,NJM2072M C-IC,LC75817W-8720 C-IC,LC75854W RCR UNIT,SBX1971-52 C-IC,SAA6579T IC,NJM3403M
87-010-213-080 87-010-198-080 87-010-194-080 87-010-194-080 87-010-197-080 87-010-495-080 87-010-197-080 87-010-197-080 87-010-553-040 87-010-196-080 87-010-494-040 87-010-494-040 87-010-494-040 87-010-494-040 87-010-494-040 87-010-494-040 87-010-494-040 87-010-494-040 87-010-184-080 87-010-184-080 87-010-198-080 87-010-198-080 87-010-498-040 87-010-498-040 87-A11-177-080 87-A11-177-080 87-A11-177-080 87-A11-177-080 87-010-498-040 87-010-498-040 87-010-555-040 87-010-498-040 87-010-196-080 87-010-494-040 87-010-805-080 87-010-805-080 87-010-805-080 87-010-494-040 87-016-526-080 87-016-526-080 87-016-526-080 87-010-196-080 87-012-141-080 87-012-141-080 87-010-178-080 87-A11-177-080 87-A11-177-080 87-A11-177-080 87-A11-177-080 87-010-180-080 87-010-180-080 87-010-180-080 87-010-180-080 87-010-068-040 87-010-552-040 87-010-198-080 8Z-KT1-633-000 87-010-553-040 87-010-196-080 87-010-196-080 87-010-196-080 87-010-196-080 87-010-322-080 87-010-322-080 87-010-322-080 87-010-322-080 87-010-322-080 87-010-322-080 87-010-322-080 87-010-322-080
C-CAP,S 0.015-50 B C-CAP,S 0.022-25 KB CAP, CHIP 0.047 CAP, CHIP 0.047 CAP, CHIP 0.01 DM CAP,E2.2-50 CAP, CHIP 0.01 DM CAP, CHIP 0.01 DM CAP,E 47-16 GAS CHIP CAPACITOR,0.1-25 CAP,E CAP,E CAP,E CAP,E CAP,E 1-50 1-50 1-50 1-50 1-50 GAS GAS GAS GAS GAS
C-TR,KRC102S-RTK C-TR,KTC3875SY-RTK C-TR,KTA1504SY-RTK C-TR,KRC111S-RTK TR,KRA226M C-TR,KRA226S-RTK C-TR,DTC343TK C-TR,KRA111S-RTK TR,KTA1273Y TR,KTA1046Y C-TR,KRA104S TR,KTC3203Y C-TR,KRC114S TR,2SD2395F
CAP,E 1-50 GAS CAP,E 1-50 GAS CAP,E 1-50 GAS CHIP CAPACITOR 3300P(K) CHIP CAPACITOR 3300P(K) CAP, CHIP 0.022 CAP, CHIP 0.022 CAP,E 10-16 GAS CAP,E 10-16 GAS C-CAP,S 0.15-16 K B C-CAP,S 0.15-16 K B C-CAP,S 0.15-16 K B C-CAP,S 0.15-16 K B CAP,E 10-16 GAS CAP,E 10-16 GAS CAP,E 100-10 SRE CAP,E 10-16 GAS CHIP CAPACITOR,0.1-25 CAP,E 1-16 GAS CAP, S 1-16 CAP, S 1-16 CAP, S 1-16 CAP,E 1-50 GAS C-CAP,S 0.47-16 BK C-CAP,S 0.47-16 BK C-CAP,S 0.47-16 BK CHIP CAPACITOR,0.1-25 CHIP-CAPACITOR,0.22-16F CHIP-CAPACITOR,0.22-16F CHIP CAP 1000P C-CAP,S 0.15-16 C-CAP,S 0.15-16 C-CAP,S 0.15-16 C-CAP,S 0.15-16 C-CER 1500P C-CER C-CER C-CER CAP E CAP,E K K K K B B B B
DIODE,1SS133 (110MA) ZENER,MTZJ 4.7C C-DIODE,KDS184 ZENER,MTZJ6.2B DIODE,KDS196-RTK DIODE,KDS226-RTK DIODE,1N4002 C-DIODE,DAN217 C-ZENER,STZ6.8T C-ZENER,02CZ10Y LEDE,TLR-124(RED) CHIP-ZENER,02CZ6.2Y CHIP-ZENER,02CZ5.1Y ZENER,MTZJ 6.8B DIODE,IN5402 (RECT) ZENER,MTZJ10A C-ZENER,02CZ11X ZENER,MTZJ5.6B ZENER,MTZJ9.1B LED,SEL2E10C BLUE
1500P 1500P 1500P 0.22-50 5L 22-16 GAS
C-CAP,S 100P-50 CH CAP, CHIP 0.01 DM C-CAP,S 100P-50 CH CAP,CHIP 4700P CAP, ELECT 0.1-50 CAP, CHIP 0.022 CAP,E 47-16 GAS CHIP CAPACITOR,0.1-25 CAP,E 47-16 GAS CAP, CHIP 0.047 C-CAP,S 0.015-50 B C-CAP,S 0.022-25 KB
CAP, CHIP 0.022 CAP,E 3300U-16 105 PW CAP,E 47-16 GAS CHIP CAPACITOR,0.1-25 CHIP CAPACITOR,0.1-25 CHIP CAPACITOR,0.1-25 CHIP CAPACITOR,0.1-25 C-CAP,S 100P-50 CH C-CAP,S 100P-50 CH C-CAP,S 100P-50 CH C-CAP,S C-CAP,S C-CAP,S C-CAP,S C-CAP,S 100P-50 100P-50 100P-50 100P-50 100P-50 CH CH CH CH CH
3
REF. NO C626 C701 C702 C703 C704 C705 C707 C708 C709 C710 C711 C712 C713 C714 C801 C802 C803 C804 C805 C806 C807 C808 C809 C810 C901 C902 C903 C904 C905 C906 C1107 C1201 C1202 C1203 C1204 C1205 C1206 C1207 C1208 C1209 C1210 C1211 C1212 C1213 C1214 C1215 C1216 C1217 C1218 C1219 C1301 CN801 CN1101 CN1102 CNA201 CNA251 CNA801 CNA802
KANRI DESCRIPTION NO. 87-010-196-080 CHIP CAPACITOR,0.1-25 87-010-490-040 CAP, ELECT 0.1-50 87-010-196-080 CHIP CAPACITOR,0.1-25 87-010-314-080 C-CAP,S 22P-50 CH 87-010-315-080 C-CAP,S 27P-50 CH 87-010-196-080 87-016-039-090 87-010-322-080 87-010-322-080 87-010-178-080 87-010-197-080 87-010-197-080 87-010-197-080 87-010-197-080 87-010-182-080 87-010-182-080 87-010-196-080 87-010-552-040 87-010-555-040 87-010-935-040 87-010-197-080 87-010-197-080 87-010-553-040 87-010-198-080 87-010-497-040 87-010-553-040 87-A10-189-040 87-010-495-040 87-010-497-040 87-010-194-080 87-010-197-080 87-010-805-080 87-010-805-080 87-010-805-080 87-010-805-080 87-010-805-080 87-010-805-080 87-010-805-080 87-010-805-080 87-010-805-080 87-010-805-080 87-010-805-080 87-010-805-080 87-012-140-080 87-012-140-080 87-012-140-080 87-012-140-080 87-010-112-040 87-010-555-040 87-010-322-080 87-010-198-080 8Z-KT1-624-010 8Z-KTH-613-010 8Z-KTH-613-010 8A-KT7-651-010 8A-KT5-661-010 8A-KT1-631-010 8A-KT1-632-010 CHIP CAPACITOR,0.1-25 CAP,DL 0.022F-5.5 Z 70 FM C-CAP,S 100P-50 CH C-CAP,S 100P-50 CH CHIP CAP 1000P CAP, CHIP 0.01 DM CAP, CHIP 0.01 DM CAP, CHIP 0.01 DM CAP, CHIP 0.01 DM C-CAP,S 2200P-50 B C-CAP,S 2200P-50 B CHIP CAPACITOR,0.1-25 CAP,E 22-16 GAS CAP,E 100-10 GAS CAP,E 220-16 M VR CAP, CHIP 0.01 DM CAP, CHIP 0.01 DM CAP,E 47-16 GAS CAP, CHIP 0.022 CAP,E 4.7-35 GAS CAP,E 47-16 GAS CAP,E 220-10 CAP,E 2.2-50 GAS CAP,E 4.7-35 GAS CAP, CHIP 0.047 CAP, CAP, CAP, CAP, CAP, CAP, CAP, CAP, CAP, CAP, CHIP 0.01 DM S 1-16 S 1-16 S 1-16 S 1-16 S S S S S 1-16 1-16 1-16 1-16 1-16
PART NO.
REF. NO L701 L801 L1201 MIC901 PL801 SW701 SW702 SW703 TU101 TU101 W301 X701
KANRI DESCRIPTION NO. 87-003-149-080 COIL,47UH 8Z-KT1-615-010 FLTR,AMORPHOUS -CHOKE 370UH 87-003-143-080 COIL 4.7 UH 8Z-KT1-643-090 MIC,EMC KUC2123-040245DB 8A-KT7-655-010 LAMP,9V-50MA 87-A91-070-010 87-036-109-010 87-A91-152-010 8A-KC8-620-010 8A-KC8-621-010 8A-KT5-611-010 87-A70-175-010 SW,TACT SKHHLV PUSH SWITCH SW,SL 1-1-2 SSSS212-11-A TU UNIT, FAE347-A11 TU UNIT, FAE347-A12 F-CABLE,3P 40MM VIB,XTAL 4.5MHZ AT-49
PART NO.
CONTROL C.B C251 C252 C253 C254 C255 C256 C257 C258 CON251 CON252 87-010-553-040 87-012-141-080 87-012-141-080 87-010-196-080 87-012-141-080 87-010-497-040 87-010-197-080 87-010-553-040 87-099-203-010 87-A61-262-010 CAP,E 47-16 GAS CHIP-CAPACITOR,0.22-16F CHIP-CAPACITOR,0.22-16F CHIP CAPACITOR,0.1-25 CHIP-CAPACITOR,0.22-16F CAP,E 4.7-35 GAS CAP, CHIP 0.01 DM CAP,E 47-16 GAS CONN,10P 6216 H CONN,12P V B12B-ZR
EQ/DOLBY C.B C201 C202 C203 C204 C205 C206 C207 C208 C209 C210 C211 C212 C213 C214 C215 C216 C218 C219 C220 C221 C222 C223 C224 C225 C226 CON201 CON202 SVR201 SVR202 87-A11-550-080 87-A11-550-080 87-A11-550-080 87-A11-550-080 87-010-426-080 87-010-426-080 87-010-494-040 87-010-196-080 87-010-196-080 87-010-494-040 87-010-494-040 87-010-196-080 87-010-196-080 87-010-494-040 87-010-197-080 87-010-197-080 87-010-555-040 87-010-196-080 87-A11-548-080 87-A11-548-080 87-010-494-040 87-010-494-040 87-010-497-040 87-010-497-040 87-010-497-040 87-009-349-010 87-A61-260-010 87-024-433-080 87-024-433-080 CHIP CHIP CHIP CHIP CAP, CAP 820P-50 KB CAP 820P-50 KB CAP 820P-50 KB CAP 820P-50 KB CHIP 0.012 KB
CAP, CHIP 0.012 KB CAP,E 1-50 GAS CHIP CAPACITOR,0.1-25 CHIP CAPACITOR,0.1-25 CAP,E 1-50 M 5L SRE CAP,E 1-50 M 5L SRE CHIP CAPACITOR,0.1-25 CHIP CAPACITOR,0.1-25 CAP,E 1-50 GAS CAP, CHIP 0.01 DM CAP, CHIP 0.01 DM CAP,E 100-10 GAS CHIP CAPACITOR,0.1-25 C-CAP,S 560P-50 KB C-CAP,S 560P-50 KB CAP,E CAP,E CAP,E CAP,E CAP,E 1-50 GAS 1-50 GAS 4.7-35 GAS 4.7-35 GAS 4.7-35 GAS PH H V B9B-ZR RH063EC RH063EC
CAP, S 1-16 CAP, S 1-16 CAP, S 1-16 CAP 470P CAP 470P CAP 470P CAP 470P CAP,E 100-16 SME CAP,E 100-10 GAS C-CAP,S 100P-50 CH CAP, CHIP 0.022 CONN,16P SOC017 CONN,3P HEADER-ANGLE CONN,3P HEADER-ANGLE CONN ASSY,5P MAIN-EQ CONN ASSY,12P MAIN-CONTROL CONN ASSY,8P ISO-BLACK CONN ASSY,8P ISO-WHITE-A CONN ASSY,6P MAIN-TAKE UP CONN ASSY,10P MAIN-TAKE UP FUSE,15A 32V ANT,AW-002 JACK,DIN 13 P SKDS1302 JACK,PIN 4P V-TYPE JACK,PIN 4P XR-401 COIL 4.7 UH COIL,68MH K7-D COIL 4.7 UH
CONN,6P CONN,9P SFR,10K SFR,10K
EQ C.B C271 C272 C273 C274 C275 C276 C277 C278 C279 C280 87-A11-550-080 87-A11-550-080 87-A11-550-080 87-A11-550-080 87-010-552-040 87-010-552-040 87-010-426-080 87-010-426-080 87-010-494-040 87-010-494-040 C-CAP,S 820P-50 K B C-CAP,S 820P-50 K B C-CAP,S 820P-50 K B C-CAP,S 820P-50 K B CAP,E 22-16 GAS CAP,E 22-16 GAS C-CAP,S 0.012-25 B C-CAP,S 0.012-25 B CAP,E 1-50 GAS CAP,E 1-50 GAS
CNA1401 8A-KT5-654-010 CNA1402 8A-KT5-652-010 F801 J101 J401 J1201 J1201 L101 L102 L301 8Z-KC1-621-010 8Z-KT1-614-010 8A-KC7-620-010 88-KTA-604-010 87-A61-224-010 87-003-143-080 8Z-KT1-619-010 87-003-143-080
4
CHIP RESISTOR PART CODE
REF. NO C281 C282 C283 C284 C285 C286 CON271 CON272 HEAD C.B TAKE UP C.B SW1017 CN1403 CON1401 CON1402 FRONT C.B C1001 C1002 C1002 C1003 C1004 C1004 C1005 C1005 C1006 C1006 C1007 CON1001 LCD1001 LCD1001 LCD1001 LED1001 LED1002 LED1003 LED1004 LED1005 LED1006 LED1007 PL1002 PL1002 PL1003 87-010-805-080 87-010-194-080 87-010-196-080 87-010-194-080 87-010-194-080 87-010-176-010 87-010-194-080 87-010-805-080 87-012-156-010 87-010-194-080 87-010-805-080 8Z-KT1-612-010 8A-KC7-610-010 8A-KC8-611-010 8A-KT7-610-010 87-017-827-070 87-017-827-070 87-017-827-070 87-A40-813-040 87-A40-813-040 87-A40-813-040 87-A40-814-080 8Z-KT1-651-010 8A-KT7-655-010 8Z-KT1-651-010 CAP, CAP, CHIP CAP, CAP, S 1-16 CHIP 0.047 CAPACITOR,0.1-25 CHIP 0.047 CHIP 0.047 87-036-220-080 8Z-KT1-613-010 87-009-411-010 87-A61-261-010 C-SW,T CONN,16P CAM-C74 CONN,6P ZH V CONN,10P V B10B-ZR SW1010 SW1011 SW1012 SW1013 SW1014 SW1015 SW1016 AUX C.B J1401 85-HRL-623-010 JACK,3.5 ST BLK 87-036-251-080 87-036-251-080 87-A90-001-080 87-036-251-080 87-A90-001-080 87-036-251-080 87-A91-597-010 SW,T CT 6X3.5 160 SW,T CT 6X3.5 160 C-SW,TACT SKQMAL SW,T CT 6X3.5 160 C-SW,TACT SKQMAL SW,T CT 6X3.5 160 SW,RTRY SIM-026MT KANRI NO. 87-010-555-040 CAP,E 87-010-497-040 CAP,E 87-010-498-040 CAP,E 87-010-494-040 CAP,E 87-010-494-040 CAP,E 87-010-553-040 87-009-349-010 87-A61-259-010 PART NO. DESCRIPTION 100-10 GAS 4.7-35 GAS 10-16 GAS 1-50 GAS 1-50 GAS REF. NO PL1003 SW1001 SW1002 SW1003 SW1004 SW1005 SW1006 SW1007 SW1008 SW1009 KANRI DESCRIPTION NO. 8A-KT7-655-010 LAMP,9V-50MA 87-A90-001-080 C-SW,TACT SKQMAL 87-036-251-080 SW,T CT 6X3.5 160 87-036-251-080 SW,T CT 6X3.5 160 87-A90-001-080 C-SW,TACT SKQMAL 87-036-251-080 87-036-251-080 87-036-251-080 87-036-251-080 87-A90-001-080 SW,T CT 6X3.5 160 SW,T CT 6X3.5 160 SW,T CT 6X3.5 160 SW,T CT 6X3.5 160 C-SW,TACT SKQMAL PART NO.
Chip Resistor Part Coding
8 8
A
Resistor Code Value of resistor Chip resistor
Dimensions (mm)
Figure
CAP,E 47-16 GAS CONN,6P PH H CONN,5P V B5B-ZR
Wattage 1/16W 1/16W 1/10W 1/8W
Type 1005 1608 2125 3216
Tolerance 5% 5% 5% 5%
Symbol CJ CJ CJ CJ
Form
L W
L 1.0
t
W 0.5 0.8 1.25 1.6
t 0.35 0.45 0.45 0.55
:A Resistor Code : A
104 108 118 128
1.6 2 3.2
RDS C.B C1101 C1102 C1103 C1104 C1105 C1106 SVR1101 X1101 87-012-149-080 87-010-315-080 87-010-175-080 87-010-196-080 87-012-157-080 87-010-495-040 87-024-437-080 87-A70-091-010 C-CAP,S 30P-50 CH C-CAP,S 27P-50 CH CAP 560P CHIP CAPACITOR,0.1-25 C-CAP,S 330P-50 CH CAP,E 2.2-50 GAS SFR100K,RH063EC VIB,XTAL 4.332MHZ CSA-309
CAP, S 680P-50 CAP, CHIP 0.047 CAP, S 1-16 C-CAP,S 220P-50 CH CAP, CHIP 0.047 CAP, S 1-16 CONN,16P CAM-C73 LCD,AKC-7(DOT) LCD,AKC-2/8(NO COLOR) LCD,AKT-3/4/7(3COLOR) C-LED,SEC 1201C RED C-LED,SEC 1201C RED C-LED,SEC 1201C RED C-LED,SEC1E01C BLUE C-LED,SEC1E01C BLUE C-LED,SEC1E01C BLUE C-LED,SEL2E10C BLUE LAMP,9V-85MA LAMP,9V-50MA LAMP,9V-85MA
LED C.B LED1008 87-A40-814-080 MECHA C.B C-LED,SEL2E10C BLUE
TRANSISTOR ILLUSTRATION
C
TYPE
MODEL NAME SUFFIX
B E ECB KTC3203 ECB KRA226M KTA1273 BCE 2SD2395 KTA1046 DTC343TK KRA104S KRA111S KRA226S KRC102S KRC111S KRC114S KTA1504 KTC3875
A B C D E F G H I J
CT-FR930M CT-FR730M CT-FRV735M CT-FR707 CT-FR710 CT-FRV715 CT-FX930M CT-FX930M CT-FX730M CT-FX730M
YZ YZ YZ YZ YZ YZ YU YH YU YH
5
6
SCHEMATIC DIAGRAM-1 [CT-FR930M YZ]
2.4 2.4
2.5
2.1
4.9 0
0
0
0 0
0 0
0 0
7.4 0
0 0
3.8 4.8
0 0
0 0
0 8.8
0 0
0 0
7.8 0
8.4 8.4
0.4 2.2
0 0
2.9 2.9
2.9 2.9
0 0
0 0
0 0
0 0
4.9 4.9
0 0
3.9 8.4 1.1 8.4
1.7 0
3.7 0
3.8
1.6
4.4
0.15
3.8
3.6
2.4 2.5 2.5
2.5 4.9
0
2.4 2.5
0
0
0
0
0
0
0 5.0 4.8 3.6 0 3.6 0 0 0 0 4.8 0 0 0 0.3 0.15 0 0 3.9 4.3 0 4.8 3.6 1.5 1.5 0 3.6 0 0 0 3.4 3.9 0 0/3.8 0/3.8 0 0 0 0 0 4.8 0 4.8 0.5
0
0
0
0
0
0
4.4/4.3
0/4.3
2.7/0
3.5/0
3.5/0
0/4.5
3.1
MOTOR DRIVE
0
0.3
0.4 0.2
4.4 4.4
14
14
0.4
0.4
4.8
4.8 4.8
4.8
4.8 4.8
4.8 4.8 4.8 4.8 4.8 9.2 4.7 5.8 4.7 4.7 2.5 4.7 4.8 4.8 4.7 4.7 4.7 4.7 4.8 4.7 4.7 9.2 9.4 3.1 2.4 3.8 4.8 4.8 4.8 4.8 4.8 4.8 4.8 0 0 0 0 4.8 4.8 4.8 3.1 0 2.8 0 2.8 2.8 0 4.8 4.8 4.8 4.8 4.8 4.8 4.8 0 0 4.8 4.8 2.8 2.8 0 2.8 3.1 0 2.8 3.1 2.8
4.7 4.7 4.7 4.7 4.9 0 0 0
4.8
4.8
4.8
4.3
0
0
0
0
0
0
0
0
0
0
0
0
0.5
0.5
0.5
0
CNA801
5.9
5.9 4.7
4.7
2.5
0.28 14.3 14.3 14.3 13 0
CNA802
7
8
SCHEMATIC DIAGRAM-2 [CT-FR730M YZ, FRV735M YZ, FR707 YZ, FR710 YZ, FRV715 YZ]
MOTOR DRIVE
CNA801
CNA802
9
10
SCHEMATIC DIAGRAM-3 [CT-FX930M YU, YH]
Q109,Q110 TUNER SWITCHING
PH
CON201
11
12
WIRING-1 [EQ/DOLBY, EQ C.B]
1 2 3 4 5 6 7
A
B
C
D
E
F
CT-FR730M(YZ)/FRV735M(YZ)/FR707(YZ)/ FR710(YZ)/FRV715(YZ)/FX730M(YU) CT-FR730M(YZ)/FRV735M(YZ)/FR707(YZ)/ FR710(YZ)/FRV715(YZ)/FX730M(YU)
G
H
I
J
13
WIRING-2 [CONTROL, MECHA C.B]
1 2 3 4 5 6 7
A
B
C
D
E
F
G
H
I
J
14
SCHEMATIC DIAGRAM-4 [CT-FX730M YU, YH]
TUNER PACK
MOTOR DRIVE
CON272
15
16
IC BLOCK DIAGRAM-1
IC, HA12192F
DIFFERENCE TABLE
[This table listes the different components marked with asterisks (*) in the MAIN CB]
Ref No. C401 C402 C901 C902 C903 C904 C905 C906 C1107 C1201 C1202 C1203 C1204 C1213 C1214 C1217 C1218 C1301 CN801 CN802 CNA202 CON801 D401 D402 D403 D404 D405 D406 D711 D713 D714 D715 D716 D720 D809 D810 D721 IC901 IC1201 J401 Q401 Q402 Q817 Q818 Q1101 Q1201 Q1202 Q1301 R401 A A A A A A A A A A B B B C C C D E F G G G G G G G G G G G G G G G G G A A A A A A A A A A A A A A A B B B C C C D D D E E E F F F G G G G G D D D E E E F F F G G A A B B C C D E F G H I J H H H H H H H B B B C C C D D D E E E F F F G G G G G G G G G G D E F G G G H H H I J H H H H H H H H H H I I I I I I I J J J J J J J H H H H H H H H H H H H H H H H H I I I J J J Ref No. R402 R403 R404 R405 R406 R407 R408 R409 R410 R411 R709 R710 R711 R712 R713 R714 R736 R737 R738 R739 R743 R901 R902 R903 R904 R905 R906 R907 R1103 R1104 R1201 R1202 R1203 R1204 R1205 R1206 R1207 R1208 R1209 R1210 R1211 R1212 R1217 R1218 R1219 R1301 R1302 SVR1101 A A A A A A A A A A A A A A A A A B B B B B B B B B B B B B B B B B C C C C C C C C C C C C C C C C C D E F G G G G G G G G G G G G G G G G G G G H H H H H H H H H H H H H H H H H H H I I I I I I I I I I I I I I I I I I I J J J J J J J J J J J J J J J J J J J
B
C
D
E
F I I I I I I I I J J J J J J J J
B A A A A A A A A A
C
D
E E E
F F F G G G G G G G H H H H H H H
I
J
IC, LB1641
IC, NJM2072M
B B B B B B
C C C C C C
B B
C C
D D
E E
F F G G G G G G G G G G G G G G G H H H H H H H H H H H H H H H I I I I I I I I I I I I I I I J J J J J J J J J J J J J J J
B
C
I I
J J
A A A A A
A
B B B B B B
C C C C C C
I I I I I I I I
J J J J J J J J
A A A
B B B
C C C
D D D
E E E
F F F
IC, SAA6579T
TYPE
VDD
MODEL NAME SUFFIX
A B C D E F G H I J
CT-FR930M CT-FR730M CT-FRV735M CT-FR707 CT-FR710 CT-FRV715 CT-FX930M CT-FX930M CT-FX730M CT-FX730M
YZ YZ YZ YZ YZ YZ YU YH YU YH
VSS
VSS
17
18
WIRING-3 (MAIN C.B)
1 2 3 4 5 6 7 8 9 10 11 12 13 14
A
[YZ]
B
[YZ]
[Except YZ]
C
D
E
F
G
H
I
J
19
20
SCHEMATIC DIAGRAM-5 [CT-FR930M YZ, FX930M YU, YH]
21
22
WIRING-4 (FRONT C.B) [CT-FR930M YZ, FX930M YU,YH]
1 2 3 4 5 6 7
IC BLOCK DIAGRAM-2
IC, LC75374E
A
B
6
5
4
3
2
1 A A
1
2
3
4
5
6
C
B B
C C
D
D D
E E
E
F F
F
G G
IC, LC75854W
H H
G
I
I
J J
H
K K
L L
I
M M
N N
J
23
24
SCHEMATIC DIAGRAM-6 [CT-FR730M YZ, FRV735M YZ, FR707 YZ, FR710 YZ, FRV715 YZ, FX730M YU, YH]
LCD1001 AKC-2/8(NO COLOR) LCD1001 AKT3/4/7(3 COLOR)
25
26
WIRING-5 (FRONT C.B) [CT-FR730M YZ, FR707 YZ, FR710 YZ, FX730M YU, YH]
1 2 3 4 5 6 7 8
WIRING-6 (FRONT C.B) [CT-FRV735M YZ, FRV715 YZ]
9 10 11 12 13 14
A
CT-FR730M(YZ)/FR707(YZ)/FR710(YZ)/ FX730M(YU)/FX730M(YH)
B
6
CT-FR730M(YZ)/FR707(YZ)/FR710(YZ)/ FX730M(YU)/FX730M(YH)
5
4
3
2
1 A A
1
2
CT-FR730M(YZ)/FR707(YZ)/FR710(YZ)/ FX730M(YU)/FX730M(YH)
3
4
5
6
6
5
4
3
2
1 A A
1
2
3
4
5
6
C
B B
B B
C C
D
C C
D D
D D
E E
E
E E
F F
F F
G G
F
G G
H H
H H
G
I
I
I
I
J J
J J
H
K K
K K
L L
I
L L
M M
M M
N N
J
N N
27
28
IC DESCRIPTION IC, µPD178016AGC-559-3B9/IC, µPD1780006A/IC, µPD178018A
Pin No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 Pin Name AM/FM S-M LEVEL-M A-VOL CONT CD CONNECT CD DISP SEL CD CLO CD DI CD DO CD CLI LCD CE DFP LAMP LCD DI LCD DO LCD CLO CD ACC CONT POWER MUTE ST-BY MUTE POWER CONT CONT 1 CONT 2 GND VDD MUTE BAND CONT RADIO CONT RDS MODE IF REQ AM IF FM IF VDD FM OSC AM OSC GND EO 0 EO 1 GND LOC/DX ST IND/SD IN PHONE MUTE I/O I I I I O O I O I O O I/O O O O O O O O O O O O O O I I I I O O O I I Description AF signal input during RDS AF operation and FM S meter signal input Level meter signal input Detects microphone input for auto volume operation.Pulled down when not used. CD changer connection check. Pulled down when not used. Determines the timing with which data is transferred to the head unit.Open when not used. Clock output to CD changer. Open when not used. Data input from CD changer. Pulled down when not used. Data output to CD changer. Open when not used. Clock input from CD changer. Open when not used. LCD DRV (LC75854W) CE output. Outputs "H" only when FLAP IN (pin 67) is "L".Open when not used. LCD DRV (LC75854W) data input. Open when not used. LCD DRV (LC75854W) data output. LCD DRV (µIPD16432B) clock output. LCD DRV (LC75854W) clock output. Transmits the power on/off status of head unit to changer. Open when not used. Muting output to power amp Standby/muting output to power amp Unit power control output LCD DRV power control 1 LCD DRV power control 2 Ground for port Power supply for port Audio muting output AM/FM power switching output. AM:"H", FM: "L". Radio ON/OFF. Power switching output. Radio ON: "H". Outputs "H" during RDS AF operation. Open when not used. Output to request IF count signal. AM IF count signal input FM IF count signal input Power supply for PLL FM local oscillation input AM local oscillation input Ground for PLL Error output from charge pump (for FM) Error output from charge pump (for AM) Ground LOC/DX switching output during radio seek (LOC: "H", DX: "L"). Open when not used. Stop pulse input during FM/AM seek. Muting control input -20 dB. Mute: "L". Pin No. 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 Pin Name MAIN M CONT SUB M CONT 1 SUB M CONT 2 MODE PL REEL STAND-BY F/R HEAD MS IN LED MI-1 MI-2 MI-3 MO-1 MO-2 MO-3 MO-4 BS CONT NR CONT MTL CONT BEEP RMT IN E-VOL CE E-VOL DO E-VOL CLO DSSA RDS DI DFP IN FLAP IN RDS CLI EJECT IN ACC IN RE1 IN RE2 IN PACK IN REG CPU GND X-OUT X-IN REG OSC VDD RESET O O O O I O O O O I I I I I I I I I I I MS/BL switching output. Open when not used Dolby B NR on/off output. Open when not used Metal tape on/off output. Open when not used Beep output (3 kHz, 50 ms) Remote control input. Pulled up when not used CE output to electronic VR (LC75374E) Data output to electronic VR (LC75374E) Clock output to electronic VR (LC75374E) Outputs "H" only when DSSA L/R are operating. RDS data inputPulled down when not used. Detects whether DFP (front panel) is provided or not. Detects whether flap DFP is open or closed. RDS clock inputPulled down when not used NC (pulled down) ACC (accessory power supply) on/off input Rotary encoder input 1. Rotary encoder input 2. Tape insertion status detection input CPU power regulator Ground System clock oscillator System clock oscillator Regulator for oscillator circuit Power supply System reset input O Diode matrix output for initial setting I Diode matrix input for initial setting I/O O O O I I I O I O Main motor control output Sub motor control output-1. Sub motor control output-2. Mode pulse input for tape mechanism. Reel pulse input for tape mechanism. Mechanism Stand-by input Head FWD/REV select output. MS signal input (no music: "H", with music: "L"). Pulled when not used Security LED flashing output ("H": 120-130 ns, 1 cycle: 3 s) Description
29
30
ELECTRICAL ADJUSTMENT
EQ/DOLBY C.B
IC201
TP1 (L ch) SVR201 SVR202
9 7 5 3
TP2 (R ch)
1
1
1. Dolby NR Adjustment [CT-FR930M, FX930M] Settings: · Test tape: TTA200 · Test points: TP1(Lch), TP2(Rch) · Adjustment location: SVR201(Lch), SVR202(Rch) Method: 1. Play a Dolby NR tape and adjust SVR201 and SVR202 so that the Lch (TP1) and Rch(TP2) levels are 300 ± 5mV. 2. Adjust the level in the forward running direction, and then check in the reverse direction. If the level drifts from the specification, perform readjustment. 2. RDS Voltage Adjustment [YZ] Settings: · Test point: Center pin of SVR1101 · Adjustment location: SVR1101 Method: Set AM/FM Signal generation to 98 MHz, 30 dBV and adjust SVR1101 so that the output becames 2.0 V ± 0.05 V.
MAIN C.B
L102
TU101
SW703 SVR1101 TEST POINT
FRONT SIDE
2
31
LCD DISPLAY-1 [CT-FR930M YZ, FX930M YU, YH]
SEGMENT
COMMON
32
LCD DISPLAY-2 [CT-FR730M YZ, FRV735M YZ, FR707 YZ, FR710 YZ, FRV715 YZ, FX730M YU.YH]
IC BLOCK DIAGRAM-3
IC, LA4743B
3/4 1/2
MUTE
ON TIME
STBY
PRE GND R.F
GND
NC
GND
IC, KIA2025P
NF-1 Metal OUT-1 VCC
6
ch1-F
4
M
2
N
1
5 7
ch1-R
AMP-1
EQ SELECT
15
9
ch2-F 13
BIAS F/R SELECT AMP-2
3
ch2-R
11
M N
12
NF-2
14
16
8
GND
Metal OUT-2
33
34
MECHANICAL EXPLODED VIEW 1/1
14 FRONT C.B 54 5 9 LCD1001 11 8 6 4 7 10 24 12
15 C 16
B
H B
EQ/DOLBY C.B (A,G,H only) EQ C.B (B,C,D,E,F,I,J only)
D
C 15 17 CDS-801AW1 B 50 CONTROL C.B 51 (G,H,I only) B AUX C.B B 26 25 B 51 (A,B,C,D,E,F only) B K 47 HT-SINK, 28 19 27 29 21 30 20 40 41 46 RDS C.B (A,B,C,D,E,F only) 38 36 E I I E 39 37 E 42 TAKE UP C.B D A D D 45 SH,PWB B 43 CHAS,SIDE L-T J B 55 52 B MAIN C.B 48 B 56 (D,E,F only) CHAS,SIDE L-T 49 B B
13
G
1
2 18 3
22 23
35 31 F
D
A
33 32
34
44 53
35
36
MECHANICAL MAIN PARTS LIST 1/1
REF. NO 1 1 2 3 3 3 3 3 3 3 3 3 4 4 5 6 6 7 7 8 9 9 10 10 11 12 12 13 13 14 15 16 17 18 19 19 20 20 20 21 21 22 22 23 23 24 24 25 26 27
KANRI DESCRIPTION NO. 8A-KT5-020-010 KNOB,RTRY A 8A-KTF-020-010 KNOB,RTRY NON RUBBER 8A-KT5-021-010 RING,RTRY A 8A-KT5-006-010 WINDOW,LCD 5 8A-KT4-012-010 WINDOW,LCD FR707 8A-KT4-001-010 8A-KT3-001-010 8A-KT1-001-010 8A-KT4-002-010 8A-KT3-002-010 8A-KT7-001-010 8A-KT5-007-010 8A-KT4-011-010 8A-KT5-004-010 8A-KT5-018-010 8A-KT5-012-010 8A-KT4-005-010 8A-KT5-011-010 8A-KT4-006-010 8A-KT5-210-010 8A-KT4-201-010 8A-KT5-207-010 8A-KT5-017-010 8A-KTG-003-010 8A-KT5-206-010 8A-KT3-202-010 8A-KT5-213-010 8A-KT3-201-010 8A-KT5-209-010 8Z-KT1-204-010 8Z-KT1-241-010 8A-KT5-002-010 8A-KT5-212-010 8A-KT5-001-010 8A-KT4-010-010 8A-KT5-005-010 8A-KT5-016-010 8A-KT1-003-010 8A-KT4-008-010 8A-KT1-004-010 8A-KT5-015-010 8A-KT5-013-010 8A-KT4-007-010 8A-KT5-014-010 8A-KT4-009-010 8A-KT5-010-010 8A-KT9-007-010 8A-KT5-019-010 8Z-KT1-242-010 8A-KT5-211-010 WINDOW,LCD WINDOW,LCD WINDOW,LCD WINDOW,LCD WINDOW,LCD FR710 FR730M FR930M FRV715 FRV735M
PART NO.
REF. NO 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 51 51 52 53 54 54 54 55 56 A B C D E F G H I J K
KANRI DESCRIPTION NO. 8A-KT5-208-010 LENS,R 5 8Z-KT1-229-010 HLDR,DAMPER F ASS'Y-T 8Z-KT1-250-010 OIL-DMPR,100 8Z-KT1-203-010 GEAR,FLAP -T 8Z-KT1-222-010 ARM,SENSOR F -T 8Z-KT1-248-010 8Z-KT1-021-010 8Z-KT1-244-010 8Z-KT1-023-110 8Z-KT1-018-010 8Z-KT1-208-010 8Z-KT1-230-010 8Z-KT1-260-010 8Z-KT1-201-110 8Z-KT1-243-010 8Z-KT1-202-010 8A-KT5-003-010 8Z-KT1-231-010 8A-KT5-203-010 8A-KT5-204-010 8A-KT5-216-010 8A-KT5-202-010 8Z-KT1-211-010 8Z-KT5-201-010 8Z-KT1-257-010 8A-KT5-219-010 8A-KT5-201-010 8Z-KT1-212-010 8Z-KTG-207-010 8Z-KT1-239-010 8Z-KTG-209-010 8Z-KTG-208-010 8Z-KT4-201-010 87-253-034-410 87-251-073-410 8Z-KT1-253-010 88-KT1-250-010 8Z-KT1-254-010 8Z-KT1-247-010 87-B10-259-010 87-B10-296-010 8Z-KT1-246-010 87-432-903-010 87-251-097-410 SPR-T,SENSOR F -T CABI,BASE F-T SPR-T,DOOR Z DOOR,CASS BTN,EJ F-T LENS,BASE -T HLDR,DFP ASS'Y-T SPR-T,F.LOCK-T ARM,F-LOCK -T SPR-T,FLAP -T LEVER,F-OPEN -T CABI,TRIM 5 HLDR,HALF-T CHAS,FRONT 5 HLDR,TR HLDR,DIN 13P HLDR,DECK 5 COVER, TOP -T COVER, ISO BLIND -T HLDR,ISO-WIRE -T HLDR,ISO-WIRE 5 HLDR,IC 5 COVER, BOTTOM -T CAP,LAMP BLU B2*4 ALC CAP,LAMP BLU B CAP,LAMP ORN CAP,LAMP GRN G50 ALC COVER, CD BLIND -T U+2-5 BLK SCREW,U+2.6-6 S-SCREW,PT 2*8 BH+ BLK S-SCREW,THIN HEAD+2.6-4 BLK S-SCREW,PT 2*5 BH+ BLK S-SCREW,GEAR2.0-1.8 -4.2 UT2+3.0-10.0 W/O SLOT (BH TAP) VT2+2-4 W/O S-SCREW,2.0-2.5 -10 WASHER,WTE 2.6 U+3-12
PART NO.
WINDOW,LCD FX730M YU WINDOW,LCD FX930M YH WINDOW,L 4 WINDOW,L 5 BTN,FNC BTN,PWR BTN,PWR 4 BTN,MU BTN,MU 4 HLDR,BTN MU LENS,ENCO 4 LENS,ENCO 5 BTN,UP/DN BTN,UP/DN G HLDR,LCD 5 LENS,LCD 3V LENS,LCD 5 CASE,LCD 3V CASE,LCD 5 HLDR,F-HOOK L -T SPR-C,DFP HOOK F -T CABI,REAR 5 HLDR,HOOK R CABI,FRONT 5 WINDOW,R 4 WINDOW,R 5 BTN,INFO BTN,TA BTN,TA 4 BTN,AF BTN,LO BTN,DISP BTN,SEL 4 BTN,A/M BTN,PS 4 BTN,P.SET BTN,P.SET 9 BTN,OPEN SPR-C,OPEN BTN F -T HLDR,BTN DISP
TYPE
MODEL NAME SUFFIX
A B C D E F G H I J
CT-FR930M CT-FR730M CT-FRV735M CT-FR707 CT-FR710 CT-FRV715 CT-FX930M CT-FX930M CT-FX730M CT-FX730M
YZ YZ YZ YZ YZ YZ YU YH YU YH
COLOR NAME TABLE
Basic color symbol Color Basic color symbol Color Basic color symbol Color B Black C Cream D Orange G Green H Gray L Blue LT Transparent Blue N Gold P Pink R Red S Silver ST Titan Silver T Brown V Violet W White WT Transparent White Y Yellow YT Transparent Yellow LM Metallic Blue LL Light Blue GT Transparent Green LD Dark Blue DT Transparent Orange 37
MECHANISM EXPLODED VIEW 1/1
57 58 56 55
H
1 53
54
52 2
I 51 3 46 50 49 49 48 F 44 43 42 41 40 D 59 14 F G 45 G 47 13 6 7 8 9 10 11 48 47 12 J 4
5
D 39 38 E 37 36 35 C
28 20 A A B 21 B 15 16 22 23 17 18 25 26 19 29
P.C.B 34 32 30 31 33
24
27
38
MECHANISM MAIN PARTS LIST 1/1
REF. NO 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35
KANRI DESCRIPTION NO. SX-080-110-130 CASSETTE HANGER ASSY S1-080-120-250 CASSETTE CATCH S1-080-110-120 CASSETTE HOLDER S1-080-140-110 HOLDER STABILIZER SPG S1-080-170-270 JOINT WIRE ASSY 6P-AW S1-080-170-220 S1-080-110-090 S1-080-140-010 S1-080-120-200 S1-080-110-050 SX-080-110-020 S1-080-110-060 SX-080-120-210 SX-080-120-220 S1-080-120-060 S1-080-140-020 S1-080-120-070 S1-080-150-020 S1-080-160-020 S1-080-130-050 S1-080-120-180 S1-080-120-300 S1-080-140-030 S1-080-120-080 S1-080-150-040 S1-080-150-010 S1-080-160-030 S1-010-120-560 S1-080-110-030 S1-080-110-040 S1-080-170-110 S1-080-170-030 S1-080-170-240 S1-080-170-050 S1-080-120-190 HEAD(P-5544-CD) HEAD SUPPORT SPG PINCH ARM SPG TAPE GUIDE PINCH SPG ARM SLIDE CHASSIS ASSY CASSETTE GUIDE PINCH ARM ASSY PINCH ARM R ASSY SPG HOLDER F TU SPG FRICTION GEAR PLAY FELT 7.5-18.5-1.0 FLYWHEEL ASSY F RACK COLLAR MODE RACK SPG HOLDER R FF SPG FRICTION GEAR FF FELT 11-18.5-1.0 BELT FLYWHEEL ASSY R IDLE PULLEY(A1) DIRECTION PLATE DIRECTION LINK FLAT CABLE 10P SW(ESE22MH1) PHOTO SENSOR(ON2170-QR FS) SW(SPPB 64) MODE SW ACTUATER
PART NO.
REF. NO 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 A B C D E F G H I J
KANRI DESCRIPTION NO. S1-080-120-050 REDUCTION GEAR B S1-080-120-040 REDUCTION GEAR A S1-080-120-090 MODE GEAR S1-080-120-170 REFLECTOR GEAR S1-080-120-150 GEAR BASE LINK S1-080-120-160 SX-080-120-030 S1-080-120-140 S1-080-140-070 SX-080-170-060 SX-080-170-570 S1-080-120-100 S1-080-140-080 S1-080-120-110 S1-080-120-240 SX-080-110-080 S1-080-140-090 S1-080-110-070 S1-080-110-110 S1-080-140-060 S1-080-120-230 SX-080-110-100 S1-080-140-050 SX-080-110-030 S2-181-600-32E S2-182-100-40D S2-181-200-32D S1-003-650-240 S1-821-004-0D2 S2-103-200-25C S1-080-150-050 S2-171-150-401 S2-133-200-35P S1-080-150-030 TAKE UP GEAR GEAR BAES ASSY GEAR BASE ARM GEAR BASE SPG SUB MOTOR ASSY MAIN REEL REEL REEL RACK MOTOR ASSY SPINDLE DRIVER SPG DRIVER LINK
PART NO.
SIDE BKT ASSY LOAD ARM SPG LOAD ARM EJECT CAM PLATE HOLDER CUSHION SPG LOAD RACK EJECT CAM LIMITER ASSY EJECT CAM PLATE SPG MAIN CHASSIS ASSY LMW-S 1.6-3.2-0.35 PSW 2.1-4.0-0.25 PSW-S 1.2-3.2-0.25 PSW-S(REEL B)1.5-3.2-0.25 PSW-S 2.1-4.0-0.25 +SCREW,PLAIN M2-2.5 REEL WASHER E-RING 1.5 S-TYPE PRECISION SCREW M2-3.5 AZIMUTH SCREW
39
211, IKENOHATA 1CHOME, TAITO-KU, TOKYO 110, JAPAN TEL:03 (3827) 3111
920074 Printed in Singapore