Text preview for : HD-5000_Service_Manual.PDF part of Mitsubishi HD-5000 (A) Service Manual Tuner Set Top Box - (22.475Kb) Part 1/11 - pag. 52



Back to : set_top_box_®_.part01.rar | Home

MITSUBISHI ELECTRIC

Ser vice Manual
SET TOP BOX V21S CHASSIS

2003

V21S MODELS

HD-5000 HD-5000A

CAUTION: Before servicing this chassis, it is important that the service person read the "SAFETY PRECAUTIONS" and "PRODUCT SAFETY NOTICE" contained in this manual.

SPECIFICATIONS
· Power Input · Power Usage · Frequency Range · Antenna Input : AC 120V, 60Hz : 79W : VHF 54 ~ 470MHz UHF 470 ~ 806MHz : VHF/UHF 75 unbalanced 2 - NTSC 1 - ATV/QAM · Input Level : VIDEO IN JACK (RCA Type) 1.0Vp-p 75 unbalanced : AUDIO IN JACK (RCA Type) -4.7dBm 43k unbalanced : S-VIDEO IN JACK (Y/C separate type) Y:1.0 Vp-p C:0.286Vp-p(BURST) 75 unbalanced : COMP / Y, Cr, Cb (RCA Type) Y: 1.0 Vp-p Cr, Cb: 700mVp-p : ATV / Y(G), Pr(R), Pb(B), H, V Y: 1.0Vp-p with sync 75 (BNC) Pr, Pb: 700mV 75 H, V: 3.0Vp-p 75 : VGA / R,G,B,V,H (15 pin D) : VIDEO OUT JACK (RCA Type) 1.0Vp-p 75 unbalanced : AUDIO OUT JACK (RCA Type) -4.7dBm 4.7k unbalanced : IEEE-1394 I/O Jacks : AC-3 Digital Audio Output : MonitorLinkTM/DVI : MonitorLinkTM Control/RS-232C : NetCommand®

· Cabinet Weight and Demensions
Mode l HD-5000 HD-5000A W e ight He ight W idth De pth 19 lbs. 19 lbs. 8" 8" 17" 17" 16" 16"

· Output Level

· Digital Interface

.

MITSUBISHI DIGITAL ELECTRONICS AMERICA, INC.
9351 Jeronimo Road, Irvine, CA 92618-1904 Copyright © 2004 Mitsubishi Digital Electronics America, Inc. All Rights Reserved

MODELS: HD-5000 / HD-5000A

CONTENTS
INTRODUCTION ................................................................................................................................ 5 PRODUCT SAFETY NOTICE ............................................................................................................. 5 SAFETY PRECAUTIONS ................................................................................................................... 6 DISASSEMBLY Top Cover Assembly / Disassembly ................................................................................................ 7 PCB Disassembly FlowChart .......................................................................................................... 7 PCB Assembly / Disassembly ........................................................................................................ 8 Cabinet Assembly / Disassembly ................................................................................................. 10 ELECTRICAL ADJUSTMENTS Test Equipment ............................................................................................................................. 11 Initial Setup ................................................................................................................................... 12 LED Indicator Diagnostics ............................................................................................................. 13 Error Codes .................................................................................................................................. 13 Remote Control Operational Mode ................................................................................................ 13 Circuit Adjustment Mode ............................................................................................................... 14 On Screen Display Position Adjustment Mode .............................................................................. 15 Data Transfer Mode ....................................................................................................................... 15 E2PROM Replacement ................................................................................................................. 15 Adjustment Items List ................................................................................................................... 15 Adjustment Test Points ................................................................................................................. 17 Adjustment Procedures ................................................................................................................ 18 Audio Circuit ........................................................................................................................ 18 Character Position ............................................................................................................... 19 Main/Sub Y Level ................................................................................................................. 19 Color Alignment ................................................................................................................... 20 CHIP PARTS REPLACEMENT ......................................................................................................... 21 REPLACEMENT PARTS Parts Ordering .............................................................................................................................. 22 Critical and Warranty Parts Designation ........................................................................................ 22 Parts Tolerance Codes .................................................................................................................. 22 Service Parts List .......................................................................................................................... 23 CIRCUITRY BLOCK DIAGRAMS Standby Supplies Regulator .......................................................................................................... 32 DM Power Supply ......................................................................................................................... 33 Video / Color A/V Switch Circuit .................................................................................................... 34 Video / Color Signal Path .............................................................................................................. 35 Control Circuitry ............................................................................................................................ 36 Sound Circuitry ............................................................................................................................. 37 Sync Circuitry ............................................................................................................................... 38

Page 3

MODELS: HD-5000 / HD-5000A

Section 2 .... Schematic Diagrams
SCHEMATIC DIAGRAMS Overall Block Diagram ..................................................................................................................... 1 PCB-POWER / CONTROL / E2P .................................................................................................... 2 PCB-TERMINAL-1 [JACK] .............................................................................................................. 3 PCB-TERMINAL-2-1 [SWITCH] ....................................................................................................... 4 PCB-TERMINAL-2-2 [3DYC] ........................................................................................................... 5 PCB-SIGNAL-1 [MICRO] ................................................................................................................. 6 PCB-SIGNAL-2 [AV / IO] ................................................................................................................. 7 PCB-SIGNAL-3 [VIDEO / CHROMA] ............................................................................................... 8 PCB-SIGNAL-4 [IR / MV / DMP] ..................................................................................................... 9 PCB-2HDW-1 [IN] ......................................................................................................................... 10 PCB-2HDW-2 [MAIN] .................................................................................................................... 11 PCB-2HDW-3 [OUT] ..................................................................................................................... 12 PCB-2HDW-4 [C720] HD-5000A ONLY ......................................................................................... 13 PCB-DEMOD ................................................................................................................................ 14 PCB LAYOUT DIAGRAMS ............................................................................................................... 15

Page 4

MODELS: HD-5000 / HD-5000A

INTRODUCTION
This service manual provides service instructions for the V21S STB chassis type. The specific models for each chassis type are listed below. Service personnel should read this manual thoroughly before servicing these chassis.

V21S Cha ssis HD-5000 HD-5000A

This service manual includes: 1. Saftey Precautions 2. Assembly and disassembly instructions. 3. Servicing printed circuit boards (PCBs). 4. Electrical adjustments. 5. Chip parts replacement procedures. 6. Circuit path diagrams. The parts list section of this service manual includes: 1. Mechanical and Cosmetic parts. 2. Electrical parts. Schematic and block diagrams of the above listed models are included in this service manual for better understanding of the circuitry. PCB drawings are also included for easy location of parts and test points.

PRODUCT SAFETY NOTICE
Many electrical and mechanical parts in television receivers have special safety related characteristics. These characteristics are often not evident from visual inspection nor can the protection afforded by them necessarily be obtained by using replacement components rated for higher voltage, wattage, etc. Replacement parts which have special safety characteristics are identified in this service manual. Electrical components having such features are identified by shading on the schematic diagram and by bold type in the parts list of this service manual. The replacement for any safety part should be identical in value and characteristics.

Page 5

MODELS: HD-5000 / HD-5000A

SAFETY PRECAUTIONS
NOTICE: Observe all cautions and safety related notes located inside the receiver cabinet and on the receiver chassis.

WARNING: 1.

2.

Operation of this receiver outside the cabinet or with the cover removed presents a shock hazard from the receiver's power supplies. Work on the receiver should not be attempted by anyone who is not thoroughly familiar with the precautions necessary when working on high voltage equipment. When service is required, observe the original lead dress. Extra precaution should be taken to assure correct lead dress in the high voltage area. Where a short-circuit has occurred, replace those components that indicate evidence of overheating.

Leakage current check Before returning the receiver to the customer, it is recommended that leakage current be measured according to the following methods.

1. Cold Check
With the alternating current (AC) plug removed from the AC source, place a jumper across the two AC plug prongs. Connect one lead of an ohm meter to the AC plug and touch the other lead to each exposed metal part (i.e. antennas, handle bracket, metal cabinet, screw heads, metal overlay, control shafts, etc.), particularly any exposed metal part that has a return path to the chassis. The resistance of the exposed metal parts having a return path to the chassis should be a minimum of 1Mega Ohm. Any resistance below this value indicates an abnormal condition and requires corrective action.

2. Hot Check ...Use the circuit shown below to perform the hot check test.
1. Keep switch S1 open and connect the receiver to the measuring circuit. Immediately after connection, and with the switching devices of the receiver in their operating positions, measure the leakage current for both positions of switch S2. 2. Close switch S1, energizing the receiver. Immediately after closing switch S1, and with the switching devices of the receiver in their operating positions, measure the leakage current for both positions of switch S2. Repeat the current measurements of items 1 and 2 after the receiver has reached thermal stabilization. The leakage current must not exceed 0.5 milliampere (mA).

GWG - Green Wire Ground (Earth Ground)

Page 6

MODELS: HD-5000 / HD-5000A

TOP COVER ASSEMBLY/DISASSEMBLY
1) Remove 3 SCREWS 2) Remove 4 SCREWS
TOP COVER

2

2

2HDW PWB SIGNAL PWB POWER PWB
under 2hdw pwb

DM PWB
under signal pwb

TERMINAL 1&2 PWB

1

PWB ASSEMBLY/DISASSEMBLY
(See detailed drawings on next 3 pages) 2HDW REMOVAL
REMOVE TOP COVER

SIGNAL REMOVAL TERMINAL REMOVAL
REMOVE TOP COVER REMOVE TOP COVER

POWER PWB
REMOVE TOP COVER

DM PWB
REMOVE TOP COVER

REMOVE 2HDW PWB

FOLLOW STEP #1 AND #2 TO REMOVE SIGNAL PWB

REMOVE SIGNAL PWB

REMOVE 2HDW PWB

REMOVE SIGNAL PWB

REMOVE TERMINAL PWB

REMOVE POWER PWB

REMOVE TERMINAL PWB

SEPARATE TERMINAL 1 AND TERMINAL 2

REMOVE DM PWB

PAGE 7

MODELS: HD-5000 / HD-5000A

2HDW ASSEMBLY 1) Remove 3 connectors (EA, EB, EC) from Signal PWB 2) Remove 4 SCREWS from 2HDW PCB
SHIELD PLATE

SIGNAL PWB ASSEMBY STEP 1 1) Remove 15 connectors (EA, EB, EC, KE, KC, KB, CD, CA, VA, DA, DV, VB, PE, PD, RF)

2HDW PWB SHIELD CASE
EA E B

WB LP NA SIG
RF

EC

EA

E B

EC

TERMINAL 1&2 PWB ASSEMBY 1) Remove 23 SCREWS (not shown) 2) Remove 4 HEX LOCK (H1~H4) screws SIGNAL PWB ASSEMBY STEP 2 1) Remove 4 connectors (SU, ST, SS, SR) 2) Remove 6 SCREWS 3) Remove RF PLATE
RF PLATE
H1/H2
SU ST

H3/H4 1 2 3 4 5 6 11 7 8 9 10 12 13 14 16 17 19 2021 23 22 15 18

B AL PW SIGN

SS SR

PWB SPACER

L NA I RM TE

B PW 2
TERMINAL 1 PWB

PAGE 8

MODELS: HD-5000 / HD-5000A

POW ER P WB

POWER PWB ASSEMBY 1) Remove 6 SCREWS from Power PCB 1) Remove 2 connectors (GS, PS) DM PWB ASSEMBY 1) Remove 5 SCREWS from DM PCB 2) Remove 2 HEX LOCK SCREWS 3) Remove DTV WASHER 3) Remove 7 connectors (DV, DA, DB, VA, VB, PD, PE)

PE PD

DB VA DA VB DV

DM PWB

DTV WASHER

FRONT PWB ASSEMBY 1) Remove 4 SCREWS from bottom 2) Remove 4 SCREWS from top 3) Remove 1 connectors (RF) 4) Remove 4 SCREWS from FRONT PWB

2

FRONT PWB

1

PAGE 9

MODELS: HD-5000 / HD-5000A

CABINET ASSEMBLY
AC INLET / FAN ASSEMBLY 1) Remove AC INLET from rear panel 2) Remove FAN MOTOR from fan holder

AC INLET

AC INLET

FAN HOLDER

FAN MOTOR

MAIN CHASSIS ASSEMBLY 1) Remove 4 SCREWS from bottom feet 2) Remove 3 SCREWS from rear panel bottom 3) Remove 2 SCREWS from cover shield bottom 1 1 3

LEAD CLAMPER COVER SHIELD

MAIN CHASSIS

2
REAR PANEL

PAGE 10

MODELS: HD-5000 / HD-5000A

ELECTRICAL ADJUSTMENTS
Note: Perform only the adjustments required. Do not attempt an alignment if proper equipment is not available.

Test Equipment
· · · · · · · Oscilloscope (Unless otherwise specified, use 10:1 probes) Signal Generator (both SD and HD capable) Frequency Counter Direct Current Voltmeter Direct Current Power Supply Multiplex Audio Signal Generator Direct Current Ampere Meter

Test Signal
A. Monoscope Signal
Note: If you do not have a monoscope signal source, connect the unit to a VCR and play a *Monoscope alignment tape. (* Part Number: 859C568060)

B. Color Bar Signal
Use the color bar signal shown below, unless otherwise specified in this manual. Monoscope Signal

100% 75%

40%

40% 1H

Split-Field Color Bars (100% window) Page 11

MODELS: HD-5000 / HD-5000A

Initial Setup
A. Option Menu Setup
Follow the steps below for the initial set-up: 1. Move switch to `Cable/DBS/DTV' layer 2. Select the "MENU" display by pressing the "MENU" button once. 3. Press the number buttons "0", "3", "7", "0" in sequence to select the "OPTION MENU" display. 4. Press the "ADJUST" button to select "INITIAL." 5. Press "ENTER." NOTE: At this time channel 3 is automatically selected.
(MENU-0-3-7-0) OPTION MENU Initial Power restore DTV Port

:OFF :Auto

B.

Default Settings

SETUP Edit Setup Review Antenna A Antenna B Antenna DTV Input 1 Input 2 Input 3 Input 4 Component 1 Component 2 Input DTV VGA

( ( ( ( ( ( ( ( ( ( (

) ) ) ) ) ) ) ) ) ) )

Enabled Enabled Enabled Enabled Enabled Enabled Enabled Enabled Enabled Enabled Enabled

As above Icon Position On Tra nsport Me nu English La ngua ge ANTENNA Antenna ANT A Memorize Channels Air Channel Ch-3 Memory Deleted CLOCK Clock Setting Manual Set Time 12:00 AM Set Day Sunday

MAIN MENU DEFAULT SETTINGS CAPTIONS AUDIO SETTINGS Closed Captions W ith Mute Volume 30% CC Background Gray Bass 50% Digital Channel Guide Off Treble 50% Balance Center V-CHIP PARENT LOCK V-CHIP Off Surround Off TV Rating TV-PG Listen to Stereo FV-Fantasy Violence ( ) Enabled Level Sound On D-Sexual Dialog ( ) Enabled VIDEO SETTINGS L-Adult Language ( ) Enabled Contrast 50% S-Sexual Situation ( ) Enabled Brightness 50% V-Violence ( ) Enabled Sharpness 50% Program not Rated ( ) Enabled Color 50% Movie Rating PG Tint Center Video Noise Standard V-CHIP LOCK BY TIME V-Chip Start Time 12:00 PM Film Mode (Auto) On V-Chip Stop Time 12:00 PM VCR Compensation Standard Video Mute On Lock By Time Lock by Time Off Black Enhancement On Unlock Time N/A Audio Out to Display On Lock Time N/A TIMER PIP/POP Timer Off Source Ant A Ch 3 Set Day Everyday PIP Position Lower Right Set Time 12:00PM POP Position Right Half Device Ant-A Format Stretched Channel Ch-3 PIP/POP Format Dble. W indow

A/V Memory Contrast Brightness Sharpness Color Tint Video Noise
Film Mode(auto)
VCR Compensation

Image Type Bass Treble Balance Surround Listen To

A/V RESET DEFAULT SETTINGS (By Input) INPUTS Component Ant A/B Ant DTV Inp-DTV 1/2/3/4 1/2 Center Center Center Center Center Center Center Center Center Center Center Center Center Center Center Center Center Center Center Center Center Center Center Center Center Standard N/A Standard Standard Standard On N/A On On On Standard N/A Standard Standard Standard Video N/A Video Video Video Center Center Center Center Center Center Center Center Center Center Center Center Center Center Center OFF OFF OFF OFF OFF Stereo English N/A N/A N/A Page 12

VGA Center Center N/A Center Center N/A N/A N/A N/A Center Center Center OFF N/A

1394 Center Center Center Center Center N/A N/A N/A N/A Center Center Center OFF N/A

MODELS: HD-5000 / HD-5000A

C. A/V Memory
Each of the external inputs has its' own Audio/Video Memory. A change in an A/V setting at a specific input is stored in memory for that specific input. A/V Reset 1. The front panel AV Reset button initializes all A/V Memories. 2. The AV Reset in the user's menu initializes only the selected input's A/V Memory.

LED Indicator Diagnostics
The "Power ON LED" provides an indication of the sets operation, and the possible cause of a malfunction.

1. Initial Control Circuitry Check
Immediately after the TV is connected to an AC power source:

LED Indications Off Fast Blink for 70 sec. Fast Blink (doesn't stop) Slow Blink

Conditions After AC is applied After AC is applied After AC is applied Set is Off

Probable Cause Standy Power Supply or TV µPC not running Normal - DM µPC is booting up TV µPC is running, but DM failed to boot up Normal - Timer is set for Automatic Turn ON

2. Error Code Operational Check
Pressing the front panel "INPUT" and "MENU" buttons at the same time, and holding for 5 seconds, activates the Error Code Mode. The LEDs flashes denoting a two digit Error Code, or indicating no problem has occured since the last Initalization. Note: The front panel buttons must be used, NOT those on the Remote Control.

· · · ·

The number of flashes indicates the value of the MSD (tens digit) of the Error Code. The flashing then pauses for approximately 1/2 second. The LEDs then flash indicating the value of the LSD (ones digit) of the Error Code. The Error Code is repeated a total of 5 times. Example: If the Error Code is "24", the LEDs will flash two times, pause, and then flash four times.

3. Error Codes
The Error Code designations indicating a malfunction, or no malfunction, are listed below:

Error Code Probable Cause 12 Normal Operation - No Error Detected 35 Fan Stop

Remote Control Operational Modes
There are two Remote Hand Unit Operational Modes, "Standard" and "NetCommandTM". The Remote is initially in the "Standard" mode. The "NetCommandTM" mode is used when controlling Home Theater devices using NetCommandTM. To change the Remote Operational Mode:

· · · ·

Set the Remote to the CABLE/DBS/DTV Layer
Point the Remote away from the Set Top Box. To change to "NetcommandTM" ... Hold the "Power" button and press "1-9-7" in sequence. To change to "Standard" ... Hold the "Power" button and press "0-0-0" in sequence.

Page 13

MODELS: HD-5000 / HD-5000A

Circuit Adjustment Mode
Most of the adjustments can only be performed using the remote hand unit. Many of the adjustments must be performed in both the 480i and 1080i modes. Video/Color adjustments must be performed in the 480i and 1080i modes, and data must be preset in the 480P (DVD) and VGA modes. Note: Set the Remote Operational Mode to "NetCommandTM". (Hold the "Power" button and press "1-9-7" in sequence.) This slows the remote's response and makes adjustments easier. When adjustments are complete, set the Remote to its' original Operational Mode.

A. Activating the Circuit Adjustment Mode
The current signal source determines if the activated Adjustment Mode is 480i or 1080i. 1. 2. 3. 4. Select the signal source (480i or 1080i). Select `Cable/DBS/DTV' remote layer. Press the "MENU" button on a remote hand unit. Press the number buttons "0", "3", "5", "7" in sequence. The screen will change to the Adjustment Mode. Note: Repeat steps 1 and 2 if the circuit adjustment mode does not appear on screen.
CHASSIS MODE ADJ ITEM

V21S 0 1 SCT 42 480i
DATA SIGNAL

ABBREV.

B. Selection of adjustment Functions and Adjustment Items
To select an adjustment item in the circuit adjustment mode, first select the adjustment function that includes the specific adjustment item to be selected. Then select the adjustment item. Refer to the following pages for the listing of adjustment functions and adjustment items. 1. Press the "AUDIO" button on a remote hand unit to select an adjustment function. Each time the button is pressed, the Function changes in the following sequence:
VC JNGL Adjustment Functions
VIDEO ADC

MNTS

AUD

SNTS

2. Press the "VIDEO" button to select a specific Adjustment Item. The Item number increases each time the "VIDEO" button is pressed.

C. Changing Data
After selecting an adjustment Item, use the "ADJUST UP/DOWN" buttons to change data. · Press "ADJUST DOWN" to decrease the data value. · Press "ADJUST UP" to increase the data value.

D. Saving Adjustment Data
Press "ENTER" to save adjustment data in memory. The character display turns red for approximately one second in this step. Note: If the circuit adjustment mode is terminated without pressing "ENTER", changes in adjustment data are not saved. Page 14

MODELS: HD-5000 / HD-5000A

E. Terminating the Circuit Adjustment Mode
Press the "MENU" button on the remote hand unit twice to terminate the adjustment mode. Note: The circuit adjustment mode can also be terminated by turning power OFF.

F. Toggle Between Reception Modes
Pressing "3" when in the Adjustment Mode VC Function toggles between 480i, 480p, 1080i and VGA. However data changes are not automatically saved. Press "ENTER" to save data before pressing "3".

On Screen Display Position Adjustment Mode
Activation
1. 2. Select 480i or 1080i (DTV INPUT) source. Press MENU-0-3-9-9

Data Transfer Mode
Activation
1. Pressing the "0" key when in the open alignment mode will access a special function table. The table will be displayed at the top of the screen and below is description of the special functions available.

Key Sequence 12

Name XFER Console Data

Description Transfers console alignment data (MNTS;SNTS;AUD) stored on the Signal EEPROM to the DM EEPROM. Used when replacing a bad DM. Transfers white balance alignment data (VC) stored on the Signal EEPROM to the DM EEPROM. Used when replacing a bad DM. Runs a check to confirm if a valid HAVI certificate has been loaded. Status message will appear after pressing the key sequence. Transfers the alignment data stored in the DM EEPROM to the signal EEPROM. Transfers the alignment data stored in the signal EEPROM to the DM EEPROM.

13

XFER White Balance Data

14

Net check

16 17

Copy DM data to signal EEPROM Copy signal data to DM

Note 1: After pressing the key sequence shown above, the special function table will disappear. The "0" key must be pressed again to bring up the special function table.

E2PROM Replacement
IC7A01 stores some adjustment data. After replacing the IC, set the data to the values given in the following tables. If good performance is not obtained, perform the Adjustments Procedures given in the Notes column.

List of Adjustment Items. VC Function (Video Color)
Function Display NO. Abbrev. 1 SBRT 2 SCOL 3 STIN 4 SCON 26 D-PIC Adjustment Description SUB-BRIGHT SUB-COL SUB-HUE SUB-CON DYNAMIC PICTURE Data Range 0~63 0~15 0~15 0~15 0~3 1080i 53 9 8 7 1 Initial Data 480i 480p 53 53 9 9 8 8 7 7 1 1 VGA 53 9 8 7 1 IC2V00 Notes Sub Contrast Sub Color Sub Tint Sub Contrast

Page 15

MODELS: HD-5000 / HD-5000A

JNGL Function (Jungle)
Display No. Abbrev. 15 HPOS 16 BLKL 17 BLKR 18 BLKT 19 38 BLKB HFRQ Adjustment Data Description Range Horizontal Position 0~63 Blanking on Left Side 0~63 Blanking on Rigth Side 0~63 Number of blanking lines after Vsync (top blank) 0~63 Number of blanking lines before Vsync (bottom blank) 0~63 Horizontal Frequency Control 0~255 720P HD 30 15 35 32 26 125 1080i HD 25 5 46 32 26 26 480i HD 28 26 42 37 27 3

IC2V01 Notes Center

MNTS Function (Main Decoder)
Function Display Item # Abbrev. 1 TNTM 2 COLM 3 YDRM 4 VPDM 5 UPDM Adjustment Description Main Tint Main Color Main Gain Control Pr Pedestal Adjustment Pb Pedestal Adjustment Data Range 0~63 0~63 0~31 0~15 0~15 Initial Data RF Non RF 24 24 17 17 5 5 7 7 7 7

IC2E00 Notes Preset " Main Y Level

SNTS Function (Sub Decoder)
Function Display Item # Abbrev. 1 TNTS 2 COLS 3 YDRS 4 VPDS 5 UPDS Adjustment Description Sub Tint Sub Color Sub Gain Control Pr Pedestal Adjustment Pb Pedestal Adjustment Data Range 0~63 0~63 0~31 0~15 0~15 Initial Data 26 18 5 7 7

IC2H00 Notes Preset " Sub Y Level " " IC3A01 Notes Input Level Separation "

AUDIO Function
Function Display Adjustment Item # Abbrev. Description 1 INP Input Level Alignment 2 WDE Wideband Separator Align. 3 SPC Spectral Separator Align. Data Range 0~15 0~31 0~31 Initial Data 8 3 3

VIDEO ADC
Function Display Item # Abbrev. 6 CPLC 7 CDUR 8 HWID 9 RGAI 10 GGAI 11 BGAI 12 ROFS 13 GOFS 14 BOFS Adjustment Description CLMPLACE CLMPDUR HWIDTH RED GAIN GRN GAIN BLUE GAIN RED OFFSET GREEN OFFSET BLUE OFFSET Data Range 8 8 8 8 8 8 7 7 7

IC53J6 Analog DVI Notes 1080i 480P 1080i 720P 480P 139 60 139 192 60 48 48 48 48 48 34 16 34 83 16 160 160 160 160 160 Color Alignment " 160 160 160 160 160 " 160 160 160 160 160 60 60 60 " 60 60 60 60 60 " 42 42 60 60 60 " 60 60
(MENU-0-3-9-9) Data Initial Range Data 114249 62754 Page 16

OSD Horizontal Centering
Abbrev. OSDHD OSDSD Description OSD POSITION FOR HD OSD POSITION FOR SD

MODELS: HD-5000 / HD-5000A

Adjustment Test Point Location

Test Points EA pin 1 - Sub Picture (Y) EA pin 15 - Main Picture (Y) SUpin 4 - Left Audio SU pin 6 - Right Audio

ST

SU
6 4

OUTPUT Y/Pr/Pb

INTPUT Y/Pr/Pb

Page 17

[Audio Circuit] 1. MCS Input Level
Measuring Instrument Test Point Ext. Trigger Measuring Range Input Signal Oscilloscope Connector SU pins 6&4 -----50mV/Div RF Stereo 300 Hz modulation

MODELS: HD-5000 / HD-5000A Purpose: Check the input signal level to the MCS circuit Symptom: Distorted sound during a stereo broadcast.

Input Terminal RF Input

1. Supply an RF MCS signal to the Ant A input, 300 Hz at 100% modulation (25 kHz deviation) for right and left channels. 2. Connect the oscilloscope to connector SU pin 6 (Right Audio). 3. Enter the Adjustment Mode and select the Audio Function. 4. Verify that the Audio Function items are set to the data values given the table below. 5. Set the data for Item "1 INP" for 1.28 Vp-p ±0.06V. (450mv ±10mv rms) 6. Connect the oscilloscope to connector ST pin 4 (Left Audio). 7. Confirm that the left audio level at pin 4 of the ST connector is 1.28 Vp-p ±0.06V (450mv ±20mv rms).
Note: Adjustment 2 (Stereo Separation) must be performed after this adjustment)

CIRCUIT ADJUST MODE
Layer ........ Cable/DBS/DTV Activate ........ MENU-0-3-5-7 Function .................AUDIO Item No. .................VIDEO Adjust Data ...........ADJUST Save Data .... .........ENTER Exit ..............MENU (twice)
ST SU
6 4

AUDIO Function Item # Abbrev. 1 INP 3 W DE 4 SPC

Data 8 3 3

[Audio Circuit] 2. Separation
Measuring Instrument Test Point Ext. Trigger Measuring Range Input Signal Oscilloscope Conector SU pin 6 -----10mV/Div RF Stereo

Purpose

Check stereo separation

Symptom: Poor stereo separation

Note: This adjustment must follow Adjustment 1 (Input Level) 1. Supply a RF Stereo Signal (dual tone stereo) to the Ant. A input. · Left Channel = 300 Hz modulation · Right Channel = no modulation 2. Connect the oscilloscope to connector SU pin 6 (Right Audio). 3. Enter the Adjustment Mode and select the Audio Function. 4. Set the data for Item "3 WDE" for minimum 300 Hz signal. 5. Change the modulation frequency to 3kHz. 6. Adjust the data for Item "4 SPC" for minimum 3kHz signal.
CIRCUIT ADJUST MODE
Layer ........ Cable/DBS/DTV Activate ........ MENU-0-3-5-7 Function .................AUDIO Item No. .................VIDEO Adjust Data ...........ADJUST Save Data .... .........ENTER Exit ..............MENU (twice)

Input Terminal RF Input

ST

SU
6 4

Page 18

[On Screen Display] 3. Character Position
Measuring Instrument Test Point Ext. Trigger Measuring Range Input Signal Input Terminal Video Signal (NTSC/HD) ANT-A / DTV INPUT

MODELS: HD-5000 / HD5000A To position the character display horizontally. Purpose: Symptom: 1. 2. 3. 4. 5. 6. 7. Incorrect display position

Supply a 480i signal to Ant-A and select Ant-A as the source. Enter the `ADJUST GFX PLANE' mode, press "MENU-0-3-9-9". Adjust "OSDSD" to center the OSD horizontally/vertically. Press "MENU" to save data and exit the mode. Supply an 1080i signal to DTV INPUT and select DTV INPUT as the source. Adjust "OSDHD" to center the OSD horizontally/vertically. Press "MENU" to save data and exit the mode.

CIRCUIT ADJUST MODE
Layer ........ Cable/DBS/DTV Activate ........ MENU-0-3-9-9 Adjus t Data ...........ADJUST Save Data .... .........ENTER Exit ..............MENU (twice)

[Video Circuit] 4. Main/Sub Y Level
Measuring Instrument Test Point Ext. Trigger Measuring Range Input Signal Input Terminal Oscilloscope EA connector pins 15 & 1 ----------Color Bars Video Input

Purpose Symptom:

To set picture luminance Excess or insufficient brightness.

1. 2. 3. 4. 5. 6.

Supply a color bar signal to a Video Input (not an RF input). Select the color bar signal for both the main and sub pictures. Connect the oscilloscope to connector EA pin 15. Activate the Adjustment Mode Select Item "3 YDRM" in the MNTS function. Adjust the data for 0.7 Vp-p max. - 0.67 Vp-p min. at EA pin 15. (If it cannot be adjusted within this range, set to the lower value) 7. Move the oscilloscope to EA pin 1. 8. Select Item "3 YDRS" in the SNTS function. 9. Adjust the data to equal the MAIN-Y Gain (+0.01V -0.04V).

CIRCUIT ADJUST MODE
Layer ........ Cable/DBS/DTV Activate ........ MENU-0-3-5-7 Function .................AUDIO Item No. .................VIDEO Adjust Data ...........ADJUST Save Data .... .........ENTER Exit ..............MENU (twice)
ST SU
6 4

Page 19

[Gain & Offset Alignment] 5. 480P / 1080i Color Alignment
Measuring Instrument Test Point Ext. Trigger Measuring Range Input Signal Input Terminal Oscilloscope Y/Pb/Pr OUTPUTS -----10 (usec/div)
200 (mV/div) / 10 (mV/div)

MODELS: HD-5000 / HD-5000A Purpose: To set picture chroma on 480P and 1080i Symptom: Output color does not match input color

Color Bar / Black Raster 480P & 1080i

(1) Connect an oscilloscope to Y/Pb/Pr of OUTPUTS TO DISPLAY on the back panel. (terminated at 75) . (2) Input a full color bar signal (with 100% white level) of 480p (Y/Pb/Pr) to DTVINPUT. (3) Go to the alignment mode (MENU+ 0 3 5 7). (4) Select Video ADC by using `Audio' button on remote. (5) Adjust VideoADC item 10 GGAI so that the Y p-p is is equal to the source Y p-p level (+/- 0.03V). (6) Adjust VideoADC item 11 BGAI so that the Pb p-p is equal to the source Pb p-p level (+/- 0.03V). (7) Adjust VideoADC item 9 RGAI so that the Pr p-p is equal to the source Pr p-p level (+/- 0.03V). (8) Input a black raster signal of 480p (Y/Pb/Pr) to DTV-INPUT. (9) Adjust VideoADC item 13 GOFS so that the Y offset level is 0.00Vp-p+/-0.01V. (10) Adjust VideoADC item 14 BOFS so that the Pb offset level is 0.00Vp-p+/-0.01V. (11) Adjust VideoADC item 12 ROFS so that the Pr offset level is 0.00Vp-p+/-0.01V. (12) Switch input signal to 1080i and restart at #2.

Y/Pb/Pr Adjustment Area

Y p-p

Offset Level

Pr p-p Pb p-p

Page 20

MODELS: HD-5000 / HD-5000A

CHIP PARTS REPLACEMENT
Some resistors, shorting jumpers (0 Ohm resistors), ceramic capacitors, transistors and diodes are chip parts. The following precautions should be taken when replacing these parts. Cautions: 1. Use a fine tipped, well insulated soldering iron (approximately 30 watts), and tweezers. 2. Melt the solder and remove the chip parts carefully so as not to tear the copper foil from the printed circuit board. 3. Discard removed chips; do not reuse them. 4. Do not apply heat for more than 3 (three) seconds to new chip parts. 5. Avoid using a rubbing stroke when soldering. 6. Take care not to scratch, or damage the chip parts when soldering. 7. Supplementary cementing is not required. Chip Parts Removal (Resistors, Capacitors, etc.) 1. Grasp the part with tweezers. Melt the solder at both sides alternately, and remove one side of the part with a twisting motion. 2. Melt the solder at the other side and remove the part. Chip Parts Removal (Transistors) 1. Melt the solder of one lead and lift the side of that lead upward. 2. Simultaneously melt the solder of the other two leads and lift the part from the PCB.

Replacement 1. Presolder the contact points on the circuit pattern. 2. Press the part downward with tweezers and apply the soldering iron as shown.

PAGE 21

MODELS: HD-5000 / HD-5000A

REPLACEMENT PARTS
Parts Ordering To expedite delivery of replacement parts orders, specify the following: 1. Model Number/Serial Number 2. Part Number and description 3. Quantity Note: Unless complete information is supplied, delay in processing of orders will result. Critical and Warranty Parts Designation Critical Electrical Components are indicated by Bold Type in the Parts List, and in the schematic diagrams by shading. Warranty Return Parts are indicated in the Parts List with an (*).

Parts Tolerance Codes Refer to the following chart for tolerance characteristics of electrical components.
MARK Tolerance % B ± 0.1 C ± 0.25 D ± 0.5 F ±1 G ±2 J ±5 K ± 10

MARK Tolerance %

M ± 20

N ± 30

V ± 10

X + 40 -20

Z + 80 -20

P + 100 -0

Q + 30 -10

MARK Tolerance (pF)

M ± 0.1

N ± 0.25

V ± 0.5

X ±1

Z ±2

PAGE 22

MODELS: HD-5000 / HD-5000A
[#] Model Legend: (a) HD-5000, (b) HD-5000A Ref # Part # Part Name & Description INTEGRATED CIRCUITS IC201 IC202 IC2A00 IC2A60 IC2B00 IC2C00 IC2C01 IC2D01 IC2E00 IC2F50 IC2F60 IC2F70 IC2F80 IC2H00 IC2K00 IC2L00 IC2R00 IC2V00 IC2V01 IC2V02 IC2V03 IC2V90 IC2Y01 IC301 IC3A01 IC5100 IC5101 IC5102 IC5103 IC5251 IC5252 IC5253 IC5290 IC52A0 IC52A1 IC52A2 IC5300 IC5301 IC5302 IC5303 IC53A0 IC53A1 IC53A2 IC53A3 IC53J3 IC53J4 IC53J6 IC53J7 IC53J8 IC53J9 IC53K0 IC5400 IC5403 IC5407 IC5408 IC5409 IC5410 IC5411 263P384010 263P384010 270P870010 272P938010 270P870010 275P496010 275P531010 272P379020 270P658030 272P379020 272P379020 275P718010 275P718010 270P658030 270P623010 270P623010 275P269010 270P663020 270P664010 263P384010 270P870010 275P419010 270P526020 270P938010 270P467010 275P686010 275P624010 274P670010 275P679010 270P988010 270P877010 270P877010 270P677030 275P715020 275P662020 270P806030 275P957010 275P672010 275P675010 275P666010 275P888010 275P888010 275P888010 275P888010 275P970010 270P998010 275P894010 275P778010 270P997010 275P464010 271P004010 275P677010 275P864010 275P124040 275P665010 275P379020 275P122020 275P674010 IC-C-MOS - TC74HC221AF-EL IC-C-MOS - TC74HC221AF-EL IC - CXA2151Q IC - M52055FP IC - CXA2151Q IC-C-MOS - UPD64082GF-3BA IC-C-MOS - MSM54V16258B IC - LM1881MX (NSC) IC - CXA2019AQ/T4 IC - LM1881MX (NSC) IC - LM1881MX (NSC) IC-C-MOS - TC74HC4053FT IC-C-MOS - TC74HC4053FT IC - CXA2019AQ/T4 IC - CXA2069Q IC - CXA2069Q IC-C-MOS - ADM331EARS IC - CXA2101AQ IC - CXA2102Q IC-C-MOS - TC74HC221AF-EL IC - CXA2151Q IC-C-MOS - SN74AHCT1G126DBV IC - MM1111XF IC - MC33202D IC - TDA9855 IC-C-MOS - TSB41AB3PFP IC-C-MOS - TSB42AA4 IC - 24LC04BT*SN IC-C-MOS - TC74LCX74FT IC-OP AMP - LM358M IC - UPC3217GV IC - UPC3217GV IC - BAO9FP IC-C-MOS - BCM3510KPF P22 IC-C-MOS - CY7C1019CV33-15 IC - SI-3018LSA IC-C-MOS - TL811A3 IC-C-MOS - RM5231-200Q IC-C-MOS - SN74LV125APWR IC-C-MOS - MAX6358SYUT-T IC-C-MOS - MT48LC16M16A2TG IC-C-MOS - MT48LC16M16A2TG IC-C-MOS - MT48LC16M16A2TG IC-C-MOS - MT48LC16M16A2TG IC-C-MOS - SIL170BCL64 IC-C-MOS - LM317EMP IC-C-MOS - AD9883AKST-110 IC-C-MOS - AD7196AKS IC-C-MOS - SM5301AS IC-C-MOS - TC7WH14FK IC - CM1208-08MS IC-C-MOS - SN74LVC573APWR IC-C-MOS - MD2211-D16-V3 IC-C-MOS - SN74LVC245APWR IC-C-MOS - M66230FP IC-C-MOS - SN74LVC00APW IC-C-MOS - SN74LV32APWR IC-C-MOS - SN74LV123APWR a [#] Ref # IC5412 IC54A0 IC54K1 IC54K5 IC54Z1 IC54Z3 IC54Z4 IC55A0 IC55A2 IC55A3 IC55A4 IC55A6 IC55A7 IC55A8 IC55A9 IC55C2 IC55C3 IC55C4 IC55E0 IC55E1 IC55E2 IC55E3 IC55F0 IC5600 IC5601 IC5602 IC5603 IC5604 IC5605 IC5606 IC5607 IC5670 IC56A0 IC56C0 IC5900 IC59P0 IC7A00 IC7A01 IC7A02 IC7A03 IC7A04 IC7A05 IC7A06 IC7A08 IC7A09 IC7A10 IC7A11 IC7D00 IC7D01 IC7D02 IC7D03 IC7D10 IC7D11 IC7E00 IC7E01 IC7E02 IC7E03 IC7E10 IC7E11 Part # 275P664010 275P726010 275P673010 275P270010 275P657050 275P657050 270P880010 275P685040 275P669010 275P689010 275P689010 275P741020 275P741020 275P741020 275P741020 275P668010 275P680010 275P680010 279P069030 275P464010 275P388010 275P679010 267P158010 275P379020 275P659010 279P069030 275P661040 275P678010 274D104020 275P464010 275P660020 270P938010 275P169030 276P019090 270P953010 270P879010 276P017010 275P533010 270P706020 271P023010 271P023010 271P023010 271P023010 271P023010 271P023010 271P023010 271P023010 275P451010 275P560010 275P560010 275P560010 275P535010 275P535010 275P451010 275P560010 275P560010 275P560010 275P535010 275P535010 Part Name & Description IC-C-MOS - IDTQS34XVH245Q3 IC-C-MOS - PIC17C43T-25/L IC-C-MOS - RTC-8563SA IC-C-MOS - M66010GP IC-C-MOS - 24LC256T-I/SN IC-C-MOS - 24LC256T-I/SN IC - 24LC64I/SN IC-C-MOS - TL850D IC-C-MOS - MK2771-15 IC-C-MOS - ICS551MT IC-C-MOS - ICS551MT IC-C-MOS - MT48LC8M16A2TG IC-C-MOS - MT48LC8M16A2TG IC-C-MOS - MT48LC8M16A2TG IC-C-MOS - MT48LC8M16A2TG IC-C-MOS - MK2716STR IC-C-MOS - TC74VCX257FT IC-C-MOS - TC74VCX257FT IC - SN74LVTH244APW IC-C-MOS - TC7WH14FK IC-C-MOS - ICS1523M IC-C-MOS - TC74LCX74FT HIC - AF-9317B IC-C-MOS - SN74LVC00APW IC-C-MOS - CS8414-CSR IC - SN74LVTH244APW IC-C-MOS - CS493002-CLR IC-C-MOS - SN74LVTH16374DGG IC-C-MOS - AT_49LV001_12TC IC-C-MOS - TC7WH14FK IC-C-MOS - CS4341-KSR IC - MC33202D IC-C-MOS - M65677FP IC-C-MOS - M4A3-128/64-55VC IC - MIC39300-2.5BU IC - SC1566IM-2.5 IC-C-MOS - M306V7FGFP IC-C-MOS - M24C64WM6T IC - MAX823REUK IC - SN74CBTD1G125DBVR IC - SN74CBTD1G125DBVR IC - SN74CBTD1G125DBVR IC - SN74CBTD1G125DBVR IC - SN74CBTD1G125DBVR IC - SN74CBTD1G125DBVR IC - SN74CBTD1G125DBVR IC - SN74CBTD1G125DBVR IC-C-MOS - TC74HC4066AFN IC-C-MOS - ADS931E IC-C-MOS - ADS931E IC-C-MOS - ADS931E IC-C-MOS - TC74AC157FN-ELP IC-C-MOS - TC74AC157FN-ELP IC-C-MOS - TC74HC4066AFN IC-C-MOS - ADS931E IC-C-MOS - ADS931E IC-C-MOS - ADS931E IC-C-MOS - TC74AC157FN-ELP IC-C-MOS - TC74AC157FN-ELP [#]

PAGE 23

MODELS: HD-5000 / HD-5000A
[#] Model Legend: (a) HD-5000, (b) HD-5000A Ref # IC7G01 IC7G04 IC7G04 IC7G05 IC7G05 IC7H00 IC7H01 IC7H02 IC7H03 IC7H04 IC7H05 IC7H06 IC7H07 IC7H08 IC7H09 IC7H11 IC7H11 IC7H12 IC7H12 IC7H13 IC7H13 IC7H14 IC7H14 IC7R1 IC8000 IC8001 IC801 IC802 IC803 IC8D04 IC8D05 IC9A20 IC9A21 IC9A22 IC9B00 IC9C00 IC9C01 IC9C02 IC9C03 IC9C04 IC9C05 IC9C20 IC9C40 IC9C50 Part # 275P247010 275P534010 275P681010 275P534010 275P681010 275P714010 275P714010 275P436030 275P439030 270P506010 263P384010 270P348010 275P437020 270P348010 274P901010 275P535010 275P769010 275P535010 275P769010 275P535010 275P769010 275P535010 275P769010 270P575020 275P980010 270P817010 271P009010 270P817010 275P464010 275P997010 275P982010 267P159010 270P816010 267P076030 270P872010 270P677020 270P677030 270P677030 270P950010 270P817010 270P677030 270P677010 270P696010 270P817010 Part Name & Description IC-C-MOS - MB40C958VPFV IC-C-MOS - TC74HCT574AFW-ELP IC-C-MOS - TC74HCT574AFW IC-C-MOS - TC74HCT574AFW-ELP IC-C-MOS - TC74HCT574AFW IC-C-MOS - NT56V1616A0T-7 IC-C-MOS - NT56V1616A0T-7 IC-C-MOS - TMC57127PPM IC-C-MOS - MSM534031E IC - M51957BFP IC-C-MOS - TC74HC221AF-EL IC - TLC2932IPW IC - SLA4028 IC - TLC2932IPW IC-C-MOS - TC74HCT7007AF IC-C-MOS - TC74AC157FN-ELP IC-C-MOS - TC74AC157FT IC-C-MOS - TC74AC157FN-ELP IC-C-MOS - TC74AC157FT IC-C-MOS - TC74AC157FN-ELP IC-C-MOS - TC74AC157FT IC-C-MOS - TC74AC157FN-ELP IC-C-MOS - TC74AC157FT IC - NJM78M05DLA - TEI IC-C-MOS - SAA7115HL IC - L4931CDT33-TR IC - RT9172-25CG IC - L4931CDT33-TR IC-C-MOS - TC7WH14FK IC-C-MOS - IP00C720 IC - MT48LC2M32B2-7 HIC - STR-G6623 IC - NJM431L HIC - SI-3050C IC - HIP6006CB IC - BA05FP IC - BAO9FP IC - BAO9FP IC - NJM78M09DL1A(TE1) IC - L4931CDT33-TR IC - BAO9FP IC - BA033FP IC - BA05SFP IC - L4931CDT33-TR [#] Ref # Part # 260P846030 261P067030 Part Name & Description DTC143ZKAT146 DTC124EKA/RT1N241C [#]

a b a b Ref # Q5250 Q54A2 Q901 Q902 Q9A20 Q9A21 Q9A22 Q9A54 Q9B00 Q9B01 Q9B02

TRANSISTORS Conventional Transistors (By Ref #) Part # 261P026010 261P114010 260P691010 260C004010 261P101010 260C004010 260C004010 260C004010 261P136010 261P136010 261P133010 Part Name & Description TR - 2SC3356 TR - 2SA1585STPR TR - 2SA1358-Y TR - 2SC1740S-R,S/2SC3311A-R,S TR - PHP21N06T TR - 2SC1740S-R,S/2SC3311A-R,S TR - 2SC1740S-R,S/2SC3311A-R,S TR - 2SC1740S-R,S/2SC3311A-R,S TR - FDS6680A TR - FDS6680A TR - FDS6612A DIODES D2M22 D5280 D52A0 D5300 D5301 D53J0 D53J9 D53K0 D5401 D54K0 D55A0 D7H01 D7K21 D7K22 D7K23 D7K24 D7K25 D7K26 D7K27 D7K28 D7K29 D9A01 D9A21 D9A22 D9A23 D9A24 D9A25 D9A28 D9A29 D9A30 D9A31 D9A32 D9A33 D9A34 D9A35 D9B00 D9B01 D9B02 D9B04 D9B05 264P822010 262P089010 262P071070 262P802010 262P802010 264P846010 262P802010 262P802010 262P071070 264P808010 262P078010 264P828010 262P099010 262P099010 262P099010 262P099010 262P099010 262P099010 262P099010 262P099010 262P099010 262P031010 264P899010 264P045080 264P045080 264P045080 264P045080 264P045080 264P460060 262P066010 264P045080 264P045080 264P628010 264P470080 264P469090 264P669030 264P718010 264P669030 264P458050 264P461050 D-CHIP - HSM2838 DIODE - MA2S728 DIODE-LE - SML-210FT D-CHIP - 1SS302 D-CHIP - 1SS302 DIODE-CHIP - MA732 D-CHIP - 1SS302 D-CHIP - 1SS302 DIODE-LE - SML-210FT DIODE-CHIP - DAN202K DIODE - LM385M3-1.2 D-CHIP - DAN202U/MA142WK DIODE-LE-CHIP - SML011BBT DIODE-LE-CHIP - SML011BBT DIODE-LE-CHIP - SML011BBT DIODE-LE-CHIP - SML011BBT DIODE-LE-CHIP - SML011BBT DIODE-LE-CHIP - SML011BBT DIODE-LE-CHIP - SML011BBT DIODE-LE-CHIP - SML011BBT DIODE-LE-CHIP - SML011BBT DIODE - D6SB80 DIODE - BYV26E DIODE - 1S2076A/1S2471OM DIODE - 1S2076A/1S2471OM DIODE - 1S2076A/1S2471OM DIODE - 1S2076A/1S2471OM DIODE - 1S2076A/1S2471OM DIODE - EQA02-05C/RD5.1EB1 DIODE - RU4A DIODE - 1S2076A/1S2471OM DIODE - 1S2076A/1S2471OM DIODE - FMB-G14L DIODE - EQA02-32C/RD33EB4 DIODE - EQA02-28C/RD30EB2 DIODE - S3L20U DIODE - FR155 DIODE - S3L20U DIODE - RD3.9EB1 DIODE - EQA02-06B/RD5.6EB3

a b a b a b a b

b b b b b

TRANSISTORS CHIP Type Transistors (Listed by Part No.) Part No. 260P806010 260P807030 260P817010 260P817020 260P817050 260P817080 260P818010 260P818050 260P818080 260P835030 260P836090 Description DTA124EK/UN2112 DTC124EKAT146 2SA1037K-Q 2SA1037K-R 2SA1037K-R,S/2SB709AI-R,S 2SA1037K-R,S 2SC2412K-Q 2SC2412K-R,S/2SD601AI-R,S 2SC2412K-R,S 2SC2413K-Q 2SC3326-A,B

PAGE 24

MODELS: HD-5000 / HD-5000A
[#] Model Legend: (a) HD-5000, (b) HD-5000A Ref # Part # Part Name & Description COILS L1A06 L1A07 L1A09 L1A13 L1A50 L1A51 L1B06 L1B07 L1B09 L1B13 L1B50 L1B51 L2991 L2992 L2993 L2995 L2A00 L2A60 L2B00 L2C01 L2C03 L2C05 L2C06 L2D01 L2D03 L2D08 L2D20 L2E03 L2E25 L2F50 L2F60 L2F70 L2F80 L2H60 L2H61 L2K42 L2L42 L2M00 L2M20 L2R00 L2V01 L2V02 L2V03 L2V06 L2V10 L2V72 L2V95 L2W01 L2X01 L2X30 L2Y10 L2Y30 L301 L3A37 L5105 L5115 L5125 L51P2 409P923060 409P923060 325C146030 409P923060 325C146030 321C114010 409P923060 409P923060 325C146030 409P923060 325C146030 321C114010 409P876040 409P876040 409P876040 409P876040 325C241030 325C241030 325C241030 325C146050 409P777080 409P777080 409P777080 325C146030 325C146030 409P777080 325C146030 409P777080 409P777080 409P923060 409P777080 409P923060 409P923060 325C146030 325C146030 409P777080 409P777080 409P777080 409P777080 325C461090 409P923060 409P923060 325C241050 325C242010 325C241050 325C242010 409P923060 325C242010 409P923060 409P923060 409P923060 409P923060 325C241030 409P923060 351P216010 351P216010 351P216010 409P865020 EMI-F-CHIP - BLM21B272S EMI-F-CHIP - BLM21B272S COIL-CHIP - 10MH-J EMI-F-CHIP - BLM21B272S COIL-CHIP - 10MH-J COIL-RF - 2200MH-J EMI-F-CHIP - BLM21B272S EMI-F-CHIP - BLM21B272S COIL-CHIP - 10MH-J EMI-F-CHIP - BLM21B272S COIL-CHIP - 10MH-J COIL-RF - 2200MH-J EMI-F-CHIP - CNF20C221S/CKD510JB1H221S EMI-F-CHIP - CNF20C221S/CKD510JB1H221S EMI-F-CHIP - CNF20C221S/CKD510JB1H221S EMI-F-CHIP - CNF20C221S/CKD510JB1H221S COIL-CHIP - 10MH-K COIL-CHIP - 10MH-K COIL-CHIP - 10MH-K COIL-CHIP - 15MH-J EMI-F-CHIP - BLM21P221S EMI-F-CHIP - BLM21P221S EMI-F-CHIP - BLM21P221S COIL-CHIP - 10MH-J COIL-CHIP - 10MH-J EMI-F-CHIP - BLM21P221S COIL-CHIP - 10MH-J EMI-F-CHIP - BLM21P221S EMI-F-CHIP - BLM21P221S EMI-F-CHIP - BLM21B272S EMI-F-CHIP - BLM21P221S EMI-F-CHIP - BLM21B272S EMI-F-CHIP - BLM21B272S COIL-CHIP - 10MH-J COIL-CHIP - 10MH-J EMI-F-CHIP - BLM21P221S EMI-F-CHIP - BLM21P221S EMI-F-CHIP - BLM21P221S EMI-F-CHIP - BLM21P221S COIL-PEAKING - 33MH-K EMI-F-CHIP - BLM21B272S EMI-F-CHIP - BLM21B272S COIL-CHIP - 15MH-K COIL-CHIP - 47MH-K COIL-CHIP - 15MH-K COIL-CHIP - 47MH-K EMI-F-CHIP - BLM21B272S COIL-CHIP - 47MH-K EMI-F-CHIP - BLM21B272S EMI-F-CHIP - BLM21B272S EMI-F-CHIP - BLM21B272S EMI-F-CHIP - BLM21B272S COIL-CHIP - 10MH-K EMI-F-CHIP - BLM21B272S COIL-CH-CHIP - 857CM-0009 COIL-CH-CHIP - 857CM-0009 COIL-CH-CHIP - 857CM-0009 EMI-F-CHIP - BLM11A601S [#] Ref # L51P3 L51P4 L5205 L5205 L5206 L5206 L5207 L5207 L5208 L5208 L5230 L5233 L5250 L5250 L5251 L5252 L5253 L5253 L5254 L5256 L5290 L5291 L5292 L52A0 L52A1 L52A2 L52A3 L5300 L5301 L5302 L5303 L53J1 L53J2 L53J3 L53J4 L53J5 L53J6 L53J7 L53J8 L53J9 L5400 L5401 L5402 L5403 L54D0 L54D1 L54D2 L54D3 L55A0 L55A1 L55A2 L55A3 L55A4 L55C0 L55E0 L55E1 L55E2 L55E3 L55E4 L55E5 Part # 409P777080 409P777080 409P936030 409P956020 409P936030 409P956020 409P936030 409P956020 409P936030 409P956020 325C240050 325C342050 325C140050 325C144090 325C140050 325C140050 325C140010 325C140040 325C140010 409P956010 325C140050 325C340050 325C140050 409P777080 409P777080 409P956010 409P956010 325C341070 409P777080 409P777080 409P777080 409P865090 409P865090 409P865090 409P865090 409P865090 409P865090 409P865090 409P865090 409P865090 409P876020 409P876020 409P876020 409P876020 409P876020 409P876020 409P876020 409P876020 409P777080 409P777080 409P777080 409P777080 409P777080 409P777080 409P944010 409P944010 409P944010 409P945010 409P945010 409P945010 Part Name & Description [#]

EMI-F-CHIP - BLM21P221S EMI-F-CHIP - BLM21P221S EMI-F-CHIP - BK1608 HS470 EMI-F-CHIP - BLM18AG221S a EMI-F-CHIP - BK1608 HS470 EMI-F-CHIP - BLM18AG221S a EMI-F-CHIP - BK1608 HS470 EMI-F-CHIP - BLM18AG221S a EMI-F-CHIP - BK1608 HS470 EMI-F-CHIP - BLM18AG221S a COIL-CHIP - 2.2MH-M COIL-CHIP - 100MH-K COIL-CHIP - 2.2MH-M/K/J COIL-CHIP - 0.68MH-M -OR-K COIL-CHIP - 2.2MH-M/K/J COIL-CHIP - 2.2MH-M/K/J COIL-CHIP - 1MH-M COIL-CHIP - 1.8MH-M -OR-K-OR-J COIL-CHIP - 1MH-M EMI-F-CHIP - BLM18PG121S COIL-CHIP - 2.2MH-M/K/J COIL-CHIP - 2.2MH-M COIL-CHIP - 2.2MH-M/K/J EMI-F-CHIP - BLM21P221S EMI-F-CHIP - BLM21P221S EMI-F-CHIP - BLM18PG121S EMI-F-CHIP - BLM18PG121S COIL-CHIP - 22MH-K EMI-F-CHIP - BLM21P221S EMI-F-CHIP - BLM21P221S EMI-F-CHIP - BLM21P221S EMI-F-CHIP - BLM11A121S EMI-F-CHIP - BLM11A121S EMI-F-CHIP - BLM11A121S EMI-F-CHIP - BLM11A121S EMI-F-CHIP - BLM11A121S EMI-F-CHIP - BLM11A121S EMI-F-CHIP - BLM11A121S EMI-F-CHIP - BLM11A121S EMI-F-CHIP - BLM11A121S EMI-F-CHIP - CNF20C470S/CKD510JB1H470S EMI-F-CHIP - CNF20C470S/CKD510JB1H470S EMI-F-CHIP - CNF20C470S/CKD510JB1H470S EMI-F-CHIP - CNF20C470S/CKD510JB1H470S EMI-F-CHIP - CNF20C470S/CKD510JB1H470S EMI-F-CHIP - CNF20C470S/CKD510JB1H470S EMI-F-CHIP - CNF20C470S/CKD510JB1H470S EMI-F-CHIP - CNF20C470S/CKD510JB1H470S EMI-F-CHIP - BLM21P221S EMI-F-CHIP - BLM21P221S EMI-F-CHIP - BLM21P221S EMI-F-CHIP - BLM21P221S EMI-F-CHIP - BLM21P221S EMI-F-CHIP - BLM21P221S EMI-F-CHIP - NFL21SP107X1 EMI-F-CHIP - NFL21SP107X1 EMI-F-CHIP - NFL21SP107X1 EMI-F-CHIP - NFL21SP506X13CD EMI-F-CHIP - NFL21SP506X13CD EMI-F-CHIP - NFL21SP506X13CD

PAGE 25

MODELS: HD-5000 / HD-5000A
[#] Model Legend: (a) HD-5000, (b) HD-5000A Ref # L55E6 L55E7 L55F0 L55F1 L55F2 L55F4 L55F5 L55F6 L5602 L5603 L56C0 L56D0 L56D1 L5900 L5901 L5905 L5906 L59A0 L59A1 L59E0 L59K0 L59K1 L59L0 L59M0 L59M1 L59N0 L59R0 L59R3 L7A01 L7A02 L7A03 L7C20 L7C21 L7C22 L7C23 L7C24 L7D01 L7D11 L7D12 L7D13 L7D14 L7D15 L7E01 L7E11 L7E12 L7E13 L7E14 L7E15 L7G00 L7G10 L7G11 L7G12 L7H10 L7H11 L7H12 L7H13 L7H14 L7H15 L7H16 L7H17 Part # 409P945010 409P945010 409P945010 409P945010 409P945010 409P876020 409P945010 409P945010 325C141030 325C141030 325C341030 409P945010 409P945010 409P809010 325C241050 325C241030 325C241050 409P809010 409P777080 411P012010 325C241050 325C141030 409P923060 325C140050 325C141090 325C141090 325C341030 325C341030 325C146030 409P923060 409P923060 409P923060 409P923060 409P777050 409P777050 409P777050 325C241030 325C242010 409P777020 325C241030 325C241030 325C241030 325C241030 325C242010 409P777020 325C241030 325C241030 325C241030 325C242050 325C242050 325C241030 325C241030 325C241030 409P777080 325C241030 325C241030 325C241030 325C241030 325C241030 325C241030 Part Name & Description [#] Ref # L7H19 L7H20 L7H30 L7H31 L7H32 L7H38 L7H40 L7H41 L7H42 L7H50 L7H60 L7H70 L7H80 L7K01 L8000 L8001 L8002 L801 L802 L803 L804 L8D05 L8D06 L8D08 L8D09 L9A02 L9A20 L9A21 L9A22 L9A23 L9A24 L9B01 L9B02 L9B03 L9B04 L9D00 L9D01 LC2J01 LC2J02 LC2J03 LC2J04 LC2J05 LC7D02 LC7D05 LC7D10 LC7D11 LC7D12 LC7D13 LC7D14 LC7E10 LC7E11 LC7E12 LC7E13 LC7E14 LC7G01 LC7G02 LC7G03 LC7G04 LC7G05 LC7G06 Part # 409P777080 325C241030 325C241030 325C241030 409P777080 325C241030 325C241030 409P777080 409P777080 409P777080 325C241030 325C241030 325C241030 325C242050 409P777080 409P923060 409P777080 409P777080 409P777080 325C241030 409P777080 409P777080 409P777080 409P777080 409P777080 351P223010 411D009020 411D009020 321C141020 321C141020 321C141020 321C140060 321C141070 321C140060 321C140060 351P222010 351P222010 409P876060 409P876060 409P876060 409P876060 409P876060 409P875090 409P875090 409P876020 409P876020 409P876020 409P876020 409P876020 409P876020 409P876020 409P876020 409P876020 409P876020 409P876020 409P876020 409P876020 409P876020 409P876020 409P876020 Part Name & Description [#]

EMI-F-CHIP - NFL21SP506X13CD EMI-F-CHIP - NFL21SP506X13CD EMI-F-CHIP - NFL21SP506X13CD EMI-F-CHIP - NFL21SP506X13CD EMI-F-CHIP - NFL21SP506X13CD EMI-F-CHIP - CNF20C470S/CKD510JB1H470S EMI-F-CHIP - NFL21SP506X13CD EMI-F-CHIP - NFL21SP506X13CD COIL-CHIP - 10MH-K COIL-CHIP - 10MH-K COIL-CHIP - 10MH-K EMI-F-CHIP - NFL21SP506X13CD EMI-F-CHIP - NFL21SP506X13CD EMI-FILTER - BNX002-01 COIL-CHIP - 15MH-K COIL-CHIP - 10MH-K COIL-CHIP - 15MH-K EMI-FILTER - BNX002-01 EMI-F-CHIP - BLM21P221S FERRITE-BEAD COIL-CHIP - 15MH-K COIL-CHIP - 10MH-K EMI-F-CHIP - BLM21B272S COIL-CHIP - 2.2MH-M/K/J COIL-CHIP - 33MH-K COIL-CHIP - 33MH-K COIL-CHIP - 10MH-K COIL-CHIP - 10MH-K COIL-CHIP - 10MH-J EMI-F-CHIP - BLM21B272S EMI-F-CHIP - BLM21B272S EMI-F-CHIP - BLM21B272S EMI-F-CHIP - BLM21B272S EMI-F-CHIP - BLM21B201S EMI-F-CHIP - BLM21B201S EMI-F-CHIP - BLM21B201S COIL-CHIP - 10MH-K COIL-CHIP - 47MH-K EMI-F-CHIP - BLM21A05 COIL-CHIP - 10MH-K COIL-CHIP - 10MH-K COIL-CHIP - 10MH-K COIL-CHIP - 10MH-K COIL-CHIP - 47MH-K EMI-F-CHIP - BLM21A05 COIL-CHIP - 10MH-K COIL-CHIP - 10MH-K COIL-CHIP - 10MH-K COIL-CHIP - 100MH-K COIL-CHIP - 100MH-K COIL-CHIP - 10MH-K COIL-CHIP - 10MH-K COIL-CHIP - 10MH-K EMI-F-CHIP - BLM21P221S COIL-CHIP - 10MH-K COIL-CHIP - 10MH-K COIL-CHIP - 10MH-K COIL-CHIP - 10MH-K COIL-CHIP - 10MH-K COIL-CHIP - 10MH-K

EMI-F-CHIP - BLM21P221S COIL-CHIP - 10MH-K COIL-CHIP - 10MH-K COIL-CHIP - 10MH-K EMI-F-CHIP - BLM21P221S COIL-CHIP - 10MH-K COIL-CHIP - 10MH-K EMI-F-CHIP - BLM21P221S EMI-F-CHIP - BLM21P221S EMI-F-CHIP - BLM21P221S COIL-CHIP - 10MH-K COIL-CHIP - 10MH-K COIL-CHIP - 10MH-K a COIL-CHIP - 100MH-K EMI-F-CHIP - BLM21P221S EMI-F-CHIP - BLM21B272S EMI-F-CHIP - BLM21P221S EMI-F-CHIP - BLM21P221S b EMI-F-CHIP - BLM21P221S b COIL-CHIP - 10MH-K b EMI-F-CHIP - BLM21P221S b EMI-F-CHIP - BLM21P221S b EMI-F-CHIP - BLM21P221S b EMI-F-CHIP - BLM21P221S b EMI-F-CHIP - BLM21P221S b FILTER-LINE - SLF15N0601 FERRITE-CORE - ZBF503D-01 FERRITE-CORE - ZBF503D-01 COIL-RF - 8.2MH COIL-RF - 8.2MH COIL-RF - 8.2MH COIL-RF - 2.7MH-M COIL-RF - 22MH-K COIL-RF - 2.7MH-M COIL-RF - 2.7MH-M FILTER-LINE - ELF24V050A FILTER-LINE - ELF24V050A EMI-F-CHIP - CNF20R102S/CKD510JB1H1025 EMI-F-CHIP - CNF20R102S/CKD510JB1H1025 EMI-F-CHIP - CNF20R102S/CKD510JB1H1025 EMI-F-CHIP - CNF20R102S/CKD510JB1H1025 EMI-F-CHIP - CNF20R102S/CKD510JB1H1025 EMI-F-CHIP - ELKE103FA EMI-F-CHIP - ELKE103FA EMI-F-CHIP - CNF20C470S/CKD510JB1H470S EMI-F-CHIP - CNF20C470S/CKD510JB1H470S EMI-F-CHIP - CNF20C470S/CKD510JB1H470S EMI-F-CHIP - CNF20C470S/CKD510JB1H470S EMI-F-CHIP - CNF20C470S/CKD510JB1H470S EMI-F-CHIP - CNF20C470S/CKD510JB1H470S EMI-F-CHIP - CNF20C470S/CKD510JB1H470S EMI-F-CHIP - CNF20C470S/CKD510JB1H470S EMI-F-CHIP - CNF20C470S/CKD510JB1H470S EMI-F-CHIP - CNF20C470S/CKD510JB1H470S EMI-F-CHIP - CNF20C470S/CKD510JB1H470S EMI-F-CHIP - CNF20C470S/CKD510JB1H470S EMI-F-CHIP - CNF20C470S/CKD510JB1H470S EMI-F-CHIP - CNF20C470S/CKD510JB1H470S EMI-F-CHIP - CNF20C470S/CKD510JB1H470S EMI-F-CHIP - CNF20C470S/CKD510JB1H470Sa

PAGE 26

MODELS: HD-5000 / HD-5000A
[#] Model Legend: (a) HD-5000, (b) HD-5000A Ref # LC7G07 LC7G08 LC7G09 LC7G10 LC7G11 LC7G12 LC7G13 LC7G14 LC7G15 LC7J03 LC7J04 LC7J05 LC7J10 LC7J13 LC7J14 LC7J15 LF56A1 LF7D00 LF7D01 LF7D02 LF7E00 LF7E01 LF7E02 LF7G00 LF7G01 LF7G02 Part # 409P876020 409P875090 409P875090 409P876020 409P876020 409P876020 409P876020 409P876020 409P876020 409P876020 409P876020 409P876020 409P876020 409P876020 409P876020 409P876020 409P900010 409P901010 409P901010 409P901010 409P901010 409P901010 409P901010 409P901010 409P901010 409P901010 Part Name & Description [#] Ref # Part # Part Name & Description Part No. 103P503040 103P814040 103P494040 103P494050 103P503050 103P494070 103P503060 103P494090 103P503070 103P495010 103P503080 103P495020 103P503090 103P495040 103P496000 103P496010 103P504030 103P496050 103P504050 103P496070 103P504060 103P504070 103P504080 103P497030 103P504090 103P497050 103P505000 103P505010 103P505020 103P505050 103P505090 103P506000 103P506010 [#] Value 1/16W 5.6K-J 1/16W 6.2K-D 1/16W 6.2K-F 1/16W 6.8K-F 1/16W 6.8K-J 1/16W 8.2K-F 1/16W 8.2K-J 1/16W 10K-F 1/16W 10K-J 1/16W 12K-F 1/16W 12K-J 1/16W 13K-F 1/16W 15K-J 1/16W 16K-F 1/16W 30K-F 1/16W 33K-F 1/16W 33K-J 1/16W 47K-F 1/16W 47K-J 1/16W 56K-F 1/16W 56K-J 1/16W 68K-J 1/16W 82K-J 1/16W 100K-F 1/16W 100K-J 1/16W 120K-F 1/16W 120K-J 1/16W 150K-J 1/16W 180K-J 1/16W 330K-J 1/16W 680K-J 1/16W 820K-J 1/16W 1M-J

EMI-F-CHIP - CNF20C470S/CKD510JB1H470Sa EMI-F-CHIP - ELKE103FA EMI-F-CHIP - ELKE103FA EMI-F-CHIP - CNF20C470S/CKD510JB1H470S EMI-F-CHIP - CNF20C470S/CKD510JB1H470S EMI-F-CHIP - CNF20C470S/CKD510JB1H470S EMI-F-CHIP - CNF20C470S/CKD510JB1H470Sa EMI-F-CHIP - CNF20C470S/CKD510JB1H470S EMI-F-CHIP - CNF20C470S/CKD510JB1H470S EMI-F-CHIP - CNF20C470S/CKD510JB1H470Sa EMI-F-CHIP - CNF20C470S/CKD510JB1H470S EMI-F-CHIP - CNF20C470S/CKD510JB1H470S EMI-F-CHIP - CNF20C470S/CKD510JB1H470S EMI-F-CHIP - CNF20C470S/CKD510JB1H470Sa EMI-F-CHIP - CNF20C470S/CKD510JB1H470Sa EMI-F-CHIP - CNF20C470S/CKD510JB1H470Sa FILTER-LP - 7MHZ SMD LP-FILTER - 14MHZ SMD LP-FILTER - 14MHZ SMD LP-FILTER - 14MHZ SMD LP-FILTER - 14MHZ SMD LP-FILTER - 14MHZ SMD LP-FILTER - 14MHZ SMD LP-FILTER - 14MHZ SMD LP-FILTER - 14MHZ SMD LP-FILTER - 14MHZ SMD TRANSFORMERS

T9A20 350P766020 TRANS-PWR - ETS35AASJ3ND T9B00 350P788010 TRANS-PWR - TCGSB 60262R7M1 RESISTORS CHIP Type Resistors (Listed by Value) Part No. 103P489050 103P409050 103P509050 103P509000 103P400010 103P500010 103P500030 103P500050 103P910050 103P500070 103P500090 103P844030 103P501000 103P911000 103P501000 103P501010 103P509090 103P401030 103P501030 103P911030 103P501030 103P490030 103P501040 Value 1/4W 00HM 1/8W 0OHM 1/16W 0OHM 1/16W 6.8-J 1/10W 10-J 1/16W 10-J 1/16W 15-J 1/16W 22-J 1/16W 22-J 1/16W 33-J 1/16W 47-J 1/16W 56-D 1/16W 56-J 1/16W 56-J 1/16W 56-J 1/16W 68-J 1/16W 75-J 1/10W 100-J 1/16W 100-J 1/16W 100-J 1/16W 100-J 1/16W 120-F 1/16W 120-J Part No. 103P810050 103P490050 103P501050 103P490060 103P490070 103P501060 103P490090 103P501070 103P491000 103P491010 103P501080 103P491020 103P491030 103P501090 103P401090 103P491050 103P502000 103P502010 103P491080 103P491090 103P502020 103P492000 103P492010 Value 1/16W 150-D 1/16W 150-F 1/16W 150-J 1/16W 160-F 1/16W 180-F 1/16W 180-J 1/16W 220-F 1/16W 220-J 1/16W 240-F 1/16W 270-F 1/16W 270-J 1/16W 300-F 1/16W 330-F 1/16W 330-J 1/10W 330-J 1/16W 390-F 1/16W 390-J 1/16W 470-J 1/16W 510-F 1/16W 560-F 1/16W 560-J 1/16W 620-F 1/16W 680-F

Part No. Value 103P502030 1/16W 680-J 103P492020 1/16W 750-F 103P492030 1/16W 820-F 103P502040 1/16W 820-JP 103P492050 1/16W 1K-F 103P502050 1/16W 1K-J 103P492070 1/16W 1.2K-F 103P502060 1/16W 1.2K-J 103P492080 1/16W 1.3K-F 103P492090 1/16W 1.5K-F 103P502070 1/16W 1.5K-J 103P493000 1/16W 1.6K-F 103P493010 1/16W 1.8K-F 103P502080 1/16W 1.8K-J 103P493030 1/16W 2.2K-F 103P502090 1/16W 2.2K-J 103P493040 1/16W 2.4K-F 103P493050 1/16W 2.7K-F 103P503000 1/16W 2.7K-J 103P495070 1/16W 22K-F 103P504010 1/16W 22K-J 103P495080 1/16W 24K-F 103P495090 1/16W 27K-F 103P493020 1/16W 2K-F 103P493060 1/16W 3K-F 103P493070 1/16W 3.3K-F 103P503010 1/16W 3.3K-J 103P506070 1/16W 3.3M-J 103P493090 1/16W 3.9K-F 103P503020 1/16W 3.9K-J 103P494010 1/16W 4.7K-F 103P503030 1/16W 4.7K-J 103P494020 1/16W 5.1K-F 103P494030 1/16W 5.6K-F

RESISTORS Conventional Resistors (By Ref #) Ref # R5290 R54E4 R54E5 R902 R903 R904 R905 R906 R9A02 R9A03 R9A04 R9A05 R9A06 R9A09 R9A10 R9A11 R9A12 R9A20 Part # 103C188040 103C180020 103C180020 103C181000 103P713010 103P142020 103P713000 103P714070 102P338040 109C010010 103P145020 109C010010 109C010010 103P144090 103P713040 103P144090 103P713030 103P713010 Part Name & Description R-METAL - 2W 2.2-J R-METAL - 2W 12-J R-METAL - 2W 12-J R-METAL - 2W 56-J R-CARBON - 1/4W 3.3K-J R-CARBON - 1/2W 560-J R-CARBON - 1/4W 2.7K-J R-CARBON - 1/4W 68K-J R-CEMENT-WIRE - 15W 2.2-K R-COMP - 1/2W 1M-K R-CARBON - 1/2W 180K-J R-COMP - 1/2W 1M-K R-COMP - 1/2W 1M-K R-CARBON - 1/2W 100K-J R-CARBON - 1/4W 5.6K-J R-CARBON - 1/2W 100K-J R-CARBON - 1/4W 4.7K-J R-CARBON - 1/4W 3.3K-J

PAGE 27

MODELS: HD-5000 / HD-5000A
[#] Model Legend: (a) HD-5000, (b) HD-5000A Ref # R9A21 R9A22 R9A23 R9A24 R9A25 R9A26 R9A27 R9A28 R9A29 R9A30 R9A31 R9A32 R9A33 R9A34 R9A35 R9A36 R9A37 R9A38 R9A39 R9A40 R9A41 R9A42 R9A43 R9A44 R9A51 R9A52 R9A84 R9A85 R9B12 R9B13 R9C21 R9D00 Part # 103C393090 103C183070 103P710070 103P713040 103P713010 103P712030 103C187050 103P711070 103C187050 103P712090 103P712050 103P713070 103P711030 103P710050 103P715010 103P714090 103P712090 103P713010 103P711030 103P712010 103P712050 103P712050 103P465000 103P463050 103C398070 103C398070 103P715040 103P714050 103P140010 103P140010 103C188000 109D036020 Part Name & Description R-METAL-P - 3W 15K-J R-METAL - 2W 10K-J R-CARBON - 1/4W 33-J R-CARBON - 1/4W 5.6K-J R-CARBON - 1/4W 3.3K-J R-CARBON - 1/4W 680-J R-METAL - 2W 0.39-J R-CARBON - 1/4W 220-J R-METAL - 2W 0.39-J R-CARBON - 1/4W 2.2K-J R-CARBON - 1/4W 1K-J R-CARBON - 1/4W 10K-J R-CARBON - 1/4W 100-J R-CARBON - 1/4W 22-J R-CARBON - 1/4W 150K-J R-CARBON - 1/4W 100K-J R-CARBON - 1/4W 2.2K-J R-CARBON - 1/4W 3.3K-J R-CARBON - 1/4W 100-J R-CARBON - 1/4W 470-J R-CARBON - 1/4W 1K-J R-CARBON - 1/4W 1K-J R-METAL - 1/4W 2.4K-F R-METAL - 1/4W 2.7K-F R-METAL-P - 3W 3.9-K R-METAL-P - 3W 3.9-K R-CARBON - 1/4W 270K-J R-CARBON - 1/4W 47K-J R-CARBON - 1/2W 10-J R-CARBON - 1/2W 10-J R-METAL - 2W 1-J R-COMP - 1/2W 4.7M-K [#] Ref # Part # Part Name & Description Part No. 141P139050 141P139070 141P139090 141P144050 141P146080 181P526010 141P134070 141P135070 141P144060 141P144060 181P526020 141P133010 181P520010 181P520030 181P522060 181P880070 181P520040 181P528010 154P337040 154P329030 [#] Value B25V/16V 0.15 M-K B16V 0.22M-K B16V 0.47M-K F16V 0.47M-Z B10V 0.47M-K 50V 1M-M B16V 1M-K F16V 1M-Z F16V 1M-Z F16V 1M-Z 50V 2.2M-M B10V 3.3M-M 6.3V 22M-M 105C 6.3V 47M-M 6V 47M-M 6.3V 100M-M 6.3V 100M-M 4V 220M-M 105C CH50V/25V SL50V/25V

Part No. 141P143080 141P133080 141P143080 141P133080 141P143080 141P142020 141P142030 141P142070 141P142090 141P144010 141P143010 172P392030 172P392040 172P391030 141P134090 141P143030 141P144020 141P138020 172P392050

Value F50V 0.01M-Z F50V 0.01M-Z F50V 0.01M-Z F50V 0.01M-Z F50V 0.01M-Z B50V 0.012M-K B50V 0.015M-K B25V 0.033M-K B25V 0.047M-K F50V 0.047M-Z B25V 0.068M-K 16V 0.068M-J 16V 0.082M-J 16V 0.01M-J F50V 0.1M-Z B16V 0.1M-K F25V 0.1M-Z B50V 0.1M-K 16V 0.1M-J

CAPACITORS AND TRIMMERS Conventional Capacitors (By Ref #) Ref # C1A10 C1A29 C1A30 C1A31 C1A50 C1B10 C1B29 C1B30 C1B31 C1B50 C2A00 C2A50 C2A51 C2A60 C2A62 C2A63 C2A64 C2A65 C2A66 C2A67 C2B00 C2B50 C2B51 C2C05 C2C09 C2C86 C2C93 C2D04 C2D08 C2D17 C2D19 C2D20 C2E02 Part # 181P355090 181P352040 181P352040 181P352040 172P262010 181P355090 181P352040 181P352040 181P352040 172P262010 181P352030 181P352030 181P352030 181P352030 181P352040 181P352040 181P352040 181P352040 181P352040 181P352040 181P352030 181P352030 181P352030 181P219010 181P219010 181P219010 181P219010 181P212070 181P212060 181P352010 181P212060 181P352040 181P355010 Part Name & Description C-ELEC - 50V 100M-M C-ELEC - 16V 100M-M C-ELEC - 16V 100M-M C-ELEC - 16V 100M-M C-M-POLY - 50V 0.047M-J C-ELEC - 50V 100M-M C-ELEC - 16V 100M-M C-ELEC - 16V 100M-M C-ELEC - 16V 100M-M C-M-POLY - 50V 0.047M-J C-ELEC - 16V 47M-M C-ELEC - 16V 47M-M C-ELEC - 16V 47M-M C-ELEC - 16V 47M-M C-ELEC - 16V 100M-M C-ELEC - 16V 100M-M C-ELEC - 16V 100M-M C-ELEC - 16V 100M-M C-ELEC - 16V 100M-M C-ELEC - 16V 100M-M C-ELEC - 16V 47M-M C-ELEC - 16V 47M-M C-ELEC - 16V 47M-M C-ELEC - 16V 10M-M C-ELEC - 16V 10M-M C-ELEC - 16V 10M-M C-ELEC - 16V 10M-M C-ELEC - 16V 100M-M C-ELEC - 16V 47M-M C-ELEC - 16V 22M-M C-ELEC - 16V 47M-M C-ELEC - 16V 100M-M C-ELEC - 50V 1M-M

CAPACITORS CHIP Type Capacitors (Listed by Value) Part No. 154P340010 154P340030 154P350040 154P330090 154P341010 154P351020 154P341030 154P341050 154P351060 154P341090 154P352020 154P342030 154P352040 154P342050 154P352060 154P342070 154P352080 154P342090 154P353000 154P343030 154P343050 154P353060 154P343070 Value CK50V 1P-C CK50V 2P-C SL50V 2P-C CH50V 8P-C CH50V 10P-C SL50V 10P-J CH50V 12P-J CH50V 15P-J SL50V 15P-J CH50V 22P-J SL50V 27P-J CH50V 33P-J SL50V 33P-J CH50V 39P-J SL50V 39P-J CH50V 47P-J SL50V 47P-J CH50V 56P-J SL50V 56P-J CH50V 82P-J CH50V 100P-J SL50V 100P-J CH50V 120P-J Part No. 154P354000 141P140010 154P344030 154P344050 154P344070 141P140050 154P345010 154P355020 141P140060 154P345030 154P345050 141P140090 141P143050 154P345090 172P390010 141P141010 141P141050 141P141070 172P391020 141P142000 141P142010 141P143080 141P133080 Value SL50V 150P-J B50V 220P-K CH50V 220P-J CH50V 270P-J CH50V 330P-J B50V 470P-K CH50V 470P-J SL50V 470P-J B50V 560P-K CH25V 560P-J CH25V 680P-J B50V 1000P-K F50V 1000P-Z CH25V 1000P-J 50V 1000P-J B50V 1500P-K B50V 3300P-K B50V 4700P-K 16V 8200P-J B50V 8200P-K B50V 0.01M-K F50V 0.01M-Z F50V 0.01M-Z

PAGE 28

MODELS: HD-5000 / HD-5000A
[#] Model Legend: (a) HD-5000, (b) HD-5000A Ref # C2E03 C2E24 C2E33 C2F30 C2F54 C2F64 C2F70 C2F80 C2H33 C2H60 C2H63 C2J02 C2K01 C2K03 C2K08 C2K10 C2K15 C2K17 C2K24 C2K30 C2K50 C2K52 C2K54 C2K60 C2K63 C2K65 C2L08 C2L10 C2L15 C2L17 C2L22 C2L24 C2L30 C2L49 C2L50 C2L60 C2L65 C2M00 C2M01 C2M02 C2M03 C2M20 C2M22 C2M23 C2M30 C2M31 C2M32 C2R05 C2V07 C2V11 C2V27 C2V30 C2V43 C2V44 C2V54 C2V72 C2V98 C2W04 C2X01 Part # 181P351080 181P211010 181P355040 181P352040 181P210040 181P210040 181P352030 181P352030 181P355040 181P352030 181P352030 181P211010 181P216050 181P216050 181P216050 181P216050 181P216050 181P216050 181P124040 181P124040 181P216050 181P216050 181P216050 181P216050 181P216050 181P212070 181P216050 181P216050 181P216050 181P216050 181P216050 181P216050 181P216050 181P582070 181P216050 181P216050 181P212070 181P351070 181P211010 181P351070 181P212070 181P35208