Text preview for : HCD-ED1.pdf part of Sony HCD-ED1 sony Service manual HCD-ED1 Ver 1.1 2001. 06
With SUPPLEMENT-1
Back to : HCD-ED1.part1.rar | Home
HCD-ED1
SERVICE MANUAL
Ver 1.1 2001. 06 With SUPPLEMENT-1 (9-922-706-81)
US Model Canadian Model AEP Model UK Model E Model
HCD-ED1 is the tuner, deck, CD and amplifier section in CMT-ED1.
This stereo system is equipped with the Dolby* Btype noise reduction system. *Dolby noise reduction manufactured under license from Dolby Laboratories Licensing Corporation. "DOLBY" and the double-D symbol a are trademarks of Dolby Laboratories Licensing Corporation.
Model Name Using Similar Mechanism CD SECTION TAPE DECK SECTION Base Unit Type Optical Pick-up Type Model Name Using Similar Mechanism Tape Transport Mechanism Type
NEW BU17-BD19 KSS-213BA/S-N NEW CMAL2Z076A
SPECIFICATIONS
-- Continued on next page --
COMPACT DISC DECK RECEIVER
9-922-706-12
2001F0200-1 © 2001.6
Sony Corporation
Home Audio Company Shinagawa Tec Service Manual Production Group
1
SAFETY CHECK-OUT After correcting the original service problem, perform the following safety checks before releasing the set to the customer: Check the antenna terminals, metal trim, "metallized" knobs, screws, and all other exposed metal parts for AC leakage. Check leakage as described below. LEAKAGE The AC leakage from any exposed metal part to earth Ground and from all exposed metal parts to any exposed metal part having a return to chassis, must not exceed 0.5 mA (500 microampers). Leakage current can be measured by any one of three methods. 1. A commercial leakage tester, such as the Simpson 229 or RCA WT-540A. Follow the manufacturers' instructions to use these instruments. 2. A battery-operated AC milliammeter. The Data Precision 245 digital multimeter is suitable for this job. 3. Measuring the voltage drop across a resistor by means of a VOM or battery-operated AC voltmeter. The "limit" indication is 0.75 V, so analog meters must have an accurate low-voltage scale. The Simpson 250 and Sanwa SH-63Trd are examples of a passive VOM that is suitable. Nearly all battery operated digital multimeters that have a 2V AC range are suitable. (See Fig. A)
CAUTION
Use of controls or adjustments or performance of procedures other than those specified herein may result in hazardous radiation exposure. Notes on chip component replacement · Never reuse a disconnected chip component. · Notice that the minus side of a tantalum capacitor may be damaged by heat. Flexible Circuit Board Repairing · Keep the temperature of soldering iron around 270°C during repairing. · Do not touch the soldering iron on the same conductor of the circuit board (within 3 times). · Be careful not to apply force on the conductor when soldering or unsoldering. Laser component in this product is capable of emitting radiation exceeding the limit for Class 1. This appliance is classified as a CLASS 1 LASER product. The CLASS 1 LASER PRODUCT MARKING is located on the rear exterior. This caution label is located inside the unit.
Parts on Set
0.15µF
1.5k
AC voltmeter (0.75V)
Earth Ground
Fig. A. Using an AC voltmeter to check AC leakage.
SAFETY-RELATED COMPONENT WARNING !! COMPONENTS IDENTIFIED BY MARK ! OR DOTTED LINE WITH MARK ! ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY. ATTENTION AU COMPOSANT AYANT RAPPORT À LA SÉCURITÉ!! LES COMPOSANTS IDENTIFIÉS PAR UNE MARQUE ! SUR LES DIAGRAMMES SCHÉMATIQUES ET LA LISTE DES PIÈCES SONT CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT. NE REMPLACER CES COMPOSANTS QUE PAR DES PIÈCES SONY DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL OU DANS LES SUPPLÉMENTS PUBLIÉS PAR SONY.
2
SERVICING NOTE
NOTES ON HANDLING THE OPTICAL PICK-UP BLOCK OR BASE UNIT The laser diode in the optical pick-up block may suffer electrostatic break-down because of the potential difference generated by the charged electrostatic load, etc. on clothing and the human body. During repair, pay attention to electrostatic break-down and also use the procedure in the printed matter which is included in the repair parts. The flexible board is easily damaged and should be handled with care. NOTES ON LASER DIODE EMISSION CHECK The laser beam on this model is concentrated so as to be focused on the disc reflective surface by the objective lens in the optical pickup block. Therefore, when checking the laser diode emission, observe from more than 30 cm away from the objective lens.
TABLE OF CONTENTS 1. GENERAL .......................................................................... 4 2. DISASSEMBLY
2-1. 2-2. 2-3. 2-4. CD Door, CD Base and Base Unit ........................................ 6 Rear Panel ........................................................................... 6 Bottom Cover and Front Panel Block ................................... 7 Door Cover Assy and Mechanical Deck (Cassette) .............. 7
3. MECHANICAL ADJUSTMENTS ............................... 8 4. ELECTRICAL ADJUSTMENTS ................................. 8 5. DIAGRAMS
5-1. Circuit Boards Location ...................................................... 13 5-2. IC Pin Function ................................................................... 14 5-3. Schematic Diagram -- CD Section -- ............................... 16 5-4. Printed Wiring Board -- CD Section -- ............................. 19 5-5. Schematic Diagram -- Input/Output Section -- ................ 21 5-6. Printed Wiring Board -- Input/Output Section -- .............. 23 5-7. Printed Wiring Board -- Deck Section -- .......................... 25 5-8. Schematic Diagram -- Deck Section -- ............................ 27 5-9. Schematic Diagram -- Display Section -- ........................ 30 5-10. Printed Wiring Board -- Display Section -- ................... 33 5-11. Schematic Diagram -- Power Section -- ........................ 36 5-12. Printed Wiring Board -- Power Section -- ..................... 39 5-13. IC Block Diagrams ........................................................... 41
6. EXPLODED VIEWS
MODEL IDENTIFICATION -- AC POWER SUPPLY CODE -- AEP, East European, CIS model 6-1. 6-2. 6-3. 6-4. 6-5. CD Section ......................................................................... 45 Rear Panl Section ................................................................ 46 Front Panel Section ............................................................. 47 Mechanism Deck Section (Cassette) .................................. 48 Base Unit Section (BU17-BD19) ........................................ 49
7. ELECTRICAL PARTS LIST ........................................ 50
(Without voltage selector) Singapore, Malaysia, Hong Kong model
(With voltage selector) UK model
US, Canadian model
3
SECTION 1 GENERAL
Location of Parts and Controls
FRONT PANEL
1
20
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 Displa y windo w DBFB lamp CD SYNC lamp REC lamp ªbutton BAND FM button POWER b utton TUNING º b utton §button (Push open) VOLUME b utton DECK Lid VOLUME + b utton TUNING ,± + b utton FUNCTON b utton BAND AM button ·button SOUND MODE b utton WIDE lamp Remotesensor NEAR F. lamp
2 3 4 19 18 17 16 15 14 13 9 10 11
5 6 7 8
12
REAR PANEL
1
1 2 3 4 5 6 7 8 9 AM ANTENNA MD IN jacks MD OUT jacks SPEAKER jacks VOLTAGE SELECT OR s witc h (Malaysia, Singapore , Hong K ong models onl FM ANTENNA terminal PHONES jack AM ANTENNA terminals OPTICAL terminal
9
y)
2 8 3 7 6 4
AEP,UK, East European ,CIS model
US,Canadian, Singapore,Malaysia, Hong Kong model
5
4
REMOTE
1 20 2 19 3 4 5 6 7 8 18 17
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 DISPLAY button DBFB b utton CD b utton TUNER/BAND b utton TAPE oebutton DIR MODE b utton CD REPEA T button b uttons ON/OFF b utton b uttons VOL (+/) b utton STEREO/MONO b utton TUNING/PLAY MODE b utton DOLBY NR b utton rREC b utton (re wind/fast f orwar d) b uttons AMS* b uttons (stop) b utton (pause) b utton POWER s witc h
16 15 14 13 12
*AMS=Auto Music Sensor
11 9 10
This section is extracted from instruction manual.
5
SECTION 2 DISASSEMBLY
Note: Follo w the disassemb ly pr ocedure in the n umerical or der given.
2-1. CD DOOR, CD BASE AND BASE UNIT
1 Open the CD door.
2 Bar rubber 5 Two hook screws 6 Three screws (K3x8) 3 Hinge pin
7 Three screws (K3x8) 4 Hinge spring !¡ CD base 9 Three screws (K3x8)
8 Two hook screws
!º Three screws (K3x8) !ª Base unit !· Two springs (compression) !¶ Two washers
!§ Two screws (TPG P2x8) !TM Wire (Flat type) ! Two springs !£ Two screws (TPG P2x8) (compression) !¢ Two washers
2-2. REAR PANEL
7 Rear panel 1 Two screws (BVTP 3x10) 2 Screw (BVTP 3x8) 3 Two screws (BVTP 3x8)
5 Side bracket
4 Three screws (BVTP 3x8)
6 Side bracket
6
2-3. BOTTOM COVER AND FRONT PANEL BLOCK
5 Front panel block
3 Bottom cover
4 Two claws
1 Two screws (BVTP 3x8)
2 Two screws (BVTP 3x8)
2-4. DOOR COVER ASSY AND MECHANICAL DECK (CASSETTE)
4 Four screws (BVTP 3x10)
A 3 Door spring
5 Mechanical deck (cassette)
1 Open the Door cover ASSY. (Push the A portion.) 2 Door cover assy
7
SECTION 3 MECHANICAL ADJUSTMENTS
PRECAUTION 1. Clean the following parts with a denatured alcohol-moistened swab : record/playback heads pinch rollers erase head rubber belts capstan idlers 2. Demagnetize the record/playback head with a head demagnetizer. 3. Do not use a magnetized screwdriver for the adjustments. 4. After the adjustments, apply suitable locking compound to the parts adjusted. 5. The adjustments should be performed with the rated power supply voltage unless otherwise noted. Torque Measurement
Torque FWD FWD back tension REV REV back tension FF/REW FWD tension Torque meter CQ-102C Meter reading 28 to 71g · cm (0.39 0.99 oz · inch) 1 to 7g · cm (0.01 0.10 oz · inch) 28 to 71g · cm (0.39 0.99 oz · inch) 1 to 7g · cm (0.01 0.10 oz · inch) 56 to 122g · cm (0.78 1.69 oz · inch) 100g or more (3.53 oz or more) 100g or more (3.53 oz or more)
SECTION 4 ELECTRICAL ADJUSTMENTS
DECK SECTION 0 dB=0.775V
1. Demagnetize the record/playback head with a head damagnetizer. (Do not bring the head demagnetizer close to the erase head.) 2. Do not use a magnetized screwdriver for the adjustments. 3. After the adjustments, apply suitable locking compound to the parts adjusted. 4. The adjustments should be performed with the rated power supply voltage unless otherwise noted. 5. The adjustments should be performed in the order given in this service manual. (As a general rule, playback circuit adjustment should be completed before performing recording circuit adjustment.) 6. The adjustments should be performed for both L-CH and R-ch. 7. Switches and controls should be set as follows unless otherwise specified.
Tape P-4-A100 WS-48B P-4-L300 Signal 10 kHz, 10 dB 3 kHz, 0 dB 315 Hz, 0 dB Used for Azimuth Adjustment Tape Speed Adjustment Level Adjustment
CQ-102C
Record/Playback Head Azimuth Adjustment Procedure : 1. Mode : Playback
test tape P-4-A100 (10kHz, 10dB) MD OUT (JK301) level meter
CQ-102RC
CQ-102RC
CQ-201B
CQ-403A
set
REV tension
CQ-403R
+
8
2. Turn the adjustment screw and check output peaks. If the peaks do not match for L-CH and R-CH, turn the adjustment screw so that outputs match within 1 dB of peak.
Tape Speed Adjustment Procedure : Mode : Playback
test tape WS-48B (3kHz, 0dB)
frequency counter
L-CH peak
output level
within 1dB
within 1dB
set
+ MD OUT (JK301)
screw position
R-CH peak screw position
1. Insert the WS-48B into the deck, and playback. 2. Adjust the VR770/RELAY board so that the frequency counter reading becomes 3000 ± 90 Hz. Adjustment Location : RELAY board Sample Value of Wow and flutter W.RMS (JIS) less than 0.3% (test tape: WS-48B)
L-CH peak
R-CH peak
3. Mode : Playback
test tape P-4-A100 (10kHz, 10dB) MD OUT (JK301) L set R oscilloscope
Playback Level Adjustment Procedure : Mode : Playback
test tape P-4-L300 (315Hz, 0dB) level meter
MD OUT (JK301)
set
Waveform of oscilloscope
MD OUT (JK301)
in phase
45 ° good
90 °
135 °
180 ° wrong
Deck is VR703 (L-CH) and VR704 (R-CH) so that adjustment within the following adjustment level. Adjustment level : Playback level: 301.5 to 338.3 mV (8.2 to 7.2 dB) level difference between the channels: within ±0.5 dB Adjustment Location : TAPE PREAMP board
4. After the adjustments, apply suitable locking compound to the parts adjusted. Adjustment Location :
FWD side Adjustment screw
REV side
9
Record Bias Adjustment Procedure : 1. Mode : Record
MD IN (JK301) 1) 315Hz } 2) 10kHz 50 mV (23.8 dB) AF OSC 600 attenuator set blank tape CS-123
2. Mode: Playback
recorded position
level meter
set
MD OUT (JK301)
2. Mode : Playback
recorded position level meter
Confirm playback the signal recorded in step 1 become adjustment level as follows. If these levels do not adjustment level, adjustment the VR705 (LCH) and VR706 (R-CH) on the TAPE PREAMP board to repeat steps 1 and 2. Adjustment level : Playback level : 47.2 to 53.0 mV (24.3 to 23.3 dB) Adjustment Location : TAPE PREAMP board Adjustment Location
set
MD OUT (JK301)
[RELAY BOARD] (Component Side) Confirm playback the signal recorded in step 1 become adjustment level as follows. If these levels do not adjustment level, adjustment the VR701 (LCH) and VR702 (R-CH) on the TAPE PREAMP board to repeat steps 1 and 2. Adjustment level : Playback output of 10kHz level diffrence against 315Hz reference should be ±0.5 dB. Adjustment Location : TAPE PREAMP board Record Level Adjustment Procedure : 1. Mode: Record
MD IN (JK301) 315Hz 50 mV (23.8 dB) AF OSC 600 attenuator set
42 1 IC703 22 21
VR770
blank tape CS-123
[TAPE PREAMP BOARD] (Component Side)
VR704 VR703 VR706
VR705
VR702 VR701
10
CD SECTION
Note: 1. CD Block is basically designed to operate without adjustment. Therefore, check each item in order given. 2. Use YEDS-18 disc (3-702-101-01) unless otherwise indicated. 3. Use an oscilloscope with more than 10M impedance. 4. Clean the object lens by an applicator with lens cleaning liquid when the signal level is low than specified value with the following checks. 5. Adjust the focus bias adjustment when optical block is replaced. Focus Bias Adjustment
oscilloscope BD board TP (RF) TP (VC) +
S Curve Check
oscilloscope BD board TP (FEO) TP (VC) +
Procedure : 1. Connect oscilloscope to test point TP (FEO). 2. Connect between test point TP (FOK) and Ground by lead wire. 3. Turn Power switch on. 4. Put disc (YEDS-18) in and turned Power switch on again and actuate the focus search. (actuate the focus search when disc table is moving in and out.) 5. Check the oscilloscope waveform (S-curve) is symmetrical between A and B. And confirm peak to peak level within 2.4 ± 0.7 Vp-p. S-curve waveform
Procedure: 1. Connect oscilloscope to test point TP (RF). 2. Turned Power switch on. 3. Put disc (YEDS-18) in and playback. 4. Adjust RV101 so that the waveform is clear. (Clear RF signal waveform means that the shape "" can be clearly distinguished at the center of the waveform.) 5. After adjustment, check the RF signal level. · RF signal VOLT/DIV: 200 mV TIME/DIV: 500 nS
symmetry
A within 2.4 ± 0.7 Vp-p B
6. After check, remove the lead wire connected in step 2. Note: · Try to measure several times to make sure than the ratio of A : B or B : A is more than 10 : 7. · Take sweep time as long as possible and light up the brightness to obtain best waveform. RF Level Check
level : 1.3 ± 0.3 Vp-p
oscilloscope BD board TP (RF) TP (VC) +
Procedure : 1. Connect oscilloscope to test point TP (RF) on BD board. 2. Turned Power switch on. 3. Put disc (YEDS-18) in and playback. 4. Confirm that oscilloscope waveform is clear and check RF signal level is correct or not. Note: Clear RF signal waveform means that the shape "" can be clearly distinguished at the center of the waveform. RF signal waveform
VOLT/DIV : 200 mV TIME/DIV : 500 nS
level : 1.3 ± 0.3 Vp-p
11
E-F Balance (1 Track Jump) Check (Without remote commander)
oscilloscope BD board TP (TE) TP (VC) +
Adjustment Location: [BD BOARD] -- Component Side --
RF FOK RV101 IC102 PCK 0V B GND
IC101
Procedure : 1. Connect oscilloscpe to test point TP (TE) on BD board. 2. Turn Power switch on. 3. Put disc (YEDS-18) in to play the number five track. 4. Press the "P (Pause)" button. (Becomes the 1 track jump mode) 5. Confirm that the oscilloscope waveform is symmetrical on the top and bottom in relation to 0Vdc, and check this level.
1 track jump waveform
RV103 TEO VC FEO RV102
TEI
FEI
IC104 A
LEVEL : 300 ± 100 mVp-p
Specified level: ·
AB x 100 = less than ± 7% 2 (A + B)
· A + B = 300 ± 100 mVp-p 6. Remove the lead wire connected in step 1. Focus/Tracking Gain Adjustment (RV102, RV103) This gain has a margin, so even if it is slightly off. There is no problem. Therfore, do not perform this adjustment. Please note that it should be fixed to mechanical center position when you moved and do not know original position.
12
SECTION 5 DIAGRAMS
5-1. CIRCUIT BOARDS LOCATION
FM/AM TUNER THIS BLOCK IS SUPPLIED AS THE ASSEMBLED BLOCK FUN/SURROUND board
TAPE PREAMP board VOL/POWER board
BD board DISPLAY board
CD DOOR SW board
CONTROL BLK ASSY THIS BLOCK IS SUPPLIED AS THE ASSEMBLED BLOCK
RELAY board
13
5-2. IC PIN FUNCTION
· IC201 MASTER CONTROL (TC9613) Pin No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 GND XOUT XIN RESET TUNED STEREO TEST POWDEC REMOTE PLL CE PLL CLK PLL DATAI PLL DATAO SERVO CK SUB Q DATA MUTE D CDPOWER CLOSESW FSW SENSE MLAT XLAT XRST SCOR PLAYSW MTRSNS TAPEIN MOTOR SOL AMS PLYMUTE REC/PB DOLBYNR RECMUTE BIAS REC LED CD SYNC WIDE KEYIO 1 KEYIO 2 BANDAREA N.C LOUDSEL N.C FRECSW RRECSW AREF AGND GND Pin Name I/O -- O I I I I I I I O O I O O I O O O I O I O O O I I I I O O I O O O O O O O O I I -- -- I -- I I I I -- Ground 8 MHz Oscillator output 8 MHz Oscillator input CPU reset input Station detector input Stereo signal input Test pin (Connected to ground) Power down detect input Remote signal input Chip enable output Clock output Data input Data output Servo clock output Servo subq data & status input Servo command data output Digital mute control output CD power supply output Top loading close switch input Servo focus down output Servo status SENSE input D/A MLAT output Servo command latch output Servo chip reset output Servo SUBQ sync input Tape play switch input Tape motor reel sense input Tape in switch input Tape control output Tape control output Tape music search input Tape play back mute signal output Tape control output Tape control output Tape recording mute signal output Tape control output Record LED output CD SYNC LED output Wide LED output AD key input (16 keys) AD key input (16 keys) Band area option (Not used) Not used Loudness initial select input Not used Tape forward record switch input Tape reverse record switch input A/D convert refrence input (+5V) A/D convert Input ground input Ground Function
14
Pin No. 51 52 53 54 55 56 57 58 59 60 61 62 63 64-91 92 93 94 95 96 97 98 99 100 VDD
Pin Name NARROW NORMAL LOUD DBFB VOL CLK VOL DATA VOL STB FUNC A FUNC B MDMUTE POWER MUTE A SEG27-SEG0 COM3 COM2 COM1 COM0 VLC N.C N.C N.C VDD
I/O -- O O O -- O O O O O O O O O O O O O O -- -- -- -- +5V power supply Narrow LED output Normal LED output Loudness on/off control output Not used (Connected to ground) Volume control clock output Volume control data output Volume control strobe output
Function
TAPE/TUNER control signal output (00: TAPE/01: TUNER) CD/MD control signal output (10: CD/11: MD) MD/REC ON mute output System power output Audio mute control output LCD segment output LCD common 3 output LCD common 2 output LCD common 1 output LCD common 0 output LCD drive power supply output Not used (Connected to ground) Not used (Connected to ground) Not used (Connected to ground) +5V power supply
15
5-13. IC BLOCK DIAGRAMS
CD SECTION IC101 CXA1782BQ
RF M PHD2 PHD1 RF O RF I PHD CC1 CC2 FOK CP CB LD
IC102 BA6397FP
DRIVE BUFFER
36
35
34
33
32
31
30
29
28
27
26
25
OUT1A 1
DRIVE BUFFER
28 GND
+ +
+
OUT1B
2 LEVEL SHIFT DRIVE BUFFER
27 OUT4A
+
IN1A
3
THERMAL SHUT DOWN
26 OUT4B LEVEL SHIFT DRIVE BUFFER
+ +
APC LEVELS
+
FOK
+
MIRR
RF IV AMP1
+
TTL RF IV AMP2 FE BIAS 37 TTL · IIL DATA RESISTOR · INPUT SHIFT RESISTOR · ADDRESS DECODER IIL
+
FE AMP
IIL
F 38
+
F IV AMP
+
E 39
+
FZC COMP
EI 40 TE AMP
BAL1 BAL2 BAL3
SPOD
SPOC
SPOB
SPOA
XLON
DATO
CLKO
VDD XLTO
CLOK
+
· TRACKING HPF COMP LPF COMP · PHASE COMPENSATION TG1 TM6 · ISET 17 ISET
64 63 62 61 60 59 58 57 56 55 54 53 52
VEE 41 TEO 42
+
FOK 1
SERVO AUTO SEQUENCER CPU INTERFACE
XLAT
CNIN
SEIN
TOG1
TOG2
TOG3
+
TZC COMP · FCS PHASE COMPENSATION
TM5 TM4 15 SL M
LPFI 43 TEI 44 ATSC 45 TZC 46 TDFCT 47 DFCT · WINDOW COMP ATSC DFCT
TM3 FS1 TM1 FS2 TM7
TM2
+
TG2
CLOCK GENERATOR
+
· F SET
VC 48
+
1
FEO
FS4
2
FEI
3
FDFCT
4
FGD
5
FLB
6
FE O
7
FE M
8
SRCH
9
TGU
10
TG2
11
FSET
TA M
PCMD
GTOP
XPCK
CZPO
LRCK
BCLK
XUGF
VDD GFS
RFCK
XROF
MNT3
41
42
MNT1
+
+
+
E IV AMP
+
+
+
IN1B 4 TR-B 5 REG 0 6 REGULATOR
25 IN4A
24 IN4B
23 VC
+
+
IIL 24 SENS
XRST
7
22 VCC
VCC
+
VCC GND 8 21 VCC
DFCT
TTL
23 C. OUT
IN2A
9 DRIVE BUFFER DRIVE BUFFER DRIVER MUTE
20 IN3B
22 XRST
IN2B 10
LEVEL SHIFT
19 IN3A
LEVEL SHIFT
21 DATA
OUT2A 11
18 OUT3B
20 XLT
OUT2B 12 DRIVE BUFFER DRIVE BUFFER
17 OUT3A
· OUTPUT DECODER TOG1-3 BAL1-3 FS1-4 TG1-2 TM1-7 PS1-4
19 CLK
GND 13
16 OP+
OP-OUT 14
15 OP
18 VCC
IC103 CXD2507AQ
5
16 SL 0
MON 2 MDP 3 MDS 4 LOCK 5 TEST 6 FILO 7 FILI 8 PCO 9 VSS 10 AVSS 11 CLTV 12 AVDD 13 RF 14 BIAS 15 ASYI 16 ASYO 17 ASYE 18 WDCK 19
14
SUB CODE PROCESSOR
4
51 DATA 50 XRST 49 SENS DIGITAL CLV 48 MUTE 47 SQCK 46 SQSO 45 EXCK 44 SBSO 43 SCOR 42 VSS 41 WFCK 40 EMPH
14 SL P
DIGITAL PLL
EFM DEMODULATOR
3
13 TA O
ASYMMETRY CORRECTOR
5
D/A INTERFACE
6
DIGITAL OUT
39 DOUT 38 C4M 37 FSTT 36 XTSL 35 XTAO 34 XTAI 33 MNTO
16K RAM
ERROR CORRECTOR
3
12
20 21 22 23 24 25 26 27 28 29 30 31 32
IC104 PCM1710U-B
LRCIN 1 DIN 2 BCKIN 3 4 TIMING CONTROL INPUT INTERFACE
28 ML/DSD 27 MC/DM2 26 MD/DM1 25 MUTE 24 MODE 23 CKSL NOISE SHAPER 22 DGND 21 VDD 5-LEVEL DAC RIGHT 5-LEVEL DAC LEFT 20 VCC2L 19 GND2L 18 EXT1L 3-STAGE AMP RIGHT 3-STAGE AMP LEFT 17 EXT2L 16 VOUTL 15 VCC1
DIGITAL FILTER
MODE CONTROL
CLKO
XTI 5 XTO 6 DGND 7 VDD 8 VCC2R 9 GND2R 10 EXT1R 11 EXT2R 12 VOUTR 13 GND1 14
LOW-PASS FILTER RIGHT
LOW-PASS FILTER LEFT
DECK SECTION IC701 BA3126N
INPUT/OUTPUT SECTION IC301 MC14052BCP
COMMON SEL.A 10 7 VEE DECODER 1 2 2 3 COMMON 4 3 5 1 6 INHIBIT 8 VSS 16 VDD 15 OUT 14 IN R-CH VOLUME 13 LD1 L-CH LATCH R-CH LATCH 12 LD2 11 AGND DATA DECODER, STB GENERATOR INPUT REGISTER 10 STB 9 DATA SEL.B 9 VDD
2
1
0 12
16
15
14
13
11
1 REC SW1
2 GND
3 PB SW1
4 CONT
5 GND
6 VCC
7 PB SW2
8 GND
9 REC SW2
POWER SECTION IC461 TC9260P
VSS 1
OUT 2
IN 3 L-CH VOLUME
LD1 4
LD2 5
AGND 6
CS 7
CK 8
43
0
3
IC351 TA2041F
GND 13 VREF 14 OUT1 15 BIAS 12 VCC
VCC VCC SW 10 SWA VCC 9 OUT2 EXT IN 16 SWITCH a b c SWITCH a b VCC 7 SW C c 8 VCC LF5 17 MIX LEVEL 11 SWB
PS4 18
VCC 6 LF2
PS3 19
5 PS2
VCC LF4 20 LF3 21
4 PS1
VCC HF1 22 LF IN1 23 VCC IN1 24 VCC VCC
VCC 3 LF1 2 LF IN2 VCC 1 IN2
44
SECTION 6 EXPLODED VIEWS
NOTE: · -XX, -X mean standardized parts, so they may have some difference from the original one. · Items marked "*" are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. · The mechanical parts with no reference number in the exploded views are not supplied. · Hardware (# mark) list and accessories and packing materials are given in the last of this parts list. · Abbreviation CND : Canadian model EE : East European model HK : Hong Kong model SP : Singapore model MY : Malaysia model The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. Les composants identifiés par une marque ! sont critiques pour la sécurité. Ne les remplacer que par une piéce portant le numéro spécifié.
6-1. CD SECTION
1
18
#3
2 4 5 7 8 17
#1
3 6 4 18
10 9
#2
#2
#3
#2 #5
#5
15
#5
16 10
#4 #2 Base unit
14 11 12
#3 #3
11 12
13
Ref. No. 1 2 3 4 5 6 7 8 9 10 Part No. 4-997-375-01 4-997-373-01 4-997-355-01 4-997-365-01 4-997-370-01 4-997-356-01 4-997-349-01 4-997-367-01 4-997-369-01 4-997-345-01 Description GLASS DOOR W/PRINGING HINGE PLATE DOOR HINGE HINGE PIN BAR RUBBER HINGE SPRING CD BASE PUSH BUTTON CUSHION HOOK SCREW Remark Ref. No. 11 12 13 * 14 * 14 15 * 16 17 18 Part No. 4-948-503-01 4-997-372-01 1-783-091-11 4-997-350-01 4-997-350-11 4-997-353-01 A-4407-244-A 4-977-376-01 4-977-371-01 Description SPRING (BU), COMPRESSION WASHER WIRE (FLAT TYPE) BACK COVER (US,CND,MY,SP,HK) BACK COVER (AEP,UK,EE,CIS) PICK UP COVER CD DOOR SW BOARD, COMPLETE STOP SPRING STOPPER Remark
45
6-2. REAR PANEL SECTION 54 (UK) 65 66 53
#6 #7
54 (EXCEPT US,CND,UK)
64
63 (HK)
#6 #7 #6
51
52
#13
54 (US,CND)
#7
62
56
55
57
#7 not supplied #7 S501 (MY, SP,HK)
not supplied #7
62
#8
62
#8
62
58
T501 #7
51
59
FRONT PANEL
60
61
#7
61
Ref. No. * 51 52 52 52 * 53 * * * * * 53 53 53 53 53 Part No. 4-997-363-01 1-693-400-21 1-693-400-31 1-693-400-41 4-997-368-11 4-997-368-21 4-997-368-31 4-997-368-41 4-997-368-51 4-997-368-61 1-551-478-00 1-555-750-00 1-751-535-11 4-997-358-01 A-4407-243-A Description SIDE BRACKET FM/AM TUNER (AEP,UK,EE,CIS) FM/AM TUNER (US,CND) FM/AM TUNER (MY,SP,HK) REAR PANEL (AEP) REAR PANEL (UK) REAR PANEL (EE,CIS) REAR PANEL (US,CND) REAR PANEL (MY,SP) REAR PANEL (HK) CORD, POWER (POLAR.SPT-2)(US,CND) CORD, POWER (AEP,EE,CIS,MY,SP,HK) CORD, POWER (UK) AC CORD BUSHING TAPE PREAMP BOARD, COMPLETE Remark
The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. Ref. No. * 58 * 58 * 58 * 59 60 61 * 62 ! 63 64 65 66 ! S501 ! T501 ! T501 ! T501 Part No. Description
Les composants identifiés par une marque ! sont critiques pour la sécurité. Ne les remplacer que par une piéce portant le numéro spécifié. Remark
A-4407-239-A VOL/POWER BOARD, COMPLETE (AEP,UK,EE,CIS) A-4407-240-A VOL/POWER BOARD, COMPLETE (US,CND) A-4407-241-A VOL/POWER BOARD, COMPLETE (MY,SP,HK) 4-997-364-01 BOTTOM BOARD 4-997-352-01 4-997-366-01 4-997-378-01 1-770-019-11 X-4949-451-1 1-501-659-11 1-501-985-11 1-771-308-11 1-431-697-21 1-431-697-31 BOTTOM COVER RUBBER FOOT PC BOARD BRACKET ADAPTOR, CONVERSION PLUG 3P (HK) AM ANT SUB ASSY ANTENNA (FM) (US,CND,MY,SP,HK) LEAD, ANTENNA (AEP,UK,EE,CIS) SELECTOR, POWER (MY,SP,HK) TRANSFORMER, POWER (AEP,UK,EE,CIS) TRANSFORMER, POWER (US,CND)
! 54 ! 54 ! 54 55 * 56 * 57
A-4407-242-A FUN/SURROUND BOARD, COMPLETE
1-431-697-41 TRANSFORMER, POWER (MY,SP,HK)
46
6-3. FRONT PANEL SECTION
105
#7
106
112 114
Z201
113
#7
109 104
#6 #9
107 111
#6
102
103
110
#5
115
108
101
Ref. No. 101 102 103 104 104 * 105 * 105 * 105 * 106 107
Part No. 4-997-351-01 4-997-354-01 X-4949-450-1 1-773-009-11 1-751-688-11
Description
Remark
Ref. No. 108 109 110 111 112 113 114 115 Z201
Part No.
Description
Remark
DOOR COVER DOOR SPRING CASS DOOR SUB ASSY WIRE (FLAT TYPE) (15 CORE) (AEP,UK,EE,CIS) WIRE (FLAT TYPE) (13 CORE) (US,CND,MY,SP,HK) A-4407-247-A DISPLAY BOARD, COMPLETE (AEP,UK,EE,CIS) A-4407-248-A A-4407-249-A A-4407-245-A 4-997-361-01 DISPLAY BOARD, COMPLETE (US,CND) DISPLAY BOARD, COMPLETE (MY,SP,HK) RELAY BOARD, COMPLETE GEAR DAMPER
X-4949-449-1 FRONT PANEL SUB ASSY 4-997-362-01 1-759-548-11 4-997-357-01 4-997-381-01 4-997-382-01 DOOR LATCH DECK, MECHANICAL GEAR HOLDER LCD HOLDER LIGHT BAR
4-997-383-01 DISPLAY FILTER 4-997-374-01 SOLDER LUG 1-803-020-11 DISPLAY PANEL, LIQUID CRYSTAL
47
Ver 1.1 2001.06
6-4. MECHANISM DECK SECTION (CASSETTE)
152
not supplied M901 not supplied not supplied not supplied not supplied
not supplied not supplied
not supplied not supplied not supplied
155 153
157
not supplied
159
not supplied
158
not supplied not supplied not supplied A #11 not supplied #12 not supplied
not supplied
154 (including A )
#11
156
151
Ref. No. 151 152 153 154 155 156 157 158 159 M901
Part No. 1-759-548-11 X-4949-565-1 X-4949-566-1 X-4949-563-1 4-997-983-01 X-4949-568-1 X-4949-569-1 4-997-984-01 X-4949-567-1 X-4949-564-1
Description DECK, MECHANICAL CONTROL BLK ASSY CLUTCH BLK ASSY PLA TE HD BLK ASSY BEL T MAIN ROLLER PINCH BLK R ASSY ROLLER PINCH BLK L ASSY F/R BEL T CLUTCH BLK2 ASSY MTR MAIN BLK ASSY (CAPST
Remark
AN/REEL)
48
Ver 1.1 2001.06
6-5. BASE UNIT SECTION (BU17-BD19) 201
202
#10
203
205
M101 M102
204
204
206
207
208
The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. Ref. No. ! 201 202 203 204 205 Part No. 8-848-387-01 1-769-069-11 4-917-567-01 4-951-940-01 4-917-565-01 Description OPTICAL PICK-UP KSS-213BA/S-N WIRE (FLAT TYPE) (16 CORE) GEAR (M) INSULATOR (BU) SHAFT, SLED Remark Ref. No. 206 * 207 208 M101 M102 Part No. 4-917-564-01 A-4673-402-B 4-951-620-01 X-4950-066-1 X-4917-504-1 Description GEAR (P), FLATNESS BD BOARD, COMPLETE SCREW (2.6X8), +BVTP MOTOR ASSY (SPINDLE) MOTOR ASSY (SLED) Les composants identifiés par une marque ! sont critiques pour la sécurité. Ne les remplacer que par une piéce portant le numéro spécifié. Remark
49
BD
Note: The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. Les composants identifiés par une marque ! sont critiques pour la sécurité. Ne les remplacer que par une piéce portant le numéro spécifié. When indicating parts by reference number, please include the board name. Ref. No. * Part No. Description
SECTION 7 ELECTRICAL PARTS LIST
· Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. · -XX, -X mean standardized parts, so they may have some difference from the original one. · Items marked "*" are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. · RESISTORS All resistors are in ohms METAL: Metal-film resistor METAL OXIDE: Metal Oxide-film resistor F : nonflammable · SEMICONDUCTORS In each case, u: µ , for example: uA...: µ A..., uPA...: µ PA..., uPB...: µ PB..., uPC...: µ PC..., uPD...: µ PD... · CAPACITORS uF : µ F · COILS uH : µ H · Abbreviation CND : Canadian model EE : East European model HK : Hong Kong model SP : Singapore model MY : Malaysia model
Remark
Ref. No. C146 C147 C148 C149
Part No. 1-135-201-11 1-163-275-11 1-163-275-11 1-164-346-11
Description TANTALUM CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 10uF 0.001uF 0.001uF 1uF 10uF 22PF 20% 5% 5%
Remark 4V 50V 50V 16V 6.3V 50V
A-4673-402-B BD BOARD, COMPLETE ****************** < CAPACITOR > C101 C102 C103 C105 C106 C107 C108 C109 C110 C111 C112 C113 C114 C115 C116 C117 C118 C119 C120 C121 C122 C123 C124 C125 C126 C127 C128 C129 C130 C131 C132 C133 C134 C135 C136 C137 C139 C140 C141 C142 C145 1-126-607-11 1-163-275-11 1-164-346-11 1-163-038-91 1-164-695-11 1-164-695-11 1-164-232-11 1-164-232-11 1-163-989-11 1-163-038-91 1-163-038-91 1-164-695-11 1-164-005-11 1-126-607-11 1-163-016-00 1-164-005-11 1-107-823-11 1-163-038-91 1-135-201-11 1-163-038-91 1-164-232-11 1-163-038-91 1-126-607-11 1-164-232-11 1-163-038-91 1-164-695-11 1-163-135-00 1-163-038-91 1-164-336-11 1-163-038-91 1-163-037-11 1-163-145-00 1-164-346-11 1-163-251-11 1-164-005-11 1-164-232-11 1-163-235-11 1-163-235-11 1-163-038-91 1-163-038-91 ELECT CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP TANTALUM CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 47uF 20% 0.001uF 5% 1uF 0.1uF 0.0022uF 5% 0.0022uF 5% 0.01uF 0.01uF 0.033uF 10% 0.1uF 0.1uF 0.0022uF 5% 0.47uF 47uF 20% 0.0039uF 10% 0.47uF 0.47uF 0.1uF 10uF 0.1uF 0.01uF 0.1uF 47uF 0.01uF 0.1uF 4V 50V 16V 25V 50V 50V 50V 50V 25V 25V 25V 50V 25V 4V 50V 25V 16V 25V 4V 25V 50V 25V 4V 50V 25V 50V 50V 25V 25V 25V 25V 50V 16V 50V 25V 50V 50V 50V 25V 25V 4V
C153 C154
1-135-259-11 TANTAL. CHIP 1-163-235-11 CERAMIC CHIP < CONNECTOR >
20% 5%
CNU101 1-770-014-11 CONNECTOR, FFC/FPC 16P CNU102 1-770-013-11 CONNECTOR, FFC/FPC 19P < IC > IC101 IC102 IC103 IC104 8-752-074-34 8-759-291-06 8-752-372-94 8-759-185-29 IC IC IC IC CXA1782CQ BA6397FP CXD2507AQ PCM1710U-B
< MOTOR > M101 M102 X-4917-523-4 MOTOR ASSY (SPINDLE) X-4917-504-1 MOTOR ASSY (SLED) < TRANSISTOR > Q101 Q102 Q103 8-729-010-08 TRANSISTOR MSB710-R 8-729-424-08 TRANSISTOR UN2111 8-729-421-22 TRANSISTOR UN2211 < RESISTOR > R102 R103 R104 R105 R106 R107 R108 R109 R112 R113 R114 R115 R116 R117 R118 R119 R120 R121 1-216-001-00 1-216-049-91 1-216-097-91 1-216-093-00 1-216-093-00 1-216-093-00 1-216-093-00 1-216-097-91 1-216-083-00 1-216-083-00 1-216-101-00 1-216-101-00 1-216-061-00 1-216-069-00 1-216-049-91 METAL CHIP METAL GLAZE METAL GLAZE METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL GLAZE METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL GLAZE 10 1K 100K 68K 68K 68K 68K 100K 27K 27K 150K 150K 3.3K 6.8K 1K 47K 47K 510K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W
10% 20%
20%
0.0022uF 5% 560PF 5% 0.1uF 0.33uF 0.1uF 0.022uF 10% 0.0015uF 5% 1uF 100PF 5% 0.47uF 0.01uF 22PF 22PF 0.1uF 0.1uF
5% 5%
1-135-201-11 TANTALUM CHIP 10uF
20%
1-216-089-91 METAL GLAZE 1-216-089-91 METAL GLAZE 1-216-114-00 METAL GLAZE
50
BD
Ref. No. R122 R123 R124 R125 R126 R127 R128 R129 R130 R131 R132 R133 R134 R135 R136 R137 R138 R139 R140 R141 R142 R143 R144 R145 R146 R147 R148 R149 R150 R151 R152 R153 R154 R156 R157 R158 Part No. Description 100K 120K 56K 6.8K 3.9K 47K 220K 1K 18K 18K 3.3K 3.3K 4.7K 4.7K 10K 4.7K 1K 220 22K 3.3K 3.3K 1M 10K 100K 100K 1K 1K 1K 330 330 330 24K 4.7K 33K 6.8K 10 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% Remark 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W Ref. No. * Part No. 1-216-097-91 METAL GLAZE 1-216-099-00 METAL CHIP 1-216-091-00 1-216-069-00 1-216-063-91 1-216-089-91 1-216-105-91 1-216-049-91 1-216-079-00 1-216-079-00 1-216-061-00 1-216-061-00 1-216-065-00 1-216-065-00 1-216-073-00 1-216-065-00 1-216-049-91 1-216-033-00 1-216-081-00 1-216-061-00 1-216-061-00 1-216-121-91 1-216-073-00 1-216-097-91 1-216-097-91 1-216-049-91 1-216-049-91 1-216-049-91 1-216-037-00 1-216-037-00 1-216-037-00 1-216-082-00 1-216-065-00 1-216-085-00 1-216-069-00 1-216-001-00 METAL CHIP METAL CHIP METAL GLAZE METAL GLAZE METAL GLAZE METAL GLAZE METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL GLAZE METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL GLAZE METAL CHIP METAL GLAZE METAL GLAZE METAL GLAZE METAL GLAZE METAL GLAZE METAL CHIP METAL CHIP METAL CHIP METAL GLAZE METAL CHIP METAL CHIP METAL CHIP METAL CHIP
CD DOOR SW
Description
DISPLAY
Remark
A-4407-244-A CD DOOR SW BOARD, COMPLETE *************************** < SWITCH > S211 1-771-298-11 SWITCH, PUSH (CD DOOR)
************************************************************** * A-4407-247-A DISPLAY BOARD, COMPLETE (AEP,UK,EE,CIS) ************************************* A-4407-248-A DISPLAY BOARD, COMPLETE (US,CND) ********************************* A-4407-249-A DISPLAY BOARD, COMPLETE (MY,SP,HK) *********************************** 4-997-381-01 LCD HOLDER 4-997-382-01 LIGHT BAR 4-997-383-01 DISPLAY FILTER < CAPACITOR > C200 C201 C202 C203 C204 C205 C206 C207 C208 C209 C212 C213 C220 C230 C232 1-126-514-11 1-102-962-00 1-102-953-00 1-136-165-00 1-136-165-00 1-126-916-11 1-136-165-00 1-136-165-00 1-136-165-00 1-136-165-00 1-136-165-00 1-126-177-11 1-136-165-00 1-102-934-00 1-126-177-11 ELECT CERAMIC CERAMIC FILM FILM ELECT FILM FILM FILM FILM FILM ELECT FILM CERAMIC ELECT < CONNECTOR > * CN1 * CN1 1-568-858-11 SOCKET, CONNECTOR 15P (AEP,UK,EE,CIS) 1-784-568-11 CONNECTOR, FFC 13P (US,CND,SP,MY,HK) < DIODE > D201 D202 D203 D210 D211 D212 8-719-920-76 8-719-920-76 8-719-920-76 8-719-920-76 8-719-920-76 DIODE DIODE DIODE DIODE DIODE 1S2076 1S2076 1S2076 1S2076 1S2076 22uF 30PF 18PF 0.1uF 0.1uF 1000uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 100uF 0.1uF 1.0PF 100uF 20% 5% 5% 5% 5% 20% 5% 5% 5% 5% 16V 50V 50V 50V 50V 6.3V 50V 50V 50V 50V
*
*
5% 50V 20% 10V 5% 50V +-0.25PF 50V 20% 10V
< VARIABLE RESISTOR > RV101 RV102 RV103 1-241-396-11 RES, ADJ, METAL GLAZE 22K 1-241-396-11 RES, ADJ, METAL GLAZE 22K 1-241-396-11 RES, ADJ, METAL GLAZE 22K < SWITCH > S101 1-572-085-11 SWITCH, LEAF (LIMIT) < VIBRATOR >
8-719-920-76 DIODE 1S2076 < IC >
X101
1-579-280-11 VIBRATOR, CRYSTAL (16.9344MHz)
************************************************************** IC201 IC202 IC203 8-759-497-90 IC TC9613 8-749-014-39 IC PIC-21041TH2 8-759-165-80 IC PST600C-T < COIL > L201 1-410-521-11 INDUCTOR 100uH
51
DISPLAY
Ref. No. Part No.
FUN/SURROUND
Description < DIODE > Remark Ref. No. R260 R261 R262 R263 R264 R270 R278 R279 R280 R281 R282 R290 Part No. Description 750 820 1.2K 1.5K 2K 10 470 470 470 470 470 10K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% Remark 1/4W 1/4W F 1/4W F (US,CND) 1/4W F 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W F F F F F 1-247-828-11 CARBON 1-249-416-11 CARBON 1-249-418-11 CARBON 1-249-419-11 CARBON 1-247-838-00 CARBON 1-249-393-11 1-249-413-11 1-249-413-11 1-249-413-11 1-249-413-11 CARBON CARBON CARBON CARBON CARBON
LD201 LD202 LD203 LD204 LD205
8-719-989-30 8-719-989-30 8-719-989-30 8-719-989-30 8-719-989-30
DIODE DIODE DIODE DIODE DIODE
EL204HD (WIDE) EL204HD (NEAR F) EL204HD (DBFB) EL204HD (CD SYNC) EL204HD (REC)
< CONNECTOR > M201 M202 M203 1-784-348-11 CONNECTOR 12P 1-784-347-11 CONNECTOR 10P 1-784-349-11 CONNECTOR 25P < LAMP > PL201 1-517-743-11 LAMP < TRANSISTOR > Q201 Q204 Q205 Q206 Q207 Q208 8-729-119-78 8-729-900-63 8-729-900-63 8-729-900-63 8-729-900-63 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR 2SC2785-HFE DTA124ES DTA124ES DTA124ES DTA124ES
1-249-413-11 CARBON 1-249-429-11 CARBON < SWITCH >
1/4W F 1/4W
S200 S201 S202 S203 S204 S205 S206 S207 S208 S209 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W F 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W F 1/4W F 1/4W 1/4W S210
1-571-760-11 1-571-760-11 1-571-760-11 1-571-760-11 1-571-760-11 1-571-760-11 1-571-760-11 1-571-760-11 1-571-760-11 1-571-760-11
SWITCH, KEY BOARD (POWER) SWITCH, KEY BOARD (VOLUME +) SWITCH, KEY BOARD (VOLUME ) SWITCH, KEY BOARD (TUNING +/) +) SWITCH, KEY BOARD (TUNING = 0/) SWITCH, KEY BOARD (BAND P/FM) SWITCH, KEY BOARD (BAND AM/p) SWITCH, KEY BOARD (PLAY ª TC) SWITCH, KEY BOARD (PLAY CD/TC ·) SWITCH, KEY BOARD (FUNCTION)
8-729-900-63 TRANSISTOR DTA124ES < RESISTOR >
R200 R201 R202 R203 R204 R205 R208 R209 R210 R222 R223 R225 R226 R227 R229 R230 R239 R240 R246 R247 R248 R250 R253 R254 R254
1-249-429-11 1-249-435-11 1-249-424-11 1-249-429-11 1-249-437-11 1-249-429-11 1-249-437-11 1-249-429-11 1-249-429-11 1-249-429-11 1-249-429-11 1-249-429-11 1-249-429-11 1-249-429-11 1-249-429-11 1-249-429-11 1-249-425-11 1-249-425-11 1-249-429-11 1-249-429-11
CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON
10K 33K 3.9K 10K 47K 10K 47K 10K 10K 10K 10K 10K 10K 10K 10K 10K 4.7K 4.7K 10K 10K 10K 100 4.7K
1-571-760-11 SWITCH, KEY BOARD (SOUND MODE) < VIBRATOR >
X201
1-767-791-11 VIBRATOR, CRYSTAL (8MHz) < LIQUID CRYSTAL DISPLAY >
Z201
1-803-020-11 DISPLAY PANEL, LIQUID CRYSTAL
************************************************************** * A-4407-242-A FUN/SURROUND BOARD, COMPLETE ***************************** 4-997-378-01 PC BOARD BRACKET 7-685-646-79 SCREW +BVTP 3X8 TYPE2 N-S < CAPACITOR > C307 C308 C309 C310 C311 C312 C313 C314 C315 C316 C317 C318 C319 C320 C351 C352 1-102-074-00 1-102-074-00 1-124-907-11 1-126-963-11 1-161-772-11 1-161-772-11 1-126-963-11 1-126-963-11 1-124-907-11 1-124-907-11 1-124-443-00 1-124-443-00 1-102-114-00 1-102-114-00 1-137-378-11 CERAMIC CERAMIC ELECT ELECT CERAMIC CERAMIC ELECT ELECT ELECT ELECT ELECT ELECT CERAMIC CERAMIC FILM 0.001uF 0.001uF 10uF 4.7uF 0.1uF 0.1uF 4.7uF 4.7uF 10uF 10uF 100uF 100uF 470PF 470PF 0.22uF 0.22uF 10% 10% 20% 20% 10% 10% 20% 20% 20% 20% 20% 20% 10% 10% 5% 5% 50V 50V 50V 50V 25V 25V 50V 50V 50V 50V 10V 10V 50V 50V 50V 50V
*
1-249-429-11 CARBON 1-247-807-31 CARBON 1-249-425-11 CARBON 1-249-420-11 CARBON 1-249-418-11 CARBON
5% 1/4W 5% 1/4W 5% 1/4W F (US,CND,AEP,UK,EE,CIS) 1.8K 5% 1/4W F (US,CND) 1.2K 5% 1/4W F (AEP,UK,EE,CIS) 470 390 390 560 680 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W F F F F F
R255 R256 R257 R258 R259
1-249-413-11 1-249-412-11 1-249-412-11 1-249-414-11 1-249-415-11
CARBON CARBON CARBON CARBON CARBON
1-137-378-11 FILM
52
FUN/SURROUND
Ref. No. C353 C354 C355 C356 C357 C358 C359 C360 C361 C362 C363 C365 C366 C367 C368 C369 C370 C398 Part No. 1-137-378-11 1-137-378-11 1-137-371-11 1-137-365-11 1-130-489-00 1-137-367-11 1-130-481-00 1-137-367-11 1-130-481-00 1-137-365-11 1-137-365-11 1-124-907-11 1-124-907-11 1-104-664-11 1-124-443-00 1-124-907-11 1-124-907-11 1-161-772-11 Description FILM FILM FILM FILM MYLAR FILM MYLAR FILM MYLAR FILM FILM ELECT ELECT ELECT ELECT ELECT ELECT CERAMIC < DIODE > D351 D352 D353 8-719-920-76 DIODE 1S2076 8-719-920-76 DIODE 1S2076 8-719-920-76 DIODE 1S2076 < IC > IC301 IC302 IC351 8-759-000-48 IC MC14052BCP 8-759-505-55 IC NJM4558L 8-759-497-89 IC TA-2041F < JACK > JK301 1-784-362-11 JACK, PIN 4P (MD IN/OUT) < CONNECTOR > M301 1-573-834-11 CONNECTOR, BOARD TO BOARD 20P < TRANSISTOR > Q301 Q302 Q303 8-729-231-55 TRANSISTOR 2SC2878-AB 8-729-231-55 TRANSISTOR 2SC2878-AB 8-729-201-53 TRANSISTOR 2SA1015-GR < RESISTOR > R301 R302 R303 R304 R305 R306 R307 R308 R309 R310 R311 R312 R313 R314 R315 R316 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 1-249-425-11 1-249-425-11 1-249-421-11 1-249-421-11 1-249-441-11 1-249-441-11 1-249-441-11 1-249-441-11 1-249-441-11 CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON 1K 1K 1K 1K 1K 1K 4.7K 4.7K 2.2K 2.2K 100K 100K 100K 100K 100K 100K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. F F F F F F F F F F R361 R362 R363 R364 R367 R368 R369 R370 ! R551 1-249-417-11 1-249-417-11 1-249-429-11 1-249-429-11 1-249-417-11 1-249-417-11 1-249-421-11 1-249-421-11 1-202-725-00 CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON SOLID 1K 1K 10K 10K 1K 1K 2.2K 2.2K 3.3M R356 R357 R358 R359 R360 1-249-432-11 1-249-425-11 1-249-425-11 1-249-437-11 1-249-437-11 CARBON CARBON CARBON CARBON CARBON 18K 4.7K 4.7K 47K 47K R351 R352 R353 R354 R355 1-249-430-11 1-249-430-11 1-249-431-11 1-249-431-11 1-249-429-11 CARBON CARBON CARBON CARBON CARBON 12K 12K 15K 15K 10K R344 R345 R346 R347 R348 1-249-425-11 1-249-437-11 1-249-437-11 1-249-425-11 1-249-421-11 CARBON CARBON CARBON CARBON CARBON 4.7K 47K 47K 4.7K 2.2K 0.22uF 0.22uF 0.015uF 0.0015uF 0.033uF 0.0033uF 0.0068uF 0.0033uF 0.0068uF 0.0015uF 0.0015uF 10uF 10uF 47uF 100uF 10uF 10uF 0.1uF 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 20% 20% 20% 20% 20% 20% 10% Remark 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 16V 10V 50V 50V 25V Ref. No. R317 R318 R319 R320 R321 R322 R323 R324 R329 R330 R335 R336 R337 R338 R339 R340 R341 R342 R343 Part No. 1-249-425-11 1-249-425-11 1-249-441-11 1-249-441-11 1-247-903-00 1-247-903-00 1-249-417-11 1-249-417-11 1-247-815-91 1-247-815-91 1-249-425-11 1-249-425-11 1-249-417-11 1-249-417-11 1-249-441-11 1-249-441-11 1-249-437-11 1-249-437-11 1-249-425-11 Description CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON 4.7K 4.7K 100K 100K 1M 1M 1K 1K 220 220 4.7K 4.7K 1K 1K 100K 100K 47K 47K 4.7K
RELAY
Remark 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 10% 1/4W F 1/4W F 1/4W 1/4W 1/4W 1/4W 1/4W F 1/4W F 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W
F F F F
1/4W 1/4W 1/4W 1/4W 1/4W F 1/4W F 1/4W 1/4W 1/4W F 1/4W F 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W F 1/4W F 1/4W 1/4W 1/4W F 1/4W F 1/4W 1/4W 1/4W F 1/4W F 1/4W F 1/4W F 1/2W (US,CND)
************************************************************** * A-4407-245-A RELAY BOARD, COMPLETE ********************** < CAPACITOR > C210 C211 C214 C215 C216 C217 C218 1-161-051-00 1-126-941-11 1-124-472-11 1-102-106-00 1-102-106-00 CERAMIC ELECT ELECT CERAMIC CERAMIC 0.01uF 470uF 470uF 100PF 100PF 0.01uF 470uF 10% 20% 20% 10% 10% 10% 20% 50V 16V 10V 50V 50V 50V 10V
1-161-051-00 CERAMIC 1-124-472-11 ELECT
1-249-441-11 CARBON
53
Les composants identifiés par une marque ! sont critiques pour la sécurité. Ne les remplacer que par une piéce portant le numéro spécifié.
RELAY
Ref. No. C229 C235 C236 C241 C242 C245 C246 C789 C797 C799 Part No.
TAPE PREAMP
Description 0.001uF 22uF 22uF 4700PF 4700PF 0.1uF 1000uF 0.01uF 0.01uF 0.01uF 10% 20% 20% 10% 10% 10% 20% 10% 10% 10% Remark 50V 50V 50V 50V 50V 25V 16V 50V 50V 50V Ref. No. R235 R236 ! R237 R245 R265 R266 R267 R268 R271 R288 R289 R291 R295 R296 R298 R299 R771 R772 R773 R774 R775 R776 R777 Part No. 1-249-429-11 1-249-429-11 1-212-966-00 1-249-429-11 1-249-429-11 1-249-429-11 1-249-429-11 1-249-429-11 1-249-429-11 1-249-429-11 1-249-429-11 1-249-429-11 1-249-415-11 1-249-415-11 1-249-435-11 1-249-435-11 1-249-425-11 1-249-434-11 1-247-856-00 1-249-430-11 Description CARBON CARBON FUSIBLE CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON 10K 10K 22 10K 10K 10K 10K 10K 10K 10K 10K 10K 680 680 33K 33K 4.7K 27K 11K 12K 12K 1.2K 1.2K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% Remark 1/4W 1/4W 1/2W F 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W F 1/4W F 1/4W 1/4W 1/4W F 1/4W 1/4W 1/4W 1/4W 1/4W F 1/4W F
1-102-074-00 CERAMIC 1-126-233-11 ELECT 1-126-233-11 ELECT 1-102-125-00 1-102-125-00 1-161-772-11 1-126-942-61 1-161-051-00 CERAMIC CERAMIC CERAMIC ELECT CERAMIC
1-161-051-00 CERAMIC 1-161-051-00 CERAMIC < CONNECTOR >
CNU102 1-770-067-11 CONNECTOR, FFC/FPC 19P < DIODE > D200 D206 D207 D208 D209 D770 D771 8-719-911-55 8-719-911-55 8-719-911-55 8-719-920-76 8-719-920-76 DIODE DIODE DIODE DIODE DIODE U05G U05G U05G 1S2076 1S2076
8-719-911-55 DIODE U05G 8-719-911-55 DIODE U05G < COIL >
1-249-430-11 CARBON 1-249-418-11 CARBON 1-249-418-11 CARBON
< VARIABLE RESISTOR > VR770 1-230-497-11 RES, ADJ, CARBON 22K < CONNECTOR > * W103 W201 W202 W203 W301 W703 W901 1-564-704-11 1-784-351-11 1-784-350-11 1-784-352-11 1-573-852-11 PIN, CONNECTOR (SMALL TYPE) 2P CONNECTOR 12P CONNECTOR 10P CONNECTOR 25P CONNECTOR, BOARD TO BOARD 20P
L203
1-408-096-00 INDUCTOR 470uH < CONNECTOR >
* M704
1-564-715-11 PIN, CONNECTOR (SMALL TYPE)13P < TRANSISTOR >
Q202 Q203 Q213 Q214 Q215 Q770 Q771 Q772 Q773
8-729-029-86 8-729-200-36 8-729-029-86 8-729-029-86 8-729-029-86 8-729-200-36 8-729-200-36 8-729-029-86 8-729-029-86
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR < RESISTOR >
DTC124ESA 2SA966-Y DTC124ESA DTC124ESA DTC124ESA 2SA966-Y 2SA966-Y DTC124ESA DTC124ESA
1-766-718-11 CONNECTOR, BOARD TO BOARD 17P 1-766-718-11 CONNECTOR, BOARD TO BOARD 17P
************************************************************** * A-4407-243-A TAPE PREAMP BOARD, COMPLETE **************************** 4-997-378-01 PC BOARD BRACKET 7-685-646-79 SCREW +BVTP 3X8 TYPE2 N-S < CAPACITOR > C483 C484 C700 C703 C704 C705 C706 C707 C708 C709 C710 C711 C712 1-161-051-00 1-161-051-00 1-161-051-00 1-102-113-00 1-102-113-00 1-104-666-11 1-104-666-11 1-102-106-00 1-102-106-00 1-137-372-11 CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC ELECT ELECT CERAMIC CERAMIC FILM 0.01uF 0.01uF 0.01uF 390PF 390PF 220uF 220uF 100PF 100PF 0.022uF 0.022uF 10uF 10uF 10% 10% 10% 10% 10% 20% 20% 10% 10% 5% 5% 20% 20% 50V 50V 50V 50V 50V 10V 10V 50V 50V 50V 50V 50V 50V
*
R206 R207 R213 R214 R215 R217 R218 R219 R220 R221 R224 R231 R232 R233 R234
1-249-430-11 1-249-418-11 1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 1-247-843-11 1-249-429-11 1-249-439-11 1-249-429-11 1-249-429-11
CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON
12K 1.2K 100 100 100 100 100 100 100 100 3.3K 10K 68K 10K 10K
5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5%
1/4W 1/4W F 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W
1-137-372-11 FILM 1-124-907-11 ELECT 1-124-907-11 ELECT
54
The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified.
Les composants identifiés par une marque ! sont critiques pour la sécurité. Ne les remplacer que par une piéce portant le numéro spécifié.
TAPE PREAMP
Ref. No. C713 C714 C715 C716 C717 C719 C720 C721 C722 C723 C724 C725 C726 C727 C728 C729 C730 C731 C732 C741 C742 C743 C744 C745 C746 C747 C748 C749 C750 C751 C752 C753 C754 C756 C758 C761 C762 C798 C799 C801 C802 Part No. Description 100uF 100uF 100uF 0.1uF 10uF 0.01uF 0.01uF 300PF 300PF 330PF 330PF 330PF 330PF 0.01uF 10uF 0.015uF 0.0033uF 0.0033uF 0.0033uF 10uF 10uF 0.0047uF 0.0047uF 4700PF 4700PF 0.1uF 0.1uF 10uF 10uF 1uF 1uF 10uF 10uF 0.01uF 3.3uF 100uF 100uF 0.1uF 0.001uF 10uF 0.1uF 20% 20% 20% 5% 20% 10% 10% 5% 5% 10% 10% 10% 10% 5% 20% 5% 5% 5% 5% 20% 20% 5% 5% 10% 10% 5% 5% 20% 20% 20% 20% 20% 20% 10% 20% 20% 20% 10% 10% 20% 10% Remark 10V 16V 10V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 200V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 10V 10V 25V 50V 50V 25V * M701 * M703 Ref. No. Part No. Description < CONNECTOR > 1-564-709-11 PIN, CONNECTOR (SMALL TYPE) 7P 1-766-720-21 CONNECTOR, BOARD TO BOARD 17P < TRANSISTOR > Q702 Q704 Q705 Q706 Q707 8-729-194-57 8-729-194-57 8-729-194-57 8-729-141-83 8-729-194-57 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR < RESISTOR > R485 R486 R701 R702 R703 R704 R705 R706 R707 R708 R709 R710 R711 R712 R713 R714 R715 R716 R717 R718 R719 R720 R721 R722 R723 R724 R725 R741 R742 R743 R744 R745 R746 R749 R750 R751 R752 R753 R754 R757 R758 R759 R760 R761 R762 1-249-395-11 1-249-395-11 1-247-807-31 1-247-807-31 1-247-889-00 1-247-889-00 1-249-404-00 1-249-404-00 1-247-863-91 1-247-863-91 1-247-882-11 1-247-882-11 1-247-850-11 1-247-850-11 1-247-815-91 1-247-815-91 1-249-437-11 1-247-815-91 1-249-430-11 1-249-430-11 1-249-389-11 1-249-389-11 1-247-863-91 1-247-863-91 1-249-381-11 1-247-863-91 1-249-429-11 1-249-435-11 1-247-863-91 1-249-417-11 1-249-417-11 1-249-426-11 1-249-426-11 1-249-441-11 1-247-891-00 1-249-429-11 1-249-434-11 1-249-429-11 1-249-426-11 1-249-429-11 1-247-840-00 1-249-432-11 1-247-840-00 1-247-866-11 1-247-866-11 CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON 15 15 100 100 270K 270K 82 82 22K 22K 130K 130K 6.2K 6.2K 220 220 47K 220 12K 12K 4.7 4.7 22K 22K 1 22K 10K 33K 22K 1K 1K 5.6K 5.6K 100K 330K 10K 27K 10K 5.6K 10K 2.4K 18K 2.4K 30K 30K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/4W F 1/4W F 1/4W 1/4W 1/4W 1/4W 1/4W F 1/4W F 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W F 1/4W F 1/4W 1/4W 1/4W F 1/4W 1/4W 1/4W 1/4W 1/4W F 1/4W F 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 2SC945-P 2SC945-P 2SC945-P 2SB1094-LK 2SC945-P Remark 1-124-443-00 ELECT 1-104-665-11 ELECT 1-124-443-00 1-137-399-11 1-124-907-11 1-161-051-00 1-161-051-00 1-102-981-00 1-102-981-00 1-102-112-00 1-102-112-00 1-102-112-00 1-102-112-00 1-104-993-91 1-124-907-11 1-137-371-11 1-137-367-11 1-137-367-11 1-137-367-11 1-124-907-11 1-124-907-11 1-137-368-11 1-137-368-11 1-102-125-00 1-102-125-00 1-137-399-11 1-137-399-11 1-124-907-11 1-124-907-11 1-124-903-11 1-124-903-11 1-124-907-11 1-124-907-11 1-161-051-00 1-126-962-11 1-124-443-00 1-124-443-00 1-161-772-11 1-102-074-00 1-124-907-11 1-161-772-11 ELECT FILM ELECT CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC FILM ELECT FILM FILM FILM FILM ELECT ELECT FILM FILM CERAMIC CERAMIC FILM FILM ELECT ELECT ELECT ELECT ELECT ELECT CERAMIC ELECT ELECT ELECT CERAMIC CERAMIC ELECT CERAMIC < IC > IC701 IC702 IC703 JK800 8-759-508-69 8-759-261-93 8-759-363-21 8-749-923-04 IC IC IC IC BA3126N NJM4580LD HA12203NT TOTX178 (OPTICAL)
< JACK > JK900 1-784-361-11 JACK (SMALL TYPE)(2) < COIL > L701 L702 L703 L704 1-410-774-11 1-410-774-11 1-431-707-11 1-410-521-11 INDUCTOR 8.2mH INDUCTOR 8.2mH TRANSFORMER, BIAS OSCILLATION INDUCTOR 100uH
55
Ver 1.1 2001.06
TAPE PREAMP
Ref. No. R763 R765 R766 Part No. 1-249-437-11 CARBON 1-249-437-11 CARBON 1-249-437-11 CARBON
VOL/POWER
Remark 47K 47K 47K 5% 5% 5% 1/4W 1/4W 1/4W Ref. No. C510 C511 C512 C513 C514 C515 C516 C517 C518 C519 C520 C521 C522 C523 C525 C526 C527 C528 C529 C530 C531 C532 C999 Part No. 1-126-943-11 1-126-951-11 1-126-924-11 1-126-924-11 1-126-933-11 1-126-933-11 1-162-851-11 1-162-851-11 1-162-851-11 1-126-923-11 1-126-923-11 1-162-851-11 1-126-924-11 1-126-924-11 1-126-924-11 1-126-924-11 1-162-851-11 1-126-924-11 1-126-933-11 1-162-851-11 Description ELECT ELECT ELECT ELECT ELECT ELECT CERAMIC CERAMIC CERAMIC ELECT ELECT CERAMIC ELECT ELECT ELECT ELECT CERAMIC ELECT ELECT CERAMIC 2200uF 470uF 330uF 330uF 100uF 100uF 0.1uF 0.1uF 0.1uF 220uF 220uF 0.1uF 330uF 330uF 330uF 330uF 0.1uF 330uF 100uF 0.1uF 0.1uF 100uF 0.1uF 20% 20% 20% 20% 20% 20% 10% 10% 10% 20% 20% 10% 20% 20% 20% 20% 10% 20% 20% 10% 10% 20% 10% Remark 25V 35V 10V 10V 16V 16V 16V 16V 16V 10V 10V 16V 10V 10V 10V 10V 16V 10V 16V 16V 16V 16V 25V
Description
< VARIABLE RESISTOR > VR701 VR702 VR703 VR704 VR705 VR706 1-230-499-11 1-230-499-11 1-230-497-11 1-230-497-11 1-230-495-11 RES, ADJ, CARBON 100K RES, ADJ, CARBON 100K RES, ADJ, CARBON 22K RES, ADJ, CARBON 22K RES, ADJ, CARBON 2K
1-230-495-11 RES, ADJ, CARBON 2K
************************************************************** * A-4407-239-A VOL/POWER BOARD, COMPLETE ************************** (AEP,UK,EE,CIS) A-4407-240-A VOL/POWER BOARD, COMPLETE (US,CND) *********************************** A-4407-241-A VOL/POWER BOARD, COMPLETE (MY,SP,HK) ************************************* 1-533-293-11 4-997-378-01 7-685-646-79 7-685-647-79 FUSE HOLDER PC BOARD BRACKET SCREW +BVTP 3X8 TYPE2 N-S SCREW +BVTP 3X10 TYPE2 N-S < CAPACITOR > C403 C404 C461 C462 C463 C464 C465 C466 C469 C470 C471 C475 C476 C477 C478 C479 C480 C481 C482 C483A C485 C486 C488 C489 C490 C491 C502 C503 C508 C509 1-136-173-00 1-136-173-00 1-126-960-11 1-126-960-11 1-137-364-11 1-137-364-11 1-137-378-11 1-137-378-11 1-126-933-11 1-126-925-11 1-162-851-11 1-126-964-11 1-126-964-11 1-137-399-11 1-137-399-11 1-126-948-11 1-126-948-11 1-102-106-00 1-102-106-00 1-124-443-00 1-102-106-00 1-102-106-00 1-126-924-11 1-161-063-00 1-126-963-11 1-126-963-11 1-102-129-00 1-102-129-00 1-126-964-11 1-126-947-11 FILM FILM ELECT ELECT FILM FILM FILM FILM ELECT ELECT CERAMIC ELECT ELECT FILM FILM ELECT ELECT CERAMIC CERAMIC ELECT CERAMIC CERAMIC ELECT CERAMIC ELECT ELECT CERAMIC CERAMIC ELECT ELECT 0.47uF 0.47uF 1uF 1uF 0.001uF 0.001uF 0.22uF 0.22uF 100uF 470uF 0.1uF 10uF 10uF 0.1uF 0.1uF 100uF 100uF 100PF 100PF 100uF 100PF 100PF 330uF 0.1uF 4.7uF 4.7uF 0.01uF 0.01uF 10uF 47uF 5% 5% 20% 20% 5% 5% 5% 5% 20% 20% 10% 20% 20% 5% 5% 20% 20% 10% 10% 20% 10% 10% 20% 10% 20% 20% 10% 10% 20% 20% 50V 50V 50V 50V 50V 50V 50V 50V 16V 10V 16V 50V 50V 50V 50V 35V 35V 50V 50V 10V 50V 50V 10V 50V 50V 50V 50V 50V 50V 35V
*
*
1-162-851-11 CERAMIC 1-126-933-11 ELECT 1-161-772-11 CERAMIC < DIODE >
*
D401 D402 D487 D502 D503 D504 D506 D507 D508 D509 D510 D511
8-719-920-76 8-719-920-76 8-719-200-02 8-719-067-67 8-719-001-64 8-719-910-25 8-719-001-85 8-719-001-76 8-719-001-42 8-719-935-81
DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE
1S2076 1S2076 10E2 W02G UZL-12L2 HZ12B2L UZL-12H3 UZL-12M3 UZL-11M1 UZL-7L2
8-719-200-02 DIODE 10E2 8-719-920-76 DIODE 1S2076 < FUSE >
! F501 ! F501 ! F502 ! F502 ! F503
1-532-350-11 FUSE, TIME-LAG (T4AL 250V) (AEP,UK,EE,CIS,MY,SP,HK) 1-532-746-11 FUSE, GLASS TUBE (4A 125V)(US,CND) 1-532-259-11 FUSE, TIME-LAG (T1.6AL 250V) (AEP,UK,EE,CIS,MY,SP,HK) 1-532-742-11 FUSE, GLASS TUBE (1.6A 125V)(US,CND) 1-532-259-11 FUSE, TIME-LAG (T1.6AL 250V) (AEP,UK,EE,CIS,MY,SP,HK) 1-532-742-11 FUSE, GLASS TUBE (1.6A 125V)(US,CND) 1-532-350-11 FUSE, TIME-LAG (T4AL 250V) (AEP,UK,EE,CIS,MY,SP,HK) 1-532-746-11 FUSE, GLASS TUBE (4A 125V)(US,CND) < IC >
! F503 ! F504 ! F504
IC461 IC472 IC501
8-759-497-88 IC TC9260P 8-759-261-93 IC NJM4580LD 8-759-701-57 IC NJM78M06FA
56
The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified.
Les composants identifiés par une marque ! sont critiques pour la sécurité. Ne les remplacer que par une piéce portant le numéro spécifié.
VOL/POWER
Ref. No. Part No. Description < JACK > JK901 JK902 1-784-353-11 JACK (DIN)(SPEAKER L) 1-784-353-11 JACK (DIN)(SPEAKER R) < CONNECTOR > M501 * M901 M902 1-564-234-11 PLUG, CONNECTOR (PIN CONTACT)8P 1-766-720-21 CONNECTOR, BOARD TO BOARD 17P 1-564-707-11 PIN, CONNECTOR (SMALL TYPE) 5P < TRANSISTOR > Q486 Q487 Q488 Q501 Q502 Q503 Q504 Q505 Q505 Q506 Q507 Q507 Q508 Q508 Q509 Q509 Q510 Q511 Q512 8-729-201-53 8-729-231-55 8-729-231-55 8-729-281-53 8-729-201-53 8-729-201-53 8-729-209-15 4-997-377-01 8-729-017-51 8-729-281-53 4-997-377-01 8-729-188-23 4-997-377-01 8-729-188-23 4-997-377-01 8-729-188-23 8-729-017-51 8-729-201-53 8-729-265-52 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR 2SA1015-GR 2SC2878-AB 2SC2878-AB 2SC1815-GR 2SA1015-GR R503 R504 R505 R506 R507 R508 R509 ! R510 R511 R512 ! R514 ! R515 R516 ! R517 R518 ! R519 R520 R521 R524 R525 R526 R527 R528 R529 1-249-429-11 1-249-421-11 1-247-863-91 1-249-429-11 1-249-437-11 1-249-437-11 1-247-807-31 1-215-869-11 1-247-863-91 1-249-431-11 1-212-853-00 1-213-048-00 1-249-413-11 1-213-064-51 1-249-413-11 1-212-946-11 1-249-413-11 1-249-413-11 1-249-381-11 1-247-887-00 1-249-441-11 1-249-441-11 1-249-425-11 1-249-437-11 CARBON CARBON CARBON CARBON CARBON CARBON CARBON METAL OXIDE CARBON CARBON FUSIBLE FUSIBLE CARBON FUSIBLE CARBON FUSIBLE CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON < RELAY > RL501 R464 R465 R466 R467 R468 R469 R470 R471 R472 R477 R478 R479 R480 R481 R482 R483 R484 R485A R486A R491 1-247-895-91 1-249-425-11 1-247-815-91 1-249-429-11 1-249-429-11 1-249-429-11 1-249-425-11 1-249-417-11 1-249-417-11 1-249-441-11 1-249-441-11 1-249-426-11 1-249-426-11 1-249-430-11 1-249-430-11 1-249-417-11 1-249-417-11 1-249-429-11 1-249-429-11 1-247-843-11 CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON 470K 4.7K 220 10K 10K 10K 4.7K 1K 1K 100K 100K 5.6K 5.6K 12K 12K 1K 1K 10K 10K 3.3K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/4W 1/4W F 1/4W 1/4W 1/4W 1/4W 1/4W F 1/4W F 1/4W F 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W F 1/4W F 1/4W 1/4W 1/4W 1-755-242-11 RELAY 10K 2.2K 22K 10K 47K 47K 100 1K 22K 15K 6.8 3.3 470 15 470 3.3 470 470 1 220K 100K 100K 4.7K 47K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/4W 1/4W F 1/4W 1/4W 1/4W 1/4W 1/4W 1W F 1/4W 1/4W 1/4W 1W 1/4W 1W 1/4W 1/2W 1/4W 1/4W 1/4W 1/4W F F F F F F F F F R497 R498 R499 ! R501 ! R502 1-249-441-11 1-249-441-11 1-247-895-91 1-213-044-51 1-212-946-11 CARBON CARBON CARBON FUSIBLE FUSIBLE 100K 100K 470K 2.2 3.3 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1W F 1/2W F Remark Ref. No. R492 R493 R494 R495 R496 Part No. 1-247-843-11 1-249-437-11 1-249-437-11 1-249-425-11 1-249-425-11 Description CARBON CARBON CARBON CARBON CARBON 3.3K 47K 47K 4.7K 4.7K 5% 5% 5% 5% 5% Remark 1/4W 1/4W 1/4W 1/4W F 1/4W F
TRANSISTOR 2SA1015-GR TRANSISTOR 2SD2012 ISOLATION FILM TRANSISTOR 2SB632K-E TRANSISTOR 2SC1815-GR ISOLATION FILM TRANSISTOR 2SD882-P ISOLATION FILM TRANSISTOR 2SD882-P ISOLATION FILM TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR < RESISTOR > 2SD882-P 2SB632K-E 2SA1015-GR 2SC2655
R457 R458 R461 R462 R463
1-247-863-91 1-247-863-91 1-249-429-11 1-249-429-11 1-247-895-91
CARBON CARBON CARBON CARBON CARBON
22K 22K 10K 10K 470K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
1/4W 1/4W 1/4W F 1/4W
************************************************************** MISCELLANEOUS ************* 13 52 52 52 ! 54 ! 54 ! 54 ! 63 65 66 104 104 110 151 ! 201 1-783-091-11 1-693-400-21 1-693-400-31 1-693-400-41 1-551-478-00 1-555-750-00 1-751-535-11 1-770-019-11 1-501-659-11 1-501-985-11 WIRE (FLAT TYPE) FM/AM TUNER (AEP,UK,EE,CIS) FM/AM TUNER (US,CND) FM/AM TUNER (MY,SP,HK) CORD, POWER (POLAR.SPT-2)(US,CND) CORD, POWER (AEP,EE,CIS,MY,SP,HK) CORD, POWER (UK) ADAPTOR, CONVERSION PLUG 3P (HK) ANTTENA (FM) (US,CND,MY,SP,HK) LEAD, ANTTENA (AEP,UK,EE,CIS)
1-773-009-11 WIRE (FLAT TYPE) (15 CORE) (AEP,UK,EE,CIS) 1-751-688-11 WIRE (FLAT TYPE) (13 CORE) (US,CND,MY,SP,HK) 1-759-548-11 DECK, MECHANICAL 1-759-548-11 DECK, MECHANICAL 8-848-387-01 OPTICAL PICK-UP KSS-213BA/S-N The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. Les composants identifiés par une marque ! sont critiques pour la sécurité. Ne les remplacer que par une piéce portant le numéro spécifié.
57
HCD-ED1
Ref. No. 202 M101 M102 M901 ! S501 ! T501 ! T501 ! T501 Z201
Part No. 1-769-069-11 X-4917-523-4 X-4917-504-1 X-4949-564-1 1-771-308-11 1-431-697-21 1-431-697-31 1-431-697-41 1-803-020-11
Description
Remark
WIRE (FLAT TYPE) (16 CORE) MOTOR ASSY (SPINDLE) MOTOR ASSY (SLED) MTR MAIN BLK ASSY (CAPSTAN/REEL) SELECTOR, POWER (MY,SP,HK) TRANSFORMER, POWER (AEP,UK,EE,CIS) TRANSFORMER, POWER (US,CND) TRANSFORMER, POWER (MY,SP,HK) DISPLAY PANEL, LIQUID CRYSTAL
************************************************************** ************* HARDWARE LIST ************* * #1 #2 #3 #4 #5 #6 #7 #8 * #9 #10 #11 #12 #13 7-683-254-08 7-682-248-09 7-685-105-19 7-685-134-19 7-685-131-19 7-685-647-79 7-685-646-79 7-685-880-09 7-627-000-02 7-621-255-15 SET-SCT, HEX. 5X5 FLAT POINT SCREW +K 3X8 TPG +P 2X8, TYPE 2, NON-SLIT SCREW +BTP 2.6X8 TYPE2 N-S SCREW +BTP 2.6X4 TYPE2 N-S SCREW +BVTP 3X10 TYPE2 N-S SCREW +BVTP 3X8 TYPE2 N-S SCREW +BVTT 4X6 (S) SCREW,PRECISION+P M1.7X10 TYPE1 SCREW +P 2X3
7-627-553-88 SCREW,PRECISION+P 2X7 7-627-554-28 SCREW,PRECISION+P M2X5 TYPE1 7-682-546-09 SCREW +B 3X5
The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified.
Les composants identifiés par une marque ! sont critiques pour la sécurité. Ne les remplacer que par une piéce portant le numéro spécifié.
58
HCD-ED1
SERVICE MANUAL
1998. 04
US Model Canadian Model AEP Model UK Model E Model
SUPPLEMENT-1
File this supplement with the service manual.
· CHANGES OF LAMP
(ENG-98003)
· The lamp on the DISPLAY board was changed to a type which use LED from following serial numbers. MODEL US, CND Model AEP Model UK Model EE, CIS Model MY, SP Model HK Model : Serial numbers : 8107801 onward : 5155844 onward : 4107801 onward : 6107951 onward : 7104797 onward : 3153682 onward : 3105301 onward
DIFFERENCE TABLE
: Indicates changed portion.
Page Ref. No. Part No. FORMER TYPE (use lamp) Description *** EXPLODED VIEWS *** 47 *116 Remark Ref. No. Part No.
· Abbreviation CND : Canadian model EE : East European model MY : Malaysia model SP : Singapore model HK : Hong Kong model
NEW TYPE (use LED) Description *** EXPLODED VIEWS *** 1-670-517-11 LED BOARD Remark
105
#7
106
112 114
Z201
113
#7
116 104
*** ELECTRICAL PARTS LIST *** *** DISPLAY BOARD *** 52 PL201 1-517-743-11 LAMP *** ELECTRICAL PARTS LIST *** *** DISPLAY BOARD ***
Sony Corporation
9-922-706-81
(SP)
Home A&V Products Company
1
98D091686-1 Printed in Japan © 1998. 4 Published by General Engineering Dept. (Shibaura)
Page Ref. No. Part No.
FORMER TYPE (use lamp) Description *** LED BOARD *** Remark Ref. No. Part No.
NEW TYPE (use LED) Description *** LED BOARD *** * D1 D2 R1 R2 1-670-517-11 8-719-064-63 8-719-064-63 1-247-807-11 1-249-404-00 LED BOARD DIODE SE