Text preview for : SONY HCD-FR1,FR8,FR9.pdf part of SONY HCD-FR1,FR8,FR9 S.M.
Back to : SONY HCD-FR1,FR8,FR9.par | Home
HCD-FR1/FR8/FR9
SERVICE MANUAL
Ver. 1.5 2004. 12
US Model
HCD-FR1/FR8/FR9
Canadian Model
HCD-FR1
PHOTO: HCD-FR1
HCD-FR1/FR8/FR9 are the amplifier, DVD/ SACD and tuner section in DAV-FR1/FR8/FR9.
Model Name Using Similar Mechanism Mechanism Type Optical Pick-up Name
NEW CDM69-DVBU16 DBU-1
SPECIFICATIONS
AUDIO POWER SPECIFICATIONS POWER OUTPUT AND TOTAL HARMONIC DISTORTION:
With 4 ohm loads, both channels driven, from 20 20,000 Hz; rated 75 watts per channel minimum RMS power, with no more than 0.7 % total harmonic distortion. (from 250 milli watts to rated output) Surround*: 114 W + 114W (with SS-TS21) Subwoofer*: 115 W × 2 (with SS-WS12)
* Depending on the sound field settings and the source, there may be no sound output.
Amplifier section (HCD-FR1) Surround mode Front: 110 W + 110 W
(reference) music power output (with SS-TS20) Center*: 110 W (with SS-CT44) Surround*: 110 W + 110W (with SS-TS20) Subwoofer*: 100 W × 2 (with SS-WS12)
Inputs
VIDEO/SAT:
Sensitivity: 250 mV/ 450 mV
Impedance: 50 kilohms
Output SURROUND BACK Voltage: 2V Impedance: 1 kilohms Accepts low-and highimpedance headphones. Semiconductor laser (Super Audio CD/DVD: = 650 nm) (CD: = 780 nm) Emission duration: continuous
87.5 108.0 MHz (100 kHz step) Antenna (aerial) FM wire antenna (aerial) Antenna (aerial) terminals 75 ohms, unbalanced Intermediate frequency 10.7 MHz AM tuner section Tuning range 531 1,710 kHz (with the interval set at 9 kHz) 530 1,710 kHz (with the interval set at 10 kHz) AM loop antenna (aerial) Antenna (aerial) Intermediate frequency 450 kHz
FM tuner section Tuning range
Phones
Video section
Outputs Video: 1 Vp-p 75 ohms\ S VIDEO: Y: 1 Vp-p 75 ohms C: 0.286 Vp-p 75 ohms COMPONENT: Y: 1 Vp-p 75 ohms
Super Audio CD/DVD system
Laser
Amplifier section (HCD-FR8) Surround mode Front: 114 W + 114 W
(reference) music power output (with SS-TS21) Center*: 114 W (with SS-CT33) Surround*: 114 W + 114W (with SS-TS20) Subwoofer*: 115 W × 2 (with SS-WS12)
PB/CB, PR/CR: 0.65 Vp-p 75 ohms General
Power requirements Power consumption Dimensions (approx.) 120 V AC, 60 Hz 120 W 430 × 70 × 398 mm (17 × 2 7/8 × 15 3/4 inches) (w/h/d) incl. projecting parts 5.5 kg (12 lb 12 oz)
Signal format system NTSC Frequency response (at 2 CH STEREO mode)
DVD (PCM): 2 Hz to 22 kHz (±1.0 dB)
Amplifier section (HCD-FR9) Surround mode Front: 114 W + 114 W
(reference) music power output (with SS-TS21) Center*: 114 W (with SS-CT33)
Harmonic distortion Tuner section
System
CD: 2 Hz to 20 kHz (±1.0 dB) Less than 0.03 %
PLL quartz-locked digital synthesizer system
Mass (approx.)
Design and specifications are subject to change without notice.
SACD/DVD RECEIVER
9-879-011-06
2004L16-1 © 2004.12
Sony Corporation
Audio Group Published by Sony Engineering Corporation
HCD-FR1/FR8/FR9
Laser component in this product is capable of emitting radiation exceeding the limit for Class 1.
This appliance is classified as a CLASS 1 LASER product. The CLASS 1 LASER PRODUCT MARKING is located on the rear exterior. CAUTION Use of controls or adjustments or performance of procedures other than those specified herein may result in hazardous radiation exposure. Notes on chip component replacement · Never reuse a disconnected chip component. · Notice that the minus side of a tantalum capacitor may be damaged by heat. Flexible Circuit Board Repairing · Keep the temperature of the soldering iron around 270 °C during repairing. · Do not touch the soldering iron on the same conductor of the circuit board (within 3 times). · Be careful not to apply force on the conductor when soldering or unsoldering. UNLEADED SOLDER Boards requiring use of unleaded solder are printed with the leadfree mark (LF) indicating the solder contains no lead. (Caution: Some printed circuit boards may not come printed with the lead free mark due to their particular size) : LEAD FREE MARK Unleaded solder has the following characteristics. · Unleaded solder melts at a temperature about 40 °C higher than ordinary solder. Ordinary soldering irons can be used but the iron tip has to be applied to the solder joint for a slightly longer time. Soldering irons using a temperature regulator should be set to about 350 °C. Caution: The printed pattern (copper foil) may peel away if the heated tip is applied for too long, so be careful! · Strong viscosity Unleaded solder is more viscou-s (sticky, less prone to flow) than ordinary solder so use caution not to let solder bridges occur such as on IC pins, etc. · Usable with ordinary solder It is best to use only unleaded solder but unleaded solder may also be added to ordinary solder.
SAFETY CHECK-OUT After correcting the original service problem, perform the following safety check before releasing the set to the customer: Check the antenna terminals, metal trim, "metallized" knobs, screws, and all other exposed metal parts for AC leakage. Check leakage as described below. LEAKAGE TEST The AC leakage from any exposed metal part to earth ground and from all exposed metal parts to any exposed metal part having a return to chassis, must not exceed 0.5 mA (500 microamperes.). Leakage current can be measured by any one of three methods. 1. A commercial leakage tester, such as the Simpson 229 or RCA WT-540A. Follow the manufacturers' instructions to use these instruments. 2. A battery-operated AC milliammeter. The Data Precision 245 digital multimeter is suitable for this job. 3. Measuring the voltage drop across a resistor by means of a VOM or battery-operated AC voltmeter. The "limit" indication is 0.75 V, so analog meters must have an accurate low-voltage scale. The Simpson 250 and Sanwa SH-63Trd are examples of a passive VOM that is suitable. Nearly all battery operated digital multimeters that have a 2 V AC range are suitable. (See Fig. A)
To Exposed Metal Parts on Set
0.15 µF
1.5 k
AC voltmeter (0.75 V)
Earth Ground
Fig. A. Using an AC voltmeter to check AC leakage.
ATTENTION AU COMPOSANT AYANT RAPPORT À LA SÉCURITÉ! SAFETY-RELATED COMPONENT WARNING!! COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY. LES COMPOSANTS IDENTIFIÉS PAR UNE MARQUE 0 SUR LES DIAGRAMMES SCHÉMATIQUES ET LA LISTE DES PIÈCES SONT CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT. NE REMPLACER CES COM- POSANTS QUE PAR DES PIÈCES SONY DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL OU DANS LES SUPPLÉMENTS PUBLIÉS PAR SONY.
2
HCD-FR1/FR8/FR9
TABLE OF CONTENTS 1. 2. 3.
3-1. 3-2. 3-3. 3-4. 3-5. 3-6. 3-7. 3-8. 3-9. 3-10. 3-11. 3-12. 3-13. 3-14. 3-15. 3-16. 3-17. 3-18. 3-19. 3-20. 3-21. 3-22.
SERVICING NOTE ................................................... 4 GENERAL ................................................................... 5 DIAGRAMS
Printed Wiring Board RF Board ................................ Schematic Diagram RF Board ................................... Printed Wiring Board RELAY Section ...................... Schematic Diagram RELAY Section ........................ Printed Wiring Board DMB08 Board (Side A) ......... Printed Wiring Board DMB08 Board (Side B) ......... Schematic Diagram DMB08 Board (1/10) ................ Schematic Diagram DMB08 Board (2/10) ................ Schematic Diagram DMB08 Board (3/10) ................ Schematic Diagram DMB08 Board (4/10) ................ Schematic Diagram DMB08 Board (5/10) ................ Schematic Diagram DMB08 Board (6/10) ................ Schematic Diagram DMB08 Board (7/10) ................ Schematic Diagram DMB08 Board (8/10) ................ Schematic Diagram DMB08 Board (9/10) ................ Schematic Diagram DMB08 Board (10/10) .............. Printed Wiring Board AMP Board (Side A) .............. Printed Wiring Board AMP Board (Side B) .............. Schematic Diagram AMP Board (1/4) ...................... Schematic Diagram AMP Board (2/4) ...................... Schematic Diagram AMP Board (3/4) ...................... Schematic Diagram AMP Board (4/4) ...................... 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30
Printed Wiring Board IO Board ................................. Schematic Diagram IO Board (1/2) ........................... Schematic Diagram IO Board (2/2) ........................... Printed Wiring Board DDCON Board ....................... Schematic Diagram DDCON Board ......................... Printed Wiring Board FL Board ................................ Schematic Diagram FL Board ................................... Printed Wiring Board SPK Board ............................. Schematic Diagram SPK Board ................................ Printed Wiring Board POWER/FRONT PANEL Section ............................. 3-33. Schematic Diagram POWER/FRONT PANEL Section .............................
3-23. 3-24. 3-25. 3-26. 3-27. 3-28. 3-29. 3-30. 3-31. 3-32.
31 32 33 34 35 36 37 38 38 39 40
4.
4-1. 4-2. 4-3. 4-4. 4-5. 4-6. 4-7. 4-8. 4-9. 4-10.
EXPLODED VIEWS
Case Section .................................................................... Front Panel Section ......................................................... Chassis Section ................................................................ Mechanism Deck Section-1 (CDM69-DVBU16) ........... Mechanism Deck Section-2 (CDM69-DVBU16) ........... Mechanism Deck Section-3 (CDM69-DVBU16) ........... Mechanism Deck Section-4 (CDM69-DVBU16) ........... Mechanism Deck Section-5 (CDM69-DVBU16) ........... Mechanism Deck Section-6 (CDM69-DVBU16) ........... Optical Pick-up Section (DBU-1) ................................... 41 42 43 44 45 46 47 48 49 50
5.
ELECTRICAL PARTS LIST .................................. 51
3
HCD-FR1/FR8/FR9 SECTION 1 SERVICING NOTE
NOTES ON HANDLING THE OPTICAL PICK-UP BLOCK OR BASE UNIT The laser diode in the optical pick-up block may suffer electrostatic break-down because of the potential difference generated by the charged electrostatic load, etc. on clothing and the human body. During repair, pay attention to electrostatic break-down and also use the procedure in the printed matter which is included in the repair parts. The flexible board is easily damaged and should be handled with care. NOTES ON LASER DIODE EMISSION CHECK The laser beam on this model is concentrated so as to be focused on the disc reflective surface by the objective lens in the optical pickup block. Therefore, when checking the laser diode emission, observe from more than 30 cm away from the objective lens.
FR1 FR8 FR9
MODEL IDENTIFICATION
BACK PANEL
Part No.
MODEL Part No. 4-253-916-0[ ] 4-253-916-1[ ] 4-253-916-2[ ]
4
HCD-FR1/FR8/FR9 SECTION 2 GENERAL
This section is extracted from instruction manual.
Front Panel
A [/1 (power) switch/STANDBY indicator (30) B DISC1-5 Z (eject)/indicators (30) C (remote sensor) (13) D Front panel display (98) E PHONES (on the side of the system) jack (30)
F VOLUME +/ (30, 83) G ./> (31, 33) H x (stop) (31) I (play/pause) (30) J FUNCTION (30, 70, 73) K Disc slot (30)
Rear Panel
VIDEO SPEAKER
FRONT R CENTER FRONT L WOOFER R AUDIO IN L
Y
PB/CB
PR/CR
S VIDEO (DVD ONLY)
OPTICAL DIGITAL IN
AM
FM 75
SURROUND R BACK
SURR R SURR L WOOFER
COMPOMEMT VIDEO OUT
AUDIO IN L VIDEO
COAXIAL
SAT MONITOR OUT
SAT
A SPEAKER jacks (15) B SURROUND BACK jack (19) C VIDEO AUDIO IN (L/R) jacks (23) D COMPONENT VIDEO OUT jacks (23) E SAT OPTICAL DIGITAL IN jack (24)
F AM terminals (21) G FM 75 COAXIAL jack (21) H MONITOR OUT (VIDEO/S VIDEO) jacks (23) I SAT AUDIO IN (L/R) jacks (23)
5
HCD-FR1/FR8/FR9
Remote
A B C D E F G
H I J K L M N O P Q R S T U V W
Open the cover.
X Y Z wj wk wl e; ea es ed ef eg eh ej ek
Note
This remote control glows in the dark. However, before glowing, the remote must be exposed to light for awhile.
DISC SKIP (30, 31) DISPLAY (46, 49, 73) SLEEP (75) ./>, PRESET /+ (31, 33, 73, 74) H (play) (30, 31, 32, 33, 37, 38, 39, 41, 41, 42, 43) DVD TOP MENU/ALBUM (33, 35, 36) C/X/x/c/ENTER (27, 33, 33, 35, 36, 38, 38, 39, 41, 42, 44, 51, 57, 60, 61, 62, 64, 71, 72, 74, 75, 77, 85) DVD DISPLAY (35, 36, 38, 41, 42, 44, 49, 50, 51, 60, 61, 62) AUTO FORMAT DIRECT (53, 54) DSGX (59) DVD SETUP (27, 64, 77) SUBTITLE (61) AUDIO (51) ANGLE (60) Number buttons (33, 33, 39, 44, 60, 62, 64, 67, 69) ENTER TUNER MENU (72, 74) TV [/1 (on/standby) (67) "/1 (standby) (27, 30, 72, 73) SONY TV DIRECT (69) TUNER/BAND (72, 73, 74) FUNCTION (27, 30, 70, 73, 74) m/M/ / SLOW, TUNING /+ (37, 43, 72, 73) x (stop) (31, 32, 33, 62, 73) X (pause) (31) MUTING (31) DVD MENU/ALBUM+ (33, 35, 36) VOL +/ (31, 73) O RETURN (27, 33, 35, 36, 38, 39, 44, 62, 64, 77) MODE (54, 55) NIGHT MODE (59) PLAY MODE (38, 39, 41) REPEAT (39, 42) TV (67, 69) TV/VIDEO (67, 69) TV CH +/ (67, 69) TV VOL +/ (67) AMP MENU (57, 71, 75, 85)
el CLEAR (27, 39, 44) r; FM MODE (73)
6
HCD-FR1/FR8/FR9 SECTION 3 DIAGRAMS
· Circuit Boards Location
IO board LF board DISC KEY board SONY LAMP board
PW KEY board FL board SWITCHING REGLATOR CONTROL KEY board HP board
AMP board
ROLLER MOTOR board STOCKER MOTOR board SW (4) board SW (3) board SW (2) board RELAY board SPK board
SW (1) board SENSOR board
MODE MOTOR board
DMB08 board
RF board DDCON board
7
HCD-FR1/FR8/FR9
THIS NOTE IS COMMON FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS. (In addition to this, the necessary note is printed in each block.)
For schematic diagrams. Note: · All capacitors are in µF unless otherwise noted. (p: pF) 50 WV or less are not indicated except for electrolytics and tantalums. · All resistors are in and 1/4 W or less unless otherwise specified. · f : internal component. · C : panel designation. Note: The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. Note: Les composants identifiés par une marque 0 sont critiques pour la sécurité. Ne les remplacer que par une piéce por tant le numéro spécifié. For printed wiring boards. Note: · X : parts extracted from the component side. a : Through hole. · · b : Pattern from the side which enables seeing. (The other layers' patterns are not indicated.) Caution: Pattern face side: (Side A) Parts face side: (Side B)
Parts on the pattern face side seen from the pattern face are indicated. Parts on the parts face side seen from the parts face are indicated.
· Indication of transistor.
· A : B+ Line. · B : B Line. · Voltages and waveforms are dc with respect to ground under no-signal (detuned) conditions. · Voltages and waveforms are dc with respect to ground in service mode. · Waveforms are taken with a oscilloscope. Voltage variations may be noted due to normal production tolerances. no mark : DVD STOP · ( ) : CD STOP · Circled numbers refer to waveforms. · Signal path. F : AUDIO J : CD PLAY c : DVD PLAY d : TUNER L : VIDEO i : OPTICAL DIGITAL IN h : VIDEO IN a : CHROMA d :Y r : COMPONENT VIDEO e : AUX IN I : SACD PLAY q : R, G, B
BC E These are omitted
C Q B E These are omitted
8
HCD-FR1/FR8/FR9
Ver. 1.4 3-1. PRINTED WIRING BOARD -- RF BOARD --
· See page 7 for Circuit Boards Location. :Uses unleaded solder.
1
2
3
4 RF BOARD (SIDE A)
5
6
7
8
9
10
11
12
13
RF BOARD (SIDE B)
R041
A
C003 Q002 R009 R008
C011 C010
C001
C
B E
B
R007 B R005
C E
OPTICAL TRAVERSE UNIT (DBU-1)
C004
L002 D002 C005
R003 R004
Q001
L001 D001 CN001 C006
R010 R006
C002
R025 R024 C025
C
R022 C008 C009 R091 C013 C052
C015
C030 C026
R023 C020
C017
C024
64 1
C029
49 R026 48
C031 R027 R028 R029 C032
C028 C027
C021 C016 R001 C042 CN003 R021
C014
C019 C018
D
C049
C022 R033 C038
C037
A
DMB08 BOARD CN401 (Page 13)
IC003 3
R047
1
5
C039 C041
R014 C023 R012 R018 R016
IC001
C034
16 17 32 33
R031 C033 C012
4 R046
R034 C050 C040
R013 R011 R017 R015
C036 C051
C035
E
R020 R035 R019
CN002
F
1-684-822-
12 (12) 1-684-822-
12 (12)
· Semiconductor Location
Ref. No. D001 D002 IC001 IC003 Q001 Q002 Location C-10 B-10 D-11 D-3 B-3 B-3
HCD-FR1/FR8/FR9
9
9
HCD-FR1/FR8/FR9
Ver. 1.4 3-2. SCHEMATIC DIAGRAM -- RF BOARD --
RFMON
4
R023 820 JL005 R024 0 C024 0.01 C025 0.1 C026 0.1
C028 0.1
C027 0.1 C030 C029 0.01 0.01
R026 12k
C006 22 10V
C013 0.1
CN002 29P AGND RFAC
1000p
C035 0.1
AGND AVC AVC MIRR MIRR PI/CE PI TE TE FE FE A5V
JL004
CN001 24P D D C C RFP RF GND VC VCC E E A A B B F F N.C D C B A C017 2200p C009 0.1 JL007 R025 100 R022 220 C019 5600p
C018 5600p
C020 22p
C021 22p
C022 22p
C023 22p
1
R027 0 R028 0 R029 0 SDEN DATA_RF CLK_RF
C031
A5V SDEN SDEN DATA_RF DATA_RF CLK_RF CLK_RF LDON LDON
RFP
C016 2200p A3V C015 2200p C014 2200p C032 0.047 JL006 CD/DVD RF AMP, FOCUS/TRACKING ERROR AMP R013 0 R012 0 IC001 SP3723CAF0PM TE R031 100 PI/CE TDTDTD+ TD+ R011 0 SLBSLEDBSLB+ SLEDB+ R017 0 C049 0.1 JL002 R015 0 JL001 SLASLEDASLA+ SLEDA+ SPDLSPDL+ JL003 C033 0.1 C012 0.1 C005 22 10V FDFDFE FD+ FD+ RFMON RFMON INLIM LDSEL
DMB08 BOARD (1/10) CN401
(Page 15)
OPTICAL PICK-UP BLOCK (DBU-1)
PD PD R001 100 VR VCC SW LD GND DVD_LD DVD LD INLIM CD_LD CD LD INLIM_3V FD+ FCS+ FDFCSTD+ TRK+ TDTRKR016 0 R018 0 R014 0
C042 180p
3 2
COMPARATOR R041 1k IC003 TL343IDBVR
0.47
VCC C036 0.47 R033 100k R047 33k C034 0.1
C039 0.033
C038 0.033
C037 680p
E F
C051
R035 0
VEE
R034 470
LDON
MIRR
R019 0
R020 0 C008 0.1 C041 0.1
R021 0
C040 0.1
R091 560k
PD
CD_LD
R003 33 IOP2
R004 33
R005 47k
C001 100 6.3V
R006 470 IOP1
R007 33
R008 33
R009 47k
C003 100 6.3V
R010 470
Q001 2SB1132-T100-QR AUTOMATIC POWER CONTROL (FOR DVD) DVD_LD CN003 9P SLA+ SLEDA+ SLB+ SLEDB+ SLBSLEDBSLASLEDALED {LIMIT-SW(A)} GND {LIMIT-SW(B)} INLIM {LIMIT-SW(B)} SPDLSPDL+ D001 1SS355TE L001 47µH C002 10 16V C010 1000p
Q002 2SB1132-T100-QR AUTOMATIC POWER CONTROL (FOR CD) C011 1000p
L002 47µH D002 1SS355TE C004 10 16V
HCD-FR1/FR8/FR9
10
10
C050 3300p
R046 10k
C052 0.1
HCD-FR1/FR8/FR9
3-3. PRINTED WIRING BOARD -- RELAY SECTION --
· See page 7 for Circuit Boards Location. :Uses unleaded solder.
1
2
3
5
4
6 1
5
6
5
7
8
6
A
SW (4) BOARD
4 4 4 1 11 S716 (STOCKER IN/OUT) 1-685-011(11) 3 2 1 4 1 1
RELAY BOARD
2 3
STOCKER MOTOR BOARD
2 1
M
(STOCKER) 1-685-006-
11 (11)
B
OFF: The moment disc in/out from stocker S717 (DISC POSITION) In the midst disc is moving between play position and stocker, ON: disc is play position side, OFF: disc is stocker side S718 (STOCKING) OFF: In the midst disc is moving between play position and stocker
2
3 1
MODE MOTOR BOARD
7
C
3
SW (3) BOARD
2 1 S715 OFF: When disc out from play position (DISC OUT) 1-685-01011 (11) 4 3 G 2 1 1 9 ROTARY ENCODER (STOCKER POSITION)
M
(MODE) 1
ROTARY ENCODER (MODE)
1 2 G 3 4 11 1-685-005(11)
SW (2) BOARD
IC701
ROLLER MOTOR BOARD
D
2 3 1 S714 (ON: Play position (8cm disc only)) (DISC IN (8cm)) 1-685-009S713 (DISC IN (8/12cm)) (ON: Play position) 11 (11)
G
DMB08 BOARD CN006 (Page 13) 1 9
IC721
2 1
M
E (ROLLER) 11 2 1 1-685-007- (11)
E
1
SW (1) BOARD
3 1 (DISC INSERT (8/12cm)) (ON: When disc insert) 1-685-008-
1 11 (11)
9
IC711
SENSOR BOARD
E C 3 1 DISC INSERT DETECT SENSOR 1-685-00411 (11) K A
1-685-01211
· Semiconductor Location
IC751
(11)
F
Ref. No. D701 D711 D721 IC701 IC711 IC721 IC751 Q731
Location D-5 E-6 E-5 D-5 E-5 D-5 F-4 E-4
HCD-FR1/FR8/FR9
11
11
HCD-FR1/FR8/FR9
Ver 1.2 3-4. SCHEMATIC DIAGRAM -- RELAY SECTION --
CNP751 3P DIODE
CN702 3P DIODE D SENSE GND
R731 150
751
IC751 RPR-220 DISC INSERT DETECT SENSOR
D SENSE GND
R733 10k R734 15k R732 1k
CN701 28P D+5V M+12V
OUT1
OUT2
VREF
RNF
GND
VCC
VM
RIN
FIN
Q731 RT1N141 MODE MOTOR DRIVE LEVEL SHIFT
M+12V MGND MGND P81 D.SENSOR
IC701 BA6956AN
IC B/D
R702 100 D701 MTZJ-T-77-4.7B R701 680
C711 10 50V
C754 0.1 C758 0.1 C755 0.1 C756 0.1 C751 0.1 C752 0.1
SW3 SW1A SW1B SW2A SW2B SW4 SW5A
P92 SW3 P40 SW1-A P41 SW1-B P42 SW2-A P43 SW2-B P93 SW4 P94 SW5-A P44 LOD POS
CNP781 2P MTR RL 1 M781 (ROLLER) MTR RL 2
CN703 2P MTR RL 2 MTR RL 1
G
DMB08 BOARD (10/10) CN006 (Page 24)
C781 0.01
P45 LOD NEG P46 SLD POS
OUT1
OUT2
VREF
GND
RNF
VCC
RIN
FIN
P47 SLD NEG ROLLER MOTOR DRIVE P91 ELV NEG SW5B P95 SW5-B P96 SLD E0 P02 SLD E1 P03 SLD E2 C765 0.1 P04 SLD E3 P82 ELV E0 P83 ELV E1 P54 ELV E2 P55 ELV E3 C762 0.1 IC711 BA6956AN P90 ELV POS
IC B/D
OUT1 OUT2 VREF GND RNF
VCC
VM
FIN
VM
RIN
STOCKER MOTOR DRIVE R712 100
C753 0.1
IC B/D
IC721 BA6956AN CNP761 2P MTR ST 2 M761 (STOCKER) MTR ST 1 CN704 2P MTR ST 2 MTR ST 1 C761 R722 0.01 100 D711 MTZJ-T-77-5.1A R711 680 C764 0.1 C763 0.1
D721 MTZJ-T-77-3.6A
R721 680
S702 ROTARY ENCODER (STOCKER POSITION) CNP711 3P GND SW1-A S711 (DISC INSERT(8/12cm)) (ON:WHEN DISC INSERT) SW1-B CNP705 3P GND SW1-A SW1-B SW1A SW1B
CNP721 3P GND SW2-A S713 (DISC IN(8/12cm)) (ON:PLAY POSITION) SW2-B
CNP706 3P GND SW2-A SW2-B SW2A SW2B
S714 (DISC IN(8cm)) (ON:PLAY POSITION(8cm DISC ONLY)) S771 ROTARY ENCODER (MODE) CNP731 2P GND SW3 S715 (DISC OUT) (ON:WHEN DISC OUT FROM PLAY POSITION) C766 0.1 E4 MTR MD 1 MTR MD 2 CNP741 4P GND SW4 S716 (STOCKER IN/OUT) ON:THE MOMENT DISC IN/OUT FROM STOCKER SW5-A SW5-B CNP708 4P GND SW4 SW5-A SW5-B SW4 SW5A SW5B C771 0.01 M771 (MODE) E4 MTR MD 1 MTR MD 2 CNP707 2P GND SW3 SW3 C768 0.1 C767 0.1 CN710 7P E1 E2 GND E3 CNP771 7P E1 E2 GND E3
C769 0.1
S717 (DISC POSITION) IN THE MIDST DISC IS MOVING BETWEEN PLAY POSITION AND STOCKER, ON:DISC IS PLAY POSITION SIDE, OFF:DISC IS STOCKER SIDE
S718 (STOCKING) OFF:IN THE MIDST DISC IS MOVING BETWEEN PLAY POSITION AND STOCKER
HCD-FR1/FR8/FR9
12
12
HCD-FR1/FR8/FR9
Ver. 1.5 3-5. PRINTED WIRING BOARD -- DMB08 BOARD (SIDE A) --
· See page 7 for Circuit Boards Location. :Uses unleaded solder.
1 A
2
3
G
4
RELAY BOARD CN701 (Page 11)
5
6
7
8
9
C002
27
1 CN006 2
R071
C009
C012
28
R094
R953
IC901
DDCON BOARD CN800 (Page 34)
Q914
R092
RB901
B
D
R894
RB902
IC612 IC801 IC607
C908
AMP BOARD CN302 (Page 26)
E
R983
B
FOR CHECK
IC606 IC301
D
FOR CHECK
IC701
IC206
IC605
C
IC813
C
AMP BOARD CN301 (Page 26)
IC402
SWITCHING REGULATOR CN8
IC401
E
· Semiconductor Location
Ref. No. D900 D901 Location C-2 C-4 D-5 C-2 D-2 D-2 C-8 C-7 B-7 B-6 D-4 B-5 C-4 B-2 C-3
F
A
RF BOARD CN002 (Page 9)
F
IO BOARD CN201 (Page 31)
E
IO BOARD CN601 (Page 31)
IC206 IC301 IC401 IC402 IC605 IC606 IC607 IC612 IC701 IC801 IC813 IC901 Q914
HCD-FR1/FR8/FR9
13
13
HCD-FR1/FR8/FR9
Ver. 1.5 3-6. PRINTED WIRING BOARD -- DMB08 BOARD (SIDE B) --
· See page 7 for Circuit Boards Location. :Uses unleaded solder.
1 A
2
3
4
5
6
7
8
· Semiconductor Location
Ref. No. D902 D903 D904 D906 D907 IC001 IC002 IC004 IC005 IC006 IC202 IC203 IC205 IC215 IC302 IC303 IC501 IC601 IC603 IC604 IC608 IC609 IC703 IC704 IC706 IC802 IC803 IC808 IC812 IC814 IC900 IC902 IC903 IC904 IC906 IC907 Q301 Q302 Q900 Q901 Q902 Q903 Q906 Q907 Q908 Q909 Q910 Q913
R076
Location B-7 B-6 C-7 B-6 B-7 E-3 D-2 C-2 C-2 E-4 D-4 D-3 D-4 C-3 C-7 C-4 E-7 D-2 E-2 C-2 D-2 D-2 E-5 C-4 D-5 C-7 C-6 B-4 C-5 C-5 B-3 B-6 C-6 D-1 B-5 B-7 D-6 D-3 B-7 B-7 B-7 B-6 B-6 C-7 B-3 B-3 B-3 B-7
R081
R927
R058
1
IC808
R924
R928
C924
IC900 IC604 IC005
15
28
15
28
C902
IC906
IC902
R930
R921 R973
B
14
1
14
R920
R925
R093
R984
IC812
D906
IC704 IC903 IC303 IC215 IC814 IC803
C923
IC907
FR1/FR8
C
IC004 IC608
FR8/FR9
IC302
D
IC904 IC601 IC609 IC002
IC203 IC205
IC001
IC202
IC706
IC802
IC501
IC006
HCD-FR1/FR8/FR9
14
IC703
E
IC603
14
HCD-FR1/FR8/FR9
Ver 1.2 3-7. SCHEMATIC DIAGRAM -- DMB08 BOARD (1/10) --
FL401 0UH (2012)
C404 0.1
R418 10k
C411 0.1
C410 10 16V
C401 0.1
C402 10
R419 68k
0
0
0
0
0
0
0
JL544 JL537
JL536
R414 0
JL535 JL531 JL530 JL529 JL527 C414 0.01 R440 47k C409 R428 1k R437 47k
R413 10k R412 10k C407 10 10V
0 0 0 1.6 1.6
0
CN401 29P
AMP,REFERENCE VOLTAGE GENERATOR
IC402 NJM3404AV(TE2)
1.6
3.2
3.2
3.2
3.2
3.2
3.3
C405 10 16V
R411 0
R401 0
C406 0.0022
0.7
0.7
0.7
5 0 0 0.2 3
R420 0 R451 10k
0.8
0.8
1.6
5
C408 0.1 R421 1k 0.0022
3.3 0.8 0 0 0 0
DIGITAL SIGNAL PROCESSOR, DIGITAL SERVO PROCESSOR R423 1k 0.8 R425 1k R426 1k IC401 CXD3068Q
JL526 JL525 JL524 JL523 JL522 JL501 JL502
1.3 1.6
R433 47k C415 0.01
C412 0.0022 C413 0.0022 R434 47k C419 0.047 B R441 1k
R429 1k R430 1k
IC B/D
1.6 0 1.6 0
R439 330
11
JL500 JL511 JL512 JL509 JL510 JL503 JL504 JL505
C420 0.0022 C418 0.1
1.6 1.6 1.6
0 3.3 3.3
C417 0.1 C416 10 10V R442 10k
R443 47k
1.6
1.6
1.2
0.9
3.3
1.6
1.6
1.7
3.3
3.3
3.3
3.3
0.4
0
0
JL507 JL508
0
R444 470k C423 0.1 R453 1M FL402 0UH (2012) C436 0.1
JL506
R455 100k
C428 0.0033
C432 100p
C421 0.1 R457 3.3k
C425 0.0022 C424 0.022 B
C435 0.1 C426 C427 0.01 0.47 B B C433 0.0015 C434 10 10V C422 100p
R452 1M
R450 1k
R449 33k
R447 10k
R448 1k
R445
1k
B
R446 10k
NO MARK : DVD STOP
16
HCD-FR1/FR8/FR9
15
15
HCD-FR1/FR8/FR9
Ver 1.2 3-8. SCHEMATIC DIAGRAM -- DMB08 BOARD (2/10) --
15
R581 12k
C526 22 16V
FOCUS/TRACKING COIL DRIVER, SPINDLE, SLED MOTOR DRIVER
R580 33k C519 0.01
1.6 1.6
R582 10k
3.2
12
0
0
0
0
0
0
R583 10k
1.6
R579 8.2k
C527 0.1
IC501 FAN8035L
1.6 1.6 1.6 1.6 1.6
1 1 0.9 0.9
C514 0.01
R533 33k R534 56k R535 0
R532 0 C512 0.01 R529 33k R530 56k R531 0
0.9 0.9
1.6 1.6 1.3
R592 0
C510 0.001
R527 2.2k
R525 10k
0.9 0.9 0.9
1.3 1.6 1.1
R522 4.7k C509 330p
R524 10k R521 100k R523 10k
R536 200k
0.8 5.1 3.2 1.6 1.6 1.6 1.6 5.1 1.6 1.4 1.4 1.1
R416 0 R510 150k R511 150k
C504 33000p
R519 100k R520 10k
R513 56k
R512 56k
R516 4.7k
C503 33000p C524 0.1
C506 330p
R517 2.2k
C508 0.001
R514 10k
C525 0.1
R515 10k
C529 0.1
C528 47 6.3V
NO MARK : DVD STOP
HCD-FR1/FR8/FR9
16
16
HCD-FR1/FR8/FR9
Ver 1.2 3-9. SCHEMATIC DIAGRAM -- DMB08 BOARD (3/10) --
TP701 R729 8.2k TP702 R725 1.8k R726 100k 16Mbit D-RAM
3.2
0.8
0.4
0.4
0.4 2
0.4 0.4
IC B/D
R545 100k R544 100k
5 1.6 1.6
IC703(1/2) NJM3404AV(TE2)
IC B/D
4.6
C721 0.1 B
R727 3.3k C728 0.1 B IC706 M51V18165M-6DTS-KR1
C523 0.0015 BUFFER
1.6
R540 10k COMPARATOR R724 1k C720 0.1 B
1.6
R728 10k
1.6
IC703(2/2) NJM3404AV(TE2) C521 0.0015 R541 100k
C715 0.0015
IC B/D
FL705 0UH (2012)
0
0
0
0
0
0
0
0
3.3
3.2
2.1
0
0.2
0.4
0.4
0.4 3.3
C726 0.1 F C740 0.01 B
0
0
0
0
0
0
0
0
0
R538 100k C729 10 10V
R721 33k C727 10 10V C718 0.01 B C722 0.01 B
C724 0.1 F
R748 33k C709 0.1 F C708 0.01 C752 0.1 C703 0.1
R712 10k
FL706 0UH (2012)
C712 100p CH
R713 10k R715 10k F F
R720 1k
C717 0.01 B
3.3
C713 0.1
R716 100
R711 2.2k
R714 10k
R780 0
R708 470k
R709 150k
R747 33k
R707 100
R719 1k
R781 0
C702 100 4V
R717 100k
R718 10k
FL701 0UH (2012)
C706 0.1 F
R710 C711 10k 0.01
C714 0.1
C716 0.47 B
C723 0.01 B
C725 0.1 F
R772 22
FL703 0UH (2012)
C780 10 10V
C777 0.01 B
1.9
1.6
1.5
3.3
3.3
1.6
1.5
1.6
0.5
0.9
0.3
3.3
3.3
1.6
1.6
1.6
1.6
1.6
1.6
3.2
1.7
3.2
3.2
0.2
0.8
FL702 0UH (2012)
0.4
R701 680
0
0
0
0
5
0
0
0
0
0
0
0
0
C778 0.01
C730 0.01 B
B
3.3 0.4 1.6 1.6 1.6 1.6 3.3 0.4 0.4 0.4 0.4 0.4 3 1.6 3.3 1.6 0 0 5 2 0.4 2.1 3.2 3.2 0 0 0 5 0 1.6 0 0
DVD DECODER IC701 TMC57929PGF -RDP C741 0.01 B R731 22 R730 22
R765 22k FL704 0UH (2012)
C781 10 10V
C776 0.1 F
R771 2.2k
C779 10 10V
C775 R767 47k C774 0.0047 R764 1M C773 0.47 B C771 0.047 B R763 8.2k C772 0.1 C770 0.01 B
0.01
B
0
R762 22k R760 0
18
C767 0.01 B
C769 0.01 R778 100k C768 0.01
B
5 0 5 3.2 3.3 1.5 0
0 0 0 5 3.3
R732 10k
B
C742 0.01 B
5 5 1.6 3.2
R799 0 R776 0 C765 0.01 B R750 10k C766 100p
5 5 5 5 5 3.2
R702 10k R703 10k R735 10k R704 10k R737 10k R705 10k
C743 0.01 B
3.2 3.2 1 1 3.3 2.5 2.6 2.6 2.6 0
5 3.3 0 2.3 5 5
R706 10k
C744 0.01 B R741 22 R742 22 C745 0.01 B
R743 22
R777 0
3.3
0
0
0
0
0
5
0
0
0
0
5
0
5
0
0
0
5
0
0
3.3
3.2
3.2
3.2
3.2
3.2
3.2
3.2
3.2
3.3
R746 47k R744 22 C764 0.01 B C763 0.01 B R745 47k C762 0.01 B C761 0.01 B
C760 0.01 B
0
NO MARK : DVD STOP
19
HCD-FR1/FR8/FR9
17
17
HCD-FR1/FR8/FR9
Ver 1.2 3-10. SCHEMATIC DIAGRAM -- DMB08 BOARD (4/10) --
IC B/D
+2.5V REG R808 10k
R888 10k R889 10k
R886 10k R887 10k
R884 10k R885 10k
R882 10k R883 10k C842 0.01 B
IC B/D
3.3 3.3 0.8 0 0 0 0 0 0 0 0 0 0 0 0 0
2.5 0
C805 0.01 B C797 100 4V 16Mbit SD-RAM
IC704 TK11125CSCL-G
IC808 MSM56V16160F-8TK 7R1
0
3.3
3.3
3.2
FL810 0UH (2012)
C796 0.1 F
3.3 3.2
3.2
3.2
C854 0.01 B C840 10 10V C843 0.01 B R805 10k SL811 R842 10k C865 0.01 B C867 0.01 B C866 0.01 B
3.2
3.3
SL813
R804 0 C870 33000p R803 100 C871 0.01 B
C815 0.01 B
C841 10 10V FL812 POWER-EMIS (3216)
C848 0.01 B
SL812
0.7
2.5
2.5
2.5
3.3
3.3
FL811 POWER-EMIS
0
0 0
0
0 0
0
0
0
0
0
0
0
0
2.5
3.3
3.3
0
FL807 0UH (2012) C802 10 10V C803 0.01 B C849 0.01
0 3.2 0 0 0 0 0 0.8 2.5
3.3
0
0
0
0
0
0
C861 0.01 B
SACD/DVD SELECT R847 22
IC814 TC7WH157FK (TE85R)
3.2 0 0
C857 0.01 B
3.2 3.2 3.2 3.2 1.6 1.6 0
R850 22 C855 0.01 B R826 22 C837 0.01 B
C813 0.01
3.3
3.2
IC B/D
17
LEVEL SHIFT IC812 SN74LV245APWR
3.2 3.2
0
IC B/D
3.3 0 0 0 0 0 0 0 0
C819 0.01 B C811 0.01 C804 0.01 B
0 0 0 2.5 0 0 3.2 0 0 0 0 0 0 3.2 0
DSD DECODER IC801 CXD2753R
1.6 1.6 1.6 1.6 1.6
R821 22 R849 22 R848 22
3.3 0 0 0 0
0 0 0 0
R822 22 R823 22
1.6
2.5
R867 0
IC813 SN74LV245APWR
R830 4.7k
0 0 0 0 0 0 0 0 0 0
C856 0.01 B
3.3 5.1 5.1 0 2.2
3.3 3.2 0 0 1.5
C812 0.01
2.5
0.8 1.2
0 0 3.2
LEVEL SHIFT
0
3.2
3.2
2.5
3.2
3.2
3.2
0
0.7
3.2
0.9
3.3
3.3
3.3
3.2
3.2
0.2
IC B/D
C808 100p C817 0.01 B
R831 33k
C807 0.01 B
C810 0.01 B
R806 0
C818 0.01 B
2.5
C838 0.01 B
R800 4.7k
R839 4.7k
R829 100
R827 100
R828 4.7k
C839 0.01 B
NO MARK : DVD STOP
19
HCD-FR1/FR8/FR9
18
18
HCD-FR1/FR8/FR9
Ver 1.2 3-11. SCHEMATIC DIAGRAM -- DMB08 BOARD (5/10) --
3
(3/10)
17
18
FL301 0UH (2012)
R304 22
C303 0.01 B
R303 22
R306 22
R307 22
C301 10 10V
R308 22
C302 0.01 B
R305 10k
Q301 DTC114EKA-T146 LASER DIODE SELECT
5
3.2 3.2 3.2 3.2 3.2 3.2 3.2 3.2 3.2 3.2 3.2 3.2 3.2 3.2 3.2 4.1 4.1 0 0 0 0 0 0 0
0
FL304 0UH (2012)
SWITCHING IC802 TC7S32FU(TE85R)
C320 0.01 B IC302 BR24L16F-WE2
R738 22
3.2 0 0
3.2
3.2
3.2
EEPROM
0 0 3.2 3.2
R312 10k R311 22
0 0.5 3.2 0 3.2 3.2
C311 0.01 B C312 10 10V R346 C310 100p C309 100p R344 1k 1k C809 0.01 FILP-FLOP R350 100 IC803 SN74AHC2G74HDCUR
3.2 3.2
IC B/D
3.2
0 0 0 0 3.2
3.1 3.2 0.1
3.2 3.2 3.2
1.6 1.1
MECHANISM CONTROLLER
R316 10k
1.6 3.3 1.6 1.1 1.6 1.6 3.2 0 0 0
3.2
IC301 CXP973064-245R
2.5 2.5 2.6 2.6 0 0 0 0 3.1 3.1 3.2 3.2
R361 10k
3.2
1.2
CL301 R355 22
8
3.2
R357 68
CL302 CL303
9
0.6 3.2
R356 68
C308 33000p
R363 10k
C318 12p
1.4 1.4
0.6 0.6
3.2 0
R337 100 C316 10 16V
C317 12p
X302 R362 R354 27MHz 150 1M
5
IC303 SM8707GV -G-E2
6
7
R358 68
10
0 3.2
R335 22
IC B/D
R333 10k R366 100k R365 100k FL303 0UH (2012)
R330 100
L301
C313 0.1 F
CLOCK GENERATOR
3.2
3.2
3.2
R323 100 3.2
3.2
3.1
3.2
1.5
1.5
3.2
1.6
1.6
0.6
3.2
3.2
R321 100
R324 0
R325 33k
R326 100 R327 100 R328 100 R329 100
R317 100
R318 100
X301 20MHz
3.2
0
0
0
0
0
0
0
0
R332 10k
R359 10k R353 10k CN301 7P JL301 JL302
C307 0.01 B
C304 0.01 B
R360 10k
R364 4.7k
JL303 JL304 JL305 JL306 JL307
R331 220
NO MARK : DVD STOP
HCD-FR1/FR8/FR9
19
19
CL304
HCD-FR1/FR8/FR9
Ver 1.2 3-12. SCHEMATIC DIAGRAM -- DMB08 BOARD (6/10) --
R608 3.3k
R600 100
X600 12.288MHz
C604 56p
C603 22p
R687 1k
C608 0.1 R606 100 R603 100 R604 100 R607 100 R605 1k
R768 0
C611 0.01 C609 0.1 C612 10
R602 1M
3.3
IC B/D
0 0 0 0 0 0 0 0
S-RAM
0
0
0
0
0
0
0
0
0
0
1.7
1.6
1.6
3.3
3.2
3.2
1.6
1.6
1.6
0
0
C616 0.1
C627 0.01 C634 0.1
IC604
IS61LV6416
-10TLT
C617 0.1
R611 100
C626 0.01
C613 10
3.3
3.3
3.3
16
IC606 LC89056W-E C636 0.1
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
2.9 2.9 3.2
R616 5.6k
3.3 0
DIGITAL AUDIO INTERFACE
3.3
C637 0.01
R615 4.7k
C635 0.01
0 0 0 0
R625 3.3k
0 4.9 4
IC B/D
R623 100
R628 100 R631 100
R629 100 R994 4.7k
C640 0.01
C642 0.01
C641 C652 220 4V
0.01
FL604 0UH FL603 0UH C643 220 4V C674 10
3.3
3.3
3.3
4.8
2.5
C646 0.01 L602
R995 4.7k C644 0.01
3.3
3.3 0 4.7 0 0 0 0 0 0 0 3.3 0 0 0 0 0 2.5 0 0 0 0 0 0 0 0
R634 1k
0
0
3.3
R614 33k
21
C647 0.01
2.6 0 0 0 0 0 0 0 0 3.3 0 0 0 0 2.6 2.7 0 0 0 0 0
R639 100
R640 100
C648 0.1
R642 100 C632 15p C629 15p
R637 2.2k R645 1M X601 13.9MHz R740 1k R648 33 C653 0.01
1.6
C650 0.01 R689 10k
2.6 1.6 0 1.6 1.7 3.3 1.7 0 1.7 1.6 1.6 0 0 0 0
IC607 CXD9718BQ
C651 0.01
18
R655 100 R658 100 FL606 0UH R659 33 R662 100 R664 100 R666 100 R667 100
DIGITAL AUDIO SIGNAL PROCESSOR
C660 0.01 R663 100
C667 10 R661 100 C666 0.01 C668 0.01
3.3 0 4.7 0 4.6 0
2.6
3.3 3.3 3.3 3.3
3.3
0 3.3
R688 0
1.6
1.7
1.6
3.3
1.6
2.6
0
1
C670 0.01 C665 0.01 R996 4.7k R898 10k
0 2.6
2.5 1.6 1.6 1.6 1.6 1.6 1.6 1.6
DIGITAL AUDIO PROCESSOR IC612 CXD9742Q
C669 0.01
0 1 0 1.7 1.7 3.3
R672 100
R673 220 R674 220 R675 220 R676 220 R677 220 R997 4.7k R679 100 R998 4.7k R678 4.7k C672 0.01 R680 100
1.6
R699 2.2k C675 0.01
4.7
IC B/D
C671 0.01
C664 10
2.6
FL607 0UH
R697 4.7k
2.5
4.7
3.2
3.2
3
R698 10k C661 0.01
R691 4.7k
C673 0.01
R692 2.2k
C679 0.01
R671 100
2.5 2.5 1
NO MARK : DVD STOP
22
HCD-FR1/FR8/FR9
20
20
HCD-FR1/FR8/FR9
Ver 1.2 3-13. SCHEMATIC DIAGRAM -- DMB08 BOARD (7/10) --
IC601
10 12
IC601
REG C601 0.1
IC B/D
L600
C607 0.1
C602 100
C600 0.1
R626 1k R657 1k
FL605 0UH
L601
A/D CONVERTER IC609 PCM1802DBR
3.3 3.3 2.1 2.1 2.1 2.1 2.1 1.6
C610 47 6.3V
LOW-PASS FILTER R610 2.2k R609 470
C619 0.1 C614 1 50V C625 1 50V
4.4
3.1
C618 10 16V C622 10 16V R590 1k C620 0.1
3.1
C631 0.1 R621 100
C633 0.1
C638 0.1
C630 10 10V
3.3
4.8
C615
0.1 R739 4.7k
IC603 NJM2904V(TE2)
R613 4.7k
C624 0.1
R612 47k
C628 10 16V
R618 4.7k
5
REG IC605 NJM2391DL1 -26(TE1)
1.5 2.5 2.5
R619 47k
10
4.4
3.1
3.3
R622 100 R624 100 R683 2.2k
20
2.5
R630 470 C639 0.1 D/A CONVERTER
1.6 1.6 0 1.7 4.7 4.7 4.7 3.8 2.5 2.5 5
IC608 AK4381VT-E2
R627 2.2k
C657 0.1 C655 100 6.3V R601 0 C552 0.1
R599 0
IC B/D
3.1
NO MARK : DVD STOP
22
HCD-FR1/FR8/FR9
21
21
HCD-FR1/FR8/FR9
Ver 1.5 3-14. SCHEMATIC DIAGRAM -- DMB08 BOARD (8/10) --
20 21
2.7
Q908 DTC124EKA -T146
Q908-Q910 ENABLE SWITCH
R992 10k FB901 0UH FB902 0UH
0 2.7
Q909 DTC124EKA -T146 CN900 8P Q903 2SC2712-GL-TE85L
0
0
Q910 DTC124EKA -T146
C900 0.1
C927 0.1
3.3
R900 100
5 0 0 3.3 5 0 0
R905 100 IC900 TC74HCT7007AF (EL) C925 0.1 R903 100 R901 100
4.7
5 0
3.2
INVERTER
0
R955 10k R957 10k TP904 TP905
R902 100
0 0
R954 10k R904 100
D903 1SS355TE-17
0
R917 820
R918 820
R931 1k
LEVEL SHIFT
R939 10k R908 10k R909 10k R959 0
R911 2.2k
R912 2.2k
R913 2.2k
R915 2.2k
R914 2.2k
JW900 100
R916 100
R910 100
IODATA1
C901 0.01
R906 3.3k
R907 3.3k
TP902
TP901
IC902
TRANSLATION CONTROLLER
4.6 4.6 4.6 4.7 4.6 4.7 4.7 4.7 5.1 0.1 4.6 4.7 4.7 4.7 4.1 4.1 4.7 4.1 4.6 4.6
C908 10 R973 0
R921 100 R953 100
IORST
C924 0.1
R928 0
0
0
0
0
0
5
0
4
0
C928 0.1
IC902 R894 10k PT8300R-TP
C902 0.1
5 0 4.6 0.2 5 5.1 5.1 5.1 5.1 5.1
IC906 PT8300R-TP R094 0
4.6 4.7 4.7 4.8
R949 JW903 0 Q900 DTA114EKA 4.8 -T146 C916 0.1 10k R929 8.2k
0 0 0 4.7 4.7 4.7
R922 10k
IORST IOCLK IOLAT1
R092 0 R920 100 R093 0 SEN2 SEN3 SEN4 SEN5 SEN6 SEN7 SEN8 RB901 10K
0
R894 10K
3.3 1.5 1.5
2.2 4.7
SWITCH
4.7 0
R932 10k R685 10k X901 20MHz
17
4.6
IC901 -M59-3BA-A
R971 10k
3.1 5 4.7 3.3 4.8 0 0 4.8 4.8 4.8 4.8
R919 2.2k TP900 R896 47k R933 4.7k
1 2 3 4 5 6 7 8 9 10 11 12 13 14
4.8 4.4 4.3 5.1 5.1 5.1 0 5.1 5.1 0 0 4.5 4.7
0 0.4
28 27 26 25 24 23 22 21 20 19 18 17 16 15
MA1 MA2 MB1 MB2 MC1 MC2
MEN10 MEN11 MEN12 MEN13 MEN20 MEN21 MEN22 MEN23 RB902 10K
1 2 3 4 5 6 7 8 9 10 11 12 13 14
5 4.8 4.4 4.3 5.1 5.1 5.1 0 5.1 5.1 0 0 4.5 4.7 0 0.4 0 0.4 4.8 5 5.1 5.1 5.1 5.1 5.1
28 27 26 25 24 23 22 21 20 19 18 17 16 15
PARA-DO2 R924 100
4.7
SYSTEM CONTROLLER
R925 100 R927 100 R930 10K
IC906
TRANSLATION CONTROLLER
D900 1SR154-400TE-25
4.7 4.9 4.7
R991 10k
4.6 4.7 4.7 6 4.7
R945 47k
Q901 RESET SWITCH
C909 0.22 16V
IC B/D
R972 10k D907 1SS355TE-17 R990 2.2k R895 10k C926 0.1
D901 1SR154-400TE-25 C912 47 6.3V C910 0.22 5.5V C911 47 6.3V
R941 10k
R944 10k C905 330p
4.8
Q901 2SC2412K-T -146-QR
4.7
R950 47k R964 100k
4.8
4.7
4.7
4.8
4.7
4.8
4.7
4.7
4.7
4.8
4.7
4.2
4.4
4.6
4.8
4.8
4.8
4.8
3.2
R942 10k R943 10k
C906 330p C907 0.001
5
0
0
0
0
0
0
0
0
0
IC907 PST3645NR
5 5 0
R936 3.3k
C913 0.01
R967 100
R926 100
C914 0.01
R968 100
R899 10k
R962 10k
R961 10k
R960 10k
R951 10k
TP903
D902 1SS355TE-17
C932 0.1
RESET SIGNAL GENERATOR
SEN2 SEN3 SEN4 SEN5
SEN2 SEN3 SEN4 SEN5 SEN6 SEN7 SEN8 MEN10 MEN11 MEN12 MEN13 MEN20 MEN21 MEN22 MEN23 MA1 MA2 MB1 MB2 MC1 MC2
R897 10k
SEN6 SEN7 SEN8 MEN10 C923 0.1 MEN11 MEN12 MEN13 MEN20 MEN21 MEN22 MEN23 MA1
D906 KDS160-RTK
4.8 4.6
Q902 DTA114EKA-T146
Q914 SIRCS DETECT
4.7 0
R984 47K
0
MUTING CONTROL
Q914 SC2712-GL -TE85L R983 47K R981 47k R963 22k R969 R935 22k:FR8 10k:FR9 no mount:FR1
MA2 MB1 MB2 MC1 MC2
KEY INPUT DETECT
10k:FR1 47k:FR8 no mount:FR9 R980 47k R979 47k 4.8 C922 0.1 Q913 2SA1037AK -T146-QR R987 47k R986 47k D904 1SS355TE-17
4.7 4.7 0
R989 0 C918 100p
4.7
4.8 0.7 0
R978 1k R985 470k
IC903 PST3241NL
0
C917 0.1
Q907 2SC2712-GL -TE85L
DISC INSERT DETECT
R977 22k
Q906 2SC2712-GL -TE85L
Q906, Q907 SIRCS DETECT
NO MARK : DVD STOP
HCD-FR1/FR8/FR9
22
22
HCD-FR1/FR8/FR9
Ver 1.2 3-15. SCHEMATIC DIAGRAM -- DMB08 BOARD (9/10) --
IC202 HY57V283220T6
128Mbit SD-RAM
C231 R259 0UH 0.01 B R264 75
R258 0UH
R257 0UH
R260 0UH
R210 75
R261 0UH
R232 0 R250 C201 R248 4.7k 220 4.7k R249 4V 4.7k FB202 0UH C235 0.01 B C228 0.01 B C225 0.1 R236 1k 1/16W 0.5% C236 0.01 B
R262 75
R207 75
R263 75
R208 75
R209 75
R266 75
R265 75
R234 75
3.3 0.8 3.3 0.9 0.6
C234 0.01 B C233 0.01 B C237 0.01 B
0.7 0.8 0.7 3.3 0.5 0.5 1 0.7 3.3 1.2
3.3 0 R245 0
R238 100
R246 4.7k
R206 0
FB201 0UH
R203 180 0.5%
C232 0.01 B
4.7k
0.5 0.6 3.3 0.9 0.4 0.6 3.3 0.4 2.9 3 3 2.5 0.2 1.1 2.3 2.1 0.4 0.4 0.6 0.4 3.3 0.7 1 0.5 3.3 1.2 0.6 0.8 0.3 3.3 0.5 3.3
C226 0.01 B
C229 0.01 B
C230 0.01 B
1.6 0 0
1.8
3.3 3.3
3.3 1.3
1.3 3.3 3.3
0.4 3.3
0.7 3.3
0.4 3.3
0.7 3.3
0.9 3.3
3.2
3.3
C239 0.01 B
C238 0.01 B
0 0
C219 0.01 B
0.4
3.3
R252 4.7k
C240 0.01 B
11
4 4.1 3.2 2.4
12
13
14
15
R253 4.7k
R233 10k
0.5 0.2 0.3 0.8 3.3 0.4 0.3 0.3 0.4 0.3 0.5 0.3 0.8 0.6 3.2 0.4 1.2 0.5 1 0.7 1.8 0.7 0.8 0.7 0.5 3.3 0.4 0.5 1 0.7 1.2 0.6 0.4 0.9 0.6 3.3 0.4 0.5 0.6 0.9 0.8 1.8 3.3 2.9
C241 0.01 B
3.3 3.3 0 0 0 0 1.8 0 0 0 0 3.2 5.1 3.2 5.1 2.3 3.1
IC206 ZIVA5X-C2F C249 0.01 B DVD SYSTEM PROCESSOR
1.8 3 0.1 0.1 0.8 0.4 1.1 1.2 1.0 0.4
C243 0.01 B
R202 0
C217 0.01 B C242 0.01 B
IC B/D
R239 47k EEPROM
0.5 3.3 0.2 0.3 0.8 0.3 3.3 0.3 0.4 0.3
C244 0.01 B
C246 0.01 B
C247 0.01 B
IC203 BR9040F-WE2
0 3.3
3 3.3 3.3 3.3
0 0
Q302 DTC114EKA -T146
C203 0.01 B
C245 0.01 B
C248 0.01 B
3.3
INVERTER
R226 4.7k
3.1 0 0
R247 4.7k
0 5.1 0 3.1
C255 0.01 B 3.2
C252 0.01 B
R255 1k
FL202 0UH (2012)
C254 10
C253 0.01 B
CL801
CL206 XX
C259 0.01 B C250 0.01 B CL201 CL202 CL203 CL204 R242 10k CL205
3.2 3.3 0.2 3.2 3.2 3.2 0.1 4.7
FL203 0UH (2012)
C257 10
C258 0.01 B
C204 0.01 B
C260 0.01 B
IC205 MBM29PL32BM90TN FR PROGRAMMABLE ROM
R212 22
R229 33 R230 33
1.8 0 0
C262 0.01 B
C261 0.01 B
R213 0
3.3 0 0 * 0 * 0 2.7 0 0 0 3.3
* 2.7 * 0
2.7 * 3.3
2.7 3.2 3.2 3.2 3.2 3.2 3.2
1.8
3.3 0.1 0.1 0.8 0.4 1.1 1.2 1.1 0.6 0.4 0.2
3.3 2.1 0.2 2.3 1.1 2.5
FL204 0UH (2012)
CL803
R256 4.7k
R225 33
C264 10
C265 0.01 B
C266 0.01 B
R227 33
R228 33
C251 0.01 B
R215 33
R217 33
R216 33
R218 33
R219 33
R220 33
R222 33
R231 33
C267 0.01 B
C268 0.01 B
C269 0.01 B
R221 33
R223 33
R224 33
C271 0.01 B
C270 0.01 B
0 0 0 0 3.2 0 0 0 0 0 3.2 3.3 0 3.3 3.3 0 0 3.2 3.2 3.2 3.2 3.2 0 0
0 3.3 0 0 0 * * 0 2.7 * * 3.3 0 0 2.7 2.7 0 * 0 2.7 3.2 3.2 0
R243 1k
R241 1k
C263 0.01 B
R244 4.7k
C314 0.01
3 3
C274 0.01
C315 0.01
C319 33p
* 2.7 *
2.7 0 3.3 * 2.7 *
2.7
0 3.3 0 0 0 0
0 0 0
0 * 0
*
IC B/D
IC215 SN74ALVCH16841DGGR BUS INTERFACE
3.2 3.2
3.2 3.2 3.3 3.2 0 0
0 3.2 0 0 0 0
C356 0.01
C355 0.01
0 0 0 3.3 0 0
*
NO MARK : DVD STOP
HCD-FR1/FR8/FR9
23
23
HCD-FR1/FR8/FR9
Ver 1.2 3-16. SCHEMATIC DIAGRAM -- DMB08 BOARD (10/10) --
12
CN006 28P TP001 TP002 TP003 TP004 TP005 TP006 TP036 TP035 TP034 TP033 CN001 9P
TP082
TP084
TP092
TP094
TP102
TP083
TP080
TP085
TP088
TP093
TP086
TP089
TP090
TP095
TP098
TP096
TP099
TP078
TP103
TP081
TP100
TP091
TP087
TP079
TP097
TP101
TP007
TP032 TP031
TP009 TP010 TP011
0.01
TP008 R071 0
TP030
C009
27
0.01
TP012 TP013 TP014 TP015
R103 1k
C002
R098 1k
R097 1k R035 470
R099 1k
R100 1k
CN004 17P TP037 TP039 TP040 TP041
100
0
0
TP016 TP017 TP019
R038 470 R040 R042 470 470
0 R085
32
TP020 R044 R045 TP021 TP022 TP038 TP048 R891 100 TP067 FB001 CN002 29P CN003 15P TP018 TP105 TP076 TP023 R050 0 R075 0 0UH R890 100 IC904 TC7W34FUTE12R R101 1k C903 0.1 470 470 470 TP042 TP043 TP044
R012
R081
R076
TP104
R892 100
IC904
BUFFER
R046
R033 470
TP077 TP045 TP046 TP047 TP049 TP052
5 4.9 3.3 *
4.9 4.9 3.3
R027 100 R048 R049 100 100
27
R102 1k
R104 1k
R064 1k
TP024 TP025
IC006
+1.8V REG
1.8
FB004 TP026 0UH IC005 IC004 C018 0.1 C020 220 4V
3.3
C019 0.1
+3.3V REG
TP027
3
5
C016 0.1
5
C015 0.1
6.2
C014 0.1
33
TP028 TP029 R043 1k
C017 0.1
IC001
IC002
+5V REG
+3.3V REG
CN005 17P TP075 TP074 TP062 TP061 TP060 FB006 0UH C022 100 4V
3.3
C008 0.1
5
C001 100 6.3V C010 0.1
5
6.2
+5V REG
C006 100 16V C005 220 4V FB010 0UH FL004 0UH
FB008 0UH
FL003 0UH
FB007 0UH
C011 0.1
FB009 0UH FL005 PWR-EMIS FB012 0UH FB011 0UH CN008 12P TP063 TP065 TP064 TP066 R019 2.2k C003 100 FB013 0UH C004 47 16V TP072 TP071 TP068 TP070
TP059 TP058 TP057 TP056
FB014 0UH
FL006 0UH
35
TP055 TP054 TP053
TP050 FB005
0UH
R059 0
TP073 TP051
HCD-FR1/FR8/FR9
24
24
HCD-FR1/FR8/FR9
3-17. PRINTED WIRING BOARD -- AMP BOARD (SIDE A) --
· See page 7 for Circuit Boards Location. :Uses unleaded solder.
1 A
2
3
4
5
6
7
B
C
IC303
D
· Semiconductor Location
IC107
IC106
IC105
IC104
IC103
IC102
IC101
Ref. No. IC101 IC102 IC103 IC104 IC105 IC106 IC107 IC108 IC109 IC110 IC301 IC303 IC305 Q102 Q104 Q106 Q108 Q110 Q112 Q114 Q301 Q304
Location D-6 D-5 D-5 D-4 D-3 D-2 D-1 E-4 E-3 E-2 E-6 C-7 E-5 B-6 B-7 B-4 B-4 B-3 B-3 B-1 E-1 C-1
E
IC110 IC109
IC305 IC108
IC301
22 (22)
F
HCD-FR1/FR8/FR9
25
25
HCD-FR1/FR8/FR9
3-18. PRINTED WIRING BOARD -- AMP BOARD (SIDE B) --
· See page 7 for Circuit Boards Location. :Uses unleaded solder.
1 A
2
3
K
SPK BOARD CN312 (Page 38)
4
J
SPK BOARD CN311 (Page 38)
5
6
I
SPK BOARD CN309 (Page 38)
7
8
B
SWITCHING REGULATOR CN4 FAN
C
SWITCHING REGULATOR CN7
D
· Semiconductor Location
Ref. No. D101 D102 D103 D104 D105 D106 D107 D201 D202 D203 D204 D205 D206 D207 D208 D303 D304 Q101 Q103 Q105 Q107 Q109 Q111 Q113 Q303 Location D-2 D-3 D-4 D-4 D-5 D-6 D-7 D-3 D-3 D-4 D-5 D-6 D-7 D-7 E-2 D-7 D-7 B-2 B-2 B-5 B-4 B-6 B-5 B-7 C-7
E
H
HP BOARD CN811 (Page 39)
1
16 17
22 (22)
F
2
C
HCD-FR1/FR8/FR9
DMB08 BOARD CN004 (Page 13)
B
DMB08 BOARD CN001 (Page 13)
26
26
HCD-FR1/FR8/FR9
Ver 1.2 3-19. SCHEMATIC DIAGRAM -- AMP BOARD (1/4) --
R345 10k 1/10W R347 10k 1/10W SL303 C326 0.1 25V F TP331 R317 470 1/10W C325 0.1 25V F
3.3
3.3
3.3
3.3
3.3
1.7
3.3
0
3
R316 470 1/10W
21
3.3 1.7 0.4 3.3 C324 0.1 25V 1.7 1.7 0 0
IC110 CXD9788AR STREAM PROCESSOR
C336 47 16V
C337 47 16V
1.7 3.3 1.7
C323 0.1 25V F R380 560
CN301 17P TP395 TP301 TP302 TP303 TP304 TP305 TP306 R309 0 R308 470 1/10W TP307 TP308 TP309 R306 470 1/10W R305 470 1/10W R304 470 1/10W TP310 TP343 TP361 TP312 TP342 TP360 R303 470 1/10W R302 470 1/10W R351 470 1/10W R300 470 1/10W C402 100p 50V CH C405 0.001 50V B
C327 0.1 25V F R326 0
3.3
0 1.8 1.7
R379 560 1/10W
C328 0.1 25V F
C335 47 16V
28
1.7
3.3
3.3
3.3
R319 10k 1/10W
R328 0
C320 0.1 25V F
C321 0.1 25V F C322 0.1 25V F
1.7
R329 0
24
SL302
C403 100p 50V CH
C404 100p 50V CH
C317 0.1 25V F TP329 R318 470 1/10W R344 470 1/10W
C316 0.1 25V F
3.3
3.3
3.3
3.3
3.3
1.8
3.3
CN302 9P
C406 0.0047
1.7
0
3
21
3.3 1.7 0.4 3.3 C315 0.1 25V 1.7 1.7 0 0
STREAM PROCESSOR IC109 CXD9788AR
TP314 TP315 TP316 TP317 TP318 TP368 TP319 R310 100 1/10W R311 100 1/10W R312 100 1/10W R313 100 1/10W R314 100 1/10W R315 33 1/10W
C334 47 16V R378 560 1/10W C333 47 16V R377 560
1.7 3.3 1.7
C314 0.1 25V F R376 560
C318 0.1
25V F
3.3
24
R327 0
0 1.8 1.7
R375 560 1/10W
30
C332 47 16V
C319 0.1 25V F
1.7
3.3
3.3
3.3
1.7
C313 0.1 25V F R325 0
R324 0
C311 0.1 25V F
C312 0.1 25V F
NO MARK : DVD STOP
29
HCD-FR1/FR8/FR9
27
27
HCD-FR1/FR8/FR9
Ver 1.2 3-20. SCHEMATIC DIAGRAM -- AMP BOARD (2/4) --
R239 100 C137 0.01 25V B IC106 CXD9774M R247 100 1/10W C147 25V F C218 0.1 25V F
R157 0 R137 0 R147 0 R167 0 R177 0
R120 22k
R384 560
R383 560
C178 47p 50V CH
0.1
12 1.7 12
POWER DRIVER C116 1 16V F
R128 22k
C180 47p 50V CH
R382 560 1/10W
R119 22k R176 0 C200 0.1 25V F R166 0 C146 0.1 25V F C136 0.01 25V B
3.2 0 0 0 0
R156 0 R146 0
0 15 15 7.9 7.9
R206 C272 3.3 0.22 50V B 1/4W C176 0.22 50V B C196 2200 35V R431 100k 1/10W D304 1SS355TE-17 C186 0.033 50V B C372 1 50V
1.7
3.3
3.3
3.3
3.3
3.2
C107 1 16V F
1.7
0
0
0
0
POWER DRIVER IC107 CXD9774M
0 3.3 3.3 3.3 7.9 7.9 15 15
R136 0
C271 C166 R196 0.22 0.22 3.3 50V 50V 1/4W B B
D303 1SS355TE-17 TP389 L136
C377 10 50V R430 10k 1/10W
7.9
7.9
7.9
7.9
12
12
15
15
15
15
12
L137
R381 560
R237 100
R246 100 1/10W
0
C156 0.033 50V B
1.7
R118 22k
12 12
C106 1 16V F IC105 CXD9774M D206 P6SMB39AT3
C226 1 50V
C292 0.0022 50V B C266 0.0022 50V B R226 2.7 1/8W R216 2.7 1/8W C256 0.0022 50V B C291 0.0022 50V B
C157 0.033 50V B C197 2200 35V TP390 C167 0.22 50V B R197 3.3 1/4W
C273 0.22 50V B
D106 P6SMB39AT3
R117 22k
12 1.7 12
POWER DRIVER C115 1 16V F L126
C216 1 50V
C274 0.22 50V B C177 0.22 50V B R207 3.3 1/4W
C187 0.033 50V B C117 1 16V F
R175 0
3.2 0
0 15 15 7.9 7.9
C185 0.033 50V B L127 L135 C290 0.0022 50V B C293 0.0022 50V B R225 2.7 1/8W R215 2.7 1/8W C289 0.0022 50V B
D107 P6SMB39AT3
D207 P6SMB39AT3
27
R481 10k 1/10W
R450 10k 1/10W
R482 10k 1/10W
R451 10k 1/10W
R483 10k 1/10W
R484 10k 1/10W
R453 10k 1/10W
R485 10k 1/10W
R454 10k 1/10W
C145 0.1 25V F R235 100
R155 0 R145 C135 0.01 25V B 0
0 3.3 3.3 3.3 7.9 7.9 15 15
R245 100 1/10W
C175 0.22 50V B D205 P6SMB39AT3 TP388 D105 P6SMB39AT3 C155 0.033 50V B C215 1 50V C225 1 50V C265 0.0022 50V B
R217 2.7 1/8W C257 0.0022 50V B
R227 2.7 1/8W
C267 0.0022 50V B
C294 0.0022 50V B
C209 C165 0.22 0.22 50V 50V B B
R195 3.3 1/4W
R135 0 C168 47p 50V CH
0
1.7
12 12
C195 2200 35V C105 1 16V F
C255 0.0022 50V B
R452 10k 1/10W
R455 10k 1/10W
3.3
R486 10k 1/10W
C199 0.1 25V F R165 0
0 0
C210 0.22 50V B
R205 3.3 1/4W
C217 1 50V
C227 1 50V
12
0
0
TP370 TP371 TP372
L125
R116 22k
4.9
C160 47p 50V CH IC104 CXD9774M
Q301 KTC3875 0 PROTECT R395 100k 1/10W C385 2.2 16V F
TP373 R139 0 TP374 TP375 R409 100k 1/10W R410 100k 1/10W R411 100k 1/10W R412 R413 100k 100k 1/10W 1/10W Q112 2SA1602 TP-1EF C396 10 10V R414 100k 1/10W CN313 6P 3.95MM
12 1.7 12
POWER DRIVER C114 1 16V F
C158 47 10V
38
R115 22k R174 0 0.1 C198 25V F
3.2 0 0
0 15 15 7.9 7.9
C208 0.22 50V B R204 3.3 1/4W C288 0.0022 50V B C264 0.0022 50V B R224 2.7 1/8W R214 2.7 1/8W C254 0.0022 50V B C287 0.0022 50V B C184 0.033 50V B L134
R365 100k 1/10W
R366 100k 1/10W
R367 100k 1/10W
C144 0.1 25V F R233 100 R244 100 1/10W
R164 0
0 3.3
C395 2.2 16V
7.9
Q110 2SA1602 TP-1EF
7.9 0
0
R154 0 R144 0
C174 0.22 50V B
D204 P6SMB39AT3
C224 1 50V
7.9 F
0
7.9
C397 10 10V F
7.9
Q114 2SA1602 TP-1EF
7.9
0
3.3 3.3 3.3
7.9 7.9 15 15
C207 C164 0.22 0.22 50V 50V B B R194 3.3 1/4W
D104 P6SMB39AT3 TP387 L124 C214 1 50V
7.9
Q109 2SA1602 TP-1EF 7.9
0
7.9
Q111 2SA1602 TP-1EF
0
7.9
Q113 2SA1602 7.9 TP-1EF
0
R134 0
7.9
C134 0.01 25V B
0
C154 0.033 50V B
OVER LOAD DETECT
1.7
12 12
R114 22k
C104 1 16V F
C194 2200 35V
NO MARK : DVD STOP
30
HCD-FR1/FR8/FR9
28
28
HCD-FR1/FR8/FR9
Ver 1.2 3-21. SCHEMATIC DIAGRAM -- AMP BOARD (3/4) --
27
R425 470 1/10W R426 560 1/10W CN300 2P R427 560 1/10W
12
12
Q303,Q304 FAN DRIVE
SL301 C306 0.1 25V F
Q303 2SB1013-TP-34
0
R428 47k 1/10W
Q304 KRC103S
C308 0.1 25V F
0
R429 4.7k 1/10W TP341 C248 47 16V C360 0.1 25V F C357 100p 50V CH CNP310 R348 470 1/10W
0
R346
470 1/10W
3.3
TP330
3.3
3.3
3.3
3.3
1.8
3.3
1.7
0
3
21
3.3 1.7 0.4 3.3 1.7 1.7
C361 47 25V
CNP309
C305 0.1 25V F
C331 47 16V R374 560 1/10W C330 47 16V R373 560
R337 22k 1/10W R336 22k 1/10W
R333 22k 1/10W C352 100p 50V R332 22k 1/10W
R341 33k
STREAM PROCESSOR IC108 CXD9788AR
0 0 1.7 3.3 1.7
C362 100 10V
4.8
4.8
12
0
HEADPHONE AMP C359 470 10V
R372 560
0UH TP366
IC301 RC4580IDR
TP320
TP365 R343
C354 100p 50V CH C353 100p 50V CH
R339 24k 1/10W
R349 2.2k 1/10W
C309 0.1
25V F
3.3
R323 0
0 1.8 1.7
TP321 TP322 TP324 CNP303 5P BOARD IN TP367
R342 0UH C358 470 10V
R338 24k 1/10W C363 0.1 25V F
C304 0.1 25V F
R371 560 1/10W
R350 2.7k 1/10W
C310 0.1 25V F
C329 47 16V
7
4.8
1.7
1.7
1.7
1.7
3.3
1.7
1.7
3.3
3.3
R340 33k 1/10W
R335 22k 1/10W 50V CH
C351 100p 50V CH R330 22k 1/10W
R322 10k 1/10W
C356 100p
R334 22k 1/10W
R320 0
R321 0
C301 25V F
1.5
40
4.8
R331 22k 1/10W
C303 0.1 25V F C302 0.1 25V F R393 22 TP325
30
0.1
FB301 0UH
C382 0.001 50V B
IC305 MC74VHC1GU04DFT1
TP392 TP391 TP327 TP363 TP396 TP364 C366 220 16V C350 0.1 50V B C367 0.1 25V F C355 100 16V C370 0.1 25V F R400 100k 1/10W
IC303 TK11118CSCL-G
CNP305 2P BOARD IN
20
R394 1M 1/10W
3.3
1.8
3.3
1.5
R396 100 1/10W
X450 49.152MHZ
OSC
TP369
0
TP328
TP362
TP340
C368 0.01 25V B
C371 0.01 25V B
C375 100 16V
C374 0.01 25V B
C380 220 10V
C381 0.01 25V B
C384 5p 50V CH
1.5
0
L302
CNP304 4P BOARD IN
C383 10p 50V CH +1.8V REG
NO MARK : DVD STOP
HCD-FR1/FR8/FR9
29
29
HCD-FR1/FR8/FR9
Ver 1.2 3-22. SCHEMATIC DIAGRAM -- AMP BOARD (4/4) --
28
IC103 CXD9774M R113 22k
12 1.7 12
POWER DRIVER C113 1 16V F C183 0.033 50V B C286 0.0022 50V B C223 1 50V
Q106 2SA1602 7.9 TP-1EF
7.9 7.9 0
R173 0 0.1 C190 25V F
3.2 0 0
0 15 15 7.9 7.9
0
Q108 2SA1602 TP-1EF
Q107,Q108 OVER LOAD DETECT
7.9
L133
0
C263 0.0022 50V B Q105 2SA1602 TP-1EF
7.9
C393 2.2 16V F R363 100k 1/10W R406 100k 1/10W
0
Q107 2SA1602 TP-1EF
7.9
C394 2.2 16V F R364 100k 1/10W R407 100k 1/10W R408 100k 1/10W
R460 10k 1/10W
R492 10k 1/10W
R461 10k 1/10W
R231 R153 0 100
0 3.3
R143 0
27
R243 100 1/10W
7.9 7.9 15 15 0
C153 0.033 50V B C205 C163 0.22 0.22 50V 50V B B R193 3.3 1/4W
D103 P6SMB39AT3
C213 1 50V
3.3 3.3
R133 0
C253 0.0022 50V B
R213 2.7 1/8W C285 0.0022 50V B
Q105,Q106 OVER LOAD DETECT R405 100k 1/10W
TP386 L123
0.01
C133 25V
R493 10k 1/10W
R491 10k 1/10W
R462 10k 1/10W
C143 0.1 25V F
R163 0
0 3.3
C206 0.22 50V B
R203 3.3 1/4W
D203 P6SMB39AT3
C173 0.22 50V B
R223 2.7 1/8W
7.9
7.9
TP379
C149 47p 50V CH
1.7
12 12
TP378 TP377 C103 1 16V F C193 2200 35V TP376
R112 22k
R111 22k C148 47p 50V CH R172 0 0.1 R162 0 C142 0.1 25V F R229 100 R242 100 1/10W R132 0 R152 0 C189 25V F
IC102 CXD9774M
R463 10k 1/10W
R464 10k 1/10W
Q103,Q104 OVER LOAD DETECT
7.9 12
POWER DRIVER C112 1 16V F D202 P6SMB39AT3 L132 Q102 2SA1602 TP-1EF
CN307 4P EH-S 2.5MM
38
7.9 7.9 0
Q104 2SA1602 TP-1EF
1.7
12
C182 0.033 50V B
0
7.9
R456 10k 1/10W R458 10k 1/10W R457 10k 1/10W R487 10k 1/10W R488 10k 1/10W R489 10k 1/10W
50V
R490 10k 1/10W
R459 10k 1/10W
50V
50V
50V
3.2 0 0 0 3.3
0 15 15 7.9 7.9
C275
C172 0.22 50V B
0 3.3 7.9 7.9 15 15
C203 C162 0.22 0.22 50V 50V B B R192 3.3 1/4W
D102 P6SMB39AT3
R142
0
3.3 3.3
C212 1 50V
R212 2.7 1/8W
R222 2.7 1/8W
Q101 2SA1602 TP-1EF Q101,Q102 OVER LOAD DETECT
7.9
Q103 2SA1602 TP-1EF
7.9
C278
C276
C277
C204 0.22 50V B
R202 3.3 1/4W
C222 1 50V
C262 0.0022 50V B
C284 0.0022 50V B
0.001
0.001
0.001
0.001
0
7.9
C391 2.2 16V F
0
7.9
C392 2.2 16V F
CN306 4P EH-S 2.5MM TP383
TP382 TP381 R362 100k 1/10W R404 100k 1/10W
TP385 L122
C252 0.0022 50V B
R401 100k 1/10W
R361 100k 1/10W
R402 100k 1/10W
R403 100k 1/10W
TP380
38
C132 0.01 25V B
0
C152 0.033 50V B
C283 0.0022 50V B
1.7
12 12
R110 22k
C102 1 16V F IC101 CXD9774M
C192 2200 35V
R109 22k
12 1.7 12
POWER DRIVER C111 1 16V F C181 0.033 50V B C171 0.22 50V B
R171 0
3.2
0.1 C188 25V F
0 15 15
C202 7.9 0.22 50V B R201 3.3 1/4W
L131
29
0 0
R161 0 0.1 C141 25V F R151 0
0 3.3
C221 1 50V D201 P6SMB39AT3 R221 2.7 1/8W C211 1 50V R211 2.7 1/8W
C282 0.0022 C261 0.0022
50V B 50V B
7.9
R129 100 R241 100 1/10W R131 0
0 3.3 7.9 7.9 15 15
C201 C161 0.22 0.22 50V 50V B B R191 3.3 1/4W
D101 P6SMB39AT3
C251 0.0022 C281 0.0022
50V B 50V B
R141
0
3.3 3.3
TP384 L121
0.01
C131 25V B
0
10k 10k 10k 10k R494 R495 R496 R497
C101 1 16V F D208 MA8027-H-TX C191 2200 35V C151 0.033 50V B
R108 22k
1.7
12 12
C138 47p 50V CH
NO MARK : DVD STOP
HCD-FR1/FR8/FR9
30
30
HCD-FR1/FR8/FR9
Ver 1.2 3-23. PRINTED WIRING BOARD -- IO BOARD --
· See page 7 for Circuit Boards Location. :Uses unleaded solder.
1 A
2
3
4
5
6
7
8
9
10
TUNER UNIT
IC603
OPTICAL DIGITAL IN
B
IC201
VIDEO
3 1 4 2
S VIDEO (DVD ONLY)
MONITOR OUT
C
F
DMB08 BOARD CN003 (Page 13)
PR/CR
COMPONENT VIDEO OUT PB/CB
D
Y
E
E
DMB08 BOARD CN002 (Page 13)
L
R VIDEO SAT
· Semiconductor Location
Ref. No. IC201 IC602 IC603 IC605 IC606 Q101 Q102 Q604 Q605 Q606 Q607 Location B-6 F-2 A-7 F-3 E-6 A-7 B-1 F-6 F-6 F-3 F-6
IC606
IC602
F
IC605
SURROUND BACK
HCD-FR1/FR8/FR9
31
31
HCD-FR1/FR8/FR9
Ver 1.2 3-24. SCHEMATIC DIAGRAM -- IO BOARD (1/2) --
C102 3300p
CN102 11P
C101 3300p C103 220 16V
R106 1k
C105 1
C106 1 R108 470k
R109 1k L101
R103 0
6.9
C107 22 25V
R107 470k
6.9
C108 22 25V R101 0 TP101 TP102 TP103 TP104 TP105 R112 6.8k R114 33k C109 0.018 TP106 TP107 TP601 TP602
1.5 0.9
Q102 2SC2412K -T-146-QR
1.5
Q101 2SC2412K -T-146-QR
R110 220
0.9
AMP
R111 220
AMP
R633 1.5k
R621 10k C605 22 25V R602 10k R601 10k R118 33k C111 22 25V
R113 6.8k
L601
J601 4P
R635 6.8k
C606 22 25V
R623 10k
R604 100
R116 33k
R634 1.5k
R622 10k
R624 10k
TP603 C110 0.018 C112 22 25V R115 33k TP604 TP201 TP605 TP606 TP607 R117 33k R607 1k TP608 TP609 TP610 R608 1k TP611 R128 0 24
R603 100
R636 6.8k
C607 22 25V
0
Q604, Q605 INVERTER
10
R119 33k
5
5
5
5
0
0
4.8
R632 47k C612 220p 50V R631 47k C611 220p 50V R627 10k R626 10k
C603 0.1
R630 47k
C610 220p 50V
R629 47k
C608 22 25V C609 220p 50V
R628 10k
R625 10k
IC602 MC14052 BDR2
C624 1000p
C604 100 16V
Q605 DTC124EK-T146
0 4.8
IC B/D
Q604 DTC124EK-T146
5
5
5
5
TP612 TP613 TP614
IC603
OPTICAL RECEIVER
IC603 TORX141L
TP615
INVERTER
C626 0.1
R609 10k
TP616 TP617 R610 10k CN601 29P
3.3 0.2
R645
100 C646 220p
C627 22 25V L602 J201 3P
C636 220p
R661 220 R654 220
IC B/D
CONVERTER
R647 10k
0
C635 0.01
Q607 DTC343TK-T-146
R655 2.2k
R653 10k
C638 100p
R651 4.7k
IC606 RC4580IDR
0.1
0 0 0 0
Q606 DTC343TK-T-146 J602 1P R605 100 R656 47k R650 1k R659 1k
IC605 M62429FP-TP
C632 100 16V
C628 220p
R652 10k
R648 10k
C631 0.1
0
4 4 4
C637 22 25V
0
C633 100p R649 C634 22 25V
0
0
R657 10k 33k
C625 22 25V
C645 100p
R664 4.7k
C629
C639 100 16V
C212 1000p
Q606, Q607 MUTE DRIVE
AMP
5
3.5
3.5
10
4
0
NO MARK : DVD STOP
33
HCD-FR1/FR8/FR9
32
32
HCD-FR1/FR8/FR9
Ver 1.2 3-25. SCHEMATIC DIAGRAM -- IO BOARD (2/2) --
32
TP202 TP203
IC B/D
VIDEO AMP 75 ohm DRIVER
TP204 TP205
TP206 TP207 TP208
23
R224 10k
22
5 0 2.4
IC201 MM1623BFBE
5 2.3 4.8 1.7 5 1.5 1.5
L209 R235 10k C225 0.1 C224 100 16V TP209 C217 0.1 L214 0
J202 2P
R225 75
TP210 TP211 TP212
24
R226 75 R227 75
C234 0.1 C235 1000 6.3V C238 1000 6.3V
0
C218 100p 50V C229 0.1
C278 10 50V C216 10 50V R203 1k R204 1k
TP213 CN201 15P
1.1 2.4
0 0 2.3
C227 22 25V
R228 75 R229 75 R230 75
C239 1000 6.3V
2.3
3.5 2.3
C240 1000 6.3V C241 1000 6.3V
R234 10k
C223 C222 1 10V
2.4
4.8 2.3
C221 1 10V
24 25 26
NO MARK : DVD STOP
HCD-FR1/FR8/FR9
33
33
HCD-FR1/FR8/FR9
3-26. PRINTED WIRING BOARD -- DDCON BOARD --
· See page 7 for Circuit Boards Location. :Uses unleaded solder.
1 A
2
3
4
5
6
7
P
IC802 B
DISC KEY BOARD CN804 (Page 39)
O
FL BOARD CN803 (Page 36)
C
15 14
D
D
DMB08 BOARD CN005 (Page 13) · Semiconductor Location
Ref. No. D810 D811 D813 D814 D815 IC802 Q802 Location C-5 C-5 C-5 C-5 C-3 A-2 C-6
HCD-FR1/FR8/FR9
34
34
HCD-FR1/FR8/FR9
Ver 1.2 3-27. SCHEMATIC DIAGRAM -- DDCON BOARD --
C829 1000p 50V C827 1000p C825 1000p C824 1000p C822 1000p C820 1000p 50V 50V 50V 50V 50V
220p 50V
220p 50V
220p 50V
220p 50V
CN802 13P
22 10V
R826 820 R827 820
TP855 TP856 TP857 TP858 TP859 TP860 TP861 TP862 TP863 TP864 TP865 TP866 TP867
0
0
0
0
0
47k
0
IC802 NJU3713G(TE2)
R823
C823
C817
C826
C819
C821
R829 820 R830 820 R831 820 R833 820 R834 820
C828 0.1
16V
0
0
0
0
0
0
0
0
6
R835 820
R819 100 R818 100
LED DRIVE
R837 820 R838 820
R817 100 R814 100
40
50V C833 1000p
1000p
1000p
C831 1000p 50V TP835 TP838 TP839 TP840 TP841 TP842 TP843 TP844 TP845 TP846 TP847 TP848 TP849 FB806 0UH R004 JW L807 L806 L805 R804 JW
50V
50V
C832
C834
TP867 R806 0
CN801 17P
TP866
FB001 FB002 FB003
0UH 0UH 0UH
37
0UH
24
TP850 FB808 TP851 TP852 TP854 CN800 17P FFC S
L804 R815 0 R811 JW R850 3.9k C818 100 10V
D814 1SS355TE-17 C830 0.022 50V T801 DC-DC CONVERTER D813 1SS355TE-17 D811 1SS355TE-17 C835 0.01 50V C836 10 50V C837 0.1 16V
19
0.1
Q802 CPH5504-TL-E
5
D815 UDZSTE-176.2B
0.1
5
R839 33k D810 1SS355TE-17 R841 100
NO MARK : DVD STOP
HCD-FR1/FR8/FR9
35
35
HCD-FR1/FR8/FR9
3-28. PRINTED WIRING BOARD -- FL BOARD --
· See page 7 for Circuit Boards Location. :Uses unleaded solder.
1 A
2
3
4
5
6
7
8
L
CONTROL KEY BOARD CN810 (Page 39)
B
C
D
IC803 IC801
E
O
DDCON BOARD CN801 (Page 34)
PW KEY BOARD CN805 (Page 39)
M
N
SONY LAMP BOARD CN806 (Page 39)
· Semiconductor Location
Ref. No. IC801 IC803 Q810 Location D-7 D-5 D-7
F
HCD-FR1/FR8/FR9
36
36
HCD-FR1/FR8/FR9
Ver 1.2 3-29. SCHEMATIC DIAGRAM -- FL BOARD --
FL801 REMOTE C0NTROL RECEIVER IC801 NJL73H400A
4.6
R828 0 CN812 7P C807 0.01 25V
5.0
C805 10 50V
FB807 0UH
40
-22.6
-20.5
-24.8
-26.8
-29
-29
-29
-27
-29
-31
-31
-29
-29
-29
-31
-29
-29
-27
-29
-31
-31
-27
-31
-29
-29
-29
-29
-31
-31 -31
IC803 ML9208-03MBZ03B CN803 17P TP815 TP814 TP811 TP813 TP812 TP816 TP821 TP822 TP823 TP824 TP825 TP826 R853 100 R844 100 R882 1k R852 47 C841 10 10V C849 0.1 16V R881 1k R880 1k R878 2.2k FL DRIVER
4.8
4.7
4.7
2.1
2.2
5.0
-31
-29
-29
-29
-29
-29
-29
-29
-29
-29
-29
-29
-29
-31
-29
-29
-31
-31
R851 100
35
TP827 TP828 TP829 TP830 TP831 C848 0.01
25V
50V
R840 3.3k
R843 10k
50V
C846 0.0022
0.6 0
Q810 2SC1623 LED DRIVE
CNP807 3P
CNP808 2P
C850
R849 10k
C842 0.001
C847 0.015
C843 100p
FB005 0UH
R877 1k
47p 50V
50V
-31
5.0
R879 2.2k
0
-29
5
NO MARK : DVD STOP
40
40
HCD-FR1/FR8/FR9
37
37
HCD-FR1/FR8/FR9
Ver 1.2 3-30. PRINTED WIRING BOARD -- SPK BOARD --
· See page 7 for Circuit Boards Location. :Uses unleaded solder.
3-31. SCHEMATIC DIAGRAM -- SPK BOARD --
1 A
2
3
4
5
CN311 4P EH-S 2.5MM TP332
TP354
TP333 TP334
TP355
30
TP335 TB301 TERMINAL BOARD 5P TP361 C481 0.001
B
30
CN312 4P EH-S 2.5MM
C492 0.001 50V B
GP307 TERMINAL GND
TP336
TP362 C482 0.001 TP338 TP339 TP340 C483 0.001 50V B C491 0.001 50V B
TP337
TP341 C484 0.001 50V B TP342
C
SPEAKER FRONT R SURR R + CENTER + FRONT L SURR L + WOOFER +
CN309 6P 3.96MM
C485 0.001
C488 0.001 50V B
TP358
TP343 C486 0.001
TP359 C487 0.001 50V B
-
+
-
+
-
+
TP344 TP345 TP346 TP347 TP350 C493 0.001 50V B
TB302 TERMINAL BOARD 2P C495 0.001 50V B TP360
D
C486 C485
28
TP348 TP349
TP351 C496 0.001 50V B
TP353
C482
C481
C494 0.001 50V B
E
F
AMP BOARD CN307 (Page 26)
AMP BOARD CN306 (Page 26)
AMP BOARD CN313 (Page 26)
HCD-FR1/FR8/FR9
38
38
HCD-FR1/FR8/FR9
3-32. PRINTED WIRING BOARD -- POWER/FRONT PANEL SECTION --
· See page 7 for Circuit Boards Location. :Uses unleaded solder.
1 A
2
3
4
5
6
7
8
9
10
11
12
13
SWITCHING REGULATOR
B
AC IN
FL BOARD CN803 (Page 36)
VOLUME FUNCTION +
C
D
FL BOARD CNP808 (Page 36) SONY
E
F
PHONES AMP BOARD CNP303 (Page 26)
FL BOARD CNP807 (Page 36)
G
· Semiconductor Location
DISC 5
DISC 4
DISC 3
DISC 2
DISC 1
H
Ref. No. D800 D801 D802 D806 D807 D808 D809 D812 D823 D824 Q800 Q801 Q803 Q804
Location G-5 G-5 G-9 H-13 H-11 H-10 H-9 H-8 D-5 E-5 F-3 F-3 G-3 G-3
P
DDCON BOARD CN802 (Page 34)
I
HCD-FR1/FR8/FR9
39
39
HCD-FR1/FR8/FR9
Ver 1.2 3-33. SCHEMATIC DIAGRAM -- POWER/FRONT PANEL SECTION --
LF901 CN900 2P C903 0.22
JW902 JW CN901 2P
R861 2.2k S818 TACT SW LS8J3M
R860 0 S801 SW. KEY LS8J3M C816 0.1 25V C851 0.1 25V TP871 TP872 TP873
JW901 JW S809 SW. KEY LS8J3M
R868 2.2k S808 SW. KEY LS8J3M
R867
0 C844 0.1 25V C852 0.1 25V
TP874 TP875
C857 1000p 50V
TP876 CN810 7P R876 47k R875 22k R874 10k R866 4.7k
37
R855 100
D823,D824
R854 100
C858 820p 50V
S817 SW. KEY LS8J3M
S816 SW. KEY LS8J3M
S815 SW. KEY LS8J3M
S807 SW. KEY LS8J3M
C845 0.1 25V
TP869
C878 0.001
D824 SML-512WBC1AR
C877 0.001
D823 SML512WBC1AR
CN809 2P
TP870
37
Q801 - Q804 MUTING
L803 R807 100 Q804 DTC343TK-T-146 C804 0.0047 L800
0
R802 100 Q801 DTC343TK-T-146 C802 0.01
0
0
R801 4.7k
D802 SML-512UWT86 J800
R809 0
CN805 3P
FB803 0UH CN811 5P TP817 TP837 FB805 0UH Q803 DTC343TK-T-146 C854 47p
0
TP836 TP853 C803 0.1 FB800 0UH Q800 DTC343TK-T-146 C800 0.001 S800 TACT SW LS8J3M C811 0.1
FB810 0UH
37
TP818 TP819 TP820
C853 47p
0 0
FB802 0UH R803 100 L802 R805 100 C806 0.0047 L801
0
R800 4.7k
C801 0.01
29
D801 1SS355TE-17
0
D800 1SS355TE-17
D806 SML-020MDT-T86 S814 TACT SW LS8J3M R865 22k S806 TACT SW LS8J3M
NO MARK : DVD STOP
D807 SML-020MDT-T86
R873 47k
R872 22k CN804 13P
S813 TACT SW LS8J3M
R864 10k
S805 TACT SW LS8J3M
D808 SML-020MDT-T86 R871 10k
S812 TACT SW LS8J3M
R863 4.7k
S804 TACT SW LS8J3M
I
D809 SML-020MDT-T86 R870 4.7k
S811 TACT SW LS8J3M
S803 TACT SW LS8J3M R862 2.2k S802 TACT SW LS8J3M
D812 SML-020MDT-T86 R869 2.2k
S810 TACT SW LS8J3M
35
J
HCD-FR1/FR8/FR9
40
40
HCD-FR1/FR8/FR9 SECTION 4 EXPLODED VIEWS
NOTE: · -XX and -X mean standardized parts, so they may have some difference from the original one. · Items marked "*" are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. · The mechanical parts with no reference number in the exploded views are not supplied. The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. Les composants identifiés par une marque 0 sont critiques pour la sécurité. Ne les remplacer que par une pièce portant le numéro spécifié.
4-1.
CASE SECTION
front panel section
b a
5
not supplied
6
3 7
3
not supplied
3
3
4
3
3
not supplied
8 3 9
#1
c
1
3
not supplied
3
not supplied
a
3
b
3
chassis section
c
3
3
not supplied
2
3
Ref. No. 1 2 3 4 5 Part No. 4-253-911-01 4-253-912-01 3-077-331-01 1-763-861-12 4-217-350-11 Description PANEL (L), SIDE PANEL (R), SIDE +BV3 (3-CR) FAN, DC STOPPER, CORD Remark Ref. No. 06 7 8 9 #1 Part No. 1-783-531-72 A-4750-572-A 1-828-962-11 A-4751-753-A 7-685-881-09 Description CORD, POWER TUNER UNIT WIRE (FLAT TYPE) (11 CORE) IO BOARD, COMPLETE SCREW +BVTT4X8 (S) Remark
41
HCD-FR1/FR8/FR9
4-2.
FRONT PANEL SECTION
51
#3
56
52
not supplied not supplied not supplied #3
64 53
64
not supplied
62 64
a not supplied
not supplied
#3 not supplied not supplied
#3 not supplied
not supplied a
54
not supplied #3
57 65 65 59
not supplied
58
65
55
51 63
#3
51 60 61
Ref. No. 51 52 53 54 55 56 57 57 57
Part No. 3-077-331-21 X-4956-316-1 4-253-902-01 X-4956-308-1 X-4956-319-1 4-253-918-01 4-253-910-01 4-253-910-11 4-253-910-21
Description +BV3 (3-CR) BUTTON SUB ASSY, DISC CUSHION, SLOT BUTTON (POWER) SUB ASSY WINDOW SUB ASSY PANEL (AL), FRONT PANEL (ML), FRONT (FR1) PANEL (ML), FRONT (FR8) PANEL (ML), FRONT (FR9)
Remark
Ref. No. 58 59 60 61 62 63 64 65 #3
Part No. A-4751-757-A X-4956-315-1 4-253-909-01 4-232-478-31 1-829-320-11 1-829-321-11 4-931-757-31 7-685-133-19 7-685-133-19
Description FL BOARD, COMPLETE BUTTON SUB ASSY, PLAY PANEL, BOTTOM FOOT FLEXIBLE FLAT CABLE (13 CORE) FLEXIBLE FLAT CABLE (17 CORE) SCREW (DIA.2.6X8) (IT3B), TAPPING SCREW +P2.6X6, TYPE 2 SCREW +P2.6X6 TYPE2
Remark
42
HCD-FR1/FR8/FR9
Ver 1.3
4-3.
CHASSIS SECTION
101
not supplied not supplied
101
101 113
not supplied
101
#2 not supplied
101
106
not supplied
101 114
107
not supplied
101
not supplied
101 101
not supplied
104 101
102
109 110
mechanism deck section-1 (CDM69-DVBU16)
112
#4
111
not supplied
not supplied
108 101 103 105
Ref. No. 101 102 102 102 103 104 104 104 105 106 Part No. 3-077-331-01 A-4751-785-A A-4753-404-A A-4753-472-A A-4751-769-A A-4751-783-A A-4753-468-A A-4753-478-A 4-232-478-31 1-829-322-11 Des