Text preview for : _RRV3452_DV-696AV-K,_DV-696AV-S_2,_5_.PDF part of Pioneer DV-696 Service Manual
Back to : _RRV3452_DV-696AV-K,_DV-6 | Home
DV-490V
ORDER NO.
RRV3452
DV-696AV-S
DVD PLAYER
DV-696AV-S
DV-696AV-K
THIS MANUAL IS APPLICABLE TO THE FOLLOWING MODEL(S) AND TYPE(S).
Model
DV-696AV-S DV-696AV-S DV-696AV-K DV-696AV-K DV-696AV-S
Type
WYXZT5 WVXZT5 WYXZT5 YXZTUR5 YXZTUR5
Power Requirement
AC220 to 240 V AC220 to 240 V AC220 to 240 V AC220 to 240 V AC220 to 240 V
Region No.
2 2 2 5 5
Remarks
For details, refer to "Important Check Points for Good Servicing" .
PIONEER CORPORATION
4-1, Meguro 1-chome, Meguro-ku, Tokyo 153-8654, Japan PIONEER ELECTRONICS (USA) INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A. PIONEER EUROPE NV Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra Road, #04-01, Singapore 159936
PIONEER CORPORATION 2006
T-ZZR JULY 2006 printed in Japan
1
2
3
4
SAFETY INFORMATION
A
This service manual is intended for qualified service technicians ; it is not meant for the casual doit-yourselfer. Qualified technicians have the necessary test equipment and tools, and have been trainedto properly and safely repair complex products such as those covered by this manual. Improperly performed repairs can adversely affect the safety and reliability of the product and may void the warranty. If you are not qualified to perform the repair of this product properly and safely, you should not risk trying to do so and refer the repair to a qualified service technician.
WARNING !
B
THE AEL (ACCESSIBLE EMISSION LEVEL) OF THE LASER POWER OUTPUT IS LESS THAN CLASS 1 BUT THE LASER COMPONENT IS CAPABLE OF EMITTING RADIATION EXCEEDING THE LIMIT FOR CLASS 1. A SPECIALLY INSTRUCTED PERSON SHOULD DO SERVICING OPERATION OF THE APPARATUS.
LASER DIODE CHARACTERISTICS FOR DVD : MAXIMUM OUTPUT POWER : 5 mW WAVELENGTH : 650 nm FOR CD : MAXIMUM OUTPUT POWER : 5 mW WAVELENGTH : 780 nm
C
LABEL CHECK
Location: inside of the unit
D
726000A140
Additional Laser Caution 1. · Laser diode is driving with Q2303,Q2305(650nm LD) and Q2302, Q2304(780nm LD)on the DVD MT PCB Assy. Therefore, when short-circuit between the emitter and collector of these transistors or the base voltage is supplied for transistors turn on, the laser oscillates. (failure mode) · In the test mode , there is the mode that the laser oscillates except for the disc judgment and playback. LD ON mode in the test mode oscillates with the laser forcibly.
(Printed on the Rear Panel)
E
2. When the cover is open, close viewing through the objective lens with the naked eye will cause exposure to the laser beam.
: See page 55.
F
2
1 2
DV-696AV-S
3 4
5
6
7
8
[Important Check Points for Good Servicing]
In this manual, procedures that must be performed during repairs are marked with the below symbol. Please be sure to confirm and follow these procedures.
1. Product safety
Please conform to product regulations (such as safety and radiation regulations), and maintain a safe servicing environment by following the safety instructions described in this manual. 1 Use specified parts for repair. Use genuine parts. Be sure to use important parts for safety. 2 Do not perform modifications without proper instructions. Please follow the specified safety methods when modification(addition/change of parts) is required due to interferences such as radio/TV interference and foreign noise. 3 Make sure the soldering of repaired locations is properly performed. When you solder while repairing, please be sure that there are no cold solder and other debris. Soldering should be finished with the proper quantity. (Refer to the example) 4 Make sure the screws are tightly fastened. Please be sure that all screws are fastened, and that there are no loose screws. 5 Make sure each connectors are correctly inserted. Please be sure that all connectors are inserted, and that there are no imperfect insertion. 6 Make sure the wiring cables are set to their original state. Please replace the wiring and cables to the original state after repairs. In addition, be sure that there are no pinched wires, etc. 7 Make sure screws and soldering scraps do not remain inside the product. Please check that neither solder debris nor screws remain inside the product. 8 There should be no semi-broken wires, scratches, melting, etc. on the coating of the power cord. Damaged power cords may lead to fire accidents, so please be sure that there are no damages. If you find a damaged power cord, please exchange it with a suitable one. 9 There should be no spark traces or similar marks on the power plug. When spark traces or similar marks are found on the power supply plug, please check the connection and advise on secure connections and suitable usage. Please exchange the power cord if necessary. 0 Safe environment should be secured during servicing. When you perform repairs, please pay attention to static electricity, furniture, household articles, etc. in order to prevent injuries. Please pay attention to your surroundings and repair safely.
A
B
C
D
2. Adjustments
To keep the original performance of the products, optimum adjustments and confirmation of characteristics within specification. Adjustments should be performed in accordance with the procedures/instructions described in this manual.
3. Lubricants, Glues, and Replacement parts
Use grease and adhesives that are equal to the specified substance. Make sure the proper amount is applied.
E
4. Cleaning
For parts that require cleaning, such as optical pickups, tape deck heads, lenses and mirrors used in projection monitors, proper cleaning should be performed to restore their performances.
5. Shipping mode and Shipping screws
To protect products from damages or failures during transit, the shipping mode should be set or the shipping screws should be installed before shipment. Please be sure to follow this method especially if it is specified in this manual.
F
DV-696AV-S
5 6 7 8
3
1
2
3
4
CONTENTS
A
B
C
D
SAFETY INFORMATION ..................................................................................................................................... 2 1. SPECIFCATIONS ............................................................................................................................................. 5 2. EXPLODED VIEWS AND PARTS LIST ............................................................................................................ 6 2.1 PACKING SECTION .................................................................................................................................. 6 2.2 EXTERIOR SECTION................................................................................................................................ 8 2.3 06 DVD MECHA SECTION...................................................................................................................... 10 3. BLOCK DIAGRAM AND SCHEMATIC DIAGRAM .......................................................................................... 12 3.1 BLOCK DIAGRAM ................................................................................................................................... 12 3.2 OVERALL and POWER BLOCK DIAGRAM ............................................................................................ 14 3.3 OVERALL WIRING CONNECTION DIAGRAM........................................................................................ 16 3.4 DVD MT PCB ASSY (1/7) ........................................................................................................................ 18 3.5 DVD MT PCB ASSY(2/7) ......................................................................................................................... 20 3.6 DVD MT PCB ASSY(3/7) ......................................................................................................................... 22 3.7 DVD MT PCB ASSY(4/7) ......................................................................................................................... 24 3.8 DVD MT PCB ASSY(5/7) ......................................................................................................................... 26 3.9 DVD MT PCB ASSY(6/7) ......................................................................................................................... 28 3.10 DVD MT PCB ASSY(7/7) ....................................................................................................................... 30 3.11 OPERATION, OPERATION 2 and OPERATION 3, 4 PCB ASSYS ....................................................... 32 3.12 POWER PCB ASSY (1/2) ...................................................................................................................... 34 3.13 POWER PCB ASSY (2/2) ...................................................................................................................... 36 3.14 WAVE FORMS ....................................................................................................................................... 38 4. PCB CONNECTION DIAGRAM ..................................................................................................................... 41 4.1 LOADING and SW PCB ASSYS.............................................................................................................. 41 4.2 DVD MT PCB ASSY................................................................................................................................. 42 4.3 OPERATION, OPERATION 2 and OPERATION 3, 4 PCB ASSYS ......................................................... 46 4.4 POWER PCB ASSY................................................................................................................................. 50 5. PCB PARTS LIST ........................................................................................................................................... 52 6. ADJUSTMENT ............................................................................................................................................... 53 6.1 WHEN REPLACING DVD DECK ............................................................................................................. 53 6.2 TEST MODE ............................................................................................................................................ 54 6.3 TEST MODE IN........................................................................................................................................ 55 6.4 DISC REMOVAL METHOD...................................................................................................................... 56 7. GENERAL INFORMATION ............................................................................................................................. 57 7.1 DIAGNOSIS ............................................................................................................................................. 57 7.1.1 DISPLAY SPECIFICATION OF THE TEST MODE............................................................................ 57 7.1.2 FUNCTIONAL SPECIFICATION OF THE SHORTCUT KEY ............................................................ 58 7.1.3 SPECIFICATION OF MODEL INFORMATION DISPLAY .................................................................. 59 7.1.4 FUNCTIONAL SPECIFICATION OF THE SERVICE MODE ............................................................. 60 7.1.5 METHOD FOR DIAGNOSING DEGRADATION OF THE LDS ON THE PICKUP ASSY .................. 61 7.1.6 TROUBLE SHOOTING ...................................................................................................................... 62 7.2 DISASSEMBLY ........................................................................................................................................ 65 7.3 DVD DECK SECTION.............................................................................................................................. 66 7.4 IC INFORMATION.................................................................................................................................... 70 7.5 DISC / CONTENT FORMAT PLAYBACK COMPATIBILITY ..................................................................... 76 8. PANEL FACILITIES ........................................................................................................................................ 78 8.1 FRONT PANEL SECTION ....................................................................................................................... 78 8.2 REMOTE CONTROL ............................................................................................................................... 79
E
F
4
1 2
DV-696AV-S
3 4
5
6
7
8
1. SPECIFCATIONS
Specifications
General
System . . . . . . . . . . . . . . . . . . . . . . . DVD player Power requirements . . . . . . . . . . . . . AC 220 to 240 V, 50/60 Hz Power consumption . . . . . . . . . . . . . . . . . . . 8 W Power consumption (standby) . . . . . . . . 0.8 W Weight . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1.7 kg
A
Video output
Output level . . . . . . . . . . . . . . . . . . . 1 Vp-p (75 ) Jack . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . RCA
Audio output (1 stereo pair)
. . . . . . . . . . . . During audio output 200 mVrms (1 kHz, ± 20 dB) Number of channels . . . . . . . . . . . . . . . . . . . . . 2 Jacks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . RCA Output level
B
Dimensions
. . . .420 (W) mm x 49.5 (H) mm x 215.5 (D) mm Operating temperature . . . . . . +5 °C to +35 °C Operating humidity . . . . . . . . . . . . . 5 % to 85 % (no condensation)
HDMI output
HDMI output . . . . . . . . . . . . . . . . . . . . . . . .19 pin
AV connector output
AV Connector (21-pin connector assignment) AV connector output . . . . . . . 21-pin connector This connector provides the video and audio signals for connection to a compatible colour TV or monitor.
Audio output (multi-channel / L, R, C, SW, SL, SR)
Output level . . . . . . . . . . . . . During audio output 200 mVrms (1 kHz, ±20 dB) Number of channels . . . . . . . . . . . . . . . . . . . . . 6 Jacks . . . . . . . . . . . . . . . . . . . . . . . . . . RCA jack
C
Digital audio characteristics
Frequency response . . . . . . . . . . 4 Hz to 44 kHz (DVD fs: 96 kHz) S/N ratio . . . . . . . . . . . . . . . . . . . . . . . . . . . 115 dB Dynamic range . . . . . . . . . . . . . . . . . . . . . . 100 dB Total harmonic distortion . . . . . . . . . . . . 0.0025 % Wow and flutter . . . . . . . . Limit of measurement (±0.001 % W. PEAK) or lower
PIN no. 1 . . . . . . . . . . . . . . . . . . . . . . . Audio 2/R out 3 . . . . . . . . . . . . . . . . . . . . . . . . . Audio 1/L out 4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . GND 7 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . B out 8 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Status 11 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . G out 15 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . R out 17 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . GND 19 . . . . . . . . . . . . . . . . . . . . . . . . . . . Video out 21 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . GND Y (luminance) - Output level . . . . . . 1 Vp-p (75 ) C (color) - Output level . . . 286 mVp-p (75 ) Jack . . . . . . . . . . . . . . . . . . . . . . . . . . . . . S-video
D
Digital output
Coaxial digital output . . . . . . . . . . . . . . .RCA jack Optical digital output . . . . . . .Optical digital jack
Accessories
Audio/video cable . . . . . . . . . . . . . . . . . . . . . . . .1 Power cable . . . . . . . . . . . . . . . . . . . . . . . . . . .1 Remote control . . . . . . . . . . . . . . . . . . . . . . . . . .1 AA/R6P dry cell batteries . . . . . . . . . . . . . . . . 2 Warranty card . . . . . . . . . . . . . . . . . . . . . . . . . . .1 Operating Instructions
The specifications and design of this product are subject to change without notice, due to improvement.
S-video output
E
Component video output
Y (luminance) - Output level . . . . . . 1 Vp-p (75 ) PB (color) - Output level . . . . . . . 0.7 Vp-p (75 ) PR (color) - Output level . . . . . . . 0.7 Vp-p (75 ) Jack . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . RCA
F
DV-696AV-S
5 6 7 8
5
1
2
3
4
2. EXPLODED VIEWS AND PARTS LIST
NOTES:
A
Parts marked by "NSP" are generally unavailable because they are not in our Master Spare Parts List. The mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. Screws adjacent to mark on product are used for disassembly. For the applying amount of lubricants or glue, follow the instructions in this manual. (In the case of no amount instructions, apply as you think it appropriate.)
2.1 PACKING SECTION
GUARANTEE CARD INSTRUCTION BOOK (E) 6 7 POLYBAG,INSTRUCTION (RED CAUTION) 12 For WVXT5 type 2
INSTRUCTION BOOK (E/I) 8
B
INSTRUCTION BOOK (G/F) 9 INSTRUCTION BOOK (S/D)10 INSTRUCTION BOOK (R) 17 7-10,17 "Operating Instructions" 5 16 BATTERY,MANGAN PACKAGE 14 POLY BAG INSTA5 TRANSMITTER CORD,RCA PIN 3
1
For WYXZT5, YXZTUR5 types
2
C
1 4 PACKAGE
14 GIFT SHEET 13
D
Fr on
t
PACKAGE
PACKAGE
14
18
E
14
11 PACKAGE,PAD
15 18
F
6
1 2
DV-696AV-S
3 4
5
6
7
8
PACKING SECTION parts List
Mark No. 1 2 3 4 NSP 5 NSP 6 7 8 9 10
>
Description Cord Set AC Cord, RCA Pin Remote Control Battery Cover Battery,Mangan (AR, R6P) Guarantee Card Instruction Book Instruction Book Instruction Book Instruction Book
Part No. See Contrast table (2) 06CPBA2006 07650KY040 VNK4998 · · · · J2I80202A See Contrast table (2) See Contrast table (2) See Contrast table (2) See Contrast table (2)
Mark No. 11 12 13 14 15 16 17 18
Description Package, Pad Polyethylene Bag,Instruction Gift Sheet Package Gift Box Poly, Bag Instruction Book Carton Label
Part No. 792WHA0604 See Contrast table (2) 791WHA0100 See Contrast table (2) See Contrast table (2) 791WHAA040 See Contrast table (2) See Contrast table (2)
A
(2) CONTRAST TABLE DV-696AV-S/WVXT5, /YXZTUR5, DV-696AV-K/WYXZT5, /YXZTUR5 and DV-696AV-S/WYXZT5 are constructed the same except for the following :
Mark No. > 1 7 8 9 10 12 14 15 17 18 Symbol and Description Cord Set AC Instruction Book (English) Instruction Book (English, Italian) Instruction Book (German, French) Instruction Book (Spanish, Duch) Polyethylene Bag,Instruction Package Gift Box Instruction Book (Russian) Carton Label DV-696AV-S/ WYXZT5 1206158802 Not used J2J00321B J2J00322B J2J00323B JB5UD400 792WHAA190 793WCD1748 Not used Not used DV-696AV-S/ WVXZT5 1206138802 J2J00501B Not used Not used Not used JB5UD200 792WHAA191 793WCDD225 Not used Not used DV-696AV-S/ YXZTUR5 1206158802 Not used Not used Not used Not used JB5UD200 792WHAA190 793WCD1748 J2J00601A 723000D363 DV-696AV-K/ WYXZT5 1206158802 Not used J2J00321B J2J00322B J2J00323B JB5UD400 792WHAA190 793WCDD223 Not used Not used DV-696AV-K/ YXZTUR5 1206158802 Not used Not used Not used Not used JB5UD200 792WHAA190 793WCDD223 J2J00601A 723000D365
B
C
D
E
F
DV-696AV-S
5 6 7 8
7
1
2
3
4
2.2 EXTERIOR SECTION
20
A
NON-CONTACT SIDE
14 20 20
CONTACT SIDE
Refer to "2.3 06 DVD MECHA SECTION". 5
32
18
20
18
PCB240 (POWER PCB ASS'Y) 4 19 19
D
18
B
19
15 31
7
E
18
20 21 21
F
19
11
25 24
C
12 12 16 13
E
23
21 21
16
D
13
28
31 19
19
15
19
8
D
13
A
PCBDF0 13 PCBDG0 (OPERATION 3 PCB ASS'Y) 30 (OPERATION 4 PCB ASS'Y) 29 27 22 22 17 19
A
9
1 PCB130 (DVD PCB ASS'Y)
G
22
B
22
101G 101M
E
H
B
PCB280 3 (OPERATION 2 PCB ASS'Y)
101N 101D 101O
6
C
10
C
22
101E 101P
101C
101J 101I 101B 101A 101 101F 101K 101L
22 26 22 22
101H
C A
B
2
30 29 22
F
" FRONT PANEL SECTION".
PCB270 (OPERATION 1 PCB ASS'Y)
8
1 2
DV-696AV-S
3 4
5
6
7
8
EXTERIOR SECTION parts List
Mark No. 1 2 3 4 5 Description DVD MT PCB Assy OPERATION PCB Assy OPERATION 2 PCB Assy POWER PCB Assy DVD MECHA ASSY Cord Jumper(CD604) Shield, 21Pin Plate,Bottom Cord Jumper(CD601) Cord Jumper(CD602) Plate,Cover power Holder,FFC Cushion,Leg Cabinet,Top Cord Jumper(CD7301) Cushion (15x20x16) OPERATION 4 PCB Assy Screw,Tap Tite(S)-Bind Wash. Screw,Tap Tite(S) (3x5.5) Screw,Tap Tite(B) (3x6.0) Screw,Tap Tite(B)Pan (3x6) Screw,Tap Tite(P) (2.6x8) Part No. A2J003A130 See Contrast table (2) A2I802A280 A2J003A240 A2I802A650 122H051706 761WSA0237 702WSA0290 122H0B1003 122H091303 755WPAA031 761WPA0396 VEB1349 See Contrast table (2) 122H0C2801 8965TS101B A2I903ADG0 816423063U 8107D3055U See Contrast table (2) 810913060U 811022680U See Contrast table (2) See Contrast table (2) Mark No. NSP 26 27 NSP 28 29 30 31 NSP 32 Description Double,Face-Tape OPERATION 3 PCB Assy Sheet Caution Spring Earth Screw PAN Cord Connector (CD502) Sheet Caution Part No. 7290000156 A2I903ADF0 726000A140 743WKAA015 810213060U 06CU2E3301 725000A088 See Contrast table (2) See Contrast table (2) 711WPA0253
B
A
>
6 7 NSP 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22
101 Front Cabi Assy NSP 101A Cabinet, Front NSP 101B Plate, Display NSP 101C Plate, Cover 101D Flap, DVD NSP 101E Badge,Brand NSP 101F Button,Frame 1 NSP 101G Button,Frame 4 NSP 101H Button,Frame 2 NSP 101I Button,Frame 5 NSP 101J Button,Frame 3 NSP 101K Button, Cap NSP 101L Button, Cap 2 NSP 101M Button, Cap 1 101N Spring,Flap-DVD 101O SHEET DVD NSP 101P Glass LED
See Contrast table (2) 735WPA0874 735WPA0879 See Contrast table (2) See Contrast table (2) See Contrast table (2) See Contrast table (2) See Contrast table (2)
C
See Contrast table (2) 743WKA0052 7236740001 713WPA0385
NSP 25
Sheet,Jack 3
(2) CONTRAST TABLE DV-696AV-S/WVXT5, /YXZTUR5, DV-696AV-K/WYXZT5, /YXZTUR5 and DV-696AV-S/WYXZT5 are constructed the same except for the following :
Mark No. 2 14 20 NSP 24 NSP 25 101 NSP NSP NSP NSP NSP 101A 101E 101H 101I 101J Symbol and Description OPERATION PCB Assy Cabinet, Top Screw,Tap Tite(B) (3x6.0) Sheet, Jack 2 Sheet, Jack 3 Front Cabi Assy Cabinet, Front Badge, Brand Button, Frame 2 Button, Frame 5 Button, Frame 3 DV-696AV-S/ WYXZT5 A2I802A270 702WSB0114 8109K3060U 722631A099 722631A100 7A7010209A 701WPQA005 7236310014 735WPB0328 735WPB0329 735WPB0330 737WPE0043 737WPE0044 737WPN0001 DV-696AV-S/ WVXZT5 A2I802A270 702WSB0114 8109K3060U 722631A099 722631A100 7A7010209A 701WPQA005 7236310014 735WPB0328 735WPB0329 735WPB0330 737WPE0043 737WPE0044 737WPN0001 DV-696AV-S/ YXZTUR5 A2I808A270 702WSB0114 8109K3060U 722631A099 722631A109 7A7010209A 701WPQA005 7236310014 735WPB0328 735WPB0329 735WPB0330 737WPE0043 737WPE0044 737WPN0001 DV-696AV-K/ WYXZT5 A2I802A270 702WSB0115 8109K3060S 722631A108 722631A100 7A701A764A 701WPQA007 7236310009 735WPA0876 735WPA0881 735WPA0878 737WPA0037 737WPA0040 737WPDA001 DV-696AV-K/ YXZTUR5 A2I808A270 702WSB0115 8109K3060S 722631A108 722631A109 7A701A764A 701WPQA007 7236310009 735WPA0876 735WPA0881 735WPA0878 737WPA0037 737WPA0040 737WPDA001
D
E
NSP 101K Button, Cap NSP 101L Button, Cap 2 NSP 101M Button, Cap 1
F
DV-696AV-S
5 6 7 8
9
1
2
3
4
2.3 06 DVD MECHA SECTION
A
34 14 AB
Lubricating Oil GYA1001
9 18
21
Cannot supply separately. If the repair is needed, replace the LOADER SUB ASS'Y.
15
B
11
Grease GEM1036
AB AB AB
AC
AB
AB
C
23
Lubricating Oil GYA1001
20 AB 4
3
12 AC
19
6
Pickup leneses GEM1004 GED-008
CD2001
29 SW1 5
1 E PCB610 (LOADING MOTOR PCB ASS'Y) 7
D
24
32
31
10
CD2302 Do not replace the parts. Because, minute adjustments are needed if this condition is disassembled further more. If the repair is needed, replace the DVD MECHA ASS'Y.
8 13 AA 8
E
22 22 16
Grease GEM1018
27
25
2
26
30 SW2
Note :
33
17 PCB640 D (SW PCB ASS'Y) 28
CD2301
CLASS GREASE
F
PART NO.
GEM1018
PART NAME
G-555G
G-313Y
MARK AA AB AC
GYA1001 GEM1036
NOTE: Applying positions AA, AB and AC for the grease are displayed for this section. Check if the correct grease is applied for each position.
FL-78A
10
1 2
DV-696AV-S
3 4
5
6
7
8
06 DVD MECHA SECTION parts List
Mark No. NSP 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 NSP 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 Description Loading Motor PCB Assy Gear,Middle Loading Motor Pulley,Motor FEED Motor Cord Jumper (24P)(CD2001) Cord Jumper (CD2302) Insulator (F) Belt,Loading Insulator (R) Frame,main Tray (B) Holder ,Traverse Gear,Pulley Gear,Main Gear,Feed SW PCB Assy (PCB640) Plate, Clamper LOADER SUB ASSY (B) Clamper Screw,Pan (M1.7x3 P3) Screw,Pan (M1.7x2.3 P3) Rack,Loading Gear,Motor Feed Rack Assy Screw,T-Tite(B) (M1.7x5.0 P3) Screw,Gear Feed Cord Jumper (CD2301) Switch (SW1) Push Switch (SW2) Screw,Tap Tite(P) (2.6x8) Sems.Tap Tite(P) (2x8) Screw,Tap Tite(P) BI DVD MECHA ASSY Part No. A2F101A610 92P100117A 1515S98004 92P100097A 1515S98004 122J402202 122H051602 92P200013A 92P200015A 92P200016A 92P100119A 92P100127B 92P100125A 92P100123A 92P100124A 92P100116A A2F101A640 92P000023A 92AAA0019B 92P100122A
C B
A
814011730U 814011723U 92P100121A 92P100088A 92AAA0017A 813381750U 92P700007A 122H061605 0515S32003 0500101036 811022680U 816112080U 811022080U A2I802A650
D
E
F
DV-696AV-S
5 6 7 8
11
1
2
3
4
3. BLOCK DIAGRAM AND SCHEMATIC DIAGRAM
3.1 BLOCK DIAGRAM
A
DVD LOADER/MPEG BLOCK DIAGRAM DVD LOADER/MPEG BLOCK DIAGRAM
DVD Loader DVD (DM-4) Loader (DM-4) C
C
IOA, V20
IOA, V20
A
A
RESET IC IC4003 IC RESET BD5229G-TR IC4003 BD5229G-TR
RESET RESET
4
RF, A, B, C, D, E, F, MDI1 OPU OPU
RF, A, B, C, D, E, F, MDI1 A A
B
X4001 27MHz X4001 27MHz LDO1, LDO2 LDO1, LDO2
LD_DVD, LD_CD LD_DVD, LD_CD T+/-, F+/-, T+/-, F+/-, LOAD+/-, LOAD+/-, MOT_SLED+/-, MOT_SLED+/-, MOT_SPDL+/MOT_SPDL+/-
C
SPINDLE/ STEPING/ SPINDLE/ SLED STEPING/ MOTOR SLED MOTOR
DMSO, FMSO, TROPEN, FMSO, DMSO, TRCLOSE, TRSO, FOSO, TROPEN, TRCLOSE, MOTOR DRIVER IC STBY, V1P4 TRSO, FOSO, IC2301 MOTOR DRIVER IC STBY, V1P4 LA6565VR-TLM-E IC2301 LA6565VR-TLM-E LIMIT, TRIN, TROUT, LIMIT, TRIN, TROUT, A0~A20, AD0~AD7, PRD#, PCE#, PWR# A0~A20, AD0~AD7, PRD#, PCE#, PWR# MA0~MA11, DQ0~DQ15, MA0~MA11, DQ0~DQ15, DQM0, DQM1, DBA0, DBA1, DQM0, DQM1, DBA0, DBA1, SDCLK, SDCKE, DWE#, DRAS#, DCAS#, DCS# SDCLK, SDCKE, DWE#, DRAS#, DCAS#, DCS#
Q2302~2305 LD DRIVE Q2302~2305 LD DRIVE D D
MPEG/MICON IC MPEG/MICON IC IC4001 IC4001 MT1389EXE/B2-L MT1389FE/E-L
D
A A
16Mbit FLASH 16Mbit FLASH IC4004 IC4004 S29AL016D70TFI020 S29AL016D70TFI020
64Mbit SDRAM 64Mbit SDRAM IC4005 IC4005 EM638165TS-7G EM638165TS-7G
A A A
A
E
HDMI CONNECTOR HDMI CONNECTOR CP5901 CP5901 1 D2+ 1 D2+ 3 D23 D24 D1+ 4 D1+ 6 D16 D17 D0+ 7 D0+ 9 D09 D010 CLK+ 10 CLK+ 12 CLK12 CLK19 19 18 18 15 15 HOTPLUG HOTPLUG POWER POWER H H
EEPROM IC EEPROM IC IC4002 IC4002 BR24L08FJ-WE2 BR24L08FJ-WE2 A, B A, B SDA SDA SCL SCL 92_Y0~Y7 92_Y0~Y7
SDA SDA SCL SCL
HDMI TRANSMITTER IC HDMI TRANSMITTER IC IC5901 IC5901 MT1392E/C-L MT1392E/C-L
92_VCK, 92_ACLK, XO 92_VCK, 92_ACLK, XO ASPDIF ASPDIF HDMI_SCL HDMI_SCL HDMI_SDA HDMI_SDA
F
SCL SCL 16 SDA 16 SDA
12
1 2
DV-696AV-S
3
5
6
7
8
LETTER, I/XP, S_Y, S_C, R/CR, B/CB, G/Y, CVBS SQUEEZE, VSEL1 ESET IC IC4003 5229G-TR RESET C VIDEO DRIVER 6CH IC IC7301 LA73054-TLM-E
S-VIDEO JACK J7301
3 4
A
Y C
CVBS/Y/U/V J7302 CR OUT Y OUT CB OUT
6 5 3
CVBS Y U V
B
A, B VSEL1 D 4CH BUS SW IC IC7302 SN74CBT3257PWR
2
21PIN CONNECTOR J8101
19 CVBS 15 R OUT 11 G OUT 7
B OUT
Q8101, Q8102 SQUEEZE N IC B2-L VSEL1 Q8104, Q8105 DVD_RGB_H_OUT F 21 PIN CTL
21 PIN CTL BLANKING_OUT
8 16 3 1
L R
C
IC8006/7/8 AUDIO LPF AND AMP IC RC4580IDR
L/R JACK J8001
2 3
R L
DAC_XCSO, SCK, SD,ACLK, ABCK, ALRCK, ASDAT0~2 ASPDIF IC8003/4/5 AUDIO DAC IC PCM1742KEG/2K
LS/RS/S/LFE JACK J8002
2 3 5 6
SR SL C LFE
D
A L
A, C COAXIAL
COAXIAL JACK J8102
1
OPTICAL OS8001 FP_DI, FP_DO, FP_SCK, STB OPTICAL FIP DRIVER IC IC651 PT6315 GR1~GR8, P1~P16 FIP (V651) HNV-08SS44T IR A IR A
E
1
IR RECEIVER (OS651) ROM-N340TAO
A.......AT+3.3V B.......+1.8V C.......P.CON+5V D.......P.CON+6V E.......AT+12V F.......P.CON+12V G.......-28V H.......V+5H
G
F
DV-696AV-S
5 6 7 8
13
SR
SL
C
LFE
4
RESET IC IC4003 BD5229G-TR 8K EEPROM IC4002 BR24L08FJ-WE2
IC8003/4/5 AUDIO DAC IC PCM1742KEG/2K
IC8006/7/8 AUDIO LPF AND AMP IC RC4580IDR
R
L
FIP HNV-08SS44T SDA, SCL KEY 27MHz
RESET
21 PIN DAC_XCSO, SCK, SD, ACLK, ABCK, ALRCK, ASDAT0~2
CVBS OUT
RGB OUT
3.2 OVERALL and POWER BLOCK DIAGRAM
FIP DRIVER IC IC651 PT6315 FP,STB
MPEG/MICON BLOCK IC4001 MT1389FE/E-L
3
AUDIO CODEC/ INTERNAL DAC
AMUTE
4CH BUS SW IC IC7302 SN74CBT3257PWR 6CH VIDEO DAC
Y
U
V
IR SERVO IR RECEIVER (OS651) ROM-N340TAO IR RF MPEG-1/2/ JPEG VIDEO DECORDER
108MHz TV Encoder
VIDEO DRIVER 6CH IC IC7301 LA73054-TLM-E ASPDIF
S_VIDEO
S
COAXIAL
CO
MA0~MA11, DQ0~DQ15 A0~A20, AD0~AD7
MOTOR DRIVER IC2301 LA6565VR-TLM-E RF
LD_DVD, LD_CD
OPTICAL
2
SERVO
· OVERALL BLOCK DIAGRAM
16Mbit FLASH IC4004 S29AL016D70TFI020 DVD LOADER (DM4)
64Mbit SDRAM IC4005 EM638165TS-7G
92_Y0~Y7, 92_VCK, 92_ACLK
HDMI TRANSMITTER IC IC5901 MT1392E/C-L P.CON+12V POWER SUPPLY P.CON+5V P.CON+6V +1.8V AT+3.3V AT+12V for mute AC220 V - 240 V -28V FLDC+/-
TX0+/-, TX1+/-, TX2+/-, TXC+/-
HDMI CONNECTOR CP5901
1
C
D
A
B
E
F
14
1
2
OP
DV-696AV-S
3
CVBS
4
5
· POWER BLOCK DIAGRAM
5
PHOTO COUPLER IC504 PS2561AL1-1-V (W)
VOLTAGE CTL IC501 KIA431A-AT
POWER CTL IC502 STR-A6131M
REG+1.8V IC4006 LM1117S-ADJ
+1.8V
Q510 P.CON +12V SW Q515 P.CON +5V SW
AT+12V for mute P.CON+12V P.CON+5V
6
SWITCHING TRANS T501 6V REG IC503 PQ070XF01SZH Q505 P.CON SW Q504 FL+ P.CON SW Q502 -28V P.CON SW
6
P.CON+6V
DV-696AV-S
E D C
AC IN
HDMI+5V REG IC IC5902 PQ1K503M2ZPH
V+5H
P.ON-H AT+3.3V FL DC -
7
7
FL DC +
-28V
8
8 A B
15
F
1
2
3
4
3.3 OVERALL WIRING CONNECTION DIAGRAM
A
H
OPERATION 4 PCB ASSY (A2I903ADG0)
R664 HDMI LED(RED) D660 LTL-1CHEE-002A 330 1/4W
W807
W808
G
GND(NC) POWER V+3E LED
B
SW2
OPERATION 3 PCB ASSY (A2I903ADF0)
CP605
B OPERATION
OPERATION 2 PCB ASSY (A2I802A280)
CP603
SW1 STOP PLAY/+SKIP PAUSE/-SKIP V+3E POWER SW2 GND LED 9 8 7 6 5 4 3 2 1 9 8 7 6 5 4 3 2 1 (CD602) 1 2 3 4 5 6 7 8 9
(CD604)
C
9 8 7 6 5 4 3 2 1 5
PCB ASSY (A2I802A270 : Other) (A2I808A270 : YXZTUR5_Only)
1
2
3 3
4 4
1
2
5
5
CP604
CP602
1 2 3 4 5 6 7 8 9 SW1 STOP PLAY/+SKIP PAUSE/-SKIP V+3E POWER SW2 GND LED
CP601
CLK DI (M to F) STB DO (F to M) IR V+3E DGND DGND FLDC+ -28V 2 GND FLDC1 2 3 4 5 6 7 8 9 10 11 1 2 3 4 5 6 7 8 9 10 11
(CD601) 1 2 3 4 5 6 7 8 9 10 11
CP4002
1 2 3 4 5 6 7 8 9 10 11 CLK DI (M to F) STB DO (F to M) IR V+3E DGND DGND FLDC+ -28V FLDC-
GND(NC)
POWER
V+3E
C
SW2
LED
OS651
1 Vout
3 B+
POWER PCB ASSY (A2J003A240)
CP8102
SPDIF GND 1 2 1 2 1 2
CP8001
1 2 SPDIF GND
D
E 1/2 : POWER BLOCK E 2/2 :D-TERMINAL/ AUDIO BLOCK
CP503_1
G GND B GND R RGB-H FS CVBS GND AUDIO L GND AUDIO R 12 11 10 9 8 7 6 5 4 3 2 1 12 11 10 9 8 7 6 5 4 3 2 1
CD7301
1 2 3 4 5 6 7 8 9 10 11 12 1 2 3 4 5 6 7 8 9 10 11 12
CP7301_1
G GND B GND R RGB-H FS CVBS GND AUDIO L GND AUDIO R
AC220 V-240 V_50 Hz/60 Hz CD501_2 N 1
AC IN
WHITE 2 1 BLACK L
2
AC INLET J501 N
21PIN CONNECTOR
NC
E 1/2, E 2/2
L
J8101
1 2
E
NC
CP502
GND P.CON+12V GND P.CON+5V P.CON+6V GND(M) AT+3.3V AT+3.3V P.ON-H GND(D) FL DCFL DC+ -28V 1 2 4 5 6 7 8 9 10 11 12 13 14 1 2 3 4 5 6 7 8 9 10 11 12 13 14
3
(CD502) 1 2 3 4 5 6 7 8 9 10 11 12 13 14
CP4003
1 2 4 5 6 7 8 9 10 11 12 13 14 GND P.CON+12V GND P.CON+5V P.CON+6V GND(M) AT+3.3V AT+3.3V P.ON-H GND(D) FL DCFL DC+ -28V
5 6
4
7
AT+12V for MUTE 3
3 AT+12V for MUTE
9 NC 11 NC 13
OS8101
3 B+ 2 GND 1 Vout 15 17 19 NC 21
F
COAXIAL J8102
E 1 2
H
16
1 2
20
18
16
14
12
10
8
DV-696AV-S
3 4
5
6
7
8
÷ When ordering service parts, be sure to refer to "EXPLODED VIEWS and PARTS LIST" or "PCB PARTS LIST". ÷ The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. ÷ : The power supply is shown with the marked box.
AUDIO OUT (5.1 ch)
S-VIDEO OUT
4 2 6 3 1 5
A
VIDEO OUT
3
H2 H1 H2 H1
AUDIO OUT
3
H2 H1 H2 H1
2 1
6
5
2 1
6
5
3
H2 H1
2 1
E
E
4
E
E
4
E
S-VIDEO OUT
J7301
CVBS/Y/U/V J7302
LS/RS/C/U/LEF J8002
AUDIO L/R OUT
DVD MECHA ASSY (A2I802A650)
CP2301
F RTN F DRV T RTN T DRV NC GND LD(DVD) PD/GND LD(CD) GND VR(CD) VR COM VR(DVD) A B 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 F RTN F DRV T RTN T DRV NC GND LD(DVD) PD/GND LD(CD) GND VR(CD) VR COM VR(DVD) A B VRF(RF_OUT) SW1(DVD/CD) C D E VCC VS F GND OPTICAL PICK-UP DVD DRIVE DM-4PB
B
J8001
C
VRF(RF_OUT) 9 SW1(DVD/CD) 8 C D E VCC VS F GND 7 6 5 4 3 2 1
A A 1/7- A 7/7
DVD MT PCB ASSY (A2J003A130)
A A A A A A A
1/7 : MPEG/MICON/RF-AMP BLOCK 2/7 : MEMORY BLOCK 3/7 : LOADER/MOTOR DRV BLOCK 4/7 : AUDIO JACK BLOCK 5/7 : VIDEO JACK BLOCK 6/7 : HDMI BLOCK 7/7 : POWER PORT BLOCK
D SW PCB ASSY (A2F101A640)
CD2301
CP2303
SP1+ SP1SLD+ SLDLIMIT SW SW(GND) 1 2 3 4 5 6 1 2 3 4 5 6 1 2 3 4 5 6 SP1+ SP1SLD+ SLDLIMIT SW SW(GND)
M2601 JCV9B12
M M
SPINDLE MOTOR
M2602 BCZ3B05
D
SLED MOTOR
SW2 ESE22MH22
LOADING MOTOR PCB ASSY CD2302(A2F101A610)
E
CP2302
CLOSE GND(D) OPEN LD+ LD1 2 3 4 5
SW-2(CLOSE) GND(SW) SW-1(OPEN)
LD+ LD-
SW1 SSS-28-5
M
LOADING MOTOR
M2603 BCZ3B05
E
HDMI CONNECTOR
CP5901
HOTPLUG
POWER
CLK-S
CLK+
D2-S
D1-S
D0-S
CLK-
GND
CEC
SDA
SCL
D2+
D1+
D0+
D2-
D1-
D0-
NC
F
10
11
12
13
14
15
16
17
18
19
1
2
3
4
5
6
7
8
9
D E
DV-696AV-S 17
7 8
5
6
1
2
3
4
3.4 DVD MT PCB ASSY (1/7)
A
A 1/7 DVD MT PCB ASSY (A2J003A130)
MPEG / MICON / RF-AMP BLOCK
25V 10 KA C4048 XO 7P CH V+3 FROM/TO LOADER/MOTOR DRIVE A B (RF) C D E F MDI1 LDO1 LDO2 V1P4 DMSO FMSO TRCLOSE TROPEN TRSO FOSO OPO OP+ OPTROUT TRIN STBY V20 LIMIT IOA RF D_GND W881 X4001 R4022 V1P4 0.1 B C4036 0.1 B 0.1 B C4039 0.47 B C4034 22P CH C4035 100K C4037 1 B C4041 0.1 B C4043
3
ASPDIF 10 PWDN# 7P CH R4030 C4049 R4027 C4050100 C4051 0.1 0.1 FP_DI FP_SCK R4035 33 B TP4035 B
100GT02720 27MHz
C4033 0.001 15K 0.1 B C4028 0.1 B C4029 0.1 B B C4031 0.033 B 0.1 B
C4046
V+3RF
0.1 B C4045
C4047 R4025 390P CH 100K R4024 750K
A 3/7
C4026
B
0.047 B C4044
R4020 C4027
C4032
D A B C RF
(D) (A) (B) (C) (RF)
C4014 C4015 C4016 C4017 C4103
1 1 1 1 1
B B B B B
(D) (A) (B) (C) (RF)
C
FROM/TO MEMORY MA0 MA1 MA2 MA3 MA4 MA5 MA6 MA7 MA8 MA9 MA10 MA11 SDCKE SDCLK DBA0 DBA1 DCS# DRAS# DCAS# DWE# DQM0 DQM1 DQ0 DQ1 DQ2 DQ3 DQ4 DQ5 DQ6 DQ7 DQ8 DQ9 DQ10 DQ11 DQ12 DQ13 DQ14 DQ15 A0 A1 A2 A3 A4 A5 A6 A7 A8 A9 A10 A11 A12 A13 A14 A15 A16 A17 A18 A19 A20 AD0 AD1 AD2 AD3 AD4 AD5 AD6 AD7 PWR# PCE# PRD# D_GND
E (E) F (F) MDI1 LDO2 LDO1 C4005 V20 V1P4 0.1 B C4007 0.1 B
OPO OPOP+ DMSO FMSO TROPEN TRSO FOSO V1P4
D
C4001 0.0022 B C4002 C4003 470P CH 470P CH
ADIN TROUT TRIN STBY TRCLOSE A2 A3 A4 A5 A6 A7 A8 A18 A19 SDA SCL V+3 (V+3D)
E
7
TP4107 EEPROM IC4001 BR24L08FJ-WE2 0.0 3.3 VCC NC 0.0 3.3
TP4108 3.3V 3.3
1.8V C4024 0.0015 B
AGND DVDA DVDB DVDC DVDD 253 DVDRF[P 254 DVDRF[N MA 255 MB 256 MC MD SA SB SC SD CDFON CDFOP TNI TPI MDI1 MDI2 LDO2 LDO1 SVDD3 CSO/RFOP RFLVL/RFON SGND V2REFO V20 VFEFO FEO TEO TEZISLV OP_OUT OP_INN OP_INP DMO FMO TROPENPWM PWMOUT1/V_ADIN9 TRO FOO USB_VSS USBP USBM USB_VDD3 FG/V_ADIN8 (PU) TDI/V_ADIN4 (JTAG) TMS/V_ADIN5 (JTAG) TCK/V_ADIN6 (JTAG) TDO/V_ADIN7 (JTAG) DVDD18 IOA2 (PU) IOA3 (PU) IOA4 (PU) IOA5 (PU) IOA6 (PU) IOA7 (PU) HIGHA0 (PU) IOA18 (PU) IOA19 (PU) DVSS APLLCAP APLLVSS 65 66 67 68 69 70 71 72 73 TP4015 TP4016 TP4017 TP4018 TP4019
64 63 62 61 60 59 58 57 56 55 54 53 52 51 50 49 48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
0.0022 B R4003
0.015 B
C4008
0.1 B
C4009
R4005
680K C4105
10K
R4008
R4006
10K
A 2/7
10K
TP4020 TP4021
TP4022 TP4023 TP4024 TP4025
TP4026 TP4027 TP4028 TP4029 TP4030 TP4031 TP4032 AD4 AD5 AD6 AD7 A17 A0
8
7 WP
6 SCL
5 SDA C4022
EEPROM
GND NC NC 2 0.0 0.0 3 0.0 4
0.1
6.3V 220 YK
C4023
C4025
B
C4030
TP4109
IOWR#
PWR# A16 A15 A14 A13 A12 A11 IOCE# A10 A9 A20 PCE# A1 PRD#
0.1
1
0.1
B
AD0 AD1 AD2 AD3
B4010 MMZ1608R102CT
TP4014
A 1/7
18
1 2
NOTE:THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE
DV-696AV-S
3 4
TP4103
F
TP4033 UWR# URD# TP4034
8
B
3.3 3.3 2.9 1.0 2.5 1.2 1.4 1.4 3.3 1.2 1.0 0.0 0.0 2.1 0.0 3.3 1.3 1.4 1.3 0.0 0.0 1.6 1.7 1.7 0.0 0.0 1.7 0.0 1.9 0.0 3.3 3.3 1.8 3.2 2.8
HIGHA6 (PU) HIGHA5 (PU) HIGHA4 (PU) HIGHA3 (PU) DVDD3 HIGHA2 (PU) HIGHA1 (PU) IOA20 XIOCS (PU) IOA1 (PU) XIOOE DVDD3 AD0 AD1 AD2 AD3 DVSS (18) AD4 AD5 AD6 IOA21/V_ADIN0 ALE (PU) AD7 A17 IOA0 (PU) DVSS (3) XUWR (PU) XURD (PU) DVDD18 UP1_2 (PU) UP1_3 (PU)
OSP CEQN CEQP RFGND CRTPLP HRFZC RFRPAC RFRPDC RFVDD3 S_VREFN S_VREFP ADCVSS S_VCM ADCVDD3 LPFOP LPFIN LPFIP LPFON PLLVDD3 IDACEXLP PLLVSS JITFN JITFO XTALI XTALO RFVDD18 RFGND18 SPDIF MC_DATA (PD) (3) DVSS (PD) ASDATA4 OSN RFGC IREF AVDD3
B
0.0 1.2 2.1 0.9 0.8 1.6 0.0 NC 2.1 2.1 2.1 2.1 0.0 NC 0.0 NC 0.0 NC 0.0 NC 0.0 NC 0.0 NC (E) 2.1 (F) 2.0 0.0 0.0 2.5 3.3 C4013 0.1 B 3.3 TP4010 2.3 CS TP4011 2.1 RFLV 0.0 C4019 0.1 B 2.8 2.0 1.4 C4020 TP4012 1.3 FE TP4013 1.3 0.1 B TE 1.3 2.5 1.7 1.5 R4015 10K 2.0 R4016 15K 1.3 0.0 R4017 22K 1.4 R4018 12K 1.4 R4019 12K 1.5 0.0 0.0 NC 0.0 NC C4012 3.3 2.5 0.1 B 3.3 0.0 3.3 R4002 10K 0.0 C4021 0.1 B 1.8 TP4001 2.2 TP4002 2.1 TP4003 1.9 TP4004 2.2 TP4005 2.0 TP4006 2.0 TP4007 1.9 TP4008 0.2 TP4009 0.0 0.0 1.6 R4004 10K 0.0 R4014 10K
3.3 1.0 1.2 1.5 0.0 0.0 0.0 0.0 2.0 1.5 1.4 1.4 3.3 0.0 0.0 0.0 0.0 3.3 1.4 1.6 1.6 1.8 3.3 0.0 0.0 1.1 1.1 1.0 0.7 1.8 0.0 1.7 3.3 0.0 1.2
256255 254 253 252251 250 249 248 247 246245 244 243242 241 240 239 238 237 236 235 234 233 232 231 230 229 228 227 226 225 224 223 222
0.047 B
C4040
C4042
0.1
1
B
1
MPEG/MICON IC4002 MT1389EXE/B2-L
65 APLLVDD3 66 XIOWR 67 A16 68 HIGHA7 (PU)
74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99
5
6
7
8
A
4
TP4039 ACLK TP4041 ABCK TP4043 ALRCK TP4036ASDAT2 TP4037ASDAT1 TP4038ASDAT0 IOA XMMUTE XAMUTE HSYNC SCK VSYNC CVBS S_C R/CR B/CB V+3A W804 G/Y S_Y TP4060 TP4066 TP4061 TP4067 TP4062 TP4068 R4064 R4065 R4066 R4067 R4068 R4069 150 +-1% 150 +-1% 150 +-1% 150 +-1% 150 +-1% 150 +-1%
(R/CR) (B/CB)
TO VIDEO VSEL1 LETTER SQUEEZE I/XP R/CR B/CB G/Y CVBS S_C S_Y D_GND TO AUDIO/JACK
TP4046 TP4065 TP4049 TP4089
R4038 33 R4040 33 R4043 33
R4046 10
R4047 33 R4050 33
V+3V
(G/Y)
(R/CR) (B/CB) (G/Y)
SD TP4050 W806 TP4047 DAC_XCS0
A 5/7
C4053
NC 0.1 B
10K 10K 10K
R405410K
R4052
0.1 B
C4060
C4061 0.1 B
R4057 R4053 R4048
C4063 0.1 B
10K
1.8 0.0 0.0 0.0 1.3 0.0 1.6 1.7 1.7 3.3 0.0 0.0 3.3 3.3 3.3 3.3 0.0 3.3 0.0 0.0 0.0 0.0 3.3 1.0 0.0 1.0 3.3 1.0 0.0
R4061 2.3 1.4 1.4 3.3 0.0 0.0 0.0 0.0 0.0 0.0 3.3 0.0 0.0 3.3 3.3 3.3 0.0 0.0 0.0 1.8 0.0 0.0 3.3 0.0 3.3 3.3 1.6 1.4 1.6 0.0 1.5 0.0 0.0 0.0 0.0 2.0 1.8 3.3 0.0 0.0 1.8 1.9 2.0 2.0 0.0 0.7 0.0 1.6 0.0 1.7 3.3 3.1 2.7 3.1 2.6 1.9 3.3 1.3 0.0 1.4 1.4 1.6 1.1 1.3 2.7K +-1% R4062 15K NC C4066 1 NC B
DVDD18 (PD) ASDATA3 (PD) ASDATA2 (PD) ASDATA1 (PD) ASDATA0 (18) DVSS ACLK ABCK (PD) ALRCK DVDD3 SPBCK/ASDATA5 SPLRCK SPDATA SPMCLK HSYNC/V_ADIN2 YUV7/ASDATA5 VSYNC/V_ADIN1 DVDD3 YUV6/R YUV5/B DACVSSA YUV4/G DACVDDA YUV3/CVBS DACVSSB YUV2/C DACVDDB YUV1/Y DACVSSC
221 220 219 218 217 216 215 214 213 212 211 210 209 208 207 206 205 204 203 202 201 200 199 198 197 196 195 194 193 129130131132133134135136137138139140141142143144145146147148149150151152153154155156157158159160161162163164165166167168169170171172173174175176177178179180181182183184185186187188189190191192
W805
B
C4117 100P CH VSEL1 LETTER SQUEEZE I/XP C4110 100P CH B
192 YUV0/CIN 191 FS 190 VREF 189 DACVDDC
(RF)
: RF SIGNAL ROUTE : VIDEO SIGNAL ROUTE
(SY)
: S VIDEO SIGNAL ROUTE (Y)
(SC)
: S VIDEO SIGNAL ROUTE (C)
(R/CR)
: VIDEO SIGNAL ROUTE (R/CR)
(G/Y)
: VIDEO SIGNAL ROUTE (G/Y)
(B/CB)
: VIDEO SIGNAL ROUTE (B/CB)
(D)
: AUDIO DATA SIGNAL ROUTE
(DA)
: AUDIO SIGNAL ROUTE (Digital)
125 RD0 126 RD15 127 DVDD3 128 RD14
FP_DO IR R4007 100 C4114 1 B V+3E
TP4098 TP4099
220P CH 3.3V 1.8V
100 101102103104105106107108109110111112113114115116117118119120121122123124125126127128
C4104 IC4003 BD5229G-TR 0.0082 B RESET IC 1.8 5 CT 0 NC 4 NC
DO(F to M) IR V+3E DGND DGND FLDC+ -28V FLDC-
4 5 6 7 8 9 10 11
2.7 3.0 3.3 3.3 3.3 0.0 3.3 3.3 3.3 TP4044 1.0 3.3 3.3 3.3 TP4106 1.9 0.0 TP4048 NC1.2 0.0 TP4051 1.1 TP4052 1.2 0.0 TP4053 1.4 TP4054 1.4 1.8 TP4055 1.0 TP4056 1.3 TP4057 0.0 TP4058 1.5 3.3 TP4059 1.4
V_OUT
FLDC+ VDD VSS -28V FLDC-
TP4100 TP4101 TP4102
TP4045
HDMI_SCL NR4001 HDMI_SDA 4D03WGJ0330T5E RXD TXD C4055
B
B
1 3.3
C4062
C4064
0.1
0.1
0.1
2 3 0 3.3 R4084 C4091 TP4094 1K 0.1 B
B
DQM0
DQ2 DQ1 DQ0 DQ15
DQ7
DQ6 DQ5
R4051 IR
DQ4 DQ3
33 V+3D V+1R8 V+3
DQ14
W846
RESET TP4110 RESET
B CP601
F
(PD) RD16 (PD) RD17 (PD) RD18 (PD) RD19 (PD) RD20 (PD) RD21 DVDD3 RD22 RD23 (PD) DQM2 (PD) DQM3 RD24 RD25 (3) DVSS RD26 DVDD18 RD27 RD28 RD29 (PU) RD30 (PU) RD31/ASDATA5 DVDD3 RA4 RA5 RA6 (18) DVSS RA7 (3)DVSS RA8 RA9 RA11 CKE RCLK DVDD3 RCLKB RVREF/V_ADIN3 DVDD18 RA3 RA2 RA1 (3) DVSS RA0 RA10 BA1 (18) DVSS BA0 XRCS DVDD3 XRAS XCAS XRWE DQM1 DQS1 RD8 (3) DVSS RD9 RD10 RD11 RD12 RD13
C4067 0.1 B
C4071 NC 0.1
SD SCK DAC_XCS0 XAMUTE XMMUTE ALRCK ABCK ACLK ASDAT0 ASDAT1 ASDAT2 ASPDIF D_GND
A 4/7
TP4063
R4032
33
92_VCK 92_Y0 92_Y1 92_Y2 92_Y3
NR4005
TO HDMI 92_Y0 92_Y1 92_Y2 92_Y3 92_Y4 92_Y5 92_Y6 92_Y7 92_VCK HDMI_SCL HDMI_SDA XO URST# HSYNC VSYNC
C4069 100P CH 4D03WGJ0220T5E NR4006
C
92_Y4 92_Y5 92_Y6 92_Y7 MA4 MA5 MA6 MA7 MA8 MA9 MA11 SDCKE SDCLK
C4068 0.1 B
4D03WGJ0220T5E TP4069 TP4070 TP4071 TP4072 TP4073 TP4074 TP4075
A 6/7
FROM/TO POWER PORT PWDN# V+1R8 V+3 V+3E V+3A FLDCFLDC+ -28V D_GND
C4072 0.1 B NC C4073 NC 0.1 B
R4082 R4083
33 100
2
TP4076 TP4077 TP4078 TP4079 TP4080 TP4081 TP4082 MA3 MA2 MA1 MA0 MA10 DBA1 DBA0
A 7/7
D
R4070 R4071
33 33
V+3 (V+3D) RXD TXD D_GND C4079 C4078 C4077 C4076 100P CH 33P CH 100P CH 33P CH
TP4104 TP4040 TP4042 TP4105
TP4083 TP4084 TP4085 TP4086 DQS1 NR4002 R4060 4D03WGJ0330T5E TP4087 33 TP4088
DCS# DRAS# DCAS# DWE# LIMIT DQM1 DQ8 DQ9 DQ10 DQ11 DQ12 DQ13
FROM/TO DISRLAY
6
TP4095 TP4096 TP4097
FP_SCK FP_DI STB
UP1_4 (PU) UP1_5 (PU) UP1_6 (PU) UP1_7 (PU) UP3_0 (PU) UP3_1 (PU) UP3_4 (PU) PU3_5 (PU) DVDD3 ICE (PD) PRST# (PU) IR INT0# (PU) DQM0 DQS0 RD7 DVSS (18) RD6 RD5 DVSS (3) RD4 RD3 DVDD18 RD2 RD1
CP4002 (CP601) 00_6232_011_006_800+ CLK 1 DI(M to F) STB 2 3
E
STB FP_DO SCL SDA
C4054
NOTE:THE DC VOLTAGE EACH PART WAS MEASURED WITH THE DIGITAL TESTER DURING PLAYBACK.
A 1/7
19
8
DV-696AV-S
5 6 7
1
2
3
4
3.5 DVD MT PCB ASSY(2/7)
A
A 2/7 DVD MT PCB ASSY (A2J003A130)
MEMORY BLOCK
B
A 1/7
C
D
A 1/7
E
A 7/7
F
A 2/7
20
1 2
DV-696AV-S
3 4
5
6
7
8
A
16Mbit FLASH IC
S29AL016D70TFI020
B
C
D
E
F
NOTE :THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE NOTE : THE DC VOLTAGE EACH PART WAS MEASURED WITH THE DIGITAL TESTER DURING PLAYBACK.
A 2/7
21
8
DV-696AV-S
5 6 7
1
2
3
4
3.6 DVD MT PCB ASSY(3/7)
A
A 3/7 DVD PCB ASSY (A2J003A130)
LOADER/MOTOR DRIVE BLOCK
V+5S C2303 0.1 PICK-UP(GOLD) B V+5S IOA 10K W864 W865 TRSO LOADING 10K +-1% R2312 TRACK 1.4 40 VIN439 NC 1.4 38 VIN4 2.6 TVD4+ 7 5 0.1 0.8 C2313 LOAD+ LOAD0.01 B VLD+ VLD6 10K +-1% R2313 0.0022 B C2322 R2342 680K 0.0 44 S-GND 4.0 43 VCONT 3.3 42 MUTE1 3.3 41 MUTE234 1B R2329 MOT_SPDL+ R2338 10K MOT_SPDLNC 4 V+3F VCC2 FWD REV 1 MOTOR DRIVER IC2301 LA6565VR-TLM-E R2319 R2331 150K 150K
CP2301
1 2 3 4 5 6 7
C2301 0.1 B TP2304 TP2305 JG002 JG003 JG004 JG005 JG006 JG007
LD07T2-24ND-03 GND F VS VCC E D C SW1(DVD/CD) VRF(RF_OUT) B A VR650(DVD) VRCOM VR780(CD) GND LD_CD(780) PD/GND LD_DVD(650) GND NC TRKG DRV TRKG RTN FOCS DRV FOCS RTN NC TP2303
JG001 (F)
(F)
F V20 E D C IOA RF B A MDI1 0.2 D G VCR_CTL Q2307 0.0 D 2SK3018T106 S 0.0 G VCR_CTL 4.9 Q2306 2SK3018T106 S 0.0
(E) (D) (C) (RF) (B) (A)
TP2306 (E) TP2307 (D) TP2308 (C) TP2309 TP2302 (RF) TP2310 (B) TP2311 (A) TP2312 TP2313 TP2314 TP2315
0.0
R2307 100K 5.0 0.0 R2309 VCR_CTL Q2301 10K KTC3875S_Y_RTK 0.0 R2306 100K
To PICKUP
B
8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24
C2302 0.1 B TP2316 TP2317 TP2318 TP2319 T+ TF+ F-
C
CD2302
CP2302
R2311 5 4 3 2 1 LOADLOAD+ OPEN GND CLOSE R2341 10K R2343 10K TP2323 TRIN TP2321 TP2322 LOAD+ TROUT V+6A R2310 2.7K R2337 5.6K V+3F C2323 0.1 SLED/SPINDLE B OPO TP2329 TP2320 LOAD10K 3 5.9 00_6232_005_006_800+
D
E
CD2301
CP2303
00_6232_006_006_800+ 6 5 4 3 2 1 SW(GND) LIMIT SW SLDSLD+ SPDSPD+ TP2324 TP2325 TP2326 TP2327 TP2328 LIMIT MOT_SLEDMOT_SLED+
OPOP+
E
0.0
D
MOTOR DRIVER
1 0.0
2
C2314
A 3/7
22
1 2
DV-696AV-S
3 4
TROPEN
TRCLOSE
F
C2312
1B
R2308
5
6
7
8
NOTE : THE DC VOLTAGE EACH PART WAS MEASURED WITH THE DIGITAL TESTER DURING PLAYBACK.
NOTE : THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE
(RF)
: RF SIGNAL ROUTE
A
FROM/TO MPEG/MICON/DSP
RF33 CD JG008 TP2341 R2320 10V 100 YK R2322 4.7 4.7 C2320 W807 JG010 TP2332 V+3F
(A) (B) (C) (D) (E) (F)
LD DRIV for CD Q2302 KTA1504S_Y_RTK
3.3 3.3 0
LD DRIV for CD Q2304 KTA1504S_Y_RTK
3.3 3.3 0
LDO1
JG009
DVD R2321 R2323 TP2342 10V 100 YK 4.7
4.7
3.1 2.5 LD DRIV for DVD Q2303 KTA1504S_Y_RTK 2.0
LD DRIV for DVD Q2305 KTA1504S_Y_RTK
3.1 2.5 2.0
C2321
V20 A B C D E F MDI1 LDO2 LDO1 IOA V1P4 LIMIT TROUT TRIN STBY DMSO FMSO TRCLOSE TROPEN TRSO FOSO OPO OP+ OPRF
B
A 1/7
LDO2
(RF)
C
FROM POWER PORT V+3F V+5S V+6A D_GND FOCUS M_GND C2305 0.1 B
FOSO
A 7/7
TP2330
TP2333 STBY R2325 10K +-1% TP2334 DMSO SPINDLE
R2317
10K +-1%
15K +-1%
R2318
VC2
TP2339 10K+-1% R2316 R2326 4.7K R2327
V1P4
D
NC
NC
NC
NC
NC
1.4 37 VREF-IN
0.0 34 NC
NC
1.4 29 VIN3
1.4 28 VIN327 NC
1.1 26 VIN2
1.4 25 VIN2-
1.4 24 VIN2+ 23 NC
36 VREF-OUT
35 REG-OUT
33 REG-IN
32 VIN+OP
31 VIN-OP
30 VO_OP
VIN1+A
PGND2
PGND1
VIN1-A
VCCS
VCC1
VD3+
VD2+
VD1+
VIN 1
VD4-
VD3-
VD2-
VD1-
NC
4.7K
8 2.5 2.5
9
10 2.6
11 0.0
12 0.0
13 1.4
14 3.9
15 2.5
16 2.7
17
18 5.9
19 5.9
20 1.4
21 1.4
22 1.4
E
C2306 10V 100 YK
R2335
R2334
2.2
2.2
0.1 B
0.01 B
0.01 B
C2311
C2310
18
R2332 R2333 1.2 1.2
10K+-1%
C2309
C2308
B
C2307
0.1
R2328
1B
R2330 10K+-1%
TP2336
FMSO SLED
TP2337
MOT_SPDL+
MOT_SLED+
MOT_SPDL-
MOT_SLED-
TP2338
F
T+
F+
F-
A 3/7
DV-696AV-S
5 6 7 8
23
1
2
3
4
3.7 DVD MT PCB ASSY(4/7)
A
A 4/7 DVD MT PCB ASSY (A2J003A130)
AUDIO JACK BLOCK
FROM/TO MPEG/MICON/RF-AMP XAMUTE XMMUTE SD SCK DAC_XCS0 ABCK ALRCK ACLK ASPDIF ASDAT0 ASDAT1 ASDAT2 V+12AT MUTE CTL Q8014 KTA1504S_Y_RTK 1.6 1.5 R8026 XMMUTE R8022 2.2K 3.2 0 C8019 0 0.1 B 0 MUTE CTL Q8004 KRC407-RTK/P 0 0 5.6K 1.6 MUTE CTL 0.9 Q8009 KRC407-RTK/P R8029 4.7K R8034 270K R8035 10K +-1%
A 1/7
(DA) (D) (D) (D)
R8004 33
TP8001 TP8002
CP8001 (CP8102) A2001WV2-2P
SD
F 2/2
SPDIF GND
1 2
SCK DAC_XCS0 ACLK1 1.6 3.2 3.2 3.2 NC 0 0
C8035 10V 100 YK
PCMMCK CS
ZERORZEROA
FROM POWER PORT
AUDIO DAC (C,Lfe)
B
16 15 14 13 12 11 10 9 VCOM AUDIO DAC (C,Lfe) IC8004 PCM1742KEG/2K ZEROL/MA GND_A SCK SI
PCMDATA
PCMLRCK
PCMBCK
VOUTR
VOUTL
GNDD
V+3A V+12 V+12AT V+5A D_GND
A 7/7
2.4
VDD
VCC
R8037 270K C8033 10V 100 YK R8036 10K +-1%
1 1.5
2 0
3 1.6
4 0
5 3.3
6 4.8
7 2.4
8 2.4
(D)
: AUDIO DATA SIGNAL ROUTE
(DA)
6.3V 220 YK
C8037
C8014
: AUDIO SIGNAL ROUTE (Digital) : AUDIO SIGNAL ROUTE (L ch)
C8031
B
ABCK1 ASDAT2 ALRCK V+5A V+3A3
(D)
C8026 330P CH
MUTE CTL Q8010 KTA1504S_Y_RTK
0.1 B
C
V+3A R8005
P.CON+3.3V Q8001 2SA1036K 3.3 2.7 3.3
TP8003 R8008
10K
1.6
3.2
3.2
3.2
2.4
C8002
AUDIO DAC (Ls,Rs) IC8005 PCM1742KEG/2K
R8007 10 R8006
PCMMCK CS
ZEROL/MA
SCK
ZERORZEROA
VCOM
R8009
GND_A
1
SI
V+3A2
16 15 14 13 12 11 10 9
AUDIO DAC (Ls,Rs)
B
4.7K
0 0
NC
R8027
10
V+12AT XMMUTE SD SCK DAC_XCS0 V+3A3 ACLK1
R8024 R8019 2.2K
5.6K 1.6 1.5 0.9 MUTE CTL Q8006 KRC407-RTK/P 1.6
C8020
0.1 B
0 0 3.2 MUTE CTL 0 Q8002 0 KRC407-RTK/P
0
0.1
1K
R8031 10K +-1% R8030 270K
TO VIDEO
PCMDATA
22K
A 5/7
VDD
AUDIO_R GND
0
0
MUTE CTL Q8020 KRC407-RTK/P
1 1.5
2
3 1.6
4
5 3.3
VCC
0
GNDD
AUDIO_L
6 4.8
7 2.4
VOUTR
VOUTL
8.2K
PCMBCK
R8012
(DA)
PCMLRCK
V+5A
R8011 3.0
0
V+3A1
10
8 2.4
D
ABCK W878 W879
6.3V 220 YK C8034
ABCK1 ASDAT1 ALRCK V+5A ABCK1 V+3A2 ABCK0
C8032 10V 100 YK C8038 10V 100 YK B MUTE CTL Q8013 KTA1504S_Y_RTK 0 0
R8032 270K R8033 10K +-1%
(D)
C8015
0.1 B
C8028
C8023 330P CH
V+12AT V+12 XAMUTE TP8011 INVERTER 1 B IC8001 TC7SHU04FU(TE85L_F R8017 10 R8018 SD C8016 25V10 KA ACLK1 ACLK0 0 3.1 3.1 1.6 0 SCK DAC_XCS0
R8038 6.8K R8023
0.1
R8020 2.2K 0
0 2.6 2.6
6.8K
R8028
3.3 5 VCC
1.6
0
MUTE CTL Q8003 KRC407-RTK/P
4.7K
MUTE CTL 0 Q8007 KRC407-RTK/P 0
D8006 R8003 1SS355 100 D8005 R8002 1SS355 100 D8004 R8001 1SS355 100 VREF_C
INVERTER
4
C8004
0
AUDIO DAC (L,R) IC8003 PCM1742KEG/2K
AUDIO DAC (L,R)
16 15 14 13 12 11 10 9 ZEROL/MA ZERORZEROA PCMMCK GND_A CS SCK SI VCOM
E
GND 1 0 NC 1.5 2 0 3
0
NC
2.4
10
12.5 REF GEN Q8008 6.3 KTC3875S_Y_RTK 5.8 12.5 REF CTL Q8005 KTC3875S_Y_RTK 12.5 6.3 W801 R8021 2.2K 6.8 UDZS6.8B R8025 680K C8039 6.3 5.8 12.5 6.3 5.8 1 B
PCMDATA
PCMLRCK
PCMBCK
ACLK
B8001 MMZ1608R102CT
1 1.5
2 1.5
3 1.6
4 0
5 3.3
6 4.9
7 2.5
VOUTR
VOUTL
REF GEN Q8011 KTC3875S_Y_RTK VREF_S
GNDD
VDD
VCC
8 2.4 C8027
16V 47 YK C8030 1 B
REF GEN Q8012 KTC3875S_Y_RTK VREF_F
ABCK0 ASDAT0 ALRCK V+5A V+3A1 C8017 1 B
(D)
D8003
6.3V 1000 YK
C8013 0.001 B
C8036
F
C8025 330P CH
A 4/7
24
1
NOTE:THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE.
W866
DV-696AV-S
2 3 4
C8029
0.1 B
R8049
5
6
7
8
A
V+12
R8045 100P CH 18K +-1% C8053
C8061 16V 47 YK
R8046 10K +-1% 560P CH C8042 AUDIO LPF& IC8006 RC4580IDR +VS + 8
10
R8072 5.7 220 R8068 22K 5.7 5.7 0 0 R8067 22K R8073 0.6 1K 0 C8060 16V 47 YK R8071 220 +-1% R8094 220 +-1% MUTE SW Q8016 KTC2875-B +-1% 0 R8074 1K 0 0.6 MUTE SW Q8015 KTC2875-B 220 +-1% 330P CH C8009 R8092
12.2 5.7
B
TP8012
10V 100 YK
560P CH
680K C8049
C8043
1 B C8048
C8063
0.1 B
+
5.7 5.7 6
7
-VS
5
R8053 10K +-1% 100P CH C8059
330P CH
C8010
AUDIO LPF&
4
3
2
1
11
TP8013
R8050 18K +-1% R8048 C8056 18K +-1% R8052 560P CH 10K+-1% C8044
100P CH
C
8
12.2 5.7 7 AUDIO LPF& IC8007 RC4580IDR +VS + 8 1 5.7 C8065 16V 47 YK R8076 220 +-1% R8093 220 +-1% CH TP8014
22K
2
5.7 5.7 0
R8069
10V 100 YK
R8054
C8047
+
5.7 C8064 0.1 B 5.7 6
1K 0
C8052
1 B
-VS
5
4
3
MUTE SW Q8017 KTC2875-B
680K
560P CH
R8070
C8045
1K 0 R8078 220 +-1%
C8008
AUDIO LPF&
22K
R8079 0.6
MUTE SW Q8018 KTC2875-B
330P CH
0
330P
R8077
0.6
C8007
0
R8058 C8057 10K+-1% 100P CH
C8066 16V 47 YK
R8095 220 +-1%
TP8015
D
R8055 18K +-1% R8059 C8062 18K +-1% C8041 R8043 R8061 10K +-1% 12.2 5.7 10V 100 YK 16V 47 YK 560P CH C8046 0.1 B C8068 C8050 5.7 5.7 AUDIO LPF& IC8008 RC4580IDR +VS + 8 1 5.7 5.7 5.7 0 330P CH 0 R8066 22K MUTE SW Q8023 KTC2875-B C8069 16V 47 YK R8075 22K R8087 220 +-1% -0.7 R8088 1K 0 0 MUTE SW Q8021 KTC2875-B 330P CH C8005 R8096 220 +-1% 100P CH
9
10V 100 YK 10K +-1% R8042 270K
6
TP8017
7
2
R8065
680K
C8054
C8067
1 B
6
-VS
5
4
3
E
+
AUDIO LPF&
560P CH C8058
R8090 1K
0 -0.7
R8081 220 +-1%
R8099 220 +-1%
C8006
C8051
CENTER SR C 6
TP8019 SR SL
16V 47 YK
C8040 10V 100 YK
R8041 10K +-1% R8040 270K
R8063 10K +-1% 100P CH C8055
7
L 3 2 1 R
H2 H1
SL 3 2 1
LFE LFE 5
E
H2 H1 H2 H1
R8064 18K +-1%
CAUTION: DIGITAL TRANSISTOR
L/R J8001 RCA-207B-02
E
E
4
F
LS/RS/C/LFE J8002 RCA-405A-06
NOTE:THE DC VOLTAGE EACH PART WAS MEASURED WITH THE DIGITAL TESTER DURING PLAYBACK.
A 4/7
25
DV-696AV-S
5 6 7 8
1
2
3
4
3.8 DVD MT PCB ASSY(5/7)
A
A 5/7 DVD PCB ASSY (A2J003A130)
VIDEO JACK BLOCK
VIDEO DRIVER 6CH IC IC7301 LA73054
VCC1 CVBS in SQ LE MUTE1 (ON=H,OFF=L) C in GND11 Y1 in YC-MIX (MIX=H,OFF=L) IN SW (RGB=H,YUV=L) Y2 in MUTE2 (ON=H,OFF=L) LPF (P=H,I=L) CB in AMP2 (9dB=H,6dB=L) CR in GND12 REG AMP1 (9dB=H,6dB=L) DRIVE1 (1D=H,2D=L) VCC21 CVBS out GND21 C out C-DC out GND22 Y1 out GND23 GND24 Y2 out VCC22 CB out GND25 CR out GND26 DRIVE2 (1D=H,2D=L) 36 35 1 5 C7305 1 SQUEEZE B 3 0 0 0 FROM AUDIO/JACK C7304 2.8 B 0 0 C7302 0.1 B 33 31 32 4 LETTER 2.9 0
2
CVBS
2.7
B
A 4/7
6
S_C AUDIO_L AUDIO_R
5
34
5
(SC)
0.1
(SC)
30 7 0 0 0 2
(SC)
W877
FROM/TO MPEG/MICON/RF-AMP S_Y SQUEEZE VSEL1 LETTER CVBS S_C S_Y G/Y B/CB (B/CB) R/CR I/XP
C7306 1 B
(SY)
28 9 0
29
8
2.7
10
(SC) (G/Y) (R/CR)
G/Y C7307 1 B 2.6
27
A 1/7
C
(SY)
0 0
VSEL1
0
11
(GY)
12 25 0 5 2
26
(GY)
5 C7317 0.1 B
13
14
1 B C7309 R7315 1K 1 B
(B/CB)
15 22 0 0
23
B/CB
C7308
2.8
24
(B/CB)
ASP TP7301
R/CR
16
(R/CR)
0
21
2.8 0 C7312 10V 100 YK 1.2
17
20
0 0
(R/CR)
18
I/XP
FROM POWER PORT
P-H/I-L W825
P-H/I-L Q7302 KRC407-RTK/P V+5V
0
C7313 0.1 10V 100 YK B +5V TP7302 C7319 GND TP7303
D
A 7/7
V+6A V+5 D_GND
19
3.4
W899
: VIDEO SIGNAL ROUTE
(SY)
: S VIDEO SIGNAL ROUTE (Y )
(SC)
: S VIDEO SIGNAL ROUTE (C)
(R/CR)
W891
: VIDEO SIGNAL ROUTE (R/CR )
E
(G/Y)
: VIDEO SIGNAL ROUTE (G/Y )
(B/CB)
: VIDEO SIGNAL ROUTE (B/CB )
(D)
: AUDIO DATA SIGNAL ROUTE
(DA)
W892
: AUDIO SIGNAL ROUTE (Digital) : AUDIO SIGNAL ROUTE (L ch)
F
A 5/7
26
1 2
DV-696AV-S
3 4
5
6
7
8
NOTE : THE DC VOLTAGE EACH PART WAS MEASURED WITH THE DIGITAL TESTER DURING PLAYBACK.
NOTE : THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE
CAUTION: DIGITAL TRANSISTOR
A
SQUEEZE
MMZ1608R102CT VSEL1
AUDIO_R MMZ1608R102CT
B7301
AUDIO_L
FROM/TO POWER VIDEO/AUDIO for 21PIN
B7302
CP7301 (G/Y)
(CP503)
21PIN-G/D-Y 21PIN-B/D-U
IMSA-9604S-12C 1 G GND B GND R RGB-H FS CVBS GND AUDIO L 2 3 4 5 6 7 8 9 10 11 12
B
(B/CB)
21PIN-R/D-V
(G/Y)
(R/CR)
P-H/I-L_RGB-H ASP/FS
(B/CB)
GND AUDIO R
(R/CR)
E 1/2
CP503
C
ASP S_Y_OUT S_C_OUT
(SY)
(SC)
CVBS_OUT
R7301 4CH BUS SW IC IC7302 SN74CBT3257PWR 16 1 0 S 1B1 1B2 1A 2B1 2B2 2A 0.001 B C7322 VCC /OE 4B1 4B2 4A 3B1 3B2 3A 5.8 0
10K
D
6.3V 470 YK C7315 MMZ1608R102CT 6.3V 470 YK C7316 6.3V 1000 YK C7318 W895 C7314 6.3V 1000 YK 6.3V 470 YK 75 +-1% 0.1 B
C7330
15
2
0 2 0
0 NC 0 NC 0 NC 0
MMZ1608R102CT B7305
14
3
75 +-1%
R7317
R7321
(GY)
5 0 2.5 2.5
B7304
12
R7320
11
6
R7319
10
7
(B/CB)
8 9 0 GND 2.5
75 +-1% R7304
2.5
R7303
1.2K
75 +-1%
75 +-1%
R7305
1.2K
1.2K
R7316
13
4
C7329
15
(R/CR)
CVBS
75 +-1%
R7302
E
17 12
U V Y 3
H2 H1 H2 H1
16
C 4 2 6 3 1 5 Y
14
CVBS/Y/U/V J7302 RCA-405A-08
E
13
S-VIDEO OUT J7301 DIN-409A
2 1
6
5
E
4
VSEL1
V+6A
F
A 5/7
DV-696AV-S
5 6 7 8
27
1
2
3
4
3.9 DVD MT PCB ASSY(6/7)
A
A 6/7 DVD PCB ASSY (A2J003A130)
HDMI BLOCK
(92_DV33) FROM/TO MPEG/MICON/DSP ASDAT0 ASDAT1 ASDAT2 ALRCK ABCK TP5917 92_SDATA3 ACLK ASPDIF
W887
W886
D_GND
W850 W885 W888 W889 W890
A 1/7
V+3H DVDD18 V+5H
W851
NC
B
C5901 92_VCK 92_Y0 92_Y1 92_Y2 92_Y3 92_Y4 92_Y5 92_Y6 92_Y7 SCL SDA URST# PWDN# ASPDIF ACLK ABCK ALRCK ASDAT0 ASDAT1 ASDAT2 HDMI_SCL HDMI_SDA XO B5905 MMZ1608R102CT 92_VCK C5902 VCK 0.1 B TP5931 0.1 B DVDD18 1.8 1.8 1.8 1.2 0.0 0.0 69 AVSS TRAP1/GPO3 (PD) 32 0.0 NC
TRAP1 TP5923 TRAP0 TP5924
NC
1.2
3.0
3.3
80 DVDD18 1 0.0 NC 2.6 NC NC 0.0 0.0
79 ALRCK
78 ABCK
77 ACK
76 AD0
75 AD1
74 AD2
73 AD3
72 SPDIF
71 R
0.0
0
0
70 B
68 G 33 0.0 TRAP0/GPO4 (PD)
A 1/7
2
1 DVSS C1 (PD) C2 (PD) C3 (PD) C4 (PD) C5 (PD) C6 (PD) C7 (PD) DVDD33 VCK DVSS Y0 (PD) Y1 (PD) Y2 (PD) Y3 (PD) Y4 (PD) Y5 (PD) 3 2 C0 (PD)
NC 0.0 NC0.0 NC0.0 NC0.0 NC 0.0 3.4 1.5 0.0 92_Y0 92_Y1 92_Y2 92_Y3 1.0 1.0 1.0 1.0 1.5 1.7 1.0 1.1
C
7
6
5
4
HDMI TRANSMITTER IC5901 MT1392E/C-L
D
17
92_Y4 92_Y5 92_Y6 92_Y7
16
15
14
13
12
11
10
9
8
19 Y6 (PD) 20 Y7 (PD) A7/GPO0 (PD) A6/GPO1 (PD) /PWDN (PU) /RST (PD) TRAP2/GPO2 (PD)
19
18
DVD18
SSCK
21 3.2 SCL SDA
22 3.2
23 1.8
24 3.3
25 3.3
26 1.1
27 0.0 NC
28 0.0
DVSS
20
SSD
CLK
INT
29 0.0 NC
30 0.0 NC
31 0.0 NC
C5904
C5903
0.1
E
NO MOUNT(READY)
92_A7(I2C)
92_A6(I2C)
0.1
B
B
R5906 820 R5922 1K
10V 100 YK
C5908
R5923 100
0.001 B
C5905
TP5921
F
PWDN#
A 6/7
28
1 2
URST#
DV-696AV-S
3 4
XO
TP5920
TP5922
TRAP2
0.0
NC
5
6
7
8
A
6.3V 47 KA
C5925 W830 92DAC_AVDD3 W829 0.1 B W831 A_GND R5918 560 +-1% 92PLL_AVDD3 92_AVDD3
C5918 0.1 B
C5919
0.1 B C5916 C5915
C5917 0.1 B
0.1 B
0.0 FS_1392 0.0 VREF_1392 0.0
B
510 +-1% 3.3 R5916 60 59 2.9 0.0 TX2+ TX2C5914 0.1 B 3.3 TX1+ TX2+ TX1TX2AVSS TX0+ TX0AVDD TCK+ TCKAVSS AVSS AVDD AVDD 53 0.0 TX0+ 03 C5913 0.1 B 3.3 0.3 0.3 0.0 TX046 0.0 C5912 0.1 B 45 3.3 C5911 0.1 B 3.3 1.3 0.0 0.0 PLLC0 TP5903 HDMI_SCL HDMI_SDA R5919 R5920 1.5K 1.5K B5902 MMZ1608R102CT C5910 TXC0.0056 B HTPLG (PD) 2 3 TXC+ 1 4 L5904 ACM2012H-900-2P TX0TXC+ TXCNC NC 2 3 TX1TX0+ TXC+ TXCTX0+ 1 L5903 ACM2012H-900-2P 4 TX2+ TX1+ TX12 3 TX0TX1+ 1 4 L5902 ACM2012H-900-2P TX2+ HDMI CONNECTOR 2 3 1 4 L5901 ACM2012H-900-2P 54 55 56 57 58
3.3
0.0 66 AVSS
67 AVDD
65 AVDD
3.3
64 AVSS
63 FS
62 VREF
61 AVDD TX2+ TX2AVDD TX1+ TX1-
60 SWING 59 AVSS
C
51
52
CP5901
1903015-3 D2+ D2-S D2D1+ D1-S D1D0+ D0-S D0CLK+ CLK-S CLKCEC NC SCL SDA GND POWER HOTPLUG 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19
47
48
49
50
D
42 PLLC0 MSD/GPO6 (PU) 41 AVSS GPO7 (PD)
PLLC1
MSCK/GPO5
GPO10
GPO8
GPO9
34 0.0 NC
35 2.7
36 0.0 NC
37 0.0 NC
38 0.0 NC
39 0.0 NC
40 5.0 R5928 10
41
42
43
44
HPD V+5H
TP5901
TP5902
C5920
TP5928
25V 10 KA
0.1 B C5921
E
W897
W898
F
VSYNC HSYNC
A 6/7
DV-696AV-S 29
7 8 6
5
1
2
3
4
3.10 DVD MT PCB ASSY(7/7)
A
A 7/7 DVD PCB ASSY (A2J003A130)
POWER PORT BLOCK
B
C
REG+1.8V IC IC4006
LM1117S-ADJ VIN 3 3.3 1.8 VOUT 2 0.6 W820 6.3V 47 KA R4011 15 R4012 39 +-1% C4096 68 +-1% R4013 ADJ 1
D
C4093
16V 1 B
C4087
C4122
FROM/TO POWER
C4086
1B
1B
0.1 B C4095
C4094
B
CP4003 (CP502)
A2001WV2-14P GND 1 2 P.CON+12V GND P.CON+6V GND(M) AT+3.3V AT+3.3V STBY L GND(D) FL DCFL DC+ -28V 3 AT+12V for MUTE
CP502
E
6 7 8 9 10 11 12 13 14
E 1/2
+3.3V TP4031
F
C4112
A 7/7
30
1 2
NOTE : THE DC VOLTAGE EACH PART WAS MEASURED WITH THE DIGITAL TESTER DURING PLAYBACK.
DV-696AV-S
3 4
C4116
5
P.CON+5V
0.001 B
0.001 B
4
0.1
1B
5
6
7
8
A
TO AUDIO JACK V+5A (AUDIO DAC) V+12AT(AUDIO MUTE) B4002 MMZ1608R102CT V+12 (AUDIO AMP) V+5A V+12AT V+12 D_GND
A 4/7
B
TO LOADER/MOTOR DRIVE V+6A (MOTOR) B4001 MMZ1608R102CT V+5S (OPU) V+3F (F/E) V+6A V+5S V+3F D_GND M_GND C5924 0.1 B R5921 22K
A 3/7
10K C5922
HDMI+5V REG(300mA) IC5902 PQ1K503M2ZPH 5.0 5.9 VOUT VIN 1 1B 2 0 6 GND ON/OFF GND NR 0 5
R5901
C
0.01 B
3
5.9
4
1.3 C5923
TO HDMI V+5H (HDMI) V+5H V+3H DVDD18 FROM/TO MPEG/MICON/DSP
W837 W838
V+3H (HDMI) DVDD18 (HDMI)
A 6/7
W822 W821
V+3 (MPEG/SDRAM/FLASH) V+3E (FIP/LED/IR/RESET) V+1R8 (CORE)
V+3 V+3E V+1R8
D
6.3V 220 YK
C4105 100P CH R4058 PWDN# 100 0.01 B C4056 FLDCFLDC+ -28V D_GND
0.001 B
C4098
1B C4099
C4100
A 1/7
FRROM/TO MEMORY D_GND
E
A 2/7
F
NOTE : THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE
A 7/7
31
7 8
DV-696AV-S
5 6
1
2
3
4
3.11 OPERATION, OPERATION 2 and OPERATION 3, 4 PCB ASSYS
A
OPERATION PCB ASSY
SW652 : DOWN SW653 : ENTER SW654 : RIGHT SW655 : RETURN SW656 : MENU SW657 : UP SW658 : TOPMENU SW659 : LEFT SW661 : HOMEMENU SW666 : EJECT
B
OPERATION PCB ASSY (A2I802A270 : Other) (A2I808A270 : YXZTUR5_Only)
1SS133 D654 D652 1SS133 1SS133 D655 1SS133 D658 1SS133 D657 D656 D659 1SS133 1SS133 1SS133 D651
B
OPERATION 3 PCB ASSY
SW667 : POWER
OPERATION 2 PCB ASSY
SW660 : STOP SW662 : +SKIP SW663 : PLAY SW664 : - SKIP SW665 : PAUSE
DOWN SW652 EVQ11L05R
ENTER SW653 EVQ11L05R RIGHT SW654 EVQ11L05R UP SW657 EVQ11L05R LEFT SW659 EVQ11L05R HOMEMENU SW661
C
RETURN SW655
H
OPERATION 4 PCB ASSY (A2I903ADG0)
R664 HDMI LED(RED) D660 LTL-1CHEE-002A
EVQ11L05R MENU SW656 EVQ11L05R TOPMENU SW658 EVQ11L05R
330 1/4W
W807
W808 EVQ11L05R
SW667 POWER EVQ11L05R
D
G OPERATION 3 PCB ASSY
(A2I903ADF0)
EJECT SW666 EVQ11L05R FFC(1.0mm pitch) CD604 2H051706
NC (CP604) 00_6232_005_102_800+
GND(NC)
POWER
V+3E
SW2
LED
CP605
FFC(1.0mm pitch) CD602 2H091303 EVQ11L05R PAUSE SW665 EVQ11L05R
1
2
3
4 2
5 1
(CP605) 00_6232_005_102_800+
5
4
3
GND(NC)
V+3E
SW2
LED
CP604
E
POWER
PLAY SW663
(CP602) 00_6232_009_102_800+ SW1 STOP PLAY/+SKIP 9 8 7 6 5 4 3 2 1
CP603
CP602
1 2 3 4 5 6 7 8 9
SW2 (CP603) 00_6232_009_102_800+ SW1 STOP PLAY/+SKIP PAUSE/-SKIP V+3E POWER SW2 GND LED
SW1 Vout 1 GND 2 B+ 3 OS651 ROM-N340TAO
EVQ11L05R -SKIP SW664
EVQ11L05R +SKIP SW662
EVQ11L05R
PAUSE/-SKIP V+3E POWER SW2 GND LED
C668 0.01 B
STOP SW660
W804
F
C B C G H
32
1
OPERATION 2 PCB ASSY (A2I802A280)
DV-696AV-S
2 3 4
5
6
7
8
A
V651 HNV-08SS44T
DVDCD
TRACK ALL
REPEAT A
B
FL+
FL+
P16
P15
P14
P13
P12
P11
P10
G8
G7
G6
G5
G4
G3
G2
G1
FL2 -22.3
32 31 -19.7 -19.7
28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 -26.8 -22.7 -22.7 -20.5 -26.8 -26.8 -22.7 -20.5 -20.5 -22.7 -20.5 -20.5 -26.8 -26.8 -26.8 -20.5 -25.1 -25.1 -25.1 -25.1
8 -25.1
7 -25.1
6 -25.1
5 -25.1
-22.3
FL1
P9
P8
P7
P6
P5
P4
P3
P2
P1
FLDCW805 FLDC+
B
TP662
D669
-28V R656 R658 1K 10K
GR8
GR7
GR6
GR5
GR4
GR3
GR2
C658
B
R655
1K R657
P16 6.3V 47 KA
P10
P11
P12
P13
P14
P15
P8
P9
0.1
10K
GR1
P16
P15
P14
P13
P12
P11
P10
P9
P8
P7
P6
P5
P4
P3
P2
P1
-6.0 -13.0 -12.6 -9.5 -13.0 -9.5 -19.0 -19.0 -15.6 3.3 22 21 20 19 18 17 16 15 14 13 P8 P9 P10 P11 P12 P13 P14 P15 P16 VDD 23 P7 P6 P5 P4 P3 P2 P1 -12.0 -6.0 -18.0 25 P5 P4 P3 P2 P1 -28V GR12 GR10 GR11 34 NC -18.0 34 GR9 GR8 GR7 GR6 GR5 GR4 GR3 GR2 44 GND VDD GR1 FIP DRIVER IC IC651 PT6315
C653
C6760.1 B
C
0 12 K2 K1 STB CLK DI DO OSC LED4 LED3 LED2 LED1 44 0 FROM/TO MPEG/MICON/DSP LED (CP4002) 00_6232_011_102_800+ 1 CLK DI (M to F) STB DO (F to M) IR C604 C605 0.1 B V+3E DGND 33P CH DGND FLDC+ -28V FLDC2 3 4 5 6 8 9 10 11 7 FFC(1.0mm pitch) CD601 2H0B1003 11 10 0 0 3.2 9 3.4 8 0.7 7 3.2 6 2.9 5 R651 2.2 R652 2.2 R653 2.2 R654 2.2 R662 100K STB FP_SCK FP_DI FP_DO
24
P6
23 P7
12 GND
-18.0 -18.0 -18.0 -18.0 -18.0 -18.0 NC -18.0 NC -18.0 NC 29 28 27 26
D
30
NC 0 0 NC NC 0 0 NC
4
31
32
33
35
36
37
38
39
40
41
42 3.3
43
-18.0 -18.0 -16.0 -16.0 -16.0 -16.0 -16.0 -16.0 GR8 GR7 GR6 GR5 GR4 GR3 GR2 GR1
1
2
3
18
CP601
LED
V+3E
IR
FP_SCK FP_DI STB FP_DO V+3E IR V+3E
E
R666 2.2 1/4W 6.3V 47 KA B C675 C674 C651 TP663
0.1
FLDC+ 0.001 B -28V FLDCGND
W809
CP4002
A 1/7
F
NOTE : THE DC VOLTAGE EACH PART WAS MEASURED WITH THE DIGITAL TESTER DURING PLAYBACK. NOTE : THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE
B
33
8
DV-696AV-S
5 6 7
1
2
3
4
3.12 POWER PCB ASSY (1/2)
A
E 1/2 POWER PCB ASSY (A2J003A240)
POWER BLOCK
W804 W803 CHASSIS GND 250V 0.0022 KX D512 FR155-F 250V 0.001 KX
C516
CD501_1 1209618901 J501 YKE31-0148N AC 220 V -240 V_ AC INLET 50 Hz/60 Hz WHITE(N) 1 1.5M 1/2W
D505 1N4005-EIC D502
100K 1/2W
1N4005-EIC R512_1 400V 82 UP
C511
BLACK(L) 275V 0.22 ECQUL
400V 0.01 ECQP
B
2 1 R503
2
C515_1
C518
D510 T501 81291354 FR155-F 16 130 130 2 3 15 14 13 12 0 0 6 7 11 10 9 0 0 0 0 0 0 -22.5 D519 0 8 NC -22.5 1F5-E
2KV 47P SL
1N4005-EIC
F501_1 T1.6 A L 250 V
C502_1
1
2 D506
FH501_1 EYF-52BCY
FH502_1 EYF-52BCY
L501 SS11V-03550-CH
1N4005-EIC
C513
3
4
RL106F-E
D503
D509_1
130 4 NC W4BRH3.5X6X1.0X2
1H3-E
D511
T1.6A 250V
C
130 IC502 STR-A6131M POWER CTL IC 8 D
130 7 D
0N C 130 FB/OLP STARTUP 6 NC 5 D515 1S40-E C514 500V 470P B D513 1H3-E R505 22 1/4W R507 10 MTZJ5.6B-EIC C508 1/4W
1 0.1 17.5
2
GND
OCP
VCC
3 0 3.9
4
D
B501
PRI
SEC
2KV 100P R
1W
D508
680P CH
50V 10 YK
PHOTO COUPLER IC504 PS2561AL1-1-V(W) 1 3.9 34 0 10.9 9.9 2 R515 1K C540 0.01 B R513 C503 R514 1K 1/4W
C505
R502
1.8
50V 2.2 KA
R504
680K
C506
C509
E
10K 1/4W 0.1 B VOLTAGE CTL IC IC501 KIA431A-AT
· NOTE FOR FUSE REPLACEMENT CAUTION - FOR CONTINUED PROTECTION AGAINST RISK OF FIRE. REPLACE WITH SAME TYPE AND RATINGS OF FUSE.
OUT 3 9.9
GND 2 02 .5
IN 1
CAUTION: SINCE THESE PARTS MARKED BY CRITICAL FOR SAFETY,USE ONES
DESCRIBED IN PARTS LIST ONLY
ARE
ETANT ATTENTION: LES PIECES REPAREES PAR UN SECURITE DANGEREUSES AN POINT DE VUE N'UTILISER QUE CELLS DECRITES DANS LA NOMENCLATURE DES PIECES
F
E 1/2
34
1 2
DV-696AV-S
3 4
5
6
7
8
6V REG (DVD MOTOR) IC IC503 PQ070XF01SZH REG P.CON+12V SW Q510 KTA1281_Y R541 12.9 12.6 12.3 12.3 5.0 4.5 25V 470 YK REG+12V CTL Q511 4.5 KTC3875S_Y_RTK R543 680 1/4W R540 REG+12V CTL Q509 12.9 KTC3875S_Y_RTK
CAUTION: DIGITAL TRANSISTOR
A
IN 1 7.0 16V 100 YK C531
OUT 2 5.9
GND 3 0 4 1.2 R545 22K+-1% D534 6.8K +-1%
R542
1K 1/4W R546 P.CON SW Q505 KRC102SRTK 3.3K 1/4W +-1% MTZJ4.3B-EIC 0
W817
820 1/4W+-1% 5.6K +-1%
5.1
16V 330 YK
C535
R509
4.7K +-1%
C523
1K
1SS133 D517
R526
R524
2.8 0 C501 W814
D532 P.CON+5V REG Q515 2SD1835S/T-AA 7.0 R547 16V 1000 FM C521 22 10V 100 YK C538 C527 5.8 5.1 1S40-E L503 22uH TSL0808
R525 C507 100 0.01 B GND 6.3V 220 YK 3.3K R519
0.01
B FROM/TO POWER PORT
B
CP502
A2001WV2-14P GND P.CON+12V
(CP4003) CORD CONNECTOR 1 2 3 4 5 6 7 8 9 10 11 12 13 14 CD502 CU2E3301
AT+12V for MUTE GND P.CON+5V P.CON+6V G