Text preview for : SONY CDX-CA900.pdf part of SONY CDX-CA900 S.M.
Back to : SONY CDX-CA900.part1.rar | Home
CDX-CA900/CA900X
SERVICE MANUAL
Ver 1.1 2002. 08
US Model Canadian Model
CDX-CA900X
AEP Model UK Model E Model
CDX-CA900
· The tuner and CD sections have no adjustments. AUDIO POWER SPECIFICATIONS (US Model) POWER OUTPUT AND TOTAL HARMONIC DISTORTION 23.2 watts per channel minimum continuous average power into 4 ohms, 4 channels driven from 20 Hz to 20 kHz with no more than 5% total harmonic distortion.
Model Name Using Similar Mechanism CD Drive Mechanism Type Optical Pick-up Name
NEW MG-393XA-121//Q KSS-720A
SPECIFICATIONS
CD player section
Signal-to-noise ratio Frequency response Wow and flutter 90 dB 10 20,000 Hz Below measurable limit
Power amplifier section
Speaker outputs (sure seal connectors) Speaker impedance 4 8 ohms Maximum power output 52 W × 4 (at 4 ohms) Outputs
Tuner section
FM Tuning range
General
Outputs Audio outputs (front /rear) Subwoofer output (mono) Power antenna relay control terminal Power amplifier control terminal Telephone ATT control terminal Illumination control terminal BUS control input terminal BUS audio input or AUX IN terminal Remote controller input connector (AEP, UK, E Model) Antenna input terminal Bass ±10 dB at 62 Hz (US, Canadian Model) Bass ±8 dB at 100 Hz (AEP, UK, E Model) Treble ±10 dB at 16 kHz (US, Canadian Model) Treble ±8 dB at 10 kHz (AEP, UK, E Model) +8 dB at 100 Hz +2 dB at 10 kHz
87.5 107.9 MHz (US, Canadian Model) 87.5 108.0 MHz (AEP, UK, E Model) Antenna terminal External antenna connector Intermediate frequency 10.7 MHz/450 kHz Usable sensitivity 8 dBf Selectivity 75 dB at 400 kHz Signal-to-noise ratio 66 dB (stereo), 72 dB (mono) Harmonic distortion at 1 kHz 0.6% (stereo), 0.3% (mono) Separation 35 dB at 1 kHz Frequency response 30 15,000 Hz AM (US, Canadian Model) Tuning range 530 1,710 kHz Antenna terminal External antenna connector Intermediate frequency 10.7 MHz/450 kHz Sensitivity 30 µV MW/LW (AEP, UK, E Model) Tuning range MW : 531 1,602 kHz LW : 153 279 kHz Aerial terminal External aerial connector Intermediate frequency 10.7 MHz/450 kHz Sensitivity MW : 30 µV LW : 40 µV
Inputs
Tone controls
Loudness
Continued on next page
FM/AM COMPACT DISC PLAYER
CDX-CA900X
FM/MW/LW COMPACT DISC PLAYER
CDX-CA900
9-874-007-02
2002H0400-1 © 2002. 08
Sony Corporation
e Vehicle Company Published by Sony Engineering Corporation
1
Ver 1.1
CDX-CA900/CA900X
Power requirements Dimensions Mounting dimensions Mass Supplied accessories
12 V DC car battery (negative ground) Approx. 178 × 50 × 179 mm (7 1/8 × 2 × 7 1/8 in.) (w/h/d) Approx. 182 × 53 × 162 mm (7 1/4 × 2 1/8 × 6 1/2 in.) (w/h/d) Approx. 1.3 kg (2 lb. 14 oz.) Parts for installation and connections (1 set) Front panel case (1) Card remote commander (1) RM-X112 (US, Canadian model) RM-X113 (AEP, UK, E model) Rotary commander (1) RM-X6S
· US, Canadian model
CAUTION
Use of controls or adjustments or performance of procedures other than those specified herein may result in hazardous radiation exposure. If the optical pick-up block is defective, please replace the whole optical pick-up block. Never turn the semi-fixed resistor located at the side of optical pick-up block.
Note
This unit cannot be connected to a digital preamplifier or an equalizer. Design and specifications are subject to change without notice.
optical pick-up block
SERVICE NOTES
NOTES ON HANDLING THE OPTICAL PICK-UP BLOCK OR BASE UNIT The laser diode in the optical pick-up block may suffer electrostatic breakdown because of the potential difference generated by the charged electrostatic load, etc. on clothing and the human body. During repair, pay attention to electrostatic breakdown and also use the procedure in the printed matter which is included in the repair parts. The flexible board is easily damaged and should be handled with care. NOTES ON LASER DIODE EMISSION CHECK The laser beam on this model is concentrated so as to be focused on the disc reflective surface by the objective lens in the optical pickup block. Therefore, when checking the laser diode emission, observe from more than 30 cm away from the objective lens. Notes on Chip Component Replacement · Never reuse a disconnected chip component. · Notice that the minus side of a tantalum capacitor may be damaged by heat.
semi-fixed resistor
TEST DISCS This set can playback CD-R and CD-ROM discs. The following test discs should be used to check the capability: CD-R test disc TCD-R082LMT (Part No. J-2502-063-1) CD-RW test disc TCD-W082L (Part No. J-2502-063-2) Notes on CD-R/CD-RW discs · You can play CD-Rs (recordable CDs)/CD-RWs (rewritable CDs) designed for audio use on this unit. Look for these marks to distinguish CD-Rs/CD-RWs for audio use.
· AEP, UK model
These marks denote that a disc is not for audio use.
This label is located on the bottom of the chassis.
CAUTION INVISIBLE LASER RADIATION WHEN OPEN DO NOT STARE INTO BEAM OR VIEW DIRECTLY WITH OPTICAL INSTRUMENTS
· Some CD-Rs/CD-RWs (depending on the equipment used for its recording or the condition of the disc) may not play on this unit. · You cannot play a CD-R/CD-RW that is not finalized. A process necessary for a recorded CD-R/CD-RW disc to be played on the audio CD player.
This label is located on the drive unit's internal chassis.
SAFETY-RELATED COMPONENT WARNING!! COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.
ATTENTION AU COMPOSANT AYANT RAPPORT À LA SÉCURITÉ!! LES COMPOSANTS IDENTIFIÉS PAR UNE MARQUE 0 SUR LES DIAGRAMMES SCHÉMATIQUES ET LA LISTE DES PIÈCES SONT CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT. NE REMPLACER CES COMPOSANTS QUE PAR DES PIÈCES SONY DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL OU DANS LES SUPPLÉMENTS PUBLIÉS PAR SONY.
2
CDX-CA900/CA900X
TABLE OF CONTENTS 1. GENERAL
Location of controls (US, Canadian Model) ........................... 4 Location of controls (E Model) ............................................... 4 Connections (US, Canadian Model) ........................................ 5 Connections (E Model) ........................................................... 6
3. DIAGRAMS
3-1. IC Pin Descriptions ........................................................... 13 3-2. Circuit Boards Location .................................................... 18 3-3. Block Diagram CD Section ........................................... 19 3-4. Block Diagram Tuner Section ....................................... 20 3-5. Block Diagram Display Section .................................... 21 3-6. Printed Wiring Boards CD Mechanism Section ............ 22 3-7. Schematic Diagram CD Mechanism Section ................ 24 3-8. Schematic Diagram Main Section (1/4) ........................ 25 3-9. Schematic Diagram Main Section (2/4) ........................ 26 3-10. Schematic Diagram Main Section (3/4) ........................ 27 3-11. Schematic Diagram Main Section (4/4) ........................ 28 3-12. Printed Wiring Board Relay Section ............................. 29 3-13. Printed Wiring Board Main Section .............................. 30 3-14. Printed Wiring Board Key Section ................................ 32 3-15. Schematic Diagram Key Section ................................... 33
2. DISASSEMBLY
2-1. Sub Panel Assy .................................................................... 7 2-2. CD Mechanism Block ......................................................... 8 2-3. Main Board ......................................................................... 8 2-4. Heat Sink ............................................................................. 9 2-5. Chassis (T.U) Assy .............................................................. 9 2-6. Disc In Board .................................................................... 10 2-7. Servo Board ....................................................................... 10 2-8. Shaft Roller Assy, Load Board .......................................... 11 2-9. Floating Block Assy .......................................................... 11 2-10. Optical Pick-up Block ....................................................... 12
4. EXPLODED VIEWS
4-1. 4-2. 4-3. 4-4. 4-5. 4-6. Chassis Section ................................................................. 37 Main Board Section .......................................................... 38 Front panel Section ........................................................... 39 CD Mechanism Section (1) ............................................... 40 CD Mechanism Section (2) ............................................... 41 CD Mechanism Section (3) ............................................... 42
5. ELECTRICAL PARTS LIST ........................................ 43
EXTENSION CABLE AND SERVICE POSITION When repairing or servicing this set, connect the jig (extension cable) as shown below. · Connect the MAIN board (CN401) and the SERVO board (CN1) with the extension cable (Part No. J-2502-062-1).
MAIN BOARD CN401
SERVO BOARD CN1
3
CDX-CA900/CA900X
Ver 1.1
SECTION 1 GENERAL
(AEP, UK, E Model)
This section is extracted from instruction manual.
(US, Canadian Model)
(US, Canadian Model)
(AEP, UK, E Model)
4
CDX-CA900/CA900X
Connections (US, Canadian Model)
5
5
CDX-CA900/CA900X
Connections (E Model)
6
6
CDX-CA900/CA900X SECTION 2 DISASSEMBLY
Note : This set can be disassemble according to the following sequence.
SET 2-5. 2-1. SUB PANEL ASSY (Page 7) 2-6. 2-2. CD MECHANISM BLOCK (Page 8) 2-8. 2-3. MAIN BOARD (Page 8) HEAT SINK (Page 9) 2-9. DISC IN BOARD (Page 10) 2-7. SERVO BOARD (Page 10) CHASSIS (T.U) ASSY (Page 9)
SHAFT ROLLER ASSY, LOAD BOARD (Page 11) FLOATING BLOCK ASSY (Page 11) OPTICAL PICK-UP BLOCK (Page 12)
2-4.
2-10.
Note : Follow the disassembly procedure in the numerical order given.
2-1. SUB PANEL ASSY
4 claws
2 PTT 2.6x6 3 claw
5 CN701
6 sub panel assy 1 PTT 2.6x6
7
CDX-CA900/CA900X
2-2. CD MECHANISM BLOCK
6 bracket (CD) 7 CD mechanism block
2 PTT 2.6x4
5 PTT 2.6x4
3 1 PTT 2.6x4
4 CN401
2-3. MAIN BOARD
4 PTT 2.6x6 6 MAIN board
5 PTT 2.6x6
1 PTT 2.6x4
2 PTT 2.6x4
3 PTT 2.6x4
8
CDX-CA900/CA900X
2-4. HEAT SINK
6 heat sink
5 PTT 2.6x10
4 PTT 2.6x16
3 PTT 2.6x10 2 PTT 2.6x4 1 PTT 2.6x4
2-5. CHASSIS (T.U) ASSY
4 P 2x3
5 P 2x3
3 Unsolder the lead wires.
6 chassis (T.U) assy
black red white
2 heat sink (MG393)
1 P 2x4
9
CDX-CA900/CA900X
2-6. DISC IN BOARD
4 guide (disc)
1 PS 2x3 2 DISC IN board
3 claws
2-7. SERVO BOARD
7 SERVO board 6 PS 2x4
2 Removal the solders.
8 connector
3 Removal the solders. 1 CN3 4 P 2x3
BLU BLU
5 loading motor assy
optical pick-up block
10
CDX-CA900/CA900X
2-8. SHAFT ROLLER ASSY, LOAD BOARD
· When installing, take note of the positions arm (roller) and washers. (Fig. 1)
3 retaing ring (roller) 4 bearing (roller)
bearing (roller) retaing ring (roller) arm washer (RA) washer (RA)
bearing (roller) arm
Fig. 1
6 PS 2x3
5 shaft roller assy 2 arm (roller T) 7 LOAD board
1 tension spring (RA3)
2-9. FLOATING BLOCK ASSY
7 floating block assy
8 compression spring (FL)
1 tension spring (KF1) 9 compression spring (FL)
2 tension spring (KR1)
5 Fit lever (D) in the direction of the arrow.
6 Turn loading ring in the direction of the arrow. 3 damper (T) 4 damper (T)
11
CDX-CA900/CA900X
2-10. OPTICAL PICK-UP BLOCK
1 P 2x3
4 P 2x3
5 leaf spring (feed)
2 sled motor assy
6 shaft (feed) assy
3 optical pick-up block
12
CDX-CA900/CA900X SECTION 3 DIAGRAMS
3-1. IC PIN DESCRIPTIONS
· IC501 MB90574CPMT-G-367-BNDE1 (SYSTEM CONTROL) (US, Canadian Model) · IC501 MB90574CPMT-G-368-BNDE1 (SYSTEM CONTROL) (AEP, UK, E Model) Pin No. Pin Name I/O Pin Description 1 RF OK I Servo IC RFOK signal input from servo IC (IC1) 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20, 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 CD RST A0 STB ATT XTAL EN LIMIT VCC AMP ATT E2PSIO E2PCKO DOOR SW/FLS SI FLS SO BUS ON BEEP (NCO) UNISI UNISO UNICKO (NCO) SYSRST (NCO) SIRCS TSI TSO TCKO PH1 CD DSW IN SW/PH2 PH3 CD LM LO VSS C CD LM EJ AMP ON VOLATT DVCC DVSS ADSO1 ADSO2 AVCC AVRH AVRL AVSS KEYIN0 NC RC IN0 (NCO) QUALITY O O O O O I -- O I/O O I O O O O I O O O O O I I O O I I I I O -- -- O O O -- -- O O -- -- -- -- I O I O I Servo IC reset signal output to servo IC (IC1) Servo IC command/parameter identification signal output to servo IC (IC1) Command transmission: "L" Servo IC data storob signal output to servo IC (IC1) System mute control signal output Not used in this set. CD mechanism limit switch signal input (SW3) Power supply pin (+5 V) Power amp mute signal output to power amp (IC381) EEPROM data signal input/output with tuner unit (TUX201) EEPROM clock signal output to tuner unit (TUX201) Front panel open/close detection signal input/Flash write data signal input Flash write data signal output Bus on control signal output Beep signal output to power amp (IC381) Not used. (Open) SONY bus data signal input SONY bus data signal output SONY bus clock signal output Not used. (Open) System reset signal output to bus interface (IC601) Not used. Remote control data signal input Servo IC serial data signal input from servo IC (IC1) Servo IC serial data signal output to servo IC (IC1) Servo IC serial clock signal output to servo IC (IC1) CD mechanism PH1 detection signal input Not used in this set. CD mechanism down switch signal input (SW4) CD mechanism disc-in switch signal input (SW1) CD mechanism PH3 detection signal input Not used in this set. CD mechanism loading motor control signal output Ground pin Capacitance pin of power stabilized CD mechanism eject motor control signal output Amp on signal output to power amp (IC381) "L": OFF, "H": ON Electronic volume mute signal output to electronic volume (IC301) "L": Mute D/A converter VREF input (+5 V) D/A converter ground pin ADSO select switch output 1 ADSO select switch output 2 Analog power supply pin (+5 V) A/D convert Vref+ input (+5 V) A/D convert Vref input (0 V) Analog ground pin Key signal input Not used. (Open) Rotary commander signal input from remote in jack (J651) Not used. (Open) Tuner noise detection signal input (E model) Data latch: "L"
Ver 1.1
13
CDX-CA900/CA900X
Pin No. 51 52 53 54 55 56 57 58 59 to 62 63 64 65, 66 67 68 69 70 71 72 73 74 75 76 77 78, 79 80 81 82 83 84 85 86 87 88, 89 90 91 92 93 94 95, 96 97 to 101 102 103 104 105 106 107 108 109 110 111 112 113
Pin Name NC MPTH VSM VCC BUS/AUX NS MASK BOOT DOORIND -- VSS CD PACK (NCO) CD SELFSW -- FLASH W I2CSIO I2CCKO KEYACK X1A X0A DAVN (NCO) BU IN -- ADON NOSESW FLASH ON PWON -- RAMBU HSTX MD2 MD1, 0 RESET VSS X0 X1 VCC NC (NCO) MODELSEL0 U·E/J (P) 10k/9k (P) (NCO) CD MON CD ON RCIN1 (P) TESTIN (P) TELATT (P) ILLIN (P) -- (NCO) TUNON
I/O O O I -- O O O O I -- I O I O I O O I -- -- I O I O O I O O O I I I I I -- -- -- -- O O I I O O O I I I I O O O
Pin Description Not used. (Open) Not used in this set. (Open) S-meter signal input from tuner unit (TUX201) Power supply pin (+5 V) BUS/AUX audio ground select signal output "H": BUS
Tuner noise mask signal output (E model) Display microcomputer write control signal output to sub system control (IC701) Front panel indicator signal output Not used in this set. (Connect to ground.) Ground pin Servo IC CD text pack synchronization signal input Not used. (Open) CD mechanism self load position detection switch signal input (SW2) Not used. (Open) Flash write mode detection signal input Tuner (TUX201), electronic volume (IC301) communication data signal output Tuner (TUX201), electronic volume (IC301) communication clock signal output Key acknowledge detection signal input Low speed oscillation signal input (32.768 kHz) Low speed oscillation signal input (32.768 kHz) RDS data block synchronization detection signal input (E model) Not used. (Open) Back up power detection signal input Not used. (Open) Power control signal output of A/D converter Front panel attachment detection signal input from nose detect switch (S102) "L": ON Flash write jig power supply signal output System power control signal output Not used. (Open) Reset detection signal input of RAM Hardware standby signal input "L": Standby mode Operation mode signal input Connect to ground in this set. Operation mode signal input Connect to VCC in this set. Microcomputer reset signal input Ground pin High speed oscillation signal input (3.68 MHz) High speed oscillation signal input (3.68 MHz) Power supply pin (+5 V) Not used. (Open) Not used. (Open) Not used. (Open) Not used. (Open) Not used. (Open) Destination detection signal input Destination detection signal input
CD mechanism power control signal output to power supply (IC801) CD mechanism voltage control signal output to power supply (IC801) Rotary commander signal input from remote in jack (J651) Test mode set up detection signal input Tell mute detection signal input Illumination line detection signal input "L": Dimmer on Not used. (Open) Not used. (Open) Tuner on signal output
14
CDX-CA900/CA900X
Pin No. 114 to 116 117 118 119 120
Pin Name -- ACCIN -- VSS CD TSTB
I/O O I O -- O
Pin Description Not used. (Open) ACC power detection signal input "L": ACC on Not used. (Open) Ground pin Servo IC CD text parameter storob signal output to servo IC (IC1)
15
CDX-CA900/CA900X
· IC701 HD64F2398A04FWV (SUB SYSTEM CONTROL) Pin No. Pin Name I/O Pin Description 1 PG3 O Spectrum analyzer data clock signal output to electronic volume (IC301) 2 3 4 5 6 to 9 10 11 to 14 15 to 18 19 20 to 23 24 to 27 28 29 to 32 33 34 35, 36 37 38 39 40 to 43 44 45 to 48 49 50 51 52 53 54, 55 56 57 58 59 60 61 62 63 64 65 66 67, 68 69 to 71 72 to 79 80 81 82 83 84 85 86 87 88 PG4 VSS NC VCC PC0 to PC3 VSS PC4 to PC7 PB0 to PB3 VSS PB4 to PB7 PA0 to PA3 VSS PA4/IRQ4 to PA7/IRQ7 SA EN BU IN VSS P65/IRQ1 BUS ON VCC PE0 to PE3 VSS PE4 to PE7 -- LINK OFF PD2 ILL ON VSS -- PD6 BOOT VCC NC TX/LCD DATA SP SI RX/DOOR SW L RST LCD SCK VSS LCD CEI VSS (NCO) P27 to P20 VCL RST NMI STBY (H) VCC XTAL EXTAL VSS PF7 O -- -- -- O -- O O -- O O -- O I I -- O I -- O -- O O O O O -- O O I -- O O O I O O -- O -- O O -- I I -- -- -- -- -- O Not used. (Open) Ground pin Not used. (Open) Power supply pin (+5 V) Not used. (Open) Ground pin Not used. (Open) Not used. (Open) Ground pin Not used. (Open) Not used. (Open) Ground pin Not used. (Open) Spectrum analyzer enable signal input from system control (IC501) Back up power signal input from bus interface (IC601) Ground pin Not used. (Open) Bus on signal input from system control (IC501) Power supply pin (+5 V) Not used. (Open) Ground pin Not used. (Open) Not used. (Open) Link off signal output Not used. (Open) Illumination power control signal output Ground pin Not used. (Open) Not used. (Open) Flash write mode detection signal input from system control (IC501) Power supply pin (+5 V) Not used. (Open) Flash write data signal output/LCD driver data signal output Not used. (Open) Flash write data signal input/Door switch detection signal input Reset signal output LCD driver clock signal output Ground pin LCD driver chip enable signal output Ground pin Not used. (Open) Not used. (Open) Connect to external capacitor Reset signal input Non-maskable interruption signal input Standby mode pin Power supply pin (+5 V) Crystal oscillator connection pin (18.432 MHz) Crystal oscillator connection pin (18.432 MHz) Ground pin Not used. (Open)
16
CDX-CA900/CA900X
Pin No. 89 90 91 to 96 97 98 99, 100 101 102 103 104 105 to 110 111 112 113 114 115 to 122 123 to 125 126 to 128
Pin Name VCC PF6 OPEN PF5 to PF0 UNI SO UNI SI VSS UNI SCK NCO AVCC VREF A40/AN0 to A45/AN5 P46/AN6/DA0 P47/AN7/DA1 AVSS VSS P17 to P10 MD0 to MD2 PG0 to PG2
I/O -- -- O O I -- I O -- -- I I I -- -- O -- O
Pin Description Power supply pin (+5 V) Not used. (Open) Not used. (Open) SONY bus data signal output SONY bus data signal input Ground pin SONY bus clock signal input Not used. (Open) Power supply pin for A/D, D/A converter Reference voltage input for A/D, D/A converter Not used. (Connect to ground in this set.) Not used. (Connect to ground in this set.) Spectrum analyzer data signal input from electronic volume (IC301) Ground pin for A/D, D/A converter Ground pin Not used. (Open) Mode pin Not used. (Open)
17
CDX-CA900/CA900X
3-2. CIRCUIT BOARDS LOCATION
DISC IN board
SUB board
SUB (CD) board LOAD board LIMIT board
tuner unit (TUX201)
MAIN board KEY board SERVO board
· Waveforms -- Servo Board --
(MODE: CD PLAY) -- Main Board -- -- Key Board --
1
1.8Vp-p
1
2.2Vp-p
1
4.6Vp-p
16.9344MHz
4.332MHz
4MHz
IC1
wd
(XTAL)
IC201
4
(OSC O)
IC903
4
(XOUT)
2
5Vp-p 3.3msec
2
4.5Vp-p
32.768kHz
IC1
ts
(PACK)
IC501
uf
(XOA)
3
1.5Vp-p
3
3.8Vp-p
3.68MHz
IC1
uj
(RFO)
IC501
os
(XO)
4
0V Approx. 100mVp-p
4
1.4Vp-p
18.432MHz
IC1
oa
(FEO)
IC701
ih
(EXTAL)
5
0V Approx. 100mVp-p
IC1
od
(TEO)
18
CDX-CA900/CA900X
3-3. BLOCK DIAGRAM -- CD SECTION --
OPTICAL PICK-UP KSS-720A
RF AMP,DIGITAL SERVO DIGITAL SIGNAL PROCESSOR IC1
A
84
A
(Page 20) TUNER SECTION
RF EQ EFM DEMOD D/A CONV LOUT 16 ROUT 12 PACK 52 TSTB 56 TSCK 55 TSI 54 SI 8 SO 7 SCK 6 STB 5 AO 4 RST 3 RFOK CDL R-CH
C B
85 82
C B
A
SYSTEM CONTROL IC501 (1/3) 64 CD_PACK 120 TSTB
D
I-V CONV.
D 83
DSUB CODE PROCESS
26 CD_TSO 25 CD TSI 27 CD TCK 4 STB 3 AO 2 CD_RST
FORCUS ERROR I/F E F PD E 87 86 F PD TRACKING ERROR APC SERVO CTL
2
1 RFOK
97
LD
LD DRIVE Q1
OSC A+5V TD 98 MD SD LD FD
62 63 64 65 FOCUS/TRACKING COIL DRIVE, SLED/SPINDLE/LOADING MOTOR DRIVE IC2 FCSFOCUS COIL FCS+ 15 16 FOCUS COIL DRIVE FD
23
24
X1 16.9344MHz SW4 (DOWN) SW2 (SELF) SW1 (DISC IN) SW3 (LIMIT) 29 D SW
26
67 SELFSW
TRK+ TRACKING COIL TRK-
17 18
TRACKING COIL DRIVE
23
TD
30 IN/PH2
7 LIMIT
M902 (SLED)
M
SLSL+
13 14
SLED MOTOR DRIVE SPINDLE MOTOR DRIVE
5
SD
M901 (SPINDLE)
M
SPSP+
11 12
6
MD
M903 (LOADING)
M
LD9 LD+ 10
LOADING MOTOR DRIVE
1 2
LOAD EJECT
32 LOAD 35 EJECT 105 CDM ON A+5V AU+5V D+5V DR+6V BU+5V 1 7 SW5V 3 SW6V 5 5V VCC 6 POWER SUPPLY IC801 BATT 106 CD ON 2 Q405
· Signal path :CD · R-ch is omitted due to same as L-ch.
19
19
CDX-CA900/CA900X
Ver 1.1
3-4. BLOCK DIAGRAM -- TUNER SECTION --
CN302 1 ELECTRONIC VOLUME IC301 GND SWITCH Q391 R-CH
L BUS AUDIO IN
2
R
CD (Page 19) SECTION DISPLAY (Page 21) SECTION
TUNER UNIT TUX201 CN201 (ANTENNA) 1 ANT AM 2 ANT FM
A B
CDL SACLK SAOUT IC304 (1/2) 5 7 ADSO SWITCH IC361 3 2 IC304 (2/2) 1
4 AUXL 43 MDL OUT LF 28 21 SACLK 23 SA OUT 38 AC OUTL 33 AC INL OUT LR 27 Q308 R-CH 12 9 14 13 19 20 MPX1 AM MP IN LEVEL SDA SCL Q306 R-CH
5 6
L R
AUDIO OUT FRONT
3 4
L R
AUDIO OUT REAR
MPX 10 AMDET 8 AEP, UK, E MODEL
CN301 L SUB OUT OUT SW 24 MUTE CONTROL Q843,844 Q310 POWER AMP IC381 5 R
FM AMP Q212
CN101 1 FL+ 9 3 2 9 RL+ 10 FL
17 SM SYSTEM CONTROL IC501 (2/3) 37 VOL ATT NOISE 6 CANCEL 7 IC202 ADSO1 40 ADSO2 41
FL 12
Q211
55 50 QUALITY BUS/AUX ATT 5 56 NS MASK AMP ATT 9 AMP ON 36 BEEP 15 TEL ATT 109 ILL IN 110 ACC IN 117 X1A 73 X0A 74 X501 32.768kHz ACC CHECK Q101
RL 11 22 MUTE 4 STBY 16 AC-GND 7 RL
RDS DECODER IC201 RDS 9 X201 4.332MHz 16 FM DET 4 XO 5 XI SDA 9 SCL 10
Q103 ILLUM CHECK Q102
R-CH
TEST IN 108 PW ON 83 X0 92 X1 93 TUN ON 113 POWER CONT Q201,202 POWER CONT Q106,107 X502 3.68MHz AUDIO+8.5V
4 FR+ 12 FR 3 RR+ 11 RR 13 TEL MUTE 14 ILL 7 ACC 15 TEST
S METER 14 SDA 12 SCL 13 SDA 17 SCL 18
53 VSM 70 I2CSIO 71 I2CCKO 10 E2PSIO 11 E2PCKO
POWER CONT Q801-803
BATT
BATT
POWER CONT Q104,105 BATT
5 6 19 17
AMP REM ANT REM B+
EEPROM
TU +8.5V
AUDIO+8.5V
BATT
· Signal path : FM : AM/MW : CD · R-ch is omitted due to same as L-ch.
TU +5V
F901 18 16 B+
+5V REG Q203
TU+8.5V
20
20
CDX-CA900/CA900X
Ver 1.1
3-5. BLOCK DIAGRAM -- DISPLAY SECTION --
BUS INTERFACE IC601 CN601 (BUS CONTROL IN) 8 6 5 4 7 1 BATT 2 RESET 13 6 3 2 1 DATA 6 9 CLK 4 BUS ON 11 12 BUF 7 IC702 8
SUB SYSTEM CONTROL IC701 98 UNI SI 97 UNI SO 101 UNI SCK 38 BUS ON 34 BU IN RST 63 SA CLK 1 SA IN 112 SA CLK SA OUT
SYSTEM CONTROL IC501 (3/3) 17 18 19 14 77 22 UNI SI UNI SO UNI CKO BUS ON BU IN SYSRST SIRCS 24 BU +5V AD ON CONTROL Q701 72 KEY ACK
B
TUNER SECTION (Page 20)
SIRCS CONTROL IC903
6 RESET 9 XOUT 4
IC902 7 16
LED900
17 OUT XIN 3
81 RST
BUS ON SW Q603
BATT
3
BATT(L) CHECK
10
80 AD ON AEP, UK, E MODEL X910 4MHz 107 RC IN1 48 RC IN0
50 LINK OFF J651 (REMOTE IN) BATT BATT CHECK(H) Q602 KEY IN MATRIX X701 18.432MHz 85 XTAL BOOT 57 86 EXTAL
46 KEY IN0 57 BOOT
IC502 LCD DRIVER IC901 CLK 119 LCD LCD901 DIMMER 106 CE 118 DATA 120 64 SCK LCD 66 CEL DOOR SW/RX 62 LCD SO/TX 60 ILL ON 52 12 FLS SI 13 FLS SO HSTX 86 RSTX 90 S101 RESET 1 RESET 3 BU +5V
DIMMER CONTROL Q901
POWER CONTL Q702,703
BATT
S102 (NOSE) 81 NOSE DET
58 DOOR IND POWER CONT Q705,706
BATT
21
21
CDX-CA900/CA900X
3-6. PRINTED WIRING BOARDS -- CD MECHANISM SECTION -- · Refer to page 18 for Circuit Boards Location.
14
13
12
11
10
9
8
7
6
5
4
3
2
1 A
THIS NOTE IS COMMON FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS. (In addition to this, the necessary note is printed in each block.) for schematic diagram: · All capacitors are in µF unless otherwise noted. pF: µµF 50 WV or less are not indicated except for electrolytics and tantalums. · All resistors are in and 1/4 W or less unless otherwise specified. · % : indicates tolerance. f · : internal component. · C : panel designation. Note: Note: The components identi- Les composants identifiés par fied by mark 0 or dotted une marque 0 sont critiques line with mark 0 are criti- pour la sécurité. Ne les remplacer que par une cal for safety. Replace only with part piéce portant le numéro spécifié. number specified. · A : B+ Line. · Power voltage is dc 14.4V and fed with regulated dc power supply from ACC and BATT cords. · Voltages are taken with a VOM (Input impedance 10 M). Voltage variations may be noted due to normal production tolerances. · Waveforms are taken with a oscilloscope. Voltage variations may be noted due to normal production tolerances. · Circled numbers refer to waveforms. · Signal path. F : FM f : AM/MW/LW J : CD · Abbreviation CND : Canadian model. for printed wiring boards: · X : parts extracted from the component side. · Y : parts extracted from the conductor side. · x : parts mounted on the conductor side. a : Through hole. · · : Pattern from the side which enables seeing. (The other layer's patterns are not indicated.) Caution: Pattern face side: (Side B) Parts face side: (Side A) Parts on the pattern face side seen from the pattern face are indicated. Parts on the parts face side seen from the parts face are indicated.
B
C
D
E
F
G
· Abbreviation CND : Canadian model.
H
I
J
22
22
CDX-CA900/CA900X
1 A
2
3
4
5
6
7
8
9
10
11
12
13
14
· Semiconductor Location Ref. No. IC1 IC2
CN
Location E-7 H-7 C-6
TP63
B
TP62
TP7
TP77
2
TP78
Q1
R30
C5 C1
TP82 C4 TP80 TP60
C71
R29
TP66
C3
TP48
Q1
C43
R21
TP79
C
TP47 TP64
TP83 TP12
TP84
R3
TP50
TP9
TP11 C9
R22
C6
R26 TP59 TP51 TP8
C70
R5
TP81
C11
C10
TP10 C13 TP89 C20 C19 C18 R9 R8 C24 TP23 TP22 TP24 C23
TP70
R18
CN1
R17 TP58 TP72
C25
C41
C17
TP56
C14
D
TP52 TP71
C16
C8
(Page 31)
C15
C27
TP76 TP74
C29
E
R19
IC1
TP61
TP25 TP88
C34
TP75 TP69 TP68 C44 R31 TP49 C26
X1
TP34 C36 TP35
TP36 TP46 TP37 C38 TP38
TP45 C35 TP44 TP43
TP57
F
R20
FB5
TP92
TP41
TP39
TP40
TP15
TP42 TP31
TP14 BP4 TP18
TP85
TP55
G
BP2 BP1 TP30 R7 R6 R15 BP3 TP32 TP21
TP73
TP53 TP91
R10 R12
TP33
R14
TP26 TP29 C30 TP4 TP6 TP5 TP28 TP3 TP2
TP1
TP87
TP90
TP19
I
TP54 CN3
TP16 TP20 TP17 TP27
IC2
H
TP86
C22
+
-
+
-
J
23
23
CDX-CA900/CA900X
· Refer to page 18 for Waveforms. 3-7. SCHEMATIC DIAGRAM -- CD MECHANISM SECTION -- · Refer to page 34 for IC Block Diagrams.
CN2 Q1 TP9 R3 TP8 C20 C23 C24
TP77 TP78
R29 R30
R26 C19 C18
R9
TP22 TP23 TP24 TP25
TP88
C35
C1
C5 TP79 TP80
C43
C3
C4 C6
TP89
TP81 TP82 TP83 TP84
C14 TP10 C13 R5 C11 TP45 TP44 TP43 TP42 TP41 TP40 TP39 TP38 TP37 TP7
C15 C10
R8
IC1
TP46 TP36 C38
SW3
TP12 C9 TP11
C8 CN1 CN3 TP93 TP94 TP95 TP96 TP97 TP98 TP85 C70 C16 TP35 TP34 C36
M902
M901
TP92
IC B/D
C17
C25 CN1 C34 R18 TP61 TP76 TP60 TP75 TP59 TP74 TP58 TP73 TP57 TP72 TP56 TP71 TP55 TP70 TP54 TP69 TP53 TP68 TP52 TP51 R22 TP50 TP64 TP49 R21 TP90 TP91 TP27 TP29 TP26 TP28 TP48 TP63 TP47 TP62
X1
C41
C26 C27
C29
C71
FB5 R19
SW4
TP1 TP4 R20
R17
C44 R7 TP31 BP1 SW2 TP5 TP2 R15 SW1 TP3 R12 TP15 BP3 TP21 R14 TP18 C22 IC2 BP4 C30 R10 TP30 R31 TP33 BP2 TP32 TP66
(Page 27)
TP14
R6
TP17 TP20 TP16 TP19
TP87
Note: · Voltage is dc with respect to ground under no-signal conditions. no mark : CD PLAY
IC B/D
M903 TP86
24
24
CDX-CA900/CA900X
· Refer to page 18 for Waveform. 3-8. SCHEMATIC DIAGRAM -- MAIN SECTION (1/4) -- · Refer to page 34 for IC Block Diagrams.
Ver 1.1
R362 R361 C318 R301 R302 C312 C317
R370
R365
C319 R305 R366 C314
R363
R364 IC361 TUX201 IC304 C361 D300
C320
R306
C315 IC305
C313
C321
C362
C363
C205
C201
C202 R201
FB201
CN201
C322 R303 R304
C206
R207
R208
R307 R308
C311
C310
C316
C394
C393
IC B/D (Page 26)
C235 C236 C237 R231 Q203 C234 FB230 R205 C227 D202 R202 R203 C306 C308 Q202 C307 IC301 R371 R372 R373 R251 C230 C251 R232 R233 X201 R236 C232 C231 FB231 R253 C221 R228 R229 C222 AEP, UK, E MODEL R309 C218 Q212 IC202 D204 R226 C217 R223 R222 C223 R225 Q211 R227 C220 C229 C224 R224 C241 C233 R252 C254 C255 R374 R375 Q201 C309
IC B/D
C252 C253
D203
IC201
C226
C225
C373 C372
R254 C304 C303
C305
C219 R230
C375 C374
C371
C302
(Page 27)
(Page 28)
Note: · Voltage is dc with respect to ground under no-signal (detuned) condition. no mark : FM ( ) : AM/MW/LW
25
25
CDX-CA900/CA900X
Ver 1.1 3-9. SCHEMATIC DIAGRAM -- MAIN SECTION (2/4) --
R331 R399 R332 R333 R334
CN302
R330 C335 Q391
R398 D391
C345 C344
C390
Q306 Q307 C337
R336 R338
C336 C346 C338
C347
C378 C339 Q308 Q309 C341 R340 R342 C340
CN301
C342
US, CANADIAN, E MODEL
C343
Q310 R344 C381 C380
IC381
R383
C382 C386
D301 D302
(Page 25)
IC801
R384
C383 C387
D303 D304
R386
C384 C388
D305 D306 AEP, UK MODEL D307 D308
Q801 Q844 R802 D845 C842 C802 D801 Q802 R801 R806 R804 C803 R805 R803 Q803 C801 Q405 C804 C807 C806 D802 C805 C843 R849 C808 Q843 R845 R847
R385
C385 C389
C848 C847 R848 C844 R840 R850
CN101
R125
D106 TH101 Q104 D105 Q103 Q102 R110 C112 R119 R113 R114 R111 C103 R105 R106 C102 Q105 R107 R108 R109 D102 C109 Q101 C111 R115 C114 C110 TH102 D107 Q107 C113
R118 R117
R104 C115 R120 R116 R103 R102 R132 R131 R130 R101 F901 C108 D101
Q106
L101
(Page 27)
(Page 28)
Note: · Voltage is dc with respect to ground under no-signal (detuned) condition. no mark : FM ( ) : AM/MW/LW < > : CD PLAY
26
26
CDX-CA900/CA900X
· Refer to page 18 for Waveforms. 3-10. SCHEMATIC DIAGRAM -- MAIN SECTION (3/4) -- · Refer to page 36 for IC Block Diagram.
Ver 1.1
(Page 25)
(Page26)
C400
R409
(Page 24)
R504 R528
FB402
C401
C408 FB400 CN401 C406
R538 R539
R501 R540 R541 R542
R548 R549
R534
R535
L401
FB401 R411 R412 R545
R533
R532
R531 R530
C501
C410 C407 C403 R407
R543
FB501 C521
R410
R523 R536 C503 C523
C504 R527 IC501 Q603 D610 R601 D601 TH601 R607 R506 CN601 D609 R605 C602 D607
D605 D604 D606 C603
IC B/D
IC601 D505
C514
(AEP, UK, E)
(Page 28)
C505
R516 C506 C522 D654 C601 R604 D653
X501
X502
Q602
D603
C604
R571 R522 C511 C512 C513 R525
R544 R511
C507 C508 R510
AEP, UK, E MODEL
IC502 R524
AEP, UK, E MODEL R653 J651 R654
R505 R507 R508 R509 C509 C510 R512 R537
R652
R514
D504
Q701 S102 S101 D501
Note: · Voltage is dc with respect to ground under no-signal (detuned) condition. no mark : FM ( ) : AM/MW/LW < > : CD PLAY
27
27
CDX-CA900/CA900X
3-11. SCHEMATIC DIAGRAM -- MAIN SECTION (4/4) -- · Refer to page 18 for Waveform.
(Page 25)
(Page 26)
R702 C704
FB701 C709 C520 C708 C705
Q702
R709 R708 R737 R738
R724
R707
Q703
R712 IC701
C706 R521 Q705
FB702
R728
(Page 27)
C703
R739
R740
Q706
C711 C707 C702 C727 C715 C726 R703 R705 R704 R706
R734
C710
X701
C716 IC702 R745 R746 R748 R749
R720
R733
R711 CN701 D852
R741 C722 R744 R717 R716 FB703 R714 LED851 LSW851(1/2) LSW851(2/2) R855 R856 R713 R732 C718 C712 D703 C701 D851
(Page 33)
C717 D708 C714
CN851
CN852
Note: · Voltage is dc with respect to ground under no-signal (detuned) condition. no mark : FM
28
28
CDX-CA900/CA900X
3-12. PRINTED WIRING BOARD -- RELAY SECTION -- · Refer to page 18 for Circuit Boards Location.
1 A
2
3
4
5
6
7
8
9
10
11
12
13
14
B
LSW851
LED851
R855
R856
C
D
(Page 31)
E
F
D852
D851 CN851
G
1 7
CN852
H
8 14
I
· Semiconductor Location Ref. No. D851 D852 LED851 Location F-12 F-11 B-8 (Page 32)
29
29
CDX-CA900/CA900X
Ver 1.1 3-13. PRINTED WIRING BOARD -- MAIN SECTION -- · Refer to page 18 for Circuit Boards Location.
14
13
12
11
10
9
8
7
6
5
4
3
2
1 A
B
R105
C385
R111
C342
R106
R104 Q101 Q102
R107
R131 R103 C382
R132 R102
R101 R130
R383
Q307
Q306
D604 D605
Q309
R601
Q843 Q844
Q603
R117
C393
R845
C603
R303
C602 D609
IC304
IC601
C394
C321
R118
R304
R301
R399
C362
Q310
R334
C842
R333 R332 R331
R605 D102 C109
R607
C390 D391 R398
Q391
D105 R114 R113 R125
R110
R342 R386 R338 R336 R330
Q103
C386
Q308
C384 C388
R384
R340
C338
C336
C102
C340
R385 C389
C383 C387
C
R847 D845
C318
C601
R850 R840
R604 D603
C847
D610
· Semiconductor Location Ref. No. Location Ref. No. (D101) D-9 IC305 D102 C-9 IC361 D105 C-7 (IC381) (D106) D-7 (IC501) (D107) D-7 IC502 D202 E-2 IC601 D203 E-2 (IC701) D204 F-3 IC702 (D300) D-3 (IC801) (D301) C-8 (D302) C-8 Q101 (D303) C-8 Q102 (D304) D-8 Q103 (D305) D-8 Q104 (D306) C-8 Q105 (D307) D-8 Q106 (D308) D-8 Q107 D391 C-3 Q201 D501 H-7 Q202 D504 H-7 Q203 (D505) H-5 Q211 (D601) H-7 Q212 D603 E-8 Q306 D604 C-9 Q307 D605 C-9 Q308 (D606) C-9 Q309 D607 I-4 Q310 D609 D-9 Q391 D610 E-9 Q405 D653 I-7 Q602 D654 I-7 Q603 (D703) I-2 Q701 (D708) I-3 (Q702) D801 H-9 Q703 D802 G-9 (Q705) D845 D-6 Q706 (Q801) IC201 H-2 Q802 IC202 G-3 Q803 (IC301) D-4 Q843 IC304 D-3 Q844 ( ): SIDE B
R120
C115
R849 R848
C113
C114
R366 R364
R119
R409
Location E-3 E-3 B-6 H-6 H-7 D-9 H-4 I-4 G-10 C-8 C-8 C-7 D-8 E-8 E-8 E-8 E-2 D-2 E-2 G-3 G-3 C-4 C-4 C-3 C-3 D-2 C-3 H-9 D-9 D-9 I-7 I-8 I-8 I-9 I-9 H-9 G-9 G-9 D-6 D-6
C251
R108
R253 C253 C252 R251
R307 C322
IC305
C315
R109
R411 R207 R412 R506 R407 D204 R410 C224 C223 C222 C221 R229 R228 R208
Q203
R306
C226
Q106
Q105
R252
C255 C307
C254 R308
C320 C319 C363 R305
D203 D202
Q201
R309
R363
IC361
Q104 C110 C111 C112 R115 R116 Q107
R361 R362
R365
R202
Q602
C317 C361
C313
Q202
R302
D
R203
R205
E
F
C229
FB201
D802 R803 C804 C806 C801
C220
R225 R224 R223
IC202
R226 R227
R542
R541
R804
R527
R548 FB701
C218
R540 R539
Q212
R549 R538
C217 R230
G
AEP, UK, E MODEL
C802 R805
Q802
Q803
R702
R232
R545
R504
R801
R528
R231
R533 R535 R532 R534
Q211
R236 C233 FB230 C231 C241
R222 C219
D801
R806
Q405
C705
R501
IC201
IC502
C501
C234
R530 R531 C504 C503 C506 R505 C703 C702 C716 R703
R521
R802
R543
C704
R571
R522
R525
D504
R516
C706
C235 C236 C237 R713
R233
R537
X502
R705
R524 Q701
X701
Q706
Q703
R712
D501
R738 R724 R737
R739
R740
C512
C513
C511 R512
AEP, UK, E MODEL
D653 D654
R728
C508 C507 R508 R509 R544 R507
D607
C726 R704 C727 C722 C715
R744
C711
R745 R746
C232
X201
H
R511
C710
R510
I
R711 R733 R741
R748 R749
IC702
J
30
30
CDX-CA900/CA900X
Ver 1.1
1 A
2
3
CN302
4
5
6
7
8
9
10
11
12
13
14
AEP, UK, E MODEL
J651
C380 C345 C381
CN101 F901 CN601 IC381
B
CN201
C344
C346
C347
C339
C341
C335
C337
C848
C108
C
C371 C372
CN301
D306 D301 D302
D606
R652 R653
R654
C373 C374
C375
D303
BATT
AEP, UK MODEL
R344 C378
C343
C316
C103
C843
D304 D308 D106 D305 D307 D107 L101
C312
R371 R372
D
C201
TUX201 C308 C306
R370
C309
TH101 TH102
R373 R374
D300
IC301
R375
FB402
C803
C406
R201 C225
C202
C303
C302
C844
C305
FB400
TH601
D101
R254
C304
FB401
C310
C311
L401
C205
C400
C410
C408
C401
E
C314
C604
C403
F
C206 C227
CN401
C407
US, CANADIAN, E MODEL
(Page 23)
FB501 C808 C805
AEP, UK, E MODEL
G
C230
C709
C708
C521 C520
FMB4 R536 FB231 R709 R708 R523 C523
H
R716
C717 C718
R732 FB702
IC701
R707 IC501 R720 AEP, UK, E MODEL D505 C514 R717 C505 Q801
R706
C522
R714 R734
FB703 C707
D601 R514
FMB5 C712 X501 CN701 C509 C510 FMB3 Q702 Q705
I
D703
C701
C714
D708
S102
S101
J
(Page 29)
31
31
IC801
C807
CDX-CA900/CA900X
3-14. PRINTED WIRING BOARD -- KEY SECTION -- · Refer to page 18 for Circuit Boards Location.
1 A
2
3
4
5
6
7
8
9
10
11
12
13
14
LSW923 C902 LED911 LED913 R934
R923
B
C905 LSW922 LED910 LED914 LSW921 LCD901 LED912 LED915
R922
C
R921
LSW924
D
R975
E
R933
R924
R973 D902 R917 R916 R915 R914
R976 R974
R979
F
C912 R910 R903 C908 R902 C907 IC903
C986 R983
FMB3 R913 IC901 FMB4 R987 C983 R994 R993 R992 R991 R988
R986 R985 R984
D974 D972
Q901
R980
CN901
D920
R912 D910 X910
C900
C990
R911
C909
FB901
C993
C992 C982
C910
R919 R918
IC902
FB902
C911
G
C904
C991
R990 R901
D900 R904
C906
R971 R972
R982
R981
D901
H
LED900
C901
· Semiconductor Location Ref. No. D900 D901 D902 D910 D920 D972 D974 IC901 IC902 IC903 Location H-12 H-12 F-11 F-4 F-14 G-10 G-11 F-8 G-1 G-3 Ref. No. LED900 LED910 LED911 LED912 LED913 LED914 LED915 Q901 Location H-1 C-3 B-3 C-3 B-13 C-13 C-13 F-13
(Page 29)
32
32
CDX-CA900/CA900X
3-15. SCHEMATIC DIAGRAM -- KEY SECTION -- · Refer to page 18 for Waveform.
R919
R918
C908 R903 R902
C906
C907
IC902
IC903
LED900
C910 R911 C904 C905 FB901 C909 C911 FB902 R912 C912 R910 X910
CN901 R904
R901
D920
C900
C902
R914 R915 R916 R917
R913 D910
R981 R982 LSW921(2/2) R933 R971 R973 LED912 R975 D974 LED910 LED914 C982 R983 C990 LED911 LED913 LED915 C991 C992 C993 R991 R992 R993 R994 LSW922(1/2) R921 LSW922(2/2) R922 R923 R972 LSW924(1/2) C901 D901 D902 D900 LSW924(2/2) LSW921(1/2) Q901 R924 R974 R976 R987 C983 R984 R985 R986 LSW923(1/2) R988 IC901 R990
(Page 28)
D972
LSW923(2/2)
C986
R979
R934
R980
LCD901
Note: · Voltage is dc with respect to ground under no-signal (detuned) condition. no mark : FM
33
33
CDX-CA900/CA900X
· IC BLOCK DIAGRAMS IC1 µPD63711GC-8EU
7D DAC2 7C DAC1 7E DAC3 7F DAC0 ATEST TEST1 TEST0
IC2 BA5810FP-E2
DGND
AGND
DVDD
AGCO
AVDD
PACK
TSCK
TSTB
EFM
ASY
TSO
C3T
MD
75
74
73
72
71
70
69
68
67
66
65
64
63
62
61
60
59
58
57
56
55
54
TSI
RFI
SD
TD
FD
FWD
1 LOADING PRE FWD REV X3 POWER SAVE
+
28 BIAS
53
52
51
REV
AGCI 76 RFO 77 EQ2 78 EQ1 79 RF- 80 AGND 81 A 82 C 83 TEOFS B 84 D 85 F 86 E 87 AVDD 88 REFOUT 89 FE- 90 DEFECT FEO 91 SWITCH DEFECT COMPARATOR EFM CLV PROCESSOR DIGITAL AUDIO INTERFACE D/A INTERFACE CIRCUIT DE-EMPHASIS CIRCUIT RF AMP BLOCK ADDER FEOFS SVDRAM MULTIPLIER SVROM SVCRAM ROM DECODER TIMING GENERATOR EFM DEMODULATOR DIGITAL PLL AUTO GAIN CONTROLLER FD/TD/SD/MD CONTROLLER EFM COMPARATOR EFM D/A MEMORY PROCESSOR 16K SRAM SUB-CODE PROCESSOR MICROCOMPUTER INTERFACE 50 C2D3
2
27 OPIN4+ 26 OPIN4
+
LDCONT PS IN1
3 4 5
ERROR CORRECTION PROCESSOR
CD-TEXT DECODER
49 C2D2 48 C2D1 47 C1D2 46 C1D1 45 DGND 44 PLCK 43 MIRR/WFCK 42 RFCK 41 LOCK 40 DVDD 39 TSOI 38 C16M 37 DGND 36 TX 35 HOLD/WDCK
7.5k
7.5k
IN2
6
16k
16k
PREVCC (PRE.LOADING)
7.5k
+
+
POWVCC12 (CH1.CH2)
16k
7.5k
PREVCC
7
16k
POWVCC
8
+
+
VOL
9
POWVCC34 (CH3,CH4) 20 POWVCC
VOL+ 10 10k 10k
10k
10k VO1 13 VO1+ 14 10k 10k
10k 10k LEVEL SHIFT 10k LEVEL SHIFT
+
10k 10k
+
A/D CONVERTER
OUTPUT PROCESSOR
TE- 92 TEO 93 TE2 94 TEC 95 AGND 96 PD 97 LD 98
FOK A3T MIRR FEO TEO
RFENV MIRENV TRACKING REGISTER FOCUS REGISTER
34 LRCK 33 LRCKIN
+
32 SCKO 31 SCKIN 30 DOUT 29 DIN 28 FLAG
10k
COMPARATOR
OCTUPLED OVERSAMPLING DIGITAL FILTER NOISE SHAVER NOISE SHAVER
OUTPUT BUFFER OUTPUT BUFFER PN 99 AVDD 100 MICROCOMPUTER INTERFACE SCF OSC 27 EMPH 26 DVDD
IC201 SAA6588T
SCOUT
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
XTALEN
DAGND
DAGND
DAVDD
DAVDD
DGND
ROUT
REGC
RFOK
DVDD
XVDD
XGND
LOUT
XTAL
XTAL
LVIN
20
19
18
17
MPX
16
15
14
13 PAUSE DETECTOR
12 11
MULTI PATH DETECTOR
POWER SUPPLY & RESET 57kHz 8th ORDER BAND-PASS FILTER SIGNAL QUALITY DECODER 4 CLOCK 5 4 CLOCK INTERFACE REGISTER DATA DATA
CLOCKED COMPARATOR
RDS/RDBS DEMODULATOR
RDS/RDBS DECODER
TEST CONTROL
OSCILLATOR & CLOCK
IIC BUS SLAVE TRANSCEIVER
1 2
MRO MPTH
3
TCON
4
OSCO
5
OSCI
6
VSSD
7
VDDD
8
DAVN
9
SDA
10
SCL
34
34
MAD PSWN
VSSA
VDDA
VREF
RST
STB
SCK
L
A0
R+
SO
R
L+
SI
CIN
AFIN
VO2+ 12
LEVEL SHIFT
+
+
VO2 11
LEVEL SHIFT
25 OPOUT4 24 OPIN3+ 23 OPIN3
22 OPOUT3
CH1-4 MUTE
21 MUTE
19 GND 10k
18 VO3 17 VO3+
+ + +
10k 10k 16 VO4 15 VO4+ 10k
CDX-CA900/CA900X
IC301 TDA7406
MIXINFL MIXINRL MIXINRR MIXINFR OUTSW OUTFR OUTRR SAOUT
23 MONO FADER CREF
33 32 31 30 29
28 27 MIXER
OUTFL OUTRL
ACINL
26 25
24
SOFT STEP FADER
SOFT STEP FADER
SOFT STEP FADER
SUPPLY
22 VDD
SUB WOOFER FILTER OUTPUT SELECTOR SWIN 34 ACIN-RCH 35
21 SACLK 20 SCL 19 SDA 18 GND
17 EXA-ATT ACOUT.RCH 36 SWACOUT 37 AC OUT.LCH 38 HIGH PASS
IIC-BUS
QUAL.
16 QUAL
A/D 7BAND EQUALIZER CREF 39 SOFT STEP VOLUME SOFT MUTE DIGITAL CONTROL HIGH OUT S&H 25kHz LP AM/FM NOISE BLANKER DEMODULATOR +STEREO ADJUST +STEREO BLEND BEEP IN GAIN + AUTO ZERO MULTI PATH DETECTOR 15 MP OUT 14 MP IN PULSE FORMER
LOUDNESS SPECTRUM ANALIZER
PILOT CANCELLATION PIL, DET PAUSE PLL 13 LEVEL (VSM)
MAIN SOURCE SELECTOR CD-RCH CD-LCH MD-RCH MD-LCH TAPE-LCH 40 41 42 43 44
MIXING SELECTOR
86kHz LP STD IN GAIN
INPUT MULTIPLEXER
12 MPX1
1 2 3 4 5
6 7 8
9
10
11
TAPE-RCH AUX-RCH PDAUX-LCH PAUSE
AM/MPX2
PHONE TIM NAVI
CMPX
AMIF
35
CDX-CA900/CA900X
IC601 BA8270F
BUS ON 1
BUS ON SWITCH RESET SWITCH BATTERY SWITCH
14 VCC
RST 2
BATT 3
13 12 11 10
RST BUS ON CLK IN B/U-C
CLK 4 VREF 5 DATA 6 I/O GND 7
9 DATA IN 8 DATA OUT
36
CDX-CA900/CA900X SECTION 4 EXPLODED VIEWS
NOTE: · The mechanical parts with no reference number in the exploded views are not supplied. · Items marked "*" are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. · -XX and -X mean standardized parts, so they may have some difference from the original one. · Color Indication of Appearance Parts Example : KNOB, BALANCE (WHITE) ... (RED) R R Parts Color Cabinet's Color · Accessories are given in the last of this parts list. · Abbreviation CND: Canadian model
Ver 1.1
The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. Les composants identifiés par une marque 0 sont critiques pour la sécurité. Ne les remplacer que par une piéce portant le numéro spécifié.
4-1. CHASSIS SECTION
20 9 18
#1 #1
11 10
19
#3 #1
MG-393XA-121//Q
8
12
#1
#1
4 12 3 1 2 7 5
#2 #1
6
17 13
#2
17 16 17
#2
15 14
#1
Ref. No. 1 2 3 4 5 6 7 8 9 9
Part No. X-3381-275-1 3-040-990-01 1-684-929-11 X-3376-699-6 3-030-909-03 3-713-786-51 X-3377-621-8 3-223-782-21 1-776-207-72 1-776-527-71
Description PANEL ASSY, SUB BUTTON (EJECT) SUB (CD) BOARD GEAR ASSY DAMPER, OIL
Remark
Ref. No. 12 * 13 14 15 16 17 18 19 20 #1 #2 #3
Part No. 3-376-464-11 3-224-755-01 3-223-781-21 1-792-195-11 3-047-812-01 3-042-244-01 3-240-185-01 3-046-626-01 3-240-187-01 7-685-790-01
Description
Remark
SCREW (+PTT 2.6X6), GROUND POINT SHEET, INSULATING CHASSIS CABLE, FLEXIBLE FLAT (14 CORE) (CN851) SCREW (LOCK) SCREW (T) HEAT SINK (MG393) SHEET, RADIATION SHEET, RADIATION SCREW +PTT 2.6X4 (S)
SCREW +P 2X3 LOCK ASSY COVER CORD (WITH CONNECTOR) (POWER) (US,CND,E) CORD (WITH CONNECTOR) (ISO) (POWER) (AEP,UK)
10 * 11
3-041-012-11 BRACKET (CD) 3-227-287-01 SHEET, DUST PROTECTION
7-685-792-09 SCREW +PTT 2.6X6 (S) 7-685-853-04 SCREW +BVTT 2X6 (S)
37
CDX-CA900/CA900X
Ver 1.1
4-2. MAIN BOARD SECTION
#5 #1 #7 #5 #5
58
55 54
#6 #6
#6
52 53
#6
TUX201 #4 F901
57 56
51
Ref. No. 51 51 52 * 53 * 54 * * * * 55 55 56 57
Part No. A-3274-217-A A-3274-218-A 3-240-186-01 3-040-998-01 3-223-783-21 3-223-780-11 3-223-780-21 3-045-878-01 3-045-877-02
Description MAIN BOARD, COMPLETE (AEP,UK,E) MAIN BOARD, COMPLETE (US,CND) HEAT SINK (REG) BRACKET (IC) CHASSIS (BACK) HEAT SINK (AEP,UK,E) HEAT SINK (US,CND) PLATE (TU), GROUND CUSHION (TU)
Remark
Ref. No. 58
Part No.
Description
Remark
1-790-355-54 CORD (WITH CONNECTOR) (RCA) (SUB OUT (MONO)) F901 1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE) 10A TUX201 A-3220-812-A TUNER UNIT (TUX-020) #1 7-685-790-01 SCREW +PTT 2.6X4 (S) #4 7-685-646-79 SCREW +BVTP 3X8 TYPE2 N-S #5 #6 #7 7-685-794-09 SCREW +PTT 2.6X10 (S) 7-685-793-09 SCREW +PTT 2.6X8 (S) 7-685-797-09 SCREW +PTT 2.6X16 (S)
38
CDX-CA900/CA900X
Ver 1.1
4-3. FRONT PANEL SECTION
113
not supplied (KEY board) #8
114
116 111 110
LCD901 #8
115 108
112 109 117 107 117 106 105
104
103 101 102
Ref. No. 101 101 102 103 104 105 106 107 108 109 110
Part No. A-3290-857-A A-3290-866-A X-3381-919-1 X-3381-895-1 3-037-267-01 3-240-181-01 X-3381-894-1 3-240-896-01 3-240-182-01 1-694-906-11
Description
Remark
Ref. No. 111 112 113 114 114 115 116 117 LCD901 #8
Part No. 3-240-183-01 3-242-548-01 X-3381-893-1 3-240-188-01 3-240-188-11 X-3378-490-2 3-241-287-01 3-242-829-01 1-804-654-11 7-685-106-19
Description
Remark
PANEL COMPLETE ASSY, FRONT (AEP,UK,E) PANEL COMPLETE ASSY, FRONT (US,CND) PANEL ASSY, FRONT BUTTON (OFF) ASSY SPRING (OPEN) BUTTON (OPEN) BUTTON (SOURCE) ASSY CUSHION (WINDOW) PLATE (LCD), GROUND CONDUCTIVE BOARD, CONNECTION
PLATE (LCD), LIGHT GUIDE SHEET (REFLECTOR) PANEL ASSY, FRONT BACK PLATE (FBP), ORNAMENTAL (AEP,UK,E) PLATE (FBP), ORNAMENTAL (US,CND) CASE (PANEL) ASSY (for FRONT PANEL) CASE (T), SHIELD CUSHION (SF) DISPLAY PANEL, LIQUID CRYSTAL SCREW +P 2X10 TYPE2 NON-SLIT
3-240-184-01 SHEET (ILLUMINATOR)
39
CDX-CA900/CA900X
4-4. CD MECHANISM SECTION (1) (MG-393XA-121//Q)
#9
151
#9
153
152
154 163 162
not supplied
161
not supplied
160
156
not supplied
C
159
157
not supplied
C
#10 M903
155
#11
158
#9
Ref. No. 151 152 153 154 155 156 157 * 158 159
Part No. A-3315-247-B 3-931-909-01 1-659-836-11 3-338-737-01 A-3315-040-A A-3283-270-A 1-683-666-11 3-039-629-02 3-225-784-01
Description CHASSIS (T.U) ASSY SPRING (LR), TENSION DISC IN BOARD SCREW (2X3), +PS ROLLER ASSY, ARM SERVO BOARD, COMPLETE PICK-UP FLEXIBLE BOARD BRACKET (MOTOR) SPRING (RA3), TENSION
Remark
Ref. No. 160 161 162 163 M903 #9 #10 #11
Part No. 3-933-152-03 3-931-913-11 1-659-837-11 3-338-737-01 A-3315-039-A
Description ROLLER (S) RING (ROLLER), RETAINING LOAD BOARD SCREW (2X3), +PS MOTOR SUB ASSY, LD (LOADING)
Remark
7-627-553-37 SCREW, PRECISION +P 2X3 TYPE3 7-627-553-17 SCREW, PRECISION +P 2X2 TYPE3 7-628-253-00 SCREW +PS 2X4
40
CDX-CA900/CA900X
4-5. CD MECHANISM SECTION (2) (MG-393XA-121//Q)
201
206 204 215
207 207
D
208 210 214
not supplied
212 216 213
216 205
203
211
D
209 202 202
202
Ref. No. 201 202 203 204 205 206 207 208
Part No. X-3378-956-8 3-931-897-61 3-039-627-01 3-040-165-02 3-014-727-01
Description ARM ASSY, CHUCKING DAMPER (T) LEVER (D) RETAINER (DISC) WHEEL (LW), WORM
Remark
Ref. No. 209 210 211 212 213 214 215 216
Part No. A-3315-243-D 3-220-180-01 3-931-881-03 3-931-882-02 3-007-537-11
Description CHASSIS (M) ASSY SPRING (TR2), TENSION LEVER (LOCK) GEAR (MDL) WHEEL (U), WORM
Remark
3-931-895-01 SPRING (CH), TENSION 3-931-898-01 SPRING (FL), COMPRESSION 3-032-483-02 SPRING (KF1), TENSION
3-039-626-01 LEVER (TR) 3-032-484-01 SPRING (KR1), TENSION 3-018-272-01 WASHER
41
CDX-CA900/CA900X
4-6. CD MECHANISM SECTION (3) (MG-393XA-121//Q)
251
M901
257 252
M902
258
261 262
253
#12
259 260 254
#9
255 256
#9
The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified.
Les composants identifiés par une marque 0 sont critiques pour la sécurité. Ne les remplacer que par une piéce portant le numéro spécifié.
Ref. No. 251 252 253 254 255 256 257 258
Part No. X-3381-611-1 3-043-494-01 3-040-170-01 3-040-419-01 A-3291-669-A
Description CHASSIS (OP) ASSY (including M901) SPRING (SL), TORSION BASE (DRIVING) GEAR (MIDWAY) SHAFT (FEED) ASSY
Remark
Ref. No. 259 0 260 261 262 M902 #9 #12
Part No. 3-909-607-01 8-820-103-11 1-659-835-12 3-338-737-01 A-3291-674-A
Description SCREW PICK-UP, OPTICAL KSS-720A/C-RP LIMIT BOARD SCREW (2X3), +PS MOTOR ASSY, SLED (SLED)
Remark
3-025-743-01 SPRING (FEED), LEAF 1-659-880-11 MOTOR FLEXIBLE BOARD 1-659-834-11 SUB BOARD
7-627-553-37 SCREW, PRECISION +P 2X3 TYPE3 7-627-850-28 SCREW, PRECISION +P 1.4X3
42
CDX-CA900/CA900X SECTION 5 ELECTRICAL PARTS LIST
NOTE: · Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. · -XX and -X mean standardized parts, so they may have some difference from the original one. · RESISTORS All resistors are in ohms. METAL:Metal-film resistor. METAL OXIDE: Metal oxide-film resistor. F:nonflammable · Abbreviation CND: Canadian model · Items marked "*" are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. · SEMICONDUCTORS In each case, u : µ, for example: uA.. : µA.. uPA.. : µPA.. uPB.. : µPB.. uPC.. : µPC.. uPD.. : µPD.. · CAPACITORS uF : µF · COILS uH : µH
DISC IN
The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified.
KEY
Les composants identifiés par une marque 0 sont critiques pour la sécurité. Ne les remplacer que par une piéce portant le numéro spécifié. When indicating parts by reference number, please include the board.
Ref. No.
Part No.
Description
Remark
Ref. No. D902 D910 D920 D972 D974
Part No. 8-719-067-40 8-719-404-50 8-719-420-90 8-719-977-03 8-719-422-94
Description DIODE DIODE DIODE DIODE DIODE STZ6.8N-T146 MA111-TX MA8051-M DTZ5.6B MA8091-L
Remark
1-659-836-11 DISC IN BOARD ************* < SWITCH > SW1 1-529-566-31 SWITCH, PUSH (1 KEY) (DISC IN) SW2 1-529-566-31 SWITCH, PUSH (1 KEY) (SELF) ************************************************************* KEY BOARD ********** 1-694-906-11 3-240-182-01 3-240-183-01 3-240-184-01 3-241-287-01 CONDUCTIVE BOARD, CONNECTION PLATE (LCD), GROUND PLATE (LCD), LIGHT GUIDE SHEET (ILLUMINATOR) CASE (T), SHIELD
< FERRITE BEAD > FB901 FB902 1-500-329-21 INDUCTOR, FERRITE BEAD 1-500-329-21 INDUCTOR, FERRITE BEAD < IC > IC901 IC902 IC903 6-701-630-01 IC LC75848T-E 8-759-830-18 IC RRX9000-0601#1 8-759-830-17 IC RRX9000-0401R#01 < LIQUID CRYSTAL DISPLAY >
3-242-548-01 SHEET (REFLECTOR) LCD901 1-804-654-11 DISPLAY PANEL, LIQUID CRYSTAL < CAPACITOR > < DIODE > C900 C901 C902 C904 C905 C906 C907 C908 C909 C910 C911 C912 C982 C983 C986 C990 C991 C992 C993 1-164-156-11 1-162-974-11 1-126-205-11 1-164-156-11 1-135-852-21 1-162-974-11 1-164-388-11 1-115-156-11 1-164-156-11 1-164-156-11 1-164-156-11 1-164-156-11 1-164-227-11 1-115-412-11 1-164-489-11 1-164-227-11 1-107-826-11 1-107-826-11 1-107-826-11 CERAMIC CHIP CERAMIC CHIP ELECT CHIP CERAMIC CHIP ELECT CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP < CONNECTOR > CN901 1-794-065-22 PLUG, CONNECTOR 14P < DIODE > D900 D901 8-719-078-81 DIODE DF5A6.8FU(TE85R) 8-719-083-85 DIODE UDZS-TE17-22B 0.1uF 0.01uF 47uF 0.1uF 22uF 0.01uF 270PF 1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.022uF 680PF 0.22uF 0.022uF 0.1uF 0.1uF 0.1uF 25V 50V 6.3V 25V 6.3V 50V 50V 10V 25V 25V 25V 25V 25V 25V 16V 25V 16V 16V 16V LED900 LED910 LED911 LED912 LED913 8-719-083-14 8-719-076-58 8-719-076-58 8-719-076-58 8-719-076-58 LED LED LED LED LED RRX9000-0501 NSSW440-BRS (LCD BACK LIGHT) NSSW440-BRS (LCD BACK LIGHT) NSSW440-BRS (LCD BACK LIGHT) NSSW440-BRS (LCD BACK LIGHT)
20% 20%
5%
LED914 8-719-076-58 LED NSSW440-BRS (LCD BACK LIGHT) LED915 8-719-076-58 LED NSSW440-BRS (LCD BACK LIGHT) < SWITCH > LSW921 LSW922 LSW923 LSW924 1-771-883-11 1-771-883-11 1-771-883-11 1-771-883-11 SWITCH, TACTILE (WITH LED) (OFF) SWITCH, TACTILE (WITH LED) (SOURCE) SWITCH, TACTILE (WITH LED) (VOL +) SWITCH, TACTILE (WITH LED) (VOL ) < TRANSISTOR >
10% 5% 10% 10% 10% 10% 10%
Q901
8-729-904-75 TRANSISTOR DTD114EK < RESISTOR >
R901 R902 R903 R904 R910 R911 R912
1-216-037-00 1-216-846-11 1-216-851-11 1-216-037-00 1-216-821-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
330 120K 330K 330 1K 1M 470
5% 5% 5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W
1-216-857-11 METAL CHIP 1-216-817-11 METAL CHIP
43
CDX-CA900/CA900X
Ver 1.1
KEY
Ref. No. R913 R914 R915 R916 R917 R918 R919 R921 R922 R923 R924 R933 R934 R971 R972 R973 R974 R975 R976 R979 R980 R981 R982 R983 R984 R985 R986 R987 R988 R990 R991 R992 R993 R994
LIMIT
Part No. 1-216-845-11 1-216-845-11 1-216-845-11 1-216-845-11 1-216-845-11 1-216-845-11 1-216-809-11 1-216-819-11 1-216-819-11 1-216-819-11 1-216-821-11 1-216-029-00 1-216-029-00 1-216-029-00 1-216-027-00 1-216-029-00 1-216-027-00 1-216-029-00 1-216-027-00 1-216-037-00 1-216-037-00 1-216-029-00 1-216-029-00 1-216-857-11 1-216-821-11 1-216-821-11 1-216-821-11 1-216-841-11 1-216-029-00 1-216-041-00 1-216-829-11 1-216-829-11 1-216-829-11 1-216-829-11
LOAD
Description METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP < VIBRATOR >
MAIN
Remark 100K 100K 100K 100K 100K 100K 100 680 680 680 1K 150 150 150 120 150 120 150 120 330 330 150 150 1M 1K 1K 1K 47K 150 470 4.7K 4.7K 4.7K 4.7K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W * * * * Ref. No. Part No. Description Remark A-3274-217-A MAIN BOARD, COMPLETE (AEP,UK,E) A-3274-218-A MAIN BOARD, COMPLETE (US,CND) ********************* 1-790-355-54 CORD (WITH CONNECTOR) (RCA) (SUB OUT (MONO)) 3-040-998-01 BRACKET (IC) 3-223-780-11 HEAT SINK (E) 3-223-780-21 HEAT SINK (US,CND) 3-223-783-21 CHASSIS (BACK) 3-240-186-01 7-685-646-79 7-685-790-01 7-685-793-09 7-685-794-09 HEAT SINK (REG) SCREW +BVTP 3X8 TYPE2 N-S SCREW +PTT 2.6X4 (S) SCREW +PTT 2.6X8 (S) SCREW +PTT 2.6X10 (S)
7-685-797-09 SCREW +PTT 2.6X16 (S) < CAPACITOR > C102 C103 C108 C109 C110 C111 C112 C113 C114 C115 C201 C202 C205 C206 C217 1-127-573-11 1-126-794-11 1-135-473-21 1-164-156-11 1-164-156-11 1-164-156-11 1-164-156-11 1-164-156-11 1-164-156-11 1-164-156-11 CERAMIC CHIP ELECT ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 1uF 4.7uF 3300uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 18PF 0.1uF 0.01uF 0.1uF 0.001uF 5% 10% 20% 20% 16V 25V 16V 25V 25V 25V 25V 25V 25V 25V 50V 25V 50V (US,CND) 25V 10% 50V (AEP,UK,E) 50V (AEP,UK,E) 10% 50V (AEP,UK,E) 10% 16V (AEP,UK,E) 5% 50V (AEP,UK,E) 0.5PF 50V (AEP,UK,E) 10% 10V (AEP,UK,E) 10% 16V (AEP,UK,E) 20% 16V 25V 20% 6.3V 25V (AEP,UK,E) 20% 6.3V (AEP,UK,E) 5% 50V (AEP,UK,E) 10%
1-162-918-11 CERAMIC CHIP 1-164-156-11 CERAMIC CHIP 1-162-974-11 CERAMIC CHIP 1-164-156-11 CERAMIC CHIP 1-162-964-11 CERAMIC CHIP
C218 C219 C220
1-162-964-11 CERAMIC CHIP 1-162-964-11 CERAMIC CHIP 1-107-826-11 CERAMIC CHIP 1-164-315-11 CERAMIC CHIP 1-162-915-11 CERAMIC CHIP
0.001uF 0.001uF 0.1uF 470PF 10PF
X910 1-781-646-21 VIBRATOR, CERAMIC (4MHz) ************************************************************* 1-659-835-12 LIMIT BOARD *********** < SWITCH > SW3 1-529-565-51 SWITCH, PUSH (1 KEY) (LIMIT) ************************************************************* 1-659-837-11 LOAD BOARD *********** < SWITCH > SW4 1-529-566-31 SWITCH, PUSH (1 KEY) (DOWN) *************************************************************
C221 C222
C223 C224 C225 C226 C227 C229 C230 C231
1-125-891-11 CERAMIC CHIP 1-165-176-11 CERAMIC CHIP 1-126-947-11 ELECT 1-164-156-11 CERAMIC CHIP 1-126-154-11 ELECT 1-164-156-11 CERAMIC CHIP 1-126-154-11 ELECT 1-162-920-11 CERAMIC CHIP
0.47uF 0.047uF 47uF 0.1uF 47uF 0.1uF 47uF 27PF
44
CDX-CA900/CA900X MAIN
Ref. No. C232 C233 C234 C235 C236 Part No. Description 27PF 0.1uF 0.1uF 330PF 2.2uF 5% 5% Remark 50V (AEP,UK,E) 25V (AEP,UK,E) 25V (AEP,UK,E) 50V (AEP,UK,E) 6.3V (AEP,UK,E) 50V (AEP,UK,E) 50V (AEP,UK,E) 50V 6.3V 6.3V 16V 25V 25V 10V 50V 16V 50V 25V 50V 50V 50V 50V 50V 50V 50V 50V 16V 10V 10V 10V 10V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 25V 50V 50V 25V 50V (US,CND) 10V 25V 25V Ref. No. C371 C372 C373 C374 C375 C378 C380 C381 C382 C383 C384 C385 C386 C387 C388 C389 C390 C393 C394 C400 Part No. 1-162-966-11 1-162-966-11 1-162-966-11 1-162-966-11 1-162-966-11 1-162-927-11 1-164-156-11 1-164-156-11 1-125-891-11 1-125-891-11 1-125-891-11 1-125-891-11 1-162-964-11 1-162-964-11 1-162-964-11 1-162-964-11 1-162-964-11 1-115-467-11 1-115-467-11 1-162-927-11 Description CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.0022uF 0.0022uF 0.0022uF 0.0022uF 0.0022uF 100PF 0.1uF 0.1uF 0.47uF 0.47uF 0.47uF 0.47uF 0.001uF 0.001uF 0.001uF 0.001uF 0.001uF 0.22uF 0.22uF 100PF 10% 10% 10% 10% 10% 5% Remark 50V 50V 50V 50V 50V 50V 25V 25V 10V 10V 10V 10V 50V 50V 50V 1-162-920-11 CERAMIC CHIP 1-164-156-11 CERAMIC CHIP 1-164-156-11 CERAMIC CHIP 1-162-959-11 CERAMIC CHIP 1-135-834-11 CERAMIC CHIP
Ver 1.1
10% 10% 10% 10% 10% 10% 10% 10% 10% 10% 10% 5%
C237 C241 C251 C252 C253 C254 C255 C302 C303 C304 C305 C306 C307 C308 C309 C310 C311 C312 C313 C314 C315 C316 C317 C318 C319 C320 C321 C322 C335 C336 C337 C338 C339 C340 C341 C342 C343 C344 C345 C346 C347 C361 C362 C363
1-164-739-11 CERAMIC CHIP 1-162-964-11 CERAMIC CHIP 1-162-968-11 CERAMIC CHIP 1-125-837-11 CERAMIC CHIP 1-125-837-11 CERAMIC CHIP 1-165-176-11 1-164-227-11 1-162-970-11 1-125-891-11 1-162-968-11 1-124-589-11 1-115-871-11 1-162-970-11 1-115-871-11 1-115-871-11 1-115-871-11 1-104-942-11 1-136-154-00 1-162-965-11 1-136-154-00 1-162-965-11 1-126-791-11 1-125-891-11 1-125-891-11 1-125-891-11 1-125-891-11 1-162-921-11 1-162-921-11 1-107-905-61 1-162-927-11 1-107-905-61 1-162-927-11 1-107-905-61 1-162-927-11 1-107-905-61 1-162-927-11 1-126-794-11 1-162-927-11 1-162-927-11 1-162-970-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT ELECT CERAMIC CHIP ELECT ELECT ELECT ELECT FILM CERAMIC CHIP FILM CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP ELECT CERAMIC CHIP ELECT CERAMIC CHIP ELECT CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
560PF 0.001uF
5% 10%
0.0047uF 10% 1uF 10% 1uF 10% 0.047uF 0.022uF 0.01uF 0.47uF 0.0047uF 47uF 1uF 0.01uF 1uF 1uF 1uF 1uF 0.012uF 0.0015uF 0.012uF 0.0015uF 10uF 0.47uF 0.47uF 0.47uF 0.47uF 33PF 33PF 4.7uF 100PF 4.7uF 100PF 4.7uF 100PF 4.7uF 100PF 4.7uF 100PF 100PF 0.01uF 0.01uF 0.47uF 0.1uF 0.1uF 10% 10% 10% 10% 10% 10% 20% 20% 10% 20% 20% 20% 20% 5% 10% 5% 10% 20% 10% 10% 10% 10% 5% 5% 20% 5% 20% 5% 20% 5% 20% 5% 20% 5% 5% 10%
50V 50V 10V 10V 50V (US,CND) 25V 6.3V 6.3V 10V 6.3V 50V 25V 25V 25V 25V
C401 C403 C406 C407 C408 C410 C501 C502 C503 C504 C505 C505 C506 C507 C508 C509 C510 C511 C512 C513 C514 C520 C521 C522 C523 C601 C602 C603 C604 C701 C702 C703
1-164-156-11 1-126-153-11 1-126-153-11 1-124-584-00 1-128-057-11 1-162-964-11 1-164-156-11 1-164-156-11 1-164-156-11 1-164-156-11
CERAMIC CHIP ELECT ELECT ELECT ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
0.1uF 22uF 22uF 100uF 330uF 0.001uF 0.1uF 0.1uF 0.1uF 0.1uF
20% 20% 20% 20% 10%
1-162-968-11 CERAMIC CHIP 1-165-176-11 CERAMIC CHIP 1-164-156-11 CERAMIC CHIP 1-164-315-11 CERAMIC CHIP 1-164-230-11 CERAMIC CHIP 1-162-921-11 1-162-917-11 1-162-964-11 1-135-834-11 1-164-156-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
0.0047uF 10% 0.047uF 0.1uF 470PF 220PF 33PF 15PF 0.001uF 2.2uF 0.1uF 100PF 0.047F 330uF 0.1uF 0.1uF 0.01uF 1uF 100PF 470uF 0.001uF 0.1uF 0.1uF
50V (AEP,UK,E) 10% 16V (US,CND) 25V 5% 50V 5% 50V 5% 5% 10% 50V 50V 50V 6.3V 25V
1-162-927-11 CERAMIC CHIP 1-125-701-11 1-128-057-11 1-164-156-11 1-164-156-11 1-162-974-11 1-125-837-11 1-162-927-11 1-126-935-11 1-162-964-11 DOUBLE LAYERS ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP
5%
50V (AEP,UK,E) 5.5V 20% 6.3V 25V 25V 50V 6.3V 50V 16V 50V 25V 25V
1-162-974-11 CERAMIC CHIP 1-125-891-11 CERAMIC CHIP 1-164-156-11 CERAMIC CHIP 1-164-156-11 CERAMIC CHIP
10% 5% 20% 10%
1-164-156-11 CERAMIC CHIP 1-164-156-11 CERAMIC CHIP
45
CDX-CA900/CA900X
Ver 1.1
MAIN
Ref. No. C704 C705 C706 C707 C708 C709 C710 C711 C712 C714 C715 C716 C717 C718 C722 Part No. 1-164-156-11 1-164-156-11 1-164-156-11 1-162-927-11 1-128-057-11 1-164-156-11 1-162-974-11 1-162-974-11 1-104-942-11 1-162-964-11 1-164-156-11 1-164-156-11 1-162-927-11 1-162-927-11 1-162-964-11 Description CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.1uF 0.1uF 0.1uF 100PF 330uF 0.1uF 0.01uF 0.01uF 1uF 0.001uF 0.1uF 0.1uF 100PF 100PF 0.001uF Remark 25V 25V 25V 50V 6.3V 25V 50V 50V 50V 50V 25V 25V 50V 50V 50V (US,CND) 50V 10V 10V 50V 50V 10V 25V 25V 25V 16V 6.3V 10V 16V 50V 50V 16V Ref. No. D302 D303 D304 D305 D306 D307 D308 D391 D501 D504 D505 D601 D603 D604 D605 D606 D607 D609 D610 D653 D654 D703 D708 D801 D802 D845 C808 C842 C843 C844 C847 C848 1-126-153-11 1-125-889-11 1-126-786-11 1-104-942-11 1-162-964-11 ELECT CERAMIC CHIP ELECT ELECT CERAMIC CHIP 22uF 2.2uF 47uF 1uF 0.001uF 10uF 20% 10% 20% 20% 10% 20% Part No. 8-719-200-82 8-719-200-82 8-719-200-82 8-719-200-82 8-719-200-82 8-719-200-82 8-719-200-82 8-719-017-58 8-719-801-78 8-719-404-50 8-719-422-41 8-719-404-50 8-719-017-94 8-719-420-51 8-719-083-85 8-719-083-85 8-719-801-78 8-719-422-64 8-719-404-50 8-719-820-05 8-719-404-50 8-719-083-85 8-719-083-85 8-719-420-14 8-719-067-56 Description DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE 11ES2 11ES2 11ES2 11ES2 11ES2 11ES2 11ES2 MA8068 1SS184 MA111-TX MA8051-L-TX (AEP,UK,E) MA111-TX MA8180 MA729 UDZS-TE17-22B UDZS-TE17-22B 1SS184 MA8062-M MA111-TX 1SS181 (AEP,UK,E) MA111-TX (US,CND) UDZS-TE17-22B UDZS-TE17-22B MA8082-M MA112-TX Remark
5% 20%
20% 10%
5% 5% 10%
C724 C726 C727 C801 C802 C803 C804 C805 C806 C807
1-162-964-11 1-125-891-11 1-125-891-11 1-162-974-11 1-162-974-11 1-124-584-00 1-164-156-11 1-164-156-11 1-164-156-11 1-126-157-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT
0.001uF 0.47uF 0.47uF 0.01uF 0.01uF 100uF 0.1uF 0.1uF 0.1uF 10uF
10% 10% 10%
20%
20%
8-719-404-50 DIODE MA111-TX < FERRITE BEAD >
1-126-157-11 ELECT < CONNECTOR >
FB201 FB230 FB231 FB400 FB401 FB402 FB501 FB701 FB702 FB703
1-414-813-11 1-414-813-11 1-414-813-11 1-414-813-11 1-414-813-11 1-414-813-11 1-414-813-11 1-414-813-11 1-414-813-11 1-414-813-11
FERRITE, EMI (SMD) FERRITE, EMI (SMD) (AEP,UK,E) FERRITE, EMI (SMD) (AEP,UK,E) FERRITE, EMI (SMD) FERRITE, EMI (SMD) FERRITE, EMI (SMD) FERRITE, EMI (SMD) FERRITE, EMI (SMD) FERRITE, EMI (SMD) FERRITE, EMI (SMD) < IC >
CN101 * CN301 CN401 CN601 * CN701
1-774-701-11 1-564-506-11 1-764-617-12 1-580-907-31 1-569-908-11
PIN, CONNECTOR 16P PLUG, CONNECTOR 3P PIN, CONNECTOR (PC BOARD) 30P PLUG, CONNECTOR (BUS CONTROL IN) SOCKET, CONNECTOR 14P < JACK >
CN201 CN302
1-815-185-12 JACK (ANTENNA) 1-774-700-11 JACK, PIN 6P (BUS AUDIO IN, AUDIO OUT REAR/FRONT) < DIODE >
IC201 IC202 IC301 IC304 IC305 IC361 IC381 IC501 IC501 IC502 IC601 IC701 IC702 IC801
8-759-492-59 8-759-100-96 6-701-403-01 8-759-832-29 8-759-832-29 8-759-530-28 8-759-827-14 6-801-609-01 6-801-610-01 8-759-828-22 8-759-449-89 6-801-611-01 8-759-277-63 6-702-050-01
IC IC IC IC IC IC IC IC IC IC IC IC IC IC
SAA6588T-118 (AEP,UK,E) uPC4558G2 (AEP,UK,E) TDA7406 NJM4580M-(TE2) NJM4580M-(TE2) TC4066BFT(EL,N) TA8268AH MB90574CPMT-G-367-BNDE1 (US,CND) MB90574CPMT-G-368-BNDE1 (AEP,UK,E) XC61CN4102MR BA8270F-E2 HD6432398A04FW TC7W14FU(TE12R) AN80T33
D101 D102 D105 D106 D107 D202 D203 D204 D300 D301
8-719-049-38 8-719-017-58 8-719-404-50 8-719-200-82 8-719-200-82 8-719-404-50 8-719-422-41 8-719-800-76 8-719-977-03 8-719-200-82
DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE
1N5404TU MA8068 MA111-TX 11ES2 11ES2 MA111-TX MA8051-L-TX 1SS226