Text preview for : Kenwood-SW505 actsub.pdf part of Kenwood SW505 active subwoofer
Back to : Kenwood-SW505 actsub.pdf | Home
POWER SUBWOOFER
SW-505D-S/505D-W
SERVICE MANUAL
© 2000-10/B51-5676-00 (K/K) 1907
Knob(VOLUME) Sensor lens Lens (K29-0586-08): B (B19-1289-08) (B19-1290-08) (K29-0591-08): W Button(POWER) Control panel (K29-0585-08): B (A21-3341-08): B (K29-0589-08): W (A21-3343-08): W
VOLUME CONTROL
POWER
ON/STANDBY
- ON OFF
PEAK INDICATOR
MIN
MAX
SLOPE
12dB 0 24dB
INPUT FROM AMPLIFIER
+ R - L +
MODE PHASE
MUSIC CINEMA CROSSOVER
LINE
L
NORMAL REVERSE
R
60Hz 200Hz
TO SPEAKERS
(MONO)
+ R - L +
OUTPUT
Grille ass'y (B06-1497-08): B (B06-1498-08): W
Lens (B19-1291-08) Knob(CONTROL) (K23-0542-08): B (K23-0546-08): W
AC power cord * (E30-)
Button(CONTROL) (K29-0587-08): B (K29-0588-08): W
B : Black W: White * Refer to parts list on page 9.
SPECIFICATIONS
Type ..........................Subwoofer system with built-in amplifier (Magnetically shielded)
[General]
Rated Power Consumption .............................................50 W Dimensions ....................................Width : 294 mm (11-9/16") Height: 457 mm (18") Depth: 415 mm (16-5/16") Net Weight .....................................................15.2 kg (33.5 lb)
KENWOOD follows a policy of continuous advancements in development. For this reason specifications may be Notes changed without notice. · Sufficient performance may not be exhibited at extremely cold locations (where water freezes).
[Amplifier]
Rated Output Power .........150 W RMS, 30 Hz ~ 200 Hz, 4 Phase Switching ....................................NORMAL, REVERSE Input Sensitivity & Input Impedance RCA-type pin-plug jack ..............................100 mV /12 k 200 mV /12 k (MONO Input) Push-type terminals ......................................1.7 V (15 k)
[Speaker]
Enclosure ...........................Bass-Reflex, Floor Standing Type Speaker Unit .....................................250 mm (10") Cone type Nominal Impedance ...........................................................4
70%
SW-505D-S/505D-W
CONTENTS / ACCESSORIES
Contents
SPECIFICATIONS ......................................Front cover CONTENTS / ACCESSORIES .................................. 2 ADJUSTMENT ............................................................2 PC BOARD ................................................................ 3 SCHEMATIC DIAGRAM ............................................ 5 EXPLODED VIEW ......................................................8 PARTS LIST................................................................9
Accessories
Pin-plug cord (1) (E30-5860-08) Remote control unit (1) (A70-0409-08)
REMOTE CONTROL UNIT RC-W0502 VOLUME POWER
Batteries (R03/ AAA)
AC plug adaptor (1) (E03-0115-05) * Use to adapt the plug on the power cord to the shape of the wall outlet. (Accessory only for regions where use is necessary)
MUSIC/CINEMA
PHASE
ADJUSTMENT
No. ITEM INPUT SETTINGS
OUTPUT SETTINGS
Connect a DC voltmeter to speaker terminal.
AMPLIFIER SETTINGS
VOLUME: 0
ALIGNMENT POINT
VR201
ALIGN FOR
FIG.
1
OFF SET
0 mV
2
A
B
C
D
E
F
G
H
I
J
PC BOARD (Component side view)
1
J225 R170 C152 C151 1 C127 R133 R132 C126 C150 C203 VR402 R203 R202 R201 C202 E C213 B R244 1 3 C201
CN01
J201 C210
Q212 R240
J202 R243 4
TR108
B R126 R171 R125 8 R108 E R130 R129 J105
D156
R102
J121
R207 R206
C102 C105 R107 C103 1 R109 8
D153
C101 C106 R114 C107 R128 R146 R143 R145 R144 1
TR101
B E 4
DZ202
D206 D205 D207 D208
J108
R219 Q204 B E
C208
J126 C100
C135
C120
11
1 E R162 E C141 R164 R142 R139 R163 R160 R161
D101 D103
J125 J124 J123 1
CN30
J114 J113 J112 J111 J110 J109 J117
TR107
B
C402 J501 C403
D151
D152
R226
J115
J116
R405
D216
R234
R233
D220
R404 VR401 C217
D218 D217
R235
R232 R231
J215
D219
D215
R228
R159
R236
J214
IC205
G O I C215
R245 J220 C219 J219 C220 J217 C237 J218
D371
C332
C331
X301 C320 C303 R318 R320 R316 R315 R331 J303 R321 R313 R312 R311 R310 R309 R308 R314 J304 J305 1
C316
C305
R323
D303
R324 J312 J313
TR311
J316
IC303
O 1 G I J325 J326
C317
R371
D226
C218
D225
C221
TR310
J317
30
CN2B 12 TR304
J336 J318 B E J320 R326 15 14
1
TR302
B B E E
B
O
I
D316 CN5 D315
J315 R301
J314
E
J324
J301 J302
J335
J319
D313 D314
J328
C313
S D G
S D G
S D G
S D G
Q210
4
Q209
Q208
Q207
IC301
J306
TR301
R322 1 2 J308 E B
J327 E
J330
D312 D311
J329
J322 J323
R370
R303
B R319 R317
TR309
E C304
CN3B
J321
C319 C370
CN4
1
3
J331 J332 R304 AC C310 AC
L205
L204
TR370
C371
D302
E
J309 J310 R330
J311
TR307
TR305
R306
R307
C312
B
4
C334
C330
TR308
TR306
C311
D310
R247
B
B
15
16
J307
D301
B
J221 C233 C225 C225-1 C224 C224-1 C236 L206 R241 C226 C230
E
E
R302
IC302 O G I D370 D317 CON28 CON29 CON31 D319
C309 1 2
CN7
J222
D309 D308 D306 D307 D304 D305
L207
CN12
J223 1 2 R250
C228
D222 D221
RELAY
C232
CON32
CON30
D223 D224
J224
C229
CON33
C231
5
POWER SW
5
VOLTAGE SELECTOR
3 1 F101 F102 3 TRANS 1 E CHANGE SW 3 K 1
CN05
CN04
3 1 4 1 1 3
POWER TRANSFORMER
CN03
6
4
2
C501
SW501
SW502 CN501
1 J506 J507 J508 J504 2
PT501
1 3 2 1 POWER SW 2 1 AC CORD
6
R503
R502
J505
15
14
D501
J503
LED504
J509 J510 E
R
J333
T301
SPEAKER
G
LED506
R501
LED503 CN3A LED505
R504 4 1
TR501
R505
AC CORD
7
B J511
LED502
C502
Refer to the schematic diagram for the value of resistors and capacitors.
3
C214
R332
R325 C318 B E
C314
G IC304
3
C216 J216
C315 C302
C234
B
C206
1
11
20
J213
D104
TR106
C401
12
IC204
R227
R403 R402 R401
Q203
B
C212 10
1
C209
E
J212
C211
Q202
D102
D213
B
J122
R406
R224
R115
CN401
CN31
SW402
C207 C227
E
C137
R155
D214
C125
C132
11
C140
J502
C109
J102 J101
J119 J118
C404
E
C128
R411
R225
C134
R119 R120
J107
R221 C238
J210
R223
J207
R100
B R147 E TR104 R148
R410
J208 D209
2
J120
J209
C129 C131
CN402
E
J106
R220
B
4
5
C139 R153
D154
DZ211
B
4
4 C133
5
B
E R121 R122
R137
R208 R222 R217
IC101
C406
D210
C235
Q211
C405
E
B
C142
R210 R230
IC105
R117 R116 R118 C110 TR103
R156
TR105
4
5
TR102
9
1
VR201
J206
IC401
1
R215 R214 R213 R212 R211
R216
IC104
R246
8
R149 R152 R154 R151 R150
IC102
5
C111
C121 R124 R123
C122 R127
D155
1 8
R140 J103 R138 R135 R134 C130 R136
DZ212
R105 R106
R104 R103
R101 C104
R112 R113 R111 R110
C138
4
5
R141 3 1
J203
4
1
R205
J204
IC103
R204 J205
C156
C155
C154
C153
8
R242 4
J211 1 C204
DZ201 IC203
5 8
1
1
IC202
5 C205 8 5
IC201
8
CN6
4
A
B
C
D
E
F
G
-12.4V
H
I
+12V R230
J
C233 1000u80 +
1 C128 10u16 + R134 10K R135 10K R136 47K C129 1u50 +
R210 3.3K
Q204
R246 470
0V
IC104 (2/2) 0V
5 6 4 7 R138
3 SLOPE GND CROSS OVER GND
C235 1u50 +
1
C130 10u16 +
R140 1K
C142 10u16 +
D210 D209
2 11 10 9 8 7 6 C401 10u16 5 + 4 3 2 1
CN401
Q211
+12V
R405
VR401:CROSS OVER VR402A
B
C236 0.1
R139 R137 470K 6.8K
VR401A 10K(C)
-24dB -12dB FLAT
VR402B
C402 10u16
C403 10u16
C404
0.27
4
-12.4V
B +B +B 1 C127 R133 27K 0.15 2 3
VR401B 10K(C)
CN6 D105
R403 47K
R404 47K
R402 47K
R401
47K
R247 3.3K
TR102
SW402
-5.1V
SLOPE
R141 100K
4.3K
R406
4.3K
0V
10K
10K
CN05
D213
+
+
VOLUME
D106
11.8V
+12V R213 3.9K
R214 C205 220P 10K R215 4.7K
+12V
R132 27K
C204 10u16 + R211
2.2K
IC401
5 6 8 7
IC104 (1/2)
0V
R142 1K 3 2 1
0V 0V
5
8 4
D206 D207
D205 D208
4 IC202
+B
IC103 (2/2)
0.082 8 9 C126
C405 0.01
C125 0.18
0V
5
CN31
1 C150 2 3 4 5 5 6 7 R130 8 9 8 9 10 11 1 2 3
C406 100u16 + 5.6V
IC201 (2/2)
3 2
(2/2)
1
2
3
5
6
8
4
7
M
4
9
PT501
GND OUT 5V
R207 10K
+12V
DZ211
+B R115 1K C110 10u16 + R116 47K 5 6 R123 1.5K R124 C111 47u16 R125 + 2.2K 1K
0.1
CN402
IC401 : BA6208
1
IC102 (2/2)
8 4 7 C121 1u50 + R127 1K C122 1u50 + R129 10K
DZ201 DZ202 R208
1K 3 2 R201 4.7M R202 C202 1K 470P 4
0V
IC103 (1/2) 0V
3 2 4 1
C501 100u6.3 +
TR101 TR103
B +B R120 R119 33K 1K R117 470
CN01
1 2 3
R243 2.2K R244 100K C213 R240 6.8K
C502 R505 10u16 1K +
-12.4V
R121
0V
1K
TR501
5.6V
6.8K
3
TR108
R108 8.2K B R126 6.8K
PHASE SW501 LED505 R503
11.9V
+B +12V R204 10K C234 100u25 + R242 10K C201 10u16 +
R118
R122
10K
47K
NORMAL LED506 R504
REUERS LED502 R502
LED501 R501
220
150
220
150
CINEMA
POWER LDE504
LDE503
MUSIC
MODE SW502
CN04
1 3 1 2 3
18.9V
0.068
TR105
+B
Q212
C203 R203 10u16 10K +
DZ212
1 2 3
4
+12V
CN3A
D501
IC203 (1/2)
8 1 R205 1K
R224 470K R225 470K
2
3
IC205
IN OUT GND 0.1
IC202 (1/2)
3 2 1
D221
C232 1000u25 + C214
PEAK
D222
C231 0.01
C131 47u16 + C132 47u16 +
R146 10K
R143 47
D109
1 2 3 4 5 6 7 8 9 7 +B R149 10K +B
R145 10K
CN30
IC105 (1/2)
3 2 8 4 1 R147 100
D110
C135 47u16 +
C133 10u16 +
R144 10K
4
C134 10u16 R128 + 4.7K
C120 10K 47u16 +
5.6V
R148
CN501/ CON33
1 2 3
4
5
6
7
8
9
10 11
12 13 14 15
D223
B +B
11.8V
CON32/ CN3B
+B B
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15
1
2
3 4
CN5
-12.4V
11 10 12 13 +B 26 20 27 25 18 24 19 21 B
IC301 IC302 IC303 IC304
: : : :
KSS57P0504N MC7805 KA7812L KA7912L
C210 10u16 +
B +B
B +B
D224
TR301,302 TR304,306,308,310 TR305,307,309,311 TR370
: : : :
DTA114ES DTC114ES KTC3198Y KTA1023Y
10.2V 5.6V
C139 10u16 + +B
C138 10u16 + TR106
TR107
5.0V
+B B +B +B +B +B
11.8V
R152 47K
10 11 12 11 12
R150 10K R151 1.5K
IC105 (2/2)
5 6 8 7 R154 100
C140 1u50 +
-5.1V
R162 1K R160 33K R159 1K
0V
5.6V
+B C332 0.1 +B
D303
5.6V
R153 10K
TR104
R155 220
IC301
1 30 29
5.6V
R161
R163 33K
R164
C141 22u16 +
47K
47K
+B
B +B
10.2V
12 7
5.0V
11
X301 4MHz
CN2B
1 B
-12.4V
+B
C303 33P C320
4.9V 0V 0V
R324 100 R323 100
2.4V 2 2.4V
3 4
+B
28 27 26 25
14.6V
27
R332 100
5
D102
+B
D103
11.2V
B R103 100K C101 10u16 + C103 100P
2 3
+B 4 C331 0.01 5
4.9V 10.2V
26
0.6V
33P R314 10K
D101 T101
2200P R101 C153
D104
5 4
-12.4V
C137 10u16 +
4 5 6 7 8 9 10 11 12 +B 19 22 21
IC101 (1/2)
3 2 8 1
12 R320 R318 12K 82K R315 10K C304 1u50 +
0V 5
R316 47K
4.8V
24
6 R109 20K
7 C109 47u16 + C108 47u16 +
TR307
+B R331 100 R321 10K
180 R301 180
25
5.5V
C318 10u16 +
1K
-11.8V
R322
R325
TR310
13
TR302
0V
TR311
5
R303 270
R302 22 1W
11.7V
4.7K
L INPUT
4.6V 6
TR301
24 +B
5.6V
IC302
13.1V
T301 SUB TRANS
D304
C310 1000u16 +
D311
0.01
2200P
R370
2200P R102
4.7K
R100 12K
OUTPUT
D370
2200P
C156
6
R106 100K
11
10K R312 10K R311 TP201 TP202
4.9V 9
22
D371
22
4
R304
D309
L
0V
10
270 -11.9V
C309 100u16 +
4.9V 10 4.9V 11
5.0V 11.8V
21 5.0V 21 C314 470u25 + 21 20 19 19 18 R326 2.2K B C317 10u16 + GND OUT IN +B C316 10u16 + OUT IN GND
IC303
20.0V
C151
R110
100K
C313
C152
100K
R170
4700P R111
10K
0V 13 0V 14 4.9V
15
J101
18 0.2V 17 16 4.9V R330 100
100
TR306
R319 10
R308 10K
C315 470u25 +
L
R113
19 4.9V
10K
D315 D316
-12.4V 0.6V
R306
-21.0V
TR308 IC101-104 : BA4558N IC105 : LM393 TR101,103,104,106,107 : DTA114ES TR102,105,108 : 2SC2874 D101-106,109,110 : 1N4148
+B B
C305 0.047F5.5 +
TR305
R307 3.3K
IC304
C319 2.2u50 +
C334 0.01
7
SIGNAL LINE GND LINE B LINE B LINE
0V
22K
0.01
LINE (MONO)
4700P
R
R112 10K C104 10u16 +
IC102 (1/2)
3 2 1
10.2V
10K R310 10K R309
D313 D314
4.9V 12
20 0.2V
D317
R
4.9V
R313
-10.0V
C312 100u16 +
10K
C155
D312
100P
C370 2.2u50 +
5.0V 8
D308
R105 100K
C102 10u16 +
C105 100P
C107
C106 100P
10K
R
TR309
D302
23
TR370
D310
C154
R317
R107 12K
4.9V 7
C311 10u16 +
R104 100K
IC101 (2/2)
R114 33K
C333
5.0V
OUT IN GND
D305
TR304
4.9V
0.6V
D306 D307
-5.5V
0.1
IC201 (1/2)
R220
3.3K C227
2
0V
PT501 : RPM-6938CBR-L TR501 : KTC3198Y D501 : 1N4148 LED501-503,505,506 : B30-1835-08 LED504 : B30-1836-08
6
7
R212 2.2K
B +B
6 5
8
7
R221 15
+12V
K
L
M
N
O
R223 2.2K
Q203
R228 3.9K R227 2.2K C209 1u50 +
Q202
WOOFER
L204 C224-1 L206 C226 R241 0.47 33 1 C230 1/2W 2 3 0.22 1 C229 0.22
DTA114ES DTA124ES DTC114ES
C211 C221 0.22
CN03
D225
C220 0.22
C217 2200P
C215 0.22
12.4V
C219
470P C224 1 L205
L207 C225-1 1 C228 0.22
C216 1
IC204
1 2 3 BHB HEN DIS BHS BHO 20 19
Q207
C218 1
D226
D215
R231 15
470P C225 1
UPC4570C
IC201 IC202 IC203 IC204 IC205 Q202 Q203 Q204 Q207-210 Q211 Q212 : LM393 : uPC4570 or LM393 : uPC4570C : HIP4080A : KA7812 : : : : : : KTC3198Y KTA1023Y DTA124ES IRF540 DTC114ES 2SC2874
R232
Q210
D216
D217
R233
3.3
VSS OUT IN+
5 6
BLO BLS VDD VCC ALS
18 17 16 15 14 13 12 C238 0.1 +12V C207 10u25 +
Q209
0.1 3W C237 2200P R245
15
11.9V
Q208
D218
R234 15 R235 3.3 R236 15
C208 1000P R222 43K
7 8 9 10
INHDEL LDEL AHB
R226 4.7K
4
ALO AHS
+12V
D220 D214
C212 0.22
C206 1000P R217 +12V 47K R216 2.2K 7 6 5 R206 2.2K
IC203 (2/2)
OFFSET
AHO
11
VR201 10K(B)
4.7K 1/4W
BA4558N
D219
R219
DZ201,202,211,212 : MTZJ3.3B D205-210 : 1N4148 D213-220,225,226 : EL1Z D221-224 : 1N4001
D301 : KBL10 D302,310,317,319,370,371 : 1N4148 D303-309,313-316 : 1N4001 D311,312 : MTZJ10B
MAIN TRANS 1 3
D301
R371 C302 100 4700u80 +
CAUTION: For continued safety, replace safety critical components only with manufacturer's recommended parts (refer to parts list). indicates safety critical components. For continued protection against risk of fire, replace only with same type and rating fuse(s). To reduce the risk of electric shock, leakage-current or resistance measurements shall be carried out (exposed parts are acceptably insulated from the supply circuit) before the appliance is returned to the customer.
L1 C330 0.1 2 L2 1
CN7
2 1
CN12
2 2 1 1
The DC voltage is an actual reading measured with a high impedance type voltmeter with no signal input. The measurement value may vary depending on the measuring instruments used or on the product.
DESTINATION F101 F102 T301 SW2 COUNTRY ABB. U.S.A. K NO NO CANADA P Y PX YES L07-3036-08 YES GENERAL M YES MARKET NO EUROPE E L07-3037-08 NO
D319
F102 T1.25AL 250V 3 RELAY1 2 F101 T2.5AL 250V RELAY2 1
TRANS
3 2 1
CHANGE_SW 220-240V
3 2 1 3 2 1 110-120V SW2
POWER_SW
2 1 2 1
POWER SW1
AC_CORD
2 1 2 1 BN BL (K,P) : AC120V 60Hz (Y,M) : AC110-120V/ 220-240V~ 50/60Hz (E) : AC230V~ 50Hz
CN4
3 2 1 3 2 1
SW-505D-S/505D-W
SW-505D
Y19-5880-20
SW-505D-S/505D-W
8
A B C 1
A B C D E F G H J K L M 3x8 (BLK) 3x10 (BLK) 4x18 (BLK) 4x14 (BLK) M4x18 (BLK) 4x12 (BLK) 3x6 (BLK) 2.6x8 (BLK) M4 M3x10 (BLK) M3 3x12(BLK) :N50-3008-45 :N50-3010-45 :N50-4018-45 :N50-4014-45 :N50-4018-45 :N30-4012-45 :N50-3006-45 :N50-2608-45 :N11-0040-46 :N30-3010-45 :N11-0030-45 :N50-3012-45
606
620
762x2 703 737
Bx2 Bx2 Bx2 Bx2
621
601
760
622
Ax2 761 Ax2 Dx4 Ex12
623
H
623 612 SW1 604 611
Hx2
EXPLODED VIEW (UNIT)
Hx2 772 775x2 760x2 773
Fx2
Gx2 Gx2 Gx2
SW2
M.Y only
Lx2
Mx3
Kx2 Fx2 Gx2 Gx2 Gx2 736 736 Gx2 735
Parts with exploded numbers larger than 700 are not supplied.
G 736 739 736 736
647 613 645 648 646x2 SP1
Gx2 Gx2 Cx2 775x2 770 736 736
735 Gx2
605
624
742 Gx4
740
Jx2
730
2
Cx2
Cx2
650
Jx2
Gx2
738
T301
610 624
Ax2
602
771
623
Gx2 Ax2 774 741 Gx2 Gx2
SW-505D
SW-505D-S/505D-W
9
New Parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohne Parts No. werden nicht geliefert. Ref. No Add- New ress Parts Parts No. Description Destination
1
Remarks
New Parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohne Parts No. werden nicht geliefert. Ref. No C103 C104 C105-7 C108 C109 C110 C111 C120 C121,2 C125 C126 C127 C128 C129 C130 C131,2 C133,4 C135 C137-9 C140 C141 C142 C150 C151,2 C153-6 C201 C202 C203,4 C205 C206 C207 C208 C209 C210 C211,2 C213 C214 C215 C216 C217 C218 C219 C220 C221 C224-1 C224,5 C225-1 C226 C227 C228,-30 C231 C232 C233 C234 C235 L : Scandinavia Y : PX(Far East,Hawaii) Y : AAFES(Europe) Add- New ress Parts Parts No. CK45FB1H101K CE04CW1C100M CK45FB1H101K CE04CW1C470M CE04CW1C470M CE04CW1C100M CE04CW1C470M CE04CW1C470M CE04CW1H010M C91-0213-08 C90-5132-08 C90-5133-08 CE04CW1C100M CE04CW1H010M CE04CW1C100M CE04CW1C470M CE04CW1C100M CE04CW1C470M CE04CW1C100M CE04CW1H010M CE04CW1C220M CE04CW1C100M CK45FB1H104K CK45FF1H472Z CK45FB1H222K CE04CW1C100M CK45FB1H471K CE04CW1C100M CK45FB1H221K CK45FB1H102K CE04CW1E100M CK45FB1H102K CE04CW1H010M CE04CW1C100M C90-5135-08 C90-5136-08 CK45FB1H104K C90-5135-08 C90-5137-08 CK45FB1H222K C90-5137-08 CK45FB1H471K C90-5135-08 CK45FB1H471K C90-5137-08 C90-5137-08 C90-5137-08 C90-5138-08 CK45FB1H104K C90-5135-08 CK45FB1H103K CE04DW1E102M C90-5139-08 CE04CW1E101M CE04CW1H010M P : Canada E : Europe Q : Russia CERAMIC ELECTRO CERAMIC ELECTRO ELECTRO ELECTRO ELECTRO ELECTRO ELECTRO FILM FILM FILM ELECTRO ELECTRO ELECTRO ELECTRO ELECTRO ELECTRO ELECTRO ELECTRO ELECTRO ELECTRO CERAMIC CERAMIC CERAMIC ELECTRO CERAMIC ELECTRO CERAMIC CERAMIC ELECTRO CERAMIC ELECTRO ELECTRO FILM FILM CERAMIC FILM FILM CERAMIC FILM CERAMIC FILM CERAMIC FILM FILM FILM FILM CERAMIC FILM CERAMIC ELECTRO ELECTRO ELECTRO ELECTRO R : Mexico G : Germany H : Korea Description 100PF 10UF 100PF 47UF 47UF 10UF 47UF 47UF 1.0UF 0.18UF 0.082UF 0.15UF 10UF 1.0UF 10UF 47UF 10UF 47UF 10UF 1.0UF 22UF 10UF 0.10UF 4700PF 2200PF 10UF 470PF 10UF 220PF 1000PF 10UF 1000PF 1.0UF 10UF 0.22UF 0.068UF 0.10UF 0.22UF 1UF 2200PF 1UF 470PF 0.22UF 470PF 1UF 1UF 1UF 0.47UF 0.10UF 0.22UF 0.010UF 1000UF 1000UF 100UF 1.0UF C : China V : China(Shanghai) M : Other Areas K 16WV K 16WV 16WV 16WV 16WV 16WV 50WV 63WV 63WV 63WV 16WV 50WV 16WV 16WV 16WV 16WV 16WV 50WV 16WV 16WV K Z K 16WV K 16WV K K 25WV K 50WV 16WV 250WV 250WV K 250WV 250WV K 250WV K 250WV K 250WV 250WV 250WV 250WV K 250WV K 25WV 80WV 25WV 50WV I : Malaysia Destination
2
Remarks
SW-505D W:WHITE/B:BLACK
601 601 602 604 604 605 605 605 605 606 610 610 611 612 613 620 621 622 622 622 623 624 645 645 646 646 647 647 648 648 650 650 SP1 SW1 SW2 1A 1A 2B 1A 1A 2C 2C 2C 2C 1B 2A 2A 1A 1A 1A 1B 1B 1C 1C 1C 1A,2A 2A,2B 1A 1A 2A 2A 1A 1A 2A 2A 2B 2B A02-2538-08 A02-2541-08 A02-2539-08 A21-3341-08 A21-3343-08 A23-5507-08 A23-5508-08 A23-5509-08 A23-5510-08 A70-0409-08 B06-1497-08 B06-1498-08 B19-1289-08 B19-1290-08 B19-1291-08 E03-0115-05 E30-5860-08 E30-5863-05 E30-5864-05 E30-5865-05 E36-0367-08 E36-0368-08 K29-0587-08 K29-0588-08 K23-0542-08 K23-0546-08 K29-0585-08 K29-0589-08 K29-0586-08 K29-0591-08 L07-3032-05 L07-3035-05 B46-0310-03 B46-0328-03 B46-0347-03 B59-1104-00 B61-1083-10 B61-1084-00 H10-8176-08 H10-8177-08 H10-8189-08 H10-8190-08 H51-1527-08 H51-1528-08 T10-0962-05 S90-0203-08 S62-0214-08 CONTROL BOX CONTROL BOX AMP BOX CONTROL PANEL CONTROL PANEL BDCC-0006-01 BDCC-0007-01 BDCC-0003-01 BDCC-0004-01 BDCC-0005-01 B W B W KP Y M E B W
CHASSIS/REAR BCCS-0571-01 CHASSIS/REAR BCCS-0572-02 CHASSIS/REAR BCCS-0572-01 CHASSIS/REAR BCCS-0571-02 REMOTE CONTROL GRILLE ASSY GRILLE ASSY SENSOR LENS BDDS-0111-01 POWER/PEAK LENS,BDDS-0110-01 CINEMA/NORM LENS,BDDS-0112-01 AC PLUG ADAPTER AUDIO CORD POWER CORD WPLU-HPC30008 POWER CORD WPLU-HPC30007 POWER CORD WPLU-HPC30005 CARD CABLE WFCB-FPC01503 CARD CABLE WFCB-FPC01504 CONTROL BUTTON BDBT-0015-01 CONTROL BUTTON BDBT-0014-01 CONTROL KNOB BDKN-0020-01 CONTROL KNOB POWER BUTTON POWER BUTTON VOLUME KNOB VOLUME KNOB BDKN-0021-01 BDBT-0012-01 BDBT-0013-01 BDKN-0018-01 BDKN-0019-01
M KP Y ME
PARTS LIST
B W B W B W B W KPMY E E KY P Y KPE YM
MAIN TRANS TTG2-EPT60010 MAIN TRANS TTG2-EPT60011 WARRANTY CARD WARRANTY CARD WARRANTY CARD SERVICE STATIONS' LIST INSTRUCTION MANUAL INSTRUCTION MANUAL POLYSTYRENE FIXTURE,TOP,FRNT POLYSTYRENE FIXTURE,BTM,FRNT POLYSTYRENE FIXTURE,TOP,REAR POLYSTYRENE FIXTURE,BTM,REAR ITEM CARTON CASE ITEM CARTON CASE WOOFER POWER SWITCH SLIDE SWITCHT ESPP-KDCA04 ESSL-SSB040
2A 1A 1C
KPYE M
MY
ELECTRICAL PARTS
LED501-3 LED504 LED505,6 C101,2 L : Scandinavia Y : PX(Far East,Hawaii) Y : AAFES(Europe) B30-1835-08 B30-1836-08 B30-1835-08 CE04CW1C100M K : USA T : England X : Australia P : Canada E : Europe Q : Russia LED LED LED ELECTRO R : Mexico G : Germany H : Korea SDLB-SLR34V3 SDLB-SPR39MV SDLB-SLR34V3 10UF C : China V : China(Shanghai) M : Other Areas 16WV I : Malaysia indicates safety critical components .
K : USA T : England X : Australia
indicates safety critical components .
SW-505D-S/505D-W
Note: Component and circuit are subject to modification to insure best operation under differing local conditions. This manual is based on Europe (E) standard, and provides information on regional circuit modification through use of alternate schematic diagrams, and information on regional component variations through use of parts list. P.O BOX 22745, 2201 East Dominguez St., Long Beach, CA 90801-5745, U.S.A.
New Parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohne Parts No. werden nicht geliefert. Ref. No C236 C237 C238 C302 C303 C304 C305 C309 C310 C311 C312 C313 C314,5 C316-8 C319 C320 C330 C331 C332 C333,4 C370 C401-3 C404 C405 C406 C501 C502 CN3B CN501 CON32,3 J101 T101 F101 F102 L1 ,2 L204,5 L206,7 T301 T301 X301 R241 R245 R302 VR201 VR401 VR402 RELAY SW402 SW501,2 D101-6 D109,10 D151-6 L : Scandinavia Y : PX(Far East,Hawaii) Y : AAFES(Europe) Add- New ress Parts Parts No. CK45FB1H104K CK45FB1H222K CK45FB1H104K C90-5140-08 CC45FCH1H330J CE04CW1H010M C90-5141-08 CE04CW1C101M CE04CW1C102M CE04CW1C100M CE04CW1C101M CK45FB1H103K CE04KW1E471M CE04CW1C100M CE04CW1H2R2M CC45FCH1H330J CK45FB1H104K CK45FB1H103K CK45FB1H104K CK45FB1H103K CE04CW1H2R2M CE04CW1C100M C90-5142-08 CK45FB1H103K CE04CW1C100M CE04CW0J101M CE04CW1C100M E41-0502-08 E41-0502-08 E41-0502-08 E63-0205-08 E70-0205-08 F53-0224-08 F53-0223-08 L90-0404-08 L90-0405-08 L90-0406-08 L07-3036-08 L07-3037-08 L71-0102-08 RD14BB2H330J RS14GB3F0R1K RD14BB3A220J R32-0403-08 R31-0420-08 R31-0421-08 S76-0209-08 S60-0203-08 S70-0204-08 1N4148 1N4148 1N4148 K : USA T : England X : Australia P : Canada E : Europe Q : Russia CERAMIC CERAMIC CERAMIC ELECTRO CERAMIC ELECTRO BACKUP C ELECTRO ELECTRO ELECTRO ELECTRO CERAMIC ELECTRO ELECTRO ELECTRO CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC ELECTRO ELECTRO FILM CERAMIC ELECTRO ELECTRO ELECTRO FPC CONNECTOR FPC CONNECTOR FPC CONNECTOR RCA JACK SCREW TERMINAL FUSE 2.5A FUSE 1.25A Description 0.10UF 2200PF 0.10UF 4700UF 33PF 1.0UF 0.047F 100UF 1000UF 10UF 100UF 0.010UF 470UF 10UF 2.2UF 33PF 0.10UF 0.010UF 0.10UF 0.010UF 2.2UF 10UF 0.27UF 0.010UF 10UF 100UF 10UF K K K 80WV J 50WV 5.5WV 16WV 16WV 16WV 16WV K 25WV 16WV 50WV J K K K K 50WV 16WV 63WV K 16WV 6.3WV 16WV Destination
3
Remarks
New Parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohne Parts No. werden nicht geliefert. Ref. No D205-10 D213-20 D221-4 D225,6 D301 D302 D303-9 D310 D311,2 D313-6 D317 D319 D370,1 D501 DZ201,2 DZ211,2 IC101-4 IC105 IC201 IC202,3 IC204 IC205 IC301 IC302 IC303 IC304 IC401 PT501 Q202 Q203 Q204 Q207-10 Q211 Q212 TR101 TR102 TR103,4 TR105 TR106,7 TR108 TR301,2 TR304 TR305 TR306 TR307 TR308 TR309 TR310 TR311 TR370 TR501 Add- New ress Parts Parts No. 1N4148 EL1Z 1N4001 EL1Z KBL10 1N4148 1N4001 1N4148 MTZJ10B 1N4001 1N4148 1N4148 1N4148 1N4148 MTZJ3.3B MTZJ3.3B BA4558N LM393 LM393 UPC4570C HIP4080A KA7812 KS57P0504N MC7805 KA7812L KA7912L BA6208 RPM-6938CBR-L KTC3198Y KTA1023Y DTA124ES IRF540 DTC114ES 2SC2874 DTA114ES 2SC2874 DTA114ES 2SC2874 DTA114ES 2SC2874 DTA114ES DTC114ES KTC3198Y DTC114ES KTC3198Y DTC114ES KTC3198Y DTC114ES KTC3198Y KTA1023Y KTC3198Y DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE ZENER DIODE DIODE DIODE DIODE DIODE DIODE ZENER DIODE ZENER DIODE IC(OP AMP X2) IC IC IC(OP AMP X2) Description SDFB-EL1Z SDFB-EL1Z Destination
4
Remarks
PARTS LIST
IC IC IC IC IC IC IC(MOTOR DRIVER) IC TRANSISTOR TRANSISTOR TRANSISTOR FET TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
HFPC-8370-157 HFPC-8370-157 HFPC-8370-157 JJR2-JE020059 FTS8-PPT00803 FFAD-CUL522R5 FFAD-CUL521R2 KPMY MEY
KENWOOD SERVICE CORPORATION
14-6,Dogenzaka 1-chome, Shibuya-ku, Tokyo, 150-8501 Japan
2C 2C
MOIDED TYPE COIL,ICCM-EMI1630 COIL ICCR-ERC02704 COIL ICCR-ERC01802 SUB TRANS TTG2-EPT60012 SUB TRANS TTG2-EPT60013 CRYSTAL,4MHZ RD FL-PROOF RS RD TRIMMING POT POTENTIOMETER EXVB-4R000 33 J 1/2W 0.1 K 3W 22 J 1W RSVB-CET68103 RVRM-SBR2060
KPYM E
POTENTIOMETER RVRM-SBR2001 RELAY ROTARY TACT SWITCH DIODE DIODE DIODE R : Mexico G : Germany H : Korea C : China V : China(Shanghai) M : Other Areas I : Malaysia indicates safety critical components . ER22-G5PA2-12 ESRL-10H13NS2 ESTS-KHH10910
L : Scandinavia Y : PX(Far East,Hawaii) Y : AAFES(Europe)
K : USA T : England X : Australia
P : Canada E : Europe Q : Russia
R : Mexico G : Germany H : Korea
C : China V : China(Shanghai) M : Other Areas
I : Malaysia indicates safety critical components .