Text preview for : DELL P1130-Ch - SONY CR1.pdf part of DELL DELL P1130 - SONY CR1 Service Manual
TORINITRON® COLOR GRAPHIC DISPLAY
Back to : DELL P1130-Ch - SONY CR1. | Home
P1130
SERVICE MANUAL
US Model Canadian Model
Chassis No. SCC-L33H-A
CR1 CHASSIS
SPECIFICATIONS
Screen dimensions Preset Image Size 4:3 Electrical Video input signals Synchronization input signals analog, 0.7 Vpp, positive at 75 ohm separate horizontal and vertical; and composite TTL level, positive or negative Sync on Green at 0.3 Vp-p 120 to 240 VAC / 50 or 60 Hz ± 3 Hz / 1.6 A (RMS) at 120 VAC and 0.9 A (RMS) at 220 VAC 50 A 80 A 5:4 Diagonal 19.09 inches (485 mm) Horizontal 15.28 inches (388 mm) Vertical 11.46 inches (291 mm) Diagonal 18.35 inches (466 mm) Horizontal 14.33 inches (364 mm) Vertical 11.46 inches (291 mm) Diagonal 19.86 inches (504 mm) Horizontal 15.90 inches (404 mm) Vertical 11.90 inches (302 mm) 0.24 mm 90° AR Coating AC input voltage / frequency / current Inrush current at 120 V Inrush current at 240 V Physical Characteristics Connector type Signal cable type Dimensions: Height Width Depth Weight (monitor only) Weight (with packaging) Environmental Temperature: Operating Nonoperating Humidity: Operating Nonoperating Altitude: Operating Nonoperating Thermal dissipation
Viewable Image Size (VIS)
Aperture Grille Pitch Deflection angle Faceplate coating Resolution Horizontal scan range Vertical scan range Optimal preset resolution Highest preset resolution Highest addressable resolution*
15-pin D-subminiature Attached to monitor 502 mm (19.8 inches) 497 mm (19.6 inches) 485 mm (19.1 inches) 30.5 kg (67.4 lb) 35.5 kg (78.4 lb)
30 kHz to 130 kHz (automatic) 48 Hz to 170 Hz (automatic) 1280 x 1024 at 85 Hz 1600 x 1200 at 85 Hz 2048 x 1536 at 80 Hz
* Addressable means the monitor will sync up to this mode. However, Dell does not guarantee the image will be sized and centered correctly. Dell guarantees image size and centering for all preset modes listed in the following table.
32° to 104°F (0° to 40°C) -4° to 140°F (-20° to 60°C) 10% to 80% (noncondensing) 5% to 90% (noncondensing) 3,048 m (10,000 ft) 10,675 m (35,000 ft) 494 BTU/hour (maximum) 426 BTU/hour (typical)
TORINITRON® COLOR GRAPHIC DISPLAY
R
POWER SAVING FUNCTION
If you have VESA's DPMS compliance display card or software installed in your PC, the monitor can automatically reduce its power consumption when not in use. If input from keyboard, mouse or other input devices is detected, the monitor will automatically "wake up". The following table shows the power consumption and signaling of this automatic power saving feature: Power Management Definition
VESA's Mode Video H-sync V-sync Power Used minimum 95 W ON Active Yes Yes maximum 135 W typical 120 W Active-OFF OFF* Blanked N/A No N/A No N/A <3W 0W Amber OFF Green LED color
This monitor is ENERGY STAR®-compliant and TCO'95 power management compatible. * Zero power consumption in OFF mode can only be achieved by disconnecting the power cable from the monitor.
P1130(E)
4
DIAGNOSIS
Failre +B failure Horizontal / Vertical Deflection failure, Thermal protector ABL protector HV failure Aging / Self Test Out of scan range Self Test (OSD Color Bar) Power LED Amber Off (0.5 sec) (0.5 sec) Amber Off (1.5 sec) (0.5 sec) Amber Off (0.5 sec) (1.5 sec) Amber Off Amber Off (0.25 sec) (0.25 sec) (0.25 sec) (1.25 sec) Amber Off Green Off (0.5 sec) (0.5 sec) (0.5 sec) (0.5 sec) Green (OSD indication)
: During Power Save, push up UP button for longer than 2 second.
P1130(E)
5
TIMING SPECIFICATION
MODE AT PRODUCTION RESOLUTION CLOCK -- HORIZONTAL -- H-FREQ 31.469 kHz usec H. TOTAL H. BLK H. FP H. SYNC H. BP H. ACTIV -- VERTICAL -- V. FREQ (Hz) 59.940 Hz lines V. TOTAL V. BLK V. FP V. SYNC V. BP V. ACTIV -- SYNC -- INT(G) EXT (H/V) /POLARITY EXT (CS) /POLARITY INT/NON INT NO YES N/N NO NON INT NO YES P/P NO NON INT NO YES P/P NO NON INT 525 45 10 2 33 480 85.000 Hz lines 1250 50 1 3 46 1200 85.024 Hz lines 1072 48 1 3 44 1024 31.778 6.356 0.636 3.813 1.907 25.422 106.250 kHz usec 9.412 2.440 0.279 0.837 1.325 6.972 91.146 kHz usec 10.971 2.844 0.406 1.016 1.422 8.127 MODE 1 640 X 480 25.175 MHz MODE 2 1600 X 1200 229.500 MHz MODE 3 1280 X 1024 157.500 MHz
2001.3.21 VER.
P1130(E)
6
SECTION 4 DIAGRAMS
4-1. BLOCK DIAGRAMS
CN309 HD15
15 5 10 4 3 2 1 5 2 4
14 9
INPUT2(HD15)
13 8 12 7 11 6
IC008 INPUT SELECT B1 G1 R1 V1 H1 B OUT SOG B2 G2 R2 V2 H2 SYNC IN
22 31 2
IC001 RGB PRE-AMP
25 7
IC002 RGB AMP R OUT G OUT B OUT
26 8
CN315
5
CN318 KR KG KB HEATER+ 5 3 1 7 V901 PICTURE TUBE
R OUT G OUT
R IN G IN B IN
R IN G IN B IN
R OUT G OUT B OUT
5 3 1 7
KR KG KB HEATER+
CN307 HD15
15 10 14 9 5
6 7
SDA SCL VCLK IC009 ROM
6 7 8
28
4
28
9
3
30
11
1
4 3 2 1 5 6 7
23
INPUT1(HD15)
13 8 12 7 11 6
10 12 14
SDA SCL VCLK
15 16
COF R COF G COF B
22 23 24
15 14 13
RIN GIN BIN
ROUT GOUT BOUT
3 5 7
G2
IC004 CUT OFF AMP
CN318 1 G2
B
G_IK
R_IK
G.SYNC
H OUT
V OUT
SW Q004 CN311 DDC SCL1 DDC SDA1 DDC GND1 DDC SCL2 DDC SDA2 DDC GND2 10 11 9 7 8 6 1 4 15 16 2 3 13 SW Q001 SW Q002 SW Q005
SDA
18
19
21 15 14 13 12 10 17 18
IC006 INVERTER
9 8 5 6
BLK
SW
SDA
23
CLAMP
OSD G
V_DET
OSD R
OSD B
IC007 ROM
13
SCL
OSD BLK
SCL
22
12
11
10
B_IK
HV
TO D BOARD FBT
7V
2
IC011 HEATER REG Vcc OUT VADJ
4 5
3
4
11
10
A
TO D BOARD CN1102
1
2
13
12 2 18 20 19 21 7 11 10
H BLK INPUT SW IIC SCL IIC SDA HS OUT VS OUT ECO SW
CN312
OSD G
OSD R
H FLY
OSD B
OSD BLK
CLP
AV
BLK
SCL SDA HS OUT VS OUT ECO SW
SCL SDA
4 3
SCL SDA HS OUT VS OUT ECO SW CS IN VS IN HS IN
RCI GCI BCI
32 31 30
HS OUT 12 VS OUT 13 ECO SW 27
23 24 25
BUFFER Q101, Q201, Q301
1 +B +80V +12V 7V 3.3V 2 4 6 7 8 9
+B +B +80V +12V 7V 3.3V 5V
C
TO D BOARD CN604
IC003 OSD
XTAL IN
14
X001 24.5MHz
5V
2 4
A1
(VIDEO AMP, RGB OUT)
IC005 INVERTER
4 3
+ +
2
IC1600 (1/2) IC1600 (2/2)
CN1601 3 4 1 2 CY4+ CY4 CY3+ CY3
Q1402 CN1400 WAKE UP KEY SCAN 2 3 4 5 8 12 13 14 TH1400 S1401 CONT S1400 BRT S1402 OK S1404 S1405 + 5V CN1603 GXSC GYSC 4 5 6 7 8
6 7
8
D
TO D BOARD CN1103
LED1 LED2 INPUT SW T_AMB VY VX
IC1603
1 2
CN1600 +
4
1 2 IC1601 (1/2)
LCC-NS (+) LCC-NS () CN1602
LCC-NS
E
TO N BOARD CN1003
F
TO D BOARD CN1106
LCC NS IIC SDA IIC SCL
IC1602 DAC
21 20
4 3 2 1 4 3 4 3 6 7 6 7
+ + + +
2
1 2 3 4 5 6 7 8
LCC-LT (+) LCC-LT () LCC-LB (+) LCC-LB () LCC-RT (+) LCC-RT () LCC-RB (+) LCC-RB ()
LCC-LT LCC-LB LCC-RT LCC-RB
SDA SCL
AO2 AO1 AO4 AO3
CN1401 TO MAGNETIC SENSOR UNIT VX VY 3 2 5V S1403 INPUT1 INPUT2
LED DRIVE Q1400
G D1400
IC1601 8 (2/2) IC1604 (1/2) IC1604 (2/2)
2
LED DRIVE Q1401
A
POWER
8
H4 (USER CONTROL)
L2 (CY, LCC)
B-SS9328-BD1-EPS05
P1130(E)
FC
FV
4-1
DA (DPU)
CN1101 H.DF REFDC XDC HD OUT HFBP H BLK VS OUT HS OUT PLL LOCK IIC SDA IIC SCL LCC_NS 1 33 37 34 36 15 11 13 7 20 19 22 24 16 21 23 2 38 39 40 32 35 5 12 10 IC1102 AMP
5 1 2 3 21 23 35 36 38 39 40 41 43 44 45 48 49 50 51 52 53 54 63 27 26 64 58 59 3 7
IC1101 DPU HDF1 DCC2 XDC HDOUT FBP-IN H BLK V-IN H-IN LOCK-DET SDA SCL LCC_NS HSAW_SW PWM2 GYSC GXSC VDF VKEY YSC XSC HSHAPE YDC POC-OUT POC-IN DCC ASW1 ASW2
CN1001 LB DET IK SIGMA DDC SDA1 DDC SCL1 DDC GND1 DDC SDA2 DDC SCL2 DDC GND2 INPUT SW IIC SDA IIC SCL TXD RXD KEY SCAN LED1 LED2 PLL LOCK POC HV DET ABL DET G2 S6 S5 S4 S3 S2 S1 S0 PWR SW DGC SW V.FBP WAKE UP ECO SW 32 34 7 9 11 13 15 17 29 1 3 2 4 35 33 31 39 40 6 8 10 12 14 16 18 24 26 28 23 25 30 36 5 INVERTER Q1001
22 21 51 52 71 49 50 70 80 35 36 37 38 23 79 78 34 31 19 20 28 7 6 5 4 3 2 1 58 60 10 13 9
IC1001 CPU P42/AN10 P41/AN09 P86/SDA1 P87/SCL1 P21/A1/A17 P84/SDA2 P85/SCL2 P20/A0/A16 P27/A7/A23 P80/SDA0/SI0 P81/SCL0/SO0 P82/TXD0 P83/RXD0 P42/AN11 P26/A6/A22 P25/A5/A21 P76/SCK0/INT3 P73/TB01N0/IN5 P57/AN07 P40/AN08 P70/TA1OUT P36/TA7OUT P35/TA61N P34 P33/MAIT P32/HWR P31/WR P30/RD P04/AD4 P06/AD6 P61/CTS0 P51/AN01 P60/INT0 X1 X2
43 41 46 64 7 6 5
CN1003
16
P54/AN04 P55/AN05 P56/AN06
17 18
4 3 2
T_AMB VY VX TO H4 BOARD CN1400
E
IC1003 ROM P12/A10/AD10 P11/A9/AD9 P10/A8/AD8 WC SCL SDA
63 62
G
TO D BOARD CN502
HSAW_SW H.LINBAL GYSC GXSC V.DF D.TILT YSC XSC HSHAPE YDC POC DCC2 VSAWN
I
TO D BOARD CN1104
5V
I O G
RESET
IC1002 RESET
2
+ 4
+ 6
X1001 16.9344MHz
N
(µ-COM)
B-SS9328-BD2-EPS05
P1130(E)
4-2
PH610
+15V
1
AC IN
CN602 AC L NC AC N 1 2 3
F601
T601 :LFT
S601
D610 AC RECT
4
IC640 +B DETECT ERROR AMP
2 1
D
3
2
DEFLECTION , HDF, VDF, HV, POWER SUPPLY
IC610 PFI
2
IC620 REG OUT
L SEN CATHODE
DGC
AC SEN
CN601 DGC DGC 1 4 THP602
RY603
TH601
DRAIN
FB VSENSE
VG (H) VS VB VC2 VG (L) OCP
16 15 14 10 12 9
1
MAIN CONVERTER OUT Q641 T620
9
RY602
D.TILT D650
3 3 2
1 1
5 10
MAIN CONVERTER OUT Q640
7 11
XSC +B IC701 CY AMP
3 1 2 8 9
RELAY DRIVE Q611 IC630 REG
1 2 4 8 5
L610 AFC
4
8 9
T630 :SRT
5 5
3.3V
1 2
3.3V
INA INA+ INB+ INB
IOUTA OUTA OUTB IOUTB
IC703 ROTATION DRIVE CN701 +
4
4 6
ROTATION
COMP FB
OUT
REG SW Q630
3 2 1
6
10 9 8 7 6 5 4 3
ROTATION+ ROTATION XSC XSC+ YSC YSC+ XDC XDC+ YDC YDC+
13
+80V
14
7
RT/CT ISENS VREF
3
+15V
8 15
D652 IC654 12V REG +12V
YSC
PH620
VCC SW Q610
PH630
4 1
4
1
16
-15V
3 2
IC702 CY AMP
5
PROTECT Q652 XDC 7V IC652 YDC REFDC
4
2
6
IN A (X) +IN A (X) +IN B (Y) IN B (Y) STBY
OUT A (X)
1
4 3 2 10
3
2 3
OUT B (Y)
1
CN1104 LB DET IK SIGMA DDC SDA1 DDC SCL1 DDC GND1 DDC SDA2 DDC SCL2 DDC GND2 ECO SW INPUT SW IIC SDA IIC SCL TXD RXD WAKE UP KEY SCAN LED1 LED2 PLL LOCK POC HV DET ABL DET G2 S6 S5 S4 S3 S2 S1 S0 PWR SW DGC SW V.FBP CN502 IIC SCL IIC SDA VSOUT HSOUT H BLK GXSC GYSC LCC NS PLL LOCK POC H.DF V.DF 19 20 11 13 15 21 23 22 7 5 1 2 10 12 16 24 32 33 34 35 36 37 38 39 40 IIC SCL IIC SDA VSOUT HSOUT H BLK GXSC GYSC LCC NS PLL LOCK POC H.DF V.DF VSAWN DCC2 H.LINBAL HSAW_SW HSHAPE REFDC HD OUT YDC HFBP XDC D.TILT YSC XSC H.LINBAL S0 S1 S2 S3 S4 S5 S6 HSAW_SW HSHAPE 32 34 7 9 11 13 15 17 5 29 1 3 2 4 36 35 33 31 39 40 6 8 10 12 14 16 18 24 26 28 23 25 30 IIC SDA IIC SCL TXD RXD WAKE UP KEY SCAN LED1 LED2 PLL LOCK POC HV DET ABL DET G2 S6 S5 S4 S3 S2 S1 S0 PWR SW DGC SW V.FBP GXSC GYSC LCC NS IIC SDA IIC SCL 4 5 6 7 8 WAKE UP KEY SCAN LED1 LED2 2 3 4 5 8 TXD RXD 4 3 IIC SDA IIC SCL VS OUT HS OUT H BLK +15V +15V 11 10 9 8 7 6 13 4 16 15 3 2 1 CN1102 DDC SDA1 DDC SCL1 DDC GND1 DDC SDA2 DDC SCL2 DDC GND2 ECO SW INPUT SW IIC SDA IIC SCL VS OUT HS OUT H BLK CN1101 TXD RXD CN1103 WAKE UP KEY SCAN LED1 LED2 INPUT SW CN1106 GXSC GYSC LCC NS IIC SDA IIC SCL V.FBP HV DET HFBP ECS V.DF TO A1 BOARD CN311 H.DF DGC SW PWR SW
IC680
1
5 2
CTL Vcc
5V 3.3V
5V 3.3V
1
IC901 HV CONT
14
CN604
5
1 +B +80V +12V 7V 3.3V 5V 2 4 6 7 8 9
+B +B +80V +12V 7V 3.3V 5V
Width H SAW GEN +
A
11 3
C
TO A1 BOARD CN312
H DF OUT Q701-705 T701 :DFT V DF OUT Q706, 707
12
+
10
I
TO N BOARD CN1001
BUFF Q507 IC401 V OUT
+B HV REG SW Q901
T902 :HRC
4 1
T901 :FBT
TO PICTURE TUBE HV
17
D
TO H4 BOARD CN1400
DCC2 VSAWN
1 7
+
OUT
5 3 6
HV DRIVE Q903-904
HV OUT Q902
2
13
FV
14
F
TO L2 BOARD CN1603
ABL DET G2 HD OUT G2 OUT Q905
7
TO PICTURE TUBE
IC503 AMP
15 5
H DRIVE BUFF Q501-503
H DRIVE Q504 T501 :HDT H_SAW SW Q521
H OUT Q505
+
6
16
8
FC
11
G2 MUTE Q906
G2 MUTE Q907
6
TO PICTURE TUBE
12
T504 :HST
SIZE DETECT BUFF Q519
CN510 1 G2
B
V DY
L502 :HLC S CAP CANGE Q511-517 Q511-516 T503 :LCT 15V
7 6 14 11 12 17
IC501 PWN CONT
3
CN501
10
G
TO DA BOARD CN1101
VSAWN DCC2 H.LINBAL HSAW_SW HSHAPE REFDC HD OUT YDC HFBP XDC D.TILT YSC XSC
SAWR
PWMOUT MIXOUT
L510 :HOC +B
1 2 4 6 L509 :HCC
V+ V H H+
9
ERRIN REFIN HDIN MIX MIX+ VREG9
ERROUT
H-SIZE FILTER SW Q523
H-SIZE FILTER SW Q524 PIN DRIVE Q508-509
PIN OUT Q506
H DY
H LIN BAL SW Q510
18
S501 (RASTER CENTER TAP SWITCH)
B-SS9328-BD3-EPS05
P1130(E)
4-3
4-2. FRAME SCHEMATIC DIAGRAM
10 15 5
14 9 4
CN309 HD15D-SUB
INPUT2 (HD15)
13 8 3 12 7 2 11 6 1
A1 (VIDEO AMP, RGB OUT )
HG H
10 15 5
14 9 4
CN307 HD15D-SUB
INPUT1 (HD15)
PICTURE TUBE
RGB G1 G2
13 8 3 12 7 2
DDC GND1 DDC GND2 DDC SDA1 DDC SDA2 DDC SCL1 DDC SCL2 INPUT SW ECO SW
HS OUT
VS OUT
IIC SDA
IIC SCA
+12V
+80V
GND
3.3V
NC
+B
+B
5V
7V
17
16
15
14
13
12
11
10
H BLK
GND
GND
GND
GND
CN318 2P
1 2
9
8
7
6
5
4
3
2
9
8
7
6
5
4
3
2
1
1
G2 G2(NC)
11 6 1
CN312 9P WHT
CN311 17P WHT
HV
GND 17 IIC SDA 16 IIC SCA 15 GND 14 ECO SW 13 GND 12 DDC SDA1 11 DDC SCL1 10 9 8 7 6 5 4 3 2 DDC GND2 INPUT SW HS OUT VS OUT DDC GND1 DDC SDA2 DDC SCL2 H BLK GND 3.3V +12V +80V GND NC 5V 7V +B +B 1
CN1101 40P 40 39 38 37 36 35 34 33 32 31 30 29 28 27 26 25 24 23 22 21 XSC YSC D.TILT XDC HFBP YDC HD OUT REFDC HSHAPE +12V NC +12V A.GND 3.3V D.GND D.GND HSAW_SW GXSC LCC NS GYSC IIC SDA IIC SCL A.GND A.GND H.LINBAL H BLK NC HS OUT DCC2 VS OUT VSAWN NC A.GND PLL LOCK A.GND POC A.GND A.GND V.DF H.DF XSC YSC D.TILT XDC HFBP YDC HD OUT REFDC HSHAPE +12V NC +12V A.GND 3.3V D.GND D.GND HSAW_SW GXSC LCC NS GYSC IIC SDA IIC SCL A.GND A.GND H.LINBAL H BLK NC HS OUT DCC2 VS OUT VSAWN NC A.GND PLL LOCK A.GND POC A.GND A.GND V.DF H.DF 40 39 38 37 36 35 34 33 32 31 30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
CN604 9P BLK CN502 40P
CN1102 17P BLK
1.2kV
CN504 1P
1
9
8
7
6
5
4
3
2
1
CN701 10P WHT :S-MICRO ROTATION+ ROTATION XSC XSC+ YSC YSC+ XDC XDC+ YDC YDC+ 10 9 8 7 6 5 4 3 2 1
ROTATION
D
DEFLECTION,HDF,VDF, HV, POWER SUPPLY
CN501 6P WHT :VH V+ V NC H NC H+ 1 2 3 4 5 6 H DY V DY
DA (DPU)
20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
CN1101 40P 1 2 3 4 5 6 7 8 -15V +15V GND GXSC GYSC LCC_NS IIC SDA IIC SCL -15V +15V GND GXSC GYSC LCC_NS IIC SDA IIC SCL 1 2 3 4 5 6 7 8
CN1603 8P WHT
CN1601 4P WHT :S-MICRO CY4+ CY4 CY3+ CY3 3 4 1 2
KEY SCAN
INPUT SW
LED 2
LED 1
+12V
GND
+5V
CN1104 44P
WAKE UP
CN1103 8P WHT
CN1600 2P WHT :S-MICRO LCC-NS (+) LCC-NS () 1 2 LCC-NS
44
43
42
41
40
39
38
37
36
35
34
33
32
31
30
29
28
27
26
25
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
8
7
6
5
4
3
2
IK SIGMA
INPUT SW
DGC SW
HTR SW
DDC GND2
DDC GND1
ECO SW
IIC SCL
G2
PLL LOCK
PWR SW
DDC SCL1
HV DET
DDC SDA2
ABL DET
DDC SCL2
CN1101 4P WHT 1 TO ECS 2 3 4 D GND
KEY SCAN
DDC GND2
KEY SCAN
DDC SDA2
DDC SDA1
DDC SCL2
DDC SCL1
INPUT SW
PLL LOCK
WAKE UP
IK SIGMA
PWR SW
ABL DET
DGC SW
ECO SW
+5V
DDC GND1
HTR SW
DDC SDA1
WAKE UP
HV DET
V.FBP
LED1
LED2
GND
GND
GND
GND
GND
POC
RXD
IIC SDA
LB DET
IIC SCL
IIC SDA
GND
GND
LB DET
GND
GND
GND
POC
LED1
LED2
V.FBP
RXD
TXD
NC
NC
NC
S7
S0
S1
S2
S3
S4
S5
+5V
S6
1
RXD
TXD
+5V
CN1602
VX 14
VY 13
T_AMB 12
GND 11
GND 10
NC
NC
NC
G2
9
8
7
6
5
4
3
2
S7
S0
S1
S2
S3
S4
S5
S6
TXD
1
INPUT SW
GND
GND
LED 2
LED 1
+5V
WAKE UP
KEY SCAN
+12V
LCC-LT (+) LCC-LT () CN1400 14P LCC-LB (+) LCC-LB () LCC-RT (+) LCC-RT () LCC-RB (+)
1 2 3 4 5 6 7 8
LCC-LT LCC-LB LCC-RT LCC-RB
44
43
42
41
40
39
38
37
36
35
34
33
32
31
30
29
28
27
26
25
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
AC IN 1 2 3
CN602 3P WHT :VH AC L NC AC N CN601 4P WHT :VH 1 DGC NC NC DGC
CN1001 44P
CN1003 6P :S-MICRO (L)
1
LCC-RB ()
N
GND
1 2 3 4 5 6
(µ-COM)
VX VY T_AMB LUMI (NC) 5V (NC)
CN1401 5P GND VX VY T_AMB LUMI (NC) 5V (NC) 1 2 3 4 5 6 TO MAGNETIC SENSOR
DGC
2 3 4
L2
(CY, LCC)
H4
(USER CONTROL)
B-SS3549-KESSENZU-EPS05
P1130(E)
4-4
(1) Schematic Diagram of A1 Board
1
2
D311 1PS226-115
3
4
5
6
7
8
IC002 LM2412T RGB AMP
9
10
C BLOCK
11
12
13
14
A
R361 82 1/4W :RN-CP C352 47 25V
R330 33
VBIAS
4
IC008 MM1470AD INPUT SELECT
32
R.OUT B.IN GND2 G.IN R.IN GND3 VCC
5
G.OUT
6
B.OUT GND1
D211 1PS226-115
1
R230 33
FV
11
VCC B1 VCC G1 VCC R1 V1 H1 GND B2 VCC
10
2.6
9
2.6
8
2.6
7
6
5
55.4
4
3
56
2
1
56
1.4
R261 82 1/4W :RN-CP
GND
1.4
R130 33
30
C252 47 25V
D111 1PS226-115
1 2 3
B OUT
31
2
C040 0.01 B:CHIP
R318 56 :CHIP
CN315 8P :XA
1 2 3 4 5 6 7 8
CN316 8P
2
R218 47 :CHIP C330 0.22 16V B:CHIP
FB002 0 :CHIP
29
VCC G OUT GND VCC R OUT GND SOG
4
IC001 M61314SP RGB PRE-AMP
32 1
GND B IN 12V G IN SOG IN GND R IN GND SOG OUT V DET +5V OSD BLK OSD B OSD G OSD R GND NC ABL B OUT 12V G OUT GND R OUT GND COF B COF G COF R G2 SCL SDA CLAMP BLK
B
R161 82 1/4W :RN-CP R011 2.2k :CHIP
28
5
C319 0.01 B:CHIP
27
6
C152 47 25V
D002 NNCD5.6A-T1 D004 1PS226-115
R013 100 :CHIP
1.4 4
7
31
2
2
R118 22 :CHIP
C230 0.22 16V B:CHIP
3.6
30 3
0.3
R007 100 :CHIP C049 0.01 B:CHIP
29
4
2
25 8
3.6
C007 2.3 0.22 16V B:CHIP C025 0.01 B:CHIP
C023 0.22 16V B:CHIP C024 C012 47 0.01 16V B:CHIP
2.6
R323 820 1/4W R304 2.7k :CHIP C311 100p CH:CHIP R204 2.7k :CHIP C211 100p CH:CHIP R104 2.7k :CHIP C111 100p CH:CHIP
R111 56 FPRD R317 33 :CHIP R310 330 :CHIP C301 15p CH:CHIP R210 680 :CHIP C201 18p CH:CHIP R110 330 :CHIP C101 18p CH:CHIP R117 33 :CHIP FB303 C015 0.1 25V B:CHIP
R211 68 FPRD
R311 56 FPRD
26
KB GND KG GND KR GND HEATER GND
KB GND KG GND KR GND HEATER GND
1 2 3 4 5 6 7 8
R351 47 1/2W SG301 :SURGE R251 47 1/2W :SURGE R151 47 1/2W GND :SURGE
TO D-b BOARD FBT FC
3
GND
J001 L004 22µH C031 1000p 500V B:CC
FC
FV G1
SG002
13 1
G1
10
11
22
R003 100 :CHIP R042 0 :CHIP
23
R012 2.2k :CHIP
D001 1PS226-115
1.7 4.7 1.7
C004 0.1 25V B:CHIP
C130 0.22 16V B:CHIP
27
6
C016 2.6 470 16V
R217 33 :CHIP FB203
11 10 G2 9
KB
3 4 H1 5 H2 8 7
KG
6 G1
IMR
24
9
28
5
KR
POWER SAVE SYNC IN G2 SW R2 V2 H2 G.SYNC VCC V OUT H OUT GND
12
13
10
CN309
12
21
C
11
INPUT2 (HD15)
22
13 8 3
NC NC NC GND
15
VCC VCLK SCL SDA
18
R001 C048 15k 0.01 :CHIP B:CHIP
0 0
16 17
4.1 0.4
R034 1.8k :CHIP R363 100 :CHIP R263 100 :CHIP
MAIN+5V
12 7 2
2 7
R098 47k :CHIP C062 0.1 25V B:CHIP
14
19
23
14 9 4
IC009 BR24C21F-E2 ROM
1 8
20
1.7
C109 47 25V
4.4
24
15
9
5
C019 0.01 B:CHIP
0
21
10
25
D003 NNCD5.6A-T1
3.1 :CHIP 0.6
R051 1M
3.6
8
26
7
2
R223 820 1/4W
FB103
2.6
R123 820 1/4W
SG201
SG101
3.0
SG001
3.3 3.2 4.5
13 20
FB104
D204 D304 HSU83TRF HSU83TRF
D104 HSU83TRF
C011 0.1 100V R018 :CHIP
C306 0.47 250V
C051 0.1 B:CHIP
C039 0.1 B:CHIP
C014 22 100V
FB302 R333
R064 220k 1/2W
C035 4700p 2kV B:CC
CN303 1P
1 1
GND
11 6 1
3 6
4.1 R002 4.3 4.2 R027
15k :CHIP
0 0
14 19
TO COATING EARTH TO COATING EARTH
4.7 0.1 100
15 18
D305 HSU83TRF C206 0.47
250V
PIN301
FB202 R233
(G2)
GND
D007 NNCD5.6A-T1 D005 1PS226-115
R028 47 47 :CHIP :CHIP
D013 1SS119
C010 47 10V C026 10p R019 2.2k :CHIP
R163 100 :CHIP
4
5
0 0
16 17
0.8
R017 100 :CHIP
D205 HSU83TRF C106 0.47
250V
(G2)
CN318 2P
1 2 G2 G2(NC) TO D-b BOARD CN510
FB102 R133
D105 HSU83TRF
R043 R044 0 0 :CHIP :CHIP
IC006 SN74AHCT04NSR INVERTER
0.3 4.5 0 4.9 4.6
A1 Y1 A2 Y2 A3 Y3 GND VCC A6 Y6 A5 Y5 A4 Y4
9 10 11 12 13 14
D301 1PS226-115
108.3
103 108.4
103 106.9
101.6
R301 82 1/4W :RN-CP
7
4.6
R240 33
FILTER SDA SCL TEST AV DVSS DVDD CLP BLK HS OUT
RCI GCI BCI AVDD VDD2 ECO SW GND HS IN VS IN CS IN
32
C320 47 25V
8
0.3
HFLY
ADCREF
33
2
3.4 C037
D201 1PS226-115
R140 33 R101 82 1/4W :RN-CP R015 2.2k :CHIP C120 47 25V
+12V
R030 0 R040 :CHIP 4.7k :CHIP R023 1k :CHIP R040 10k R022 :CHIP 0 :CHIP
26
STBY+5V
D019 1PS226-115
R008 100 :CHIP R016 2.2k :CHIP
0.1
10 25
R054 2.2k
0.8
11 24
0.5 4.2
R059 2.2k :CHIP
C105 C205 C305 0.1 0.1 0.1 25V 25V 25V B:CHIP B:CHIP B:CHIP
R307 R207 R107 33k 33k 33k :CHIP :CHIP :CHIP
R164 R264 R364 120k 120k 120k :CHIP :CHIP :CHIP
0.3
12
C058 7p CH:CHIP R052 4.7M 0 :CHIP
D006 MA151WK-TX
5 2.1
IC005 TC75SU04FU INVERTER
NC IN OUT GND
14
FB007 0
F
CN307 HD15D-SUB
INPUT1 (HD15)
VCC
FB009
OSD BLK XTAL OUT OSD G OVSS OSD B
21
X001 24.5MHz
2.1
C055 22p CH:CHIP
VS OUT CLP DELEY XTAL IN
0.6
22
4.3 0 150p
20
C061 :CHIP R308 4.7k :CHIP R321 470k :CHIP
D308 1PS181-115 Q301 2SC2412K BUFF
4.8
C308 R315 0.22 22k 16V :CHIP B:CHIP R208
D208 1PS181-115 Q201 2SC2412K BUFF
4.1 4.7k 4.8
R221 470k :CHIP C208 R215 0.22 22k 16V :CHIP B:CHIP R108 :CHIP
D108 1PS181-115 Q101 2SC2412K BUFF
4.1 4.7k 4.8
R121 470k :CHIP C108 R115 0.22 22k 16V :CHIP B:CHIP :CHIP
C045 0.1 25V B:CHIP
1
13
23
+200V
D016 NNCD5.6A-T1
9
R010 100 :CHIP
S
FB006 0
C021 C091 0.01 1 :CHIP
C059 0.1 25V B:CHIP
+80V
C017 100p
28
7
E
29
6
R201 82 1/4W :RN-CP
C220 47 25V
30
S
5
R033 1k :CHIP 2.2 C036 100p CH:CHIP C038 4.7 4700p B:CHIP
0.1 25V B:CHIP
1.3 1.3 1.3 4.9 4.9 4.9
6
R340 33
A GND
ADCGND
34
4.9 0 0.2
4
IC003 CXD9548M OSD
R097 0 :CHIP
R206 39k 1/4W R106 39k 1/4W
B_IK G_IK R_IK B_IN G_IN R_IN VBB GND
+B
C033 0.1 25V B:CHIP
D008 NNCD5.6A-T1
3
L002 1mH
R_OUT R_BASE G_OUT G_BASE B_OUT B_BASE
D
C063 0.01 B:CHIP
4.5 0.4
2
R306 39k 1/4W
IC004 H8D3060 CUT OFF AMP
D306 HSS82 D206 HSS82 D106 HSS82
1
1
3
4
5
6
7
8
10 11 12 13 14 15 16 17
FB310 FB210 FB110 C053 0.1 25V B:CHIP R320 R319 470k 470k :CHIP :CHIP R220 470k :CHIP R120 470k :CHIP R219 470k :CHIP R119 470k :CHIP
5
R109 1M :CHIP R122 1M :CHIP
R209 1M :CHIP R222 1M :CHIP
R309 1M :CHIP R322 1M :CHIP
0.4
3
1
31
4
4.2 4.2 4.2
C046 0.01 B:CHIP C009 1 C018 2.2 250V
C123 0.1 250V :PT
C223 C323 0.1 0.1 250V 250V :PT :PT
D101 1PS226-115
Q001 2SK1828 SW Q002 2SK1828 SW
4.5
4.4
27 8
4.9
15
5
14 9 4
1
IC007 BR24C21F ROM
NC NC NC GND VCC VCLK SCL SDA
16
L001 100µH
8
13 8 3 12 7 2 11 6 1
R077 R092 15k 15k :CHIP :CHIP C090 0.01 B:CHIP C054 0.1 25V B:CHIP L007 100µH C057 47 25V R025 4.7k :CHIP
17
OVDD
OSD R
18
C092 0.01 CH:CHIP
7
19
4
3
R045 0 :CHIP
15
10
D009 NNCD5.6A-T1
2.3
2
FB004
4.1
L003 100µH FB005 C001 0.001 500V B:CC
0 0 0
IC011 BA00AST-V5 HEATER REG
C064 100 16V R078 5.1k :CHIP R079 3.3k :CHIP R080 2.7k :CHIP C065 100 16V
2
7
0 4.2
6
R039 47 :CHIP
CTL Vcc GND OUT VADJ
4.2
R038 47 :CHIP
G
D012 1PS226-115
R046 0 :CHIP
Q004 2SK1828 SW
R021 R020 100 100 :CHIP :CHIP R024 4.7k :CHIP L005 100µH C043 0.1 25V B:CHIP C005 0.1 25V B:CHIP
C022 47 10V
1
2
3
4
5 4.9
1.2
C042 0.1 B:CHIP C050 0.1 B:CHIP
4
3
5
R082 1 2W :RS
C027 47 10V
S
C032 0.1 25V B:CHIP
R047 0 :CHIP
A1(VIDEO AMP,RGB OUT)
B-SS9328-A1..-EPS05 RCV
D010 NNCD5.6A-T1
S
Q005 D011 2SK1828 NNCD5.6A-T1 SW
R014 100 R058 1k :CHIP
R006 100 R032 100 R031 15k :CHIP
+12V
L006 100µH
D014 1SS119
GND 17 IIC SDA 16 IIC SCL 15 GND 14 ECO SW 13 GND 12 DDC SDA1 11 DDC SCL1 10 DDC GND1 9 DDC SDA2 8 DDC SCL2 7 DDC GND2 6 GND 5 INPUT SW 4 VS OUT 3 HS OUT 2 H BLK 1
H
CN311 17P WHT
9 8 7 6 5 4 3 2 1
H
CN312 9P WHT
V901 PICTURE TUBE 21TKD
KB KR G2 G4 KG G1 GM HV TO D-b BOARD FBT
TO D-b BOARD CN1102
I
5V 3.3V 7V +12V GND +80V NC +B +B
TO D-c BOARD CN604
· A1 BOARD WAVEFORMS
1
H
2
1.12 Vp-p (H)
3
H
4
56.0 Vp-p (H)
5
54.5 Vp-p (H)
6
54.5 Vp-p (H)
7
1.24 Vp-p (24.5 MHz)
0.74 Vp-p (H)
0.73 Vp-p (H)
P1130(E)
4-8
(2) Schematic Diagrams of D (a, b, c) Board
· Divided circuit diagram One sheet of D board circuit diagram is divided into three sheets, each having the code D-a to D-c. For example, the destination ab1 on the code D-a sheet is connected to ab1 on the D-b sheet. a b 1 Ref. No. Circuit diagram division code
· D-a BOARD WAVEFORMS
1
0.71 Vp-p (H)
2
11.3 Vp-p (H)
3
59.5 Vp-p (V)
4
1.7 Vp-p (V)
5
180 Vp-p (H)
6
640 Vp-p (H)
1
2
3
4
ROTATION
5
6
7
8
9
10
11
12
13
14
A
0
YDC+ YDCXDC+ XDCYSC+ YSCXSC+ XSCROTATION+ ROTATIONR731 22k :CHIP R734 220 1W :RS R732 1.5 :FPRD R733 22 1W :RS C738 0.22 :MPS C734 0.1 B:CHIP
CN701 10P WHT :S-MICRO
1 2 3 4 5 6 7 8 9 10
IC701 LA6510 AMP
C500 220p CH:CHIP R501 1k :CHIP
+12V
R503 220 :CHIP C554 1000p B:CHIP
D518 RB441Q-40T-77
R522 1k :CHIP
HSW
IOUTA OUTA INAINA+ VEE INB+ INBOUTB IOUTB VCC
C
0-0.6 15.1 0.7 0.7
R716 2.2 :FPRD
R717 2.2 :FPRD
-10.4
C514 0.0047 :PT R509 1 :FPRD
OUT B(Y)
-IN B(Y)
+IN B(Y)
+IN A(X)
-IN A(X)
OUT A(X)
S
D502 D5SC4M-F
R513 27 1W :RS
66.7
-1.3
STBY
VEE
VCC
GND
1
0.8 0
2
0.8
3
0.8
4
0.8
5
-0.1
6
7
8
9
10
4.8
R507 D501 22k HZS182-TE C505 220 35V R584 47 3W :RS R586 47 3W :RS
C510 0.0022 100V :PT
R516 4.7k :CHIP
C513 0.1 25V F:CHIP
D406 RB441Q-40T-77
C402 0.47 100V :PT R401 1.5 :FPRD
-14.4
IC702 STK391-220 AMP
R585 0.22 3W :RS
R510 2.2 10W :RN
D504 FMQ-G5GS
D705 MA111-TX
D
E
H.DF 1 H.DF V.DF 2 V.DF 3 A.GND 4 A.GND POC 5 POC PLL 6 A.GND +3.3V LOCK PLL LOCK 7 8 A.GND 9 NC VSAWN 10 VSAWN VS OUT VS OUT 11 DCC2 12 DCC2 HS OUT HS OUT 13 14 NC H BLK 15 H BLK H.LIN BAL H.LINBAL 16 17 A.GND 18 A.GND IIC SCL 19 IIC SCL IIC SDA 20 IIC SDA GYSC 21 GYSC LCC NS LCC NS 22 GXSC 23 GXSC HSW HSAW_SW 24 25 D.GND L508 26 D.GND 10µH 2 1 27 3.3V 28 A.GND 29 +12V +12V R596 30 NC 100 31 +12V HSP HSHAPE 32 REFDC 33 REFDC HD HD OUT 34 YDC 35 YDC HFBP 36 HFBP XDC 37 XDC D.TILT D.TILT 38 YSC 39 YSC XSC 40 XSC TO DA BOARD CN1101
HD
+15V
1.2 2
0.2 4
C559 0.1 25V F:CHIP
HSP
B
CN502 40P
D.TILT
R738 6.8k :CHIP
Q502 2PD602AR-115 H DRIVE BUFF
100 6.1 :CHIP
CN1104 44P
C533 4700p B:CHIP R537 2.2k :RN-CP C564 0.01 B:CHIP R577 1000p B:CHIP 3.2 R527 22k :RN-CP R528 22k :RN
IIC SDA TXD IIC SCL RXD ECO SW HV DET DDC SDA1 ABL DET DDC SCL1 +5V
R594 G2 4.7k :CHIP DDC GND1 R593 10k :CHIP R592 4.7k R591 4.7k
0.3
R504 10k :CHIP R505 22k :CHIP
6.1 R502
6.1
C515 0.01 B:CHIP C516 220 16V
R524 R525 3.3k 1.8k :RN-CP :RN-CP R523 27k :RN-CP
R735 4.7k :CHIP
1 1.2
3
5
C719 0.1 25V F:CHIP +15V C736 47 -15V C737 47 R706 150 2W :RS
SAWR PWMOUT SAWOUT PGND SGND SLOW SW HDIN REFIN NC ERRIN MIX+ NC MIXERROUT MIXOUT
VREG9
R707 82k
+15V
C718 0.1 25V F:CHIP R737 C730 2.7k 1000p :CHIP B:CHIP
18 17 16 15 14 13 12 11 10
C704 0.01 :PT R710 R711 8.2k 9.1k :RN-CP :RN-CP
R712 4.7k C706 0.01 :PT
+B L510 :HOC
9.8
L501 1 100µ H T501 :HDT
10.1
R521 100
D519 1 2 3 4 5 6 7 8 9 UDZS-TE17-5.1B
10.1 8 4.7 4.7 3
PVCC
VCC
R709 C713 C714 4.7k 0.01 0.01 C705 :CHIP B:CHIP B:CHIP 0.1 25V B:CHIP
C511 0.1 25V F:CHIP
3.8
-15V R701 2.2 C701 330p B:CHIP
C726 R703 0.1 2.2 25V F:CHIP C703 330p
Q501 2SC1623-T1-L5L6 H DRIVE BUFF
Q503 2PB710AR-115 H DRIVE BUFF
R520 220 :CHIP C525 0.1 25V B:CHIP F:CHIP
Q521 DTC124EKA-T146 R579 H-SAW SW 1k B:CHIP
IC703 LA6500-FA ROTATION DRIVE
+
OUT VEE VCC
1
2
3
4
5
6
7
8
9 10
1.5 1.5 1.5 1.5
1.5 1.5 0.2 0.2
1
2
+15V
C517 470p CH:CHIP
C727 R700 B:CHIP 0.1 82k 25V :CHIP F:CHIP R713 150 2W :RS
R599 R598 100k 3.9k :RN-CP :RN-CP C565 R526 0.1 47k 25V :RN-CP B:CHIP 5.6
0.2
Q508 2PD602AR-115 PINDRIVE
IC501 BA9759F-E2 PWM CONT
S6 DDC SDA2 S5 DDC SCL2 S4 DDC GND2 S3
Q506 2SJ569LS-CC11 PIN OUT
66.6
S
5 4
6
1
XSC YSC
C503 0.1 :PT R506 10
8
C506 22 250V
24.7k 1.1µH
R515 FB501
Q509 2PB710AR-115 PINDRIVE
C524 470 25V R530 3k :RN-CP R531 R532 2.7k 22k :RN-CP :CHIP R512 R534 2.2k 2.2k :CHIP :CHIP
C520 0.015 B:CHIP C522 22
R572 100 :CHIP
HTR SW
C562 1000p B:CHIP R590 4.7k PWR SW :CHIP
3
R508 47 1W :RS
217.4 2 4
C504 0.0047 :PT
R758 2.2 :FPRD
R759 2.2 :FPRD
+3.3V +15V -15V
+15V -15V
Q504 2SK2231 H DRIVE
-0.2
5
1
10
C512 R518 470p 220 Q507 C509 B:CHIP :CHIP 2SC2412K 100p 2kV BUFF SL -0.7
Q519 2SA1037AK SIZE DETECT BUFF
R541 47k :CHIP
C519 R573 4700p 2.2k B:CHIP :CHIP
C521 0.01 B:CHIP R578 1k :CHIP
-15V
R412 JW(5)
4
5
6
7
1
2
3
D706 UDZS-TE17-5.1B
D505 R514 C507 FB555 D2L40-TA 22 0.047 0 :FPRD 400V :CHIP D503 :MPS HZS182-TE
D509
R511 MA111-TX 22k :RN-CP
2
9
IC401 STV9379A V OUT VEE O + - VCC
+15V
R756 2.2k
R589 4.7k DGS SW :CHIP
S2
S1 +5V S0
R588 4.7k :CHIP
Q523 DTA124EKA-T146 H-SIZE FILTER SW
D401 EGP10GPKG23
C403 220 R407 10k :CHIP
C732 0.01 B:CHIP
Q505 2SC5570 H OUT
C508 3300p 1.8kV :PP
D506 HZS5B2-TE
0.2
R517 47k :CHIP
R519 330 :CHIP
Q524 DTC124EKA-T146 H-SIZE FILTER SW
L509 :HCC
C404 470 25V R757 10k :CHIP
C733 2200 10V
INPUT V.FBP LED2 LB DET LED1 KEY SCAN WAKE UP
R575 470 :CHIP
C401 470 25V
D512 1SS119-25TD
3
T504 :HST
4
5 6
C408 5p CH:CHIP
D405 RD5.1ES-T1B2
V.FBP
5
C708 220 25V C707 220 25V R718 330 1W :RS R719 2.2 2W :RS
2
1 2
L506 2.2mH C537 L504 0.13 L505 400V 4.7mH :PP 4.7mH
R571 120 1/2W :RN R542 R570 C502 R533 120 120 0.01 18k 1/2W 1/2W C563 :PT :RN-CP :RN :RN 2200p 2kV R546 470 2W :RS
C407 2200p B:CHIP C406 2200p :PT TH401 R409 15k :RN-CP
R408 C405 100k 1000p :CHIP B:CHIP
VSAWN
R410 18k :RN-CP
PLL LOCK POC
D510 11DF2N
2 1 7
DCC2
R404 15k :RN R406 18k :RN
1
C712 33p CH:CHIP C560 0.018 400V :PP C549 0.033 400V :PP C547 0.082 250V :PP C545 0.18 250V :PP C543 0.39 250V :PP C541 0.82 250V :PP C539 1.2 250V :PP R549 47 0 1/2W Q511 :FPRD 2SK2098 C538 4.7 S CAP CHANGE 250V
2
1
R722 330 * 1W :RS
C711 33p CH:CHIP
R721 10k :RN-CP
6
5
2
1
24.2
24.2
R561 47k
2 R536 1 100 1W :RS R548 100 T503 1 1/2W :LCT 2 :FPRD 2
D516 D1NL40-TA
L502 :HLC
R402 470 1W :RS
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44
IIC SDA TXD IIC SCL RXD ECO SW HV DET DDC SDA1 ABL DET DDC SCL1 G2 DDC GND1 S6 DDC SDA2 S5 DDC SCL2 S4 DDC GND2 S3 GND GND HTR SW GND PWR SW S2 DGS SW S1 +5V S0 INPUT SW V.FBP LED2 LB DET LED1 IK SIGMA KEY SCAN WAKE UP S7 GND PLL LOCK POC NC NC GND NC
TO N BOARD CN1001
9 2.6 3.7
0.5
5 4 3
3.2
5
24.8
24.8
R557 47k
24.8
D520 1SS119
D517 11DF2N
R403 R405 1.5 1.5 1/2W 1/2W :RN :RN
3 4
1 2 3 4 5 6
Q516 Q517 2SK3155 R581 2SK3155 47k S CAP CHANGE S CAP CHANGE
0.2
C561 0.01 B:CHIP
S
Q515 2SK3155 S CAP CHANGE
0.2
C548 0.01 B:CHIP
S
Q514 FS10KMJ S CAP CHANGE
Q513 FS30KMJ S CAP CHANGE
S
Q512 2SK2098 S CAP CHANGE
4.9
C542 1 16V F:CHIP
S
R725 2.2 2W :RS
R724 R726 8.2k 10k :RN-CP :RN-CP R754 10k :RN-CP
R727 8.2k :RN-CP R728 10k :RN-CP
R729 8.2k :RN-CP
0.2
C550 0.01 B:CHIP
S
0.2 S
C546 0.22 25V F:CHIP
0.2
C544 0.47 16V F:CHIP
0.2
C540 47 25V
S
C566 0.1 25V B:CHIP 26.5C536 0.47 R550 400V 47k
CN501 6P WHT :VH
V DY
S501 (RASTER CENTER TAP SWITCH)
12
9
7
+15V
R580 470 1/4W :FPRD
C535 0.1 25V B:CHIP
D521 1SS119
5 6
R559 47k
R555 47k
R553 R552 47k 47k
Q510 2SC3371A H LIN BAL SW
0.4
R547 39 :RN
12.8 0.9
C534 0.01 B:CHIP R545 2.2k :CHIP
V+ VNC HNC H+
H DY
F
R755 8.2k :RN-CP
R574 0 :CHIP
R583 100 :CHIP
R568 100 :CHIP
R567 100 :CHIP
R566 100 :CHIP
R565 100 :CHIP
R564 1k :CHIP
R563 100 :CHIP
REFDC
PWR SW1
H LIN BAL
YDC
XDC
HFBP
S1
S2
S3
S4
S5
S1
S6
S6
ac1
ac2
G
D-a(DEFLECTION)
ab1
B-SSS9328-D..-P1-EPS05
H
ab2
P1130(E) 4-10
1
2
3
4
5
6
7
8
9
10
11
12
13
14
A
D-b(HV,HDF,VDF)
ab1 ab2
R901 100k :CHIP C901 100 25V C905 470p CH:CHIP R904 C904 0.1 2.2k :CHIP B:CHIP C902 C903 0.01 B:CHIP 3.3
B
D901 MA111-TX
R902 47k :CHIP C906 100p CH:CHIP R905 1k :CHIP
H.DF
+5V
CN1101 4P WHT
1 2 3 4
9.1
2.6 2.5
5.4 0 8.9
C
RXD TXD
D GND +5V RXD TXD
TO ECS CN1103 8P WHT :S-MICRO
20 19 18 17 16 15 14 13 12 11
IC901 BA9758AFS-E2 HV CONT
SVcc VREG9 PVcc NC PWMOUT AGC PGND SAWOUT NC HVD HVDCAP SGND NC HDIN SLOW SW DELAY NC ERROUT + -
+12V
bc1
+12V
+B
D921 1SS119
D917 UDZS-TE17-9.1B
+80V WAKE UP
FB1005 0 :CHIP
8.7
8.6 8.6
C909 100 25V
3.8
D
FB902
C908 0.01 B:CHIP
1
2
3
4
5
6
7
8
9 10
Q702 2SC2459-GR-TPE4 H DF OUT
C911 680p CH:CHIP C721 47 100V
R753 10 :FPRD R739 27k :RN R761 JW5MM :RN
C910 220p CH:CHIP
33.8
R934 4.7 1/2W :FPRD FB901 1.1µH
1 2 KEY SCAN 3 LED1 FB1000 4 LED2 5 FB1002 0 6 :CHIP 7 INPUT 8
FB1007 0 :CHIP
+12V WAKE UP KEY SCAN LED1 LED2 GND +5V INPUT SW
TO H4 BOARD CN1400 1-8 PIN
1
2
Q901 2SJ585LS-CC11 HV REG SW D907 D2L40-TA
S
C900 4.7 C915 470p 250V :APS T902 :HRC R909 68 10W :RN C916 0.33 250V :PP
R907 4.7k :CHIP
T701 :DFT
Q704 2SC3421-Y H DF OUT
5
R745 4.7 :FPRD R746 4.7 :FPRD R747 15 2W :RS
D701 1SS119-25TD
33.4 33.3 R744
470 :FPRD
E
R911 47 :FPRD
C913 47 250V :HR
R908 10k C914 0.01 630V :MPS
1 3 4
8 6 5
D922 MA111-TX
TO PICTURE TUBE
T901 :FBT R924 R925 10k 270k :RN-CP :RN-CP
D702 1SS119-25TD D703 1SS119-25TD
+15V -15V 1 2 3 4 5 6 7 8
CN1106 8P WHT
D906 UDZ-TE-17-13B
54.4 218.5
L902 22µH
HV ADJ
RV901 100k
6 7 8
4 3 2 1
C723 22 100V
33.1 32.9
4
R912 1k :CHIP
HV 17 13
Q701 2SC2362KG-AA H DF OUT
32.1 R741 1k 1.2 :CHIP
GXSC
R740 47k :CHIP
Q903 2PD602AR-115 HV DRIVE
R914 470 :CHIP C917 0.1 B:CHIP
C925 0.022 :PT R926 27k :CHIP R927 4.7k 1/2W :RC R929 C926 47k 0.1 :CHIP 100V :PT C927 SG901 470p 500V :B R930 SG902 JW(15) R928 330k 1/2W :RC
Q902 FS5KM-18A-AT HV OUT
8.2
1 54.8
C918 2000p 1.2kV :PP
Q705 2SA1358-Y H DF OUT
Q703 2SA1049TP-GR H DF OUT
R743 330 :CHIP
C761 0.01 B:CHIP
F
+15V R937
1k :CHIP
D920 UDZS-TE17-10B
Q904 2PB710AR-115 HV DRIVE
R915 22 :FPRD
D909 HZS182-TE
S
2 8
R916 47 :FPRD
FV1 14
C720 0.01 B:CHIP R742 5.1k :RN-CP
GYSC LCC_NS IIC SDA IIC SCL
-15V +15V GND GXSC GYSC LCC_NS IIC SDA IIC SCL
TO L2 BOARD CN1603
D910 RP1H-V1
C919 0.01 2kV F
Q706 2SC4620TV2Q V DF OUT
+12V
D918 MA111-TX G2
R939 82k :CHIP C932 0.1 25V B:CHIP R938 390k :CHIP R940 330k :CHIP 9.4 R941 22M :RN C936 1000p B:CHIP 3.8
R936 2.2M IC902 1W NJM2904M(TE2) :RN
6 107.8 3 15
SG903 R931 4.7k 1/2W :RC
AMP
+ OUT VCC
C935 0.01 B:CHIP
R748 470k 1/2W :RC
R702 10k :CHIP
72.5
R942 1M :CHIP R944 1k :CHIP R943 100k :CHIP
3.8 8.6
GND
6
3
CN904 1P
1.3
C724 470p 2kV B
5
4
1.8 1.2
R749 R760 2.2k 68k :CHIP :CHIP R704 1k :CHIP
5
16
V.DF
L1001
7
2
-0.1
G
C933 47 16V
R945 R946 100 10k :CHIP :CHIP
D911 ERA34-10TP1
R918 820k 1/2W :RN C920 0.01 2kV F R917 2.2 :FPRD
7 9 10 FV2
Q707 2SA1037AK V DF OUT
8
8.8 Q905 2SC4634LS-CB11 G2 OUT Q906 2SA1037AK-T146 G2 MUTE
+15V R953 2.2M :CHIP R919 10k :CHIP
1
3.6
R950 C937 1k 22 :CHIP 25V
R951 100k :CHIP R952
D914 HSS82-TJ
11
R935 3.3k :RN C930 0.22 :MPS R932 3.9k :RN-CP R933 2.7k :RN-CP B-SSS9328-D..-P2-EPS05
D919 UDZS-TE17-5.1B
R903 180k :RN-CP C923 0.47 R921 4.7k C929 4.7 25V R923 82k :RN
D923 2.2k MA111-TX:CHIP
R920 56k :RN-CP
12
HV DET
H
ABL DET
R954 0.7 10M 3.7 :CHIP C938 470 16V R955 10M :CHIP
Q907 2SB709A G2 MUTE
C921 0.1 25V F:CHIP
D912 RD15ES-T1B3
IIC SDA IIC SCL
ECO SW
INPUT
SDA1 SCL1 GND1 SDA2 SCL2 GND2
GND IIC SDA IIC SCL GND ECO SW GND DDC SDA1 DDC SCL1 DDC GND1 DDC SDA2 DDC SCL2 DDC GND2 GND INPUT SW VS OUT HS OUT H BLK
TO A1 BOARD CN311
17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
1
DDC DDC DDC DDC DDC DDC
I
VS OUT HS OUT H BLK
CN510
CN1102 17P BLK
J
TO A1 BOARD CN318
G2
P1130(E) 4-11
1
2
3
4
5
6
7
8
9
10
11
12
13
14
A
ac1 ac2
D-c(POWER
B
C606 4700p 250V
SUPPLY)
+15V 1
PH610 TLP421F
2
12.8
3
IC640 SEB3-LF4 +B DETECT ERROR AMP
10
9
8
6
0.1
L610 AFC
D610 D4SB60L
0
4
1
0
D613 RM11A
R615 6.8k R652 22k :CHIP C610 330 450V
R651 1k :RN
C687 0.1 :MPS
3
2
R640 1.8k
R694 33k :RN R693 36k :RN
2
1
IC610 MZ1532 PFI
R620 0.1 1/2W :RF R675 2.2M 1/2W R647 2.2M 1/2W
1
2
3
4
5
12.8
T620 0PIT220
7.1
13.8
R639 1.5k
L611 68µ H
CATHODE
AC SEN
SOURCE
IC620 MCZ3001D REG OUT
VSENSE F/B CT RT GND TIMER SS VC1 OCP VD NC VG(H) VS VB NC
18
D650 D4SBL40
9
R692 36k :RN R691 36k :RN R699 680 :CHIP +B C650 100 250V
DRAIN
L SEN
GATE
COMP
1.5 2
GND
C
VCC
C605 4700p 250V
1
378
90.4 0 2.2 90.7 14.6 2.2
C611 1 450V C607 2200p 250V C614 100p :CHIP R630 1 :FPRD C613 47 R614 100
14
5
R611 R610 0.47 0.33 2W 2W
C612 0.22 :MPS
R676 C644 150k 0.1 :RN-CP2.1 :MPS C645 1000p 2.3 2% :PP R653 6.8k :RN-CP
17
1
2
3
4
5
6
7
8
9
10
Q641 2SK2876-01MR-F122 MAIN CONVERTER OUT
194.7 194.6
S
378
7 6
C643 100p 1kV :SL
10 11 12
bc1
+15V
IC654 NJM7812FA +12V REG
I G O
+12V
2
16
3
R646 10 190.3 190.1 :CHIP C642 R645 0.1 10k 250V :CHIP :MPS
5
+80V
13 3 2 1
C658 8200p 800V :PP R643 0.1 2W :RS
D651 D1NL40-TR2
C654 2200 25V
C652 100 100V L652 100µ H +15V C655 47 25V R698 15k :RN-CP
15
4
C667 47 16V
-0.1
200
13 6
D
D690 1SS119-25TD
RY602 TH601 C648 47
C647 4.7 C646 2.2
4.4 VG(L) P.GND VC2
12 7
D641 ERB38-06V1 Q640 2SK2876-01MR-F122 MAIN CONVERTER OUT
R642 10
14 15 16 4
2 3 1
4.4 15.1
11
R656 100 :CHIP R654 47 :CHIP
C641 100p 1kV :SL
S
4.4
C656 2200 25V L653 C657 100µ H 47 25V
-15V
-15V
R661 0 :CHIP
LB DET
C640 R641 10k 10 :CHIP
D652 D4SBS4
8
10
9
10.2
C602 0.47 250V
R696 270 1/2W
R612 100
C649 1000p B:CHIP
D697 MA111-TX
R660 4.7k :RN-CP
E
S601 POWER
0 16.6
3 2
Q610 DTA143ZSA-TP VCC SW
R635 1M 1/2W R636 1M 1/2W
1.8
1.8
1.1
4 1
0
Q652 DTC114ESA-TP PROTECT
C692 220 6.3V R665 2.2k
D632 P6KE200AG23
16.6 4
0 :SRT
5 6
T630
D680 FCH10A15
PH620 TLP421F
4.1
R655 1k :CHIP
F
R601 330k 1/2W :SURGE
C603 470p 250V B
C604 470p 250V B
D634 D1NL20U-TR D635 RD27ES-T1B
C632 2.2 C630 0.1 25V :CHIP
D633 ERB38-06V1 D631 D1NL20U-TR
C631 100 25V R632 R633 22k 120 :CHIP C615 100 2kV
3 2 1 385
L680 22µ H C680 4700 16V
PWR SW1 PWR SW
VDR601
IC680 C682 MM1431ATT 4700p :PT RECT
4.9 3 3 1 1 2 2 2
7V C681 220 10V
8
R670 15k :RN-CP
IC652 BA3953T-V5 3.3V/5V REG
+80V
1
T601 :LFT
4 3
RY603
2
8
VREF
7
VCC
6
OUT
5
GND
D692 1SS119-25TD
12.1 4 2 0
Q630 2SK2647-01MR-F91 S REG SW 1.2 D694 -0.1 1SS119-25TD PH630
R634 1k
16.1
4.8
1.4
+3.3V 1 2 3 4
6.7
TLP421F
1
ISENS
6
COMP
AC IN
AC L NC AC N DGC NC NC DGC
CN601 4P WHT :VH
1 2 3 1 2 3 4
4700p :CHIP R638 10k :CHIP THP602 C693 1000p 250V
R637 6.8k :CHIP
-0.1
0 FH602
5
3
1
Q611 DTC143XSA-TP RELAY DRIVE C629
FB
0
CN602 3P WHT :VH
FH601
RT/CT
G
C601 1 250V F601 SG601 6.3A
IC630 FA13842P REG
4.8
R631 1 1W :RS
5.9
R686 220 :CHIP
3.3V Vcc GND 5V CTL
5 +5V
R617 10k :CHIP
4
3
2
1
2
3
4 20
R629 15k :RN-CP C636 2200p B:CHIP
R687 4.9 22k :CHIP
R671 10k :RN-CP L612 4.7µ H
C686 220 6.3V C683 220 6.3V
D643 MA111
R618 1k :CHIP
D644 MA111
DGC
VDR602
C635 470p B:CHIP
DGS SW
H
9 8 7 6 5 4 3 2 1
B-SSS9328-D..-P3-EPS05
I
5V 3.3V 7V +12V GND +80V NC +B +B
TO A1 BOARD CN312
CN604 9P BLK
P1130(E) 4-12
(3) Schematic Diagram of DA Board
1
2
3
H BLK
4
5
6
7
8
9
10
A
VS OUT HS OUT PLL LOCK SDA SCL C1103 C1104 0.1 0.1 25V 25V B:CHIP B:CHIP 3.3V C1102 0.1 25V B:CHIP C1101 0.1 25V B:CHIP RB1102 1k :CHIP C1139 0.1 25V B:CHIP
DA(DPU)
R1139 47k :CHIP RB1101 100 :CHIP C1105 0.01 B:CHIP
LCC_NS HSAW_SW HLINBAL HCENT
3.3V
B
CN1101 40P
C1108 0.01 B:CHIP
3.3V
C1137 47 6.3V
C
D
E
F
XSC YSC D.TILT XDC HFBP YDC HD OUT REFDC HSHAPE +12V NC +12V A.GND 3.3V D.GND D.GND HSAW_SW GXSC LCC_NS GYSC IIC SDA IIC SCL A.GND A.GND H.LINBAL H BLK NC HS OUT DCC2 VS OUT VSAWN NC A.GND PLL LOCK A.GND POC A.GND A.GND V.DF H.DF TO D-a BOARD CN502
40 39 38 37 36 35 34 33 32 31 30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
C1109 0.01 B:CHIP C1110 0.01 B:CHIP C1111 0.01 B:CHIP C1112 0.1 25V B:CHIP C1113 0.01 B:CHIP C1115 0.01 B:CHIP
R1103 100 :CHIP PLL LOCK HLINBAL
GXSC VDF D.TILT YSC XSC HSHAPE H BLK VS OUT HS OUT REF DC HD OUT YDC H FBP XDC R1112 R1108 10k 5.6k :CHIP :CHIP
12V
R1102 2.2k :CHIP
3.3V
C1117 C1116 6800p B:CHIP 0.01 R1109 B:CHIP 5.6k :CHIP 12V
RB1106 1k :CHIP
2
7
FB1101
3
6
C1131 0.1 25V B:CHIP
R1114 1k :CHIP
IC1102 NJM2904M AMP
R1141 C1122 100 0.1 25V B:CHIP :CHIP C1140 R1134 100p 3.3k CH:CHIP :RN-CP R1115 47k :RN-CP R1113 3.9k :RN-CP
HDF1 DCC2 XDC AVDD1 TEST0 TEST1 MOR-FIL TEST5 PIN/KEYBAL AVDD0 PC2-FIL OSC-LIM2 OSC-REF2 VCO-FIL PC-ADJ
C1121 6800p R1131 100
YDC R1116 R1119 1.5k 1k :RN-CP :CHIP RB1104 100 :CHIP
R1132 100 :CHIP DCC2
C1125 0.01 B:CHIP
1
2
3
4
5
6
7
8
9 10 11 12 13 14 15 16
OSC-REF1
R1136 1k :CHIP
49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64
GXSC VDF VKEY YSC XSC HSHAPE DGND2 TEST3 TEST4 ASW1 ASW2 AGND1 VSAWL VSAWH YDC DCC
HSAW_SW LCC_NS RESET SCL SDA LOCK-DET H-IN DGND1 V-IN H.BLK VSAWRST VSH
GYSC DVDD2 PWM3 PWM2
GYSC
RB1103 1k :CHIP
48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33
SDA SCL
IC1101 CXD9563Q DPU
P3 DVDD1 P2 P1 P0 POC-OUT POC-IN P4 TEST2 FBP-IN DVDD0 HDOUT DGND0 AGND0 PC1-FIL
32 31 30 29 28 27 26 25 24 23 22 21 20 19 18 OSC-LIM1 17
R1106 47k :RN-CP C1118 R1110 0.1 10k 25V :RN-CP B:CHIP POC C1114 4700p B:CHIP R1111 8.2k :RN-CP H FBP C1119 0.01 B:CHIP HD OUT R1133 R1118 10k 1M :CHIP :CHIP C1120 100p CH:CHIP
3.3V
1
4
5
8
R1122 2.2k :RN-CP C1123 C1124 0.047 100p 25V CH:CHIP B:CHIP R1126 430 :RN-CP
D1106 STZ6.8
HDF REF DC XDC
3.3V
R1101 100 :CHIP HD OUT C1138 100p CH:CHIP
C1126 0.01 B:CHIP R1128 220k :CHIP R1137 C1127 180k 2.2 :RN-CP 6.3V B:CHIP R1142 R1129 0 22k :CHIP :RN-CP
D1104 1SS357
R1135 1M :CHIP C1130 C1129 680p 0.15 B:CHIP 16V B:CHIP R1127 10k :CHIP
R1124 R1125 470 2.2k :RN-CP:RN-CP R1123 C1128 1.6k 220 :RN-CP 4V :CHIP C1132 C1133 220 4V :CHIP 0.01 B:CHIP
RB1105 100 :CHIP
D1105 STZ6.8
H FBP POC
VDF HDF
D1107 STZ6.8
B-SSS9328-DA..-EPS05
P1130(E)
4-14
(4) Schematic Diagram of H4 Board
1
2
3
4
5
6
7
8
9
10
A
R1422 22k C1404 0.01 R1423 22k
CN1401 5P
1 2 3 4 5
B
Q1402 DTA124ESA
5
C1403 0.01
C1405 47 16V
GND VY VX +5V +12V
TO MAGNETIC SENSOR CN1400 14P
C
S1405
R1400 220 :RN
R1401 220 :RN
R1402 100 :RN
R1403 100 :RN
R1408 470
0
FB1401 1.1µH FB1402 1.1µH FB1403 1.1µH C1401 47 16V
D1402 1SS119 D1403 1SS119
S1404
S1402
S1400
+
-
OK
BRT
R1404 470 :RN S1401
CONT
R1409 100k
D
Q1400 DTC114ESA-TP LED DRIVE
R1406 150
5 0.1 3.3 0.7
R1407 220 R1421 10k :RN R1424 22k :RN TH1400 R1419 100k 10K C1498 0.1 :B FB1404 JW(5) FB1405 JW(5) FB1406 JW(5)
E
POWER G
Q1401 DTC114TSA LED DRIVE
INPUT1
S1403 C1400 10
R1420 10k
C1407 47 16V
A
1 2 3 4 5 6 7 8 9 10 11 12 13 14
+12V WAKE UP KEY SCAN LED 1 LED 2 GND +5V INPUT SW GND GND GND T_AMB VY VX
TO D- b BOARD CN1106
CHASSIS GND TO N BOARD CN1003
D1400 SML79423C-TP15
INPUT2
F
H4(USER
CONTROL)
B-SSS9328-H4..-EPS05
P1130(E)
4-16
(5) Schematic Diagram of L2 Board
1
2
3
4
5
6
7
8
9
10
A
C1619 0.1 25V F:CHIP C1607 330p B:CHIP R1601 4.7 :CHIP
CN1600 2P WHT :S-MICRO
1 2 8 7 6 LCCLB
R1600 10k :CHIP C1600 0.1 25V B:CHIP FB1600 1.1µH C1608 0.1 25V B:CHIP R1604 10k :CHIP R1605 22 1W :RS
0
LCC-NS
LCC-NS(+) LCC-NS(-)
24 23 22 21 20 19 18 17 16 15 14 13
GND Vss1 Vdd1 SDA SCL MOD CS2 CS1 CS0 Vdd2 Vss2 Vcc
10
9
V.S2
OUT2
VCC
+
4
IC1602 MB88141PF DAC
V/S1
OUT1
B
GXSC GYSC
AO1 AO2 AO3 AO4 AO5 AO6 AO7 AO8 AO9 AO10 AO11 AO12
1
2
3
4
5
6
7
8
9 10 11 12
C1611 0.01 B:CHIP
1
2
-
3
LCCLB LCCLT LCCRB LCCRT
R1603 4.7 :CHIP C1604 330p B:CHIP R1608 8.2k :CHIP
VEE
5
C1613 0.01 B:CHIP R1610 8.2k :CHIP
IC1600 LA6510 AMP
+
V.S2
OUT2
VCC
R1653 C1628 1.2 47 :FPRD 25V
IC1605 NJM78L05 +5V REG
I G O
C1633 10 16V C1605 0.01 R1607 B:CHIP R1609 22 4.7k 1W :CHIP :RS
IC1601 LA6510 AMP 10
R1613 4.7 :CHIP
9
8
7
6
+
4
C
GXSC
0
CN1601 4P WHT :S-MICRO
R1652 1.2 :FPRD
CY4CY4+ CY3CY3+
CN1603 8P WHT
4 3 2 1
GYSC
C1632 47 25V
C1606 0.01 B:CHIP R1611 22 R1617 1W 4.7k :RS :CHIP
V.S1
OUT1
1
2
R1621 4.7 :CHIP
3
VEE
5
C1614 0.01 B:CHIP
-
+
CN1602 8P YEL :S-MICRO
1 2 3 4 5 6 7 8
LCCLT
R1624 10k :CHIP R1650 1.2 :FPRD R1651 1.2 :FPRD C1639 47 25V C1640 47 25V R1631 10k :CHIP R1654 100 :CHIP C1627 C1623 FB1604 0.1 0.1 1.1µH B:CHIP B:CHIP R1635 15k :CHIP R1636 22 1W :RS C1617 0.1 25V B:CHIP C1621 0.1 25V B:CHIP R1628 10k :CHIP C1622 0.1 25V B:CHIP R1634 4.7 :CHIP FB1601 1.1µH C1618 0.1 25V B:CHIP R1625 10k :CHIP R1626 22 1W :RS
0
LCC-LT LCC-LB LCC-RT LCC-RB
D
-15V +15V GND GXSC GYSC LCC_NS IIC SDA IIC SCL
TO D- b BOARD CN1106
1 2 3 4 5 6 7 8
R1655 100 :CHIP
LCCRB
FB1602 1.1µH
R1629 10k :CHIP R1630 22 1W :RS
LCC-LT(+) LCC-LT(-) LCC-LB(+) LCC-LB(-) LCC-RT(+) LCC-RT(-) LCC-RB(+) LCC-RB(-)
2
4
10
9
8
7
6
VCC
V.S2
+
4
FB1603 1.1µH
V.S1
OUT1
IC1603 LA6500-FA AMP
+
1
E
3
5
R1641 18k :CHIP R1644 1.5k :CHIP
1
2
R1643 4.7 :CHIP
3
C1629 0.01 B:CHIP
LCCRT
R1647 10k :CHIP R1640 4.7k :CHIP C1637 0.1 25V B:CHIP
L2(CY,LCC)
F
VEE
5
VEE
VCC
-
IC1604 LA6510 AMP
+
-
OUT
OUT2
C1638 0.1 25V B:CHIP
R1648 10k :CHIP
R1649 22 1W :RS B-SSS9328-L2..-EPS05
P1130(E)
4-18
(6) Schematic Diagram of N Board
1
2
3
4
5
6
7
8
9
10
11
12
13
14
A
N(µ-COM)
WAKE UP
FB1004 0 :CHIP VY VX T AMB LUMI INPUT SW S0 S1 S2 S3 S4 S5 S6 S7 ECO SW V FBP HV DET ABL DET IK SIGMA LB DET KEY SCAN C1001 0.01 B:CHIP R1001 1.5M :CHIP RB1001 100 :CHIP RB1002 100 :CHIP FB1007 0 :CHIP FB1003 0 :CHIP FB1005 0 :CHIP FB1006 0 :CHIP
FB1002 0 :CHIP
CN1003 6P :S-MICRO(L)
1 2 3 4 5 6
B
GND VX VY T_AMB LUMI(NC) 5V(NC)
TO H4 BOARD CN1400 11-14 PIN
5V
C
RB1003 100 :CHIP RB1004 100 :CHIP RB1005 100 :CHIP
D1001 MA111-TX
ABL DET C1002 0.01 B:CHIP HV DET T AMB
R1003 100 :CHIP C1027 0.01 B:CHIP
VY
VX
WAKE UP
D
R1042 10k :CHIP
C1028 C1014 47 0.1 6.3V 25V B:CHIP :CHIP C1015 0.01 B:CHIP
C1002 0.01 B:CHIP C1004 0.01 B:CHIP C1005 0.01 B:CHIP
ECO SW
LUMI
24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9
8
7
6
5
4
3
2
1
CN1001 44P
5V 44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
R1043 1M :CHIP R1004 4.7k :CHIP R1041 4.7k :CHIP POC C1030 0.01 B:CHIP LOCK SDA RB1006 100 :CHIP SCL TXD RXD
E
DDC GND2
DDC GND1
LED2
5V
FB1001
C1017 0.01 B:CHIP C1018 3p CH:CHIP
41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64
C1019 22p CH:CHIP
5V
DEGAUSS REMOTE FAN SW HEATER
R1011 4.7k :CHIP R1012 4.7k :CHIP C1021 0.01 B:CHIP
5V
X1001 16.9344MHz C1020 100 6.3V :CHIP R1015 4.7k :CHIP C1022 0.01 B:CHIP R1020 47 :CHIP R1021 47 :CHIP
VCC OUT GND
G
RB1007 100 :CHIP
5
6
7
8
R1014 4.7k :CHIP
IC1003 BR24C16F-E2
IC1002 PST574CMT-T1 RESET
REMOTE HEATER DEGAUSS DDC GND1
4
C1023 0.01 B:CHIP
3
2
1
H
R1018 47 :CHIP R1019 47 :CHIP
LED2 LED1 DDC GND2 DSCL2 DSDA2 DSCL1
I
R1040 100 :CHIP R1017 1k :CHIP R1016 100 :CHIP
DSDA1
R1044 1M :CHIP
B-SSS9328-N..-EPS05
LED1
C1029 0.01 B:CHIP
P12/A10/AD10
P10/A8/AD8
P11/A9/AD9
X2 DVSS1 X1 REGOUT AM1 RESET EMU0 EMU1 R84/SDA2 P85/SCL2 P86/SDA1 P87/SCL1 ALE P00/AD0 P01/AD1 P02/AD2 P03/AD3 P04/AD4 P05/AD5 P06/AD6 P07/AD7
F
NC GND NC NC POC PLL LOCK GND S7 WAKE UP KEY SCAN IK SIGMA LED1 LB DET LED2 V.FBP INPUT SW S0 +5V S1 DGS SW S2 PWR SW GND HTR SW GND GND S3 DDC GND2 S4 DDC SCL2 S5 DDC SDA2 S6 DDC GND1 G2 DDC SCL1 ABL DET DDC SDA1 HV DET ECO SW RXD IIC SCL TXD IIC SDA TO D- a BOARD CN1104
RB1009 100 :CHIP
25 VREFL 26 AVSS 27 AVCC 28 P70/TA1OUT R1006 4.7k 29 P71/TA3OUT :CHIP 30 P72/TA5OUT 31 P73/TB0IN0/IN5 R1005 4.7k 32 P74/TB0IN1/INT6 :CHIP 33 P75/TB0OUT0 34 P76/SCK0/INT3 35 P80/SDA0/SI0 R1010 36 P81/SCL0/SO0 1k :CHIP 37 P82/TXD0 38 P83/RXD0 5V 39 AM0 40 DVCC1
VREFH P42/AN11 P42/AN10 P41/AN09 P40/AN08 P57/AN07 P56/AN06 P55/AN05 P54/AN04 P53/AN03/ADTRG P52/AN02 P51/AN01 P50/AN00 P62/SCOUT/INT2 P61/CTS0/INT1 P60/INT0 P37/INT4 P36/TA7OUT P35/TA61N P34 P33/WAIT P32/HWR P31/WR P30/RD
IC1001 TMP91CW18F-1B69(Z) CPU
P26/A6/A22 P25/A5/A21 P24/A4/A20 P23/A3/A19 P22/A2/A18 DVCC2 NMI DVSS2 P21/A1/A17 P20/A0/A16 P17/A15/AD15 P16/A14/AD14 P15/A13/AD13
80 79 78 77 76 75 74 73 72 71 70 69 68 67 P14/A12/AD12 66 P13/A11/AD11 65
P27/A7/A23
INPUT SW
Q1001 DTC124EU INVERTER
V FBP
S7
S6
S5
S4
S3
S2
S1
S0
5V R1023 4.7k :CHIP C1016 R1022 0.01 4.7k B:CHIP :CHIP
R1008 100 :CHIP R1009 100 :CHIP
P1130(E) 4-20