Text preview for : Pioneer-DJM909 mix.pdf part of Pioneer DJM909 DJ mixer
Back to : Pioneer-DJM909 mix.part1. | Home
MIC
PHONO 1 /LINE 1 CD 1
BANK 1
BANK 1
CH-1
PHONO 2 /LINE 2 CD 2
MIC LEVEL TRIM
BANK 2 BANK 2
MASTER LEVEL TRIM
0
0
HI
+9
BANK 3
BANK 3
+9
BOOTH/SESSION OUT HI
HI
-12 +12
FX ADJ.
FX ADJ.
0
LOW
-26 +6
PHONES
FADER CURVE FADER CURVE
-26 +6
MID
-12 +12
MID
0
BANK EDIT
BANK EDIT PROFESSIONAL 2CHANNEL MIXER
SELECT
MASTER -26 +6
MIC SEND
-26 +6
TIME/SELECT
LOW
DJM-909
EFFECT EFFECT
LOCK ON OFF ON
TIME/SELECT
LOW
EFFECT CUE
SESSION IN
-26 0 +6
CH-1
CH-2
MIX/DEPTH
MIX/DEPTH
-26
+6
EQ
OFF MIN ON MAX MIN MAX
EQ
OFF
CH-1 SEND
CH-2 SEND
TAP
TAP
ON
FADER START
TRANSFORM
TRANSFORM
FADER START
MASTER LEVEL REVERSE REVERSE
L CH-1
10 9 8 7 6 5 4 3 2 1 0 14 9 5 3 1 0 1 3 6 9 15 22 dB
R
14 9 5 3 1 0 1 3 6 9 15 22 dB 10 9 8 7 6 5 4 3 2 1 0
CH-2
CH-1 FADER START
CH-2 FADER START
CH-1
CH-2
REVERSE C.F.1 FADER START C.F.2 FADER START
ORDER NO.
1
2
FEELING ADJ.
FOOT SW
PHONES POWER
RRV2871
DJM-909
DJ MIXER
DJM-909
THIS MANUAL IS APPLICABLE TO THE FOLLOWING MODEL(S) AND TYPE(S).
Model
DJM-909 DJM-909 DJM-909
Type
KUCXJ WYXJ TLTXJ AC120V
Power Requirement
Remarks
AC220 - 240V AC110 - 240V
For details, refer to "Important symbols for good services" .
PIONEER CORPORATION
4-1, Meguro 1-chome, Meguro-ku, Tokyo 153-8654, Japan PIONEER ELECTRONICS (USA) INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A. PIONEER EUROPE NV Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra Road, #04-01, Singapore 159936
PIONEER CORPORATION 2003
T-ZZY DEC. 2003 printed in Japan
1
2
3
4
SAFETY INFORMATION
A
This service manual is intended for qualified service technicians ; it is not meant for the casual do-ityourselfer. Qualified technicians have the necessary test equipment and tools, and have been trained to properly and safely repair complex products such as those covered by this manual. Improperly performed repairs can adversely affect the safety and reliability of the product and may void the warranty. If you are not qualified to perform the repair of this product properly and safely, you should not risk trying to do so and refer the repair to a qualified service technician.
WARNING This product contains lead in solder and certain electrical parts contain chemicals which are known to the state of California to cause cancer, birth defects or other reproductive harm. Health & Safety Code Section 25249.6 Proposition 65
B
C
(FOR USA MODEL ONLY)
1. SAFETY PRECAUTIONS
The following check should be performed for the continued protection of the customer and service technician.
ANY MEASUREMENTS NOT WITHIN THE LIMITS OUTLINED ABOVE ARE INDICATIVE OF A POTENTIAL SHOCK HAZARD AND MUST BE CORRECTED BEFORE RETURNING THE APPLIANCE TO THE CUSTOMER.
LEAKAGE CURRENT CHECK
D
Measure leakage current to a known earth ground (water pipe, conduit, etc.) by connecting a leakage current tester such as Simpson Model 229-2 or equivalent between the earth ground and all exposed metal parts of the appliance (input/output terminals, screwheads, metal overlays, control shaft, etc.). Plug the AC line cord of the appliance directly into a 120V AC 60Hz outlet and turn the AC power switch on. Any current measured must not exceed 0.5mA.
2. PRODUCT SAFETY NOTICE
Many electrical and mechanical parts in the appliance have special safety related characteristics. These are often not evident from visual inspection nor the protection afforded by them necessarily can be obtained by using replacement components rated for voltage, wattage, etc. Replacement parts which have these special safety characteristics are identified in this Service Manual. Electrical components having such features are identified by marking with a on the schematics and on the parts list in this Service Manual. The use of a substitute replacement component which does not have the same safety characteristics as the PIONEER recommended replacement one, shown in the parts list in this Service Manual, may create shock, fire, or other hazards. Product Safety is continuously under review and new instructions are issued from time to time. For the latest information, always consult the current PIONEER Service Manual. A subscription to, or additional copies of, PIONEER Service Manual may be obtained at a nominal charge from PIONEER.
E
Device under test Test all exposed metal surfaces
Reading should Leakage not be above current 0.5mA tester
Also test with plug reversed (Using AC adapter plug as required)
F
Earth ground
AC Leakage Test
2
1 2
DJM-909
3 4
5
6
7
8
[ Important symbols for good services ]
In this manual, the symbols shown-below indicate that adjustments, settings or cleaning should be made securely. When you find the procedures bearing any of the symbols, be sure to fulfill them:
A
1. Product safety
You should conform to the regulations governing the product (safety, radio and noise, and other regulations), and should keep the safety during servicing by following the safety instructions described in this manual.
2. Adjustments
To keep the original performances of the product, optimum adjustments or specification confirmation is indispensable. In accordance with the procedures or instructions described in this manual, adjustments should be performed.
3. Cleaning
For optical pickups, tape-deck heads, lenses and mirrors used in projection monitors, and other parts requiring cleaning, proper cleaning should be performed to restore their performances.
B
4. Shipping mode and shipping screws
To protect the product from damages or failures that may be caused during transit, the shipping mode should be set or the shipping screws should be installed before shipping out in accordance with this manual, if necessary.
5. Lubricants, glues, and replacement parts
Appropriately applying grease or glue can maintain the product performances. But improper lubrication or applying glue may lead to failures or troubles in the product. By following the instructions in this manual, be sure to apply the prescribed grease or glue to proper portions by the appropriate amount.For replacement parts or tools, the prescribed ones should be used.
C
CONTENTS
SAFETY INFORMATION......................................................................................................................................2 1. SPECIFICATIONS .............................................................................................................................................5 2. EXPLODED VIEWS AND PARTS LIST.............................................................................................................6 2.1 PACKING ....................................................................................................................................................6 2.2 EXTERIOR SECTION ................................................................................................................................8 2.3 CONTROL PANEL (LOWER) SECTION ..................................................................................................10 2.4 CONTROL PANEL (UPPER) SECTION ...................................................................................................12 2.5 FRONT PANEL SECTION ........................................................................................................................14 3. BLOCK DIAGRAM AND SCHEMATIC DIAGRAM ..........................................................................................16 3.1 BLOCK DIAGRAM....................................................................................................................................16 3.1.1 OVERALL BLOCK DIAGRAM ............................................................................................................16 3.1.2 DSP/ LCD BLOCK DIAGRAM............................................................................................................18 3.2 OVERALL CONNECTION DIAGRAM ......................................................................................................20 3.3 MAIN ASSY (1/6)......................................................................................................................................22 3.4 MAIN ASSY (2/6)......................................................................................................................................24 3.5 MAIN ASSY (3/6)......................................................................................................................................26 3.6 MAIN ASSY (4/6)......................................................................................................................................28 3.7 MAIN ASSY (5/6)......................................................................................................................................30 3.8 MAIN ASSY (6/6)......................................................................................................................................32 3.9 DSP ASSY (1/2) .......................................................................................................................................34 3.10 DSP ASSY (2/2) .....................................................................................................................................36 3.11 C1EQ ASSY (1/2) ...................................................................................................................................38 3.12 C1EQ ASSY (2/2) ...................................................................................................................................40 3.13 C2EQ ASSY ...........................................................................................................................................42 3.14 C1BF ASSY ............................................................................................................................................44 3.15 C2BF ASSY ............................................................................................................................................46 3.16 MICB ASSY ............................................................................................................................................48 3.17 HPBO ASSY ...........................................................................................................................................50 DJM-909
5 6 7 8 D
E
F
3
1
2
3
4
A
B
C
D
3.18 FDVR ASSY ........................................................................................................................................... 52 3.19 SDRT ASSY........................................................................................................................................... 54 3.20 XLR ASSY (1/2) ..................................................................................................................................... 56 3.21 XLR ASSY (2/2) ..................................................................................................................................... 58 3.22 LVMR (1/2), C1TR, C2TR, FVA1 and FVA2 ASSYS .............................................................................. 60 3.23 LVMR ASSY (2/2) .................................................................................................................................. 62 3.24 CFVR, RVSW and FSSW ASSYS ......................................................................................................... 64 3.25 LCD ASSY ............................................................................................................................................. 66 3.26 SW POWER SUPPLAY.......................................................................................................................... 68 3.27 VOLTAGES ............................................................................................................................................. 69 3.28 WAVEFORMS ........................................................................................................................................ 75 4. PCB CONNECTION DIAGRAM ..................................................................................................................... 80 4.1 MAIN ASSY ............................................................................................................................................. 80 4.2 DSP ASSY ............................................................................................................................................... 84 4.3 C1EQ ASSY............................................................................................................................................. 86 4.4 C2EQ ASSY............................................................................................................................................. 87 4.5 C1BF ASSY ............................................................................................................................................. 88 4.6 C2BF ASSY ............................................................................................................................................. 89 4.7 MICB ASSY ............................................................................................................................................. 90 4.8 HPBO ASSY ............................................................................................................................................ 91 4.9 LVMR, C1TR, C2TR, FVA1, FVA2 and FDVR ASSYS............................................................................. 92 4.10 LVMR, C1TR, C2TR, FVA1, FVA2 and FDVR ASSYS........................................................................... 94 4.11 SDRT ASSYS ........................................................................................................................................ 96 4.12 XLR ASSY ............................................................................................................................................. 97 4.13 CFVR, RVSW and FSSW ASSYS ......................................................................................................... 98 4.14 LCD ASSY ........................................................................................................................................... 100 4.15 SW POWER SUPPLY .......................................................................................................................... 102 5. PCB PARTS LIST ......................................................................................................................................... 104 6. ADJUSTMENT ............................................................................................................................................. 112 6.1 ADJUSTMENT REQUIRED WHEN THE SET IS REPAIRED OR REPLACED ..................................... 112 6.2 CH1 OFFSET ADJUSTMENT................................................................................................................ 114 6.3 CH1 GAIN ADJUSTMENT ..................................................................................................................... 115 6.4 CH2 OFFSET ADJUSTMENT................................................................................................................ 116 6.5 CH2 GAIN ADJUSTMENT ..................................................................................................................... 117 6.6 CH1 EQ Low ADJUSTMENT ................................................................................................................. 118 6.7 CH1 EQ Mid ADJUSTMENT.................................................................................................................. 119 6.8 CH1 EQ Hi ADJUSTMENT .................................................................................................................... 120 6.9 CH2 EQ Low ADJUSTMENT ................................................................................................................. 121 6.10 CH2 EQ Mid ADJUSTMENT................................................................................................................ 122 6.11 CH2 EQ Hi ADJUSTMENT .................................................................................................................. 123 7. GENERAL INFORMATION ........................................................................................................................... 124 7.1 DIAGNOSIS ........................................................................................................................................... 124 7.1.1 SERVICE MODE ............................................................................................................................. 124 7.1.2 Rewriting of the Software................................................................................................................. 128 7.1.3 POWER ON SEQUENCE................................................................................................................ 135 7.1.4 Table of the roles of the microcomputers ......................................................................................... 136 7.1.5 DISASSEMBLY................................................................................................................................ 138 7.1.6 CONFIGURATION OF THE PC BOARD ......................................................................................... 144 7.2 PARTS.................................................................................................................................................... 145 7.2.1 IC INFORMATION ........................................................................................................................... 145 8. PANEL FACILITIES AND SPECIFICATIONS ............................................................................................... 150
E
F
4
1 2
DJM-909
3 4
5
6
7
8
1. SPECIFICATIONS
A
Audio Section
Input terminal (input level/impedance) CD 1, 2 ................................................. 14 dBV (200 mV) / 22 k LINE 1, 2 .............................................. 14 dBV (200 mV) / 47 k PHONO 1, 2 ............................................. 54 dBV (2 mV) / 47 k MIC .................................................. ......... 54 dBV (2 mV) / 3 k SESSION IN ........................................ 14 dBV (200 mV) / 22 k RETURN ............................................. 14 dBV (200 mV) / 22 k
[KUCXJ type] Electrical Section, etc.
Power supply voltage .......................................... AC 120 V, 60 Hz Power consumption ............................................................... 31 W Operating temperature ................ +5 °C to +35 °C (41 °F to 95 °F) Operating humidity ....................................................... 5% to 85% External dimensions ............. 251 (W) x 381.6 (D) x 107.9 (H) mm 9-7/8 (W) x 15 (D) x 4-1/4 (H) in Weight .................................................................................. 6.5 kg 14 lbs 5 oz
Output terminal (output level/impedance)
MASTER OUT 1 (XLR) .................................... 0 dBV (1 V) / 600 MASTER OUT 2 (RCA) ................................... 0 dBV (1 V) / 1 k BOOTH / SESSION OUT ................................ 0 dBV (1 V) / 1 k SEND .................................................... 14 dBV (200 mV) / 1 k PHONES ............................................... 6 dBV (2 V) / 22 or less (Rated load impedance 32 )
Accessories
÷ Hexagonal Allen driver ............................................................. 1 ÷ These operating instructions..................................................... 1 ÷ Warranty ................................................................................... 1
B
Frequency characteristics
CD, LINE, MIC ..................................................... 20 Hz to 20 kHz PHONO (RIAA) .................................................... 20 Hz to 20 kHz
[WYXJ type] Electrical Section, etc.
Power supply voltage .............................. AC 220-240 V, 50/60 Hz Power consumption ............................................................... 30 W Operating temperature ............................................ +5°C to +35°C Operating humidity ....................................................... 5% to 85% External dimensions ............. 251 (W) x 381.6 (D) x 107.9 (H) mm Weight .................................................................................. 6.5 kg
SN ratio
CD, LINE ........................................ 93 dB or more (EFFECT OFF) PHONO................................................................... 78 dB or more MIC ......................................................................... 64 dB or more
Total harmonic distortion rate
CD, LINE ................................................................. 0.02% or less Cross talk (1 kHz) .................................................... 77 dB or more
Accessories
÷ Hexagonal Allen driver ............................................................. 1 ÷ These operating instructions..................................................... 1
C
Channel equalizer (CD, LINE/PHONO)
HI ........................................................................ +6 dB to 26 dB MID...................................................................... +6 dB to 26 dB LOW ................................................................... +6 dB to 26 dB
[TLTXJ type] Electrical Section, etc.
Power supply voltage .............................. AC 110-240 V, 50/60 Hz Power consumption ............................................................... 30 W Operating temperature ........................................... +5°C to +35°C Operating humidity ....................................................... 5% to 85% External dimensions ............. 251 (W) x 381.6 (D) x 107.9 (H) mm Weight .................................................................................. 6.5 kg
Microphone equalizer (MIC)
HI ....................................................................... +12 dB to 12 dB LOW .................................................................. +12 dB to 12 dB
Accessories
÷ Hexagonal Allen driver ............................................................. 1 ÷ These operating instructions..................................................... 1 For improvement purposes, specifications and design may be subject to modification without notice.
D
E
Accessories
¶ Hexagonal Allen driver..........x1 (DEX1018)
¶ Operating instructions................... x1 ¶ Warranty........................................ x1
F
DJM-909
5 6 7 8
5
1
2
3
4
2. EXPLODED VIEWS AND PARTS LIST
NOTES:
A
Parts marked by "NSP" are generally unavailable because they are not in our Master Spare Parts List. The mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. Screws adjacent to mark on product are used for disassembly. For the applying amount of lubricants or glue, follow the instructions in this manual. (In the case of no amount instructions, apply as you think it appropriate.)
2.1 PACKING
1
B
3 2 4
6
8
C
7
D
5
E
FRONT 10
9
F
6
1 2
DJM-909
3 4
5
6
7
8
PACKING parts List
Mark No. 1 NSP 2 3 4 Description Hexagon Screwdriver Warranty Card Operating Instructions Polyethylene Bag (0.03 x 230 x 340) Pad (A) Part No. DEX1018 See Contrast table(2) See Contrast table(2) Z21-038 Mark No. 6 7 8 9 NSP 10 Description Pad (B) Sheet Polyethylene Bag Packing Case Label Part No. DHA1587 RHX1006 VHL1051 See Contrast table(2) VRW1629
A
5
DHA1586
(2) CONTRAST TABLE DJM-909/ KUCXJ, DJM-909/ WYXJ and DJM-909/ TLTXJ are constructed the same except for the following :
Mark No. NSP Symbol and Description DJM-909 KUCXJ ARY7043 DRB1349 Not used Not used DHG2441 DJM-909 WYXJ Not used Not used DRB1350 Not used DHG2440 DJM-909 TLTXJ Not used Not used Not used DRB1351 DHG2442
B
2 Warranty Card 3 Operating Instructions (English) 3 Operating Instructions (English/ French/ German/ Italian/ Duch/ Spanish) 3 Operating Instructions (English/ Spanish/ Chinese) 9 Packing Case
C
D
E
F
DJM-909
5 6 7 8
7
1
2
3
4
2.2 EXTERIOR SECTION
A
Refer to "2.3 CONTROL PANEL (LOWER) SECTION". 48
J
Refer to "2.4 CONTROL PANEL (UPPER) SECTION". 48
48 48
48 48
52
B D O N
B
NON-CONTACT SIDE
10
K
A
I
4 11
CONTACT SIDE
J
15 5 3
O
2
E
13
M
K F
D L
12 25 49 17
C
M
16 14 49 19
H
N
49 21
49 21 49
20
18
41 40
C
49 39 49
K 49 L
42
A
1 38
35 49
22 30 24
E
J
10
50 43 49 50
28 44 45 49
49 49
23
D
F
49 26 49
B
36 49
B
G H
I
G
50 43 49 37 49 34 49
27 49
6
A
29
U
49
7
28 29
F C
E
49 31 9
P
49 8
47
E
30
21
P
49
46 33 32
49
49
49 49 Refer to "2.5 FRONT PANEL SECTION". 51
F
49 51
49
8
1 2
DJM-909
3 4
5
6
7
8
EXTERIOR SECTION Parts List
Mark No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 NSP 16 17 18 19 NSP 20 NSP 21 22 23 24 25 26 27 Description MAIN Assy C1BF Assy C2BF Assy SDRT Assy XLR Assy DSP Assy SW POWER SUPPLY AC Power Cord Strain Relief Flexible Cable (23P) Flexible Cable (15P) Flexible Cable (17P) Connector Assy (9P) Flexible Cable (27P) Locking Card Spacer PC Support Spacer B Shield Sheet G Spacer A Shield Case Cord Stopper Shield Sheet B Shield Sheet C Flexible Cable (19P) Flexible Cable (35P) Connector Assy Connector Assy Part No. DWX2337 DWS1328 DWS1329 DWX2321 DWX2322 DWX2316 DWR1377 See Contrast table(2) See Contrast table(2) DDD1239 DDD1243 DDD1234 DKP3662 DDD1242 PNW2917 VEC1584 DEC2622 DEC2610 DEC2617 DNH2572 ZCB-069Z DEC2570 DEC2584 DDD1238 DDD1241 PF08EE-D15 DKP3659
D
Mark No. 28 29 30 31 NSP 32 33 NSP 34 NSP 35 NSP 36 NSP 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52
Description Blind Cap Foot Flexible Cable (17P) Cord Stopper Stay Bottom Plate Rivet Chassis (9) Assy Partition Plate Chassis (9) Rear Panel Shield Sheet A Connector Assy (6P) Mini Clamp Flexible Cable (11P) Card Spacer Terminal Screw Washer Nut Cord Cover Power Knob Screw Screw Screw Screw Connector Assy (8P)
Part No. DNK4218 REC-434 DDD1246 DNH2576 DNH2570 RBM-003 DXB1815 DNH2573 DNA1296 See Contrast table(2) DEC2569 DKP3661 DEC2588 DDD1245 DNK2769 AKE-031 DBE1010 NKX2FUC DNK4197 DAC2133 CMZ30P100FZK BBZ30P060FZK BPZ30P080FMC BBZ40P120FMC DKP3660
A
> > >
B
C
(2) CONTRAST TABLE DJM-909/ KUCXJ, DJM-909/ WYXJ and DJM-909/ TLTXJ are constructed the same except for the following :
Mark No. > > NSP Symbol and Description DJM-909 KUCXJ VDG1075 CM-22C DNC1656 DJM-909 WYXJ VDG1077 CM-22B DNC1655 DJM-909 TLTXJ VDG1077 CM-22B DNC1657
8 AC Power Cord 9 Strain Relief 37 Rear Panel
E
F
DJM-909
5 6 7 8
9
1
2
3
4
2.3 CONTROL PANEL (LOWER) SECTION
A
7 7
NON-CONTACT SIDE
8
CONTACT SIDE
B
9 11 42 48 13 42
C
A
10
41 41 12
11
12
3 50 42 1
14
M O
41
B
4
N
41
KUCXJ 40 ONLY
16 17 16 18 19 43 20 43
D
42 13
48 24 16 17 16 22 23 29 44 25 47 29 46 28 44 30 27
To. B DSP ASSY (EXTERIOR SECTION: No.24)
46 32 5 46 34 34 33
A
21 24
I
49
2
P
33
35
33 45 31 47 37 36 42 33
To. B DSP ASSY (EXTERIOR SECTION: No.10)
45 26
B
34
E
15
L
6
42
39
38
F
38 42
10
1 2
DJM-909
3 4
5
6
7
8
CONTROL PANEL (LOWER) SECTION Parts List
Mark No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 Description FVA1 Assy FVA2 Assy C1TR Assy C2TR Assy FDVR Assy LVMR Assy Slider Knob (L) Control Panel (D9) Fader Packing (A) Push SW Guide SW Packing (A) Transform Panel CH Fader Bracket CR Fader Bracket Cross Fader Assy-S Washer O Ring (2.8) Slider Base Lever Plate Fader Magnet Yoke Encoder Plate S Stopper S Guide Shaft MG Plate Assy Part No. DWX2323 DWX2324 DWS1334 DWS1335 DWX2320 DWS1330 DNK4210 DNB1121 DEC2571 DNK4208 DEC2573 DNF1682 DNF1683 DNF1684 DXX2535 WT28D060D025 DEB1618 DNK4192 DNH2564 DMG1010 DNH2569 DEC2568 DNH2578 DLA1966 DXA1968 Mark No. 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 NSP 49 50 Description Case A Worm gear S Rack gear S MG Shaft WG Holder WG Spring Case B LED Lens (C) Push SW Knob (B) LED Lens (B) Level Meter Holder Flexible Cable (9P) Rivet Shield Sheet (F) 65 Label (S) Screw Screw Screw Screw Screw Screw Screw Thin Head Screw Panel Stay (D) Assy Screw Part No. DNK4193 DNK4195 DNK4196 DLA1947 DNF1681 DBK1245 DNK4194 DNK4217 DNK4207 DNK4216 DNK4214 DDD1240 RBM-003 DEC2591 See Contrast table(2) AMZ26P040FMC BBZ30P060FZK BPZ20P060FMC CPZ26P100FZK AMZ20P040FMC BPZ20P050FMC PBA1062 DBA1198 DXB1787 BPZ30P080FMC
B A
C
(2) CONTRAST TABLE DJM-909/ KUCXJ, DJM-909/ WYXJ and DJM-909/ TLTXJ are constructed the same except for the following :
Mark No. 40 65 Label (S) Symbol and Description DJM-909 KUCXJ DRW2164 DJM-909 WYXJ Not used DJM-909 TLTXJ Not used
D
E
F
DJM-909
5 6 7 8
11
1
2
3
4
2.4 CONTROL PANEL (UPPER) SECTION
A
NON-CONTACT SIDE
54
Types of the rotary Knobs (by color)
CONTACT SIDE
6 7
13
30
No.6
No.7
No.8
B
31 32 33
Gray Gray (No indicating line) No.9
B
Red
54
No.10
7 8 9
10 9 11 10 7
Red
Gray
34
14
35
C
36 15
C
55 20
18
39 54 54
12
37
52
16 52
12 15
40
Wide
12 53
54
38
53
A
20
20 56
21
12
17
54
56
20
22
41
Wide
43 44 42 45
D
17
56 56 23 24 25 26
56
54
46
C
1
57
27
B 47
58
26 60
E
5
T
59
48
25
26
D
A
C
2 55 55 55 49
To. E CIBF ASSY (EXTERIOR SECTION: No.12)
To. F C2BF ASSY (EXTERIOR SECTION: No.41)
25
28 51
G
F
3 4
55 55
H
50
12
1 2
DJM-909
3 4
5
6
7
8
CONTROL PANEL (UPPER) SECTION Parts List
Mark No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 NSP 23 24 25 26 27 28 29 30 Description C1EQ Assy C2EQ Assy MICB Assy HPBO Assy LCD Assy Rotary Knob (Small: Gray) Rotary Knob (Small: Gray) Rotary Knob (Small: Red) Rotary Knob (Large: Red) Rotary Knob (Large: Glay) Slider Knob (S) SW Packing (D) Escutcheon Control Panel (U9) Push SW Guide SW Packing (C) SW Packing (B) Fader Packing (B) ····· Flange Nut SW Packing (A) 65 Label (S) Panel Stay (U9) Shield Sheet E LED Lens (A) Push SW Knob (A) Cue Earth Plate Flexible Cable (7P) · · · · · Earth Plate Part No. DWS1326 DWS1327 DWX2318 DWX2319 DWX2317 DNK4205 DNK4203 DNK4204 DNK4202 DNK4201 DNK4211 DEC2580 DNK4222 DNB1120 DNK4208 DEC2621 DEC2574 DEC2572 DBN1004 DEC2573 See Contrast table(2) DND1250 DEC2581 DNK4215 DNK4206 DBK1252 DDD1244 DNH2577 Mark No. 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 Description Touch Panel Bracket Gasket LCD Module Diffusion Sheet Lighting Conductor Reflection Sheet LCD Holder LCD Holder (M) Earth Spring Earth Bracket Tap Knob Preset Knob Tact Knob (E) Tact Knob Shade Sheet LED Lens (C) Earth Lug Assy Shield Sheet D Flexible Cable (21P) Rivet Screw Screw Screw Screw Screw Screw Knob Cushion L Knob Cushion R Cue Fader Bracket Part No. DSX1062 DNH2574 DEC2632 DAV1002 DEC2619 DNK4200 DEC2620 DNK4199 DNK4225 DBK1248
B A
DNH2575 DNK4209 DNK4306 DNK4265 DNK4213 DEC2631 DNK4217 DDX1191 DEC2579 DDD1237 RBM-003 PBA1062 AMZ26P040FMC BBZ30P060FZK BPZ30P080FMC CMZ26P050FZK DBA1141 DEC2656 DEC2657 DNF1690
C
D
(2) CONTRAST TABLE DJM-909/ KUCXJ, DJM-909/ WYXJ and DJM-909/ TLTXJ are constructed the same except for the following :
Mark No. 22 65 Label (S) Symbol and Description DJM-909 KUCXJ DRW2164 DJM-909 WYXJ Not used DJM-909 TLTXJ Not used
E
F
DJM-909
5 6 7 8
13
1
2
3
4
2.5 FRONT PANEL SECTION
A
R
1
4
To. B DSP ASSY (EXTERIOR SECTION: No.30)
6
B
2
Q
8 19 9 10 14 12 20 13 10 11 11 5 3 7 6
To. A MAIN ASSY (EXTERIOR SECTION: No.39)
S
C
18
15
18 15 18
NON-CONTACT SIDE
CONTACT SIDE
D
17
KUCXJ ONLY
16
E
F
14
1 2
DJM-909
3 4
5
6
7
8
Parts List
Mark No. 1 2 3 4 5 6 7 NSP 8 9 10 Description RVSW Assy CFVR Assy FSSW Assy Flexible Cable (6P) Flexible Cable (3P) Rivet Slide Packing (B) Front Panel Stay Slide SW Packing (A) Washer Part No. DWS1332 DWS1331 DWS1333 DDD1235 DDD1236 RBM-003 DEC2590 DNH2571 DEC2589 DBE1010 Mark No. 11 12 13 14 15 16 NSP 17 18 19 20 Description Nut SW Packing (A) Flange Nut Front Panel (9) Rotary Knob (SS) Power Knob Guide Caution Label Screw Screw Screw Part No. NKX2FUC DEC2573 DBN1004 DNB1119 DAA1162 DNK4198 See Contrast table(2) BBZ30P060FZK AMZ26P040FMC PMA30P060FMC
B A
(2) CONTRAST TABLE DJM-909/ KUCXJ, DJM-909/ WYXJ and DJM-909/ TLTXJ are constructed the same except for the following :
Mark No. NSP 17 Caution Label Symbol and Description DJM-909 KUCXJ DRW1975 DJM-909 WYXJ Not used DJM-909 TLTXJ Not used
C
D
E
F
DJM-909
5 6 7 8
15
1
2
3
4
3. BLOCK DIAGRAM AND SCHEMATIC DIAGRAM
3.1 BLOCK DIAGRAM
A
3.1.1 OVERALL BLOCK DIAGRAM
JA1251
L CD R CH-1 PHONO /LINE L R 3 (1/2) 1 2 4 IC1253 NJM5532MD Phono Amp. 3 IC1255 NJM4580DD Amp. 2 (1/2) RIAA 1 IC1251 NJM5532MD Buffer 3 (1/2) 1 RY1251 RY1252 4 2 3 2 4 3 3 (1/2) 1 6 4 10 8 RY1253 IC1254 NJM5532MD
E
C1BF ASSY
CN1252
(10P) CH1_TO2_L CH1_TO2_R MIC_IN_L MIC_IN_R
CN102
(10P)
6 4 10 8
IC1252 NJM5532MD Buffer 5 (2/2) 7
CN1251
3 1
(18P) CH1_OUT_L CH1_OUT_R
CN101
(18P)
3 1
B
2 5 (6P)
CH1_OUT_R CH1_OUT_L
CN1253
CN1254 1 4 (6P)
CH1_IN_R CH1_IN_L
CN1255 1 3 (17P)
SESSION_OUT_R SESSION_OUT_L
5 SESSION_OUT_R 5 SESSION_OUT_L 7 7
C
C1EQ ASSY
2 5 (6P)
CN1602
7
CN1601 1 4 (6P)
(2/2) 5 VR1601 TRIM
CN1603 17 15 (17P)
VR1604 2 1 (1/2) 3 IC1604 NJM4580MD 1 (1/2) 3 1
VR1603
VR1602 IC1601 NJM5532MD Buffer IC1607 NJM4580MD VR1605 5 (2/2) 7 IC118 NJM4558MD MIC 6 (2/2) 2 (1/2) 1 7
(1/2) 3
1
(1/2) 3
C
IC1605 NJM4580MD LOW
IC1603 NJM4580MD MID 3 Band Equalizer
IC1602 NJM4580MD HI
VR1606 LO
JA1202
L SESSION R 1 IC1202 NJM4580MD Session Amp. IC1201 IC1203 NJM2068M NJM2068M Mic. Amp. Mix Amp. 2 (1/2) 1 2 (1/2) 1 3 5 (2/2) 7 2 (1/2) IC1203 NJM2068M 5 (2/2) Mic Level VR1201
CN1202
CN1604
1 1 3 SESSION_IN_R 3
SESSION_IN_L
(6P)
(6P)
7
6 5
MIC_EQ_IN MIC_EQ_OUT
6 5
JA1201
IC1610 HI NJM4558MD VR1607 2Band Equalizer 12 2
MIC PHONES
12 3 (1/2) 1 2
MIC_OUT MIC_TO_CH1
IC109 NJM4558MD CH1 MIC 2 (1/2) 1
D
G
JA1351
L CD R CH-2 PHONO /LINE L R
IC1204 NJM2068M Gain Amp.
CN1201
(12P)
CN115
(12P)
MICB ASSY
IC1351 NJM5532MD Buffer 3 (1/2) 1 RY1351 3 (1/2) 1 2 4 IC1353 NJM5532MD Phono Amp. 3 IC1355 NJM4580DD Amp. 2 (1/2) RIAA 2 5 (6P)
CH2_OUT_R CH2_OUT_L
F
RY1352 4 2 3 2 4 3 RY1353
C2BF ASSY
CN1351
18 16
(18P) CH1_IN_L CH1_IN_R
CN127
(18P)
IC1352 NJM5532MD Buffer 5 (2/2) 7
18 16
E
1
3 1
CH2_OUT_L CH2_OUT_R
3 1
CN1353
1 4 CN1354 (6P)
CH2_IN_L CH2_IN_R
2 5 (6P)
CN1751
1
CN1752 1 4 (6P)
(1/2) 3 VR1751 TRIM VR1755 Monitor Fader 2 (1/2) 1 3 (1/2) 1 2 6 CUE_R_OUT
CUE_L_OUT
CN1453
(7P)
6 2
VR1754 6 7 (2/2) 5 IC1754 NJM4580MD
VR1753
VR1752
IC1751 NJM5532MD Buffer
IC1750 NJM4558MD
IC1748 NJM4558MD 1 (1/2) 3 1 (1/2) 3 1 (1/2) 3 6 (2/2) 7 1 5 3
CUE_L1 CUE_R1 CUE_L2 CUE_R2
F
IC1755 NJM4580MD LOW
IC1753 NJM4580MD MID 3 Band Equalizer
IC1752 NJM4580MD HI
7 3 5 1
D
C2EQ ASSY
3
CN1754 7
(7P)
16
1 2
DJM-909
4
5
6
7
8
A
IC126 NJM4580MD DSP1 Input IC124 NJM4580MD DSP2 Input
CN117
3 (1/2) 1 12 10 24 22 5 (2/2) 7
(35P) DSP1ch_IN_L
CN705
(35P)
24 26 12 14
DSP2ch_IN_L
IC727 NJM4580MD (2/2) 7 6 2 IC724 NJM4580MD 6 (2/2) 7 2
B
IC701 AK5380VT ADC for CH1 IC700 AK5380VT ADC for CH2 IC703 PCM1742KE DAC for CH1 MIX IC702 PCM1742KE DAC for CH2 MIX IC707 DSPA56367PV150 DSP2 for CH1 IC706 DSPA56367PV150 DSP1 for CH2
DSP ASSY
IC714 XC2S50-5PQ208C FPGA
IC728 NJM4580MD DSP1ch_OUT_L 1 (1/2) 2 8 28 6 30
DSP2ch_OUT_L
20 18 4 2 16 14
16 18 32 34 20 22
1
(1/2) 2
7
IC713 K4S641632F-TC75 SDRAM IC718 HD64F3064BFBL25 CPU
IC725 NJM4580MD 7
EFF_MON1_L EFF_MON1_R EFF_MON2_L EFF_MON2_R
IC729 NJM4558MD 1 (1/2) 2 IC726 NJM4558MD 1 (1/2) 2
B
IC705 PCM1742KE 7 DAC for CH1 HP MONITOT IC704 PCM1742KE DAC for CH2 HP MONITOT
7
IC115 SSM2018TP CH1 VCA 6 14
CH_1 CH_1_DSP CH_2 CH_2_DSP MIC
2 (1/2)
1
5 7 1 3
SEND_L SEND_R RTN_L RTN_R
11 9 15 13
3 (1/2)
1
JA1904
L R SEND
IC117 SSM2018TP CH2 VCA 6 14
IC104 NJM4558MD Send Mix
IC1902 NJM4558MD
JA1903 JA1902
L R RETURN
IC105 TC9215AF Effect Mix ON/OFF 15 14
CN116
(15P)
CN1901
(15P)
7
(2/2) 6
C
IC106 TC9215AF Effect Mix ON/OFF 15 14
IC1901 NJM4558MD Return Amp.
JA1901
J
SDRT ASSY
CH_1 CH_1_DSP CH_2 CH_2_DSP MIC RETURN SESSION
CN120 1 19 3 17 11 13 5 15 (22P)
A K
XLR ASSY
7 (2/2) 5 7 (2/2) 5
MAIN ASSY
D
4 2 IC110 NJM5532L BAL Amp. 2 (1/2) 1
FIL_IN_L FIL_IN_R
4 2
1
(1/2) 2
IC137 NJM4580MD
MASTER_OUT_R
MASTER_IN_R MASTER_OUT_L
L
MASTER_IN_L
5 (2/2)
7 5 (2/2) 7 R
MASTER1
8 6
4 2
CN122
(8P)
IC102 NJM4580MD Filter IC108 NJM5532DD Buffer
CN124
(9P)
IC101 CN123 NJM5532MD (9P) Mix Amp.
JA102
2CUE_R 1EF_L
1CUE_R
2CUE_L
1EF_R 1CUE_L
2EF_R
2EF_L
IC112 NJM4580DD MASTER2 Amp. 3 (1/2) 1
JA101
L MASTER2 R L R BOOTH/ SESSION OUT
E
JA103 CN1454
(8P)
CN1451 1 19 3 17 11 13 5 15 (22P)
8 6
4 2
IC1452 NJM4580MD IC1453 NJM4580MD 3 (1/2) 1 IC1454 NJM2068M 5 (2/2) HP Level 14 IC1455 TC9215AF HP Monitor SW 7 3 RY1451 4 VR1452 Booth Level 3 (1/2) 1
IC1456 TC9215AF 4 VR1451 Master Level 3
18 18 20 MASTER2_OUT_R 20 14 16
BOOTH_OUT_L BOOTH_OUT_R
MASTER2_OUT_L
14 16
VR1453 3 (1/2) 1 3 4 IC1451 NJM5532MD 13 15 11 9 10
CN125
9 11
(20P) HP_L HP_R
(6P)
CN582
(6P) L R
9 11
5 3
5 3
JA581
PHONES
CN1452
CN119
(20P)
S
FSSW ASSY
F
H
5 6
HPBO ASSY
7
DJM-909
8
17
1
2
3
4
3.1.2 DSP/ LCD BLOCK DIAGRAM
A
6
7 AIN L
2
9,10,11,12 SDT0,LRCK,MCLK,SCLK
B
3,5,10,12
1,7,8,14 V1-V4
5 XRESET 3
C
63 185 GCK
5
51
11
71 DT0-DT15 AD0-AD19 SYSCLK
D
SYSCLK
VCA1-CONT 95
VCA2-CONT 97 66 EXTAL
3
5
E
T
LCD ASSY
6
7 AIN L
2
9,10,11,12 SDT0,LRCK,MCLK,SCLK
F
18
1 2
DJM-909
3 4
5
6
7
8
A
2 DATA
7 VOUT L
2
1
B
2 DATA
7 VOUT L
2
1
2
4 EXTAL
D8-D20
A0-A6
C
66 A0-A11 D0-14
B
DSP ASSY
TXD,RXD,SCK
FPWM1 1 2 3
1
D
D8-D23
A0-A6
FPWM2 13 12 5
7
E
2 DATA
7 VOUT L
2
1
2 DATA
7 VOUT L
2
7
F
DJM-909
5 6 7 8
19
1
2
3
4
3.2 OVERALL CONNECTION DIAGRAM
A
CH2 EQ Low ADJ. CH2 EQ Mid ADJ. CH2 EQ Hi ADJ.
11P FFC DDD1245
B
C2EQ ASSY (DWS1327)
7P FFC DDD1244
H
HPBO ASSY (DWX2319)
C2BF ASSY (DWS1329)
CONNECTOR ASSY DKP3660
D
C
K K 1/2 - K 2/2
XLR ASSY (DWX2322)
35P FFC DDD1241
C1BF ASSY (DWS1328)
D
17P FFC DDD1246
F
C1EQ ASSY (DWS1326)
A A 1/6 - A 6/6
MAIN ASSY (DWX2337)
27P FFC DDD1242
E
C C 1/2 - C 2/2
E
CH1 EQ Low ADJ. CH1 EQ Mid ADJ. CH1 EQ Hi ADJ.
15P FFC DDD1243
F
G MICB ASSY (DWX2318)
20
1 2
SDRT ASSY (DWX2321)
J
DJM-909
3 4
5
6
7
8
CONNECTOR ASSY DKP3661
A
O
FVA1 ASSY (DWX2323)
P
FVA2 ASSY (DWX2324)
I
FDVR ASSY (DWX2320)
9P FFC DDD1240
M
C1TR ASSY (DWS1334)
CONNECTOR ASSY PG03KA-E07
N
C2TR ASSY (DWS1335)
CONNECTOR ASSY PG03KA-E07
L L 1/2 - L 2/2
LVMR ASSY (DWS1330)
TOUCH PANEL (DSX1062)
LCD ASSY (DWX2317)
23P FFC DDD1239
19P FFC DDD1238
B
LCD MODULE (DAV1002)
21P FFC DDD1237
CH1 Offset ADJ. CH2 Offset ADJ. CH1 Gain ADJ. CH2 Gain ADJ.
T
C
CFVR ASSY
DSP ASSY (DWX2316)
17P FFC DDD1234
Q (DWS1331)
3P FFC DDD1236
S
D
B B 1/2 - B 2/2
CONNECTOR ASSY PF08EE-D15
U
SW POWER SUPPLY (DWR1377)
E
CONNECTOR ASSY DKP3659
÷ When ordering service parts, be sure to refer to "EXPLODED VIEWS and PARTS LIST" or "PCB PARTS LIST". ÷ The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. ÷ : The power supply is shown with the marked box. DJM-909
5 6 7
RVSW ASSY (DWS1332)
6P FFC DDD1235
R
8
FSSW ASSY (DWS1333)
F
POWER CORD KUCXJ : VDG1075 WYXJ : VDG1077 TLTXJ : VDG1077
21
1
2
3
4
3.3 MAIN ASSY (1/6)
A
16
A 3/6 A 4/6 A 3/6
(CH1)
(CH1)
(CH1)
(CH2) (CH2)
A 4/6
B
(CH1_D) (CH2_D) (CH1_D)
A 5/6
A 4/6
EFFECT MIX ON/OFF
(MIC) (RET) (SES)
(CH1_D)
A 3/6
A 5/6
C
A 4/6 A 3/6 A 4/6 A 3/6
(CH2_D)
A 4/6 A 3/6 A 4/6
(CH1)
D
A 4/6 A 5/6
(CH2_D)
A 3/6 A 5/6 A 4/6
(CH1)
(CH2) (CH1_D)
EFFECT MIX (CH2_D) ON/OFF
(CH2_D) (MIC)
E
A 4/6 A 5/6 A 3/6 A 4/6 A 5/6 A 4/6
F
A 1/6
22
1 2
DJM-909
3 4
5
6
7
8
A 1/6 MAIN ASSY (DWX2337)
· MIX AMP. BLOCK
: Main Signal Route
(CH1) (CH2) (CH1_D) (CH2_D) (MIC) (SEND) (RET) (SES)
A
: Channel_1 Main Signal Route : Channel_2 Main Signal Route : Channel_1 DSP Signal Route : Channel_2 DSP Signal Route : Microphone Signal Route : Send Signal Route : Return Signal Route : Session Signal Route
B
17
C
K 1/2
CN124
A 2/6, 4/6-6/6
· SEND MIX BLOCK 28
(CH1) (CH2) (CH1_D) (CH2_D) (MIC) (MIC) (SEND) (CH1) (CH2) (CH1_D) (CH2_D)
D
29
A 4/6
E
A 4/6
F
A 1/6
DJM-909
5 6 7 8
23
1
2
3
4
3.4 MAIN ASSY (2/6)
A
A 2/6 MAIN ASSY (DWX2337)
B
23
(MA_2)
C
A 5/6, 6/6
A 1/6
D
E
F
A 2/6
24
1 2
DJM-909
3 4
5
6
7
8
A
(MA_2) (BOOTH)
: MASTER_2 Signal Route : Booth Signal Route
B
(MA_2) (MA_2)
(MA_2)
24
(MA_2)
(BOOTH)
27
C
(BOOTH)
A 6/6
D
UPPER LOWER
E
F
A 2/6
DJM-909
5 6 7 8
25
1
2
3
4
3.5 MAIN ASSY (3/6)
A
A 3/6 MAIN ASSY (DWX2337)
A 4/6
A 4/6 A 4/6 E
B
(SES)
CN1251
A 1/6
(CH1)
14
(CH1)
(CH1) (CH1_D)
13
(MIC_TH)
C
A 4/6
(CH1)
E
CN1252
D
(CH1)
(CH2) (CH1)
(CH2_D)
E
F
CN1351
A 5/6 A 4/6
(CH2) (CH2)
F
A 3/6
26
1 2
DJM-909
3 4
(CH2)
5
6
7
8
(CH1) (CH2) (CH1_D) (CH2_D) (MIC_TH) (SES)
: Channel_1 Main Signal Route : Channel_2 Main Signal Route : Channel_1 DSP Signal Route : Channel_2 DSP Signal Route : Microphone Through Signal Route : Session Signal Route
A
(CH1)
(CH1)
A 1/6
15
B
(CH1)
(CH1_D)
(CH1_D)
(CH1_D)
A 5/6, 6/6
A 1/6
C
A 5/6
A 5/6, 6/6
(CH2) (CH2)
A 1/6
D
(CH2) (CH2)
(CH2_D)
(CH2_D)
(CH2_D)
A 5/6, 6/6 A 1/6
E
A 5/6 A 5/6, 6/6
F
A 3/6
DJM-909
5 6 7 8
27
1
2
3
4
3.6 MAIN ASSY (4/6)
A
A 4/6 MAIN ASSY (DWX2337)
(MIC_TH) (MIC_TH)
(MIC_TH)
B
(MIC) (MIC)
CN1201
(MIC)
MIC MIX ON/OFF
(MIC) (MIC)
G
(MIC)
(MIC)
C
A 3/6
A 3/6
D
(RET) (RET)
(MIC)
A 3/6
A 1/6
CN1901
(SEND) (SEND)
E
J
A 1/6 A 1/6
F
A 4/6
28
1 2
DJM-909
3 4
5
6
7
8
(MIC) (MIC_TH) (SEND) (RET)
: Microphone Signal Route : Microphone Through Signal Route : Send Signal Route : Return Signal Route
A
CONTROL
(MIC_TH)
A 3/6 A 1/6 A 3/6
(MIC)
B
A 1/6
(MIC)
A 1/6
(MIC)
(MIC)
A 1/6
A 1/6
C
A 1/6 A 1/6
A 5/6 A 1/6 A 3/6
D
A 1/6
E
A 1/6
A 1/6
F
A 5/6
DJM-909
5 6 7 8
A 4/6
29
1
2
3
4
3.7 MAIN ASSY (5/6)
A
A 5/6 MAIN ASSY (DWX2337)
A 4/6 A 3/6, 6/6
(CH2_D) (CH2_D)
B
(CH2_D)
(CH2_D)
A 3/6, 6/6
A 1/6
(CH2_D) (CH2_D) (CH2_D)
C
(CH1_D)
A 6/6
(CH1_D)
(CH1_D)
A 6/6
A 3/6
(CH1_D) (CH1_D)
D
A 3/6 A 2/6, 6/6 A 1/6
(CH1_D)
(CH1_D)
A 2/6, 6/6
E
A 3/6, 6/6
A 3/6, 6/6
F
A 5/6
30
1 2
DJM-909
3 4
5
6
7
8
(CH1_D) (CH2_D)
: Channel_1 DSP Signal Route : Channel_2 DSP Signal Route
A
(CH2_D)
B
(CH2_D)
B 2/2
CN705
(CH2_D)
(CH1_D)
A 6/6 A 3/6 A 3/6
(CH1_D)
C
(CH1_D)
A 1/6 A 6/6 A 6/6 A 3/6
B 2/2 CN706
D
A 3/6, 6/6
E
A 3/6, 6/6
F
A 5/6
DJM-909
5 6 7 8
31
1
2
3
4
3.8 MAIN ASSY (6/6)
A
A 6/6 MAIN ASSY (DWX2337)
(BOOTH) (BOOTH) (BOOTH)
A 2/6
A 2/6
B
A 1/6 A 5/6 A 3/6, 5/6
C
(CH1) (CH2)
(CH1)
(CH1)
(CH1)
(CH2)
(CH2)
D
A 5/6
E
A 5/6
F
A 6/6
32
1 2
DJM-909
3 4
5
6
7
8
(CH1) (CH2) (CH1_D) (BOOTH) (CH2_D) (MA_2) (BOOTH)
: Channel_1 Main Signal Route : Channel_2 Main Signal Route : Channel_1 DSP Signal Route : Channel_2 DSP Signal Route : MASTER_2 Signal Route : Booth Signal Route
A
(BOOTH)
S H
(BOOTH)
B
CN582
CN1452
26
(MA_2)
A 2/6, 5/6
(CH1)
C
A 5/6
(CH2) (CH2)
(CH2_D)
(CH2_D)
(CH2)
(CH1)
(CH1)
A 5/6
(CH1_D)
H
CN1451
D
A 5/6
E
CN202
CAUTION : FOR CONTINUED PROTECTION AGAINST RISK OF FIRE. REPLACE ONLY WITH SAME TYPE NO. ICP-N15, MFD BY ROHM CO., LTD. FOR IC135. CAUTION : FOR CONTINUED PROTECTION AGAINST RISK OF FIRE. REPLACE ONLY WITH SAME TYPE NO. ICP-N20, MFD BY ROHM CO., LTD. FOR IC134. CAUTION : FOR CONTINUED PROTECTION AGAINST RISK OF FIRE. REPLACE ONLY WITH SAME TYPE NO. AEK7004 MFD, BY LITTELFUSE INK. FOR IC136, IC140, IC142 and IC143.
U
F
A 6/6
DJM-909
5 6 7 8
33
1
2
3
4
3.9 DSP ASSY (1/2)
A
B 1/2 DSP ASSY (DWX2316)
B
POWER SUPPLY for LCD
B 2/2
C
D
52
B 2/2
E
B 2/2
F
B 2/2 B 2/2
B 1/2
34
1 2
DJM-909
3 4
5
6
7
8
A
CH1 Offset ADJ.
VCA CONTROL
CH1 Gain ADJ.
B
CH2 Offset ADJ. CH2 Gain ADJ.
B 2/2
53 B 2/2
C
51
D
B 2/2
B 2/2
E
F
B 1/2
DJM-909
5 6 7 8
35
1
2
3
4
3.10 DSP ASSY (2/2)
A
B 1/2 B 1/2
B 2/2 DSP ASSY (DWX2316)
ADC for CH2
(CH2)
U
CN201
(CH2) (CH2_D) (CH2_D)
B
(CH2_D)
DAC for CH2 MIX
T
(CH2_D)
CN1002
B 1/2
(CH2_D) (CH2_D)
B 1/2
C
(CH2)
DAC for CH2 HP MONITOR
(CH2_D)
(CH2) (CH1)
A 5/6
CN117
(CH2_D) (CH1) (CH2_D)
54
(CH1) (CH1_D)
ADC for CH1
57
55
(CH1_D)
56
D
(CH1_D)
DAC for CH1 MIX
(CH1_D)
A 5/6 CN118
(CH1_D)
DAC for CH1 HP MONITOR
E
L 1/2 CN401
L 1/2 CN402
F
B 2/2
36
1
DJM-909
2 3 4
Q
CN551
5
6
7
8
(CH1) (CH2) (CH1_D) (CH2_D)
: Channel_1 Main Signal Route : Channel_2 Main Signal Route : Channel_1 DSP Signal Route : Channel_2 DSP Signal Route
A
B
DSP1 for CH2
C
B 1/2 B 1/2
D
DSP2 for CH1
E
B 1/2
CAUTION : FOR CONTINUED PROTECTION AGAINST RISK OF FIRE. REPLACE ONLY WITH SAME TYPE NO. ICP-N15, MFD BY ROHM CO., LTD. FOR IC731. CAUTION : FOR CONTINUED PROTECTION AGAINST RISK OF FIRE. REPLACE ONLY WITH SAME TYPE NO. ICP-N20, MFD BY ROHM CO., LTD. FOR IC732. CAUTION : FOR CONTINUED PROTECTION AGAINST RISK OF FIRE. REPLACE ONLY WITH SAME TYPE NO. AEK7004 MFD, BY LITTELFUSE INK. FOR IC734 and IC740. CAUTION : FOR CONTINUED PROTECTION AGAINST RISK OF FIRE. REPLACE ONLY WITH SAME TYPE NO. AEK7005 MFD, BY LITTELFUSE INK. FOR IC738 and IC739.
F
B 2/2
37
8
DJM-909
5 6 7
1
2
3
4
3.11 C1EQ ASSY (1/2)
A
C 1/2 C1EQ ASSY (DWS1326)
(CH1) CH1 EQ Hi ADJ. (CH1)
(CH1)
B
9
(CH1)
8
(CH1) (CH1)
E
CN1254
(CH1) (CH1)
C
CH1 EQ Hi ADJ.
D
43
(SES) (SES)
C 2/2
E
F
C 1/2
38
1 2
E
CN1255
DJM-909
3 4
(CH1)
5
6
7
8
(CH1) (SES) (CH1) CH1 EQ Mid ADJ. CH1 EQ Low ADJ. (CH1) (CH1)
: Channel_1 Main Signal Route : Session Signal Route
A
(CH1)
10
(CH1)
11 12
(CH1)
(CH1)
B
(CH1)
E
CN1253
C
CH1 EQ Mid ADJ.
CH1 EQ Low ADJ.
D
E
F
C 1/2
DJM-909
5 6 7 8
39
1
2
3
4
3.12 C1EQ ASSY (2/2)
A
C 2/2 C1EQ ASSY (DWS1326)
(MIC) (SES)
: Microphone Signal Route : Session Signal Route
B
37
(MIC) (MIC) (MIC)
CN1202
(MIC)
G
(MIC) (SES)
38
C
(SES)
(MIC)
D
E
F
C 2/2
40
1 2
DJM-909
3 4
5
6
7
8
A
B
C
42
(SES)
D
(SES) (SES)
C 1/2
E
C 1/2
F
DJM-909
5 6 7 8
41
1
2
3
4
3.13 C2EQ ASSY
A
D C2EQ ASSY (DWS1327)
CH2 EQ Hi ADJ. CH2 EQ Mid ADJ. (CH2)
B
(CH2) (CH2)
(CH2) CH2 EQ Hi ADJ. CH2 EQ Mid ADJ.
C
F
CN1354
D
H
CN1453
E
F
F
CN1355
D
42
1 2
DJM-909
3 4
(CH2)
(CH2)
5
6
7
8
(CH2)
: Channel_2 Main Signal Route
A
(CH2)
CH2 EQ Low ADJ. (CH2) (CH2)
(CH2)
(CH2) (CH2) (CH2)
B
CH2 EQ Low ADJ.
(CH2)
F
CN1353
C
D
E
F
D
DJM-909
5 6 7 8
43
1
2
3
4
3.14 C1BF ASSY
A
E
C1BF ASSY (DWS1328)
1
(CD_1)
(CD_1) (CD_1)
2
(CD_1)
B
3
C
(L/P_1) (L_1)
4
(L_1)
5
(P_1) (P_1)
D
(P_1) (P_1) (P_1)
E
F
E
44
1 2
DJM-909
3 4
5
6
7
8
(CH1) (MIC) (SES) (CD_1) (L/P_1)
: Channel_1 Main Signal Route : Microphone Signal Route : Session Signal Route : CD_1 Signal Route : Line/Phono_1 Signal Route
A
(CD_1)
(CH1) (CH1)
B
6
(CD/L/P_1) (CH1)
(CH1)
A 3/6
CN102
(MIC) (L/P_1)
(MIC)
(MIC)
7
(CH1) (CH1) (CH1)
C
C 1/2
CN1601
(CH1) (L/P_1)
(CH1)
(CH1)
C 1/2
CN1602
D
(CH1)
(SES)
(SES)
(SES)
A 3/6 CN101
E
(SES)
C 1/2 CN1603
F
E
DJM-909
5 6 7 8
45
1
2
3
4
3.15 C2BF ASSY
A
F
C2BF ASSY (DWS1329)
(CD_2) (CD_2) (CD_2) (CD_2) (CD_2)
B
C
(L/P_2)
(L/P_2) (L_2) (L_2) (L_2)
(P_2)
(P_2)
D
(P_2) (P_2) (P_2)
E
F
F
46
1 2
DJM-909
3 4
5
6
7
8
(CH1) (CH2) (CD_2) (L/P_2)
: Channel_1 Main Signal Route : Channel_2 Main Signal Route : CD_2 Signal Route : Line/Phono_2 Signal Route
A
(CD_2)
(CD_2)
B
(CD/L/P_2)
(L/P_2)
(CD/L/P_2)
(CH1)
(CH1)
(CH2)
(CH2)
C
D
CN1752
(CH2) (L/P_2)
(CH2) (CH2)
(L/P_2)
D
CN1751
(CH2)
D
(CH2)
A 3/6 CN127
(CH1)
E
D
CN1753
F
F
DJM-909
5 6 7 8
47
1
2
3
4
3.16 MICB ASSY
A
G MICB ASSY (DWX2318)
33
(MIC) (MIC) (MIC) (MIC)
34
B
(MIC)
(MIC) (MIC) (MIC)
(MIC) (MIC)
35
C
D
E
(SES)
(SES)
(SES)
40
(SES)
(SES)
F
G
48
1 2
DJM-909
3 4
5
6
7
8
(MIC) (MIC_TH) (SES)
: Microphone Signal Route : Microphone Through Signal Route : Session Signal Route
A
B
36
(MIC) (MIC_TH) (MIC) (MIC) (MIC)
(MIC)
(MIC_TH)
(SES)
(SES)
(MIC)
41
C 2/2 CN1604
(MIC)
C
(MIC_TH)
D
(MIC_TH)
39
(SES)
A 4/6 CN115
(MIC)
(SES)
(SES)
(MIC)
E
F
G
DJM-909
5 6 7 8
49
1
2
3
4
3.17 HPBO ASSY
A
H HPBO ASSY (DWX2319)
19
(BOOTH)
(BOOTH)
A 6/6 CN119
K 1/2 CN122
(HP)
(MA_1)
B
(BOOTH) (MA_1) (MA_2) (MA_2)
20
(MA_2)
C
(CH1_D) (CH1_D) (CH1) (CH2) (CH2_D) (HP) (CH1)
30
HP MONIOTR (HP) SW
(CH1)
(HP)
A 6/6 CN120
(CH2_D)
D
(CH2)
(CH2) (CH2_D)
E
F
H
50
1 2
D
CN1754
DJM-909
3 4
(CH2)
5
6
7
8
(BOOTH)
(BOOTH)
A
25
(BOOTH) (BOOTH) (BOOTH)
B
31
C
32
(HP) (HP) (HP) (HP)
(HP)
D
(HP)
E
: Main Signal Route
(CH1) (CH2) (CH1_D) (CH2_D) (MA_1) (MA_2) (BOOTH) (HP)
: Channel_1 Main Signal Route : Channel_2 Main Signal Route : Channel_1 DSP Signal Route : Channel_2 DSP Signal Route : MASTER_1 Signal Route : MASTER_2 Signal Route : Booth Signal Route : Phones Signal Route
F
H
51
DJM-909
5 6 7 8
1
2
3
4
3.18 FDVR ASSY
A
I
FDVR ASSY (DWX2320)
B
C
D
E
F
I
52
1 2
DJM-909
3 4
5
6
7
8
A
B
L 1/2 CN405
C
D
E
F
DJM-909
5 6 7 8
53
1
2
3
4
3.19 SDRT ASSY
A
J
SDRT ASSY (DWX2321)
45
B
(RET)
C
(RET)
(RET)
(RET)
44
(SEND)
(SEND)
D
E
(SEND)
47
(SEND) (SEND)
(SEND)
F
J
54
1 2
DJM-909
3 4
(RET)
5
6
7
8
(SEND) (RET)
: Send Signal Route : Return Signal Route
A
(RET)
(RET)
(RET)
B
46
(SEND)
A 4/6
CN116
(SEND)
C
(SEND)
(SEND)
D
E
48
(SEND) (SEND)
F
J
DJM-909
5 6 7 8
55
1
2
3
4
3.20 XLR ASSY (1/2)
A
K 1/2 XLR ASSY (DWX2322)
B
C
D
A 1/6
CN123
E
K 2/2
F
K 1/2
56
1 2
DJM-909
3 4
5
6
7
8
: Main Signal Route
A
B
18
C
H
CN1454
D
K 2/2
E
F
K 1/2
DJM-909
5 6 7 8
57
1
2
3
4
3.21 XLR ASSY (2/2)
A
K 2/2 XLR ASSY (DWX2322)
B
21
K 1/2
C
D
K 1/2
E
K 1/2
F
K 2/2
58
1 2
DJM-909
3 4
5
6
7
8
: Main Signal Route
A
B
MASTER 1 AMP
C
D
22
E
F
K 2/2
DJM-909
5 6 7 8
59
1
2
3
4
3.22 LVMR (1/2), C1TR, C2TR, FVA1 and FVA2 ASSYS
A
L 1/2 LVMR ASSY (DWS1330)
L 2/2 B 2/2
B
CN708
C
B 2/2
CN707
L 2/2
D
I
CN301
E
L 2/2
F
L 1/2
60
1 2
DJM-909
3 4
5
6
7
8
A
M C1TR ASSY N C2TR ASSY (DWS1334) (DWS1335)
B
C
P
FVA2 ASSY (DWS2324)
O FVA1 ASSY (DWS2323)
D
E
F
L 1/2 M N O P
DJM-909
5 6 7 8
61
1
2
3
4
3.23 LVMR ASSY (2/2)
A
L 2/2 LVMR ASSY (DWS1330)
L 1/2
B
59
L 1/2
58
L 1/2
C
60
L 1/2
L 1/2
D
L 1/2
L 1/2
E
L 1/2
F
L 2/2
62
1 2
DJM-909
3 4
5
6
7
8
A
B
C
D
E
F
L 2/2
DJM-909
5 6 7 8
63
1
2
3
4
3.24 CFVR, RVSW and FSSW ASSYS
A
Q CFVR ASSY (DWS1331)
B
B 2/2
CN709
C
D
E
F
Q
64
1 2
DJM-909
3 4
5
6
7
8
A
R
RVSW ASSY (DWS1332)
B
C
S
FSSW ASSY (DWS1333)
D
E
A 6/6
CN125
F
R S
DJM-909
5 6 7 8
65
1
2
3
4
3.25 LCD ASSY
A
T
LCD ASSY (DWX2317)
LCD MODULE
B
C
D
E
F
T
66
1 2
TOUCH PANEL
DJM-909
3 4
5
6
7
8
A
B
C
49
50
D
B 2/2 CN704
E
F
T
DJM-909
5 6 7 8
67
F
E
B
A
D
C
68
CN201
D201 D202 R201
U
1 MUTE
C201 C202 C302 JA2 D201 AC+ T101 D301 R118 C301 C401 R401 L401 JC2 R119 L103 D401 R501 R405 C404 R403 R404 C403 R107 IC401 R407 ACJA4 C501 R122 JE3 D601 C115 C604 D701 C701 2 R114 C109 PC101 C111 C112 R112 5 1 C703 R701 C702 R113 3 C113 JC4 C601 R601 L701 C602 C603 D103 R115 JC3 TH101 R108 ZD501 L601 R502 R406 D502 R504 PC101 Q101 R116 JB1 C107 D501 C402 R402 R102 R120 R104 R117 L105 D104 JB5 R503 Q501 R505 Q502 JB4 Q503 JE5 D503 JA3 R301 R101 R506
U SW POWER SUPPLY (DWR1377)
3.26 SW POWER SUPPLAY
C101
C505
JE1
C502
DJM-909
7 8 R109 IC101 4 6 C801 D801 R801 JB3 JB2
JE4
C506
C503
C503
1
2 12V 8 RESET 4 5VD
1 IC501 3 4 2 C504 JB6
1
· NOTE FOR FUSE REPLACEMENT CAUTION - FOR CONTINUED PROTECTION AGAINST RISK OF FIRE. REPLACE WITH SAME TYPE AND RATINGS ONLY.
CN101
F101
LIVE
1
SW101
C102
2
L801
2
L101
L102
B 2/2 CN703
Z101
C104
7 3.3V
3 GND 5 GND 6 GND
3
NEUTRAL
C103
CN202
5 +15V 2 5VA
ZD601
3
3
ZD101
AC IN
Q102
4 GND
JA5 C802 C803
R121 C108
A 6/6 CN121
1 GND 3 -15V
JE2
C114
4
4
U
5
6
7
8
3.27 VOLTAGES
VOLTAGES
Measurement condition
1 Front panel FADER REVERSE : All OFF FOOT SW : OFF 2 Top panel MIC HI LOW MIC SEND SESSION IN CH-1 SEND FADER CURVE CUT LAG : Turn all knobs clockwise fully : Turn it counterclockwise fully FADER START : OFF
A
: MAX : MID : MID : OFF : MAX : OFF : OFF : Center : OFF : OFF : MAX
CH-1 switch TRIM HI MID LOW EQ
: CD 1 : MAX : MID : MID : MID : OFF
CH-2 switch TRIM HI MID LOW EQ : OFF : Center : OFF : OFF : MAX
: CD 2 : MAX : MID : MID : MID : OFF
MASTER BOOTH/SESSION OUT PHONES SELECT FADER CH-2 SEND
: MAX : MAX : MAX : MASTER : Center : OFF
B
(CH-1) EFFECT (CH-1) MIX/DEPTH FADER START TRANSFORM CH-1 Fader
(CH-2) EFFECT (CH-2) MIX/DEPTH FADER START TRANSFORM CH-2 Fader
MASTER LEVEL : ON Cross Fader : Center 3 Rear panel PHONO/LINE switch : Set both CH-1 and CH-2 to PHONO side SEND, RETURN : Non connection LCD : BRIGHT is 10 (Maximum luminance), CONTRAST is the center CD1, CD2 : 1kHz, 0dB input
C
A
MAIN ASSY IC106
No. Voltage 1 1.8mV 2 1.7mV 3 1.8mV 4 1.7mV 5 1.8mV 6 1.8mV 7 1.8mV 8 -14.25V 9 1.8mV 10 1.8mV 11 1.7mV 12 4.97V 13 1.7mV 14 1.7mV 15 1.8mV 16 14.14V
IC101
No. Voltage 1 2.0mV 2 1.3mV 3 0.7mV 4 -14.24V 5 0.7mV 6 0.7mV 7 3.4mV 8 14.14V
IC114
No. Voltage 1 2.5mV 2 14.35V 3 1.4mV 4 3.4mV 5 -11.76V 6 3.4mV 7 2.5mV 8 6.77V 9 3.4mV 10 -14.48V 11 18.1mV 12 963mV 13 -7.5mV 14 -7.5mV 15 2.04V 16 -14.48V
IC116
No. Voltage 1 3.3mV 2 14.34V 3 2.5mV 4 6.5mV 5 -11.73V 6 5.0mV 7 3.2mV 8 6.76V 9 4.1mV 10 -14.48V 11 26.2mV 12 961mV 13 1.3mV 14 -7.2mV 15 2.03V 16 -14.49V
IC118
No. Voltage 1 0.8mV 2 1.8mV 3 1.8mV 4 -14.24V 5 1.8mV 6 2.1mV 7 1.2mV 8 14.11V
IC126
No. Voltage 1 3.4mV 2 3.4mV 3 3.4mV 4 -14.23V 5 11.6mV 6 3.4mV 7 3.6mV 8 14.1V
D
IC104
No. Voltage 1 -0.5mV 2 1.6mV 3 1.4mV 4 -14.48V 5 1.4mV 6 1.7mV 7 0.2mV 8 14.34V
IC119
No. Voltage 1 1.8mV 2 1.8mV 3 1.8mV 4 1.8mV 5 1.8mV 6 1.8mV 7 1.8mV 8 -14.24V 9 1.8mV 10 1.8mV 11 1.8mV 12 46.1mV 13 1.8mV 14 1.8mV 15 1.8mV 16 14.1V
IC131
No. Voltage 1 180.4mV 2 55.2mV 3 -3.1mV 4 -14.25V 5 -3.2mV 6 55.1mV 7 180.7mV 8 14.15V
IC109
No. Voltage 1 0.4mV 2 1.7mV 3 1.8mV 4 -14.23V 5 1.8mV 6 2.2mV 7 1.6mV 8 14.11V
IC115
No. Voltage 1 3.4mV 2 14.35V 3 4.6mV 4 5.2mV 5 -11.76V 6 5.2mV 7 5.1mV 8 6.54V 9 3.3mV 10 -14.48V 11 18.8mV 12 956mV 13 1.3mV 14 -7.4mV 15 2.04V 16 -14.48V
IC117
No. Voltage 1 4.0mV 2 14.34V 3 3.7mV 4 7.2mV 5 -11.77V 6 7.3mV 7 4.0mV 8 6.75V 9 4.2mV 10 -14.48V 11 26.2mV 12 953mV 13 1.3mV 14 -6.9mV 15 2.02V 16 -14.48V
IC105
No. Voltage 1 1.6mV 2 1.6mV 3 1.6mV 4 1.6mV 5 1.6mV 6 1.6mV 7 1.6mV 8 -14.23V 9 1.7mV 10 1.8mV 11 1.8mV 12 4.97V 13 1.8mV 14 1.8mV 15 1.7mV 16 14.11V
IC132
No. Voltage 1 -6.1mV 2 -4.4mV 3 -4.5mV 4 -14.22V 5 3.9mV 6 -6.1mV 7 -6.1mV 8 14.11V
E
IC112
No. Voltage 1 90.4mV 2 47.8mV 3 5.9mV 4 -14.24V 5 48.3mV 6 93.5mV 7 93.8mV 8 14.15V
IC124
No. Voltage 1 3.6mV 2 3.4mV 3 3.4mV 4 -14.24V 5 3.2mV 6 3.2mV 7 3.2mV 8 14.14V
IC133
No. Voltage 1 -6.3mV 2 -4.6mV 3 -4.6mV 4 -14.24V 5 -4.4mV 6 -4.3mV 7 -6.0mV 8 14.15V
F
DJM-909
5 6 7 8
69
1
2
3
4
A
B
DSP ASSY IC704
No. Voltage 1 1.62V 2 1.63V 3 1.63V 4 12.7mV 5 3.23V 6 4.89V 7 2.47V 8 2.43V 9 12.7mV 10 2.45V 11 15.8mV 12 15.8mV 13 2.68V 14 3.2V 15 3.23V 16 1.58V
IC700
No. Voltage 1 2.45V 2 2.45V 3 12.7mV 4 2.45V 5 12.7mV 6 4.9V 7 3.23V 8 12.7mV 9 1.22V 10 1.63V 11 1.59V 12 1.62V 13 3.23V 14 12.6mV 15 12.6mV 16 13.3mV
IC706
No. Voltage No. Voltage 1 21.7mV 73 1.55V 2 1.63V 74 3.24V 3 3.24V 75 14.4mV 4 14.1mV 76 164.8mV 5 1.63V 77 140.8mV 6 3.24V 78 1.57V 7 13.6mV 79 14.6mV 8 3.24V 80 3.28V 9 14.4mV 81 14.4mV 10 3.23V 82 3.27V 11 1.22V 83 498mV 12 1.63V 84 494mV 13 1.63V 85 490mV 14 1.61V 86 3.28V 15 1.62V 87 14.4mV 16 1.6V 88 480mV 17 1.6V 89 467mV 18 1.81V 90 14.4mV 19 14.4mV 91 1.81V 20 3.29V 92 461mV 21 418mV 93 461mV 22 424mV 94 467mV 23 423mV 95 3.28V 24 414mV 96 14.4mV 25 3.28V 97 467mV 26 14.4mV 98 3.25V 27 418mV 99 14.6mV 28 14.4mV 100 11.5mV 29 411mV 101 11.5mV 30 411mV 102 11.4mV 31 3.28V 103 3.28V 32 403mV 104 14.4mV 33 397mV 105 11.4mV 34 404mV 106 56.6mV 35 414mV 107 56.4mV 36 432mV 108 9.2mV 37 514mV 109 57.7mV 38 3.25V 110 84.5mV 39 14.4mV 111 3.25V 40 873mV 112 14.4mV 41 878mV 113 81.6mV 42 899mV 114 82.8mV 43 872mV 115 84.5mV 44 3.23V 116 3.29V 45 1.82V 117 82.5mV 46 422mV 118 83.5mV 47 14.4mV 119 3.24V 48 774mV 120 14.4mV 49 3.24V 121 85.6mV 50 777mV 122 840mV 51 3.24V 123 830mV 52 3.24V 124 840mV 850mV 53 821 - 947mV 125 54 14.4mV 126 1.81V 55 1.61V 127 14.4mV 56 1.81V 128 830mV 57 3.24V 129 3.24V 58 14.4mV 130 14.4mV 59 740mV 131 835mV 60 770mV 132 968mV 61 14.4mV 133 2.21V 62 15.2mV 134 11.0mV 63 2.92V 135 3.28V 64 17.0mV 136 10.6mV 65 3.24V 137 3.28V 66 14.4mV 138 11.0mV 67 3.11V 139 580mV 68 3.1V 140 3.23V 69 3.24V 141 14.4mV 70 2.92V 142 3.23V 71 15.8mV 143 3.24V 72 1.77V 144 0.94 - 2.66V
IC707
No. Voltage No. Voltage 1 20.8mV 73 3.28V 2 1.65V 74 3.28V 3 3.24V 75 15.8mV 4 15.8mV 76 165.7mV 5 15.8mV 77 141.7mV 6 3.24V 78 1.65V 7 15.8mV 79 15.8mV 8 3.24V 80 3.24V 9 15.8mV 81 15.8mV 10 3.24V 82 15.8mV 11 1.22V 83 15.8mV 12 1.63V 84 15.8mV 13 1.63V 85 15.8mV 14 1.61V 86 3.24V 15 1.62V 87 15.8mV 16 1.6V 88 15.8mV 17 1.63V 89 15.8mV 18 1.82V 90 15.8mV 19 15.8mV 91 1.81V 20 3.29V 92 15.8mV 21 526mV 93 15.8mV 22 528mV 94 15.8mV 23 505mV 95 3.24V 24 540mV 96 15.8mV 25 3.29V 97 15.8mV 26 15.8mV 98 3.24V 27 522mV 99 15.8mV 28 15.8mV 100 20.6mV 29 525mV 101 19.9mV 30 538mV 102 20.2mV 31 3.24V 103 3.24V 32 570mV 104 15.8mV 33 540mV 105 37.0mV 34 490mV 106 37.2mV 35 467mV 107 36.7mV 36 464mV 108 37.0mV 37 452mV 109 37.0mV 38 3.24V 110 38.1mV 39 15.8mV 111 3.24V 40 586mV 112 15.8mV 41 502mV 113 38.2mV 42 465mV 114 38.3mV 43 455mV 115 37.9mV 44 3.23V 116 38.3mV 45 1.81V 117 37.9mV 46 437mV 118 38.6mV 47 15.8mV 119 3.24V 48 340mV 120 15.8mV 49 3.24V 121 29.0 - 39.0mV 50 445mV 122 25.0 - 49.0mV 51 3.24V 123 21.9 - 49.7mV 52 3.24V 124 20.0 - 40.0mV 53 433mV 125 35.5 - 65.2mV 54 15.8mV 126 1.81V 55 1.6V 127 15.8mV 56 1.81V 128 35.7 - 65.4mV 57 3.24V 129 3.24V 58 15.8mV 130 15.8mV 59 520mV 131 36.6mV 60 547mV 132 149.8mV 61 15.8mV 133 1.37V 62 10.3mV 134 3.23V 63 3.8V 135 3.24V 64 3.28V 136 15.8mV 65 3.28V 137 3.24V 66 15.8mV 138 3.23V 67 3.28V 139 477mV 68 3.28V 140 3.22V 69 475mV 141 15.8mV 70 1.14V 142 3.22V 71 9.5mV 143 3.24V 72 3.28V 144 1.2 - 2.9V
IC708
No. Voltage 1 3.23V 2 8.1mV 3 1.26V 4 1.81V 5 3.29V
IC713
No. Voltage 1 3.24V 2 1.18V 3 3.24V 4 820mV 5 830mV 6 13.5mV 7 770mV 8 770mV 9 3.24V 10 750mV 11 860mV 12 13.5mV 13 770mV 14 3.24V 15 14.9mV 16 3.24V 17 2.81V 18 2.82V 19 14.8mV 14.8Å 20 21 23.6mV 23.5Å 22 23 19.2mV 24 19.2mV 25 19.2mV 26 23.7mV 27 3.24V 28 13.6mV 29 23.5mV 30 23.6mV 31 23.6mV 32 23.6mV 22.7Å 33 14.8Å 34 35 14.8mV -82.6Å 36 37 3.24V 38 1.49V 39 14.4mV -325.5Å 40 41 13.2mV 42 2.65V 43 3.25V 44 2.67V 45 2.68V 46 13.2mV 47 2.67V 48 2.68V 49 3.25V 50 2.72V 51 2.72V 52 13.1mV 53 2.67V 54 13.2mV
IC709
No. Voltage 1 3.29V 2 8.9mV 3 1.26V 4 1.84V 5 3.29V
B
IC710
No. Voltage 1 1.69V 2 1.69V 3 1.78V 4 14.0mV 5 1.79V 6 1.79V 7 1.75V 8 3.28V
IC701
No. Voltage 1 2.45V 2 2.45V 3 12.9mV 4 2.44V 5 12.9mV 6 4.9V 7 3.23V 8 12.9mV 9 1.22V 10 1.63V 11 1.59V 12 1.61V 13 3.23V 14 12.9mV 15 12.9mV 16 13.6mV
IC705
No. Voltage 1 1.61V 2 1.62V 3 1.63V 4 13.1mV 5 3.23V 6 4.89V 7 2.47V 8 2.43V 9 13.1mV 10 2.45V 11 16.1mV 12 16.2mV 13 2.68V 14 3.2V 15 3.23V 16 1.56V
IC712
No. Voltage 1 4.85V 2 15.0mV 3 809mV 4 15.0mV 5 1.26V 6 4.91V 7 4.9V 8 4.63V
C
IC702
No. Voltage 1 1.61V 2 14.3mV 3 1.63V 4 12.9mV 5 3.23V 6 4.89V 7 2.47V 8 2.43V 9 12.9mV 10 2.44V 11 3.23V 12 3.23V 13 2.68V 14 3.2V 15 3.23V 16 1.57V
D
IC703
No. Voltage 1 1.61V 2 15.0mV 3 1.63V 4 13.3mV 5 3.23V 6 4.89V 7 2.47V 8 2.43V 9 13.3mV 10 2.45V 11 3.23V 12 3.23V 13 2.68V 14 3.2V 15 3.23V 16 1.56V
E
F
70
1 2
DJM-909
3 4
5
6
7
8
IC714
No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 Voltage 14.5mV 2.53V 1.07V 1.34V 1.33V 1.23V 1.19V 1.21V 1.16V 1.09V 14.7mV 3.24V 2.53V 15.9mV 14.7mV 1.37V 14.7mV 15.8mV 14.8mV
15.9 - 24.9mV -46.2 - 321.3mV
IC716
No. 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100 101 102 103 104 105 106 107 108 109 110 111 112 113 114 115 116 117 118 119 120 121 122 123 124 125 126 127 128 129 130 131 132 133 134 135 136 137 138 139 140 Voltage 165.6mV 15.3mV 1.54V 1.72V 3.1V 2.54V 15.3mV 3.24V 15.3mV 15.3mV 3.11V 15.3mV 15.3mV 1.73V 15.1mV 3.23V 15.2mV 3.24V 15.2mV 2.68V 2.54V 3.24V 15.2mV 3.23V 3.2V 1.63V 21.3mV
1.22 - 2.88V
IC718
No. Voltage No. Voltage 1 3.21V 51 17.5mV 2 15.6mV 52 19.4mV 3 15.6mV 53 16.1mV 4 15.9mV 54 16.2mV 5 15.9mV 55 24.5mV 6 15.6mV 56 24.5mV 7 15.6mV 57 16.2mV 8 4.98V 58 16.2mV 9 16.0mV 59 16.2mV 10 15.7mV 60 16.2mV 11 15.7mV 61 16.2mV 12 4.13V 62 4.98V 13 636mV 63 4.98V 14 131mV 64 16.2mV 15 473mV 65 16.2mV 16 4.93V 66 2.59V 17 3.93V 67 2.42V 18 15.7mV 68 4.98V 19 15.7mV 69 17.2mV 20 4.97V 70 17.2mV 21 15.7mV 71 17.2mV 22 15.7mV 72 17.2mV 23 4.98V 73 4.98V 24 4.98V 74 4.98V 25 15.7mV 75 4.98V 26 15.7mV 76 4.98V 27 15.7mV 77 4.98V 28 15.7mV 78 4.98V 29 4.98V 79 4.98V 30 4.95V 80 4.98V 31 4.96V 81 4.98V 32 15.9mV 82 4.98V 33 4.98V 83 4.98V 34 4.98V 84 4.98V 35 4.98V 85 16.7mV 36 4.98V 86 16.0mV 37 4.98V 87 16.2mV 38 4.98V 88 4.98V 39 15.8mV 89 16.0mV 40 4.98V 90 3.24V 41 15.6mV 91 15.8mV 42 4.98V 92 15.8mV 43 4.98V 93 4.98V 44 15.9mV 94 4.98V 45 4.98V 95 4.98V 46 23.8mV 96 16.4mV 47 4.98V 97 4.98V 48 4.98V 98 16.4mV 49 3.22V 99 3.24V 50 3.24V 100 4.98V
IC725
No. Voltage 1 9.4mV 2 13.0mV 3 13.1mV 4 -14.55V 5 13.1mV 6 13.0mV 7 9.3mV 8 14.41V
IC736
No. Voltage 1 21.6mV 2 21.5mV 3 21.5mV 4 -14.55V 5 28.8mV 6 28.9mV 7 28.9mV 8 14.41V
A
25.0mV 25.0mV
5.3 - 325.4mV
15.2mV 3.24V 24.8mV 2.54V 3.24V 3.24V 1.63V 15.3mV 1.67V 1.59V 23.0mV
0.89 - 2.68V 33.2 - 323.4mV
2.54V 3.24V 15.1mV 2.2V
0.5 - 323.4mV
3.24V 2.21V 950mV 850mV 3.24V 15.4mV 3.24V 3.24V 16.1mV 880mV 880mV 840mV 840mV 840mV
77.0 - 87.0mV
836mV 840mV 856mV 846mV 850mV 826mV 85.4mV 3.24V 15.1mV 3.24V 3.24V 15.2mV
-35.9 - 317.3mV -30.1 - 320.4mV
85.0mV 85.0mV 84.0mV 86.0mV 85.0mV 84.0mV 84.5mV 15.1mV 3.24V 2.54V 15.3mV 15.4mV 1.64V 141.6mV
83.0mV 83.0mV 15.4mV 3.24V 2.54V 80.4mV 80.4mV 80.0mV 81.5mV 81.4mV 15.4mV 16.4mV 16.3mV 1.58V 2.54V 142.1mV 3.24V 15.3mV 166.0mV
1.53 - 1.63V 1.69 - 1.79V
3.09V 3.11V 15.3mV 1.64V 15.3mV 3.23V
No. Voltage 141 15.3mV 142 3.24V 143 2.54V 144 3.24V 145 15.3mV 146 4.94V 147 4.94V 148 4.94V 149 3.24V 150 3.24V 151 60.3mV 152 4.94V 153 2.68V 154 16.4mV 155 3.2V 156 3.24V 157 395mV 158 15.2mV 159 2.53V 160 4.93V 161 131.2mV 162 4.13V 163 15.2mV 164 4.98V 165 3.22V 166 3.24V 167 4.98V 168 4.98V 169 15.3mV 170 3.24V 171 2.54V 172 15.3mV 173 3.24V 174 15.3mV 175 4.98V 176 15.3mV 177 15.3mV 178 910mV 179 770mV 180 820mV 181 960mV 182 15.3mV 183 15.3mV 184 3.24V 185 1.7V 186 2.54V 187 980mV 188 1.1V 189 1.0V 190 15.5mV 191 1.03V 192 16.6mV 193 3.24V 194 2.82V 195 2.82V 196 2.54V 197 3.24V 198 15.5mV 199 16.4mV 200 16.4mV 201 25.2mV 202 25.2 - 34.1mV 203 20.8mV 204 20.8mV 205 20.8mV 206 25.3mV 207 2.53V 208 3.24V
No. Voltage 1 4.97V 2 12.3mV 3 14.41V
IC717
No. Voltage 1 12.3mV 2 -14.55V 3 -4.94V
IC726
No. Voltage 1 0.1mV 2 13.4mV 3 13.1mV 4 -14.55V 5 13.1mV 6 13.0mV 7 -0.5mV 8 14.41V
IC737
No. Voltage 1 4.2 - 319.6mV 2 2.58V 3 14.3mV 4 2.59V 5 4.99V
IC719
No. Voltage 1 14.1mV 2 664mV 3 446mV 4 10.5mV 5 25.0mV 6 28.8mV 7 10.5mV 8 10.5mV 9 10.6mV 10 4.98V 11 3.28V 12 4.99V 13 10.5mV 14 3.28V
B
IC727
No. Voltage 1 12.8mV 2 13.1mV 3 13.0mV 4 -14.55V 5 13.1mV 6 13.1mV 7 12.8mV 8 14.41V
IC720
No. Voltage 1 4.95V 2 14.1mV 3 4.95V 4 14.1mV 5 14.1mV 6 3.24V 7 14.1mV 8 3.24V 9 14.1mV 10 3.24V 11 14.2mV 12 3.24V 13 14.2mV 14 3.24V
C
IC728
No. Voltage 1 10.2mV 2 13.7mV 3 13.5mV 4 -14.55V 5 13.5mV 6 13.7mV 7 10.1mV 8 14.41V
IC729
No. Voltage 1 -0.3mV 2 13.4mV 3 13.5mV 4 -14.55V 5 13.5mV 6 13.7mV 7 0.4mV 8 14.41V
IC722
No. Voltage 1 4.94V 2 4.94V 3 3.21V 4 4.13V 5 4.13V 6 2.68V 7 14.0mV 8 3.24V 9 4.99V 10 4.99V 11 14.0mV 12 14.0mV 13 14.0mV 14 3.24V
D
IC730
No. Voltage 1 3.24V 2 14.2mV 3 1.27V 4 2.53V 5 3.24V
E
IC724
No. Voltage 1 12.3mV 2 12.6mV 3 12.7mV 4 -14.55V 5 12.7mV 6 12.6mV 7 12.3mV 8 14.41V
IC735
No. Voltage 1 4.98V 2 18.9mV 3 14.0mV 4 4.99V 5 14.0mV 6 4.99V 7 14.0mV 8 4.99V 9 14.1mV 10 4.99V 11 14.1mV 12 18.9mV 13 4.98V 14 4.99V
F
DJM-909
5 6 7 8
71
1
2
3
4
A
C
C1EQ ASSY IC1607
No. Voltage 1 3.2mV 2 3.2mV 3 2.9mV 4 -14.23V 5 2.8mV 6 3.1mV 7 3.1mV 8 14.11V
D
C2EQ ASSY IC1753
No. Voltage 1 9.6mV 2 9.6mV 3 9.4mV 4 -14.24V 5 9.4mV 6 9.5mV 7 9.5mV 8 14.11V
E
C1BF ASSY
F
C2BF ASSY
G
MICB ASSY
IC1601
No. Voltage 1 -2.9mV 2 3.0mV 3 3.9mV 4 -14.23V 5 2.8mV 6 3.2mV 7 -2.3mV 8 14.12V
IC1748
No. Voltage 1 1.8mV 2 2.1mV 3 1.6mV 4 -14.22V 5 1.7mV 6 1.7mV 7 1.4mV 8 14.12V
IC1251
No. Voltage 1 11.4mV 2 11.4mV 3 11.4mV 4 -14.23V 5 11.7mV 6 12.8mV 7 12.8mV 8 14.14V
IC1351
No. Voltage 1 11.2mV 2 11.2mV 3 11.1mV 4 -14.