Text preview for : SONY STR-DE445_DE545_SE501.pdf part of Sony DE445 Service Manual
Back to : SONY STR-DE445_DE545_SE5 | Home
STR-DE445/DE545/SE501
SERVICE MANUAL
US Model
STR-DE445/DE545/SE501
Canadian Model AEP Model UK Model
STR-DE445/DE545
Photo: STR-DE445
E Model Australian Model Chinese Model PX Model
STR-DE545
Dolby Laboratories Licensing Corporation. "DOLBY" the double-D symbol ; "AC-3" and "PRO LOGIC" are trademarks of Dolby Laboratories Licensing Corporation.
SPECIFICATIONS
AUDIO POWER SPECIFICATIONS
POWER OUTPUT AND TOTAL HARMONIC DISTORTION With 8 loads, both channels driven, from 20 20,000 Hz; rated 100a) W per channel minimum RMS power, with no more than 0.09% total harmonic distortion from 250 mW to rated output (US model only). STR-DE445: a) 80 W Inputs (Analog) 5.1 CH INPUT, CD, DVD/LD, MD/TAPE, TV/SAT, VIDEO, AUX: Sensitivity: 250 mV Impedance: 50 k S/Nb): 96 dB (A, 250 mVc)) BASS BOOST TONE +6 dB at 70 Hz ±6 dB at 100 Hz and 10 kHz
Sampling Frequency 48 kHz
b) Input short. c) Weighted nework, input level. Inputs (Digital) DVD/LD (coaxial): Sensitivity: -- Impedance: 75 S/N: 100 dB (A, 20 kHz LPF) DVD/LD, TV/SAT* (Optical): Sensitivity: -- Impedance: -- S/N: 100 dB (A, 20 kHz LPF)
FM tuner section
Tuning range 87.5 108.0 MHz Antenna terminals 75 , unbalanced Sensitivity Mono: 18.3 dBf, 2.2 µV/75 Stereo: 38.3 dBf, 22.5 µV/75
Amplifier section
Rated Power Output at Stereo mode US model: (8 20 Hz 20 kHz, THD 0.09 % ) EXCEPT US: (8 1 kHz, THD 0.7 %) STR-DE545/SE501: 100 W + 100 W STR-DE445: 80 W + 80 W Reference Power Output (8 at 1 kHz, THD 0.7 %) STR-DE545/SE501: Front: 100 W + 100 W Center: 100 W Rear: 100 W + 100 W STR-DE445: Front: 80 W + 80 W Center: 80 W Rear: 80 W + 80 W Frequency response CD, MD/TAPE, DVD/LD, TV/ SAT, VIDEO, AUX: 10 Hz 50 kHz +0.5/2 dB (with sound field, tone, and bass boost bypassed)
Usable sensitivity 11.2 dBf, 1 µV/75 S/N Mono: 76 dB Stereo: 70 dB
*) STR-DE545 and STR-SE501 only. Outputs MD/TAPE, (REC OUT); VIDEO (AUDIO OUT): Voltage: 250 mV, Impedance: 10 k SUB WOOFER: Voltage: 2 V Impedance: 1 k PHONES: Accepts low- and highimpedance headphones Harmonic distortion at 1 kHz Mono: 0.3 % Stereo: 0.5 % Separation Frequency response 30 Hz 15 kHz +0.5/2 dB Selectivity 60 dB at 400 kHz 45 dB at 1 kHz
-- Continued on next page --
FM STEREO FM-AM RECEIVER
1
AM tuner section
Tuning range With 10-kHz tuning scale: 530 1,710 kHzd) With 9-kHz tuning scale: 531 1,710 kHzd) Loop antenna 50dB/m (at 1,000kHz or 999kHz) 54dB (at 50mV/m) 0.5% (50mV/m, 400kHz) At 9kHz: 35dB At 10kHz: 40dB
MODEL IDENTIFICATION
-- BACK PANEL --
Antenna Usable sensitivity S/N Harmonic distortion Selectivity
Parts No.
d) You can change the AM tuning interval to 9kHz. After tuning in any AM station, turn off the receiver. Hold down the TUNING + button and press the @/1 button. All preset stations will be erased when you change the tuning interval. To reset the scale to 10 kHz, repeat the procedure.
Video section
Inputs Video: 1Vp-p 75 S-video*: Y: 1Vp-p 75 C: 0.286Vp-p 75 Video: 1Vp-p 75 S-video*: Y: 1Vp-p 75 C: 0.286Vp-p 75
Outputs
* STR-DE545 and STR-SE501 only.
General
System Tuner section: PLL quartz-locked digital synthesizer system Preamplifier section: Low-noise NF type equalizer Power amplifier section: Pure-complementary SEPP US, Canadian model: 120V AC, 60Hz Taiwan model: 110V AC, 60Hz Chinese, Singapore, Malaysia model: 220 230V AC, 50/60Hz AEP, UK, CIS model: 230V AC, 50/60Hz Australian model: 240V AC, 50/60Hz E, PX model: 120V or 220V or 240V AC, 50/60Hz STR-DE545/SE501: US model: 190W AEP, UK model: 220W STR-DE445: US model: 185W AEP, UK model: 160W
MODEL DE545: US model DE545: Canadian model DE545: Australian model DE545: E, PX model DE545: Malaysia, Singapore model DE545: Chinese model DE545: AEP, UK, CIS model DE545: Taiwan model DE445: US model DE445: Canadian model DE445: AEP, UK model DE445: CIS model SE501: US model
PARTS No. 4-226-802-0s 4-226-802-1s 4-226-802-2s 4-226-802-3s 4-226-802-4s 4-226-802-5s 4-226-802-6s 4-226-802-7s 4-226-808-0s 4-226-808-1s 4-226-808-2s 4-226-808-3s 4-227-063-0s
Power requirements
Power consumption
AC outlets (STR-DE545 and STR-SE501 only) US model: 1switched, total 120W/1A Max EXCEPT US: 1switched, max 100W Dimensions 430 × 303 × 157 mm (17 × 12 × 6 1/4 inches) including projecting parts and controls STR-DE545: 7.9kg (17 lbs. 7 oz) STR-DE445: 7.7kg (16 lbs. 16 oz) STR-SE501: 8.2kg (18 lbs. 2 oz) FM wire antenna (1) AM loop antenna (1) R6 (size-AA) batteries (2) STR-DE545 and STR-SE501 only Remote Commander RM-PP404 (remote) (1) Operating instructions of the remote (1) Operating instructions of CONTROLA1 II (1) STR-DE445 only Remote Commander RM-U304 (remote) (1)
Mass (Aporox.)
Supplid accessories
Design and specifications are subject to change without notice.
2
SAFETY CHECK-OUT
(US model)
After correcting the original service problem, perform the following safety checks before releasing the set to the customer: Check the antenna terminals, metal trim, "metallized" knobs, screws, and all other exposed metal parts for AC leakage. Check leakage as described below.
TABLE OF CONTENTS 1. GENETAL ........................................................................... 4 2. TEST MODE ...................................................................... 6 3. DIAGRAMS
3-1. Circuit Boards Location ..................................................... 7 3-2. Block Diagrams .................................................................. 8 · Main Section .................................................................... 8 · Power Section .................................................................. 9 3-3. Printed Wiring Board -- Digital Section -- .................... 10 3-4. Schematic Diagram -- Digital Section -- ....................... 11 3-5. Printed Wiring Board -- Main Section -- ....................... 12 3-6. Schematic Diagram -- Main (1/3) Section -- ................. 13 3-7. Schematic Diagram -- Main (2/3) Section -- ................. 14 3-8. Schematic Diagram -- Main (3/3) Section -- ................. 15 3-9. Printed Wiring Board -- Display Section -- ................... 16 3-10. Schematic Diagram -- Display Section -- ..................... 17 3-11. Printed Wiring Board -- Video/Key Section -- ............... 18 3-12. Schematic Diagram -- Video/Key Section -- ................. 19 3-13. Printed Wiring Board -- Power Supply Section -- ......... 20 3-14. IC Pin Function Description ............................................. 21 3-15. IC Block Diagrams ........................................................... 28
LEAKAGE
The AC leakage from any exposed metal part to earth ground and from all exposed metal parts to any exposed metal part having a return to chassis, must not exceed 0.5 mA (500 microamperes). Leakage current can be measured by any one of three methods. 1. A commercial leakage tester, such as the Simpson 229 or RCA WT-540A. Follow the manufacturers' instructions to use these instruments. 2. A battery-operated AC milliammeter. The Data Precision 245 digital multimeter is suitable for this job. 3. Measuring the voltage drop across a resistor by means of a VOM or battery-operated AC voltmeter. The "limit" indication is 0.75 V, so analog meters must have an accurate low-voltage scale. The Simpson 250 and Sanwa SH-63Trd are examples of a passive VOM that is suitable. Nearly all battery operated digital multimeters that have a 2V AC range are suitable. (See Fig. A)
4. EXPLODEO VIEWS
4-1. Front Panel Section .......................................................... 30 4-2. Chassis Section ................................................................. 32
5. ELECTRICAL PARTS LIST ....................................... 34
To Exposed Metal Parts on Set
0.15µF
1.5k
AC voltmeter (0.75V)
Earth Ground
Fig. A. Using an AC voltmeter to check AC leakage.
SAFETY-RELATED COMPONENT WARNING!! COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.
ATTENTION AU COMPOSANT AYANT RAPPORT À LA SÉCURITÉ! LES COMPOSANTS IDENTIFÉS PAR UNE MARQUE 0 SUR LES DIAGRAMMES SCHÉMATIQUES ET LA LISTE DES PIÈCES SONT CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT. NE REMPLACER CES COMPOSANTS QUE PAR DES PIÈSES SONY DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL OU DANS LES SUPPÉMENTS PUBLIÉS PAR SONY.
3
SECTION 1 GENERAL
FRONT PANEL
1 2 3 4 5 6 7 8 9 0 qa
wh
wg
wf
wd
wswaw;
ql
qkqjqh
qg
qf qd qs
PHOTO: STR-DE445
1 2 3 4 5 6 @/1 button INPUT MODE button DIMMER button DISPLAY button 5.1CH INPUT button CHINEMA STUDIO A button CHINEMA STUDIO B button CHINEMA STUDIO C button MULTI CHANNEL DECODING indicator <, > buttons BASS BOOST indicator TONE indicator PRESET TUNING +/ buttons TUNING +/ buttons FM/AM button FM MODE button RDS EON button (AEP, UK, CIS model) RDS PTY button (AEP, UK, CIS model) SHIFT button MEMORY button TONE button BASS BOOST button qf qg qh qj qk ql w; wa ws wd MUTING button MASTER VOLUME knob SET UP button NAME button ENTER button Jog dial BASS/TREBLE button SUR button LEVEL button A.F.D button/indicator 2CH button/indicator MODE button/indicator VIDEO button DVD/LD button TV/SAT button MD/TAPE button CD button TUNER button AUX button PHONES jack SPEAKER A button SPEAKER B button (DE545, SE501 model)
7 8 9 0
wf
qa qs qd
wg wh
4
REAR PANEL
1 2 3 4 5 qj
qh
qg qf
qd
qs qa
0
9 8
7
6
PHOTO: STR-DE445
1 2 ANTENNA terminal DIGITAL IN jack TV/SAT OPTICAL (DE545, SE501 model) DVD/LD OPTICAL (DE545, SE501 model) COAXIAL MONITOR jack VIDEO OUT S-VIDEO OUT (DE545, SE501 model) CTRL A1 II jack (DE545, SE501 model) SPEAKERS terminal REAR CENTER FRONT A FRONT B (DE545, SE501 model) AC power cord AC OUTLET (DE545, SE501 model) IMPEDANCE SELECTOR switch (DE545, SE501 model) SUB WOOFER jack VIDEO jack VIDEO IN/OUT AUDIO IN/OUT qa DVD/LD jack VIDEO IN S-VIDEO IN (DE545, SE501 model) AUDIO IN TV/SAT jack VIDEO IN AUDIO IN MD/TAPE jack CD jack AUX jack 5.1CH INPUT jack FRONT REAR CENTER SUB WOOFER VOLTAGE SELECTOR switch (E, PX model)
3
qs
4 5
qd qf qg qh
6 7 8 9 0
qj
5
SECTION 2 TEST MODE
SOFTWARE VERSION DISPLAY MODE
* The software version is displayed. * Procedure: While depressing the TUNER and the VIDEO buttons simultaneously, press the power [@/1] button to turn on the main power. The model name, destination and the software version are displayed.
ALL CLEAR MODE
* All preset contents are cleared when this mode is activated. Use this mode before returning the product to clients upon completion of repair. * Procedure: While depressing the TUNER and the MD/TAPE buttons simultaneously, press the power [@/1] button to turn on the main power. Alternatively, press @/1 more than 4S. The message ALL CLEAR appears and initialization is performed.
FLUORESCENT INDICATOR TUBE TEST MODE
* All fluorescent segments are tested. When this test is activated, all segments turn on at the same time, then each segment turns on one after another. * Procedure: While depressing the TV/SAT and the CD buttons simultaneously, press the power [@/1] button to turn on the main power. 1. All segments turn on.
; DIGITAL PRO LOGIC OPT COAX ; dts D.RANGE TA NEWS INFO MONO STEREO
RDS L C R LFE LS S RS
mft . dB kHz MHz
SURROUND CLEAR MODE
* The preset sound field is cleared when this mode is activated. Use this mode before returning the product to clients upon completion of repair. * Procedure: While depressing the SOUND FIELD MODE button, press the power [@/1] button to turn on the main power. The message SURR CLR appears and initialization is performed.
MEMORY
A.F.D, LEVEL, BASS/TREBLE, SET UP and MUTING LED turn on. 2. Press the VIDEO button, confirm display
; DIGITAL
L C R OPT
AM CHANNEL STEP 9 KHZ/10 KHZ SELECTION MODE (US, Canadian, E, PX model)
* Either the 9 kHz step or 10 kHz step can be selected for the AM channel step. * Procedure: Set the FUNCTION to AM. Turn off the main power. While depressing the TUNING+ button or the PRESET+ button, press the power [@/1] button to turn on the main power. Either the message AM 9k STEP or AM 10k STEP appears. Select the desired step.
;
D.RANGE
NEWS
MONO
m dB Hz
STEREO
LFE LS S RS
2CH, SUR, NAME and JOG dial LED turn on. 3. Press the VIDEO button, confirm display
PRO LOGIC COAX dts TA INFO RDS
ft . k MHz
MEMORY
MODE, BASS BOOST, TONE and Digital Cinema Sound LED turn on. 4. Press the VIDEO button, All segments turn off. 5. Every pressing of the VIDEO button turns on each segment one after another in the following order. (Not only the VIDEO button, but also the other buttons sach as DVD/LD, TV/SAT, MD/TAPE, CD, TUNER, AUX can be used.)
FACTORY SET MODE
* All preset contents are reset to the default setting. * Procedure: While depressing the VIDEO and the CD buttons simultaneously, press the power [@/1] button to turn on the main power. The message FACTORY appears and the present contents are reset to the default values.
6
STR-DE445/DE545/SE501 SECTION 3 DIAGRAMS
3-1. CIRCUIT BOARDS LOCATION THIS NOTE IS COMMON FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS. (In addition to this necessary note is printed in each block.)
For schematic diagrams. Note:
STBY board AC SEL board (E, PX model) VIDEO board POWER SWITCH board S-VIDEO board (DE545, SE501 model)
For printed wiring boards. Note:
· X : parts extracted from the component side. a · : Through hole. f · : internal component. · b : Pattern from the side which enables seeing. C Q B E These are omitted.
DIGITAL board
· All capacitors are in µF unless otherwise noted. pF: µµF 50 WV or less are not indicated except for electrolytics and tantalums. · All resistors are in and 1/4 W or less unless otherwise specified. · % : indicates tolerance. f · : internal component. · 2 : nonflammable resistor. · 1 : fusible resistor. · C : panel designation.
Note: The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. Note: Les composants identifiés par une marque 0 sont critiques pour la sécurité. Ne les remplacer que par une pièce portant le numéro spécifié.
HEADPHONE board TUNER UNIT
B
C
E These are omitted.
DISPLAY board
MAIN board JOG board TUNER SWITCH board
· · · ·
·
· · ·
·
U : B+ Line. V : B Line. H : adjustment for repair. Voltages and waveforms are dc with respect to ground under no-signal (detuned) conditions. No mark : FM Voltages are taken with a VOM (Input impedance 10 M). Voltage variations may be noted due to normal production tolerances. Waveforms are taken with a oscilloscope. Circled numbers refer to waveforms. Signal path. F : FM J : CD c : digital out Abbreviation CND : Canadian model AUS : Australian model CH : Chinese model MY : Malaysia model SP : Singapore model TW : Taiwan model
· Waveform DIGITAL Board
1 IC1005 25
5.5Vp-p
12.288MHz
DISPLAY Board
1 IC102 is (XO)
3.6Vp-p
16.0MHz
MAIN Board
1 IC301 qf (XO)
2.8Vp-p
4.33MHz
7
7
STR-DE445/DE545/SE501
3-2. BLOCK DIAGRAMS - MAIN SECTION J401 AUX IN CD IN REC OUT IN L L J402 L L L J403 L REC OUT IN J501 FRONT 5.1CH INPUT REAR CENTER 3 IC401 1 L L 50 LCH NIN 44 SLCH NIN 38 CCH NIN 27 SWCH NIN 63 ING2 TIN2 DOUT2 SLCH DIN CCH DIN SWCH DIN SEL OUT2 CLOCK DATA LATCH SWCH OUT 28 MUTE Q364 CCH OUT 37 MUTE Q363 WOOFER CENTER 67 INE2 62 REC OUT 2B 66 INF2 61 REC OUT 2A 69 INC2 68 IND2 IC201 SOUND PROCESSOR SLCH OUT 43 MUTE Q362 LCH OUT 49 MUTE Q361 REAR FRONT 71 INA2 70 INB2
MD/TAPE
TV/SAT IN DVD/LD IN VIDEO
A
(Page 9)
SUBWOOFER
60 IC1008 AUDIO CODEC 30 LIN+ 39 MCLKI 4 BCLK 5 LRCK IC1006 AUDIO DSP 13 14 15 16 IC1005 CLOCK OSC X IN 22 5 2 8 XI RAMCEN 2 RAMWEN 88 RAMDEN 89 A0-A14 IC CSB CS SO SI SCK D0-D7 SDIAI 85 83 SD BCKO 82 SDWCKO 84 SDIA SDOB0 47 SDOB1 46 SDOB2 45 9 SDTO 6 SDTI1 7 SDTI2 8 SDTI3 LOUT3 23
58 59 45 39 26
31 32 33
Q379 IC402 5 7 IC403 3 1 IC404(1/2) 3 1 IC404(2/2) 5 7 MUTE SWITCH
LOUT1 27
IC1004 DIGITAL AUDIO I/F RECEIVER J1001 COAXIAL DVD/LD DIGITAL IN OPTICAL IC1001 IR LINK DET IC1002 IR LINK DET CK OUT BCK LRCK DATAO
LOUT2 25
IC1003 3 DIN0
ROUT3 24
5 DIN2
TV/SAT OPTICAL DE545,SE501 MODEL
4 DIN1
IC1007 SRAM 20 CS 27 WE 22 OE SMUTE DFS PDN DIFO/CSN CCLK CDTI 3 11 17 41 42 43
XSTATE ERROR DO DI CE CLK XMODE
TUNER UNIT ANTENNA FM AM DET OUT 4 IC301 RDS 13 14 16 2 L CH AEP,UK,CIS MOEL
3
1
17 34 35 36 37 38 48
X1101 12.288MHz
62 65 66 67 68 69
Q103,104 MUTE CONTROL
SIGNAL STEREO TUNED T.MUTE S.DATA S.CLK DO S.LAT DE545,SE501 MODEL J1003 C IN S VIDEO OUT Y J1002 C Y IC1016 SELECTOR 1 V3 SW1 12 SW2 13 12 V1 5 VOUT M2 4 10 MON M1 11
X301 4.33MHz
59 60 61 62 65 66 67 44 48 53 TUNER LAT TUNER DATA OUT S VIDEO TUNER CLK MUTE TUNER DATA IN S1 TUNER MUTE AUTO STOP S2 STEREO VIDEO RDS SIGNAL MUTE RDS DT AUBUS IN RDS CLK
96 95 89 90 91 92 93 DIR CLK DIR XMODE D.EER D.DO DIR DI DIR CE DIR XSTATE
94 DIR DATAO
100 99 25 24 22 21 Y-IC Y-CS Y-SO Y-SI Y-CLK Y-CSB
72 70 71 73 68 69 CCODE MUTE CCODE DFS CCODE PD CCODE CS CCODE CLK CCODE CDTI
79 78 80 98 M.CE ANA/DIG M.CLK M.DATA
88 SYSTEM MUTE
28 J1004 MONITOR OUT VIDEO IN DVD/LD VIDEO IN TV/SAT VIDEO IN VIDEO OUT J1007 CTRL A1 J1006 3 V2 1 V3 5 OUT 10 MON SW1 2 12 V1 SW2 13 M2 4 M1 11
75
76
74
63 Q102 BUFFER
AUBUS OUT
IC102(1/2) SYSTEM CONTROL
64
· R ch is omitted · Signal Path : FM : CD(ANALOG) : DVD(DIGITAL)
DE545,SE501 MODEL
8
8
STR-DE445/DE545/SE501
- POWER SECTION RY791 IC701 POWER AMP +V OUT2 12 FRONT 8 IN2 NF2 9 Q704 BOOSTER Q655,656 CURRENT DET Q657,658 AF POWER PROTECT Q730 RELAY DRIVER RY740 +V OUT1 2 Q653 BOOSTER Q659 Q740 RELAY DRIVER RY601 Q654 BOOSTER Q610 RELAY DRIVER TM601 REAR L B Q701,702 LIMTER Q703 BOOSTER Q791 RELAY DRIVER RY730 TM602 L DE545,SE501 MODEL A FRONT R CH J791 PHONES
Q705,706 CURRENT DET
Q707,708 AF POWER PROTECT
Q709
REAR
6 IN1
-VOUT2 11
Q651,652 LIMTER
1 MUTE
NF1 5
A
(Page 8)
-VOUT1 3
CENTER IC501 POWER AMP CENTER 1 IN +VOUT 6 NF 2 Q504 BOOSTER Q501,502 LIMTER Q503 BOOSTER Q505,506 CURRENT DET Q507,509 AF POWER PROTECT
RY550 Q550 RELAY DRIVER RY560 Q560 RELAY DRIVER J502 SUB WOOFER
-VOUT 3 IC401 WOOFER 5 7
· R ch is omitted · Signal Path : CD(ANALOG) · Abbraviation CND: Canadian model AUS: Australian model SP : Singapore model TW : Taiwan model CH : Chinese model
B+ Q747,748 MUTE SWITCH S100-109 FUNCTION KEY 38 S110-119 FUNCTION KEY 39 S120-128 FUNCTION KEY 40 S129-137 FUNCTION KEY 41 S150-152 FUNCTION KEY 56 55 54
FOR POWER AMP
Q722,723,725
Q695,696 SWITCH Q697 INV.SW BQ691-694 SWITCH Q801 REG
D824-827
T901
E,PX MODEL S901 VOLTAGE SELECTOR 240V
PROTECTOR
+9.2V +30V
X101 16MHz 29 82 83
D802 IC801 +7V 3 REG IC807 +5V 3 REG IC804 2 BF1 2 2 B+
F903 220V 120V
58
15 10 9 14 12
13
FL LAT PROTECTOR FL CLK FL DATA
PWKEY IN SP A SP B BLUE LED BB LED TONE LED DOLBY LED
IC102(2/2) SYSTEM CONTROL
SELECT LED
AFD LED 2CH LED MODE LED
MUTE LED
WOOFER RY
AD KEY IN1
AD KEY IN2
AD KEY IN3
ADKEY IN4
H/P RY SP-A RY SP-B RY REAR RY CENTER RY
AC MUTE
XO
XI
FL LED
RESET
SIRCS
VOL-A
VOL-B
STOP PWRY
JOG-A
JOG-B
HSTX
LED1
LED2 LED3
S501 IMPEDANCE SELECTOR 8 DE545,SE501 MODEL
4
57 IC101 REMOTE CONTROL RECEIVER
85 86
45 46
87 Q007
30 31 32 Q004-006 LED DRIVER D005-010
33 Q001-003 LED SWITCH
1 2
3 4
5
6 7
16 17 18 19
77 Q100,101 RESET
52
47 8
LED +5V
3
REG IC803
F2 D820-823
DE545:US,CND,E,PX,SE501 MODEL
ROTARY ENCODER RV102 VOLUME
ROTARY ENCODER RV101 JOG
LED DRIVER
LED DRIVER
Q008 I Q011
D002 I D004
+5V -12V
3
REG
2
IC802 3 REG IC806 2 EXCEPT E,PX
D001
+7V D011-014
24 26 34 29
-7V
LAT CLK D.IN
CLR
IC103 FL DRIVER
TUNER +12V
3
REG
2 D898 D899 Q901 F901
EXCEPT US,CND,E,PX F902 DE545,SE501 MODEL JW515
G1-11
P1-19
F1 FL101 F2
RELAY DRIVER Q951 +5.6V IC950 8 REG D910-913 3 POWER CONTROL 6 D915 5 D914 T902 E,PX MODEL JW519 JW518 EXCEPT E,PX
J911 AC OUTLET
US,CND,E,PX MODEL
AC IN
9
9
STR-DE445/DE545/SE501
3-3. PRINTED WIRING BOARD -- DIGITAL SECTION -- · See page 7 for Circuit Boards Location.
· Semiconductor Location
Ref. No. D1201 D1202 D1301 IC1001 IC1002 IC1009 IC1010 IC1011 IC1013 Location C-3 C-3 A-3 A-2 A-2 B-3 B-3 D-1 B-3
· Semiconductor Location
Ref. No. D1101 IC1003 IC1004 IC1005 IC1006 IC1007 IC1008 IC1201 IC1251 Location B-3 A-1 A-3 A-3 C-3 D-3 C-2 D-2 D-1
10
10
STR-DE445/DE545/SE501
3-4. SCHEMATIC DIAGRAM -- DIGITAL SECTION -- · See page 7 for Waveforms. · See page 21 for IC Pin Functions.
PIN FUNCTION
PIN FUNCTION
PIN FUNCTION
11
11
STR-DE445/DE545/SE501
3-5. PRINTED WIRING BOARD -- MAIN SECTION -- · See page 7 for Circuit Boards Location.
· Semiconductor Location
Ref. No. D505 D506 D508 D510 D560 D605 D606 D607 D610 D617 D627 D691 D692 D706 D710 D721 Location E-4 E-4 E-3 B-10 B-8 E-7 E-8 E-7 B-9 E-8 E-11 D-8 D-9 E-6 B-10 D-10 Ref. No. D722 D725 D726 D727 D728 D731 D732 D734 D735 D736 D740 D757 D791 D801 D802 D804 Location D-10 E-9 E-9 E-5 E-5 C-10 C-11 D-10 C-9 C-10 B-10 E-9 E-12 D-13 B-13 D-13 Ref. No. D820 D821 D822 D823 D824 D825 D826 D827 D833 D896 D898 D899 IC201 IC301 IC401 Location D-12 D-12 D-12 D-12 D-12 D-13 D-13 D-12 C-7 C-6 E-11 E-12 C-4 B-1 B-7 Ref. No. IC402 IC403 IC404 IC501 IC701 IC702 IC801 IC802 IC803 IC804 IC806 IC807 Q361 Q362 Q363 Location D-2 E-1 D-1 D-4 D-6 D-7 C-8 C-9 C-9 C-11 C-9 C-8 C-5 C-6 D-3 Ref. No. Q364 Q365 Q366 Q379 Q501 Q502 Q503 Q504 Q505 Q506 Q507 Q509 Q550 Q560 Q601 Q602 Location D-5 C-7 C-8 E-2 E-3 F-3 F-3 F-4 E-4 E-3 E-4 E-4 C-10 C-9 E-11 F-11 Ref. No. Q603 Q604 Q605 Q606 Q610 Q651 Q652 Q653 Q654 Q655 Q656 Q657 Q658 Q659 Q691 Q692 Location F-10 F-11 E-11 E-11 C-9 E-6 F-7 F-7 F-8 E-6 F-8 E-8 E-8 E-8 D-9 D-8 Ref. No. Q693 Q694 Q695 Q696 Q697 Q701 Q702 Q703 Q704 Q705 Q706 Q707 Q708 Q709 Q722 Q723 Location D-9 D-9 D-8 D-8 D-8 E-4 F-5 F-5 F-6 E-6 E-5 E-6 E-6 E-6 D-10 D-11 Ref. No. Q725 Q730 Q740 Q747 Q748 Q751 Q752 Q753 Q754 Q755 Q756 Q757 Q758 Q759 Q791 Q801 Location D-11 C-10 C-10 D-7 C-7 E-8 E-9 F-8 F-9 E-9 E-10 E-9 E-9 E-9 D-11 D-13
12
12
STR-DE445/DE545/SE501
3-6. SCHEMATIC DIAGRAM -- MAIN (1/3) SECTION -- · See page 7 for Waveforms. · See page 28 for IC Block Diagrams.
13
13
STR-DE445/DE545/SE501
3-7. SCHEMATIC DIAGRAM -- MAIN (2/3) SECTION --
14
14
STR-DE445/DE545/SE501
3-8. SCHEMATIC DIAGRAM -- MAIN (3/3) SECTION --
15
15
STR-DE445/DE545/SE501
3-9. PRINTED WIRING BOARD -- DISPLAY SECTION -- · See page 7 for Circuit Boards Location.
· Semiconductor Location
Ref. No. D002 D003 D004 D005 D006 D007 D008 D009 D010 D011 D012 D013 D014 D100 D101 D102 D103 D104 D109 D110 Location D-8 D-9 D-9 E-6 E-6 C-6 D-6 D-4 D-4 A-7 B-2 B-2 B-10 B-7 A-4 D-1 C-5 A-3 C-13 C-12 Ref. No. IC101 IC102 IC103 Q001 Q002 Q003 Q004 Q005 Q006 Q007 Q008 Q009 Q010 Q011 Q100 Q101 Q102 Q103 Q104 Location B-3 B-5 B-8 C-8 D-8 D-8 D-4 C-7 D-7 A-1 A-10 C-10 C-2 C-2 D-1 D-1 A-3 E-2 E-2
16
16
STR-DE445/DE545/SE501
3-10. SCHEMATIC DIAGRAM -- DISPLAY SECTION -- · See page 7 for Waveforms. · See page 26 for IC Pin Functions.
PIN FUNCTION
17
17
STR-DE445/DE545/SE501
3-11. PRINTED WIRING BOARD -- VIDEO/KEY SECTION -- · See page 7 for Circuit Boards Location.
18
18
STR-DE445/DE545/SE501
3-12. SCHEMATIC DIAGRAM -- VIDEO/KEY SECTION -- · See page 29 for IC Block Diagrams.
19
19
STR-DE445/DE545/SE501
3-13. PRINTED WIRING BOARD -- POWER SUPPLY SECTION -- · See page 7 for Circuit Boards Location.
· Semiconductor Location
Ref. No. D901 D910 D911 D912 D913 D914 D915 IC950 Q901 Q951 Location C-3 A-4 A-4 B-4 A-4 B-4 B-4 C-4 C-3 C-3
20
20
3-14. IC PIN FUNCTIONS
· IC1004 LC89055W-RA8 DIGITAL AUDIO I/F RECEIVER (DIGITAL BOARD) Pin No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 Pin Name DISEL DOUT DIN0 DIN1 DIN2 D. GND D. VDD R V IN LPF A. VDD A. GND CK OUT BCK LRCK DATA O XSTATE D. GND D. VDD XMCK XOUT XIN EMPHA AUDIO CSFLAG F0/P0/C0 F1/P1/C1 F2/P2/C2 F3/P3/C3 D. VDD D. GND AUTO BPSYNC ERROR DO DI CE CLK XSEL MODE0 MODE1 D. GND D. VDD DOSEL0 DOSEL1 CKSEL0 CKSEL1 XMODE I/O I O I O I -- O I I O -- -- -- O O O O -- -- -- O I O -- O -- -- -- -- -- -- O O O O I I I I I I -- -- O O I I I Function Input data select. (connected to ground.) EIAJ data and parity flag output terminal (Not used) Amplifier integrate data input terminal Amplifier integrate data input terminal Amplifier integrate data input terminal Digital ground Digital power supply Input terminal for VCO generator band adjustment Input terminal for VCO self running frequency set External LPF for PLL is connected to this terminal Analog power supply Analog ground 256fs or 128fs clock output terminal (Select CLKMD terminal) Bit clock output terminal "L, R clock output terminal (L-ch: "H", R-ch: "L")" Audio data output terminal Xtal status frag output. Digital ground Digital power supply Not used. Crystal oscillator output terminal (Not used.) Crystal oscillator input terminal Emphasis monitor output terminal ("H" = ON) (Not used.) Not used. C-bit change frag output. (Not used.) Not used. Not used. Not used. Not used. Digital power supply Digital ground Non PCM data detect flag output. (Not used.) Non PCM sync detect flag output. (Not used.) Error mute output terminal Microprocessor I/F. When CCB/SUB is "H", data output terminal (high level open drain output) Microprocessor I/F. Data input terminal Microprocessor I/F. Chip enable/latch input terminal Microprocessor I/F. Clock input terminal Xtal select. (Connected to +5V.) Mode 0 input. (Connected to ground.) Mode 1 input. (Connected to ground.) Digital ground Digital power supply Output data select 0. (Connected to ground.) Output data select 1. (Connected to ground.) System clock select input 0. (Connected to ground.) System clock select input 1. (Connected to ground.) Reset input.
21
· IC1006 CXD9511AQ Audio DISP (DIGITAL BOARD) Pin No. 1 2 3, 4 57 8 9 10 11 12 13, 14 15 16 17 18 19 20 21 22 24 25 29 30 31 32 39 40 41 42 44 45 47 48 49 50 51 52 53 54 55 56 57 58, 59 60 61 62 63 64 65 66 67 68 69 70 Pin Name VDD1 RAMCEN RAM16, 15 SDIB0 2 XI XO VSS AVDD SDIB3 TEST OVFB DTS DATA AC3 DATA SDOB3 CPO AVSS VDD2 SDOA2 0 RAMA14 10 VSS VDD1 OPORT0 7 VSS VDD2 RAMA9 7 SDOB2-0 SDBCK1 SDWCK1 VSS VDD2 NONPCM CRC MUTE KARAOKE SURENC SDBCKO RAMA6, 5 VSS RAMA4 IC TEST RAMA3 CSB CSB SO SI SCK RAMA2 I/O -- O O I I O -- -- O -- O O O O O -- -- O O -- -- O -- -- O O I I -- -- O O O O O O O -- O I -- O I I O I I O Function Power supply. (+5v.) External RAM chip select output. External RAM address data output. (Not used.) PCM input to sub DSP. (Not used.) Xta'l 12.288MHz input. Not used. Ground. Power supply. (+3.3v) PCM input to sub DSP. (Not used.) Test terminal.(Not used.) Sub DSP over fllow detect. (Not used.) DTS data detect. (Not used.) AC-3 data detect. (Not used.) PCM output from Sub DSP. Not used. Output for PLL.Connected to external analog filter. Ground. Power supply. (+3.3v.) PCM output from Main DSP. (Not used.) External RAM address data output. Ground. Power supply. (+5v.) Not used. Ground. Power supply. (+3.3v) External RAM address data output. PCM output from Sub DSP. Bit clock input for SDOA, SDIB, SDOB. (Not used.) Word clock input for SDOA, SDIB, SDOB. (Not used.) Ground. Power supply. (+3.3v.) Non-PCM data detect. (Not used.) AC-3 CRC error detect.(Not used.) Auto mute detect.(Not used.) AC-3 karaoke data detect. (Not used.) AC-3 2/0 mode dolby surround encode input detect. (Not used.) SDBCK0 inverter clock output. (Not used.) External SRAM address data output. Ground. External SRAM address data output. Initial clear. Test terminal. (Not used.) External SRAM address data output. Chip select input for Sub DSP. Microcomputer interface chip select input. Microcomputer interface data output. Microcomputer interface data input. Microcomputer interface clock input. External SRAM address data output.
22
Pin No. 71 72 79 80 81 82 83 84 85 86 87 88 89 90 91 92 99 100
Pin Name VDD1 RAMD0 7 VSS VDD2 SDWCKO SDBCKO SDIA0 SDIA1 RAMA1 RAMA0 RAMWEN RANOEN VSS VDD2 IPORT7 0 VSS
I/O -- I/O -- -- I I I O O O O O -- -- I --
Function Power supply. (+5v.) External SRAM data input/output. Ground. Power supply. (+3.3v.) Bit clock input for SDOA, SDIB, SDOB. Word clock input for SDOA, SDIB, SDOB. AC-3/DTS bitstream or PCM data input to Main DSP. AC-3/DTS bitstream or PCM data input to Main DSP. External SRAM address data output. External SRAM address data output. Write enable for external SRAM. Output enable for external SRAM. Ground. Power supply. (+3.3v.) Not used. Ground.
23
· IC1008 AK4527 A/D, D/A CONVERTER (DIGITAL BOARD) Pin No. 1 2 3 4 5 6 7 8 9 10 11 SDOS I2C S MUTE BCLK LRCK SDT11 SDT12 SDT13 SDTO DAUX DFS Pin Name I/O SDTO source select pin I I I I/O I/O I I I O I I "L": internal ADC output, "H": DAUX input ORed with serial control register if P/S = "L" (Connected to ground) Serial control mode select pin Soft mute pin "H": Soft mute ON, "L": OFF Audio serial data clock pin Input/output channel clock pin DAC1 audio serial data input pin DAC2 audio serial data input pin DAC3 audio serial data input pin Audio serial data output pin AUX audio serial data input pin (Connected to ground) Double speed sampling mode pin "L": normal speed, "H": double speed ORed with serial control register if P/S = "L" 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 DEM1 DEM0 TVDD D. 5V D. GND PDN ICKS2 ICKS1 ICKS0 CAD1 CAD0 LOUT3 ROUT3 LOUT2 ROUT2 LOUT1 ROUT1 LIN LIN+ I -- -- -- I I I I I I O O O O O O I I De-emphasis pin ORed with serial control register if P/S = "L" (Connected to ground) Connected to digital power supply. Digital power supply pin Digital ground pin Power-down & reset pin When "L", the AK4527 is powered-down and the control registers are reset to default state. If the state of CAD0-1 changes, then the AK4527 must be reset by PDN. Input clock select 2 pin. (Connected to ground) Input clock select 1 pin. (Connected to digital power supply) Input clock select 0 pin. (Connected to digital power supply) Chip address pin Used during the serial control mode. (Connected to ground) Chip address pin Used during the serial control mode. (Connected to ground) Lch #3 analog output pin Rch #3 analog output pin Lch #2 analog output pin Rch #2 analog output pin Lch #1 analog output pin Rch #1 analog output pin Lch analog negative input pin Lch analog positive input pin Function
24
Pin No. 31 32 33 34 35 36 37 38 39 40 41 42 43 44
Pin Name RIN RIN+ DZF2 VCOM VREFH A. 5V A. GND DZF1 MCLK P/S DIFø/CSN CCLK CDTI LOOP1
I/O I I O O I -- -- O I I I I I I
Function Rch analog negative input pin Rch analog positive input pin Zero input detect 2. (Not used.) Common voltage output pin, AVDD/2 Large external capacitor is used to reduce power-supply noise "Positive voltage reference input pin, AVDD" Analog power supply pin Analog ground pin Zero input detect 1. (Not used.) Master clock input pin Parallel/serial select pin "L": serial control mode, "H": parallel control mode (Connected to ground) Audio data interface formtat. (At pararel control mode.) Chip select pin in serial mode Control data clock pin in serial mode Control data input in serial mode Loop back model
25
· IC102 MB90553ABPF-G-158-BND System control (DISPLAY BOARD) Pin No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 32 33 34 35 36 37 38 41 42 43 44 45 46 47 48 49 50 51 52 53 54 Pin Name BLUE LED BB LED TONE LED DOLBY LED AFD LED 2CH LED MODE LED PW RY SP B RY SP A RY VSS CENTER RY WOOFER RY REAR RY H/P RY FL CLR FL LAT FL CLK FL DATA/FLASH FLASH2 YSS912 CLK YSS912 SI VCC YSS912 SO YSS912 CS SECTION NAME C SVIDEO MUTE AC MUTE LED1 3 SELECT LED AVCC AVRH AVRL AVSS AD KEY IN1 4 VSS VERSION RDS SIGNAL JOG A (UP) JOG B (DWN) STOP RDS DT MD0 MD1 MD2 HSTX RDS CLK SP B I/O O O O O O O O O O O -- O O O O O O O O I O O -- I O I -- O O O O -- -- -- -- I -- I I I I I I I I I I I I Function MULTI CHANNEL DECODING display data output to LED. BASS BOOST display data output to LED. TONE display data output to LED. DOLBY DIGITAL display data output to LED. A.F.D display data output to LED. 2CH display data output to LED. MODE display data output to LED. Power relay. Speaker B relay. Speaker A relay. Ground. Center Speaker relay. Sub Woofer relay. Rear Speaker relay. Phones relay. Clear output to flourescent display tube. Latch output to flourescent display tube. Clock output to flourescent display tube. Data output to flourescent display tube./FLASH data output. FLASH data input. Clock output to Audio DSP IC. Serial data output to Audio DSP IC. Power suppley. Serial data input to Audio DSP IC. Chip select output to Audio DSP IC. Section name signal input. External power regulator capacitor 0.1 is connected to this terminal. S-video mute output. AC mute output. LED data output. LED select data output. Analog power suppley. Connected to power supply. Connected to ground. Ground. Key input. Power suppley. Version signal input. RDS signal input. Function encoder up input. Function encoder down input. Stop input. RDS data input. Selection of micrprocessor operation mode. Selection of micrprocessor operation mode. (Connected to power supply.) Selection of micrprocessor operation mode. Hardware standby signal input. RDS clock input. Speaker B signal input.
26
Pin No. 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100
Pin Name SP A PW KEY IN SIRCS PROTECTOR TUNER LAT TUNER DATA OUT TUNER CLK TUNER DATA IN AUBUS IN AUBUS OUT TUNER MUTE AUTO STOP STEREO CODEC CLK CODEC DFS CODEC CDT1 CODEC PD CODEC MUTE CODEC CS VIDEO MUTE S1 S2 RESET M61501 DATA M. CLK M. CE VSS XO XI VCC VOL-A (UP) VOL-B (DOWN) MUTE LED SYSTEM MUTE D.DO DIR DI DIR CE DIR CLK DIR XMODE DIR DATAO D.ERR DIR XSTATE DTS ANG/DIG Y CS Y IC
I/O I I I I O O O I I O O I I O O O O O O O O O I O O O -- O I -- I I O O I O O O O I I I I O O O
Function Speaker A signal input. Power key input. Sircs signal input. Protect signal input. Tuner latch output. Tuner data output. Tuner clock output. Tuner data input. Audio data bus input. Audio data bus output. Tuner mute output. Auto stop signal input. Stereo signal input. CODEC clock output. CODEC double speed sampling output. CODEC control data output. CODEC power down output. CODEC mute output. CODEC chip select output. Video mute output. Video select switch1 output. Video select switch2 output. Reset input. Data output to sound processor. Clock output to sound processor. Chip enable output to sound processor. Ground. External ceramic filter 16MHz is connected to this terminal. External ceramic filter 16MHz is connected to this terminal. Power suppley. Volume up signal input. Volume down signal input. Muting display data output to LED. System mute output. Data input to digital audio I/F receiver. Data output to digital audio I/F receiver. Chip enable output to digital audio I/F receiver. Clock output to digital audio I/F receiver. Reset signal output to digital audio I/F receiver. Audio data input to digital audio I/F receiver. Error mute signal input to digital audio I/F receiver. Xtal status frag signal input to digital audio I/F receiver. Digital theater system signal input. Analog/digital select signal output. Chip select output to Audio DSP IC. Reset signal output to Audio DSP IC.
27
3-15. IC BLOCK DIAGRAMS
IC301 BU1924F-E2 (MAIN BOARD)
RCLK VDD2 NC XO VSS2 T1 T2 XI
16
15
14
13
12 11 10
9
CLOCK PLL 57kHz RDS/ARI PLL 1187.5Hz
DIGITAL
TEST
COMPARATOR
DEFFERENTIAL DECODER
ANTI-ALIASING FILTER
1
QUAL
2
RDAT
3
VREF
4
MUX
ANALOG
BIPHASE DECODER
8th SWITCHED CAPACITOR FILTER
5
VDD1
6
VSS1
7
VSS3
R6 D3
8
CMP
IC501 STK350-230 (MAIN BOARD)
TR3 TR1 INPUT NF 1 2 3 4 -VEOUT +VEOUT VSS GND VCC 5 6 7 8 9 R9 TR8 R4 TR5 R3 TR7 TR2 TR4
R1
R2
TR6 D4
SUB
D1
D2
R5
R8
R7
IC701, 702 µPC2581V (MAIN BOARD)
BIAS CIRCUIT PROTECTOR
REG DRIVE 1
MUTE
PRE DRIVE 5
NF1
PRE DRIVE 7
GND
DRIVE
2
3 4
6
IN1
8 9 10 11 12 13 14 15
IN2 NF2 COMP2 VOUT2 +VOUT2 VCC1 VCC2 VEE
28
+VOUT1 VOUT1 COMP1
IC950 NJM2103D (STBY BOARD)
CR
1
8
RESET
VSC 2 + VREF
+ 7 VSA
OUTC
3
6
VSB/SESIN
GND
4 Q R S + +
5
V+
IC1015 NJM2279D (VIDEO BOARD) IC1016 NJM2279D (S VIDEO BOARD)
VIN 3 1 SW 1 2 VIN 2 3
14 V13 SW 2 12 VIN 1
MUTE 2 4 VOUT 2 5 GND 2 6 GND 1 7 2 1
11 MUTE 1 10 VOUT 1 9 8 NC V+
29
SECTION 4 EXPLODED VIEWS
NOTE: · -XX, -X mean standardized parts, so they may have some differences from the original one. · Items marked "*" are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. · Color Indication of Appearance Parts Example: KNOB, BALANCE (WHITE) . . . (RED) Parts of Color Cabinet's Color · · The mechanical parts with no reference number in the exploded views are not supplied. Hardware (# mark) list and accessories and packing materials are given in the last of this parts list.
The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. Les composants identifiés par une marque 0 sont critiques pour la sécurité. Ne les remplacer que par une pièce portant le numéro spécifié.
·
Abbreviation CND : Canadian AUS : Australian CH : Chinese
MY SP TW
: Malaysia : Singapore : Taiwan
4-1. FRONT PANEL SECTION
6 11
12
12 6 7 13 11 (DE545/SE501) 8 12 9 16 5 8
FL101
10
6
#3
15 6
4
Supplied with RV101
1
14
3
2
Supplied with RV102
#1
30
Ref. No. 1 1 1 1 1 1 1 1 1 2
Part No. X-4952-628-1 X-4952-629-1 X-4952-679-1 X-4952-680-1 X-4952-681-1
Description
Remark
Ref. No. 10 10 10 10 10 10 10 11 11 11
Part No.
Description
Remark
FRONT PANEL ASSY(DE545:US,CND) FRONT PANEL ASSY(DE445:US,CND) FRONT PANEL ASSY(DE545:AUS) FRONT PANEL ASSY(DE545:AEP,UK,CIS) FRONT PANEL ASSY(DE545:CH,TW,SP,MY)
X-4952-682-1 FRONT PANEL ASSY(BLACK)(DE445:AEP,UK,CIS) X-4952-683-1 FRONT PANEL ASSY(SE501) X-4952-831-1 FRONT PANEL ASSY(SILVER) (DE445:AEP,UK,CIS) X-4952-938-1 FRONT PANEL ASSY(DE545:E,PX) 4-226-453-11 KNOB(VOL-E3) (BLACK) (CH,US,CND,AEP,UK,CIS,AUS) 4-226-453-21 KNOB(VOL-E3)(DE545:TW,SP,MY) 4-226-453-41 KNOB(VOL-E3)(SILVER) (DE445:AEP,UK,CIS/DE545:E,PX,AUS) 4-226-799-01 KNOB(JOG)(BLACK)(US,CND,AEP,UK,CIS) 4-226-799-11 KNOB(JOG)(SILVER) (DE445:AEP,UK,CIS/DE545:CH,TW,SP,MY,E,PX,AUS) 4-996-698-01 EMBLEM, SONY(EXCEPT CH,TW,SP,MY) 4-996-698-11 1-676-786-11 4-951-620-01 1-676-784-11 4-921-941-01 3-386-245-12 A-4428-428-A A-4428-438-A A-4428-458-A EMBLEM, SONY(CH,TW,SP,MY) HEADPHONE BOARD SCREW(2.6X8), +BVTP POWER SWITCH BOARD CUSHION (FL) HOLDER (FL) DISPLAY BOARD, COMPLETE(DE445:US) DISPLAY BOARD, COMPLETE(DE545:US) DISPLAY BOARD, COMPLETE(SE501)
A-4428-464-A DISPLAY BOARD, COMPLETE(DE445:CND) A-4428-466-A DISPLAY BOARD, COMPLETE (DE445:AEP,UK,CIS) A-4428-468-A DISPLAY BOARD, COMPLETE(DE545:CND) A-4428-471-A DISPLAY BOARD, COMPLETE (DE545:AEP,UK,CIS) A-4428-479-A DISPLAY BOARD, COMPLETE(DE545:TW,E,PX) A-4428-482-A A-4428-492-A 4-226-445-11 4-226-445-21 4-226-445-41 DISPLAY BOARD, COMPLETE(DE545:CH,SP,MY) DISPLAY BOARD, COMPLETE(DE545:AUS) BUTTON (S)(BLACK)(US,CND,AEP,UK,CIS) BUTTON (S)(DE545:CH,TW,SP,MY) BUTTON (S)(SILVER) (DE445:AEP,UK,CIS/DE545:E,PX,AUS)
2 2 3 3 4 4 5 6 7 * 8 * 9 10 10 10
12 12 13 13 13
4-210-291-01 SCREW (CASE 3 TP2)(BLACK) (US,CND,AEP,UK,CIS) 4-210-291-11 SCREW (CASE 3 TP2)(SILVER) (DE445:AEP,UK,CIS/DE545:CH,TW,SP,MY,E,PX,AUS) 4-226-945-01 CASE(E5)(BLACK)(US,CND,AEP,UK,CIS) 4-226-945-21 CASE(E5)(CH,TW,SP,MY) 4-226-945-41 CASE(E5)(SILVER) (DE445:AEP,UK,CIS/DE545:E,PX,AUS) 1-676-785-11 1-676-787-11 4-996-683-21 4-996-683-51 4-996-683-71 TUNER SWITCH BOARD JOG BOARD BUTTON (POWER)(BLACK)(US,CND,AEP,UK,CIS) BUTTON (POWER)(CH,TW,SP,MY) BUTTON (POWER)(SILVER) (DE445:AEP,UK,CIS/DE545:E,PX,AUS)
14 15 16 16 16
FL101
1-517-929-11 TUBE, FLUORESCENT INDICATOR
31
4-2. CHASSIS SECTION
69 58
#1 #3 not supplied #2 not supplied not supplied #3 #2
#1 (DE545/SE501) #1 #1
61
57
60 62
#1 #1 #1 #1 #1
#4 T901
#4
70
63
#1
#3
55
56
#3
64
54
65
#1
67 53
#1
66
#4
52
51
#1
51
not supplied
#1
68
E,PX
59
US,CH,CND
59
59
AEP,UK,CIS,SP,MY,TW,E AUS
32
Ref. No. 51 51 51 51 52 * 53 54 54 54 54 54 54 54 55 * 56 57 57 57 57 57 57 * 58 0 59 0 59 0 59 0 59 0 59 60 60 60 60
Part No.
Description
Remark
Ref. No. 60 60 60 60 60 60 60 60 60 61 62 63 64 65 65 66 66 67 0 68 69 70 0 T901 0 T901 0 T901 0 T901 0 T901 0 T901 0 T901 0 T901 0 T901 0 T901
Part No. 4-226-802-41 4-226-802-51 4-226-802-61 4-226-802-71 4-226-808-01 4-226-808-11 4-226-808-21 4-226-808-31 4-227-063-01 4-956-370-12 1-676-781-11 1-769-840-11 1-676-782-11 A-4424-456-A A-4424-459-A 1-693-407-41 1-693-408-41 1-773-001-11 1-569-008-21 1-676-788-11 1-500-386-11 1-435-306-11 1-435-306-21 1-435-307-11 1-435-308-11
Description BACK PANEL (E5)(DE545:SP,MY) BACK PANEL (E5)(DE545:CH) BACK PANEL (E5)(DE545:AEP,UK,CIS) BACK PANEL (E5)(DE545:TW) BACK PANEL (E4)(DE445:US) BACK PANEL (E4)(DE445:CND) BACK PANEL (E4)(DE445:AEP,UK) BACK PANEL (E4)(DE445:CIS) BACK PANEL (S5)(SE501) BAND, PLUG FIXED(DE545:TW,AUS)
Remark
X-4947-124-1 FOOT ASSY (F50150S)(SILVER) (DE445:AEP,UK,CIS/DE545:E,PX,AUS) X-4947-208-1 FOOT ASSY (F50150S)(BLACK) (DE445:US,CND,AEP,UK/DE545:CH,US,CND,AEP,UK,CIS,SE501) X-4947-389-1 FOOT ASSY (F50150S)(BLACK)(DE445:CIS) X-4947-547-1 FOOT ASSY (F50150S)(DE545:TW,SP,MY) 4-226-801-01 SUB MOLD (E5) 4-954-051-51 A-4428-423-A A-4428-429-A A-4428-463-A A-4428-465-A HOLDER, PC BOARD(DE445) MAIN BOARD, COMPLETE(DE445:US) MAIN BOARD, COMPLETE(DE545:US,SE501) MAIN BOARD, COMPLETE(DE445:CND) MAIN BOARD, COMPLETE(DE445:AEP,UK,CIS)
A-4428-467-A MAIN BOARD, COMPLETE(DE545:CND,E,PX) A-4428-469-A MAIN BOARD, COMPLETE(DE545:AEP,UK,CIS) A-4428-490-A MAIN BOARD, COMPLETE (DE545:CH,TW,SP,MY,AUS) 3-905-609-01 SCREW (TRANSISTOR) 4-924-098-91 HOLDER, PC BOARD A-4428-435-A A-4428-478-A A-4428-481-A A-4428-491-A A-4428-497-A A-4473-334-A 3-703-244-00 1-696-847-11 1-777-070-21 1-777-071-21 1-783-205-11 1-783-820-11 4-226-802-01 4-226-802-11 4-226-802-21 STBY BOARD, COMPLETE(US,CND) STBY BOARD, COMPLETE(E,PX) STBY BOARD, COMPLETE(AEP,UK,CIS,SP,MY) STBY BOARD, COMPLETE(AUS) STBY BOARD, COMPLETE(CH) STBY BOARD, COMPLETE(TW) BUSHING (2104), CORD CORD, POWER(AUS) CORD, POWER(CND) CORD, POWER(AEP,UK,CIS,SP,MY,TW,E,PX) CORD, POWER(CH) CORD, POWER(US) BACK PANEL (E5)(DE545:US) BACK PANEL (E5)(DE545:CND) BACK PANEL (E5)(DE545:AUS)
VIDEO BOARD WIRE(FLAT TYPE) (5 CORE)(DE545,SE501) S-VIDEO BOARD(DE545,SE501) DIGITAL BOARD, COMPLETE(DE445) DIGITAL BOARD, COMPLETE(DE545,SE501) TUNER(TW,US,CND,E) TUNER(CH,AEP,UK,CIS,SP,MY,AUS) WIRE(FLAT TYPE) (15 CORE) ADAPTOR, CONVERSION 2P(E,PX) AC SEL BOARD(E,PX) FILTER, CLAMP (FERRITE CORE) TRANSFORMER, POWER(DE545:US) TRANSFORMER, POWER(SE501) TRANSFORMER, POWER(DE545:CND) TRANSFORMER, POWER(DE545:AUS)
1-435-309-11 TRANSFORMER, POWER (DE545:CH,AEP,UK,CIS,SP,MY) 1-435-310-11 TRANSFORMER, POWER(DE545:E,PX) 1-435-312-11 TRANSFORMER, POWER(DE445:CND) 1-435-313-11 TRANSFORMER, POWER(DE445:US) 1-435-314-11 TRANSFORMER, POWER(DE445:AEP,UK,CIS) 1-435-562-11 TRANSFORMER, POWER(DE545:TW)
4-226-802-31 BACK PANEL (E5)(DE545:E,PX)
The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified.
Les composants identifiés par une marque 0 sont critiques pour la sécurité. Ne les remplacer que par une pièce portant le numéro spécifié.
33
AC SEL
DIGITAL
· ·
SECTION 5 ELECTRICAL PARTS LIST
CAPACITORS: uF: µF RESISTORS All resistors are in ohms. METAL: metal-film resistor METAL OXIDE: Metal Oxide-film resistor F: nonflammable COILS uH: µH
When indicating parts by reference number, please include the board name.
NOTE: · Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. · -XX, -X mean standardized parts, so they may have some difference from the original one. · Items marked "*" are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. · Abbreviation CND : Canadian MY : Malaysia AUS : Australian SP : Singapore CH : Chinese TW : Taiwan
·
SEMICONDUCTORS In each case, u: µ, for example: uA...: µA... , uPA... , µPA... , uPB... , µPB... , uPC... , µPC... , uPD..., µPD...
The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. Les composants identifiés par une marque 0 sont critiques pour la sécurité. Ne les remplacer que par une pièce portant le numéro spécifié.
·
Ref. No.
Part No.
Description
Remark
Ref. No. C1221 C1222 C1223 C1224 C1225 C1226 C1228 C1229 C1230 C1231 C1232 C1233 C1251 C1252 C1253 C1254 C1271 C1272 C1273 C1301 C1302 C1303 C1304 C1305 C1306 C1307 C1308 C1309 C1310 C1311 C1312 C1313 C1314 C1315 C1316 C1317 C1318 C1319 C1320 C1321 C1322 C1323 C1324 C1325 C1329
Part No. 1-126-965-11 1-126-965-11 1-126-965-11 1-165-319-11 1-165-319-11 1-126-964-11 1-165-319-11 1-104-664-11 1-165-319-11 1-126-964-11 1-126-935-11 1-126-960-11 1-126-965-11 1-165-319-11 1-126-964-11 1-106-347-00 1-126-965-11 1-126-965-11 1-126-965-11 1-126-935-11 1-165-319-11 1-165-319-11 1-104-664-11 1-163-133-00 1-165-319-11 1-165-319-11 1-165-319-11 1-165-319-11 1-165-319-11 1-165-319-11 1-165-319-11 1-165-319-11 1-126-960-11 1-126-935-11 1-126-935-11 1-126-960-11 1-104-665-11 1-104-665-11 1-126-935-11 1-165-319-11 1-163-243-11 1-163-217-11 1-126-965-11 1-163-021-91 1-163-251-11
Description ELECT ELECT ELECT CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP ELECT CERAMIC CHIP ELECT ELECT ELECT ELECT CERAMIC CHIP ELECT MYLAR ELECT ELECT ELECT ELECT CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT ELECT ELECT ELECT ELECT ELECT ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP 22uF 22uF 22uF 0.1uF 0.1uF 10uF 0.1uF 47uF 0.1uF 10uF 470uF 1uF 22uF 0.1uF 10uF 0.0015uF 22uF 22uF 22uF 470uF 0.1uF 0.1uF 47uF 470PF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 1uF 470uF 470uF 1uF 100uF 100uF 470uF 0.1uF 47PF 1PF 22uF 0.01uF 100PF
Remark 20.00% 50V 20.00% 50V 20.00% 50V 50V 50V 20.00% 50V 50V 20.00% 16V 50V 20.00% 50V 20.00% 6.3V 20.00% 50V 20.00% 50V 50V 20.00% 50V 5.00% 20.00% 20.00% 20.00% 20.00% 50V 50V 50V 50V 6.3V
1-676-788-11 AC SEL BOARD (E,PX) ************* 1-533-223-11 HOLDER, FUSE (E,PX) < CONNECTOR > * CNP910 1-580-445-11 PIN, CONNECTOR 3P(E,PX) < FUSE > 0 F903 1-532-504-31 FUSE T4AL 250V(E,PX) < SWITCH > 0 S901 1-571-437-11 SWITCH, POWER VOLTAGE CHANGE (VOLTAGE SELECTOR)(E,PX) ************************************************************** A-4424-456-A DIGITAL BOARD, COMPLETE (DE445) ************************ A-4424-459-A DIGITAL BOARD, COMPLETE (DE545,SE501) ************************ 7-685-646-79 SCREW +BVTP < CAPACITOR > C1001 C1002 C1101 C1102 C1103 C1104 C1105 C1106 C1107 C1108 C1109 C1110 C1111 C1112 C1113 C1114 C1115 C1116 C1201 C1202 1-165-319-11 CERAMIC CHIP 1-165-319-11 CERAMIC CHIP 1-165-319-11 CERAMIC CHIP 1-163-021-91 CERAMIC CHIP 1-165-319-11 CERAMIC CHIP 1-104-664-11 1-165-319-11 1-163-021-91 1-104-664-11 1-165-319-11 1-165-319-11 1-165-319-11 1-163-021-91 1-163-233-11 1-163-233-11 1-165-319-11 1-104-664-11 1-163-251-11 1-126-965-11 1-106-347-00 ELECT CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP ELECT MYLAR 0.1uF 0.1uF 0.1uF 0.01uF 0.1uF 47uF 0.1uF 0.01uF 47uF 0.1uF 0.1uF 0.1uF 0.01uF 18PF 18PF 0.1uF 47uF 100PF 22uF 0.0015uF 50V 50V (DE545,SE501) 50V 10.00% 50V 50V 20.00% 16V 50V 10.00% 50V 20.00% 16V 50V 50V 50V 10.00% 50V 5.00% 50V 5.00% 50V 50V 16V 50V 50V 50V 3X8 TYPE2 IT-3
50V 50V 20.00% 16V 5% 50V 50V 50V 50V 50V 50V 50V 50V 50V 20.00% 50V 20.00% 6.3V 20.00% 6.3V 20.00% 20.00% 20.00% 20.00% 50V 10V 10V 6.3V 50V 50V 50V 50V 50V 50V
20.00% 5.00% 20.00% 5.00%
5.00% 0.25PF 20.00% 10.00% 5.00%
34
DIGITAL
Ref. No. C1330 Part No. Description 100PF Remark 5.00% 50V Ref. No. R1002 R1003 R1101 R1102 R1103 R1104 R1110 R1111 R1112 R1113 R1114 R1115 R1116 R1117 R1118 R1119 R1120 R1201 R1202 R1203 R1204 R1205 R1206 R1221 R1222 R1223 R1251 R1252 R1253 R1254 R1255 R1256 R1257 R1258 R1301 R1302 R1303 R1304 R1305 R1306 R1307 R1308 R1309 R1310 R1311 R1312 R1313 R1314 R1315 R1316 R1317 Part No. Description 100 75 8.2K 5.1K 5.1K 75 1K 1K 1K 10K 10K 560 1M 100 100 100 100 10K 2.7K 330 10K 10K 330 100 10K 100K 10K 2.7K 330 10K 10K 330 4.7K 4.7K 10K 100 100 100 10K 22K 560K 560K 100 1K 10K 100 100 100 100 100 100 Remark 5% 1/10W (DE545,SE501) 5% 1/10W 5% 1/10W 5% 1/10W 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1-163-251-11 CERAMIC CHIP < CONNECTOR > * CNP501 1-691-774-11 PLUG (MICRO CONNECTOR) 12P * CNP502 1-564-506-11 PLUG, CONNECTOR 3P < CONNECTOR > CNS103 1-794-006-11 CONNECTOR 20P < DIODE > D1101 D1201 D1202 D1301 8-719-016-74 8-719-016-74 8-719-016-74 8-719-016-74 DIODE DIODE DIODE DIODE 1SS352-TPH3 1SS352-TPH3 1SS352-TPH3 1SS352-TPH3 1-216-073-00 1-216-073-00 1-216-043-91 1-216-121-91 1-216-025-91 1-216-025-91 1-216-025-91 1-216-025-91 1-216-073-00 1-216-059-00 1-216-037-00 1-216-073-00 1-216-073-00 1-216-037-00 1-216-025-91 1-216-073-00 1-216-097-91 1-216-073-00 1-216-059-00 1-216-037-00 1-216-073-00 1-216-073-00 1-216-037-00 1-216-065-91 1-216-065-91 1-216-073-00 1-216-025-91 1-216-025-91 1-216-025-91 1-216-073-00 1-216-081-00 1-216-115-00 1-216-115-00 1-216-025-91 1-216-049-91 1-216-073-00 1-216-025-91 1-216-025-91 1-216-025-91 1-216-025-91 METAL CHIP METAL CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP METAL CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP METAL CHIP RES-CHIP RES-CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP METAL CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP 1-216-025-91 RES-CHIP 1-216-022-00 METAL CHIP 1-216-071-00 METAL CHIP 1-216-066-00 METAL CHIP 1-216-066-00 1-216-022-00 1-216-049-91 1-216-049-91 1-216-049-91 METAL CHIP METAL CHIP RES-CHIP RES-CHIP RES-CHIP
< FERRITE BEAD > FB1101 FB1102 FB1103 FB1104 FB1105 FB1106 FB1107 FB1108 FB1201 FB1301 FB1302 FB1303 FB1304 FB1305 1-414-813-11 1-469-152-11 1-469-152-11 1-469-152-11 1-469-152-11 1-469-152-11 1-469-152-11 1-469-152-11 1-414-813-11 1-414-813-11 1-414-813-11 1-414-813-11 1-414-813-11 1-414-813-11 FERRITE FERRITE FERRITE FERRITE FERRITE FERRITE FERRITE FERRITE FERRITE FERRITE FERRITE FERRITE FERRITE FERRITE < IC > IC1001 IC1002 IC1003 IC1004 IC1005 IC1006 IC1007 IC1008 IC1009 IC1010 IC1011 IC1013 IC1201 IC1251 8-749-017-36 IC TORX-179(DVD/LD OPTICAL IN) 8-749-923-05 IC TORX178A(TV/SAT OPTICAL IN) (DE545,SE501) 8-759-242-70 IC TC7WU04F(TE12R) 8-759-639-35 IC LC89055W-RA8 8-759-242-70 IC TC7WU04F(TE12R) 8-759-643-42 8-759-342-94 8-759-657-47 8-759-039-69 8-759-647-10 8-759-039-69 8-759-039-69 8-759-099-06 8-759-099-06 IC IC IC IC IC IC IC IC IC CXD9511AQ IDT71256SA20Y-TL AK4527 uPC7805AHF uPC2933HF uPC7805AHF uPC7805AHF M5218AFP-TE1 M5218AFP-TE1 0UH 0UH 0UH 0UH 0UH 0UH 0UH 0UH 0UH 0UH 0UH 0UH 0UH 0UH
< JACK > J1001 1-784-431-11 JACK, PIN 1P(DVD/LD COAXIAL IN) < JUMPER RESISTOR > JW1101 1-216-295-91 SHORT 0 (DE445) < RESISTOR > R1001 1-216-025-91 RES-CHIP 100 5% 1/10W
1-216-025-91 RES-CHIP 1-216-025-91 RES-CHIP < VIBRATOR >
X1101 1-781-465-21 VIBRATOR, CRYSTAL (12.288MHz) **************************************************************
35
DISPLAY
Ref. No. Part No. Description Remark Ref. No. C132 C134 C198 C199 Part No. 1-164-159-11 1-164-159-11 1-164-159-11 1-164-159-11 Description CERAMIC CERAMIC CERAMIC CERAMIC < CONNECTOR > A-4428-458-A DISPLAY BOARD, COMPLETE (SE501) ************************ A-4428-464-A DISPLAY BOARD, COMPLETE (DE445:CND) ************************ A-4428-466-A DISPLAY BOARD, COMPLETE ************************ (DE445:AEP,UK,CIS) A-4428-468-A DISPLAY BOARD, COMPLETE (DE545:CND) ************************ A-4428-471-A DISPLAY BOARD, COMPLETE ************************ (DE545:AEP,UK,CIS) A-4428-479-A DISPLAY BOARD, COMPLETE (DE545:TW,E,PX) ************************ A-4428-482-A DISPLAY BOARD, COMPLETE (DE545:CH,SP,MY) ************************ A-4428-492-A DISPLAY BOARD, COMPLETE (DE545:AUS) ************************ * * 3-386-245-12 HOLDER (FL) 4-921-941-01 CUSHION (FL) < CAPACITOR > C011 C100 C101 C102 C103 C109 C110 C111 C112 C113 C114 C115 C116 C117 C119 C120 C121 C122 C123 C124 C125 C126 C127 C128 C129 C130 C131 1-164-159-11 1-164-159-11 1-164-159-11 1-104-905-11 1-164-159-11 1-164-159-11 1-164-159-11 1-124-589-11 1-124-465-00 1-136-169-00 1-164-159-11 1-164-159-11 1-164-159-11 1-124-261-00 1-124-261-00 1-164-159-11 1-128-809-11 1-128-809-11 1-164-159-11 1-128-809-11 1-162-306-11 1-162-306-11 1-162-306-11 1-162-306-11 1-124-261-00 CERAMIC CERAMIC CERAMIC CAPACITOR CERAMIC CERAMIC CERAMIC ELECT ELECT MYLAR CERAMIC CERAMIC CERAMIC ELECT ELECT CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC ELECT 0.1uF 0.1uF 0.1uF 0.22F 0.1uF 0.1uF 0.1uF 47uF 0.47uF 0.22uF 0.1uF 0.1uF 0.1uF 10uF 10uF 0.1uF 100PF 100PF 0.1uF 100PF 0.01uF 0.01uF 0.01uF 0.01uF 10uF 0.1uF 10uF 50V 50V 50V 5.5V 50V 50V 50V 20% 16V 20% 50V 5.00% 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 16V 16V 16V 16V 50V 50V 50V D012 D013 D014 D100 D101 D102 D103 D104 D109 D110 8-719-313-50 8-719-313-50 8-719-046-37 8-719-911-19 8-719-911-19 8-719-911-19 8-719-911-19 8-719-911-19 8-719-911-19 8-719-911-19 DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE CNP100 * CNP102 CNP103 CNP104 CNP104 1-794-028-11 1-564-705-11 1-794-001-11 1-794-002-11 1-794-003-11 BOARD TO BOARD PIN 4P PIN, CONNECTOR (SMALL TYPE) 3P CONNECTOR 20P CONNECTOR 13P(EXCEPT AEP,UK,CIS) CONNECTOR 15P(AEP,UK,CIS) 0.1uF 0.1uF 0.1uF 0.1uF Remark 50V 50V 50V 50V A-4428-428-A DISPLAY BOARD, COMPLETE (DE445:US) ************************ A-4428-438-A DISPLAY BOARD, COMPLETE (DE545:US) ************************
* CNP106 1-564-594-11 PLUG, CONNECTOR 15P * CNP107 1-564-521-11 PLUG, CONNECTOR 6P CNP110 1-794-028-11 BOARD TO BOARD PIN 4P < CONNECTOR > * CNS101 1-568-449-11 HOUSING, CONNECTOR(PC BOARD)3P * CNS105 1-695-808-11 CONNECTOR, PC BOARD 8P < DIODE > D002 D003 D004 D005 D006 D007 D008 D009 D010 D011 8-719-046-39 8-719-046-39 8-719-046-39 8-719-046-39 8-719-046-39 8-719-046-39 8-719-046-39 8-719-046-39 8-719-046-39 8-719-072-82 DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE SEL5821A-TP15(MODE) SEL5821A-TP15(2 CH) SEL5821A-TP15(A.F.D) SEL5821A-TP15(BASS/TREBLE) SEL5821A-TP15(JOG) SEL5821A-TP15(LEVEL) SEL5821A-TP15(SUR) SEL5821A-TP15(SET UP) SEL5821A-TP15(NAME) SELU5E20C-STP15(MULTICHANNEL DECODING) SEL6810A-TH12(BASS BOOST) SEL6810A-TH12(TONE) SEL5820A-TH8F(DIGITAL) 1SS133T-72 1SS133T-72 1SS133T-72 1SS133T-72 1SS133T-72(DE545,SE501) 1SS133T-72 1SS133T-72
< FERRITE BEAD > FB100 1-412-473-31 FERRITE 0UH < FILTER > FL101 1-517-929-11 TUBE, FLUORESCENT INDICATOR < TERMINAL > * G791 1-537-738-21 TERMINAL, EARTH < IC > IC101 IC102 IC103 8-759-332-18 IC GP1U27XB(REMOTE SENSOR) 8-759-656-88 IC MB90553ABPF-G-158-BND 8-759-463-11 IC MSC1162AGS-BK
20% 20%
5% 5% 5% 30.00% 30.00% 30.00% 30.00% 20%
1-164-159-11 CERAMIC 1-124-261-00 ELECT
20%
36
DISPLAY
Ref. No. Part No. Description < COIL > L101 1-408-117-00 INDUCTOR 10uH < TRANSISTOR > Q001 Q002 Q003 Q004 Q005 Q006 Q007 Q008 Q009 Q010 Q011 Q100 Q101 Q102 Q103 Q104 8-729-900-63 8-729-900-63 8-729-900-36 8-729-311-51 8-729-311-51 8-729-311-51 8-729-900-63 8-729-900-63 8-729-900-63 8-729-900-63 8-729-900-63 8-729-900-63 8-729-900-36 8-729-119-78 8-729-119-78 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR BN1F4M-TP BN1F4M-TP BA1F4M-TP 2SC1115 2SC1115 2SC1115 BN1F4M-TP BN1F4M-TP BN1F4M-TP BN1F4M-TP BN1F4M-TP BN1F4M-TP BA1F4M-TP 2SC2785TP-HFE (DE545,SE501) 2SC2785TP-HFE Remark Ref. No. R098 R098 R098 R098 R098 Part No. Description 680 Remark 5% 1/4W F (DE445:US,CND) 3.3K 5% 1/4W (DE545:CH,SP,MY) 6.8K 5% 1/4W F (DE545:TW,AEP,UK,CIS,E,PX) 22K 5% 1/4W (DE545:AUS) 2.2K 5% 1/4W F (DE445:AEP,UK,CIS) 5% 1/4W (DE445:US,CND) 6.8K 5% 1/4W F (DE545:CH,SP,MY) 3.3K 5% 1/4W (DE545:TW,E,PX) 33K 5% 1/4W (DE545:AEP,UK,CIS) 22K 5% 1/4W (DE445:AEP,UK,CIS/DE545:AUS) 100 100 100 100 10K 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W (SE501) 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W F F F F F F F F F F 15K 1-249-415-11 CARBON 1-247-843-11 CARBON 1-249-427-11 CARBON 1-249-433-11 CARBON 1-249-421-11 CARBON
R099 R099 R099 R099 R099
1-249-431-11 CARBON 1-249-427-11 CARBON 1-247-843-11 CARBON 1-249-435-11 CARBON 1-249-433-11 CARBON
8-729-900-36 TRANSISTOR BA1F4M-TP < RESISTOR >
R100 R101 R102 R103 R104
1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 1-249-429-11
CARBON CARBON CARBON CARBON CARBON
R011 R012 R013 R014 R015 R016 R021 R022 R023 R024 R025 R026 R027 R028 R030 R031 R032 R033 R034 R035 R036 R037 R052 R053 R054 R055 R056 R057 R058 R061 R062 R063 R064 R065
1-249-411-11 1-249-413-11 1-249-415-11 1-249-417-11 1-249-419-11 1-249-421-11 1-249-411-11 1-249-413-11 1-249-415-11 1-249-417-11 1-249-419-11 1-249-421-11 1-247-843-11 1-249-425-11 1-249-411-11 1-249-413-11 1-249-415-11 1-249-417-11 1-249-419-11 1-249-421-11 1-247-843-11 1-249-425-11 1-249-407-11 1-249-407-11 1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 1-249-407-11 1-249-407-11 1-249-407-11 1-249-407-11 1-249-441-11
CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON
330 470 680 1K 1.5K 2.2K 330 470 680 1K 1.5K 2.2K 3.3K 4.7K 330 470 680 1K 1.5K 2.2K 3.3K 4.7K 150 150 100 100 100 100 100 150 150 150 150 100K
5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W
F F F F F F F F
R105 R106 R107 R108 R109 R110 R111 R112 R113 R114 R115 R116 R117 R118 R119 R120 R121 R122 R123 R124 R125 R126 R127 R128 R129 R130 R131 R132 R133 R134 R135 R136 R137
1-249-417-11 1-249-421-11 1-249-421-11 1-249-421-11 1-249-421-11 1-249-421-11 1-249-421-11 1-249-427-11 1-249-427-11 1-249-427-11
CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON
1K 2.2K 2.2K 2.2K 2.2K 2.2K 2.2K 6.8K 6.8K 6.8K 6.8K 1K 47K 10K 4.7K 10K 680K 22K 22K 22K 100 100 10K 100 100 100 100 100 100 100 100 100 100
5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5%
1/4W F 1/4W F 1/4W 1/4W F 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W F F F F F
1-249-427-11 CARBON 1-249-417-11 CARBON 1-249-437-11 CARBON 1-249-429-11 CARBON 1-249-425-11 CARBON 1-249-429-11 1-247-899-11 1-249-433-11 1-249-433-11 1-249-433-11 1-247-807-31 1-247-807-31 1-249-429-11 1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON
1/4W F 1/4W F (AEP,UK,CIS) 5% 1/4W 5% 1/4W 5% 1/4W F 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W
1/4W 1/4W F 1/4W F 1/4W F 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W F 1/4W F 1/4W F 1/4W F 1/4W
1-247-807-31 CARBON 1-247-807-31 CARBON 1-247-807-31 CARBON
37
DISPLAY
Ref. No. R138 R139 R140 R141 R142 R143 R144 R145 R146 R147 R148 R149 R150 R151 R152 R153 R154 R161 R162 R163 R164 R165 R175 R176 R177 R178 R179 R187 R188 R189 R198 R199 Part No.
HEADPHONE
Description CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON 100 100 100 100 100 100 10K 100 100 100 100 100 100 100 100 100 10K 100K 100K 100K 100K 47K 10 10K 4.7K 10K 10K 10K 10K 10K 2.2 2.2
JOG
5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5%
MAIN
Remark 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W Ref. No. S131 S132 S133 S134 S135 S136 S137 Part No. 1-771-410-21 1-771-410-21 1-771-410-21 1-771-410-21 1-771-410-21 Description SWITCH, TACTILE(A.F.D) SWITCH, TACTILE(INPUT MODE) SWITCH, TACTILE(5.1CH INPUT) SWITCH, TACTILE(LEVEL) SWITCH, TACTILE(TV/SAT) Remark
1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 1-249-429-11 1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 1-249-429-11 1-249-441-11 1-249-441-11 1-249-441-11
1-771-410-21 SWITCH, TACTILE(MD/TAPE) 1-771-410-21 SWITCH, TACTILE(VIDEO) < VIBRATOR >
X101 1-781-356-21 VIBRATOR, CERAMIC (16MHz) ************************************************************** 1-676-786-11 HEADPHONE BOARD ***************** < CONNECTOR > CNP792 1-691-765-11 PLUG (MICRO CONNECTOR) 3P < JACK > 1-750-733-11 JACK (LARGE TYPE)(PHONES) (EXCEPT CH,TW,SP,MY) J791 1-750-735-11 JACK (LARGE TYPE)(PHONES)(CH,TW,SP,MY) ************************************************************** 1-676-787-11 JOG BOARD ********** < VARIABLE RESISTOR > J791
1-249-441-11 CARBON 1-249-437-11 CARBON 1-249-393-11 CARBON 1-249-429-11 CARBON 1-249-425-11 CARBON 1-249-429-11 CARBON 1-249-429-11 1-249-429-11 1-249-429-11 1-249-429-11 CARBON CARBON CARBON CARBON
5% 1/4W 5% 1/4W 5% 1/4W F (DE545,SE501) 5% 1/4W (DE545,SE501) 5% 1/4W F 5% 5% 5% 5% 5% 5% 5% 1/4W (DE445) 1/4W 1/4W 1/4W 1/4W 1/6W F 1/6W F
RV101 1-418-817-11 ENCODER (ROTARY)(JOG) ************************************************************** A-4428-423-A MAIN BOARD, COMPLETE (DE445:US) ********************** A-4428-429-A MAIN BOARD, COMPLETE (DE545:US,SE501) ********************* A-4428-463-A MAIN BOARD, COMPLETE (DE445:CND) ********************* A-4428-465-A MAIN BOARD, COMPLETE (DE445:AEP,UK,CIS) ********************* A-4428-467-A MAIN BOARD, COMPLETE (DE545:CND,E,PX) ********************* A-4428-469-A MAIN BOARD, COMPLETE (DE545:AEP,UK,CIS) ********************* A-4428-490-A MAIN BOARD, COMPLETE ********************* (DE545:CH,TW,SP,MY,AUS) 7-685-646-79 SCREW +BVTP < CAPACITOR > C303 C304 C305 1-128-815-11 CERAMIC 1-126-961-11 ELECT 1-164-159-11 CERAMIC 330PF 2.2uF 0.1uF 5% 50V (AEP,UK,CIS) 20.00% 50V (AEP,UK,CIS) 50V (AEP,UK,CIS) 3X8 TYPE2 IT-3
1-249-385-11 CARBON 1-249-385-11 CARBON
< VARIABLE RESISTOR > RV102 1-418-773-11 ENCODER, ROTARY(MASTER VOLUME) < SWITCH > S110 S111 S112 S113 S114 S115 S116 S120 S121 S122 S123 S124 S125 S126 S127 S128 S129 S130 1-771-410-21 1-771-410-21 1-771-410-21 1-771-410-21 1-771-410-21 1-771-410-21 1-771-410-21 1-771-410-21 1-771-410-21 1-771-410-21 1-771-410-21 1-771-410-21 1-771-410-21 1-771-410-21 1-771-410-21 SWITCH, TACTILE(<) SWITCH, TACTILE(CHINEMA STUDIO C) SWITCH, TACTILE(SUR) SWITCH, TACTILE(ENTER) SWITCH, TACTILE(BASS/TREBLE) SWITCH, TACTILE(NAME) SWITCH, TACTILE(SET UP) SWITCH, TACTILE(>) SWITCH, TACTILE(CHINEMA STUDIO B) SWITCH, TACTILE(CHINEMA STUDIO A) SWITCH, TACTILE(AUX) SWITCH, TACTILE(DVD/LD) SWITCH, TACTILE(2 CH) SWITCH, TACTILE(MODE) SWITCH, TACTILE(TUNER)
1-771-410-21 SWITCH, TACTILE(CD) 1-771-410-21 SWITCH, TACTILE(DISPLAY) 1-771-410-21 SWITCH, TACTILE(DIMMER)
38
MAIN
Ref. No. C306 C307 C308 C309 C310 Part No. Description 560PF 82PF 47PF 10uF 0.1uF 5% Remark 50V (AEP,UK,CIS) 5.00% 50V (AEP,UK,CIS) 5.00% 50V (AEP,UK,CIS) 20% 50V (AEP,UK,CIS) 50V (AEP,UK,CIS) 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V Ref. No. C462 C463 C464 C465 C466 C467 C468 C469 C470 C471 C472 C473 C474 C475 C476 C477 C484 C491 C492 C493 C494 C495 C496 C497 C498 C499 C501 C502 C503 C504 C505 C506 C510 C511 C520 C524 C526 C601 C603 C604 C605 C606 C607 C610 C611 C620 C624 C626 C651 C653 C654 C655 C656 C657 C660 C661 C670 C701 Part No. 1-130-481-00 1-136-495-11 1-130-481-00 1-124-261-00 1-136-165-00 1-136-165-00 1-124-261-00 1-124-261-00 1-124-261-00 1-126-963-11 1-126-963-11 1-126-963-11 1-126-963-11 1-126-963-11 1-126-963-11 1-126-963-11 1-126-965-11 1-128-803-11 1-128-803-11 1-128-803-11 1-128-803-11 1-128-803-11 1-128-803-11 1-128-803-11 1-128-803-11 1-124-261-00 1-126-963-11 1-128-809-11 1-102-989-00 1-102-989-00 1-104-665-11 1-107-583-11 1-104-664-11 1-136-157-00 1-128-813-11 1-126-960-11 1-127-876-11 1-126-963-11 1-104-665-11 1-107-583-11 1-102-233-00 1-128-809-11 1-128-809-11 1-104-664-11 1-136-157-00 1-128-813-11 1-126-960-11 1-127-876-11 1-126-963-11 1-104-665-11 1-107-583-11 1-102-233-00 1-128-809-11 1-128-809-11 1-104-664-11 Description MYLAR MYLAR MYLAR ELECT MYLAR MYLAR ELECT ELECT ELECT ELECT ELECT ELECT ELECT ELECT ELECT ELECT ELECT CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC ELECT ELECT CERAMIC CERAMIC CERAMIC ELECT CERAMIC ELECT MYLAR CERAMIC ELECT CERAMIC ELECT ELECT CERAMIC CERAMIC CERAMIC CERAMIC ELECT MYLAR CERAMIC ELECT CERAMIC ELECT ELECT CERAMIC CERAMIC CERAMIC CERAMIC ELECT 0.0068uF 0.068uF 0.0068uF 10uF 0.1uF 0.1uF 10uF 10uF 10uF 4.7uF 4.7uF 4.7uF 4.7u