Text preview for : STR-DE585 sony audio.pdf part of Sony STR-DE585 Service Manual
Back to : STR-DE585 sony audio.part | Home
STR-DE585
SERVICE MANUAL
Ver 1.0 2002. 04
Canadian Model AEP Model UK Model
Manufactured under license from Dolby Laboratories. "Dolby", "Pro Logic" and the double-D symbol are trademarks of Dolby Laboratories. "DTS" and "DTS Digital Surround" are registered trademarks of Digital Theater Systems, Inc.
SPECIFICATIONS
AUDIO POWER SPECIFICATIONS Amplifier section
POWER OUTPUT Models of area code Canadian Rated Power Output at Stereo Mode (8 ohms 40 Hz 20 kHz, THD 0.09 %) 100 W + 100 W Reference Power Output (8 ohms 1 kHz, THD 0.7 %) FRONT 1) : 100 W/ch CENTER 1) : 100 W SURR 1) : 100 W/ch Models of area code AEP, UK Rated Power Output at Stereo Mode (8 ohms 1 kHz, THD 0.7 %) 100 W + 100 W 2) Reference Power Output (8 ohms 1 kHz, THD 0.7 %) FRONT 1) : 100 W/ch CENTER 1) : 100 W SURR 1) : 100 W/ch 1) Depending on the sound field settings and the source, there may be no sound output. 2) Measured under the following conditions: Area code Power requirements AEP, UK 230 V AC, 50 Hz Frequency response MULTI CH IN, CD, MD/TAPE, DVD/LD, VIDEO 1, 2 Inputs (Analog) MULTI CH IN, CD, MD/TAPE, DVD/LD, VIDEO 1, 2 10 Hz 50 kHz +0.5/2 dB (with sound field, and tone bypassed)
Sensitivity: 250 mV Impedance: 50 kilohms S/N 3) : 96 dB (A, 250 mV 4) )
3) INPUT SHORT (with sound field and tone bypassed). 4) Weighted network, input level. Inputs (Digital) DVD/LD (Coaxial)
VIDEO 2 (Optical)
Sensitivity: Impedance: 75 ohms S/N: 100 dB (A, 20 kHz LPF) Sensitivity: Impedance: S/N: 100 dB (A, 20 kHz LPF)
Outputs MD/TAPE (REC OUT), VIDEO1 (AUDIO OUT) SUB WOOFER
Voltage: 250 mV Impedance: 10 kilohms Voltage: 2 V Impedance: 1 kilohms
Tone Gain levels:
±6 dB, 1 dB step
Continued on next page
FM STEREO/FM-AM RECEIVER
9-873-966-01
2002D0400-1 © 2002. 04
Sony Corporation
Home Audio Company Published by Sony Engineering Corporation
1
STR-DE585
FM tuner section
Tuning range Antenna terminals Intermediate Frequency Sensitivity Mono: Stereo: Usable sensitivity S/N Mono: Stereo: Harmonic distortion at 1 kHz Mono: Stereo: Separation Frequency response Selectivity 87.5 - 108.0 MHz 75 ohms, unbalanced 10.7 MHz 18.3 dBf, 2.2 µV/75 ohms 38.3 dBf, 22.5 µV/75 ohms 11.2 dBf, 1 µV/75 ohms 76 dB 70 dB 0.3% 0.5% 45 dB at 1 kHz 30 Hz 15 kHz, +0.5/2 dB 60 dB at 400 kHz
Video section
Inputs Video: Outputs Video: 1 Vp-p, 75 ohms 1 Vp-p, 75 ohms
General
Power requirements Area code Canadian AEP, UK Power consumption Area code Canadian AEP, UK Power requirements 120 V AC, 60 Hz 230 V AC, 50/60 Hz
Power consumption 300 VA 180 W
AM tuner section
Tuning range Models of area code Canadian With 10-kHz tuning scale: 530 1710 kHz 5) With 9-kHz tuning scale: 531 1710 kHz 5) Models of area code AEP, UK With 9-kHz tuning scale: 531 1602 kHz Antenna Intermediate Frequency Usable sensitivity S/N Harmonic distortion Selectivity At 9 kHz: At 10 kHz: Loop antenna 450 kHz 50 dB/m (at 1,000 kHz or 999 kHz) 54 dB (at 50 mV/m) 0.5 % (50 mV/m, 400 Hz) 35 dB 40 dB
Power consumption (during standby mode) 0.5 W Dimensions 430 × 145 × 298 mm (16 7/8 × 5 6/8 × 11 6/8 in.) including projecting parts and controls Mass (Approx.) 7.0 kg (15 lb 7 oz) Supplied accessories FM wire antenna (1) AM loop antenna (1) · Models of area code Canadian Remote commander RM-PP506 (1) R6 (size-AA) batteries (2) · Models of area code AEP, UK Remote commander RM-U306 (1) R6 (size-AA) batteries (2) Design and specifications are subject to change without notice.
5) You can change the AM tuning scale to 9 kHz or 10 kHz. After tuning in any AM station, turn off the receiver. Hold down PRESET TUNING + and press ?/1 . All preset stations will be erased when you change the tuning scale. To reset the scale to 10 kHz (or 9 kHz), repeat the procedure.
2
STR-DE585
SAFETY CHECK-OUT After correcting the original service problem, perform the following safety check before releasing the set to the customer: Check the antenna terminals, metal trim, "metallized" knobs, screws, and all other exposed metal parts for AC leakage. Check leakage as described below. LEAKAGE TEST The AC leakage from any exposed metal part to earth ground and from all exposed metal parts to any exposed metal part having a return to chassis, must not exceed 0.5 mA (500 microampers.). Leakage current can be measured by any one of three methods. 1. A commercial leakage tester, such as the Simpson 229 or RCA WT-540A. Follow the manufacturers' instructions to use these instruments. 2. A battery-operated AC milliammeter. The Data Precision 245 digital multimeter is suitable for this job. 3. Measuring the voltage drop across a resistor by means of a VOM or battery-operated AC voltmeter. The "limit" indication is 0.75 V, so analog meters must have an accurate lowvoltage scale. The Simpson 250 and Sanwa SH-63Trd are examples of a passive VOM that is suitable. Nearly all battery operated digital multimeters that have a 2 V AC range are suitable. (See Fig. A)
To Exposed Metal Parts on Set
MODEL IDENTIFICATION
-- BACK PANEL --
Part No.
Area code Canadian AEP UK
Part No. 4-238-189-1s 4-240-192-0s 4-240-192-1s
0.15 µF
1.5 k
AC voltmeter (0.75 V)
Earth Ground
SAFETY-RELATED COMPONENT WARNING!! COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.
ATTENTION AU COMPOSANT AYANT RAPPORT À LA SÉCURITÉ!! LES COMPOSANTS IDENTIFIÉS PAR UNE MARQUE 0 SUR LES DIAGRAMMES SCHÉMATIQUES ET LA LISTE DES PIÈCES SONT CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT. NE REMPLACER CES COMPOSANTS QUE PAR DES PIÈCES SONY DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL OU DANS LES SUPPLÉMENTS PUBLIÉS PAR SONY.
3
STR-DE585
TABLE OF CONTENTS 1. GENERAL
Main unit ................................................................................. 5 Remote button description ....................................................... 6
2. DISASSEMBLY
2-1. 2-2. 2-3. 2-4. 2-5. 2-6. Case ..................................................................................... 8 Front Panel Section ............................................................. 9 Back Panel ........................................................................... 9 Digital Board ..................................................................... 10 Standby Board ................................................................... 10 Main Board ....................................................................... 11
3. TEST MODE ...................................................................... 12 4. DIAGRAMS
4-1. IC Pin Descriptions ........................................................... 13 4-2. Block Diagram Tuner/Audio Section .......................... 16 4-3. Block Diagram Digital Section ................................... 17 4-4. Block Diagram Video/Display Section ....................... 18 4-5. Block Diagram Power Section .................................... 19 4-6. Circuit Boards Location .................................................... 20 4-7. Printed Wiring Boards Main Section .......................... 21 4-8. Schematic Diagram Main Section (1/2) ...................... 22 4-9. Schematic Diagram Main Section (2/2) ...................... 23 4-10. Printed Wiring Board Digital Section (1/2) ................ 24 4-11. Printed Wiring Board Digital Section (2/2) ................ 25 4-12. Schematic Diagram Digital Section (1/2) ................... 26 4-13. Schematic Diagram Digital Section (2/2) ................... 27 4-14. Printed Wiring Board Video Section ........................... 28 4-15. Schematic Diagram Video Section .............................. 29 4-16. Printed Wiring Boards Display Section ...................... 30 4-17. Schematic Diagram Display Section ........................... 31 4-18. Printed Wiring Board Power Section .......................... 32 4-19. Schematic Diagram Power Section ............................. 33 4-20. IC Block Diagrams ............................................................ 34
5. EXPLODED VIEWS
5-1. 5-2. 5-3. 5-4. Case Section ...................................................................... 35 Front Panel Section ........................................................... 36 Chassis Section-1 .............................................................. 37 Chassis Section-2 .............................................................. 38
6. ELECTRICAL PARTS LIST ......................................... 39
4
STR-DE585 SECTION 1 GENERAL
This section is extracted from instruction manual.
List of Button Locations and Reference Pages
How to use this page
Illustration number
List of Button Locations and Reference Pages
r
Use this page to find the location of buttons that are mentioned in the text.
NAME
R
8 (35)
R
Name of button/part
Reference page
Main unit
ALPHABETICAL ORDER
0 --9
2 CH wh (25)
A --D
A.DEC wk (2325) AM (Except for models of area code CEL, CEK) es (30, 31) BASS +/ wg (29, 54) CD ql (21) CINEMA STUDIO EX A, B, C 9 (23, 24) Digital Cinema Sound (indicator) qs (23) DIMMER ej (22) DISPLAY 2 (22, 33, 51) Display qa (22) DVD/LD wa (21)
FM MODE (Models of area code CEL, CEK only) ed, (Except for models of area code CEL, CEK) ef (31) INPUT MODE qg (21) IR (receptor) 4 (38, 45, 51) LEVEL 0 (20, 27, 55)
M
MASTER VOLUME wd (20, 49) MD/TAPE qj (21) MEMORY eh (30, 32) MENU +/ e; (16, 27, 35, 36) MENU ea (16, 27, 35, 36) MODE wj (24, 50) MULTI CHANNEL DECODING (indicator) (Except for STR-DE485E) 7 (21) MULTI CH IN (Except for STR-DE485E) qf (21) MUTING wf (21, 49)
PRESET/PTY SELECT +/ (Models of area code CEL, CEK only) 3 (32, 33) PRESET TUNING +/ (Except for models of area code CEL, CEK) 3 (32, 53) PTY (Models of area code CEL, CEK only) ef (33) SET UP 6 (4, 16, 36, 54) SHIFT eg (32) SLEEP (STR-DE485E only)qf (36) SURR qd (27, 54)
T --Z
TREBLE +/ qh (29, 54) TUNER ws (21, 30-32, 35) TUNING +/ 5 (31) VIDEO 1 qk (21) VIDEO 2 w; (21)
BUTTON DESCRIPTIONS
E --L
ENTER wl (35) FM (Except for models of area code CEL, CEK) ed (30, 31) FM/AM (Models of area code CEL, CEK only) es (30, 31)
N --S
NAME 8 (35) PHONES (jack) ek (21)
`/1 (power) 1 (4, 15, 20, 29, 30, 53)
1
23
4
5
6 7 8 90 qa qs qdqf qg qh qjqkqlw; waws
ek
ej
eh eg ef ed es ea e; wl wk wj wh
wg
wf
wd
5GB
5
STR-DE585
Operations Using the Remote RM-PP506
Remote Button Operations Function
You can use the remote RM-PP506 to operate the components in your system.
VIDEO 1 VIDEO 2 VIDEO 3 DVD/LD
Receiver Receiver Receiver Receiver Receiver Receiver Receiver Receiver Receiver Receiver Receiver Receiver Receiver
To watch VCR. (VTR mode 3) To watch VCR. (VTR mode 1) To watch VCR. (VTR mode 2) To watch DVD or laser disc. To watch TV programs or satellite receiver. To listen to an audio equipment. To listen to Minidisc or audio tape. To listen to compact disc. To listen to radio programs. To listen to turntable. Selects input mode for your digital components. To assign the audio input for each function. Press repeatedly to select a memory page for presetting radio stations or tuning to preset stations. Tuner station direct keyin-mode. Selects AUTO DECODING mode. Selects sound field mode. Selects 2CH mode. Selects preset sound field (e.g. Cinema Studio EX A, B, C) Press to output test tone.
SLEEP
AV ? / 1
SYSTEM STANDBY
?/1
TV/SAT
TV/SAT
VIDEO 1
VIDEO 2
VIDEO 3
DVD/LD
AUX MD/TAPE CD/SACD TUNER PHONO INPUT MODE AUDIO SPLIT SHIFT
AUX
MD/TAPE CD/SACD
TUNER
PHONO
MONITOR
TV/VIDEO
AV1
AV2
3RD
2ND ROOM
1 4
2 5 8 0
/11 /10
3
(SOURCE)
INPUT MODE
6 9
ENTER
/12
SEARCH MODE
WIDE
7
SHIFT
AUDIO SPLIT ANT TV/VTR
DISC JUMP
CLEAR
/ D.TUNING
>10
SUB CH +
POSITION
SWAP
m
M
.
MUTING
>
P IN P
VOL +
D. SKIP/ CH/PRESET
n
AUTO DEC AV DISPLAY TITLE/ GUIDE
N
X
x
PRESET MULTI/2CH A. DIRECT
SOUND FIELD 2CH MODE TEST TONE NIGHT MODE AV MENU EQ/ TONE ON SCREEN
MUTING
D.TUNING Receiver AUTO DEC Receiver MODE +/ Receiver 2CH PRESET Receiver Receiver
MAIN MENU ENTER/ EXEC EXIT/ RETURN
MASTER VOL
TEST TONE
Receiver
The tables below show the settings of each button.
Remote Button Operations Function
SLEEP
Receiver
Activates the sleep function and the duration which the receiver turns off automatically. Turns the receiver on or off.
?/1
Receiver
38GB
39GB
6
STR-DE585
Operations Using the Remote RM-U306
Except for STR-DE585 area code CA
You can use the remote RM-U306 to operate the components in your system.
Remote button description (continued)
Remote Button Operations Function
Remote button description
SLEEP AV ?/1
SYSTEM STANDBY
VIDEO 1 VIDEO 2
?/1
Receiver Receiver Receiver
To watch VCR. (VTR mode 3) To watch VCR. (VTR mode 1) To watch DVD or laser disc. To listen to Minidisc or audio tape. To listen to compact disc. To listen to radio programs. Press repeatedly to select a memory page for presetting radio stations or tuning to preset stations. Tuner station direct keyin-mode. Select AUTO DECODE mode. Selects sound field mode. Selects 2CH mode. Press to output test tone. Press this button repeatedly to select one of the four cursor modes: SURR, LEVEL, SET UP and NAME. Selects MULTI CH IN source. Selects a menu item. Makes adjustment or change the setting.
DVD/LD
MD/TAPE Receiver
DVD/LD TUNER
DVD MENU
VIDEO 1
VIDEO 2 CD
MD/TAPE
TOP MENU
CD TUNER SHIFT
Receiver Receiver Receiver
F
1
G
2
ENTER
3
g
4 7
SHIFT
5
f
6
O
8 0
9
D.TUNING
>10
-
ENTER
RETURN
CH/PRESET + . >
m M
TV/VIDEO
ANT TV/VTR
D.TUNING Receiver A.DEC MODE Receiver Receiver Receiver Receiver Receiver
D.SKIP
Operations Using the Remote RM-U306
N
A.DEC
TEST TONE
X
SOUND FIELD
x
2CH
MULTI CH
MODE
MAIN MENU
2CH TEST TONE MAIN MENU
MENU
MUTING
MASTER VOL
TV VOL
TV CH
MULTI CH Receiver MENU Receiver MENU +/ Receiver MUTING Receiver
Mutes the sound from the receiver.
The tables below show the settings of each button.
Remote Button Operations Function
SLEEP
Receiver
Activates the sleep function and the duration which the receiver turns off automatically.
?/1
Receiver
Turns the receiver on or off.
continued
45GB
46GB
7
STR-DE585 SECTION 2 DISASSEMBLY
Note : This set can be disassemble according to the following sequence.
SET 2-1. CASE (Page 8)
2-2.
FRONT PANEL SECTION (Page 9)
2-3.
BACK PANEL (Page 9) DIGITAL BOARD (Page 10) STANDBY BOARD (Page 10) MAIN BOARD (Page 11)
2-4.
2-5.
2-6.
Note : Follow the disassembly procedure in the numerical order given.
2-1. CASE
1 two screws (case 3 TP2) 2 two screws (case 3 TP2)
4 case
3 two screws (case 3 TP2)
8
STR-DE585
2-2. FRONT PANEL SECTION
3 two screws (BVTP3 x 8)
2 CNP791
5 front panel section 1 CNS4
4 four screws (BVTP3 x 8)
2-3. BACK PANEL
qd back panel (DE4)(Canadian) back panel (DE5)(AEP, UK) 0 screw (BVTP3 x 8) 9 screw (BVTP3 x 8) 8 two screws (BVTP3 x 8) 3 CNP901 7 two screws (BVTP3 x 8) qa screw (BVTP3 x 8) 5 two screws (BVTP3 x 8) 2 CNS8 6 five screws (BVTP3 x 8)
qs screw (BVTP3 x 8) 1 CNS7
4 CNP154
9
STR-DE585
2-4. DIGITAL BOARD
3 CNP5 2 CNP6
7 DIGITAL board
8 screw (BVTP3 x 8)
6 CNS2
5 CNS1 9 bracket (digital)
1 CNS4
4 screw (BVTP3 x 8)
2-5. STANDBY BOARD
4 three screws (BVTP3 x 8)
2 CNP902
5 STANDBY board
3 CNP903 1 CNP915
10
STR-DE585
2-6. MAIN BOARD
1 CNP801 7 MAIN board 5 screw (BVTP3 x 8) 2 CNP802 4 two screws (BVTP3 x 6) 3 two screws (BVTP3 x 6) 6 two screws (BVTP3 x 8)
11
STR-DE585 SECTION 3 TEST MODE
SOFTWARE VERSION DISPLAY MODE
* The software version is displayed. * Procedure: While depressing the [ENTER] and the SOUND FIELD [A.DEC] buttons simultaneously, press the power ?/1 button to turn on the main power. The model name, destination and the software version are displayed.
FACTORY PRESET MODE
* All preset contents are reset to the default setting. * Procedure: While depressing the [VIDEO 1] and the SOUND FIELD [2CH] buttons simultaneously, press the power ?/1 button to turn on the main power. The message FACTORY appears and switch off the set. While depressing the [VIDEO 1] and the SOUND FIELD [2CH] buttons simultaneously, press the power ?/1 button again. The message FACTORY appears and the preset contents are reset to the default values.
FLUORESCENT INDICATOR TUBE TEST MODE
* All fluorescent segments are tested. When this test is activated, all segments turn on at the same time, then each segment turns on one after another. * Procedure: While depressing the [MD/TAPE] and the [SHIFT] buttons simultaneously, press the power ?/1 button to turn on the main power. 1. All segments turn on.
SW L SLEEP SP.OFF C R DDDIGITALPRO LOGIC DTS MPEGSTEREO MONO RDS OPT COAX MULTI CH IN D.RANGE EQ TA NEWS INFO dB kHz mft. MHz MEMORY MUTING
SOUND FIELD CLEAR MODE
* The preset sound field is cleared when this mode is activated. Use this mode before returning the product to clients upon completion of repair. * Procedure: While depressing the SOUND FIELD [MODE] button, press the power ?/1 button to turn on the main power. The message S. F. CLR appears and initialization is performed.
(((LFE))) SL S SR
[MULTI CHANNEL DECODING], [Digital Cinema Sound], SOUND FIELD [A.DEC], [MODE], [2CH] and [SET UP] LED turn on. 2. Press the [VIDEO 1] button, confirm display
SW L LFE S SLEEP R k m MHz DD COAX PRO LOGIC MPEGSTEREO D.RANGE TA RDS INFO MUTING
AM CHANNEL STEP 9 kHz/10 kHz SELECTION MODE
* Either the 9 kHz step or 10 kHz step can be selected for the AM channel step. * Procedure: Set the [TUNER] to [AM]. Turn off the main power. While depressing the [TUNING+] button or the [PRESET TUNING ] button, press the power ?/1 button to turn on the main power. Either the message 9 k STEP or 10 k STEP appears. Select the desired step. * For Canadian model only
SOUND FIELD [A.DEC], [MODE], SOUND CONTROL [LEVEL], [SET UP] and [Digital Cinema Sound] LED turn on. 3. Press the [VIDEO 1] button, confirm display
SP.OFF C ((( SL ))) SR DIGITAL DTS OPT MULTI CH IN EQ MONO NEWS dB Hz ft. MEMORY
KEY CHECK MODE
* Button check * Procedure: While depressing the [VIDEO 1] and the [SHIFT] buttons simultaneously, press the power ?/1 button to turn on the main power. "REST 39" appears. Every pressing of any button other than the ?/1 , [TREBLE+, ] and the [BASS+, ] counts down the buttons. The buttons which are already counted once are not counted again. When all buttons are pressed "REST 04" appears. When [MASTER VOLUME] is rotated in clockwise direction, "VOL MIN", "VOL 1" to "VOL 73", "VOL MAX" appear.
[MULTI CHANNEL DECODING], SOUND FIELD [2CH], SOUND CONTROL [SURR] and [NAME] LED turn on. 4. Press the [VIDEO 1] button, All segments turn off. 5. Every pressing of the [VIDEO 1] button turns on each segment and LED one after another in the same order. (Not only the [VIDEO 1] button, but also the other buttons such as [VIDEO 2], [DVD/LD], [MD/TAPE], [CD], [TUNER] can be used.)
12
STR-DE585 SECTION 4 DIAGRAMS
4-1. IC PIN DESCRIPTIONS
· IC1201 CXD9617R (DSP) (DIGITAL Board (1/2)) Pin No. Pin Name I/O 1 VSS -- Ground 2 XRST I Reset signal input 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 to 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 EXTIN FS2 VDDI FS1 PLOCK VSS MCLK1 VDDI VSS MCLK2 MS SCKOUT LRCKI1 VDDE BCKI1 SDI1 LRCKO BCKO VSS KFSIO SDO1 to SDO3 SDO4 SPDIF LRCKI2 BCKI2 SDI2 VSS HACN HDIN HCLK HDOUT HCS SDCLK CLKEN RAS VDDI VSS CAS DQM/OE0 CS0 WE0 VDDE WMD1 VSS WIMD0 PAGE2 VSS PAGE1 PAGE0 I I I I O -- I I -- O I O I I I I O O -- I/O O O O I I I -- O I I O I O O O I -- O O O O I I -- I O -- O O Not used (connected to ground) Not used (connected to ground) Power supply Not used (connected to ground) Internal PLL lock signal output (Not used (open)) Ground Clock signal input (13.5 MHz) Power supply Ground Clock signal output (13.5 MHz) Switching of master/slave operation (L : internal clock, H : EXTIN clock is used) Internal system clock signal output Not used (open) Power supply Not used (open) Audio IF data input Sampling clock output for digital audio serial data Bit clock output terminal for digital audio serial data Ground Audio clock signal (364fs/256fs) input/output Digital audio serial data output Audio IF serial output (Not used (open)) Not used (open) Sampling clock input for audio serial data Bit clock input terminal for audio serial data Digital audio data input Ground Acknowledge signal output for system control Serial data input for system control Clock input for system control Serial data output for system control Chip select input for system control Not used (open) Not used (open) Not used (open) Power supply Ground Not used (open) Not used (open) External memory chip select (SRAM) SRAM write enable output Power supply Not used (connected to "H") Ground Not used (connected to "H") Not used (open) Ground External memory page switching signal output (Not used (open)) External memory page switching signal output (Not used (open)) Description
13
STR-DE585
Pin No. 54 55 56 57 58 59 60 61 62, 63 64 to 66 67 68 69 70 71 72 to 75 76 77 to 80 81 82 to 85 86 87 88 89 90 91 92 to 97 98, 99 100 101 102 to 105 106 107, 108 109, 110 111 112 113 114, 115 116 117 to 119 120
Pin Name BOOT BTACT BST MOD1 MOD0 EXLOCK VDDI VSS A17, A16 A15 to A13 GP10 GP9 (DECODE) GP8 (AUDIO) VDDI VSS D15/GP7 to D12/GP4 VDDE D11/GP3 to D8/GP0 VSS A9 to A12 TDO TMS XTRST TCK TDI VSS A8 to A3 D7, D6 VDDI VSS D5 to D2 VDDE D1, D0 A2, A1 VSS A0 PM SDI3, SDI4 SYNC VSS VDDI
I/O I O I I I I I -- O O O O I I -- I/O I I/O -- O O I I I I -- O I/O I -- I/O I I/O O -- O I I I -- I Not used (connected to ground) Not used (open) Boot stop signal input
Description
Operation mode signal input (L : 386fs, H : 256fs) Operation mode signal input (L : single chip mode, H : use prohibited) Lock signal input Power supply Ground Not used (open) External memory address output (SRAM) LRCK0 DECODE AUDIO Power supply Ground External memory data input/output (general port) Power supply External memory data input/output (general port) Ground External memory address output (SRAM) Not used (open) Not used (open) Not used (open) Not used (open) Not used (open) Ground External memory address output (SRAM) External memory data input/output (SRAM) Power supply Ground External memory data input/output (SRAM) Power supply External memory data input/output (SRAM) External memory address output (SRAM) Ground External memory address output (SRAM) PLL initialization input terminal Not used (open) Sync/async selection input (L : sync, H : async) Ground Power supply
14
STR-DE585
· IC1601 MB90478PF-G-120-BND (SYSTEM CONTROL) (DIGITAL Board (2/2)) Pin No. Pin Name I/O Description 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 to 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 DATAO GP9 BST HCS HACN XRST PM PD SMUTE CDT1 VSS SCL CS DATA CLK LATCH-VOL IC SPK B RELAY HDOUT HDIN HCLK F.MUTE AC MUTE VCC5 ANA/DIG HP DETECT DCS LED FLASH2 SP SWITCH/FLASH1 MCH LED MODE 2CH AFD SCL SDA AVCC AVRH AVSS A/D0 to A/D3 VSS RDS SIGNAL MODEL VERSION NC NC STOP MD0 MD1 MD2 RDS CLOCK RDS DATA SIRCS FUSE DETECT I I O O I O O O O O -- O O O O O O I O O O O I I I O O I/O O O O O O I/O I I -- I -- I I I O O I -- -- -- I I I I Serial data input for DIR Decode signal input Boot stop signal output to DSP Chip select signal output to DSP Acknowledge signal input for DSP Reset signal output to DSP PLL initialization output to DSP Power down signal output to CODEC Soft mute signal output to CODEC Control data output to CODEC Ground Serial data clock to CODEC Chip select signal output to CODEC Serial data output to VOL/TUNER Clock signal output to VOL/TUNER Latch signal output to VOL/TUNER Speaker out control signal output (Fixed at "L") Serial data for DSP Serial data to DSP Clock signal output to DSP Function input mute signal output Power amp mute signal output Power supply Muting and error port signal input Headphone detect signal input LED (Digital Cinema Sound) driver signal output Flash programming signal output Speaker ON/OFF signal output LED (MULTI CHANNEL DECODING) driver signal output LED (MODE) driver signal output LED (2CH) driver signal output LED (A.F.D.) driver signal output Clock signal output to EEPROM Serial data to EEPROM Power supply Not used (connected to "H") Ground Key signal input (A/D port) Ground RDS signal input (AEP, UK model) Model detection port Version resistor port Not used (Fixed at "L") Not used (Fixed at "H") Input signal when AC off Selection of micom operation mode Not used (connected to "H") Selection of micom operation mode RDS clock signal output (AEP, UK model) RDS data output (AEP, UK model) Input data from remote control receiver Power down detect input
Pin No. 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 to 90 91 92 93 94 95 96 97 98 99 100
Pin Name POWER KEY JOG (B) JOG (A) VOL (B) VOL (A) DIN CLK FL_STB CONTROL A1 OUT CONTROL A1 IN POWER RELAY PROTECTOR HEADPHONE RELAY WOOFER RELAY REAR RELAY CENTER RELAY PREOUT/FRONT RELAY TUNED STEREO MUTE DO RSTX SLATCH X1A X0A VSS X0 X1 VCC3 NC NC SW4 to SW1 SELECT1 SELECT2 XMODE CKSEL1 CLK CE DI DO ERROR XSTATE
I/O I I I I I O O O O I O I O O O O O O O O I I O -- -- -- I O I I O O O O O O O O O I I I
Description Detect power switch key Jog encoder signal input (Fixed at "L") Jog encoder signal input (Fixed at "L") Volume encoder signal input Volume encoder signal input Serial data output to FL driver Clock signal output to FL driver Strobe signal output to FL driver Control A1 signal output (Fixed at "L") Control A1 signal input (Not used) Control power relay driver output Detect protector status input Control headphone relay driver output Control woofer speaker relay driver output Control rear speaker relay driver output Control center speaker relay driver output Control front speaker relay driver output Tuned signal output to tuner Stereo signal output to tuner Mute signal output to tuner Serial data input for tuner Reset signal input Latch signal to tuner Not used (open) Not used (connected to ground) Ground Clock signal input (16 MHz) Clock signal output (16 MHz) Power supply Not used (Fixed at "L") Not used (Fixed at "L") Video input select signal output Optical input select signal output (Fixed at "L") Optical input select signal output (Fixed at "L") Mode signal output to DIR Clock select signal output to DIR Clock signal output to DIR Chip select signal output to DIR Serial data output to DIR Serial data input for DIR Error signal input for DIR XSTATE signal input for DIR
15
15
STR-DE585
4-2. BLOCK DIAGRAM -- TUNER/AUDIO SECTION --
TM301 FM/AM TUNER UNIT TU+10V +10V L CH FM 75 COAXIAL ANTENNA STEREO AM TUNED MUTE CE ST-DO/MC-DI ST-DI/MC-DO CLK STEREO TUNED MUTE CE DO/DI DATA CLK -3 L DVD/LD AUDIO IN -4 R -1 L MD/TAPE IN -2 R J404 (1/2) AUDIO IN -5 L -6 R -1 L -2 R J401 FRONT SYSTEM CONTROL IC1601 (1/4) FM OUT RDS DATA RDS INT -1 L -2 R MULTI CH IN -3 L -4 R R-CH R-CH 13 ASL IN 11 AL IN R-CH R-CH 63 64 IN 2 IN 3 62 IN 1 R-CH J403 69 R-CH 70 71 IN 6 IN 7 IN 8 CD IN R CH R-CH -1 L -2 R 1 IN 8
DIR FUNCTION SELECT IC201 R-CH LREC 3 67
J402 (2/2) -4 R -3 L OUT MD/TAPE
J402 (1/2) IN 9 2 IN 10 3 R-CH IN 5 ATT 0/-6dB R-CH 0/6/12dB ALOUT AROUT 10 9 LREC 1 61 R-CH
J404 (2/2) -3 L -4 R AUDIO OUT VIDEO 1
68
L-IN R-IN
1
DIGITAL SECTION (Page 17)
FM SIGNAL OUT RDS DATA RDS INT TU+3.3V
FM OUT RDS DATA RDS INT
0/6/12dB LSELOUT 49 50 R-CH SLDELOUT 45 46 R-CH LOUT ROUT SLOUT SROUT 51 55 47 43 MUTE Q361,362 CSELOUT 37 38 COUT 39 MUTE Q363 WOOFER AMP IC401 SWSELOUT 33 34 SWOUT 35 5 7 MUTE Q365,366 C-CH FL-CH FR-CH SL-CH SR-CH
VIDEO 1
AEP,UK MODEL VIDEO 2 AUDIO IN
4
POWER SECTION (Page 19)
0/6/12dB
SURROUND -6 SUB WOOFER -5 CENTER
RDS SIGNAL 43 RDS DATA 53 RDS CLOCK 52
0/6/12dB 16 15 ASW IN AC IN 0/6/12dB MUTE Q364
J405 SUB WOOFER AUDIO OUT
DSLIN STEREO 76 TUNED 73 TUNER MUTE 75 SLATCH 78 DO 76 VOL IC/ TUNER DATA 14 CLK 15 STEREO TUNED MUTE CE DO/DI CLK DATA DSWIN
29 32 31 27
DSL IN DSW IN DC IN DL IN
Q379 INV.
DIGITAL SECTION (Page 17)
RELAY DRIVER Q560 RY560
3
DCIN DLIN
FC MUTE 20 21 22 DATA CLK LATCH +3.3V +3.3V REG Q471 MCU I/F +7V VCC +7V
2
DIGITAL SECTION (Page 17)
LATCH VOL IC 16
WOOFER RELAY 69
· Signal path : TUNER (FM/AM) : CD (ANALOG) : VIDEO · R-ch is omitted due to same as L-ch.
16
16
STR-DE585
4-3. BLOCK DIAGRAM -- DIGITAL SECTION --
CODEC IC1501
DSP IC1201 29 L INL IN+ ADC LPF AUDIO I/F (1/2) SDTO 9 18 DSI1 SD01 23 SD02 24 R-IN R-CH AMP IC1502 SD03 25 MCLKI 39 14 SCKOUT DAC GP10 67 LRCKO 19 DIR IC1101 IC1102 COAXIAL DVD/LD IN J1101 3 WAVE SHAPER 2 5 AUDIO 24 CKOUT 13 BCK 14 LRCK 15 DATAO 16 69 GP8
S.MUTE
6 7 8
SDTI1 SDTI2 SDTI3 AUDIO I/F (2/2)
DAC
LOUT1
27
DLIN
TUNER/ AUDIO SECTION (Page 16)
L-IN
6
7
2
1
30
1
+5V-2 AVDD
DAC
LOUT 3
23
DCIN
3
ROUT 3 24 DSWIN LOUT 2
TUNER/ AUDIO SECTION (Page 16)
5 LRCK 4 BCK
DAC
25
DSLIN
BCKO 20
+5V-1 D5V
CCLK CDT1 CS
22 KFSI0 29 BCKI2 28 LRCKI2 30 DSI2
MCLK2 12
X1201 13.5MHz ROM IC1202
17
PD
MCLK1 9
3
43
42
41
DIGITAL IC1105 OPTICAL VIDEO 2 IN OUT 1 4
INPUT
DATA DEMODULATOR
D1101 Pa,Pb DETECTION C bit DETECTION LOCK DETECTION ERROR 34 59 EXLOCK
CSO 44 WEO 45
6 CS 17 WE
D0-15 108,107,105 -102,99, 98,79 - 77,75 - 72
MICROPROCESSOR I/F 21 XOUT
BPSYNC CKSEL1
22 XIN
CLK DO CE DI
XSTATE
X1101 12.288MHz
29 - 32,35 - 38, 16-13,10 - 7 D0-15
38 VDD +3.3V
37
36
35
33 NC
47
17
· Signal path : TUNER (FM/AM) : CD (ANALOG) : CD (DIGITAL) · R-ch is omitted due to same as L-ch.
A0-15 112,110,109,99 - 92, 85-82,66 - 64
VDDI
GP9 BST HCS HACN XRST PM HDOUT HDIN HCLK
+2.5V +3.3V
VDDE
68 56 36 32 2 113 35 33 34
TUNER/ AUDIO SECTION (Page 16)
CLK
CE
DI
DO
CKSEL1
XSTATE
DATAO
GP9 BST HCS HACN XRST PM HDOUT HDIN HCLK
PD
SMUTE
CDT1
SCL
2
FC MUTE
21 F.MUTE
DIR Q1602 99 ERROR
DSP SYSTEM CONTROL IC1601 (2/4)
CODEC
17
17
CS
Q1601 INV.
95
96
97
98
94
100
1
2 3 4 5 6 7 18 19 20
24 - 27,42 - 44, 1 - 5,18 - 21 A0-15
8
9
10
12
13
STR-DE585
4-4. BLOCK DIAGRAM -- VIDEO/DISPLAY SECTION --
VIDEO SELECTOR IC103 J201 (1/2) VIDEO 1 VIDEO IN J200 (1/2) VIDEO 2 VIDEO IN 5 V2 13 V1 J201 (2/2) M.OUT 1 VIDEO OUT MONITOR
J200 (2/2) DVD/LD VIDEO IN 3 DVD V1.OUT 15 VIDEO OUT +V 1 -V VEE 8 3 -5V REG IC804 2 FL101 FLUORESCENT INDICATOR TUBE
SW3 SW2 SW4 SW1 SW5
VIDEO 1
IC807 VCC 16 3 +5V REG
F1 F2 +5V-1
4
10
6
14
2
OR D203, D204 88
SW3
BUFFER IC101 5 DIN 61 FL DRV/ LED DRV CLK 62 4 2 1 10 9 6 3 8 14 - 29 42 - 31 SEG1-16 GRID1-16 Q109 SW1 1 Q110 LED DRIVER Q108 LED MATRIX D110-114
Q111 7 DIN 8 CLK 9 STB FL DISPLAY DRIVER IC100
89 87
SW2 SW4
90
SW1
EEPROM IC1604 SDA 5 SCL 6
X1601 20MHz
83 X1 82 X0 34 SDA
VIDEO SW
SW2 2
FL_STB 63 EEPROM
33 SCL
SW3 3
LED DRIVER Q107
MCH LED AFD 2CH MODE DSC LED SYSTEM CONTROL IC1601 (3/4) S145 I/ I CNS3 1 2 FLASH PROGRAMMING 7 6 5 FLASH1 FLASH2 MD2 MD0 RESET 28 27 51 49 SP SWITCH/FLASH1 FLASH2 MD2 MD0
29 32 31 30 26
MCH-LED AFD-LED 2CH-LED MODE-LED DSC-LED
LED DRIVERS Q100-104
D100, D102-104
SIRCS 54
SIRCS
1 OUT
REMOTE CONTROL RECEIVER IC102
56 POWER KEY
VOL(A) 60 VOL(B) 59
1 3
RV102 MASTER VOLUME
A/D0 38
SW NETWORK S100-109
A/D1 39 RESET IC1602 2 1 77 RSTX A/D3 41
SW NETWORK S110-119
· Signal path : VIDEO
+3.3V (STBY)
A/D2 40
SW NETWORK S120-128
SW NETWORK S130-137, S143,144
18
18
STR-DE585
4-5. BLOCK DIAGRAM -- POWER SECTION --
J791 PHONES PRE DRIVER IC701 IN 2 PRE DRIVE +VOUT2 12 -VOUT2 11 R-CH TM602 POWER AMP Q701-704 CURRENT DETECT Q705,706 R-CH R-CH +VOUT2 12 -VOUT2 11 OVERLOAD DETECT D740,Q740 R-CH L RELAY DRIVER Q790 RELAY DRIVER Q710 RY701 POWER AMP Q651-654 CURRENT DETECT Q655,656 R-CH +VOUT 6 -VOUT 5 R-CH POWER AMP Q501-504 CURRENT DETECT Q505,506 -B PROTECTOR 67 D734 D733 HEADPHONE RELAY 68 PREOUT/FRONT 72 RELAY REAR RELAY 70 CENTER RELAY 71 HP DETECT 25 D731 HP-RY FRONT-RY REAR-RY CENTER-RY IC601 HP DETECT OVERLOAD 2 7 DETECT AMP +7V 3 +B -B -BB -30V Q691 TU+3.3V Q692 TU+10V IC801 +7V REG -7V REG IC802 1 3 IC1901 +2.5V +3.3V 5 2 BACK-UP SWITCH 4 -30V D804 RY901 POWER RELAY 66 RELAY DRIVER Q901 RECT D910-913 F901 IC1903 +5V REG 1 F1 F2 1 +V AEP,UK M0DEL 3 PROTECTOR D721,722 Q722,723,725 +B OVERLOAD DETECT D540,Q540
HP-RY FRONT-RY REAR-RY CENTER-RY HP DETECT
FL-CH FR-CH R-CH
8
DRIVE
-BB +B -B PRE DRIVER IC702 +B
R-CH RY791 R
FRONT
TM601 RY601
SPEAKERS IMPEDANCE USE 8-16
TUNER/ AUDIO SECTION (Page 16)
4
SL-CH
8
IN 2
PRE DRIVE
DRIVE
SR-CH
R-CH -BB +B PRE DRIVER IC501 IN+ PRE DRIVE -B +B
OVERLOAD DETECT D640,Q640 R-CH
RELAY DRIVER Q610 RY501 RELAY DRIVER Q550 R-CH
L SURROUND R
C-CH
1
DRIVE
CENTER
-BB +B
RECT D802
T901 POWER TRANSFORMER
-30V REG Q801 IC1905 +3.3V 1 REG 3 IC1902 +10V 1 REG D898,899 DOUBLER COMMUTATION RECT D820-822
-7V SYSTEM CONTROL IC1601 (4/4) +5V-2 +5V-1 3
3 IC1503 +5V REG
2 -V RECT D902-905
· Signal path : TUNER (FM/AM) · R-ch is omitted due to same as L-ch.
T902 POWER TRANSFORMER
IC1904 +3.3V (STBY) 3 +3.3V 1 REG
~ AC IN
Q921 D914 D915
STOP 48
19
19
STR-DE585
4-6. CIRCUIT BOARDS LOCATION
THIS NOTE IS COMMON FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS. (In addition to this, the necessary note is printed in each block.) for schematic diagram: · All capacitors are in µF unless otherwise noted. pF: µµF 50 WV or less are not indicated except for electrolytics and tantalums. · All resistors are in and 1/4 W or less unless otherwise specified. f · : internal component. · 2 : nonflammable resistor. · 5 : fusible resistor. · C : panel designation. Note: The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. Note: Les composants identifiés par une marque 0 sont critiques pour la sécurité. Ne les remplacer que par une piéce por tant le numéro spécifié. for printed wiring boards: · X : parts extracted from the component side. f · : internal component. : Pattern from the side which enables seeing. · Caution: Pattern face side: (Side B) Parts face side: (Side A) C Q B E These are omitted. Parts on the pattern face side seen from the pattern face are indicated. Parts on the parts face side seen from the parts face are indicated.
STANDBY board POWER SW board MAIN board VIDEO board
DIGITAL board
Q B C Q B C E E These are omitted.
HEADPHONE board
DISPLAY board
· A : B+ Line. · B : B Line. · Voltage and waveforms are dc with respect to ground under no-signal (detuned) conditions. no mark : FM · Voltages are taken with a VOM (Input impedance 10 M). Voltage variations may be noted due to normal production tolerances. · Waveforms are taken with a oscilloscope. Voltage variations may be noted due to normal production tolerances. · Circled numbers refer to waveforms. · Signal path. F : TUNER (FM/AM) g : VIDEO J : CD (ANALOG) c : CD (DIGITAL)
· Waveforms (DIGITAL Board)
1
1V/DIV 50nsec/DIV 3.4Vp-p 12.288MHz
5
1V/DIV 50nsec/DIV 3.6Vp-p 13.5MHz
IC1101
qd
(CKOUT)
IC1201
qs
(MCLK2)
2
1V/DIV 0.2µsec/DIV 3.4Vp-p 3.07MHz
6
1V/DIV 50nsec/DIV 4Vp-p 12.288MHz
IC1101
qf
(BCK)
IC1201
qf
(SCKOUT)
3
1V/DIV 50nsec/DIV 3.6Vp-p 12.288MHz
7
1V/DIV 50nsec/DIV 3Vp-p 20MHz
IC1101
wa
(XOUT)
IC1601
id
(X1)
4
1V/DIV 50nsec/DIV 5Vp-p 12.288MHz
IC1501
el
(MCLKI)
20
20
STR-DE585
4-7. PRINTED WIRING BOARDS -- MAIN SECTION -- · Refer to page 20 for Common Note on Printed Wiring Boards and Circuit Boards Location.
1 A
2
J401
3
4
J402
5
J403
6
J404
7
J405
8
(Page 28)
9
10
TM601
11
12
TM602
13
14
CC14
RR15
C400
RR14
CC19
JW523
CC15
CC62 R462 R464
CC61
R405 CC57
CC42 C800 CC32 R432
R409 CC54
CC04
CC09
CC55
R455 CC05
R457 CC07
CC58
R458 CC08
CC56
R463 R461
CC52 R452
CC02
R402
CC59 R459
CC06
R454
R407
R404 C700
R408
R456
C500
R406
R412
R469
CC41 R411
CC31
JW623
R431
R435
CC17
B
C411
JW525
RR13 CC16
CC21
RR12
CC20
CC18
C431
CC12 JW524 CC13 TP1
RR11
JW526
JW426
R415
R416
R445
JW451
R442
JW760
R436
JWH101
JW412 JW411 JW410
JW622 JW521
JW402 JW404 JW405 JW406 JW407 JW408
R425
JW455
R444
R424
C432
R422
C412
C452
C402 JW419 JW430 JW448
C459
R427
C462
C461
C409
C454
C404
C455
C405
C457
C407 R447
C408 C458 R446 R470
JW454
C456 R426
JW522
C406
JW546
C413 R472
C433 C466 JW409
JW401 JW403
JW429
JW H10 4
JW428
TP2 C811 JW759
RY601
C804
C803
JW439
R634
R802 D560
C414
R668
R471
Q471
JW804
JW805
D896
C808
C810
JW452
C467 C497 C490 C489 JW415
C488
Q710
Q560
CNP501
R533
IC801 IC802
R532
JW745
R768
L751
L601
R731
JW752
R417 C465 R413
C464
R734
R363
Q365
JWH108
R420 R419 R418
R360
C371
C372
JW417 JW416
JW100
R651 R653 R744 C755
R751 R752 C757 C607 R602 R601
C606 R603
R753
R743
R380 JW456
JW742 JW741
D722R737
JW420
C373 R367 R375 R366 C374
R379
Q363
Q364
R368 R499
JW611
R604
C604
JW610
Q722
C703 IC701
JW613 R692
R691
C493
C484
IC702
JW614 JWH105
C472R376 C496
CNP911
JW421 JW422 C483 JW431
R694
R770
C753
JW783
R699
C901 R910
C707 C657 R652
C486
JW739 R703 R701
JW734
JW712
Q725
C492
R702
C653
R698
C701
C605
IC601
R736 JW731
C419
C495
C485
R693
R780
C721
Q723JW781 D732
D690
R373
R696
R690
Q692
C416
JW713
C494
C751
C601
C603
Q790 JW821 D902 D905 D903
Q691
C741 JW706 JW707 JW628 JW630 JW736
R623 JW721 JW720 JW722
JWH106
C756 JW735 R754
JW612
JW723 JW718
C655
IC401
C654
JW457
R473
C656 R654
R474
C498
R704
R381
Q379
JW702
C706
C830
Q748 JW434
C754
C503
R501C501
JW717 JW716
JW701
D721
C722
R794
R502 C507
C704
R560
R806
JW615 JW582
R756
R755
JWH109
JW581
JW424
JW626
C616
C617
CNP502
C742
JW637
R556 JW636
R680 JW559 R625
R503
D740
R723 R740
R657
D680
R638
R555
R675
R676
R793
R573 C506
R748
R504
C711 Q706
R521 R522 R525 Q506
JW569
C505
R724 R722
Q505
R640 C642 R677 R674 D640 R672 D665
R772
R671 JW620
JW508 R524 D505
C761 JW568 R771 JWH112
Q740
R719
R778
C770
JW507 R557
Q651
JW445 JWH107
JW504 R520
R505
C504
C519
R621
R513
Q501
R714
C666
R764
C510
R514 R511 R510
C517
JW505 JW506
C717 R710 R711 C716
R664
R665
C516
JWB01
R660 R661
C766
C669
R760 R761
R614 C767
R610 R611
C620
JW601
R515
R765
R613
R615
CN792 Q602
Q502 Q503 TP800 Q504 Q703
Q702 Q704 Q653
Q652 Q654 Q753
Q752 Q754 Q603
Q604
G
· Semiconductor Location
Ref. No. D505 D510 D540 D560 D605 D610 D640 D665 D680 D690 D691 D705 D710 D721 D722 D731 D732 D733 D734 D740 Location F-3 C-9 F-4 C-7 F-11 C-8 F-7 F-7 E-10 D-9 D-8 F-5 C-9 E-10 D-10 D-10 D-11 D-10 D-10 E-5 Ref. No. D750 D765 D791 D801 D802 D804 D896 D902 D903 D904 D905 IC201 IC401 IC501 IC601 IC701 IC702 IC801 IC802 Location E-9 F-9 F-12 E-13 C-13 E-11 C-6 D-12 E-12 E-12 D-12 D-4 E-3 E-3 D-8 E-6 D-7 C-6 C-6 Ref. No. Q361 Q362 Q363 Q364 Q365 Q366 Q379 Q471 Q501 Q502 Q503 Q504 Q505 Q506 Q540 Q550 Q560 Q601 Q602 Q603 Location D-5 D-6 E-2 E-2 D-6 D-7 E-2 C-2 F-2 F-4 F-3 F-4 F-3 F-3 F-4 C-9 C-7 F-10 F-10 F-10 Ref. No. Q604 Q605 Q606 Q610 Q640 Q651 Q652 Q653 Q654 Q655 Q656 Q680 Q691 Q692 Q701 Q702 Q703 Q704 Q705 Q706 Location F-11 F-11 F-10 D-8 E-7 F-6 F-7 F-7 F-7 F-6 F-8 E-10 E-9 D-9 F-4 F-5 F-5 F-6 F-6 F-5 Ref. No. Q710 Q722 Q723 Q725 Q740 Q747 Q748 Q750 Q751 Q752 Q753 Q754 Q755 Q756 Q790 Q801 Location C-9 E-10 D-11 D-10 F-5 E-5 E-4 E-9 F-8 F-9 F-8 F-9 F-8 F-9 D-12 E-12
TP701
C792
H
CNP791 JW793
TP900
F
R516
C710 R713
JW705 R715 R663
C760 R763
R620
R716
R666
C621
C660
C670 R669
JW501 JW502 JW503
R540 R546 C541 D540
Q756
Q705
Q751
R721 C720
Q540
Q701
C619
R766
C610
R616
R803
D791
R732
RY791
Q655 C661
Q601
Q606
C611
C511
D705
D765 R769
R624 D605
R622
Q605
C540
Q755
R517
C740
R673
C640
Q656
C822 R656
JW710
JWB03
R767
R655
JW811
R717
R747
R746
R745
Q640
R667 R648
R617
C733
JW558 Q680
(Page 25)
R725
C732
C750
JW714
IC501
JW703
R733
JW578 R775 R773 R750 C752 R757 D750
JW719 C680 R681
Q750
JW822 JW823
C802
C471
R758
Q801
JW820
R742
CNP802
E
Q747
JW711
C705
JW704 C681 R792
D804
C903
D904 R804 D801
C801
R735
JW450
JW757
D
Q361
Q362
C491
R374
D691
D733
R791
CNP915
C418
R377
C651
JW444 JW733
JW751
C481
C375 R369 R370 C376
Q366
C415
R371
R695 C691
JW753
R361 R362
R378
IC
L521
R534
20
(Page 25)
C487
C482
R372
C417
R718
CNP801
D731 D734
JW754 JW755 JW756
1
C806
R475 JW432 R414
Q610
R631
C807
R528
Q550
D710
L701
D510 R531
JWH110
JWH111
JW782 JW801
JW825 JW826
D802
CN505
R618
RY501
RY701
C805
L651
JWH1
02
JW400
JW300
RY560
JW545
C
JW453
JWH103
D610
(Page 32) (Page 32)
JW746
(Page 25)
JW584
(Page 32)
J791
I
C790
J
21
21
STR-DE585
4-8. SCHEMATIC DIAGRAM -- MAIN SECTION (1/2) -- · Refer to page 20 for Common Note on Schematic Diagram.
C481 J404 CC07 R407 C407 CC57 R457 C457 C500 CC06 R406 C406 CC56 R456 C456 R426 R427 R447
C491
C493
C483
C492 R373 Q361 IC201 R363
R361 C371 C372 R362
R446
CC08 R408 C408 CC58 R458 C458 C485 C482
R360 R374
(Page 23)
Q362
J403 CC05 R405 CC55 R455 C700 CC04 R404 CC54 R454 C404 C454 R424 R444 C405 C455 R425 R445
JW300 C495 C419
C486 R375 R367
Q363
R379 CNP502 JW100
C373 C374 R366 Q364
JW400
C418 C496 C417
R368 R376
J402 CC09 R409 CC59 R459 C409 C459
C416
C494 R377 R371
Q365
R369
(Page 27)
CNP911
C375 C376 R370
C415 R372
CC02 R402 CC52 R452
C402 C452
R422
C484 C414
R378
Q366
R414
R413 R417
R418 R419
R442 C488 C413 C433 C487
C465 C464
R420
R380
C489 C490 C497 C467
R475 Q471 R471 R472 R381 Q379
(Page 27)
J401 CC61 R461 CC62 R462 C461 C462 R463 R464
C466
CC32 R432 CC42 R412 C800 CC31 R431 CC41 R411
C432 C412
R436 R416 R469 RY560 C471 C400 R470 R532 D560 Q560 R474 C498 C472 C803 C805 CNP801
D802
C431 C411
R435 R415
J405
R802
R533
R560
IC401
R499
R473
C804
C806
CN505
(Page 33)
IC801
CNP802 D905
(Page 29)
CNP501 C807 C811 C822 D896 C808 C810 D804 Q801 R803 C903
R910 C901 C830
D902
D903 D904
(Page 33)
CNP915
R806 IC802 C801 C802
R804
D801
(Page 26) (Page 33)
The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified.
Les composants identifiés par une marque 0 sont critiques pour la sécurité. Ne les remplacer que par une piéce portant le numéro spécifié.
22
22
STR-DE585
4-9. SCHEMATIC DIAGRAM -- MAIN SECTION (2/2) -- · Refer to page 20 for Common Note on Schematic Diagram and page 34 for IC Block Diagrams.
CNP791 Q747 R792 CN792 C792 C790 RY791 J791
IC B/D
C717 R742 Q748 R744 R710 R711 Q701 IC701 R714 Q703 R716 C710 C701 R701 C655 C656 C707 C651 R702 R651 C716 C706 C705 R713 R715 Q704 R725 D705 Q702 C711 Q706 R717 R748 R721 R719 C720 L701 Q705 R718 R722 R724 R740 C742
R723
R794 R745 D740 R746 Q740 R747 C740 R793 D791 R791 Q790
C654 C657 R652 R653 C653 R654 R703 C703
C704 R704 C660 Q652 R663
C669 Q654 R665
R638 L651 R668 R666 R671 R640 R672 C661 R674 Q656 Q653 D665 R669 C670 R667
R673 CC13 R675 D640 Q640 R648 R677 C640 R676 RY701 TM602 CC12 RR11
Q655
C741
IC B/D
IC702 Q651 R743
C642
R660
R661
R664 C666
R734 R623
D710 R731 Q710
CC15
CC14
RR12
C751
R751 C605 C606 C756 C755
C621
Q603 L601 R620 C619 R618 R616 Q605 R680 R621 R622 R624 C611 R617 Q604 Q606 R625 D605 R773 L751 Q755 R766 R771 R768 R750 C761 C752 D750 Q750 R758 R757 C750 R755 R756 RY601 RR15 CC20 CC21 C681 R681 R657 D680 R656 Q680 C721 TM601 R770 R655 RR14 CC18 CC19 RR13 CC16 CC17
C601
R601
C757
R752 Q601 R602 R603 C604 R604 R753 C753 C754 C610 R754 C616 C617 IC501
R610
R611
R614
Q602 C680
D731
C607
(Page 22)
C603
R613
R615 C620
Q725 R780 D722 D721 R736 R737
Q723 R735 Q722
IC B/D
C767 Q754 R763 C760 Q752 R765
D734
C722
R504
C501 R501
C505 C506 R505
R760 Q751 C732 C733
R761 R764 Q753
R772
R778 R767 D765 Q756
C507
R502
R503 C503 C504
C766 R732 R733 C517 R510 R769 C770 Q503 R511 R514 C519 R520
R634
D610 R631 Q610
R573
D691 Q692 IC601 R516 D690 Q691 R698 R690 R696 Q501
L521 R555 Q505 R540 R522 R524 C511 R546 R517 R557 C540 R528 C541 D540 Q540 R556 RY501
C510
Q502 R513 R515
R521
R691 R694 R692 R699
R693
C691 R695
Q504 C516
Q506 R525
D505
R534
D510 R531 Q550
23
23
The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified.
D733
R775
D732
Les composants identifiés par une marque 0 sont critiques pour la sécurité. Ne les remplacer que par une piéce portant le numéro spécifié.
STR-DE585
4-10. PRINTED WIRING BOARD -- DIGITAL SECTION (1/2) -- · Refer to page 20 for Common Note on Printed Wiring Boards and Circuit Boards Location.
13
12
11
10
9
8
7
6
5
4
3
2
1 A
B
· Semiconductor Location (side A)
Ref. No. D1001 D1101 D1601 IC1101 IC1102 IC1201 IC1202 IC1501 IC1502 IC1552 IC1601 IC1602 IC1604 Q1601 Q1602 Location G-10 F-10 H-4 E-9 H-11 F-7 E-7 G-9 I-9 H-8 H-5 H-3 H-3
R1105
Z1
C
L1901 Z2
R1121
JR1122
R1113
D
R1110
R1107
R1101
IC1101
FB1601
Z4
R1600
IC1202
R1104
C1104
R1112 FB1105 FB1104 D1101
C1109 C1110
R1212 R1213
R1214 R1215 R1216 R1217
R1221
R1676
R1677
R1673
R1102
R1631
JR1111
R1111
Z3
R1114
R1308
C1101
X1101
R1670
R1668
R1100
R1698 R1602 R1667
R1222
R1699
I-5 I-5
R1124
E
R1678
R1669
F
R1639 R1640 R1704 R1703 R1636 Z9
R1108 R1649
R1674
IC1201
R1205
R1103 C1124 D1001 FB1101
C1524
FB1501
C1525 Z6 Z5
R1206
R1209
R1638
R1641
FB1602
C1603 R1688
R1687
C1605
R1204
R1508
C1514
R1679
C1607
IC1501
R1647
G
R1661 R1633
R1648
R1109
C1115
JR1104
C1117
R1666 IC1601
FB1502 Z10
R1634
R1118
R1630 R1629 R1628 R1627
R1520
IC1602
IC1102
R1554
C1501
C1551 R1551
R1644
R1694
C1612
C1617
R1521
R1643
R1642
R1518
R1117
R1502
R1516
R1501
R1553
R1119
R1505
R1618
R1614 R1615
R1557
R1656
Z7
R1612 R1611
R1610
R1657
R1556 R1555
R1617
R1609
Q1602
IC1502
R1607
R1613
Q1601
R1604 R1608
R1606
R1655
R1624 R1625
R1621
R1517 R1506
R1619
R1605
R1603
R1601
D1601
C1114
R1646
R1663
R1662
R1519
R1504 R1503
R1552
IC1552
R1645 Z8
IC1604
H
R1685
R1686 R1684
R1683 R1623
I
J
24
24
STR-DE585
4-11. PRINTED WIRING BOARD -- DIGITAL SECTION (2/2) -- · Refer to page 20 for Common Note on Printed Wiring Boards and Circuit Boards Location.
1 A
2
3
4
5
6
7
8
9
10
11
12
13
B
(Page 32)
(Page 21)
TM301
(Page 28)
· Semiconductor Location (side B)
Ref. No. D1501 D1502 D1905 D1906 D1907 Location H-9 H-9 E-3 E-3 E-4 D-11 H-7 E-3 D-3 F-3 D-4 C-3
FB1202
FB1201
C1916
C1915 CNP5 C1911 IC1904 CNP6
C1227
FB1102
C
IC1905 C1221 C1311 R1314 C1310 R1364 C1309
CNS7
CNS8 C1126
C1914 IC1902
CNS3
C1906
C1912
R1710 R1711
C1112 C1212 C1129 C1111 R1115
C1214
JR1210
C1113
R1705 D1906 D1907 R1304
C1230
C1106
C1108
JR1200
R1305
C1213
C1103
E
R1690
D1905
C1131
C1107
R1219
R1218
C1905
C1619
R1665 R1664
R1220
C1211
C1208
IC1901 C1909 IC1903
C1105
R1203
C1207
R1708
R1707
C1611
C1610
R1637
C1910
C1205
R1210
C1210
F
R1650
C1206
R1509
X1201
C1219
R1106
C1102
JR1115
IC1105
C1913
C1908
C1231
C1121
D
C1127
IC1105 IC1503 IC1901 IC1902 IC1903 IC1904 IC1905
JR1116
J1101
R1201
R1659
FB1203
FB1603
C1627
C1203
C1218
JR1103
R1651
JR1112 JR1113
JR1121
FB1204
C1204
C1209
C1130
R1207 R1208 R1202 JR1118
R1116 C1119
C1620
C1202
R1654
R1689
C1216
R1658
X1601
G
R1632 C1616 C1632 CNS4
C1201
C1626
C1513
C1606
C1604
C1509
C1615
C1618
R1635
JR1114
C1601
(Page 30)
C1635
R1622
R1706
H
C1613
C1507 IC1503 C1505 C1503
C1312
C1634
C1552 R1682
I
CNS2
CNS1
R1507
C1614
R1697
R1709
C1523
C1506
C1504
D1502
R1626
C1633
C1602
C1508
C1631
D1501
C1511
C1229
C1512
C1220
C1510 C1522
C1515
C1116
C1502
J
(Page 21) (Page 21)
25
25
C1118
STR-DE585
4-12. SCHEMATIC DIAGRAM -- DIGITAL SECTION (1/2) -- · Refer to page 20 for Common Note on Schematic Diagram and Waveforms, and refer to page 34 for IC Block Diagrams.
C1111 C1112 R1115
C1129 FB1102
(Page 27)
FB1201 JR1210 C1214
IC B/D
JR1116 R1101 C1126 IC1105 JR1115 R1121 JR1122 C1121 C1107 C1119 R1106 C1101 J1101 R1116 C1124 C1106 R1107 R1105 R1104 C1104 C1103 C1102 IC1101 R1110 R1113 C1127
FB1202
C1230
C1211
C1212
C1113
C1231
IC1202
C1118
R1117 C1213 R1204 R1118 R1119 C1114 FB1104 IC1102 R1112 FB1105 R1102 R1100 X1101 R1124 C1131 JR1118 C1205 C1204 C1218 JR1200
C1130
FB1101 D1001
R1103 R1114 R1108
R1111
C1203
TP1215
TP1220
TP1219 TP1218 TP1217
R1109 C1116
R1504
R1505
R1506 C1502
IC1502 C1522 C1501 R1503 C1523 R1501 R1502 R1220 C1206 R1557 C1207 R1554 R1555 R1556 C1552 R1216 R1215 R1214 C1511 R1213 R1212 C1216 TP1209 TP1208 C1201 TP1207 TP1206 TP1205 JR1121 R1219 R1218 R1217 IC1201 R1222 R1221 C1220
C1115
C1117
C1110
TP1216
TP1214
D1101
C1108 C1105
C1109
TP1213 TP1212 TP1211 TP1210
C1202
FB1501 R1509
IC B/D
IC1552 JR1103
C1512 D1501 D1502
TP1221 R1203 TP1222
C1551 R1553 C1513 C1515 C1514 C1503 C1504 R1507 R1508 JR1104 C1508 IC1501 R1210 C1219 C1208
R1551 R1552
R1201
C1210
FB1204 C1209
R1206
R1207 R1208
IC1503 C1525
C1509 C1510
TP1202
FB1203
TP1203
TP1204
FB1502 C1524
C1507
TP1201 X1201 R1202
(Page 27)
R1520 R1521 R1518
R1519 R1516
C1505
C1506
(Page 22)
R1205
CNS1
R1517
26
26
R1209
STR-DE585
4-13. SCHEMATIC DIAGRAM -- DIGITAL SECTION (2/2) -- · Refer to page 20 for Common Note on Schematic Diagram and Waveforms.
CNP5
(Page 33)
R1688 CNP6
D1907 IC1904
L1901 IC1903 D1906 D1905 IC1901 C1910 C1908 C1909 C1906 C1905 C1911
(Page 22)
FB1601 C1912
CNS4
(Page 26)
R1670 JR1112
JR1111
C1611
C1610 R1707
R1708
CNS8 R1668
R1689
JR1113
IC1602
R1690 C1619 R1305 R1304 R1704 R1703
(Page 29)
IC1902 R1642 C1914 C1913 C1612 C1617
R1650 R1651 R1654
FB1603
(Page 31)
R1638 R1631 R1602 R1667 R1308 R1664 R1665 R1699 R1698 R1600 R1674 R1673 R1669 R1641 R1640 R1639 R1658
IC1905 FB1602 X1601
C1618 C1606 R1636 C1605 C1604 C1620 C1603 R1666 R1697 R1632 JR1114 C1633 C1616 C1615 C1614 C1613 CNS3 C1635
C1627
C1626 C1229
C1915
C1916
R1659 R1637 R1676 R1677 R1678 R1679
CNS7 TM301
IC1601
R1643 R1694 R1644 R1645 R1646 R1647 R1648 R1649 R1710 R1711 R1705
R1635 R1687 R1661 C1607 R1634 R1633 C1631 C1632 R1630 R1629 R1628 R1627 C1602 R1662 R1663 R1686 R1685
R1314 R1364
C1312 R1684 R1683 IC1604
R1709 R1706
C1601
R1614 R1615 R1622 R1617 R1618
R1601
C1221
C1309 C1310 C1311
C1227
R1611 R1612 R1613
R1603 R1604 R1605
R1606 R1607 R1608
R1609 R1610
R1619
R1621
R1626 R1623 C1634 D1601 R1624 Q1602 R1656 CNS2 R1657 Q1601 R1625 R1682
(Page 26)
R1655
(Page 22)
27
27
STR-DE585
4-14. PRINTED WIRING BOARD -- VIDEO SECTION -- · Refer to page 20 for Common Note on Printed Wiring Boards and Circuit Boards Location.
1
· Semiconductor Location
Ref. No. D203 D204 IC103 IC804 IC807 Location F-4 F-4 E-7 E-10 C-11
2
3
4
5
6
7
8
9
10
11
A
J200 J201
B
C
C249 C207
IC807
C827
R219 R218 C248 JW202 JW207 R221 R220
C210 C208 R200
C214
R201
D
C206
C200
C201
JW206
JW212
CNS150
JW214
C209 C809
JW203
C215
JW216
E
(Page 25)
IC103
JW213
C213
JW204
C825
JW218
JW220
D204
JW211
JW205
IC804 T20
F
D203
T21
CNP156
G
(Page 21)
28
28
C824
STR-DE585
4-15. SCHEMATIC DIAGRAM -- VIDEO SECTION -- · Refer to page 20 for Common Note on Schematic Diagram and page 34 for IC Block Diagrams.
J201
R201 C208 R220 C201 C214 C210 R219 C209
J200
C200
R200
IC B/D
C206 IC103 C207 C827
IC807 CNP156 C824
R221
R218
C809
C825
(Page 22)
C249 C248
IC804
D203
D204
C215
C213
CNS150
(Page 27)
29
29
STR-DE585
4-16. PRINTED WIRING BOARDS -- DISPLAY SECTION -- · Refer to page 20 for Common Note on Printed Wiring Boards and Circuit Boards Location.
1 A
2
3
4
5
6
7
8
R165 R171
9
10
11
12
13
14
JW150
D102
JW114 L103
JW112
R141
Q100
R199
R109
R115
Q104
JW146
C100
B
C156
JW103
C150
JW121 S111
FL101
Q110 JW106 JW102
R116 R114
R108
R132
C151
D100
C115
JW111
JW147 C144
R198
S131
S116
S108
C109 C143 C142 C141 C140 C139 C138 C137 C136 C135 C134
C133 C132
C104
C108
C114 R153 C105 CNP103 IC102 R155
Q108
Q109
R175
R164 R150 R172 R173 R174 JW110 JW108 JW109
JW122
JW120
R111
C160 C159 C158
JW118
R161
JW127 JW128 JW129 JW130
C157 L101
JW126
JW101
JW123 JW124 L102 JW131 S112
JW151 RV102
S128
R112
R104
JW136 JW137
JW132
JW135
JW138
D
JW156
R133 S132
R131 S130
R102 S134
S123
S124
R107
S105
S104
R128
(Page 25)
R105 R134 R135 S133
JW144
D112
D111
R163 D114
C110 C111 C112
C155
C
JW107
CNS100
JW117
JW119
R160
R169
JW116
R148
JW143
JW125
R113
R162 D113
S102
S107
JW104
S115
S114
C101
S109
C145 R170
Q107
R101 S101 S119 S100
JW139
R117
S127
JW140
Q111 R154
S113
JW115
IC
10
IC101
0
R126
R125
R119
JW148
R121
Q101
Q103
Q102
R167 R168 R166
R142
R144
R143
TP100
JW142
JW141 S135
R137
R118 S117 S110 R136 S137 S118
R122
D104
D105
D103
R124 R103 R106
R123
R127 JW145
E
S106 S103 S136
S125
S120
S122
S121
S126
F
G
· Semiconductor Location
Ref. No. D100 D102 D103 D104 D105 D111 D112 D113 D114 IC100 IC101 IC102 Location B-6 A-9 D-7 D-6 D-7 C-7 C-6 C-10 C-8
R138
S145
H
B-9 B-4 B-13 B-6 D-2 D-3 D-2 B-5 B-11 B-12 B-12 B-12 B-12
S143
R139
I
J
Q100 Q101 Q102 Q103 Q104 Q107 Q108 Q109 Q110 Q111
S144
30
30
STR-DE585
4-17. SCHEMATIC DIAGRAM -- DISPLAY SECTION -- · Refer to page 20 for Common Note on Schematic Diagram.
R101
R102
R103
R104
R105
R106
R107
R108
R109
S100
S101
S102
S103
S104
S105
S106
S107
S108
S109
Q111 R175 Q110 D113 D111 R168 D114 R163 R162 D112 R161 R160 C101 D105 D104 D103 S110 S111 S112 S113 S114 S115 S116 S117 S118 S119 R167 R166 R111 R112 R113 R114 R115 R116 R117 R118 R119
Q103
Q102
Q101
Q109
Q108
Q107
R164 R150 IC100
R144
R143
R142 R121 R122 R123 R124 R125 R126 R127 R128
C151
C150
L102
S120
S121
S122
S123
S124
S125
S126
S127
S128
R172 R173 R174
R165 D102 R171 C104 R170 C145
R169 D100
IC101 R131 C100 Q100 C144 Q104 S130 C115 R141 R148 CNP103 CN104 S131 S132 S133 S134 S135 S136 S137 S143 S144 S145 R132 R133 R134 R135 R136 R137 R138 R139
C112 C111 C110
CNS100
L103 C156
C132 C133 C134 C135 C136 C137 C138 C139 C140 C141 C142 C143
C157 RV102 C109 IC102 C160 C159 C158
L101 C155
C108
R198 R199 R153 R155 FL101 C105 C114 R154
(Page 27)
31
31
STR-DE585
4-18. PRINTED WIRING BOARD -- POWER SECTION -- · Refer to page 20 for Common Note on Printed Wiring Boards and Circuit Boards Location.
1 A
· Semiconductor Location
Ref. No. D820 D821 D822 D823 D898 D899 D901 D910 D911 D912 D913 D914 D915 Q901 Q921 Location F-6 F-6 F-7 F-6 G-5 G-6 F-8 H-9 H-9 H-9 H-9 H-8 H-8 G-8 G-7
2
3
4
5
6
7
8
9
10
11
12
B
(Page 21)
C
(Page 21)
B901
CNP901
CNP902
D
F901 JW906 JW904 JW831 RY901 JW905
E
C816
(Page 25)
C815
CNP905
D823
D820
C813
C814
D821
D822 R904 D901 Q901
F
D898 JW832
D899
R903 CNP912 R811 R810 R812 Q921 R923 C950 JW833 C923 R922 R921 D914 D915 C920 D911 D913 C921 D910 D912 R902 T902
G
(Page 21)
C898
C899
CNP903
H
G901
32
32
R901
STR-DE585
4-19. SCHEMATIC DIAGRAM -- POWER SECTION -- · Refer to page 20 for Common Note on Schematic Diagram.
T901
(Page 22)
(Page 22)
CNP903
CNP902
CNP905
C815
D820
D823
R810 Q901 F901
R812 C816 C813 D821 D822 R811 R903 R902
(Page 22)
C814 C898 D898 D899 C899
D901 RY901 R904 T902
D910
CNP901 D911 C950 C920 R901 Q921 R923 D913 D915 G901 D914 D912 R922 C923 C921
(Page 27)
CNP912
R921
The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified.
Les composants identifiés par une marque 0 sont critiques pour la sécurité. Ne les remplacer que par une piéce portant le numéro spécifié.
33
33
STR-DE585
4-20. IC BLOCK DIAGRAMS
IC501 STK350-230 (MAIN BOARD (2/2)) IC1501 AK4527 (DIGITAL BOARD (1/2))
LOOP1 CDTI CCLK CS S/P MCLKI DZF1 A.GND A.5V FREFH VCOM
44 43 42 41 40 39 38 37 36 35 34
PRE DRIVER
AUDIO I/F MCLK
5 6 GND 7 8 9
33 DZF2 HPF ADC 32 RIN+ 31 RIN30 LIN+ 29 LINLPF LPF LPF LPF LPF LPF 28 ROUT1 27 LOUT1 26 ROUT2 25 LOUT2 24 ROUT3 23 LOUT3
1
2
3
4
-VOUT
IN-
+BOUT
-B GND +B
IN+
SDOS 1 FORMAT CONVERTER
SDOUT
IC701, 702 µPC2581V-S (MAIN BOARD (2/2))
12C S.MUTE BCLK LRCK SDTI1 SDTI2 SDTI3 SDTO DAUX DFS
2 3 4 5 6 7 8 9 10 11
HPF BCLK LRLK SDT0 SDTI1 SDTI2 DATT DATT DATT DATT DATT DATT
ADC DAC DAC DAC DAC DAC DAC
BIAS CIRCUIT PROTECTOR
1
2
3 4
5
6
7
8 9 10 11 12 13 14 15
+VOUT1 VOUT1
VOUT2 +VOUT2
IN1
GND
IN2 NF2
VCC VCC
NF1
VEE
IC1101 LC89056W-E (DIGITAL BOARD (1/2))
LPF VIN R DVDD D.GND A.GND AVDD DIN0 DOUT DISEL
IC103 NJM2595D (VIDEO BOARD)
DIN2
DIN1
12 11
10 9 8 7 6
5
4
3 2 1 48 47 46 45 44 43 42 41 40 39 38 XMODE CKSEL1 CKSEL0 DOSEL1 DOSEL0 DVDD DGND MODE1 MODE0 XSEL CLK
M.OUT 1 SW5 2 75 6dB AMP DRIVER S5 DVD SW3 V2 SW4 NC 3 4 5 6 7
DEM1 DEM0 TVDD D.5V D.GND PD ICKS2 ICKS1 ICKS0 CAD1 CAD0
REG DRIVE
PRE DRIVE
PRE DRIVE
12 13 14 15 16 17 18 19 20 21 22
DRIVE
+V
16 VCC
Pa,Pb DETECTION C BIT DETECTION
MICROPROCESSOR INTERFACE
CKOUT 13 BCK 14 LRCK 15 DATAO 16 XSTATE 17 DGND 18 DVDD 19 XMCK 20 XOUT 21 XIN 22 EMPHA 23 AUDIO 24
S3 S1 S2 S4
S6 15 V1.OUT 14 13 12 11 SW1 V1 GND NC
PLL
INPUT
S7
37 CE
X'TAL1
TIMING
DATA DEMODULATOR
VEE 8
-V
10 SW2 9 V3
LOCK DETECTION
fs CALCULATION
25 26 27 28 29
CSFLAG F0/P0/C0 F1/P1/C1 F2/P2/C2 F3/P3/C3
30 31 32 33 34 35 36
DVDD DGND AUTO BPSYNC ERROR DO DI
34
34
STR-DE585 SECTION 5 EXPLODED VIEWS
NOTE: · The mechanical parts with no reference number in the exploded views are not supplied. · Items marked "*" are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. · -XX and -X mean standardized parts, so they may have some difference from the original one. · Color Indication of Appearance Parts Example : KNOB, BALANCE (WHITE) ... (RED) R R Parts Color Cabinet's Color · Accessories are given in the last of this parts list. The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. Les composants identifiés par une marque 0 sont critiques pour la sécurité. Ne les remplacer que par une piéce portant le numéro spécifié.
5-1. CASE SECTION
2
1
2
3 4
#1 #1
2
3
#1
4
#1
Ref. No. 1 1 2 2
Part No. 4-232-118-01 4-232-118-21 4-210-291-01 4-210-291-11
Description CASE (BLACK) CASE (SILVER) SCREW (CASE 3 TP2) (BLACK) SCREW (CASE 3 TP2) (SILVER)
Remark
Ref. No. 3 4 #1
Part No.
Description
Remark
4-232-237-01 FOOT (DIA.30) 4-921-941-01 CUSHION 7-685-646-79 SCREW +BVTP 3X8 TYPE2 IT-3
35
STR-DE585
5-2. FRONT PANEL SECTION
56 55 56 56 56 54 56 56
57
52 53 51
58
supplied with RV102
52
Ref. No. 51 51 51 52 53 54
Part No. X-4954-472-1 X-4954-706-1 X-4954-707-1 4-921-941-01 1-773-250-11
Description
Remark
Ref. No. 55 56 57 58 58
Part No. 1-683-759-11 4-951-620-01 A-4727-847-A 4-232-113-01 4-232-113-12
Description POWER SW BOARD SCREW (2.6X8), +BVTP DISPLAY BOARD, COMPLETE KNOB (VOL) (BLACK) KNOB (VOL) (SILVER)
Remark
PANEL ASSY, FRONT (BLACK) (Canadian) PANEL ASSY, FRONT (BLACK) (AEP,UK) PANEL ASSY, FRONT (SILVER) CUSHION WIRE (FLAT TYPE) (27 CORE)
1-683-763-11 HEADPHONE BOARD
36
STR-DE585
5-3. CHASSIS SECTION-1
103 104 107
#1 #1 #1 #1 #1 #1 #1 #1 not supplied
101
#1 #1
102
TM301
105
#1 #1
106
#1
not supplied not supplied
The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified.
Les composants identifiés par une marque 0 sont critiques pour la sécurité. Ne les remplacer que par une piéce portant le numéro spécifié.
Ref. No. 101 101 102 102 0 103 0 103 104
Part No. A-4727-840-A A-4727-849-A 1-769-940-11 1-773-004-11 1-769-744-11
Description
Remark
Ref. No. 105 106 106 107 TM301 TM301 #1
Part No. 1-575-662-31 A-4676-979-A A-4727-993-A 4-956-370-12 1-693-577-21
Description
Remark
VIDEO BOARD, COMPLETE (Canadian) VIDEO BOARD, COMPLETE (AEP,UK) WIRE (FLAT TYPE) (11 CORE) (Canadian) WIRE (FLAT TYPE) (15 CORE) (AEP,UK) CORD, POWER (AEP,UK)
WIRE (FLAT TYPE) (5 CORE) DIGITAL BOARD, COMPLETE (AEP,UK) DIGITAL BOARD, COMPLETE (Canadian) BAND, PLUG FIXED (UK) TUNER PACK (FM/AM) (ANTENNA) (Canadian)
1-783-820-11 CORD, POWER (Canadian) 3-703-244-00 BUSHING (FBS001), CORD
1-693-578-21 TUNER PACK (FM/AM) (ANTENNA) (AEP,UK) 7-685-646-79 SCREW +BVTP 3X8 TYPE2 IT-3
37
STR-DE585
5-4. CHASSIS SECTION-2
Q603 #1 Q604
153
Q754 Q753 Q654 Q653 Q704 Q703 #1
#3
#3
Q504
152
F901 not supplied #1 not supplied T901 #2 #2
Q503
151
not supplied
The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified.
Les composants identifiés par une marque 0 sont critiques pour la sécurité. Ne les remplacer que par une piéce portant le numéro spécifié.
Ref. No. 151 151 152 153 153 0 F901 0 F901 Q503 Q504 Q603 Q604
Part No. A-4727-841-A A-4727-850-A 3-905-609-01 A-4676-978-A A-4727-992-A 1-532-464-31 1-576-193-11 8-749-010-25 8-749-010-26 8-749-010-25
Description
Remark
Ref. No. Q653 Q654 Q703 Q704 Q753 Q754 0 T901 0 T901 #1 #2 #3
Part No. 8-749-010-25 8-749-010-26 8-749-010-25 8-749-010-26 8-749-010-25 8-749-010-26 1-435-903-11 1-435-905-11 7-685-646-79 7-685-880-09
Description TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR MN2488-OPY-M MP1620-OPY-M MN2488-OPY-M MP1620-OPY-M MN2488-OPY-M
Remark
STANDBY BOARD, COMPLETE (Canadian) STANDBY BOARD, COMPLETE (AEP,UK) SCREW (TRANSISTOR) MAIN BOARD, COMPLETE (AEP,UK) MAIN BOARD, COMPLETE (Canadian) FUSE (T2.5A/250V) (AEP,UK) FUSE (6.3A/125V) (Canadian) TRANSISTOR MN2488-OPY-M TRANSISTOR MP1620-OPY-M TRANSISTOR MN2488-OPY-M
TRANSISTOR MP1620-OPY-M TRANSFORMER, POWER (AEP,UK) TRANSFORMER, POWER (Canadian) SCREW +BVTP 3X8 TYPE2 IT-3 SCREW +BVTT 4X6 (S)
8-749-010-26 TRANSISTOR MP1620-OPY-M
7-685-645-79 SCREW +BVTP 3X6 TYPE2 N-S
38
STR-DE585 SECTION 6 ELECTRICAL PARTS LIST
NOTE: · Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. · -XX and -X mean standardized parts, so they may have some difference from the original one. · RESISTORS All resistors are in ohms. METAL:Metal-film resistor. METAL OXIDE: Metal oxide-film resistor. F:nonflammable · Items marked "*" are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. · SEMICONDUCTORS In each case, u : µ, for example: uA.. : µA.. uPA.. : µPA.. uPB.. : µPB.. uPC.. : µPC.. uPD.. : µPD.. · CAPACITORS uF : µF · COILS uH : µH
DIGITAL
The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. Les composants identifiés par une marque 0 sont critiques pour la sécurité. Ne les remplacer que par une piéce portant le numéro spécifié. When indicating parts by reference number, please include the board.
Ref. No.
Part No.
Description
Remark
Ref. No. C1213 C1214 C1216 C1218 C1219 C1220 C1221
Part No. 1-164-156-11 1-164-156-11 1-162-927-11 1-162-927-11 1-164-156-11
Description CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.1uF 0.1uF 100PF 100PF 0.1uF 100PF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.0015uF 10% 22uF 20% 0.1uF 10uF 20% 0.1uF 470uF 10uF 0.1uF 0.1uF 47uF 0.01uF 0.022uF 0.1uF 0.1uF 10uF 20% 20%
Remark 25V 25V 50V 50V 25V 50V 25V (AEP,UK) 25V 25V 25V 25V 25V 25V 25V 25V 50V 50V 25V 50V 25V 16V 50V 25V 25V 16V 50V 50V 25V 25V 50V 25V 50V 50V 50V 50V 50V 25V 25V 25V 25V 25V 16V 25V 50V
A-4676-979-A DIGITAL BOARD, COMPLETE (AEP,UK) A-4727-993-A DIGITAL BOARD, COMPLETE (Canadian) *********************** 7-685-646-79 SCREW +BVTP 3X8 TYPE2 IT-3 < CAPACITOR > C1101 C1102 C1103 C1104 C1105 C1106 C1107 C1108 C1109 C1110 C1111 C1112 C1113 C1114 C1115 C1116 C1117 C1118 C1119 C1121 C1124 C1126 C1127 C1129 C1130 C1131 C1201 C1202 C1203 C1204 C1205 C1206 C1207 C1208 C1209 C1210 C1211 C1212 1-164-156-11 1-126-947-11 1-164-156-11 1-162-974-11 1-126-947-11 1-164-156-11 1-162-974-11 1-164-156-11 1-162-918-11 1-162-918-11 1-164-156-11 1-162-974-11 1-164-156-11 1-162-905-11 1-162-923-11 1-126-935-11 1-164-156-11 1-115-416-11 1-126-965-11 1-164-156-11 1-164-156-11 1-126-964-11 1-164-156-11 1-115-416-11 1-164-156-11 1-162-927-11 1-164-156-11 1-164-156-11 1-164-156-11 1-164-156-11 1-164-156-11 1-164-156-11 1-164-156-11 1-164-156-11 1-164-156-11 CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.1uF 47uF 0.1uF 0.01uF 47uF 0.1uF 0.01uF 0.1uF 18PF 18PF 0.1uF 0.01uF 0.1uF 1PF 47PF 470uF 0.1uF 0.001uF 22uF 0.1uF 0.1uF 10uF 0.1uF 0.001uF 0.1uF 100PF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 470uF 470uF 25V 16V 25V 50V 16V 25V 50V 25V 50V 50V
5% 5%
1-162-927-11 CERAMIC CHIP 1-164-156-11 CERAMIC CHIP 1-164-156-11 CERAMIC CHIP 1-164-156-11 CERAMIC CHIP 1-164-156-11 CERAMIC CHIP 1-164-156