Text preview for : Sony-ICFM410L rec.pdf part of Sony ICFM410L portable receiver
Back to : Sony-ICFM410L rec.pdf | Home
ICF-M410L
SERVICE MANUAL
Ver 1.0 2001. 05
AEP Model
SPECIFICATIONS
Speaker: 7.7 cm (31/8 inches) 8 Power output: 200 mW (at 10 % harmonic distortion) Output: v (earphone) jack (ø3.5 mm minijack) Power requirements: 4.5 V DC, three R6 (size AA) batteries External power source: DC IN 4.5 V Dimensions: Approx. 205 × 104 × 40.5 mm (w/h/d) (Approx. 8 1/3 × 4 1/8 × 1 5/8 inches) not incl. projecting parts and controls Approx. 212 × 104 × 42.5 mm (w/h/d) (Approx. 8 3/8 × 4 1/8 × 1 11/16 inches) incl. projecting parts and controls Mass: Approx. 504 g (17.8 oz ) incl. batteries
Design and specifications are subject to change without notice.
FM STEREO/MW/LW PLL SYNTHESIZED RADIO
9-873-156-01
2001E1600-1 © 2001.5
Sony Corporation
Personal Audio Company Shinagawa Tec Service Manual Production Group
ICF-M410L
TABLE OF CONTENTS 1. GENERAL ·································································· 3 2. DISASSEMBLY ························································· 4 3. ELECTRICAL ADJUSTMENTS ····························· 5 4. DIAGRAMS
4-1. 4-2. 4-3. 4-4. 4-5. Block Diagram ····························································· 7 Schematic Diagram ······················································ 8 Printed Wiring Board ··················································· 9 IC Pin Function Description ······································ 10 IC Block Diagram ······················································ 10
5. EXPLODED VIEWS ················································ 11 6. ELECTRICAL PARTS LIST ·································· 12
Notes on chip component replacement · Never reuse a disconnected chip component. · Notice that the minus side of a tantalum capacitor may be damaged by heat. Flexible Circuit Board Repairing · Keep the temperature of soldering iron around 270°C during repairing. · Do not touch the soldering iron on the same conductor of the circuit board (within 3 times). · Be careful not to apply force on the conductor when soldering or unsoldering.
2
ICF-M410L SECTION 1 GENERAL
This section is extracted from instruction manual.
*
Telescopic Antenna
v jack DC IN 4.5V TUNE/TIME SET VOL
Setting the Clock
The display will flash "0:00" when the batteries are installed or the AC power adaptor is plugged in for the first time. The clock can be adjusted when the radio is off.
1 2
To stop flashing of the display, press CLOCK (mb/CLOCK for ICF-M410S). While holding down CLOCK, turn TUNE/TIME SET to set the clock to the current time.
When you turn the control knob a little to or , the clock digits move forward or back one by one, and when you turn the control knob or , the clock digits move further to rapidly. When you release CLOCK, the clock starts operating, and ":" starts flashing. 24-hour system : "0:00" = midnight, "12:00" = noon
3
ICF-M410L SECTION 2 DISASSEMBLY
Note : Follow the disassembly procedure in the numerical order given.
9 Screw (+PTPWH 2 × 8)
qj MAIN board
2 Antenna, telescopic
Remove the Claws
qg KEY board
Cabinet rear
qf Two screws (+P 2 × 8) qh Knob 4 Claws
1 Screw (+B 3 × 6)
Remove the Claws
qd Arm (jog) 7 Side panel (L) 3 Five screws (+BTP 3 × 14) 5 Plate, contact 6 Screw (+PTPWH 2.6 × 8) 8 JACK board q; Two screws (+P 2 × 8)
Cabinet (front) sub assy Knob (jog)
qs Side panel (R) qa Claws
4
ICF-M410L SECTION 3 ELECTRICAL ADJUSTMENTS
MW/LW SECTION
BAND : AM · Repeat the procedures in each adjustment several times for the maximum level meter indication. · The frequency coverage and tracking adjustments should be finally done by the trimmer capacitors. AM IF ADJUSTMENT Adjust for a maximum reading on level meter. T15 450 kHz
AM RF signal generator
Put the lead-wire antenna close to the set.
MW/LW FREQUENCY COVERAGE ADJUSTMENT
30% amplitude modulation by 400Hz signal. Output level : as low as possible
LW MW
Adjust for a maximum reading on level meter. CT4 153 kHz L4 531 kHz
MW/LW TRACKING ADJUSTMENT
FM SECTION
BAND : FM LW MW
Adjust for a maximum reading on level meter. ANT102 162 kHz CT2 ANT102 CT1 243 kHz 603 kHz 1,404 kHz
FM RF signal generator
0.01µF
telescopic antenna terminal
FM TRACKING ADJUSTMENT Adjust for a maximum reading on level meter. L6 CT3 87.5 MHz 108 MHz
75kHz (100%) amplitude modulation by 1kHz signal. Output level : as low as possible
[Adjustment Location : Main board] (Component side)
level meter 16 set +
MAIN BOARD (Component side)
L6,CT3 T1 FM TRACKING AM IF adjustment adjustment
CT1 MW TRACKING adjustment
Speaker terminal (EPJ301)
L4 CT2 MW FREQUENCY LW TRACKING COVERAGE adjustment adjustment CT4 LW FREQUENCY COVERAGE adjustment
5
ICF-M410L SECTION 4 DIAGRAMS
Note on Schematic Diagram: · All capacitors are in µF unless otherwise noted. p: pF. 50 WV or less are not indicated except for electrolytics and tantalums. · All resistors are in and 1/4 W or less unless otherwise specified. f · : internal component. · C : panel designation. The components identified by mark 0 or dotted line with mark 0 are critical for safety. · A : B+ Line. · H : adjustment for repair. · Voltages are dc with respect to ground under no-signal (detuned) conditions. no mark : FM : Impossible to measure · Voltages are taken with a VOM (Input impedance 10 M). Voltage variations may be noted due to normal production tolerances. · Signal path. F : FM f : AM (LW/MW) Note on Printed Wiring Board: · X : parts extracted from the component side. · : Pattern from the side which enables seeing.
· Waveform
1 IC101 wf (XOUT)
2Vp-p
1.4V
6
ICF-M410L
4-1. BLOCK DIAGRAM
MAIN BOARD
ANT101 (TELESCOPIC) Q5 BPF1 1 B.P.F 3 2 FM RF L6 CT3 L7 16 BAND 13 FM RF IN 10 FM RF IF OUT 15 BAND(FM/AM) IC1 FM/AM FRONT-END,IF,DET,AF AMP
METER 20 DET 24 Q8,Q9
JACK BOARD
DCJ301
FM TRACKING
CF2 CF3 10.7MHz
18 FM IF IN
AF IN 25
Q7
DC IN 4.5V
+
L3 FM OSC ANT102 (FERRITE-R0D) MW TRACKING CT1 VT 8 FM OSC
T1 CF1 450kHz IFT 450kHz
17 AM IF IN AF OUT 28
DRY BATTERY SIZE "AA" (IEC DESIGNATION R6) 3PCS, 4.5V
EPJ301
AM IF Q1 MW FREQUENCY COVERAGE CT2 11 AM RF IN L4 MW OSC 6 AM OSC FM 3 DISCRI B + 27 CF4 VOL 5 Q4
IC2 3.0V REG 1 VOUT VIN 2
( EARPHONE ) SP301 ( SPEAKER )
LW FREQUENCY COVERAGE LW TRACKING Q3
CT4
RV1 VOL NF 4
+
7 9
AFC REG
BAND(MW/LW) Q2 BUFFER
BAND(MW/LW)
BEEP MUTE BAND(FM/AM)
VT
POWER B+
CN1
CN2
VT VCOL VCOH VDD VDET GND
Signal Path : FM
KEY BOARD
LCD101 15 1 19 16
IC101 DIGITAL TUNING SYSTEM CONTROL 35 LCD0 49 LCD14 VDD 23 BAND(MW/LW)
W101 VDD
W102
S101-S114 KEY MATRIX
4 BAND(FM/AM) 5 31 COM0 POWER 2 34 COM3 MUTE 3 BEEP 52 6 KEY SCAN0 EO 19 VCOL 20 9 KEY SCAN3 10 KEY RET0 13 KEY RET3 BATT LOW 53 VCOH 21 Q101 AMP
Q153,Q154,T101 (+13V) DC/DC CONVERTER
Q151,Q152 TUNING CONTROL
IC102 +3.2V VOLTAGE DET. 1 VOUT VDD 2
S115
OFF R HOLD ON
VDD 51 INT CE 50 1 VOUT VDD 2
XOUT 24 XIN 25
IC103 +2.5V VOLTAGE DET. X101 75kHz
7
7
ICF-M410L
4-2. SCHEMATIC DIAGRAM
· See page 6 for Wavefoms. · See page 10 for IC Pin Function Description. · See page 10 for IC Block Diagrams.
IC B/D
8
8
ICF-M410L
4-3. PRINTED WIRING BOARD
1 A
2
S115 HOLD
3
4
5
6
7
8
9
10
· Semiconductor
11
· Semiconductor
ON t OFF
KEY BOARD
S102 POWER S106 1 5
Location MAIN BOARD
Ref. No. Location G-1 G-3 F-4 G-4 G-6 F-7 G-7 G-6 G-5 G-7 F-3 G-5 F-3 H-2 F-6 G-6 G-7 F7 D1 D2 D3 D4 D5 D6 D7 D8 IC1 IC2 Q1 Q2 Q3 Q4 Q5 Q7 Q8 Q9
Location KEY BOARD
Ref. No. D101 D102 IC101 IC102 IC103 Q101 Q151 Q152 Q153 Q154 Location D-4 D-4 B-2 B-4 B-3 B-3 B-3 B-3 C-4 D-4
LCD101
10 15 19
R127 R126 R125 R124 R123 R122 R121 R120 R119 R118 R117 R116
TP113 (RFGND) TP112 (VCOH) TP107 (VCOL)
C118 R136 R139 C117 R141 R134 R133 R132 R131 R130 R129 R128
R142
R138
S105
C116 C114 C113
B
JW122 29 28
C110
C115
C119 R140 R137 R101
E
JW102
JW101
CJ102
43 42
R146 C136 R148 Q101 C135
56 1
IC101
14 15
X101
TP110 (3V)
R142
CJ101 C159 R149 C137
1
C123
CJ107
1
R147 JW121
W101
R151 C158 C111 C152 C112
C122
C109
Q151
Q152
R105
R108
C121
R104
R109
JW112
TP115 (ED)
E
E
4 3 1 2
R152 C151
(VDET)
1 2
R144 R143 JW107
JW106
JW105
JC103
C103 R107 JC105
JC106
JW110
JW115
JW109
TP102 (POWER)
S108
SLEEP
C101
JW108
C
S103
JW114
JW113
STANDBY
TP103 (MUTING)
R110
TP104 TP105 (MW/SW) (FM/AM)
TP111 TP101 (GND) (+B)
JW104
C105 C104 C108 R112 C102 C104 C107 R111
R106
S101 S107 CLOCK
C134 C133
C120
R102 R103
JW111
C121
S104
C132 JW103 C131
TP109 (GND)
IC103 4 3 TP108
IC102
W102
R115
TP114 (VT)
JW117
R152
S110
JW116
S111
PRESET TUNING 1
R157 Q153 R156
JW119
L101
TP106 (BEEP)
T101
C154
S112
JW18
JW120
PRESET TUNING 3
PRESET TUNING 2
C156
E
E
S113
S114
PRESET TUNING 4
R158 C157 R154 K TP116 (13V)
D
S109 BAND
PRESET TUNING 5
D102 C155 D101 R155
Q154
K
C153 11 (11)
SELECT/
PRESET
1-681-634-
E
MAIN BOARD
E
ANT102 MW/LW FERRITE-ROD ANTENNA TP13 (BEP) JW12 CT3
E TP22 (RFGND)
JACK BOARD
EPJ301 CN1
1
BPF1
1
TP19 (VT) JW9 CF2 T1 TP11 (MW/LW)
JW4 JW5
TP12 (MUTE) TP10 (FM/AM)
CN2 TP17 1
(RFGND)
F
ANT101 FM TELESCOPIC ANTENNA
C
B
C
B
TP14 (VCOL)
K
3 15
L6 CT1 GRN
K 1 4 8
CF3
16
JW6
C K
E B
C16 CT4 L7 NTL JW10 RED
TP9 (POWER) 7 E C C B C TP15 (VDET) E K B K
C302
7
SP301 JW1
TP16 (3V) TP3 (+B)
IC1
CF1
K B E
JW301
K
G
5
TP2 (DET)
TP20 (MET) C22 C23
JW2
DCJ301 DC IN 4.5V
K W1 5 5 W301
BLK
TP8 L5 (+B)
CT2 L4 CF4 C27 TP21 (+B) C29
1 30
IC2
5 4
TP4 (VDD)
1 TP5 2 (GND) 3 TP7 (SP+) JW3 1 1
11 11 (11)
1-681-636K DRY BATTERY SIZE "AA" (IEC DESIGNATION R6) 3PCS, 4.5V
RV1 MIN VOL
JW11
E
C18
TP6 (GND)
C32
(11)
H
MAX
C B
JW8
TP18 (VCOH)
TP1 (GND)
JW7
1-681-635-
9
9
ICF-M410L
4-4.
IC PIN FUNCTION DESCRIPTION
Pin Name VOUT POWER MUTING BAND(MW/SW) BAND(FM/AM) KEY SCAN0 KEY SCAN1 KEY SCAN2 KEY SCAN3 KEY RET0 KEY RET1 KEY RET2 KEY RET3 NC NC NC NC GND EO VCOL VCOH REG 0 VDD X OUT X IN REG 1 REG LCD0 CAP LCD0 CAP LCD1 REG LCD1 COM 0 COM 1 COM 2 COM 3 LCD 0 - 14 CE INT BEEP BAT LOW NC INITIAL NC I/O O O O O O O O O O I I I I -- -- -- -- -- O I I O -- O I O O -- -- O O O O O O I I O I -- I -- For pull-up of INITIAL, L:CE = at L Radio power control signal output. Description
4-5. IC BLOCK DIAGRAM
IC1 CXA1019S
· IC101 uPD17072GB-565-1A7(DIGITAL TUNING SYSTEM CONTROL) Pin No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35-49 50 51 52 53 54 55 56
DET OUT
AFC AGC
AFC AGC
Key source signal output. Key source signal output. Key source signal output. Key source signal output. Key return signal input. Key return signal input. Key return signal input. Key return signal input. Not used. Not used. Not used. Not used. Ground. Error signal output. AM VCO (local oscillation) frequency input. FM VCO (local oscillation) frequency input. Regulater for PLL output. Power supply (+3V). Pin for connecting crystal resonator for system clock. Pin for connecting crystal resonator for system clock. Regulater for PLL output. LCD drive voltage output. Pin for capacitor connection for LCD drive voltage. Pin for capacitor connection for LCD drive voltage. LCD drive voltage output. LCD common signal output. LCD common signal output. LCD common signal output. LCD common signal output. LCD segment signal output. Chip select emable input. Hold input. L:ON BEEP signal output. Low voltage detect signal input. Not used. Connected to L. Not used.
30 29 28 27 26 25
24
23
22
21
20
19
N.C
"Band select signal output. L:FM/TV, H:AM"
18 17 16
AM IF DET AGC
TUNING METER FM IF
AF POWER AMP
AM FE FM DISCRIMINATOR FM FE
1
2
3
4
5
6
7
8
9
10
11 12 13 14
FM IF IN
VCC RIPPLE FILTER AF IN
AF OUT
METER
IF GND
"Band select signal output. L:MW, H:LW/SW"
GND GND
FM RF IN
REG OUT
FE GND
FM RF
FM DISCRI
AM RF IN
AM OSC
FM OSC
10
10
FM/AM IF OUT
GND
GND
NF
VOL
AFC
N.C
AM IF IN FM/AM BAND SELECT
15
Muting signal output.
ICF-M410L SECTION 5 EXPLODED VIEWS
NOTE: · -XX, -X mean standardized parts, so they may have some differences from the original one. · Items marked "*" are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. · · The mechanical parts with no reference number in the exploded views are not supplied. Hardware (# mark) list and accessories and packing materials are given in the last of this parts list.
ANT101
not supplied
10
ANT102
20
9 11
23 2
21 4 5
22 1 3 20
SP301
8 7 20 6 15 19 20 16 17
13 12
18
14
24
Ref. No. 1 2 3 * 4 5 6 7 8 * 9 10 11 12 13 14
Part No. 3-228-706-01 3-228-694-01 3-228-700-01 A-3062-438-A 3-228-693-01 3-228-707-01 3-228-708-01 3-380-333-21 A-3021-467-A 3-228-696-01 3-370-475-01 3-228-692-01 3-228-709-01 3-228-704-01
Description TERMINAL (+), BATTERY SIDE PANEL (L) KNOB (HOLD) KEY BOARD, COMPLETE CHASSIS TERMINAL (-), BATTERY SPRING (JOG) KNOB MAIN BOARD, COMPLETE BATTERY COVER SCREW (NYLOCK +B 3X6) CABINET REAR PLATE, CONTACT ARM (JOG)
Remarks
Ref. No. 15 16 17 18 19 20 21 22 23 24
Part No. 3-228-699-01 3-228-703-01 3-228-695-01 3-228-698-01 3-228-701-01 7-685-105-19 7-685-134-19 7-685-549-14 1-681-636-11 X-3380-863-1
Description BUTTON (KEY) KNOB (JOG) SIDE PANEL (R) BUTTON (PRESET) BUTTON (POWER) SCREW +P 2X8 TYPE2 NON-SLIT SCREW +P 2.6X8 TYPE2 NON-SLIT SCREW +BTP 3X14 TYPE2 N-S JACK BOARD CABINET (FRONT) SUB ASSY
Remarks
ANT101 1-501-222-31 ANTENNA, TELESCOPIC ANT102 1-424-815-11 COIL, FERRITE-ROD ANTENNA SP301 1-544-793-11 SPEAKER (7.7cm)
11
ICF-M410L JACK KEY
· ·
SECTION 6 ELECTRICAL PARTS LIST
CAPACITORS: uF: µF RESISTORS All resistors are in ohms. METAL: metal-film resistor METAL OXIDE: Metal Oxide-film resistor F: nonflammable COILS uH: µH · SEMICONDUCTORS In each case, u: µ, for example: uA...: µA... , uPA... , µPA... , uPB... , µPB... , uPC... , µPC... , uPD..., µPD...
When indicating parts by reference number, please include the board name. The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified.
NOTE: · Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. · -XX, -X mean standardized parts, so they may have some difference from the original one. · Items marked "*" are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. Ref. No. Part No. Description
·
Remarks
Ref. No. C132 C135 C137 C151 C152
Part No. 1-115-416-11 1-162-927-11 1-115-156-11 1-162-970-11 1-128-934-11 1-124-255-11 1-162-915-11 1-124-227-61 1-164-156-11 1-162-970-11
Description CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP < DIODE > 0.001uF 100PF 1uF 0.01uF 0.33uF 1uF 10PF 10uF 0.1uF 0.01uF
Remarks 5.00% 25V 5% 50V 10V 10% 25V 20% 10V 20% 0.5PF 50V 50V 10V 25V 25V
1-681-636-11 JACK BOARD *********** < CAPACITOR > C302 1-126-926-11 ELECT < DIODE > D301 D302 D303 8-719-975-40 DIODE RB411D-T146 8-719-988-61 DIODE 1SS355TE-17 8-719-069-29 DIODE RB520S-30TE61 < JACK > DCJ301 1-580-681-21 JACK,DC(POLARITY UNIFIED TYPE)(DC IN 4.5V) EPJ301 1-563-836-21 JACK(@) < RESISTOR > R301 1-216-809-11 METAL CHIP 100 5% 1/16W R302 1-216-805-11 METAL CHIP 47 5% 1/16W ************************************************************ * A-3062-438-A KEY BOARD, COMPLETE ******************** 3-228-702-01 3-228-710-01 3-228-711-01 3-230-978-01 3-230-979-01 HOLDER (LCD) SHIELD CASE (LCD) SHIELD PLATE (A) SHIELD, PLATE (B) SHIELD, PLATE (C) < CAPACITOR > 1000uF 20.00% 10V
C153 C155 C156 C157 C159
10%
D101 D102
8-719-988-61 DIODE 1SS355TE-17 8-719-420-87 DIODE MA8130-TX < IC >
IC101 IC102 IC103
6-800-549-01 IC uPD17072GB-565-1A7 8-759-489-98 IC S-80832ANNP-EDW-T2 8-759-479-03 IC S-80825ANNP-EDN-T2 < JUMPER RESISTOR >
* * * *
JC101 JC102 JC103 JC104 JC105 JC106 JC107
1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
0 0 0 0 0 0 0
5% 5% 5% 5% 5% 5% 5%
1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W
1-216-864-11 METAL CHIP 1-216-864-11 METAL CHIP < COIL >
C101 C102 C103 C104 C109 C110 C111 C112 C113 C114 C115 C116 C117 C118 C119 C120 C121 C123 C124 C131
1-164-315-11 1-164-315-11 1-164-315-11 1-164-315-11 1-164-156-11 1-115-156-11 1-162-922-11 1-162-917-11 1-115-156-11 1-115-156-11 1-164-156-11 1-115-416-11 1-164-156-11 1-162-970-11 1-164-156-11 1-162-970-11 1-162-970-11 1-124-224-11 1-115-416-11 1-162-970-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP
470PF 470PF 470PF 470PF 0.1uF 1uF 39PF 15PF 1uF 1uF 0.1uF 0.001uF 0.1uF 0.01uF 0.1uF 0.01uF 0.01uF 47uF 0.001uF 0.01uF
5.00% 5.00% 5.00% 5.00%
50V 50V 50V 50V 25V
L101 L102
1-412-963-11 INDUCTOR 1-412-963-11 INDUCTOR
100uH 100uH
< LIQUID CRYSTAL DISPLAY > LCD101 1-804-264-11 DISPLAY PANEL, LIQUID CRYSTAL < TRANSISTOR > Q101 Q151 Q152 Q153 Q154 8-729-423-52 8-729-402-32 8-729-402-32 8-729-402-32 8-729-402-32 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR < RESISTOR > R101 R102 R103 R104 R105 1-216-821-11 1-216-833-11 1-216-821-11 1-216-821-11 1-216-821-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 1K 10K 1K 1K 1K 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W 2SC3931-C-TX 2SD1819A-R-TX 2SD1819A-R-TX 2SD1819A-R-TX 2SD1819A-R-TX
10V 5.00% 50V 5% 50V 10V 10V 25V 5.00% 25V 25V 10% 25V 25V 10% 10% 25V 25V 6.3V 5.00% 25V 10% 25V
12
ICF-M410L
KEY
Ref. No. R106 R107 R108 R109 R110 R111 R112 R115 R116 R117 R118 R119 R120 R121 R122 R123 R124 R125 R126 R127 R128 R129 R130 R131 R132 R133 R134 R136 R137 R139 R140 R141 R142 R143 R144 R146 R147 R148 R149 R151 R152 R154 R155 R156 R157 R158 Part No. 1-216-821-11 1-216-821-11 1-216-821-11 1-216-821-11 1-216-821-11 1-216-821-11 1-216-821-11 1-216-837-11 1-216-845-11 1-216-845-11 1-216-845-11 1-216-845-11 1-216-845-11 1-216-845-11 1-216-845-11 1-216-845-11 1-216-845-11 1-216-845-11 1-216-845-11 1-216-845-11 1-216-845-11 1-216-845-11 1-216-845-11 1-216-845-11 1-216-845-11 1-216-845-11 1-216-845-11 1-216-841-11 1-216-845-11 1-216-833-11 1-216-833-11 1-216-833-11 1-216-833-11 1-216-853-11 1-216-853-11 1-216-845-11 1-216-817-11 1-216-805-11 1-216-797-11 1-216-833-11 1-216-833-11 1-216-841-11 1-216-821-11 1-216-845-11 1-216-841-11 Description METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 1K 1K 1K 1K 1K 1K 1K 22K 100K 100K 100K 100K 100K 100K 100K 100K 100K 100K 100K 100K 100K 100K 100K 100K 100K 100K 100K 47K 100K 10K 10K 10K 10K 470K 470K 100K 470 47 10 10K 10K 47K 1K 100K 47K 100K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% Remarks 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W Ref. No.
S111 S112 S113 S114 S115
MAIN
Remarks
Part No.
1-762-196-21 1-762-196-21 1-762-196-21 1-762-196-21 1-553-977-00
Description
SWITCH, TACT(PRESET TUNING 1) SWITCH, TACT(PRESET TUNING 3) SWITCH, TACT(PRESET TUNING 5) SWITCH, TACT(PRESET TUNING 4) SWITCH, SLIDE(HOLD .) < TRANSFORMER >
T101
1-449-138-11 TRANSFORMER, DC-DC CONVERTER < VIBRATOR >
X101 1-567-769-11 VIBRATOR, CRYSTAL 75kHz ************************************************************ * A-3021-467-A MAIN BOARD, COMPLETE ********************* < FILTER > BPF1 1-236-022-11 FILTER, BAND PASS < CAPACITOR > C1 C2 C4 C5 C6 C7 C8 C9 C10 C11 C12 C13 C14 C15 C16 C17 C18 C19 C20 C21 C22 C23 C24 C25 C26 C27 C28 C29 C30 C31 C32 C33 C36 C37 C39 C40 C41 C42 C43 C44 1-164-315-11 1-162-928-11 1-115-156-11 1-115-416-11 1-115-416-11 1-162-915-11 1-162-905-11 1-162-927-11 1-162-970-11 1-164-393-11 1-162-916-11 1-164-391-11 1-115-416-11 1-162-970-11 1-107-795-11 1-115-156-11 1-124-231-11 1-115-416-11 1-162-970-11 1-115-156-11 1-124-231-11 1-124-227-11 1-162-995-11 1-164-361-11 1-164-156-11 1-124-228-11 1-115-156-11 1-104-655-11 1-115-156-11 1-162-970-11 1-126-518-11 1-162-970-11 1-164-156-11 1-115-156-11 1-164-156-11 1-115-416-11 1-115-416-11 1-115-416-11 1-115-416-11 1-115-416-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 470PF 120PF 1uF 0.001uF 0.001uF 10PF 1PF 100PF 0.01uF 430PF 12PF 330PF 0.001uF 0.01uF 100uF 1uF 4.7uF 0.001uF 0.01uF 1uF 4.7uF 10uF 0.022uF 0.047uF 0.1uF 22uF 1uF 470uF 1uF 0.01uF 470uF 0.01uF 0.1uF 1uF 0.1uF 0.001uF 0.001uF 0.001uF 0.001uF 0.001uF 5.00% 50V 5% 50V 10V 5.00% 25V 5.00% 25V 0.5PF 0.25PF 5% 10% 5.00% 5% 5% 5.00% 10% 50V 50V 50V 25V 50V 50V 50V 25V 25V 4V
10V 20.00% 16V 5.00% 25V 10% 25V 10V 20.00% 16V 10V 50V 16V 25V 10V 10V 20.00% 6.3V 10V 10% 25V 20.00% 4V 10% 25V 25V 10V 25V 5.00% 5.00% 5.00% 5.00% 5.00% 25V 25V 25V 25V 25V
1-216-845-11 METAL CHIP < SWITCH >
S101 S102 S103 S104 S105 S106 S107 S108 S109 S110
1-762-196-21 1-572-596-11 1-762-196-21 1-762-365-21 1-762-365-21 1-762-365-21 1-762-196-21 1-762-365-21 1-762-196-21 1-762-196-21
SWITCH, TACT(CLOCK) SWITCH, KEY BOARD(POWER) SWITCH, TACT(SLEEP) SWITCH, TACTILE( ) SWITCH, TACTILE( ) SWITCH, TACTILE( ) SWITCH, TACT(STANDBY) SWITCH, TACTILE( ) SWITCH, TACT( BAND) SWITCH, TACT(PRESET TUNING 2)
13
ICF-M410L MAIN
Ref. No. C45 C46 C47 C48 C49 C51 Part No. 1-115-416-11 1-115-416-11 1-115-416-11 1-115-416-11 1-162-907-11 Description CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.001uF 0.001uF 0.001uF 0.001uF 2PF 0.001uF 5.00% 5.00% 5.00% 5.00% 0.25PF Remarks 25V 25V 25V 25V 50V Ref. No. Part No. Description < RESISTOR > R2 R3 R4 R5 R7 R8 R9 R10 R11 R12 R13 R14 R15 R16 R17 R18 R19 R20 R21 R22 1-216-839-11 1-216-815-11 1-216-845-11 1-216-845-11 1-216-837-11 1-216-833-11 1-216-857-11 1-216-821-11 1-216-805-11 1-216-813-11 1-216-841-11 1-216-837-11 1-216-825-11 1-216-815-11 1-216-833-11 1-216-825-11 1-216-805-11 1-216-845-11 1-216-821-11 1-216-849-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 33K 330 100K 100K 22K 10K 1M 1K 47 220 4.7K 22K 2.2K 330 10K 2.2K 47 100K 1K 220K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W Remarks
1-115-416-11 CERAMIC CHIP < FILTER >
5.00% 25V
CF1 CF2 CF3 CF4
1-578-677-21 1-577-600-11 1-577-600-11 1-577-600-11
FILTER, CRYSTAL FILTER, CERAMIC FILTER, CERAMIC FILTER, CERAMIC < CONNECTOR >
* CN1 * CN2
1-568-273-11 SOCKET, CONNECTOR 7P 1-568-273-11 SOCKET, CONNECTOR 7P < TRIMMER >
CT1 CT2 CT3 CT4
1-141-601-21 1-141-604-11 1-141-601-21 1-141-622-11
CAP, ADJ CAP, ADJ CAP, ADJ CAP, ADJ 50PF < DIODE >
< VARIABLE RESISTOR > RV1 D1 D2 D3 D4 D5 D6 D7 D8 8-719-062-51 8-719-023-99 8-719-084-67 8-719-084-67 8-719-988-61 DIODE DIODE DIODE DIODE DIODE 1PS226-115 KV1563MTL-2,3 HVU202ATRU HVU202ATRU 1SS355TE-17 1-223-450-11 RES, VAR, CARBON 50K(VOL w) < TRANSFORMER > T1 1-404-902-11 TRANSFORMER, IF ************************************************************ MISCELLANEOUS ************** ANT101 1-501-222-31 ANTENNA, TELESCOPIC ANT102 1-424-815-11 COIL, FERRITE-ROD ANTENNA SP301 1-544-793-11 SPEAKER (7.7cm)
8-719-988-61 DIODE 1SS355TE-17 8-719-069-29 DIODE RB520S-30TE61 8-719-988-61 DIODE 1SS355TE-17 < IC >
IC1 IC2
8-752-055-05 IC CXA1019S 8-759-198-63 IC S-81230SG-QB-T1 < COIL > ACCESSORIES & PACKING MATERIALS ******************************* 3-229-096-11 MANUAL, INSTRUCTION (ENGLISH, FRENCH, SPANISH, POLISH) 3-229-096-21 MANUAL, INSTRUCTION (GERMAN, DUTCH, SWEDISH, ITALIAN,FINNISH)
L3 L4 L5 L6 L7
1-414-690-11 1-406-485-11 1-414-187-11 1-406-540-11 1-428-290-11
INDUCTOR 82nH COIL (OSC) INDUCTOR 47uH COIL, AIR-CORE COIL, AIR-CORE < TRANSISTOR >
Q1 Q2 Q3 Q4 Q5 Q7 Q8 Q9
8-729-402-32 8-729-423-52 8-729-402-32 8-729-800-71 8-729-029-15
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
2SD1819A-R-TX 2SC3931-C-TX 2SD1819A-R-TX 2SB815B6B7-TA DTC144TUA-T106 DTC144TUA-T106 2SB815B6B7-TA DTC144TUA-T106
8-729-029-15 TRANSISTOR 8-729-800-71 TRANSISTOR 8-729-029-15 TRANSISTOR
14
ICF-M410L
MEMO
15
ICF-M410L
REVISION HISTORY
Clicking the version allows you to jump to the revised page. Also, clicking the version at the upper right on the revised page allows you to jump to the next revised page. Ver. 1.0 Date 2001.05 New Description of Revision