Text preview for : Service-Manual_Sony_Car-Stereo_XR-C440E_XR-C450E_XR-C440_XR-C450.pdf part of Sony XR-C440E_XR-C450E_XR-C440_XR-C450 Service-Manual_Sony_Car-Stereo_XR-C440E_XR-C450E_XR-C440_XR-C450.
Back to : Service-Manual_Sony_Car-S | Home
XR-C440/C450
SERVICE MANUAL
Ver 1.1 2001.08
US Model Canadian Model
XR-C450
E Model
XR-C440/C450
Photo: XR-C450 Refer to RM-X2S/X3S SERVICE MANUAL (9-960-039-) issued previously for information of remote commander (RM-X2S) supplied with XR-C440.
Dolby noise reduction manufactured under license from Dolby Laboratories Licensing Corporation. "DOLBY" and the double-D symbol a are trademarks of Dolby Laboratories Licensing Corporation.
Model Name Using Similar Mechanism Tape Transport Mechanism Type
NEW MG-25C-136
SPECIFICATIONS
AUDIO POWER SPECIFICATIONS (US model) POWER OUTPUT AND TOTAL HARMONIC DISTORTION 12 watts per channel minimum continuous average power into 4 ohms, 4 channels driven from 20 Hz to 20 kHz with no more than 1% total harmonic distortion.
Cassette player section Tape track 4-track 2-channel stereo Wow and flutter 0.08% (WRMS) Frequency response 30 18,000 Hz (C440/C450: US, Canadian) 30 20,000 Hz (C450: E, Saudi Arabia) Signal-to-noise ratio Cassette type TYPE II, IV TYPE I Tuner section FM Tuning range Dolby B NR 67 dB 64 dB Dolby NR off 61 dB 58 dB Antenna terminal External antenna connector Intermediate frequency 10.7 MHz Usable sensitivity 8 dBf Selectivity 75 dB at 400 kHz Signal-to-noise ratio 65 dB (stereo), 68 dB (mono) Harmonic distortion at 1 kHz 0.5% (stereo), 0.3% (mono) Separation 35 dB at 1 kHz Frequency response 30 15,000 Hz Capture ratio 2 dB (C450: E, Saudi Arabia) 4 dB (C440/C450: US, Canadian) -- Continued on next page --
US, Canadian model: 87.5 107.9 MHz E, Saudi Arabia model: 50 kHz/200 kHz switchable 87.5 108.0 MHz (at 50 kHz step) 87.5 107.9 MHz (at 200 kHz step)
XR-C440/C450: US, Canadian Model
FM/AM CASSETTE CAR STEREO
XR-C450: E Model
FM/MW/SW CASSETTE CAR STEREO
9-925-536-12
2001H0500-1 C 2001.8
Sony Corporation
e Vehicle Company Shinagawa Tec Service Manual Production Group
AM (MW) Tuning range
TABLE OF CONTENTS
US, Canadian model: 530 1,710 MHz E, Saudi Arabia model: 9 kHz/10 kHz switchable 531 1,602 kHz (at 9 kHz step) 530 1,710 kHz (at 10 kHz step)
1.
GENERAL
Location of Controls (XR-C440) ....................................... Location of Controls (XR-C450) ....................................... Installation (XR-C440/XR-C450: E, saudi Arabia) ........... Installation (XR-C450: US, Canadian) .............................. Installing the rotary remote (XR-C440) ............................ Connection (XR-C440) ..................................................... Connection (XR-C450) ..................................................... 3 4 6 7 8 9 11
SW (C450: E, Saudi Arabia) Tuning range SW tuning interval: SW1: 2,940 7,735 kHz SW2: 9,500 18,135 kHz (except for 10,140 11,575 kHz) Antenna terminal External antenna connector Intermediate frequency 10.71 MHz/450 kHz Sensitivity 30 µV (C440/C450: US, Canadian) 40 µV (C450: E, Saudi Arabia)
Power amplifier section Outputs Speaker outputs (sure seal connectors) Speaker impedance 4 8 ohms Maximum power output 35 W × 4 (at 4 ohms) General Outputs
2. 3. 4. 5.
DISASSEMBLY ............................................................ 14 ASSEMBLY OF MECHANISM DECK ............. 16 MECHANICAL ADJUSTMENTS ......................... 19 ELECTRICAL ADJUSTMENTS
Test Mode .......................................................................... 19 Tape Deck Section ............................................................. 20 Tuner Section (XR-C450: E, Saudi Arabia) ...................... 20
6.
Power antenna control lead Line out Rear (1) Front (1) (C450) Bass ħ8 dB at 100 Hz Treble ħ8 dB at 100 Hz 12 V DC car battery (negative ground) Approx. 188 × 58 × 181 mmm (7 1/2 × 2 3/8 × 7 1/4 in.) (w / h / d) Approx. 182 × 53 × 164 mmm (7 1/4 × 2 1/8 × 6 1/2 in.) (w / h / d) Approx. 1.2 kg (2 lb. 10 oz.) Parts for installation and connections (1 set) Front panel case (1) Rotary remote RM-X2S (C440) Wireless Remote Commander RM-X40 (C450: E, Saudi Arabia)
DIAGRAMS
Printed Wiring Board Main Section .............................. Schematic Diagram Main Section ................................ Printed Wiring Board Key Section (XR-C440) ............ Schematic Diagram Key Section (XR-C440) ............... Printed Wiring Board Key Section (XR-C450) ............ Schematic Diagram Key Section (XR-C450) ............... IC Pin Function Description .............................................. 23 25 29 31 33 35 39
Tone controls Power requirements Dimensions
6-1. 6-2. 6-3. 6-4. 6-5. 6-6. 6-7.
7. 8.
EXPLODED VIEWS .................................................. 41 ELECTRICAL PARTS LIST .................................. 45
Mounting dimensions
Mass Supplied accessories
Design and specifications are subject to change without notice.
Flexible Circuit Board Repairing · Keep the temperature of the soldering iron around 270 ° C during repairing. · Do not touch the soldering iron on the same conductor of the circuit board (within 3 times). · Be careful not to apply force on the conductor when soldering or unsoldering . Notes on chip component replacement · Never reuse a disconnected chip component. · Notice that the minus side of a tantalum capacitor may be damaged by heat.
2
SECTION 1 GENERAL
This section is extracted from instruction manual.
(XR-C440)
3
(XR-C450)
4
(XR-C450: E, Saudi Arabia)
5
(XR-C440/XR-C450: E, Saudi Arabia)
6
(XR-C450: US, Canadian)
7
8
(XR-C440)
9
10
(XR-C450)
(E, Saudi Arabia model)
11
(E, Saudi Arabia model)
12
(US, Canadian model)
(E, Saudi Arabia model)
13
SECTION 2 DISASSEMBLY
Note: Follow the disassembly procedure in the numerical order given.
FRONT PANEL ASS'Y
1 Push the button (release). A 2 Remove the front panel ass'y to the direction of the arrow A.
COVER ASS'Y
2
1
3 cover ass'y
2
1
14
SUB PANEL, MECHANISM DECK
5 screw (PTT2.6 × 6)
3 connector (CN302) 6 mechanism deck
4 flexible flat cable (CN301)
2 sub panel
1 three screws (PTT2.6 × 8) 1 three screws (PTT2.6 × 8)
MAIN BOARD, HEAT SINK
2 two ground point screws
4 nine screws (PTT2.6 × 10)
1 screw (PTT2.6 × 8)
5 heat sink
3 main board
1 two screws (PTT2.6 × 8)
15
SECTION 3 ASSEMBLY OF MECHANISM DECK
Note: Follow the assembly procedure in the numerical order given.
HOUSING
5 Fit projection on C part. 2 Install the hanger onto two claws of the housing. 4 Fit claw on B part.
7 Holder the hanger by bending the claw. 1 Install the catch to the hanger.
hanger
6 Fit projection on D part.
3 Put the housing under A part.
housing
C part 8 Hold the hanger by bending the claw.
D part
A part
B part
ARM (SUCTION)
2 Move the arm (suction) in the arrow direction and fit on projection.
projection
1 Fit the arm (suction) on the shaft.
16
LEVER (LDG-A) / (LDG-B)
shaft A shaft A shaft B shaft C shaft B
1 Fit the lever (LDG-A) on shafts A C and install it.
4 type-E stop ring 2.0
2 Pull the lever in the arrow direction. 3 Fit the lever (LDG-B) on shafts A and B and install it.
GEAR (LDG-FT)
5 polyethyene washer 5 gear (LDG-FT)
1 tension spring (lever LDG)
gear (LDG-D) hole
2 Move the lever (LDG-B) in the arrow direction.
hole
lever (LDG-A) gear (LDG-FB)
3 Align hole in the gear (LDG-D) with hole the lever (LDG-A).
17
GUIDE (C)
2 guide (C)
1 three claws
18
SECTION 4 MECHANICAL ADJUSTMENTS
1. Clean the following parts with a denatured-alcohol-moistened swab: playback head pinch roller rubber belt capstan idles 2. Demagnetize the playback head with a head demagnetizer. 3. Do not use a magnetized screwdriver for the adjustments. 4. After the adjustments, apply suitable locking compound to the parts adjusted. 5. The adjustments should be performed with the power supply voltage unless otherwise noted. · Torque Measurement Mode Forward Forward Back Tension Reverse Reverse Back Tension FF, REW Torqu Meter CQ-102C CQ-102C CQ-102RC CA-102RC CQ-201B Meter Reading 30 - 65 g·cm (0.42 - 0.90 oz·inch) 0.5 - 4.5g·cm (0.01 - 0.06 oz·inch) 30 - 65 g·cm (0.42 - 0.90 oz·inch) 0.5 - 4.5g·cm (0.01 - 0.06 oz·inch) 60 - 200 g·cm (0.83 - 2.78 oz·inch)
SECTION 5 ELECTRICAL ADJUSTMENTS
TEST MODE This set have the test mode function. In the test mode, FM Auto Scan/Stop Level and AM (MW) Auto Scan/Stop Level adjustments can be performed easier than it in ordinary procedure. 1. Set the "OFF" mode. 2. Push the preset 4 button. 3. Push the preset 5 button. 4. Press the preset 1 button for more than two seconds. 5. Then the display indicates all lights, the test mode is set. 1. Push the "OFF" button.
· Tape Tension Measurement Mode Forward Reverse Torqu Meter CQ-403A CQ-403R Meter Reading more than 90 g (more than 3.18 oz) more than 90 g (more than 3.18 oz)
19
See the adjustment location from on page 22 for the adjustment. TAPE DECK SECTION 0 dB=0.775 V
TUNER SECTION (XR-C450: E, Saudi Arabia model only) 0dB=1µV Cautions during repair When the tuner unit is defective, replace it by a new one because its internal block is difficult to repair.
Tape Speed Adjustment Procedure: 1. Put the set into the FWD PB mode.
speed checker or frequency counter 10 k
test tape WS-48A (3 kHz, 0 dB) set
FM Auto Scan/Stop Level Adjustment Setting: SOURCE button : FM FREQUENCY SELECT switch : 10 k
FM RF signal generator antenna jack (J1) 0.01 µF set
LINE OUT
+
Specification: Constant speed Speed checker 1.5 to +2.5% Adjustment Location: See page 22. DOLBY Level Adjustment Setting: Preset 3 (DOLBY) button SEL (BAS) button SEL (TRE) button SEL (BAL) button SEL (FAD) button SEL (VOL) button D-BASS control Frequency counter 2,955 to 3,075Hz
Carrier frequency Output level Mode Modulation
: 97.9 MHz : 22 dB (12.6 µV) : mono : 1 kHz, 75 kHz deviation
Procedure: 1. Set to the test mode. (See page 19). 2. Push the SOURCE button and set to FM. OFF Center Center Center Center Maximum OFF
L-CH: IC301 7 R-CH: IC301@˘ level meter
+
: : : : : : :
Display
FM
3. Push the preset 3 button. Display
SHUF1
test tape P-4-D400 (400Hz, 0dB)
main board TP (DOLBY )
FM
SHUF1
set main board TP (GND)
Procedure: 1. Put the set into the FWD PB mode. 2. Adjust RV231 (L-CH) and RV131 (R-CH) so that the level meter reading is 6ħ0.5 dB (0.37 to 0.41 V). Adjustment Location: See page 22.
4. Adjust with the volume RV2 on TU1 so that the "FM" indication turns to "FM0" indication on the display window. But, in case of already indicated "FM0", turn the RV2 so that put out light "0" indication and adjustment. Display
SHUF1
Adjustment Location: See page 22.
20
FM Noise Focus Adjustment Setting: SOURCE button : FM FREQUENCY SELECT switch : 10 k
FM RF signal generator antenna jack (J1) 0.01 µF set Carrier frequency Output level Mode Modulation : 97.9 MHz LINE OUT : 60 dB (1 mV) : mono : 1 kHz, 75 kHz deviation 10 k level meter
AM (MW) Auto Scan/Stop Level Adjustment Setting: SOURCE and MODE button : MW FREQUENCY SELECT switch : 10 k
30 15 pF
+
65 pF
AM RF signal generator AM dummy antenna (50 )
Procedure : 1. Tune the 97.9 MHz 2. The then output level is supposing that (A) dB. 3. Adjust with the volume RV3 on TU1 so that the output level is (A) 32 dB then signal generator input set to 20 dB. Adjustment Location: See page 22. FM Stereo Separation Adjustment Setting: SOURCE button : FM FREQUENCY SELECT switch : 10 k
FM RF signal generator antenna jack (J1) 0.01 µF set Carrier frequency Output level Mode Modulation : 97.9 MHz LINE OUT : 70 dB (3.2 mV) : stereo : main: 1 kHz, 20 kHz deviation (26%) sub: 1 kHz, 20 kHz deviation (26%) 19 kHz pilot: 7.5 kHz deviation (10%) 10 k level meter
set antenna jack (J1)
Carrier frequency : 1000 kHz 30% amplitude modulation by 400 Hz signal Output level : 33 dB (44.7 µV)
Procedure: 1. Set to the test mode. (See page 19.) 2. Push the SOURCE button and set to FM. 3. Push the MODE button and set to MW. Display
MW
+
1
Display
SHUF1
4. Push the preset 3 button.
MW
FM Stereo signal generator output channel L-CH R-CH R-CH L-CH
Level meter connection L-CH L-CH R-CH R-CH
Level meter reading (dB) A B Adjust RV4 on TU1 for minimum reading. C D Adjust RV4 on TU1 for minimum reading.
3
1
Display
SHUF1
5. Adjust with the volume RV1 on TU1 so that the "MW" indication turns to "MW0" indication on the display window. But, in case of already indicated "MW0", turn the RV1 so that put out light "0" indication and adjustment.
3
1
SHUF1
Adjustment Location: See page 22. Procedure: L-CH Stereo separation: A-B R-CH Stereo separation: C-D The separations of both channels should be equal. Specification: Separation more than 30 dB Adjustment Location: See page 22.
21
Adjustment Location:
SET UPPER VIEW
Tape Speed Adjustment
(XR-C450: E, Saudi Arabia model only) TU1 RV1 AM (MW) Auto Scan/Stop Level Adjustment RV2 FM Auto Scan/Stop Level Adjustment RV3 FM Noise Focus Adjustment RV4 FM Stereo Separation Adjustment
RV131 RV231 (R-CH) (L-CH)
DOLBY Level Adjustment
MAIN BOARD (CONDUCTOR SIDE)
J1 antenna jack
TU1 TP (DOLBY R) TP (GND) IC301 TP (DOLBY L) IC501
22
· IC Block Diagrams IC1
XOUT 1 XIN 2 REFERENCE DIVIDER PHASE DETECT
BU2624F-E2
20 VSS 19 PD1
IC361
MM1322XFBE
GND 1 8 OUT2
CONTROL CIRCUIT
7 VS
IN2 2
18 VDD
VCC 3
I/O CONTROL
CE 3 CK 4 DA 5 CD 6
IN1 4
17 FMIN
6 OUT1 5 GND
MAIN COUNT
16 AMIN
P0 7
SHIFT REGISTER LATCH
PRESCALLER 15 P2
IC651
RN5VD23AA-TL
5
P1 8 14 IF1
P3 9
IF COUNT CONTROL
VREF +
P4 10
20BIT COUNT
13 IF2
12 SD
IC161
LC75373ED
LTOUT LSIN LS1 LVRIN LCOM LS2 LS3 LT1 LT2 LT3 LSOUT
33
32 +
31 30
29
28 27 26
25 24
23
+
+
+ + +
22 LFIN 21 LFOUT
1 RVRIN
2 RCOM
3 4 RT1 RT2
5 RT3
6 7 8 RTOUT RSIN RS1
9 10 RS2 RS3
11 RSOUT
37
+
+
+
+
R1 R2 R3 R4 RSELO
40 41 42 43 44
+
+
VDD 39
+
LSELO L4 L3 L2 L1
34 35 36 37 38
+
+
20 LROUT
19 VREF DECODER LATCH SHIFT REGISTER CONTROL 18 17 16 15 CE DI CL VSS 14 RROUT
13 RFOUT 12 RFIN
GND
VDD
OUT
11 PD2
1
2
NC
4
CD
3
+
+ +
IC301
CXA2510AQ-T4
LINEOUT1 TAPEIN1 PBOUT1 AUXIN1 MSSW PBEQ1 DIREF TCH1 GND
IC701
BA8270F-E2
BUS ON 1
BUS ON SWITCH RESET SWITCH BATTERY SWITCH
30
29
28 27
26
25
24
23 22 21 NR
RST 2 13 12 11 10 RST BUS ON CLK IN BU IN
T2 + PBFB1 31 PBRIN1 32 PBREF1 33 PBFIN1 34 F2 TAPE EQ FWD/RVS VCT 35 PBGND 36 VCT + PBFIN2 37 PBREF2 38 PBRIN2 39 PBFB2 40 T1 120µ/ 70µ 1 2 3 4 5 6 7 + + F1 F3 X1 LPF VCC + NR BIAS X1 TAPE/AUX
+
OFF/B
120µ/ 70µ
NC
14 VCC
20 MSMODE MS MODE 19 DRSW 18 TAPESW 17 INSW NR MODE 16 NRSW
BATT 3
CLK 4 VREF 5 DATA 6 GND 7
9 DATA IN 8 DATA OUT
MS ON/ 15 NC OFF DETECT 14 MSOUT 13 DGND
12 MSTC OFF/B NR 8 9 10 11 FF
TAPEIN2 AUXIN2
LINEOUT2
PBOUT2
MSLPF
PBEQ2
VCC
IC671
BA3918-V2
REGULATOR
OVER VOLTAGE PROTECT + + + +
TCH2 NC PLAY
1
NC
2 3 4
MODE2 MODE1 STB
5
VDD
6
AMP
7
VCC
8
ANT
9
COM
10
AM
11
FM
12
GND
38
6-7.
IC PIN FUNCTION DESCRIPTION
µPD78058GC-913-3B9 (SYSTEM CONTROL) I/O I I I -- I/O O I I O O I O O O O I O I O O O O O O O O I/O Function Destination setting pin Rotary remote commander input pin (A/D input) Station detection signal input GND Stereo detection signal input and forced monaural signal output pin PLL chip enable output pin A/D reference voltage input pin PLL data input pin PLL data output pin PLL clock output pin Polar stereo input pin LCD data output pin LCD clock output pin LCD chip enable output pin LCD blank indication control pin Data input pin (for SONY BUS) Data output pin (for SONY BUS) Clock input pin (for SONY BUS) Clock output pin (for SONY BUS) BUS ON control signal output pin (for SONY BUS) System reset signal output pin Power amp power supply control pin Power amp muting control pin. At muting: "L" Tape power supply control pin FM power supply control pin System power supply control pin Illumination color selection input/output pin At initial mode: valid/invalid selection input of color select function At normal mode: color selection output Tape AMS control pin. At AMS: "L" Reel table rotation detection pin AUTO METAL detection pin. "L": METAL Tape position control pin GND Tape position control pin Loading motor control pin (loading direction) Loading motor control pin (eject direction) Forward/reverse control pin Polar stereo detection output pin. At polar stereo on: "H" Capstan motor control pin Tape power supply control pin Illumination color setting pin. "L": amber, "H": green Rotary remote commander input pin (A/D input) Test mode setting pin Pin Name DSEL RC_IN0 SD_IN AVSS ST PLLCE AVREF1 PLLSI PLLSO PLLCKO P.ST_IN LCDSO LCDCKO LCDCE LCDINH UNISI UNISO UNICKI UNICKO BUSON SYSRST AMPON AMP_MUT TUNON FM_ON PW_ON COLOR
MAIN BOARD IC501 Pin No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27
28 29 30 31, 32 33 34, 35 36 37 38 39 40 41 42 43 44
AMSON REL MTLIN POS3, POS2 GND POS0, POS1 LM_LOD LM_EJ N/R_OUT P.ON CM_ON TAPON COLSEL RC_IN1 TEST
I I I I -- I O O O O O O I I I
39
Pin No. 45
Pin Name ILLON
I/O O Illumination power supply control pin At PW SEL on: ACC on: "H" At PW SEL off: Power on: "H" Beep sound output pin System mutig control pin. At muting: "H" Chip enable output pin to electrical volume
Function
46 47 48 49 50 51 52 53 54
BEEP MUT VOLCE SUBCE VOLCKO SUBCKO VOLSO TAPMUT DOLON
O O O O O O O O I/O
Chip enable output pin to sub volume (not used) Clock output pin to electrical volume Clock output pin to sub volume (not used) Data output pin to electrical volume Tape mutig control pin. At muting: "H" DOLBY control input/output pin At initial mode: valid/invalid selection input of DOLBY function At normal mode: DOLBY on/off output DOLBY B/C selection pin At initial mode: valid/invalid selection input of DOLBY C function At normal mode: DOLBY B/C selection output. "L": DOLBY B, "H": DOLBY C Tape music with/without detection pin. "L": with music METAL control input/output pin At initial mode: auto/manual serection input of METAL function. "L": manual At manual mode: METAL on/off output. "H": on At auto mode: input st 30 MTLIN Power supply control pin for A/D conversion Reset detection pin of RAM Reset input pin SIRCS signal input pin Buck up power supply detection pin Power select switch input pin Accessory voltage detection pin Front panel removal or attaching detection pin Telephone muting detection pin. "L": 20dB audio muting Key acknowledge signal input pin Power supply Main system clock output pin (5MHz) Main system clock input pin (5MHz) GND Sub system clock output pin (32.768kHz) Sub system clock input pin (32.768kHz) Power supply A/D reference voltage input pin Key input pin (A/D input) D-BASS switch input pin (A/D input) FM/AM signal meter voltage detection pin (A/D input) Key function setting pin
55
DOLBC
I/O
56 57
AMSIN MTLSEL
I I/O
58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 78 79 80
AD_ON RAMBU RESET SIRCS BU_IN PW_SEL ACCIN NOSESW TELMUT KEYACK VDD OSCOUT OSCIN GND XT_OUT XT_IN AVDD AVREF0 D.POSI VSM KEYSEL
O I I I I I I I I O -- O I -- O I -- I I I I I
76, 77 KEYIN0, KEYIN1
40
SECTION 7 EXPLODED VIEWS
NOTE: · -XX and -X mean standardized parts, so they may have some difference from the original one. · Color Indication of Appearance Parts Example: KNOB, BALANCE (WHITE) . . . (RED) Parts Color Cabinet's Color · Abbreviation EA: Saudi Arabia · Items marked "*" are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. · The mechanical parts with no reference number in the exploded views are not supplied. · Accessories and packing materials are given in the last of the electrical parts list.
Ver 1.1
8
(1) CHASSIS SECTION
MG-25C-136
#3
15
F901
9 7
#4
10 6
#4 #4 #2
11 5
#4
XR-C440
4 3 2
12
#2
11
14 2
Front panel ass'y #1 #2 #2
13
1
Remark Ref. No. 9 9 * 10 * 11 * 11 12 * 13 * 14 15 15 Part No. Description Remark
Ref. No. 1 2 3 3 4 * 5 * 6 * 6 * 6 * 6 7 * 8 * 8
Part No. 3-009-294-01 3-935-003-01 3-932-205-31 3-932-205-51
Description
PANEL, SUB SPRING, TORSION DOOR, CASSETTE (XR-C450: E, EA) DOOR, CASSETTE (XR-C440/XR-C450: US, Canadian) X-3367-636-1 LOCK ASSY 3-009-306-01 SHEET, INSULATING A-3309-720-A MAIN BOARD, COMPLETE (XR-C450: US, Canadian) A-3309-723-A MAIN BOARD, COMPLETE (XR-C450: E) A-3313-122-A MAIN BOARD, COMPLETE (XR-C450: EA) A-3309-877-A MAIN BOARD, COMPLETE (XR-C440) 3-915-923-01 SCREW, GROUND POINT X-3373-270-1 COVER ASSY (XR-C440) X-3373-269-1 COVER ASSY (ISO) (XR-C450)
1-776-207-11 CORD (WITH CONNECTOR) (XR-C440/XR-C450: E, EA) 1-776-207-31 CORD (WITH CONNECTOR) (XR-C450: US, Canadian) 3-009-809-01 BRACKET (IC) 3-009-808-01 HEAT SINK (XR-C450) 3-009-808-21 HEAT SINK (XR-C440) 9-911-840-XX 3-009-813-01 3-012-859-01 3-360-123-01 3-937-650-01 CUSHION (U) CHASSIS CAP, RUBBER PLATE (C), GROUND (XR-C450: E, EA) PLATE (C), GROUND (XR-C440/XR-C450: US, Canadian)
F901
1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE) (10A)
41
(2) FRONT PANEL SECTION (XR-C440)
not supplied (KEY board)
#5 #5
56 55
57
64 58 59 61 62 63
54
LCD901
60 53 51
Ref. No. 51 53 54 55 56 57 58
Part No. 3-010-396-01 3-010-398-01 3-013-272-01 X-3373-678-1 3-010-383-01
Description KNOB (D-BASS) BUTTON (RELEASE) SPRING (RELEASE) PANEL SUB ASSY BUTTON (SOURCE)
Remark
Ref. No. 59 60 * 61 * 62 * 63
Part No. 3-010-387-01 3-010-390-01 3-010-375-11 3-010-393-01 3-010-394-01
Description
Remark
BUTTON (PRESET) (6. 1. 2. 3. 4. 5. 6. DSPL) BUTTON (L. L. D) (PTY. AF/ TA. DISC +) SHEET (REFLECTOR) (XR-C440) PLATE (LCD), LIGHT GUIDE HOLDER (LCD)
3-010-384-01 BUTTON (M. O. S) ( r. OFF. = 0. SEEK AMS. + ) +) 3-010-386-01 BUTTON (B.M.+/) (. SEL. +. MUTE. SENS)
64 3-010-382-01 PANEL, FRONT BACK LCD901 1-801-587-11 DISPLAY PANEL, LIQUID CRYSTAL
42
(3) FRONT PANEL SECTION (XR-C450)
not supplied (KEY board) #5
#5 PL903
108 107 106
109 117 116 118
105
SO NY
110 114 111 112
115
LCD901 PL904
104 103
113
101
Ref. No. 101 103 104 105 106 107 108 109 110
Part No. 3-009-301-01 3-009-299-01 3-009-304-01 3-932-475-01 3-904-194-01
Description BUTTON (BASS) BUTTON (L2) (+.-) BUTTON (RELEASE) SPRING (RELEASE) EMBLEM (NO. 2.5), SONY
Remark
Ref. No. 111 112 113 * 114 * 115 * 116 * 117 118 LCD901 PL903 PL904
Part No. 3-009-308-01 3-009-309-11 3-009-310-01 3-010-282-01 3-009-305-01 3-009-302-11 3-009-303-01 3-009-295-01 1-801-587-11 1-517-633-11 1-517-633-11
Description BUTTON (1-3) (6. 1. 2. 3) BUTTON (4-6) (4. 5. 6) BUTTON (R) (L) (PTY. AF/ TA. DISC +) PLATE (LCD), GROUND SHEET (REFLECTOR) PLATE (LCD), LIGHT GUIDE HOLDER (LCD) PANEL, FRONT BACK DISPLAY PANEL, LIQUID CRYSTAL LAMP, PILOT LAMP, PILOT
Remark
X-3373-665-1 PANEL SUB ASSY 3-009-300-01 BUTTON (SOURCE) 3-009-297-01 BUTTON (L) (+ + ). SEEK AMS. = 0 .r. OFF. r. SEL. MUTE) 3-009-311-01 LENS
43
(4) MECHANISM DECK SECTION (MG-25C-136)
209
210
208
A
213
HP901
211 205 207
#6
212
206
A
M901
214 204
203
215
#7
202
202 216
217 201
Ref. No. 201 202 * 203 * 204 205 206 207 208 * 209 210 Part No. A-3291-667-A 3-701-437-21 3-008-883-01 3-008-884-01 3-008-890-01 3-933-335-01 3-341-753-11 3-008-861-01 3-008-882-01 3-008-860-01 Description CLUTCH (FR) ASSY WASHER LEVER (LDG-A) LEVER (LDG-B) SPRING (LEVER LDG), TENSION GEAR (LDG-FT) WASHER, POLYETHYLENE HOUSING ARM (SUCTION) HANGER Remark Ref. No. 211 212 213 214 215 216 217 HP901 M901 Part No. 3-008-874-02 3-933-344-01 3-927-100-01 3-364-151-01 A-3291-919-A 3-928-675-01 3-936-853-01 1-500-196-21 A-3291-665-A Description CATCHER GUIDE (C) SCREW (+PS 2X10), SPECIAL WASHER CHASSIS ASSY (A) BELT (52) FLYWHEEL (F) HEAD, MAGNETIC (PLAYBACK) MOTOR ASSY, MAIN (CAPSTAN/ REEL) Remark
44
SECTION 8 ELECTRICAL PARTS LIST
NOTE: · Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. · -XX and -X mean standardized parts, so they may have some difference from the original one. · RESISTORS All resistors are in ohms. METAL: Metal-film resistor. METAL OXIDE: Metal oxide-film resistor. F: nonflammable · Abbreviation EA: Saudi Arabia Ref. No. Part No. Description KEY BOARD ********* * * * * * * * 3-009-302-01 3-009-303-01 3-009-305-11 3-010-282-01 3-010-375-11 PLATE (LCD), LIGHT GUIDE (XR-C450) HOLDER (LCD) (XR-C450) SHEET (REFLECTOR) (XR-C450) PLATE (LCD), GROUND (XR-C450) SHEET (REFLECTOR) (XR-C440) · Items marked "*" are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. · SEMICONDUCTORS In each case, u: µ, for example: uA. . : µA. . uPA. . : µPA. . uPB. . : µPB. . uPC. . : µPC. . uPD. . : µPD. . · CAPACITORS uF: µF · COILS uH: µH Remark Ref. No. Part No. Description < CHIP CONDUCTOR > JC901 1-216-295-00 CONDUCTOR, CHIP (2012)
KEY
When indicating parts by reference number, please include the board.
Remark
< LIQUID CRYSTAL DISPLAY > LCD901 1-801-587-11 DISPLAY PANEL, LIQUID CRYSTAL < SWITCH > LSW901 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (OFF) (XR-C440/XR-C450: US, Canadian) LSW901 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (OFF) (XR-C450:E, EA) LSW902 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (SOURCE) (XR-C440/XR-C450: US, Canadian) LSW902 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (SOURCE) (XR-C450: E, EA) LSW903 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (MODE) (XR-C440/XR-C450: US, Canadian) LSW903 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (MODE) (XR-C450: E, EA) LSW904 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (+ + ) (SEEK/AMS)) (XR-C440/XR-C450: US, Canadian) LSW904 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (+ + ) (SEEK/AMS)) (XR-C450: E, EA) LSW905 1-762-619-11 SWITCH, KEY BOARD (WITH LED) ( = 0 (SEEK/AMS)) (XR-C440/XR-C450: US, Canadian) LSW905 1-762-620-11 SWITCH, KEY BOARD (WITH LED) ( = 0 (SEEK/AMS)) (XR-C450: E, EA) LSW906 1-762-619-11 SWITCH, KEY BOARD (WITH LED) () (XR-C440/XR-C450: US, Canadian) LSW906 1-762-620-11 SWITCH, KEY BOARD (WITH LED) () (XR-C450: E, EA) LSW907 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (SEL) (XR-C440/XR-C450: US, Canadian) LSW907 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (SEL) (XR-C450: E, EA)
3-010-393-01 PLATE (LCD), LIGHT GUIDE (XR-C440) 3-010-394-01 HOLDER (LCD) (XR-C440) < CAPACITOR > C901 C902 C903 C904 C905 1-163-033-91 1-163-038-00 1-163-038-00 1-163-251-11 1-163-038-00 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.022uF 0.1uF 0.1uF 100PF 5% 0.1uF 50V 25V 25V 50V 25V (XR-C450)
< CONNECTOR > CNP901 1-764-423-11 PIN, CONNECTOR 12P < DIODE > D901 D902 D903 D904 D905 D908 8-719-976-99 8-719-105-99 8-719-105-99 8-719-105-99 8-719-105-99 DIODE DIODE DIODE DIODE DIODE DTZ5.1B RD6.2M-B1 RD6.2M-B1 RD6.2M-B1 RD6.2M-B1
8-719-976-99 DIODE DTZ5.1B (XR-C450) < IC >
IC901 IC902
8-759-365-90 IC LC75824W 8-749-012-25 IC RS-170-TU (XR-C450)
45
KEY
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
LSW908 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (+) (XR-C440/XR-C450: US, Canadian) LSW908 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (+) (XR-C450: E, EA) LSW909 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (MUTE) (XR-C440) LSW909 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (DSPL) (XR-C450: US, Canadian) LSW909 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (DSPL) (XR-C450: E, EA) LSW910 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (BTM) (XR-C440) LSW910 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (MUTE) (XR-C450: US, Canadian) LSW910 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (MUTE) (XR-C450: E, EA) LSW921 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (6) (XR-C440/XR-C450: US, Canadian) LSW921 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (6) (XR-C450: E, EA) LSW922 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (1/INTRO) (XR-C440/XR-C450: US, Canadian) LSW922 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (1/INTRO) (XR-C450: E, EA) LSW923 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (2/REPEAT) (XR-C440/XR-C450: US, Canadian) LSW923 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (2/REPEAT) (XR-C450: E, EA) LSW924 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (3/SHUF/a) (XR-C440/XR-C450: US, Canadian) LSW924 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (3/SHUF/a) (XR-C450: E, EA) LSW925 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (6/BL.SKIP) (XR-C440/XR-C450: US, Canadian) LSW925 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (6/BL.SKIP) (XR-C450: E, EA) LSW926 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (5/ATA) (XR-C440/XR-C450: US, Canadian) LSW926 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (5/ATA) (XR-C450:E, EA) LSW927 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (4/BANK/MTL) (XR-C440/XR-C450: US, Canadian) LSW927 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (4/BANK/MTL) (XR-C450: E, EA) LSW928 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (LCL) (XR-C440) LSW928 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (LCL/BTM) (XR-C450: US, Canadian) LSW928 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (LCL/BTM) (XR-C450: E, EA) LSW929 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (LIST) (XR-C440)
LSW929 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (FILE) (XR-C450: US, Canadian) LSW929 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (FILE) (XR-C450: E, EA) LSW930 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (+ (DISC/PRESET)) (XR-C440/XR-C450: US, Canadian) LSW930 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (+ (DISC/PRESET)) (XR-C450: E, EA) LSW931 1-762-619-11 SWITCH, KEY BOARD (WITH LED) ( (DISC/PRESET)) (XR-C440/XR-C450: US, Canadian) LSW931 1-762-620-11 SWITCH, KEY BOARD (WITH LED) ( (DISC/PRESET)) (XR-C450: E, EA) LSW932 1-762-619-11 SWITCH, KEY BOARD (WITH LED) (DSPL) (XR-C440) < PILOT LAMP > PL903 PL904 1-517-633-11 LAMP, PILOT 1-517-633-11 LAMP, PILOT < TRANSISTOR > Q901 Q902 Q903 Q904 8-729-106-60 8-729-106-60 8-729-900-53 8-729-900-53 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR < RESISTOR > R901 R902 R903 R904 R905 R906 R907 R908 R909 R910 1-216-045-00 1-216-045-00 1-216-045-00 1-216-049-11 1-216-053-00 1-216-053-00 1-216-057-00 1-216-061-00 1-216-065-00 1-216-069-00 METAL CHIP METAL CHIP METAL CHIP METAL GLAZE METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 680 680 680 1K 1.5K 1.5K 2.2K 3.3K 4.7K 6.8K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W (XR-C440) 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W (XR-C440) 2SB1115A (XR-C450: E, EA) 2SB1115A (XR-C450: E, EA) DTC114EK (XR-C450: E, EA) DTC114EK (XR-C450: E, EA)
R921 R922 R923 R924 R925 R926 R927 R928 R929 R930 R931 R932
1-216-045-00 1-216-045-00 1-216-045-00 1-216-049-11 1-216-053-00 1-216-053-00 1-216-057-00 1-216-061-00 1-216-065-00 1-216-069-00
METAL CHIP METAL CHIP METAL CHIP METAL GLAZE METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
680 680 680 1K 1.5K 1.5K 2.2K 3.3K 4.7K 6.8K 10K 15K
5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5%
1-216-073-00 METAL CHIP 1-216-077-00 METAL CHIP
46
KEY
Ref. No. R951 R952 R953 R954 R955 R956 R957 R958 Part No. Description 470 330K 1K 1K 1K 1K 10K 4.7K 5% 5% 5% Remark 1/10W 1/10W 1/10W Ref. No. R972 R981 R982 R983 R984 R991 R992 R999 R959 R960 R961 R961 R961 1-216-073-00 METAL CHIP 1-216-065-00 METAL CHIP 1-216-025-00 METAL GLAZE 1-216-033-00 METAL CHIP 1-216-037-00 METAL CHIP 5% 1/10W (XR-C450: E, EA) 4.7K 5% 1/10W (XR-C450: E, EA) 100 5% 1/10W (XR-C440) 220 5% 1/10W (XR-C450: US, Canadian) 330 5% 1/10W (XR-C450: E, EA) 220 100 150 220 100 5% 1/10W (XR-C450: E, EA) 5% 1/10W (XR-C450: US, Canadian) 5% 1/10W (XR-C450: E, EA) 5% 1/10W (XR-C440) 5% 1/10W (XR-C450: E, EA) 10K Part No. Description 68 1.5K 3.3K 6.8K 22K 100
MAIN
Remark
1-216-041-00 METAL CHIP 1-216-109-00 METAL CHIP 1-216-049-11 METAL GLAZE 1-216-049-11 1-216-049-11 1-216-049-11 1-216-073-00 METAL GLAZE METAL GLAZE METAL GLAZE METAL CHIP
1-216-021-00 METAL GLAZE 1-216-053-00 METAL CHIP 1-216-061-00 METAL CHIP 1-216-069-00 METAL CHIP 1-216-081-00 METAL CHIP 1-216-025-00 METAL GLAZE
5% 1/10W (XR-C450: E, EA) 5% 1/10W 5% 1/10W 5% 5% 5%
1-216-065-00 METAL CHIP
5% 1/10W 5% 1/10W 5% 1/10W 5% 1/10W (XR-C450: E, EA) 5% 1/10W (XR-C450: E, EA)
1/10W 1/10W 1/10W (XR-C450) 1-216-041-00 METAL CHIP 470 5% 1/10W (XR-C450) 1-216-308-00 METAL GLAZE 4.7 5% 1/10W (XR-C440/XR-C450: US, Canadian) < SWITCH >
SW951 1-762-937-11 SWITCH, ROTARY (D-BASS) ************************************************************ * A-3309-720-A MAIN BOARD, COMPLETE ********************* (XR-C450: US, Canadian) A-3309-723-A MAIN BOARD, COMPLETE (XR-C450: E) ********************* A-3309-877-A MAIN BOARD, COMPLETE (XR-C440) ********************* A-3313-122-A MAIN BOARD, COMPLETE (XR-C450: EA) ********************* 3-009-808-01 3-009-808-21 3-009-809-01 7-685-794-09 HEAT SINK (XR-C450) HEAT SINK (XR-C440) BRACKET (IC) SCREW +PTT 2.6X10 (S) < CAPACITOR > C1 C2 C3 C4 C5 C6 C7 C8 C10 C11 C12 C13 C14 C15 C16 C17 C18 1-163-235-11 1-163-133-00 1-124-234-00 1-124-234-00 1-124-234-00 1-164-232-11 1-164-232-11 1-164-232-11 1-164-232-11 CERAMIC CHIP CERAMIC CHIP ELECT ELECT ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 22PF 470PF 22uF 22uF 22uF 0.01uF 0.01uF 0.01uF 0.01uF 100PF 100PF 100PF 47uF 0.01uF 0.22uF 5% 5% 20% 20% 20% 50V 50V 16V 16V 16V
R962 R963 R963 R963 R964
1-216-033-00 METAL CHIP 1-216-025-00 METAL GLAZE 1-216-029-00 METAL CHIP 1-216-033-00 METAL CHIP 1-216-025-00 METAL GLAZE
*
*
*
R965 R965 R966 R967 R967
1-216-033-00 METAL CHIP 1-216-037-00 1-216-033-00 1-216-021-00 1-216-029-00
220 5% 1/10W (XR-C440/XR-C450: US, Canadian) METAL CHIP 330 5% 1/10W (XR-C450: E, EA) METAL CHIP 220 5% 1/10W (XR-C450: E, EA) METAL GLAZE 68 5% 1/10W (XR-C440/XR-C450: US, Canadian) METAL CHIP 150 5% 1/10W (XR-C450: E, EA) 68 68 180 330 180 5% 1/10W (XR-C450: E, EA) 5% 1/10W (XR-C440) 5% 1/10W (XR-C450: US, Canadian) 5% 1/10W (XR-C450: E, EA) 5% 1/10W (XR-C450:E, EA)
* * *
R968 R969 R969 R969 R970
1-216-021-00 METAL GLAZE 1-216-021-00 METAL GLAZE 1-216-031-00 METAL CHIP 1-216-037-00 METAL CHIP 1-216-031-00 METAL CHIP
1-163-251-11 CERAMIC CHIP 1-163-251-11 1-163-251-11 1-124-589-11 1-164-232-11 1-164-489-11 CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP
50V 50V 50V 50V (XR-C450: E, EA) 5% 50V 5% 5% 20% 10% 50V 50V 16V 50V 16V 50V 16V
R971 R971
1-216-021-00 METAL GLAZE 68 5% 1/10W (XR-C440/XR-C450: US, Canadian) 1-216-029-00 METAL CHIP 150 5% 1/10W (XR-C450: E, EA)
1-163-017-00 CERAMIC CHIP 1-124-234-00 ELECT
0.0047uF 5% 22uF 20%
47
MAIN
Ref. No. C19 C20 C21 C22 C93 C94 C95 C96 C97 C98 C99 C101 C101 Part No. Description 10uF 0.1uF 27PF 27PF 100PF 22PF 47PF 0.01uF 20% 10% 5% 5% 5% 5% 5% Remark 16V 25V 50V 50V 50V 50V 50V 50V Ref. No. C176 Part No. Description 100PF 5% Remark 50V (XR-C450)
1-126-157-11 ELECT 1-164-004-11 CERAMIC CHIP 1-163-237-11 CERAMIC CHIP 1-163-237-11 1-163-251-11 1-163-235-11 1-163-243-11 1-164-232-11 1-164-232-11 1-164-232-11 1-164-232-11 1-163-024-00 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
1-163-251-11 CERAMIC CHIP
C191 C192 C193 C194 C201
1-136-165-00 1-136-165-00 1-136-165-00 1-136-165-00 1-163-024-00
FILM FILM FILM FILM CERAMIC CHIP
0.1uF 5% 50V 0.1uF 5% 50V 0.1uF 5% 50V 0.1uF 5% 50V 0.018uF 10% 50V (XR-C440/XR-C450: E, EA) 0.027uF 10% 25V (XR-C450: US, Canadian) 1uF 20% 50V 100PF 5% 50V 100PF 5% 50V 1uF 20% 50V 0.001uF 100PF 10uF 1uF 1uF 10% 5% 20% 20% 20% 50V 50V 16V 50V 50V 50V 25V 16V 16V 16V 16V 50V 50V 50V 50V 50V 50V (XR-C450) 50V 50V 50V 50V 50V 16V 50V 25V 50V 16V 50V 50V 25V 16V 10V 16V 50V
1-163-986-00 CERAMIC CHIP
0.01uF 50V 0.01uF 50V 0.01uF 50V 0.018uF 10% 50V (XR-C440/XR-C450: E, EA) 0.027uF 10% 25V (XR-C450: US, Canadian) 1uF 0.47uF
C201 C203 C231 C232 C233 C234 C241 C242 C251 C252 C253 C254 C255 C256 C257 C258 C271 C272 C273 C274 C275 C276 C291 C292 C293 C294 C311 C312 C313 C315 C321 C322 C323 C324 C325 C331 C332 C333 C334
1-163-986-00 CERAMIC CHIP 1-126-160-11 1-163-251-11 1-163-251-11 1-126-160-11 1-163-009-11 1-163-251-11 1-126-157-11 1-126-160-11 1-126-160-11 1-164-182-11 1-163-037-11 1-126-157-11 1-164-492-11 1-164-492-11 1-126-157-11 1-126-163-11 1-126-163-11 1-163-009-11 1-163-009-11 ELECT CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP ELECT ELECT ELECT CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP ELECT ELECT ELECT CERAMIC CHIP CERAMIC CHIP
C103 C121 C121 C122 C122
1-126-160-11 ELECT 1-107-823-11 CERAMIC CHIP
20% 50V 10% 16V (XR-C450: E, EA) 1-164-489-11 CERAMIC CHIP 0.22uF 10% 16V (XR-C440/XR-C450: US, Canadian) 1-163-037-11 CERAMIC CHIP 0.022uF 10% 25V (XR-C440/XR-C450: US, Canadian) 1-164-344-11 CERAMIC CHIP 0.068uF 10% 25V (XR-C450: E, EA) 1-163-037-11 CERAMIC CHIP 1-164-489-11 0.022uF 10% 25V (XR-C450: E, EA) CERAMIC CHIP 0.22uF 10% 16V (XR-C440/XR-C450: US, Canadian) CERAMIC CHIP 100PF 5% 50V CERAMIC CHIP 100PF 5% 50V ELECT 1uF 20% 50V CERAMIC CHIP CERAMIC CHIP ELECT ELECT ELECT CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP ELECT ELECT CERAMIC CHIP ELECT ELECT ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.001uF 100PF 10uF 1uF 1uF 10% 5% 20% 20% 20% 50V 50V 16V 50V 50V 50V 25V 16V 16V 16V 16V 10V 50V 16V 50V 50V 50V 50V 50V
0.0033uF 10% 0.022uF 10% 10uF 20% 0.15uF 10% 0.15uF 10% 10uF 4.7uF 4.7uF 1000PF 1000PF 100PF 100PF 0.1uF 0.1uF 0.1uF 0.1uF 0.01uF 0.22uF 0.01uF 0.1uF 0.01uF 0.22uF 0.01uF 100PF 0.1uF 22uF 100uF 0.47uF 0.01uF 20% 20% 20% 10% 10% 5% 5% 5% 5% 5% 5% 10% 10%
C123 C123 C131 C132 C133 C134 C141 C142 C151 C152 C153 C154 C155 C156 C157 C158 C161 C162 C163 C171 C172 C173 C174 C175
1-163-251-11 1-163-251-11 1-126-160-11 1-163-009-11 1-163-251-11 1-126-157-11 1-126-160-11 1-126-160-11 1-164-182-11 1-163-037-11 1-126-157-11 1-164-492-11 1-164-492-11 1-126-157-11 1-124-584-00 1-164-232-11 1-124-234-00 1-126-163-11 1-126-163-11 1-163-009-11 1-163-009-11 1-163-251-11
1-163-251-11 CERAMIC CHIP 1-163-251-11 CERAMIC CHIP 1-136-165-00 FILM 1-136-165-00 FILM 1-136-165-00 FILM 1-136-165-00 1-164-232-11 1-164-489-11 1-164-232-11 1-164-004-11 1-164-232-11 1-164-489-11 1-164-232-11 1-163-251-11 1-164-004-11 1-124-234-00 1-124-584-00 1-107-823-11 1-164-232-11 FILM CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT ELECT CERAMIC CHIP CERAMIC CHIP
0.0033uF 10% 0.022uF 10% 10uF 20% 0.15uF 10% 0.15uF 10% 10uF 100uF 0.01uF 22uF 4.7uF 4.7uF 1000PF 1000PF 100PF 20% 20% 20% 20% 20% 10% 10% 5%
10% 5% 10% 20% 20% 10%
48
MAIN
Ref. No. C335 C336 C361 C362 C364 C365 C366 C501 C502 C503 C504 C601 C602 C603 C604 C611 C612 C613 C614 C615 C621 C622 C631 C651 C652 C653 C654 C655 C661 C671 C672 C673 C674 C675 C676 C701 C702 C703 C704 C705 Part No. Description 0.01uF 10uF 0.1uF 0.1uF 10uF 10uF 220uF 20PF 22PF 0.01uF 10uF 20% Remark 50V 16V 25V 25V 16V 16V 16V 50V 50V 50V 16V Ref. No. CN601 CN631 CN701 Part No. Description Remark
1-164-232-11 CERAMIC CHIP 1-126-157-11 1-163-038-00 1-163-038-00 1-126-157-11 1-126-157-11 1-126-934-11 1-163-234-11 1-163-235-11 1-164-232-11 1-126-157-11 1-126-938-51 1-163-251-11 1-163-251-11 1-164-004-11 ELECT CERAMIC CHIP CERAMIC CHIP ELECT ELECT ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
1-774-701-11 PIN, CONNECTOR 16P 1-764-422-11 PLUG, CONNECTOR 12P 1-580-907-31 PLUG, CONNECTOR (BUS CONTROL IN) < CONPOSITION CIRCUIT BLOCK >
20% 20% 20% 5% 5% 20%
CP1
1-519-504-11 GAP, DISCHARGE < DIODE >
1-126-157-11 ELECT 1-126-157-11 1-163-243-11 1-136-165-00 1-164-506-11 1-124-589-11 1-126-161-11 1-164-222-11 1-164-004-11 1-164-004-11 1-163-038-00 1-125-710-11 1-124-584-00 1-126-163-11 1-126-157-11 1-126-157-11 1-126-157-11 1-126-157-11 1-126-157-11 1-126-157-11 1-164-004-11 1-163-038-00 1-163-037-11 1-163-077-00 1-164-232-11 ELECT CERAMIC CHIP FILM CERAMIC CHIP ELECT ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CAPACITOR ELECT ELECT ELECT ELECT ELECT ELECT ELECT ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP < CONNECTOR >
6800uF 20% 16V 100PF 5% 50V 100PF 5% 50V 0.1uF 10% 25V (XR-C440/XR-C450: E, EA) 10uF 20% 16V 10uF 47PF 0.1uF 4.7uF 47uF 2.2uF 0.22uF 0.1uF 0.1uF 0.1uF 0.1F 100uF 4.7uF 10uF 10uF 10uF 10uF 10uF 10uF 0.1uF 20% 5% 5% 20% 20% 10% 10% 16V 50V 50V 16V 16V 50V 25V 25V 25V 25V 5.5V 10V 50V 16V 16V 16V 16V 16V 16V 25V 25V 25V 25V 50V
D1 D2 D3 D331 D361 D362 D501 D601 D602 D603 D604 D605 D606 D621 D622 D631 D632 D633 D634 D635 D636 D637 D638 D639 D640 D641 D651 D652 D661 D662 D671 D672 D701 D702 D703 D704 D705 D706
8-719-991-65 8-719-977-25 8-719-977-02 8-719-991-33 8-719-977-25 8-719-991-33 8-719-914-44 8-719-049-38 8-719-977-69 8-719-977-69 8-719-105-99 8-719-105-99 8-719-988-62 8-719-976-88 8-719-988-62 8-719-158-49 8-719-109-93 8-719-109-93 8-719-110-49 8-719-109-93 8-719-109-93 8-719-109-93 8-719-109-93 8-719-105-99 8-719-105-99 8-719-105-99 8-719-988-62 8-719-988-62 8-719-914-43 8-719-977-17 8-719-970-02 8-719-970-02 8-719-056-93 8-719-105-99 8-719-105-99
DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE
SB02W03C DTZ9.1C DTZ-TT11-5.6A 1SS133T-77 DTZ9.1C 1SS133T-77 DAP202K 1N5404TU DTZ24B DTZ24B RD6.2M-B1 RD6.2M-B1 (XR-C440/XR-C450: E, EA) 1SS355 (XR-C440/XR-C450: E, EA) DTZ3.9B 1SS355 RD12SB2 RD6.2ESB2 RD6.2ESB2 RD18ES-B2 RD6.2ESB2 RD6.2ESB2 RD6.2ESB2 RD6.2ESB2 RD6.2M-B1 RD6.2M-B1 RD6.2M-B1 (XR-C450) 1SS355 1SS355 DAN202K DTZ7.5C 1SR139-400 1SR139-400 UDZ-TE-17-18B RD6.2M-B1 RD6.2M-B1
20% 20% 20% 20% 20% 20% 20% 20% 10%
0.1uF 0.022uF 10% 0.1uF 10% 0.01uF
CN151 CN151 CN301 * CN302
1-774-699-12 JACK, PIN 4P (BUS AUDIO IN/LINE OUT) (XR-C440) 1-774-700-11 JACK, PIN 6P (BUS AUDIO IN/LINE OUT) (XR-C450) 1-766-260-11 CONNECTOR, FFC/FPC (ZIF) 7P 1-506-995-11 PIN, CONNECTOR (PC BOARD) 13P
8-719-105-99 DIODE RD6.2M-B1 8-719-105-99 DIODE RD6.2M-B1 8-719-988-62 DIODE 1SS355 (XR-C450)
49
MAIN
Ref. No. Part No. Description < IC > IC1 IC161 IC301 IC361 IC501 IC611 IC651 IC652 IC671 IC701 8-759-448-84 8-759-443-67 8-752-079-79 8-759-395-97 8-759-461-73 8-759-369-41 8-759-344-91 8-759-363-81 8-759-347-49 8-759-449-89 IC IC IC IC IC IC IC IC IC IC BU2624F-E2 LC75373ED CXA2510AQ-T4 MM1322XFBE uPD78058GC-913-3B9 HA13155 RN5VD23AA-TL XC61AN4002PR BA3918-V2 BA8270F-E2 Remark Ref. No. JC115 JC116 JC117 JC118 JC119 JC120 JC121 JC122 JC123 JC124 JC125 JC126 JC131 JC132 JC133 JC134 JC136 JC137 JC138 JC139 JC140 Part No. Description (3216) (3216) (3216) (XR-C450) (3216) (3216) (3216) (3216) (3216) (3216) (3216) (3216) (3216) (3216) (3216) (3216) (3216) (3216) (3216) (3216) (3216) (3216) Remark
1-216-296-00 CONDUCTOR, CHIP 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 CONDUCTOR, CHIP CONDUCTOR, CHIP CONDUCTOR, CHIP CONDUCTOR, CHIP CONDUCTOR, CHIP CONDUCTOR, CHIP CONDUCTOR, CHIP CONDUCTOR, CHIP CONDUCTOR, CHIP CONDUCTOR, CHIP CONDUCTOR, CHIP CONDUCTOR, CHIP CONDUCTOR, CHIP CONDUCTOR, CHIP CONDUCTOR, CHIP CONDUCTOR, CHIP CONDUCTOR, CHIP CONDUCTOR, CHIP CONDUCTOR, CHIP
< JACK > J1 J501 1-764-808-14 JACK (ANT) (ANT IN) 1-566-822-41 JACK (REMOTE IN) < CHIP CONDUCTOR > JC1 JC2 JC5 JC6 JC7 JC8 JC9 JC10 JC11 JC12 JC31 JC33 JC34 JC35 JC36 JC37 JC101 JC102 JC103 JC104 JC105 JC106 JC107 JC108 JC110 JC111 JC112 JC113 JC114 1-216-295-00 1-216-295-00 1-216-295-00 1-216-295-00 1-216-295-00 1-216-295-00 1-216-057-00 1-216-295-00 1-216-295-00 1-216-295-00 1-216-295-00 1-216-295-00 1-216-295-00 1-216-295-00 1-216-295-00 CONDUCTOR, CHIP CONDUCTOR, CHIP CONDUCTOR, CHIP CONDUCTOR, CHIP CONDUCTOR, CHIP CONDUCTOR, CHIP METAL CHIP 2.2K CONDUCTOR, CHIP CONDUCTOR, CHIP CONDUCTOR, CHIP CONDUCTOR, CHIP CONDUCTOR, CHIP CONDUCTOR, CHIP CONDUCTOR, CHIP CONDUCTOR, CHIP (2012) (2012) (2012) (2012) (2012) (2012) 5% (2012) (2012) (2012) (2012) (2012) (2012) (2012) (2012) (2012) (XR-C450: US, Canadian) (3216) (3216) (XR-C450: E, EA) (3216) (XR-C450: E, EA) (3216) (3216) (3216) (3216) (3216) (3216) (3216) (3216) (3216) (XR-C450) (3216)
1-216-296-00 CONDUCTOR, CHIP < COIL >
1/10W L1 L601 1-410-989-11 INDUCTOR CHIP 0.47uH (XR-C440/XR-C450: US, Canadian) 1-411-669-12 COIL, CHOKE < TRANSISTOR > Q1 Q2 Q3 Q5 Q171 Q172 Q271 Q272 Q361 Q362 Q363 Q364 Q365 Q621 Q622 Q631 Q633 Q651 Q661 Q701 8-729-120-28 8-729-021-94 8-729-106-68 8-729-120-28 8-729-920-21 8-729-920-21 8-729-920-21 8-729-920-21 8-729-921-48 8-729-027-23 8-729-900-53 8-729-106-60 8-729-900-53 8-729-027-23 8-729-900-53 8-729-423-99 8-729-020-67 8-729-024-31 8-729-120-28 8-729-900-53 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR 2SC1623-L5L6 2SK1657-T1B 2SD1615A-GP 2SC1623-L5L6 DTC314TKH04 DTC314TKH04 DTC314TKH04 DTC314TKH04 2SD1760F5-TRPQR DTA114EKA-T146 DTC114EK 2SB1115A DTC114EK DTA114EKA-T146 DTC114EK 2SD2137-OP XN1A312-TX XN1111-TX 2SC1623-L5L6 DTC114EK
1-216-295-00 CONDUCTOR, CHIP 1-216-296-00 CONDUCTOR, CHIP 1-216-296-00 CONDUCTOR, CHIP 1-216-296-00 CONDUCTOR, CHIP 1-216-296-00 CONDUCTOR, CHIP 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 CONDUCTOR, CHIP CONDUCTOR, CHIP CONDUCTOR, CHIP CONDUCTOR, CHIP CONDUCTOR, CHIP CONDUCTOR, CHIP CONDUCTOR, CHIP CONDUCTOR, CHIP CONDUCTOR, CHIP
50
MAIN
Ref. No. Q702 Part No. Description Remark Ref. No. R192 R193 R194 R201 R202 R233 R234 R242 R251 R271 R272 R273 R274 R275 R276 R277 R278 R291 R292 R293 R294 R311 R312 R313 R314 R321 R322 R323 R331 R332 R333 R334 R335 R361 R362 R363 R364 R365 R501 R502 R503 R504 R505 R506 R507 R508 R509 Part No. Description 2.2 2.2 2.2 5% 5% 5% Remark 1/10W 1/10W 1/10W
8-729-027-38 TRANSISTOR DTA144EKA-T146 (XR-C450) < RESISTOR >
1-216-298-00 METAL CHIP 1-216-298-00 METAL CHIP 1-216-298-00 METAL CHIP
JW15 R1 R2 R4 R5 R6 R7 R8 R9 R10 R11 R12 R13 R14 R15 R17
1-247-767-00 CARBON 1-216-049-11 METAL GLAZE 1-216-037-00 METAL CHIP 1-216-041-00 METAL CHIP 1-216-105-00 METAL GLAZE 1-216-073-00 METAL CHIP 1-216-081-00 1-216-073-00 1-216-061-00 1-216-073-00 1-216-057-00 1-216-049-11 1-216-065-00 1-216-206-00 1-216-057-00 1-216-073-00 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL GLAZE METAL CHIP METAL GLAZE METAL CHIP METAL CHIP
2.2 1K 330 470 220K 10K 22K 10K 3.3K 10K 2.2K 1K 4.7K 2.2K 2.2K 10K
5% 1/4W 5% 1/10W 5% 1/10W (XR-C450: E, EA) 5% 1/10W 5% 1/10W 5% 1/10W 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W
1-216-065-00 METAL CHIP 4.7K 5% 1/10W 1-216-089-00 METAL GLAZE 47K 5% 1/10W (XR-C440/XR-C450: US, Canadian) 1-216-069-00 METAL CHIP 6.8K 5% 1/10W 1-216-230-00 METAL GLAZE 22K 5% 1/8W 1-216-073-00 METAL CHIP 10K 5% 1/10W 1-216-061-00 1-216-017-00 1-216-017-00 1-216-073-00 1-216-073-00 1-216-081-00 1-216-081-00 1-216-129-00 1-216-129-00 1-216-298-00 1-216-298-00 1-216-298-00 1-216-298-00 1-216-109-00 1-216-079-00 1-216-079-00 1-208-812-11 1-216-109-00 1-216-079-00 1-216-079-00 1-216-009-00 1-216-065-00 1-216-077-00 1-216-113-00 1-216-073-00 1-216-049-11 1-249-389-11 1-249-389-11 1-216-073-00 1-216-065-00 1-216-206-00 1-216-206-00 1-216-206-00 1-216-057-00 1-216-057-00 1-216-057-00 1-216-057-00 1-216-057-00 1-216-246-00 METAL CHIP METAL GLAZE METAL GLAZE METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL GLAZE METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL GLAZE CARBON CARBON METAL CHIP METAL CHIP METAL GLAZE METAL GLAZE METAL GLAZE METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL GLAZE 3.3K 47 47 10K 10K 22K 22K 2.2M 2.2M 2.2 2.2 2.2 2.2 330K 18K 18K 18K 330K 18K 18K 22 4.7K 15K 470K 10K 1K 4.7 4.7 10K 4.7K 2.2K 2.2K 2.2K 2.2K 2.2K 2.2K 2.2K 2.2K 100K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 2% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/4W 1/4W 1/10W 1/10W 1/8W 1/8W 1/8W 1/10W 1/10W
5% 1/10W 5% 1/10W 5% 1/8W 5% 1/10W 5% 1/10W (XR-C450: E, EA)
R18 R19 R91 R92 R101 R102 R121 R121 R122 R133 R134 R142 R151 R171 R172 R173 R174 R175 R176 R177 R178 R191
1-216-073-00 METAL CHIP 1-216-061-00 1-216-295-00 1-216-049-11 1-216-214-00
5% 1/10W (XR-C450: E, EA) METAL CHIP 3.3K 5% 1/10W CONDUCTOR, CHIP (2012) METAL GLAZE 1K 5% 1/10W (XR-C440/XR-C450: US, Canadian) METAL GLAZE 4.7K 5% 1/8W
10K
1-216-089-00 METAL GLAZE 47K 5% 1/10W (XR-C440/XR-C450: US, Canadian) 1-216-057-00 METAL CHIP 2.2K 5% 1/10W (XR-C450: E, EA) 1-216-295-00 CONDUCTOR, CHIP (2012) (XR-C440/XR-C450: US, Canadian) 1-216-073-00 METAL CHIP 10K 5% 1/10W (XR-C440/XR-C450: US, Canadian) 1-216-069-00 METAL CHIP 6.8K 5% 1/10W 1-216-230-00 1-216-073-00 1-216-061-00 1-216-017-00 1-216-017-00 1-216-073-00 1-216-073-00 1-216-081-00 1-216-081-00 1-216-129-00 METAL GLAZE METAL CHIP METAL CHIP METAL GLAZE METAL GLAZE METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 22K 10K 3.3K 47 47 10K 10K 22K 22K 2.2M 2.2M 2.2 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/8W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W
1-216-129-00 METAL CHIP 1-216-298-00 METAL CHIP
5% 1/10W 5% 1/10W 5% 1/10W 5% 1/8W (XR-C450: E, EA)
51
MAIN
Ref. No. R510 R511 R512 R513 R514 R515 R516 R517 R518 R519 R520 R521 R522 R523 R524 R525 R526 R527 R528 R529 R530 R531 R532 R533 R534 R535 Part No. Description 100K 100K 100K 100K 100K 100K 100K 22K 22K 470 22K 100K 100K 100K 2.2K 2.2K 2.2K 100K 100K 100K 100K 100K 100K 100 10K 33K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 0.50% 5% Remark 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/8W 1/10W 1/10W 1/10W 1/8W 1/10W 1/10W 1/10W 1/8W 1/10W 1/10W 1/8W 1/10W 1/8W 1/10W 1/10W 1/10W (XR-C440) Ref. No. R602 R611 R612 R613 R621 R622 R631 R632 R633 R634 R636 R638 R639 R640 R641 R642 R651 R652 R653 R654 R655 R656 R661 R662 R663 R664 R665 R701 R702 R703 R704 R705 Part No. Description Remark 2.2M 5% 1/10W (XR-C440/XR-C450: E, EA) 10K 5% 1/10W 47K 5% 1/10W 100K 47 2.2K 1.5 1.5 1.5 1.5 330 100 100 2.2K 10K 10K 470K 100K 10K 10K 100 100 2.2K 10K 47K 47K 33K 47 10K 100 100 47K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/6W 1/6W 1/6W 1/6W 1/8W 1/10W 1/10W
1-216-097-00 METAL GLAZE 1-216-097-00 1-216-097-00 1-216-097-00 1-216-097-00 1-216-097-00 1-216-097-00 1-216-081-00 1-216-081-00 1-216-190-00 1-216-081-00 1-216-097-00 1-216-097-00 1-216-246-00 1-216-057-00 1-216-057-00 1-216-057-00 1-216-246-00 1-216-097-00 1-216-097-00 1-216-246-00 1-216-097-00 1-216-246-00 1-216-025-00 1-208-806-11 1-216-085-00 METAL GLAZE METAL GLAZE METAL GLAZE METAL GLAZE METAL GLAZE METAL GLAZE METAL CHIP METAL CHIP METAL GLAZE METAL CHIP METAL GLAZE METAL GLAZE METAL GLAZE METAL CHIP METAL CHIP METAL CHIP METAL GLAZE METAL GLAZE METAL GLAZE METAL GLAZE METAL GLAZE METAL GLAZE METAL GLAZE METAL GLAZE METAL CHIP
1-216-129-00 METAL CHIP 1-216-073-00 METAL CHIP 1-216-089-00 METAL GLAZE 1-216-097-00 1-216-017-00 1-216-057-00 1-249-383-11 1-249-383-11 1-249-383-11 1-249-383-11 1-216-186-00 1-216-025-00 1-216-025-00 METAL GLAZE METAL GLAZE METAL CHIP CARBON CARBON CARBON CARBON METAL GLAZE METAL GLAZE METAL GLAZE
1-216-057-00 METAL CHIP 1-208-806-11 1-208-806-11 1-216-113-00 1-216-097-00 1-208-806-11 1-208-806-11 1-216-025-00 1-216-025-00 1-216-206-00 1-216-073-00 1-216-089-00 1-216-089-00 1-216-085-00 1-216-017-00 1-216-073-00 1-216-174-00 1-216-025-00 1-216-089-00 METAL GLAZE METAL GLAZE METAL CHIP METAL GLAZE METAL GLAZE METAL GLAZE METAL GLAZE METAL GLAZE METAL GLAZE METAL CHIP METAL GLAZE METAL GLAZE METAL CHIP METAL GLAZE METAL CHIP METAL GLAZE METAL GLAZE METAL GLAZE
1/10W (XR-C450) 0.50% 1/10W 0.50% 1/10W 5% 1/10W 5% 1/10W 0.50% 0.50% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/8W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/8W 1/10W 1/10W (XR-C450)
R535 R536 R537 R537 R538
1-216-097-00 METAL GLAZE 1-216-097-00 METAL GLAZE 1-216-089-00 METAL GLAZE 1-216-097-00 METAL GLAZE 1-216-093-00 METAL CHIP
1/10W (XR-C450) 100K 5% 1/10W (XR-C440) 47K 5% 1/10W (XR-C440) 100K 5% 1/10W (XR-C450: US, Canadian) 68K 5% 1/10W (XR-C450: US, Canadian)
100K
5%
< VARIABLE RESISTOR > RV131 RV231 1-223-829-11 RES, ADJ, CARBON 1.0K 1-223-829-11 RES, ADJ, CARBON 1.0K < SWITCH > S501 S502 S503 1-571-478-11 SWITCH, SLIDE (POWER SELECT) 1-571-478-11 SWITCH, SLIDE (FREQUENCY SELECT) (XR-C440/XR-C450: E, EA) 1-692-431-21 SWITCH, TACTILE (RESET) < TUNER >
R538 R539 R540 R540 R541
1-216-097-00 METAL GLAZE 1-216-097-00 1-216-093-00 1-216-097-00 1-216-097-00
100K 5% 1/10W (XR-C440/XR-C450: E, EA) METAL GLAZE 100K 5% 1/10W (XR-C440) METAL CHIP 68K 5% 1/10W (XR-C440) METAL GLAZE 100K 5% 1/10W (XR-C450: E, EA) METAL GLAZE 100K 5% 1/10W (XR-C440/XR-C450: US, Canadian) 1K 1K 5% 1/8W 5% 1/10W (XR-C440/XR-C450: E, EA)
R542 R601
1-216-198-00 METAL GLAZE 1-216-049-11 METAL GLAZE
TU1
A-3282-019-A TUNER UNIT TUX-008 (EA) (XR-C450: E, EA)
52
MAIN
Ref. No. TU1 Part No. Description Remark Ref. No. Part No. Description Remark
A-3282-034-A TUNER UNIT TUX-010 (E) (XR-C440/XR-C450: US, Canadian) < VIBRATOR >
X1 1-577-126-51 VIBRATOR, CRYSTAL (7.2MHz) X501 1-579-233-11 VIBRATOR, CERAMIC (5MHz) X502 1-567-098-41 VIBRATOR, CRYSTAL (32.768kHz) ************************************************************ MISCELLANEOUS ************** 1-776-207-11 CORD (WITH CONNECTOR) (XR-C440/XR-C450: E, EA) 9 1-776-207-31 CORD (WITH CONNECTOR) (XR-C450: US, Canadian) F901 1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE) (10A) HP901 1-500-196-21 HEAD, MAGNETIC (PLAYBACK) M901 A-3291-665-A MOTOR ASSY, MAIN (CAPSTAN/REEL) ************************************************************ ************** HARDWARE LIST ************** #1 #2 #3 #4 #5 7-621-772-10 7-685-793-09 7-685-792-09 7-685-794-09 7-685-106-19 SCREW +B 2X4 SCREW +PTT 2.6X8 (S) SCREW +PTT 2.6X6 (S) SCREW +PTT 2.6X10 (S) SCREW +P 2X10 TYPE2 NON-SLIT 9
3-859-894-11 MANUAL, INSTRUCTION, INSTALL (ENGLISH, ARABIC) (XR-C450: EA) 3-859-492-21 MANUAL, INSTRUCTION, INSTALL (ENGLISH, SPANISH, CHINESE) (XR-C440) 9-939-081-01 LID, BATTERY CASE (for RM-X40) X-3373-371-1 CASE ASSY (for FRONT PANEL) ************************************************************ PARTS FOR INSTALLATION AND CONNECTIONS ************************************** 501 502 503 504 505 506 507 508 509 510 511 512 512 513 514 3-916-161-31 FRAME ASSY X-3370-077-1 SCREW ASSY (AE.KEY), FITTING (XR-C440/XR-C450: E, EA) 3-386-828-01 SCREW, FITTING (XR-C440/XR-C450: E, EA) 3-349-410-01 BUSHING (XR-C440/XR-C450: E, EA) 3-388-078-01 KEY (XR-C440/XR-C450: E, EA) 3-924-961-01 SUPPORT (ND), FITTING (XR-C450: US, Canadian) X-3370-076-1 SCREW ASSY (KEY), FITTING (XR-C450: US, Canadian) 7-682-560-04 SCREW +P 4X6 (XR-C450: US, Canadian) 3-926-426-01 KEY (XR-C450: US, Canadian) X-3371-913-1 SCREW ASSY (J) 3-934-325-01 SCREW, +K (5X8) TAPPING 1-776-207-11 CORD (WITH CONNECTOR) (XR-C440/XR-C450: E, EA) 1-776-207-31 CORD (WITH CONNECTOR) (XR-C450: US, Canadian) X-3373-432-1 BRACKET ASSY (XR-C440) 1-775-543-11 CORD, GROUND
#6 7-624-104-04 STOP RING 2.0, TYPE-E #7 7-627-553-17 PRECISION SCREW +P 2X2 TYPE3 ************************************************************ ACCESSORIES & PACKING MATERIALS ******************************** 1-467-559-22 REMOTE COMMANDER (RM-X40) (XR-C450: E, EA) 1-473-067-31 REMOTE COMMANDER (RM-X2S) (XR-C440) 3-856-246-61 MANUAL, INSTRUCTION, INSTALL (for RM-X2S) (ENGLISH, FRENCH, GERMAN, DUTCH, SWEDISH, ITALIAN, PORTUGUESE, CHINESE) (XR-C440) 3-859-489-31 MANUAL, INSTRUCTION (ENGLISH) (XR-C450: US, Canadian) 3-859-489-41 MANUAL, INSTRUCTION (FRENCH) (XR-C450: Canadian) 3-859-489-51 MANUAL, INSTRUCTION (ENGLISH, SPANISH, CHINESE) (XR-C450: E) 3-859-490-31 MANUAL, INSTRUCTION, INSTALL (ENGLISH, FRENCH) (XR-C450: US, Canadian) 3-859-490-41 MANUAL, INSTRUCTION, INSTALL (ENGLISH, SPANISH, CHINESE) (XR-C450: E) 3-859-491-21 MANUAL, INSTRUCTION (ENGLISH, SPANISH, CHINESE) (XR-C440) 3-859-893-11 MANUAL, INSTRUCTION (ENGLISH, ARABIC) (XR-C450: EA)
501
502 503
XR-C440/XR-C450:E, EA
504
505
XR-C450: US, Canadian
506
507 508 509
510 511
512
513
XR-C440
514
53
XR-C440/C450
REVISION HISTORY
Clicking the version allows you to jump to the revised page. Also, clicking the version at the upper right on the revised page allows you to jump to the next revised page. Ver. 1.1 1.0 Date 2001.08 1997.05 1997.01 Description of Revision Correction-1 is included Correction-1 New
54