Text preview for : Alpine-CDE9802_9801_CDM9803 carrec.pdf part of Alpine CDE9801, 9802, CDM9803 car radio
Back to : Alpine-CDE9802_9801_CDM98 | Home
SERVICE MANUAL
FM/MW/LW/RDS CD Receiver
(CDM-9803R)
TO ALPINE Home Page
2/03-A 68E35086S01
CDM-9803R/CDM-9803RM /CDE-9802RB/CDE-9801R
The following cautions will prevent accidents in the workplace and will ensure safe products. *The symbols indicate caution is needed to prevent injuries and damage to property. The symbols and their meanings follow. If you ignore this symbol and handle the product incorrectly or unsafely, serious injury or death may result. If you ignore this symbol and handle the product incorrectly or unsafely, injury or only material damage may result.
Warning Caution
*The following symbols indicate two levels of cautions. When you see this symbol, you have to be very careful.
When you see this symbol, you have to follow the instructions there.
Warning
Do not look squarely into the laser light coming from the pickup.
You may loose you sight.
Fuse Caution
Always use a designated fuse. Use of an incorrect fuse may result in a fire.
Caution
Do not allow wiring to be caught in the screw/chassis.
If wiring is caught in the screw/chassis, it may cause a short circuit, resulting in a fire.
Battery Caution
Use the designated battery. Confirm the correct polarity and seat of the battery. An incorrect battery or an improperly connected or seated battery may result in a fire.
High Temperature Caution
Touching the heat sink may cause severe burns.
Designated Parts Caution
Look up the part list and ensure that only designated parts are used to prevent problems or accidents.
Reverse Power Supply Connections or Misconnections Caution
Reverse power supply connections or misconnections may cause ignition problems and smoke may result.
Wiring Caution
Ensure that the wiring is correct when rewiring to prevent problems with ignition/breakdown.
Soldering Caution
Hot solder from solder splash may cause severe burns.
Wear Gloves
Wear gloves to prevent electrical shocks or injury from the end face of the metal.
Contents
Packing Assembly Parts List Packing Method View Specifications Adjustment Procedures Adjustment Locations Extension Cable Block Diagram Parts Layout on P.W.Boards and Wiring Diagram Schematic Diagram Terminal Voltage of IC/TR Description of IC Terminal Exploded View (Cabinet) Exploded View (CD Deck Mechanism) (DP23S2B0)
Cabinet Assembly Parts List Deck Assembly Parts List Electrical Parts List
NOTE : Due to continuing product improvement, specifications and designs are subject to change without notice.
Packing Assembly Parts List
Symbol No. 101-1 101-2 101-3 102 103 104 #1 $1 &1 105 105 105 03S72235F13 36A11113W01 03A11112W01 15D00529K02 15D01798K01 68P02294K52 01T15359Y03 01T15359Y03 01T15359Y04 01T15359Y03 SCR,MCH M5X8 FLAT CAP,RUBBER(A) BOLT,HEX.M5(A) CASE,INNER CARRYING,CASE O/M AOEU AODN ASSY,ISO CONN 7837R0 ASSY,ISO CONN 7837R0 ASSY,ISO CONN 7842R ASSY,ISO CONN 7837R0 Part No. Description Symbol No. Part No. Description
%1 105
Note : #1 : For CDM-9803R Model Only, $1 : For CDM-9803RM Model Only, %1 : For CDE-9802RB Model Only, &1 : For CDE-9801R Model Only, Others : Common.
Packing Method View
104
103
102
BO T SID TOM E
105 101
TO CONTENTS
Specifications
Intermediate Frequency ......................................................................................................................... 10.7±0.2MHz Frequency Range ............................................................................................................................ 87.5 to 108.0MHz Usable Sensitivity (Mono, 30dB S/N, at 98.1MHz) .......................................................................................... 20.2dBf -3dB Limiting Sensitivity (at 98.1MHz) ............................................................................................................ 19.2dBf Residual Noise (Ref. 400Hz (WID), at 98.1MHz) .......................................................................................... 25±10dB S/N Ratio (at 98.1MHz) ......................................................................................................................... Stereo : 50dB Mono : 55dB Image Rejection (at 106.1MHz) .......................................................................................................................... 40dB IF Rejection (at 90.1MHz) ................................................................................................................................... 60dB Distortion (Input 60dBu, at 98.1MHz) .................................................................................................................. 1.5% Frequency Response (Ref. 400Hz, at 98.1MHz) ................................................................................. 100Hz : 0±3dB 10kHz : -12±3dB Stereo Separation (1kHz, at 98.1MHz) ............................................................................................................... 20dB PS Sensitivity (at 98.1MHz) ............................................................................................................................ 36.2dBf TP OFF Alarm (at 98.1MHz) ...................................................................................................................... 70±10Sec.
Intermediate Frequency ................................................................................................................. 1st. IF : 10.71MHz 2nd. IF : 450kHz Frequency Range .............................................................................................................................. 531 to 1,602kHz Usable Sensitivity (20dB S/N, at 999kHz) ........................................................................................................... 36dB S/N Ratio (at 999kHz) ......................................................................................................................................... 42dB Image Rejection (at 603kHz) ............................................................................................................................... 40dB IF Rejection (at 603kHz) ..................................................................................................................................... 40dB Distortion (at 999kHz) .......................................................................................................................................... 1.5% Frequency Response (Ref. 400Hz, at 999kHz) ............................................................................. 100Hz : -3+3,-4dB 4kHz : -12+4, -8dB
Intermediate Frequency ................................................................................................................. 1st. IF : 10.71MHz 2nd. IF : 450kHz Frequency Range ................................................................................................................................. 153 to 281kHz Usable Sensitivity (20dB S/N, at 216kHz) ........................................................................................................... 43dB S/N Ratio (at 216kHz) ......................................................................................................................................... 40dB Image Rejection (at 270kHz) ............................................................................................................................... 40dB IF Rejection (at 162kHz) ..................................................................................................................................... 50dB Distortion (at 216kHz) .......................................................................................................................................... 1.5% Frequency Response (Ref. 400Hz, at 216kHz) ............................................................................. 100Hz : -3+3,-4dB 4kHz : -12+4, -8dB
Wave Length .................................................................................................................................................... 795nm Laser Power ................................................................................................................................................... CLASS I
TO CONTENTS
System ....................................................................................................................... Optical (Compact Disc System) Channel Balance (1kHz, TCD-782) ................................................................................................................... 0±3dB Distortion (1kHz, TCD-782) ................................................................................................................................. 0.1% Frequency Response (Ref. 1kHz, TCD-782) .......................................................................................... 17Hz : 0±3dB 127Hz : 0±2dB 10.007kHz : 0±2dB 19.997kHz : 0±4dB S/N Ratio (TCD-782) ........................................................................................................................................... 85dB Separation (1kHz, TCD-782) ............................................................................................................................... 55dB De-Emphasis (Ref. 1kHz, TCD-782) .................................................................................................. 4kHz : -20±3dB 16kHz : -20±3dB
Power Supply ................................................................................................................................................ DC14.4V Power Output (Ref. CD Mode/SP-OUT, T.H.D. 10%)/Impedance SUB-W OFF Mode, Rear PRE-OUT Mode) Dimensions (W x H x D) ................................................................................................. Chassis : 178 x 50 x 160mm Nose : 188 x 58 x 27mm Weight ................................................................................................................................................................. 1.5kg NOTE : Due to Continuing product improvement, specifications and designs are subject to change without notice. ........................................................ 16W/ch/4ohm ................................... 2V±2.5dBV/ch/10kohm Pre Output (Ref. CD (TCD-782 (0dB/1kHz)), T.H.D. 1%, /Impedance
TO CONTENTS
Adjustment Procedures
1. FM SECTION
(1) Dummy Antenna Circuit
10ohm Input 45ohm 60ohm
Output
For 50 ohm FM Signal Generator
Figure 1
(2) Connections
Antenna Receptacle DC Volt Meter
+ FM Signal Generator
FM Dummy Antenna
TP1 + TP2 Unit Under Test Figure 2
(3) Control Settings Power Switch .............................................. ON Fader/Balance Control ............. Center Position Treble/Bass Control ................. Center Position (4) Adjustment Procedures
Step Description Connection Signal Generator 98.1MHz, 72dBµ (Mod. OFF/ ST OFF) Dial Control Test Point TP1 TP2 Adjustment
Band Switch ............................................ FM LOUD/SUB-W ....................................... OFF Others ................................................... OFF
1
0V Adjustment
Figure2
98.1MHz
Adjust for 0V±15mV.
Adjustment Locations
0V Adjustment VR
TP1
TP2
TUNER Unit (TU001) (Component Side View)
TUNER Unit (TU001) (Foil Side View)
TO CONTENTS
Extension Cable
* When repairing or measuring the voltage of this unit, connect with the Extension Cable as shown in below.
CD MECHANISM (DP23S2B0)
Wire Assy 7P 01E34878S01
Connector Assy 7P 01E33206S01
Connector Assy 15P 01E33204S01 Extension Cable 15P 01E33207S01
Extension Cable 7P 01E33205S01
Main P.W.Board
TO CONTENTS
Block Diagram
ANT Mini BUS-IN #1,$1 Mini BUS
FM AM
E-VOL Selector Vol.1 Tre/Bass Vol. 2
L.P.F.
CD
RDS Tuner Unit TUNER+B MUTE DRIVER
#1,$1
MUTE MUTE
REAR/Sub-W #1,$1 FRONT
CD MECHA u-COM
CD LSI DRIVER
Mini BUS #1,$1 I/F SYSTEM RESET MAIN u-COM CD VDD 5V SERVO +B 7V BATT DET ACC DET POWER ON +B
POWER-IC
REAR
Power Connector
DP23S2BO
FRONT
BUFFER
BATT ACC P.ANT O.REM
P.ANT O.REM
LCD/KEY DRIVER
LCD Display (14 Seg. X 8 )
KEY MATRIX NOTE : #1 : For CDM-9803R Model Only, $1 : For CDM-9803RM Model Only, Others : Common.
TO CONTENTS
47k
N.U.
#1, $1 Model Only Q601 DTA124EKA D601 R630 22k 1SS133
%1, &1 N.U.
R633
R643
R631 22k-1/4 R632 220-1/4
R638
12k
R606 1k
FMG1 Q602 R628 C628 N.U. #1, %1, &1 180k-F 0.01 TP606 R658 100k-F N.U. R637 R601 R602 C601 12k #1, %1, $1 N.U. $1 TP605 R672 TP601 TP602 TP603 N.U. 22k-1/4 N.U. N.U. TH601 100k 1000p C662
C610
R686 R607 10k
2.2k
R671
10k-1/4
$1
R641
330p R653 3.9k-F
R604 22k Q664 DTA143EKA R649 D662 DAN202k 10k R621 R611 100k-F IC601 D784216AGF TP604 R665 N.U. #1, $1 22k-1/8 %1, &1 C609 18p
10k-F R650 IC602 S-80930CNMC
2.7k-1/4 C612
R642
1k
SW601 SKHHLW
IC651 TDA3606AT 0.022-B
C608 XL601
18p
C814 1000p
L601 4.7uH
12.288MHz R663 22k-1/4 #1, $1 N.U. %1, &1 Q651 FMC2
C651
56k
C613 0.047-B 330k-1/8 R657 120kF E651 33/16 R808 470-1/4 C652 N.U. R651 R656
R664 47k-1/8
R661 22k-1/4 %1,&1 N.U. #1,$1
R662 12k #1, $1 N.U. %1, &1
270
270 1k
R617 1k-1/8
Ik-1/8 R613
TP609
TP610
TP600
1k
R618 0
R600 47k
R666
R668
R667
R635
R634
R625 R626 R619 R620
10k 10k C602 0.022
L602 4.7uH Q652 FMC2
R636 47k-1/8 0-1/8 0-1/8 0-1/8
ZD652 HZS7B2L
L651 4.7uH
R654 4.7k-1/4
1000p
C501
R629
R640
470k
C653
C611 #1, $1 Model Only %1, &1 N.U. 47k 22/16 E601
0.022
R647 4.7k-1/8
R605
1k R623 Q606 2SA1037AK Q605 DTC114EKA R622
Q604 FMC3
R648 22k
R639 22k
R609 12-2W R646 4.7k-1/8 R660 10k-1/4 %1 Model Only #1, $1, &1 N.U. Q608 UN2212 Q807 2SD1760
Q607 DTC114EKA D602 DAN202K C604
1k-1/8
1k-1/8
1k-1/8
10k R608 R627 Q603 DTC114EKA C603 100p 10k-1/8 0.01
1k-1/8
R659 10k-1/4 ZD803 HZS9C2L
R615
R616
R614
R612
C605 0.1
3.3k
JK001 JAC, CK-3.5-14
C606 2200p
CB601 BTB, TMD-V15X-A1
R603 12k-1/8
E604 10/16
C607 0.1
R645 100-1/4
R624
TO P. W. Board
R803 100k
TO PARTS LIST
E805 1/50
2.2k
R655 4.7k-1/4
1SS133
E602 220/10
HM102
Z601
47k-1/8
47k
R644
D653
0.1
0.1-B
TO CONTENTS
#1, $1 Model Only
%1, &1 N.U.
#1, $1 Model Only E261 R261
%1, &1 N.U. R265 100 R283 51k
1C203 R241 1.3k E241 22/16
BA4560F R242 1.3k 2.2/50 Q261 DTC343TK Q262 DTC343TK E262 2.2/50 R262
200
%1, &1 Model Only
#1, $1 N.U. JK201 ASSY, CONN NLT1660
WTB202 CONN RCA 9801R R284 51k R266 200 100 R269 100 R270 51k #1, $1 Model Only %1, &1 N.U. ASSY, CDNN NLT1661 51k R272 100 C212 C213 C311 C312 C313 0.22-TF 0.22-TF 0.22-TF 0.22-TF C214 C211 WTB201 CONN RCA 9803R
C204 R201 6.8k 0.012-B E215 E216
E263 2.2/50 1/50 1/50 IC201 TDA7404 Q263
R267
200
DTC343TK Q264 DTC343TK E264
E211 E213 E214
1/50 1/50 1/50 200 R268 10/16 10/16 R204 1k 1k R205 R312 0 %1, &1 N.U. #1, $1 E312 E314
R271
E211
1/50
N.U.
N.U.
0 %1, &1 N.U. #1, $1 R311
2.2/50 E311 E313 10/16 10/16
C314
R305
10k-1/4
0.22-B
C303
R399 0 47/16 Q301 DTC124EKA 100/16 C201 E202 N.U. E304
0.047
C310
E201
1/50
0.22/50
E302
10/16
E303
IC301 TA8263BH
N.U.
N.U.
0.047
3300/16 E801
TP201
1SS353
D862
SRT14 D305 SRT14 D306 SRT14 D307 SRT14 D308
SRT14 SRT14
C801
D302 SRT14 SRT14 D303 D304
Q201 DTC124EKA C209 0.068
C800 1000p L801 CHOKE
SD801 CB801 WTB, IMSA9451B-16
DSA3A4
R866
D301
N.U.
ILLM %1 NC #1, $1, &1
PS801 D861 1SS133 R867 100-1/4 R823
PTGL05BA1R8M1
R802 0.022 C808 C811 R801 1.8k-1/4 MPG06G R829 10k-1/4 0.1-TF DIN501 DIN, SKT 8P CMS-R 1k-1/4 C810 0.01(630V) C813 0.01 (630V) 3 10k-1/4 0.01(630V) Q810 2SB1243 R827 1 2
Q805 2SC3421
24k-1/4
Q803 2SB1243 R806 1.8k-1/4 R812 1.5k-1/4
Q813 N.U.
N.U. R824 N.U. R825 N.U. R826 N.U. D803 N.U. R853 10k 1
R804
R820
220/10
100/16
R865
E803
N.U.
N.U.
1.8k-1/4
ZD802 HZS9C1L
1.5k-1/4
R805
R813
100/16
E842
R864 10k
2
D804
RB33
C802
Q862 FMC2
E800
Q814 N.U.
22k RB28 1.8k-1/4
270k
R807 820-1/4 47/16 E861 33/16
E804
R822 N.U.
R821
E203 E204 2.2/50 2.2/50
Q804 DTC143XKA E810 Q815 DTC143EKA N.U.
3 2
E205 2.2/50
R810
N.U.
Q863 DTC124EKA
#1, $1 Model Only %1, &1 N.U.
TO P. W. Board
TO PARTS LIST
TO CONTENTS
3k-1/8 R017 47k R016
R015 18k R014 68k R013 3.3k
R012
10k C051 330p C059 560p E010 1/50 C060 0.1
R010 R011
2200p IC007 BA4558F-E2 E011 10/16 C011 100p C013 N.U. IC007 BA4558F-E2
C010 0.01
C012 560p
C055
ANT001 ASSY, ANTCABLE ISO03R TP001 TP002
10k
10k
5.6k R065 R067 1k R068 1k R669 JP-1/8 R670 JP-1/8 R069 4.7k C063 C061 Q003 2SD1994A R004 3.3k-1/4 ZD002 HZS6B1L E001 1/50 100p XL002 4.332MHz 27p C062 100p
R063
10
SA001 DSP-201M VT001 N.U. 15uH L002 D001 1PS226 0.022 0.01 Q004 DTB123YK C047 0.1-TF C046 0.01 R050 3.9k R051 47 R007 10k R053 18k C048 0.01 R054 1k C049 E017 2.2/35 0.27-TF R055 2.2k R056 1k IC006 NJM2904M R057 0 C056 100p
4.7uH
L001
R049 1k IC006 NJM2904M E005 47/16 R008
10-1/4
R001
C050
N.U.
TU001 MX-E062
C058
C044
C045
E016 47/16
39k
0.1
2.2/50
0.022
E019
C066
C064
E006 47/16 N.U.
2.2-1/4 R042 330-1/4 C042 0.022 D002 1PS226 220/10 E013 E003 33/16
Q006 2SD601A 4.7k-1/4 R006 E018 22/16 R009 100-1/4
R036
R025 47
C019 1000p
R028 43k-1/8 R029
C033 1000p
C034 10k 10k C036 1000p R059 R060 R061 R062 C037 R030 47k E008 1/50 1000p 10k 2.2k 0.01 R021 IC002 MC14066BFEL Q012 FMC2 R073 10k
IC003 LC72191JM
1k
1k
TP005
HZS9B2L ZD001
C017 0.01
27p
Q001 R003 2SD1994A
Q002 2SD1994A
R071 C065 2200p
R002 2.2-1/4
R052 22k
470k
R070 N.U.
Q013 FMC3
E020 22/16 0.22 C0.38 Q011 DTC124EKA R031 JP C053 R032 0.022 0.022 N.U. N.U. JP Q009 FMG1 39k 0.01 C068 0.033
R033
R034
C039
C040
R035
C054 0.01
Q010 DTC124EKA
XL001 7.2MHz C041 100p
27p
C069
Q005 2SD601A
HZS12B1L ZD003
10/16
E002
R005 4.7k-1/4
TO P. W. Board
C070
27p
R066
5.6k
IC004 SAA6588T
TO PARTS LIST
TO CONTENTS
TP732
TP733
TP734
TP735
TP728
TP729
TP730
R734 100
R735 100
100-1/4 R736
R737 100-1/4
TP731
C720 0.1 33k 0.1 R743 R744
TP703
TP704
TP701
TP702
C722 0.033 C723 0.1 C724 E707 10/16 R706 10k R705 15k C748 N.U. C747 N.U. R704 39k TP720 C726 0.22
R724
R723 10k
33k
CB102 IMSA9615S-07A
R707 10k
C708 0.1
TP727
C725 3900p
TP726
C721
39k 0.1
R745 33k
TP736 C727 22p-CH R725 7.5k-1/8 5p-CH TP749 N.U. N.U. IC702 UPD63711A TP725 E729 56p-CH C730 R714 N.U. TP724 22/10-TA TP742 TP738
TP715
IC701
BA5984FP
C728 R738
TP705 R701 10-1/4
E703 10/16-TA
R739 C702 E701 47/16 0.1 C750 560p-CH D701 1SS355 1SS355 D702
TP706
R702 10-1/4 2SB1132 Q701
TP737 TP745 TP744
C709
SW105 SPPB120
0.1
R721
N.U.
HD101 PICKUP EP21A67L
R710 R709 10k
R711 22k
CB101 IMSA9615S-15A R708 TP101 22k
N.U.
150p-CH C749
C712
R715 N.U.
10k
C731 39p-CH TP755 0.1 C732 TP739
M102 ASSY, MOTOR SLED 2BO
ASSY, MTR SPINDOL 2BO
C706 0.1
C705 0.1
C704 0.022
M103
C719
0.1
C710
IC704 AN80M50RSPE1
R726 100
E737 47/16
C736
R731 N.U.
D703 1SS355
R727 27k
TP710
TP707
TP709
TP708
R720 N.U.
E716
R741 J
C703 0.022
R742
0.022 C718
22/16
E717
Q702 DTC124EUA
CL701 16.9MHz 22p-CH C701
N.U.
R763 N.U.
SW4 SPVG23
SW3 SPVG21
SW2 SPVG13
SW1 SPVG23
CH103 ASSY, WIRE JOINT 7P
CB103 53253-0710
47/16
RA701 100x4 TP754 TP740 TP756 47k R712 R713 47k R703 47k RA702 100x4
47k 47k
47k
47k
47k
47k 47k
47k
47k
R718 47k
R766 N.U.
N.U.
C700
TP712
R719 R762
R764
R722
R729
R732 R733
R740
R746
TP760 R747 33k IC703 D789026GB R748 C717 47k TP761 R717 220 R749 N.U.
R716 220 2200p C714
TP711
R730 N.U. TP202 TP777
TP723
0.1 100 R760 47k 47k 47k R751 10k
TP713 E704 47/16 CL702 4.19MHz R761 100
R759 33k
R755 47k
R758
R757
R756
TP762 C716 0.01
TP763 M101 ASSY, MOTOR WORM 2BO
R754 47k
47k R752
TP768 TP769 TP770 TP771 TP772 TP773 TP774 TP775 TP776 TP778
R753 47k
TO P. W. Board
C729 0.1
R750 J
TO PARTS LIST
2200p
C715
C713 0.1
0.1
100k
E733 10/16
C734 0.1
E738 10/16-TA
E736 10/16-TA
2.2/16-TA E735
R728
0.1
C711 1000p
TO CONTENTS
C104 R103 560-1/4 R104 C101 N.U. 560-1/4 C105
3300p
3300p
L751 220uH
Q751 2SB1261 Q752 FMC2 100-1/4 R768 560-1/4 R765
R769 22k-F-1/8
R767
560-1/4
D751 SB040
R771 430k
E752 470/10
C707
N.U.
C752
120p
0.022
C751
R772 N.U.
IC751 MC34083AML
C733 N.U.
R770 4.7k-F-1/8
E751
10/16
TO P. W. Board
TO PARTS LIST
TO CONTENTS
LCD401 LCD, WTD-21544ABHU #1 LCD, WTD-21654AAHU #1 LCD, LUC1382A %1 LCD, LUC1382A &1
IC401 PT6583LQ
R462 0 N.U. %1, &1 #1, &1
R407 R408 R409 C401 0.047 C402 0.047 1k 1k 1k C403 R410 C404 SW415 SW403 SW416 SW411 SW417 SW412 SW405 SW413 SW407 SW418 SW419 SW414 SW409 D401 MA159 MA159 D402 SW408 SW406 #1 $1 Model Only SW404 %1, &1 N.U. SW410 SW402 SW401 0.047 47k ZD401 RD6.2MB3 R411 4.7k R412 100k 1k 1k 1k 1k 1k 1k 820p R420 2.2k N.U.
R406
R403 R405
R404 R402
R401
R413 R414 R415 R416 R417
1k 1k 1k 1k 1k
% Model Only
Q401 %1 2SD1328 N.U. #1, $1, &1 %1 #1, $1, &1
#1, $1, &1 N.U.
D404 LD425 EB1111C LD423 EB1111C 1PS226 R425 200-1/4 R419 R418 0-1/4 #1, $1, &1 82-1/4 %1 0-1/4 #1, $1, &1 82-1/4 %1 1PS226 LD422 EB1111C LD421 EB1111C D406 R427 200-1/4 R423 200-1/4 1PS226 D407 PL403 N.U. $1, %1 6V-80mA #1, &1 R460 R459 33-1/4 $1 33-1/4 $1 N.U. #1, %1, &1 N.U. #1, %1, &1 PL406 PL405 6V-80mA #1, &1 6V-80mA #1, &1 N.U. $1, %1 N.U. $1, %1 R428 1PS226 27-1/4 #1 &1 36-1/4 $1 N.U. %1 PL404 6V-80mA #1, $1, &1 N.U. %1 R443 36-1/4 $1 N.U. #1, %1, &1 R424 27-1/4 N.U. R457 #1, &1 $1, %1 D408 1PS226 R421 200-1/4 D405
LD405, 406, 411, 412, 413, 418;
LD418
LD411
680-1/4 #1, $1, &1 LD427 AA1111C #1, $1, &1 1.8-1/4 %1 BR1111C %1 R430 220-1/4 $1 LD405 560-1/4 %1 R429 N.U. #1, &1 AA1111C $1 BR1111C %1 LD413 LD412 N.U. #1, &1 R432 LD406 220-1/4$1 R431
220-1/4 $1 560-1/4 %1 N.U. #1, &1 220-1/4 $1 560-1/4 %1 N.U. #1, &1 BG1111C #1, &1 EB1111C %1 N.U. $1 FA1112C $1 N.U. #1, %1, &1 LD407 LD414 R458 270-1/4 #1, &1 220-1/4 $1 330-1/4 %1 560-1/4 %1 N.U. #1, &1 R437 270-1/4 #1, %1, & 1 220-1/4 $1 R438 270-1/4#1, $1, &1 LD415 LD408 560-1/4 %1 R434 R433 270-1/4 #1 %1, &1 220-1/4 $1 270-1/4 #1 %1, &1 560-1/4 $1
BG1111C #1, &1 AA1111C $1 BR1111C %1
LD419
LD416
LD409
R439 150-1/4 #1, &1 220-1/4 $1 560-1/4 %1 R440 150-1/4 #1, &1 220-1/4 $1 LD420 LD417 LD410 1k-1/4 %1 PL401 9V-100mA #1, $1, &1 N.U. %1 PL402 9V-100mA #1, $1, &1 N.U. %1 R441 15-1/4 #1, $1, &1 N.U. %1 R442 15-1/4 #1, $1, &1 N.U. %1 R435
LD408-410, 415-417, 419, 420; MAZS180 D403 1PS226 LD404 NSCWS405T
220-1/4 #1 $1, &1 560-1/4 $1
R436
220-1/4 #1 $1, &1 820-1/4 $1
TO P. W. Board
ZD403
LD403 NSCWS405T
R445 120-1/4
R444 56-1/4
MAZS180 R455 N.U. LD402 NSCWS405T
ZD402 LD401 NSCWS405T
IC402 RS-671
R447 120-1/4
R446 56-1/4
C405 1u-B
R456 100 R453 %1 Model Only #1, $1, &1 N.U. 10k-1/8 R448 10k-1/8 10k-1/8 1k-1/8 R452 R451 10k-1/8
C407 0.022
C406 0.022
1k-1/8 #1, $1 N.U. %1, &1 R449 R450
TO PARTS LIST
TO CONTENTS
R454 CH401 BTB, TMD-V15P-A1 N.U.
Terminal Voltage of IC/TR
IC002 1 2 3 4 5 6 7 4 4 NC 12 12 0 / 11 0 8 9 10 11 12 13 14
FM / AM
12 12 12
IC003 1 2 3 4 5 6 7 8 9 10 11 12 2.4 0 0 0 0 0 0 5.2 NC 0 0 8.2 / 0 13 14 15 16 17 18 19 20 21 22 23 24 0 / 8.4 NC 0 0 NC 0 2.7 5.2 4.2 2.9 0 2.7 FM / AM
FM / AM
IC004 1 2 3 4 5 6 7 8 9 10 0.2 0.2 0 2.6 2.2 0 5.2 5.2 5.2 4.6 11 12 13 14 15 16 17 18 19 20 NC 0 2.6 5.2 0 2.6 2.6 2.6 2.5 2.6 1 2 3 4 4.2 4.2 0
IC006 5 6 7 8 2.8 2.9 12
IC007 1 2 3 4 2.6 2.6 2.6 0 5 6 7 8 2.6 2.6 2.6 5.2
IC201 1 2 3 4 5 6 7 8 9 10 11 12 13 14 4.3 4.3 4.3 4.3 4.3 4.3 4.3 4.4 4.3 4.3 4.3 4.3 4.3 4.4 15 16 17 18 19 20 21 22 23 24 25 26 27 28 0 4.4 4.4 4.4 4.4 4.4 4.4 4.4 5 0.5 0.5 8.7 4.4 4.4 1 2 3 4
#1,$1 IC203 4.4 4.4 4.4 0 5 6 7 8 4.4 4.4 4.4 8.8
NOTE : #1 : For CDM-9803R Model Only, $1 : For CDM-9803RM Model Only, Others : Common.
TO SCHEMATIC
TO CONTENTS
IC301 1 2 3 4 5 6 7 8 9 10 11 12 13 0 0 7.5 5 7.5 14.2 7.6 0 7.6 8.5 1.4 1.4 0 14 15 16 17 18 19 20 21 22 23 24 25 1.4 1.4 1.4 7.6 0 7.6 14.2 7.5 4.1 7.5 0 NC
IC401 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 2.4 2.4 2.4 2.4 2.5 2.4 2.5 2.4 2.5 2.4 2.4 2.4 2.4 2.4 2.4 2.4 2.4 2.4 2.4 2.4 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 2.4 2.4 2.4 2.4 2.4 2.4 2.4 2.4 2.4 2.4 2.4 2.4 2.4 2.4 2.4 2.4 2.4 2.4 2.4 2.4 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 2.4 2.4 2.4 2.4 2.4 2.4 2.4 2.4 2.4 2.4 2.4 2.4 2.4 2.4 2.4 2.4 2.4 2.4 2.4 NC 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 4.9 4.9 4.9 4.9 0 0 0 0 0 4.9 3.2 1.6 0 0 3.8 4.4 4.9 0.7 0.2 1.3
#1,$1 IC402 1 2 3 4 4.9 0 0 0.2
NOTE : #1 : For CDM-9803R Model Only, $1 : For CDM-9803RM Model Only, Others : Common.
TO SCHEMATIC
TO CONTENTS
IC601 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 NC NC 4.96 1.3 0.7 0.2 4.8 NC 4.96 4.96 4.92 NC 4.9 NC 4.94 4.94 NC 4.94 4.7 NC NC 0 NC NC 4.7 4.9 0 0 0 0 4.95 / 0 4.95 / 0 0 4.96 / 0 4.95 / 0 0 / 4.95 4.96 2.7 2.5 0 NC 0 4.95 4.96 4.95 NC 4.97 0 4.96 0 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100 4.96 4.96 4.8 2.5 4.6 / 3.6 0.3 NC 3 0 NC 0 NC NC 4.96 4.94 4.96 NC 4.96 / 0 0 4.95 / 0 NC NC NC 4.95 NC 4.9 0 0 4.95 / 0 5.2 0 0.2 4.9 / 0 0 NC 4.95 NC NC NC NC NC NC NC NC NC NC NC NC 4.94 0
FM / AM
CD / RADIO CD / RADIO
$1 / #1,%1,&1
%1,&1 / #1,$1 CD / RADIO CD / RADIO CD / RADIO %1,&1 / #1,$1
MONO / ST
NOTE : #1 : For CDM-9803R Model Only, $1 : For CDM-9803RM Model Only, %1 : For CDE-9802RB Model Only, &1 : For CDE-9801R Model Only, Others : Common.
TO SCHEMATIC
TO CONTENTS
1 2 3 4 5
IC602 4.95 4.95 0 NC 0
1 2 3 4 5
0 0 0 3.6 4.9
6 7 8 9 10
2.7 0 0 0 0
IC651 11 12 13 14 15
0 0 0 NC NC
16 17 18 19 20
5 14.2 0 0 0
IC701 1 2 3 4 5 6 7 8 9 10 0 2.5 2.5 2.5 2.5 2.5 2.34 7.1 0 0 11 12 13 14 15 16 17 18 19 20 3.8 2.8 3.34 3.3 3.4 3.4 3.4 3.3 0 2.5 21 22 23 24 25 26 27 28 4.6 2.5 2.5 2.5 2.5 2.5 2.5 0
at CD mode
at CD mode
at CD mode
IC702 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 0 5 5 3.2 4.9 3.6 0.9 2.2 0 5 5 2.5 0 2.6 0 2.4 5 0 5 5 0 5 1.93 2.3 0 5 NC 0 2.5 2.5 2.5 2.5 2.5 2.5 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 0 NC 0 2.9 0 5 5 2.5 0 2.6 0 NC NC 0 0 NC 5 NC NC 0 0 0 0 0 0 NC 25 2.5 2.5 2.6 NC NC NC NC 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100 NC 5 2.5 2.5 2.9 2.5 2.5 2.5 2.1 NC 2.2 2.3 0 2.6 2.5 2.6 2.5 2.9 2.9 5 2.5 2.5 2.5 2.5 2.5 2.6 2.5 0 0.2 3.8 0 5
at CD mode
at CD mode
at CD mode
TO SCHEMATIC
TO CONTENTS
IC703 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 0 0 0 0 0 5 0 0 0 0 0 0 0 3.2 2.6 0 5 5 5 0 0 0 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 0 1.2 5 0 5 5 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0
at CD mode
at CD mode
IC704 1 2 3 4 5 7.1 7.1 0 1.26 5 1 2 3 4 5 6 7 8 9.1 0 0.8 0 1.26 14.2 14.2 9.1
IC751
at CD mode
at CD mode
TO SCHEMATIC
TO CONTENTS
Pin No. Q009 Q012 Q013 #1,$1 Q602 Q604 Q651 Q652 Q752 Q862
1 12 NC NC 4.97 NC NC NC NC NC
2 0 0/1 14.2 14.2 4.93 4.96 4.95 14.2 / 0 0
3 0.94 5.2 14.2 0 5 4.96 4.96 14.2 14.3
4 0 0 14.2 0 4.92 4.96 4.95 4.9/0 0
5 11 0 0 0 0 0 0 0 0
NOTE FM / AM
CD / RADIO
Pin No. Q001 Q002 Q003 Q004 Q005 Q006 Q010 Q011 Q201 #1,$1 Q261 #1,$1 Q262 Q263 Q264 Q301 %1 Q401 #1,$1 Q601 #1,$1 Q603 #1,$1 Q605 #1,$1 Q606 #1,$1 Q607 %1 Q608 Q664 Q701 Q702 Q751 Q803 Q804 Q805 Q807 Q810 Q815 Q863
B 9.1 9.1 5.8 0 / 8.4 12.7 14 0 4.9 0 0 0 0 0 0 0.6 5 1.8 2.7 4.8 0 0 4.95 3.8 0 14.4 13.5 4.9 9.3 9.5 13.5 4.8 4.94
E 8.5 8.5 5.2 8.5 12 13.3 0 0 0 0 0 0 0 0 0 5 0 0 4.9 0 0 4.95 4.5 0 14.4 14.3 0 8.6 8.9 14.2 0 0
C 14.3 14.3 14.3 8.4 / 0.3 14.2 14.2 12 0 5 0 0 0 0 4.1 0.1 0 0 0.6 0 4.7 4.95 0 2.1 2.5 7.2 / 0 14.2 0 14.3 14.4 14.2 0 0
NOTE
FM / AM
CD CD CD / RADIO
NOTE : #1 : For CDM-9803R Model Only, $1 : For CDM-9803RM Model Only, %1 : For CDE-9802RB Model Only, Others : Common. [Measuring Conditions] 1. Power Supply oltage 2. Measuring Meter 3. Measuring Point Reference 4. Measuring Conditions
: DC14.4 : Digital Multi oltmeter : Between GND : FM : 98.1MHz AM : 999KHz CD : at playing Disc * All the data was measured in FM mode expect noted.
TO SCHEMATIC
TO CONTENTS
Description of IC Terminal
D784216AGF : IC601
No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 / LCD RST LCD DI LCD CE LCD CLK LCD DO NC VDD POWER IC ON NOSE POWER NC POWER CONT NC SD SW 50k REF NC V-CONT #1,$1 REMOCON %1,&1 NC NC Vpp NC RDS SCL RDS SDA E.VOL SCL E.VOL SDA PLL CE PLL DO SEL1 /CD STBY 0 MUTE-DET /CD RST /CD CS V-Link Select VDD X2 X1 GND XT2(NC) GND /RESET BATT DET No connect terminal. O O O O I O O O O O O I RESET signal output terminal to LCD Driver (LC75883). Serial Data signal output terminal to LCD Driver (LC75883). Chip Enable signal output terminal to LCD Driver (LC75883). Serial Clock signal output terminal to LCD Driver (LC75883). Serial Data signal input terminal from LCD Driver (LC75883). No connect terminal. Power supply terminal. STBY CONT signal output terminal to Power IC. Power supply control signal output terminal of LCD Driver and Remote Control. No connect terminal. Power supply control signal output terminal of Audio and Key lighting. No connect terminal. Time Constant switching terminal of High Speed PLL active by AF Check etc. LPF switching output terminal at RDS active. No connect terminal. Power supply control signal output terminal of Servo/Mechanism. Remote Control Data input terminal. Symbol NC I/O No connect terminal. Terminal Description
O I/O O I/O O I I O I O O I I I
Flash Memory writing terminal. No connect terminal. RDS Clock output terminal from RDS Decoder (SAA6588T). RDS Data input/output terminal to RDS Decoder (SAA6588T). Serial Clock signal output terminal to E.VOL (TDA7404). Serial Data signal input/output terminal to E.VOL (TDA7404). Communication CONT signal output terminal to PLL (LC72191M). Data input terminal from PLL (LC72191M). Model selection input terminal. Stand-by control signal output terminal of Mechanism u-COM. 0-bit MUTE signal input terminal. RESET signal output terminal of Mechanism u-COM. Communication control signal output terminal of Mechanism u-COM. V-Link set up input terminal. Power supply terminal. Main System Clock OSC input terminal. (12.288MHz)
GND connect terminal.
No connect terminal.
GND connect terminal.
System RESET signal input terminal. BATT detect signal input terminal. (Compulsion Stand-by)
NOTE : #1 : For CDM-9803R Model Only, $1 : For CDM-9803RM Model Only, %1 : For CDE-9802RB Model Only, &1 : For CDE-9801R Model Only, Others : Common.
TO SCHEMATIC
TO CONTENTS
No. 45 46 47
Symbol ACC DET NC #1,$1 CHG BUS IN %1,&1 NC
I/O I I O I I I I I I I I I O I O O -
Terminal Description ACC (IGNITION) detect signal input terminal. No connect terminal. Signal input terminal from CD CHANGER BUS I/F. No connect terminal. Signal output terminal to CD CHANGER BUS I/F. No connect terminal. DISC insert detect SW input terminal. Communication request signal input terminal from Mechanism u-COM. Analog power supply terminal of A/D Converter. Standard voltage input terminal of A/D Converter. Temperature sensor signal (Thermistor) input terminal for CD. FRONT Panel detect signal input terminal. Signal Meter input terminal. Multipath rejection detect terminal of receiving station. No connect terminal. AFC signal input terminal. Sub-W output GAIN set up input terminal. No connect terminal. GND terminal od A/D Converter. No connect terminal. Standard voltage input terminal of A/D Converter. Serial Data input terminal from RDS Monitor Soft (P/C). Serial Data output terminal to RDS Monitor Soft (P/C). No connect terminal. Status signal input termminal from Mechanism u-COM. (Flash-Pro II connect terminal by UART format.) Command output terminal to Mechanism u-COM. (Flash-Pro II connect terminal by UART format.) Serial Clock output terminal to Mechanism u-COM. (Flash-Pro II connect terminal by UART format.)
48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68
#1,$1 CHG BUS OUT %1,&1 NC DISC IN SW /CD SRQ AVDD AVREF 0 HI-TEMP NOSE ON S-METER MULTIPATH NC AFC GAIN Select NC AVSS NC AVREF 1 RDS MONI RxD RDS MONI TxD NC CD STS (RXD1)
69
CD CMD (TXD1)
70 71 I 73 74 75 76 77 78 79 80 81 82 83 84 85
CD SCK (ASCK1) NC
-
No connect terminal.
#1,$1,&1 NC %1 DIMMER OUT NC AM SD PLL CL PLL DI SEL2 /DAVN RDS CONT IF-MUTE FM SD/ST IND IN-INT OUT REM ON(NC) O I O O I I O O I I DIMMER control signal output terminal. No connect terminal. AM SD signal input terminal. Sync. signal output terminal to PLL (LC72191M). Data output terminal to PLL (LC72191M). Model selection input terminal. Available input terminal of RDS Decoder (SAA6588T). MPX MUTE signal output terminal to RDS Decoder (SAA6588T) at FM adjoining rejection. High Speed MUTE signal output terminal at AF SW. ST signal input terminal at FM receiving. (L : at receiving ST) FM SD signal input terminal at FM tunning. (H : SD ON) Outernal AUDIO signal input terminal. No connect terminal.
NOTE : #1 : For CDM-9803R Model Only, $1 : For CDM-9803RM Model Only, %1 : For CDE-9802RB Model Only, &1 : For CDE-9801R Model Only, Others : Common.
TO SCHEMATIC
TO CONTENTS
No. 86 87 I 97 98 99 100
Symbol #1,$1,&1 NC %1 DIMMER IN NC
I/O I No connect terminal.
Terminal Description
Outernal DIMMER detect signal input terminal.
-
No connect terminal.
RDS AUDIO(NC) /A-MUTE GND O AUDIO MUTE signal output terminal. (L : MUTE ON)
GND connect terminal.
NOTE : #1 : For CDM-9803R Model Only, $1 : For CDM-9803RM Model Only, %1 : For CDE-9802RB Model Only, &1 : For CDE-9801R Model Only, Others : Common.
D789026GB : IC703
No. 1 2 3 4 5 6 7 I 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 VPP X2 X1 VSS0 VDD0 /RESET S-CONT NC(GND) SW-A NC(GND) L-ZERO /CS /STBY CMD STS SCK NC(GND) /SRQ R-ZERO ZMUTE /XTALEN SI SO /SCK NC(GND) I O I I I I I O I O I O O O I O GND connect terminal. VDD connect terminal. Host I/F RESET signal input terminal. Servo power supply control output terminal. GND connect terminal. SW-A input terminal for mechanism control. GND connect terminal. DSP L-ch 0 data signal input terminal. Host I/F communication start/end signal input terminal. Host I/F STBY signal input terminal. Host I/F command input terminal. Host I/F status output terminal. Clock input terminal for Host I/F communication. GND connect terminal. Host I/F status request signal output terminal. DSP R-ch 0 data signal input terminal. Host I/F 0 data signal output terminal. DSP crystal OSC control output terminal. DSP serial data output terminal. DSP serial data/status signal input terminal. Clock output terminal for DSP serial data. GND connect terminal. Pull-down connect terminal. Crystal OSC connect terminal. (4.19MHz) NC(GND) GND connect terminal. Symbol SW-D SW-C SW-B LODMLODM+ DR MUTE O Driver IC Mute control output terminal. I/O I I I O Terminal Description SW-D input terminal for mechanism control. SW-C input terminal for mechanism control. SW-B input terminal for mechanism control. Loading Motor control output terminal.
TO SCHEMATIC
TO CONTENTS
No. 38 39 40 41 42 43 44
Symbol VDD1 VSS1 /STB AO /RST RFOK LIMIT SW
I/O O O O I I VDD connect terminal. GND connect terminal.
Terminal Description
DSP data strobe signal output terminal. DSP command/parameter discrimination signal output terminal. DSP RESET signal output terminal. DSP RFOK signal input terminal. LIMIT-SW input terminal.
TO SCHEMATIC
TO CONTENTS
Exploded View (Cabinet)
30 X2 7 X2 30 X2
21
ANT001
A
2 15 7
#1,$1
9 11 X4
JK201 23 1 25 CH401
#1,$1,&1
D E
18
14
CB801
C 14 X2
E D
14
5 #1,$1
28
LCD401
29 23 32
%1,&1
B
#1,$1
27
19
#1,$1
10
DIN501 JK001
#1,$1
24
26 CB601 29
%1
20 #1,$1 10
%1,&1
%1,&1
16 4
%1
JK201
7 7
31
6 8 12
C
A
20
%1,&1
B
3
13
7
NOTE : #1 : For CDM-9803R Model Only, $1 : For CDM-9803RM Model Only, %1 : For CDE-9802RB Model Only, &1 : For CDE-9801R Model Only, Others : Common.
7
TO PARTS LIST
TO CONTENTS
67 X2 31 65
(DP23S2BO)
8 33 41 6 32
B
30 78
P
2
5 3 6 4 23 X3 39 34
42 81
40
38 37 7 1 75 72 M102 22
N D K
Exploded View (CD Deck Mechanism)
62 36
L
D
M103
L P
19
27 45
SW105
67 21 29 53
C
28
HD101
20
66
64 79 88 87 86 83 85 84 82 13 12 89 49
G E F
64
52
J G
29 68
M
24
A
43 44 47 48
25 63 26 X2
59
F J A
51 61
E K
67 X2 10 X2 54
46 50
L
67 9 11 67 55
M N B L H
TO PARTS LIST
M101
C
57
SW4 SW3 SW1 SW2
H
56
58
TO CONTENTS
60
77 X2
CDM-9803R/CDM-9803RM/CDE-9802RB/CDE-9801R(CAB)
Cabinet Assembly Parts List
Notes : The part that has not PART NUMBER will not be supplied. #1 : For CDM-9803R Model Only, $1 : For CDM-9803RM Model Only, %1 : For CDE-9802RB Model Only, &1 : For CDE-9801R Model Only, Others : Common. #1 $1 %1 &1 1 1 1 1 2 3 4 5 5 6 7 8 9 10 11 12 13 14 15 16 18 19 20 21 23 24 24 24 24 25 26 27 27 27 27 28 29 29 29 29 30 31 32 32 01V64500Y93 01V64500Y98 01V64600Y09 01V64600Y06 ------------------14B02859K01 03S68555F30 03S68555F30 13C02811K01 03S44205G29 33C01797K01 03S71677F05 ---------03S38013W02 07D00749K01 07D00749K02 03T25225Y01 75T25010Y33 75S40755Y71 77T55278Y01 09T84840F01 ---------81D50701Y01 03S71677F56 13D02847K04 13C02846K01 13C02846K02 13D02847K06 13D02810K01 15B01768K01 26A41975Y01 26A41975Y01 26A41376Y01 26A41975Y01 75T03213K02 15D01772K01 15D01772K01 15D01770K01 15D01772K01 03S44205G07 14A03538K01 26A41376Y02 26A41975Y02 ASSY,NOSE UNIT 03RN ASSY,NOSE UTNI 03RM ASSY,NOSE UNIT 02RN ASSY,NOSE UNIT 01RN COVER,TOP CHAS,BASE INSULATOR,MAIN SCR,WAVE M2.6X10 SCR,WAVE M2.6X10 NOSE,BASE ASSY SCR,T-TITE M2.6X6 FACE,PLATE SCR,T-TITE-B M3X8 HEAT,SINK(L) SCR,T-TITE M2.6X14 BKT,SIDE L BKT,SIDE R SCR,GND CUSHION,SHLD5-5.5-25 CUS,RUB 6X6X4 MX-E062(TU001) LUG,STYLE 18MM BKT,CHAS REAR(L) DP23S2BO,CD MECH SCR,B-TITE M1.7X12 NOSE,PIECE ASSY(L) NOSE,PIECE ASSY(L) NOSE,PIECE ASSY(L) NOSE,PIECE ASSY(L) NOSE,BOTTOM COVER,LCD REFLECTOR,SHEET REFLECTOR,SHEET REFRECTOR,SHEET REFLECTOR,SHEET RUBBER,ELECTRIC CASE,LCD ASSY CASE,LCD ASSY CASE,LCD ASSY CASE,LCD ASSY SCR,T-TITE M2.6X5 INS,CVR 11X8 PEFLECTOR,SHEET(A) REFLECTOR,SHEET(A)
#1 $1
#1 $1 %1 &1 #1 $1 %1 &1 #1 $1 %1 &1 %1 %1 &1
CDM-9803R/CDM-9803RM/CDE-9802RB/CDE-9801R(DK)
CD Deck Mechanism Assembly Parts List
Note : The part that has not PART NUMBER will not be supplied. 1 2 3 4 5 6 7 8 9 10 11 12 13 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 01V43800Y84 ---------45B11564Y02 45B11595Y02 45B11596Y02 41B11613Y16 15D50248Y01 75A21286Y04 07C50608Y01 03S40014G07 44B11578Y02 44B11579Y02 44B11580Y02 27D11602Y04 47A11575Y01 01V28100Y59 44A70590W03 03S72235F96 07B30337Y02 41A11606Y10 03S94385F18 84T01803K01 41B11566Y10 03S70494F13 ------------------07A11565Y02 03S94385F01 43A41812Y02 ---------45A11599Y02 41B11613Y03 41B11613Y05 41A11609Y01 41B40574Y10 41B11613Y15 41A11040Y10 03S70494F52 43A21240Y01 ---------45B40510Y02 44B40527Y02 45A11601Y02 44B11581Y02 45B11594Y02 45A11592Y02 03A11574Y01 45B11591Y02 07A50606Y01 45B11593Y02 45B11607Y02 45A11597Y02 41B11613Y04 ASSY,ARM GUIDE 280 CHASSIS,TOP LEVER,LINK-TOP LEVER DISC(R) LEVER,DISC(L) SPRING,PULL GUIDE,TOP-DPS2 CUSHION,CLAMPER DPS2 BKT,MOTOR LOAD-P SCR,MCH M2X4 GEAR,(A) GEAR,(B) GEAR,(C) CHASSIS,PICKUP SHAFT,PICK ASSY,SHAFT.SCREW GEAR,MIDDLE SCR,MCH M1.7X3.5(SW) BKT,SPRING NUT SPRING,NUT SCR,NYLON M2X3.5 PANEL,FPC CONT SPRING SHAFT SCR,P-TITE M2X6 BLK ASSY,RIV.ARM CLAMP LEVER,LOCK PLATE,CLAMP SCR,NYLOK M1.7X2.3 TABLE,CLAMPER2 SLIDER DISC LEVER,ACTUATOR SPRING,PULL SPRING,LEV-ACT SPRING,LEVER SPRING,PLATE-S SPRING,PULL SPRING,SLED-HOE SCR,P-TITE M1.4X4.5 SHEET,FPC PICK ASSY,RIV CHAS BASE SLIDER,LOAD RACK LEVER,TRIGER GEAR,(D) SLIDER,LOCK(L) ARM,LOCK(L2) SCREW,LOCK ARM,LOCK(L1) BKT,MOTOR WIRE-P SLIDER,LOCK(R) ARM,LOCK(R) LEVER,SW SPRING,TRIGER
60 61 62 63 64 65 66 67 68 72 75 77 78 79 81 82 83 84 85 86 87 88 89
75C30466Y04 41B11613Y06 41B11613Y07 41B11613Y08 41A40518Y01 41A31894Y02 ---------03A21791Y01 07B20905Y02 41A21613Y02 43A31443Y01 75C30466Y05 41B11613Y14 04B41345P52 75A21286Y02 44B40523Y02 04A40528Y01 44A40524Y02 41A40529Y01 44A40525Y02 15A40526Y02 43A41446Y02 04B41345P25
DAMPER,DPS2 SPRING,PULL SPRING,PULL SPRING,PULL SPRING,ROL SPRING,SLIDER BKT,SP-TOP SCREW,M2X3.5 S-TITE BKT,FPC CONT SPRING,SPINDLE ROLLER,ARM DISC (C) DAMPER,DPS2 SPLING,PULL WASH,1.6X3.5X0.25 CUSHION,CLAMPER BACK GEAR,BASE WASHER,FELT GEAR,CLUTCH SPRING,CLUTCH GEAR,PINION HOLDER,CLUTCH SLEEVE,CLUTCH WASH,L. 3.1X6X0.35
CDM-9803R/CDM-9803RM/CDE-9802RB/CDE-9801R(ELE)
Electrical Parts List
Note : #1 : For CDM-9801R Model Only, $1 : For CDM-9803RM Model Only, %1 : For CDE-9802RB Model Only, &1 : For CDE-9801R Model Only, Others : Common. *******MAIN P.W.Board =======IC's IC002 IC003 IC004 IC006 IC007 IC201 #1 IC203 $1 IC203 IC301 IC601 IC602 IC651 IC701 IC702 IC703 IC704 IC751 =======Transistors Q001 Q002 Q003 Q004 Q005 Q006 Q009 Q010 Q011 Q012 Q013 Q201 #1 Q261 $1 Q261 #1 Q262 $1 Q262 Q263 Q264 Q301 #1 Q601 $1 Q601 #1 Q602 $1 Q602 #1 Q603 $1 Q603 Q604 #1 Q605 $1 Q605
51T40941U02 51T85265W02 51T15132Y02 51T93333F01 51T15419Y02 51T35261Y01 51T15420Y01 51T15420Y01 51T45409Y01 51T65269Y01 51T65016Y19 51T95193W01 51T55093Y01 51T55156Y01 51T55329Y02 51T55295Y01 51T15510W01 48T93828F04 48T93828F04 48T93828F04 48T94875F04 48T52438F01 48T52438F01 48T73888F08 48T62967F03 48T62967F03 48T73888F12 48T73888F13 48T62967F03 48T62967F33 48T62967F33 48T62967F33 48T62967F33 48T62967F33 48T62967F33 48T62967F03 48T62966F03 48T62966F03 48T73888F08 48T73888F08 48T62967F02 48T62967F02 48T73888F13 48T62967F02 48T62967F02
IC ,MC14066BFEL-SE06 LC72191JM -SE9 SAA6588T -SE9 NJM2904M-TE3 -SE2 BA4558F-E2 -SE2 TDA7404 -SE9 BA4560F-E2 -SE2 BA4560F-E2 -SE2 TA8263BH -ZS IC,D784216AGF-531-QT S-80930CNMC-T2 -CP TDA3606AT -SE9 BA5984FP-E2 -SEA UPD63711A -QT IC,D789026GB-A82 -QT AN80M50RSPE1 -NE5 IC ,MC34063AML -SPD TR,2SD1994A-S-TA -RD TR,2SD1994A-S-TA -RD TR,2SD1994A-S-TA -RD DTB,CP-123YK-96 TR ,2SD601A-RS/TX-CP TR ,2SD601A-RS/TX-CP TR ,CP.FMG1-99 TR,DTC124EKA-T146-CP TR,DTC124EKA-T146-CP TR ,CP.FMC2-99 TR ,CP FMC3-99 TR,DTC124EKA-T146-CP TR,DTC343TK-T146 -CP TR,DTC343TK-T146 -CP TR,DTC343TK-T146 -CP TR,DTC343TK-T146 -CP TR,DTC343TK-T146 -CP TR,DTC343TK-T146 -CP TR,DTC124EKA-T146-CP TR,DTA124EKA-T146-CP TR,DTA124EKA-T146-CP TR ,CP.FMG1-99 TR ,CP.FMG1-99 TR,DTC114EKA-T146-CP TR,DTC114EKA-T146-CP TR ,CP FMC3-99 TR,DTC114EKA-T146-CP TR,DTC114EKA-T146-CP
Q606 Q606 Q607 Q607 Q608 Q651 Q652 Q664 Q701 Q702 Q751 Q752 Q803 Q804 Q805 Q807 Q810 Q815 Q862 Q863 =======Diodes D001 D002 D301 D302 D303 D304 D305 D306 D307 D308 #1 D601 $1 D601 #1 D602 $1 D602 D653 D662 D701 D702 D703 D751 D804 D861 D862 SD801 ZD001 ZD002 ZD003 ZD652 ZD802 ZD803 =======Coils L001 L002 L601 L602 L651
#1 $1 #1 $1 %1
48T63420F01 48T63420F01 48T62967F02 48T62967F02 48T64222F02 48T73888F12 48T73888F12 48T62966F01 48T55462Y01 48T94606F03 48T15511W02 48T73888F12 48T84366F04 48T62967F05 48T69176F02 48T92368F04 48T84366F04 48T62967F01 48T73888F12 48T62967F03 48T85357W01 48T85357W01 48T02162K01 48T02162K01 48T02162K01 48T02162K01 48T02162K01 48T02162K01 48T02162K01 48T02162K01 48T68828F01 48T68828F01 48T63462F01 48T63462F01 48T68828F01 48T63462F01 48T25665Y01 48T25665Y01 48T25665Y01 48T85269W01 48T85270W01 48T68828F01 48T75404W01 48T68580F03 48T83128F23 48T83128F04 48T83128F40 48T83128F14 48T83128F25 48T83128F26 24T65053W18 24T16403W29 24T65053W18 24T65053W18 24T16403W23
TR,2SA1037AK-146 -CP TR,2SA1037AK-146 -CP TR,DTC114EKA-T146-CP TR,DTC114EKA-T146-CP TR ,UN2212 22-22 -TX TR ,CP.FMC2-99 TR ,CP.FMC2-99 TR,DTA143EKA-T146-CP TR,2SB1132-QR-100-E2 TR,DTC124EUA-T106-CP CP.2SB1261-TE2 -E5 TR ,CP.FMC2-99 TR,2SB1243-QR-TV2-RD TR,DTC143XKA-T146-CP TR ,2SC3421-Y TR,2SD1760 R -E5 TR,2SB1243-QR-TV2-RD TR,DTC143EKA-T146-CP TR ,CP.FMC2-99 TR,DTC124EKA-T146-CP DIO,1PS226 -CP DIO,1PS226 -CP DIO,SHT SRT14 -A5 DIO,SHT SRT14 -A5 DIO,SHT SRT14 -A5 DIO,SHT SRT14 -A5 DIO,SHT SRT14 -A5 DIO,SHT SRT14 -A5 DIO,SHT SRT14 -A5 DIO,SHT SRT14 -A5 DIO,1SS133 -A5 DIO,1SS133 -A5 DIO,CP.DAN202K -96 DIO,CP.DAN202K -96 DIO,1SS133 -A5 DIO,CP.DAN202K -96 DIO,1SS355-TE17 -CP DIO,1SS355-TE17 -CP DIO,1SS355-TE17 -CP DIO,SHT SB040 -A5 DIO,MPG06G -A5 DIO,1SS133 -A5 DIO,1SS353-TE17 -CP DIO,SI DSA3A4-F5 DIO,ZEN.HZS 9B2L -A5 DIO,ZEN.HZS 6B1L -A5 DIO,ZEN.HZS12B1L -A5 DIO,ZEN HZS 7B2L -A5 DIO,ZEN.HZS 9C1L -A5 DIO,ZEN.HZS 9C2L -A5 IND,LAL02VD 4R7K -R5 COI,IND.15R-M -CP IND,LAL02VD 4R7K -R5 IND,LAL02VD 4R7K -R5 COI,IND.4R7-M -CP
L751 24T16271W13 L801 25T01879K01 =======Crystals CL701 91T55147Y01 CL702 91T45281Y03 XL001 91T25806W43 XL002 91T25806W18 XL601 91T55360Y03 =======Filter Z601 91T65112W06 =======Poly Switch PS801 48T95226W01 =======Surge Protector SA001 48T81909F01 =======Switch SW601 40T16096W03 =======Thermistor TH601 48T25250Y01 =======Capacitors C010 08S45676W73 C011 08S45677W36 C012 08S45677W54 C017 08S45676W73 C019 08S45677W60 C033 08S45677W60 C034 08S45676W73 C036 08S45677W60 C037 08S45677W60 C038 08S45676W93 C039 08S45676W80 C040 08S45676W80 C041 08S45677W36 C042 08S45676W80 C044 08S45676W80 C045 08S45676W73 C046 08S45676W73 C047 08T35122W13 C048 08S45676W73 C049 08T55390W34 C051 08S45677W48 C053 08S45676W73 C054 08S45676W73 C055 08S45676W65 C056 08S45677W36 C058 08S45676W85 C059 08S45677W54 C060 08S45676W85 C061 08S45677W36 C062 08S45677W36 C063 08S45677W22 C064 08S45677W22 C065 08S45676W65 C066 08S45676W80 C068 08S45676W87 C069 08S45677W22 C070 08S45677W22 C104 08S45676W67
COIL,RCR875D-221K CHOKE,LAT1608-105-DB OSC,CER CSACV16M9-E1 OSC,CER CSTCR4M19-E1 XTL,7.200M -AT51-TP XTL,4.332M -AT51-TP XTL,AT-51 12.288M-R5 EMI,BK2125HM102 -CP
TMT,PTGL05BA1R8M1-R5 PTT,DSP-201M -A1
SW ,TACT SKHHLW(RESET) TMT,ERTJ1VV104J -CP
CAP,CER.103K-B1H -CP CAP,CER.101J-CH1H-CP CAP,CER 561J-CH1H-CP CAP,CER.103K-B1H -CP CAP,CER 102J-CH1H-CP CAP,CER 102J-CH1H-CP CAP,CER.103K-B1H -CP CAP,CER 102J-CH1H-CP CAP,CER 102J-CH1H-CP CAP,CER 224K-B1A -CP CAP,CER 223K-B1E -CP CAP,CER 223K-B1E -CP CAP,CER.101J-CH1H-CP CAP,CER 223K-B1E -CP CAP,CER 223K-B1E -CP CAP,CER.103K-B1H -CP CAP,CER.103K-B1H -CP CAP,MMTS-104-J -R5 CAP,CER.103K-B1H -CP CAP,TF 274J-1H -R5 CAP,CER.331J-CH1H-CP CAP,CER.103K-B1H -CP CAP,CER.103K-B1H -CP CAP,CER.222K-B1H -CP CAP,CER.101J-CH1H-CP CAP,CER 104K-B1C -CP CAP,CER 561J-CH1H-CP CAP,CER 104K-B1C -CP CAP,CER.101J-CH1H-CP CAP,CER.101J-CH1H-CP CAP,CER.27RJ-CH1H-CP CAP,CER.27RJ-CH1H-CP CAP,CER 222K-B1E -CP CAP,CER 223K-B1E -CP CAP,CER 333K-B1E -CP CAP,CER.27RJ-CH1H-CP CAP,CER.27RJ-CH1H-CP CAP,CER.332K-B1H -CP
#1 $1 #1 $1 #1 $1 #1 $1 %1 #1 $1
C105 C204 C209 C303 C310 C311 C312 C313 C314 C501 C602 C603 C603 C604 C604 C605 C605 C606 C606 C607 C608 C609 C610 C610 C611 C612 C613 C628 C651 C653 C662 C701 C702 C703 C704 C705 C706 C708 C709 C710 C711 C713 C714 C715 C716 C717 C718 C719 C720 C721 C722 C723 C724 C725 C726 C727 C728
08S45676W67 08S45676W74 08S45676W84 08S45676W93 08S45676W83 08T35122W17 08T35122W17 08T35122W17 08T35122W17 08S45677W60 08S65128F78 08S45677W36 08S45677W36 08S45676W73 08S45676W73 08S65128F88 08S65128F88 08S45676W65 08S45676W65 08S45676W85 08S45677W18 08S45677W18 08S45677W48 08S45677W48 08S45676W80 08S35374W01 08S65128F90 08S45676W73 08S45676W80 08S45676W85 08S45677W60 08S45677W20 08S45676W85 08S45676W80 08S45676W80 08S45676W85 08S45676W85 08S45676W85 08S45676W85 08S45676W85 08S45677W60 08S45676W85 08S45676W65 08S45676W65 08S45676W73 08S45676W85 08S45676W80 08S45676W85 08S45676W85 08S45676W85 08S45676W87 08S45676W85 08S45676W85 08S45676W68 08S45676W93 08S45677W20 08S45677W07
CAP,CER.332K-B1H -CP CAP,CER 123K-B1H -CP CAP,CER 683K-B1C -CP CAP,CER 224K-B1A -CP CAP,CER 473K-B1C -CP CAP,MMTS-224-J -R5 CAP,MMTS-224-J -R5 CAP,MMTS-224-J -R5 CAP,MMTS-224-J -R5 CAP,CER 102J-CH1H-CP CAP,CER.223K-B1H -CP CAP,CER.101J-CH1H-CP CAP,CER.101J-CH1H-CP CAP,CER.103K-B1H -CP CAP,CER.103K-B1H -CP CAP,CER 104K-B1H -CP CAP,CER 104K-B1H -CP CAP,CER.222K-B1H -CP CAP,CER.222K-B1H -CP CAP,CER 104K-B1C -CP CAP,CER.18RJ-CH1H-CP CAP,CER.18RJ-CH1H-CP CAP,CER.331J-CH1H-CP CAP,CER.331J-CH1H-CP CAP,CER 223K-B1E -CP CAP,CER 104K-B1E-CP CAP,CER 473K-B1H -CP CAP,CER.103K-B1H -CP CAP,CER 223K-B1E -CP CAP,CER 104K-B1C -CP CAP,CER 102J-CH1H-CP CAP,CER.22RJ-CH1H-CP CAP,CER 104K-B1C -CP CAP,CER 223K-B1E -CP CAP,CER 223K-B1E -CP CAP,CER 104K-B1C -CP CAP,CER 104K-B1C -CP CAP,CER 104K-B1C -CP CAP,CER 104K-B1C -CP CAP,CER 104K-B1C -CP CAP,CER 102J-CH1H-CP CAP,CER 104K-B1C -CP CAP,CER.222K-B1H -CP CAP,CER.222K-B1H -CP CAP,CER.103K-B1H -CP CAP,CER 104K-B1C -CP CAP,CER 223K-B1E -CP CAP,CER 104K-B1C -CP CAP,CER 104K-B1C -CP CAP,CER 104K-B1C -CP CAP,CER 333K-B1E -CP CAP,CER 104K-B1C -CP CAP,CER 104K-B1C -CP CAP,CER.392K-B1H -CP CAP,CER 224K-B1A -CP CAP,CER.22RJ-CH1H-CP CAP,CER.5R0C-CH1H-CP
#1 $1 #1 $1 #1 $1
#1 $1 #1 $1 #1 $1
C729 C730 C731 C732 C734 C736 C749 C750 C751 C752 C800 C801 C802 C808 C810 C811 C813 C814 E001 E002 E003 E005 E006 E008 E010 E011 E013 E016 E017 E018 E019 E020 E201 E202 E203 E203 E204 E204 E205 E205 E211 E212 E213 E214 E215 E216 E241 E241 E261 E261 E262 E262 E263 E264 E302 E303 E304
08S45676W85 08S45677W30 08S45677W26 08S45676W85 08S45676W85 08S45676W85 08S45677W40 08S45677W54 08S65128F78 08S45677W38 08S45677W60 08S45676W89 08T35122W13 08S45676W80 08S45539Y04 08S45539Y04 08S45539Y04 08S45677W60 23S75373W13 23S75373W02 23S75373W04 23S75373W05 23S75373W05 23S75373W13 23S75373W13 23S75373W02 23S75372W03 23S75373W05 23S82372F13 23S65134W32 23S75373W14 23S75373W03 23S75373W05 23S75373W06 23S75373W14 23S75373W14 23S75373W14 23S75373W14 23S75373W14 23S75373W14 23S75373W13 23S75373W13 23S75373W13 23S75373W13 23S75373W13 23S75373W13 23S75373W03 23S75373W03 23S75373W14 23S75373W14 23S75373W14 23S75373W14 23S75373W14 23S75373W14 23S95415W14 23S95415W03 23S95415W17
CAP,CER 104K-B1C -CP CAP,CER.56RJ-CH1H-CP CAP,CER.39RJ-CH1H-CP CAP,CER 104K-B1C -CP CAP,CER 104K-B1C -CP CAP,CER 104K-B1C -CP CAP,CER.151J-CH1H-CP CAP,CER 561J-CH1H-CP CAP,CER.223K-B1H -CP CAP,CER 121J-CH1H-CP CAP,CER 102J-CH1H-CP CAP,CER 473K-B1E -CP CAP,MMTS-104-J -R5 CAP,CER 223K-B1E -CP CAP,CER 103KX7R2J-CP CAP,CER 103KX7R2J-CP CAP,CER 103KX7R2J-CP CAP,CER 102J-CH1H-CP CAP,ELY 1R0-1H -R2 CAP,ELY 10R-1C -R2 CAP,ELY 33R-1C -R2 CAP,ELY 47R-1C -R2 CAP,ELY 47R-1C -R2 CAP,ELY 1R0-1H -R2 CAP,ELY 1R0-1H -R2 CAP,ELY 10R-1C -R2 CAP,ELY 221-1A -H2 CAP,ELY 47R-1C -R2 CAP,ELY.2R2-1V-BP-R2 CAP,ELY 22R-1C(5)-E3 CAP,ELY 2R2-1H -R2 CAP,ELY 22R-1C -R2 CAP,ELY 47R-1C -R2 CAP,ELY 101-1C -R2 CAP,ELY 2R2-1H -R2 CAP,ELY 2R2-1H -R2 CAP,ELY 2R2-1H -R2 CAP,ELY 2R2-1H -R2 CAP,ELY 2R2-1H -R2 CAP,ELY 2R2-1H -R2 CAP,ELY 1R0-1H -R2 CAP,ELY 1R0-1H -R2 CAP,ELY 1R0-1H -R2 CAP,ELY 1R0-1H -R2 CAP,ELY 1R0-1H -R2 CAP,ELY 1R0-1H -R2 CAP,ELY 22R-1C -R2 CAP,ELY 22R-1C -R2 CAP,ELY 2R2-1H -R2 CAP,ELY 2R2-1H -R2 CAP,ELY 2R2-1H -R2 CAP,ELY 2R2-1H -R2 CAP,ELY 2R2-1H -R2 CAP,ELY 2R2-1H -R2 CAP,ELY R22-1H -R2 CAP,ELY 10R-1C -R2 CAP,ELY 1R0-1H -R2
E311 E312 E313 E314 E601 E602 %1 E604 E651 E701 E703 E704 E707 E716 E717 E729 E733 E735 E736 E737 E738 E751 E752 E800 E801 E803 E804 E805 E842 E861 =======Resistors J007 J023 J029 R001 R002 R003 R004 R005 R006 R007 R008 R009 R010 R011 R012 R013 R014 R015 R016 R017 R021 R025 R028 R029 R030 R031 R032
23S75373W02 23S75373W02 23S75373W02 23S75373W02 23S75373W03 23S75372W03 23S75373W02 23S75373W04 23S75372W07 23S55311W35 23S75373W05 23S75373W02 23S75373W05 23S75373W03 23S55311W28 23S75373W02 23S55311W31 23S55311W35 23S65134W34 23S55311W35 23S75373W02 23T55378W03 23S75373W06 23T75346W03 23S75372W03 23S75373W04 23S75373W13 23S75373W06 23S75373W05 06S35095Y08 06S35095Y08 06S35095Y08 06S70072F05 06S70072F78 06S70072F78 06S70072F65 06S70072F69 06S70072F69 06S45674W81 06S45674W95 06S70072F29 06S45674W81 06S45674W81 06S45674W81 06S45674W69 06S45675W02 06S45674W87 06S55363Y76 06S45674W97 06S45674W57 06S45674W25 06S64995F92 06S45674W57 06S45674W97 06S45675W43 06S45675W43
CAP,ELY 10R-1C -R2 CAP,ELY 10R-1C -R2 CAP,ELY 10R-1C -R2 CAP,ELY 10R-1C -R2 CAP,ELY 22R-1C -R2 CAP,ELY 221-1A -H2 CAP,ELY 10R-1C -R2 CAP,ELY 33R-1C -R2 CAP,ELY 47R-1C -R2 CAP,TAN 10R-1C-B -CP CAP,ELY 47R-1C -R2 CAP,ELY 10R-1C -R2 CAP,ELY 47R-1C -R2 CAP,ELY 22R-1C -R2 CAP,TAN 22R-1A-B -CP CAP,ELY 10R-1C -R2 CAP,TAN.2R2-1C-A -CP CAP,TAN 10R-1C-B -CP CAP,ELY 47R-1C(6)-E6 CAP,TAN 10R-1C-B -CP CAP,ELY 10R-1C -R2 CAP,KMG 471-1A -R2 CAP,ELY 101-1C -R2 CAP,X-PRO 332-1C + CAP,ELY 221-1A -H2 CAP,ELY 33R-1C -R2 CAP,ELY 1R0-1H -R2 CAP,ELY 101-1C -R2 CAP,ELY 47R-1C -R2 RES,RK JUMPER 1/4-CP RES,RK JUMPER 1/4-CP RES,RK JUMPER 1/4-CP RES,CP .10R-J-1/4-CP RES,CP .2R2-J-1/4-CP RES,CP .2R2-J-1/4-CP RES,CP .332-J-1/4-CP RES,CP .472-J-1/4-CP RES,CP .472-J-1/4-CP RES,RK 103J 1/10 -CP RES,RK 393J 1/10 -CP RES,CP .101-J-1/4-CP RES,RK 103J 1/10 -CP RES,RK 103J 1/10 -CP RES,RK 103J 1/10 -CP RES,RK 332J 1/10 -CP RES,RK 683J 1/10 -CP RES,RK 183J 1/10 -CP RES,RK 302J 1/8 -CP RES,RK 473J 1/10 -CP RES,RK 102J 1/10 -CP RES,RK 47RJ 1/10 -CP RES,RK 433J 1/8 -CP RES,RK 102J 1/10 -CP RES,RK 473J 1/10 -CP RES,RK JUMPER1/10-CP RES,RK JUMPER1/10-CP
#1 $1 #1 $1 #1 $1 #1 $1 #1 $1 #1 $1 #1 $1 #1 $1
%1 &1 %1 &1
R035 R042 R049 R050 R051 R052 R053 R054 R055 R056 R057 R059 R060 R061 R062 R063 R065 R066 R067 R068 R069 R071 R073 R103 R104 R201 R204 R205 R241 R241 R242 R242 R261 R261 R262 R262 R263 R263 R264 R264 R265 R265 R266 R266 R267 R268 R269 R270 R271 R272 R305 R311 R311 R312 R312 R399 R600
06S45674W95 06S70072F41 06S45674W57 06S45674W71 06S45674W25 06S45674W89 06S45674W87 06S45674W57 06S45674W65 06S45674W57 06S45675W43 06S45674W81 06S45674W65 06S45674W81 06S45674W81 06S45674W09 06S45674W75 06S45674W75 06S45674W57 06S45674W57 06S45674W73 06S45675W22 06S45674W81 06S70072F47 06S70072F47 06S45674W77 06S45674W57 06S45674W57 06S45674W60 06S45674W60 06S45674W60 06S45674W60 06S45674W40 06S45674W40 06S45674W40 06S45674W40 06S45674W98 06S45674W98 06S45674W98 06S45674W98 06S45674W33 06S45674W33 06S45674W33 06S45674W33 06S45674W40 06S45674W40 06S45674W33 06S45674W98 06S45674W98 06S45674W33 06S70072F77 06S45675W43 06S45675W43 06S45675W43 06S45675W43 06S45675W43 06S45674W97
RES,RK 393J 1/10 -CP RES,CP .331-J-1/4-CP RES,RK 102J 1/10 -CP RES,RK 392J 1/10 -CP RES,RK 47RJ 1/10 -CP RES,RK 223J 1/10 -CP RES,RK 183J 1/10 -CP RES,RK 102J 1/10 -CP RES,RK 222J 1/10 -CP RES,RK 102J 1/10 -CP RES,RK JUMPER1/10-CP RES,RK 103J 1/10 -CP RES,RK 222J 1/10 -CP RES,RK 103J 1/10 -CP RES,RK 103J 1/10 -CP RES,RK 10RJ 1/10 -CP RES,RK 562J 1/10 -CP RES,RK 562J 1/10 -CP RES,RK 102J 1/10 -CP RES,RK 102J 1/10 -CP RES,RK 472J 1/10 -CP RES,RK 474J 1/10 -CP RES,RK 103J 1/10 -CP RES,CP .561-J-1/4-CP RES,CP .561-J-1/4-CP RES,RK 682J 1/10 -CP RES,RK 102J 1/10 -CP RES,RK 102J 1/10 -CP RES,RK 132J 1/10 -CP RES,RK 132J 1/10 -CP RES,RK 132J 1/10 -CP RES,RK 132J 1/10 -CP RES,RK 201J 1/10 -CP RES,RK 201J 1/10 -CP RES,RK 201J 1/10 -CP RES,RK 201J 1/10 -CP RES,RK 513J 1/10 -CP RES,RK 513J 1/10 -CP RES,RK 513J 1/10 -CP RES,RK 513J 1/10 -CP RES,RK 101J 1/10 -CP RES,RK 101J 1/10 -CP RES,RK 101J 1/10 -CP RES,RK 101J 1/10 -CP RES,RK 201J 1/10 -CP RES,RK 201J 1/10 -CP RES,RK 101J 1/10 -CP RES,RK 513J 1/10 -CP RES,RK 513J 1/10 -CP RES,RK 101J 1/10 -CP RES,CP .103-J-1/4-CP RES,RK JUMPER1/10-CP RES,RK JUMPER1/10-CP RES,RK JUMPER1/10-CP RES,RK JUMPER1/10-CP RES,RK JUMPER1/10-CP RES,RK 473J 1/10 -CP
#1 $1 #1 $1 #1 $1 #1 $1
#1 $1 #1 $1
#1 $1
#1 $1 #1 $1
R603 R604 R605 R606 R607 R608 R609 R611 R612 R613 R614 R615 R616 R617 R618 R619 R620 R621 R622 R622 R623 R623 R624 R624 R625 R626 R627 R627 R628 R629 R630 R631 R631 R632 R632 R633 R634 R635 R636 R638 R639 R639 R640 R641 R642 R644 R645 R645 R646 R647 R648 R648 R649 R650 R651 R653 R654
06S64995F79 06S45674W89 06S45674W97 06S45674W57 06S45674W81 06S64995F77 06T45541Y01 06S15593Y97 06S64995F53 06S64995F53 06S64995F53 06S64995F53 06S64995F53 06S64995F53 06S45675W43 06S45674W57 06S45674W57 06S45674W81 06S45674W81 06S45674W81 06S45674W57 06S45674W57 06S45674W65 06S45674W65 06S45674W81 06S45674W81 06S45674W69 06S45674W69 06S15594Y04 06S45674W97 06S45674W89 06S70072F98 06S70072F98 06S70072F37 06S70072F37 06S45674W97 06S45674W43 06S45674W43 06S64995F93 06S45674W83 06S45674W89 06S45674W89 06S45675W22 06S70072F98 06S45674W57 06S64995F93 06S70072F29 06S70072F29 06S64995F69 06S64995F69 06S45674W89 06S45674W89 06S70072F63 06S15593Y73 06S45674W99 06S15593Y63 06S70072F69
RES,RK 123J 1/8 -CP RES,RK 223J 1/10 -CP RES,RK 473J 1/10 -CP RES,RK 102J 1/10 -CP RES,RK 103J 1/10 -CP RES,RK 103J 1/8 -CP RES,RS 12RJ 2W RES,RK 104F 1/10 -CP RES,RK 102J 1/8 -CP RES,RK 102J 1/8 -CP RES,RK 102J 1/8 -CP RES,RK 102J 1/8 -CP RES,RK 102J 1/8 -CP RES,RK 102J 1/8 -CP RES,RK JUMPER1/10-CP RES,RK 102J 1/10 -CP RES,RK 102J 1/10 -CP RES,RK 103J 1/10 -CP RES,RK 103J 1/10 -CP RES,RK 103J 1/10 -CP RES,RK 102J 1/10 -CP RES,RK 102J 1/10 -CP RES,RK 222J 1/10 -CP RES,RK 222J 1/10 -CP RES,RK 103J 1/10 -CP RES,RK 103J 1/10 -CP RES,RK 332J 1/10 -CP RES,RK 332J 1/10 -CP RES,RK 184F 1/10 -CP RES,RK 473J 1/10 -CP RES,RK 223J 1/10 -CP RES,RK 223J 1/4 -CP RES,RK 223J 1/4 -CP RES,CP .221-J-1/4-CP RES,CP .221-J-1/4-CP RES,RK 473J 1/10 -CP RES,RK 271J 1/10 -CP RES,RK 271J 1/10 -CP RES,RK 473J 1/8 -CP RES,RK 123J 1/10 -CP RES,RK 223J 1/10 -CP RES,RK 223J 1/10 -CP RES,RK 474J 1/10 -CP RES,RK 223J 1/4 -CP RES,RK 102J 1/10 -CP RES,RK 473J 1/8 -CP RES,CP .101-J-1/4-CP RES,CP .101-J-1/4-CP RES,RK 472J 1/8 -CP RES,RK 472J 1/8 -CP RES,RK 223J 1/10 -CP RES,RK 223J 1/10 -CP RES,CP .272-J-1/4-CP RES,RK 103F 1/10 -CP RES,RK 563J 1/10 -CP RES,RK 392F 1/10 -CP RES,CP .472-J-1/4-CP
%1 %1 &1 #1 $1 #1 $1 %1 &1
&1 #1 %1 &1
R655 R656 R657 R658 R659 R660 R661 R661 R662 R662 R663 R663 R664 R665 R665 R666 R667 R668 R669 R670 R671 R672 R672 R672 R686 R701 R702 R703 R704 R705 R706 R707 R708 R709 R710 R711 R712 R713 R716 R717 R718 R719 R722 R723 R724 R725 R726 R727 R728 R729 R732 R733 R734 R735 R736 R737 R740
06S70072F69 06S64996F14 06S15593Y99 06S15593Y97 06S70072F77 06S70072F77 06S70072F98 06S70072F98 06S45674W83 06S45674W83 06S70072F98 06S70072F98 06S64995F93 06S64995F85 06S64995F85 06S64996F39 06S64996F39 06S64996F39 06S64996F39 06S64996F39 06S70072F77 06S45674W83 06S45674W83 06S45674W83 06S45674W65 06S70072F05 06S70072F05 06S45674W97 06S45674W95 06S45674W85 06S45674W81 06S45674W81 06S45674W89 06S45674W81 06S45674W81 06S45674W89 06S45674W97 06S45674W97 06S45674W41 06S45674W41 06S45674W97 06S45674W97 06S45674W97 06S45674W81 06S45674W95 06S64995F74 06S45674W33 06S45674W91 06S45675W06 06S45674W97 06S45674W97 06S45674W97 06S45674W33 06S45674W33 06S70072F29 06S70072F29 06S45674W97
RES,CP .472-J-1/4-CP RES,RK 334J 1/8 -CP RES,RK 124F 1/10 -CP RES,RK 104F 1/10 -CP RES,CP .103-J-1/4-CP RES,CP .103-J-1/4-CP RES,RK 223J 1/4 -CP RES,RK 223J 1/4 -CP RES,RK 123J 1/10 -CP RES,RK 123J 1/10 -CP RES,RK 223J 1/4 -CP RES,RK 223J 1/4 -CP RES,RK 473J 1/8 -CP RES,RK 223J 1/8 -CP RES,RK 223J 1/8 -CP RES,RK JUMPER 1/8-CP RES,RK JUMPER 1/8-CP RES,RK JUMPER 1/8-CP RES,RK JUMPER 1/8-CP RES,RK JUMPER 1/8-CP RES,CP .103-J-1/4-CP RES,RK 123J 1/10 -CP RES,RK 123J 1/10 -CP RES,RK 123J 1/10 -CP RES,RK 222J 1/10 -CP RES,CP .10R-J-1/4-CP RES,CP .10R-J-1/4-CP RES,RK 473J 1/10 -CP RES,RK 393J 1/10 -CP RES,RK 153J 1/10 -CP RES,RK 103J 1/10 -CP RES,RK 103J 1/10 -CP RES,RK 223J 1/10 -CP RES,RK 103J 1/10 -CP RES,RK 103J 1/10 -CP RES,RK 223J 1/10 -CP RES,RK 473J 1/10 -CP RES,RK 473J 1/10 -CP RES,RK 221J 1/10 -CP RES,RK 221J 1/10 -CP RES,RK 473J 1/10 -CP RES,RK 473J 1/10 -CP RES,RK 473J 1/10 -CP RES,RK 103J 1/10 -CP RES,RK 393J 1/10 -CP RES,RK 752J 1/8 -CP RES,RK 101J 1/10 -CP RES,RK 273J 1/10 -CP RES,RK 104J 1/10 -CP RES,RK 473J 1/10 -CP RES,RK 473J 1/10 -CP RES,RK 473J 1/10 -CP RES,RK 101J 1/10 -CP RES,RK 101J 1/10 -CP RES,CP .101-J-1/4-CP RES,CP .101-J-1/4-CP RES,RK 473J 1/10 -CP
R741 R743 R744 R745 R746 R747 R748 R750 R751 R752 R753 R754 R755 R756 R757 R758 R759 R760 R761 R762 R764 R765 R767 R768 R769 R770 R771 #1 R801 $1 R801 R802 R803 R804 R805 R806 R807 R808 R812 R813 R827 R828 R829 R833 R853 R864 R865 R867 RA701 RA702 =======Connectors CB101 CB102 CB103 #1 WTB201 $1 WTB201 %1 WTB202 &1 WTB202
06S45675W43 06S45674W93 06S45674W93 06S45674W93 06S45674W97 06S45674W93 06S45674W97 06S45675W43 06S45674W81 06S45674W97 06S45674W97 06S45674W97 06S45674W97 06S45674W97 06S45674W97 06S45674W97 06S45674W93 06S45674W33 06S45674W33 06S45674W97 06S45674W97 06S70072F29 06S70072F47 06S70072F47 06S35084Y41 06S35084Y33 06S45675W21 06S70072F53 06S70072F53 06S70072F77 06S45675W06 06S35095Y15 06S70072F59 06S70072F59 06S70072F51 06S70072F45 06S70072F57 06S70072F57 06S45674W89 06S70072F59 06S70072F59 06S70072F77 06S45674W81 06S45674W81 06S45675W16 06S70072F29 06S45591W07 06S45591W07 09T55355Y15 09T55355Y07 09T25436Y07 01T01877K03 01T01877K03 01T01877K04 01T01877K04
RES,RK JUMPER1/10-CP RES,RK 333J 1/10 -CP RES,RK 333J 1/10 -CP RES,RK 333J 1/10 -CP RES,RK 473J 1/10 -CP RES,RK 333J 1/10 -CP RES,RK 473J 1/10 -CP RES,RK JUMPER1/10-CP RES,RK 103J 1/10 -CP RES,RK 473J 1/10 -CP RES,RK 473J 1/10 -CP RES,RK 473J 1/10 -CP RES,RK 473J 1/10 -CP RES,RK 473J 1/10 -CP RES,RK 473J 1/10 -CP RES,RK 473J 1/10 -CP RES,RK 333J 1/10 -CP RES,RK 101J 1/10 -CP RES,RK 101J 1/10 -CP RES,RK 473J 1/10 -CP RES,RK 473J 1/10 -CP RES,CP .101-J-1/4-CP RES,CP .561-J-1/4-CP RES,CP .561-J-1/4-CP RES,RK 223F 1/8 -CP RES,RK 472F 1/8 -CP RES,RK 434J 1/10 -CP RES,CP .102-J-1/4-CP RES,CP .102-J-1/4-CP RES,CP .103-J-1/4-CP RES,RK 104J 1/10 -CP RES,RK 243J 1/4 -CP RES,CP .182-J-1/4-CP RES,CP .182-J-1/4-CP RES,CP .821-J-1/4-CP RES,CP .471-J-1/4-CP RES,CP .152-J-1/4-CP RES,CP .152-J-1/4-CP RES,RK 223J 1/10 -CP RES,CP .182-J-1/4-CP RES,CP .182-J-1/4-CP RES,CP .103-J-1/4-CP RES,RK 103J 1/10 -CP RES,RK 103J 1/10 -CP RES,RK 274J 1/10 -CP RES,CP .101-J-1/4-CP RES,ARY MNR101J 4-CP RES,ARY MNR101J 4-CP FFC,IMSA9615S-15A-DB FFC,IMSA9615S-07A-DB WTB,53253-0710 -DB ASSY,CONN RCA 9803R ASSY,CONN RCA 9803R ASSY,CONN RCA 9801R ASSY,CONN RCA 9801R
*******FRONT P.W.Board =======IC's IC401 51T02347K01 #1 IC402 51T55628Y01 $1 IC402 51T55628Y01 =======Transistor %1 Q401 48T63788F04 =======Diodes D401 48T81063F01 D402 48T81063F01 #1 D403 48T85357W01 $1 D403 48T85357W01 D404 48T85357W01 D405 48T85357W01 D406 48T85357W01 D407 48T85357W01 D408 48T85357W01 ZD401 48T62934F26 %1 ZD402 48T15541Y23 %1 ZD403 48T15541Y23 =======LED's %1 LD401 48T45280Y01 %1 LD402 48T45280Y01 %1 LD403 48T45280Y01 %1 LD404 48T45280Y01 $1 LD405 48T25534Y03 %1 LD405 48T25534Y02 $1 LD406 48T25534Y03 %1 LD406 48T25534Y02 #1 LD407 48T25534Y01 %1 LD407 48T25534Y11 &1 LD407 48T25534Y01 #1 LD408 48T25534Y01 $1 LD408 48T25534Y03 %1 LD408 48T25534Y02 &1 LD408 48T25534Y01 #1 LD409 48T25534Y01 $1 LD409 48T25534Y03 %1 LD409 48T25534Y02 &1 LD409 48T25534Y01 #1 LD410 48T25534Y01 $1 LD410 48T25534Y03 %1 LD410 48T25534Y02 &1 LD410 48T25534Y01 $1 LD411 48T25534Y03 %1 LD411 48T25534Y02 $1 LD412 48T25534Y03 %1 LD412 48T25534Y02 $1 LD413 48T25534Y03 %1 LD413 48T25534Y02 $1 LD414 48T65285Y01 #1 LD415 48T25534Y01 $1 LD415 48T25534Y03 %1 LD415 48T25534Y02 &1 LD415 48T25534Y01 #1 LD416 48T25534Y01 $1 LD416 48T25534Y03
PT6583LQ RS-671 RS-671
-QT -NE2 -NE2
TR ,CP.2SD1328-T -TX DIO,CP.MA159 / TX-CP DIO,CP.MA159 / TX-CP DIO,1PS226 -CP DIO,1PS226 -CP DIO,1PS226 -CP DIO,1PS226 -CP DIO,1PS226 -CP DIO,1PS226 -CP DIO,1PS226 -CP DIO,ZEN.RD6.2MB3 -CP DIO,ZEN MAZS180 -CP DIO,ZEN MAZS180 -CP LED,WHT NSCWS405T-E2 LED,WHT NSCWS405T-E2 LED,WHT NSCWS405T-E2 LED,WHT NSCWS405T-E2 LED,AMB AA1111C -CP LED,RED BR1111C -CP LED,AMB AA1111C -CP LED,RED BR1111C -CP LED,GRN BG1111C -CP LED,BLU EB1111C -CP LED,GRN BG1111C -CP LED,GRN BG1111C -CP LED,AMB AA1111C -CP LED,RED BR1111C -CP LED,GRN BG1111C -CP LED,GRN BG1111C -CP LED,AMB AA1111C -CP LED,RED BR1111C -CP LED,GRN BG1111C -CP LED,GRN BG1111C -CP LED,AMB AA1111C -CP LED,RED BR1111C -CP LED,GRN BG1111C -CP LED,AMB AA1111C -CP LED,RED BR1111C -CP LED,AMB AA1111C -CP LED,RED BR1111C -CP LED,AMB AA1111C -CP LED,RED BR1111C -CP LED,AMB FA1112C -CP LED,GRN BG1111C -CP LED,AMB AA1111C -CP LED,RED BR1111C -CP LED,GRN BG1111C -CP LED,GRN BG1111C -CP LED,AMB AA1111C -CP
%1 LD416 &1 LD416 #1 LD417 $1 LD417 %1 LD417 &1 LD417 $1 LD418 %1 LD418 #1 LD419 $1 LD419 %1 LD419 &1 LD419 #1 LD420 $1 LD420 %1 LD420 &1 LD420 %1 LD421 %1 LD422 %1 LD423 %1 LD425 #1 LD427 $1 LD427 %1 LD427 &1 LD427 =======Switches SW401 SW402 SW403 SW404 SW405 SW406 SW407 SW408 SW409 SW410 SW411 SW412 SW413 SW414 SW415 SW416 SW417 SW418 SW419 =======Lamps #1 PL401 $1 PL401 &1 PL401 #1 PL402 $1 PL402 &1 PL402 #1 PL403 &1 PL403 #1 PL404 $1 PL404
48T25534Y02 48T25534Y01 48T25534Y01 48T25534Y03 48T25534Y02 48T25534Y01 48T25534Y03 48T25534Y02 48T25534Y01 48T25534Y03 48T25534Y02 48T25534Y01 48T25534Y01 48T25534Y03 48T25534Y02 48T25534Y01 48T25534Y11 48T25534Y11 48T25534Y11 48T25534Y11 48T25534Y03 48T25534Y03 48T25534Y02 48T25534Y03 40T65353Y01 40T65353Y01 40T65353Y01 40T65353Y01 40T65353Y01 40T65353Y01 40T65353Y01 40T65353Y01 40T65353Y01 40T65353Y01 40T65353Y01 40T65353Y01 40T65353Y01 40T65353Y01 40T65353Y01 40T65353Y01 40T65353Y01 40T65353Y01 40T65353Y01 65T45309Y03 65T45309Y02 65T45309Y01 65T45309Y03 65T45309Y02 65T45309Y01 65T35324Y02 65T35324Y02 65T35324Y02 65T35324Y03
LED,RED BR1111C LED,GRN BG1111C LED,GRN BG1111C LED,AMB AA1111C LED,RED BR1111C LED,GRN BG1111C LED,AMB AA1111C LED,RED BR1111C LED,GRN BG1111C LED,AMB AA1111C LED,RED BR1111C LED,GRN BG1111C LED,GRN BG1111C LED,AMB AA1111C LED,RED BR1111C LED,GRN BG1111C LED,BLU EB1111C LED,BLU EB1111C LED,BLU EB1111C LED,BLU EB1111C LED,AMB AA1111C LED,AMB AA1111C LED,RED BR1111C LED,AMB AA1111C
-CP -CP -CP -CP -CP -CP -CP -CP -CP -CP -CP -CP -CP -CP -CP -CP -CP -CP -CP -CP -CP -CP -CP -CP
SW,TACT SKRPACE010E2(EJECT) SW,TACT SKRPACE010E2(4/M.I.X.) SW,TACT SKRPACE010E2(3/PTY) SW,TACT SKRPACE010E2(MUTE) SW,TACT SKRPACE010E2(2/NEWS) SW,TACT SKRPACE010E2(6/SCAN