Text preview for : Sony-XM444W caramp.pdf part of Sony XM444W car amplifier
Back to : Sony-XM444W caramp.pdf | Home
XM-444W
SERVICE MANUAL
Ver 1.1 2003. 02
US Model
SPECIFICATIONS
AUDIO POWER SPECIFICATIONS POWER OUTPUT AND TOTAL HARMONIC DISTORTION 35 watts per channel minimum continuous average power into 4 ohms, both channels driven from 20 Hz to 20 kHz with no more than 0.04% total harmonic distortion per Car Audio Ad Hoc Committee standards. Other Specifications
OTL (output transformerless) circuit Pulse power supply Inputs RCA pin jacks High level input connector Input level adjustment range 0.3 6 V (RCA pin jacks), 0.6 12 V (High level input) Outputs Speaker terminals Speaker impedance 2 8 (stereo) 4 8 (when used as a bridging amplifier) Maximum outputs 4 Speakers: 80 W × 4 (at 4 ) 3 Speakers: 80 W × 2 + 222 W × 1 (at 4 ) 2 Speakers: 222 W × 2 (at 4 ) Rated outputs (supply voltage at 14.4 V) 4 Speakers: 35 W × 4 (20 Hz 20 kHz, 0.04% THD, at 4 ) 40 W × 4 (20 Hz 20 kHz, 0.1% THD, at 2 ) 2 Speakers: 80 W × 2 (20 Hz 20 kHz, 0.1% THD, at 4 ) Frequency response 5 Hz 80 kHz ( +0 dB) 3 Harmonic distortion 0.005% or less (at 1 kHz, 4 , 10 W) Low-pass filter 80 Hz, 18 dB/oct High-pass filter 80 Hz, 12 dB/oct Power requirements 12 V DC car battery (negative ground) Power supply voltage 10.5 16 V Current drain at rated output : 20 A (4 , 35 W × 4) Remote input : 1.5 mA Dimensions Approx. 260 × 55 × 180 mm (w/h/d) not incl. projecting parts and controls Mass Approx. 2.4 kg not incl. accessories Supplied accessories Mounting screws (4) High level input cord (1) Protection cap (1) Design and specifications are subject to c hange without notice. Circuit system
STEREO POWER AMPLIFIER
9-873-977-02
2003B0400-1 © 2003. 02
Sony Corporation
e Vehicle Company Published by Sony Engineering Corporation
1
XM-444W
PROTECTOR OPERATION CHECK
Thermal Protect 1. Short across TH801 with the power on. 2. Verify that the protector is operated and LD801 illuminates red. 3. Verify that the protector is released and LD801 illuminates green when the short is removed. 4. Likewise, perform items 1 to 3 for TH802 and TH803. Over Current Protect 1. Short between the positive and negative sides of the speaker output terminal CN802 with the power on. (Perform this shorting for each channel on FRONT and REAR.) 2. Verify that the protector is operated and LD801 illuminates red. 3. Verify that the protector is not released and LD801 remains red even when the short is removed. 4. Verify that the protector is released and LD801 illuminates green when the power is turned off and then on again. Offset Protect 1. Short between the +12V terminal of CN801 and the BTL+ or BTL of the speaker output terminal CN802. (Short between +12V terminal and BTL+ and between +12V terminal and BTL.) 2. Verify that the protector is operated and LD801 illuminates red. 3. Verify that the protector is not released and LD801 remains red even when the short is removed. 4. Verify that the protector is released and LD801 illuminates green when the power is turned off and then on again. Chassis Short Protect 1. Short between the +12V terminal of CN801 and the chassis with the power on. 2. Verify that the pilot lamp PL801 goes on. 3. Verify that PL801 goes off when the short is removed.
TABLE OF CONTENTS 1. GENERAL
Connections ............................................................................. 3
2. DISASSEMBLY
2-1. Bottom Plate ........................................................................ 5 2-2. Heat Sink ............................................................................. 6 2-3. Amp Board .......................................................................... 6
3. DIAGRAMS
3-1. 3-2. 3-3. 3-4. 3-5. Block Diagram Front Section ......................................... 7 Block Diagram Rear/Power Section ............................... 8 Schematic Diagram Amp Section ................................... 9 Schematic Diagram Power Section ............................... 10 Printed Wiring Board ........................................................ 11
4. EXPLODED VIEW ........................................................... 12 5. ELECTRICAL PARTS LIST ......................................... 13
Notes on Chip Component Replacement · Never reuse a disconnected chip component. · Notice that the minus side of a tantalum capacitor may be damaged by heat.
SAFETY-RELATED COMPONENT WARNING!! COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.
2
XM-444W SECTION 1 GENERAL
This section is extracted from instruction manual.
3
XM-444W
4
XM-444W SECTION 2 DISASSEMBLY
Note : This set can be disassemble according to the following sequence.
SET 2-1. BOTTOM PLATE (Page 5)
2-2.
HEAT SINK (Page 6)
2-3.
AMP BOARD (Page 6)
Note : Follow the disassembly procedure in the numerical order given.
2-1. BOTTOM PLATE
1 BTP 3x6 3 bottom plate 2 BTP 3x6
5
XM-444W
2-2. HEAT SINK
1 BVTP 3x8 3 BVTP 3x8 2 BVTP 3x8
4 AMP board
5 heat sink
2-3. AMP BOARD
2 rear panel 1 BVTP 3x8
4 front panel
5 AMP board
3 BVTP 3x8
6
XM-444W SECTION 3 DIAGRAMS
3-1. BLOCK DIAGRAM -- FRONT SECTION --
-1 L (BTL)
-1 2
PRE AMP IC801 (1/2) 1 3 5
HPF IC802 (1/2) 7 5 6 S801-1 HPF (80Hz)
GAIN CONTROL AMP IC803 (1/2) 7 SWITCH Q101 DIFFERENTIAL AMP Q102 DRIVE AMP Q104 DRIVE AMP Q108 POWER AMP Q110
CN802 (1/2) SPEAKER OUT (FRONT)
L VR801-1 LEVEL (FRONT) BIAS Q106,107
CNJ801 (1/2) INPUT (FRONT)
(FRONT) ON OFF
DIFFERENTIAL AMP Q103
DRIVE AMP Q105
DRIVE AMP Q109
POWER AMP Q111
OVERLOAD DET Q112
-2 R
-2 5
PRE AMP IC801 (2/2) 7 6 3
HPF IC802 (2/2) 1
BTL GAIN CONTROL AMP IC803 (2/2) 3 2 S801-2 HPF (80Hz) 1 SWITCH Q201 DIFFERENTIAL AMP Q202 DRIVE AMP Q204 DRIVE AMP Q208 POWER AMP Q210
B
(Page 8)
R
CNJ802 (1/2) HI LEVEL
L
R
(FRONT) ON OFF
VR801-2 LEVEL (FRONT)
BIAS Q206,207
C
(Page 8)
DIFFERENTIAL AMP Q203
DRIVE AMP Q205
DRIVE AMP Q209
POWER AMP Q211
OVERLOAD DET Q212
A
· Signal path : AUDIO (FRONT) (Page 8)
7
7
XM-444W
3-2. BLOCK DIAGRAM -- REAR/POWER SECTION --
-3 L (BTL)
-3 2
PRE AMP IC804 (1/2) 1 3 5
LPF IC805 (1/2) 7 5 6 S802-1 LPF (80Hz)
GAIN CONTROL AMP IC806 (1/2) 7 SWITCH Q301 DIFFERENTIAL AMP Q302 DRIVE AMP Q304 DRIVE AMP Q308 POWER AMP Q310
CN802 (2/2) SPEAKER OUT (REAR)
L VR802-1 LEVEL (REAR) DIFFERENTIAL AMP Q303 BIAS Q306,307
CNJ801 (2/2) INPUT (REAR)
(REAR) ON OFF
DRIVE AMP Q305
DRIVE AMP Q309
POWER AMP Q311
OVERLOAD DET Q312
(Page 7)
PRE AMP IC804 (2/2) 5 7 6 S802-2 LPF (80Hz) CNJ802 (2/2) HI LEVEL L R (REAR) ON OFF 3 1 LPF IC805 (2/2)
B
GAIN CONTROL AMP IC806 (2/2) 3 2 1 SWITCH Q401 DIFFERENTIAL AMP Q402 DRIVE AMP Q404 DRIVE AMP Q408 POWER AMP Q410 OFFSET DET Q852,853
BTL
-4 R
-4
VR802-2 LEVEL (REAR)
C
(Page 7)
MUTE Q851 DIFFERENTIAL AMP Q403
R BIAS Q406,407
DRIVE AMP Q405
DRIVE AMP Q409
POWER AMP Q411
OVERLOAD DET Q412
B+ (14.8V)
15V REG Q905,D905 DC DET 4 IC851 2 PROTECTOR Q802
A
(Page 7)
F901 40A CN801 +12V
B(-14.8V)
-15V REG Q906,D906 RECT D903,904 DC-DC CONVERTER TRANSFORMER T901
INVERTER Q903
DRIVER Q907
9
12 1 ERROR 2 3 LED DRIVE Q803 LD801 POWER/ PROTECTOR
B+ SWITCH Q902
B+ (23.5V) INVERTER Q904 DRIVER Q908 10
POWER ON/OFF Q901 REM GND
B(-23.5V)
ERROR
15 16
13
14
THERMAL Q801
DC-DC CONVERTER IC901
TH801
TH802
TH803
· Signal path : AUDIO (REAR)
D804
D802
8
8
XM-444W
3-3. SCHEMATIC DIAGRAM -- AMP SECTION -- · Refer to page 12 for Common Note on Schematic Diagrams.
R114
R116 Q102
D101
R118 Q104 Q108 R124 R126 R122 R119 C115 Q106 R123 R125 R127 Q105 Q111 Q109 R128 C116 R135 Q107 R130 Q110 R129 Q112 R133
C857
C104 Q101 C112 R131
C113 C114
C101 R101 C102 R102 C103
R103 R106
C109 IC803 (1/2) IC802 (1/2) C111 R113 Q103 R115 R111 R117 R132 R120
C107 C108 IC801 (1/2)
R112
C861
R861
R862
R138 C862 C119
R139 C105 C120 R104 R107 C110 R108 R109
S801 R110
VR801
D102
R121 R136
R207 C205 C201 R201 IC801 (2/2) C203 C202 R202 R203 C858 CNJ801 CNJ802 R238 R239 C220 C204 C207 C208 R204
C210
R208
R209
R210
R211 R216 R214 Q204 Q202 IC803 (2/2) C211 Q201 R213 C212 R231 C214 R219 C215 R220 R212 Q203 R232 Q205 R215 R217 Q209 D202 R221 R236 CN802 R316 Q302 R318 Q304 Q308 R333 R324 R326 Q301 C312 R322 C315 IC806 (1/2) R320 C311 R312 R313 Q303 R332 Q305 R323 Q306 R325 C316 R327 Q311 Q309 R335 Q307 R330 R328 Q310 R329 Q312 R223 R222 Q206 R225 R227 Q211 Q207 R230 R228 C216 R235 D201 R218 Q208 R224 R226 Q210 R229 Q212 R233
IC802 (2/2)
C213
R206
C209
C117 C118 C217 C218
C219
R137 R237 R337 R437 C320 C319 R338 C859 C304
R314
D301
C317 C318 C417 C418
C313 C314
R339
R863
C863
C301 R301
R303 C307 R305
R331
R319
C309
C303 C302 R302 C420 R864 C864 R439 C419 C305 R438 IC804 (1/2)
R306 R307 IC805 (1/2)
C306
R304 C308
S802 C310 R308 R309
R310
VR802 R311
R315
R317
D302
R321
R336 C408 C405 R404 IC804 (2/2) C403 R406 R407 C407 C860 R403 R420 C404 R412 Q403 R415 R417 R432 Q405 D402 Q409 R421 R436 R423 R405 C409 R408 R409 R410 R411 R416 R414 C406 IC806 (2/2) C411 Q401 R413 C412 R431 C414 R419 C415 Q406 R425 R427 Q411 R422 Q407 R430 R428 C416 R435 Q402 D401 R418 Q404 IC805 (2/2) C413 R424 R426 Q408 Q410 R429 R433 Q412
C410
C401 R401
C402
R402
(Page 10)
9
9
XM-444W
3-4. SCHEMATIC DIAGRAM -- POWER SECTION -- · Refer to page 12 for IC Block Diagram and Common Note on Schematic Diagrams.
(Page 9)
R855
T901 R851 Q851 R852 R915 IC851 R853 D851 C851 R854 D852 R917 R918 R920 R922 Q908 R925 R928 Q904 C910 D904 R926 C908 C915 R916 R921 R927 R923 R924 R919 Q907 Q903 C907 C913 L951 D903
C914
R929
Q905
C919 C911 D905 C917
C912
D906
C918 C920 R856
R858 C852 C853 C854
C916
R930 Q906 R857 Q853 D805
Q852
IC B/D
Q902 R914 C801 R905 F901 Q901 R906 R907 D902 C904 C802 D901 R803 Q801 R815 R913 R909 R865 R802 D803 C901 R901 R904 R902 IC901 D802 R801 D801
TH802
D806
D804 TH801
TH803
C804
R809
R812 R811
LD801
R810 Q802 CN801 L901
R814 R805 R806
C909
R813 R807 C803 R808 R859 R961 C959 Q803
R912 R911
C906
R910
C902 R903
C903 C905
PL801
C805 R804
· Waveform
1
1V/DIV, 5µsec/DIV 3.4Vp-p 15µsec
IC901
5
10
10
XM-444W
3-5. PRINTED WIRING BOARD · Refer to page 12 for Semiconductor Location and Common Note on Printed Wiring Boards.
1 A
CN802 SPEAKER OUT (REAR) (FRONT)
2
3
4
5
6
7
8
9
10
11
12
13
14
15
AMP BOARD
C316
Q410
Q411
Q310
Q311
R410
R336
JW41
JW46
E C B
C859 JW45
C411
JR9
JW154
R335
B
R136 JW155 C116
Q406
E
C
B
E
C
B
Q306
R322
E
C
B
JW44 JW43
4 IC806
1 8
JW40
L BTL
R429 B C E R430 Q412
R433
ECB
ECB
R135
R422
R426 B C E R423 R424 Q407 JW118 JW120 JW119 R425 R428 Q408 JW156 Q409
TH803 JW49
JW47 R321
R315 D302
JW48 JW50 JW52
C406
R406 C407 R405
R310 5 R408 R409 C410
R309 JW42
C311 -1
R411 R311
R427
R326 B C E R323 R324 Q307 JW51 C315
R318
R327
-2
S802 -2 -1
S802 LPF(80Hz) (REAR) ON OFF VR802 LEVEL (REAR) CNJ802 HI LEVEL
C416
R331
JW39
R435
R236
JW124
JW153
R432
R431
R235 C216
Q301
ECB
C405 R403 C303 R404 R438 R401 R439 JW25 JW24 R339 JW23 JW22
R137
C853
D806 D805
JW117
JW53
JW38
JW37 JW36
JR3
R412
C118
JW128 JW129 JW131 JW133 JW134 JW110 JW109 JW108 JW107
JW99 R806 R805
ECB
JW152 C852 R858
JW150
R812
R854
JR8
JW130 JW132 JW113 JW112 JW111 JW106 JW105 JW104 JW103 D802 JW102 JW101
R857 R856
JW60
Q803
BCE
R855
C851
JW61
R813
R
R815
D804
R811
JW65
JR2
R909
C917
C904 JW135
R801 C801
G
R810
C858 JW14
JW66
JR6 JR5
Q906 Q905 JW31 JW30 R112 JW69 ECB Q101 D102
R132 R131
R861
D905
C103 R203 R239 R238 R202 R102
R809
R804
D801
R139
C804
JW64
R930
JR1
R104 C105
LD801 POWER/ PROTECTOR
JW63
JW62
D851
R808
C906 JR7 R910 R911 C909 R912
R803
R103 R138 C104 R101 4 1 IC801 5 8
C959 R961 JW19 C861
R863 C863
C802
Q851
C918
JW33 C920 JW29 JW28
C803 R807
JW149 JW148
JW151
R851 R852
C403 C404
Q852
D906 JW59 C919
C860
JW20 C401
C864
R333
R853
D
IC851
D803 E C B
JW116 JW115 JW114
Q401 D852
R312
JW32
C117
R859 Q853
C854
C412
ECB
JW34
JW125 JW126 JW127
C415
R416
R413
JW55 JW56 R329 JW57 R330 JW58 Q312
R319 R320
R
R419 R420 D401 R418
Q308
JW54 D301
R316 C312
C308
JW27 JW26
Q309
R313
C419 C306 C320 C319 C420 C219 R303 R338 C220 C304 R301 C119 4 1 C120 JW21 IC804 R302 C301 R402 8 5
C217 C317 C417 C218 C318 C418
R332
JW123
5
8
R237 R337
R325
R307 R306
C
JW35
R304 C305
Q403 Q405 D402 Q404 C413 C414 R414 R417 Q402 JR4
R415
R436
JW122
R328
IC805
C307 C310
R305
JW121
R421
Q303 Q305 C313 C314 R314 R317 Q304 Q302
4
1
R437 R
R308
C408 R407
C409
C309 VR802
(REAR) L R (FRONT) L
C302 C402
R864
(REAR) -3 L (BTL)
-4 R CNJ801 INPUT
JW17 JW16 JW15 C857
E
F901 40A
LD801
Q802
R802 Q801
JW145 JW144
JW147 JW146 C905
8 9 IC901
1
C903
JW72 JW73 JW74
JW76
C101 JW18 C201 C102 C202 C862 R862
JR10 C211
(FRONT) -1 L (BTL)
-2 R
R212
Q201 ECB
JW79
R906
R907
C911
JW82
JW81
JW77 JW78
C212
JW70 JW71
C112 JW10 R113 R115 Q103 R114 C114 R117
R116 JW9
JW11
JW12
B
JW136
E Q902 R814
R915
R917
C
R914
D902
R211 R111
R902 R903
R865
Q901
R905 JW137
R221
R232 R231
JW142 JW143
L901
R220 R219
R120 R119
JW8 JW7
Q908 Q907
ECB ECB
R904
D901
C215 C914 C915 Q209
C912
R121
R916
R230 R229 E C B Q212 JW83
Q205 C213
Q203 R214 C214 R217
R216 R218
R233
C115
-1 VR801
JW3
F
REM
R922 R921
C913
C916
D202
R213 R215
JW80
R920 R918 R919
JW100
JW75
JW13
C203 C204 C205 R204 R201
16 R913
JW67 JW68
R929
-2
S801 -2 -1
S801 HPF(80Hz) (FRONT) ON OFF
CN801
D201
D101
R210 1 4 IC803 5 8 R110
JW6 JW5 JW4
C111
JW138
JW139
R208
R209
R130
C901
C208
R924
R927
C902
C907
C908 TH801
R133
JW1
C910
BCE
JW92 TH802
Q207
R222
JW89
Q107
BCE
G
JW87
JW86
R122
4 IC802 5
1 8
GND PL801
C805
R926
R928
G D S G D S
R227 K A K A K A B C E
R224 R223 E C B Q206
R226
B C E
R127
B
R124 R123 E C B C E Q106
R206 R106 R107
C207
+12V
R901
JW141
JW96 JW95 JW94 JW93
JW88
R128
JW85
B C E Q112 JW2
R207
C209
JW140
T901 R923 DC-DC CONVERTER R925 TRANSFORMER
L951
R225 JW90 JW91 R228
R125 Q104 R129
R118
C210
Q208 Q204
Q202
Q109 JW84
Q105 C113 Q108
Q102
R108 C109 R109 C110
VR801 LEVEL (FRONT)
C107 C108
R126 B C
E
H
Q904
Q903
D904
D903
Q211
Q210
Q111
Q110
1-684-682-
11
I
11
11
XM-444W SECTION 4 EXPLODED VIEW
· Semiconductor Location Ref. No. D101 D102 D201 D202 D301 D302 D401 D402 D801 D802 D803 D804 D805 D806 D851 D852 D901 D902 D903 D904 D905 D906 IC801 IC802 IC803 IC804 IC805 IC806 IC851 IC901 LD801 Q101 Q102 Q103 Q104 Q105 Q106 Q107 Q108 Q109 Q110 Q111 Q112 Q201 Q202 Location F-12 F-11 F-10 F-9 C-10 C-11 D-7 C-8 E-3 E-6 D-3 E-4 D-5 D-5 D-9 D-9 F-3 F-4 H-7 H-6 E-10 D-10 E-12 G-13 F-12 D-11 C-11 B-12 D-3 E-4 E-3 F-11 F-11 F-11 G-11 F-11 H-11 G-10 F-11 F-10 H-11 H-10 G-12 E-9 F-9 Ref. No. Q203 Q204 Q205 Q206 Q207 Q208 Q209 Q210 Q211 Q212 Q301 Q302 Q303 Q304 Q305 Q306 Q307 Q308 Q309 Q310 Q311 Q312 Q401 Q402 Q403 Q404 Q405 Q406 Q407 Q408 Q409 Q410 Q411 Q412 Q801 Q802 Q803 Q851 Q852 Q853 Q901 Q902 Q903 Q904 Q905 Q906 Q907 Q908 Location F-9 G-9 F-9 H-8 G-8 F-8 F-8 H-9 H-8 F-10 D-10 C-10 C-10 C-10 C-10 B-9 C-9 C-9 C-9 B-9 B-10 D-9 D-10 C-8 C-8 C-7 C-7 B-7 B-7 C-6 C-7 B-6 B-7 B-6 E-3 E-3 D-2 D-10 D-4 D-4 F-3 E-4 H-5 H-4 E-10 E-10 F-6 G-6 THIS NOTE IS COMMON FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS. (In addition to this, the necessary note is printed in each block.) for schematic diagram: · All capacitors are in µF unless otherwise noted. pF: µµF 50 WV or less are not indicated except for electrolytics and tantalums. · All resistors are in and 1/4 W or less unless otherwise specified. · 2 : nonflammable resistor. Note: The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. · A : B+ Line. · B : B Line. · Power voltage is dc 14.4V and fed with regulated dc power supply from +12V and REM terminals. · Voltage is dc with respect to ground under no-signal condition. · Voltages are taken with a VOM (Input impedance 10 M). Voltage variations may be noted due to normal production tolerances. · Waveforms are taken with a oscilloscope. Voltage variations may be noted due to normal production tolerances. · Circled numbers refer to waveforms. · Signal path. F : AUDIO for printed wiring boards: · X : parts extracted from the component side. · : Pattern from the side which enables seeing. NOTE: · The mechanical parts with no reference number in the exploded views are not supplied. · Items marked "*" are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. · Color Indication of Appearance Parts Example : KNOB, BALANCE (WHITE) ... (RED) R R Parts Color Cabinet's Color · Accessories are given in the last of this parts list. The components identified by mark 0 or dotted line with mark. 0 are critical for safety. Replace only with part number specified.
4 5
6
10 12 3 8
10
11 6
12
9
F901
2
6 11 1
11
· IC Block Diagram IC901 µPC494GS-T1
16 15 14 13 REF. REG. 12 11 10 9
6
6
7
ERROR
7
0.1V ERROR 1 2 3 4 5 OSC
6
7 8
Ref. No. 1 2 3 4 5 6 7
Part No. 3-240-650-01 3-238-669-01 3-238-668-21 3-238-670-01 A-3274-222-A
Description PLATE, BOTTOM PANEL, FRONT HEAT SINK PANEL, REAR AMP BOARD, COMPLETE
Remark
Ref. No. 8 9 10 11 12 0 F901
Part No. 3-240-642-01 3-240-651-01 3-225-184-01 3-225-183-01 3-912-432-01
Description HEAT SINK (SUB 2CH) HEAT SINK (SUB 4CH) SCREW (+PS.TT.3X6) SCREW (+PSW.TT.3XL) SCREW (+B)
Remark
7-685-646-79 SCREW +BVTP 3X8 TYPE2 IT-3 7-685-545-14 SCREW +BTP 3X6 TYPE2 N-S
1-533-743-11 FUSE (BLADE TYPE) (AUTO FUSE) 40A
12
12
XM-444W SECTION 5 ELECTRICAL PARTS LIST
NOTE: · Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. · RESISTORS All resistors are in ohms. METAL:Metal-film resistor. METAL OXIDE: Metal oxide-film resistor. F:nonflammable · Items marked "*" are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. · SEMICONDUCTORS In each case, u : µ, for example: uA.. : µA.. uPA.. : µPA.. uPB.. : µPB.. uPC.. : µPC.. uPD.. : µPD.. · CAPACITORS uF : µF · COILS uH : µH The components identified by mark 0 or dotted line with mark. 0 are critical for safety. Replace only with part number specified. When indicating parts by reference number, please include the board.
AMP
Ref. No.
Part No.
Description
Remark
Ref. No. C217 C218 C219 C220 C301 C302 C303 C304 C305 C306 C307 C308 C309 C310 C311 C312 C313 C314 C315 C316 C317 C318 C319 C320 C401 C402 C403 C404 C405 C406 C407 C408 C409 C410 C411 C412 C413 C414 C415 C416 C417 C418 C419 C420 C801
Part No. 1-162-927-11 1-162-927-11 1-115-467-11 1-115-467-11 1-126-963-11 1-126-963-11 1-162-923-11 1-162-927-11 1-162-927-11 1-126-963-11 1-107-826-11 1-164-227-11 1-128-551-11 1-128-551-11 1-162-927-11 1-126-933-11 1-162-923-11 1-162-923-11 1-126-960-11 1-136-161-00 1-162-927-11 1-162-927-11 1-115-467-11 1-115-467-11 1-126-963-11 1-126-963-11 1-162-923-11 1-162-927-11 1-162-927-11 1-126-963-11 1-107-826-11 1-164-227-11 1-128-551-11 1-128-551-11 1-162-927-11 1-126-933-11 1-162-923-11 1-162-923-11 1-126-960-11 1-136-161-00 1-162-927-11 1-162-927-11 1-115-467-11 1-115-467-11 1-163-021-00
Description CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP ELECT ELECT CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP ELECT FILM CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP ELECT ELECT CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP ELECT FILM CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 100PF 100PF 0.22uF 0.22uF 4.7uF 4.7uF 47PF 100PF 100PF 4.7uF 0.1uF 0.022uF 22uF 22uF 100PF 100uF 47PF 47PF 1uF 0.047uF 100PF 100PF 0.22uF 0.22uF 4.7uF 4.7uF 47PF 100PF 100PF 4.7uF 0.1uF 0.022uF 22uF 22uF 100PF 100uF 47PF 47PF 1uF 0.047uF 100PF 100PF 0.22uF 0.22uF 0.01uF 5% 5% 10% 10% 20% 20% 5% 5% 5% 20% 10% 10% 20% 20% 5% 20% 5% 5% 20% 5% 5% 5% 10% 10% 20% 20% 5% 5% 5% 20% 10% 10% 20% 20% 5% 20% 5% 5% 20% 5% 5% 5% 10% 10% 10%
Remark 50V 50V 10V 10V 50V 50V 50V 50V 50V 50V 16V 25V 25V 25V 50V 16V 50V 50V 50V 50V 50V 50V 10V 10V 50V 50V 50V 50V 50V 50V 16V 25V 25V 25V 50V 16V 50V 50V 50V 50V 50V 50V 10V 10V 50V
A-3274-222-A AMP BOARD, COMPLETE ********************* 1-537-479-11 3-225-183-01 3-225-184-01 3-240-642-01 3-240-651-01 TERMINAL SCREW (+PSW.TT.3XL) SCREW (+PS.TT.3X6) HEAT SINK (SUB 2CH) HEAT SINK (SUB 4CH)
3-912-432-01 SCREW (+B) < CAPACITOR > C101 C102 C103 C104 C105 C107 C108 C109 C110 C111 C112 C113 C114 C115 C116 C117 C118 C119 C120 C201 C202 C203 C204 C205 C207 C208 C209 C210 C211 C212 C213 C214 C215 C216 1-126-963-11 1-126-963-11 1-162-923-11 1-162-927-11 1-162-927-11 1-164-227-11 1-164-227-11 1-128-551-11 1-128-551-11 1-162-927-11 1-126-933-11 1-162-923-11 1-162-923-11 1-126-960-11 1-136-161-00 1-162-927-11 1-162-927-11 1-115-467-11 1-115-467-11 1-126-963-11 1-126-963-11 1-162-923-11 1-162-927-11 1-162-927-11 1-164-227-11 1-164-227-11 1-128-551-11 1-128-551-11 1-162-927-11 1-126-933-11 1-162-923-11 1-162-923-11 1-126-960-11 1-136-161-00 ELECT ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT ELECT CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP ELECT FILM CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT ELECT CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP ELECT FILM 4.7uF 4.7uF 47PF 100PF 100PF 0.022uF 0.022uF 22uF 22uF 100PF 100uF 47PF 47PF 1uF 0.047uF 100PF 100PF 0.22uF 0.22uF 4.7uF 4.7uF 47PF 100PF 100PF 0.022uF 0.022uF 22uF 22uF 100PF 100uF 47PF 47PF 1uF 0.047uF 20% 20% 5% 5% 5% 10% 10% 20% 20% 5% 20% 5% 5% 20% 5% 5% 5% 10% 10% 20% 20% 5% 5% 5% 10% 10% 20% 20% 5% 20% 5% 5% 20% 5% 50V 50V 50V 50V 50V 25V 25V 25V 25V 50V 16V 50V 50V 50V 50V 50V 50V 10V 10V 50V 50V 50V 50V 50V 25V 25V 25V 25V 50V 16V 50V 50V 50V 50V
13
XM-444W AMP
Ref. No. C802 C803 C804 C805 C851 C852 C853 C854 C857 C858 C859 C860 C861 C862 C863 C864 C901 C902 C903 C904 C905 C906 C907 C908 C909 C910 C911 C912 C913 C914 C915 C916 C917 C918 C919 C920 C959 Part No. 1-128-551-11 1-164-315-11 1-128-551-11 1-164-156-11 1-128-551-11 1-162-964-11 1-128-551-11 1-128-551-11 1-164-156-11 1-164-156-11 1-164-156-11 1-164-156-11 1-126-934-11 1-115-467-11 1-115-467-11 1-115-467-11 1-137-194-81 1-162-964-11 1-126-947-11 1-128-551-11 1-126-933-11 1-162-964-11 1-136-161-00 1-131-731-11 1-163-021-00 1-131-731-11 1-136-165-00 1-136-165-00 1-165-949-11 1-165-949-11 1-165-949-11 1-165-949-11 1-126-963-11 1-126-963-11 1-126-933-11 Description ELECT CERAMIC CHIP ELECT CERAMIC CHIP ELECT CERAMIC CHIP ELECT ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP FILM CERAMIC CHIP ELECT ELECT ELECT CERAMIC CHIP FILM ELECT CERAMIC CHIP ELECT FILM FILM ELECT ELECT ELECT ELECT ELECT ELECT ELECT 22uF 470PF 22uF 0.1uF 22uF 0.001uF 22uF 22uF 0.1uF 0.1uF 0.1uF 0.1uF 220uF 0.22uF 0.22uF 0.22uF 0.47uF 0.001uF 47uF 22uF 100uF 0.001uF 0.047uF 2200uF 0.01uF 2200uF 0.1uF 0.1uF 1500uF 1500uF 1500uF 1500uF 4.7uF 4.7uF 100uF 100uF 0.1uF 20% 5% 20% 20% 10% 20% 20% Remark 25V 50V 25V 25V 25V 50V 25V 25V 25V 25V 25V 25V 16V 10V 10V 10V 50V 50V 16V 25V 16V 50V 50V 16V 50V 16V 50V 50V 35V 35V 35V 35V 50V 50V 16V 16V 25V Ref. No. Part No. Description < DIODE > D101 D102 D201 D202 D301 D302 D401 D402 D801 D802 D803 D804 D805 D806 D851 D852 D901 D902 D903 D904 D905 D906 8-719-801-78 8-719-801-78 8-719-801-78 8-719-801-78 8-719-801-78 8-719-801-78 8-719-801-78 8-719-801-78 8-719-801-78 8-719-801-78 8-719-801-78 8-719-801-78 8-719-801-78 8-719-820-05 8-719-025-34 8-719-801-78 8-719-025-50 8-719-025-34 6-500-209-01 6-500-210-01 DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE 1SS184 1SS184 1SS184 1SS184 1SS184 1SS184 1SS184 1SS184 1SS184 1SS184 1SS184 1SS184 1SS184 1SS181 02CZ6.8-TE85L 1SS184 02CZ16-TE85L 02CZ6.8-TE85L FCH08A15 FRH08A15 Remark
20% 10% 10% 10% 5% 10% 20% 20% 20% 10% 5% 20% 10% 20% 5% 5%
8-719-025-49 DIODE 02CZ15-TE85L 8-719-025-49 DIODE 02CZ15-TE85L < FUSE >
0 F901
1-533-743-11 FUSE (BLADE TYPE) (AUTO FUSE) 40A < IC >
20% 20% 20% 20%
IC801 IC802 IC803 IC804 IC805 IC806 IC901
8-759-710-28 8-759-710-28 8-759-710-28 8-759-710-28 8-759-710-28
IC IC IC IC IC
NJM4565M-A NJM4565M-A NJM4565M-A NJM4565M-A NJM4565M-A
1-126-933-11 ELECT 1-164-156-11 CERAMIC CHIP
8-759-710-28 IC NJM4565M-A 8-759-144-88 IC uPC494GS < PHOTO COUPLER >
< TERMINAL BOARD > IC851 CN801 CN802 1-537-477-11 TERMINAL BOARD (3P) (REM,+12V,GND) 1-694-902-11 TERMINAL BOARD (8P) (SPEAKER OUT (FRONT/REAR)) < JACK > CNJ801 1-779-078-21 JACK, PIN 4P (INPUT (FRONT/REAR)) < CONNECTOR > CNJ802 1-580-283-11 PIN, CONNECTOR (PC BOARD) 8P (HI LEVEL (INPUT (FRONT/REAR))) JR6 JR7 JR8 JR9 JR10 1-216-864-11 1-216-864-11 1-216-296-11 1-216-296-11 1-216-296-11 METAL CHIP METAL CHIP SHORT SHORT SHORT 0 0 0 0 0 5% 5% 1/16W 1/16W JR1 JR2 JR3 JR4 JR5 1-216-864-11 1-216-296-11 1-216-864-11 1-216-864-11 1-216-864-11 8-719-156-72 PHOTO COUPLER PS2501-1-K < JUMPER RESISTOR > METAL CHIP SHORT METAL CHIP METAL CHIP METAL CHIP 0 0 0 0 0 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W
The components identified by mark 0 or dotted line with mark. 0 are critical for safety. Replace only with part number specified.
14
XM-444W AMP
Ref. No. Part No. Description < COIL > L901 L951 1-411-756-11 COIL, CHOKE 1-410-396-41 INDUCTOR, FERRITE BEAD 0.45uH < DIODE > LD801 8-719-076-62 LED GL5ED60 (POWER/PROTECTOR) < PILOT LAMP > PL801 1-517-156-11 LAMP, PILOT < TRANSISTOR > Q101 Q102 Q103 Q104 Q105 Q106 Q107 Q108 Q109 Q110 Q111 Q112 Q201 Q202 Q203 Q204 Q205 Q206 Q207 Q208 Q209 Q210 Q211 Q212 Q301 Q302 Q303 Q304 Q305 Q306 Q307 Q308 Q309 Q310 Q311 Q312 Q401 Q402 Q403 Q404 8-729-202-38 8-729-014-86 8-729-232-66 8-729-140-82 8-729-140-84 8-729-902-11 8-729-230-46 8-729-020-80 8-729-232-32 8-729-024-79 8-729-024-76 8-729-230-49 8-729-202-38 8-729-014-86 8-729-232-66 8-729-140-82 8-729-140-84 8-729-902-11 8-729-230-46 8-729-020-80 8-729-232-32 8-729-024-79 8-729-024-76 8-729-230-49 8-729-202-38 8-729-014-86 8-729-232-66 8-729-140-82 8-729-140-84 8-729-902-11 8-729-230-46 8-729-020-80 8-729-232-32 8-729-024-79 8-729-024-76 8-729-230-49 8-729-202-38 8-729-014-86 8-729-232-66 8-729-140-82 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR 2SC3326N-A 2SC4207-YGR-TE85L 2SA1618-Y 2SA988-PAFAEA 2SC1841-PAFAEA 2SC2021-Q 2SA1162-YG 2SC2235-O/Y(TPE6) 2SA965 2SC5100-P 2SA1908-P 2SC2712-YG 2SC3326N-A 2SC4207-YGR-TE85L 2SA1618-Y 2SA988-PAFAEA 2SC1841-PAFAEA 2SC2021-Q 2SA1162-YG 2SC2235-O/Y(TPE6) 2SA965 2SC5100-P 2SA1908-P 2SC2712-YG 2SC3326N-A 2SC4207-YGR-TE85L 2SA1618-Y 2SA988-PAFAEA 2SC1841-PAFAEA 2SC2021-Q 2SA1162-YG 2SC2235-O/Y(TPE6) 2SA965 2SC5100-P 2SA1908-P 2SC2712-YG 2SC3326N-A 2SC4207-YGR-TE85L 2SA1618-Y 2SA988-PAFAEA Q803 Q851 Q852 Q853 Q901 Q902 Q903 Q904 Q905 Q906 Q907 Q908 8-729-027-43 8-729-049-77 8-729-027-43 8-729-049-77 8-729-049-77 8-729-106-60 8-729-053-05 8-729-053-05 8-729-207-82 8-729-207-89 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR DTC114EKA-T146 HN1B01F-GR(T5LSONY) DTC114EKA-T146 HN1B01F-GR(T5LSONY) HN1B01F-GR(T5LSONY) Q410 Q411 Q412 Q801 Q802 8-729-024-79 8-729-024-76 8-729-230-49 8-729-049-77 8-729-049-77 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR 2SC5100-P 2SA1908-P 2SC2712-YG HN1B01F-GR(T5LSONY) HN1B01F-GR(T5LSONY) Remark Ref. No. Q405 Q406 Q407 Q408 Q409 Part No. 8-729-140-84 8-729-902-11 8-729-230-46 8-729-020-80 8-729-232-32 Description TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR 2SC1841-PAFAEA 2SC2021-Q 2SA1162-YG 2SC2235-O/Y(TPE6) 2SA965 Remark
TRANSISTOR 2SB1115A FET FKV550T FET FKV550T TRANSISTOR 2SC3421-Y TRANSISTOR 2SA1358-Y
8-729-230-49 TRANSISTOR 2SC2712-YG 8-729-230-49 TRANSISTOR 2SC2712-YG < RESISTOR >
R101 R102 R103 R104 R106 R107 R108 R109 R110 R111 R112 R113 R114 R115 R116 R117 R118 R119 R120 R121 R122 R123 R124 R125 R126 R127 R128 R129 R130
1-216-837-11 1-216-837-11 1-218-867-11 1-218-867-11 1-216-843-11 1-218-332-11 1-216-841-11 1-216-841-11 1-216-829-11 1-218-482-11 1-216-222-00 1-216-829-11 1-216-839-11 1-216-823-11 1-216-823-11 1-216-839-11 1-216-809-11 1-216-845-11 1-216-845-11 1-216-174-00 1-216-820-11 1-216-814-11 1-216-829-11 1-216-182-00 1-216-150-00 1-216-150-00 1-205-991-11 1-216-821-11 1-216-821-11
METAL CHIP METAL CHIP RES-CHIP RES-CHIP METAL CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP RES-CHIP METAL METAL CHIP METAL CHIP
22K 22K 6.8K 6.8K 68K 130K 47K 47K 4.7K 430 10K 4.7K 33K 1.5K 1.5K 33K 100 100K 100K 100 820 270 4.7K 220 10 10 0.1X2 1K 1K
5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 10% 5% 5%
1/16W 1/16W 1/10W 1/10W 1/16W 1/10W 1/16W 1/16W 1/16W 1/10W 1/8W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/8W 1/16W 1/16W 1/16W 1/8W 1/8W 1/8W 5W 1/16W 1/16W
15
XM-444W AMP
Ref. No. R131 R132 R133 R135 R136 R137 R138 R139 R201 R202 R203 R204 R206 R207 R208 R209 R210 R211 R212 R213 R214 R215 R216 R217 R218 R219 R220 R221 R222 R223 R224 R225 R226 R227 R228 R229 R230 R231 R232 R233 R235 R236 R237 R238 R239 R301 R302 R303 R304 R305 R306 R307 R308 Part No. 1-216-823-11 1-216-222-00 1-216-833-11 1-215-857-31 1-216-853-11 1-216-206-00 1-216-841-11 1-216-841-11 1-216-837-11 1-216-837-11 1-218-867-11 1-218-867-11 1-216-843-11 1-218-332-11 1-216-841-11 1-216-841-11 1-216-829-11 1-218-482-11 1-216-222-00 1-216-829-11 1-216-839-11 1-216-823-11 1-216-823-11 1-216-839-11 1-216-809-11 1-216-845-11 1-216-845-11 1-216-174-00 1-216-820-11 1-216-814-11 1-216-829-11 1-216-182-00 1-216-150-00 1-216-150-00 1-205-991-11 1-216-821-11 1-216-821-11 1-216-823-11 1-216-222-00 1-216-833-11 1-215-857-31 1-216-853-11 1-216-206-00 1-216-841-11 1-216-841-11 1-216-837-11 1-216-837-11 1-218-867-11 1-218-867-11 1-216-816-11 Description METAL CHIP RES-CHIP METAL CHIP METAL OXIDE METAL CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP METAL CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP RES-CHIP METAL METAL CHIP METAL CHIP METAL CHIP RES-CHIP METAL CHIP METAL OXIDE METAL CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP METAL CHIP 1.5K 10K 10K 10 470K 2.2K 47K 47K 22K 22K 6.8K 6.8K 68K 130K 47K 47K 4.7K 430 10K 4.7K 33K 1.5K 1.5K 33K 100 100K 100K 100 820 270 4.7K 220 10 10 0.1X2 1K 1K 1.5K 10K 10K 10 470K 2.2K 47K 47K 22K 22K 6.8K 6.8K 390 47K 47K 47K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 10% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% Remark 1/16W 1/8W 1/16W 1W F 1/16W 1/8W 1/16W 1/16W 1/16W 1/16W 1/10W 1/10W 1/16W 1/10W 1/16W 1/16W 1/16W 1/10W 1/8W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/8W 1/16W 1/16W 1/16W 1/8W 1/8W 1/8W 5W 1/16W 1/16W 1/16W 1/8W 1/16W 1W F 1/16W 1/8W 1/16W 1/16W 1/16W 1/16W 1/10W 1/10W 1/16W 1/16W 1/16W 1/16W Ref. No. R309 R310 R311 R312 R313 R314 R315 R316 R317 R318 R319 R320 R321 R322 R323 R324 R325 R326 R327 R328 R329 R330 R331 R332 R333 R335 R336 R337 R338 R339 R401 R402 R403 R404 R405 R406 R407 R408 R409 R410 R411 R412 R413 R414 R415 R416 R417 R418 R419 R420 R421 R422 R423 Part No. 1-216-841-11 1-216-829-11 1-218-482-11 1-216-222-00 1-216-829-11 1-216-839-11 1-216-823-11 1-216-823-11 1-216-839-11 1-216-174-00 1-216-845-11 1-216-845-11 1-216-809-11 1-216-820-11 1-216-814-11 1-216-829-11 1-216-182-00 1-216-150-00 1-216-150-00 1-205-991-11 1-216-821-11 1-216-821-11 1-216-823-11 1-216-222-00 1-216-222-00 1-215-857-31 1-216-853-11 1-216-206-00 1-216-841-11 1-216-841-11 1-216-837-11 1-216-837-11 1-218-867-11 1-218-867-11 1-216-816-11 1-216-841-11 1-216-841-11 1-216-841-11 1-216-841-11 1-216-829-11 1-218-482-11 1-216-222-00 1-216-829-11 1-216-839-11 1-216-823-11 1-216-823-11 1-216-839-11 1-216-174-00 1-216-845-11 1-216-845-11 Description METAL CHIP METAL CHIP RES-CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP RES-CHIP METAL METAL CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP METAL OXIDE METAL CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP METAL CHIP METAL CHIP 47K 4.7K 430 10K 4.7K 33K 1.5K 1.5K 33K 100 100K 100K 100 820 270 4.7K 220 10 10 0.1X2 1K 1K 1.5K 10K 10K 10 470K 2.2K 47K 47K 22K 22K 6.8K 6.8K 390 47K 47K 47K 47K 4.7K 430 10K 4.7K 33K 1.5K 1.5K 33K 100 100K 100K 100 820 270 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 10% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% Remark 1/16W 1/16W 1/10W 1/8W 1/16W 1/16W 1/16W 1/16W 1/16W 1/8W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/8W 1/8W 1/8W 5W 1/16W 1/16W 1/16W 1/8W 1/8W 1W F 1/16W 1/8W 1/16W 1/16W 1/16W 1/16W 1/10W 1/10W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/10W 1/8W 1/16W 1/16W 1/16W 1/16W 1/16W 1/8W 1/16W 1/16W 1/16W 1/16W 1/16W
1-216-841-11 METAL CHIP 1-216-841-11 METAL CHIP 1-216-841-11 METAL CHIP
1-216-809-11 METAL CHIP 1-216-820-11 METAL CHIP 1-216-814-11 METAL CHIP
16
XM-444W
Ver 1.1
AMP
Ref. No. R424 R425 R426 R427 R428 R429 R430 R431 R432 R433 R435 R436 R437 R438 R439 R801 R802 R803 R804 R805 R806 R807 R808 R809 R810 R811 R812 R813 R814 R815 R851 R852 R853 R854 R855 R856 R857 R858 R859 R861 R862 R863 R864 R865 R901 R902 R903 R904 R905 R906 R907 R909 R910 R911 R912 Part No. 1-216-829-11 1-216-182-00 1-216-150-00 1-216-150-00 1-205-991-11 1-216-821-11 1-216-821-11 1-216-823-11 1-216-222-00 1-216-833-11 1-215-857-31 1-216-853-11 1-216-206-00 1-216-841-11 1-216-841-11 1-216-833-11 1-216-833-11 1-216-829-11 1-216-837-11 1-216-821-11 1-216-821-11 1-216-833-11 1-216-833-11 1-216-833-11 1-216-829-11 1-216-206-00 1-216-206-00 1-216-202-00 1-216-820-11 1-216-821-11 1-216-222-00 1-216-821-11 1-216-845-11 1-216-837-11 1-216-286-00 1-216-833-11 1-216-833-11 1-216-857-11 1-216-841-11 1-216-214-00 1-216-198-00 1-216-198-00 1-216-198-00 1-216-829-11 1-216-222-00 1-216-833-11 1-216-833-11 1-216-190-00 1-216-829-11 1-216-190-00 1-216-190-00 1-216-849-11 1-216-836-11 1-216-835-11 1-216-833-11 Description METAL CHIP RES-CHIP RES-CHIP RES-CHIP METAL METAL CHIP METAL CHIP METAL CHIP RES-CHIP METAL CHIP METAL OXIDE METAL CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP RES-CHIP METAL CHIP METAL CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP METAL CHIP RES-CHIP METAL CHIP METAL CHIP RES-CHIP METAL CHIP RES-CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 4.7K 220 10 10 0.1X2 1K 1K 1.5K 10K 10K 10 470K 2.2K 47K 47K 10K 10K 4.7K 22K 1K 1K 10K 10K 10K 4.7K 2.2K 2.2K 1.5K 820 1K 10K 1K 100K 22K 4.7M 10K 10K 1M 47K 4.7K 1K 1K 1K 4.7K 10K 10K 10K 470 4.7K 470 470 220K 18K 15K 10K 5% 5% 5% 5% 10% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% Remark 1/16W 1/8W 1/8W 1/8W 5W 1/16W 1/16W 1/16W 1/8W 1/16W 1W F 1/16W 1/8W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/8W 1/8W 1/8W 1/16W 1/16W 1/8W 1/16W 1/16W 1/16W 1/8W 1/16W 1/16W 1/16W 1/16W 1/8W 1/8W 1/8W 1/8W 1/16W 1/8W 1/16W 1/16W 1/8W 1/16W 1/8W 1/8W 1/16W 1/16W 1/16W 1/16W Ref. No. R913 R914 R915 R916 R917 R918 R919 R920 R921 R922 R923 R924 R925 R926 R927 R928 R929 R930 R961 Part No. 1-216-853-11 1-216-833-11 1-216-190-00 1-216-821-11 1-216-190-00 1-216-821-11 1-216-166-00 1-216-166-00 1-216-821-11 1-216-821-11 1-216-186-00 1-216-190-00 1-216-186-00 1-216-190-00 1-216-166-00 1-216-166-00 1-216-206-00 1-216-206-00 1-216-206-00 Description METAL CHIP METAL CHIP RES-CHIP METAL CHIP RES-CHIP METAL CHIP RES-CHIP RES-CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP < SWITCH > S801 S802 1-771-271-11 SWITCH, SLIDE (HPF(80Hz) (FRONT)) 1-771-271-11 SWITCH, SLIDE (LPF(80Hz) (REAR)) < TRANSFORMER > T901 1-437-744-11 TRANSFORMER, DC-DC CONVERTER < THERMISTOR > TH801 TH802 TH803 1-808-877-11 THERMISTOR 1-808-877-11 THERMISTOR 1-808-877-11 THERMISTOR 20K 20K 20K 470K 10K 470 1K 470 1K 47 47 1K 1K 330 470 330 470 47 47 2.2K 2.2K 2.2K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% Remark 1/16W 1/16W 1/8W 1/16W 1/8W 1/16W 1/8W 1/8W 1/16W 1/16W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W
< VARIABLE RESISTOR > VR801 1-225-459-11 RES, VAR, CARBON 10KX2 (LEVEL (FRONT)) VR802 1-225-459-11 RES, VAR, CARBON 10KX2 (LEVEL (REAR)) ************************************************************* ACCESSORIES ************ 3-244-242-11 MANUAL, INSTRUCTION (ENGLISH,FRENCH) ************************************************************* PARTS FOR INSTALLATION AND CONNECTIONS *************************************** 51 52 53 3-367-410-01 SCREW (DIA.5X15), TAPPING 1-823-952-11 CORD, CONNECTION 8P (0.2m) 3-013-264-01 COVER, 3P TERMINAL BOARD
51
52
53
5 x 15 (x 4)
0.2 m
17
XM-444W
REVISION HISTORY
Clicking the version allows you to jump to the revised page. Also, clicking the version at the upper on the revised page allows you to jump to the next revised page. Ver. 1.0 1.1 Date 2002. 04 2003. 02 Description of Revision New Part number correction of S801, 802.
(SPM-03002)
18