Text preview for : Sony-XM504Z caramp.pdf part of Sony XM504Z car amplifier
Back to : Sony-XM504Z caramp.pdf | Home
XM-504Z
SERVICE MANUAL
Ver 1.0 2004. 01
US Model Canadian Model AEP Model UK Model E Model
SPECIFICATIONS
AUDIO POWER SPECIFICATIONS (US model) POWER OUTPUT AND TOTAL HARMONIC DISTORTION 50 watts per channel minimum continuous average power into 4 ohms, both channels driven from 20 Hz to 20 kHz with no more than 0.04% total harmonic distortion per Car Audio Ad Hoc Committee standards. Other Specifications
OTL (output transformerless) circuit Pulse power supply Inputs RCA pin jacks High level input connector Input level adjustment range 0.3 6 V (RCA pin jacks), 0.6 12 V (High level input) Outputs Speaker terminals Speaker impedance 2 8 (stereo) 4 8 (when used as a bridging amplifier) Maximum outputs Four speakers: 100 W × 4 (at 4 ) Three speakers: 100 W × 2 + 250 W × 1 (at 4 ) Rated outputs (supply voltage at 14.4 V) Four speakers: 50 W × 4 (20 Hz 20 kHz, 0.04% THD, at 4 ) 60 W × 4 (20 Hz 20 kHz, 0.1% THD, at 2 ) Frequency response 5 Hz 80 kHz ( +0 dB) 3 Harmonic distortion 0.005% or less (at 1 kHz, 4 , 10 W) Low-pass filter 80 Hz, 18 dB/oct High-pass filter 80 Hz, 12 dB/oct Power requirements 12 V DC car battery (negative ground) Power supply voltage 10.5 16 V Current drain at rated output : 30 A (4 , 50 W × 4) Remote input : 1 mA Dimensions Approx. 350 × 55 × 233 mm (13 7/8 × 2 1/4 × 9 1/4 in.) (w/h/d) not incl. projecting parts and controls Mass Approx. 3.1 kg (6 lb. 14 oz.) not incl. accessories Supplied accessories Mounting screws (4) High level input cord (1) Protection cap (1) Design and specifications are subject to change without notice. Circuit system
STEREO POWER AMPLIFIER
9-877-562-01
2004A04-1 © 2004. 01
Sony Corporation
e Vehicle Company Published by Sony Engineering Corporation
1
XM-504Z
PROTECTOR OPERATION CHECK
Thermal Protect 1. Short across TH901 with the power on. 2. Verify that the protector is operated and LED901 illuminates red. 3. Verify that the protector is released and LED901 illuminates green when the short is removed. 4. Likewise, perform items 1 to 3 for TH902 and TH903. Over Current Protect 1. Short between the positive and negative sides of the speaker output terminal CN903 and CN904 (1/2) with the power on. (Perform this shorting for each channel on FRONT and REAR.) 2. Verify that the protector is operated and LED901 illuminates red. 3. Verify that the protector is not released and LED901 remains red even when the short is removed. 4. Verify that the protector is released and LED901 illuminates green when the power is turned off and then on again. Offset Protect 1. Short between the +12V terminal of CN904 (2/2) and the BTL+ or BTL of the speaker output terminal CN903 and CN904 (1/ 2). (Short between +12V terminal and BTL+ and between +12V terminal and BTL.) 2. Verify that the protector is operated and LED901 illuminates red. 3. Verify that the protector is not released and LED901 remains red even when the short is removed. 4. Verify that the protector is released and LED901 illuminates green when the power is turned off and then on again.
TABLE OF CONTENTS 1. GENERAL
Connections ............................................................................. 3
2. DISASSEMBLY
2-1. Bottom Plate ........................................................................ 5 2-2. Main Board Section ............................................................ 6 2-3. Main Board ......................................................................... 6
3. DIAGRAMS
3-1. 3-2. 3-3. 3-4. IC Block Diagram ............................................................... 7 Printed Wiring Board .......................................................... 8 Schematic Diagram Amp Section ................................... 9 Schematic Diagram Power Section ............................... 10
4. EXPLODED VIEWS
4-1. Heat Sink (Main) Section .................................................. 11 4-2. Main Board Section .......................................................... 12
5. ELECTRICAL PARTS LIST ........................................ 13
Notes on Chip Component Replacement · Never reuse a disconnected chip component. · Notice that the minus side of a tantalum capacitor may be damaged by heat.
SAFETY-RELATED COMPONENT WARNING!! COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY. ATTENTION AU COMPOSANT AYANT RAPPORT À LA SÉCURITÉ!! LES COMPOSANTS IDENTIFIÉS PAR UNE MARQUE 0 SUR LES DIAGRAMMES SCHÉMATIQUES ET LA LISTE DES PIÈCES SONT CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT. NE REMPLACER CES COMPOSANTS QUE PAR DES PIÈCES SONY DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL OU DANS LES SUPPLÉMENTS PUBLIÉS PAR SONY.
2
XM-504Z SECTION 1 GENERAL
This section is extracted from instruction manual.
3
XM-504Z
4
XM-504Z SECTION 2 DISASSEMBLY
Note : This set can be disassemble according to the following sequence.
SET 2-1. BOTTOM PLATE (Page 5) MAIN BOARD SECTION (Page 6) MAIN BOARD (Page 6)
2-2.
2-3.
Note : Follow the disassembly procedure in the numerical order given.
2-1. BOTTOM PLATE
1 three screws (+BTP 3 x 8)
2 three screws (+BTP 3 x 8)
3 bottom plate
5
XM-504Z
2-2. MAIN BOARD SECTION
1 three screws (+BTP 3 x 8) 4 screw (+BTP 3 x 8) 2 three screws (+BTP 3 x 8) 3 three screws (+BTP 3 x 8) 5 MAIN board section
After unfastening the screw, taping with the screw inserted facilitates the work.
heat sink (MAIN)
2-3. MAIN BOARD
4 MAIN board
3 panel (front)
1 two screws (+BTP 3 x 8) 2 three screws (+BTP 3 x 8)
6
XM-504Z SECTION 3 DIAGRAMS
THIS NOTE IS COMMON FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS. (In addition to this, the necessary note is printed in each block.) for schematic diagram: · All capacitors are in µF unless otherwise noted. pF: µµF 50 WV or less are not indicated except for electrolytics and tantalums. · All resistors are in and 1/4 W or less unless otherwise specified. Note: The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. Note: Les composants identifiés par une marque 0 sont critiques pour la sécurité. Ne les remplacer que par une piéce portant le numéro spécifié.
· A : B+ Line. · B : B Line. · Power voltage is dc 14.4V and fed with regulated dc power supply from +12V and REM terminals. · Voltage is dc with respect to ground under no-signal condition. · Voltages are taken with a VOM (Input impedance 10 M). Voltage variations may be noted due to normal production tolerances. · Waveforms are taken with a oscilloscope. Voltage variations may be noted due to normal production tolerances. · Circled numbers refer to waveforms. · Signal path. F : AUDIO for printed wiring boards: · : Pattern from the side which enables seeing.
3-1. IC BLOCK DIAGRAM IC901 µPC494GS
16 15 14 13 REF. REG. 12 11 10 9
ERROR
0.1V ERROR 1 2 3 4 5 OSC
6
7 8
7
7
XM-504Z
3-2. PRINTED WIRING BOARD · Refer to page 7 for Common Note on Printed Wiring Boards.
1 A
2
MAIN BOARD
3
4
5
6
7
8
9
10
11
12
13
14
TH901
Q311 JW151 JW150 JW152
Q310
Q411
Q410
C823
D807 JW158
TH902
C819
C821
E
C
B
E
C
B
E
C
B
E
C
B
JW149
R907
R908
R277
ECB
R367
R368
R468
JR14
B Q210 C E
R267
R365
ECB
R377
R465
ECB
D901
E C B Q312
E C B Q412
C820
C818 C817
R363
R270
R463
B
R467 R477
JW147
JW145
JW101 JW100 R469
C822
R364 Q207 BCE R265 JW85 JW78 JW84 JW83 R369 JW86 JW87
R464
R470
JW146
R370
L801
Q307
Q407
JW148
Q206
C
B Q211 C E
R264
C B
JW99 JW97 JW98
R269
R263 R268
JW123
E
K A K
JW63
JW76
JW104
JW132
JW64
JW62
JW65
R166
R170
BCE
JW67
JW73
JW91
C824 C825
D805
C454 R466
R177
D806
R366
R922 R924
C254
C154
C354
JW157
Q110
JW108
JW109
C E Q105 R160
C152 Q104
Q309 C252 Q204
Q308 Q409 JR11 C352
Q408
JW111 C827
TH903
R255 R257 R256 R258
R155 R157 R156 R158
JW49
R355 R357 R356 R358
R455 R457 R456 R458
Q106
R359
R459
E C B
JW153
C814
R371 R471 C812
C914
R153
R154
R262
R254
R253
R168 Q111 C
R169
JR21
JR22
JR23
JR26
R353 R354
R462
R453
R152
JW33
R252
R807
R809
C810
JW116 C918
JW117 JR17
JW118 JR18
R913 C908
JR9 C451 R452
C808 C809 R806
R808 D801
JW35
C112
JW42
D904
JW36
JW41
JR7
JR8
JR33 JW44
C109 C108
JW27 JW28
R108
JR6
D802
JW43
R109
JR4
C351
JW48 C312 4 1 IC806 5 8 C412
B C E Q906 Q907
JW125
C308
C211 C208
C811 R271
ECB ECB
JW9 JW10 R213 C111 R113
R408 R308 C408
C210
JW11
C110
JW112
JW113
JW114
C813
R202 R204 R203 R205 R207
JW135
JW4
Q803 JW5
R301
-1
-2
R101
R201
JW159 JW47
R210 R110 R112 R212
R111 R211
H
C155
R172 C255
R272
VR801 LEVEL JW7 JW6
JW13 C802 JW15 R802 JW14
-1 -2
JW16 JW17 -2 -4 -3
R401
C805 R805
-6 -5
-8 -7
JR15
C102
JR1 SW801 -1 -2 R801 C801 R803 C803
C804 R804
-1
JW156 SW802 -1 -2 OFF ON SW802 LPF(80Hz)
JR16 VR802 LEVEL R G ECB Q903 R905 R904
JW131 R372 R472 C355 C455 JW130 JW129 C910
C101
C202C302C401
JW134
JW136
JW8
JW22
JW18
JW31
JW115
C205 C207
JW19
JW26 JW25 JW24 JW23
C410 R410 C409 R312 R411 R412 C411 JW29 R413 JW30 R313 C311
Q804
JW1
JW2
R171
JW3
JW155
4 1 IC801 5 8
R306 R402 R406 R404 C406 C306 R403 R405
C212
R209 R208
R106 R206 C106 C206
R302
C305 C307 JW21 4 1 IC802 JW20 5 8 R407 C405 C407
JR5
R309
JW45
JW12
JW46
G
R810
C310 R310 R311
JR32
C105 C107
1 C309 4 IC804 5 8
JR30 R918 R917
R102 R104 R103 R105
R107
R304 R303 R305 R307
4 1 IC805 5 8
4 1 IC803 5 8 C209
L901
JW137
JW40
C815
JR2
ECB
C911 R934
JR3
Q802
Q301
D903
R916
JW39 JW38 JW37
R352
R351
R914
ECB
ECB Q401
IC902
R915
JW126
JW139
JW34
BCE
R451
Q904
JW138
ECB Q101
ECB Q201
JW119 JR19
E
ECB
3
2
D902
B
C
E Q905
JW127
C912
JW140
R151
R251
C251
F
R454
C903 R906
JW124
R928
B
JR24
C913
R163
D402 R475 JW59 R476 ECB ECB JW133 C2 C1 C1 C2 Q805 Q402 Q403 Q806 JW102 B2 E B1 B1E B2 R811 JR20 C453 R461 4 1
Q911
D401
JW128
JW53
C907 R912 C904 C906 R909 R910 C905 JR25 R911
R165
D101 R176 R175 C2 C1 C2 C1 Q102 B2 E B1B2 E B1 Q103 C153 R162 R161 C151
JW58 D202 R276 R275 D302 C2 C1 C1 C2 Q203 Q202 JW57 B2 E B1B1 E B2 R376 R375 C253 C2 C1 C1 C2 Q302 Q303 R261 B2 E B1 B1E B2 Q801 C353 BCE R362 R361
JW61 R460 JW60 D301
JW52
8 JW120
JW154
JW50
R164
JW51
BCE
Q305 R360
Q405
9
R932
E
Q107
D102
JW55 D201
Q304
Q404
R921
C915
R929
Q205 JW56 R260 JW54
JW106
JW107
R159
R259
R902 Q901 B C E 16 IC901 C902 1 R903
JR27
JR12 C452
ECB
C901
R920
JW141
S D G
Q910
JR31
E C B Q808 R815 Q902 R901
R927
Q909
ECB
JW88
JW110
JW74
ECB
B
R167
JR10
Q908
R930
Q109
Q108
Q209
Q208
R926
R925 R923
JW89
JR29
R814
Q912
JW68
JW69
JW70
JW71
JW90
C826
D
C917
Q112
JW72
JW92
Q807 E C B
T901
JW75
JW79 R266
JW105
JW93
JW122
JW66
R933
JW80
JW121
JW95 JW94
C916
R931
JW81
JW103
JW96
Q913
JW77
JR13
JW82
JW144
S D G
D804
D803
Q212
Q306 B C E
Q406 B C E
A K A
JR28
JW143
S D G
· Semiconductor Location Ref. No. D101 D102 D201 D202 D301 D302 D401 D402 D801 D802 D803 D804 D805 D806 D807 D901 D902 D903 D904 IC801 IC802 IC803 IC804 IC805 IC806 IC901 IC902 LED901
11 1-861-860-
JW142
S D G
Location E-4 E-4 E-5 E-5 E-7 E-6 E-8 E-7 F-5 F-6 B-13 C-13 D-9 D-10 A-12 B-4 F-9 F-9 G-10 G-5 G-6 G-4 G-7 G-4 G-8 E-10 F-8 I-8 F-4 E-4 E-4 E-5 E-4 E-2 E-2 D-5 D-4 F-1 E-1 D-2 F-4 E-5 E-6 E-5 E-5 C-2 C-2
R409
JW32
R919
C201C301 C402
I
OFF ON SW801 HPF(80Hz) -1 L L CN903 FRONT SPEAKER OUT R -2 R CN901 INPUT -4 R -3 L (L+R) -1 -2
FRONT
REAR -7 -8
LED901 POWER/ PROTECTOR
L
J
R L R CN902 HIGH LEVEL INPUT
L (L+R) REAR SPEAKER OUT
R
F901 25A
F902 25A
REM
+12V
GND
(FRONT)
(REAR)
CN904
Q101 Q102 Q103 Q104 Q105 Q106 Q107 Q108 Q109 Q110 Q111 Q112 Q201 Q202 Q203 Q204 Q205 Q206 Q207
Ref. No. Q208 Q209 Q210 Q211 Q212 Q301 Q302 Q303 Q304 Q305 Q306 Q307 Q308 Q309 Q310 Q311 Q312 Q401 Q402 Q403 Q404 Q405 Q406 Q407 Q408 Q409 Q410 Q411 Q412 Q801 Q802 Q803 Q804 Q805 Q806 Q807 Q808 Q901 Q902 Q903 Q904 Q905 Q906 Q907 Q908 Q909 Q910 Q911 Q912 Q913
Location D-5 D-5 B-1 C-1 B-3 F-6 F-6 F-7 E-7 E-6 B-6 B-6 E-7 E-6 A-7 A-6 B-7 F-7 F-7 F-8 E-8 E-7 B-9 B-9 E-8 E-7 A-9 A-8 B-10 F-5 G-3 H-3 G-3 F-8 F-9 D-10 E-10 E-9 E-10 H-8 F-9 F-10 G-10 G-10 D-12 E-12 E-13 E-13 D-13 C-13
8
8
C909
XM-504Z
3-3. SCHEMATIC DIAGRAM -- AMP SECTION -- · Refer to page 7 for Common Note on Schematic Diagrams.
R155
R158
R175
D101
R159 Q104 Q108 R165 R167 R163 R161 C154 R162 R164 Q106 R166 R168 Q105 Q111 Q109 R169 C155 R172 Q107 Q110 R177 R170 Q112
Q103
C152
IC801(1/2) CN901 R102 R108 C111
R112
VR801 R113
Q101
C151
R153
C153
R103
C105 C107
C108
C109 IC803(1/2)
C112
R151
R152 Q102 R156 R154
C802
R104
R105 C110 C106 R106 R107 R109 R111 R110
SW801 IC805(1/2)
R802
R801
C801
R157 R176
D102
R160 R171
R207 C206 R203 R206 C207
R209
C210
R211
R210
CN903 IC805(2/2) R258 R255 Q204 R275 D201 R259 Q208 R265 R267 C251 R253 C253 R261 C254 R262 R212 VR801 R213 R251 Q202 R256 R254 Q205 R257 R276 Q209 D202 R260 R271 R264 R263 Q206 R266 R268 Q211 Q207 R269 C255 R272 Q210 R277 Q212 R270
IC803(2/2) C205 R202 IC801(2/2) CN902 CN901 C208 C209 C212 Q201 R252
Q203
C252
R208
C211
R205
C101
C102
C202
C201
R204
R101 R201 R301 R401 R304
R355
R358
R375
D301
R359 Q304 Q308 R370 R365 R367 Q307 Q306 R364 R366 C355 R368 Q305 Q311 Q309 R372 R369 Q310 R377 Q312
Q303 C808 C309 R308 C305 C308 R309 R310 R311 C312 C310 IC804(1/2) C311 R312 VR802 R313 Q301 C351
C301
C401
C302
C402
C352
R305
CN901
IC802(1/2) R803 C803 R302
R353
C353
R361 C354 R362
R363
R351
R352 Q302 R356 R354
R303 C815 R804 C804 C306 R306
C307
R357 R307 SW802 IC806(1/2)
R376
D302
R360 R371 CN904
R407 R404 R403 R405 R406 C407 C406 C405 C411 R402 IC802(2/2) R408 R409 R410 C409 R411 R412 VR802 R413 C408 C410 IC804(2/2)
IC806(2/2) R455 R458 R475 D401 R459 Q404 Q403 C412 Q401 R452 C451 R453 C453 R461 C454 Q406 R462 R451 R464 R466 R468 Q405 R456 R806 R457 R476 D402 R460 R471 Q409 Q411 R463 Q407 R469 C455 R472 C452 R465 R467 Q408 Q410 R477 R470 Q412
C809
Q402
R454
(Page 10)
9
9
XM-504Z
3-4. SCHEMATIC DIAGRAM -- POWER SECTION -- · Refer to page 7 for IC Block Diagram and Common Note on Schematic Diagrams.
(Page 9)
R805
C805 Q807 Q911 Q801 R926 R923 D802 R807 IC902 Q802 D801 C810 Q913 C918 R809 R808 R921 R924 R927 R925 Q909 R930 Q912 C916 R933 R931 C914 D804 C822 Q808 R811 R815 C913 R920 R922 Q908 R929 R928 Q910 R932 C915 L801 C818 C820 D806 T901 D803 C819 R810 R814 C826 C912 C817 C821 D805 C824 C825 C823 C827
D807 Q803 Q804
C811
C813
Q805 Q806
CN904 C908 F902 Q905 R913 C917 F901 L901 R915 LED901 R903
C812
C814
IC B/D
TH903 TH902 TH901
C901 Q902 C906 IC901 R901
R904
R916 D904
R914 D903
D901
Q906 R919 C909 R934 R918 Q904 C910 R917 Q907 C911 C903 R906
D902
R912 C904
R902
R905 Q903
R909 R908 R907
R910
C905
C907
R911
C902
Q901
· Waveform
1
1V/DIV, 5µsec/DIV 3.5Vp-p 20µsec
IC901
5
10
10
XM-504Z SECTION 4 EXPLODED VIEWS
NOTE: · The mechanical parts with no reference number in the exploded views are not supplied. · Items marked "*" are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. · Abbreviation CND : Canadian model · Color Indication of Appearance Parts Example : KNOB, BALANCE (WHITE) ... (RED) R R Parts Color Cabinet's Color · Accessories are given in the last of this parts list. The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. Les composants identifiés par une marque 0 sont critiques pour la sécurité. Ne les remplacer que par une piéce portant le numéro spécifié.
4-1. HEAT SINK (MAIN) SECTION
not supplied
MAIN board section #1
#1 F901 #1 F902 #1 not supplied
#1 #1
Ref. No. 0 F901 0 F902
Part No.
Description
Remark
Ref. No. #1
Part No.
Description
Remark
1-576-256-11 FUSE (BLADE TYPE) (AUTO FUSE) (25A) 1-576-256-11 FUSE (BLADE TYPE) (AUTO FUSE) (25A)
7-685-546-14 SCREW +BTP 3X8 TYPE2 N-S
11
XM-504Z
4-2. MAIN BOARD SECTION
51
not supplied not supplied #4 #4
54
#4 #3
54
#3
53 52
not supplied
#3 #2
#1
Ref. No. 51 52 52 53 54
Part No. A-3283-674-A 3-263-893-01 3-263-893-11 3-266-086-01 3-912-431-01
Description MAIN BOARD, COMPLETE PANEL (FRONT) (US,CND,E,MX) PANEL (FRONT) (AEP,UK) COVER (LED) SCREW (+P)
Remark
Ref. No. #1 #2 #3 #4
Part No. 7-685-546-14 7-685-546-19 7-682-948-01 7-682-648-09
Description SCREW +BTP 3X8 TYPE2 N-S SCREW +BTP 3X8 TYPE2 N-S SCREW +PSW 3X8 SCREW +PS 3X8
Remark
12
XM-504Z SECTION 5 ELECTRICAL PARTS LIST
NOTE: · Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. · RESISTORS All resistors are in ohms. METAL:Metal-film resistor. METAL OXIDE: Metal oxide-film resistor. F:nonflammable · Items marked "*" are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. · SEMICONDUCTORS In each case, u : µ, for example: uA.. : µA.. uPA.. : µPA.. uPB.. : µPB.. uPC.. : µPC.. uPD.. : µPD.. · CAPACITORS uF : µF · COILS uH : µH When indicating parts by reference number, please include the board. · Abbreviation CND : Canadian model The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. Les composants identifiés par une marque 0 sont critiques pour la sécurité. Ne les remplacer que par une piéce portant le numéro spécifié.
MAIN
Ref. No.
Part No.
Description
Remark
Ref. No. C308 C309 C310 C311 C312 C351 C352 C353 C354 C355
Part No. 1-126-960-11 1-107-823-11 1-164-004-11 1-126-933-11 1-163-251-11 1-126-947-11 1-163-243-11 1-163-235-11 1-126-960-11 1-104-760-11 1-163-251-11 1-163-251-11 1-163-243-11 1-163-251-11 1-163-251-11 1-126-960-11 1-107-823-11 1-164-004-11 1-126-933-11 1-163-251-11 1-126-947-11 1-163-243-11 1-163-235-11 1-126-960-11 1-104-760-11 1-115-340-11 1-126-934-11 1-115-340-11 1-115-340-11 1-164-004-11 1-164-004-11 1-164-004-11 1-126-965-11 1-163-009-11 1-163-009-11 1-104-655-11 1-104-655-11 1-126-933-11 1-163-021-11 1-163-021-11 1-165-949-11 1-165-949-11 1-165-949-11 1-165-949-11 1-163-009-11
Description ELECT CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP ELECT MYLAR CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP ELECT MYLAR CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP ELECT ELECT ELECT CERAMIC CHIP CERAMIC CHIP ELECT ELECT ELECT ELECT CERAMIC CHIP 1uF 0.47uF 0.1uF 100uF 100PF 47uF 47PF 22PF 1uF 0.047uF 100PF 100PF 47PF 100PF 100PF 1uF 0.47uF 0.1uF 100uF 100PF 47uF 47PF 22PF 1uF 0.047uF 0.22uF 220uF 0.22uF 0.22uF 0.1uF 0.1uF 0.1uF 22uF 0.001uF 0.001uF 470uF 470uF 100uF 0.01uF 0.01uF 1500uF 1500uF 1500uF 1500uF 0.001uF 20% 10% 10% 20% 5% 20% 5% 5% 20% 10% 5% 5% 5% 5% 5% 20% 10% 10% 20% 5% 20% 5% 5% 20% 10% 10% 20% 10% 10% 10% 10% 10% 20% 10% 10% 20% 20% 20% 10% 10%
Remark 50V 16V 25V 16V 50V 25V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 16V 25V 16V 50V 25V 50V 50V 50V 50V 25V 16V 25V 25V 25V 25V 25V 50V 50V 50V 6.3V 6.3V 16V 50V 50V 35V 35V 35V 35V 50V
A-3283-674-A MAIN BOARD, COMPLETE ********************* 3-266-086-01 3-912-431-01 7-682-648-09 7-682-948-01 7-685-146-14 COVER (LED) SCREW (+P) SCREW +PS 3X8 SCREW +PSW 3X8 SCREW +P 3X8 TYPE2 NON-SLIT < CAPACITOR > C101 C102 C105 C106 C107 C108 C109 C110 C111 C112 C151 C152 C153 C154 C155 C201 C202 C205 C206 C207 C208 C209 C210 C211 C212 C251 C252 C253 C254 C255 C301 C302 C305 C306 C307 1-163-251-11 1-163-251-11 1-163-243-11 1-163-251-11 1-163-251-11 1-164-004-11 1-164-004-11 1-126-933-11 1-126-963-11 1-163-251-11 1-126-947-11 1-163-243-11 1-163-235-11 1-126-960-11 1-104-760-11 1-163-251-11 1-163-251-11 1-163-243-11 1-163-251-11 1-163-251-11 1-164-004-11 1-164-004-11 1-126-933-11 1-126-963-11 1-163-251-11 1-126-947-11 1-163-243-11 1-163-235-11 1-126-960-11 1-104-760-11 1-163-251-11 1-163-251-11 1-163-243-11 1-163-251-11 1-163-251-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT ELECT CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP ELECT MYLAR CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT ELECT CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP ELECT MYLAR CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 100PF 100PF 47PF 100PF 100PF 0.1uF 0.1uF 100uF 4.7uF 100PF 47uF 47PF 22PF 1uF 0.047uF 100PF 100PF 47PF 100PF 100PF 0.1uF 0.1uF 100uF 4.7uF 100PF 47uF 47PF 22PF 1uF 0.047uF 100PF 100PF 47PF 100PF 100PF 5% 5% 5% 5% 5% 10% 10% 20% 20% 5% 20% 5% 5% 20% 10% 5% 5% 5% 5% 5% 10% 10% 20% 20% 5% 20% 5% 5% 20% 10% 5% 5% 5% 5% 5% 50V 50V 50V 50V 50V 25V 25V 16V 50V 50V 25V 50V 50V 50V 50V 50V 50V 50V 50V 50V 25V 25V 16V 50V 50V 25V 50V 50V 50V 50V 50V 50V 50V 50V 50V
C401 C402 C405 C406 C407 C408 C409 C410 C411 C412 C451 C452 C453 C454 C455 C801 C802 C803 C804 C805 C808 C809 C810 C811 C812 C813 C814 C815 C817 C818 C819 C820 C821 C822 C823
10%
13
XM-504Z MAIN
Ref. No. C824 C825 C826 C827 C901 C902 C903 C904 C905 C906 C907 C908 C909 C910 C911 C912 C913 C914 C915 C916 C917 C918 Part No. 1-164-004-11 1-164-004-11 1-126-933-11 1-126-933-11 1-127-573-11 1-163-009-11 1-163-021-11 1-163-021-11 1-163-009-11 1-126-933-11 1-164-004-11 1-126-933-11 1-163-009-11 1-137-380-11 1-164-004-11 1-137-374-11 1-131-731-11 1-131-731-11 1-163-021-11 1-163-021-11 Description CERAMIC CHIP CERAMIC CHIP ELECT ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP ELECT CERAMIC CHIP MYLAR CERAMIC CHIP MYLAR ELECT ELECT CERAMIC CHIP CERAMIC CHIP 0.1uF 0.1uF 100uF 100uF 1uF 0.001uF 0.01uF 0.01uF 0.001uF 100uF 0.1uF 100uF 0.001uF 0.47uF 0.1uF 0.047uF 2200uF 2200uF 0.01uF 0.01uF 0.01uF 0.1uF 10% 10% 20% 20% 10% 10% 10% 10% 10% 20% 10% 20% 10% 5% 10% 5% 20% 20% 10% 10% 10% 10% Remark 25V 25V 16V 16V 16V 50V 50V 50V 50V 16V 25V 16V 50V 50V 25V 50V 16V 16V 50V 50V 50V 25V Ref. No. Part No. Description < IC > IC801 IC802 IC803 IC804 IC805 IC806 IC901 8-759-710-28 8-759-710-28 8-759-710-28 8-759-710-28 8-759-710-28 IC IC IC IC IC NJM4565M-A NJM4565M-A NJM4565M-A NJM4565M-A NJM4565M-A Remark
8-759-710-28 IC NJM4565M-A 8-759-144-88 IC uPC494GS < PHOTO COUPLER >
IC902
8-719-156-72 PHOTO COUPLER PS2501-1-K < JUMPER RESISTOR >
JR1 JR2 JR3 JR4 JR5 JR6 JR7 JR8 JR9 JR10 JR11 JR12 JR13 JR14 JR15 JR16 JR17 JR18 JR19 JR20 JR21 JR22 JR23 JR24 JR25 JR26 JR27 JR28 JR29 JR30 JR31 JR32 JR33
1-216-296-11 1-216-296-11 1-216-296-11 1-216-296-11 1-216-296-11 1-216-296-11 1-216-296-11 1-216-296-11 1-216-296-11 1-216-296-11 1-216-295-11 1-216-295-11 1-216-296-11 1-216-296-11 1-216-296-11 1-216-296-11 1-216-296-11 1-216-296-11 1-216-296-11 1-216-296-11 1-216-296-11 1-216-296-11 1-216-296-11 1-216-296-11 1-216-296-11 1-216-296-11 1-216-296-11 1-216-296-11 1-216-296-11 1-216-296-11
SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP
0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0
1-163-021-11 CERAMIC CHIP 1-164-004-11 CERAMIC CHIP < JACK >
CN901
1-779-078-21 JACK, PIN 4P (INPUT (FRONT/REAR)) < CONNECTOR >
CN902
1-580-283-11 PIN, CONNECTOR (PC BOARD) 8P (HIGH LEVEL INPUT) < TERMINAL BOARD >
CN903 CN904
1-780-132-11 TERMINAL BOARD (4P) (FRONT SPEAKER OUT) 1-780-134-11 TERMINAL BOARD (4P+3P+FUSE) (REM,+12V, GND,REAR SPEAKER OUT,25A) < DIODE >
D101 D102 D201 D202 D301 D302 D401 D402 D801 D802 D803 D804 D805 D806 D807 D901 D902 D903 D904
8-719-801-78 8-719-801-78 8-719-801-78 8-719-801-78 8-719-801-78 8-719-801-78 8-719-801-78 8-719-801-78 8-719-025-34 8-719-801-78 6-500-209-01 6-500-210-01 8-719-025-48 8-719-025-49 8-719-801-78 8-719-801-78 8-719-801-78 8-719-801-78 8-719-025-50
DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE
1SS184 1SS184 1SS184 1SS184 1SS184 1SS184 1SS184 1SS184 02CZ6.8-TE85L 1SS184 FCH08A15 FRH08A15 02CZ13-TE85L 02CZ15-TE85L 1SS184 1SS184 1SS184 1SS184 02CZ16-TE85L
1-216-296-11 SHORT CHIP 1-216-296-11 SHORT CHIP 1-216-296-11 SHORT CHIP < COIL >
L801 L901
1-410-396-41 INDUCTOR, FERRITE BEAD 0.45uH 1-411-756-11 INDUCTOR < DIODE >
LED901 8-719-076-62 LED GL5ED60 (POWER/PROTECTOR) < TRANSISTOR > Q101 8-729-202-38 TRANSISTOR 2SC3326N-A
14
XM-504Z MAIN
Ref. No. Q102 Q103 Q104 Q105 Q106 Q107 Q108 Q109 Q110 Q111 Q112 Q201 Q202 Q203 Q204 Q205 Q206 Q207 Q208 Q209 Q210 Q211 Q212 Q301 Q302 Q303 Q304 Q305 Q306 Q307 Q308 Q309 Q310 Q311 Q312 Q401 Q402 Q403 Q404 Q405 Q406 Q407 Q408 Q409 Q410 Q411 Q412 Q801 Q802 Q803 Q804 Q805 Q806 Q807 Q808 Q901 Q902 Q903 Part No. 8-729-232-66 8-729-014-86 8-729-140-82 8-729-140-84 8-729-902-11 8-729-230-46 8-729-020-80 8-729-232-32 8-729-024-79 8-729-024-76 8-729-027-43 8-729-202-38 8-729-232-66 8-729-014-86 8-729-140-82 8-729-140-84 8-729-902-11 8-729-230-46 8-729-020-80 8-729-232-32 8-729-024-79 8-729-024-76 8-729-027-43 8-729-202-38 8-729-232-66 8-729-014-86 8-729-140-82 8-729-140-84 8-729-902-11 8-729-230-46 8-729-020-80 8-729-232-32 8-729-024-79 8-729-024-76 8-729-027-43 8-729-202-38 8-729-232-66 8-729-014-86 8-729-140-82 8-729-140-84 8-729-902-11 8-729-230-46 8-729-020-80 8-729-232-32 8-729-024-79 8-729-024-76 8-729-027-43 8-729-901-04 8-729-120-28 8-729-120-28 8-729-120-28 8-729-120-28 8-729-120-28 8-729-209-15 8-729-209-60 Description TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR 2SA1618Y 2SC4207-YGR-TE85L 2SA988-PAFAEA 2SC1841-PAFAEA 2SC2021-Q 2SA1162-YG 2SC2235-O/Y(TPE6) 2SA965 2SC5100-P 2SA1908-P DTC114EKA-T146 2SC3326N-A 2SA1618Y 2SC4207-YGR-TE85L 2SA988-PAFAEA 2SC1841-PAFAEA 2SC2021-Q 2SA1162-YG 2SC2235-O/Y(TPE6) 2SA965 2SC5100-P 2SA1908-P DTC114EKA-T146 2SC3326N-A 2SA1618Y 2SC4207-YGR-TE85L 2SA988-PAFAEA 2SC1841-PAFAEA 2SC2021-Q 2SA1162-YG 2SC2235-O/Y(TPE6) 2SA965 2SC5100-P 2SA1908-P DTC114EKA-T146 2SC3326N-A 2SA1618Y 2SC4207-YGR-TE85L 2SA988-PAFAEA 2SC1841-PAFAEA 2SC2021-Q 2SA1162-YG 2SC2235-O/Y(TPE6) 2SA965 2SC5100-P 2SA1908-P DTC114EKA-T146 DTA114EK 2SC1623-L5L6 2SC1623-L5L6 2SC1623-L5L6 2SC1623-L5L6 2SC1623-L5L6 2SD2012 2SB1375 Remark Ref. No. Q904 Q905 Q906 Q907 Q908 Q909 Q910 Q911 Q912 Q913 Part No. 8-729-027-43 8-729-106-60 8-729-120-28 8-729-027-43 8-729-202-38 8-729-202-38 6-550-341-01 6-550-341-01 6-550-341-01 6-550-341-01 Description TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR DTC114EKA-T146 2SB1115A 2SC1623-L5L6 DTC114EKA-T146 2SC3326N-A Remark
TRANSISTOR 2SC3326N-A FET FKV550N FET FKV550N FET FKV550N FET FKV550N < RESISTOR >
R101 R102 R103 R104 R105 R106 R107 R108 R109 R110 R111 R112 R113 R151 R152 R153 R154 R155 R156 R157 R158 R159 R160 R161 R162 R163 R164 R165 R166 R167 R168 R169 R170 R171 R172 R175 R176 R177 R201 R202 R203 R204 R205 R206 R207 R208
1-216-206-00 1-216-081-00 1-216-081-00 1-216-097-11 1-216-097-11 1-216-077-11 1-216-077-11 1-216-077-11 1-216-084-00 1-216-073-00 1-216-073-00 1-216-045-00 1-216-069-00 1-216-222-00 1-216-065-00 1-216-057-00 1-216-222-00 1-216-085-11 1-216-085-11 1-216-053-00 1-216-053-00 1-216-025-11 1-216-025-11 1-216-097-11 1-216-097-11 1-216-045-00 1-216-033-00 1-216-073-00 1-216-182-00 1-216-134-00 1-216-134-00 1-205-991-11 1-216-073-00 1-216-089-11 1-216-134-00 1-216-053-00 1-216-053-00 1-216-065-00 1-216-206-00 1-216-081-00 1-216-081-00 1-216-097-11 1-216-097-11 1-216-077-11 1-216-077-11
RES-CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP METAL CHIP RES-CHIP RES-CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP METAL CHIP RES-CHIP RES-CHIP RES-CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP METAL CHIP METAL CHIP METAL RES-CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP
2.2K 22K 22K 100K 100K 15K 15K 15K 30K 10K 10K 680 6.8K 10K 4.7K 2.2K 10K 33K 33K 1.5K 1.5K 100 100 100K 100K 680 220 10K 220 2.2 2.2 0.1X2 10K 47K 2.2 1.5K 1.5K 4.7K 2.2K 22K 22K 100K 100K 15K 15K 15K
5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 10% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5%
1/8W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/8W 1/10W 1/10W 1/8W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/8W 1/8W 1/8W 5W F 1/10W 1/10W 1/8W 1/10W 1/10W 1/10W 1/8W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W
8-729-027-43 TRANSISTOR DTC114EKA-T146 8-729-027-38 TRANSISTOR DTA144EKA-T146 8-729-027-43 TRANSISTOR DTC114EKA-T146
1-216-077-11 RES-CHIP
15
XM-504Z MAIN
Ref. No. R209 R210 R211 R212 R213 R251 R252 R253 R254 R255 R256 R257 R258 R259 R260 R261 R262 R263 R264 R265 R266 R267 R268 R269 R270 R271 R272 R275 R276 R277 R301 R302 R303 R304 R305 R306 R307 R308 R309 R310 R311 R312 R313 R351 R352 R353 R354 R355 R356 R357 R358 R359 R360 R361 R362 R363 R364 R365 Part No. 1-216-084-00 1-216-073-00 1-216-073-00 1-216-045-00 1-216-069-00 1-216-222-00 1-216-065-00 1-216-057-00 1-216-222-00 1-216-085-11 1-216-085-11 1-216-053-00 1-216-053-00 1-216-025-11 1-216-025-11 1-216-097-11 1-216-097-11 1-216-045-00 1-216-033-00 1-216-073-00 1-216-182-00 1-216-134-00 1-216-134-00 1-205-991-11 1-216-073-00 1-216-089-11 1-216-134-00 1-216-053-00 1-216-053-00 1-216-065-00 1-216-206-00 1-216-081-00 1-216-081-00 1-216-097-11 1-216-097-11 1-216-077-11 1-216-077-11 1-216-055-00 1-216-084-00 1-216-073-00 1-216-055-00 1-216-045-00 1-216-069-00 1-216-222-00 1-216-065-00 1-216-057-00 1-216-222-00 1-216-085-11 1-216-085-11 1-216-053-00 1-216-053-00 1-216-025-11 1-216-025-11 1-216-097-11 1-216-097-11 Description METAL CHIP RES-CHIP RES-CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP METAL CHIP RES-CHIP RES-CHIP RES-CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP METAL CHIP METAL CHIP METAL RES-CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP METAL CHIP METAL CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP METAL CHIP RES-CHIP RES-CHIP RES-CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP 30K 10K 10K 680 6.8K 10K 4.7K 2.2K 10K 33K 33K 1.5K 1.5K 100 100 100K 100K 680 220 10K 220 2.2 2.2 0.1X2 10K 47K 2.2 1.5K 1.5K 4.7K 2.2K 22K 22K 100K 100K 15K 15K 1.8K 30K 10K 1.8K 680 6.8K 10K 4.7K 2.2K 10K 33K 33K 1.5K 1.5K 100 100 100K 100K 680 220 10K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 10% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% Remark 1/10W 1/10W 1/10W 1/10W 1/10W 1/8W 1/10W 1/10W 1/8W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/8W 1/8W 1/8W 5W F 1/10W 1/10W 1/8W 1/10W 1/10W 1/10W 1/8W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/8W 1/10W 1/10W 1/8W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W Ref. No. R366 R367 R368 R369 R370 R371 R372 R375 R376 R377 R401 R402 R403 R404 R405 R406 R407 R408 R409 R410 R411 R412 R413 R451 R452 R453 R454 R455 R456 R457 R458 R459 R460 R461 R462 R463 R464 R465 R466 R467 R468 R469 R470 R471 R472 R475 R476 R477 R801 R802 R803 R804 R805 R806 R807 R808 R809 R810 Part No. 1-216-182-00 1-216-134-00 1-216-134-00 1-205-991-11 1-216-073-00 1-216-089-11 1-216-134-00 1-216-053-00 1-216-053-00 1-216-065-00 1-216-206-00 1-216-081-00 1-216-081-00 1-216-097-11 1-216-097-11 1-216-077-11 1-216-077-11 1-216-055-00 1-216-084-00 1-216-073-00 1-216-055-00 1-216-045-00 1-216-069-00 1-216-222-00 1-216-065-00 1-216-057-00 1-216-222-00 1-216-085-11 1-216-085-11 1-216-053-00 1-216-053-00 1-216-025-11 1-216-025-11 1-216-097-11 1-216-097-11 1-216-045-00 1-216-033-00 1-216-073-00 1-216-182-00 1-216-134-00 1-216-134-00 1-205-991-11 1-216-073-00 1-216-089-11 1-216-134-00 1-216-053-00 1-216-053-00 1-216-065-00 1-216-198-11 1-216-206-00 1-216-198-11 1-216-198-11 1-216-206-00 1-208-291-11 1-216-097-11 Description RES-CHIP METAL CHIP METAL CHIP METAL RES-CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP METAL CHIP METAL CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP METAL CHIP RES-CHIP RES-CHIP RES-CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP METAL CHIP METAL CHIP METAL RES-CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP 220 2.2 2.2 0.1X2 10K 47K 2.2 1.5K 1.5K 4.7K 2.2K 22K 22K 100K 100K 15K 15K 1.8K 30K 10K 1.8K 680 6.8K 10K 4.7K 2.2K 10K 33K 33K 1.5K 1.5K 100 100 100K 100K 680 220 10K 220 2.2 2.2 0.1X2 10K 47K 2.2 1.5K 1.5K 4.7K 1K 2.2K 1K 1K 2.2K 4.7M 100K 100K 10K 1K 5% 5% 5% 10% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 10% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% Remark 1/8W 1/8W 1/8W 5W F 1/10W 1/10W 1/8W 1/10W 1/10W 1/10W 1/8W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/8W 1/10W 1/10W 1/8W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/8W 1/8W 1/8W 5W F 1/10W 1/10W 1/8W 1/10W 1/10W 1/10W 1/8W 1/8W 1/8W 1/8W 1/8W 1/10W 1/10W 1/10W 1/8W 1/10W
1-216-045-00 METAL CHIP 1-216-033-00 METAL CHIP 1-216-073-00 RES-CHIP
1-216-097-11 RES-CHIP 1-216-222-00 RES-CHIP 1-216-049-11 RES-CHIP
16
XM-504Z MAIN
Ref. No. R811 R814 R815 R901 R902 R903 R904 R905 R906 R907 R908 R909 R910 R911 R912 R913 R914 R915 R916 R917 R918 R919 R920 R921 R922 R923 R924 R925 R926 R927 R928 R929 R930 R931 R932 R933 R934 Part No. 1-216-049-11 1-216-210-00 1-216-210-00 1-216-065-00 1-216-065-00 1-216-089-11 1-216-033-00 1-216-041-00 1-216-073-00 1-216-049-11 1-216-049-11 1-216-041-00 1-216-069-00 1-216-081-00 1-216-097-11 1-216-065-00 1-216-206-00 1-216-035-00 1-216-049-11 1-216-073-00 1-216-073-00 1-216-222-00 1-216-190-00 1-216-190-00 1-216-049-11 1-216-049-11 1-216-049-11 1-216-049-11 1-216-158-00 1-216-158-00 1-216-134-00 1-216-134-00 1-216-134-00 1-216-134-00 1-216-150-00 Description RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP RES-CHIP METAL CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP 1K 3.3K 3.3K 4.7K 4.7K 47K 220 470 10K 1K 1K 470 6.8K 22K 100K 4.7K 2.2K 270 1K 10K 10K 10K 470 470 1K 1K 1K 1K 22 22 2.2 2.2 2.2 2.2 10 10 2.2K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% Remark 1/10W 1/8W 1/8W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/8W 1/10W 1/10W 1/10W 1/10W 1/8W 1/8W 1/8W 1/10W 1/10W 1/10W 1/10W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W Ref. No. Part No. Description MISCELLANEOUS *************** 0 F901 1-576-256-11 FUSE (BLADE TYPE) (AUTO FUSE) (25A) 0 F902 1-576-256-11 FUSE (BLADE TYPE) (AUTO FUSE) (25A) ************************************************************* ACCESSORIES ************ 3-263-283-11 MANUAL, INSTRUCTION (ENGLISH,SPANISH) (US,CND) 3-263-283-21 MANUAL, INSTRUCTION (ENGLISH,SPANISH, TRADITIONAL CHINESE) (AEP,UK,E,MX) 3-263-283-31 MANUAL, INSTRUCTION (GERMAN,FRENCH, ITALIAN) (AEP,UK) 3-263-283-41 MANUAL, INSTRUCTION (DUTCH,RUSSIAN, SWEDISH) (AEP,UK) 3-263-283-51 MANUAL, INSTRUCTION (GREEK,POLISH, PORTUGUESE) (AEP,UK) ************************************************************* PARTS FOR INSTALLATION AND CONNECTIONS *************************************** 101 102 103 3-367-410-01 SCREW (DIA.5X15), TAPPING (MOUNTING SCREW) 1-823-952-11 CORD (WITH CONNECTOR) 8P (0.2m) 3-263-276-01 COVER (POWER) Remark
101
102
103
1-216-150-00 RES-CHIP 1-216-206-00 RES-CHIP < SWITCH >
SW801 SW802
1-571-478-11 SWITCH, SLIDE (HPF(80Hz) (FRONT)) 1-571-478-11 SWITCH, SLIDE (LPF(80Hz) (REAR)) < TRANSFORMER >
T901
1-443-277-11 TRANSFORMER, DC-DC CONVERTER < THERMISTOR (POSITIVE) >
TH901 TH902 TH903
1-810-506-11 THERMISTOR NTH5G39B223K01 1-810-506-11 THERMISTOR NTH5G39B223K01 1-810-506-11 THERMISTOR NTH5G39B223K01 < VARIABLE RESISTOR >
VR801 1-225-459-11 RES, VAR, CARBON 10KX2 (LEVEL (FRONT)) VR802 1-225-459-11 RES, VAR, CARBON 10KX2 (LEVEL (REAR)) *************************************************************
The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified.
Les composants identifiés par une marque 0 sont critiques pour la sécurité. Ne les remplacer que par une piéce portant le numéro spécifié.
17
XM-504Z
REVISION HISTORY
Clicking the version allows you to jump to the revised page. Also, clicking the version at the upper right on the revised page allows you to jump to the next revised page. Ver. 1.0 Date 2004. 01 Description of Revision New
18