Text preview for : Sony-XM1505SX_1805GX caramp.pdf part of Sony XM1505SX, XM1805GX car amplifier (all files: http://www.eserviceinfo.com/service_manual/datasheets_a_0.html )
Back to : Sony-XM1505SX_1805GX cara | Home
XM-1505SX/1805GX
SERVICE MANUAL
Ver 1.1 2001.06
US Model Canadian Model
XM-1505SX/1805GX
E Model
XM-1505SX
Photo: XM-1805GX
SPECIFICATIONS
AUDIO POWER SPECIFICATIONS POWER OUTPUT AND TOTAL HARMONIC DISTORTION 40 watts/150 watts per channel minimum continuous average power into 4 ohms, 5channels driven from 50 Hz (1505SX), 20 Hz (1805GX) to 20 kHz/20 Hz to 300 Hz (subwoofer) with no more than 0.04% total harmonic distortion per Car Audio Ad Hoc Committee standards. Other Specifications
OTL (output transformerless) circuit Pulse power supply Inputs RCA pin jacks Outputs Speaker terminals Through out pin jacks Speaker impedance 2 8 (stereo) 4 8 (when used as a bridging amplifier) 1.3 8 (only for subwoofer output) (XM-1805GX) Maximum outputs 80 watts × 4 + 300 watts × 1 (at 4 ) Rated outputs (supply voltage at 14.4 V) 5 Speakers: 1505SX: 40 watts × 4 (50 Hz 20 kHz, 0.04% THD, at 4 ) + 150 watts × 1 (20 300 Hz, 0.04% THD, at 4 ) 60 watts × 4 (50 Hz 20 kHz, 0.1% THD, at 2 ) + 180 watts × 1 (20 300 Hz, 0.1% THD, at 2 ) 1805GX: 40 watts × 4 (Front: 50 Hz 20 kHz, Rear: 20 Hz 20 kHz, 0.04% THD, at 4 ) + 150 watts × 1 (20 300 Hz, 0.04% THD, at 4 ) 60 watts × 4 (Front: 50 Hz 20 kHz, Rear: 20 Hz 20 kHz, 0.1% THD, at 2 ) + 180 watts × 1 (20 300 Hz, 0.1% THD, at 2 ) 3 Speakers: 120 watts × 2 (50 Hz 20 kHz, 0.1% THD, at 4 ) + 150 watts × 1 (20 300 Hz, 0.04% THD, at 4 ) Circuit system Frequency response 5 Hz 50 kHz ( +0 dB) 3 Harmonic distortion 0.005% or less (at 1 kHz, 4 ) Input level adjustment range 0.2 6.0 V (RCA pin jacks) High-pass filter 50 300 Hz, 12 dB/oct Low-pass filter 50 300 Hz, 12 dB/oct Phase shift adjustment range (XM-1805GX) 0° 180° (at 40 Hz) (only for subwoofer output) Power requirements 12 V DC car battery (negative ground) Power supply voltage 10.5 16 V Current drain at rated output : 42 A Remote input : 1.0 mA Dimensions Approx. 358 × 50 × 264 mm (w/h/d) (14 1/8 × 2 1/4 × 10 1/2 in.) not incl. projecting parts and controls Mass Approx. 3.5 kg (7 lb. 11 oz.) not incl. accessories Supplied accessories Mounting screws (4) Design and specifications are subject to change without notice.
STEREO POWER AMPLIFIER
9-870-240-12
2001F0400-1 © 2001.6
Sony Corporation
e Vehicle Company Shinagawa Tec Service Manual Production Group
1
SECTION 1 SERVICE NOTE
TABLE OF CONTENTS 1. SERVICE NOTE ................................................................. 2 2. GENERAL
Location and Function of Controls .......................................... 3 Connections ............................................................................. 4
heat sink (retainer plate) C937 Q512 Q510
NOTE FOR REPLACEMENT OF Q510 AND Q512 When replacing Q510 and Q512, remove C937 and then remove the screw securing the heat sink (retainer plate).
3. DISASSEMBLY
3-1. 3-2. 3-3. 3-4. Plate, Bottom ....................................................................... 6 Amp Board Section ............................................................. 6 Amp Board, HPF Board, LPF Board ................................... 7 LED Board ........................................................................... 7
4. ELECTRICAL ADJUSTMENT ...................................... 8 5. DIAGRAMS
5-1. 5-2. 5-3. 5-4. 5-5. 5-6. Block Diagram ..................................................................... 9 Printed Wiring Board Amp Section ............................... 11 Schematic Diagram Amp Section (1/2) ......................... 12 Schematic Diagram Amp Section (2/2) ......................... 13 Printed Wiring Boards HPF, LPF, LED Section ............ 14 Schematic Diagram HPF, LPF, LED Section ................ 15 Notes on Chip Component Replacement · Never reuse a disconnected chip component. · Notice that the minus side of a tantalum capacitor may be damaged by heat.
6. EXPLODED VIEWS
6-1. Heat Sink (Main) Section .................................................. 16 6-2. Amp Board Section ........................................................... 16
7. ELECTRICAL PARTS LIST ......................................... 17
2
SECTION 2 GENERAL
This section is extracted from instruction manual.
3
4
5
SECTION 3 DISASSEMBLY
Note : Follow the disassembly procedure in the numerical order given.
3-1. PLATE, BOTTOM
3 BTP 3x6 2 BTP 3x6
1 BTP 3x6
4 P 2.6x2.8
5 plate, bottom
7 sheet, insulating 6
3-2. AMP BOARD SECTION
1 B.TT. 3x14 2 B.TT. 3x14
3 B.TT. 3x14
5 AMP board section
6 CNP808
4
6
3-3. AMP BOARD, HPF BOARD, LPF BOARD
4 BVTT 3x5 6 HPF board
7 BVTT 3x5
9 LPF board
5 CNP806
0 AMP board
2 P 3x8 8 CNP807
1 P 3x8
3 panel (5ch), front
3-4. LED BOARD
1 BTP 3x6
2 LED board
heat sink (main)
7
SECTION 4 ELECTRICAL ADJUSTMENT
Bias Adjustment
Note : The Bias adjustment should be performed only if any of Q106, Q107, Q206, Q207, Q306, Q307, Q406, Q407, Q506 Q507 and Q509 to Q512 are replaced. Setting :
Stabilized Power supply Digital Voltmeter
Adjustment Location :
AMP BOARD (COMPONENT SIDE) VR401 BIAS ADJUSTMENT VR301 BIAS ADJUSTMENT VR201 BIAS ADJUSTMENT VR101 BIAS ADJUSTMENT VR501 BIAS ADJUSTMENT
B+,REM terminals
set
+ _
GND terminal
test points
Procedure : 1. Rotate the variable resistors VR101, VR201, VR301, VR401 and VR501 fully in the clockwise direction to minimize the idling current of the stabilized power supply. 2. The input signal is to be no signal. 3. Set the power voltage to +14.4 V, and turn the remote mode ON (Connect between the REM terminal and B+ terminal). 4. Connect on digital voltmeter between each test points. 5. Adjust VR101, VR201, VR301 and VR401 so that the digital voltmeter reading is 5 ± 0.5 mV. 6. Adjust VR501 so that the digital voltmeter reading is 3.5 ± 0.5 mV. RV Ref. No. VR101 VR201 VR301 VR401 VR501 Test points TP101 and TP102 TP201 and TP202 TP301 and TP302 TP401 and TP402 TP501 and TP502
Test Point Location :
AMP BOARD (CONDUCTOR SIDE) TP401 TP402 TP301 TP302 TP201 TP502 TP501 TP202 TP101 TP102
8
XM-1505SX/1805GX SECTION 5 DIAGRAMS
5-1. BLOCK DIAGRAM
PRE AMP IC801(1/2) CNJ805-1 L 5 6 7 5 6 LINE AMP IC804(1/2) LEVEL SHIFT IC802(2/2) 7 RV802 (1/4) RV802 HPF (FRONT) RV802 (3/4) 3 1 LINE SWITCH Q116
DIFFERENTIAL AMP Q101
DRIVE AMP Q103 VR101 BIAS BIAS Q105
POWER AMP Q107 OVER LOAD DET Q108 POWER AMP Q106
CN804
L
RV801(1/2) RV801 LEVEL (FRONT) PRE AMP IC801(2/2) CNJ805-2 R 3 2 1 3 2 LEVEL SHIFT IC802(1/2) 1
S801 HPF X20 X1 -14.5V
1 12 13 1
10
9
8 HIGH PASS FILTER IC803
FRONT
DIFFERENTIAL AMP Q102 LINE SWITCH Q216 7
DRIVE AMP Q104
BTL FRONT
2
3
4 RV802 (4/4)
LINE AMP IC804(2/2) 5
DIFFERENTIAL AMP Q201
DRIVE AMP Q203 VR201 BIAS
POWER AMP Q207 R OVER LOAD DET Q208 POWER AMP Q206
TEST TONE GENERATOR IC805 RV801(2/2) 7 1 1805GX PRE AMP IC806(2/2) CNJ805-3 L 5 6 7 5 6 LEVEL SHIFT IC807(2/2) 6 2 S851 TEST TONE
RV802 (2/4) DIFFERENTIAL AMP Q202 LINE AMP IC808(2/2) 5 7 DRIVE AMP Q204
BIAS Q205
SPEAKER OUT
LINE SWITCH Q316
7 S802 HPF ON VR803(1/2) OFF
VR804 (2/4)
1505SX
DIFFERENTIAL AMP Q301
DRIVE AMP Q303 VR301 BIAS BIAS Q305
POWER AMP Q307 L OVER LOAD DET Q308 POWER AMP Q306 BTL REAR
VR804 (2/4) VR804 HPF (REAR) DIFFERENTIAL AMP Q302 DRIVE AMP Q304
REAR
VR803 LEVEL (REAR) PRE AMP IC806(1/2) 3 2 LEVEL SHIFT IC807(1/2)
LINE AMP IC808(1/2) 3 1
CNJ805-4 R
LINE SWITCH Q416
1
2 3
1
VR804 (4/4)
1505SX
DIFFERENTIAL AMP Q401
DRIVE AMP Q403 VR401 BIAS BIAS Q405
POWER AMP Q407 R OVER LOAD DET Q408 POWER AMP Q406 CN803 SUB WOOFER SPEAKER OUT
S803 MODE (SUB WOOFER) F F+R
VR803(2/2)
VR804 (3/4) DIFFERENTIAL AMP Q402 1805GX DRIVE AMP Q404
PRE AMP IC809(1/2) CNJ805-5 L SUB WOOFER 3 2 CNJ805-6 1 5 6
LEVELAMP IC809(2/2) 7
RV806 PHASE 5 6 VR805 LEVEL (SUB WOOFER)
PHASE SHIFT IC810(2/2) 7 RV807 LPF 3
L.P.F AMP IC810(1/2) 1
LINE SWITCH Q516
DIFFERENTIAL AMP Q501
DRIVE AMP Q503 VR501 BIAS
POWER AMP Q507,509 (1505SX) Q507,509,511 (1805GX) OVER LOAD DET Q508 POWER AMP Q506,510 (1505SX) Q506,510,512 (1805GX)
L+R
R DC DET IC903
DC DET IC811 MUTE Q804 DIFFERENTIAL AMP Q502 LED842 OVER CURRENT DRIVE AMP Q504
BIAS Q505
B+ (+39V) B(-45V) DC DET Q914
LED DRIVE Q802 LED DRIVE Q803 T901 D905 OFFSET DET Q805-807 B+ (+30V)
CN801 +12V 2
F901
REG Q901,902 T902 D915 B+ (+45V) IC901 B+ (+39V) 12 11 8 10 DC-DC CONVERTER 9
LED843 OFFSET
GND
1 POWER ON/OFF Q903 CN802 D841 THERMAL
D844 POWER 12 11 8 16 TH803805 14
IC902 10 DC-DC CONVERTER 9 DRIVER Q910 INVERTER Q912 DRIVER Q911 INVERTER Q913
D917
D907 DRIVER Q905 INVERTER Q907 D908 DRIVER Q904 INVERTER Q906 B- REG Q908 D906 B+ REG Q909
B+ (+14.5V)
D918 B+ (-45V) D916 B+ (-39V)
· Signal path : AUDIO
REM SWITCH Q841 04
LED DRIVE Q801
B(-14.5V)
B(-30V)
9
9
THIS NOTE IS COMMON FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS. (In addition to this, the necessary note is printed in each block.) for schematic diagram: Note: · All capacitors are in µF unless otherwise noted. pF: µµF 50 WV or less are not indicated except for electrolytics and tantalums. · All resistors are in and 1/4 W or less unless otherwise specified. · % : indicates tolerance. · 2 : nonflammable resistor. · U : B+ Line. · V : B Line. · Power voltage is dc 14.4V and fed with regulated dc power supply from +12V and REMOTE terminals. · Voltage is dc with respect to ground under no-signal condition. · Voltages are taken with a VOM (Input impedance 10 M). Voltage variations may be noted due to normal production tolerances. · Signal path. F : AUDIO for printed wiring boards: Note: · X : parts extracted from the component side. · b : Pattern from the side which enables seeing. (The other layer's patterns are not indicated.)
· Semiconductor Location (AMP SECTION) Ref. No. D506 D507 D801 D802 D803 D804 D805 D806 D807 D901 D902 D903 D904 D905 D906 D907 D908 D909 D910 D911 D912 D913 D914 D915 D916 D917 D918 D919 D920 D921 D922 D923 D928 IC801 IC806 IC807 IC808 IC809 IC811 IC901 IC902 IC903 Q101 Q102 Q103 Q104 Q105 Q106 Q107 Q108 Q116 Q201 Q202 Q203 Q204 Location F-3 F-3 D-8 B-4 F-8 F-7 E-8 E-8 B-4 F-5 F-5 D-6 D-6 B-8 B-8 B-9 B-9 B-12 B-12 F-9 F-9 D-5 D-5 D-4 D-4 C-2 B-2 F-4 F-4 E-5 E-5 E-5 E-5 H-8 H-7 H-8 H-10 H-6 E-7 D-7 D-5 E-5 G-12 G-12 F-13 G-13 G-14 G-14 F-14 G-13 G-12 E-12 E-12 E-13 E-13 Ref. No. Q205 Q206 Q207 Q208 Q216 Q301 Q302 Q303 Q304 Q305 Q306 Q307 Q308 Q316 Q401 Q402 Q403 Q404 Q405 Q406 Q407 Q408 Q416 Q501 Q502 Q503 Q504 Q505 Q506 Q507 Q508 Q509 Q510 Q511 Q512 Q516 Q801 Q802 Q803 Q804 Q805 Q806 Q807 Q901 Q902 Q903 Q904 Q905 Q906 Q907 Q908 Q909 Q910 Q911 Q912 Q913 Q914 Location E-14 E-14 D-14 F-13 F-12 C-12 C-12 C-13 D-13 C-14 D-14 C-14 D-13 D-11 C-11 C-11 C-10 C-11 B-11 B-11 B-10 B-11 D-11 F-4 F-4 G-4 F-4 F-2 E-2 F-2 F-3 G-2 E-2 H-2 D-2 G-6 F-7 G-8 G-9 F-8 F-9 G-9 G-9 F-5 G-5 F-5 E-6 D-6 B-7 B-6 F-9 F-9 E-5 D-5 B-6 B-5 F-5
· IC Block Diagram IC901, 902 µPC494GS-T
16 15 14 13 REF. REG. 12 11 10 9
ERROR
0.1V ERROR 1 2 3 4 5 OSC
6
7 8
10
10
XM-1505SX/1805GX
5-2. PRINTED WIRING BOARD -- AMP SECTION -- · Refer to page 10 for Semiconductor Location.
1 A
2
AMP BOARD
3
4
5
6
7
8
9
10
11
12
13
14
R942
R944
R939
R937
R938
R941 R843
R929 R847 R846 TH903 D802 Q913
R930
R915
R940
R916 C918 Q906 C917
D907
D908 C952
Q407
R428 Q405 Q406 R427 R432 C953 R433 TP402 R431 D909 D910 C924 C923 R435 E CB Q408 C415 R425 R436 C418 VR401
D918
B
D917
TP2 TP1 D807
Q912
Q907
TH802
D906 D905
TP401 JW64 JW63 JW65 JW66
R430 R439 R434 Q403
T902 C932 C909
T901
JR16 Q404 Q402 R424 R421 R429 C417
JW180
R327 R227 Q107 R127 R137
JW181
C931
C934
C314
C943
JR20 R803 C935 JR19
VR301 C318 TP302 R335 R331 BCE R333
R801
R925 C927 R924 R923
C926
Q911 E CB C937 C939 C941 R927 8 9 D913 R928 JR30 BCE R922 IC902 1 18
C903 R912
D
C942
BCE R913 8 IC901 9 D903 D904 R914 C907 BCE Q904 1 18
C911
D915 D916
R417
Q905
R911 C904 R910 R909
Q512
Q416
R318 R319
JR15
1805GX
R541
JR18
D801
R419
Q306
C313 Q316
C914
C916
Q308 R317 Q203 R239 R223 R226 R222 R220 R224 R221 R229 C217 C951
B1C1 E B2C2 B1C1 E C2C2
C929 R921 C928
JR17 C905
R926
D914 R539 C930 Q510 C515 C940
R908 C906 R802
TP201 Q207 R230
IC903
D921 D928
C807
C912
E
Q506 R533 TP502 Q505 R528 R527 TH805 JR32
4 3 1 2 D923
4 3 1 2 IC811 TH901
D806
D805
R820 R822 R823
R932 R931
R217
JR14
Q201 C216 C215 R225 Q202
C936
C938
R234
D922
Q910
R232 R228 Q205 Q206 Q105 Q106 R133 R128 C119 1-680-818-
C913
C915
VR201 C218
R235
R917 R919
BCE
Q508 BCE R535 TP3
JR21
R536 R519 R904 JR26
R517
R821
D919 D920 Q504
BCE Q914 R907
R918 R920
C1 B2E2 E1 B1C2
Q216 C214
Q204 R236
R231
TP202 R233
D507
C919
R525 JR22 C518
R816 R814 R815 R811
R530
R905 R906
TH804
R839 C803 R810
JR12 R825
R824
R826 R828 R830
R807 R805 R806 C801
C514
Q507
C518
Q502
R118 R119 C114
C802 R809
R838
R534
R903
TP501 VR501 Q509
R813 R812
R544
R545
R546
R818 R817
Q802
C810 R831
R808
JR33
JR11
5
1 CNP808
C806
R524 R520 R522 Q501 R526 R523
C933
C812
C1 B2E2 E1 B1C2
C804
C1 B2E2 E1 B1C2
C1 B2E2 E1 B1C2
C1 B2E2 E1 B1C2
Q116
Q901 BCE Q902
C910
C2B2 E C1B1 C2B2 E C1B1
D803
R117
R139
R531
D902
F
C920
R532
D506
R529 R521 R547
D804
C922
BCE
D901
Q805 BCE
D912
R219
Q903
Q804
R819
Q909
C921
Q908
Q208 TP101 R130
D911
C950 R123 R126 R122 R120 R124
B1C1 E B2C2 B1C1 E C2C2
Q103
R134
Q801
Q807
Q803
C1 B2E2 R827 E1 B1C2
Q101 C116 C115 R125 Q102 JR13
R132
R829
VR101 C118 TP102 BCE R135 R131
G
3
LED BOARD CNJ808
Q516 C303 R304 R542 L901 1 C819 Q511 1805GX R840 R834 C815 R601 C503 C505 C504 R501 R504 JR40 R505 R503 R502 R602 4 1 5 8 IC809 C506 JR2 JR3 CNP807 R404 C403 5 4 5 C404 R405 R204 C203 JR4
C949
R540
Q503
JW71
Q806
JR41
R307
R407
C113
C204 R205
R121 R129 C117
R306
R303
C307
C406 4 5 1 IC807 8 JR8 C306 JR7 R411 -1 -2
R309
C601 C402 R440
JR27 JR28
C502
R537
R301
C409 -3 -4 -1
R410 R310 4
R902 R901 PL801 C902 R900 R506 C901
C814
C602
C301
C820
C401
R308 R408
JR1 04 CN803 CN801 F901 40A VR805 S803 LEVEL MODE (SUB WOOFER) (SUB WOOFER) F+R F
C818 R837
C817 R836
C816 R835 VR803 LEVEL (REAR)
R311
I
C308
R538
C519
R438 C310 JR35 R314 R313 JR9 -2 R312 -1 1805GX -2 1505SX R437 JR36 R412 S802 HPF (REAR) ON OFF
5 8 IC808 C309
C501
R414 C410
R833
1
R413 JR10 R409 C419 R338 C319 R238 C219 R138
C407
H
R340
C408
1805GX
R337 CN804
R237
TH801
C304 R305
R203 R302
R201 C302 R240 R202 C201 C105 C202 C103 R104 C101 R140 R103 R101 JR34 C813 R832 C102
(Page 14)
C405
1 IC806 8
4 C205 5
1 IC801 8 C104 R105 R102
R406 JR5 JR6
R207 1 R206 R106 R107
10 C948 CN806
Q104 R136 Q108
R403 R401 R402 C305
R328 Q305
Q401
R422 C414 R420
JR29
R323 R326 Q301 B1C1 R322 E C2 C316 B2 R320 B1C1 C315 E R325 R324 C2C2 Q302 R321 R329 C317 Q304 R336
R330
R334
L903
L902
C
R423 R426 C416
C1 C2 C1 C2 B1 E B2 B1 E B2
R339
Q303
TP301 Q307
R332
11
L+R
J
SUB WOOFER SPEAKER OUT
CN802 REM
GND
+12V
R L SUB WOOFER
R REAR INPUT
L
R CNJ805
L FRONT
VR804 HPF (REAR)
R
L BTL REAR SPEAKER OUT
R BTL FRONT
L
2
LPF BOARD CNJ807
1
HPF BOARD CNJ806
(Page 14)
(Page 14)
11
11
XM-1505SX/1805GX
5-3. SCHEMATIC DIAGRAM -- AMP SECTION (1/2) --
(Page 15)
(Page 15)
(Page 15)
(Page 15)
(Page 13)
12
12
XM-1505SX/1805GX
5-4. SCHEMATIC DIAGRAM -- AMP SECTION (2/2) -- · Refer to page 10 for IC Block Diagram.
(Page 12)
(Page 15)
· Waveform
1
1V/DIV, 5µsec/DIV 3.4Vp-p 15µsec
IC901, 902
5
13
13
XM-1505SX/1805GX
5-5. PRINTED WIRING BOARDS -- HPF, LPF, LED SECTION --
1 A
2
3
4
5
6
7
8
9
(Page 11) AMP BOARD CNP807
10
11
12
(Page 11) AMP BOARD CNP806
2 HPF BOARD
C853 R857 R854 C851 R853 R855 R861 1 C110 C109 R111 IC805 D851 8 5 1 4 C853 R862 R858 R860 5 CNJ807 1505SX C509 C508 R859
1
B
10 R934 R933 CNJ806 R112 C111
LPF BOARD
1805GX 1 C507 11 JR37
1805GX C108
R851 R852
C
D924
R212 C211
C210
C208
D925 D927 1 IC803 7 R214 D926 1805GX R215 C212 R216
C209
14
8
C854 C852 R856
R211
R109
JR24 JR23
4 1 IC810 5 8 R510
1505SX
-4 -2 -1 -3
C106 8 1 5 4
R936
C206
R115 C112 R116
R113 R114
JR25 R935
R511
R209 -1 -2
IC802
-2
R108 R208
R508 1-680-821RV806 PHASE
D
IC804 8 5 1 4 R213
1805GX
-1
E
04
S851 TEST TONE S801 HPF (FRONT) X1 X20 1805GX RV802 HPF (FRONT) RV801 LEVEL (FRONT) 1-680-82011 04
RV807 LPF
F
G
(Page 11) AMP BOARD CNP808
3
H
Q841 BC E 1 R841 CNJ808 R843 R842 1-680-819R844 R845 5
LED BOARD
I
04 LED841 THERMAL
11 LED843 OFFSET LED842 OVER CURRENT POWER/PROTECTOR LED844 POWER
J
14 14
R509 R507 JR31
XM-1505SX/1805GX
5-6. SCHEMATIC DIAGRAM -- HPF, LPF, LED SECTION --
(Page 12) (Page 12)
(Page 13) (Page 12)
(Page 12)
15
15
SECTION 6 EXPLODED VIEWS
NOTE: · The mechanical parts with no reference number in the exploded views are not supplied. · Items marked "*" are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. · Color Indication of Appearance Parts Example : KNOB, BALANCE (WHITE) ... (RED) R R Parts Color Cabinet's Color · Accessories and packing materials and hardware (# mark) list are given in the last of this parts list.
6-2. AMP BOARD SECTION
#4
6-1. HEAT SINK (MAIN) SECTION 61
#4
60 62 1 8 2
#5
55 54 57
53
56 55 55 58 54 67 64 54 68
62 58
58 1505SX
53 52 1805GX 53
7 7
A
3
#3
4
A
55 59
#1
57
54 58
5
65 66 59
59
F901
7
#3
63
51
6
#1
#1 #2
#1
Ref. No. * 51 * 51 * 52 53 * 54 55 * 56 * 57 * 58 59 * 60
Part No. A-3326-994-A A-3340-000-A 3-225-067-01 3-225-183-01 3-225-080-01 3-225-183-11 3-225-066-01 3-226-618-01 3-225-086-01 3-225-184-01
Description AMP BOARD, COMPLETE (1505SX) AMP BOARD, COMPLETE (1805GX) HEAT SINK (SUB 2) SCREW (+PSW.TT.3XL) HEAT SINK (RETAINER PLATE) SCREW (+PSW.TT.3XL) HEAT SINK (SUB 1) HEAT SINK (SUB 3) SHEET (TR), INSULATING SCREW (+PS.TT.3X6)
Remark
Ref. No. * 61 * 61 * 62 63 63 64 65 66 * 67 * 68
Part No. A-3326-995-A A-3326-998-A 3-225-076-01 3-225-075-01 3-225-075-11 3-912-431-01 3-369-647-01 3-912-432-01 3-225-078-01 3-225-077-01
Description HPF BOARD, COMPLETE (1505SX) HPF BOARD, COMPLETE (1805GX) BRACKET (5CH.VR3) PANEL (5CH), FRONT (1805GX) PANEL (5CH), FRONT (1505SX) SCREW (P) SCREW (M4 SPACER) SCREW (B) BRACKET (5CH.VR1) BRACKET (5CH.VR2)
Remark
Ref. No. 1 1 1 * 2 * 3
Part No.
Description
Remark
Ref. No. * 4 * 5 * 6 7 8 F901
Part No. 1-680-819-11 3-225-081-01 3-225-068-01 3-225-185-01 3-225-153-01
Description LED BOARD SHEET, INSULATING PLATE, BOTTOM SCREW (+B.TT.3X14) SHEET (HEAT SINK), ADHESIVE
Remark
3-225-070-21 PLATE (HEAT SINK), ORNAMENTAL (1805GX) 3-225-079-21 PLATE (HEAT SINK), ORNAMENTAL (1505SX:US,CND) 3-225-079-61 PLATE (HEAT SINK), ORNAMENTAL (1505SX:E) 3-225-071-01 HEAT SINK (MAIN) 3-225-065-01 HOLDER, LED
1-532-947-11 FUSE (BLADE TYPE) (AUTO FUSE) 30A
1-680-821-11 LPF BOARD
16
16
SECTION 7 ELECTRICAL PARTS LIST
NOTE: · Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. · RESISTORS All resistors are in ohms. METAL:Metal-film resistor. METAL OXIDE: Metal oxide-film resistor. F:nonflammable · Items marked "*" are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. · SEMICONDUCTORS In each case, u : µ, for example: uA.. : µA.. uPA.. : µPA.. uPB.. : µPB.. uPC.. : µPC.. uPD.. : µPD.. · CAPACITORS uF : µF · COILS uH : µH
AMP
When indicating parts by reference number, please include the board.
Ref. No. * *
Part No.
Description
Remark
Ref. No. C305 C306 C307 C308 C309 C310 C313 C314 C315 C316 C317 C318 C319 C401 C402 C403 C404 C405 C406 C407
Part No.
Description 47PF 220PF 10uF 0.22uF 0.22uF 100PF 47uF 22uF 10PF 0.1uF 0.1uF 0.1uF 0.047uF 4.7uF 4.7uF 100PF 100PF 47PF 220PF 10uF 5% 5% 20% 5% 5% 5% 20% 20% 0.5PF 10% 10% 5% 5% 20% 20% 5% 5% 5% 5% 20%
Remark 50V 50V 16V (1805GX) 50V 50V 50V 25V 50V 50V 16V 16V 50V 50V 50V 50V 50V 50V 50V 50V 16V (1805GX) 50V 50V 50V 25V 50V 16V 16V 50V 50V 50V 50V 50V 50V 50V 50V 25V 50V 50V 50V 50V 50V 50V 16V
A-3326-994-A AMP BOARD, COMPLETE (1505SX) A-3340-000-A AMP BOARD, COMPLETE (1805GX) ********************* 3-225-066-01 3-225-067-01 3-225-077-01 3-225-078-01 3-225-080-01 3-225-086-01 3-225-183-01 3-225-183-11 3-225-184-01 3-226-618-01 HEAT SINK (SUB 1) HEAT SINK (SUB 2) BRACKET (5CH.VR2) BRACKET (5CH.VR1) HEAT SINK (RETAINER PLATE) SHEET (TR), INSULATING SCREW (+PSW.TT.3XL) SCREW (+PSW.TT.3XL) SCREW (+PS.TT.3X6) HEAT SINK (SUB 3)
1-162-923-11 CERAMIC CHIP 1-164-230-11 CERAMIC CHIP 1-126-157-11 ELECT 1-136-169-00 MYLAR 1-136-169-00 MYLAR 1-162-927-11 1-126-022-11 1-126-049-11 1-162-915-11 1-107-826-11 1-107-826-11 1-136-165-00 1-136-161-00 1-126-047-21 1-126-047-21 1-162-927-11 1-162-927-11 1-162-923-11 1-164-230-11 1-126-157-11 CERAMIC CHIP ELECT ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP MYLAR MYLAR ELECT ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT
* * * * * *
*
7-685-646-79 SCREW +P 3X8 TYPE2 NON-SLIT 7-685-544-19 SCREW +BTP 3X5 TYPE2 N-S < CAPACITOR > C101 C102 C103 C104 C105 C113 C114 C115 C116 C117 C118 C119 C201 C202 C203 C204 C205 C214 C215 C216 C217 C218 C219 C301 C302 C303 C304 1-126-047-21 1-126-047-21 1-162-927-11 1-162-927-11 1-162-923-11 1-126-022-11 1-126-049-11 1-162-915-11 1-107-826-11 1-107-826-11 1-136-165-00 1-136-161-00 1-126-047-21 1-126-047-21 1-162-927-11 1-162-927-11 1-162-923-11 1-126-022-11 1-162-915-11 1-107-826-11 1-107-826-11 1-136-165-00 1-136-161-00 1-126-047-21 1-126-047-21 ELECT ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP MYLAR MYLAR ELECT ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP MYLAR MYLAR ELECT ELECT 4.7uF 4.7uF 100PF 100PF 47PF 47uF 22uF 10PF 0.1uF 0.1uF 0.1uF 0.047uF 4.7uF 4.7uF 100PF 100PF 47PF 47uF 10PF 0.1uF 0.1uF 0.1uF 0.047uF 4.7uF 4.7uF 100PF 100PF 20% 20% 5% 5% 5% 20% 20% 0.5PF 10% 10% 5% 5% 20% 20% 5% 5% 5% 20% 0.5PF 10% 10% 5% 5% 20% 20% 5% 5% 50V 50V 50V 50V 50V 25V 50V 50V 16V 16V 50V 50V 50V 50V 50V 50V 50V 25V 50V 16V 16V 50V 50V 50V 50V 50V 50V
C408 C409 C410 C414 C415 C416 C417 C418 C419 C501 C502 C503 C504 C505 C506 C514 C515 C516 C518 C519 C601 C602 C801
1-136-169-00 1-136-169-00 1-162-927-11 1-126-022-11 1-162-915-11 1-107-826-11 1-107-826-11 1-136-165-00 1-136-161-00 1-126-047-21 1-126-047-21 1-162-927-11 1-162-927-11 1-162-923-11 1-164-230-11 1-126-022-11 1-136-153-00 1-136-157-00 1-136-165-00 1-136-161-00
MYLAR MYLAR CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP MYLAR MYLAR ELECT ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT FILM MYLAR MYLAR MYLAR
0.22uF 0.22uF 100PF 47uF 10PF 0.1uF 0.1uF 0.1uF 0.047uF 4.7uF 4.7uF 100PF 100PF 47PF 220PF 47uF 0.01uF 0.022uF 0.1uF 0.047uF 4.7uF 4.7uF 0.1uF
5% 5% 5% 20% 0.5PF 10% 10% 5% 5% 20% 20% 5% 5% 5% 5% 20% 5% 5% 5% 5% 20% 20% 10%
1-162-927-11 CERAMIC CHIP 1-162-927-11 CERAMIC CHIP
1-126-047-21 ELECT 1-126-047-21 ELECT 1-107-826-11 CERAMIC CHIP
17
AMP
Ref. No. C802 C803 C804 C805 C806 C807 C810 C812 C813 C814 C815 C816 C817 C818 C819 C820 C901 C902 C903 C904 C905 C906 C907 C909 C910 C911 C912 C913 C914 C915 C916 C917 C918 C919 C920 C921 C922 C923 C924 C926 C927 C928 C929 C930 C931 C932 C933 C934 C935 C936 C937 C938 C939 Part No. 1-162-970-11 1-162-962-11 1-126-049-11 1-162-962-11 1-126-044-11 1-126-049-11 1-126-022-11 1-126-022-11 1-126-024-11 1-126-044-11 1-126-044-11 1-165-128-11 1-165-128-11 1-165-128-11 1-162-970-11 1-107-826-11 1-136-173-00 1-162-964-11 1-162-970-11 1-162-964-11 1-126-022-11 1-126-049-11 1-126-009-81 1-131-731-11 1-131-731-11 1-136-165-00 1-136-165-00 1-115-819-11 1-115-819-11 1-115-819-11 1-115-819-11 1-126-052-11 1-126-052-11 1-126-047-21 1-126-047-21 1-126-009-81 1-126-009-81 1-162-964-11 1-162-964-11 1-107-715-11 1-162-964-11 1-126-022-11 1-126-049-11 1-126-009-81 1-136-153-00 1-131-731-11 1-131-731-11 1-136-165-00 1-136-165-00 1-115-454-51 Description CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP ELECT ELECT ELECT ELECT ELECT ELECT ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP MYLAR CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT ELECT ELECT ELECT ELECT MYLAR MYLAR ELECT ELECT ELECT ELECT ELECT ELECT ELECT ELECT ELECT ELECT CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP ELECT ELECT ELECT FILM ELECT ELECT MYLAR MYLAR ELECT 0.01uF 470PF 22uF 470PF 1uF 22uF 47uF 47uF 220uF 1uF 1uF 0.22uF 0.22uF 0.22uF 0.01uF 0.1uF 0.47uF 0.001uF 0.01uF 0.001uF 47uF 22uF 100uF 2200uF 2200uF 0.1uF 0.1uF 2200uF 2200uF 2200uF 2200uF 100uF 100uF 4.7uF 4.7uF 100uF 100uF 0.001uF 0.001uF 22uF 0.001uF 47uF 22uF 100uF 0.01uF 2200uF 2200uF 0.1uF 0.1uF 1500uF 1500uF 1500uF 1500uF 10% 10% 20% 10% 20% 20% 20% 20% 20% 20% 20% Remark 25V 50V 50V 50V 50V 50V 25V 25V 16V 50V 50V 16V 16V 16V 25V 16V 50V 50V 25V 50V 25V 50V 16V 16V 16V 50V 50V 35V 35V 35V 35V 35V 35V 50V 50V 16V 16V 50V 50V 16V 50V 25V 50V 16V 50V 16V 16V 50V 50V 50V 50V 50V 50V Ref. No. C940 C941 C942 C943 C948 C949 C950 C951 C952 C953 Part No. 1-126-063-11 1-126-063-11 1-162-964-11 1-162-964-11 1-162-970-11 1-162-970-11 1-126-044-11 1-126-044-11 1-126-044-11 1-126-044-11 Description ELECT ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT ELECT ELECT ELECT 100uF 100uF 0.001uF 0.001uF 0.01uF 0.01uF 1uF 1uF 1uF 1uF 20% 20% 10% 10% 10% 10% 20% 20% 20% 20% Remark 63V 63V 50V 50V 25V 25V 50V 50V 50V 50V
< TERMINAL BOARD > CN801 CN803 CN804 1-694-755-11 TERMINAL BOARD (2P+FUSE) (+12V,GND) 1-694-754-11 TERMINAL BOARD (2P) (SUB WOOFER SPEAKER OUT) 1-694-752-11 TERMINAL BOARD (8P) (SPEAKER OUT) < JACK > CN805 1-794-852-11 JACK, PIN 6P (INPUT) < CONNECTOR >
10% 10% 5% 10% 10% 10% 20% 20% 20% 20% 20% 5% 5% 20% 20% 20% 20% 20% 20% 20% 20% 20% 20% 10% 10% 20% 10% 20% 20% 20% 5% 20% 20% 5% 5% 20% 20% 20% 20%
CN802 CNP806 CNP807 CNP808
1-815-300-11 1-815-524-11 1-815-522-11 1-506-987-11
CONNECTOR (REMOTE) 1P (REM) CONNECTOR, BOARD TO BOARD 10P CONNECTOR, BOARD TO BOARD 5P PIN, CONNECTOR (PC BOARD) 5P < DIODE >
D506 D507 D801 D802 D803 D804 D805 D806 D807 D901 D902 D903 D904 D905 D906 D907 D908 D909 D910 D911 D912 D913 D914 D915 D916 D917
8-719-978-65 8-719-978-65 8-719-801-78 8-719-801-78 8-719-801-78 8-719-801-78 8-719-978-33 8-719-016-74 8-719-801-78 8-719-025-50 8-719-978-33 8-719-016-74 8-719-016-74 8-719-054-55 8-719-054-55 8-719-076-60 8-719-076-61 8-719-016-74 8-719-016-74 8-719-025-49 8-719-025-49 8-719-016-74 8-719-016-74 8-719-054-55 8-719-054-55
DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE
DTZ-TT11-15B DTZ-TT11-15B 1SS184 1SS184 1SS184 1SS184 DTZ-TT11-6.8B 1SS352 1SS184 02CZ16-TE85L DTZ-TT11-6.8B 1SS352 1SS352 1SS306(TE85L) 1SS306(TE85L) FCH20A15 FRH20A15 1SS352 1SS352 02CZ15-TE85L 02CZ15-TE85L 1SS352 1SS352 1SS306(TE85L) 1SS306(TE85L)
1-115-454-51 ELECT 1-115-454-51 ELECT 1-115-454-51 ELECT
8-719-079-00 DIODE FCH10A15
18
Ver 1.1 2001.06
AMP
Ref. No. D918 D919 D920 D921 D922 D923 D928 Part No. 8-719-079-01 8-719-016-74 8-719-016-74 8-719-025-51 8-719-025-51 Description DIODE DIODE DIODE DIODE DIODE FRH10A15 1SS352 1SS352 02CZ18-TE85L 02CZ18-TE85L Remark Ref. No. JR36 JR40 JR41 Part No. Description 0 0 0 5% 5% Remark 1/16W (1505SX) 1/16W 1-216-864-11 METAL CHIP 1-216-864-11 METAL CHIP 1-216-296-11 SHORT < DIODE > 8-719-025-51 DIODE 02CZ18-TE85L 8-719-025-51 DIODE 02CZ18-TE85L < IC > IC801 IC806 IC807 IC808 IC809 IC901 IC902 8-759-711-82 8-759-711-82 8-759-711-82 8-759-711-82 8-759-711-82 IC IC IC IC IC NJM4580E(T1) NJM4580E(T1) NJM4580E(T1) NJM4580E(T1) NJM4580E(T1) JR5 JR6 JW71 8-719-977-12 DIODE DTZ6.8B 8-719-977-12 DIODE DTZ6.8B 8-719-901-33 DIODE 1SS133 < FERRITE BEAD > JW63 JW64 JW65 JW66 JW180 JW181 L901 L902 L903 1-410-396-41 1-410-396-41 1-410-396-41 1-410-396-41 1-410-396-41 1-410-396-41 1-424-719-11 1-410-396-41 1-410-396-41 INDUCTOR, FERRITE BEAD INDUCTOR, FERRITE BEAD INDUCTOR, FERRITE BEAD INDUCTOR, FERRITE BEAD INDUCTOR, FERRITE BEAD 0.45uH 0.45uH 0.45uH 0.45uH 0.45uH
8-759-144-88 IC uPC494GS-T1 8-759-144-88 IC uPC494GS-T1 < PHOTO COUPLER >
IC811 IC903
8-719-156-72 PHOTO COUPLER PS2501-1-K 8-719-156-72 PHOTO COUPLER PS2501-1-K < JUMPER RESISTOR >
INDUCTOR, FERRITE BEAD 0.45uH COIL, CHOKE (EI-35) INDUCTOR, FERRITE BEAD 0.45uH INDUCTOR, FERRITE BEAD 0.45uH < PILOT LAMP >
PL801 JR1 JR2 JR3 JR4 JR7 JR8 JR9 JR10 JR11 JR12 JR13 JR14 JR15 JR16 JR17 JR18 JR19 JR20 JR21 JR22 JR26 JR27 JR28 JR29 JR30 JR32 JR33 JR34 JR35 1-216-296-11 1-216-864-11 1-216-864-11 1-216-296-11 1-216-296-11 1-216-864-11 1-216-296-11 1-216-296-11 1-216-864-11 1-216-864-11 1-216-296-11 1-216-296-11 1-216-296-11 1-216-296-11 1-216-864-11 1-216-296-11 1-216-296-11 1-216-296-11 1-216-864-11 1-216-296-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-296-11 1-216-864-11 1-216-296-11 1-216-864-11 1-216-864-11 1-216-864-11 SHORT METAL CHIP METAL CHIP SHORT SHORT METAL CHIP SHORT SHORT METAL CHIP METAL CHIP SHORT SHORT SHORT SHORT METAL CHIP SHORT SHORT SHORT METAL CHIP SHORT METAL CHIP METAL CHIP METAL CHIP SHORT METAL CHIP SHORT METAL CHIP METAL CHIP METAL CHIP 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 5% 5% 1/16W 1/16W Q101 Q102 Q103 Q104 Q105 Q106 Q107 Q108 Q116 Q201 Q202 Q203 Q204 Q205 Q206 Q207 Q208 Q216 Q301 Q302 Q303 Q304 Q305 Q306 Q307 Q308 Q316 Q401
1-518-540-11 LAMP, PILOT (50mA/18V) < TRANSISTOR > 8-729-014-86 8-729-014-85 8-729-140-82 8-729-184-53 8-729-055-13 8-729-053-85 8-729-924-78 8-729-230-49 8-729-203-48 8-729-014-86 8-729-014-85 8-729-140-82 8-729-184-53 8-729-055-13 8-729-053-85 8-729-924-78 8-729-230-49 8-729-203-48 8-729-014-86 8-729-014-85 8-729-140-82 8-729-184-53 8-729-055-13 8-729-053-85 8-729-924-78 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR 2SC4207-YGRTE85L 2SA1618-YGRTE85R 2SA988-PAFAEA 2SC1845-EA 2SD1861-TV2
5%
1/16W
5% 5%
1/16W 1/16W
FET IRF9540 FET IRF540 TRANSISTOR 2SC2712-YG TRANSISTOR 2SC3327-A TRANSISTOR 2SC4207-YGRTE85L TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR FET IRF9540 FET IRF540 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR 2SA1618-YGRTE85R 2SA988-PAFAEA 2SC1845-EA 2SD1861-TV2
5%
1/16W
5%
1/16W
5% 5% 5% 5%
1/16W 1/16W 1/16W 1/16W
2SC2712-YG 2SC3327-A 2SC4207-YGRTE85L 2SA1618-YGRTE85R
5% 5% 5%
1/16W 1/16W 1/16W (1505SX)
TRANSISTOR 2SA988-PAFAEA TRANSISTOR 2SC1845-EA TRANSISTOR 2SD1861-TV2 FET IRF9540 FET IRF540
8-729-230-49 TRANSISTOR 2SC2712-YG 8-729-203-48 TRANSISTOR 2SC3327-A 8-729-014-86 TRANSISTOR 2SC4207-YGRTE85L
19
Ver 1.1 2001.06
AMP
Ref. No. Q402 Q403 Q404 Q405 Q406 Q407 Q408 Q416 Q501 Q502 Q503 Q504 Q505 Q506 Q507 Q508 Q509 Q510 Q511 Q512 Q516 Q801 Q802 Q803 Q804 Q805 Q806 Q807 Q901 Q902 Q903 Q904 Q905 Q906 Q907 Q908 Q909 Q910 Q911 Q912 Q913 Q914 Part No. 8-729-014-85 8-729-140-82 8-729-184-53 8-729-055-13 8-729-053-85 8-729-924-78 8-729-230-49 8-729-203-48 8-729-926-22 8-729-055-75 8-729-209-18 8-729-203-45 8-729-055-13 8-729-053-85 8-729-924-78 8-729-230-49 8-729-924-78 8-729-053-85 8-729-924-78 8-729-053-85 8-729-203-48 8-729-049-77 8-729-049-77 8-729-049-77 8-729-049-77 8-729-230-49 8-729-049-77 8-729-049-77 8-729-048-66 8-729-216-21 8-729-230-49 8-729-901-98 8-729-901-98 8-729-053-05 8-729-053-05 8-729-141-83 8-729-209-15 8-729-901-98 8-729-901-98 8-729-053-05 Description TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR FET IRF9540 FET IRF540 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR 2SA1618-YGRTE85R 2SA988-PAFAEA 2SC1845-EA 2SD1861-TV2 Remark Ref. No. R119 R120 R121 R122 R123 R124 R125 R126 R127 R128 R129 R130 R131 R132 R133 R134 R135 R136 R137 R138 R139 R140 R201 R202 R203 R204 R205 R206 R207 R217 R219 R220 R221 R222 R223 R224 R225 R226 R227 R228 R229 R230 R231 R232 R233 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W R234 R235 R236 R237 R238 R239 R240 R301 Part No. 1-216-829-11 1-216-835-11 1-216-829-11 1-216-835-11 1-216-829-11 1-216-829-11 1-208-494-61 1-216-813-11 1-216-835-11 1-216-833-11 1-216-813-11 1-216-845-11 1-216-845-11 1-216-809-11 1-216-809-11 1-216-819-11 1-216-821-11 1-216-833-11 1-216-853-11 1-215-857-11 1-205-991-11 1-216-821-11 1-216-837-11 1-216-837-11 1-220-397-11 1-216-837-11 1-216-837-11 1-216-821-11 1-216-825-11 1-216-837-11 1-216-829-11 1-216-835-11 1-216-829-11 1-216-835-11 1-216-829-11 1-216-829-11 1-216-210-00 1-216-813-11 1-216-835-11 1-216-833-11 1-216-813-11 1-216-845-11 1-216-845-11 1-216-809-11 1-216-809-11 1-216-819-11 1-216-821-11 1-216-833-11 1-216-853-11 1-215-857-11 Description METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL OXIDE METAL METAL CHIP METAL CHIP METAL CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL OXIDE 4.7K 15K 4.7K 15K 4.7K 4.7K 2.2K 220 15K 10K 220 100K 100K 100 100 680 1K 10K 470K 10 0.1X2 1K 22K 22K 4.7M 22K 22K 1K 2.2K 22K 4.7K 15K 4.7K 15K 4.7K 4.7K 3.3K 220 15K 10K 220 100K 100K 100 100 680 1K 10K 470K 10 0.1X2 1K 22K 5% 5% 5% 5% 5% 5% 2% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% Remark 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/8W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1W F
2SC2712-YG 2SC3327-A FMW3 FMS3
TRANSISTOR 2SA1360-Y TRANSISTOR 2SC3423-O TRANSISTOR 2SD1861-TV2 FET IRF9540 FET IRF540 TRANSISTOR 2SC2712-YG FET IRF540 FET IRF9540 FET IRF540 (1805GX) FET IRF9540 (1805GX) TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR 2SC3327-A HN1B01F-GR(T5LSONY) HN1B01F-GR(T5LSONY) HN1B01F-GR(T5LSONY) HN1B01F-GR(T5LSONY) 2SC2712-YG HN1B01F-GR(T5LSONY) HN1B01F-GR(T5LSONY) 2SB1238PQR-TV2 2SA1162-Y
5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 2% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5%
1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/8W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1W F
TRANSISTOR 2SC2712-YG TRANSISTOR 2SA1036K-R TRANSISTOR 2SA1036K-R FET FKV550T FET FKV550T TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR FET FKV550T 2SB1094-LK 2SD2012 2SA1036K-R 2SA1036K-R
8-729-053-05 FET FKV550T 8-729-230-49 TRANSISTOR 2SC2712-YG < RESISTOR >
R101 R102 R103 R104 R105 R106 R107 R117 R118
1-216-837-11 1-216-837-11 1-220-397-11 1-216-837-11 1-216-837-11 1-216-821-11 1-216-825-11 1-216-837-11 1-216-829-11
METAL CHIP METAL CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
22K 22K 4.7M 22K 22K 1K 2.2K 22K 4.7K
1-205-991-11 METAL 1-216-821-11 METAL CHIP 1-216-837-11 METAL CHIP
5% 5%
1/16W 1/16W
20
AMP
Ref. No. R302 R303 R304 R305 R306 R307 R308 R309 R310 R311 R312 R313 R314 R317 R318 R319 R320 R321 R322 R323 R324 R325 R326 R327 R328 R329 R330 R331 R332 R333 R334 R335 R336 R337 R338 R339 R340 R401 R402 R403 R404 R405 R406 R407 R408 R409 R410 R411 R412 R413 Part No. 1-216-837-11 1-220-397-11 1-216-837-11 1-216-837-11 1-216-821-11 Description METAL CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP 22K 4.7M 22K 22K 1K 2.2K 100 10K 2.2K 2.2K 470K 10K 4.7K 22K 4.7K 4.7K 15K 4.7K 15K 4.7K 4.7K 2.2K 220 15K 10K 220 100K 100K 100 100 680 1K 10K 470K 10 0.1X2 1K 22K 22K 4.7M 22K 22K 1K 2.2K 100 10K 2.2K 2.2K 470K 10K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 2% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% Remark 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W (1805GX) 1/16W 1/16W 1/16W (1805GX) 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/8W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1W F Ref. No. R414 R417 R419 R420 R421 R422 R423 R424 R425 R426 R427 R428 R429 R430 R431 R432 R433 R434 R435 R436 R437 R438 R439 R440 R501 R502 R503 R504 R505 R506 R517 R519 R520 R521 R522 R523 R524 R525 R526 R527 R528 R529 R530 R531 R532 R533 R534 R534 R535 R536 R537 Part No. 1-216-829-11 1-216-837-11 1-216-829-11 1-216-835-11 1-216-829-11 1-216-835-11 1-216-829-11 1-216-829-11 1-216-210-00 1-216-813-11 1-216-835-11 1-216-833-11 1-216-813-11 1-216-845-11 1-216-845-11 1-216-809-11 1-216-809-11 1-216-819-11 1-216-821-11 1-216-833-11 1-216-853-11 1-215-857-11 1-205-991-11 1-216-821-11 1-216-837-11 1-216-837-11 1-220-397-11 1-216-833-11 1-216-833-11 1-216-809-11 1-216-837-11 1-216-829-11 1-216-841-11 1-216-829-11 1-216-841-11 1-216-829-11 1-216-829-11 1-208-510-61 1-216-813-11 1-216-835-11 1-216-833-11 1-216-813-11 1-216-845-11 1-216-845-11 1-216-809-11 Description METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL OXIDE METAL METAL CHIP METAL CHIP METAL CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 4.7K 22K 4.7K 15K 4.7K 15K 4.7K 4.7K 3.3K 220 15K 10K 220 100K 100K 100 100 680 1K 10K 470K 10 0.1X2 1K 22K 22K 4.7M 10K 10K 100 22K 4.7K 47K 4.7K 47K 4.7K 4.7K 10K 220 15K 10K 220 100K 100K 100 100 820 1.8K 1K 10K 470K 5% 5% 5% 5% 5% 5% 5% 5% 2% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 2% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% Remark 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/8W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1W F 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/8W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W (1805GX) 1/16W (1505SX) 1/16W 1/16W 1/16W
1-216-825-11 METAL CHIP 1-216-809-11 METAL CHIP 1-216-833-11 METAL CHIP 1-216-825-11 METAL CHIP 1-216-825-11 METAL CHIP 1-216-853-11 METAL CHIP 1-216-833-11 1-216-829-11 1-216-837-11 1-216-829-11 1-216-829-11 1-216-835-11 1-216-829-11 1-216-835-11 1-216-829-11 1-216-829-11 1-208-494-61 1-216-813-11 1-216-835-11 1-216-833-11 1-216-813-11 1-216-845-11 1-216-845-11 1-216-809-11 1-216-809-11 1-216-819-11 1-216-821-11 1-216-833-11 1-216-853-11 1-215-857-11 1-205-991-11 1-216-821-11 1-216-837-11 1-216-837-11 1-220-397-11 1-216-837-11 1-216-837-11 1-216-821-11 1-216-825-11 1-216-809-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL OXIDE METAL METAL CHIP METAL CHIP METAL CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5%
1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W (1805GX) 1/16W 1/16W 1/16W (1805GX) 1/16W
1-216-809-11 METAL CHIP 1-216-820-11 METAL CHIP 1-216-824-11 METAL CHIP 1-216-821-11 METAL CHIP 1-216-833-11 METAL CHIP 1-216-853-11 METAL CHIP
1-216-833-11 METAL CHIP 1-216-825-11 METAL CHIP 1-216-825-11 METAL CHIP 1-216-853-11 METAL CHIP 1-216-833-11 METAL CHIP
21
AMP
Ref. No. R538 R539 R540 R541 R542 Part No. 1-215-857-11 1-216-809-11 1-216-809-11 1-216-809-11 Description METAL OXIDE METAL CHIP METAL CHIP METAL CHIP 10 100 100 100 100 5% 5% 5% 5% 5% Remark 1W F 1/16W 1/16W 1/16W (1805GX) 1/16W (1805GX) F F F (1805GX) 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/8W 1/16W 1/16W 1/16W 1/16W 1/8W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/8W 1/8W 1/8W 1/16W 1/16W 1/16W 1/16W 1/16W 1/8W Ref. No. R846 R847 R900 R901 R902 R903 R904 R905 R906 R907 R908 R909 R910 R911 R912 R913 R914 R915 R916 R917 R918 R919 R920 R921 R922 R923 R924 R925 R926 R927 R928 R929 R930 R931 R932 R937 R938 R939 R940 R941 R942 R943 R944 Part No. 1-216-823-11 1-216-823-11 1-208-510-61 1-216-833-11 1-216-833-11 1-216-214-00 1-216-190-00 1-216-190-00 1-216-190-00 1-216-829-11 1-216-833-11 1-216-833-11 1-216-835-11 1-216-834-11 1-216-849-11 1-216-821-11 1-216-821-11 1-216-805-11 1-216-805-11 1-216-829-11 1-216-829-11 1-216-829-11 1-216-829-11 1-216-833-11 1-216-817-11 1-216-833-11 1-216-835-11 1-216-834-11 1-216-849-11 1-216-821-11 1-216-821-11 1-216-805-11 1-216-805-11 1-216-829-11 1-216-813-11 1-208-473-11 1-208-473-11 1-208-473-11 1-208-473-11 1-208-473-11 Description METAL CHIP METAL CHIP RES-CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP 1.5K 1.5K 10K 10K 10K 4.7K 470 470 470 4.7K 10K 10K 15K 12K 220K 1K 1K 47 47 4.7K 4.7K 4.7K 4.7K 10K 470 10K 15K 12K 220K 1K 1K 47 47 4.7K 220 300 300 300 300 300 300 300 300 5% 5% 2% 5% 5% 2% 2% 2% 2% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 2% 2% 2% 2% 2% 2% 2% 2% Remark 1/16W 1/16W 1/8W 1/16W 1/16W 1/8W 1/8W 1/8W 1/8W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W
1-216-809-11 METAL CHIP
R544 R545 R546 R547 R601 R602 R801 R802 R803 R805 R806 R807 R808 R809 R810 R811 R812 R813 R814 R815 R816 R817 R818 R819 R820 R821 R822 R823 R824 R825 R826 R827 R828 R829 R830 R831 R832 R833 R834 R835 R836 R837 R838 R839 R840
1-244-300-11 METAL 1-244-300-11 METAL 1-244-300-11 METAL 1-216-809-11 METAL CHIP 1-216-837-11 METAL CHIP 1-216-837-11 1-216-823-11 1-216-831-11 1-216-823-11 1-216-837-11 1-216-829-11 1-216-849-11 1-216-833-11 1-216-833-11 1-216-833-11 1-216-833-11 1-216-829-11 1-208-510-61 1-216-845-11 1-216-833-11 1-216-833-11 1-216-829-11 1-208-510-61 1-216-857-11 1-216-833-11 1-216-821-11 1-216-845-11 1-216-837-11 1-216-833-11 1-216-833-11 1-216-833-11 1-216-833-11 1-216-833-11 1-216-857-11 1-216-833-11 1-216-857-11 1-216-214-00 1-216-214-00 1-216-214-00 1-216-821-11 1-216-821-11 1-216-821-11 1-216-833-11 1-216-841-11 1-208-494-61 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP
0.22X2 0.22X2 0.22X2 100 22K 22K 1.5K 6.8K 1.5K 22K 4.7K 220K 10K 10K 10K 10K 4.7K 10K 100K 10K 10K 4.7K 10K 1M 10K 1K 100K 22K 10K 10K 10K 10K 10K 1M 10K 1M 4.7K 4.7K 4.7K 1K 1K 1K 10K 47K 2.2K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 2% 5% 5% 5% 5% 2% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 2% 2% 2% 5% 5% 5% 5% 5% 2%
1-208-473-11 RES-CHIP 1-208-473-11 RES-CHIP 1-208-473-11 RES-CHIP < SWITCH >
S802 S803
1-572-185-11 SWITCH, SLIDE (HPF (REAR)) (1805GX) 1-572-185-11 SWITCH, SLIDE (MODE (SUB WOOFER)) < TRANSFORMER >
T901 T902
1-435-931-11 TRANSFORMER, DC-DC CONVERTER 1-435-932-11 TRANSFORMER, DC-DC CONVERTER
22
AMP
Ref. No. Part No. Description < THERMISTOR > TH801 TH802 TH804 TH805 TH901 TH903 1-809-664-51 1-808-877-11 1-808-877-11 1-808-877-11 1-804-301-11 THERMISTOR, POSITIVE THERMISTOR THERMISTOR THERMISTOR THERMISTOR (SMD) Remark Ref. No. C851 C852 C853 C854 C855 Part No. 1-162-970-11 1-162-970-11 1-162-970-11 1-162-970-11 1-107-826-11 Description CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP < CONNECTOR > CNJ806 1-815-523-11 CONNECTOR, BOARD TO BOARD 10P < DIODE > D851 D924 D925 D926 D927 8-719-801-78 8-719-056-85 8-719-056-85 8-719-800-76 8-719-800-76 DIODE DIODE DIODE DIODE DIODE < IC > IC802 IC803 IC804 IC805 8-759-711-82 8-759-008-67 8-759-711-82 8-759-924-46 IC IC IC IC NJM4580E(T1) TC4066BF-TP1 (1805GX) NJM4580E(T1) BA4560F-T1 1SS184 UDZS-TE17-8.2B (1805GX) UDZS-TE17-8.2B (1805GX) 1SS226-TE85R (1805GX) 1SS226-TE85R (1805GX) 0.01uF 0.01uF 0.01uF 0.01uF 0.1uF 10% 10% 10% 10% 10%
HPF
Remark 25V 25V 25V 25V 16V
1-808-877-11 THERMISTOR < VARIABLE RESISTOR >
VR101 VR201 VR301 VR401 VR501 VR803 VR804 VR805
1-241-761-11 1-241-761-11 1-241-761-11 1-241-761-11 1-241-761-11
RES, ADJ, CERMET RES, ADJ, CERMET RES, ADJ, CERMET RES, ADJ, CERMET RES, ADJ, CERMET
1K 1K 1K 1K 1K
1-225-648-11 RES, VAR, CARBON 5KX2 (LEVEL (REAR)) 1-225-647-11 RES, VAR, CARBON 20KX4 (HPF (REAR)) 1-225-648-11 RES, VAR, CARBON 5KX2 (LEVEL (SUB WOOFER)) ************************************************************* * * A-3326-995-A HPF BOARD, COMPLETE (1505SX) A-3326-998-A HPF BOARD, COMPLETE (1805GX) ********************
< JUMPER RESISTOR > JR23 1-216-864-11 METAL CHIP 0 5% 1/16W (1805GX) 1/16W (1805GX) 1/16W (1805GX)
*
3-225-076-01 BRACKET (5CH.VR3) < CAPACITOR > C106 C108 C109 C109 C110 1-164-230-11 CERAMIC CHIP 1-136-169-00 MYLAR 1-136-153-00 FILM 1-136-169-00 MYLAR 1-136-153-00 FILM 220PF 0.22uF 0.01uF 0.22uF 0.01uF 5% 5% 5% 5% 5% 50V 50V (1805GX) 50V (1805GX) 50V (1505SX) 50V (1805GX) 50V (1505SX) 50V (1805GX) 50V 50V 50V (1805GX) 50V (1805GX) 50V (1505SX) 50V (1805GX) 50V (1505SX) 50V (1805GX) 50V JR23 JR24 JR24 JR25 8-719-977-12 DIODE DTZ6.8B (1505SX) 1-216-864-11 METAL CHIP 0 8-719-977-12 DIODE DTZ6.8B (1505SX) 1-216-864-11 METAL CHIP 0 5%
5%
< RESISTOR > R108 R109 R109 1-216-809-11 METAL CHIP 1-216-809-11 METAL CHIP 1-216-864-11 METAL CHIP 1-216-857-11 METAL CHIP 1-216-857-11 METAL CHIP 100 100 0 1M 1M 5% 5% 5% 5% 5% 1/16W 1/16W (1805GX) 1/16W (1505SX) 1/16W (1805GX) 1/16W (1805GX) 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W (1805GX) 1/16W (1505SX) 1/16W (1805GX) 1/16W (1805GX) 1/16W
C110 C111 C112 C206 C208
1-136-169-00 MYLAR 1-136-169-00 MYLAR 1-162-927-11 CERAMIC CHIP 1-164-230-11 CERAMIC CHIP 1-136-169-00 MYLAR
0.22uF 0.22uF 100PF 220PF 0.22uF
5% 5% 5% 5% 5%
R111 R112
C209 C209 C210 C210 C211
1-136-153-00 FILM 1-136-169-00 MYLAR 1-136-153-00 FILM 1-136-169-00 MYLAR 1-136-169-00 MYLAR
0.01uF 0.22uF 0.01uF 0.22uF 0.22uF
5% 5% 5% 5% 5%
R113 R114 R115 R116 R208 R209 R209 R211 R212 R213
1-216-825-11 1-216-825-11 1-216-833-11 1-216-829-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
2.2K 2.2K 10K 4.7K 100 100 0 1M 1M 2.2K
5% 5% 5% 5% 5% 5% 5% 5% 5% 5%
1-216-809-11 METAL CHIP 1-216-864-11 METAL CHIP 1-216-857-11 METAL CHIP 1-216-857-11 METAL CHIP 1-216-825-11 METAL CHIP
C212
1-162-927-11 CERAMIC CHIP
100PF
5%
23
HPF
Ref. No. R214 R215 R216 R851 R852 R853 R854 R855 R856 R857 R858 R859 R860 R861 R862 R933 R934 R935 R936
LED
Part No. 1-216-825-11 1-216-833-11 1-216-829-11 1-216-833-11 1-216-835-11 1-216-829-11 1-216-829-11 1-216-845-11 1-216-833-11 1-216-833-11 1-216-833-11 1-216-845-11 1-216-833-11 1-216-821-11 1-216-821-11
LPF
Description METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 2.2K 10K 4.7K 10K 15K 4.7K 4.7K 100K 10K 10K 10K 100K 10K 1K 1K 1K 1K 10K 10K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% Remark 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W (1805GX) 1/16W (1805GX) 1/16W (1805GX) 1/16W (1805GX) Ref. No. * Part No. Description Remark 1-680-821-11 LPF BOARD ********** 3-225-076-01 BRACKET (5CH.VR3) < CAPACITOR > C507 C508 C509 1-126-044-11 ELECT 1-136-165-00 MYLAR 1-136-169-00 MYLAR < CONNECTOR > CNJ807 1-815-521-11 CONNECTOR, BOARD TO BOARD 5P < IC > IC810 8-759-711-82 IC NJM4580E(T1) < JUMPER RESISTOR > JR31 JR38 1-216-864-11 METAL CHIP 1-216-864-11 METAL CHIP 0 0 5% 5% 1/16W (1505SX) 1/16W (1505SX) 1uF 0.1uF 0.22uF 20% 5% 5% 50V (1805GX) 50V 50V
*
1-216-821-11 METAL CHIP 1-216-821-11 METAL CHIP 1-216-833-11 METAL CHIP 1-216-833-11 METAL CHIP
< VARIABLE RESISTOR > RV801 RV802 1-225-648-11 RES, VAR, CARBON 5KX2 (LEVEL (FRONT)) 1-225-647-11 RES, VAR, CARBON 20KX4 (HPF (FRONT)) < SWITCH > S801 1-572-185-11 SWITCH, SLIDE (HPF (FRONT)) (1805GX) S851 1-771-802-11 SWITCH (TEST TONE) ************************************************************* * 1-680-819-11 LED BOARD ********** 3-225-065-01 HOLDER, LED < DIODE > D841 D842 D843 D844 8-719-302-91 8-719-302-91 8-719-302-91 8-719-064-23 LED LED LED LED SEL2111R (THERMAL) SEL2111R (OVER CURRENT) SEL2111R (OFFSET) SEL2411G (POWER) R507 R508 R509 R510 R511
< RESISTOR > 1-216-833-11 METAL CHIP 1-216-809-11 METAL CHIP 1-216-833-11 METAL CHIP 1-216-827-11 METAL CHIP 1-216-827-11 METAL CHIP 10K 100 10K 3.3K 3.3K 5% 5% 5% 5% 5% 1/16W 1/16W (1805GX) 1/16W 1/16W 1/16W
< VARIABLE RESISTOR > RV806 1-227-320-11 RES, VAR, CARBON 50KX2 (PHASE) (1805GX) RV807 1-225-922-11 RES, VAR, CARBON 20KX2 (LPF) ************************************************************* MISCELLANEOUS *************** F901 1-532-947-11 FUSE (BLADE TYPE) (AUTO FUSE) 30A ************************************************************* ACCESSORIES & PACKING MATERIALS ******************************** 3-229-137-11 MANUAL, INSTRUCTION (ENGLISH,FRENCH) (1805GX) 3-229-138-11 MANUAL, INSTRUCTION (ENGLISH,FRENCH) (1505SX) 3-229-138-21 MANUAL, INSTRUCTION (GERMAN,ITALIAN) (1505SX:E) 3-367-410-01 SCREW (DIA.5X15), TAPPING (MOUNTING SCREW) *************************************************************
*
< TRANSISTOR > Q841 8-729-230-49 TRANSISTOR 2SC2712-YG < RESISTOR > R841 1-208-494-61 RES-CHIP 2.2K 2% 1/8W R842 1-208-494-61 RES-CHIP 2.2K 2% 1/8W R843 1-208-494-61 RES-CHIP 2.2K 2% 1/8W R844 1-216-190-00 RES-CHIP 470 2% 1/8W R845 1-216-190-00 RES-CHIP 470 2% 1/8W *************************************************************
24
Ref. No.
Part No.
Description ************** HARDWARE LIST **************
Remark
#1 #2 #3 #4 #5
7-685-545-14 7-627-556-07 7-685-646-79 7-685-870-01 7-685-544-19
SCREW +BTP 3X6 TYPE2 N-S SCREW, PRECISION +P 2.6X2.8 SCREW +P 3X8 TYPE2 NON-SLIT SCREW +BVTT 3X5 (S) SCREW +BTP 3X5 TYPE2 N-S
25
XM-1505SX/1805GX
REVISION HISTORY
Clicking the version allows you to jump to the revised page. Also, clicking the version at the upper right on the revised page allows you to jump to the next revised page. Ver. 1.1 1.0 Date 2001. 06 2000. 12 Description of Revision Corrected error for Q107, 207, 307, 407, 507, 509 and 511. New
(ENG-01006)
26