Text preview for : McIntosh-MC207 pwramp.pdf part of McIntosh MC207 power amplifier
Back to : McIntosh-MC207 pwramp.pdf | Home
POWER AMPLIFIER
SERIAL NO. VQ1001 And Above
CONTENTS
Performance Specifications ........................................ 2 Notes ......................................................................... 2 Rear Panel .................................................................. 3 Section Location ........................................................ 5 Block Diagram ........................................................... 6 Interconnection Diagram ...................................... 7 - 8 Input Schematic and PCB .................................... 9 - 12 Heatsink 1-Channel Schematic and PCB ............ 13 - 18 Heatsink 2-Channel Schematic and PCB ............ 21 - 26 Display Schematic and PCB ............................... 29 - 32 Capacitor Schematic and PCB .................................. 33 Power Supply Schematic and PCB ..................... 34 - 35 Parts List ............................................................ 36 - 42 Exploded Views and Parts Lists .......................... 43 - 46 Repacking Instruction .............................................. 47
SERVICE MANUAL
Serial Number VQ1001 And Above
PERFORMANCE SPECIFICATIONS
Power Output Minimum sine wave continuous average power output per channel, all channels operating is: 200 watts into 4 ohm or 8 ohm load Rated Power Band 20Hz to 20,000Hz Total Harmonic Distortion Maximum Total Harmonic Distortion at any power level from 250 milliwatts to rated power output is: 0.005% for 4 or 8 ohm loads Dynamic Headroom 1.7dB Frequency Response +0, -0.25dB from 20Hz to 20,000Hz +0, -3dB from 10Hz to 100,000Hz Sensitivity 1.0 Volt Unbalanced with a 4 ohm Loudspeaker 2.0 Volt Balanced with a 4 ohm Loudspeaker 1.4 Volt Unbalanced with a 8 ohm Loudspeaker 2.8 Volt Balanced with a 8 ohm Loudspeaker A-Weighted Signal To Noise Ratio 89dB (112dB below rated output) Intermodulation Distortion Maximum Intermodulation Distortion if instantaneous peak output per channel does not exceed twice the rated output, for any combination of frequencies from 20Hz to 20,000Hz, with all channels operating is: 0.005% for 4 or 8 ohm loads Input Impedance 20,000 ohms Balanced 10,000 ohms Unbalanced Wide Band Damping Factor Greater than 60 at 4 ohms Greater than 140 at 8 ohms Power Requirements 100 Volts, 50/60Hz at 1440 watts 110 Volts, 50/60Hz at 13.0 amps 120 Volts, 50/60Hz at 12.0 amps 220 Volts, 50/60Hz at 6.0 amps 230 Volts, 50/60Hz at 6.0 amps 240 Volts, 50/60Hz at 6.0 amps
Note: Refer to the rear panel of the MC207 for the correct voltage.
Dimensions Front Panel: 17-1/2 inches (44.45cm) wide, 9-7/16 inches (23.97cm) high. Depth behind front mounting panel is 18-3/4 inches (47.63cm), including clearance for connectors. Weight 83 pounds (37.6kg) net, 116 pounds (52.6kg) in shipping carton
NOTES
1. The heavy lines on the schematic denote the primary signal path. 2. Unless otherwise noted, all voltages indicated on the schematics are measured under the following conditions: a. AC input at 120 volts, 50/60Hz. b. All voltages are +/-10% with respect to ground. A high impedance (10 megaohm) voltmeter must be used. 3. Unless otherwise specified: a. Resistor values are in ohms. b. Capacitor values are microfarads (uF). c. Inductor values are in microhenries (uH). 4. On PC board drawings, Square pad indicates: a. Polarized Capacitors - Positive b. Diodes - Cathode c. Others - Pin 1
5.
WARNING
Parts marked with the symbol have critical characteristics. Use only replacement parts recommended by the manufacturer.
2
MC207
REAR PANEL
3
NOTES
4
MC207
SECTION LOCATIONS
TOP VIEW
TOP VIEW WITH COVER REMOVED
5
BLOCK DIAGRAM
6
MC207
1
INTERCONNECT
7
8
2
INPUT
050065
9
10
MC207
2
INPUT
050065
11
12
3B
A
HEATSINK 1-CHANNEL
050070
13
14
MC207
3B
A
HEATSINK 1-CHANNEL
DRIVER SECTION 050070
15
16
3B
A
HEATSINK 1-CHANNEL
050070
* Denotes components on reverse or backside of PC Board.
17
18
MC207
NOTES
19
20
4B C
A
HEATSINK 2-CHANNEL
050064
21
22
MC207
4
A B C
HEATSINK 2-CHANNEL DRIVER SECTION 050064
23
24
25
3A 4B B C
A
HEATSINK 2-CHANNEL
050064
5
DISPLAY
ILLUMINATION SECTION 050066
* Denotes components on reverse or backside of PC Board.
26
27
28
MC207
5
DISPLAY
METER SECTION 050066
5
DISPLAY
POWER GUARD SECTION 050066
29
30
5
DISPLAY
050066
* Denotes components on reverse or backside of PC Board.
31
32
MC207
6
CAPACITOR
050063
* Denotes components on reverse or backside of PC Board.
33
7
POWER SUPPLY
050062
34
MC207
7
POWER SUPPLY
050062
35
PARTS LIST
Ref No.
1
Part No.
Description
052005 052005 070139 124089 124089 124089 052017 052017 146243 146243 050061 074091 084124 084124 084124 084124 084124 084124 084124 C43 C44 C45 C46 C47 J1 J2 J3 J4 J5 J6 J7 J8 J9 J10 J11 J12 J13 J14 J16 J17 J18 J19 J20 R1 R2 R3 R4 R5 R6 R7 R8 R9 R10 R11 R12 R13 R14 R16 R17 R18 R19 R20 R21 R22 R23 R24 R25 R26 R27 R28 R29 R30 R31 R33 R34 R35 R37 R38 R39 R40 R41 CAP ELECT 10UF 16V 4X5 CASE 066382 CAP MONO 47PF 200V 10% NPO 061299 CAP ELECT 10UF 16V 4X5 CASE 066382 CAP MONO 22PF 200V 10% NPO 061298 CAP MONO 22PF 200V 10% NPO 061298 CONN MALE 9 POS FRICTION LOCK 117244 JACK RCA BLK 117847 JACK RCA 1X2 BLK/BLK 14MM 117848 CONN 4 PIN 117215 CONN 4 PIN 117215 RECEPTACLE XLR FEMALE 117685 RECEPTACLE XLR FEMALE 117685 JACK RCA 1X2 BLK/BLK 14MM 117848 CONN 4 PIN 117215 CONN D 25-PIN 117501 CONN 4 PIN 117215 RECEPTACLE XLR FEMALE 117685 RECEPTACLE XLR FEMALE 117685 RECEPTACLE XLR FEMALE 117685 JACK RCA 1X2 BLK/BLK 14MM 117848 CONN 4 PIN 117215 RECEPTACLE XLR FEMALE 117685 JACK HEADPHONE DUAL BLACK 1/8 117825 RECEPTACLE XLR FEMALE 117685 RES MF 1K 1% 1/4W 144090 RES MF 1K 1% 1/4W 144090 RES MF 20K 1% 1/4W 144104 RES MF 221 OHM 1% 1/4W 144172 RES MF 20K 1% 1/4W 144104 RES MF 221 OHM 1% 1/4W 144172 RES MF 100K 1% 1/4W 144113 RES MF 100K 1% 1/4W 144113 RES MF 20K 1% 1/4W 144104 RES MF 20K 1% 1/4W 144104 RES MF 10K 1% 1/4W 144053 RES MF 10K 1% 1/4W 144053 RES MF 10 OHM 1% 1/4W 144157 RES MF 10K 1% 1/4W 144053 RES MF 100K 1% 1/4W 144113 RES MF 10K 1% 1/4W 144053 RES MF 100K 1% 1/4W 144113 RES MF 10 OHM 1% 1/4W 144157 RES MF 1K 1% 1/4W 144090 RES MF 20K 1% 1/4W 144104 RES MF 221 OHM 1% 1/4W 144172 RES MF 1K 1% 1/4W 144090 RES MF 100K 1% 1/4W 144113 RES MF 20K 1% 1/4W 144104 RES MF 20K 1% 1/4W 144104 RES MF 221 OHM 1% 1/4W 144172 RES MF 100K 1% 1/4W 144113 RES MF 10K 1% 1/4W 144053 RES MF 20K 1% 1/4W 144104 RES MF 10K 1% 1/4W 144053 RES MF 100K 1% 1/4W 144113 RES MF 10K 1% 1/4W 144053 RES MF 10K 1% 1/4W 144053 RES MF 100K 1% 1/4W 144113 RES MF 1K 1% 1/4W 144090 RES MF 20K 1% 1/4W 144104 RES MF 221 OHM 1% 1/4W 144172 RES MF 100K 1% 1/4W 144113
INTERCONNECT C1 ASSEMBLY CAPACITOR C2 ASSEMBLY CAPACITOR D1 DIODE BRID RECT M1 METER MC207 M2 METER MC207 M3 METER MC207 RT1 ASSEMBLY THERMISTOR RT2 ASSEMBLY THERMISTOR S1 SWITCH POWER S2 SWITCH POWER T1 POTTED TRANSFORMER POWER TB1 TERMINAL BLOCK AC TB2 POST BINDING DUAL TB3 POST BINDING DUAL TB4 POST BINDING DUAL TB5 POST BINDING DUAL TB6 POST BINDING DUAL TB7 POST BINDING DUAL TB8 POST BINDING DUAL 050065 INPUT PCB C1 CAP ELECT 10UF 16V 4X5 CASE C2 CAP ELECT 10UF 16V 4X5 CASE C3 CAP MONO 47PF 200V 10% NPO C4 CAP MONO 47PF 200V 10% NPO C5 CAP ELECT 10UF 16V 4X5 CASE C6 CAP ELECT 10UF 16V 4X5 CASE C7 CAP MONO .1uF 50V 20% Z5U C8 CAP MONO .1uF 50V 20% Z5U C9 CAP MONO 22PF 200V 10% NPO C10 CAP MONO 22PF 200V 10% NPO C11 CAP MONO 47PF 200V 10% NPO C12 CAP ELECT 10UF 50V C13 CAP MONO 47PF 200V 10% NPO C14 CAP ELECT 10UF 50V C15 CAP ELECT 10UF 16V 4X5 CASE C16 CAP ELECT 10UF 16V 4X5 CASE C17 CAP MONO 47PF 200V 10% NPO C18 CAP ELECT 10UF 16V 4X5 CASE C19 CAP MONO 47PF 200V 10% NPO C20 CAP MONO .1uF 50V 20% Z5U C21 CAP MONO .1uF 50V 20% Z5U C22 CAP ELECT 10UF 16V 4X5 CASE C23 CAP MONO 22PF 200V 10% NPO C24 CAP MONO .1uF 50V 20% Z5U C25 CAP MONO .1uF 50V 20% Z5U C26 CAP MONO 47PF 200V 10% NPO C27 CAP MONO 22PF 200V 10% NPO C28 CAP MONO 47PF 200V 10% NPO C29 CAP ELECT 10UF 16V 4X5 CASE C30 CAP MONO 47PF 200V 10% NPO C31 CAP ELECT 10UF 16V 4X5 CASE C32 CAP MONO 22PF 200V 10% NPO C33 CAP MONO 47PF 200V 10% NPO C34 CAP ELECT 10UF 16V 4X5 CASE C35 CAP MONO 47PF 200V 10% NPO C36 CAP ELECT 10UF 16V 4X5 CASE C38 CAP MONO 22PF 200V 10% NPO C39 CAP MONO .1uF 50V 20% Z5U C40 CAP MONO .1uF 50V 20% Z5U C41 CAP MONO 47PF 200V 10% NPO
2
066382 066382 061299 061299 066382 066382 061305 061305 061298 061298 061299 066445 061299 066445 066382 066382 061299 066382 061299 061305 061305 066382 061298 061305 061305 061299 061298 061299 066382 061299 066382 061298 061299 066382 061299 066382 061298 061305 061305 061299
36
MC207
PARTS LIST con't
R42 R43 R44 R45 R46 R47 R48 R49 R50 R51 R55 R56 R58 R59 R60 R61 R62 R63 R64 R65 R66 R68 S1 SP1 U1 U2 U3 U4
3A 3B
RES MF 20K 1% 1/4W RES MF 10K 1% 1/4W RES MF 10K 1% 1/4W RES MF 100K 1% 1/4W RES MF 100 OHM 1% 1/4W RES MF 1K 1% 1/4W RES MF 20K 1% 1/4W RES MF 221 OHM 1% 1/4W RES MF 100K 1% 1/4W RES MF 20K 1% 1/4W RES MF 10K 1% 1/4W RES MF 10K 1% 1/4W RES MF 100K 1% 1/4W RES MF 1K 1% 1/4W RES MF 20K 1% 1/4W RES MF 221 OHM 1% 1/4W RES MF 100K 1% 1/4W RES MF 20K 1% 1/4W RES MF 100 OHM 1% 1/4W RES MF 10K 1% 1/4W RES MF 10K 1% 1/4W RES MF 100K 1% 1/4W SWITCH SLIDE BRACKET PCB CARD MOUNTING IC DUAL OPERATIONAL AMPLIFIER IC DUAL OPERATIONAL AMPLIFIER IC DUAL OPERATIONAL AMPLIFIER IC DUAL OPERATIONAL AMPLIFIER
144104 144053 144053 144113 144196 144090 144104 144172 144113 144104 144053 144053 144113 144090 144104 144172 144113 144104 144196 144053 144053 144113 148059 003611 133260 133260 133260 133260
050070 HEATSINK 1-CHANNEL PCB C1 CAP ELECT 47UF 35V C2 CAP ELECT 47UF 35V C3 CAP MONO .1uF 50V 20% Z5U C4 CAP POLYPROP 0.15UF 10% 250VDC C7 CAP MONO 100PF 100V 10% NPO C8 CAP MONO 100PF 100V 10% NPO C9 CAP MONO .01UF 50V 20% X7R C14 CAP MONO 100PF 100V 10% NPO C16 CAP MONO .01UF 50V 20% X7R C22 CAP ELECT 220UF 25V C27 CAP MONO 100PF 100V 10% NPO C30 CAP ELECT 47UF 35V C31 CAP ELECT .47UF 50V C32 CAP MONO .1uF 50V 20% Z5U C33 CAP MONO .1uF 50V 20% Z5U C35 CAP ELECT 10UF 100VDC C36 CAP ELECT 10UF 100VDC C37 CAP ELECT 10UF 100VDC C38 CAP ELECT 10UF 100VDC C40 CAP ELECT 220UF 50V 20% C41 CAP ELECT 10UF 100VDC C47 CAP POLYPROP .047UF 10% 250VDC C51 CAP ELECT 10UF 100VDC C200 CAP ELECT 10UF 100VDC D1 DIODE SILICON D2 DIODE SILICON D4 DIODE SILICON D5 DIODE SILICON D6 DIODE RECTIFIER D7 DIODE RECTIFIER IC2 IC DUAL AMP J1 CONN MALE 9 POS FRICTION LOCK
066446 066446 061305 064363 061300 061300 061304 061300 061304 066507 061300 066446 066244 061305 061305 066462 066462 066462 066462 066254 066462 064364 066462 066462 070047 070047 070047 070047 070131 070131 133259 117244
J2 J4 J5 J6 J8 J9 K1 K2 L2 LD1 Q1 Q2 Q3 Q4 Q5 Q6 Q7 Q8 Q9 Q10 Q11 Q20 Q22 Q23 Q25 Q27 Q29 Q30 Q31 Q32 Q33 Q35 Q37 Q39 Q41 Q49 Q50 Q51 Q52 Q53 Q54 Q55 Q56 Q59 Q60 Q61 Q63 Q64 R1 R2 R3 R4 R5 R6 R7 R8 R9 R10 R11 R12 R13 R14 R15
CONN 4 PIN CONN HEADER 2 PIN 0.156 BLADE FASTON .110 BLADE FASTON W/FEET CONN HEADER 2 PIN 0.156 CONN 2 PIN MALE RELAY 24VDC 5A 277VAC RELAY 24VDC 5A 277VAC CHOKE 0.65UH OUTPUT LDR NETWORK TRANSISTOR NPN TRANSISTOR PNP TRANSISTOR NPN TRANSISTOR PNP TRANSISTOR NPN TRANSISTOR NPN TRANSISTOR PNP TRANSISTOR PNP POWER TRANSISTOR NPN POWER TRANSISTOR PNP POWER TRANSISTOR NPN POWER TRANSISTOR NPN POWER TRANSISTOR PNP POWER TRANSISTOR NPN POWER TRANSISTOR PNP POWER TRANSISTOR PNP TRANSISTOR PNP POWER TRANSISTOR SI NPN 25V TRANSISTOR NPN TRANSISTOR NPN TRANSISTOR PNP POWER TRANSISTOR NPN TRANSISTOR NPN TRANSISTOR PNP TRANSISTOR PNP TRANSISTOR PNP TRANSISTOR NPN TRANSISTOR NPN TRANSISTOR NPN TRANSISTOR PNP POWER TRANSISTOR PNP TRANSISTOR PNP POWER TRANSISTOR PNP POWER TRANSISTOR NPN TRANSISTOR SI NPN 25V TRANSISTOR SI NPN 25V TRANSISTOR NPN TRANSISTOR PNP POWER RES MF 332 OHM 1% 1/4W RES MET OX 680 OHM 5% .5W RES MF 22.1K 1% 1/4W RES MF 100K 1% 1/4W RES MF 22.1K 1% 1/4W RES MET OX 1.8k 5% .5W RES MET OX 430 OHM 5% .5W RES MF 332 OHM 1% 1/4W RES MET OX 680 OHM 5% .5W RES MF 22.1K 1% 1/4W RES MET OX 1.8k 5% .5W RES MET OX 47 OHM 5% .5W POT TRIM 200 OHM 20% HORIZ AD RES MF 100K 1% 1/4W RES MF 100 OHM 1% 1/4W
117215 117404 117712 117708 117404 117213 087057 087057 122297 144179 132223 132224 132268 132267 132223 132285 132286 132297 132296 132297 132296 132296 132297 132296 132297 132224 132255 132254 132223 132223 132255 132223 132285 132286 132224 132224 132223 132223 132223 132255 132224 132255 132255 132223 132254 132254 132223 132255 144446 137093 144187 144113 144187 137094 137095 144446 137093 144187 137094 137096 134390 144113 144196
37
PARTS LIST con't
R16 R17 R30 R32 R33 R34 R36 R37 R38 R39 R41 R42 R43 R45 R46 R48 R50 R51 R52 R53 R54 R55 R56 R57 R58 R59 R60 R62 R63 R65 R67 R70 R71 R72 R77 R79 R82 R83 R84 R85 R86 R88 R90 R93 R101 R103 R104 R105 R106 R109 R111 R114 R119 R122 R123 R124 RT1 RT2
4A 4B 4B
RES MF 100 OHM 1% 1/4W RES MF 100 OHM 1% 1/4W RES MF 475K 1% 1/4W RES MF 47.5K 1% 1/4W RES MF 47.5K 1% 1/4W RES MF 5.11K 1% 1/4W RES 511 OHM 1% 1/4W RES MF 681K 1% 1/4W RES MF 866 OHM 1% 1/4W RES MF 2.21 OHM 1/4W 1% RES WW DUAL .47 OHM 5% 3W RES WW DUAL .47 OHM 5% 3W RES WW DUAL .47 OHM 5% 3W RES WW DUAL .47 OHM 5% 3W RES MF 4.75K 1% 1/4W RES MF 100 OHM 1% 1/4W RES MF 14.7K 1% 1/4W RES MF 221 OHM 1% 1/4W RES MF 267K 1% 1/4W RES MF 221 OHM 1% 1/4W RES MF 3.32K 1% 1/4W RES MF 3.32K 1% 1/4W RES MF 10K 1% 1/4W RES MF 475K 1% 1/4W RES MF 1.1K 1% 1/4W RES MF 2.21 OHM 1/4W 1% RES FP 22 OHM 1/4W 5% RES MF 22.1K 1% 1/4W RES FP 22 OHM 1/4W 5% RES MF 681K 1% 1/4W RES MF 100 OHM 1% 1/4W RES MF 100 OHM 1% 1/4W RES MF 100 OHM 1% 1/4W RES MF 100 OHM 1% 1/4W RES MF 1M 1/4W RES CF 10 OHM 5% 1/2W RES MF 1M 1/4W RES MF 10K 1% 1/4W RES MF 47.5K 1% 1/4W RES MF 1.1K 1% 1/4W RES MF 4.75K 1% 1/4W RES MF 12.1K 1% 1/4W RES MF 1.1K 1% 1/4W RES MF 4.75K 1% 1/4W RES MF 953 OHM 1/4W 1% RES MF 332K 1% 1/4W RES MF 15K 1% 1/4W RES MF 6.49K 1% 1/4W RES MF 475 OHM 1% 1/4W RES CF 0 OHM 5% 1/4W RES MET OX 430 OHM 5% .5W RES CF 10 OHM 5% 1/2W RES MO 4.7 OHM 1W 5% RES MF 47.5K 1% 1/4W RES MF 22.1K 1% 1/4W RES MF 47.5K 1% 1/4W SENSOR THERMAL SENSOR THERMAL
144196 144196 144364 144108 144108 144083 144123 144443 144028 144378 139244 139244 139244 139244 144097 144196 144149 144172 144118 144172 144095 144095 144053 144364 144091 144378 137033 144187 137033 144443 144196 144196 144196 144196 144269 141165 144269 144053 144108 144091 144097 144154 144091 144097 144473 144119 144412 144140 144086 141389 137095 141165 144464 144108 144187 144108 144249 144249
050064 HEATSINK 2-CHANNEL PCB C1 CAP ELECT 47UF 35V C2 CAP ELECT 47UF 35V
066446 066446
C3 C4 C7 C8 C9 C10 C11 C12 C13 C14 C15 C16 C17 C18 C19 C22 C27 C28 C29 C30 C31 C32 C33 C35 C36 C37 C38 C39 C40 C41 C44 C47 C48 C50 C51 C200 D1 D2 D4 D5 D6 D7 D8 D9 D11 D12 D13 D14 IC1 IC2 J1 J2 J3 J4 J5 J6 J8 J9 J10 K1 K2 L1 L2
CAP MONO .1uF 50V 20% Z5U CAP POLYPROP 0.15UF 10% 250VDC CAP MONO 100PF 100V 10% NPO CAP MONO 100PF 100V 10% NPO CAP MONO .01UF 50V 20% X7R CAP ELECT 47UF 35V CAP ELECT 47UF 35V CAP MONO 100PF 100V 10% NPO CAP MONO 100PF 100V 10% NPO CAP MONO 100PF 100V 10% NPO CAP MONO .1uF 50V 20% Z5U CAP MONO .01UF 50V 20% X7R CAP MONO .01UF 50V 20% X7R CAP MONO .01UF 50V 20% X7R CAP MONO 100PF 100V 10% NPO CAP ELECT 220UF 25V CAP MONO 100PF 100V 10% NPO CAP MONO 100PF 100V 10% NPO CAP ELECT 47UF 35V CAP ELECT 47UF 35V CAP ELECT .47UF 50V CAP MONO .1uF 50V 20% Z5U CAP MONO .1uF 50V 20% Z5U CAP ELECT 10UF 100VDC CAP ELECT 10UF 100VDC CAP ELECT 10UF 100VDC CAP ELECT 10UF 100VDC CAP ELECT .47UF 50V CAP ELECT 220UF 50V 20% CAP ELECT 10UF 100VDC CAP ELECT 220UF 25V CAP POLYPROP .047UF 10% 250VDC CAP POLYPROP .047UF 10% 250VDC CAP ELECT 10UF 100VDC CAP ELECT 10UF 100VDC CAP ELECT 10UF 100VDC DIODE SILICON DIODE SILICON DIODE SILICON DIODE SILICON DIODE RECTIFIER DIODE RECTIFIER DIODE SILICON DIODE SILICON DIODE SILICON DIODE SILICON DIODE RECTIFIER DIODE RECTIFIER IC DUAL AMP IC DUAL AMP CONN MALE 9 POS FRICTION LOCK CONN 4 PIN CONN HEADER 2 PIN 0.156 CONN HEADER 2 PIN 0.156 BLADE FASTON .110 BLADE FASTON W/FEET CONN HEADER 2 PIN 0.156 CONN 2 PIN MALE CONN 2 PIN MALE RELAY 24VDC 5A 277VAC RELAY 24VDC 5A 277VAC CHOKE 0.65UH OUTPUT CHOKE 0.65UH OUTPUT
061305 064363 061300 061300 061304 066446 066446 061300 061300 061300 061305 061304 061304 061304 061300 066507 061300 061300 066446 066446 066244 061305 061305 066462 066462 066462 066462 066244 066254 066462 066507 064364 064364 066462 066462 066462 070047 070047 070047 070047 070131 070131 070047 070047 070047 070047 070131 070131 133259 133259 117244 117215 117404 117404 117712 117708 117404 117213 117213 087057 087057 122297 122297
38
MC207
PARTS LIST con't
LD1 LD2 Q1 Q2 Q3 Q4 Q5 Q6 Q7 Q8 Q9 Q10 Q11 Q12 Q13 Q14 Q15 Q16 Q17 Q18 Q19 Q20 Q21 Q22 Q23 Q24 Q25 Q26 Q27 Q28 Q29 Q30 Q31 Q32 Q33 Q34 Q35 Q36 Q37 Q38 Q39 Q40 Q41 Q42 Q43 Q44 Q45 Q46 Q47 Q48 Q49 Q50 Q51 Q52 Q53 Q54 Q55 Q56 Q57 Q58 Q59 Q60 Q61 LDR NETWORK LDR NETWORK TRANSISTOR NPN TRANSISTOR PNP TRANSISTOR NPN TRANSISTOR PNP TRANSISTOR NPN TRANSISTOR NPN TRANSISTOR PNP TRANSISTOR PNP POWER TRANSISTOR NPN POWER TRANSISTOR PNP POWER TRANSISTOR NPN POWER TRANSISTOR NPN TRANSISTOR PNP TRANSISTOR NPN TRANSISTOR PNP TRANSISTOR NPN TRANSISTOR PNP TRANSISTOR NPN TRANSISTOR NPN POWER TRANSISTOR NPN POWER TRANSISTOR PNP POWER TRANSISTOR PNP POWER TRANSISTOR NPN POWER TRANSISTOR NPN POWER TRANSISTOR PNP POWER TRANSISTOR PNP POWER TRANSISTOR PNP TRANSISTOR SI NPN 25V TRANSISTOR PNP POWER TRANSISTOR SI NPN 25V TRANSISTOR NPN TRANSISTOR NPN TRANSISTOR PNP POWER TRANSISTOR NPN TRANSISTOR NPN TRANSISTOR NPN TRANSISTOR NPN TRANSISTOR PNP POWER TRANSISTOR PNP TRANSISTOR PNP TRANSISTOR PNP TRANSISTOR NPN TRANSISTOR PNP TRANSISTOR PNP POWER TRANSISTOR PNP POWER TRANSISTOR PNP TRANSISTOR SI NPN 25V TRANSISTOR PNP TRANSISTOR PNP TRANSISTOR NPN TRANSISTOR NPN TRANSISTOR NPN TRANSISTOR PNP POWER TRANSISTOR PNP TRANSISTOR PNP POWER TRANSISTOR PNP POWER TRANSISTOR SI NPN 25V TRANSISTOR NPN TRANSISTOR NPN TRANSISTOR SI NPN 25V TRANSISTOR SI NPN 25V 144179 144179 132223 132224 132268 132267 132223 132285 132286 132297 132296 132297 132296 132223 132224 132223 132286 132285 132267 132268 132296 132296 132297 132297 132296 132296 132297 132297 132224 132254 132255 132254 132223 132223 132255 132223 132223 132285 132285 132255 132286 132224 132224 132223 132224 132255 132255 132224 132254 132286 132224 132223 132223 132223 132255 132224 132255 132255 132254 132223 132223 132254 132254 Q62 Q63 Q64 R1 R2 R3 R4 R5 R6 R7 R8 R9 R10 R11 R12 R13 R14 R15 R16 R17 R18 R19 R20 R21 R22 R23 R24 R25 R26 R27 R28 R29 R30 R31 R32 R33 R34 R35 R36 R37 R38 R39 R40 R41 R42 R43 R44 R45 R46 R47 R48 R49 R50 R51 R52 R53 R54 R55 R56 R57 R58 R59 R60 TRANSISTOR PNP TRANSISTOR NPN TRANSISTOR PNP POWER RES MF 332 OHM 1% 1/4W RES MET OX 680 OHM 5% .5W RES MF 22.1K 1% 1/4W RES MF 100K 1% 1/4W RES MF 22.1K 1% 1/4W RES MET OX 1.8k 5% .5W RES MET OX 430 OHM 5% .5W RES MF 332 OHM 1% 1/4W RES MET OX 680 OHM 5% .5W RES MF 22.1K 1% 1/4W RES MET OX 1.8k 5% .5W RES MET OX 47 OHM 5% .5W POT TRIM 200 OHM 20% HORIZ AD RES MF 100K 1% 1/4W RES MF 100 OHM 1% 1/4W RES MF 100 OHM 1% 1/4W RES MF 100 OHM 1% 1/4W RES MET OX 47 OHM 5% .5W RES MET OX 1.8k 5% .5W RES MF 332 OHM 1% 1/4W RES MF 22.1K 1% 1/4W RES MET OX 680 OHM 5% .5W RES MET OX 430 OHM 5% .5W RES MET OX 680 OHM 5% .5W RES MF 22.1K 1% 1/4W RES MET OX 1.8k 5% .5W RES MF 332 OHM 1% 1/4W POT TRIM 200 OHM 20% HORIZ AD RES MF 475K 1% 1/4W RES MF 475K 1% 1/4W RES MF 5.11K 1% 1/4W RES MF 47.5K 1% 1/4W RES MF 47.5K 1% 1/4W RES MF 5.11K 1% 1/4W RES MF 47.5K 1% 1/4W RES 511 OHM 1% 1/4W RES MF 681K 1% 1/4W RES MF 866 OHM 1% 1/4W RES MF 2.21 OHM 1/4W 1% RES WW DUAL .47 OHM 5% 3W RES WW DUAL .47 OHM 5% 3W RES WW DUAL .47 OHM 5% 3W RES WW DUAL .47 OHM 5% 3W RES WW DUAL .47 OHM 5% 3W RES WW DUAL .47 OHM 5% 3W RES MF 4.75K 1% 1/4W RES MF 4.75K 1% 1/4W RES MF 100 OHM 1% 1/4W RES MF 1.1K 1% 1/4W RES MF 14.7K 1% 1/4W RES MF 221 OHM 1% 1/4W RES MF 267K 1% 1/4W RES MF 221 OHM 1% 1/4W RES MF 3.32K 1% 1/4W RES MF 3.32K 1% 1/4W RES MF 10K 1% 1/4W RES MF 475K 1% 1/4W RES MF 1.1K 1% 1/4W RES MF 2.21 OHM 1/4W 1% RES FP 22 OHM 1/4W 5% 132224 132223 132255 144446 137093 144187 144113 144187 137094 137095 144446 137093 144187 137094 137096 134390 144113 144196 144196 144196 137096 137094 144446 144187 137093 137095 137093 144187 137094 144446 134390 144364 144364 144083 144108 144108 144083 144108 144123 144443 144028 144378 139244 139244 139244 139244 139244 139244 144097 144097 144196 144091 144149 144172 144118 144172 144095 144095 144053 144364 144091 144378 137033
39
PARTS LIST con't
R61 R62 R63 R64 R65 R66 R67 R68 R69 R70 R71 R72 R73 R74 R75 R76 R77 R78 R79 R80 R81 R82 R83 R84 R85 R86 R87 R88 R89 R90 R91 R92 R93 R94 R95 R96 R97 R98 R99 R100 R101 R102 R103 R104 R105 R106 R107 R108 R109 R110 R111 R112 R113 R114 R115 R119 R120 R122 R123 R124 RT1 RT2 RES MF 100 OHM 1% 1/4W RES MF 22.1K 1% 1/4W RES FP 22 OHM 1/4W 5% RES MF 10K 1% 1/4W RES MF 681K 1% 1/4W RES MF 681K 1% 1/4W RES MF 100 OHM 1% 1/4W RES MF 475K 1% 1/4W RES MF 22.1K 1% 1/4W RES MF 100 OHM 1% 1/4W RES MF 100 OHM 1% 1/4W RES MF 100 OHM 1% 1/4W RES MF 100 OHM 1% 1/4W RES MF 100 OHM 1% 1/4W RES MF 267K 1% 1/4W RES MF 221 OHM 1% 1/4W RES MF 1M 1/4W RES MF 100 OHM 1% 1/4W RES CF 10 OHM 5% 1/2W RES CF 10 OHM 5% 1/2W RES MF 100 OHM 1% 1/4W RES MF 1M 1/4W RES MF 10K 1% 1/4W RES MF 47.5K 1% 1/4W RES MF 1.1K 1% 1/4W RES MF 4.75K 1% 1/4W RES MF 14.7K 1% 1/4W RES MF 12.1K 1% 1/4W RES MF 953 OHM 1/4W 1% RES MF 1.1K 1% 1/4W RES MF 681K 1% 1/4W RES MF 866 OHM 1% 1/4W RES MF 4.75K 1% 1/4W RES MF 47.5K 1% 1/4W RES MF 1.1K 1% 1/4W RES MF 3.32K 1% 1/4W RES 511 OHM 1% 1/4W RES MF 3.32K 1% 1/4W RES MF 221 OHM 1% 1/4W RES MF 1.1K 1% 1/4W RES MF 953 OHM 1/4W 1% RES MF 332K 1% 1/4W RES MF 332K 1% 1/4W RES MF 15K 1% 1/4W RES MF 6.49K 1% 1/4W RES MF 475 OHM 1% 1/4W RES MF 475 OHM 1% 1/4W RES MF 6.49K 1% 1/4W RES CF 0 OHM 5% 1/4W RES MET OX 430 OHM 5% .5W RES MET OX 430 OHM 5% .5W RES MF 1M 1/4W RES CF 10 OHM 5% 1/2W RES CF 10 OHM 5% 1/2W RES MF 1M 1/4W RES MO 4.7 OHM 1W 5% RES MO 4.7 OHM 1W 5% RES MF 47.5K 1% 1/4W RES MF 22.1K 1% 1/4W RES MF 47.5K 1% 1/4W SENSOR THERMAL SENSOR THERMAL 144196 144187 137033 144053 144443 144443 144196 144364 144187 144196 144196 144196 144196 144196 144118 144172 144269 144196 141165 141165 144196 144269 144053 144108 144091 144097 144149 144154 144473 144091 144443 144028 144097 144108 144091 144095 144123 144095 144172 144091 144473 144119 144119 144412 144140 144086 144086 144140 141389 137095 137095 144269 141165 141165 144269 144464 144464 144108 144187 144108 144249 144249
5
050066 DISPLAY PCB C1 CAP ELECT 10UF 50V C2 CAP MPF 0.47UF 5% 50/63VDC C3 CAP MONO .1uF 50V 20% Z5U C4 CAP MONO .1uF 50V 20% Z5U C5 CAP MPF 0.1UF 5% 63VDC C6 CAP ELECT 10UF 50V C7 CAP MPF 0.47UF 5% 50/63VDC C8 CAP MONO .1uF 50V 20% Z5U C9 CAP MONO .1uF 50V 20% Z5U C10 CAP MPF 0.1UF 5% 63VDC C11 CAP ELECT 10UF 50V C12 CAP MPF 0.47UF 5% 50/63VDC C13 CAP MONO .1uF 50V 20% Z5U C14 CAP ELECT 100UF 16V OR 25V C15 CAP MPF 0.1UF 5% 63VDC C16 CAP MONO .1uF 50V 20% Z5U D1 DIODE SILICON D2 DIODE SILICON D3 DIODE SILICON D4 DIODE SILICON D5 DIODE SILICON D6 DIODE SILICON D7 DIODE SILICON D8 DIODE SILICON D9 DIODE SILICON D10 DIODE SILICON D11 DIODE SILICON D12 DIODE SILICON D13 DIODE SILICON D14 DIODE SILICON D15 DIODE SILICON D16 DIODE SILICON D17 DIODE SILICON D18 DIODE SILICON D19 DIODE SILICON D20 DIODE SILICON D21 DIODE SILICON D22 DIODE SILICON D23 DIODE SILICON D24 DIODE SILICON D25 DIODE SILICON D26 DIODE SILICON D27 DIODE SILICON D28 DIODE SILICON D29 DIODE SILICON D30 DIODE SILICON DS1 LED BLUE 5MM HI-INTENSITY DS2 LED BLUE 5MM HI-INTENSITY DS3 LED GREEN 5MM HI-INTENSITY DS4 LED GREEN 5MM HI-INTENSITY DS5 LED RED HIGH EFFICIENCY DS6 LED BLUE 5MM HI-INTENSITY DS7 LED BLUE 5MM HI-INTENSITY DS8 LED GREEN 5MM HI-INTENSITY DS9 LED GREEN 5MM HI-INTENSITY DS10 LED BLUE 5MM HI-INTENSITY DS11 LED BLUE 5MM HI-INTENSITY DS12 LED GREEN 5MM HI-INTENSITY DS13 LED GREEN 5MM HI-INTENSITY DS14 LED GREEN 5MM HI-INTENSITY DS15 LED GREEN 5MM HI-INTENSITY DS16 LED GREEN 5MM HI-INTENSITY
066445 064333 061305 061305 064325 066445 064333 061305 061305 064325 066445 064333 061305 066447 064325 061305 070047 070047 070047 070047 070047 070047 070047 070047 070047 070047 070047 070047 070047 070047 070047 070047 070047 070047 070047 070047 070047 070047 070047 070047 070047 070047 070047 070047 070047 070047 058166 058166 058165 058165 058148 058166 058166 058165 058165 058166 058166 058165 058165 058165 058165 058165
40
MC207
PARTS LIST con't
DS17 DS18 DS19 DS20 DS21 DS22 DS23 J1 J2 J3 J4 J5 J6 J7 J8 J9 J10 J11 J12 Q1 Q2 Q3 Q4 Q5 Q6 Q7 Q8 Q9 Q10 Q11 Q12 Q13 Q14 Q15 Q16 Q17 Q18 Q19 Q20 Q21 Q22 Q23 Q24 Q25 Q26 Q27 Q28 Q29 Q30 Q31 Q32 Q33 Q34 Q35 Q36 R1 R2 R3 R4 R5 R6 R7 R8 LED AMBER LED AMBER LED AMBER LED AMBER LED AMBER LED AMBER LED AMBER CONN MALE 9 POS FRICTION LOCK CONN MALE 9 POS FRICTION LOCK CONN MALE 9 POS FRICTION LOCK CONN MALE 9 POS FRICTION LOCK CONN MALE 9 POS FRICTION LOCK CONN MALE 9 POS FRICTION LOCK CONN 3 POS MALE MTS100 NORM CONN 4 PIN CONN MALE 9 POS FRICTION LOCK CONN 2 PIN MALE CONN 2 PIN MALE CONN 2 PIN MALE TRANSISTOR PNP TRANSISTOR PNP TRANSISTOR NPN TRANSISTOR PNP TRANSISTOR NPN TRANSISTOR PNP TRANSISTOR PNP TRANSISTOR PNP TRANSISTOR PNP TRANSISTOR PNP TRANSISTOR PNP TRANSISTOR PNP TRANSISTOR PNP TRANSISTOR PNP TRANSISTOR PNP TRANSISTOR PNP TRANSISTOR PNP TRANSISTOR PNP TRANSISTOR PNP TRANSISTOR NPN TRANSISTOR NPN TRANSISTOR NPN TRANSISTOR NPN TRANSISTOR NPN TRANSISTOR NPN TRANSISTOR NPN TRANSISTOR NPN TRANSISTOR NPN TRANSISTOR NPN TRANSISTOR NPN TRANSISTOR NPN TRANSISTOR NPN TRANSISTOR NPN TRANSISTOR NPN TRANSISTOR PNP TRANSISTOR PNP RES MF 5.62K OHM 1% 1/4W RES MF 15K 1% 1/4W RES MF 100K 1% 1/4W RES MF 22.1K 1% 1/4W RES MF 10K 1% 1/4W RES MF 100K 1% 1/4W RES MF 5.62K OHM 1% 1/4W POT TRIM 500 OHM 20% HORIZ ADJ 058133 058133 058133 058133 058133 058133 058133 117244 117244 117244 117244 117244 117244 117214 117215 117244 117213 117213 117213 132224 132224 132223 132224 132223 132224 132224 132224 132224 132224 132224 132224 132224 132224 132224 132224 132224 132224 132224 132223 132223 132223 132223 132223 132223 132223 132223 132223 132223 132223 132223 132223 132223 132223 132224 132224 144447 144412 144113 144187 144053 144113 144447 134410 R9 R10 R11 R12 R13 R14 R15 R16 R17 R18 R19 R20 R21 R22 R23 R24 R25 R26 R27 R28 R29 R30 R31 R32 R33 R34 R35 R36 R37 R38 R39 R40 R41 R42 R43 R44 R45 R46 R47 R48 R49 R50 R51 R52 R53 R54 R55 R56 R57 R58 R59 R60 R61 R62 R63 R64 R65 R66 R67 R68 R69 R70 R71 RES MF 221 OHM 1% 1/4W RES MF 1.5K 1% 1/4W POT TRIM 500 OHM 20% HORIZ ADJ RES MF 221 OHM 1% 1/4W RES MF 5.62K OHM 1% 1/4W POT TRIM 500 OHM 20% HORIZ ADJ RES MF 221 OHM 1% 1/4W POT TRIM 500 OHM 20% HORIZ ADJ RES MF 221 OHM 1% 1/4W POT TRIM 500 OHM 20% HORIZ ADJ RES MF 221 OHM 1% 1/4W POT TRIM 500 OHM 20% HORIZ ADJ RES MF 221 OHM 1% 1/4W RES MF 27.4K 1% 1/4W RES MF 365 OHM 1% 1/4W RES MF 1K 1% 1/4W RES MF 5.62K OHM 1% 1/4W RES MF 681 OHM 1% 1/4W RES MF 681 OHM 1% 1/4W RES MF 681 OHM 1% 1/4W RES MF 681 OHM 1% 1/4W RES MF 1M 1/4W RES MF 1M 1/4W RES MF 1M 1/4W RES MF 1M 1/4W RES MF 187K 1% 1/4W RES MF 187K 1% 1/4W RES MF 187K 1% 1/4W RES MF 187K 1% 1/4W RES MF 681 OHM 1% 1/4W RES MF 681 OHM 1% 1/4W RES MF 681 OHM 1% 1/4W RES MF 1M 1/4W RES MF 10K 1% 1/4W RES MF 121K 1% 1/4W RES MF 187K 1% 1/4W RES MF 187K 1% 1/4W RES MF 187K 1% 1/4W RES MF 68.1K 1% 1/4W RES MF 10M 1% 1/4W RES MF 27.4K 1% 1/4W RES MF 2.67K 1% 1/4W RES MF 10.2K 1% 1/4W RES MF 5.62K OHM 1% 1/4W RES MF 221 OHM 1% 1/4W RES MF 4.75M 1/4W 1% RES MF 121K 1% 1/4W POT TRIM 100K OHM 20% RES MF 1.21K 1% 1/4W RES MF 68.1K 1% 1/4W RES MF 10M 1% 1/4W RES MF 27.4K 1% 1/4W RES MF 2.67K 1% 1/4W RES MF 10.2K 1% 1/4W RES MF 5.62K OHM 1% 1/4W RES MF 221 OHM 1% 1/4W RES MF 4.75M 1/4W 1% RES MF 121K 1% 1/4W POT TRIM 100K OHM 20% RES MF 1.21K 1% 1/4W RES MF 68.1K 1% 1/4W RES MF 10M 1% 1/4W RES MF 27.4K 1% 1/4W 144172 144128 134410 144172 144447 134410 144172 134410 144172 134410 144172 134410 144172 144141 144071 144090 144447 144195 144195 144195 144195 144269 144269 144269 144269 144406 144406 144406 144406 144195 144195 144195 144269 144053 144418 144406 144406 144406 144081 144264 144141 144121 144130 144447 144172 144379 144418 134383 144191 144081 144264 144141 144121 144130 144447 144172 144379 144418 134383 144191 144081 144264 144141
41
PARTS LIST con't
R72 R73 R74 R75 R76 R77 R78 R79 R80 R81 R82 R83 R84 R85 R86 R87 R88 R89 R90 R91 R92 R93 R94 R95 U1 U2 U3 U4 U5 U6
6
RES MF 2.67K 1% 1/4W RES MF 10.2K 1% 1/4W RES MF 5.62K OHM 1% 1/4W RES MF 221 OHM 1% 1/4W RES MF 20 OHM 1/4W RES MF 4.75M 1/4W 1% RES MF 121K 1% 1/4W POT TRIM 100K OHM 20% RES MF 1.21K 1% 1/4W RES MF 121K 1% 1/4W RES MF 10K 1% 1/4W RES MF 121K 1% 1/4W RES MF 47.5K 1% 1/4W RES MF 10K 1% 1/4W RES MF 47.5K 1% 1/4W RES MF 47.5K 1% 1/4W RES MF 187K 1% 1/4W RES MF 187K 1% 1/4W RES MF 15K 1% 1/4W RES MF 15K 1% 1/4W RES MF 15K 1% 1/4W RES MF 15K 1% 1/4W RES MF 15K 1% 1/4W RES MF 15K 1% 1/4W IC HEX SCHMITT INVERTER IC AND 3 INPUT X 3 IC DUAL OPERATIONAL AMPLIFIER IC QUAD ANALOG SW IC DUAL OPERATIONAL AMPLIFIER IC DUAL OPERATIONAL AMPLIFIER
144121 144130 144447 144172 144174 144379 144418 134383 144191 144418 144053 144418 144108 144053 144108 144108 144406 144406 144412 144412 144412 144412 144412 144412 133526 133185 133260 133117 133260 133260
050063 CAPACITOR PCB C1 CAP ELECT 67000UF 100V C2 CAP ELECT 67000UF 100V J1 BLADE FASTON W/FEET J2 BLADE FASTON W/FEET J3 BLADE FASTON W/FEET J4 BLADE FASTON W/FEET J5 CONN HEADER 2 PIN 0.156 J6 CONN HEADER 2 PIN 0.156 J7 CONN HEADER 2 PIN 0.156 J8 CONN HEADER 2 PIN 0.156 J9 CONN HEADER 2 PIN 0.156 J10 BLADE FASTON W/FEET J11 BLADE FASTON W/FEET 050062 POWER SUPPLY PCB C1 CAP ELECT 3300UF 35V C2 CAP ELECT 100UF 25V C3 CAP MONO .1uF 50V 20% Z5U C4 CAP MONO .1uF 50V 20% Z5U C5 CAP ELECT 3300UF 35V C6 CAP MONO .1uF 50V 20% Z5U C7 CAP ELECT 100UF 25V C8 CAP ELECT 10UF 50V C9 CAP ELECT 10UF 50V C10 CAP ELECT 22UF 100V D1 DIODE RECTIFIER D2 DIODE RECTIFIER D3 DIODE ZENER 6.2V 5% 500MW D4 DIODE RECTIFIER
066543 066543 117708 117708 117708 117708 117404 117404 117404 117404 117404 117708 117708
D5 D6 D7 F1 IC1 J1 J2 J3 J4 J5 J6 J7 J8 J11 J12 K1 Q1 Q2 Q3 Q4 Q5 Q6 Q7 Q8 Q9 Q10 Q11 R1 R2 R3 R4 R5 R6 R7 R8 R9 R10 R11 R12 U1 U2
DIODE RECTIFIER DIODE ZENER 6.2V 5% 500MW DIODE SILICON FUSE 3.15A SLO-BLO 5X20 IEC IC REGULATOR +5 VOLT BLADE FASTON W/FEET BLADE FASTON W/FEET CONN MALE 9 POS FRICTION LOCK BLADE FASTON W/FEET CONN MALE 7 PIN CONN 4 PIN BLADE FASTON W/FEET BLADE FASTON W/FEET BLADE FASTON W/FEET BLADE FASTON W/FEET RELAY 48VDC TRANSISTOR NPN TRIAC OPTOCOUPLER OPTOCOUPLER OPTICAL SCR OPTOCOUPLER OPTICAL SCR SCR REV BLOCKING THYRISTOR SCR REV BLOCKING THYRISTOR SCR REV BLOCKING THYRISTOR SCR REV BLOCKING THYRISTOR OPTOCOUPLER OPTICAL SCR OPTOCOUPLER OPTICAL SCR TRANSISTOR NPN RES WW 1K 5W 10% RES MF 332K 1% 1/4W RES MF 33.2K 1% 1/4W RES MF 33.2K 1% 1/4W RES MF 22.1K 1% 1/4W RES MF 1.1K 1% 1/4W RES MET OX 47 OHM 5% .5W RES MET OX 47 OHM 5% .5W RES MET OX 47 OHM 5% .5W RES MET OX 47 OHM 5% .5W RES MF 475 OHM 1% 1/4W RES MF 20K 1% 1/4W IC REGULATOR +12 VOLT IC REGULATOR -12V 1A
070131 070085 070047 089098 133093 117708 117708 117244 117708 117217 117215 117708 117708 117708 117708 087049 132223 131024 131025 131025 131026 131026 131026 131026 131025 131025 132223 139121 144119 144015 144015 144187 144091 137096 137096 137096 137096 144086 144104 133119 133138
7
066509 066447 061305 061305 066509 061305 066447 066445 066445 066506 070131 070131 070085 070131
42
MC207
MC207 EXPLODED VIEW
43
44
MC207 EXPLODED VIEW and PARTS LIST
Ref No.
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50
Part No.
016507 094360 004939 018615 101042 094016 098113 018706 100149 101232 018619 104164 049321 092413 005407 017901 017921 094429 146243 021159 104014 124089 017922 005411 102001 050066 112038 112060 005404 100287 126999 005408 101054 078024 078040 017956 050061 166001 050090 166002 094450 050063 005413 102045 100118 018750 084183 050064 101059 112087
Description
GLASS TAPE FOAM 1/2 X 1/2 BRACKET EXTRUSION END CAP 9" SCREW TS 4-40 X 1/2 SLOT FILL TAPE FOAM 1/4 X 1/8 CORD DIAL .027 BLACK BRAID SILK EXTRUSION BOTTOM SCREW MACH 6-32 X 1/4 FL U/H ST SCREW 6-32 X 1/4 PH FLAT EXTRUSION TOP WASHER BLK FELT 1 X 1/4 X 1/16 ASSY KNOB ACETATE FILTER BLUE DISPLAY SUBPANEL LOGO PUSHBUTTON BACKLIGHT LOGO/SELECTOR BACKLIGHT FOAM TAPE WHITE 1/32" THK SWITCH POWER BUSHING SWITCH WASHER INT STAR 3/8 X .507 X .002 METER MC207 METER BACKLIGHT METER PLATE NUT KEP 4-40 CADMIUM PLATE ASSY METER/DISPLAY PCB SPACER STEEL 4 X 3/8L NCKL PLT SPACER 4 X 5/16 STEEL DUST COVER SCREW MACH 8-32 X 3/8 PH TRUSS HD DECAL DUST COVER CHASSIS SCREW TAPTITE 6-32 X 1/4 PH PN BLK GROMMET RUBBER 1" ID GROMMET 3/4" X 1" TRANSFORMER SHIELD POTTED TRANSFORMER POWER DECAL POWER TRANSFORMER CAN POTTED CAPACITOR DECAL CAPACITOR COVER SOUND DAMPING PAD MC207 ASSY CAPACITOR PCB CAPACITOR CLAMP NUT KEP 6-32 X 1/2 PH PN SCREW MACH 6-32 X 1/2 PH PN HEATSINK ISOSTRATE ASSY HEATSINK PCB 2 CH SCREW SM 6 X 5/8 PH PN TYPE A SPACER PCB 1/4" 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 114118 114119 005007 005439 005406 005405 084124 005419 005418 104130 104148 110009 074091 005435 104001 104142 102022 114072 005434 102003 094255 017452 021094 104014 084209 102020 050062 018751 114141 100250 084208 005410 070139 084207 102006 005401 101176 005065 088023 117487 100250 101197 112015 104004 005400 017937 100159 101078 100173 TRANSISTOR CLIP 218 TRANSISTOR CLIP 214 ASSY HEATSINK PCB 1 CH COVER HEATSINK CH 5-6 HEATSINK COVER CENTER COVER HEATSINK CH 1-3 POST BINDING DUAL OUTPUT PLATE TRIPLE OUTPUT PLATE SINGLE WASHER LOCK #10 SPLIT PHOS/BRNZ WASHER FLAT BRASS NUT M5 X 0.8 BRASS W/GOLD PLATE TERMINAL BLOCK AC TERMINAL BRACKET WASHER FLAT STEEL 4 X 9/32 X .025 WASHER LOCK 2.5mm INT STAR ZINC NUT MACH 4-40 X 3/16 X 1/16 RIVET PLASTIC TRANSFORMER BRACKET NUT MACH 6-32 W/LOCK CABLE TIE PANDUIT PLT1M-M KLIP WIRE SPACER 4 X 1/4 3/8 INT STAR WASHER THERMSTRATE MC207 NUT MACH 6-32 SELF LOCK ASSY POWER SUPPLY PCB SUB HEATSINK CLIP RIGHT ANGLE SCREW MACH SEMS 6-32 X 1/4 PH PN ISOSTRATE POWER SUPPLY CHASSIS SUPPORT REAR DIODE BRIDGE RECTIFIER THERMAL PAD 1.25 X 1.25 ALUMINUM NUT MACH 10-32 W/LOCK HEATSINK VENT SCREW TC 6-32 X 1/2 PH PN TYPE F ASSY INPUT PCB CIRCUIT BREAKER 10A 240VAC RECEPTACLE AC LINE SCREW MACH SEMS 6-32 X 1/4 PH PN SCREW HI-LO 4-24 X 3/8 PH RD BLK STANDOFF WASHER LOCK 5 X .255 INT STAR BOTTOM COVER FOOT SCREW MACH 10-32 X 3/4 PH PN ST 8-32 X 5/16 PH PN MS 8-32 X 1/4 PH PN
45
46
MC207
REPACKING INSTRUCTION
47
POWER AMPLIFIER
SERVICE MANUAL
SERIAL NO. VQ1001 And Above
The continuous notice. Because accuracy of the
improvement of its products is the policy of McIntosh Laboratory Incorporated, who reserve the right to improve design without of the constant upgrading of McIntosh products' circuitry and components, the Company cannot insure, and does not warrant, the within schematic material, which is intended for information only. 2 CHAMBERS STREET, BINGHAMTON, NEW YORK 13903 Printed in U.S.A. Part Number 040929
McINTOSH LABORATORY, INC.,