Text preview for : Hitachi P50S601.pdf part of hitachi P50S601 Plasma TV Service Manual - also covers models P50X901 and P50V701
Back to : Hitachi P50S601.part1.rar | Home
PA No. 0226
P50X901/DW3D
P50V701/DW3D
SERVICE MANUAL P50S601/DW3F
NTSC
NT SC D
D 3
P W1 R/C: CLU-4372A / CLU-123S P50X901
R/C: CLU-4374A P50V701
NTSC
AT SC A hassis
C R/C: CLU-4373A P50S601
This ADDENDUM is made due to the new models P50X901 (DW3D), P50V701 (DW3D) and P50S601 (DW3F).
They are different to models P50H401 (DW3A), P50T501 (DW3A) and P50H4011 (DW3A). The Main difference is the
panel, the X/V/S models use "AF1" Plasma Panel and the H/T Models use "AE1" Plasma Panel. Software (Digital Main PWB)
is also different because of Plasma Panel difference.
Refer to Service Manual PA0224 when servicing X/V/S models in regards to other adjustments not covered in this addendum.
This ADDENDUM indicates only the differences and special considerations to be taken when servicing the X/V/S models.
CONTENTS
SPECIFICATIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
ADJUSTMENTS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
BLOCK DIAGRAM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
CONNECTION DIAGRAM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
FINAL WIRING DIAGRAM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
QUICK DISASSEMBLY GUIDE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
CIRCUIT SCHEMATIC DIAGRAMS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
PRINTED CIRCUIT BOARDS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
PARTS LIST . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
PANEL PART S . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29
QUICK REFERENCE PARTS LIST . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 49
CAUTION: These servicing instructions are for use by qualified service personnel only. To reduce the risk of
electric shock do not perform any servicing other than that contained in the operating instructions
unless you are qualified to do so. Before servicing this chassis, it is important that technician
read the "IMPORTANT SAFETY INSTRUCTIONS" in Service Manual PA0224.
SAFETY NOTICE
USE ISOLATION TRANSFORMER WHEN SERVICING
Components having special safety characteristics are identified by a ! on the schematics and on the parts list in this
Service Manual and on the PA0224. Before servicing the chassis, it is important that the service technician read and
follow the "Important Safety Instructions" shown in Service Manual PA0224.
SPECIFICATIONS AND PARTS ARE SUBJECT TO CHANGE FOR IMPROVEMENT
PLASMA DISPLAY PANEL
MAY 2007 HHEA-MANUFACTURING DIVISION
DW3
SPECIFICATIONS
APPEARANCE
Model name Series Name Cabinet Design
P50X901 Director's High Gloss Black/Frame, High Gloss Black/Bezel, High Gloss Hidden/SP
P50S601 UltraVision High Gloss Black/Frame, Black/Bezel, High Gloss Hidden/SP
P50V701 UltraVision High Gloss Black/Frame, Black/Bezel, High Gloss Hidden/SP
SYSTEM
Channel coverage band Reception system
No. Model name VHF(ch) UHF(ch) CATV(ch) NTSC ATSC 64QAM/
(8VSB) 256QAM
1 P50X901 213 1469 A-5A-1, A
I,J W,W+1W+94 X X X
2 P50S601 X X X
3 P50V701 X X X
STRUCTURAL DIMENSIONS
No. Model name WIDTH HEIGHT DEPTH WEIGHT
[mm] [mm] [mm] [kg] Note
Without table
1 P50X901 1250 885(817) 423(134) 50.9(44.8)
top stand.
2 P50S601 1241.4 884(820.2) 422.7(129) 49.8(43.7)
3 P50V701 1241.4 884(820.2) 422.7(129) 49.9(43.8)
EXTERNAL TERMINALS AND JACKS
Model Rear
name A/V S COMP. HDMI M A Subwoofer ANT OPT DV IN POD
IN IN IN OUT OUT OUT IN OUT IEEE 1394 CARD
P50X901 3 1 2 2 1 1 1 1 1
P50S601 3 1 2 2 1 1 1 1
P50V701 3 1 2 2 1 1 1 1 1
Model Front Rear
name A/V S COMP. HDMI Photo Upgrade DV IR OUT IR OUT SWIVEL RS232C
IN IN IN (SD) IN /G-LINK OUT
P50X901 1 1 1 Common 1 1 1 1
P50S601 1 1 1 Common (1: Service) 1 1
P50V701 1 1 1 Common 1 1 1 1
TABLE OF CONTENTS 2
DW3
MAIN FEATURES
P50 P50 P50
No. Feature
X901 S601 V701
1 Panel AF1 AF1 AF1
1920x 1920x 1920x
2 Resolution
1080i 1080i 1080i
Front Filter with ARF Mesh Mesh Mesh
3
(Transparency) (36%) (41%) (36%)
4 Seine2 X X X
5 FRC (FC8) X X
6 One NTSC/ATSC Tuner X X X
7 POD (Point Of Deployment) X X
8 PinP (Digital/External Analog SPLIT) X X
9 3 Picture Mode X X X
10 Color Temperature Mode 4 4 4
11 Color Decoding Adjustment X
12 Color Management Adjustment X
13 7 Mode Aspect Ratio Interchangeable X X X
14 EPG (G-GUIDE) Function X X
15 SD-card Photo Viewer X X
16 Audio Output 10W x2 10W x2 10W x2
17 Swivel Power Power Power
18 AV NET, AV NET Learning X X
19 IR Pass Through X X
20 OSD Design Direc. B C
21 Energy Star
POWER CONSUMPTION
MODEL INDICATED VALUE PST [W] CHASSIS
NAME Max. Rating Max. Rating (Average Rating) Without POD With POD
P50X901 605W 5.7A 364W 0.6W 14W DW3D
P50S601 587W 5.3A 350W 0.6W - DW3F
P50V701 605W 5.7A 364W 0.6W 14W DW3D
SAFETY KEY COMPONENTS
Symbol.No. / P/N / Spec. Model
F9A1 / P#FN00551 / Fuse
P50X901, P50V701, P50S601
10A
TABLE OF CONTENTS 3
DW3
ADJUSTMENTS
NOTE: The next adjustment procedure is only for the P50X901, P50V701 and the P50S601, refer to the service manual PA
no. 0224 for all the other adjustments.
VIDEO COLOR TEMPERATURE ADJUSTMENT - BLACK AND WHITE MODE.
-Preparation
(1) Set the output of signal generator to white raster (Ratio: 100%).
(2) Component signal (480i)
Video level: 0.7Vp-p
SYNC: 0.3Vp-p
Set-up level: 0V
(3) Input white raster signal into COMPONENT input terminal.
(4) Set user control to Day (Dynamic) mode (Picture mode).
(5) Confirm that the mode is set as `Factory setting mode'.
(6) Aspect: 4:3 Expanded.
-Adjustment
(1) Perform the following adjustment with the remote control.
(2) Set the CRT color analyzer (CA-100) at the center of the panel.
(3) Ensure that the adjustment parameters R/G/B DRIVE(B/W) are all set as FF.
(4) After receiving the PC signal, reduce the value of two (or only one) of the RGB adjustment
parameters step down two (or one) among adjustment R/G/B DRIVE(B/W) and adjust the value
shown below.
Specification
Video Color temperature (B/W)
x = 0.335 ± 0.005
y = 0.343 ± 0.005
(Color temp5400K)
At least one of the data should be FF.
-Remarks
(1) Color temperature should be adjusted under the condition in which the screen is the brightest,
thus the initial value for adjustment is set at its maximum.
(2) Adjustment is made by reducing brightness only. Reduce the brightest color for adjustment.
(3) Video color temperature & Adjustment number are the same, but addresses in the memory are
different, thus there's no problem.
(4) When this adjustment item is done through MMC slot, Sniffer Jig must be inserted after the set is
switched to Sniffer Mode. (the PC would have trouble if this sequence is not kept.)
TABLE OF CONTENTS 4
DW3
BLOCK DIAGRAM
For P50X901, P50V701 and P50S601.
P50X901, P50V701 only.
Scan Driver
Scan Driver
Y SUS
X-SUS
Address Driver
Driver Controller Data Controller
PDP LOGIC
Panel LVDS Receiver Signal Controller
Module
Vcego RGB
AC
Vsago (LVDS)
Inlet
Power
CPUgo
Supply PDPgo
Filter PWB FAN FAN FAN FAN
Unit
Fuse Main
Power SW
FC8 PWB
FC8 DDR2 DC-DC
Conv.
AC-CLK
Main-Digital PWB Terminal PWB
Sub PLD DC-DC Digital/ Reg.
Power2 Demodulator
Micro (Nereid) Conv. Analog For FAN
Power1 Tuner
Seine2 Seine2 VCXO Video Audio
POD PWB A-chip D-chip PLL SW SW
PLD
(Oberon) Audio Audio
DDR2 A/V
DSP ADC Pin Jack
POD
Card I/F
Audio Digital Audio IR-Blaster RS-232C
UEI
DC-DC PWM Audio DAC Driver
(POD-Vcc) Amplifier
Motor OPT-Audio
HDMI
Driver Output
Remote
Control
IR LED Key A/V HDMI SD/MMC
Receiver SW Pin Jack I/F Card I/F
LED PWB Control PWB SD PWB
Speaker R Speaker L
Stand
TABLE OF CONTENTS 5
DW3
Power system block diagram
AC120V P50X901, P50V701 only.
PDP Panel Module
Filter PWB Power Supply Unit Vs
Va
Vcc
AC +16V
SW
+15V +10.5V +5.6V
STBY+5V
+3.3V Main-Digital PWB
Reg.
+12V +3.3V +9V +1.3V +1.8V +3.3V +3.3V Sub
Reg. Reg. Reg. DC-DC DC-DC DC-DC Reg. MICRO
Bus Digital Audio Audio Audio +2.5V +1.3V
SW Audio Amp. DSP PWM DAC Reg. Reg. +2.5V
Reg.
Seine2-D
+5V +3.3V Seine2-D DDR2
Reg. Reg. +1.5V
Reg.
Audio +5V
ADC Reg. +3.3V +1.0V +5V Seine2-A
Reg. DC-DC +3.0V Reg.
Reg.
+3.3V +3.3V IR IR-Blaster
Reg. Reg. +1.8V Mod. Driver
Reg. +9V +9V +2.5V
Reg. Reg. Reg.
Cable Key Bus Flash Memory PLD
Equalizer ROM SW Demodulator LPF Buffer VCXO PLL (OneNand) (Nereid)
+3.3V +3.3V Vari.
Reg. DC-DC Reg.
+30V +5V +5V +5V +5V +9V
Reg. Reg. Reg. Reg. Reg. Reg.
POD- POD-
+2.5V Vcc Vpp
Reg.
Tuner OOB AGC AV SW
Buffer +1.2V POD PWB
I2C OPT Reg.
Level shift Output
AV-Control
Swivel Oberon2 FC8 PWB
Vari. Motor
Terminal PWB Reg. Driver
+1.8V +1.05V
+3.3V x2 x2 Swivel DC-DC DC-DC
Reg. FAN FAN Stand
+1.8V
x2 x2
Reg.
+1.05V +3.3V
IR-receiver I2C Clock SD Reg. Reg.
LED Buffer Buffer MMC Buffer
FC8- LVDS
LED PWB SD PWB Control PWB DDR2 FC8 SW
TABLE OF CONTENTS 6
DW3
CONNECTIONS DIAGRAM
For P50S601.
Power Supply Unit PDP Module
CONNECTION DIAGRAM CN64 CN23
VH-10P VH-10P
Va 1 1 Va
N.C. 2 2 N.C.
Vcc 3 3 Vcc
GND 4 4 GND
GND 5 5 GND
GND 6 6 GND
AC INLET FILTER PWB N.C. 7 7 N.C.
Vs 8 8 Vs
PFAC PPU1 CN61 Vs 9 9 Vs
VT-2P VT-2P VT-2P Vs 10 10 Vs
L 2 AC(L) AC(L) 1 1 AC(L)
AC IN N 1 AC(N) AC(N) 2 2 AC(N) CN68 CN8
PH-9P PH-9P
FG Vcc 1 1 Vcc
GND 2 2 GND
N.C. 3 3 N.C.
GND 4 4 GND
Vra 5 5 Vra
Vrs 6 6 Vrs
Vcego 7 7 Vcego
Vsago 8 8 Vsago
N.C. 9 9 N.C.
Main Digital board
CN63 PPM1 EC01 CN1
EH-8P ZH-08H FI-RE51S FI-RE51S
STBY+5V 1 1 STBY+5V GND 51 1 GND
GND 2 2 GND SDA 50 2 SDA
N.C. 3 3 N.C. SCL 49 3 SCL
PoWERoFF 4 4 PoWERoFF GND 48 4 N.C.
ACCLoCK 5 5 ACCLoCK PNL_RX 47 5 N.C.
PoWER1 6 6 PoWER1 iRQ 46 6 IRQOUT
PoWER2 7 7 PoWER2 PNL_TX 45 7 N.C.
N.C. 8 8 PNLoN PDWN 44 8 PDWN
PNLRST 43 9 CPUGO
PNLoN 42 10 PDPGO
CNPPS PPM2 GND 41 11 GND
EH-15P DF3D-15H TA1- 40 12 RA0-
+5.6V 1 1 +5.6V TA1+ 39 13 RA0+
+5.6V 2 2 +5.6V TB1- 38 14 RA1-
+5.6V 3 3 +5.6V TB1+ 37 15 RA1+
GND 4 4 GND TC1- 36 16 RA2-
GND 5 5 GND TC1+ 35 17 RA2+
GND 6 6 GND GND(LVDS) 34 18 GND
+10.5V 7 7 +10.5V TCLK1- 33 19 RACLK-
GND 8 8 GND TCLK1+ 32 20 RACLK+
+16V 9 9 +16V GND 31 21 GND
GND 10 10 GND TD1- 30 22 RA3-
GND 11 11 GND TD1+ 29 23 RA3+
GND 12 12 GND TE1- 28 24 RA4-
+15V 13 13 N.C. TE1+ 27 25 RA4+
+15V 14 14 N.C. GND 26 26 GND
+15V 15 15 N.C. GND 25 27 GND
TA2- 24 28 RB0-
PPM2
PPM3 TA2+ 23 29 RB0+
PA-6V
DF3D-15H TB2- 22 30 RB1-
1 GND TB2+ 21 31 RB1+
2 GND TC2- 20 32 RB2-
3 GND TC2+ 19 33 RB2+
4 +15V GND(LVDS) 18 34 GND
5 +15V TCLK2- 17 35 RBCLK-
6 +15V TCLK2+ 16 36 RBCLK+
GND 15 37 GND
TD2- 14 38 RB3-
TD2+ 13 39 RB3+
TE2- 12 40 RB4-
TE2+ 11 41 RB4+
GND 10 42 GND
TERMINAL PWB GND 9 43 GND
GND 8 44 GND
GND 7 45 GND
PSM PMS1 GND 6 46 GND
501497-160VS 501493-160VP N.C. 5 47 N.C.
SWIVEL PWB 1 GND GND 2 PNL_MoDE 4 48 N.C.
3 +5.6V D+3.3V 4 PNL_P2 3 49 N.C.
PWT PTW 5 +5.6V D+3.3V 6 PNL_P0 2 50 N.C.
52418-05HS-D 53290-05VP-D 7 +5.6V D+3.3V 8 PNL_CLK 1 51 N.C.
GND 1 1 GND 9 +5.6V GND 10
MoToR+ 2 2 MoToR+ 11 GND GND 12
MoToR- 3 3 MoToR- 13 SBY+5.0V SBY+3.3V 14
JoiNTDET 4 4 JoiNTDET 15 GND GND 16
SW_CoM 5 5 SW_CoM 17 +16V +10V 18
19 GND SWiVEL_G 20
21 N.C. MAiN_Y/V 22
23 iRoUT GND 24
25 N.C. MAiN_Y_E 26
FAN 27 N.C. GND 28
29 FiN MAiN_PB 30
PFA1 31 RiN GND 32
ZH-03H 33 CPDET MAiN_PR/C 34
VCC 1 1 VCC 35 SWVLDET GND 36
LoCK 2 2 LoCK 37 GND SUB_Y/V 38
GND 3 3 GND 39 AEP_R GND 40
41 AEP_L S/PDiT 42
43 GND GND 44
45 ASP_R SD_Yo 46
47 ASP_L GND 48
FAN 49 GND SD_Co 50
51 N.C. GND 52
PFA2 53 GND FAN_EN 54
ZH-03H 55 SEL_L_S N.C. 56 Speaker (L)
VCC 1 1 VCC 57 SEL_R_S GND 58
LoCK 2 2 LoCK 59 GND N.C. 60
GND 3 3 GND 61 SCL1_3V_100 N.C. 62
63 SDA1_3V_100 GND 64
65 GND N.C. 66
67 SCL_TU N.C. 68 PSPK
69 SDA_TU GND 70 PA-04V
FAN 71 ANA/DIGI SEL_L_M 72 Lout-P 1
73 GND SEL_R_M 74 Lout-N 2
PFB1 75 IF_AGC GND 76 Rout-P 3 Speaker (R)
ZH-04H 77 GND UATXD3 78 Rout-N 4
VCC 1 1 VCC 79 FDC_AGC UARXD3 80
LoCK 2 2 LoCK 81 GND GND 82
GND 3 3 GND 83 FAT_INP SDA2_3V_100 84
4 N.C. 85 GND GND 86
87 GND SCL2_3V_100 88
89 FAT_INN GND 90
91 GND N.C. 92
FAN 93 FDC_INP N.C. 94
95 GND PoWER_2_Td 96
PFB2 97 FDC_INN N.C. 98
ZH-04H 99 GND GND 100
VCC 1 1 VCC 101 FS_OUTP FAN_CONT 102
LoCK 2 2 LoCK 103 GND N.C. 104
GND 3 3 GND 105 PoWERoFF GND 106
4 N.C. 107 GND N.C. 108
109 FS_OUTN N.C. 110
111 GND N.C. 112
113 GND N.C. 114
115 FAN_DET GND 116
117 GND N.C. 118
119 MTV_AFC GND 120
121 SIG_DET N.C. 122
123 N.C. GND 124
125 PNLoN N.C. 126
127 GND GND 128
129 REC_MUTE N.C. 130
131 GND GND 132
133 N.C. N.C. 134
135 N.C. GND 136
137 GND AVCTXD 138 SD PWB
139 N.C. AVCRXD 140
141 N.C. AVCCTS_N 142
143 N.C. AVCRTS_N 144 CNPPS
PSD
PDS PSD
PDS
PPM2
145 N.C. GND 146 EH-15P
501331-12V
501568-12H DF3D-15H
501331-12V
501568-12H
147 N.C. N.C. 148 SDCLK 1 1 SDCLK
149 N.C. N.C. 150 SDCMD 2 2 SDCMD
151 N.C. N.C. 152 GND 3 3 GND
153 N.C. N.C. 154 SDDAT0 4 4 SDDAT0
155 GND N.C. 156 SDDAT1 5 5 SDDAT1
157 N.C. N.C. 158 SDDAT2 6 6 SDDAT2
159 GND N.C. 160 SDDAT3 7 7 SDDAT3
CONTROL PWB +5.6V 8 8 +5.6V
SDCD 9 9 SDCD
SDWP 10 10 SDWP
PCST PTC
PTF GND 11 11 GND
GH-14V ZH-13H
GH-10V D+3.3V 12 12 D+3.3V
V4_CY 1 1 V4_CY
GND 2 2 GND
V4_Y 3 3 V4_Y P403
PH01 PH01
P403
GND 4 4 GND FI-RE31S
FIR-31V FIR-31H
FI-RE31S
V4_C 5 5 V4_C VBUS 31 1 VBUS
GND 6 6 GND VBUS 30 2 VBUS
V4_L 7 7 V4_L VBUS 29 3 VBUS
V4_R 8 8 V4_R GND 28 4 GND
GND 9 9 GND PTF
PSC D+ 27 5 D+
T+9V 10 10 T+9V ZH-13H
GH-04H D- 26 6 D-
PWRKEY 11 1 PWRKEY GND 25 7 GND
ADKEY0 12 2 ADKEY0 +3.3V 24 8 +3.3V
ADKEY1 13 3 ADKEY1 +5V 23 9 +5V
GND 14 4 GND WP 22 10 WP
HPD 21 11 HPD
DDCPOW 20 12 DDCPOW
GND 19 13 GND
SDA 18 14 SDA
SCL 17 15 SCL
LED PWB ACK 16 16 ACK