Text preview for : CDX-CA650X_CA660X_CA690X VER 1.1.pdf part of SONY CDX-CA650X/CA660X/CA690X Ver1.1
Back to : CDX-CA650X_CA660X_CA690X | Home
CDX-CA650X/CA660X/CA690X
SERVICE MANUAL
Ver 1.1 2001. 07
US Model Canadian Model
CDX-CA650X/CA660X
E Model
CDX-CA690X
Photo: CDX-CA660X
· The tuner and CD sections have no adjustments. AUDIO POWER SPECIFICATIONS (US Model) POWER OUTPUT AND TOTAL HARMONIC DISTORTION 23 watts per channel minimum continuous average power into 4 ohms, 4 channels driven from 20 Hz to 20 kHz with no more than 5% total harmonic distortion. CD player section
Signal-to-noise ratio 90 dB Frequency response 10 20,000 Hz Wow and flutter Below measurable limit Laser Diode Properties (US, Canadian Model) Material GaAlAs Wavelength 780 nm Emission Duration Continuous Laser output power Less than 44.6 µW* * This output is the value measured at a distance of 200 mm from the objective lens surface on the Optical Pick-up Block.
Model Name Using Similar Mechanism CD Drive Mechanism Type Optical Pick-up Name
NEW MG-393X-121//K KSS-720A
SPECIFICATIONS
Power amplifier section
Outputs Speaker outputs (sure seal connectors) Speaker impedance 4 8 ohms Maximum power output 50 W × 4 (at 4 ohms)
General
Outputs Audio outputs Power Antenna relay control lead Power amplifier control lead Telephone ATT control lead Bass ±10 dB at 62 Hz (US, Canadian model) Bass ±8 dB at 100 Hz (E model) Treble ±10 dB at 16 kHz (US, Canadian model) Treble ±8 dB at 10 kHz (E model) +8 dB at 100 Hz +2 dB at 10 kHz 12 V DC car battery (negative ground) Approx. 178 × 50 × 176 mm (7 1/8 × 2 × 7 in.) (w/h/d) Approx. 182 × 53 × 161 mm (7 1/4 × 2 1/8 × 6 3/8 in.) (w/h/d) Approx. 1.2 kg (2 lb. 10 oz.) Parts for installation and connections (1 set) Front panel case (1) Card remote commander RM-X114
Inputs Tone controls
Tuner section
FM Tuning range 87.5 107.9 MHz (US, Canadian model) FM tuning interval (E Model): 50 kHz/200 kHz switchable 87.5 108 MHz (at 50 kHz step) 87.5 107.9 MHz (at 200 kHz step) Antenna terminal External Antenna connector Intermediate frequency 10.7 MHz/450 kHz Usable sensitivity 8 dBf Selectivity 75 dB at 400 kHz Signal-to-noise ratio 66 dB (stereo), 72 dB (mono) Harmonic distortion at 1 kHz 0.6% (stereo), 0.3% (mono) Separation 35 dB at 1 kHz Frequency response 30 15,000 Hz AM Tuning range 530 1,710 kHz (US, Canadian model) AM tuning interval (E model): 9 kHz/10 kHz switchable 531 1,602 kHz (at 9 kHz step) 530 1,710 kHz (at 10 kHz step) Antenna terminal External Antenna connector Intermediate frequency 10.7 MHz/450 kHz Sensitivity 30 µV Loudness (E model) Power requirements Dimensions Mounting dimensions Mass Supplied accessories
Note
This unit cannot be connected to a digital preamplifier or an equalizer. Design and specifications are subject to change without notice.
FM/AM COMPACT DISC PLAYER
9-870-259-12
2001G0400-1 © 2001. 7
Sony Corporation
e Vehicle Company Shinagawa Tec Service Manual Production Group
1
CDX-CA650X/CA660X/CA690X
SERVICE NOTES CAUTION
Use of controls or adjustments or performance of procedures other than those specified herein may result in hazardous radiation exposure. If the optical pick-up block is defective, please replace the whole optical pick-up block. Never turn the semi-fixed resistor located at the side of optical pick-up block.
TABLE OF CONTENTS 1. GENERAL
Location of controls ................................................................. 3 Getting Started ......................................................................... 3 CD Player ................................................................................ 4 Radio ....................................................................................... 5 Other Functions ....................................................................... 6 Connection Diagram ................................................................ 7
2. DISASSEMBLY
2-1. Sub Panel (CD) Assy ........................................................... 8 2-2. CD Mechanism Block ......................................................... 8 2-3. Main Board ......................................................................... 8 2-4. Heat Sink (Main) ................................................................. 9 2-5. Chassis (T) Sub Assy .......................................................... 9 2-6. Lever Section .................................................................... 10 2-7. Servo Board ....................................................................... 10 2-8. Arm Roller Assy ................................................................ 11 2-9. Floating Block ................................................................... 11 2-10. Optical Pick-up Block ....................................................... 12
optical pick-up block
3. DIAGRAMS
semi-fixed resistor
NOTES ON HANDLING THE OPTICAL PICK-UP BLOCK OR BASE UNIT The laser diode in the optical pick-up block may suffer electrostatic breakdown because of the potential difference generated by the charged electrostatic load, etc. on clothing and the human body. During repair, pay attention to electrostatic breakdown and also use the procedure in the printed matter which is included in the repair parts. The flexible board is easily damaged and should be handled with care. NOTES ON LASER DIODE EMISSION CHECK The laser beam on this model is concentrated so as to be focused on the disc reflective surface by the objective lens in the optical pickup block. Therefore, when checking the laser diode emission, observe from more than 30 cm away from the objective lens. Notes on Chip Component Replacement · Never reuse a disconnected chip component. · Notice that the minus side of a tantalum capacitor may be damaged by heat.
3-1. IC Pin Descriptions ........................................................... 13 3-2. Block Diagram CD Section ........................................... 15 3-3. Block Diagram Tuner Section ....................................... 16 3-4. Block Diagram Display Section .................................... 17 3-5. Circuit Boards Location .................................................... 17 3-6. Printed Wiring Boards CD Mechanism Section ............ 18 3-7. Schematic Diagram CD Mechanism Section ................ 20 3-8. Printed Wiring Boards Main Section ............................ 21 3-9. Schematic Diagram Main Section (1/2) ........................ 22 3-10. Schematic Diagram Main Section (2/2) ........................ 23 3-11. Printed Wiring Board Relay Section ............................. 24 3-12. Schematic Diagram Relay Section ................................ 25 3-13. Schematic Diagram Display Section ............................. 26 3-14. Printed Wiring Board Display Section .......................... 27
4. EXPLODED VIEWS
4-1. 4-2. 4-3. 4-4. 4-5. Chassis Section ................................................................. 30 Front panel Section ........................................................... 31 CD Mechanism Section (1) ............................................... 32 CD Mechanism Section (2) ............................................... 33 CD Mechanism Section (3) ............................................... 34
5. ELECTRICAL PARTS LIST ........................................ 35
SAFETY-RELATED COMPONENT WARNING!! COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.
ATTENTION AU COMPOSANT AYANT RAPPORT À LA SÉCURITÉ!! LES COMPOSANTS IDENTIFIÉS PAR UNE MARQUE 0 SUR LES DIAGRAMMES SCHÉMATIQUES ET LA LISTE DES PIÈCES SONT CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT. NE REMPLACER CES COMPOSANTS QUE PAR DES PIÈCES SONY DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL OU DANS LES SUPPLÉMENTS PUBLIÉS PAR SONY.
2
CDX-CA650X/CA660X/CA690X SECTION 1 GENERAL
This section is extracted from instruction manual.
3
CDX-CA650X/CA660X/CA690X
4
CDX-CA650X/CA660X/CA690X
5
CDX-CA650X/CA660X/CA690X
6
CDX-CA650X/CA660X/CA690X
7
7
CDX-CA650X/CA660X/CA690X SECTION 2 DISASSEMBLY
Note : This equipiment can be removed usiing the following procedure.
2-2. CD MECHANISM BLOCK
Set
Sub Panel (CD) Assy
CD Mechanism Block
Main Board
Heat Sink (Main)
7 bracket (CD)
Chassis (T) Sub Assy
Lever Section Servo Board
Arm Roller Assy
5 CD mechanism block
6 PTT 2.6x6
Floating Block Assy
Optical Pick-up Block
2 PTT 2.6x6
3 1 PTT 2.6x6
4 CNP701
Note : Follow the disassembly procedure in the numerical order given.
2-1. SUB PANEL (CD) ASSY
2-3. MAIN BOARD
5 MAIN board
4 6 sub panel (CD) assy two claws
3 screw (+BTT)
4 screws (+BTT)
2 PTT 2.6x8
2 PTT 2.6x6
3 claw
5 CNP802 1 PTT 2.6x6
1 PTT 2.6x8
8
8
CDX-CA650X/CA660X/CA690X
2-4. HEAT SINK (MAIN)
7 heat sink (main)
6 PTT 2.6x8
5 PTT 2.6x8 4 PTT 2.6x8
3 PTT 2.6x12 2 PTT 2.6x8 1 PTT 2.6x8
2-5. CHASSIS (T) SUB ASSY
2 P 2x3 3 P 2x3
1 Unsolder the lead wires.
4 chassis (T) sub assy
black red white
9
CDX-CA650X/CA660X/CA690X
2-6. LEVER SECTION
5 guide (disc)
6 lever (R) 3 tension spring (LR) 7 lever (L) 1 special screw 2 IN SELF SW board
4 claws
2-7. SERVO BOARD
7 special screw 6 special screw 3 Removal the solders. 2 CN2
1 CN3 4 P 2x3 8 SERVO board
5 loading motor assy
10
CDX-CA650X/CA660X/CA690X
2-8. ARM ROLLER ASSY
· When installing, take note of the positions arm (roller) and washers. (Fig. 1)
3 retaing ring (RA) shaft retainer (roller) retaing ring (RA) arm washer 4 shaft retainer (roller) arm washer shaft retainer (roller)
Fig. 1
5 shaft roller assy 2 arm (roller)
1 tension spring (RA)
2-9. FLOATING BLOCK ASSY
6 floating block assy
7 compression spring (FL)
1 tension spring (KF1) 8 compression spring (FL)
4 Fit lever (D) in the direction of the arrow.
5 Turn loading ring in the direction of the arrow. 2 damper (T) 3 damper (T)
11
CDX-CA650X/CA660X/CA690X
2-10. OPTICAL PICK-UP BLOCK
1 P 2x3
2 sled motor assy
3 optical pick-up block
12
CDX-CA650X/CA660X/CA690X SECTION 3 DIAGRAMS
3-1. IC PIN DESCRIPTION
· IC801 MN101C49KTG1 (SYSTEM CONTROL) Pin No. Pin Name I/O Pin Description 1 VREF -- Ground for A/D converter power supply 2 3 4 5 6 7, 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 VSM NIL KEYIN1 KEYIN0 RC IN0 NIL DSTSEL VREF+ VDD OSCOUT OSCIN VSS XIN XOUT MMOD LCDSO LCDCE LCDCKO CD SO/TSO CD SI/TSI CD CKO/TCKO SYSRST BUS ON KEYACK NIL BU IN SIRCS CD SELFSW CD PACK NIH RESET NOSE SW BEEP NCO TESTIN ACCIN NCO TELATT NIH BUSSO BUSSI BUSCKO I2CSIO NCO I2CCKO NCO TUNON PW ON I I I I I I I -- -- O I -- I O I O O O O I O O O I I I I I I I I I O O I I O I I O I O I/O O O O O O S-meter voltage detection signal input from tuner unit (TU601) Connect to ground. Key signal input Key signal input Rotary commander key signal input from remote in jack (CNP801) Not used. (Connect to ground.) Destination set up detection signal input ("L": CDX-CA650X/CA660X, "H": CDX-CA690X) A/D converter power supply Power supply (+5 V) input pin High speed clock signal output (18.432 MHz) High speed clock signal input (18.432 MHz) Ground for power supply Low speed clock signal input (32.768 kHz) Low speed clock signal output (32.768 kHz) Memory mode select signal input (Input to "Low" (single chip mode).) (Connect to ground.) LCD serial data signal output to LCD driver (IC501) LCD chip enable signal output to LCD driver (IC501) LDC serial clock signal output to LCD driver (IC501) CD servo IC serial data signal output CD servo IC serial data signal input CD servo IC serial clock signal output System reset signal output to bus interface (IC803) Bus on signal output to bus interface (IC803) Key acknowledge detection signal input Not used. (Connect to ground.) Back up current detection signal input Remote signal input from remote control receiver (IC502) CD mechanism self load position detection switch signal input from self switch (SW2) CD text pack sync signal input from CD servo (IC1) Connect to power supply. microcomputer reset signal input from reset IC (IC802) "L": reset Front panel attachment detection signal input from nose detect switch (S902) "L": ON Beep signal output to power amp (IC404) Not used. (Open) Test mode detection signal input Accessory power supply detection signal input Not used. (Open) Telephone ATT detection signal input Connect to power supply. Sony-Bus serial data signal output to bus interface (IC803) Sony-Bus serial data signal input from bus interface (IC803) Sony-Bus serial clock signal output to bus interface (IC803) I2C bus serial data signal input/output Not used. (Open) I2C bus serial clock signal output Not used. (Open) Tuner power supply control signal output to power supply (IC901) System power supply control signal output to power supply (IC901)
13
CDX-CA650X/CA660X/CA690X
Pin No. 51 52 53 54 55 56 57 58 59 60 61 62 63 64, 65 66 67 68 69 70 71 75 76 77, 78 79 80 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100
Pin Name CD TSTB CD RFOK CD XRST CD A0 CD STB CD XTALEN CD LIMIT CD PH1 CD DSW CD INSW/PH2 CD PH3 CD LM LO CD LM EJ NCO AMPATT AMPON CDM ON ATT VOLATT NCO 4VPRE NCO CD ON NCO EE SIO EE CKO NCO FLASH W NCO XKEYON DOORIND ILLON DOOR SW DAVSS RE IN1 RE IN0 RC IN NCO DAVDD
I/O O I O O O O I I I I I O O O O O O O O O I O O O I/O O O I O O O O I -- I I I O --
Pin Description CD text parameter strob signal output to servo IC (IC1) RF OK signal input from servo IC (IC1) Reset signal output to servo IC (IC1) Command/parameter identification signal output to servo IC (IC1) "L": Command, "H": Parameter Data strob signal output to servo IC (IC1) Crystal oscillation control signal output to servo IC (IC1) CD Mechanism in-limit switch signal input from limit switch (SW3) CD Mechanism PH1 detection signal input Not used in this set. CD Mechanism down switch signal input from down switch (SW4) CD Mechanism disc-in switch detection signal input from disc-in switch (SW1) CD Mechanism PH3 detection signal input Not used in this set. CD Mechanism loading motor control signal output to loading motor drive (IC2) CD Mechanism eject motor control signal output to loading motor drive (IC2) Not used. (Open) Power amp ATT control signal output to power amp (IC404) Power amp standby control signal output to power amp (IC404) CD mechanism deck power supply control signal output System ATT control signal output Electrical volume ATT control signal output to electrical volume (IC401) Not used. (Open) Pre-out menu selection set up signal input CA650X/CA690X: "H", CA660X: "L" Not used. (Open) CD on signal output "H": Play, "L": Loading or standby Not used. (Open) EEPROM serial data signal input/output EEPROM serial clock signal output Not used. (Open) Flash microcomputer write detection signal input "L": Write mode Not used. (Open) Key power supply control signal output Sub panel power supply control signal output Illumination power supply control signal output Front panel open/close detection signal input "L": Close, "H": Open Ground pin Rotary encoder signal input from rotary encoder (RE501) Rotary encoder signal input from rotary encoder (RE501) Rotary commander shift key signal input from remote in jack (CNP801) "L": Shift key on Not used. (Open) Power supply pin
14
CDX-CA650X/CA660X/CA690X
3-2. BLOCK DIAGRAM -- CD SECTION --
OPTICAL PICK-UP KSS-720A
RF AMP,DIGITAL SERVO DIGITAL SIGNAL PROCESSOR IC1
A
82
A
(Page 16) TUNER SECTION
RF EQ EFM DEMOD D/A CONV LOUT 16 ROUT 12 PACK 52 TSTB 56 TSCK 55 TSI 54 SI 8 SO 7 SCK 6 STB 5 AO 4 RST 3 RFOK CDL R-CH
C B
83 84
C B
A
SYSTEM CONTROL IC801(1/3) 31 CD PACK 51 TSTB
D
I-V CONV.
D 85
DSUB CODE PROCESS
21 CD_SO/TSO 22 CD_SI/TSI 23 CD_CKO/TCKO 55 CD_TSTB 54 CD_AO 53 CD_XRST
FORCUS ERROR I/F E F PD E 87 86 F PD TRACKING ERROR APC SERVO CTL
2
52 CD_RFOK
97
OSC LD DRIVE Q1 LD
XTALEN
9
56 CD_XTALEN
BUS BUFFER IC803 D804 BU IN 28 10 3 BATT DET Q803
SD
TD
FD
98
MD
LD
BATT
62 63 64 65 FOCUS/TRACKING COIL DRIVE SLED/SPINDLE/LOADING MOTOR DRIVE IC2 FCSFOCUS COIL FCS+ FOCUS COIL DRIVE
23
24 SYS RST 24 13 2
X1 16.9344MHz FD SW1 (DISC IN) SW2 (SELF) SW3 (LIMIT) SW4 (DOWN) 60 CD_INSW/PH2
BUS ON 25
12
1 8
15 16
26
BUS SO 42
9 6
6 5 4 7 4
3 2 1
30 CD_SELF SW
TRK+ TRACKING COIL TRK-
BUS SI 43
8
17 18
TRACKING COIL DRIVE
23
TD
57 CD_LIMIT
BUS CKO 44
11
CNJ801 (BUS CONTROL IN)
59 CD_DSW IC802 D901 RESET 33 1 RESET 2 BU 5V
M902 (SLED)
M
SLSL+
13 14
SLED MOTOR DRIVE SPINDLE MOTOR DRIVE
5
SD
M901 (SPINDLE)
M
SP+ SP-
11 12
6
MD
S901 RESET
M903 (LOADING)
M
LD9 LD+ 10
LOADING MOTOR DRIVE
1 2
LOAD EJECT
62 CD_LM LO 63 CD_LM EJ POWER CONTROL Q908, 909 POWER CONTROL Q907 REG Q910 BATT
68 CDM ON
A5V AU5V D5V DR6V
REG Q911
· Signal path :CD
79 CD ON
15
15
CDX-CA650X/CA660X/CA690X
3-3. BLOCK DIAGRAM -- TUNER SECTION --
PJ401 (2/2) L AUDIO OUT FRONT R-CH PJ401 (1/2) L BUS AUDIO IN R R-CH ELECTRONIC VOLUME IC401 4 AUX LCH CDL 43 MD LCH 12 MPXI 9 AM CA650X/CA690X 13 14 19 20 17 LEVEL MPIN SDA SCL EXA ATT OUT RL 27 5 OUT FL 28 3 L-CH AMP IC301 7 7 1 2 L-CH AMP IC431 12 Q102 MUTE Q101 MUTE CA650X/CA690X 13 CA660X 5 3 L-CH AMP IC405 7 1 CA660X 11 16 AUX 4 STBY 22 MUTE 4 FR+ 12 FRR-CH 3 RR+ 11 RR9 7 2 RL+ 10 RL12 CA650X/CA690X CA650X/CA690X R-CH POWER AMP IC404 5 3 CNP902 1 FL+ 9 FLR L AUDIO OUT REAR R
(Page 15)
TUNER UNIT TU601 PJ601 (ANTENNA)
A
CD SECTION
2 ANTFM 1 ANTAM
MPX 10 AM DET 8
R-CH MUTE CONT Q912,913
SYSTEM CONTROL IC801 (2/3) ATT BEEP AMP ON AMP ATT TEL ATT 69 35 67 66 40
D908 DELAY BATT
70 VOL ATT
ACC IN 38 TEST IN 37 S-METER 14 I2C SDA 12 I2C SCL 13 2 VSM 45 I2C SIO 47 I2C CKO
ACC CHECK Q902, D934, 935 POWER SUPPLY IC901 AMP +B 6
TEL ATT Q901
13 ATT 7 ACC 15 TEST D919 5 AMP R D907 6 ANT R 8 GND
(FREQUENCY ) SW802 SELECT
FM 50K AM 9K FM 200K AM 10K CA690X CA650X/ CA660X 2 8.7V ON 3 5.6V ON 4 STB 9 DSTSEL
ANT +B 8
BATT VCC 7 19 17 F901 10A 18 16 +B (BATT)
TUN ON 49 E2PROM SDA 17 E2PROM SCL 18 86 EE SIO 87 EE CKO PW ON 50
BU+B COM 8V TU 5.6V TU 8.7V
5 9 10 11
BU 5V COM 8V TU 5.6V TU 8.7V
· Signal path :FM :AM :CD
16
16
CDX-CA650X/CA660X/CA690X
3-4. BLOCK DIAGRAM -- DISPLAY SECTION --
3-5. CIRCUIT BOARDS LOCATION
SYSTEM CONTROL IC801 (3/3) KEY MATRIX LSW501-510, LSW513-522 5 KEY IN0
LCD DRIVE IC501 80 SEG2 · | 1 SEG66 | 64 COM1 65 | | COM4 68
IN SELF SW board
SL SW board
4 KEY IN1
LCD SO 18 LCD CKO 20 LCD CE 19
78 DATA 77 CLK 76 CE
LCD LCD500
RELAY board
D801 KEY ACTIVE Q801 26 KEY ACK 91 AD ON D802 DOOR IND 92 CNP801 (REMOTE IN) 98 RC IN1 6 RC IN0 IC502 IR RECEIVE 29 SIRCS DOOR IND DRIVE Q914, 915
tuner unit (TU601)
LED905,LSW916
MAIN board
ROTARY ENCODER RE501 97 RE IN0 96 RE IN1 ILL ON 93 POWER CONT Q906 SWITCH Q905 LSW501-510 LSW513-522
( KEY ILLUMINATION )
BATT OSC OUT 12 OSC IN 13
DISPLAY board SERVO board
S902 (NOSE DET) X802 32.768kHz
34 NOSE SW 15 XIN 16 XOUT
( LCD BACK ) LIGHT
LED510-513
X801 18.43MHz
· Waveforms -- Servo Board --
(MODE: CD PLAY) -- Main Board --
1
4.4Vp-p
1
3.8Vp-p
16.9344MHz
18.43MHz
IC1
wd
(XTAL)
IC801
qs
(OSCOUT)
2
4.8Vp-p 34msec
2
5Vp-p
30.5µsec
IC1
ts
(PACK)
IC801
qh
(XOUT)
3
1.2Vp-p
IC1
uj
(RFO)
4
0V Approx. 1Vp-p
IC1
oa
(FEO)
5
0V Approx. 400mVp-p
IC1
od
(TEO)
17
17
CDX-CA650X/CA660X/CA690X
3-6. PRINTED WIRING BOARDS -- CD MECHANISM SECTION --
THIS NOTE IS COMMON FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS. (In addition to this, the necessary note is printed in each block.) for schematic diagram: · All capacitors are in µF unless otherwise noted. pF: µµF 50 WV or less are not indicated except for electrolytics and tantalums. · All resistors are in and 1/4 W or less unless otherwise specified. · % : indicates tolerance. f · : internal component. · C : panel designation. Note: Note: The components identi- Les composants identifiés par fied by mark 0 or dotted une marque 0 sont critiques line with mark 0 are criti- pour la sécurité. Ne les remplacer que par une cal for safety. Replace only with part piéce portant le numéro spécifié. number specified. · A : B+ Line. · Power voltage is dc 14.4V and fed with regulated dc power supply from ACC and BATT cords. · Voltages are taken with a VOM (Input impedance 10 M). Voltage variations may be noted due to normal production tolerances. · Waveforms are taken with a oscilloscope. Voltage variations may be noted due to normal production tolerances. · Circled numbers refer to waveforms. · Signal path. F : FM f : AM J : CD for printed wiring boards: · X : parts extracted from the component side. · Y : parts extracted from the conductor side. · x : parts mounted on the conductor side. a · : Through hole. · : Pattern from the side which enables seeing. (The other layer's patterns are not indicated.) Caution: Pattern face side: (Side B) Parts face side: (Side A)
Parts on the pattern face side seen from the pattern face are indicated. Parts on the parts face side seen from the parts face are indicated.
18
18
CDX-CA650X/CA660X/CA690X
· Semiconductor Location Ref. No. IC1 IC2 Q1 Location D-2 G-2 B-3
(Page 21)
19
19
CDX-CA650X/CA660X/CA690X
· Refer to page 17 for Waveforms. 3-7. SCHEMATIC DIAGRAM -- CD MECHANISM SECTION -- · Refer to page 28 for IC Block Diagrams.
IC B/D
IC B/D (Page 22)
Note: · Voltage is dc with respect to ground under no-signal conditions. no mark : CD PLAY
20
20
CDX-CA650X/CA660X/CA690X
3-8. PRINTED WIRING BOARD -- MAIN SECTION --
· Semiconductor Location Ref. No. Location Ref. No. D941 D601 J-1 D801 J-6 (IC301) D802 K-7 (IC302) D803 I-12 IC401 D804 I-12 IC404 D805 D-12 (IC405) D806 D-12 (IC406) D807 D-12 (IC431) D809 K-4 (IC441) D811 K-4 IC801 D812 K-3 IC802 D813 K-3 IC803 D814 K-3 IC901 D815 J-2 D816 K-3 Q101 D817 K-2 Q102 D818 K-4 Q201 D901 H-12 Q202 D902 D-11 Q801 D906 D-11 Q803 D907 F-11 Q901 D908 D-9 Q902 D909 D-9 Q905 D911 A-9 Q906 D912 A-9 Q907 D913 C-10 Q908 D914 C-10 Q909 D915 A-9 Q910 D916 A-9 Q911 D917 B-10 Q912 D918 A-10 Q913 D919 F-11 Q914 D920 C-11 Q915 D931 B-14 (Q922) D932 E-12 (Q923) (D933) D-7 (Q924) D934 D-10 D935 D-10 ( ): CDX-CA660X only
Location G-10 H-5 I-5 I-3 A-7 D-5 D-5 G-4 E-4 I-9 J-12 H-11 G-13 C-4 B-3 B-5 B-4 K-11 I-11 E-10 D-11 J-13 K-13 H-12 D-13 E-13 B-13 F-10 D-8 D-8 H-13 H-13 D-7 D-7 D-7
(Page 24)
(Page 19)
21
21
CDX-CA650X/CA660X/CA690X
· Refer to page 17 for Waveforms. 3-9. SCHEMATIC DIAGRAM -- MAIN SECTION (1/2) -- · Refer to page 28 for IC Block Diagrams.
IC B/D
IC B/D
IC B/D
(Page 23) (Page 20)
Note: · Voltage is dc with respect to ground under no-signal (detuned) condition. no mark : FM ( ) : AM < > : CD PLAY
22
22
CDX-CA650X/CA660X/CA690X
3-10. SCHEMATIC DIAGRAM -- MAIN SECTION (2/2) -- · Refer to page 29 for IC Block Diagrams.
IC B/D
(Page 22)
IC B/D
(Page 25)
Note: · Voltage is dc with respect to ground under no-signal (detuned) condition. no mark : FM
23
23
CDX-CA650X/CA660X/CA690X
3-11. PRINTED WIRING BOARD -- RELAY SECTION --
(Page 21)
(Page 27)
24
24
CDX-CA650X/CA660X/CA690X
3-12. SCHEMATIC DIAGRAM -- RELAY SECTION --
(Page 26)
(Page 23)
25
25
CDX-CA650X/CA660X/CA690X
3-13. SCHEMATIC DIAGRAM -- DISPLAY SECTION --
(Page 25)
Note: · Voltage is dc with respect to ground under no-signal (detuned) condition. no mark : FM
26
26
CDX-CA650X/CA660X/CA690X
3-14. PRINTED WIRING BOARD -- DISPLAY SECTION --
· Semiconductor Location Ref. No. Location (D501) A-11 (D502) A-10 (D503) B-10 (D504) B-6 (IC501) IC502 LED510 LED511 LED512 LED513 ( B-9 A-5 B-12 A-12 B-5 B-5
(Page 24)
) : SIDE B
27
27
CDX-CA650X/CA660X/CA690X
· IC BLOCK DIAGRAMS IC1 µPD63711GC-8EU
7D DAC2 7C DAC1 7E DAC3 7F DAC0 ATEST TEST1 TEST0
IC2 BA5810FP
IC431, 441 NJM2160AM-TE2
DGND
AGND
DVDD
AGCO
AVDD
PACK
TSCK
TSTB
EFM
ASY
75
74
73
72
71
70
69
68
67
66
65
64
63
62
61
60
59
58
57
56
55
54
53
TSO
C3T
MD
TSI
RFI
SD
TD
FD
FWD
1 LOADING PRE FWD REV X3 POWER SAVE
+
28 BIAS
VCC1 1 IN1 2 BUFFER VCCL
52
51
REV 2
27 OPIN4+ 26 OPIN4
16 C1+ 15 C1
+
AGCI 76 RFO 77 EQ2 78 EQ1 79 RF- 80 AGND 81 A 82 C 83
EFM COMPARATOR EFM D/A MEMORY PROCESSOR 16K SRAM
MICROCOMPUTER INTERFACE
SVR1 3 BUFFER
50 C2D3
LDCONT PS IN1 IN2
3 4 5
LIFT AMP
ERROR CORRECTION PROCESSOR
CD-TEXT DECODER SUB-CODE PROCESSOR
49 C2D2 48 C2D1 47 C1D2 46 C1D1 45 DGND
25 OPOUT4 24 OPIN3+ 23 OPIN3
REFERENCE
AUTO GAIN CONTROLLER
FD/TD/SD/MD CONTROLLER
6
VCCL SIGNAL AMP
7.5k
7.5k
16k
16k
PREVCC (PRE.LOADING)
+
+
7.5k
FEOFS SVDRAM TEOFS MULTIPLIER SVROM SVCRAM ROM DECODER
EFM DEMODULATOR
7.5k
ADDER
DIGITAL PLL
44 PLCK 43 MIRR/WFCK
PREVCC
7 POWVCC12 (CH1.CH2)
16k
16k
B 84 D 85 F 86 E 87 AVDD 88 REFOUT 89 FE- 90 DEFECT FEO 91 SWITCH EFM RF AMP BLOCK
TIMING GENERATOR
42 RFCK 41 LOCK 40 DVDD 39 TSOI
POWVCC
8
+
+
VOL
9
POWVCC34 (CH3,CH4) 20 POWVCC
VOL+ 10 10k 10k
CLV PROCESSOR DIGITAL AUDIO INTERFACE D/A INTERFACE CIRCUIT DE-EMPHASIS CIRCUIT
38 C16M 37 DGND 36 TX 35 HOLD/WDCK
VO2 11 VO2+ 12
10k
LEVEL SHIFT 10k 10k
LEVEL SHIFT 10k 10k
+
+
DEFECT COMPARATOR
10k VO1 13 VO1+ 14 10k 10k
A/D CONVERTER
OUTPUT PROCESSOR
TE- 92 TEO 93 TE2 94 TEC 95 AGND 96 PD 97 LD 98
FOK A3T MIRR FEO TEO
RFENV MIRENV TRACKING REGISTER FOCUS REGISTER
34 LRCK 33 LRCKIN 32 SCKO 31 SCKIN 30 DOUT 29 DIN 28 FLAG
LEVEL SHIFT 10k
LEVEL SHIFT 10k
+
+
COMPARATOR
OCTUPLED OVERSAMPLING DIGITAL FILTER NOISE SHAVER NOISE SHAVER
OUTPUT BUFFER OUTPUT BUFFER PN 99 AVDD 100 MICROCOMPUTER INTERFACE SCF OSC 27 EMPH 26 DVDD
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
DAGND
DAGND
DAVDD
DAVDD
DGND
DVDD
REGC
XTALEN
XGND
RFOK
XVDD
ROUT
LOUT
XTAL
XTAL
SCK
RST
STB
SO
SI
R+
A0
R
L+
L
IC901 BA4908-V3
REGULATOR
OVER VOLTAGE PROTECT + + + +
1
2 3 4
5
6
7
8
9
MODE2 MODE1 STB
VDD
ANT
AMP
COM
28
28
GND
NC
VCC
AM
FM
14 GND1 13 OUT1
INM1 4
22 OPOUT3
VCCR
CH1-4 MUTE
INM2 5
21 MUTE
12 OUT2 SIGNAL AMP REFERENCE 11 GND2
19 GND
BUFFER
10k
VCCR LIFT AMP 10 C29 C2+
SVR2 6
18 VO3 17 VO3+
+ +
IN2 7 VCC2 8
BUFFER
10k
10k
16 VO4 15 VO4+
+ +
10k
IC803 BA8270F-E2
BUS ON SWITCH RESET SWITCH BATTERY SWITCH 14 VCC
BUS ON 1
RST 2
BATT 3
13 12 11 10
RST BUS ON CLK IN BU IN
CLK 4 VREF 5 DATA 6 GND 7
9 DATA IN 8 DATA OUT
10
11
12
CDX-CA650X/CA660X/CA690X
IC401 TDA7406T
MIXINFL MIXINRL MIXINRR MIXINFR OUTSW OUTFR OUTRR SAOUT
23 MONO FADER CREF
33 32 31 30 29
28 27 MIXER
OUTFL OUTRL
ACINL
26 25
24
SOFT STEP FADER
SOFT STEP FADER
SOFT STEP FADER
SUPPLY
22 VDD
SUB WOOFER FILTER OUTPUT SELECTOR SWIN 34 ACINR 35
21 SACLK 20 SCL 19 SDA 18 GND
17 ATT ACOUTR 36 SWACOUT 37 AC OUTL 38 HIGH PASS
IIC-BUS
QUAL.
16 QUAL
A/D 7BAND EQUALIZER CREF 39 SOFT STEP VOLUME SOFT MUTE DIGITAL CONTROL HIGH OUT S&H 25kHz LP AM/FM NOISE BLANKER DEMODULATOR +STEREO ADJUST +STEREO BLEND BEEP IN GAIN + AUTO ZERO MULTI PATH DETECTOR 15 MP OUT 14 MP IN PULSE FORMER
LOUDNESS SPECTRUM ANALIZER
PILOT CANCELLATION PIL, DET PAUSE PLL 13 LEVEL
MAIN SOURCE SELECTOR CDR CDL MDR MDL TAPEL 40 41 42 43 44
MIXING SELECTOR
86kHz LP STD IN GAIN
INPUT MULTIPLEXER
12 AUX1
1 2 3 4 5
6 7 8
9
10
11
TAPE R FDR+ FDL FDL+ PAUSE
PHONE TIM NAVI
AM/MPX2
CMPX
AMIF
29
CDX-CA650X/CA660X/CA690X SECTION 4 EXPLODED VIEWS
NOTE: · The mechanical parts with no reference number in the exploded views are not supplied. · Items marked "*" are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. · -XX and -X mean standardized parts, so they may have some difference from the original one. · Color Indication of Appearance Parts Example : KNOB, BALANCE (WHITE) ... (RED) R R Parts Color Cabinet's Color · Accessories and packing materials and hardware (# mark) list are given in the last of this parts list. The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. Les composants identifiés par une marque 0 sont critiques pour la sécurité. Ne les remplacer que par une piéce portant le numéro spécifié.
4-1. CHASSIS SECTION
11 9
MG-393X-121//K #2
10
#1 #1 #1
12 8 13 17 14 16 15
#1 #3 #1 #1 #1
TU601
4 3 1 2 5
#2 #5 #2 #5
#6
12 20 7 6
#2
F901
19
#5
#2
#2
18
Ref. No. 1 2 * 3 4 5 6 7 * 8 9 * 10 * 11 12
Part No. X-3380-007-1 3-041-039-01 1-679-988-11 X-3376-686-1 3-030-909-01 3-713-786-51 X-3376-687-1 3-224-309-01 1-776-207-82 3-024-285-01
Description PANEL ASSY (CD), SUB BUTTON (EJECT) RELAY BOARD GEAR ASSY DAMPER, OIL SCREW +P 2X3 LOCK ASSY COVER CORD (WITH CONNECTOR) (POWER) CUSHION (RUBBER)
Remark
Ref. No. * 13 * 13 13 14 * 15 * 16 * 17 * 18 19 * 20 F901 TU601
Part No. A-3283-087-A A-3283-091-A A-3283-156-A 3-226-766-01 3-019-565-01 3-041-261-01 3-224-313-01 3-224-308-01 3-035-250-01 X-3376-689-1
Description MAIN BOARD, COMPLETE (CA660X) MAIN BOARD, COMPLETE (CA690X) MAIN BOARD, COMPLETE (CA650X) HEAT SINK (MAIN) BRACKET (IC) BRACKET (TR) HEAT SINK (REG) CHASSIS SCREW (LOCK) BRACKET (GEAR) ASSY
Remark
3-041-173-01 BRACKET (CD) 3-922-535-11 SCREW (+BTT)
1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE) 10A A-3220-738-A TUNER UNIT (TUX-020)
30
CDX-CA650X/CA660X/CA690X
4-2. FRONT PANEL SECTION
66
#4 #4
64 63
65
#4
not supplied (DISPLAY board)
62 61 60
LCD500
59
57 58 55
56
51
52 53
54
Ref. No. 51 52 53 54 54 54 55 56 57 58
Part No. 3-224-293-11 3-224-300-11 3-038-318-01 X-3379-986-1 X-3379-993-1 X-3380-014-1 3-224-299-01 3-224-298-01 3-224-297-01 3-224-296-01
Description BUTTON (CROSS) BUTTON (OPEN) SPRING (RELEASE) PANEL (S) ASSY, FRONT (CA650X) PANEL (S) ASSY, FRONT (CA660X) PANEL (S) ASSY, FRONT (CA690X) BUTTON (1-6) BUTTON (OFF) BUTTON (MANU) BUTTON (EQ)
Remark
Ref. No. * 59 60 * 61 * 62 63 64 65 66 LCD500
Part No. 3-224-306-01 1-694-787-11 3-224-307-01 X-3379-981-1 3-224-292-11 3-224-295-01 X-3379-982-1 3-231-599-01 1-804-294-11
Description PLATE (LCD), GROUND CONDUCTIVE BOARD, CONNECTION SHEET (DIFFUSION) HOLDER (LCD) ASSY KNOB (VOL) BUTTON (SOURCE) PANEL ASSY, FRONT BACK CUSHION (1-6) DISPLAY PANEL, LIQUID CRYSTAL
Remark
31
CDX-CA650X/CA660X/CA690X
4-3. CD MECHANISM SECTION (1) (MG-393X-121//K)
#8
102
#8
104
103 107
109 101
116 115 114 106 114
105
105 113
C
C
M903
111 110
#9
#7
112
#8
108
#7
Ref. No. * 101 102 103 104 105 106 107 108 109
Part No. 1-676-709-11 3-040-039-01 3-040-038-01 3-040-050-01 3-040-022-01 3-040-044-01 3-040-067-01 A-3301-980-A 3-040-037-01
Description IN SELF SW BOARD CHASSIS (T) SPRING (LR), TENSION LEVER (L) RETAINER (ROLLER), SHAFT ROLLER (S) LEVER (R) SHAFT ROLLER ASSY GUIDE (DISC)
Remark
Ref. No. 110 * 111 112 113 114 115 116 M903
Part No. 3-040-040-01 A-3283-048-A 3-221-779-01 3-040-034-01 3-040-042-01
Description ARM (ROLLER) SERVO BOARD, COMPLETE BRACKET (MOTOR) SPRING (RA), TENSION WASHER
Remark
3-043-880-01 RING (RA), RETAINING 3-044-206-11 SCREW, SPECIAL A-3315-039-A MOTOR SUB ASSY, LO (LOADING)
32
CDX-CA650X/CA660X/CA690X
4-4. CD MECHANISM SECTION (2) (MG-393X-121//K)
154
151
156
157 157 158
D
164 160 155 162 165 163 153
161
D
159 152 152
152
Ref. No. 151 152 153 154 155 156 157 158
Part No. 3-040-025-01 3-040-031-01 3-040-056-01 3-040-024-01 3-040-053-01
Description ARM, CHUCKING DAMPER (T) LEVER (D) RETAINER (DISC) RING, LOADING
Remark
Ref. No. 159 160 161 162 163 164 165
Part No. A-3307-422-A 3-040-059-01 3-040-057-01 3-040-058-01 3-040-052-01
Description CHASSIS (M) COMPLETE ASSY SPRING (TR), TENSION LEVER (LOCK) GEAR (MDL) WHEEL (U), WORM
Remark
3-040-026-01 SPRING (CH), TENSION 3-040-032-01 SPRING (FL), COMPRESSION 3-040-033-01 SPRING (KF1), TENSION
3-040-051-01 LEVER (TR) 3-040-054-01 WHEEL (LW), WORM
33
CDX-CA650X/CA660X/CA690X
4-5. CD MECHANISM SECTION (3) (MG-393X-121//K)
201
M901
207 202
M902
208
203
#10
209 210
#8
204
205 206 211
#8
The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified.
Les composants identifiés par une marque 0 sont critiques pour la sécurité. Ne les remplacer que par une piéce portant le numéro spécifié.
Ref. No. 201 202 203 204 205 206
Part No. X-3378-480-1 3-040-029-01 3-040-045-01 3-040-194-01 A-3301-983-A
Description CHASSIS (OP) ASSY (including M901) SPRING (SL), TORSION BASE (DRIVING) GEAR (MIDWAY) SHAFT (FEED) ASSY
Remark
Ref. No. 207 * 208 209 0 210 211 M902
Part No. 1-677-182-11 1-676-708-11 3-909-607-01 8-820-103-03 3-040-030-01
Description MOTOR FLEXIBLE BOARD SL SW BOARD SCREW PICK-UP, OPTICAL KSS-720A/K1RP SPRING (FEED), PLATE
Remark
1-676-707-11 PICK-UP FLEXIBLE BOARD
A-3301-985-A MOTOR ASSY, SLED (SLED)
34
CDX-CA650X/CA660X/CA690X SECTION 5 ELECTRICAL PARTS LIST
NOTE: · Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. · -XX and -X mean standardized parts, so they may have some difference from the original one. · RESISTORS All resistors are in ohms. METAL:Metal-film resistor. METAL OXIDE: Metal oxide-film resistor. F:nonflammable · Items marked "*" are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. · SEMICONDUCTORS In each case, u : µ, for example: uA.. : µA.. uPA.. : µPA.. uPB.. : µPB.. uPC.. : µPC.. uPD.. : µPD.. · CAPACITORS uF : µF · COILS uH : µH
DISPLAY
The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. Les composants identifiés par une marque 0 sont critiques pour la sécurité. Ne les remplacer que par une piéce portant le numéro spécifié. When indicating parts by reference number, please include the board.
Ref. No.
Part No.
Description DISPLAY BOARD **************
Remark
Ref. No.
Part No.
Description
Remark
* *
1-694-787-11 CONDUCTIVE BOARD, CONNECTION 3-224-306-01 PLATE (LCD), GROUND 3-224-307-01 SHEET (DIFFUSION) < CAPACITOR > C531 C532 C533 C534 C535 C536 1-107-826-11 1-115-467-11 1-164-227-11 1-107-826-11 1-107-826-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.1uF 0.22uF 0.022uF 0.1uF 0.1uF 680PF 10% 10% 10% 10% 10% 10% 16V 10V 25V 16V 16V 50V
LSW506 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (., SEEK , m) LSW507 1-771-883-11 SWITCH, TACTILE (WITH LED) (SOUND) LSW508 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (ENTER) LSW509 1-771-883-11 SWITCH, TACTILE (WITH LED) (DSPL) LSW510 1-771-883-11 SWITCH, TACTILE (WITH LED) (LIST) LSW513 LSW514 LSW515 LSW516 LSW517 LSW518 LSW519 LSW520 LSW521 LSW522 1-771-476-11 1-771-883-11 1-771-500-21 1-771-500-21 1-771-883-11 1-771-883-11 1-771-883-11 1-771-883-11 1-771-883-11 1-771-883-11 SWITCH, KEYBOARD (WITH LED) (SOURCE) SWITCH, TACTILE (WITH LED) (MODE) SWITCH, KEYBOARD (WITH LED) (EQ7) SWITCH, KEYBOARD (WITH LED) (POS) SWITCH, TACTILE (WITH LED) (6) SWITCH, TACTILE (WITH LED) (5) SWITCH, TACTILE (WITH LED) (4) SWITCH, TACTILE (WITH LED) (3) SWITCH, TACTILE (WITH LED) (2/SHUF) SWITCH, TACTILE (WITH LED) (1/REP) < RESISTOR > R501 R502 R503 R504 R505 R506 R507 R508 R509 R510 R514 R515 R516 R517 R518 R519 R520 R521 R522 R523 R524 R525 R526 R527 R528 R532 R533 1-216-819-11 1-216-819-11 1-216-819-11 1-216-821-11 1-216-823-11 1-216-823-11 1-216-825-11 1-216-827-11 1-216-829-11 1-216-831-11 1-216-819-11 1-216-819-11 1-216-819-11 1-216-821-11 1-216-823-11 1-216-823-11 1-216-825-11 1-216-827-11 1-216-829-11 1-216-831-11 1-216-864-11 1-216-817-11 1-216-817-11 1-216-817-11 1-216-817-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP SHORT METAL CHIP METAL CHIP METAL CHIP METAL CHIP 680 680 680 1K 1.5K 1.5K 2.2K 3.3K 4.7K 6.8K 680 680 680 1K 1.5K 1.5K 2.2K 3.3K 4.7K 6.8K 0 470 470 470 470 2.2K 330 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W
1-162-963-11 CERAMIC CHIP < CONNECTOR >
CN501
1-794-065-12 PLUG, CONNECTOR 14P < DIODE >
D501 D502 D503 D504
8-719-056-93 8-719-068-68 8-719-069-56 8-719-069-54
DIODE DIODE DIODE DIODE < IC >
UDZ-TE-17-18B SDZ6V2WA UDZS-TE17-6.2B UDZS-TE17-5.1B
IC501 IC502
8-759-826-21 IC LC75874W 8-749-017-35 IC KSM-401N < LIQUID CRYSTAL DISPLAY >
LCD500 1-804-294-11 DISPLAY PANEL, LIQUID CRYSTAL < DIODE > LED510 LED511 LED512 LED513 8-719-078-19 8-719-078-19 8-719-078-19 8-719-078-19 LED LED LED LED LWA673-R1S2 (LCD BACK LIGHT) LWA673-R1S2 (LCD BACK LIGHT) LWA673-R1S2 (LCD BACK LIGHT) LWA673-R1S2 (LCD BACK LIGHT)
< SWITCH > LSW501 1-771-883-11 SWITCH, TACTILE (WITH LED) (OFF) LSW502 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (MENU) LSW503 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (DISC/PRESET +) LSW504 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (DISC/PRESET ) LSW505 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (>, SEEK +, M) 5% 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W
1-216-825-11 METAL CHIP 1-216-815-11 METAL CHIP
35
CDX-CA650X/CA660X/CA690X DISPLAY
Ref. No. R534 R535 R536 R537 R538 R539 R540 R541 R542 R543 R544 R545 R546 R547 R548 R549 R550 R551 R552 R553 R554 R555 R556 R557 Part No. 1-216-857-11 1-216-829-11 1-216-829-11 1-216-829-11 1-216-841-11 1-216-821-11 1-216-821-11 1-216-821-11 1-216-818-11 1-216-818-11 1-216-864-11 1-216-864-11 1-216-823-11 1-216-823-11 1-216-823-11 1-216-823-11 1-216-823-11 1-216-823-11 1-216-818-11 1-216-818-11 1-216-817-11 1-216-817-11 1-216-817-11 1-216-817-11
IN SELF SW
Description METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP SHORT SHORT METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 1M 4.7K 4.7K 4.7K 47K 1K 1K 1K 560 560 0 0 1.5K 1.5K 1.5K 1.5K 1.5K 1.5K 560 560 470 470 470 470
MAIN
Remark 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W Ref. No. C121 C122 C123 C131 C132 C133 C143 C201 C211 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W C212 C213 C221 C222 C223 C231 C232 C233 C243 C311 Part No. Description 10uF 10uF 0.47uF 100PF 1uF 1uF 1uF 1uF 10uF 10uF 0.47uF 10uF 10uF 0.47uF 100PF 1uF 1uF 1uF 1uF 1uF 20% 20% 10% 5% 10% 10% 10% 10% 20% 20% 10% 20% 20% 10% 5% 10% 10% 10% 10% 10% Remark 16V (CA660X) 16V 10V 50V 6.3V 6.3V (CA660X) 6.3V (CA660X) 6.3V 16V (CA660X) 16V 10V 16V (CA660X) 16V 10V 50V 6.3V 6.3V (CA660X) 6.3V (CA660X) 6.3V (CA660X) 6.3V (CA660X) 1-124-233-11 ELECT 1-124-233-11 1-125-891-11 1-162-927-11 1-125-837-11 ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
1-125-837-11 CERAMIC CHIP 1-125-837-11 CERAMIC CHIP 1-125-837-11 CERAMIC CHIP 1-124-233-11 ELECT 1-124-233-11 ELECT 1-125-891-11 CERAMIC CHIP 1-124-233-11 ELECT 1-124-233-11 ELECT 1-125-891-11 CERAMIC CHIP 1-162-927-11 CERAMIC CHIP 1-125-837-11 CERAMIC CHIP 1-125-837-11 CERAMIC CHIP 1-125-837-11 CERAMIC CHIP 1-125-837-11 CERAMIC CHIP 1-125-837-11 CERAMIC CHIP
< ROTARY ENCODER > C312 RE501 1-418-818-21 ENCODER, ROTARY ************************************************************* C321 * 1-676-709-11 IN SELF SW BOARD **************** < SWITCH > SW2 1-529-566-41 SWITCH, PUSH (1 KEY) (SELF) SW3 1-529-566-41 SWITCH, PUSH (1 KEY) (DISC IN) ************************************************************* * * A-3283-087-A MAIN BOARD, COMPLETE (CA660X) A-3283-091-A MAIN BOARD, COMPLETE (CA690X) A-3283-156-A MAIN BOARD, COMPLETE (CA650X) ********************* 3-019-565-01 3-041-261-01 3-226-766-01 3-224-313-01 7-685-535-19 BRACKET (IC) BRACKET (TR) HEAT SINK (MAIN) HEAT SINK (REG) SCREW +BTP 2.6X10 TYPE 2 N-S C322 C402 C402 C403 C404 C405 C430 C433 * * * C435 C440 C443 7-685-793-09 SCREW +PTT 2.6X8 (S) 7-685-795-09 SCREW +PTT 2.6X12 (S) < CAPACITOR > C455 C101 C111 C112 C113 1-125-837-11 CERAMIC CHIP 1-124-233-11 ELECT 1-124-233-11 ELECT 1-125-891-11 CERAMIC CHIP 1uF 10uF 10uF 0.47uF 10% 20% 20% 10% 6.3V 16V (CA660X) 16V 10V C463 C465 C471 1-162-927-11 CERAMIC CHIP 1-126-382-11 ELECT 1-162-927-11 CERAMIC CHIP 1-162-964-11 CERAMIC CHIP 100PF 100uF 100PF 0.001uF 5% 20% 5% 10% C445 C453 1-125-837-11 CERAMIC CHIP 1-125-837-11 CERAMIC CHIP 1-124-259-11 ELECT 1-126-163-11 ELECT 1-124-233-11 ELECT 1-162-970-11 CERAMIC CHIP 1-162-964-11 CERAMIC CHIP 1-124-233-11 ELECT 1-126-382-11 ELECT 1-162-927-11 CERAMIC CHIP 1-124-233-11 ELECT 1-126-382-11 ELECT 1-162-927-11 CERAMIC CHIP 1-126-382-11 ELECT 1uF 1uF 4.7uF 4.7uF 10uF 0.01uF 0.001uF 10uF 100uF 100PF 10uF 100uF 100PF 100uF 10%
6.3V (CA660X) 10% 6.3V (CA660X) 20% 16V (CA650X/CA690X) 20% 50V (CA660X) 20% 16V 10% 10% 20% 20% 5% 20% 20% 5% 20% 25V 50V 16V (CA660X) 16V (CA660X) 50V 16V (CA660X) 16V (CA660X) 50V 16V (CA660X) 50V 16V (CA660X) 50V 50V
36
CDX-CA650X/CA660X/CA690X MAIN
Ref. No. C476 C479 C601 C602 C603 C604 C605 C606 C607 C608 C610 C611 C612 C701 C702 C703 C704 C705 C706 C708 C709 C710 C801 C804 C805 C806 C809 C810 C811 C812 C813 C814 C815 C816 C865 C869 C905 C905 C906 C907 C912 C914 C915 C916 C917 C919 C921 C922 C924 Part No. Description 0.1uF 330uF 18PF 0.1uF 100uF 0.1uF 100uF 1uF 0.047uF 0.0047uF 0.022uF 1uF 100PF 0.01uF 0.0047uF 0.47uF 0.01uF 220uF 10uF 22uF 220uF 22uF 0.0047uF 18PF 18PF 0.1uF 0.1F 100uF 0.01uF 0.1uF 330uF 1uF 0.001uF 0.001uF 0.022uF 0.01uF 0.47uF 1uF 0.001uF 0.001uF 10uF 3300uF 0.068uF 47uF 10uF 0.1uF 22uF 0.1uF 0.1uF 20% 5% 20% Remark 25V 6.3V (CA660X) 50V 25V 16V 25V 16V 10V 16V 50V 25V 10V 50V 25V 50V 10V 25V 10V 16V 6.3V 10V 6.3V 50V 50V 50V 25V 5.5V 10V 25V 25V 16V 6.3V 50V 50V 25V Ref. No. C925 C926 C927 C928 C929 C930 C931 C932 C933 C934 Part No. Description 10uF 10uF 10uF 0.01uF 0.01uF 1uF 0.047uF 2.2uF 0.1uF 0.047uF 20% 20% 20% 10% 10% 10% 10% Remark 16V (CA660X) 16V 16V 25V 25V 1-164-156-11 CERAMIC CHIP 1-128-057-11 ELECT 1-162-918-11 CERAMIC CHIP 1-164-156-11 CERAMIC CHIP 1-126-382-11 ELECT 1-164-156-11 1-126-382-11 1-109-982-11 1-165-176-11 1-162-968-11 1-164-227-11 1-109-982-11 1-162-927-11 1-162-970-11 1-162-968-11 1-125-891-11 1-162-970-11 1-126-176-11 1-124-233-11 1-126-153-11 1-126-176-11 1-126-153-11 1-162-968-11 1-162-918-11 1-162-918-11 1-164-156-11 1-128-647-11 1-124-584-00 1-162-970-11 1-164-156-11 1-124-119-00 1-125-837-11 1-162-964-11 1-162-964-11 1-164-227-11 CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT ELECT ELECT ELECT ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP DOUBLE LAYERS ELECT CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 1-124-233-11 ELECT 1-126-157-11 1-126-157-11 1-162-970-11 1-162-970-11 ELECT ELECT CERAMIC CHIP CERAMIC CHIP
20% 10% 10% 10% 10% 10% 5% 10% 10% 10% 10% 20% 20% 20% 20% 20% 10% 5% 5%
1-125-837-11 CERAMIC CHIP 1-165-176-11 CERAMIC CHIP 1-164-505-11 CERAMIC CHIP 1-164-156-11 CERAMIC CHIP 1-165-176-11 CERAMIC CHIP
6.3V 16V (CA660X) 16V 25V 10% 16V (CA650X/CA690X)
< CONNECTOR > CNJ801 CNP701 CNP802 CNP902 1-580-907-31 1-764-617-12 1-569-907-11 1-774-701-11 PLUG, CONNECTOR (BUS CONTROL IN) PIN, CONNECTOR (PC BOARD) 30P SOCKET, CONNECTOR 12P PIN, CONNECTOR 16P < JACK > CNP801 1-764-270-21 JACK, STEREO MINIATURE (DIA.3.5) (REMOTE IN) < DIODE > D601 D801 D802 D803 D804 D805 D806 D807 D809 D811 D812 D813 D814 D815 D816 D817 D818 D901 D902 D906 D907 D908 D909 D911 D912 D913 D914 D915 D916 8-719-056-65 8-719-988-61 8-719-988-61 8-719-109-93 8-719-110-49 8-719-058-24 8-719-056-93 8-719-056-93 8-719-109-97 8-719-978-33 8-719-978-33 8-719-978-33 8-719-978-33 8-719-109-97 8-719-978-33 8-719-109-97 8-719-978-33 8-719-991-33 8-719-200-82 8-719-978-33 8-719-200-82 8-719-988-61 1-216-864-11 8-719-079-97 8-719-079-97 8-719-079-97 8-719-079-97 8-719-079-97 8-719-079-97 DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE SHORT DIODE DIODE DIODE DIODE DIODE DIODE 1SS372-TE85L 1SS355TE-17 1SS355TE-17 MTZJ-T-77-6.2B MTZJ-T-77-18B RB501V-40TE-17 UDZ-TE-17-18B UDZ-TE-17-18B MTZJ-T-77-6.8B UDZS-TE17-6.8B UDZS-TE17-6.8B UDZS-TE17-6.8B UDZS-TE17-6.8B MTZJ-T-77-6.8B UDZS-TE17-6.8B MTZJ-T-77-6.8B UDZS-TE17-6.8B 1SS133T-77 11ES2-TA1B UDZS-TE17-6.8B 11ES2-TA1B 1SS355TE-17 0 CRZ22(TE85L.SONY) CRZ22(TE85L.SONY) CRZ22(TE85L.SONY) CRZ22(TE85L.SONY) CRZ22(TE85L.SONY) CRZ22(TE85L.SONY)
20% 10%
20% 10% 10% 10% 10% 10% 20%
1-162-970-11 CERAMIC CHIP 1-124-465-00 ELECT 1-126-160-11 ELECT 1-162-964-11 CERAMIC CHIP 1-162-964-11 CERAMIC CHIP 1-124-233-11 1-135-473-21 1-110-563-11 1-124-589-11 1-126-157-11 1-164-156-11 1-126-153-11 1-164-156-11 1-164-156-11 ELECT ELECT CERAMIC CHIP ELECT ELECT CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP
25V 50V (CA660X) 20% 50V (CA650X/CA690X) 10% 50V 10% 50V 20% 20% 10% 20% 20% 16V 16V 16V 16V 16V 25V 6.3V 25V 25V (CA660X)
20%
37
CDX-CA650X/CA660X/CA690X MAIN
Ref. No. D917 D918 D919 D920 D931 D932 D933 D934 D934 D935 D935 D941 Part No. 8-719-079-97 8-719-079-97 8-719-200-82 8-719-049-38 8-719-056-84 8-719-978-33 8-719-056-88 1-216-864-11 8-719-978-33 1-216-864-11 Description DIODE DIODE DIODE DIODE DIODE CRZ22(TE85L.SONY) CRZ22(TE85L.SONY) 11ES2-TA1B 1N5404TU UDZS-TE17-7.5B Remark Ref. No. JR703 JR704 JR801 JR802 JR803 JR804 JR805 JR806 JR901 Part No. 1-216-864-11 1-162-970-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 Description SHORT CERAMIC CHIP SHORT SHORT SHORT SHORT SHORT SHORT SHORT < COIL > 8-719-988-61 DIODE 1SS355TE-17 8-719-109-89 DIODE MTZJ-T-77-5.6B < IC > IC301 IC302 IC401 IC404 IC405 IC406 IC431 IC441 IC801 IC802 IC803 IC901 8-759-909-71 8-759-909-71 8-759-827-13 8-759-827-14 8-759-909-71 8-759-909-71 8-759-593-97 8-759-593-97 6-800-079-01 8-759-682-69 IC IC IC IC IC IC IC IC IC IC BA4558F-E2 (CA660X) BA4558F-E2 (CA660X) TDA7406T TA8268AH BA4558F-E2 (CA660X) BA4558F-E2 (CA660X) NJM2160AM-TE2 (CA660X) NJM2160AM-TE2 (CA660X) MN101C49KTG1 XC61CN4302MR PJ401 PJ601 (CA660X) L900 1-419-476-31 COIL, CHOKE < JACK > 1-794-068-11 JACK, PIN 6P (AUDIO OUT FRONT/REAR, BUS AUDIO IN) 1-793-598-11 JACK (ANTENNA) < TRANSISTOR > Q101 Q102 Q201 Q202 Q801 Q803 Q901 Q902 Q905 Q906 (CA650X/CA690X) (CA650X/CA690X) (CA650X/CA690X) (CA650X/CA690X) (CA650X/CA690X) (CA650X/CA690X) (CA650X/CA690X) (CA650X/CA690X) (CA650X/CA690X) (CA650X/CA690X) (CA650X/CA690X) (CA650X/CA690X) (CA660X) (CA660X) (CA660X) (CA660X) (CA660X) (CA660X) R111 R112 R113 R114 R115 (CA660X) R116 R117 1-216-844-11 METAL CHIP 1-216-845-11 METAL CHIP 82K 100K 5% 5% 1/16W (CA660X) 1/16W (CA660X) Q907 Q908 Q909 Q910 Q911 Q912 Q913 Q914 Q915 Q922 Q923 Q924 8-729-920-21 8-729-920-21 8-729-920-21 8-729-920-21 8-729-027-31 8-729-900-53 8-729-049-40 8-729-049-40 8-729-049-43 8-729-901-00 8-729-900-53 8-729-901-00 8-729-027-31 8-729-021-82 8-729-052-35 1-801-806-11 8-729-901-04 8-729-901-00 8-729-027-31 8-729-052-35 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR DTC314TK-T-146 DTC314TK-T-146 DTC314TK-T-146 DTC314TK-T-146 DTA124EKA-T146 DTC114EKA-T146 STC2412G STC2412G STB1132Y DTC124EKA-T146 DTC114EKA-T146 DTC124EKA-T146 DTA124EKA-T146 2SD2396K STD1664 DTC144EK-T146 DTA114EK-T146 DTC124EKA-T146 DTA124EKA-T146 STD1664 (CA660X) 250uH 0 0.01uF 0 0 0 0 0 0 0 10% Remark 25V
DIODE UDZS-TE17-6.8B DIODE UDZ-TE-17-11B SHORT 0 DIODE UDZS-TE17-6.8B SHORT 0
(CA660X) (CA650X/CA690X) (CA660X) (CA650X/CA690X)
8-759-449-89 IC BA8270F-E2 8-759-661-47 IC BA4908-V3 < JUMPER RESISTOR >
JR101 JR102 JR103 JR104 JR105 JR106 JR107 JR108 JR201 JR202 JR203 JR204 JR301 JR302 JR303 JR304 JR401 JR403 JR404 JR411 JR412 JR413 JR490 JR602 JR701 JR702
1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11
SHORT SHORT SHORT SHORT SHORT SHORT SHORT SHORT SHORT SHORT SHORT SHORT SHORT SHORT SHORT SHORT SHORT SHORT SHORT SHORT SHORT SHORT SHORT SHORT SHORT
0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0
8-729-901-00 TRANSISTOR DTC124EKA-T146 (CA660X) 8-729-027-31 TRANSISTOR DTA124EKA-T146 (CA660X) < RESISTOR > 1-216-813-11 METAL CHIP 1-218-725-11 RES-CHIP 1-202-926-11 RES-CHIP 1-216-864-11 SHORT 1-216-841-11 METAL CHIP 220 24K 36K 0 47K 5% 5% 5% 1/16W 1/16W (CA660X) 1/16W (CA660X) 1/16W
5%
1-216-864-11 SHORT
38
CDX-CA650X/CA660X/CA690X MAIN
Ref. No. R118 R119 R121 R122 R123 Part No. Description 0 100K 220 24K 36K 5% 5% 5% 5% Remark 1/16W (CA660X) 1/16W 1/16W (CA660X) 1/16W (CA660X) Ref. No. R232 R233 R234 R243 R244 Part No. Description 1K 150K 100K 150K 100K 5% 5% 5% 5% 5% Remark 1/16W 1/16W (CA660X) 1/16W (CA660X) 1/16W (CA660X) 1/16W (CA660X) 1/16W (CA660X) 1/16W (CA660X) 1/16W (CA660X) 1/16W (CA660X) 1/16W (CA660X) 1/16W (CA660X) 1/16W (CA660X) 1/16W (CA660X) 1/16W (CA660X) 1/16W (CA660X) 1/16W (CA660X) 1/16W (CA660X) 1/16W (CA660X) 1/16W (CA660X) 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1-216-864-11 SHORT 1-216-845-11 METAL CHIP 1-216-813-11 METAL CHIP 1-218-725-11 RES-CHIP 1-202-926-11 RES-CHIP 1-216-821-11 METAL CHIP 1-216-847-11 METAL CHIP 1-216-845-11 METAL CHIP 1-216-847-11 METAL CHIP 1-216-845-11 METAL CHIP
R124 R125 R126 R127 R128 R129 R131 R132 R133 R134
1-216-864-11 SHORT 1-216-841-11 METAL CHIP 1-216-844-11 METAL CHIP 1-216-845-11 METAL CHIP 1-216-864-11 SHORT 1-216-845-11 METAL CHIP 1-216-833-11 METAL CHIP 1-216-821-11 METAL CHIP 1-216-847-11 METAL CHIP 1-216-845-11 METAL CHIP
0 47K 82K 100K 0
5% 5% 5%
1/16W 1/16W (CA660X) 1/16W (CA660X)
R301 R302 R311 R312
1-410-841-11 METAL CHIP 1-410-841-11 METAL CHIP 1-216-846-11 METAL CHIP 1-216-840-11 METAL CHIP 1-216-845-11 METAL CHIP
4.7K 4.7K 120K 39K 100K
5% 5% 5% 5% 5%
100K 10K 1K 150K 100K
5% 5% 5% 5% 5%
1/16W (CA660X) 1/16W 1/16W 1/16W (CA660X) 1/16W (CA660X) 1/16W (CA660X) 1/16W (CA660X) 1/16W 1/16W (CA660X) 1/16W (CA660X)
R313
R314 R315 R316
1-216-846-11 METAL CHIP 1-216-840-11 METAL CHIP 1-216-845-11 METAL CHIP 1-216-846-11 METAL CHIP 1-216-840-11 METAL CHIP
120K 39K 100K 120K 39K
5% 5% 5% 5% 5%
R143 R144 R211 R212 R213
1-216-847-11 METAL CHIP 1-216-845-11 METAL CHIP 1-216-813-11 METAL CHIP 1-218-725-11 RES-CHIP 1-202-926-11 RES-CHIP
150K 100K 220 24K 36K
5% 5% 5% 5% 5%
R321 R322
R323 R324 R325
1-216-845-11 METAL CHIP 1-216-846-11 METAL CHIP 1-216-840-11 METAL CHIP 1-216-845-11 METAL CHIP 1-216-821-11 METAL CHIP 1-216-833-11 1-216-841-11 1-216-831-11 1-216-864-11 1-216-831-11 1-216-845-11 1-216-809-11 1-216-809-11 1-216-864-11 1-216-841-11 1-216-841-11 1-216-864-11 1-216-864-11 1-216-837-11 1-216-813-11 METAL CHIP METAL CHIP METAL CHIP SHORT METAL CHIP METAL CHIP METAL CHIP METAL CHIP SHORT METAL CHIP METAL CHIP SHORT SHORT METAL CHIP METAL CHIP
100K 120K 39K 100K 1K 10K 47K 6.8K 0 6.8K 100K 100 100 0 47K 47K 0 0 22K 220 2.2K 2.2K 2.2K
5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5%
R214 R215 R216 R217 R218 R219 R221 R222 R223 R224 R225 R226 R227 R228 R229
1-216-864-11 SHORT 1-216-841-11 METAL CHIP 1-216-844-11 METAL CHIP 1-216-845-11 METAL CHIP 1-216-864-11 SHORT 1-216-845-11 METAL CHIP 1-216-813-11 METAL CHIP 1-218-725-11 RES-CHIP 1-202-926-11 RES-CHIP 1-216-864-11 SHORT 1-216-841-11 METAL CHIP 1-216-844-11 METAL CHIP 1-216-845-11 METAL CHIP 1-216-864-11 SHORT 1-216-845-11 METAL CHIP
0 47K 82K 100K 0 100K 220 24K 36K 0 47K 82K 100K 0 100K
5% 5% 5%
1/16W 1/16W (CA660X) 1/16W (CA660X)
R326 R401 R402 R403 R404 R601 R602 R604 R608 R609 R610 R611 R701 R702 R703 R801 R802 R803 R804 R805
5% 5% 5% 5%
1/16W (CA660X) 1/16W 1/16W (CA660X) 1/16W (CA660X)
5% 5% 5%
1/16W 1/16W (CA660X) 1/16W (CA660X) 1/16W (CA660X) 1/16W
5% 5% 5% 5% 5%
1/16W 1/16W 1/16W 1/16W 1/16W
5%
R231
1-216-833-11 METAL CHIP
10K
5%
1-216-825-11 METAL CHIP 1-216-825-11 METAL CHIP 1-216-825-11 METAL CHIP
39
CDX-CA650X/CA660X/CA690X MAIN
Ref. No. R806 R807 R808 R810 R811 R812 R813 R814 R815 R816 R817 R818 R819 R820 R821 R822 R823 R825 R826 R827 R828 R830 R831 R834 R835 R836 R839 R840 R841 R842 R843 R844 R845 R846 R851 Part No. 1-216-809-11 1-216-809-11 1-216-841-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-845-11 1-216-809-11 1-216-821-11 1-216-809-11 1-216-809-11 1-216-821-11 1-216-821-11 1-216-845-11 1-216-845-11 1-216-845-11 1-216-675-00 1-216-675-00 1-216-837-11 1-216-821-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-675-00 1-216-849-11 1-216-849-11 1-216-849-11 1-216-833-11 Description METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 100 100 47K 100 100 100 100 100K 100 1K 100 100 1K 1K 100K 100K 100K 10K 10K 22K 1K 100 100 100 100 10K 220K 220K 220K 10K 100 100 100K 0 100K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 0.5% 0.5% 5% 5% 5% 5% 5% 5% 0.5% 5% 5% 5% 5% Remark 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/10W 1/10W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/10W 1/16W 1/16W 1/16W 1/16W Ref. No. R910 R911 R912 R913 R914 Part No. 1-216-841-11 1-216-833-11 1-216-833-11 1-216-073-00 1-216-836-11 Description METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 47K 10K 10K 10K 18K 5% 5% 5% 5% 5% Remark 1/16W 1/16W 1/16W 1/10W 1/16W (CA660X)
R914 R915 R915 R916 R916
1-216-841-11 METAL CHIP 1-216-838-11 METAL CHIP 1-216-841-11 METAL CHIP 1-216-829-11 METAL CHIP 1-216-835-11 METAL CHIP
47K 27K 47K 4.7K 15K
5% 1/16W (CA650X/CA690X) 5% 1/16W (CA660X) 5% 1/16W (CA650X/CA690X) 5% 1/16W (CA650X/CA690X) 5% 1/16W (CA660X) 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/16W 1/10W 1/10W 1/10W 1/10W 1/10W 1/16W 1/16W 1/10W 1/10W 1/10W 1/16W 1/4W 1/4W 1/4W 1/4W 1/16W (CA660X)
R917 R919 R920 R921 R922 R923 R924 R925 R926 R927 R928 R930 R934 R935 R936 R937 R940
1-216-845-11 1-216-057-00 1-216-057-00 1-216-057-00 1-216-057-00 1-216-057-00 1-216-809-11 1-216-845-11 1-216-059-00 1-216-073-00 1-216-057-00 1-216-829-11 1-249-400-11 1-249-400-11 1-249-400-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP CARBON CARBON CARBON
100K 2.2K 2.2K 2.2K 2.2K 2.2K 100 100K 2.7K 10K 2.2K 4.7K 39 39 39 39 10K
1-247-807-31 CARBON 1-247-807-31 CARBON 1-216-845-11 METAL CHIP 1-216-864-11 SHORT 1-216-845-11 METAL CHIP
5% 1/4W 5% 1/4W 5% 1/16W (CA650X/CA690X) (CA660X) 5% 1/16W (CA690X) (CA650X/CA660X) 5% 1/16W (CA690X) 5% 1/4W 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W
1-249-400-11 CARBON 1-216-833-11 METAL CHIP
< SWITCH > S901 S902 SW802 1-762-638-21 SWITCH, TACTILE (RESET) 1-771-540-11 SWITCH, PUSH (1 KEY) (NOSE DET) 1-571-478-11 SWITCH, SLIDE (FREQUENCY SELECT) (CA690X) < THERMISTOR (POSITIVE) > TH900 1-801-792-21 THERMISTOR, POSITIVE < TUNER > TU601 A-3220-738-A TUNER UNIT (TUX-020) < VIBRATOR > X801 1-781-822-21 VIBRATOR, CERAMIC (18.432MHz) X802 1-567-098-41 VIBRATOR, CRYSTAL (32.768kHz) *************************************************************
R852 R853 R854 R855 R856 R857 R861 R862 R863 R864 R901 R906 R907 R908 R909
1-216-864-11 SHORT 1-216-841-11 METAL CHIP 1-249-417-11 CARBON 1-216-864-11 SHORT 1-216-821-11 METAL CHIP 1-216-833-11 1-216-845-11 1-216-845-11 1-216-833-11 1-216-833-11 1-216-833-11 1-216-805-11 1-216-829-11 1-216-864-11 1-216-821-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP SHORT METAL CHIP
0 47K 1K 0 1K 10K 100K 100K 10K 10K 10K 47 4.7K 0 1K
40
CDX-CA650X/CA660X/CA690X RELAY
Ref. No. * Part No. Description Remark Ref. No. C35 C36 C37 C38 C39 C41 C43 C44 Part No. 1-164-227-11 1-164-227-11 1-126-393-11 1-164-227-11 1-126-391-11 Description CERAMIC CHIP CERAMIC CHIP ELECT CHIP CERAMIC CHIP ELECT CHIP 0.022uF 0.022uF 33uF 0.022uF 47uF 10% 10% 20% 10% 20% 1-679-988-11 RELAY BOARD ************ < CONNECTOR > CNP902 1-794-064-12 SOCKET, CONNECTOR 14P CNP903 1-792-173-11 CABLE, FLAT (FFC) 12P < DIODE > LED905 8-719-078-39 LED CL-170SR-CD-T (CD WINDOW) < SWITCH > LSW916 1-771-883-11 SWITCH, TACTILE (WITH LED) (Z) < RESISTOR > R930 1-216-823-11 METAL CHIP 1.5K 5% 1/16W R931 1-216-823-11 METAL CHIP 1.5K 5% 1/16W R932 1-216-823-11 METAL CHIP 1.5K 5% 1/16W ************************************************************* * A-3283-048-A SERVO BOARD, COMPLETE ********************** < CAPACITOR > C1 C3 C4 C5 C6 C7 C8 C9 C10 C11 C13 C14 C15 C16 C17 C18 C19 C20 C21 C22 C23 C24 C25 C26 C27 C28 C29 C30 C31 C34 1-164-227-11 1-164-227-11 1-104-609-11 1-164-227-11 1-164-227-11 1-126-394-11 1-107-826-11 1-162-924-11 1-162-924-11 1-162-909-11 1-162-916-11 1-125-837-11 1-164-227-11 1-164-227-11 1-162-970-11 1-162-966-11 1-107-826-11 1-107-826-11 1-164-227-11 1-164-227-11 1-162-970-11 1-164-227-11 1-164-227-11 1-126-391-11 1-164-227-11 1-126-391-11 1-164-227-11 1-164-227-11 1-126-391-11 1-164-227-11 CERAMIC CHIP CERAMIC CHIP ELECT CHIP CERAMIC CHIP CERAMIC CHIP ELECT CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CHIP CERAMIC CHIP ELECT CHIP CERAMIC CHIP CERAMIC CHIP ELECT CHIP CERAMIC CHIP 0.022uF 0.022uF 100uF 0.022uF 0.022uF 10uF 0.1uF 56PF 56PF 4PF 12PF 1uF 0.022uF 0.022uF 0.01uF 0.0022uF 0.1uF 0.1uF 0.022uF 0.022uF 0.01uF 0.022uF 0.022uF 47uF 0.022uF 47uF 0.022uF 0.022uF 47uF 0.022uF 10% 10% 20% 10% 10% 20% 10% 5% 5% 0.25PF 5% 10% 10% 10% 10% 10% 10% 10% 10% 10% 10% 10% 10% 20% 10% 20% 10% 10% 20% 10% 25V 25V 4V 25V 25V 16V 16V 50V 50V 50V 50V 6.3V 25V 25V 25V 50V 16V 16V 25V 25V 25V 25V 25V 6.3V 25V 6.3V 25V 25V 6.3V 25V IC1 IC2 FB1 FB2 FB3 FB4 FB6 FB7 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 CN1 CN2 CN3
SERVO
Remark 25V 25V 10V 25V 6.3V 25V 50V 6.3V
1-164-227-11 CERAMIC CHIP 1-162-967-11 CERAMIC CHIP 1-125-837-11 CERAMIC CHIP < CONNECTOR >
0.022uF 10% 0.0033uF 10% 1uF 10%
1-764-616-12 HOUSING, CONNECTOR (PC BOARD) 30P 1-794-153-21 CONNECTOR, FPC (ZIF) 16P 1-770-347-21 CONNECTOR, FPC 6P < JUMPER RESISTOR > SHORT SHORT SHORT SHORT SHORT 0 0 0 0 0 0
1-216-864-11 SHORT < IC >
8-759-699-98 IC uPD63711GC-8EU 8-759-658-87 IC BA5810FP-E2 < TRANSISTOR >
Q1
8-729-904-87 TRANSISTOR 2SB1197K-T-146-R < RESISTOR >
R3 R5 R6 R7 R8 R9 R10 R12 R14 R15 R17 R18 R19 R20 R21 R22 R24 R25 R26 R29 R30
1-216-797-11 1-218-344-11 1-216-837-11 1-216-839-11 1-216-833-11 1-216-840-11 1-216-835-11 1-216-837-11 1-216-841-11 1-216-841-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-821-11 1-216-821-11 1-216-864-11 1-216-864-11 1-216-797-11 1-216-833-11
METAL CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP SHORT SHORT METAL CHIP METAL CHIP
10 7.5K 22K 33K 10K 39K 15K 22K 47K 47K 100 100 100 100 1K 1K 0 0 10 10K 10K
5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5%
1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W
5% 5% 5%
1/16W 1/16W 1/16W
1-216-833-11 METAL CHIP
41
CDX-CA650X/CA660X/CA690X SERVO
Ref. No. Part No.
SL SW
Description < SWITCH > Remark Ref. No. Part No. Description ************** HARDWARE LIST ************** #1 #2 #3 #4 #5 7-685-793-09 7-685-792-09 7-685-795-09 7-685-106-19 7-621-772-20 SCREW +PTT 2.6X8 (S) SCREW +PTT 2.6X6 (S) SCREW +PTT 2.6X12 (S) SCREW +P 2X10 TYPE 2 NON-SLIT SCREW +B 2X5 Remark
SW1
1-762-944-12 SWITCH, DETECTION (SMALL TYPE) (DOWN) < VIBRATOR >
1-781-759-21 VIBRATOR, CERAMIC (CHIP TYPE) (16.9344MHz) ************************************************************* * 1-676-708-11 SL SW BOARD ************ < CONNECTOR > CN13 1-770-347-21 CONNECTOR, FPC 6P < SWITCH > SW4 1-529-565-41 SWITCH, PUSH (1 KEY) (LIMIT) ************************************************************* MISCELLANEOUS *************** 9 201 206 207 0 210 1-776-207-82 X-3378-480-1 1-676-707-11 1-677-182-11 8-820-103-03 CORD (WITH CONNECTOR) (POWER) CHASSIS (OP) ASSY (including M901) PICK-UP FLEXIBLE BOARD MOTOR FLEXIBLE BOARD PICK-UP, OPTICAL KSS-720A/K1RP
X1
#6 7-685-535-19 SCREW +BTP 2.6X10 TYPE 2 N-S #7 7-628-253-00 SCREW, SPECIAL #8 7-627-553-37 SCREW, PRECISION +P 2X3 TYPE 3 #9 7-627-553-17 SCREW, PRECISION +P 2X2 TYPE 3 #10 7-627-850-28 SCREW, PRECISION +P 1.4X3 ************************************************************* PARTS FOR INSTALLATION AND CONNECTIONS *************************************** 251 252 253 254 255 256 257 258 259 3-014-370-21 FRAME, FITTING 3-916-012-01 BRACKET (ND), FITTING ASSIST (CA650X/CA660X) X-3368-725-1 SCREW ASSY, FITTING (CA650X/CA660X) 7-682-160-01 SCREW +P 4X6 (CA650X/CA660X) X-3366-405-1 SCREW ASSY (EXP), FITTING (CA690X) 3-934-325-01 3-030-929-04 3-226-508-01 1-776-207-82 SCREW (+K 5X8 TP) SPRING, FITTING COLLAR CORD (WITH CONNECTOR) (POWER)
F901 1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE) 10A M902 A-3301-985-A MOTOR ASSY, SLED (SLED) M903 A-3315-039-A MOTOR SUB ASSY, LO (LOADING) ************************************************************* ACCESSORIES & PACKING MATERIALS ******************************** 1-476-526-11 REMOTE COMMANDER (RM-X114) 3-230-047-01 LID, BATTERY CASE (for RM-X114) 3-226-762-11 MANUAL, INSTRUCTION, INSTALL (ENGLISH, SPANISH,TRADITIONALCHINESE) (CA690X) 3-226-822-11 MANUAL, INSTRUCTION (ENGLISH,SPANISH, TRADITIONAL CHINESE) (CA690X) 3-226-675-11 MANUAL, INSTRUCTION, INSTALL (ENGLISH, FRENCH) (CA650X/CA660X) 3-226-961-11 MANUAL, INSTRUCTION (ENGLISH,FRENCH) (CA650X/CA660X) X-3378-390-2 CASE ASSY (for FRONT PANEL) *************************************************************
253 251 252 254
255
256
257
258
259
The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified.
Les composants identifiés par une marque 0 sont critiques pour la sécurité. Ne les remplacer que par une piéce portant le numéro spécifié.
42
CDX-CA650X/CA660X/CA690X
US Model Canadian Model
SERVICE MANUAL
Ver 1.1 2001. 07
CDX-CA650X/CA660X
E Model
CDX-CA690X
SUPPLEMENT-1
File this supplement with the service manual.
Subject : Change of Main Board
(ECN-CSA04450)
When performing service and inspection, check the suffix of the part number of the main board.
1. DISCRIMINATION
MAIN BOARD (COMPONENT SIDE)
MAIN Board Part No. Former :1-679-989-11 New :1-679-989-12
1
CDX-CA650X/CA660X/CA690X
TABLE OF CONTENTS
1. 2. 3. 4. Printed Wiring Board Main Section ................................... 4 Schematic Diagram Main Section (1/2) ............................. 5 Schematic Diagram Main Section (2/2) ............................. 6 Electrical Parts List ................................................................. 7
2
CDX-CA650X/CA660X/CA690X
THIS NOTE IS COMMON FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS. (In addition to this, the necessary note is printed in each block.) for schematic diagram: · All capacitors are in µF unless otherwise noted. pF: µµF 50 WV or less are not indicated except for electrolytics and tantalums. · All resistors are in and 1/4 W or less unless otherwise specified. · % : indicates tolerance. f · : internal component. · C : panel designation. Note: Note: The components identi- Les composants identifiés par fied by mark 0 or dotted une marque 0 sont critiques line with mark 0 are criti- pour la sécurité. Ne les remplacer que par une cal for safety. Replace only with part piéce portant le numéro spécifié. number specified. · A : B+ Line. · Power voltage is dc 14.4V and fed with regulated dc power supply from ACC and BATT cords. · Voltages are taken with a VOM (Input impedance 10 M). Voltage variations may be noted due to normal production tolerances. · Waveforms are taken with a oscilloscope. Voltage variations may be noted due to normal production tolerances. · Circled numbers refer to waveforms. · Signal path. F : FM f : AM J : CD for printed wiring boards: · X : parts extracted from the component side. · Y : parts extracted from the conductor side. · x : parts mounted on the conductor side. a · : Through hole. · : Pattern from the side which enables seeing. (The other layer's patterns are not indicated.) Caution: Pattern face side: (Side B) Parts face side: (Side A) · ( · ((
· Waveforms -- Main Board --
1
3.8Vp-p
18.43MHz
IC801
qs
(OSCOUT)
2
5Vp-p
30.5µsec
IC801
qh
(XOUT)
Parts on the pattern face side seen from the pattern face are indicated. Parts on the parts face side seen from the parts face are indicated.
) : Refer to page of Supplement-1. )) : Refer to page of Service Manual.
3
3
CDX-CA650X/CA660X/CA690X
1. PRINTED WIRING BOARD -- MAIN SECTION --
· Semiconductor Location Ref. No. Location Ref. No. D935 (D401) H-6 D941 (D402) E-5 D601 J-1 (IC301) D801 J-6 (IC302) D802 K-7 IC401 D803 I-12 IC404 D804 I-