Text preview for : lg-cl-32-fpd1530-lg508k-tft-lcd.pdf part of Gateway FPD1530 Gateway FPD1530 LCD color monitor service manual
Back to : lg-cl-32-fpd1530-lg508k-t | Home
COLOR MONITOR SERVICE MANUAL
CHASSIS NO. : CL-32 FACTORY MODEL: LG508K
MODEL: FPD1530
KRSVM000063305
BEFORE SERVICING THE UNIT, READ THE SAFETY PRECAUTIONS IN THIS MANUAL.
OSD
AUTO/SET
To apply the LG Philips Module.
CONTENTS
To apply the LG Philips Module SPECIFICATIONS ..........................................................A-2 PRECAUTIONS ..............................................................A-3 TIMING CHART ............................................................. A-4 OPERATING INSTRUCTIONS .................................... A-5 WIRING DIAGRAM ....................................................... A-6 BLOCK DIAGRAM ......................................................... A-7 DESCRIPTION OF BLOCK DIAGRAM ....................... A-8 ADJUSTMENT ............................................................... A-9 TROUBLESHOOTING GUIDE ................................... A-10 PRINTED CIRCUIT BOARD.........................................A-14 EXPLODED VIEW.........................................................A-15 REPLACEMENT PARTS LIST ....................................A-17 PIN CONFIGURATION.................................................A-20 SCHEMATIC DIAGRAM ............................................. A-22 To apply the Toshiba Module SPECIFICATIONS ..........................................................B-2 PRECAUTIONS ..............................................................B-3 TIMING CHART ............................................................. B-4 OPERATING INSTRUCTIONS .................................... B-5 WIRING DIAGRAM ....................................................... B-6 BLOCK DIAGRAM ......................................................... B-7 DESCRIPTION OF BLOCK DIAGRAM ....................... B-8 ADJUSTMENT ............................................................... B-9 TROUBLESHOOTING GUIDE ................................... B-10 PRINTED CIRCUIT BOARD.........................................B-14 EXPLODED VIEW.........................................................B-15 REPLACEMENT PARTS LIST ....................................B-17 PIN CONFIGURATION.................................................B-20 SCHEMATIC DIAGRAM ............................................. B-21
SPECIFICATIONS
1. LCD CHARACTERISTICS Type : TFT XGA LCD Module Size : 352.0(H) x 263.5(V) x 14.0(T) Pixel Pitch : 0.297mm x 0.297mm Color Depth : 6bits(with FRC)/ 16M colors Active Video Area : 15.0inch (304.128 x 228.096) Surface Treatment : Anti-Glare, Hard Coating (3H) Backlight Unit : Top/Bottom edge side 2CCFL Electrical Interface : LVDS interface 2. OPTICAL CHARACTERISTICS 2-1. Viewing Angle by Contrast Ratio 10 Left : 55° min. Right : 55° min. Top : 40° min. Bottom : 40° min. 2-2. Luminance : 200(min.), 250(typ.) at Center point 2-3. Contrast Ratio :250(min.), 350(typ.) 3. SIGNAL (Refer to the Timing Chart) 3-1. Sync Signal 1) Type : Separate Sync. (Horizontal & Vertical) 2) Input Voltage Level : Low=0~0.8V, High=2.1~5.5V 3) Sync Polarity : Positive or Negative 3-2. Video Input Signal 1) Type 2) Voltage Level a) Color 0, 0 b) Color 7, 0 c) Color 15, 0 3) Input Impedance 3-3. Operating Frequency Horizontal Vertical : R, G, B Analog : 0~0.714 V : 0 Vp-p : 0.467 Vp-p : 0.714 Vp-p : 75 4. POWER SUPPLY 4-1. Power 100~240V, 50/60Hz 0.6A 4-2. Power Consumption
MODE POWER ON (NORMAL) STAND-BY SUSPEND DPMS OFF H/V SYNC VIDEO POWER CONSUMPTION LED COLOR ON/ON OFF/ON ON/OFF ACTIVE OFF OFF -
less than 30 W less than 2 W less than 2 W less than 2 W
GREEN AMBER AMBER AMBER
5. ENVIRONMENT 5-1. Operating Temperature: 10°C~35°C (50°F~95°F) (Ambient) 5-2. Relative Humidity : 10%~80% (Non-condensing) 5-3. MTBF : 50,000 Hours (Min.) Lamp Life : 40,000 Hours (Min.) 6. DIMENSIONS (with TILT/SWIVEL) Width Depth Height : 356mm (14.01'') : 151.7mm (5.97'') : 359.8mm (14.16'')
7. WEIGHT (with TILT/SWIVEL) Net. Weight Gross Weight : 4.7kg (10.36 lbs) : 5.8kg (12.79 lbs)
: 31 ~ 63kHz : 56 ~ 75Hz
A-2
PRECAUTION
WARNING FOR THE SAFETY-RELATED COMPONENT. · There are some special components used in LCD monitor that are important for safety. These parts are marked on the schematic diagram and the replacement parts list. It is essential that these critical parts should be replaced with the manufacturer's specified parts to prevent electric shock, fire or other hazard. · Do not modify original design without obtaining written permission from manufacturer or you will void the original parts and labor guarantee.
WARNING
BE CAREFUL ELECTRIC SHOCK ! · If you want to replace with the new backlight (CCFL) or inverter circuit, must disconnect the AC adapter because high voltage appears at inverter circuit about 650Vrms. · Handle with care wires or connectors of the inverter circuit. If the wires are pressed cause short and may burn or take fire.
TAKE CARE DURING HANDLING THE LCD MODULE WITH BACKLIGHT UNIT. · Must mount the module using mounting holes arranged in four corners. · Do not press on the panel, edge of the frame strongly or electric shock as this will result in damage to the screen. · Do not scratch or press on the panel with any sharp objects, such as pencil or pen as this may result in damage to the panel. · Protect the module from the ESD as it may damage the electronic circuit (C-MOS). · Make certain that treatment person's body are grounded through wrist band. · Do not leave the module in high temperature and in areas of high humidity for a long time. · The module not be exposed to the direct sunlight. · Avoid contact with water as it may a short circuit within the module. · If the surface of panel become dirty, please wipe it off with a softmaterial. (Cleaning with a dirty or rough cloth may damage the panel.)
CAUTION
Please use only a plastic screwdriver to protect yourself from shock hazard during service operation.
A-3
TIMING CHART
VIDEO
B A
C
E D F
SYNC
MODE 1 2 3 4 5 6 7 8 9 10 11 12 13 14
H/V H (Pixels) V (Lines) H (Pixels) V (Lines) H (Pixels) V (Lines) H (Pixels) V (Lines) H (Pixels) V (Lines) H (Pixels) V (Lines) H (Pixels) V (Lines) H (Pixels) V (Lines) H (Pixels) V (Lines) H (Pixels) V (Lines) H (Pixels) V (Lines) H (Pixels) V (Lines) H (Pixels) V (Lines) H (Pixels) V (Lines)
Sync + + + + + + + + + + + +
Dot 25.175 28.322 25.175 30.24 31.5 31.5 36.0 40.0 50.0 49.5
Frequency 31.468 KHz 70.0 Hz 31.468 KHz 70.0 Hz 31.469 KHz 60.0 Hz 35.00 KHz 66.67 Hz 37.861 KHz 72.8 Hz 37.50 KHz 75.0 Hz 35.156KHz 56.25 Hz 37.879 KHz 60.3 Hz 48.077 KHz 72.188 Hz 46.875 KHz 75.0 Hz
Polarity Clock
Total Period (E) 800 449 900 449 800 525 864 525 832 520 840 500 1024 625 1056 628 1040 666 1056 625 1152 667 1344 806 1328 806 1312 800
Video Blanking Sync Active Time Duration Time ( A ) (B) (D) 640 160 96 350 720 400 640 480 640 480 640 480 640 480 800 600 800 600 800 600 800 600 832 624 1024 768 1024 768 1024 768 99 180 49 160 45 224 45 192 40 200 20 224 25 256 28 240 66 256 25 320 43 320 38 304 38 288 32 2 108 2 96 2 64 3 40 3 64 3 72 2 128 4 120 6 80 3 64 3 136 6 136 6 96 3
Back Porch (F) 48 60 55 34 48 33 96 39 128 28 120 16 128 22 88 23 64 23 160 21 224 39 160 29 144 29 176 28
Front Porch (C) 16 37 17 13 16 10 64 3 24 9 16 1 24 1 40 1 56 37 16 1 32 1 24 3 24 3 16 1
Resolution 640 x 350 720 x 400
(TEXT)
640 x 480 640 x 480 640 x 480 640 x 480 800 x 600 800 x 600 800 x 600 800 x 600 832 x 624
(MAC)
57.2832 49.725 KHz 74.55 Hz 65 75 78.75 48.363 KHz 60.0 Hz 56.476 KHz 70.0 Hz 60.023 KHz 75.0 Hz
1024 x 768 1024 x 768 1024 x 768
A-4
OPERATING INSTRUCTIONS
FRONT VIEW REAR VIEW
OSD
AUTO/SET
Power Indicator Power Button OSD Button AUTO/SET Button Power Connector Buttons D-Sub Signal Connector
Front Control Panel
OSD
AUTO/SET
5
1 3 4
2
1. Power ON/OFF Button Use this button to turn the monitor on or off. 2. Power Indicator This indicator lights up green when the monitor operates normally; in DPMS (Energy Saving) mode, - stand-by, suspend, or power off mode - its color changes to amber. 3. Button
Use these buttons to choose or adjust items in the on screen display.
4. AUTO/SET Button
Use this button to enter a selection in the on screen display.
* AUTO adjustment function Touch the AUTO/SET button before using OSD menu. This button is for the automatic adjustment of the screen position, clock and phase.
PROCESSING AUTO CONFIGURATION
Note: Some signal from some graphics boards may not function properly. If the results are unsatisfactory, adjust your monitor's Position, Clock and Phase manually.
5. OSD Button
Use this button to enter or exit the on screen display.
A-5
WIRING DIAGRAM
Connector Ass'y : P/N: 6631T11016C
Connector Ass'y : P/N: 6631T20015K J702 J706 J705 CN2
CN3 J1
A-6
BLOCK DIAGRAM
A-7
DESCRIPTION OF BLOCK DIAGRAM
1. Scaler One chip IC(GMZAN-2, U201) GMZAN-2 (U201) is one chip IC which it supports four internal function blocks of Video Amp, PLL, A/D converter and Video processor. Video signal (0.7Vp.p) clamped through C207, 208, 209 with matching IC's proper cut off voltage. This signal is processed as a proper 8 bit digital signal by U201's amplifying, phase locking, A/D converting, and scaling operations. U201 outputs 24bit RGB data and control signals(Clock, Horizontal and Vertical sync, and Data Enable) as LVDS IC's input signals. 2. System Controller (Microprocessor) Circuit 1) Microprocessor (U501) distinguishes polarity and frequency by calculating horizontal and vertical sync input from signal source. 2) Microprocessor (U501) carries out power control by sending power-down trigger signal to each IC. 3) Microprocessor (U501) communicates with EEPROM (U502), and GMZAN-2 (U201) through IIC(2 lines) or 4 bit bus line. It makes all devices operated properly. 4) Microprocessor (U501) let User adjust screen by OSD function. 3. LVDS(Low Voltage Differential Signal, U411) LVDS transmitter (U411) delivers digital signal to the receiver inside LCD module by method of abstraction. The abstracted signals are pairs of RIN0+-, RIN1+-, RIN2+-, RIN3+-, and RCLKIN+- of which voltage swing is 0.5V each. When SHUTON pin's input is High, transmitter goes to power down mode. 4. DC/DC block This block is composed of regulators which supplies 2.5V and 3.3V. Each regulator's source power is 5VR from LIPS(LCD Inverter and Power Supply) block. U806 supplies 2.5VD and 2.5VA and U802 supplies 3.3VD, 3.3V_AD, and 3.3V_PL powers to GMZAN-2's internal PLL, ADC, Pre-amp, and scaler by dropping down 5VR. U805 supplies MODPWR-3.3V for LCD module's operation by dropping down 5VR. 5. LIPS Block (LCD Inverter and Power Supply) This block supplies DC voltages of 5VS to interface board and 12V to inverter by converting AC input voltage of 100~240Vac. Converting method is SMPS(Switching Mode Power Supply). Inverter on/off signal from microprocessor makes inverter turned on or off . DIMADJ signal from microprocessor does inverter's current adjustment for Brightness control.
A-8
ADJUSTMENT
All adjustment are thoroughly checked and corrected when the monitor leaves the factory, but sometimes several minor adjustment may be required. Adjustment should be following procedure and after warming up for a minimum of 10 minutes. Alignment appliances and tools. - IBM Compatible PC - Programmable Signal Generator. (eg. VG-819 made by Astrodesign Co.) - E(E)PROM with each mode data saved. - Alignment Adapter and Software. 1. Adjustment for Factory Preset Mode 1) Run alignment program for LG508K on the IBM compatible PC. 2) Select EEPROM All Init. command and Enter. 3) Display cross hatch pattern at Mode 1. 4) Select EDID WRITE[A] [A6]command and Enter. 2. Adjustment for White Balance 1) Display color 0,0 pattern at Mode 13. 2) Set External Bright to MAX position and Contrast to MAX Position. 3) Select PRESET START BIAS CAL command and Enter. 4) No attempt to manually adjust, BIAS data is automatically adjusted and saved to the EEPROM. 5) Display color 15,0 pattern at Mode 13. 6) Select DRIVE CAL command and Enter. 7) Color 1 (9300K) and Color 2 (6500K) are automatically adjusted and saved to the EEPROM. 8) Select PRESET EXIT command and Enter.
A
Video Signal Generator
d
IBM Compatible PC
9 15 10 5 11 6 1 5
6 1
C
13 1 14 25
PARALLEL PORT
RS 23 2C
No
tu
se
5V
OFF
ON
Control Line
EL
PA
RA
C
F
Power inlet (required)
220
LL
5V ON 4.7K 4.7K 4.7K 74LS06 74LS06
VG
PO
S MO NI
A
CS T
Power Select Switch (110V/220V) Power LED
WE R
5V
E
OFF
R
V-S
TO
YN
B
E ST Switch
B
F V-Sync On/Off Switch (Switch must be ON.)
Figure 1. Cable Connection
A-9
TROUBLESHOOTING GUIDE
1. NO POWER
NO POWER (POWER INDICATOR OFF)
CHECK J705 VOLTAGE PIN5, PIN6 (5V)? YES CHECK U802 PIN 1 VOLTAGE (5V) ? YES
NO
CHECK POWER BOARD, AND FIND OUT A SHORT POINT AS OPENING EACH POWER LINE
NO
CHECK U803.
CHECK U805 PIN 1 Voltage (5V) ? YES
NO
CHECK 5VS LINE (OPEN CHECK) NO PROBLEM
CHECK KEY CONTROL CONNECTOR ROUTINE
IS U201 PIN12 (3.3V) VOLTAGE REPEATED AS PULSE SHAPE ? NO
NO
CHECK IIC LINE CONNECTION (U501, U502)
CHECK U201 VCC, XTAL, RESET
A-10
2. NO RASTER (OSD IS NOT DISPLAYED) LIPS
NO RASTER (OSD IS NOT DISPLAYED)
J705 PIN5, PIN 6 5V? YES
NO
CHECK LIPS
J705 PIN2 5V? YES
NO
CHECK MICOM INV ON/OFF PORT.
J705 PIN1 5V?
NO
1. CONFIRM BRIGHTNESS OSD CONTRL STATE. 2. CHECK MICOM DIM-ADJ PORT
YES
CHECK PULSE AS CONTACTING SCOPE PROBE TO CAUTION LABEL. (CONTACT PROBE TO CAUTION LABEL. CAN YOU SEE PULSE AT YOUR SCOPE?
NO
LIPS
YES
REPLACE CCFL LAMP IN THE LCD MODULE
A-11
3. NO RASTER (OSD IS NOT DISPLAYED) gmZAN2
NO RASTER (OSD IS NOT DISPLAYED)
U201 POWER PINS 3.3V?
NO
CHECK U802, U806
YES
U201 PIN141, 142 OSCILLATE AS 20MHZ?
NO
1. CHECK PIN141, 142 SOLDERING CONDITION 2. CHECK X201 3. TROUBLE IN U201
YES
U401 PIN31 IS 65MHz CLOCK? PIN27 IS 48KHz H-SYNC? PIN28 IS 60Hz V-SYNC? PIN30 IS 48KHz DEN? IS PULSE APPEARED AT SIGNAL PINS?
NO
CHECK CONNECTION LINE FROM U201 TO U401
YES
U401 PIN1 3.3V?
NO
CHECK U805
YES
TROUBLE IN CABLE OR LCD MODULE
A-12
4. NO RASTER (OSD IS DISPLAYED) gmZAN2
NO RASTER (OSD IS DISPLAYED) YES
U201 POWER PIN 3.3V? YES CHECK R,G,B INPUT? U201 PIN 87, 91, 95 YES
NO
CHECK U802, U806
NO
1. CHECK PC 2. CHECK SIGNAL CABLE & D-SUB CONNECTOR LINE
CHECK H-SYNC INPUT U201 PIN 150?
NO
CHECK H-SYNC LINE (D-SUBU701MICOM U201 PIN150)
A-13
C514
R561 R560
1. MAIN BOARD (Component Side)
R581
R580 R570 R571 R525
C820
U805
PRINTED CIRCUIT BOARD
C832
J706
R807 L701 C706
U502
J702
C816
R537 R533 R534 C503 C502
C813
C516 R528
C410 C409 C408 R403 R404 C403 C407 C406 R712
Q506
C819
C818
R531
Q502
R713
R530 C835 L802 R511 R512
R805
U702
R510
R715
U701
Q505
L401
C511
C235
ZD501
PANNEL
C402
R206
C270
C248 C249 C242
R532
C224 C212
C223
160
Q501
R535
U802
LPL
L703
L702
L705
R540
C501
C401
L704
R539 R515 R518 R516 C237 C227 C233 C218 C247 C245 C241 C239
R401
C817
120
R710
R733
R716
C404
C708 C709 R708 C711 C710 R709
C243
Q503
C513
R705
R722
Q701
ZD701
5
C731
X501
C505 R523 R527 C506
BA206
100
C824 C507 C508 R519 R520
R205
C222 C219 R524
C232
R201
20
C827 C821
ZD702
R207 C225
C261
R521
L805
C205
R501 R502 R503 R504 R505 R506 R507 R508 R509
R538
C802
C226
U806
BA202
L201
C801
C258
C230 L204
C262
C259
30
C269
BA201
C515
C715
L707
L706
R513
C504
R720
R522
R813
C250
R204
U501
C257
40
C831
R203
L203
BA204
C211
RA501
RA502 J705
U201
C509
L801
C717
C220
C271
MODEL:LB500K DATE :2002.07.20
C716 L708
L205
C216
P/N :6870T534A12
J703
R706
C203 C254 C202 C255 C201 C256
C209 R208 C208 R210 C207 R209
C204
D702 D701 D706
C825
L202
R701
R703
C826
BA203
A-14
BA205 U807
C707
C512
R517 R526
C238 C234 C229 C231 C217 C246 C244 C240 C228 C221
C236
R536
L803
U401
C405
C206
C214 R202
110
R734
D703
D704
D705
R717
R707
D707
10 90 80 60 70 50
150
C215
C828
C712 R714 R711
D708
C210
C829
L804
R727
R724 R723 R725 C703
1
R529
X201
R551
L710
R541
C713
R726
EXPLODED VIEW
a
3
11 7 8
6
9
A-15
5
2
4
1
10
EXPLODED VIEW PARTS LIST
Description CABINET ASSEMBLY, LG508J G/WAY LOCAL SUB_MATERIAL C/SKD LCD(LIQUID CRYSTAL DISPLAY) LM150X07-B4 LG PHILPS TFT COLOR 15.0 INCH XGA BACK COVER ASSEMBLY, LG508J 3808TKL032A MX LOCAL TILT SWIVEL ASSEMBLY LG508J . MX, SEMI-CKD METAL ASSEMBLY, FRAME MAIN,LG508K(LPL) ADAPTER,AC-DC, PWI1502LG 5V/12A 1A/1A LIPS FOR K-CHASSIS ADAPTER,AC-DC, ADP-30EP 5V/12A 1A/1A LIPS FOR K-CHASSIS MAIN TOTAL ASSEMBLY LG508K G/WAY CL-32 METAL REAR LB508J C/SKD CONNECTOR ASSEMBLY, 20P H-H 100MM UL20276 I/FACE CABLE LB500K PWB(PCB) ASSEMBLY,SUB, LG508J CONTROL TOTAL G/WAY CABLE,D-SUB, UL 2990-9C(7.5) DT 1870MM BLACK(9930) , DM SCREW,DRAWING, D3.0 L10.0 MSWR/BK
Ref. No. 1 2 3 4 5 6
Part No. 3091TKL041E 6304FLP024A 3809TKL027E 3043TKK078M 4951TKS091F 6634B00051A or 6634B00053A
7 8 9 10 11 a
3313TL5056A 4950TKK424D 6631T11016C 6871TST245E 6850TD9001G 332-113E
A-16
REPLACEMENT PARTS LIST
CAUTION: BEFORE REPLACING ANY OF THESE COMPONENTS, READ CAREFULLY THE SAFETY PRECAUTIONS IN THIS MANUAL. * NOTE : S SAFETY Mark AL ALTERNATIVE PARTS
*S *AL LOC. NO.
PART NO.
DATE: 2002. 10. 07. DESCRIPTION / SPECIFICATION
*S *AL LOC. NO. C270 C271 C401 C402 C403 C404 C405 C501 C502 C503 C504 C505 C506 C507 C508 C509 C512 C513 C514 C515 C516 C703 C706 C707 C712 C713 C715 C731 C801 C802 C813 C816 C817 C818 C819 C820 C821 C824 C825 C826 C827 C828 C829 C831 C832 C835
PART NO. 0CK103CK51A 0CK103CK51A 0CK104CK56A 0CK104CK56A 0CK104CK56A 0CK104CK56A 0CK104CK56A 0CK104CK56A 0CC101CK41A 0CC101CK41A 0CK104CK56A 0CC101CK41A 0CC101CK41A 0CK104CK56A 0CK104CK56A 0CK104CK56A 0CC180CK41A 0CC180CK41A 0CH8106F611 0CC680CK41A 0CK104CK56A 0CK104CK56A 0CK104CK56A 0CC680CK41A 0CC101CK41A 0CK104CK56A 0CH3105F946 0CC680CK41A 0CK103CK51A 0CK104CK56A 0CK103CK51A 0CK104CK56A 0CE107CF610 0CK104CK56A 0CK103CK51A 0CE107CF610 0CK104CK56A 0CH8107F611 0CE107CF610 0CK104CK56A 0CK103CK51A 0CK104CK56A 0CK103CK51A 0CH8107F611 0CH8107F611 0CK104CK56A
DATE: 2002. 10. 07. DESCRIPTION / SPECIFICATION 0.01UF 1608 50V 10% R/TP B(Y5P 0.01UF 1608 50V 10% R/TP B(Y5P 0.1UF 1608 50V 10% R/TP X7R 0.1UF 1608 50V 10% R/TP X7R 0.1UF 1608 50V 10% R/TP X7R 0.1UF 1608 50V 10% R/TP X7R 0.1UF 1608 50V 10% R/TP X7R 0.1UF 1608 50V 10% R/TP X7R 100PF 1608 50V 5% R/TP NP0 100PF 1608 50V 5% R/TP NP0 0.1UF 1608 50V 10% R/TP X7R 100PF 1608 50V 5% R/TP NP0 100PF 1608 50V 5% R/TP NP0 0.1UF 1608 50V 10% R/TP X7R 0.1UF 1608 50V 10% R/TP X7R 0.1UF 1608 50V 10% R/TP X7R 18PF 1608 50V 5% R/TP NP0 18PF 1608 50V 5% R/TP NP0 10UF 16V M 85STD(CYL) R/TP 68PF 1608 50V 5% R/TP NP0 0.1UF 1608 50V 10% R/TP X7R 0.1UF 1608 50V 10% R/TP X7R 0.1UF 1608 50V 10% R/TP X7R 68PF 1608 50V 5% R/TP NP0 100PF 1608 50V 5% R/TP NP0 0.1UF 1608 50V 10% R/TP X7R 1UF 16V Z F 2012 R/TP 68PF 1608 50V 5% R/TP NP0 0.01UF 1608 50V 10% R/TP B(Y5P 0.1UF 1608 50V 10% R/TP X7R 0.01UF 1608 50V 10% R/TP B(Y5P 0.1UF 1608 50V 10% R/TP X7R 100UF SHL,SD 16V 20% BULK FL 0.1UF 1608 50V 10% R/TP X7R 0.01UF 1608 50V 10% R/TP B(Y5P 100UF SHL,SD 16V 20% BULK FL 0.1UF 1608 50V 10% R/TP X7R 100UF 16V M 85STD(CYL) R/TP 100UF SHL,SD 16V 20% BULK FL 0.1UF 1608 50V 10% R/TP X7R 0.01UF 1608 50V 10% R/TP B(Y5P 0.1UF 1608 50V 10% R/TP X7R 0.01UF 1608 50V 10% R/TP B(Y5P 100UF 16V M 85STD(CYL) R/TP 100UF 16V M 85STD(CYL) R/TP 0.1UF 1608 50V 10% R/TP X7R
MAIN BOARD CAPACITORS
C201 C202 C203 C204 C205 C206 C207 C208 C209 C210 C211 C212 C214 C215 C216 C217 C218 C219 C221 C222 C223 C224 C226 C227 C228 C229 C230 C231 C233 C234 C237 C238 C239 C240 C241 C242 C243 C244 C245 C246 C247 C248 C249 C254 C255 C256 C257 C258 C259 C261 C262 C269 0CC100CK41A 0CC100CK41A 0CC100CK41A 0CK104CK56A 0CK103CK51A 0CK104CK56A 0CK103CK51A 0CK103CK51A 0CK103CK51A 0CK103CK51A 0CK103CK51A 0CK103CK51A 0CK104CK56A 0CK103CK51A 0CK104CK56A 0CC220CK41A 0CC220CK41A 0CC220CK41A 0CC220CK41A 0CC220CK41A 0CC180CK41A 0CC180CK41A 0CC680CK41A 0CC220CK41A 0CC220CK41A 0CC220CK41A 0CC080CK11A 0CC220CK41A 0CC220CK41A 0CC220CK41A 0CC220CK41A 0CC220CK41A 0CC220CK41A 0CC220CK41A 0CC220CK41A 0CC220CK41A 0CC220CK41A 0CC220CK41A 0CC220CK41A 0CC220CK41A 0CC220CK41A 0CC220CK41A 0CC220CK41A 0CK103CK51A 0CK103CK51A 0CK103CK51A 0CK103CK51A 0CK103CK51A 0CK103CK51A 0CC680CK41A 0CC680CK41A 0CK103CK51A 10PF 1608 50V 5% R/TP NP0 10PF 1608 50V 5% R/TP NP0 10PF 1608 50V 5% R/TP NP0 0.1UF 1608 50V 10% R/TP X7R 0.01UF 1608 50V 10% R/TP B(Y5P 0.1UF 1608 50V 10% R/TP X7R 0.01UF 1608 50V 10% R/TP B(Y5P 0.01UF 1608 50V 10% R/TP B(Y5P 0.01UF 1608 50V 10% R/TP B(Y5P 0.01UF 1608 50V 10% R/TP B(Y5P 0.01UF 1608 50V 10% R/TP B(Y5P 0.01UF 1608 50V 10% R/TP B(Y5P 0.1UF 1608 50V 10% R/TP X7R 0.01UF 1608 50V 10% R/TP B(Y5P 0.1UF 1608 50V 10% R/TP X7R 22PF 1608 50V 5% R/TP NP0 22PF 1608 50V 5% R/TP NP0 22PF 1608 50V 5% R/TP NP0 22PF 1608 50V 5% R/TP NP0 22PF 1608 50V 5% R/TP NP0 18PF 1608 50V 5% R/TP NP0 18PF 1608 50V 5% R/TP NP0 68PF 1608 50V 5% R/TP NP0 22PF 1608 50V 5% R/TP NP0 22PF 1608 50V 5% R/TP NP0 22PF 1608 50V 5% R/TP NP0 8PF 1608 50V 0.5 PF R/TP NP0 22PF 1608 50V 5% R/TP NP0 22PF 1608 50V 5% R/TP NP0 22PF 1608 50V 5% R/TP NP0 22PF 1608 50V 5% R/TP NP0 22PF 1608 50V 5% R/TP NP0 22PF 1608 50V 5% R/TP NP0 22PF 1608 50V 5% R/TP NP0 22PF 1608 50V 5% R/TP NP0 22PF 1608 50V 5% R/TP NP0 22PF 1608 50V 5% R/TP NP0 22PF 1608 50V 5% R/TP NP0 22PF 1608 50V 5% R/TP NP0 22PF 1608 50V 5% R/TP NP0 22PF 1608 50V 5% R/TP NP0 22PF 1608 50V 5% R/TP NP0 22PF 1608 50V 5% R/TP NP0 0.01UF 1608 50V 10% R/TP B(Y5P 0.01UF 1608 50V 10% R/TP B(Y5P 0.01UF 1608 50V 10% R/TP B(Y5P 0.01UF 1608 50V 10% R/TP B(Y5P 0.01UF 1608 50V 10% R/TP B(Y5P 0.01UF 1608 50V 10% R/TP B(Y5P 68PF 1608 50V 5% R/TP NP0 68PF 1608 50V 5% R/TP NP0 0.01UF 1608 50V 10% R/TP B(Y5P
DIODEs
D701 D702 D703 D704 D705 0DS226009AA 0DS226009AA 0DS226009AA 0DS226009AA 0DS226009AA KDS226 KDS226 KDS226 KDS226 KDS226 TP KEC SOT-23 80V 300M TP KEC SOT-23 80V 300M TP KEC SOT-23 80V 300M TP KEC SOT-23 80V 300M TP KEC SOT-23 80V 300M
A-17
*S *AL LOC. NO. D706 D707 D708
PART NO. 0DS226009AA 0DS301109AA 0DS301109AA 0DZ560009GB
DATE: 2002. 10. 07. DESCRIPTION / SPECIFICATION KDS226 TP KEC SOT-23 80V 300M MMBD301LT1 TP MOTOROLA SOT23 3 MMBD301LT1 TP MOTOROLA SOT23 3 BZT52C5V6S DIODES R/TP SOD323
*S *AL LOC. NO. R504 R505 R506 R507 R508 R509 R510 R511 R512 R513 R515 R516 R517 R518 R519 R520 R521 R522 R523 R524 R525 R526 R527 R528 R529 R530 R531 R532 R533 R534 R535 R536 R537 R540 R541 R551 R561 R571 R581 R701 R703 R705 R706 R707 R708 R709 R711 R712 R713 R714 R715 R716 R717 R722 R723 R724 R725 R726 R727 R733 R734 R805
PART NO. 0RJ4701D677 0RJ1002D677 0RJ4701D677 0RJ1002D677 0RJ1002D677 0RJ4701D677 0RJ1000D677 0RJ4701D677 0RJ4701D677 0RJ1002D677 0RJ1000D677 0RJ4701D677 0RJ4701D677 0RJ4701D677 0RJ4701D677 0RJ4701D677 0RJ4701D677 0RJ1500D677 0RJ0332D677 0RJ0332D677 0RJ1000D677 0RJ4701D677 0RJ4701D677 0RJ1000D677 0RJ1000D677 0RJ1000D677 0RJ1000D677 0RJ3301D677 0RJ0332D677 0RJ0332D677 0RJ3301D677 0RJ1004D677 0RJ4701D677 0RJ1002D677 0RJ1000D677 0RJ0000D677 0RJ0000D677 0RJ0000D677 0RJ0000D677 0RJ0752D677 0RJ0752D677 0RJ4700D677 0RJ0752D677 0RJ0272D677 0RJ1500D677 0RJ1500D677 0RJ0000D677 0RJ1000D677 0RJ1000D677 0RJ1000D677 0RJ4701D677 0RJ4701D677 0RJ4701D677 0RJ1001D677 0RJ0332D677 0RJ0332D677 0RJ4701D677 0RJ4701D677 0RJ4701D677 0RJ1501D677 0RJ4701D677 0RJ1001D677
DATE: 2002. 10. 07. DESCRIPTION / SPECIFICATION 4.7K OHM 1/10 W 5% 1608 R/TP 10K OHM 1/10 W 5% 1608 R/TP 4.7K OHM 1/10 W 5% 1608 R/TP 10K OHM 1/10 W 5% 1608 R/TP 10K OHM 1/10 W 5% 1608 R/TP 4.7K OHM 1/10 W 5% 1608 R/TP 100 OHM 1/10 W 5% 1608 R/TP 4.7K OHM 1/10 W 5% 1608 R/TP 4.7K OHM 1/10 W 5% 1608 R/TP 10K OHM 1/10 W 5% 1608 R/TP 100 OHM 1/10 W 5% 1608 R/TP 4.7K OHM 1/10 W 5% 1608 R/TP 4.7K OHM 1/10 W 5% 1608 R/TP 4.7K OHM 1/10 W 5% 1608 R/TP 4.7K OHM 1/10 W 5% 1608 R/TP 4.7K OHM 1/10 W 5% 1608 R/TP 4.7K OHM 1/10 W 5% 1608 R/TP 150 OHM 1/10 W 5% 1608 R/TP 33 OHM 1/10 W 5% 1608 R/TP 33 OHM 1/10 W 5% 1608 R/TP 100 OHM 1/10 W 5% 1608 R/TP 4.7K OHM 1/10 W 5% 1608 R/TP 4.7K OHM 1/10 W 5% 1608 R/TP 100 OHM 1/10 W 5% 1608 R/TP 100 OHM 1/10 W 5% 1608 R/TP 100 OHM 1/10 W 5% 1608 R/TP 100 OHM 1/10 W 5% 1608 R/TP 3.3K OHM 1/10 W 5% 1608 R/TP 33 OHM 1/10 W 5% 1608 R/TP 33 OHM 1/10 W 5% 1608 R/TP 3.3K OHM 1/10 W 5% 1608 R/TP 1000000 OHM 1/10 W 5% 1608 R/T 4.7K OHM 1/10 W 5% 1608 R/TP 10K OHM 1/10 W 5% 1608 R/TP 100 OHM 1/10 W 5% 1608 R/TP 0 OHM 1/10 W 5% 1608 R/TP 0 OHM 1/10 W 5% 1608 R/TP 0 OHM 1/10 W 5% 1608 R/TP 0 OHM 1/10 W 5% 1608 R/TP 75 OHM 1/10 W 5% 1608 R/TP 75 OHM 1/10 W 5% 1608 R/TP 470 OHM 1/10 W 5% 1608 R/TP 75 OHM 1/10 W 5% 1608 R/TP 27 OHM 1/10 W 5% 1608 R/TP 150 OHM 1/10 W 5% 1608 R/TP 150 OHM 1/10 W 5% 1608 R/TP 0 OHM 1/10 W 5% 1608 R/TP 100 OHM 1/10 W 5% 1608 R/TP 100 OHM 1/10 W 5% 1608 R/TP 100 OHM 1/10 W 5% 1608 R/TP 4.7K OHM 1/10 W 5% 1608 R/TP 4.7K OHM 1/10 W 5% 1608 R/TP 4.7K OHM 1/10 W 5% 1608 R/TP 1K OHM 1/10 W 5% 1608 R/TP 33 OHM 1/10 W 5% 1608 R/TP 33 OHM 1/10 W 5% 1608 R/TP 4.7K OHM 1/10 W 5% 1608 R/TP 4.7K OHM 1/10 W 5% 1608 R/TP 4.7K OHM 1/10 W 5% 1608 R/TP 1.5K OHM 1/10 W 5% 1608 R/TP 4.7K OHM 1/10 W 5% 1608 R/TP 1K OHM 1/10 W 5% 1608 R/TP
ICs
U201 U401 U501 U502 U701 U702 U802 U805 U806 0IPRPGA002A 0ITH638300B 0IZZTSZ207A 0ISG240860B 0IMO741420B 0ICS240213A 0IPMGKE011A 0IRH033000A 0IPMGON007A GMZAN2-160P GENESIS MICROCHIP THC63LVDM83R THINE 56P,TSSOP R MYSON 42PIN BK OTP LG508K M24C08W6 SGS-THOMSON 8SOP R/TP MC74HCT14ADR2 14P,SOIC TP LEVE CAT24WC02J-TE13 8P SOP TP 2K I KIA78D33F KEC DPAK R/TP 3.3V L BA033SFP P/MOLD-5 TP REGULATOR NCP1117ST25T3 ON SEMI SOT223 R
COILs & COREs
L201 L202 L203 L204 L205 L401 L701 L702 L703 L704 L705 L706 L707 L710 L801 L802 L803 L804 L805 6210TCE001P 6210TCE001P 6210TCE001P 6210TCE001P 6210TCE001P 6210TCE001G 6210TCE001S 6210TCE001P 6210TCE001P 6210TCE001P 6210TCE001P 6210TCE001P 6210TCE001P 6210TCE001G 6210TCE001G 6210TCE001G 6210TCE001G 6210TCE001G 6210TCE001G HB-1S2012-121JT CERATECH 2012M HB-1S2012-121JT CERATECH 2012M HB-1S2012-121JT CERATECH 2012M HB-1S2012-121JT CERATECH 2012M HB-1S2012-121JT CERATECH 2012M HH-1M3216-501 CERATEC 3216MM R HU-1M2012-121 CERATECH 2012MM HB-1S2012-121JT CERATECH 2012M HB-1S2012-121JT CERATECH 2012M HB-1S2012-121JT CERATECH 2012M HB-1S2012-121JT CERATECH 2012M HB-1S2012-121JT CERATECH 2012M HB-1S2012-121JT CERATECH 2012M HH-1M3216-501 CERATEC 3216MM R HH-1M3216-501 CERATEC 3216MM R HH-1M3216-501 CERATEC 3216MM R HH-1M3216-501 CERATEC 3216MM R HH-1M3216-501 CERATEC 3216MM R HH-1M3216-501 CERATEC 3216MM R
TRANSISTOR
Q502 Q503 Q701 0TR390409AE 0IKE704200H 0TR390409AE FAIRCHILD KST3904(LGEMTF) TP S KIA7042AP TO-92 TP 4.2 VOLT. FAIRCHILD KST3904(LGEMTF) TP S
RESISTORs
R201 R202 R203 R204 R205 R206 R207 R208 R209 R210 R401 R403 R404 R501 R502 R503 0RJ4701D677 0RJ4701D677 0RJ1000D677 0RJ1000D677 0RJ1000D677 0RJ2701D677 0RJ0472D677 0RJ1000D677 0RJ1000D677 0RJ1000D677 0RJ1002D677 0RJ1001D677 0RJ5601D477 0RJ4701D677 0RJ4701D677 0RJ4701D677 4.7K OHM 1/10 W 5% 1608 R/TP 4.7K OHM 1/10 W 5% 1608 R/TP 100 OHM 1/10 W 5% 1608 R/TP 100 OHM 1/10 W 5% 1608 R/TP 100 OHM 1/10 W 5% 1608 R/TP 2.7K OHM 1/10 W 5% 1608 R/TP 47 OHM 1/10 W 5% 1608 R/TP 100 OHM 1/10 W 5% 1608 R/TP 100 OHM 1/10 W 5% 1608 R/TP 100 OHM 1/10 W 5% 1608 R/TP 10K OHM 1/10 W 5% 1608 R/TP 1K OHM 1/10 W 5% 1608 R/TP 5.6K OHM 1/10 W 1% 1608 R/TP 4.7K OHM 1/10 W 5% 1608 R/TP 4.7K OHM 1/10 W 5% 1608 R/TP 4.7K OHM 1/10 W 5% 1608 R/TP
A-18
*S *AL LOC. NO. R807 R813 RA501 RA502
PART NO. 0RJ1003D677 0RJ1001D677 0RHZTCZ001A 0RHZTCZ001A
DATE: 2002. 10. 07. DESCRIPTION / SPECIFICATION 100K OHM 1/10 W 5% 1608 R/TP 1K OHM 1/10 W 5% 1608 R/TP 100 OHM 1/16 W 5% 3215 R/TP CH 100 OHM 1/16 W 5% 3215 R/TP CH
OTHERs
X201 X501 6212AA2004B 6212AA2004A HC-49U TXC 20.0MHZ +/- 30 PPM HC-49U TXC 12.0MHZ +/- 30 PPM
CONTROL BOARD
C1 C2 C3 LED1 R1 R2 R3 R4 R5 R6 R7 SW1 SW2 SW3 SW4 SW5 SW6 SW7 ZD1 ZD2 0CN1040K949 0CN1040K949 0CN1040K949 0DL305029BA 0RD4701Q509 0RD4701Q509 0RD1501Q509 0RD1501Q509 0RD3301Q509 0RD3301Q509 0RD9101Q609 140-058D 140-058D 140-058D 140-058D 140-058D 140-058D 140-058E 0DZ560009CE 0DZ560009CE 0.1M 50V Z F TA52 0.1M 50V Z F TA52 0.1M 50V Z F TA52 LTL-305DJ-0C2 TP LITEON GREEN/ 4.7K OHM 1/4 W (3.4) 2% TA52 4.7K OHM 1/4 W (3.4) 2% TA52 1.5K OHM 1/4 W (3.4) 2% TA52 1.5K OHM 1/4 W (3.4) 2% TA52 3.3K OHM 1/4 W (3.4) 2% TA52 3.3K OHM 1/4 W (3.4) 2% TA52 9.10K 1/4W(3 5% TA52 SKHV10911A LGEC NON 12 20 HORI SKHV10911A LGEC NON 12 20 HORI SKHV10911A LGEC NON 12 20 HORI SKHV10911A LGEC NON 12 20 HORI SKHV10911A LGEC NON 12 20 HORI SKHV10911A LGEC NON 12 20 HORI SKHV10910B LGEC NON 12V 20A HO MTZJ5.6B TP ROHM-K DO34 500MW MTZJ5.6B TP ROHM-K DO34 500MW
A-19
PIN CONFIGURATION
CAT24WC02J-TE13 8P
BLOCK DIAGRAM
DIP Package(p)
A0 A1 A2 V SS 1 2 3 4 8 7 6 5 VCC WP SCL SDA
SOIX Package(J)
EXTERNAL LOAD A0 A1 A2 V SS 1 2 3 4 8 7 6 5 VCC WP SCL SDA
V CC V SS WORD ADDRESS BUFFERS COLUMN DECODERS
D OUT ACK
SENSE AMPS SHIFT REGISTERS
TSSOP Package(U)
SDA START/STOP LOGIC
A0 A1 A2 V SS
1 2 3 4
8 7 6 5
VCC WP SCL SDA
WP CONTROL LOGIC XDEC E 2 PROM
PIN CONFIGURATION PIN FUNCTION
DATA IN STORAGE
Pin Name
A0, A1, A2 SDA SCL WP Vcc Vss
Function
Device Adress Inputs Serial Data/Address
SCL STATE COUNTERS SLAVE ADDRESS COMPARATORS HIGH VOLTAGE/ TIMING CONTROL
Serial Clock Write Protect +1.8V to + 6.0V power Supply Ground
A0 A1 A2
MC74HCT14ADR2 14P
BLOCK DIAGRAM
A1
1
2
Y1
A1 Y1 A2 Y2 A3 Y3 GND
1 2 3 4 5 6 7
14 13 12 11 10 9 8
VCC AS Y6 A5
A4 A2
3
4
Y2
A3
5
6
Y3
9
8
Y4
Y5 A4 Y4
A6 A5
11
10
Y5
13
12
Y6
PIN CONFIGURATION
PIN 14=VCC PIN 7=GND
A-20
THC63LVDM83R
PIN CONFIGURATION
THC63LVDM83R RS TD1 TA5 TA6 GND TB0 TB1 TD2 VCC TD3 TB2 TB3 GND TB4 TB5 TD4 R/F TD5 TB6 TC0 GND TC1 TC2 TC3 TD6 VCC TC4 TC5 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 56 55 54 53 52 51 50 49 48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 TA4 TA3 TA2 GND TA1 TA0 TD0 LVDS GND TATA+ TBTB+ LVDS VCC LVDS GND TCTC+ TCLK TCLK+ TDTD+ LVDS GND PLL GND PLL VCC PLL GND /PDWN CLK IN TC6 GND
BLOCK DIAGRAM
THC63LVDM83R DATA (LVDS) TA0-6 TB0-6 TC0-6 TD0-6 7 7 7 7 TTL PARALLEL TO SERIAL TA +/TB +/TC +/TD +/(140-595Mbit/On Each LVDS Channel) PLL TCLK +/CLOCK (LVDS) 20~85MHz
TRANSMITTER CLOCK IN (20 to 85MHz) R/F /PDWN RS
A-21
SCHEMATIC DIAGRAM
1. GMZAN2
A-22
2. LVDS
A-23
3. MICOM
Ready
Ready
A-24
4. DC/DC BLOCK
A-25
Ready
5. CONNECTOR & JACKS
Ready
A-26
6. CONTROL
A-27
COLOR MONITOR SERVICE MANUAL
CHASSIS NO. : CL-32 FACTORY MODEL: LG508K
MODEL: FPD1530
CAUTION
BEFORE SERVICING THE UNIT, READ THE SAFETY PRECAUTIONS IN THIS MANUAL.
OSD
AUTO/SET
To apply the Toshiba Module.
SPECIFICATIONS
1. LCD CHARACTERISTICS Type : TFT XGA LCD Module Size : 352.0(H) x 263.5(V) x 14.0(T) Pixel Pitch : 0.297mm x 0.297mm Color Depth : 6 Bits+FRC/ 16,194,277 colors Active Video Area : 15.0 inch (304.128 x 228.096) Surface Treatment : Anti-Glare, Hard Coating (3H) Backlight Unit : Top/Bottom edge side 4CCFL Electrical Interface : LVDS 2. OPTICAL CHARACTERISTICS 2-1. Viewing Angle by Contrast Ratio 10 Left : 50° min. Right : 50° min. Top : 40° min. Bottom : 40° min. 2-2. Luminance : 200(min.), 250(typ.) at Center point 2-3. Contrast Ratio 250(min.), 350(typ.) 3. SIGNAL (Refer to the Timing Chart) 3-1. Sync Signal 1) Type : Separate Sync. (Horizontal & Vertical) 2) Input Voltage Level : Low=0~0.8V, High=2.1~5.5V 3) Sync Polarity : Positive or Negative 3-2. Video Input Signal 1) Type : R, G, B Analog 2) Voltage Level : 0~0.714 V a) Color 0, 0 : 0 Vp-p b) Color 7, 0 : 0.467 Vp-p c) Color 15, 0 : 0.714 Vp-p 3) Input Impedance : 75 3-3. Operating Frequency Horizontal : 31 ~ 63kHz Vertical : 56 ~ 75Hz 4. POWER SUPPLY 4-1. Power 100~240V, 50/60Hz 0.6A 4-2. Power Consumption
MODE POWER ON (NORMAL) STAND-BY SUSPEND H/V SYNC VIDEO POWER CONSUMPTION LED COLOR ON/ON ON/OFF OFF/ON ACTIVE OFF OFF
less than 30 W less than 2 W less than 2 W
GREEN AMBER AMBER
5. ENVIRONMENT 5-1. Operating Temperature: 10°C~35°C (50°F~95°F) (Ambient) 5-2. Relative Humidity : 10%~80% (Non-condensing) 5-3. MTBF : 50,000 Hours (Min.) Lamp Life : 50,000 Hours (min.) 6. DIMENSIONS (with TILT/SWIVEL) Width Depth Height : 380mm (14.96'') : 205mm (8.07'') : 367mm (14.45'')
7. WEIGHT (with TILT/SWIVEL) Net. Weight Gross Weight : 4.9kg (10.80 lbs) : 5.8kg (12.79 lbs)
B-2
PRECAUTION
WARNING FOR THE SAFETY-RELATED COMPONENT. · There are some special components used in LCD monitor that are important for safety. These parts are marked on the schematic diagram and the replacement parts list. It is essential that these critical parts should be replaced with the manufacturer's specified parts to prevent electric shock, fire or other hazard. · Do not modify original design without obtaining written permission from manufacturer or you will void the original parts and labor guarantee.
WARNING
BE CAREFUL ELECTRIC SHOCK ! · If you want to replace with the new backlight (CCFL) or inverter circuit, must disconnect the AC adapter because high voltage appears at inverter circuit about 650Vrms. · Handle with care wires or connectors of the inverter circuit. If the wires are pressed cause short and may burn or take fire.
TAKE CARE DURING HANDLING THE LCD MODULE WITH BACKLIGHT UNIT. · Must mount the module using mounting holes arranged in four corners. · Do not press on the panel, edge of the frame strongly or electric shock as this will result in damage to the screen. · Do not scratch or press on the panel with any sharp objects, such as pencil or pen as this may result in damage to the panel. · Protect the module from the ESD as it may damage the electronic circuit (C-MOS). · Make certain that treatment person's body are grounded through wrist band. · Do not leave the module in high temperature and in areas of high humidity for a long time. · The module not be exposed to the direct sunlight. · Avoid contact with water as it may a short circuit within the module. · If the surface of panel become dirty, please wipe it off with a softmaterial. (Cleaning with a dirty or rough cloth may damage the panel.)
CAUTION
Please use only a plastic screwdriver to protect yourself from shock hazard during service operation.
B-3
TIMING CHART
VIDEO
B A
C
E D F
SYNC
MODE 1 2 3 4 5 6 7 8 9 10 11 12 13 14
H/V H (Pixels) V (Lines) H (Pixels) V (Lines) H (Pixels) V (Lines) H (Pixels) V (Lines) H (Pixels) V (Lines) H (Pixels) V (Lines) H (Pixels) V (Lines) H (Pixels) V (Lines) H (Pixels) V (Lines) H (Pixels) V (Lines) H (Pixels) V (Lines) H (Pixels) V (Lines) H (Pixels) V (Lines) H (Pixels) V (Lines)
Sync + + + + + + + + + + + +
Dot 25.175 28.322 25.175 30.24 31.5 31.5 36.0 40.0 50.0 49.5
Frequency 31.468 KHz 70.0 Hz 31.468 KHz 70.0 Hz 31.469 KHz 60.0 Hz 35.0 KHz 66.67 Hz 37.861 KHz 72.8 Hz 37.50 KHz 75 Hz 35.156KHz 56.25 Hz 37.879 KHz 60.3 Hz 48.077 KHz 72.188 Hz 46.875 KHz 75.0 Hz
Polarity Clock
Total Period (E) 800 449 900 449 800 525 864 525 832 520 840 500 1024 625 1056 628 1040 666 1056 625 1152 667 1344 806 1328 806 1312 800
Video Blanking Sync Active Time Duration Time ( A ) (B) (D) 640 160 96 350 720 400 640 480 640 480 640 480 640 480 800 600 800 600 800 600 800 600 832 624 1024 768 1024 768 1024 768 99 180 49 160 45 224 45 192 40 200 20 224 25 256 28 240 66 256 25 320 43 320 38 304 38 288 32 2 108 2 96 2 64 3 40 3 64 3 72 2 128 4 120 6 80 3 64 3 136 6 136 6 96 3
Back Porch (F) 48 60 55 34 48 33 96 39 128 28 120 16 128 22 88 23 64 23 160 21 224 39 160 29 144 29 176 28
Front Porch (C) 16 37 17 13 16 10 64 3 24 9 16 1 24 1 40 1 56 37 16 1 32 1 24 3 24 3 16 1
Resolution 640 x 350 720 x 400
(TEXT)
640 x 480 640 x 480 640 x 480 640 x 480 800 x 600 800 x 600 800 x 600 800 x 600 832 x 624
(MAC)
57.2832 49.725 KHz 74.55 Hz 65 75 78.75 48.363 KHz 60.0 Hz 56.476 KHz 70.0 Hz 60.023 KHz 75.0 Hz
1024 x 768 1024 x 768 1024 x 768
B-4
OPERATING INSTRUCTIONS
FRONT VIEW REAR VIEW
OSD
AUTO/SET
Power Indicator Power Button OSD Button AUTO/SET Button Power Connector Buttons D-Sub Signal Connector
Front Control Panel
OSD
AUTO/SET
5
1 3 4
2
1. Power ON/OFF Button Use this button to turn the monitor on or off. 2. Power Indicator This indicator lights up green when the monitor operates normally; in DPMS (Energy Saving) mode, - stand-by, suspend, or power off mode - its color changes to amber. 3. Button
Use these buttons to choose or adjust items in the on screen display.
4. AUTO/SET Button
Use this button to enter a selection in the on screen display.
* AUTO adjustment function Touch the AUTO/SET button before using OSD menu. This button is for the automatic adjustment of the screen position, clock and phase.
PROCESSING AUTO CONFIGURATION
Note: Some signal from some graphics boards may not function properly. If the results are unsatisfactory, adjust your monitor's Position, Clock and Phase manually.
5. OSD Button
Use this button to enter or exit the on screen display.
B-5
WIRING DIAGRAM
Connector the Main PCB Ass'y and Inverter.
Connector Ass'y P/N : 6631T11016C Connector Ass'y : P/N: 6631T20008G
J705 P902 CN4 CN5 CN1 CN2 CN3 J707 J702 J706
Connector Ass'y : P/N: 6631T20015K
J1
Connector Ass'y P/N : 6631T20015V
Connector the Control PCB Ass'y and Main PCB Ass'y.
B-6
BLOCK DIAGRAM
B-7
DESCRIPTION OF BLOCK DIAGRAM
1. Input signal switching part. There is one input which is analog. It comes from 15 pin D-Sub connector. 2. Pre-amp/ ADC / PLL / Video Controller. This part amplifies the level of video signal from the analog video signal to the digital video signal using a pixel clock. The pixel clock for each mode is generated by the PLL. The range of the pixel clock is from 25MHz to 78.75MHz. The Scaler gets the video signal converted analog to digital, interpolates input to 1024 X 768 resolution signal and outputs 8-bit R, G, B signal to LCD module. Especially pre-amp / ADC / Video controller are merged to one chip `gmZAN2' by Genesis. 3. Power Part. This circuit is working of 90~260VAC(50/60Hz). The operation procedure is as follows: 1) AC Input voltage is rectified and smoothed by the bridge diodes(BD901) and the capacitor(C905). 2) The Rectified voltage(DC) is applied to the primary coil of the transformer(T901) 3) The control IC(IC901) generates switching pulse to turn on and turn off the primary coil of the transformer(T901) 4) Depending on turn ratio of the transformer, the secondary voltages appear at the secondary coils of the transformer(T901) 5) These secondary voltages(12V,5V) are rectified by each diodes(D903,D906) and operates other circuit.(Inverter,Scaler...etc) 4. MICOM Part. This part consists of EEPROM IC which stores control data, Reset IC and the Micom. The Micom distinguishes polarity and frequency of the H/V sync are supplied from signal cable. The controlled data of each modes is stored in EEPROM. 5. Inverter The inverter converts from DC12V to AC 700V and operate back-light lamp of module.
B-8
ADJUSTMENT
All adjustment are thoroughly checked and corrected when the monitor leaves the factory, but sometimes several minor adjustment may be required. Adjustment should be following procedure and after warming up for a minimum of 10 minutes. Alignment appliances and tools. - IBM Compatible PC - Programmable Signal Generator. (eg. VG-819 made by Astrodesign Co.) - E(E)PROM with each mode data saved. - Alignment Adapter and Software. 1. Adjustment for Factory Preset Mode 1) Run alignment program for LG508K on the IBM compatible PC. 2) Select EEPROM All Init. command and Enter. 3) Display cross hatch pattern at Mode 1. 4) Select COMMAND PRESET START command. 5) Select EDID WRITE[A] [A6] command and Enter. 2. Adjustment for White Balance 1) Display color 0,0 pattern at Mode 13. 2) Set External Bright to MAX position and Contrast to MAX Position. 3) Select PRESET START BIAS CAL command and Enter. 4) No attempt to manually adjust, BIAS data is automatically adjusted and saved to the EEPROM. 5) Display color 15,0 pattern at Mode 13. 6) Select DRIVE CAL command and Enter. 7) Color 1 (9300K) and Color 2 (6500K) are automatically adjusted and saved to the EEPROM. 8) Select PRESET EXIT command and Enter.
A
Video Signal Generator
ed
IBM Compatible PC
9 15 10 5 11 6 1 5
6 1
C
13 1 14 25
PARALLEL PORT
RS 23 2C
No t
us
5V
OFF
ON
Control Line
EL
PA
RA
C
F
Power inlet (required)
220
LL
5V ON 4.7K 4.7K 4.7K 74LS06 74LS06
VG
PO
S MO NI
A
CS T
Power Select Switch (110V/220V) Power LED
WE R
5V
E
OFF
R
V-S
TO
YN
B
E ST Switch
B
F V-Sync On/Off Switch (Switch must be ON.)
Figure 1. Cable Connection
B-9
TROUBLESHOOTING GUIDE
1. NO POWER
NO POWER (POWER INDICATOR OFF)
CHECK J707 VOLTAGE PIN1&PIN2(12V) PIN4(5V)? YES CHECK U501 PIN 8 VOLTAGE (5V) ? YES
NO
CHECK POWER BOARD, AND FIND OUT A SHORT POINT AS OPENING EACH POWER LINE
NO
CHECK U803.
CHECK U805 Voltage (5V) ? YES
NO
CHECK 5V LINE (OPEN CHECK) NO PROBLEM
CHECK KEY CONTROL CONNECTOR ROUTINE
IS U201 PIN12 VOLTAGE REPEATED AS PULSE SHAPE ?
NO
NO
CHECK IIC LINE CONNECTION (U502)
CHECK U201 VCC, XTAL, RESET
B-10
2. NO RASTER (OSD IS NOT DISPLAYED) INVERTER
NO RASTER (OSD IS NOT DISPLAYED)
J705 PIN1 12V? YES
NO
CHECK POWER BOARD
J705 PIN8 5V? YES
NO
CHECK MICOM INV ON/OFF PORT.
J705 PIN7 5V?
NO
1. CONFIRM BRIGHTNESS OSD CONTRL STATE. 2. CHECK MICOM DIM-ADJ PORT
YES
CHECK PULSE AS CONTACTING SCOPE PROBE TO CAUTION LABEL. (CONTACT PROBE TO CAUTION LABEL. CAN YOU SEE PULSE AT YOUR SCOPE?
NO
REPLACE INVERTER ASS'Y
YES
REPLACE CCFL LAMP IN THE LCD MODULE
B-11
3. NO RASTER (OSD IS NOT DISPLAYED) gmZAN2
NO RASTER (OSD IS NOT DISPLAYED)
U201 POWER PINS 2.5V, 3.3V? YES
NO
CHECK U802, U806
U201 PIN141, 142 OSCILLATE AS 20M?
NO
1. CHECK PIN141, 142 SOLDERING CONDITION 2. CHECK X201 3. TROUBLE IN U201
YES
U401 PIN31 IS 65MHz CLOCK? PIN27 IS 48KHz H-SYNC? PIN28 IS 60Hz V-SYNC? PIN30 IS 48KHz DEN? IS PULSE APPEARED AT SIGNAL PINS?
NO
CHECK CONNECTION LINE FROM U201 TO U401
YES
U401 PIN1 3.3V?
NO
CHECK U805
YES TROUBLE IN CABLE OR LCD MODULE
B-12
4. NO RASTER (OSD IS DISPLAYED) gmZAN2
NO RASTER (OSD IS DISPLAYED) YES
U201 POWER PIN 3.3V? YES CHECK R,G,B INPUT? U201 PIN 87, 91, 95 YES
NO
CHECK U802, U806
NO
1. CHECK PC 2. CHECK SIGNAL CABLE & D-SUB CONNECTOR LINE
CHECK H-SYNC INPUT U201 PIN 150?
NO
CHECK H-SYNC LINE (D-SUBU701MICOM U201 PIN150)
B-13
1. MAIN BOARD (Component Side)
U502
PRINTED CIRCUIT BOARD
C820
J702
C514 R581 R580 U805 R571 R537 R533 R534 C503 C502 C813 R525 R529 C818 C819 R528 R531 R530 R510 C835 R805 U802 L806 R511 R512 C822 R582 C823 R515 R518 D801 R516 C830 R517 R526 C505 R523 R527 C506 U803 R501 R502 R503 R504 R505 R506 R507 R508 R509 C504 R720 L707 C715 RA501 RA502 R513 L706 C509 U501 R524 C507 C508 R519 C831 R520 C825 R521 R522 C515 C802 C801 C716 L711 C717 L708 C826 L805 RA202 C817 R810 C401 R811 L401 C516 Q506 C816 C706 R570 L701 R560
R561
C832
J706
R807
X201
R404 C410 C409 C408 C407 C406
R403
R712 L804 R713 C828 C829 R715 C403 C212 C223 C235 C210
R551 U701
R541 L710
C713
ZD501
PANNEL
C402
C270
Hydis
Q501
R535
R401
C512 R536 C513 C501
R539
120
L703 L702 L705 L704
U201
C404
C708 C709 R708 C711 C710 R709
R538
Q503
C824
5
U401 5VR 5V
RA206 RA205
C405
C214 R202
10
C731
R717 R735 C3
X501
U806
R201 C226 L201 C232
100
20
C827 C821
ZD702 R703 R205 D702 C258 C230 L204 C262 C259
30
R207 C225
C261
C205
RA201
RA203
C269 L203 L202 R204 C257
40
R203
C272
ARRAY NO.:#1
RA204
C203 C254 C202 C255 C201 C256 C204
C2 80
C209 R208 C208 R210 C207 R209
D701 D706
J705
J707
MODEL:LB500K & LG508K DATE :2002.07.29 P/N :6870T561A10
C220
C271
C211
L1
J703
R706
R701
B-14
C206
L803
C236
R734 D703
Q701
D704
R3 C1
R2
R1
R733
R716 ZD701
R722
D705
D1
C224
R206 C215
130
C712 R714 R711 R710
160
R705
D2
Q505
R532 Q502 C511
U1
1
EXPLODED VIEW
a 3
9 8 7 6
10
12
5
2
4
1
11
B-15
EXPLODED VIEW PARTS LIST
Note: SAFETY Mark
Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 a
Part No. 3091TKL041E 6304FTS003A 3809TKL027E 3043TKK078M 4951TKS085N 6633TZA003L 6871TPT223C 3313TL5056B 4950TKK424D 6631T11016C 6871TST245E 6850TD9001G 332-113E
Description CABINET ASSEMBLY, LG508J G/WAY LOCAL SUB_MATERIAL C/SKD LCD(LIQUID CRYSTAL DISPLAY), LTM15C462L TOSHIBA TFT COLOR XGA 15.0 INCH LVDS BACK COVER ASSEMBLY LG508J 3808TKL032A MX LOCAL TILT SWIVEL ASSEMBLY LG508J . MX, SEMI-CKD METAL ASSEMBLY, FRAME MAIN (LB500J,TOSHIBA) INVERTER ASSEMBLY, SAMSUNG LG1512 4-LAMP,LB500J,HYDIS PWB(PCB) ASSEMBLY,POWER, LB500J POWER TOTAL BRAND CL-32 MAIN TOTAL ASSEMBLY, LG508K G/WAY CL-32 TOSHIBA_MODULE METAL REAR LB508J C/SKD CONNECTOR ASSEMBLY 20P H-H 100MM UL20276 I/FACE CABLE LB500K PWB(PCB) ASSEMBLY,SUB, LG508J CONTROL TOTAL G/WAY CABLE,D-SUB, UL 2990-9C(7.5) DT 1870MM BLACK(9930) , DM SCREW, DRAWING, D3.0 L10.0 MSWR/BK
B-16
REPLACEMENT PARTS LIST
CAUTION: BEFORE REPLACING ANY OF THESE COMPONENTS, READ CAREFULLY THE SAFETY PRECAUTIONS IN THIS MANUAL. * NOTE : S SAFETY Mark AL ALTERNATIVE PARTS
*S *AL LOC. NO.
PART NO.
DATE: 2002. 10. 07. DESCRIPTION / SPECIFICATION
*S *AL LOC. NO. C512 C513 C514 C515 C516 C706 C712 C713 C715 C716 C717 C731 C801 C802 C813 C816 C817 C818 C819 C820 C821 C822 C823 C824 C825 C826 C827 C828 C829 C830 C831 C832 C835
PART NO. 0CC220CK41A 0CC220CK41A 0CH8106F611 0CC680CK41A 0CK104CK56A 0CK104CK56A 0CC101CK41A 0CK104CK56A 0CE106CK610 0CE107CH610 0CK104CK56A 0CC680CK41A 0CC102CK41A 0CK104CK56A 0CC102CK41A 0CK104CK56A 0CE107CF610 0CK104CK56A 0CC102CK41A 0CE107CF610 0CK104CK56A 0CK104CK56A 0CC102CK41A 0CH8107F611 0CE107CF610 0CK104CK56A 0CC102CK41A 0CK104CK56A 0CC102CK41A 0CE107CF610 0CH8107F611 0CH8107F611 0CK104CK56A
DATE: 2002. 10. 07. DESCRIPTION / SPECIFICATION 22PF 1608 50V 5% R/TP NP0 22PF 1608 50V 5% R/TP NP0 10UF 16V M 85STD(CYL) R/TP 68PF 1608 50V 5% R/TP NP0 0.1UF 1608 50V 10% R/TP X7R 0.1UF 1608 50V 10% R/TP X7R 100PF 1608 50V 5% R/TP NP0 0.1UF 1608 50V 10% R/TP X7R 10UF SHL,SD 50V 20% BULK FL 100UF SHL,SD 25V 20% BULK FL 0.1UF 1608 50V 10% R/TP X7R 68PF 1608 50V 5% R/TP NP0 1000PF 1608 50V 5% R/TP NP0 0.1UF 1608 50V 10% R/TP X7R 1000PF 1608 50V 5% R/TP NP0 0.1UF 1608 50V 10% R/TP X7R 100UF SHL,SD 16V 20% BULK FL 0.1UF 1608 50V 10% R/TP X7R 1000PF 1608 50V 5% R/TP NP0 100UF SHL,SD 16V 20% BULK FL 0.1UF 1608 50V 10% R/TP X7R 0.1UF 1608 50V 10% R/TP X7R 1000PF 1608 50V 5% R/TP NP0 100UF 16V M 85STD(CYL) R/TP 100UF SHL,SD 16V 20% BULK FL 0.1UF 1608 50V 10% R/TP X7R 1000PF 1608 50V 5% R/TP NP0 0.1UF 1608 50V 10% R/TP X7R 1000PF 1608 50V 5% R/TP NP0 100UF SHL,SD 16V 20% BULK FL 100UF 16V M 85STD(CYL) R/TP 100UF 16V M 85STD(CYL) R/TP 0.1UF 1608 50V 10% R/TP X7R
MAIN BOARD CAPACITORS
C1 C2 C3 C201 C202 C203 C204 C205 C206 C207 C208 C209 C210 C211 C212 C214 C215 C223 C224 C225 C226 C230 C254 C255 C256 C257 C258 C259 C261 C262 C269 C270 C271 C401 C402 C403 C404 C405 C406 C407 C408 C409 C410 C501 C502 C503 C504 C505 C506 C507 C508 C509 0CK104CK56A 0CK104CK56A 0CC680CK41A 0CC100CK41A 0CC100CK41A 0CC100CK41A 0CK104CK56A 0CK103CK51A 0CK104CK56A 0CK103CK51A 0CK103CK51A 0CK103CK51A 0CK103CK51A 0CK103CK51A 0CK103CK51A 0CK104CK56A 0CK103CK51A 0CC150CK41A 0CC150CK41A 0CC100CK41A 0CC680CK41A 0CC150CK41A 0CK103CK51A 0CK103CK51A 0CK103CK51A 0CK103CK51A 0CK103CK51A 0CK103CK51A 0CC680CK41A 0CC680CK41A 0CK103CK51A 0CK103CK51A 0CK103CK51A 0CK104CK56A 0CK104CK56A 0CK104CK56A 0CK104CK56A 0CK104CK56A 0CC100CK41A 0CC100CK41A 0CC100CK41A 0CC100CK41A 0CC100CK41A 0CK104CK56A 0CC101CK41A 0CC101CK41A 0CK104CK56A 0CC101CK41A 0CC101CK41A 0CK104CK56A 0CK104CK56A 0CK104CK56A 0.1UF 1608 50V 10% R/TP X7R 0.1UF 1608 50V 10% R/TP X7R 68PF 1608 50V 5% R/TP NP0 10PF 1608 50V 5% R/TP NP0 10PF 1608 50V 5% R/TP NP0 10PF 1608 50V 5% R/TP NP0 0.1UF 1608 50V 10% R/TP X7R 0.01UF 1608 50V 10% R/TP B(Y5P 0.1UF 1608 50V 10% R/TP X7R 0.01UF 1608 50V 10% R/TP B(Y5P 0.01UF 1608 50V 10% R/TP B(Y5P 0.01UF 1608 50V 10% R/TP B(Y5P 0.01UF 1608 50V 10% R/TP B(Y5P 0.01UF 1608 50V 10% R/TP B(Y5P 0.01UF 1608 50V 10% R/TP B(Y5P 0.1UF 1608 50V 10% R/TP X7R 0.01UF 1608 50V 10% R/TP B(Y5P 15PF 1608 50V 5% R/TP NP0 15PF 1608 50V 5% R/TP NP0 10PF 1608 50V 5% R/TP NP0 68PF 1608 50V 5% R/TP NP0 15PF 1608 50V 5% R/TP NP0 0.01UF 1608 50V 10% R/TP B(Y5P 0.01UF 1608 50V 10% R/TP B(Y5P 0.01UF 1608 50V 10% R/TP B(Y5P 0.01UF 1608 50V 10% R/TP B(Y5P 0.01UF 1608 50V 10% R/TP B(Y5P 0.01UF 1608 50V 10% R/TP B(Y5P 68PF 1608 50V 5% R/TP NP0 68PF 1608 50V 5% R/TP NP0 0.01UF 1608 50V 10% R/TP B(Y5P 0.01UF 1608 50V 10% R/TP B(Y5P 0.01UF 1608 50V 10% R/TP B(Y5P 0.1UF 1608 50V 10% R/TP X7R 0.1UF 1608 50V 10% R/TP X7R 0.1UF 1608 50V 10% R/TP X7R 0.1UF 1608 50V 10% R/TP X7R 0.1UF 1608 50V 10% R/TP X7R 10PF 1608 50V 5% R/TP NP0 10PF 1608 50V 5% R/TP NP0 10PF 1608 50V 5% R/TP NP0 10PF 1608 50V 5% R/TP NP0 10PF 1608 50V 5% R/TP NP0 0.1UF 1608 50V 10% R/TP X7R 100PF 1608 50V 5% R/TP NP0 100PF 1608 50V 5% R/TP NP0 0.1UF 1608 50V 10% R/TP X7R 100PF 1608 50V 5% R/TP NP0 100PF 1608 50V 5% R/TP NP0 0.1UF 1608 50V 10% R/TP X7R 0.1UF 1608 50V 10% R/TP X7R 0.1UF 1608 50V 10% R/TP X7R
DIODEs
D1 D2 D701 D702 D703 D704 D705 D706 D801 D903 D906 ZD501 0DS301109AA 0DS301109AA 0DS226009AA 0DS226009AA 0DS226009AA 0DS226009AA 0DS226009AA 0DS226009AA 0DS181009AA 0DRGS00281A 0DR206000AA 0DZ910009FE 0DZ560009GB MMBD301LT1 TP MOTOROLA SOT23 3 MMBD301LT1 TP MOTOROLA SOT23 3 KDS226 TP KEC SOT-23 80V 300M KDS226 TP KEC SOT-23 80V 300M KDS226 TP KEC SOT-23 80V 300M KDS226 TP KEC SOT-23 80V 300M KDS226 TP KEC SOT-23 80V 300M KDS226 TP KEC SOT-23 80V 300M KDS181 TP KEC SOT-23 80V 300 MBRF10H100CT GENERAL SEMICONDU MBRF2060CT BK G.I ITO220 60V 2 UDZS 9.1B TP ROHM - - 9.1V - BZT52C5V6S DIODES R/TP SOD323
ICs
U1 U201 0ICS240213A 0IPRPGA002A CAT24WC02J-TE13 8P SOP TP 2K I GMZAN2-160P GENESIS MICROCHIP
B-17
*S *AL LOC. NO. U401 U501 U502 U701 U802 U803 U805 U806 IC901
PART NO. 0ITH638300B 0IZZTSZ207A 0ISG240860B 0IMO741420B 0IPMGKE011A 0ISS780500H 0IRH033000A 0IPMGON007A 0IPMGPF004A
DATE: 2002. 10. 07. DESCRIPTION / SPECIFICATION THC63LVDM83R THINE 56P,TSSOP R MYSON 42PIN BK OTP LG508K M24C08W6 SGS-THOMSON 8SOP R/TP MC74HCT14ADR2 14P,SOIC TP LEVE KIA78D33F KEC DPAK R/TP 3.3V L KA78M05-R 3P,D-PAK TP 5V 0.5A BA033SFP P/MOLD-5 TP REGULATOR NCP1117ST25T3 ON SEMI SOT223 R TOP246F POWER INTEGRATION TO26
*S *AL LOC. NO. R504 R505 R506 R507 R508 R509 R510 R511 R512 R513 R515 R516 R517 R518 R519 R520 R521 R522 R523 R524 R525 R526 R527 R528 R529 R530 R531 R532 R533 R534 R535 R536 R537 R538 R539 R541 R551 R560 R570 R581 R582 R701 R703 R705 R706 R708 R709 R711 R712 R713 R714 R715 R716 R717 R722 R733 R734 R735 R805 R807 R810 R811
PART NO. 0RJ4701D677 0RJ1002D677 0RJ4701D677 0RJ1002D677 0RJ1002D677 0RJ4701D677 0RJ1000D677 0RJ4701D677 0RJ4701D677 0RJ1002D677 0RJ1000D677 0RJ4701D677 0RJ4701D677 0RJ4701D677 0RJ4701D677 0RJ4701D677 0RJ4701D677 0RJ1500D677 0RJ0332D677 0RJ0332D677 0RJ1000D677 0RJ4701D677 0RJ4701D677 0RJ1000D677 0RJ1000D677 0RJ1000D677 0RJ1000D677 0RJ3301D677 0RJ1500D677 0RJ1500D677 0RJ3301D677 0RJ1004D677 0RJ4701D677 0RJ2202D677 0RJ1002D677 0RJ1000D677 0RJ0000D677 0RJ0000D677 0RJ0000D677 0RJ0000D677 0RJ1002D677 0RJ0752D677 0RJ0752D677 0RJ4700D677 0RJ0752D677 0RJ1500D677 0RJ1500D677 0RJ0000D677 0RJ1000D677 0RJ1000D677 0RJ1000D677 0RJ4701D677 0RJ4701D677 0RJ4701D677 0RJ1001D677 0RJ1501D677 0RJ4701D677 0RJ0272D677 0RJ1001D677 0RJ1003D677 0RJ0221D677 0RJ0221D677
DATE: 2002. 10. 07. DESCRIPTION / SPECIFICATION 4.7K OHM 1/10 W 5% 1608 R/TP 10K OHM 1/10 W 5% 1608 R/TP 4.7K OHM 1/10 W 5% 1608 R/TP 10K OHM 1/10 W 5% 1608 R/TP 10K OHM 1/10 W 5% 1608 R/TP 4.7K OHM 1/10 W 5% 1608 R/TP 100 OHM 1/10 W 5% 1608 R/TP 4.7K OHM 1/10 W 5% 1608 R/TP 4.7K OHM 1/10 W 5% 1608 R/TP 10K OHM 1/10 W 5% 1608 R/TP 100 OHM 1/10 W 5% 1608 R/TP 4.7K OHM 1/10 W 5% 1608 R/TP 4.7K OHM 1/10 W 5% 1608 R/TP 4.7K OHM 1/10 W 5% 1608 R/TP 4.7K OHM 1/10 W 5% 1608 R/TP 4.7K OHM 1/10 W 5% 1608 R/TP 4.7K OHM 1/10 W 5% 1608 R/TP 150 OHM 1/10 W 5% 1608 R/TP 33 OHM 1/10 W 5% 1608 R/TP 33 OHM 1/10 W 5% 1608 R/TP 100 OHM 1/10 W 5% 1608 R/TP 4.7K OHM 1/10 W 5% 1608 R/TP 4.7K OHM 1/10 W 5% 1608 R/TP 100 OHM 1/10 W 5% 1608 R/TP 100 OHM 1/10 W 5% 1608 R/TP 100 OHM 1/10 W 5% 1608 R/TP 100 OHM 1/10 W 5% 1608 R/TP 3.3K OHM 1/10 W 5% 1608 R/TP 150 OHM 1/10 W 5% 1608 R/TP 150 OHM 1/10 W 5% 1608 R/TP 3.3K OHM 1/10 W 5% 1608 R/TP 1000000 OHM 1/10 W 5% 1608 R/T 4.7K OHM 1/10 W 5% 1608 R/TP 22K OHM 1/10 W 5% 1608 R/TP 10K OHM 1/10 W 5% 1608 R/TP 100 OHM 1/10 W 5% 1608 R/TP 0 OHM 1/10 W 5% 1608 R/TP 0 OHM 1/10 W 5% 1608 R/TP 0 OHM 1/10 W 5% 1608 R/TP 0 OHM 1/10 W 5% 1608 R/TP 10K OHM 1/10 W 5% 1608 R/TP 75 OHM 1/10 W 5% 1608 R/TP 75 OHM 1/10 W 5% 1608 R/TP 470 OHM 1/10 W 5% 1608 R/TP 75 OHM 1/10 W 5% 1608 R/TP 150 OHM 1/10 W 5% 1608 R/TP 150 OHM 1/10 W 5% 1608 R/TP 0 OHM 1/10 W 5% 1608 R/TP 100 OHM 1/10 W 5% 1608 R/TP 100 OHM 1/10 W 5% 1608 R/TP 100 OHM 1/10 W 5% 1608 R/TP 4.7K OHM 1/10 W 5% 1608 R/TP 4.7K OHM 1/10 W 5% 1608 R/TP 4.7K OHM 1/10 W 5% 1608 R/TP 1K OHM 1/10 W 5% 1608 R/TP 1.5K OHM 1/10 W 5% 1608 R/TP 4.7K OHM 1/10 W 5% 1608 R/TP 27 OHM 1/10 W 5% 1608 R/TP 1K OHM 1/10 W 5% 1608 R/TP 100K OHM 1/10 W 5% 1608 R/TP 2.2 OHM 1/10 W 5% 1608 R/TP 2.2 OHM 1/10 W 5% 1608 R/TP
COILs & COREs
L1 L201 L202 L203 L204 L401 L701 L702 L703 L704 L705 L706 L707 L708 L710 L711 L803 L804 L805 L806 6210TCE001S 6210TCE001P 6210TCE001P 6210TCE001P 6210TCE001P 6210TCE001G 6210TCE001S 6210TCE001P 6210TCE001P 6210TCE001P 6210TCE001P 6210TCE001P 6210TCE001P 6210TCE001S 6210TCE001G 6210TCE001G 6210TCE001G 6210TCE001G 6210TCE001G 6210TCE001G HU-1M2012-121 CERATECH 2012MM HB-1S2012-121JT CERATECH 2012M HB-1S2012-121JT CERATECH 2012M HB-1S2012-121JT CERATECH 2012M HB-1S2012-121JT CERATECH 2012M HH-1M3216-501 CERATEC 3216MM R HU-1M2012-121 CERATECH 2012MM HB-1S2012-121JT CERATECH 2012M HB-1S2012-121JT CERATECH 2012M HB-1S2012-121JT CERATECH 2012M HB-1S2012-121JT CERATECH 2012M HB-1S2012-121JT CERATECH 2012M HB-1S2012-121JT CERATECH 2012M HU-1M2012-121 CERATECH 2012MM HH-1M3216-501 CERATEC 3216MM R HH-1M3216-501 CERATEC 3216MM R HH-1M3216-501 CERATEC 3216MM R HH-1M3216-501 CERATEC 3216MM R HH-1M3216-501 CERATEC 3216MM R HH-1M3216-501 CERATEC 3216MM R
TRANSISTOR
Q502 Q503 Q505 Q506 Q701 0TR390409AE 0IKE704200H 0TR162309CA 0TR162309CA 0TR390409AE FAIRCHILD KST3904(LGEMTF) TP S KIA7042AP TO-92 TP 4.2 VOLT. KSC1623 TP SAMSUNG SOT23 NPN KSC1623 TP SAMSUNG SOT23 NPN FAIRCHILD KST3904(LGEMTF) TP S
RESISTORs
R1 R2 R3 R201 R202 R203 R204 R205 R206 R207 R208 R209 R210 R401 R403 R404 R501 R502 R503 0RJ1500D677 0RJ1500D677 0RJ4701D677 0RJ4701D677 0RJ4701D677 0RJ1000D677 0RJ1000D677 0RJ1000D677 0RJ2701D677 0RJ0332D677 0RJ1000D677 0RJ1000D677 0RJ1000D677 0RJ1002D677 0RJ1001D677 0RJ5601D477 0RJ4701D677 0RJ4701D677 0RJ4701D677 150 OHM 1/10 W 5% 1608 R/TP 150 OHM 1/10 W 5% 1608 R/TP 4.7K OHM 1/10 W 5% 1608 R/TP 4.7K OHM 1/10 W 5% 1608 R/TP 4.7K OHM 1/10 W 5% 1608 R/TP 100 OHM 1/10 W 5% 1608 R/TP 100 OHM 1/10 W 5% 1608 R/TP 100 OHM 1/10 W 5% 1608 R/TP 2.7K OHM 1/10 W 5% 1608 R/TP 33 OHM 1/10 W 5% 1608 R/TP 100 OHM 1/10 W 5% 1608 R/TP 100 OHM 1/10 W 5% 1608 R/TP 100 OHM 1/10 W 5% 1608 R/TP 10K OHM 1/10 W 5% 1608 R/TP 1K OHM 1/10 W 5% 1608 R/TP 5.6K OHM 1/10 W 1% 1608 R/TP 4.7K OHM 1/10 W 5% 1608 R/TP 4.7K OHM 1/10 W 5% 1608 R/TP 4.7K OHM 1/10 W 5% 1608 R/TP
B-18
*S *AL LOC. NO. RA201 RA202 RA203 RA204 RA205 RA206 RA501 RA502
PART NO. 0RHZTCZ001A 0RHZTCZ001A 0RHZTCZ001A 0RHZTCZ001A 0RHZTCZ001A 0RHZTCZ001A 0RHZTCZ001A 0RHZTCZ001A
DATE: 2002. 10. 07. DESCRIPTION / SPECIFICATION 100 OHM 1/16 W 5% 3215 R/TP CH 100 OHM 1/16 W 5% 3215 R/TP CH 100 OHM 1/16 W 5% 3215 R/TP CH 100 OHM 1/16 W 5% 3215 R/TP CH 100 OHM 1/16 W 5% 3215 R/TP CH 100 OHM 1/16 W 5% 3215 R/TP CH 100 OHM 1/16 W 5% 3215 R/TP CH 100 OHM 1/16 W 5% 3215 R/TP CH
*S *AL LOC. NO.
PART NO.
DATE: 2002. 10. 07. DESCRIPTION / SPECIFICATION
CONTROL BOARD
C1 C2 C3 LED1 R1 R2 R3 R4 R5 R6 R7 SW1 SW2 SW3 SW4 SW5 SW6 SW7 ZD1 ZD2 0CN1040K949 0CN1040K949 0CN1040K949 0DL305029BA 0RD4701Q509 0RD4701Q509 0RD1501Q509 0RD1501Q509 0RD3301Q509 0RD3301Q509 0RD9101Q609 140-058D 140-058D 140-058D 140-058D 140-058D 140-058D 140-058E 0DZ560009CE 0DZ560009CE 0.1M 50V Z F TA52 0.1M 50V Z F TA52 0.1M 50V Z F TA52 LTL-305DJ-0C2 TP LITEON GREEN/ 4.7K OHM 1/4 W (3.4) 2% TA52 4.7K OHM 1/4 W (3.4) 2% TA52 1.5K OHM 1/4 W (3.4) 2% TA52 1.5K OHM 1/4 W (3.4) 2% TA52 3.3K OHM 1/4 W (3.4) 2% TA52 3.3K OHM 1/4 W (3.4) 2% TA52 9.10K 1/4W(3 5% TA52 SKHV10911A LGEC NON 12 20 HORI SKHV10911A LGEC NON 12 20 HORI SKHV10911A LGEC NON 12 20 HORI SKHV10911A LGEC NON 12 20 HORI SKHV10911A LGEC NON 12 20 HORI SKHV10911A LGEC NON 12 20 HORI SKHV10910B LGEC NON 12V 20A HO MTZJ5.6B TP ROHM-K DO34 500MW MTZJ5.6B TP ROHM-K DO34 500MW
OTHERs
X201 X501 6212AA2004B 6212AA2004A HC-49U TXC 20.0MHZ +/- 30 PPM HC-49U TXC 12.0MHZ +/- 30 PPM
POWER BOARD
BD901 C901 C902 C902 C903 C903 C905 C906 C907 C908 C909 C911 C914 C916 C918 C920 C922 C923 D901 D904 D908 F901 IC904 LF901 P901 PC901 R901 R902 R903 R904 R905 R906 R907 R908 R909 R913 R917 R918 R920 R921 R923 T901 TH901 ZD901 0DD260000BE 0CBZTBU002D 0CKZTBU003D 0CKZTBU003D 0CKZTBU003D 0CKZTBU003D 0CZZTAB004B 0CK10201515 0CE105EK638 0CE476EH638 181-288B 0CE108EF630 0CE335EK638 181-288L 0CE108EF630 0CKZTBU003C 0CK10201515 0CK10201515 0DD400709CB 0DR400409AB 0DZ620009AP 0FZZTTH001E 0ISS431000A 6200TZZ001B 6620TKB002C 0ILI817000E 0RD6803A609 0RD1004Q609 0RD1004Q609 0RD4704Q609 0RD4704Q609 0RX4702J609 0RD0471Q609 0RD0681Q609 0RD1001Q609 0RN1302F409 0RD1201Q609 0RD1000Q609 0RN1302F409 0RN2701F409 0RD1202Q609 6170TMZ133A 6322A00002B 0DZ750009AG D2SB60 SHINDENKEN 0.33UF D 275V K M/PP NI FM22.5 SC SAMWHA 250V 1000PF M BULK 7 SC SAMWHA 250V 1000PF M BULK 7 SC SAMWHA 250V 1000PF M BULK 7 SC SAMWHA 250V 1000PF M BULK 7 KMG SYE / SWE 400V 68UF 20% BU 1000P 1KV K B TS 1UF KMG 50V M FM5 TP 5 47UF KMG 25V M FM5 TP 5 MKT 100V 104JTR PHS26104 1000UF KMG 16V M FM5 BULK 3.3UF KMG 50V M FM5 TP 5 MKT 100V 823JTR PHS26823 1000UF KMG 16V M FM5 BULK SC E 472M 14.0BW7 250V BK7.5 S 1000P 1KV K B TS 1000P 1KV K B TS UF4007 TP G.I DO204AL 1000V 1 UF4004 TP G.I DO204AL 400V 1A P6KE200A GENERAL SEMICONDUCTOR TIME LAG HBC 2153.15MXE(LEAD), KA431AZ (LM431AZ) - 0 BK L/FILTER, 9MH,LG56BP BCP031S-A,BAE EUN AC UNIVERSAL LTV-817M B 4P BK PHOTO COUPLER 680K OHM 1/2 W (7.0) 5% TA52 1M OHM 1/4 W (3.4) 5% TA52 1M OHM 1/4 W (3.4) 5% TA52 4.7M OHM 1/4 W (3.4) 5% TA52 4.7M OHM 1/4 W (3.4) 5% TA52 47K OHM 1 W 5% TA52 4.70 1/4W(3 5% TA52 6.8 OHM 1/4 W (3.4) 5% TA52 1K 1/4W(3 5% TA52 13K 1/6W 1% TA52 1.20K 1/4W(3 5% TA52 100 1/4W(3 5% TA52 13K 1/6W 1% TA52 2.70K 1/6W 1% TA52 12K 1/4W(3 5% TA52 EER3016 1200 UH V-10PIN LG500J SCK-102L THINKING 10OHM 20% 25 MTZJ7.5B TP ROHM-K DO34 0.5W 7
B-19
PIN CONFIGURATION
CAT24WC08J-TE13 8P
BLOCK DIAGRAM
DIP Package(p)
A0 A1 A2 V SS 1 2 3 4 8 7 6 5 VCC WP SCL SDA
SOIX Package(J)
EXTERNAL LOAD A0 A1 A2 V SS 1 2 3 4 8 7 6 5 VCC WP SCL SDA
V CC V SS WORD ADDRESS BUFFERS COLUMN DECODERS
D OUT ACK
SENSE AMPS SHIFT REGISTERS
TSSOP Package(U)
SDA START/STOP LOGIC
A0 A1 A2 V SS
1 2 3 4
8 7 6 5
VCC WP SCL SDA
WP CONTROL LOGIC XDEC E 2 PROM
PIN CONFIGURATION PIN FUNCTION
DATA IN STORAGE
Pin Name
A0, A1, A2 SDA SCL WP Vcc Vss
Function
Device Adress Inputs Serial Data/Address
SCL STATE COUNTERS SLAVE ADDRESS COMPARATORS HIGH VOLTAGE/ TIMING CONTROL
Serial Clock Write Protect +1.8V to + 6.0V power Supply Ground
A0 A1 A2
MC74HCT14ADR2 14P
BLOCK DIAGRAM
A1
1
2
Y1
A1 Y1 A2 Y2 A3 Y3 GND
1 2 3 4 5 6 7
14 13 12 11 10 9 8
VCC AS Y6 A5
A4 A2
3
4
Y2
A3
5
6
Y3
9
8
Y4
Y5 A4 Y4
A6 A5
11
10
Y5
13
12
Y6
PIN CONFIGURATION
PIN 14=VCC PIN 7=GND
B-20
SCHEMATIC DIAGRAM
1. GMZAN2
B-21
2. LVDS
B-22
3. MICOM
B-23
4. DC/DC BLOCK
B-24
5. CONNECTOR & JACKS
C3
B-25
6. CONTROL
B-26
7. POWER
B-27
P/NO : 3828TSO045D
Oct. 2002 Printed in Korea