Text preview for : al722sg.pdf part of Acer al722sg LCD Monitor
Back to : al722sg.pdf | Home
1. ELECTRICAL REQUIREMENTS..................................................................... 2
A. LCD Panel Specification............................................................................................................................................2
B. CONTROLS ..............................................................................................................................................................3
C. Power Management ...................................................................................................................................................3
D. Display Modes FOR Inspections ...............................................................................................................................4
2. VL-710 DISPLAY CONTROL BOARD............................................................. 5
A. Description.................................................................................................................................................................5
B. Features......................................................................................................................................................................5
C. BLOCK DIAGRAM..................................................................................................................................................5
D. Connector Locations ..................................................................................................................................................6
E. Connector Type..........................................................................................................................................................6
F. Connector pin assignment..........................................................................................................................................6
3. VK-715 Control Panel and Audio Board ............................................................ 9
E. Description.................................................................................................................................................................9
F. Electrical characteristics (Tamb=25°)........................................................................................................................9
G. Connector and Switch Locations ...............................................................................................................................9
H. Connector and Switch Locations ...............................................................................................................................9
I. Connector pin Assignment.........................................................................................................................................10
J. J2................................................................................................................................................................................10
K. Switch definition........................................................................................................................................................11
L. LED definition ...........................................................................................................................................................11
M. Variable resistor .........................................................................................................................................................11
4. DC/DC POWER and Audio CKT VM-517 ........................................................ 12
A. Input:..........................................................................................................................................................................12
B. Output: .......................................................................................................................................................................12
C. Efficiency: 80% min at Maximum Load....................................................................................................................12
D. Connector Locations ..................................................................................................................................................12
E. Connector type for VM-515.......................................................................................................................................12
F. Connector pin Assignment.........................................................................................................................................13
5. PK070011400/LIENHANG INVERTER BOARD............................................. 14
A. Description.................................................................................................................................................................14
B. Electrical characteristics ............................................................................................................................................14
C. Connector locations ...................................................................................................................................................15
D. Connector pin Assignment.........................................................................................................................................15
6. AC Adapter (LSL9901B12320) ............................................................................ 16
A. Quick specification review ........................................................................................................................................16
7. CIRCUIT DESCRPTION .................................................................................... 16
A. Display-Controller .....................................................................................................................................................16
B. Circuit of Plug and Play.............................................................................................................................................16
C. Power Regulator ........................................................................................................................................................16
8. Introduction ........................................................................................................... 17
A. Front Panel Control and Led......................................................................................................................................17
B. Rear Panel connector Input Signals ...........................................................................................................................18
C. Rear Panel Cable and Connector ...............................................................................................................................18
9. TROUBLESHOOTING........................................................................................ 19
A. Main Procedure..........................................................................................................................................................19
Appendix A: Parts Lists ----------------------------------------------------------------------------------------
24
Appendix B: Display Unit Assembly ------------------------------------------------------------------------29
Appendix C: P.C.B.A Assembly ------------------------------------------------------------------------------
39
1
1. ELECTRICAL REQUIREMENTS
A. LCD Panel Specification
Display: 17 inch (17" viewable image size): active matrix: thin film transistor
(TFT): liquid crystal display (LCD): 0.264 mm dot pitch: R.G.B.
Vertical stripe 200 cd//m2 white luminance, typical: 200:1 contrast
ratio, Min.
Compatibility: 640 x 350: VGA-350
720 x 400: VGA text
640 x 480: VGA, 60Hz to 75 Hz vertical refresh rate
800 x 600: 56Hz to 75 Hz vertical refresh rate
1024 x 768 non-interlaced: 60Hz to 75 Hz vertical refresh rate
1280 x 1024 non-interlaced: 60Hz to 75 Hz vertical refresh rate
Synchronization Horizontal: 24 kHz to 80 kHz
Frequencies: Vertical: 56 Hz to 75 Hz
Pixel Frequency: 21 Mhz 135 Mhz
Resolution: Horizontal: 1280 dots
Vertical: 1024 lines
Active Display Horizontal: 337.92 mm
Area:
Vertical: 270.34 mm
Viewing Angles: Up 40deg down 80deg (TYP)
Left 60deg, Right 80deg (TYP)
CR 10
Display Colors: 16,777,216 (with FRC)
Power Supply: AC 100 to 240V worldwide input, 50 / 60Hz
Power Consumption: Typical:50W on mode +10 / -25%
Environmental: Operating temperature: 0ºC to 50ºC
Storage temperature: -20ºC to 65ºC
Relative Humidity: 20%~80%
2
B. CONTROLS
B-1 Control panel (monitor front panel)
1. Power LED
2. Adjust decrease.
3. Adjust increase.
4. Function select counter-clockwise.
5. Function select clockwise.
6. Power ON/OFF switch, push to ON and push to OFF. (toggle switch)
7. Ear phone jack.
8. Volume Control.
C. Power Management
C-1 Power Management
1. Meet VESA DPMS proposal
2. Power Consumption
Meet VESA DPMS Proposal
On mode 54 Wmax Green
Stand-by 5 Wmax Yellow
Suspend 5 Wmax Yellow
Off mode 5 Wmax Yellow
DC power off 5 Wmax Dark
Dark (DC power off)
disconnection 5 Wmax Yellow (DC power
on)
Power saving states are measured with speakers attached but not worked.
The recovery time from stand by /suspend/off mode to on mode is 3 seconds maximun.
C-2 Power Consumption
Meet VESA DPMS Proposal
On mode 54 Wmax
Stand-by 5 Wmax
Suspend 5 Wmax
Off mode 5 Wmax
DC power off 5 Wmax
disconnection 5 Wmax
1. Measured from AC input end of AC power adapter.
2. Power saving states are measured with speakers attached but not worked.
3
D. Display Modes FOR Inspections
D-1 Supported Timing
FH(KH SYNC TOTAL ACTIVE SYNC FRONT BACK PIXEL
TIMING Z)
FV(HZ) POLARITY (DOT/LINE) (DOT/LINE) WIDTH PORCH PORCH FOREQ.(MHZ)
(DOT/LINE) (DOT/LINE) (DOT/LINE)
640x350 31.469 800 640 96 16 48 25.175
VGA-350 70.087 449 350 2 37 60
640x400 24.83 848 640 64 64 80 21.05
NEC PC9801 56.42 440 400 8 7 25
640x400 31.5 800 640 64 16 80 25.197
NEC PC9821 70.15 449 400 2 13 34
640x480 31.469 800 640 96 16 48 25.175
VGA-480 59.94 525 480 2 10 33
640x480 35 832 640 40 24 128 31.5
APPLE MAC- 66.67 520 480 3 9 28
480
640x480 37.861 832 640 40 16 120 31.5
VESA-480-72Hz 72.809 520 480 3 1 20
640x480 37.5 840 640 64 16 120 31.5
VESA-480-75Hz 75 500 480 3 1 16
720x400 31.469 900 720 108 18 54 28.322
VGA-400-TEXT 70.087 449 400 2 12 35
832x624 49.725 1152 832 64 32 224 57.2832
APPLE MAC- 74.55 667 624 3 1 39
800
800x600 35.156 1024 800 72 24 128 36
SVGA 56.25 625 600 2 1 22
800x600 37.879 1056 800 128 40 88 40
VESA-600-60Hz 60.317 628 600 4 1 23
800x600 48.077 1040 800 120 56 64 50
VESA-600-72Hz 72.188 666 600 6 37 23
800x600 46.875 1056 800 80 16 160 49.5
VESA-600-75Hz 75 625 600 3 1 21
1024x768 48.363 1344 1024 136 24 160 65
XGA 60.004 806 768 6 3 29
1024x768 53.964 1328 1024 176 16 112 71.664
COMPAQ-XGA 66.132 816 768 4 8 36
1024x768 56.476 1328 1024 136 24 144 75
VESA-768-70Hz 70.069 806 768 6 3 29
1024x768 60.023 1312 1024 96 16 176 78.75
VESA-768-75Hz 75.029 800 768 3 1 28
1024x768 60.24 1328 1024 96 32 176 80
APPLE MAC- 75.02 803 768 3 3 29
768
1280x1024 64 1688 1280 112 48 248 108
VESA-1024- 60 1066 1024 3 1 38
60Hz
1280x1024 80 1688 1280 144 16 248 135
VESA-1024- 75 1066 1024 3 1 38
75Hz
If the input timing is not a supported timing listed above but within the supported frequency range
(Horizontal:80KHz,Vertical:75Hz),this monitor will select a closest mode instead,But the display
quality may not be optimized.
4
2. VL-710 DISPLAY CONTROL BOARD
A. Description
The VL-710 display control board is design to directly convert the analog RGB signals from
standard VGA display card to optimum LCD timing signals so as to construct a high display
quality LCD monitor.
B. Features
· On board embedded micro-processor to detect display timings and control user functions.
· Using MXIC design to generate optimum LCD timings.
2
· Using E PROM to memorize every adjusted parameter.
· support up to 22 display modes from VGA to SXGA.
· Offer full screen expansion function on non-SXGA mode (automatic).
· flexible color temperature selection function including 9300,6500 and user mode.
· Support OSD functions.
· Support VESA DPMS function.
· Support DDC1/2B functions.
· Support 5 languages for OSD description.
· The longest time for mode change is 3 seconds.
C. BLOCK DIAGRAM
5
D. Connector Locations
E. Connector Type
Location Type Maker Number of pins
CN1 DZ11A91-L8 P1.524 FEMALE 15
JP1 85205-1200 ACES 12
J1 85205-1400 ACES 4
J2 85205-1000 ACES 10
J3 E&T 46213-4001D-40P-P1.25 E&T 40
F. Connector pin assignment
F-1 CN1
Pin NO. Signal Comment
1 R-Video Red Video Input.
2 G-Video Green Video Input.
3 B-Video Blue Video Input.
4 N. C.
5 PCDETECT PCDETECT Input.
6 Ground Ground.
7 Ground Ground.
8 Ground Ground
9 5VCC DDC Power Input.
10 Ground Ground.
11 NC
12 SDA DDC 1/2B
13 HS Horizontal Sync Input.
14 VS Vertical Sync Input.
15 SCL DDC 2B
6
F-2 CN7
Terminal No. Symbol Function
1, 3, 5, 7 VDD 5V POWER SUPPLY
2 TXE0- LVDS EVEN OUTPUT DATA PAIRS
4 TXE0+ LVDS EVEN OUTPUT DATA PAIRS
6 TXE1- LVDS EVEN OUTPUT DATA PAIRS
8 TXE1+ LVDS EVEN OUTPUT DATA PAIRS
10 TXE2- LVDS EVEN OUTPUT DATA PAIRS
12 TXE2+ LVDS EVEN OUTPUT DATA PAIRS
14 TXECLK- LVDS EVEN OUTPUT DATA PAIRS
16 TXECLK+ LVDS EVEN OUTPUT DATA PAIRS
18 TXE3- LVDS EVEN OUTPUT DATA PAIRS
20 TXE3+ LVDS EVEN OUTPUT DATA PAIRS
22 TXO0- LVDS ODD OUTPUT DATA PAIRS
24 TXO0+ LVDS ODD OUTPUT DATA PAIRS
26 TXO1- LVDS ODD OUTPUT DATA PAIRS
28 TXO1+ LVDS ODD OUTPUT DATA PAIRS
30 TXO2- LVDS ODD OUTPUT DATA PAIRS
32 TXO2+ LVDS ODD OUTPUT DATA PAIRS
34 TXOCLK- LVDS ODD OUTPUT DATA PAIRS
36 TXOCLK+ LVDS ODD OUTPUT DATA PAIRS
38 TXO3- LVDS ODD OUTPUT DATA PAIRS
40 TXO3+ LVDS ODD OUTPUT DATA PAIRS
9, 11, 13, 15 GND Ground
17, 19, 21, 23 GND Ground
25, 27, 29, 31 GND Ground
33, 35, 37, 39 GND Ground
7
F-3 CN3
Pin NO. Signal Comment
1,2,3 12 VCC Inverter Power Output.
4 BLON Bright Light ON/OFF.
5,6,10,11,12 GND GND
7,8 5 VCC Inverter Power Output.
9 BRIGHT Brightness Adjustment.
F-4 CN8
Pin NO. Signal Comment
1 12 VCC 12 VCC Power Input
2 5 VCC 5V Power Input
3 GND GND
4 GND GND
F-5 CN4
Pin NO. Signal Comment
1 MUTE Volume adjust power input
2 LED-Y Power saving mode
3 LED-G Monitor is ON
4 GND GND
5 KEY-UP Function select counter-clockwise key
6 KEY-DOWN Function select counter-clockwise key
7 KEY-R Adjust up key
8 KEY-L Adjust down key
9 KEY-POWER Power ON/OFF key
10 GND GND
8
3. VK-715 Control Panel and Audio Board
E. Description
The VK-715 is designed to offer a user interfaced control panel which passes and receives signals to and from
VL-710 display control board. Also there is a stereo audio amplifier to drive a pair of speakers. When in power
saving mode the audio circuit can be turned off by the control signal from VL-710 board.
F. Electrical characteristics (Tamb=25°)
Audio amplifier(USE Panasonic VP-7723A Audio Analyzor.
Item Audio Input Freq. Spec. Comment
Min. Typ. Max.
Input Voltage(V) 8.4 9 9.6
Input Current(m A) - 500 800
Audio Voltage Gain 50m Vrms 1KHz - - 14d B Volume Max.,load 8
Frequency Response 100m Vrms 50Hz-20KHz -3dB - +3d B Volume Max.,load 8
Signal to Noise ratio 500m Vrms 1KHz - - -70d B Volume Max.,load 8
Cross talk 100m Vrms 1KHz - - -60d B Volume Max.,load 8
Distortion 500m Vrms 1KHz - - 1% Volume Max.,load 8
Output Watt. 500m Vrms 1KHz - - 0.5W Volume Max.,load 8
Volume Control - - - Analog
Speakersmodel:4Ø28CP
2X2w speaker; Impedance 8 at 1KHz
G. Connector and Switch Locations
H. Connector and Switch Locations
Location Type Maker Number of pins
J1 96113-0813 E&T 8
J2 SCJ-0348-C SC 9
J3 87502-0200 ACES 2
J4 87502-0200 ACES 2
J5 96113-1013 E&T 10
9
I. Connector pin Assignment
E-1 J1
Pin NO. Signal Comment
1 VOL Audio Volume Adjust
2,5,8 GND GND
3 OUTL - Left side audio signal
4 OUTL + Left side audio signal
6 OUTL - Right side audio signal
7 OUTL + Right side audio signal
E-2 J5
Pin NO. Signal Comment
1 MUTE Volume adjust power input.
2 LED-Y Power saving mode.
3 LED-G Monitor on mode.
4,10 GND
5 KEY-UP Function select up to VL-515
6 KEY-DOWN Function select down to VL-515
7 KEY-R Function select right to VL-515
8 KEY-L Function select left to VL-515
9 KEY-PWR Power ON/OFF signal to VL-515
E-3 J3 and J4
Pin NO. Signal Comment
1 LO (RO) Speaker out
2 OUTL- (OUTR-) Speaker out
J. J2
Pin NO. Signal I/O Comment
1 GND Ground
2 LI 2 Earphone out L
3 RI 2 Earphone out R
4 LI 1 Earphone out L
5 LO Speaker out L
6 NC No connector
7 RI 1 Earphone out R
8 RO Speaker out R
10
K. Switch definition
Location Definition
S1 Power ON/OFF
S2 Function select by clockwise direction
S3 Function select by counter-clockwise direction
S4 Adjust up
S5 Adjust down
L. LED definition
Location Definition
D1 Green for ON mode; Yellow for OFF mode; yellow for Power Saving mode; Dark for
DC power OFF mode.
M. Variable resistor
VR1: Volume control, clockwise for increasing; counter-clockwise for decreasing
11
4. DC/DC POWER and Audio CKT VM-517
A. Input:
12V ±5% from adapter (LSE 9901B1260)
B. Output:
ITEM Output Voltage Max Load. Min Load Tolerance Ripple & Noise(max)
VCC +5V 1.9A 0.25A ±5% 150mVpp
C. Efficiency: 80% min at Maximum Load.
D. Connector Locations
E. Connector type for VM-515
Location Type Maker Number of pins
J801 DC-IN SC 2
J3 SCJ-0345-1-X-S SC 3
J2 96113-0803 E&T 8
J802 B4B-XH-A JST 4
12
F. Connector pin Assignment
F-1 J801 DC 12V Input
Pin No Signal Comment
Pin 1 +12V From adapter output cable
Pin 2 GND From adapter output cable
F-2 J802 FOR I/F CKT
Pin No Signal Comment
Pin 1 +12V From adapter +12V power
Pin 3, 4 GND GND
Pin 2 +5V Supply for I/F CKT
F-3 J3 FOR Audio input
Pin No Signal Comment
Pin 1 GND GND
Pin 2 Audio IN (1) From Audio output (1)
Pin 3 Audio IN (2) From Audio output (2)
F-4 J2 TO Speaker CKT
Pin No Signal Comment
Pin 2, 5, 8 AGND GND
Pin 1 Volume voltage To adjustment volume
Pin 3 Audio out L- From AMP L-
Pin 4 Audio out L+ From AMP L+
Pin 6 Audio out R- From AMP R-
Pin 7 Audio out R+ From AMP R+
13
5. PK070011400/LIENHANG INVERTER BOARD
A. Description
The LI-2098 Inverter board is designed for lighting up the back-lights of LCD module.
B. Electrical characteristics
B-1 FOR FUJITSU PANEL (FLC44SXC8V)
MIN. TYP. MAX. COMMENT
INPUT VOLTAGE 11.4V 12.0V 12.6V 12V±5%
Vin=12V,Vbrite=3.7
INPUT CURRENT -------- 2.1A _
5V
Normal BACKLIGHT
-------- 700 Vrms. --------
VOLTAGE
LAMP CURRENT Each CCFL
4m 6mArms 7m
DRIVING
40KHz 50KHZ 60KHz
FREQUENCY
Vin = 12V,max
EFFICIENCY -------- 78% --------
brightness
PWM dimming
160Hz 180Hz 200Hz
frequency
Vin ON/OFF
-------- 0.5S --------
sequence
Open lamp
OLP TIME -------- 1S _
protection time
BRIGHTNESS
30% -------- 100%
RANGE
Brightness control 0V _ 3.75V 3.75V, brightness
max
Brightness 170 cd/m2 220cd/m2 _
Strike voltage at 0°C _ _ 1500 Vrms
Strike voltage at 25°C _ 1300 Vrms 1500 Vrms
Operating life time 50,000 hrs _ _ (note)
Note:
Life time (hr) can be defined as the time in which it continues to operate under the condition:
Ta=25±2°C, IL =12 mArms until one of the following event occurs:
1. When the brightness becomes 50 %
2. When the startup voltage (Vs) at 0°C becomes higher than the maximal value of Vs specified above.
14
C. Connector locations
D. Connector pin Assignment
D-1 CN1(ACES, 85205-1200 12P)
Pin NO. Signal Comment
1,2,3 BP+ +12V
5,6,10,11,12 GND GND
4 BLT_ON Back-light ON/OFF control , high active(5V)
7 +5VS +5VS
9 BRITE BRITE Brightness (0-5V)control from I/F
0V for max. brightness
8 NC NC
D-2 CN2,CN3 (JST SM04(4.0)B-BHS-14P)
Pin NO. Signal Comment
1 HV High voltage for lamp
2 HV High voltage for lamp
3 NC NC
4 LV Low voltage (common)
15
6. AC Adapter (LSL9901B12320)
A. Quick specification review
· Input voltage
Single phase, 50/60HZ, 100VAC to 240VAC ±10%
· Input current
1.5A (max), at 90VAC input and full load 0.75A (max), at 264 VAC input and full
load.
· Inrush current @ cold start
30A(0-peak)@ 110Vac ,50A(0-peak) @ 220Vac
· Output
Tolerance Output Current
Volt Tolerance
Output Volt - MIN MAX
+12Vdc ±5% 0A 5A 11.4~12.6Vdc
· Total output power: 60 Watt max.
· Efficiency
80% min. @115V/230VAC, maximum load.
· Dimension: 110Lx63Wx31H
7. CIRCUIT DESCRPTION
A. Display-Controller
The U6 is image processor. The functions of the CHIP support as below:
1. Hight quality image scalar
2. On screen display
3. Automatic image optimizer
B. Circuit of Plug and Play
Plug and play allows the serial communication of host PC and peripherals offering minimal
configurations to end users. This monitor supports DDC2B communication protocal.
C. Power Regulator
1. The U5 (APL5883) & U14(APL1085)are linear requlator that transfer input voltage from
5V to 3.3V.
2. The U7 (APL1117) is linear requlator that transfer input voltage from 5V to 2.5V.
16
8. Introduction
A. Front Panel Control and Led
Front Panel Controls
Item Control Function
1 Stereo Speakers PC Audio Stereo output.
2 Increase Volume - Turn the knob clock wise.
Speaker Volume Control
Decrease Volume - Turn the knob counter clock wise.
3 Press the power switch to switch the monitor ON/OFF.
DC Power Switch
4 LED lights Green color --- Power is ON.
DC Power-On Indicator LED lights Yellow --- Monitor is in "Power Saving Mode".
LED is off --- Power is OFF.
5 Press either left or right control button for OSD (On Screen Display) menu
Function Select Buttons
selection.
6 Press the left button to decrease the OSD setting and press the right button to
Adjustment Control Buttons
increase the OSD setting.
7 The monitor speakers will be disabled when using an external headphone or
External Headphone Jack
external speakers.
17
B. Rear Panel connector Input Signals
C. Rear Panel Cable and Connector
Item Cable / Connector Function
1 Signal Connector Connectors the video cable
2 Power Connector Connectors the adapter cable
3 Audio connector Connector the audio cable
18
9. TROUBLESHOOTING
A. Main Procedure
CM67B
19
Power Circuit Troubleshooting
20
Backlights Troubleshooting
21
Performance Troubleshooting
22
Function Troubleshooting
23
APPENDIX A: PARTS LISTS
24
A. FRU Board
A-1 PCBA Inverter board
A-2 454A8130001 PCBA Key Board (VK-715)
A-3 455A3330021 PCBA Audio Board (VM-517)
25
A-4 461A7830011Firmware CTRLl Board (VL-710)
26
A. FRU BOM LIST
Product Line: Monitor System
Product Family:
System Model:ABO_AL722(ET.72202.00X),X=4,5,9.
SUGGEST
2 months COMMENT FOR MINIMAL DEFECT PARTS LOCAL
ACER PART Compal PART Common/ Rolling REFERNCE/MB Unit Price Action ORDER RETURN/SCRAP/ BUY INDIVIDUAL
LEVEL Acer F/G P/N Compal F/G P/N CATEGORY PARTNAME DESCRIPTION NO. NO. Unique TAT Forecast LOCATION (US) Code Q'TY VENDOR S/N COLLECT (YES/NO) PACK(YES/NO)
1 ET.72202.004/005/009 LAM67BY1003/1004/1010 BOARDS INVERTER/POWER BOARD PCBA INVERTER&POWER PK070011600 U 4WKS REQUIRED SYSTEM 13.32 30 LOCAL SCRAP NO NO
1 ET.72202.004/005/009 LAM67BY1003/1004/1010 BOARDS KEY BOARD PCBA KEY 454A8130001 U 4WKS REQUIRED SYSTEM 3.50 30 LOCAL SCRAP NO NO
FIRMWARE CONTROL
1 ET.72202.004/005/009 LAM67BY1003/1004/1010 BOARDS BOARD(M/B) FIRMWARE CTRL (M/B) 461A7030032 U 4WKS REQUIRED SYSTEM 28.81 30 LOCAL REPAIR/LOCAL SCRAP NO NO
1 ET.72202.004/005/009 LAM67BY1003/1004/1010 BOARDS PCBA AUDIO BOARD PCBA AUDIO 455A3330021 U 4WKS REQUIRED SYSTEM 7.99 30 LOCAL SCRAP NO NO
1 ET.72202.004/005/009 LAM67BY1003/1004/1010 CABLE LCD NET WIR SET NET WIR SET NA200150000 U 4WKS REQUIRED 0.15 50 LOCAL SCRAP NO NO
1 ET.72202.004/005/009 LAM67BY1003/1004/1010 CABLE KEY BOARD CABLE H-CON SET DC020143400 U 4WKS REQUIRED 1.04 50 LOCAL SCRAP NO NO
1 ET.72202.004/005/009 LAM67BY1003/1004/1010 CABLE CABLE CB ASY DC190013710 U 4WKS REQUIRED 0.67 50 LOCAL SCRAP NO NO
1 ET.72202.004/005/009 LAM67BY1003/1004/1010 CABLE SINGLE CABLE CB ASY DC190020400 U 4WKS REQUIRED 3.07 50 LOCAL SCRAP NO NO
1 ET.72202.009 LAM67BY1010 CABLE POWER CORD( EU) POWER CORD( EU) GA0200000C0 U 4WKS REQUIRED 1.78 50 LOCAL SCRAP NO NO
1 ET.72202.009 LAM67BY1010 CABLE POWER CORD( EU) POWER CORD( EU) GA040080200 U 4WKS REQUIRED 4.55 50 LOCAL SCRAP NO NO
1 ET.72202.009 LAM67BY1010 CABLE POWER CORD( EU) POWER CORD( EU) GA070030200 U 4WKS REQUIRED 3.06 50 LOCAL SCRAP NO NO
1 ET.72202.005 LAM67BY1003 CABLE POWER CORD (AU) POWER CORD (AU) GA060000210 U 4WKS REQUIRED 2.26 50 LOCAL SCRAP NO NO
CASE/COVER/BRAC
1 ET.72202.004/005/009 LAM67BY1003/1004/1010 KET ASSEMBLY LCD COVER ASSY LCD COVER FACM871B011 U 4WKS REQUIRED 7.31 50 LOCAL SCRAP NO NO
CASE/COVER/BRAC
1 ET.72202.004/005/009 LAM67BY1003/1004/1010 KET ASSEMBLY LCD BEZEL A'SSY (ACER) LCD BEZEL A'SSY (ACER) FAAM671A100 U 4WKS REQUIRED 8.44 50 LOCAL SCRAP NO NO
CASE/COVER/BRAC
1 ET.72202.004/005/009 LAM67BY1003/1004/1010 KET ASSEMBLY CHASSIS CHASSIS FAAM671A100 U 4WKS REQUIRED 6.08 50 LOCAL SCRAP NO NO
CASE/COVER/BRAC
1 ET.72202.004/005/009 LAM67BY1003/1004/1010 KET ASSEMBLY EMI SHIELD EMI SHIELD ECCM8814000 U 4WKS REQUIRED 1.83 50 LOCAL SCRAP NO NO
CASE/COVER/BRAC
1 ET.72202.004/005/009 LAM67BY1003/1004/1010 KET ASSEMBLY STAND NECK(BASE) STAND NECK(BASE) FAAM671C000 U 4WKS REQUIRED 6.22 50 LOCAL SCRAP NO NO
CASE/COVER/BRAC
1 ET.72202.004/005/009 LAM67BY1003/1004/1010 KET ASSEMBLY HINGE HINGE ECCM872A000 U 4WKS REQUIRED 5.84 50 LOCAL SCRAP NO NO
1 ET.72202.004/005/009 LAM67BY1003/1004/1010 LCD HT17E11-300 17.0" (HYDIS) HT17E11-300 17.0" (HYDIS) AC600019810 C 4WKS REQUIRED 388.50 20 RETURN NO NO
3 ET.72202.004/005/009 LAM67BY1003/1004/1010 PCB COMPONENT S IC CS5824 TSSOP-56 LV SA582400100 C 2WKS U11 3.30 50 LOCAL SCRAP NO NO
27
3 ET.72202.004/005/009 LAM67BY1003/1004/1010 PCB COMPONENT S IC SM2965C40J PLCC-44 SA029650000 C 2WKS U9 3.90 50 LOCAL SCRAP NO NO
3 ET.72202.004/005/009 LAM67BY1003/1004/1010 PCB COMPONENT SM DIODE 1N4148 (SM) SC11N4148T8 C 2WKS D802 0.03 50 LOCAL SCRAP NO NO
3 ET.72202.004/005/009 LAM67BY1003/1004/1010 PCB COMPONENT FPC CM87C VF-706 REV1 DA3M87CV010 C 2WKS FPC 7.32 20 LOCAL SCRAP NO NO
3 ET.72202.004/005/009 LAM67BY1003/1004/1010 PCB COMPONENT S IC MX88L250EC-S QFP12 SA882500100 C 2WKS U6 8.75 50 LOCAL SCRAP NO NO
3 ET.72202.004/005/009 LAM67BY1003/1004/1010 PCB COMPONENT S IC CS5824 TSSOP-56 LV SA582400100 C 2WKS U11 3.30 50 LOCAL SCRAP NO NO
3 ET.72202.004/005/009 LAM67BY1003/1004/1010 PCB COMPONENT SM IC EE 16K SO-8 C AT24 SA024160100 C 2WKS U10 0.68 50 LOCAL SCRAP NO NO
3 ET.72202.004/005/009 LAM67BY1003/1004/1010 PCB COMPONENT SM IC MAX810MTR SOT-23 4 SA008100400 C 2WKS U8 0.56 50 LOCAL SCRAP NO NO
3 ET.72202.004/005/009 LAM67BY1003/1004/1010 PCB COMPONENT LED LYG2093 YEL/GRN 3D BC5G2093000 C 2WKS LED 0.25 20 LOCAL SCRAP NO NO
3 ET.72202.004/005/009 LAM67BY1003/1004/1010 PCB COMPONENT SM IC AIC1563CS SO-8 SA015630000 C 2WKS U801 1.04 50 LOCAL SCRAP NO NO
3 ET.72202.004/005/009 LAM67BY1003/1004/1010 PCB COMPONENT SM TRANSISTOR FDS4435 1P SO-8 W/ SB944350100 C 2WKS U13 0.96 50 LOCAL SCRAP NO NO
3 ET.72202.004/005/009 LAM67BY1003/1004/1010 PCB COMPONENT SM IC APL1084-33UC TO-25 SA010840400 C 2WKS U14 0.88 50 LOCAL SCRAP NO NO
3 ET.72202.004/005/009 LAM67BY1003/1004/1010 PCB COMPONENT SM IC EE 128X8 SOP-8 24L SA024210300 C 2WKS U4 1.04 20 LOCAL SCRAP NO NO
3 ET.72202.004/005/009 LAM67BY1003/1004/1010 PCB COMPONENT S IC APL1117-25 SOT-223 SA011170200 C 2WKS U7 0.56 50 LOCAL SCRAP NO NO
3 ET.72202.004/005/009 LAM67BY1003/1004/1010 PCB COMPONENT VR RES 1/20W 50KB R102H-O CF150021030 C 2WKS VR 0.42 20 LOCAL SCRAP NO NO
3 ET.72202.004/005/009 LAM67BY1003/1004/1010 PCB COMPONENT WAFER CONN. E&T 96113-1103 11P DC03E000900 C 2WKS J2 1.64 20 LOCAL SCRAP NO NO
3 ET.72202.004/005/009 LAM67BY1003/1004/1010 PCB COMPONENT CRYSTAL 14.31818MHZ HC-49/ BD114P3M010 C 2WKS X1 0.45 20 LOCAL SCRAP NO NO
3 ET.72202.004/005/009 LAM67BY1003/1004/1010 PCB COMPONENT SRYSTAL 11.0592MHZ HC-49/U BD111P0M100 C 2WKS X2 0.44 20 LOCAL SCRAP NO NO
3 ET.72202.004/005/009 LAM67BY1003/1004/1010 PCB COMPONENT SM TRANSISTOR DTC124EK (SOT-23) SBX012400T0 C 2WKS Q7 0.06 50 LOCAL SCRAP NO NO
3 ET.72202.004/005/009 LAM67BY1003/1004/1010 PCB COMPONENT S DIO EC10QS04 SC10QS042T4 C 2WKS D2 0.18 50 LOCAL SCRAP NO NO
Spare Parts Level 1: Stands for FRU( Field Replaceable Unit) and CRU( Customer Replaceable Unit) which are used for first tier system service use and in LOW stock level and RTV items.
Spare Parts Level 2: Stands for subassemblies of FRU and consumed parts which should be in HIGH stock level and scrap items.
Spare parts Level 3: Mainboard Components
Option items: "MFG" is responsible for 1st year support after product phase-out. CSD only provides FRU(plain package) instead of whole option item(marketing package) accordingly.
* RETURN/SCRAP" : the choice made for high dollar valued item to be returned for repair and low dollar valued item to be scrapped locally.
* VENDOR S/N COLLECT : which the item may not be returned local but with vendor S/N collect for pass-through warranty claim. The details please do follow AIH/RTV process procedures.
28
APPENDIX B: DISPLAY UNIT ASSEMBLY
29
\\M-id\ART1\
MANUAL\service\AB
====================================================================================================================================
QUANTITY REQUIRED DWG.NO. LAM67B REV. 0B
C NO. PART NO. DESCRIPTION SPECIFICATION ------------------ --------------------------------------
T1 T1 T1 T1 T1
001 002 003 004 005 REMARKS
- ---- ----------- ------------------------ ------------------------------ --- --- --- --- --- ----- ----- ----- ----- ----- -----
# LAM67BT1001 LAM67BT ABO CHN UR+TCO99 110V WG017 17"AU
# LAM67BT1002 LAM67BT ABO-EUROPE UR+TCO99 WG017 17"AU AL722
# LAM67BT1003 LAM67BT ABO-CHINA UR+TCO99 WG017 17"AU AL722
# LAM67BT1004 LAM67BT ABO-TAIWAN UR+TCO99 WG017 17"AU AL722
# LAM67BT1005 LAM67BT ABO-AUS UR+TCO99+C-T WG017 17"AU AL722
1 PK100005010 AC ADAP LSE SLS9901B12320 12V/5A IVO 1 1 1 1 1 301
2 GA0200000C0 POWER CORD SET SP022X1.8MXIS14 H05VV-F OPL - 1 - - - 302
3 GA0500000C0 POWER CORD SET SP305X1.8MXIS14 SVT OPL 1 - - 1 - 302
4 GA060000210 POWER CORD SET SP508X1.8MXIS14 3ASL-3 W/L IVO - - - - 1 302
5 GA0900000C0 POWER CORD SET SP506X1.8MXIS14 RVV3C OPL - - 1 - - 302
6 DC190013710 CABLE ASSY CM35H AUDIO IN 3P WG017-GRN 1 1 1 1 1 303
7 DC190020400 CB ASY CM35H SIG 2CORE 1.5M W-BLU 1 1 1 1 1 304
8 X66A5630001 MECHANICAL PACKING LCM87A (WG017) 1 - - - - 351
9 X66A5630002 MECHANICAL PACKING LAM67BY WG017 - 1 1 1 1 351
10 58271030001 DIS ABO LAM67BT TCO99 17"AU 1280X1024 1 - - - - 352
11 58271030003 DIS ABO LAM67BT UR+T99 17"AU 1280X1024 - 1 1 1 1 352
12 68006330001 PACKING ABO-ASIA LAM67BT UR+TCO99 WG017 1 - - - - 353
13 68006330002 PACKING ABO-CHINA LAM67BY UR+TCO99 WG017 - - 1 - - 353
14 68006330003 PACKING ABO-AUS LAM67BY UR+TCO99+C-T WG017 - - - - 1 353
15 68006330004 PACKING ABO-Europe LAM67BY UR+TCO99 WG017 - 1 - - - 353
16 68006330006 PACKING ABO-Taiwan LAM67BY UR+TCO99 WG017 - - - 1 - 353
31
====================================================================================================================================
QUANTITY REQUIRED DWG.NO. LAM67B REV. 0B
C NO. PART NO. DESCRIPTION SPECIFICATION ------------------ --------------------------------------
T1 T1 T1 T1 Y1
006 007 008 009 001 REMARKS
- ---- ----------- ------------------------ ------------------------------ --- --- --- --- --- ----- ----- ----- ----- ----- -----
# LAM67BT1006 LAM67BT ABO-ASIA UR+TCO99 WG017 17"AU AL722
# LAM67BT1007 LAM67BT ABO-USA UR+TCO99 WG017 17"AU AL722
# LAM67BT1008 LAM67BT ABO-Switzerland UR+TCO99 WG017 17"AU AL722
# LAM67BT1009 LAM67BT ABO-UK UR+TCO99 WG017 17"AU AL722
# LAM67BY1001 LAM67BY ABO UR+TCO99 WG017 17"HYDIS
1 PK100005010 AC ADAP LSE SLS9901B12320 12V/5A IVO 1 1 1 1 1 301
2 GA040080200 PWR CORD SP60X1.8MXIS14 H05/1.0 OPL 10A - - - 1 - 302
3 GA0500000C0 POWER CORD SET SP305X1.8MXIS14 SVT OPL - 1 - - 1 302
4 GA070030200 POWER CORD SP027X1.8MXIS14 H05VU-F IVO - - 1 - - 302
5 DC190013710 CABLE ASSY CM35H AUDIO IN 3P WG017-GRN 1 1 1 1 1 303
6 DC190020400 CB ASY CM35H SIG 2CORE 1.5M W-BLU 1 1 1 1 1 304
7 X66A5630002 MECHANICAL PACKING LAM67BY WG017 1 1 1 1 1 351
8 58271030002 DIS ABO LAM67BY T99 17"HYDIS 1280X1024 - - - - 1 352
9 58271030003 DIS ABO LAM67BT UR+T99 17"AU 1280X1024 1 1 1 1 - 352
10 68006330001 PACKING ABO-ASIA LAM67BT UR+TCO99 WG017 1 - - - 1 353
11 68006330004 PACKING ABO-Europe LAM67BY UR+TCO99 WG017 - - 1 1 - 353
12 68006330005 PACKING ABO-USA LAM67BY UR+TCO99 WG017 - 1 - - - 353
====================================================================================================================================
QUANTITY REQUIRED DWG.NO. LAM67B REV. 0B
C NO. PART NO. DESCRIPTION SPECIFICATION ------------------ --------------------------------------
Y1 Y1 Y1 Y1 Y1
002 003 004 005 006 REMARKS
- ---- ----------- ------------------------ ------------------------------ --- --- --- --- --- ----- ----- ----- ----- ----- -----
# LAM67BY1002 LAM67BY ABO-CHN UR+TCO99 WG017 17"HY 1280X1024
# LAM67BY1003 LAM67BY ABO-AUS U+T99+C-T WG017 17"Y 1280X1024
# LAM67BY1004 LAM67BY ABO-Asia UR+TCO99 WG017 17"HY 1280X1024
# LAM67BY1005 LAM67BY ABO-Swiss UR+TCO99 WG017 17"HY 1280X1024
# LAM67BY1006 LAM67BY ABO-UK UR+TCO99 WG017 17"HY 1280X1024
1 PK100005010 AC ADAP LSE SLS9901B12320 12V/5A IVO 1 1 1 1 1 301
2 GA040080200 PWR CORD SP60X1.8MXIS14 H05/1.0 OPL 10A - - - - 1 302
3 GA060000210 POWER CORD SET SP508X1.8MXIS14 3ASL-3 W/L IVO - 1 - - - 302
4 GA070030200 POWER CORD SP027X1.8MXIS14 H05VU-F IVO - - - 1 - 302
5 GA0900000C0 POWER CORD SET SP506X1.8MXIS14 RVV3C OPL 1 - - - - 302
6 DC190013710 CABLE ASSY CM35H AUDIO IN 3P WG017-GRN 1 1 1 1 1 303
7 DC190020400 CB ASY CM35H SIG 2CORE 1.5M W-BLU 1 1 1 1 1 304
8 X66A5630002 MECHANICAL PACKING LAM67BY WG017 1 1 1 1 1 351
9 58271030002 DIS ABO LAM67BY T99 17"HYDIS 1280X1024 1 1 1 1 1 352
10 68006330001 PACKING ABO-ASIA LAM67BT UR+TCO99 WG017 - - 1 - - 353
11 68006330002 PACKING ABO-CHINA LAM67BY UR+TCO99 WG017 1 - - - - 353
12 68006330003 PACKING ABO-AUS LAM67BY UR+TCO99+C-T WG017 - 1 - - - 353
13 68006330004 PACKING ABO-Europe LAM67BY UR+TCO99 WG017 - - - 1 1 353
32
====================================================================================================================================
QUANTITY REQUIRED DWG.NO. LAM67B REV. 0B
C NO. PART NO. DESCRIPTION SPECIFICATION ------------------ --------------------------------------
Y1 Y1 Y1 Y1
007 008 009 010 REMARKS
- ---- ----------- ------------------------ ------------------------------ --- --- --- --- --- ----- ----- ----- ----- ----- -----
# LAM67BY1007 LAM67BY ABO-USA UR+TCO99 WG017 17"HY 1280X1024
# LAM67BY1008 LAM67BY ABO-Europe UR+TCO99 WG017 17"HY 1280X1024
# LAM67BY1009 LAM67BY ABO-Taiwan UR+TCO99 WG017 17"HY 1280X1024
# LAM67BY1010 LAM67BY ABO-Europe UR+TCO99 WG017 17"HY Three pow
1 PK100005010 AC ADAP LSE SLS9901B12320 12V/5A IVO 1 1 1 1 - 301
2 GA0200000C0 POWER CORD SET SP022X1.8MXIS14 H05VV-F OPL - 1 - 1 - 302
3 GA040080200 PWR CORD SP60X1.8MXIS14 H05/1.0 OPL 10A - - - 1 - 302
4 GA0500000C0 POWER CORD SET SP305X1.8MXIS14 SVT OPL 1 - 1 - - 302
5 GA070030200 POWER CORD SP027X1.8MXIS14 H05VU-F IVO - - - 1 - 302
6 DC190013710 CABLE ASSY CM35H AUDIO IN 3P WG017-GRN 1 1 1 1 - 303
7 DC190020400 CB ASY CM35H SIG 2CORE 1.5M W-BLU 1 1 1 1 - 304
8 X66A5630002 MECHANICAL PACKING LAM67BY WG017 1 1 1 1 - 351
9 58271030002 DIS ABO LAM67BY T99 17"HYDIS 1280X1024 1 1 1 1 - 352
10 68006330004 PACKING ABO-Europe LAM67BY UR+TCO99 WG017 - 1 - - - 353
11 68006330005 PACKING ABO-USA LAM67BY UR+TCO99 WG017 1 - - - - 353
12 68006330006 PACKING ABO-Taiwan LAM67BY UR+TCO99 WG017 - - 1 - - 353
13 68006330007 PACKING ABO-EUROPE LAM67BY U+T99 WG017 THREE POW - - - 1 - 353
End of Report
==================================================================================================================================
QUANTITY REQUIRED DWG.NO. 680063 REV. 0B
C NO. PART NO. DESCRIPTION SPECIFICATION ------------------ --------------------------------------
30 30 30 30 30
001 002 003 004 005 REMARKS
- ---- ----------- ------------------------ ------------------------------ --- --- --- --- --- ----- ----- ----- ----- ----- -----
# 68006330001 PACKING ABO-ASIA LAM67BT UR+TCO99 WG017
# 68006330002 PACKING ABO-CHINA LAM67BY UR+TCO99 WG017
# 68006330003 PACKING ABO-AUS LAM67BY UR+TCO99+C-T WG017
# 68006330004 PACKING ABO-Europe LAM67BY UR+TCO99 WG017
# 68006330005 PACKING ABO-USA LAM67BY UR+TCO99 WG017
1 EJ4AM670000 RATING NP N-AM67B-ABO UFGC 99 W/W 1 - 1 1 1 001
2 EJ4AM670100 RATING NP N-AM67B-ABO UFGC 99 PRC - 1 - - - 001
3 HB4AM670000 CARTON C-AM67B-ABO W/W CHN 1 1 1 1 1 003
4 HDABOAM6700 USER'S MANUAL U-AM67B-ABO EFGSIDPJCCS 1 1 1 1 1 004
5 HF6TCO99000 TCO99 (NOTICE SHEET) FOR TCO99 1 1 1 1 1 005
6 HGTCO990000 TCO99 LABEL TCO99 FOR BEZEL/MANUAL 1 1 1 1 1 006
7 HGTCO990100 TCO99 LABEL TCO99 FOR CARTON 1 1 1 1 1 008
8 HK3CM870100 PE BAG CM870-K001 FOR MAC LCDMONITOR 1 1 1 1 1 009
9 HF6VS558000 WARRANTY CARD F-VS558-ABO FOR ANZ - - 1 - - 010
10 HF6VS558110 WARRANTY CARD F-VS558-ABO USA LCD/CRT R1 - - - - 1 010
11 HF6VS558200 WARRANTY CARD F-VS558-ABO FOR EURO - - - 1 - 010
12 HGVS5580300 ADDRESS LABEL VS558-L003 ABO CARTON-PRC - 1 - - - 013
33
====================================================================================================================================
QUANTITY REQUIRED DWG.NO. 680063 REV. 0B
C NO. PART NO. DESCRIPTION SPECIFICATION ------------------ --------------------------------------
30
006 REMARKS
- ---- ----------- ------------------------ ------------------------------ --- --- --- --- --- ----- ----- ----- ----- ----- -----
# 68006330006 PACKING ABO-Taiwan LAM67BY UR+TCO99 WG017
1 EJ4AM670200 RATING NP N-AM67B-ABO UFGC 99 TWN 1 - - - - 001
2 HB4AM670000 CARTON C-AM67B-ABO W/W CHN 1 - - - - 003
3 HDABOAM6700 USER'S MANUAL U-AM67B-ABO EFGSIDPJCCS 1 - - - - 004
4 HF6TCO99000 TCO99 (NOTICE SHEET) FOR TCO99 1 - - - - 005
5 HGTCO990000 TCO99 LABEL TCO99 FOR BEZEL/MANUAL 1 - - - - 006
6 HGTCO990100 TCO99 LABEL TCO99 FOR CARTON 1 - - - - 008
7 HK3CM870100 PE BAG CM870-K001 FOR MAC LCDMONITOR 1 - - - - 009
8 HGVS5580200 WARRANTY LABEL VS558-L002 ABO COVER TWN 1 - - - - 011
9 HGVS5580100 WARRANTY LABEL VS558-L001 ABO 15" CARTON-TWN 1 - - - - 012
End of Report
====================================================================================================================================
QUANTITY REQUIRED DWG.NO. X66A56 REV. 1F
C NO. PART NO. DESCRIPTION SPECIFICATION ------------------ --------------------------------------
30 30
001 002 REMARKS
- ---- ----------- ------------------------ ------------------------------ --- --- --- --- --- ----- ----- ----- ----- ----- -----
# X66A5630001 MECHANICAL PACKING LCM87A (WG017)
# X66A5630002 MECHANICAL PACKING LAM67BY WG017
1 FJCM8715100 EPE FOAM RIGHT CM8715 1 - - - - 201
2 FJCM8715200 EPE FOAM (R) (ACER) - 1 - - - 201
3 FJCM8716100 EPE FOAM LEFT CM8716 1 - - - - 202
4 FJCM8716200 EPE FOAM (L) (ACER) - 1 - - - 202
5 FJCM8722100 CORD BOX CM8722 1 1 - - - 203
End of Report
34
\\M-id\ART1\ \\M-id\ART1\
MANUAL\service\ABMANUAL\service\AB
============