Text preview for : sony_STR-NX5MD_service_manual.pdf part of Sony STR-NX5MD STR-NX5MD Tuner and Amplifier Section in DHC-NX5MD - Service Manual



Back to : sony_STR-NX5MD_service_ma | Home

STR-NX5MD
SERVICE MANUAL
AEP Model UK Model E Model

STR-NX5MD is the Tuner and Amplifier Section in DHC-NX5MD.

SPECIFICATIONS
Amplifier section
European model
DIN power output (rated) 80 + 80 watts (6 ohms at 1 kHz, DIN) Continuous RMS power output (reference) 100 + 100 watts (6 ohms at 1 kHz, 10% THD) Music power output (reference) 160 + 160 watts (6 ohms at 1 kHz, 10% THD)

Tuner section
FM stereo, FM/AM superheterodyne tuner

General
Power requirements European models: Other models: 230 V AC, 50/60 Hz 120 V, 220 V or 230 ­ 240 V AC, 50/60 Hz Adjustable with voltage selector

FM tuner section
Tuning range Tourist model: Other models: Aerial Aerial terminals Intermediate frequency 76.0 ­ 108.0 MHz 87.5 ­ 108.0 MHz FM lead aerial 75 ohm unbalanced 10.7 MHz

Power consumption European models: Other models: Dimensions (w/h/d)

190 watts 220 watts Approx. 225 × 202 × 356 mm

Other models
DIN power output (rated) 90 + 90 watts (6 ohms at 1 kHz, DIN) Continuous RMS power output (reference) 110 + 110 watts (6 ohms at 1 kHz, 10% THD) Inputs VIDEO IN: voltage 250 mV (phono jacks) impedance 47 kilohms TAPE IN: voltage 250 mV (phono jacks) impedance 47 kilohms Outputs TAPE OUT: voltage 250 mV (phono jacks) impedance 1 kilohms PHONES: accepts headphones of 8 ohms or (stereo mini jack) more FRONT SPEAKER: accepts impedance of 6 to 16 ohms REAR SPEAKER: accepts impedance of 16 ohms SUPER WOOFER: voltage 1 V, impedance 1 kilohms

AM tuner section
Tuning range European models: Other models: 531 ­ 1,602 kHz (with the interval set at 9 kHz) 531 ­ 1,602 kHz (with the interval set at 9 kHz) 530 ­ 1,710 kHz (with the interval set at 10 kHz) AM loop aerial External aerial terminal 450 kHz Mass European models: Other models: Supplied accessories: Approx. 7.8 kg Approx. 7.6 kg AM loop aerial (1) Remote Commander (1) Batteries (2) FM lead aerial (1) Speaker cords (2) Front speaker pads (8)

Aerial Aerial terminals Intermediate frequency

Design and specifications are subject to change without notice.

TUNER/AMPLIFIER

1

· MODEL IDENTIFICATION ­ Rear Panel ­
PART No.

TABLE OF CONTENTS 1. GENERAL .......................................................................... 3 2. DISASSEMBLY
2-1. Case ....................................................................................... 5 2-2. Front Panel Assy ................................................................... 5 2-3. Back Panel Assy .................................................................... 6 2-4. Main Board ........................................................................... 6

3. TEST MODE ........................................................................ 7 4. DIAGRAMS
4-1. Notes for Printed Wiring Boards and Schematic Diagrams .. 9 4-2. Schematic Diagram ­ Main Board (1/3) ­ .......................... 10 4-3. Schematic Diagram ­ Main Board (2/3) ­ .......................... 11 4-4. Schematic Diagram ­ Main Board (3/3) ­ .......................... 12 4-5. Printed Wiring Board ­ Main Board ­ ................................ 13 4-6. Printed Wiring Board ­ PA Board ­ .................................... 14 4-7. Schematic Diagram ­ PA Board ­ ...................................... 15 4-8. Printed Wiring Board ­ Panel Section ­ ............................. 16 4-9. Schematic Diagram ­ Panel Section ­ ................................ 17 4-10. Printed Wiring Board ­ Transformer Section ­ ................. 18 4-11. Schematic Diagram ­ Transformer Section ­ ................... 19 4-12. IC Pin Function Description ............................................. 20

MODEL AEP, UK, G, AED and CIS models Malaysia and Singapore models · Abbreviation G : German model AED : North European model

PART No. 4-221-391-8[] 4-221-391-9[]

5. EXPLODED VIEW
5-1. General Section ................................................................... 22 5-2. Front Panel Section ............................................................. 23 5-3. Chassis Section ................................................................... 24

6. ELECTRICAL PARTS LIST ........................................ 25

SAFETY-RELATED COMPONENT WARNING!! COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.

2

SECTION 1 GENERAL
· LOCATION OF CONTROLS ­ Front Panel ­

5 6 7 8 90

1 ?/1 (Power) button and indicator 2 CD/TUNER NAME button 3 DISPLAY button

4 3 2 1 wh wg wf

qa qs qd

4 TIMER indicator (AEP, UK, German, AED and CIS models) 5 VIDEO button 6 TAPE button 7 MD button

qf qg qh

8 CD button 9 TUNER button q; Display window qa TUNER BAND button qs STEREO/MONO button qd TUNER MEMORY button qf DBFB button

wd ws

wa w;ql qk

qj

qg SURROUND button qh GROOVE button and indicator qj VOLUME knob qk PLAY MODE button ql REPEAT/PTY button w; + M button wa ENTER button and indicator ws Remote sensor wd PHONES jack wf Jog dial wg ­ m button wh POWER SAVE/DEMO (STANDBY) button wj FILE SELECT button

­ Rear Panel ­

1

2 3

1 SYSTEM CONTROL terminals 2 AM ANTENNA terminals 3 FM ANTENNA terminal 4 VOLTAGE SELECTOR switch (Malaysia and Singapore models)

4 0 9 8

5 REAR SPEAKER terminals 6 CENTER SPEAKER terminals 7 SUPER WOOFER OUT jack 8 MD OUT jacks 9 MD IN jacks q; VIDEO (AUDIO) jacks · Abbreviation AED : North European model

7

6

5
Photo: AEP model

3

This section is extracted from instruction manual.

Step 2: Setting the time
You must set the time beforehand to use the timer functions. The clock is on a 24-hour system for the European model, and a 12-hour system for other models. The 24-hour system is used for illustration purposes.

3

Press ENTER.
The minute indication flashes.

Getting Started

4 5

Press V or v to set the minute. Press ENTER.
The clock starts.

Tips
· If you've made a mistake, start over from step 1. · Setting the time deactivates the demo mode. If you want to display the demo mode, press DISPLAY (European model) or DEMO (STANDBY) (other models) when the power is off.

3,5 1

2,4

To change the time
The previous explanation shows you how to set the time while the power is off. To change the time while the power is on, do the following: 1 2 3 4 Press CLOCK/TIMER SET. Press V or v to select the SET CLOCK. Press ENTER. Perform steps 2 through 5 above.

Note
The clock settings are cancelled when you disconnect the mains lead or if a power failure occurs.

1

Press CLOCK/TIMER SET.
The hour indication flashes.

2

Press V or v to set the hour.

7

4

SECTION 2 DISASSEMBLY
Note: Follow the disassembly procedure in the numerical order given.
2 two screws (BVTP3 × 10)

2-1. CASE
3 case

1 two screws (case 3 TP2)

1 two screws (case 3 TP2)

2-2. FRONT PANEL ASSY

1 flat cable (7 core) (CN132)

4 front panel assy

2 flat cable (25 core) (CN131)

3 two screws (BVTT3 × 6)

5

2-3. BACK PANEL ASSY
2 connector (CN173)

4 back panel assy

1 flat cable (13 core) (CN1)

3 six screws (BVTP3 × 10)

3 four screws (BVTP3 × 10)

2-4. MAIN BOARD
2 connector (CN111) 1 connector (CN181)

3 two screws (BVTP3 × 10)

4 connector (CN152)

5 main board

6

SECTION 3 TEST MODE
[CD Delivery Mode] · This mode moves the optical pick-up to the position durable to vibration. Use this mode when returning the set to the customer after repair. Procedure: 1. Press the ?/1 button to turn the power ON. 2. Press the [ENTER] and ?/1 buttons simultaneously. 3. A message "LOCK" is displayed on the liquid crystal display, and the CD delivery mode is set. [Change-over the MW Tuning Interval] · The MW tuning interval can be changed over 9 kHz or 10 kHz. Procedure: 1. Press the ?/1 button to turn the power ON. 2. Press the [TUNER] button to select the function "TUNER", and press the [TUNER BAND] button to select the BAND "MW". 3. Press the ?/1 button to turn the power OFF. 4. Press the [TUNER MEMORY] and ?/1 buttons simultaneously, and the display on the liquid crystal display changes to "MW 9 k STEP" or "MW 10 k STEP", and thus the tuning interval is changed over. [MC Cold Reset] · The cold reset clears all data including preset data stored in the RAM to initial conditions. Execute this mode when returning the set to the customer. Procedure: 1. Turn the power ON or set to the DEMO mode. 2. Press the [GROOVE] and ?/1 buttons simultaneously. 3. The set is reset, and displays "COLD RESET", then becomes DEMO mode. [Amplifier Test Mode] Procedure: 1. Press the ?/1 button to turn the power ON. 2. Press three buttons of [ENTER] , [DISPLAY] , and [TUNER BAND] simultaneously. 3. "ALC OFF" is displayed, then the function which was set before the test mode became active is displayed. [LED and Liquid Crystal Display All Lit, Software Version Display, Key Check, VACS Level Display Mode] Procedure: 1. Press the ?/1 button to turn the power ON. 2. Press three buttons of [ENTER] , [DISPLAY] , and [STEREO/MONO] simultaneously. 3. LEDs and liquid crystal display are all turned on. Rotating the JOG dial changes over the check patterns of liquid crystal display. 4. Successively, the following three modes can be activated. (1) Press the [VIDEO] button, and the software version is displayed on the liquid crystal display. (2) Press the [MD] button, and the key check mode is activated. In the key check mode, the liquid crystal display displays "K 0 J0 V0". Each time a button is pressed, "K" value increases. However, once a button is pressed, it is no longer taken into account. "J" value increases like 1, 2, 3 ... if turn the JOG dial clockwise, or it decreases like 0, 9, 8 ... if turn the JOG dial counterclockwise. "V" value increases like 1, 2, 3 ... if turn the [VOLUME] dial clockwise, or it decreases like 0, 9, 8 ... if turn the JOG dial counterclockwise. (3) Press the [TAPE] button, and the VACS level is displayed on the liquid crystal display. 5. To release from these mode, press three buttons in the same manner as step 2, or remove the power cord. [MC Hot Reset] · This mode resets the set with the preset data kept stored in the memory. The hot reset mode functions same as if the power cord is plugged in and out. Procedure: 1. Turn the power ON or set to the DEMO mode. 2. Press three buttons of [ENTER] , [DISPLAY] , and [TUNER MEMORY] simultaneously. 3. The set is reset, and becomes standby state. [Change-over of VACS ON/OFF] Procedure: 1. Press the ?/1 button to turn the power ON. 2. Press three buttons of [ENTER] , [DISPLAY] , and [GROOVE] simultaneously, and the display on the liquid crystal display changes to "VACS ON" or "VACS OFF", and thus the VACS ON/OFF is changed over. [VIDEO input, Record and CD play in CD function] Procedure: 1. Press the ?/1 button to turn the power ON. 2. Press three buttons of [ENTER] , [DISPLAY] , and - m simultaneously. 3. "DVD 5.1CH" is displayed on liquid crystal display, and at the same time, CD is played and the deck B is placed in the record status. [CD Service Mode] · This mode can run the CD sled motor optionally. Use this mode, for instance, when cleaning the optical pick-up. Procedure: 1. Press the ?/1 button to turn the power ON. 2. Press the [CD] button to select the function "CD". 3. Press three buttons of [ENTER] , [POWER SAVE/DEMO (STANDBY) , and [STEREO/MONO] simultaneously. 4. Set to the Sled Servo mode. 5. With the CD in stop status, turn the JOG dial clockwise to move the optical pick-up to outside track, or turn it counterclockwise to inside track. 6. To release from this mode, perform as follows. 1) Move the optical pick-up to the most inside track. 2) Remove the power cord.
Notes: · Always move the optical pick-up to most inside track when releasing from this mode. Otherwise, a disc will not be unloaded. · Do not run the sled motor excessively, otherwise the gear can be chipped.

7

[Aging Mode] This mode can be used for operation check of CD section and tape deck section. CD section and tape deck section work in parallel. · If an error occurred: The aging operation stops only an error occurred sections and display then status. · If no error occurs: The aging operation continues repeatedly. Procedure: 1. Set disc in DISC5 tray. 2. Load the tapes into the decks A and B respectively. 3. Press the [PLAY MODE] button to set the "ALL DISCS" mode, and press the [REPEAT/PTY] button to "REPEAT" off. 4. Press the [CD] button to select the function "CD". 5. Press three buttons of [ENTER] , [POWER SAVE/DEMO (STANDBY) , and [TUNER BAND] simultaneously. 6. The aging mode is activated, if the indicator of disc tray number on the liquid crystal display is blinking. 7. To release from the aging mode, press the ?/1 button to turn the power OFF and operate the cold reset. (Refer to the "MC Cold Reset") 1. Display at the Aging Mode · Display operating state of CD section and tape deck section alternately. · If an error occurred, stop display which that section. 2. CD Section · Display at the aging mode is the same as the normal operation. · The sequence during the aging mode is following as below. Aging mode sequence (CD section) :

· Display at an error occurred 1) Display of the error count (1) Press three buttons of [ENTER] , [POWER SAVE/DEMO (STANDBY) , and [GROOVE] simultaneously. (2) Display of the error count following as below. Display

EMC**EDC**
Notes: EMC**: The number of mechanical error. EDC** : The number of no disc error after chucking the disc.

2) Display of mechanical error Display

E**M##$$&&
Notes: ** : The number of mechanical error.("00" is latest one) (Press the [PLAY MODE] button to changes next error display) ## : Not used. $$ : Loading error. (Second figure is not used) D : The error in the midst of close at the except mechanical trouble. E : The error in the midst of open at the except mechanical trouble. C : The error in the midst of chuck up at the except mechanical trouble. F : The error in the midst of EX-open at the except mechanical trouble. &&: Loading error. (Second figure in not used) 1:The error in the midst of chuck up. 2:The error in the midst of chuck down. 3:Time up of EX-open 4:Time up of EX-close.

Open the disc1 tray

3) Display of no disc error
Disc5 chucking

Display

Disc5 TOC read

E**D##$$&&
Notes: ** : The number of mechanical error.("00" is latest one) (Press the [REPEAT] button to changes next error display) ##: 01: Focus error 02: GFS error 03: Set up error $$: 00: No disc error when does not chucking retry. 02: No disc error when chucking retry to completion. &&: The state when judged no disc error. (Second figure is not used) 1:Stop 2:Set up 3:TOC read 4:Access 5:Play 6:Pause 7:Manual search (Play) 8:Manual search (Pause)

Disc5 play track1 for 2 seconds

Disc5 play last track for 2 seconds

8

SECTION 4 DIAGRAMS
4-1. NOTE FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS
Note on Printed Wiring Board: · X : parts extracted from the component side. · Y : parts extracted from the conductor side. x : parts mounted on the conductor side. · · b : Pattern from the side which enables seeing. (The other layers' patterns are not indicated) · Indication of transistor.
Q B C E These are omitted.

· Circuit Boards Location

Note on Schematic Diagram: · All capacitors are in µF unless otherwise noted. pF: µµF 50 WV or less are not indicated except for electrolytics and tantalums. · All resistors are in and 1/4 W or less unless otherwise specified. f · : internal component. · 2 : nonflammable resistor. · 5 : fusible resistor. · C : panel designation. Note: The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. · U : B+ Line. · V : B­ Line. · Voltages and waveforms are dc with respect to ground under no-signal (detuned) conditions. no mark : TUNER (FM) · Voltages are taken with a VOM (Input impedance 10 M). Voltage variations may be noted due to normal production tolerances. · Waveforms are taken with a oscilloscope. Voltage variations may be noted due to normal production tolerances. · Circled numbers refer to waveforms. · Signal path. F : FM E : MD PLAY J : CD PLAY j : MD REC · Abbreviation MY : Malaysia model SP : Singapore model G : German model AED : North European model

SUB TRANS board (AEP, UK, G, AED, CIS)

TRANS board

TUNER pack

Q B C E These are omitted.

BACK LIGHT board

MAIN board

PANEL board

PA board R board

· IC Block Diagram ­ MAIN Board ­ IC401 BA3830F

· Waveforms ­ MAIN Board ­
1 IC501 qa (XCOUT)

R02 R01 LINE NF LINE IN

1 2 3 4

REFERENCE CURRENT REFERENCE CURRENT

RESET

18 RESET

3 Vp-p
17 16 15 14 13 12 F01 F02 F03 F04 F05 F06

­ +

BAND PASS FILTER DET

32.768 kHz

REC NF REC IN

5 6 ­ + 11 REC LEVEL 10 VCC

2 IC501 qd (XOUT)

RESET C BIAS C GND

7 8 9

2.8 Vp-p

16.025 MHz

9

9

STR-NX5MD

4-2. SCHEMATIC DIAGRAM ­ MAIN Board (1/3) ­ · See page 13 for Printed Wiring Board.

12

11

10

10

STR-NX5MD

4-3. SCHEMATIC DIAGRAM ­ MAIN Board (2/3) ­ · See page 9 for Waveforms. · See page 13 for Printed Wiring Board.

10

PIN FUNCTION

12

11

11

STR-NX5MD
4-4. SCHEMATIC DIAGRAM ­ MAIN Board (3/3) ­ · See page 9 for IC Block Diagram.
· Semiconductor Location
Ref. No. D141 D501 D502 D503 D504 D505 D506 D507 D508 D510 D901 D902 D903 D904 D905 D906 D914 D915 D920 D921 D925 D931 D932 IC101 IC401 IC501 IC502 IC901 IC921 Location A-8 B-2 D-1 D-1 E-1 E-1 E-1 F-1 E-2 C-1 B-5 B-5 B-5 B-4 A-6 A-6 A-3 B-3 B-4 B-3 B-4 A-4 A-4 B-9 E-5 E-3 E-1 A-2 C-2 Ref. No. Q112 Q113 Q114 Q162 Q163 Q164 Q191 Q411 Q421 Q431 Q432 Q461 Q501 Q502 Q503 Q901 Q902 Q903 Q904 Q905 Q906 Q907 Q921 Q926 Q927 Q951 Q952 Q953 Location A-8 A-8 G-6 A-9 A-9 G-6 G-11 D-5 C-3 E-6 D-6 D-5 F-1 F-1 F-1 A-6 A-6 A-6 A-3 A-3 B-3 B-4 B-3 B-3 B-3 B-6 B-6 B-6

10

11

12

12

STR-NX5MD

4-5. PRINTED WIRING BOARD ­ MAIN Board ­ · See page 9 for Circuit Boards Location.

(Page 18)

(Page 18)

(Page 16)

(Page 18)

(Page 16)

(Page 14)

There are a few cases that the part isn't mounted in model is printed on diagram.

13

13

STR-NX5MD
4-6. PRINTED WIRING BOARD ­ PA Board ­ · See page 9 for Circuit Boards Location.
MAIN BOARD CN152

(Page 13)

(AEP, UK, AED, CIS)

(AEP, UK, AED, CIS)

(MY, SP)

· Semiconductor Location
TRANS BOARD CN952

Ref. No. D802 D821 D831 D852 D871 D881 D883 D884 D885

Location B-5 E-4 C-6 C-5 B-10 E-2 A-11 C-11 F-10

(MY, SP)

Ref. No. IC801 Q801 Q821 Q822 Q823 Q824 Q825 Q826

Location C-8 B-5 D-7 D-7 C-7 C-7 H-4 H-4

Ref. No. Q827 Q828 Q829 Q830 Q831 Q851 Q881 Q882

Location H-4 G-4 G-4 G-4 C-7 C-5 B-10 B-9

(Page 18)

There are a few cases that the part isn't mounted in model is printed on diagram.

14

14

STR-NX5MD
4-7. SCHEMATIC DIAGRAM ­ PA Board ­

15

15

STR-NX5MD
4-8. PRINTED WIRING BOARDS ­ PANEL Section ­ · See page 9 for Circuit Boards Location.

(Page 13)

· Semiconductor Location
Ref. No. D631 D636 D637 D638 D643 D644 D645 D646 D647 D648 Q631 Q636 Q637 Q638 Q641 Q642 Q643 Location E-2 G-5 A-8 D-8 C-6 C-7 C-4 C-5 C-2 C-3 E-1 F-5 B-7 D-8 D-7 D-7 D-7 (Page 13) There are a few cases that the part isn't mounted in model is printed on diagram.

16

16

STR-NX5MD

4-9. SCHEMATIC DIAGRAM ­ PANEL Section ­

17

17

STR-NX5MD
4-10. PRINTED WIRING BOARDS ­ TRANSFORMER Section ­ · See page 9 for Circuit Boards Location.

1
(AEP, UK, G, AED, CIS) (MY, SP)
CN952

(MY, SP)

(Page 13)
JW953

MAIN BOARD CN111 MAIN BOARD CN181 PA BOARD CN808

(Page 13)

(Page 14)
10

(MY, SP)

(AEP, UK, G, AED, CIS)

09

(Page 13)

There are a few cases that the part isn't mounted in model is printed on diagram.

18

18

STR-NX5MD
4-11. SCHEMATIC DIAGRAM ­ TRANSFORMER Section ­

19

19

4-12. IC PIN FUNCTION DESCRIPTION
· MAIN BOARD IC501 M30622MAA-A39FP (SYSTEM CONTROLLER ) Pin No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 L+R BPF SL F RELAY R RELAY SIRCS LINE MUTE DBFB BYTE CNVSS XCIN XCOUT RESET XOUT VSS XIN VCC NMI WAKE UP PHONES MUTE RDS INT RDS DATA AC CUT PL CLK PL DATA PL LAT STK POWER SPEAKER PROTECT SOFT-TEST IIC CLK IIC DATA TXD1 RXD1 CLK1 RTS1 LCD DATA RXD0 LCD CLK 493 LT CLOCK OUT VC L+R/L­R Pin Name I/O I I O O I O O I -- I O I O -- I -- I O O I I I O O O O I O I/O I/O O I I O O I O O O O Descriptions Spectrum analyzer drive signal input from the spectrum analyzer band-pass filter (IC401) (for VACS, non-stop signal) Spectrum analyzer drive (super low frequency) signal input from the spectrum analyzer band-pass filter (IC401) (for 40 Hz) Speaker protect relay drive signal output for the front side speaker "H": relay on Speaker protect relay drive signal output for the rear side speaker "H": relay on Remote control signal input from the remote control receiver (IC601) Line muting on/off control signal output terminal "L": muting on DBFB normal/high selection signal output to the M62493FP (IC101) "L": DBFB high, "H": DBFB low/off External data bus line byte selection signal input terminal Fixed at "L" in this set Ground terminal Sub system clock input terminal (32.768 kHz) Sub system clock output terminal (32.768 kHz) System reset signal input from the reset signal generator (IC502) "L": reset For several hundreds msec. after the power supply rises, "L" is input, then it changes to "H" Main system clock output terminal (16 MHz) Ground terminal Main system clock input terminal (16 MHz) Power supply terminal (+5V) Non-maskable interrupt input terminal Fixed at "H" in this set Wakeup control signal output to the CPU on the HMC-NX5MD "H" active Muting on/off control signal output terminal "L": muting on Not used (open) RDS serial data transfer clock signal input from the tuner pack (Used for the AEP, UK, (Used for the AEP, UK, Not used (open) Not used (open) Not used (open) Power amplifier on/off selection signal output terminal "L": standby mode, "H": on Protect on/off detection signal input from the speaker protect circuit "L": protect on, "H": protect off Output terminal for the software test Not used (open) Communication data reading clock signal input or transfer clock signal output with the CPU on the HMC-NX5MD Communication data bus with the CPU on the HMC-NX5MD Not used (open) Not used (fixed at "L") Not used (fixed at "L") Not used (open) Serial data output to the liquid crystal display unit (LCD601) Not used (fixed at "L") Serial data transfer clock signal output to the liquid crystal display unit (LCD601) Serial data latch pulse output to the M62493FP (IC101) Output terminal for the clock signal check Not used (open) Not used (open) 86 LED DOLBY O Virtual cinema L+R/L­R selection signal output terminal 82 83 84 85 LED LCD LED ENTER LED JOG LED CINEMA O O O O 81 LED TIMER O G*, AED* G*, AED* and CIS models only) and CIS models only) RDS serial data input from the tuner pack AC off detection signal input from the reset signal generator (IC502) "L": AC cut checked 57 58 59 60 61 62 63 64 65 to 67 68 69 70 71 72 73 to 75 76 77, 78 79 80 PHONES DETECT LCD LAT LCD A0 LCD RESET NC VCC NC VSS NC TUNER MUTE JOG B JOG A VOL B VOL A NC HMC POWER NC LED FUNCTION LED POWER I O O O O -- O -- O O I I I I O O O O O 44 45 46 47 48 49 50 51 52 53 54 55 56 BASS FREQ OPT SEL XWR 493 DATA 493 CLK ST MUTE STEREO TUNED ST CE ST DOUT ST DIN ST CLK VC BYPASS O O I O O O I I O O I O O 43 STBY RELAY O 42 LCD SW O Pin No. 41 Pin Name XHOLD I/O I Descriptions Not used (fixed at "L") Liquid crystal display on/off selection signal output terminal "L": on, "H": off Not used (open) Main power on/off control signal output terminal "L": standby mode, "H": power on (Used for the AEP, UK, G*, AED* and CIS models only) Sync bass frequency normal/high selection signal output to the M62493FP (IC101) "L": sync bass off (normal), "H": sync bass high Not used (open) Not used (open) Not used (fixed at "H") Serial data output to the M62493FP (IC101) Serial data transfer clock signal output to the M62493FP (IC101) Tuner muting control signal output to the tuner pack "H": muting on FM stereo detection signal input from the tuner pack PLL chip enable signal output to the tuner pack PLL serial data output to the tuner pack PLL serial data input from the tuner pack PLL serial data transfer clock signal output to the tuner pack Virtual cinema bypass control signal output terminal "L": no connected, "H": headphone connected Serial data latch pulse output to the liquid crystal display unit (LCD601) Address signal output to the liquid crystal display unit (LCD601) Reset signal output to the liquid crystal display unit (LCD601) Not used (open) Power supply terminal (+5V) Not used (open) Ground terminal Not used (open) TUNER 5V ON/OFF SW Jog dial pulse input from the rotary encoder (S652 JOG) (B phase input) Jog dial pulse input from the rotary encoder (S652 JOG) (A phase input) Jog dial pulse input from the rotary encoder (S651 VOLUME) (B phase input) Jog dial pulse input from the rotary encoder (S651 VOLUME) (A phase input) Not used (open) HMC POWER detection Not used (open) LED drive signal output of the key illumination indicator (D643 to D648) "H": LED on LED drive signal output of the I/1 indicator (D638) "H": LED on LED drive signal output of the TIMER indicator (D637) "H": LED on (Used for the AEP, UK, G*, AED* and CIS models only) LED drive signal output of the liquid crystal display back light indicator (D639 to D642) "H": LED on LED drive signal output of the ENTER indicator (D636) "H": LED on LED drive signal output terminal Not used (open) LED drive signal output terminal Not used (open) LED drive signal output of the PRO LOGIC indicator (D633) "H": LED on Not used (open) "L": reset Not used (open) Connection detect signal input of the headphone jack (J701) "L": stereo Tuning detection signal input from the tuner pack "L": tuned

20

20

Pin No. 87 88 89 90 91 92

Pin Name LED 5.1CH LED GROOVE BPF 1 BPF 2 BPF 3 BPF 4

I/O O O I I I I

Descriptions LED drive signal output of the DVD 5.1CH indicator (D632) "H": LED on Not used (open) LED drive signal output of the GROOVE indicator (D631) filter (IC401) (for 100 Hz) Spectrum analyzer drive (low and middle frequency) signal input from the spectrum analyzer band-pass filter (IC401) (for 400 Hz) Spectrum analyzer drive (middle and high frequency) signal input from the spectrum analyzer band-pass filter (IC401) (for 2 kHz) Spectrum analyzer drive (high frequency) signal input from the spectrum analyzer bandpass filter (IC401) (for 6 kHz) Key input terminal (A/D input) S615 to S617, S619 to S622 (TUNER BAND, STEREO/MONO, TUNER MEMORY, GROOVE, + M, ­ m) keys input Key input terminal (A/D input) S601 to S614 (I/1, DISPLAY, POWER SAVE/DEMO (STANDBY), VIDEO/DVD, MD, "H": LED on Spectrum analyzer drive (low frequency) signal input from the spectrum analyzer band-pass

93

KEY1

I

94

KEY0

I

TAPE, CD, TUNER, DSB, DBFB, PLAY MODE, REPEAT, EDIT, FILE SELECT) keys input Destination setting terminal Ground terminal (for A/D conversion) Setting terminal for the version Reference voltage (+5V) input terminal (for A/D conversion) Power supply terminal (+5V) (for A/D conversion) Power on/off control signal output terminal "L": standby mode, "H": power on

95 96 97 98 99 100

MODEL-IN AVSS SPEC-IN VREF AVCC POWER

I -- I I -- O

* Abbreviation G : German model AED : North European model

21

SECTION 5 EXPLODED VIEWS
NOTE: · -XX and -X mean standardized parts, so they may have some difference from the original one. · Color Indication of Appearance Parts Example: KNOB, BALANCE (WHITE) . . . (RED) Parts Color Cabinet's Color · Abbreviation MY : Malaysia model SP : Singapore model G : German model AED : North European model · Items marked "*" are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. · The mechanical parts with no reference number in the exploded views are not supplied. · Hardware (# mark) list is given in the last of the electrical parts list. The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified.

5-1. GENERAL SECTION

M401

#1

2

#1 #1 #1 #1

6
#1

1 4 1

#1 #1

3

5

Front panel assy #4

Ref. No. 1 2 3 3 4

Part No. 3-363-099-11 4-221-365-11 X-4952-909-1 X-4952-910-1 1-751-688-11

Description

Remark

Ref. No. 4 5 6 6 M401

Part No.

Description

Remark

SCREW(CASE 3 TP2) CASE PANEL ASSY, BACK(MY,SP) PANEL ASSY, BACK(AEP,UK,G,AED,CIS) WIRE(FLAT TYPE) (13 CORE)(MY,SP)

1-773-011-11 WIRE(FLAT TYPE) (15 CORE) (AEP,UK,G,AED,CIS) 4-965-822-01 FOOT 1-693-482-11 TUNER(FM/AM)(MY,SP) 1-693-490-11 TUNER(FM/AM)(AEP,UK,G,AED,CIS) 1-763-478-11 FAN, DC

22

5-2. FRONT PANEL SECTION
60 57

LCD601

53

61

59
not supplied

57

66 65
#1

57 62 57

55

58 56

57 63

54 67
supplied with S652

64

not supplied

52 51

supplied with S651

Ref. No. 51 52 53 53 54 55 55 56 57 58 59

Part No. X-4951-814-2 X-4951-831-2 X-4952-907-1 X-4952-908-1 4-221-378-01 4-221-380-31 4-221-380-61 X-4952-249-1 4-951-620-01 4-221-377-21

Description

Remark

Ref. No. 60 61 62 63 64 65

Part No. 4-221-369-01 1-674-798-11 1-769-908-11 1-675-197-11 1-773-213-11

Description HOLDER (LCD) BACKLIGHT BOARD WIRE(FLAT TYPE) (9 CORE) R BOARD WIRE(FLAT TYPE) (25 CORE)

Remark

KNOB(VOL) ASSY KNOB(JOG) ASSY PANEL ASSY, FRONT(AEP,UK,G,AED,CIS) PANEL ASSY, FRONT(MY,SP) RING PANEL (ST)(AEP,UK,G,AED,CIS) PANEL (ST)(MY,SP) WINDOW (STR) ASSY SCREW (2.6X8), +BVTP PLATE (TA-HL), ORNAMENTAL

A-4473-303-A PANEL BOARD, COMPLETE (AEP,UK,G,AED,CIS) 65 A-4473-312-A PANEL BOARD, COMPLETE(MY,SP) 66 1-568-441-11 SOCKET, CONNECTOR 9P 67 1-769-885-11 WIRE(FLAT TYPE) (7 CORE) LCD601 1-803-738-11 DISPLAY PANEL, LIQUID CRYSTAL

4-221-370-01 SHEET, DIFFUSION

23

5-3. CHASSIS SECTION
AEP, UK, G, AED, CIS 108
not supplied

109
#5

101
#5

#3

#3

T951

not supplied

#5 #2

102

106 105
B not supplied #5

#1

not supplied

MY, SP

UK

104 107
B AEP, UK, MY, SP

107

The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified.

Ref. No. 101 102 102 0 104 0 104 * 105 106

Part No. 1-674-803-11 A-4473-309-A A-4473-318-A 1-777-071-51 1-777-071-61

Description

Remark

Ref. No. 106 0 107 0 107 108 109 0 T951 0 T951

Part No. A-4473-314-A 1-770-019-11 1-569-008-21 1-674-801-11 4-900-386-01

Description

Remark

TRANS BOARD PA BOARD, COMPLETE(AEP,UK,G,AED,CIS) PA BOARD, COMPLETE(MY,SP) CORD, POWER(MY,SP) CORD, POWER(AEP,UK,G,AED,CIS)

MAIN BOARD, COMPLETE(MY,SP) ADAPTOR, CONVERSION PLUG 3P(UK) ADAPTOR, CONVERSION(MY,SP) SUBTRANS BOARD(AEP,UK,G,AED,CIS) SCREW

3-703-244-00 BUSHING (2104), CORD A-4473-305-A MAIN BOARD, COMPLETE(AEP,UK,G,AED,CIS)

1-435-566-11 TRANSFORMER, POWER(AEP,UK,G,AED,CIS) 1-435-567-11 TRANSFORMER, POWER(MY,SP)

24

SECTION 6 ELECTRICAL PARTS LIST
NOTE: · Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. · -XX and -X mean standardized parts, so they may have some difference from the original one. · RESISTORS All resistors are in ohms. METAL: Metal-film resistor. METAL OXIDE: Metal oxide-film resistor. F: nonflammable · Abbreviation MY : Malaysia model SP : Singapore model G : German model AED : North European model Ref. No. Part No. Description · Items marked "*" are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. · SEMICONDUCTORS In each case, u: µ, for example: uA. . : µA. . uPA. . : µPA. . uPB. . : µPB. . uPC. . : µPC. . uPD. . : µPD. . · CAPACITORS uF: µF · COILS uH: µH

BACK LIGHT

MAIN

The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. When indicating parts by reference number, please include the board.

Remark

Ref. No. C119 C120 C121 C122 C123 C124 C125 C127 C128 C131 C132 C134 C141 C151 C152 C153 C161 C162 C163 C164 C165 C166 C167 C168 C169 C170 C171 C172 C173 C174 C175 C191 C280 C420 C421 C431 C432 C437 C438 C439 C440 C441 C470 C501

Part No. 1-137-368-11 1-137-367-11 1-126-964-11 1-162-291-31 1-136-169-00 1-136-169-00 1-126-964-11 1-162-306-11 1-136-495-11 1-104-664-11 1-104-664-11 1-126-964-11 1-126-959-11 1-162-286-31 1-162-286-31 1-162-286-31 1-137-195-11 1-136-158-00 1-136-167-00 1-137-437-11 1-136-159-00 1-137-365-11 1-136-153-00 1-162-288-31 1-137-368-11 1-137-367-11 1-126-964-11 1-162-291-31 1-136-169-00 1-136-169-00 1-126-964-11 1-162-286-31 1-126-964-11 1-110-518-91 1-107-717-11 1-164-159-11 1-126-963-11 1-126-964-11 1-162-303-11 1-126-964-11 1-126-964-11 1-126-963-11 1-110-518-91 1-126-964-11

Description MYLAR MYLAR ELECT CERAMIC FILM FILM ELECT CERAMIC FILM ELECT ELECT ELECT ELECT CERAMIC CERAMIC CERAMIC FILM FILM FILM MYLAR FILM MYLAR FILM CERAMIC MYLAR MYLAR ELECT CERAMIC FILM FILM ELECT CERAMIC ELECT ELECT ELECT CERAMIC ELECT ELECT CERAMIC ELECT ELECT ELECT ELECT ELECT 0.0047uF 0.0033uF 10uF 560PF 0.22uF 0.22uF 10uF 0.01uF 0.068uF 47uF 47uF 10uF 0.47uF 220PF 220PF 220PF 0.56uF 0.027uF 0.15uF 0.0056uF 0.033uF 0.0015uF 0.01uF 330PF 0.0047uF 0.0033uF 10uF 560PF 0.22uF 0.22uF 10uF 220PF 10uF 10uF 47uF 0.1uF 4.7uF 10uF 0.0033uF 10uF 10uF 4.7uF 10uF 10uF 5.00% 5.00% 20.00% 10.00% 5.00% 5.00% 20.00% 30.00% 5.00% 20.00% 20.00% 20.00% 20.00% 10% 10% 10% 5.00% 5.00% 5.00% 5.00% 5.00% 5.00% 5% 10% 5.00% 5.00% 20.00% 10.00% 5.00% 5.00% 20.00% 10% 20.00% 20.00% 20.00%

Remark 50V 50V 50V 50V 50V 50V 50V 16V 50V 16V 16V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 100V 50V 50V 50V 50V 16V 50V 50V 50V 100V 50V

1-674-798-11 BACK LIGHT BOARD ***************** < CONNECTOR > CN605 1-785-329-11 PIN, CONNECTOR (LIGHT ANGLE)3P < DIODE > D639 D640 D641 D642 8-719-076-15 8-719-076-15 8-719-076-15 8-719-076-15 DIODE DIODE DIODE DIODE SELS6B14C-TP6 (LCD BACK LIGHT) SELS6B14C-TP6 (LCD BACK LIGHT) SELS6B14C-TP6 (LCD BACK LIGHT) SELS6B14C-TP6 (LCD BACK LIGHT)

< TRANSISTOR > Q639 Q640 8-729-900-36 TRANSISTOR BA1F4M-TP 8-729-900-36 TRANSISTOR BA1F4M-TP < RESISTOR > R639 1-249-403-11 CARBON 68 5% 1/4W F R640 1-249-403-11 CARBON 68 5% 1/4W F R670 1-247-807-31 CARBON 100 5% 1/4W ************************************************************** A-4473-305-A MAIN BOARD, COMPLETE (AEP,UK,G,AED,CIS) ********************* A-4473-314-A MAIN BOARD, COMPLETE (MY,SP) ********************* 7-685-646-79 SCREW +BVTP 3X8 TYPE2 N-S < CAPACITOR > C101 C102 C103 C104 C105 1-162-286-31 1-162-286-31 1-162-286-31 1-164-159-11 1-164-159-11 CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC 220PF 220PF 220PF 0.1uF 0.1uF 50V 50V 50V 50V 50V (AEP,UK,G,AED,CIS) 5.00% 5.00% 5.00% 5.00% 5.00% 50V 50V 50V 50V 50V 10% 10% 10%

C111 C112 C113 C114 C115 C116 C117 C118

1-137-195-11 1-136-158-00 1-136-167-00 1-137-437-11 1-136-159-00

FILM FILM FILM MYLAR FILM

0.56uF 0.027uF 0.15uF 0.0056uF 0.033uF

20.00% 20.00% 30.00% 20.00% 20.00% 20.00% 20.00% 20.00%

1-137-365-11 MYLAR 1-136-153-00 FILM 1-162-288-31 CERAMIC

0.0015uF 5.00% 50V 0.01uF 5% 50V 330PF 10% 50V

25

MAIN
Ref. No. C502 C503 C505 C506 C507 C511 C512 C513 C514 C515 C521 C522 C523 C523 C901 C902 C903 C904 C905 C908 C909 C920 C921 C922 C923 C924 C926 C927 C931 C941 Part No. 1-164-159-11 1-136-165-00 1-126-916-11 1-162-306-11 1-107-713-11 1-162-205-31 1-162-203-31 1-162-306-11 1-162-306-11 1-104-665-11 Description CERAMIC FILM ELECT CERAMIC ELECT CERAMIC CERAMIC CERAMIC CERAMIC ELECT 0.1uF 0.1uF 1000uF 0.01uF 4.7uF 18PF 15PF 0.01uF 0.01uF 100uF 100uF 0.01uF 2.2uF 10uF 0.1uF 3300uF 220uF 330uF 47uF 10uF 1000uF 1000uF 470uF 1000uF 0.1uF 47uF 1000uF 100uF 2.2uF 0.1uF 5.00% 20.00% 30.00% 20.00% 5% 5.00% 30.00% 30.00% 20.00% Remark 50V 50V 6.3V 16V 35V 50V 50V 16V 16V 10V Ref. No. D508 D510 D901 D902 D903 D904 D905 D906 D914 D915 D920 D921 D925 D931 D932 Part No. 8-719-911-19 8-719-911-19 8-719-024-99 8-719-024-99 8-719-024-99 8-719-024-99 8-719-911-19 8-719-921-48 8-719-911-19 8-719-024-99 8-719-024-99 8-719-110-23 8-719-024-99 8-719-911-19 8-719-911-19 Description DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE Remark 1SS133T-72 1SS133T-72 (AEP,UK,G,AED,CIS) 11ES2-NTA2B 11ES2-NTA2B 11ES2-NTA2B 11ES2-NTA2B 1SS133T-72 MTZJ-T-72-5.6C 1SS133T-72 (MY,SP) 11ES2-NTA2B (MY,SP) 11ES2-NTA2B MTZJ-T-72-11C 11ES2-NTA2B 1SS133T-72 1SS133T-72

1-104-665-11 ELECT 1-162-306-11 CERAMIC 1-126-961-11 ELECT 1-126-964-11 ELECT 1-136-165-00 FILM 1-126-936-11 1-126-934-11 1-126-924-11 1-104-664-11 1-126-964-11 1-126-916-11 1-126-767-11 1-126-941-11 1-126-952-11 1-164-159-11 1-126-786-11 1-126-916-11 1-126-933-11 1-126-961-11 1-164-159-11 ELECT ELECT ELECT ELECT ELECT ELECT ELECT ELECT ELECT CERAMIC ELECT ELECT ELECT ELECT CERAMIC

20.00% 10V 30.00% 16V 20.00% 50V (AEP,UK,G,AED,CIS) 20.00% 50V (MY,SP) 5.00% 50V 20.00% 20.00% 20.00% 20.00% 20.00% 20.00% 20.00% 20.00% 20.00% 16V 16V 10V 16V 50V 6.3V 16V 25V 35V 50V

< EARTH TERMINAL > * EP901 * EP902 1-537-738-21 TERMINAL, EARTH 1-537-738-21 TERMINAL, EARTH < IC > IC101 IC401 IC501 IC502 IC901 IC921 8-759-571-54 8-759-083-77 8-759-668-66 8-759-635-63 8-759-231-53 IC IC IC IC IC M62493FP BA3830F M30622MAA-A39FP M51943BSL-TP M5F7805L

8-759-231-58 IC M5F7812L < JACK >

16V 6.3V 16V 50V 50V (AEP,UK,G,AED,CIS) 5.00% 20.00% 20.00% 20.00% 50V 16V 16V 10V

20.00% 20.00% 20.00% 20.00%

J101 J191

1-784-275-11 JACK, PIN 6P (VIDEO (AUDIO) IN/MD IN/MD OUT) 1-774-785-11 JACK, PIN 1P (SUPER WOOFER OUT) < COIL >

C951 C952 C953 C954

1-136-165-00 1-126-768-11 1-126-934-11 1-126-924-11

FILM ELECT ELECT ELECT < CONNECTOR >

0.1uF 2200uF 220uF 330uF

L436 L501

1-410-517-11 INDUCTOR 47uH 1-410-509-11 INDUCTOR 10uH < TRANSISTOR >

CN101 * CN111 CN121 CN121 CN131 CN132 CN141 CN152 * CN173 * CN181

1-793-351-11 1-564-506-11 1-784-774-11 1-784-776-11 1-784-786-11 1-568-826-11 1-506-468-11 1-778-982-21 1-564-506-11 1-564-506-11

SOCKET, CONNECTOR 19P PLUG, CONNECTOR 3P CONNECTOR, FFC 13P(MY,SP) CONNECTOR, FFC 15P(AEP,UK,G,AED,CIS) CONNECTOR, FFC 25P CONNECTOR, FFC 7P PIN, CONNECTOR 3P(AEP,UK,G,AED,CIS) CONNECTOR, BOARD TO BOARD 13P PLUG, CONNECTOR 3P PLUG, CONNECTOR 3P < DIODE >

Q112 Q113 Q114 Q162 Q163 Q164 Q191 Q411 Q421 Q431 Q432 Q461 Q501 Q502 Q503 Q901 Q902 Q903 Q904 Q905

8-729-119-78 8-729-119-78 8-729-141-30 8-729-119-78 8-729-119-78 8-729-141-30 8-729-141-30 8-729-141-30 8-729-900-63 8-729-111-29 8-729-119-76 8-729-141-30 8-729-119-78 8-729-900-63 8-729-900-63 8-729-018-60 8-729-119-78 8-729-119-78 8-729-900-36 8-729-900-36

TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR

2SC2785TP-HFE 2SC2785TP-HFE 2SC3623ATP-LK 2SC2785TP-HFE 2SC2785TP-HFE 2SC3623ATP-LK 2SC3623ATP-LK 2SC3623ATP-LK BN1F4M-TP 2SD1616-TP-LK 2SA1175TP-HFE 2SC3623ATP-LK 2SC2785TP-HFE BN1F4M-TP BN1F4M-TP 2SD2012-LC 2SC2785TP-HFE 2SC2785TP-HFE BA1F4M-TP BA1F4M-TP

D141 D501 D502 D503 D504 D505 D506 D507

8-719-911-19 8-719-911-19 8-719-911-19 8-719-911-19 8-719-911-19

DIODE DIODE DIODE DIODE DIODE

1SS133T-72 1SS133T-72 1SS133T-72 1SS133T-72 1SS133T-72

8-719-911-19 DIODE 1SS133T-72 8-719-911-19 DIODE 1SS133T-72 8-719-911-19 DIODE 1SS133T-72

26

MAIN
Ref. No. Q906 Q907 Q921 Q926 Q927 Q951 Q952 Q953 Part No. 8-729-040-20 8-729-900-36 8-729-026-68 8-729-040-20 Description TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR Remark Ref. No. R193 R194 R411 R411 R412 8-729-018-59 TRANSISTOR 2SB1375(LB-SONY) 8-729-119-76 TRANSISTOR 2SA1175TP-HFE 8-729-119-76 TRANSISTOR 2SA1175TP-HFE < RESISTOR > R101 R102 R103 R105 R106 R111 R112 R114 R115 R117 R118 R119 R120 R121 R122 R123 R124 R126 R128 R131 R132 R133 R141 R142 R143 R144 R145 R151 R152 R153 R155 R156 R161 R162 R164 R165 R167 R168 R169 R170 R171 R172 R173 R174 R178 R191 R192 1-249-417-11 1-249-417-11 1-249-417-11 1-247-807-31 1-247-807-31 1-249-421-11 1-249-429-11 1-247-895-00 1-247-899-11 1-249-414-11 1-249-429-11 1-249-438-11 1-249-429-11 1-249-437-11 1-249-421-11 1-249-441-11 1-249-425-11 1-249-421-11 1-247-903-00 1-247-807-31 1-247-807-31 1-247-807-31 1-249-433-11 1-249-433-11 1-249-417-11 1-249-441-11 1-247-903-00 1-249-417-11 1-249-417-11 1-249-417-11 1-247-807-31 1-247-807-31 1-249-421-11 1-249-429-11 1-247-895-00 1-247-899-11 1-249-414-11 1-249-429-11 1-249-438-11 1-249-429-11 1-249-437-11 1-249-421-11 1-249-441-11 1-249-425-11 1-247-903-00 CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON 1K 1K 1K 100 100 2.2K 10K 470K 680K 560 10K 56K 10K 47K 2.2K 100K 4.7K 2.2K 1M 100 100 100 22K 22K 1K 100K 1M 1K 1K 1K 100 100 2.2K 10K 470K 680K 560 10K 56K 10K 47K 2.2K 100K 4.7K 1M 1K 100K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/4W F 1/4W F 1/4W F 1/4W 1/4W 1/4W F 1/4W 1/4W 1/4W 1/4W F 1/4W 1/4W 1/4W 1/4W 1/4W F 1/4W 1/4W 1/4W F 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W F 1/4W 1/4W 1/4W F 1/4W F 1/4W F 1/4W 1/4W 1/4W F 1/4W 1/4W 1/4W 1/4W F 1/4W 1/4W 1/4W 1/4W 1/4W F 1/4W 1/4W 1/4W 1/4W F 1/4W Part No. Description 1K 10K 150 180 150 Remark 5% 1/4W F 5% 1/4W 5% 1/2W (AEP,UK,G,AED,CIS) 5% 1/2W (MY,SP) 5% 1/2W (AEP,UK,G,AED,CIS) 5% 5% 5% 5% 5% 5% 1/2W (MY,SP) 1/2W 1/4W F 1/4W 1/4W 1/4W F RT1P137L-TP BA1F4M-TP 2SD2525(TP) RT1P137L-TP (AEP,UK,G,AED,CIS) 8-729-900-36 TRANSISTOR BA1F4M-TP(AEP,UK,G,AED,CIS) 1-249-417-11 CARBON 1-249-429-11 CARBON 1-260-089-11 CARBON 1-260-319-51 CARBON 1-260-089-11 CARBON

R412 R413 R414 R415 R416 R417 R418 R418 R431 R432 R433 R436 R437 R438 R440 R441 R442 R443 R444 R447 R448 R461 R461 R462 R462 R463 R464 R468 R468 R501 R502 R503 R504 R505 R506 R507 R510 R511 R513 R514 R515 R516 R517

1-260-319-51 CARBON 1-260-084-11 1-249-417-11 1-249-429-11 1-249-437-11 1-249-417-11 CARBON CARBON CARBON CARBON CARBON

180 56 1K 10K 47K 1K 150 180 2.2K 4.7K 100K 390K 390K 100K 47K 100K 82K 1.8K 10K 33K 470K 150 180 150 180 56 1K 150 180 470 4.7K 47K 47K 10K 220 100K 10K 330K 10K 100 4.7K 10K 100

1-260-089-11 CARBON 1-260-319-51 CARBON 1-249-421-11 CARBON 1-249-425-11 CARBON 1-249-441-11 CARBON 1-247-893-11 1-247-893-11 1-249-441-11 1-249-437-11 1-249-441-11 1-249-440-11 1-249-420-11 1-249-429-11 1-249-435-11 1-247-895-00 CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON

5% 1/2W (AEP,UK,G,AED,CIS) 5% 1/2W (MY,SP) 5% 1/4W F 5% 1/4W F 5% 1/4W 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W F 1/4W 1/4W 1/4W

1-260-089-11 CARBON 1-260-319-51 CARBON 1-260-089-11 CARBON 1-260-319-51 CARBON 1-260-084-11 CARBON 1-249-417-11 CARBON 1-260-089-11 CARBON 1-260-319-51 CARBON 1-249-413-11 CARBON 1-249-425-11 CARBON 1-249-437-11 1-249-437-11 1-249-429-11 1-249-409-11 1-249-441-11 1-249-429-11 1-247-891-00 1-249-429-11 1-247-807-31 1-249-425-11 CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON

5% 1/2W (AEP,UK,G,AED,CIS) 5% 1/2W (MY,SP) 5% 1/2W (AEP,UK,G,AED,CIS) 5% 1/2W (MY,SP) 5% 1/2W 5% 1/4W F 5% 1/2W (AEP,UK,G,AED,CIS) 5% 1/2W (MY,SP) 5% 1/4W F 5% 1/4W F 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W F 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W F 1/4W 1/4W

1-249-417-11 CARBON 1-249-441-11 CARBON

1-249-429-11 CARBON 1-247-807-31 CARBON

27

MAIN
Ref. No. R518 R519 R520 R521 R527 R528 R530 R531 R532 R534

PA
Part No. 1-249-425-11 1-249-425-11 1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 1-249-429-11 1-247-807-31 Description CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON 4.7K 4.7K 100 100 100 100 100 100 10K 100 5% 5% 5% 5% 5% Remark 1/4W F 1/4W F 1/4W 1/4W 1/4W Ref. No. R588 R589 R901 R902 R903 R905 R906 R907 R908 R909 R910 R920 R921 R931 R932 R933 R951 R952 R953 Part No. Description 100 100 3.3K 680 1.5 1.5K 560 4.7K 10K 12K 10K 1K 220 4.7K 4.7K 22K 3.3K 680 1.5 Remark 5% 1/4W (AEP,UK,G,AED,CIS) 5% 1/4W (AEP,UK,G,AED,CIS) 5% 1/4W 5% 1/4W F 5% 1/6W F 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/4W F 1/4W F 1/4W F 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1-247-807-31 CARBON 1-247-807-31 CARBON 1-247-843-11 CARBON 1-249-415-11 CARBON 1-249-383-11 CARBON 1-249-419-11 1-249-414-11 1-249-425-11 1-249-429-11 1-249-430-11 1-249-429-11 1-249-417-11 1-249-409-11 1-249-425-11 1-249-425-11 1-249-433-11 1-247-843-11 1-249-415-11 1-249-383-11 CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON < VIBRATOR > X511 1-567-098-41 VIBRATOR, CRYSTAL (32.768kHz) X512 1-781-107-21 VIBRATOR, SERAMIC (16MHz) ************************************************************** A-4473-309-A PA BOARD, COMPLETE (AEP,UK,G,AED,CIS) ******************* A-4473-318-A PA BOARD, COMPLETE (MY,SP) ******************* 7-685-646-79 SCREW +BVTP 3X8 TYPE2 N-S < CAPACITOR > C801 C802 C803 C804 C806 C807 C808 C809 C810 C811 1-128-582-11 1-162-292-31 1-162-286-31 1-126-967-11 1-128-560-11 1-128-582-11 1-136-495-11 1-136-495-11 1-136-165-00 ELECT CERAMIC CERAMIC ELECT ELECT ELECT FILM FILM FILM 10uF 680PF 220PF 47uF 22uF 10uF 0.068uF 0.068uF 0.1uF 0.1uF 20.00% 10% 10% 20.00% 20.00% 100V 50V 50V 50V 100V

5% 1/4W 5% 1/4W 5% 1/4W 5% 1/4W 5% 1/4W (AEP,UK,G,AED,CIS) 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/4W 1/4W F 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W F

R535 R536 R537 R538 R539 R543 R544 R546 R547 R548 R549 R550 R551 R552 R553 R554 R555 R556 R557 R558 R559 R560 R561 R562 R563 R566 R567 R568 R570 R571 R572 R573 R574 R575 R581 R582 R583 R583 R584 R584

1-249-429-11 1-249-417-11 1-249-429-11 1-247-807-31 1-247-843-11 1-249-429-11 1-249-429-11 1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 1-249-429-11 1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 1-249-429-11 1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 1-249-429-11 1-249-429-11 1-249-425-11

CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON

10K 1K 10K 100 3.3K 10K 10K 100 100 100 100 100 100 10K 100 100 100 100 100 100 100 10K 100 100 100 100 100 100 100 100 100 100 10K 10K 4.7K 1.5K 680 4.7K 330 4.7K

F F F F

1/4W 1/4W 1/4W F 1/6W F

1-136-165-00 FILM

20.00% 100V 5.00% 50V 5.00% 50V 5.00% 50V (AEP,UK,G,AED,CIS) 5.00% 50V (AEP,UK,G,AED,CIS)

1-249-419-11 CARBON 1-249-415-11 CARBON 1-249-425-11 CARBON 1-249-411-11 CARBON 1-249-425-11 CARBON

5% 1/4W F 5% 1/4W F (AEP,UK,G,AED,CIS) 5% 1/4W F (MY,SP) 5% 1/4W (MY,SP) 5% 1/4W F (AEP,UK,G,AED,CIS) 5% 5% 5% 1/4W 1/4W 1/4W

C812 C821 C822 C823 C825 C826 C827 C831 C851 C852 C853

1-161-494-00 CERAMIC 1-128-562-11 1-162-306-11 1-162-294-31 1-104-665-11 1-126-961-11 1-104-665-11 1-126-968-11 1-128-582-11 1-162-292-31 ELECT CERAMIC CERAMIC ELECT ELECT ELECT ELECT ELECT CERAMIC

25V (AEP,UK,G,AED,CIS) 47uF 20.00% 100V 0.01uF 30.00% 16V 0.001uF 10% 50V 100uF 20.00% 10V 2.2uF 100uF 100uF 10uF 680PF 220PF 20.00% 20.00% 20.00% 20.00% 10% 10% 50V 10V 50V 100V 50V 50V

0.022uF

R585 R586 R587

1-247-807-31 CARBON 1-247-807-31 CARBON 1-247-807-31 CARBON

100 100 100

1-162-286-31 CERAMIC

28

PA
Ref. No. C854 C856 C857 C858 C859 C860 C861 C862 C880 C883 Part No. 1-126-967-11 1-128-560-11 1-128-582-11 1-136-495-11 1-136-495-11 Description ELECT ELECT ELECT FILM FILM 47uF 22uF 10uF 0.068uF 0.068uF 0.1uF 20.00% 20.00% 20.00% 5.00% 5.00% Remark 50V 100V 100V 50V 50V Ref. No. Q829 Q830 Q831 Q851 Q881 Q882 Part No. 8-729-140-84 8-729-140-84 8-729-140-84 8-729-140-84 8-729-140-82 Description TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR 2SC1841TP-PAFAEA 2SC1841TP-PAFAEA 2SC1841TP-PAFAEA 2SC1841TP-PAFAEA 2SA988TP-PAFAEA Remark

1-136-165-00 FILM 1-136-165-00 FILM 1-161-494-00 CERAMIC 1-126-163-11 ELECT 1-127-752-11 ELECT

5.00% 50V (AEP,UK,G,AED,CIS) 0.1uF 5.00% 50V (AEP,UK,G,AED,CIS) 0.022uF 25V (AEP,UK,G,AED,CIS) 4.7uF 20% 50V 3300uF 20% 63V (AEP,UK,G,AED,CIS) 71V (MY,SP) 3300uF 20% 63V (AEP,UK,G,AED,CIS) 3300uF 20% 71V (MY,SP) 0.1uF 10.00% 100V 0.1uF 10.00% 100V 0.01uF 30.00% 16V 3300uF 20%

8-729-140-84 TRANSISTOR 2SC1841TP-PAFAEA < RESISTOR >

R801 R802 R803 R804 0 R805 0 R807 R808 R809 R810 R811 R812 R813

1-249-417-11 1-249-438-11 1-249-414-11 1-249-438-11 1-212-881-11 1-217-156-00 1-249-417-11 1-249-431-11 1-249-441-11 1-260-076-11

CARBON CARBON CARBON CARBON FUSIBLE METAL CARBON CARBON CARBON CARBON

1K 56K 560 56K 100 0.22 1K 15K 100K 10 10 10 47K 33K 33K 68K 2.2K 22K 10K 22K 1 100K 100K 10K 12K

5% 5% 5% 5% 5% 10% 5% 5% 5% 5%

1/4W F 1/4W 1/4W F 1/4W 1/4W 5W 1/4W F 1/4W 1/4W 1/2W

C883 C884 C884 C887 C888 C889

1-127-813-11 ELECT 1-127-752-11 ELECT 1-127-813-11 ELECT 1-130-777-00 MYLAR 1-130-777-00 MYLAR 1-162-306-11 CERAMIC < CONNECTOR >

1-260-076-11 CARBON 1-260-076-11 CARBON 1-249-437-11 CARBON 1-249-435-11 CARBON 1-249-435-11 CARBON 1-249-439-11 1-249-421-11 1-249-433-11 1-249-429-11 1-249-433-11 1-202-972-61 1-249-441-11 1-249-441-11 1-249-429-11 CARBON CARBON CARBON CARBON CARBON FUSIBLE CARBON CARBON CARBON

R814 R821 R822 R823 R824 R825 R826 R827 0 R828 R829 R830 R831 R831

5% 1/2W (AEP,UK,G,AED,CIS) 5% 1/2W (AEP,UK,G,AED,CIS) 5% 1/4W 5% 1/4W 5% 1/4W 5% 5% 5% 5% 5% 1/4W 1/4W F 1/4W 1/4W 1/4W

CN802 CN808

1-778-981-21 CONNECTOR, BOARD TO BOARD 13P 1-691-766-11 PLUG (MICRO CONNECTOR) 4P < DIODE >

D802 D821 D831 D852 D871 D881 D883

8-719-911-19 8-719-911-19 8-719-911-19 8-719-911-19 8-719-911-19

DIODE DIODE DIODE DIODE DIODE

1SS133T-72 1SS133T-72 1SS133T-72 1SS133T-72 1SS133T-72

8-719-510-68 DIODE D5SBA204101 8-719-911-19 DIODE 1SS133T-72 < EARTH TERMINAL >

1-249-430-11 CARBON

5% 1/4W 5% 1/4W 5% 1/4W 5% 1/4W (AEP,UK,G,AED,CIS) 5% 1/4W (MY,SP) 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 10% 5% 5% 5% 5% 1/4W 1/4W 1/4W F 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W F 1/4W 1/4W F 1/4W 1/4W 5W 1/4W F 1/4W 1/4W 1/2W

* EP802 * EP803

1-537-738-21 TERMINAL, EARTH 1-537-738-21 TERMINAL, EARTH (AEP,UK,G,AED,CIS) < IC >

R832 R833 R836 R837 R838 R839 R840 R841 R842 0 R850 R851 R852 R853 R854 0 R855 0 R857 R858 R859 R860 R861

1-249-431-11 1-249-435-11 1-249-425-11 1-249-433-11 1-249-435-11 1-249-429-11 1-249-429-11 1-249-437-11 1-249-438-11 1-202-972-61 1-249-417-11 1-249-438-11 1-249-414-11 1-249-438-11 1-212-881-11 1-217-156-00 1-249-417-11 1-249-431-11 1-249-441-11 1-260-076-11

CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON FUSIBLE CARBON CARBON CARBON CARBON FUSIBLE METAL CARBON CARBON CARBON CARBON

15K 33K 4.7K 22K 33K 10K 10K 47K 56K 1 1K 56K 560 56K 100 0.22 1K 15K 100K 10

IC801

8-749-015-39 IC STK407-120E < COIL >

L801 L851

1-420-872-00 COIL, AIR-CORE (AEP,UK,G,AED,CIS) 1-420-872-00 COIL, AIR-CORE (AEP,UK,G,AED,CIS) < TRANSISTOR >

Q801 Q821 Q822 Q823 Q824 Q825 Q826 Q827 Q828

8-729-140-84 8-729-140-82 8-729-140-84 8-729-140-84 8-729-119-78 8-729-119-78 8-729-119-78 8-729-119-78 8-729-140-82

TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR

2SC1841TP-PAFAEA 2SA988TP-PAFAEA 2SC1841TP-PAFAEA 2SC1841TP-PAFAEA 2SC2785TP-HFE 2SC2785TP-HFE 2SC2785TP-HFE 2SC2785TP-HFE 2SA988TP-PAFAEA

The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified.

29

PA
Ref. No. R862 R863 R864 R881 R882 R883 R884 0 R885

PANEL
Part No. Description 10 10 47K 10K 47K 10K 100K 1.2K Remark 5% 1/2W (AEP,UK,G,AED,CIS) 5% 1/2W (AEP,UK,G,AED,CIS) 5% 1/4W 5% 1/4W 5% 1/4W 5% 5% 5% 1/4W 1/4W 3W Ref. No. D647 D648 Part No. Description Remark 1-260-076-11 CARBON 1-260-076-11 CARBON 1-249-437-11 CARBON 1-249-429-11 CARBON 1-249-437-11 CARBON 1-249-429-11 CARBON 1-249-441-11 CARBON 1-216-481-11 METAL OXIDE < RELAY > 8-719-076-15 DIODE SELS6B14C-TP6 (KEY ILLUMINATION) 8-719-076-15 DIODE SELS6B14C-TP6 (KEY ILLUMINATION) < EARTH TERMINAL > * EPT601 1-537-738-21 TERMINAL, EARTH * EPT602 1-537-738-21 TERMINAL, EARTH < JACK > J701 1-785-569-11 JACK (SMALL TYPE) (PHONES) < COIL > L601 1-410-509-11 INDUCTOR 10uH < TRANSISTOR > Q631 Q636 Q637 Q638 Q641 Q642 Q643 8-729-900-36 8-729-900-36 8-729-900-36 8-729-900-36 8-729-900-36 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR BA1F4M-TP BA1F4M-TP BA1F4M-TP (AEP,UK,G,AED,CIS) BA1F4M-TP BA1F4M-TP

RY881

1-755-168-11 RELAY < TERMINAL >

TM801 1-537-240-11 TERMINAL BOARD (CHECKER PIN) TM802 1-537-240-11 TERMINAL BOARD (CHECKER PIN) ************************************************************** A-4473-303-A PANEL BOARD, COMPLETE (AEP,UK,G,AED,CIS) ********************** A-4473-312-A PANEL BOARD, COMPLETE (MY,SP) ********************** < CAPACITOR > C601 C651 C652 C653 C654 C655 C656 C657 C658 C659 C660 C701 C702 C703 C741 1-164-159-11 1-164-159-11 1-104-664-11 1-162-306-11 1-162-306-11 1-162-306-11 1-162-306-11 1-104-664-11 1-104-664-11 1-104-664-11 1-164-159-11 1-162-294-31 1-162-294-31 1-164-159-11 1-164-159-11 CERAMIC CERAMIC ELECT CERAMIC CERAMIC CERAMIC CERAMIC ELECT ELECT ELECT CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC < CONNECTOR > CN601 CN602 CN603 * CN606 CN608 1-784-731-11 1-784-747-11 1-568-850-11 1-560-666-00 1-564-718-11 CONNECTOR, FFC 9P CONNECTOR, FFC 25P CONNECTOR, FFC 7P PIN, CONNECTOR 3P PIN, CONNECTOR (SMALL TYPE) 2P < DIODE > D631 D636 D637 D638 D643 D644 D645 D646 8-719-076-21 DIODE SEL5255S-TP15 (GROOVE) 8-719-076-21 DIODE SEL5255S-TP15 (ENTER) 8-719-076-21 DIODE SEL5255S-TP15 (TIMER) (AEP,UK,G,AED,CIS) 8-719-076-21 DIODE SEL5255S-TP15 (`/1) 8-719-076-15 DIODE SELS6B14C-TP6 (KEY ILLUMINATION) 8-719-076-15 DIODE SELS6B14C-TP6 (KEY ILLUMINATION) 8-719-076-15 DIODE SELS6B14C-TP6 (KEY ILLUMINATION) 8-719-076-15 DIODE SELS6B14C-TP6 (KEY ILLUMINATION) 0.1uF 0.1uF 47uF 0.01uF 0.01uF 0.01uF 0.01uF 47uF 47uF 47uF 0.1uF 0.001uF 0.001uF 0.1uF 0.1uF 50V 50V 20.00% 16V 30.00% 16V 30.00% 16V 30.00% 30.00% 20.00% 20.00% 20.00% 16V 16V 16V 16V 16V 50V 50V 50V 50V 50V

8-729-900-36 TRANSISTOR BA1F4M-TP 8-729-900-36 TRANSISTOR BA1F4M-TP < RESISTOR >

R602 R603 R604 R605 R606 R607 R608 R609 R610 R611 R612 R613 R614 R616 R617 R618 R619 R620 R621 R622 R626 R627 R631 R636 R637

1-249-411-11 1-249-413-11 1-249-414-11 1-249-415-11 1-249-417-11 1-249-418-11 1-249-420-11 1-249-422-11 1-247-843-11 1-249-425-11 1-249-427-11 1-249-429-11 1-249-431-11 1-249-411-11 1-249-413-11 1-249-414-11 1-249-415-11 1-249-417-11 1-249-418-11 1-249-420-11 1-249-410-11 1-249-410-11 1-249-411-11 1-249-411-11 1-249-411-11

CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON

330 470 560 680 1K 1.2K 1.8K 2.7K 3.3K 4.7K 6.8K 10K 15K 330 470 560 680 1K 1.2K 1.8K 270 270 330 330 330

5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W

F F F F F F F F

10% 10%

1/4W F 1/4W 1/4W 1/4W 1/4W F 1/4W 1/4W 1/4W 1/4W 1/4W F F F F F

5% 1/4W F 5% 1/4W F 5% 1/4W 5% 1/4W 5% 1/4W (AEP,UK,G,AED,CIS) 5% 5% 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W

R638 R641 R642 R643 R651 R652 R653

1-249-411-11 1-249-403-11 1-249-403-11 1-249-403-11 1-249-401-11

CARBON CARBON CARBON CARBON CARBON

330 68 68 68 47 10K 10K

F F F F

1-249-429-11 CARBON 1-249-429-11 CARBON

The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified.

30

PANEL
Ref. No. R654 R655 R656 R657 R661 R666 R667 R668 R669 Part No. 1-249-429-11 1-249-429-11 1-249-417-11 1-249-417-11 1-247-807-31 Description CARBON CARBON CARBON CARBON CARBON 10K 10K 1K 1K 100 100 100 100 100 5% 5% 5% 5% 5% Remark 1/4W 1/4W 1/4W F 1/4W F 1/4W Ref. No. 0 C991 Part No.

R

SUB TRANS
Description 0.01uF

TRANS
Remark 20.00% 250V (AEP,UK,G,AED,CIS)

1-113-925-11 CERAMIC

< CONNECTOR > * CN901 1-580-230-11 PIN, CONNECTOR (PC BOARD) 2P (AEP,UK,G,AED,CIS) 1-564-321-00 PIN, CONNECTOR 2P (AEP,UK,G,AED,CIS) < DIODE > D952 D953 D954 D955 D956 D957 8-719-024-99 8-719-024-99 8-719-024-99 8-719-024-99 8-719-911-19 DIODE DIODE DIODE DIODE DIODE 11ES2-NTA2B (AEP,UK,G,AED,CIS) 11ES2-NTA2B (AEP,UK,G,AED,CIS) 11ES2-NTA2B (AEP,UK,G,AED,CIS) 11ES2-NTA2B (AEP,UK,G,AED,CIS) 1SS133T-72 (AEP,UK,G,AED,CIS)

1-247-807-31 CARBON 1-247-807-31 CARBON 1-247-807-31 CARBON 1-247-807-31 CARBON < SWITCH >

5% 1/4W 5% 1/4W (AEP,UK,G,AED,CIS) 5% 1/4W 5% 1/4W

CN902

S601 S602 S603 S604 S605 S606 S607 S608 S609 S610 S611 S612 S613 S614 S615 S616 S617 S619 S620 S621

1-762-875-21 SWITCH, KEYBOARD (`/1) 1-762-875-21 SWITCH, KEYBOARD (DISPLAY) 1-762-875-21 SWITCH, KEYBOARD (POWER SAVE/DEMO (STANDBY)) 1-762-875-21 SWITCH, KEYBOARD (VIDEO) 1-762-875-21 SWITCH, KEYBOARD (MD) 1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21 SWITCH, KEYBOARD (TAPE) SWITCH, KEYBOARD (CD) SWITCH, KEYBOARD (TUNER) SWITCH, KEYBOARD (SURROUND) SWITCH, KEYBOARD (DBFB) SWITCH, KEYBOARD (PLAY MODE) SWITCH, KEYBOARD (REPEAT/PTY) SWITCH, KEYBOARD (CD/TUNER NAME) SWITCH, KEYBOARD (FILE SELECT) SWITCH, KEYBOARD (TUNER BAND) SWITCH, KEYBOARD (STEREO/MONO) SWITCH, KEYBOARD (TUNER MEMORY) SWITCH, KEYBOARD (GROOVE) SWITCH, KEYBOARD (+ M) SWITCH, KEYBOARD (­ m)

8-719-911-19 DIODE 1SS133T-72 (AEP,UK,G,AED,CIS) < IC >

IC991

8-759-450-47 IC BA05T (AEP,UK,G,AED,CIS) < TRANSISTOR >

Q991

8-729-119-78 TRANSISTOR 2SC2785TP-HFE (AEP,UK,G,AED,CIS) < RESISTOR >

R991 R992

1-249-441-11 CARBON 1-249-429-11 CARBON

100K 10K

5% 1/4W (AEP,UK,G,AED,CIS) 5% 1/4W (AEP,UK,G,AED,CIS)

< RELAY > 0 RY901 1-755-276-11 RELAY, POWER (AEP,UK,G,AED,CIS) < TRANSFORMER > 0 T901 1-433-999-11 TRANSFORMER, POWER (AEP,UK,G,AED,CIS) ************************************************************** 1-674-803-11 TRANS BOARD ************ 1-533-293-11 FUSE HOLDER < CAPACITOR > C951 C952 C953 1-162-306-11 CERAMIC 1-162-306-11 CERAMIC 1-162-306-11 CERAMIC < CONNECTOR > 0.01uF 0.01uF 0.01uF 30.00% 16V 30.00% 16V 30.00% 16V

S622 1-762-875-21 SWITCH, KEYBOARD (ENTER) S651 1-473-392-11 ENCODER, ROTARY (VOLUME) S652 1-473-534-11 ENCODER, ROTARY (JOG DIAL) ************************************************************** 1-675-197-11 R BOARD ******** < CONNECTOR > * CN607 1-565-835-11 SOCKET, CONNECTOR 3P < IC > IC601 8-749-011-05 IC GP1U28X (REMOTE CONTROL RECIEVER) ************************************************************** 1-674-801-11 SUB TRANS BOARD (AEP,UK,G,AED,CIS) **************** < CAPACITOR > C932 C933 C934 C935 1-126-768-11 ELECT 1-164-159-11 CERAMIC 1-126-933-11 ELECT 1-126-964-11 ELECT 2200uF 0.1uF 100uF 10uF 20.00% 16V (AEP,UK,G,AED,CIS) 50V (AEP,UK,G,AED,CIS) 20.00% 16V (AEP,UK,G,AED,CIS) 20.00% 50V (AEP,UK,G,AED,CIS)

CN951

1-564-321-00 PIN, CONNECTOR 2P (MY,SP) < FUSE >

0 F951 0 F961 0 F962 0 F965 0 F966

1-532-505-31 1-533-949-31 1-533-949-31 1-532-504-31 1-532-504-31

FUSE (TIME LUG) T5AL/250 V(MY,SP) FUSE, CYLINDRICAL (TIME LUG) T8AL/250V FUSE, CYLINDRICAL (TIME LUG) T8AL/250V FUSE (TIME LUG) T4AL/250V FUSE (TIME LUG) T4AL/250V

The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified.

31

STR-NX5MD TRANS
Ref. No. Part No. Description < RESISTOR > 0 R951 0 R952 1-219-120-11 FUSIBLE 1-219-120-11 FUSIBLE < SWITCH > 0 S951 1-771-291-11 SWITCH, POWER (VOLTAGE SELECTOR) (MY,SP) < TRANSFORMER > 0 T951 1-435-566-11 TRANSFORMER, POWER (AEP,UK,G,AED,CIS) 0 T951 1-435-567-11 TRANSFORMER, POWER (MY,SP) ************************************************************** MISCELLANEOUS *************** 4 4 6 6 62 64 66 67 0 104 0 104 0 107 0 107 LCD601 M401 0 T951 1-751-688-11 WIRE (FLAT TYPE) (13 CORE) (MY,SP) 1-773-011-11 WIRE (FLAT TYPE) (15 CORE) (AEP,UK,G,AED,CIS) 1-693-482-11 TUNER (FM/AM) (MY,SP) 1-693-490-11 TUNER (FM/AM) (AEP,UK,G,AED,CIS) 1-769-908-11 WIRE (FLAT TYPE) (9 CORE) 1-773-213-11 1-568-441-11 1-769-885-11 1-777-071-51 1-777-071-61 1-770-019-11 1-569-008-21 1-803-738-11 1-763-478-11 1-435-566-11 WIRE (FLAT TYPE) (25 CORE) SOCKET, CONNECTOR 9P WIRE (FLAT TYPE) (7 CORE) CORD, POWER (MY,SP) CORD, POWER (AEP,UK,G,AED,CIS) ADAPTOR, CONVERSION PLUG 3P (UK) ADAPTOR, CONVERSION (MY,SP) DISPLAY PANEL, LIQUID CRYSTAL FAN, DC TRANSFORMER, POWER (AEP,UK,G,AED,CIS) 0.15 0.15 5% 5% 1/4W 1/4W Remark

0 T951 1-435-567-11 TRANSFORMER, POWER (MY,SP) ************************************************************** ************** HARDWARE LIST ************** #1 #2 #3 #4 #5 7-685-647-79 7-685-650-79 7-685-872-09 7-685-871-01 7-685-646-79 SCREW +BVTP SCREW +BVTP SCREW +BVTT SCREW +BVTT SCREW +BVTT 3X10 TYPE2 N-S 3X16 TYPE2 IT-3 3X8 (S) 3X6 (S) 3X8 TYPE2 N-S

The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified.

9-929-520-11

Sony Corporation
Audio Entertainment Group

32

2000H097551-1 Printed in Hungary © 2000. 8 Published by HA Quality Assurance Dept.