Text preview for : xdjrx.pdf part of Pioneer xdjrx Pioneer Audio XDJ-RX xdjrx.pdf
Back to : xdjrx.pdf | Home
ORDER NO.
RRV4592
XDJ-RX
DJ SYSTEM
XDJ-RX
THIS MANUAL IS APPLICABLE TO THE FOLLOWING MODEL(S) AND TYPE(S).
Model Type Power Requirement Remarks
XDJ-RX LSYXJ8 AC 110 V to 240 V
XDJ-RX UXJCB AC 110 V to 240 V
XDJ-RX AXJ5 AC 110 V to 240 V
PIONEER CORPORATION 1-1, Shin-ogura, Saiwai-ku, Kawasaki-shi, Kanagawa 212-0031, Japan
PIONEER ELECTRONICS (USA) INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A.
PIONEER EUROPE NV Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium
PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra Road, #04-01, Singapore 159936
PIONEER CORPORATION 2015
K-MZV MAR. 2015 Printed in Japan
Downloaded from www.Manualslib.com manuals search engine
1 2 3 4
SAFETY INFORMATION
A
This service manual is intended for qualified service technicians; it is not meant for the casual do-it-
yourselfer. Qualified technicians have the necessary test equipment and tools, and have been trained
to properly and safely repair complex products such as those covered by this manual.
Improperly performed repairs can adversely affect the safety and reliability of the product and may
void the warranty. If you are not qualified to perform the repair of this product properly and safely, you
should not risk trying to do so and refer the repair to a qualified service technician.
WARNING
B This product may contain a chemical known to the State of California to cause cancer, or birth defects or other reproductive
harm.
Health & Safety Code Section 25249.6 - Proposition 65
(FOR USA MODEL ONLY)
ANY MEASUREMENTS NOT WITHIN THE LIMITS
1. SAFETY PRECAUTIONS
OUTLINED ABOVE ARE INDICATIVE OF A POTENTIAL
The following check should be performed for the
SHOCK HAZARD AND MUST BE CORRECTED BEFORE
continued protection of the customer and service
RETURNING THE APPLIANCE TO THE CUSTOMER.
technician.
C LEAKAGE CURRENT CHECK
Measure leakage current to a known earth ground 2. PRODUCT SAFETY NOTICE
(water pipe, conduit, etc.) by connecting a leakage Many electrical and mechanical parts in the appliance
current tester such as Simpson Model 229-2 or have special safety related characteristics. These are
equivalent between the earth ground and all exposed often not evident from visual inspection nor the protection
metal parts of the appliance (input/output terminals, afforded by them necessarily can be obtained by using
screwheads, metal overlays, control shaft, etc.). Plug replacement components rated for voltage, wattage, etc.
the AC line cord of the appliance directly into a 120 V Replacement parts which have these special safety
AC 60 Hz outlet and turn the AC power switch on. Any characteristics are identified in this Service Manual.
current measured must not exceed 0.5 mA. Electrical components having such features are
identified by marking with a > on the schematics and on
D
the parts list in this Service Manual.
Reading should The use of a substitute replacement component which
Leakage not be above does not have the same safety characteristics as the
Device current 0.5 mA
under tester PIONEER recommended replacement one, shown in the
test parts list in this Service Manual, may create shock, fire,
Test all or other hazards.
exposed metal
surfaces Product Safety is continuously under review and new
instructions are issued from time to time. For the latest
information, always consult the current PIONEER Service
Also test with Manual. A subscription to, or additional copies of,
plug reversed Earth PIONEER Service Manual may be obtained at a nominal
E (Using AC adapter ground
plug as required) charge from PIONEER.
AC Leakage Test
F
2 XDJ-RX
1 2 3 4
Downloaded from www.Manualslib.com manuals search engine
5 6 7 8
CONTENTS
SAFETY INFORMATION.......................................................................................................................................................... 2
1. SERVICE PRECAUTIONS .................................................................................................................................................... 5
1.1 NOTES ON SOLDERING ............................................................................................................................................... 5 A
1.2 NOTES ON REPLACING ............................................................................................................................................... 5
1.3 SERVICE NOTICE.......................................................................................................................................................... 5
2. SPECIFICATIONS................................................................................................................................................................. 6
3. BASIC ITEMS FOR SERVICE .............................................................................................................................................. 7
3.1 CHECK POINTS AFTER SERVICING ........................................................................................................................... 7
3.2 JIGS LIST ....................................................................................................................................................................... 7
3.3 PCB LOCATIONS ........................................................................................................................................................... 8
4. BLOCK DIAGRAM .............................................................................................................................................................. 10
4.1 OVERALL WIRING DIAGRAM (1/2) ............................................................................................................................. 10
4.2 OVERALL WIRING DIAGRAM (2/2) ............................................................................................................................. 12
4.3 SIGNAL BLOCK DIAGRAM (CHASSIS SECTION)...................................................................................................... 14
4.4 SIGNAL BLOCK DIAGRAM (PANEL SECTION) .......................................................................................................... 16 B
4.5 POWER BLOCK DIAGRAM ......................................................................................................................................... 18
5. DIAGNOSIS ........................................................................................................................................................................ 20
5.1 STARTUP SEQUENCE ................................................................................................................................................ 20
5.2 TROUBLESHOOTING.................................................................................................................................................. 21
5.3 SIMPLIFIED DIAGNOSTIC PROCEDURE FOR AUDIO SIGNAL................................................................................ 30
5.4 VOLTAGE MONITORING CIRCUIT .............................................................................................................................. 31
5.5 ABOUT PROTECTOR .................................................................................................................................................. 33
5.6 METHOD FOR CONNECTION CONFIRMATION OF THE LAN (LINK) PORT............................................................ 34
5.7 IC INFORMATION ........................................................................................................................................................ 35
6. SERVICE MODE ................................................................................................................................................................. 36
6.1 TEST MODE................................................................................................................................................................. 36
C
6.2 ABOUT THE DEVICE................................................................................................................................................... 42
7. DISASSEMBLY ................................................................................................................................................................... 43
8. EACH SETTING AND ADJUSTMENT ................................................................................................................................ 59
8.1 NECESSARY ITEMS TO BE NOTED........................................................................................................................... 59
8.2 UPDATING OF THE FIRMWARE ................................................................................................................................. 60
8.3 ADJUSTMENT METHOD FOR ROTATION LOAD OF THE JOG DIALS ..................................................................... 61
8.4 USER SETABLE ITEMS ............................................................................................................................................... 62
9. EXPLODED VIEWS AND PARTS LIST............................................................................................................................... 64
9.1 PACKING SECTION ..................................................................................................................................................... 64
9.2 BOTTOM SECTION...................................................................................................................................................... 66
9.3 CHASSIS SECTION ..................................................................................................................................................... 68
9.4 CONTROL PANEL SECTION (1/3)............................................................................................................................... 70 D
9.5 CONTROL PANEL SECTION (2/3)............................................................................................................................... 72
9.6 CONTROL PANEL SECTION (3/3)............................................................................................................................... 74
9.7 JOG DIAL SECTION .................................................................................................................................................... 76
9.8 LCD SECTION.............................................................................................................................................................. 78
10. SCHEMATIC DIAGRAM .................................................................................................................................................... 80
10.1 MAIN ASSY (1/16)...................................................................................................................................................... 80
10.2 MAIN ASSY (2/16)...................................................................................................................................................... 82
10.3 MAIN ASSY (3/16)...................................................................................................................................................... 84
10.4 MAIN ASSY (4/16)...................................................................................................................................................... 86
10.5 MAIN ASSY (5/16)...................................................................................................................................................... 88
10.6 MAIN ASSY (6/16)...................................................................................................................................................... 90
10.7 MAIN ASSY (7/16)...................................................................................................................................................... 92 E
10.8 MAIN ASSY (8/16)...................................................................................................................................................... 94
10.9 MAIN ASSY (9/16)...................................................................................................................................................... 96
10.10 MAIN ASSY (10/16).................................................................................................................................................. 98
10.11 MAIN ASSY (11/16)................................................................................................................................................ 100
10.12 MAIN ASSY (12/16)................................................................................................................................................ 102
10.13 MAIN ASSY (13/16)................................................................................................................................................ 104
10.14 MAIN ASSY (14/16)................................................................................................................................................ 106
10.15 MAIN ASSY (15/16)................................................................................................................................................ 108
10.16 MAIN ASSY (16/16)................................................................................................................................................ 110
10.17 JACK1 ASSY (1/2).................................................................................................................................................. 112
10.18 JACK1 ASSY (2/2).................................................................................................................................................. 114
F
10.19 JACK2 ASSY (1/3).................................................................................................................................................. 116
10.20 JACK2 ASSY (2/3).................................................................................................................................................. 118
XDJ-RX 3
5 6 7 8
Downloaded from www.Manualslib.com manuals search engine
1 2 3 4
10.21 JACK2 ASSY (3/3) ..................................................................................................................................................120
A 10.22 HPJB and MICT ASSYS .........................................................................................................................................122
10.23 USB1 and USB2 ASSYS ........................................................................................................................................123
10.24 USBP1 ASSY..........................................................................................................................................................124
10.25 USBP2 ASSY..........................................................................................................................................................126
10.26 EXTB ASSY (1/3)....................................................................................................................................................128
10.27 EXTB ASSY (2/3)....................................................................................................................................................130
10.28 EXTB ASSY (3/3)....................................................................................................................................................132
10.29 DPNL1 and DPNL2 ASSYS ....................................................................................................................................134
10.30 MIXB ASSY (1/4) ....................................................................................................................................................136
10.31 MIXB (2/4), CRFB and CHF1 ASSYS.....................................................................................................................138
10.32 MIXB ASSY (3/4) ....................................................................................................................................................140
10.33 MIXB ASSY (4/4) ....................................................................................................................................................142
B
10.34 LLED ASSY.............................................................................................................................................................144
10.35 CDJB ASSY (1/3)....................................................................................................................................................146
10.36 CDJB ASSY (2/3)....................................................................................................................................................148
10.37 CDJB ASSY (3/3)....................................................................................................................................................150
10.38 PNL1 ASSY.............................................................................................................................................................152
10.39 PNL2 ASSY.............................................................................................................................................................154
10.40 JOGT1 and JOGR1 ASSYS....................................................................................................................................156
10.41 JOGT2 and JOGR1 ASSYS....................................................................................................................................158
10.42 JLED1 ASSY...........................................................................................................................................................160
10.43 JLED2 ASSY...........................................................................................................................................................162
10.44 POWER SUPPLY ASSY .........................................................................................................................................164
C 10.45 VOLTAGES..............................................................................................................................................................166
10.46 WAVEFORMS .........................................................................................................................................................167
11. PCB CONNECTION DIAGRAM ......................................................................................................................................170
11.1 MAIN ASSY...............................................................................................................................................................170
11.2 JACK1, JACK2, HPJB and MICT ASSYS .................................................................................................................174
11.3 USB1, USB2, USBP1 and USBP2 ASSYS...............................................................................................................178
11.4 EXTB, DPNL! And DPNL2 ASSYS ...........................................................................................................................180
11.5 MIXB, CRFB, CHF1 and LLED ASSYS ....................................................................................................................184
11.6 CDJB, PNL1 and PNL2 ASSYS ................................................................................................................................188
11.7 JOGT1, JOGT2, JOGR1, JLED1 and JLED2 ASSYS ..............................................................................................192
11.8 POWER SUPPLY ASSY ...........................................................................................................................................196
12. PCB PARTS LIST ............................................................................................................................................................197
D
E
F
4 XDJ-RX
1 2 3 4
Downloaded from www.Manualslib.com manuals search engine
5 6 7 8
1. SERVICE PRECAUTIONS
1.1 NOTES ON SOLDERING